2004 FORD F-350 Problems & Recalls

The contact owns a 2004 Ford F-350. The contact stated that while driving approximately 76 MPH with his wife in the front passenger seat, the vehicle shuddered uncontrollably and stalled. The contact and his wife were concerned for their safety. There was no warning light illuminated. The contact wa...

Mileage: 190,019

While driving at 40-50 MPH the vehicle will lose power and then then stalls while moving leading to loss of power. The loss power of affects the power steering posing a direct threat for an auto collision due to the difficult in steering the moving vehicle into an emergency lane. Avoided several a...

While driving at 40-50 MPH the vehicle will lose power and then then stalls while moving leading to loss of power. The loss power of affects the power steering posing a direct threat for an auto collision due to the difficult in steering the moving vehicle into an emergency lane. Avoided several a...

The contact owns a 2004 Ford F-350 equipped with Cooper Tires, Tire Line: Discover AT3, Tire size: 265/75/R16, DOT Number: UPWM1M11718M16L. The contact stated that while driving 65 MPH, the rear driver’s side tire had a sidewall blowout. The contact stated that all four tires had sidewall blowouts...

MY TRUCK HAS MAJOR ENGINE DAMAGE BOUGHT IT AND THREE DAYS LATER THE EGR WENT OUT THEN NEXT THING YOU KNOW I GOT A BLOWN MOTOR

Mileage: 170,000

MY TRUCK HAS MAJOR ENGINE DAMAGE BOUGHT IT AND THREE DAYS LATER THE EGR WENT OUT THEN NEXT THING YOU KNOW I GOT A BLOWN MOTOR

Mileage: 170,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY LOSS MOTIVE POWER AND STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE HOWEVER, THE FAILURE RECURRED. UPON INSPECTION, THE CONTACT DISCOVERED THE FUEL FILTER WAS COVERED...

Mileage: 332,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OFF TO THE SIDE OF THE ROAD AND MADE MULTIPLE ATTEMPTS TO RESTART THE VEHICLE HOWEVER, THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO ...

Mileage: 220,000

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF. ALSO, WHILE IDLING, THE ENGINE RPMS REMAINED VERY HIGH AND THE VEHICLE WOULD ATTEMPT TO SURGE FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE ICP SENSOR AND INJECTOR CONTRO...

Mileage: 200,000

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF. ALSO, WHILE IDLING, THE ENGINE RPMS REMAINED VERY HIGH AND THE VEHICLE WOULD ATTEMPT TO SURGE FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE ICP SENSOR AND INJECTOR CONTRO...

Mileage: 200,000

TAKATA INFLATORS; MY VEHICLE STARTED ALL TYPES OF PROBLEMS INTERMITTENT ONES THAT COST ME SEVERAL THOUSAND DOLLARS NEVER FIXING THE PROBLEM THIS IS WERE IT ALL BEGAN,,.MY VEHICLE DIED GOING UP FAIRLY STEEP HILL TO GRAVE YARD, IT IMMEDIATELY ROLLED BACK SHOVING A FAMILY MEMBERS VEHICLE DOWN HILL A ...

Mileage: 268,000

TAKATA INFLATORS; MY VEHICLE STARTED ALL TYPES OF PROBLEMS INTERMITTENT ONES THAT COST ME SEVERAL THOUSAND DOLLARS NEVER FIXING THE PROBLEM THIS IS WERE IT ALL BEGAN,,.MY VEHICLE DIED GOING UP FAIRLY STEEP HILL TO GRAVE YARD, IT IMMEDIATELY ROLLED BACK SHOVING A FAMILY MEMBERS VEHICLE DOWN HILL A ...

Mileage: 268,000

TAKATA INFLATORS; MY VEHICLE STARTED ALL TYPES OF PROBLEMS INTERMITTENT ONES THAT COST ME SEVERAL THOUSAND DOLLARS NEVER FIXING THE PROBLEM THIS IS WERE IT ALL BEGAN,,.MY VEHICLE DIED GOING UP FAIRLY STEEP HILL TO GRAVE YARD, IT IMMEDIATELY ROLLED BACK SHOVING A FAMILY MEMBERS VEHICLE DOWN HILL A ...

Mileage: 268,000

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT PLACED THE GEAR SHIFTER INTO NEUTRAL AND WAS ABLE TO RESTART THE VEHICLE. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. WHILE DRIVING VARIOUS SPEEDS, THE BATTERY, OI...

Mileage: 150,000

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT PLACED THE GEAR SHIFTER INTO NEUTRAL AND WAS ABLE TO RESTART THE VEHICLE. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. WHILE DRIVING VARIOUS SPEEDS, THE BATTERY, OI...

Mileage: 150,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT THE FUEL TANK STRAP WAS SEVERELY CORRODED AND THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT STATED THAT THIS WAS THE SECOND TIME THE FAILURE OCCURRED. AN UNKNOWN FORD DEALER WAS CONTACTED AND REFERRED THE CONTACT TO FORD USA. THE...

Mileage: 82,000

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, IT WAS OBSERVED THAT THE DRIVER AND PASSENGER SIDE INNER ROCKER PANELS HAD SEVERE CORROSION, FAILED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. PRIOR TO THE FAILURE, THE CONTACT NOTICED...

Mileage: 140,590

SPEED CONTROL DOES NOT DISENGAGE WHEN HITTING THE BRAKES. YOU MUST SLOW THE TRUCK DOWN BY SEVERAL MILES PER HOUR BEFORE THE SYSTEM WILL DISENGAGE. (PUSH HARD AND LONG). THE PROBLEM WILL GO AWAY FOR A PERIOD OF TIME IF YOU PREFORM AN EMERGENCY STOP THAT CAUSES THE ANTI-LOCK BRAKE SYSTEM TO ACTIVATE. ...

Mileage: 90,000

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE TO THE SHOULDER TO A COMPLETE STOP. THE VEHICLE WAS STARTED NORMALLY, BUT STALLED AGAIN THE SAME AFTERNOON. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE ...

Mileage: 133,307

WE HAVE HAD FOUR SEPARATE INCIDENTS INVOLVING UNINTENDED ACCELERATION WITH OUR 2004 FORD F350. WHEN APPLYING THE BRAKES, THE VEHICLE SUDDENLY ACCELERATES. IT HAS HAPPENED TWICE GOING DOWN OUR DRIVEWAY, ONCE WHEN DRIVING IN CITY TRAFFIC, AND ONCE WHEN WE WERE PARKING AT A REST STOP. THE VEHICLE WA...

Mileage: 49,000

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING THE VEHICLE, IT EXPERIENCED A COMPLETE LOSS OF POWER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. PRIOR TO THE FAILURE, THE VEHICLE WAS ...

Mileage: 100,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY SHUT OFF AND ON SEVERAL OCCASIONS WOULD NOT START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DETERMINED THAT THE FUEL INJECTION CONTROL MODULE WIRE HARNESS NEEDED T...

Mileage: 83,000

WHILE APPLYING BRAKES IN AN ATTEMPT TO STOP, THE BRAKE PEDAL UNEXPECTEDLY WENT DIRECTLY TO THE FLOOR, THUS DISALLOWING THE TRUCK TO STOP. THE PEDAL WAS ABLE TO BE PUMPED,UP ENOUGH IN ORDER TO STOP THE TRUCK, BUT ONLY ONE TIME. ATTEMPTS TO PUMP THE PEDAL AND INCREASE THE PRESSURE ENOUGH FOR FUTURE ...

Mileage: 91,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE POWER STEERING FAILED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

TL*THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DISCOVERED THAT OIL WAS LEAKING FROM THE HEAD GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FA...

Mileage: 210,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 37,237.

Mileage: 37,237

MY VEHICLE HAS BEEN BUCKING AND JERKING INTERMITTENTLY SINCE WAY BEFORE ABOVE.DATE IT STOPPED RUNNING AT A STOP SIGN THEN BUCKED AND JERKED SO IN 2013 IT GOT SO BAD THAT I FINALLY HAD IT CHECKED OUT. I THOUGHT IT WAS TRANSMISSION, HAD IT CHECKED AND WAS REFERRED TO LOCAL MECHANIC WHO WAS ACQUAIN...

Mileage: 44,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THE EXHAUST SYSTEM WARNING LIGHT ILLUMINATED AND THE ENGINE LOSS POWER. THE VEHICLE RESTARTED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 07V139000 (POWER TRAIN). THE ...

CAM POSITION SENSOR FAILURE, VEHICLE WILL NOT START, FOUND COOLANT IN OIL ON REPAIR. *TR

Mileage: 162,317

CRACKED HEAD, RESULTING IN COOLANT IN ENGINE OIL, HARD STARTING OR FAILURE TO START. *TR

Mileage: 163,596

VEHICLE HARD STARTING CAUSED BY FAILURE OF HIGH PRESSURE OIL PUMP, REPLACED ICP REGULATOR, REPLACED EGR VALVE AND INTAKE GASKETS. *TR

Mileage: 173,603

CHECK ENGINE LIGHT/NO POWER/HARD STARTING- REPLACED EXHAUST BACK PRESSURE SENSOR- VEHICLE FAILURE OF AMBULANCE RESPONDING TO A CALL. *TR

Mileage: 176,063

SHORTLY AFTER STARTING FROM A STOP THE VEHICLE LOST POWER AND HAD TO BE TOWED TO REPAIR SHOP. PROBLEM DIAGNOSED AND REPAIRED AS REPLACING THE PCM AND REFLASH OF THE ONBOARD COMPUTER. *TR

Mileage: 176,253

WHILE DRIVING VEHICLE HAS INTERMITTENT LOSS OF POWER, DIAGNOSED AND SERVICED EGR VALVE, REPLACED EGR THROTTLE VALVE AND SEALED THE BOOST INLET TUBE. *TR

Mileage: 176,159

VEHICLE WILL NOT START, CRANKS BUT DOES NOT START. DIAGNOSED AND REPLACED CAM POSITION SENSOR. *TR

Mileage: 199,958

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE ENGINE STALLED AND WAS ABLE TO RESTART. THE FAILURE OCCURRED ON FOUR OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PRESSURE SENSOR NEEDED TO BE REPLACED. TH...

Mileage: 116,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE AT A STOP, THE VEHICLE SURGED FORWARD. THE CONTACT ALSO STATED EXCESSIVE FORCE WAS APPLIED TO THE BRAKE PEDAL WHEN MAKING A STOP. IN ADDITION, THE VEHICLE STALLED ON MULTIPLE OCCASIONS. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE...

Mileage: 18,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE VEHICLE WOULD SUDDENLY HESITATE AND THE SPEED WOULD DECELERATE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE INJECTOR CONTROL PRESSURE SENSOR WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFA...

Mileage: 100,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT TOOK THE VEHICLE TO THE DEALER, WHO STATED THAT THE COMPUTER MODULE WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED THE FOLLOWING DAY AND THE VEHICLE WAS TAKEN B...

Mileage: 140,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT TOOK THE VEHICLE TO THE DEALER, WHO STATED THAT THE COMPUTER MODULE WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED THE FOLLOWING DAY AND THE VEHICLE WAS TAKEN B...

Mileage: 140,000

FOR UNKNOWN REASONS ON 12/20/13 AT 0030 HRS MY TRUCK CAUGHT ON FIRE AS IT SAT IN MY DRIVEWAY. I DROVE THE TRUCK LAST ON 12/14/13. THE FIRE STARTED IN THE ENGINE COMPARTMENT ON THE DRIVERS SIDE. I HAVE OWNED THE TRUCK FOR ABOUT 8 MONTHS AND IT HAD 105000 MILES ON IT WHEN I PURCHASED IT. THE FIRE D...

Mileage: 111,000

FOR UNKNOWN REASONS ON 12/20/13 AT 0030 HRS MY TRUCK CAUGHT ON FIRE AS IT SAT IN MY DRIVEWAY. I DROVE THE TRUCK LAST ON 12/14/13. THE FIRE STARTED IN THE ENGINE COMPARTMENT ON THE DRIVERS SIDE. I HAVE OWNED THE TRUCK FOR ABOUT 8 MONTHS AND IT HAD 105000 MILES ON IT WHEN I PURCHASED IT. THE FIRE D...

Mileage: 111,000

WHILE TRAVELING THROUGH TN, TOWING A TRAILER, THE FRONT DRIVER'S SIDE TIRE DELAMINATED AND BLEW. THIS CAUSED THE VEHICLE TO VEER ACROSS THE MERIDIAN AND ALMOST INTO ON-COMING TRAFFIC. THE DAMAGES INCLUDE THE RIM, FENDER, WHEEL WELL, FRONT BUMPER AND FAIRING. THIS IS A ESTIMATE, THE VEHICLE GOES INTO...

Mileage: 47,000

WHILE TRAVELING THROUGH TN, TOWING A TRAILER, THE FRONT DRIVER'S SIDE TIRE DELAMINATED AND BLEW. THIS CAUSED THE VEHICLE TO VEER ACROSS THE MERIDIAN AND ALMOST INTO ON-COMING TRAFFIC. THE DAMAGES INCLUDE THE RIM, FENDER, WHEEL WELL, FRONT BUMPER AND FAIRING. THIS IS A ESTIMATE, THE VEHICLE GOES INTO...

Mileage: 47,000

WHILE TRAVELING THROUGH TN, TOWING A TRAILER, THE FRONT DRIVER'S SIDE TIRE DELAMINATED AND BLEW. THIS CAUSED THE VEHICLE TO VEER ACROSS THE MERIDIAN AND ALMOST INTO ON-COMING TRAFFIC. THE DAMAGES INCLUDE THE RIM, FENDER, WHEEL WELL, FRONT BUMPER AND FAIRING. THIS IS A ESTIMATE, THE VEHICLE GOES INTO...

Mileage: 47,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING 65 MPH. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE AN INDEPENDENT MECHANIC PERFORMED A DIAGNOSTIC. THE FAILURE WAS LOCATED AT THE FUEL INJECTION PRESSURE SENSOR. THE MANUFACT...

Mileage: 85,000

TL* THE CONTACT OWNS A 2004 FORD F350. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE...

Mileage: 74,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE REDUCED POWER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE FUEL INJECTORS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, ...

Mileage: 235,000

ENGINE BEGAN BUCKING, SUDDEN POWER LOSS AND POWER STEERING AND POWER BRAKE LOSS. MECHANIC CONCLUSION WAS THAT THE LINING OF THE FUEL TANK HAD DISLODGED AND CAUSED THE ENGINE TO FOUL, CAUSING A SUDDEN POWER LOSS. DEALER SAID THEY HAD NEVER HEARD OF THE PROBLEM BUT WE LATER LEARNED THEY WERE VERY FA...

Mileage: 73,251

ENGINE BEGAN BUCKING, SUDDEN POWER LOSS AND POWER STEERING AND POWER BRAKE LOSS. MECHANIC CONCLUSION WAS THAT THE LINING OF THE FUEL TANK HAD DISLODGED AND CAUSED THE ENGINE TO FOUL, CAUSING A SUDDEN POWER LOSS. DEALER SAID THEY HAD NEVER HEARD OF THE PROBLEM BUT WE LATER LEARNED THEY WERE VERY FA...

Mileage: 73,251

ENGINE BEGAN BUCKING, SUDDEN POWER LOSS AND POWER STEERING AND POWER BRAKE LOSS. MECHANIC CONCLUSION WAS THAT THE LINING OF THE FUEL TANK HAD DISLODGED AND CAUSED THE ENGINE TO FOUL, CAUSING A SUDDEN POWER LOSS. DEALER SAID THEY HAD NEVER HEARD OF THE PROBLEM BUT WE LATER LEARNED THEY WERE VERY FA...

Mileage: 73,251

ENGINE BEGAN BUCKING, SUDDEN POWER LOSS AND POWER STEERING AND POWER BRAKE LOSS. MECHANIC CONCLUSION WAS THAT THE LINING OF THE FUEL TANK HAD DISLODGED AND CAUSED THE ENGINE TO FOUL, CAUSING A SUDDEN POWER LOSS. DEALER SAID THEY HAD NEVER HEARD OF THE PROBLEM BUT WE LATER LEARNED THEY WERE VERY FA...

Mileage: 73,251

THE FRONT END AUTO HUB DID NOT DISCONNECT FROM 4 WHEEL DRIVE. THE POSITION SWITCH WAS AT 2 WHEEL DRIVE. THE DASH LIGHT SHOWING 4 WHEEL DRIVE WAS OFF. NOTHING INDICATED THE VACUUM SYSTEM HAD FAILED TO CORRECTLY POSITION THE AUTO HUB. THE FRONT HUB GEARING WAS DESTROYED. NOISE AND FUNNY STEERING. ...

Mileage: 81,191

TL* THE CONTACT OWNS A 2004 FORD F-350 SD EQUIPPED WITH MICKEY THOMPSON BAJA MTZ TIRES, SIZE 395/75/16. THE CONTACT WAS DRIVING 40 MPH WHEN THE REAR PASSENGER TIRE EXPLODED. THE CONTACT STATED THAT THERE WERE SEVERAL NARROW CUTS ON THE INSIDE SIDEWALL OF THE TIRE. THE CUTS WERE ALSO PRESENT ON THE ...

Mileage: 80,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT COOLANT WAS OBSERVED LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE HEAD GASKET NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE...

Mileage: 60,000

TL* THE CONTACT OWNS A SET OF NITTO MUD GRAPPLER TIRES, SIZE 35/14/16, THAT WERE EQUIPPED ON A 2004 FORD F-350. WHILE TRAVELING 40 MPH, THE CONTACT NOTICED THAT THE FRONT DRIVER SIDE TIRE HAD A SUDDEN BLOWOUT. AFTER EXAMINING THE TIRE THE CONTACT NOTICED THAT THE TIRE WAS SPLIT IN SEVERAL AREAS. TH...

Mileage: 14,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT THE VEHICLE ENGINE FAILED. THE ENGINE BLOCK WAS CORRODED DUE TO DEFECTIVE MATERIAL AND LEAKED CAUSED COOLANT TO LEAK. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT THE ENGINE WOULD NEED TO BE REPLACED. THE MANUFACTURE...

Mileage: 26,000

MY 2004 FORD F-350 6.0 DIESEL. HESITATE OR SURGES WHILE DRIVING, AND/OR THE ENGINE MAY STALL WHILE DRIVING AT ALL SPEEDS INCLUDING HIGHWAY SPEED, WILL LOSE POWER STEERING AND BRAKES AND WHEN AT A STOP IT WILL LUNGE FORWARD. THE ENGINE MAY OR MAY NOT RESTART AFTER STALL. I FEEL THAT THIS IS A GREAT ...

Mileage: 89,000

MY 2004 FORD F-350 6.0 DIESEL. HESITATE OR SURGES WHILE DRIVING, AND/OR THE ENGINE MAY STALL WHILE DRIVING AT ALL SPEEDS INCLUDING HIGHWAY SPEED, WILL LOSE POWER STEERING AND BRAKES AND WHEN AT A STOP IT WILL LUNGE FORWARD. THE ENGINE MAY OR MAY NOT RESTART AFTER STALL. I FEEL THAT THIS IS A GREAT ...

Mileage: 89,000

MY 2004 FORD F-350 6.0 DIESEL. HESITATE OR SURGES WHILE DRIVING, AND/OR THE ENGINE MAY STALL WHILE DRIVING AT ALL SPEEDS INCLUDING HIGHWAY SPEED, WILL LOSE POWER STEERING AND BRAKES AND WHEN AT A STOP IT WILL LUNGE FORWARD. THE ENGINE MAY OR MAY NOT RESTART AFTER STALL. I FEEL THAT THIS IS A GREAT ...

Mileage: 89,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE DECELERATED TO APPROXIMATELY 5 MPH AND THE LIMP HOME MODE MESSAGE APPEARED ON THE INSTRUMENT PANEL. THE VEHICLE WAS SAFELY DRIVEN TO AN AUTHORIZED DEALER, WHERE THE CONTACT WAS INFORMED THAT THE EGR AND...

Mileage: 72,000

LOSS OF COOLANT, WHITE SMOKE EXITING OUT OF EXHAUST. ENGINE OVER HEATING. CAN LEAD TO BLOWN HEAD GASKETS. *TR

Mileage: 83,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE BEGAN TO FUNCTION WITH DIFFICULTY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE GRV VALVE, OIL COOLER AND THE TURBO HAD TO BE DISASSEMBLED AND REBUILT. THE DEALER STAT...

Mileage: 80,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT WAS DRIVING 50 MPH WHEN THE VEHICLE INDEPENDENTLY DECREASED IN SPEED. THE VEHICLE WAS TAKEN TO THE DEALER. THE FAILURE DIAGNOSIS WAS THAT THE PINTLE FROM THE FUEL INJECTOR HAD BROKEN. THE VEHICLE WAS REPAIRED, AND THE MANUFACTURER WAS CONTACTED. T...

Mileage: 74,881

OWN A 2004 FORD F-350 SD. FOR YEARS HAVE HAD SURGING PROBLEMS WHEN DRIVING. HAVE TAKEN INTO SHOP AND THEY CANNOT DETERMINE REASON. IT HAPPENS WHILE STOPPED OR DRIVING, SURGING AND TRYING TO JUMP BECAUSE OF THE SURGE. TURBO CHARGER HAS NOT BEEN REPLACED. *TR

Mileage: 45,000

SINCE NEW MY 2004 F 350 HAS HAD A BOUNCING ISSUE @ 38 TO 45 MPH REGUARDLESS OF ACCLERATION OR DECELLERATION ITS THERE NOW ITS BAD ENOUGH IT WILL SPILL DRINKS THAT ARE IN THE CUP HOLDER. HAVE WENT THROUGH NUMEROUS SETS/BRANDS OF TIRES INSTALLED NEW SHOCKS HAVE TRIED VARIOUS TIRE PRESSURE COMBOS. HAVE...

Mileage: 100,000

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT WAS DRIVING APPROXIMATELY 50 MPH WHEN THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED AND WAS TAKEN TO THE DEALER. THE VEHICLE WAS DIAGNOSED AS THE FICM WIRING HARNESS NEEDING REPLACEMENT. THE DEALER ADVISED THAT ...

Mileage: 98,800

SUDDEN POWER LOSSES AT HIGHWAY SPEEDS RESULTING IN ENGINE SHUTTING OFF AND NOT BEING ABLE TO BE RESTARTED. *TR

Mileage: 121,355

TL*THE CONTACT OWNS A 2004 FORD F-350. UPON ENTERING THE VEHICLE HE APPLIED PRESSURE TO THE BRAKE PEDAL AND IT EXTENDED TO THE FLOOR. HE STEPPED OUT OF THE VEHICLE AND NOTICED BRAKE FLUID LEAKING FROM UNDERNEATH. HE ALSO NOTICED THAT THE BRAKE LINES WERE COMPLETELY COVERED WITH RUST. THE VEHICLE WA...

Mileage: 123,000

GENERAL TIRES - AMERITRAC MTS LT 235/85R16 - ON 9/23/2010 WE WERE DRIVING ON I-75 IN 2004 FORD F-350 SUPER DUTY DUALLY - THE LEFT FRONT TREAT SEPARATED FROM THE TIRE, THE TIRE DIDN'T LOOSE TIRE PRESSURE, BUT IT CAME APART. IT DAMAGED THE LEFT FRONT FENDER, FRONT BUMPER, AND DRIVER SIDE DOOR. THESE...

Mileage: 50,051

ON 6-13-09 I HAD A TIRE EXPLODE ON MY 2004 FORD F350 SUPER DUTY PICKUP TRUCK WHILE DRIVING ON THE NORTHEAST EXTENSION OF THE PA TURNPIKE. WE WERE PULLING A 5TH WHEEL TRAILER LOADED WITH ATV'S AND MY HUSBAND AND I HAD OUR 11 YEAR OLD NIECE AND 12 YEAR OLD NEPHEW WITH US. WE STRUCK A MINIVAN. THE MINI...

Mileage: 38,000

TL* THE CONTACT OWNS A 2004 FORD F350. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR FACILITY FOR ROUTINE BRAKE MAINTENANCE. THE MECHANIC ADVISED THAT THE REAR BACKING PLATES ON BOTH REAR WHEELS WERE COMPLETELY RUSTED AND WERE AFFECTING THE BRAKE PADS. THE MECHANIC WAS ABLE TO MA...

Mileage: 150,000

TL* THE CONTACT OWNS A 2004 FORD F350. THE CONTACT WAS DRIVING AT APPROXIMATELY 40 MPH WHEN THE VEHICLE SUDDENLY BEGAN TO SHAKE AND JERK FORWARD. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO INFORMED THE CONTACT THAT THE EGR COOLER AND THREE FUEL INJECTORS WERE THE CAUSE FOR THE FAILURE. THE VEHICL...

Mileage: 121,000

TL* THE CONTACT OWNS A 2004 FORD F350. THE CONTACT WAS DRIVING AT APPROXIMATELY 40 MPH WHEN THE VEHICLE SUDDENLY BEGAN TO SHAKE AND JERK FORWARD. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO INFORMED THE CONTACT THAT THE EGR COOLER AND THREE FUEL INJECTORS WERE THE CAUSE FOR THE FAILURE. THE VEHICL...

Mileage: 121,000

SINCE NEW VEHICLE PURCHASE, MY FORD F350 DIESEL P/U EXPERIENCED ENGINE SURGING (200-250 RPM) WHILE STOPPED WITH THE AUTOMATIC TRANSMISSION IN DRIVE. THE SURGE WAS SIGNIFICANT ENOUGH TO LURCH THE TRUCK FORWARD WITH THE BRAKE APPLIED, SUCH AS AT A STOPLIGHT. IN SEVERAL CASES, I ALMOST REAR ENDED OTH...

Mileage: 3,000

SINCE NEW VEHICLE PURCHASE, MY FORD F350 DIESEL P/U EXPERIENCED ENGINE SURGING (200-250 RPM) WHILE STOPPED WITH THE AUTOMATIC TRANSMISSION IN DRIVE. THE SURGE WAS SIGNIFICANT ENOUGH TO LURCH THE TRUCK FORWARD WITH THE BRAKE APPLIED, SUCH AS AT A STOPLIGHT. IN SEVERAL CASES, I ALMOST REAR ENDED OTH...

Mileage: 3,000

2004 F350 DIESEL 6.0 ,EGR COOLER WENT OUT. I WAS IN THE MIDDLE OF THE HWY WHEN THIS OCCURED. CLOUDS OF SMOKE WENT OUT THE TAILPIPE, ENGINE OVERHEATING STRANDING ME IN THE CENTER LANE STOPPED BEFORE I COULD GET OVER TO THE SHOULDER. PASSERBY'S HELP ME PUSH MY TRUCK OFF A BUSY HWY. SMOKE WAS SO THICK ...

Mileage: 86,000

2004 F350 DIESEL 6.0 ,EGR COOLER WENT OUT. I WAS IN THE MIDDLE OF THE HWY WHEN THIS OCCURED. CLOUDS OF SMOKE WENT OUT THE TAILPIPE, ENGINE OVERHEATING STRANDING ME IN THE CENTER LANE STOPPED BEFORE I COULD GET OVER TO THE SHOULDER. PASSERBY'S HELP ME PUSH MY TRUCK OFF A BUSY HWY. SMOKE WAS SO THICK ...

Mileage: 86,000

TL*- THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT INTERMITTENTLY WHILE DRIVING, THE VEHICLE WOULD STALL FOR 2-3 MINUTES, FOLLOWED BY A CLOUD OF SMOKE COMING OUT OF THE EXHAUST PIPE. ENGINE FAILURE WHILE DRIVING INCREASES THE RISK FOR VEHICLE CRASH. THE VEHICLE WAS TAKEN TO THE DEALERS...

Mileage: 94,000

TL*THE CONTACT OWNS A 2004 FORD F350 CREW CAB DIESEL. THE VEHICLE HAS 6 GENERAL 87516 TIRES, SIZE, P235/85R16. WHILE DRIVING 65 MPH, THE TREAD SHREDDED OFF THE TIRES AND DESTROYED THE FENDERS. THE FIRST FENDER COST $1,100 TO REPAIR. THE FAILURE OCCURRED A SECOND TIME ON JUNE 3, 2009. THE TIRES ...

Mileage: 42,500

2004 F350 6.0 POWERSTROKE BOGGS WHEN TAKING OFF. SOMETIMES WILL ACT LIKE YOU TURNED OFF SWITCH WHEN YOU PUSH DOWN THE PEDAL THERE IS NO EFFECT. MOSTLY WHEN DRIVING UP THE MOUNTAIN ITS LIKE IT DON'T GO PAST IDLE HAS NOT STALLED YET. 8 INJECTORS REPLACED FRONT AND REAR INJECTOR HARNESS REPLACED HIGH P...

Mileage: 50,000

TL*THE CONTACT OWNS A 2004 FORD F350. THE CONTACT STATED THAT SMOKE APPEARED FROM THE EGR COOLER TUBE. SHE ALSO SMELLED ANTIFREEZE IN THE CAB OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT IT WAS STILL SAFE TO DRIVE AND TO RETURN IF THE FAILURE WORSENED. LATER, THE CONT...

Mileage: 79,000

TL*THE CONTACT OWNS A 2004 FORD F350. THE CONTACT STATED THAT SMOKE APPEARED FROM THE EGR COOLER TUBE. SHE ALSO SMELLED ANTIFREEZE IN THE CAB OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT IT WAS STILL SAFE TO DRIVE AND TO RETURN IF THE FAILURE WORSENED. LATER, THE CONT...

Mileage: 79,000

TL*THE CONTACT OWNS A 2004 FORD F350. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED. THE DEALER REPLACED THE INJECTOR CONTROL WIRING MODULE AND THE OWNER WAS RESPONSIBLE FOR PAYING $2200. AFTER THE REPAIR, THE VEHICLE MISS FIRED, BLACK SMOKE WAS IN THE ENGINE AREA AND THEIR WAS TRODDLE RES...

TL*THE CONTACT OWNS A 2004 FORD F350. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED. THE DEALER REPLACED THE INJECTOR CONTROL WIRING MODULE AND THE OWNER WAS RESPONSIBLE FOR PAYING $2200. AFTER THE REPAIR, THE VEHICLE MISS FIRED, BLACK SMOKE WAS IN THE ENGINE AREA AND THEIR WAS TRODDLE RES...

Mileage: 217,000

TL*THE CONTACT OWNS A 2004 FORD F350. WHILE DRIVING AT HIGHWAY SPEEDS, THE VEHICLE WILL SPONTANEOUSLY DECELERATE FROM 60 MPH TO 15 MPH. IN ADDITION, THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AND A MECHANIC STATED THAT TH...

Mileage: 40,000

THE GAS TANK FAILED ON MY 2004 FORD TRUCK WITH ONLY 23,000 MILES ON IT CAUSING ENGINE DAMAGE. *TR

Mileage: 23,000

TL*THE CONTACT OWNS A 2004 FORD F350. IN JANUARY OF 2008, WHILE DRIVING 40 MPH, THE VEHICLE STALLED. THE CONTACT PARKED THE VEHICLE AND ATTEMPTED TO RESTART IT, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE LINER IN THE FUEL TANK DELAMINATED, CAUSING PLASTIC P...

Mileage: 45,000

2004 FORD F350 DUMP TRUCK SHUTS DOWN WITH NO WARNING. CONSUMER STATES THAT FORD WILL NOT HONOR TRUCK WARRANTY AND WILL NOT REPAIR THE PROBLEM. *NJ THE CONSUMER STATED WHEN THE DUMP TRUCK SHUT DOWN, THERE WAS NO POWER STEERING OR BRAKES. THE DEALER STATED THE PROBLEM WAS WITH THE DIESEL TANK AN...

2004 FORD F350 DUMP TRUCK SHUTS DOWN WITH NO WARNING. CONSUMER STATES THAT FORD WILL NOT HONOR TRUCK WARRANTY AND WILL NOT REPAIR THE PROBLEM. *NJ THE CONSUMER STATED WHEN THE DUMP TRUCK SHUT DOWN, THERE WAS NO POWER STEERING OR BRAKES. THE DEALER STATED THE PROBLEM WAS WITH THE DIESEL TANK AN...

TL*THE CONTACT OWNS A 2004 FORD 350 DIESEL. WHILE DRIVING 60 MPH, THE FRONT PASSENGER TIRE BLEW OUT. A TOWING SERVICE REPLACED THE TIRE. THE TIRE SHOP INSPECTED THE TIRES AND NOTICED THAT THE VALVE STEMS ON THE OTHER 3 TIRES WERE DEFECTIVE, HOWEVER HE STATED THAT THE TIRE THAT EXPLODED DID NOT HA...

Mileage: 60,000

TL*THE CONTACT OWNS A 2004 FORD 350 DIESEL. WHILE DRIVING 60 MPH, THE FRONT PASSENGER TIRE BLEW OUT. A TOWING SERVICE REPLACED THE TIRE. THE TIRE SHOP INSPECTED THE TIRES AND NOTICED THAT THE VALVE STEMS ON THE OTHER 3 TIRES WERE DEFECTIVE, HOWEVER HE STATED THAT THE TIRE THAT EXPLODED DID NOT HA...

Mileage: 60,000

WE HAVE A FORD F350 4X4 DULLY WITH GENERAL AMERI-TRAC TIRES. WAS TRAVELING ON I-20 INTERSTATE WITH CRUISE SET ON 70. ALL OF A SUDDEN IT STARTED SNOWING RUBBER. THOUGH TIRE NEVER WENT FLAT, IT CAUSED $2,540.00 IN DAMAGE TO THE VEHICLE,AND A VERY SCARED WOMAN WHOSE PRESENCE OF MIND AVERTED A LIFE-THRE...

Mileage: 54,800

MY 2004 FORD F-360 TRUCK WOULD "CUT OUT" AND TRY TO QUIT RUNNING WHEN SLOWING FOR A STOP SIGN OR RED LIGHT. THOUGHT IT WAS BAD FUEL, FUEL FILTERS. HAD RECALLS DONE (GFR). PROBLEM BEGAN AGAIN AND WHILE MY DAUGHTER WAS PULLING A 16 FT. TRAILER WITH ONE HORSE LOADED, BEGAN TO EMIT WHITE SMOKE FROM T...

Mileage: 104,000

I HAVE A 2004 F-350 SUPERDUTY 4X4 [6.0 DIESEL]. I DROVE THROUGH WATER THE DEPTH OF THE STOCK TIRES. THE ENGINE INGESTED WATER BY WAY OF THE INTAKE. I WAS ADVISED BY THE FORD DEALERSHIP THAT THE INCIDENT DESTROYED THE ENGINE. THE AIR INTAKE IS LOCATED AT THE FRONT GRILL. I BELIEVE THIS IS A FLAW IN D...

Mileage: 50,047

TL*THE CONTACT OWNS A 2004 FORD F350. WHILE DRIVING 55 MPH, THE FRONT END BEGAN SHAKING BADLY AND THE VEHICLE JUMPED INTO SEVERAL LANES. THE BODY OF THE VEHICLE WAS VEERING TO THE RIGHT WHILE THE FRONT END VEERED TO THE LEFT. THE CONTACT WAS ABLE TO BRAKE SLOWLY AND PULLED OVER ON THE SHOULDER. ...

Mileage: 88,000

ON 01-06-2008 I STARTED TO HAVE SIGNIFICANT PROBLEMS WITH MY 2004 FORD F-350. IT HAS JUST OVER 41,000 MILES ON IT. IT WAS SMOKING AND HAD SIGNIFICANT LOSS OF POWER PROBLEMS WHILE AT LOW ROAD SPEED. PROBLEM WOULD CLEAR ONCE TRUCK WAS >40 MPH IN SPEED. TOOK IT TO LOCAL FORD DEALER ON 01-07-2008....

Mileage: 41,070

TL*THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING 5 MPH, THE CLUTCH PEDAL BROKE WHEN DEPRESSED. THE CONTACT STATED THAT THE VEHICLE WOULD NOT STOP UNTIL HE SHUT OFF THE IGNITION. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE BRACKET THAT HELD THE FIRE WALL BROKE. THE DEALER S...

Mileage: 63,000

TL*THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING 5 MPH, THE CLUTCH PEDAL BROKE WHEN DEPRESSED. THE CONTACT STATED THAT THE VEHICLE WOULD NOT STOP UNTIL HE SHUT OFF THE IGNITION. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE BRACKET THAT HELD THE FIRE WALL BROKE. THE DEALER S...

Mileage: 63,000

THE TRUCK STALLED IN RUSH HOUR TRAFFIC, JUST BEFORE THE ENTRANCE TO A TUNNEL. THIS COULD HAVE BEEN A VERY SERIOUS SAFETY ISSUE HAD I NOT BEEN ABLE TO GET OUT OF THE TRAVEL LANES OF THE INTERSTATE. MANAGED TO CROSS FROM THE RIGHT LANE, ACROSS A MERGE LANE TO THE SHOULDER. MANAGED TO RESTART ENGIN...

Mileage: 54,000

THE TRUCK STALLED IN RUSH HOUR TRAFFIC, JUST BEFORE THE ENTRANCE TO A TUNNEL. THIS COULD HAVE BEEN A VERY SERIOUS SAFETY ISSUE HAD I NOT BEEN ABLE TO GET OUT OF THE TRAVEL LANES OF THE INTERSTATE. MANAGED TO CROSS FROM THE RIGHT LANE, ACROSS A MERGE LANE TO THE SHOULDER. MANAGED TO RESTART ENGIN...

Mileage: 54,000

ON MARCH 5 2007 I WAS HAVING PROBLEMS STEERING MY TRUCK. I TOOK IT TO AN ALIGNMENT SHOP. THEY TOLD ME TO TAKE IT TO THE FORD DEALERSHIP. FORD SAID THEY REPAIRED THE PROBLEM. 4 DAYS LATER I LOST CONTROL OF THE TRUCK IN A CURVE AND HIT A DUMP TRUCK. THE ALIGNMENT SHOP LATER TOLD ME THAT THE TRUCK HAD ...

Mileage: 35,570

TL*THE CONTACT OWNS A 2004 FORD F350. WHILE AT A STOP LIGHT, THE ENGINE WOULD REV. DEPENDING ON THE CONTACT'S REACTION TIME, THE VEHICLE WOULD MOVE 4-5 FEET. THERE WERE NO WARNING INDICATORS. THE RPM WOULD INCREASE TO 1,000. THE DEALER REPLACED THE CONTROL MODULE, THREE TURBOS, THREE EGR VALVES...

Mileage: 40,000

TL*THE CONTACT OWNS A 2004 FORD F350. WHILE AT A STOP LIGHT, THE ENGINE WOULD REV. DEPENDING ON THE CONTACT'S REACTION TIME, THE VEHICLE WOULD MOVE 4-5 FEET. THERE WERE NO WARNING INDICATORS. THE RPM WOULD INCREASE TO 1,000. THE DEALER REPLACED THE CONTROL MODULE, THREE TURBOS, THREE EGR VALVES...

Mileage: 40,000

VEHICLE HAD A STALLING PROBLEM ON ACCELLERATION. VEHICLE IDLED FINE, BUT FREQUENTLY ON ACCELERATION FROM A STOP AFTER VEHICLE STARTED TO ROLL. ENGINE WILL MISFIRE, SHUTTER, OR BACKFIRE FOR SEVERAL SECONDS UNTIL CLEARING UP. ALSO, VEHICLE MISFIRED AT HIGHWAY SPEEDS. VEHICLE WAS TAKEN TO THE DEALE...

Mileage: 3,000

VEHICLE HAD A STALLING PROBLEM ON ACCELLERATION. VEHICLE IDLED FINE, BUT FREQUENTLY ON ACCELERATION FROM A STOP AFTER VEHICLE STARTED TO ROLL. ENGINE WILL MISFIRE, SHUTTER, OR BACKFIRE FOR SEVERAL SECONDS UNTIL CLEARING UP. ALSO, VEHICLE MISFIRED AT HIGHWAY SPEEDS. VEHICLE WAS TAKEN TO THE DEALE...

Mileage: 3,000

VEHICLE HAD A STALLING PROBLEM ON ACCELLERATION. VEHICLE IDLED FINE, BUT FREQUENTLY ON ACCELERATION FROM A STOP AFTER VEHICLE STARTED TO ROLL. ENGINE WILL MISFIRE, SHUTTER, OR BACKFIRE FOR SEVERAL SECONDS UNTIL CLEARING UP. ALSO, VEHICLE MISFIRED AT HIGHWAY SPEEDS. VEHICLE WAS TAKEN TO THE DEALE...

Mileage: 3,000

THE PICKUP TRUCK KEEPS RUNNING VERY ROUGH AND LURCHING FORWARD WHILE IN DRIVE. THE TRUCK HAS ALMOST COMPLETELY DIED ON ME SEVERAL TIMES. EVEN WHEN YOU HAVE YOUR FOOT ON THE BRAKE IT WILL LUNGE FORWARD AND HAS ALMOST CAUSED ME TO HIT THE CAR IN FRONT OF ME. I HAVE TAKEN IT TO THE DEALER 5 OR 6 TIME O...

Mileage: 82,000

THE PICKUP TRUCK KEEPS RUNNING VERY ROUGH AND LURCHING FORWARD WHILE IN DRIVE. THE TRUCK HAS ALMOST COMPLETELY DIED ON ME SEVERAL TIMES. EVEN WHEN YOU HAVE YOUR FOOT ON THE BRAKE IT WILL LUNGE FORWARD AND HAS ALMOST CAUSED ME TO HIT THE CAR IN FRONT OF ME. I HAVE TAKEN IT TO THE DEALER 5 OR 6 TIME O...

Mileage: 82,000

I PURCHASED A NEW 2004 FORD F-350 IN OCTOBER 2004. SINCE THAT TIME, I HAVE HAD THE VEHICLE SERVICED 8 TIMES PRIOR TO 6/2006 FOR THE SAME PROBLEM. THE VEHICLE HAS NOT BEEN DRIVEN SINCE THAT TIME AS IT CONTINUOUSLY STALLS WITHOUT WARNING AND NEEDS TO BE FIXED AGAIN. THE VEHICLE DIES FOR NO APPARENT ...

Mileage: 25,000

I BROADSIDED A FORD RANGER THAT RAN A STOP SIGN. TRAVELING AT 35 TO 45 MPH. IT WAS A DIRECT HIT AND NEITHER AIR BAG WENT OFF. MY INSURANCE COMPANY HAS THE TRUCK AND IS LOOKING INTO THE FAILURE. FT. WORTH POLICE OFFICER SAID HE HAD SEEN A 1000 WRECKS AND IF THAT WRECK DID NOT SET THEM OFF THEY ...

Mileage: 58,000

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS AT AN IDLE OR AT VARIOUS SPEEDS, ACCELERATION OCCURRED ON ITS OWN. THE VEHICLE WAS TAKEN TO THE DEALERSHIP TWICE BUT WAS UNABLE TO LOCATE THE PROBLEM WHICH PERSISTED.

Mileage: 19,700

2004 FORD F350 CREWCAB REAR SEAL HAS BEEN REPLACED THREE TIMES, TURBO UNIT HAS BEEN REPLACED TWICE. *KB ***NAR*** THE REAR ABS SENSOR WAS REPLACED. *JB

2004 FORD F350 CREWCAB REAR SEAL HAS BEEN REPLACED THREE TIMES, TURBO UNIT HAS BEEN REPLACED TWICE. *KB ***NAR*** THE REAR ABS SENSOR WAS REPLACED. *JB

2004 FORD F350 CREWCAB REAR SEAL HAS BEEN REPLACED THREE TIMES, TURBO UNIT HAS BEEN REPLACED TWICE. *KB ***NAR*** THE REAR ABS SENSOR WAS REPLACED. *JB

AT JUST UNDER 25,000 MILES, MY ROTORS WERE WARPED ON MY 2004 F350 DIESEL DUALLY (4X4 8'BED CREW CAB). I DO HAUL TRAILERS UNDER 8000 LBS OCCASIONALLY BUT THERE HAS BEEN NO UNDO STRESS ON THIS TRUCK TO WARRANT SUCH A CONDITION SO EARLY. EVEN THOUGH MY BRAKES WERE "IN THE GREEN" AT MY LAST OIL CHANG...

Mileage: 24,987

DT*: THE CONTACT STATED THE VEHICLE STALLED WHILE DRIVING AT ANY SPEED, FUMES WERE LEAKING INTO THE CAB AND THERE WAS AN OIL LEAK. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND REPAIRS. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE STALLING. THE FUEL HOSES ON THE TURBO CHARGER WER...

Mileage: 50,575

DT*: THE CONTACT STATED UPON STARTING THE VEHICLE THE OIL PRESSURE DROPPED AND THE ENGINE DIED. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHERE IT WAS DETERMINED THE OIL PUMP AND THE LOWER INTAKE MANIFOLD GASKETS FAILED. THE OIL PUMP IS MADE OF ALUMINUM WHICH INFLUENCED THE INTEGRITY OF...

Mileage: 75,000

FORD F-350 POWER STROKE DIESEL 2004 HAS STALLED TWICE WHILE DRIVING DOWN THE ROAD. LOOSE POWER STEER AND BRAKES ON HIGHWAY. HAVE REPLACED TURBO CHARGER AND WORKED ON FUEL INJECTION SYSTEM. TURBO CHARGER IS NOW MAKING THE SAME NOISE AGAIN. MILEAGE WHEN WORKED ON 2994/4437/18081. *JB

Mileage: 2,994

FORD F-350 POWER STROKE DIESEL 2004 HAS STALLED TWICE WHILE DRIVING DOWN THE ROAD. LOOSE POWER STEER AND BRAKES ON HIGHWAY. HAVE REPLACED TURBO CHARGER AND WORKED ON FUEL INJECTION SYSTEM. TURBO CHARGER IS NOW MAKING THE SAME NOISE AGAIN. MILEAGE WHEN WORKED ON 2994/4437/18081. *JB

Mileage: 2,994

WHEN TRUCK ORIGINALLY PURCHASED BUBBLE ON TIRE, AND DEALER SAID THEY ALL COME THAT WAY, TIRE WENT FLAT WHILE PARKED ABOUT A MONTH LATER, NO HOLES, WE WERE TOLD TIRE WAS NO GOOD, HAD TO BE REPLACED. TRUCK KEPT STALLING, LOSS OF BRAKES AND STEERING WHILE NAVIGATING DOWNHILL, SOLENOID ASSEMBLY REPLACED...

Mileage: 4,000

WHEN TRUCK ORIGINALLY PURCHASED BUBBLE ON TIRE, AND DEALER SAID THEY ALL COME THAT WAY, TIRE WENT FLAT WHILE PARKED ABOUT A MONTH LATER, NO HOLES, WE WERE TOLD TIRE WAS NO GOOD, HAD TO BE REPLACED. TRUCK KEPT STALLING, LOSS OF BRAKES AND STEERING WHILE NAVIGATING DOWNHILL, SOLENOID ASSEMBLY REPLACED...

Mileage: 4,000

WHEN TRUCK ORIGINALLY PURCHASED BUBBLE ON TIRE, AND DEALER SAID THEY ALL COME THAT WAY, TIRE WENT FLAT WHILE PARKED ABOUT A MONTH LATER, NO HOLES, WE WERE TOLD TIRE WAS NO GOOD, HAD TO BE REPLACED. TRUCK KEPT STALLING, LOSS OF BRAKES AND STEERING WHILE NAVIGATING DOWNHILL, SOLENOID ASSEMBLY REPLACED...

Mileage: 4,000

WHEN TRUCK ORIGINALLY PURCHASED BUBBLE ON TIRE, AND DEALER SAID THEY ALL COME THAT WAY, TIRE WENT FLAT WHILE PARKED ABOUT A MONTH LATER, NO HOLES, WE WERE TOLD TIRE WAS NO GOOD, HAD TO BE REPLACED. TRUCK KEPT STALLING, LOSS OF BRAKES AND STEERING WHILE NAVIGATING DOWNHILL, SOLENOID ASSEMBLY REPLACED...

Mileage: 4,000

WHEN TRUCK ORIGINALLY PURCHASED BUBBLE ON TIRE, AND DEALER SAID THEY ALL COME THAT WAY, TIRE WENT FLAT WHILE PARKED ABOUT A MONTH LATER, NO HOLES, WE WERE TOLD TIRE WAS NO GOOD, HAD TO BE REPLACED. TRUCK KEPT STALLING, LOSS OF BRAKES AND STEERING WHILE NAVIGATING DOWNHILL, SOLENOID ASSEMBLY REPLACED...

Mileage: 4,000

WHEN TRUCK ORIGINALLY PURCHASED BUBBLE ON TIRE, AND DEALER SAID THEY ALL COME THAT WAY, TIRE WENT FLAT WHILE PARKED ABOUT A MONTH LATER, NO HOLES, WE WERE TOLD TIRE WAS NO GOOD, HAD TO BE REPLACED. TRUCK KEPT STALLING, LOSS OF BRAKES AND STEERING WHILE NAVIGATING DOWNHILL, SOLENOID ASSEMBLY REPLACED...

Mileage: 4,000

WHEN TRUCK ORIGINALLY PURCHASED BUBBLE ON TIRE, AND DEALER SAID THEY ALL COME THAT WAY, TIRE WENT FLAT WHILE PARKED ABOUT A MONTH LATER, NO HOLES, WE WERE TOLD TIRE WAS NO GOOD, HAD TO BE REPLACED. TRUCK KEPT STALLING, LOSS OF BRAKES AND STEERING WHILE NAVIGATING DOWNHILL, SOLENOID ASSEMBLY REPLACED...

Mileage: 4,000

DIESEL SMELL IN THE CAB OF A FORD F350 TRUCK WITH 6.0 ENGINE. THIS IS THE SECOND INSTANCE OF THIS IN THIS TRUCK. BOTH HAVE BEEN COVERED BY WARRANTY, BUT THE FIRST TIME WAS IN MAY OF 05 AND THE SECOND TIME WAS FEB 06 IS THIS GOING TO HAPPEN AGAIN. THE SMELL IS SICKENING AND IF YOU DO NOT OPEN THE WIN...

DIESEL SMELL IN THE CAB OF A FORD F350 TRUCK WITH 6.0 ENGINE. THIS IS THE SECOND INSTANCE OF THIS IN THIS TRUCK. BOTH HAVE BEEN COVERED BY WARRANTY, BUT THE FIRST TIME WAS IN MAY OF 05 AND THE SECOND TIME WAS FEB 06 IS THIS GOING TO HAPPEN AGAIN. THE SMELL IS SICKENING AND IF YOU DO NOT OPEN THE WIN...

LOSS OF PULLING POWER ON MY 2004 FORD 350 SUPER DUTY. THE TRUCK WILL LOSE POWER TO PULL UNDER EVEN A SMALL LOAD. WHEN PULLING OUT I HAVE TO HAVE A LARGE AREA OF NO TRAFFIC, HAVE HAD SEVERAL INCIDENTS WHERE I CAME CLOSE TO BEING HIT IN THE SIDE WHEN I HAD A POWER FAILURE AND PULLING ONTO ROADWAY. ...

Mileage: 29,000

LOSS OF PULLING POWER ON MY 2004 FORD 350 SUPER DUTY. THE TRUCK WILL LOSE POWER TO PULL UNDER EVEN A SMALL LOAD. WHEN PULLING OUT I HAVE TO HAVE A LARGE AREA OF NO TRAFFIC, HAVE HAD SEVERAL INCIDENTS WHERE I CAME CLOSE TO BEING HIT IN THE SIDE WHEN I HAD A POWER FAILURE AND PULLING ONTO ROADWAY. ...

Mileage: 29,000

I RECENTLY ATTENDED A FUNERAL FOR MY NEPHEW IN OMAHA, NE. HE HAD DIED ON MONDAY, JANUARY 2, 2006 IN BELLEVUE, NE HE WAS IN A CAR WASH AND (ACCORDING TO SOME WITNESSES), THE FORD F350 SUPER DUTY DIESEL TRUCK (I BELIEVE IT WAS A 2004) SUDDENLY WENT INTO REVERSE AT A HIGH SPEED AND BACKED OUT OF THE ...

2004 F350 TURBO DIESEL PICK UP THE TURBO DIESEL BOOSTER IS DEFECTIVE AND CANNOT BE REPAIRED AS TO MAKE THE TRUCK SAFE WHILE TOWING. THIS MAY CAUSE AN ACCIDENT ON AN UPHILL GRADE BECAUSE OF RAPID LOSE OF POWER AND SPEED. IF A VEHICLE IS FOLLOWING TO CLOSELY BEHIND THIS VEHICLE. MY VEHICLE HAS BE...

Mileage: 13,350

DT: THE VEHICLE STALLED ON THREE DIFFERENT OCCASIONS. THE VEHICLE HAD BEEN TAKEN TO THE DEALERSHIP NUMEROUS TIMES. THE CONSUMER WAS NOT SURE IF THEY HAD REPLACED ANYTHING ON THE VEHICLE. THE VEHICLE WOULD SURGE AT TIMES OR WOULD COMPLETELY STALL. THIS STARTED ON MARCH 1, 2004. THERE WAS NO WA...

I WAS DRIVING MY FORD F350 DOWN A 2 LANE ROAD WITH A TRACTOR TRAILER FOLLOWING CLOSE BEHIND ME AT 60 MPH WHEN MY TRUCK STALLED. TO AVOID BEING CRUSHED BY THE SEMI I VEERED OFF THE ROAD TO THE RIGHT AND PUT MY TRUCK INTO THE DITCH AND THE SEMI HAD TO SWERVE TO MAKE IT ALL THE AROUND ME. THE TRUCK W...

Mileage: 91,890

FORD F-350 DIESEL-2004 CAR SHUT DOWN IN THE PASSING LANE ON PA TURNPIKE. TOWED TO FORD...NO INSULATION ON WIRING HARNESS, SHORTED OUT THE TRUCK. THE TRUCK STOPPED DEAD IN THE ROAD..NOW THE FORD DEALER FIXED IT BY PUTTING INSULATION OVER IT TO GET ME BACK ON THE ROAD. IT HAD BEEN IN THE SHOP THE ...

Mileage: 63,285

WE HAVE HAD SEVERAL INCIDENTS WHERE WE ARE DRIVING THE VEHICLE AND IT WILL BEGIN TO SHAKE AND A PUFF OF BLACK SMOKES COMES OUT OF THE EXHAUST. THEN SHORTLY AFTER THIS HAPPENS, WE YOU STOP AT AN INTERSECTION, THE VEHICLE WILL DIE. THIS HAS HAPPENED SEVERAL TIMES. HAVE HAD IT INTO THE FORD DEALER...

2004 F350. OWNED TRUCK FOR 13 MONTHS, THE TRUCK HAS BEEN IN THE SHOP NUMEROUS TIMES. IT SURGES WHILE DRIVING AND ALSO GOES DEAD WHILE DRIVING. RECALL WORK WAS DONE AND DID NOT FIX THE PROBLEM. *NM

DT: CONTACT STATED THERE HAS BEEN TWO RECALLS THAT HAVE BEEN SERVICED. BUT THE CONSUMER WAS STILL HAVING STALLING PROBLEMS. THE SERVICE DEALER INSPECTED THE FUEL INJECTOR CONTROL MODULE HARNESS AND REPLACED THE INJECTOR CONTROL PRESSURE SENSOR AND REP THE AIR CHARGING COOLER DUCT. MOST OF THE ...

DT: THE CONSUMER EXPERIENCED THREE BLOWS OUT IN SHORT PERIOD OF TIME. THE FIRST BLOW OUT OCCURRED ON THE PASSENGER SIDE. THE SECOND OCCURRED ON THE PASSENGER REAR TIRE AND 50 MILES LATER THE OTHER ONE ON THE DRIVERS SIDE REAR BLEW OUT. *JB

DT: UNDER ACCELERATION BETWEEN 25 AND 45 MPH THE VEHICLE LOSES POWER. THERE IS HESITATION WHEN VEHICLE ACCELERATES. IT IS AS THOUGH IT BOGS DOWN AND CAN NOT GAIN ANY SPEED. ALSO, A LARGE AMOUNT OF BLACK SMOKE WAS EXPELLED FROM THE EXHAUST. WHEN THIS OCCURS THE TRUCK COMES TO CRAWL IN MIDDLE ...

Mileage: 1,000

DT: UNDER ACCELERATION BETWEEN 25 AND 45 MPH THE VEHICLE LOSES POWER. THERE IS HESITATION WHEN VEHICLE ACCELERATES. IT IS AS THOUGH IT BOGS DOWN AND CAN NOT GAIN ANY SPEED. ALSO, A LARGE AMOUNT OF BLACK SMOKE WAS EXPELLED FROM THE EXHAUST. WHEN THIS OCCURS THE TRUCK COMES TO CRAWL IN MIDDLE ...

Mileage: 1,000

DT: UNDER ACCELERATION BETWEEN 25 AND 45 MPH THE VEHICLE LOSES POWER. THERE IS HESITATION WHEN VEHICLE ACCELERATES. IT IS AS THOUGH IT BOGS DOWN AND CAN NOT GAIN ANY SPEED. ALSO, A LARGE AMOUNT OF BLACK SMOKE WAS EXPELLED FROM THE EXHAUST. WHEN THIS OCCURS THE TRUCK COMES TO CRAWL IN MIDDLE ...

Mileage: 1,000

2004 FORD F350 DEVELOPED PROBLEMS WITH THE ENGINE.***NO ANSWER REQUIRED***. *MR THE VEHICLE WOULD RUN ROUGH. THE STARTER BURNED OUT CAUSING THE VEHICLE NOT TO START. THE VEHICLE HAD MULTIPLE FUEL SYSTEM PROBLEMS. THE REAR WINDOW LATCH ASSEMBLY BROKE. THE STEERING DAMPNER CHAFED. THE LONG DRAG ...

Mileage: 60,942

2004 FORD F350 DEVELOPED PROBLEMS WITH THE ENGINE.***NO ANSWER REQUIRED***. *MR THE VEHICLE WOULD RUN ROUGH. THE STARTER BURNED OUT CAUSING THE VEHICLE NOT TO START. THE VEHICLE HAD MULTIPLE FUEL SYSTEM PROBLEMS. THE REAR WINDOW LATCH ASSEMBLY BROKE. THE STEERING DAMPNER CHAFED. THE LONG DRAG ...

Mileage: 60,942

2004 FORD F350 DEVELOPED PROBLEMS WITH THE ENGINE.***NO ANSWER REQUIRED***. *MR THE VEHICLE WOULD RUN ROUGH. THE STARTER BURNED OUT CAUSING THE VEHICLE NOT TO START. THE VEHICLE HAD MULTIPLE FUEL SYSTEM PROBLEMS. THE REAR WINDOW LATCH ASSEMBLY BROKE. THE STEERING DAMPNER CHAFED. THE LONG DRAG ...

Mileage: 60,942

2004 FORD F350 DEVELOPED PROBLEMS WITH THE ENGINE.***NO ANSWER REQUIRED***. *MR THE VEHICLE WOULD RUN ROUGH. THE STARTER BURNED OUT CAUSING THE VEHICLE NOT TO START. THE VEHICLE HAD MULTIPLE FUEL SYSTEM PROBLEMS. THE REAR WINDOW LATCH ASSEMBLY BROKE. THE STEERING DAMPNER CHAFED. THE LONG DRAG ...

Mileage: 60,942

2004 FORD F350 DEVELOPED PROBLEMS WITH THE ENGINE.***NO ANSWER REQUIRED***. *MR THE VEHICLE WOULD RUN ROUGH. THE STARTER BURNED OUT CAUSING THE VEHICLE NOT TO START. THE VEHICLE HAD MULTIPLE FUEL SYSTEM PROBLEMS. THE REAR WINDOW LATCH ASSEMBLY BROKE. THE STEERING DAMPNER CHAFED. THE LONG DRAG ...

Mileage: 60,942

2004 F-350 BEGAN HAVING STALLING PROBLEMS AT <2000 MILES. AFTER SEVERAL ATTEMPTS TO FIX THE VEHICLE, WE ASKED FOR A REPLACEMENT. WHILE WAITING ON ACTION FROM FORD, WE WERE IN AN ACCIDENT ON APRIL 15,2005 AFTER THE TRUCK FAILED WHILE CROSSING AN INTERSECTION.

OCCASIONALLY WHILE STOPPED IN GEAR WITH THE BRAKE DEPRESSED MY TRUCK WILL "SURGE" AND LURCH FORAWD AS THE IDLE INCREASES. IF I'M NOT DEPRESSING THE BRAKE FIRMLY THE TRUCK MOVE FOWARD AND WON'T STOP UNTILL VERY FIRM PRESSURE IS APPLIED TO THE BRAKE.

INCIDENT OCCURRED IN THE AFTERNOON, THE TEMP WAS ABOUT 70 DEGREES. THE TRUCK WAS LOADED WITH MY FAMILY (5 INCLUDING MYSELF); WE WERE TRAVELING OVER A HILL AT ABOUT 50 MPH. A SIGN INDICATED A 6 PERCENT GRADE. ON THE WAY UP THE HILL, AT ABOUT 2000RPM AND ABOUT 45 MPH WE NOTICED A LARGE AMOUNT OF BLACK...

Mileage: 11,000

DT: CONTACT STATES WHILE DRIVING VEHICLE IT SHIFTS INTO NEUTRAL. THE SERVICE DEALER INFORMED HIM THERE WAS NOTHING WRONG WITH THE VEHICLE.*AK

DT: CONTACT STATED WHILE DRIVING APPROXIMATELY 15-20 MPH STEERING LOCKED UP, CAUSING A VEHICLE CRASH. MANUFACTURER STATED THERE HAD TO HAVE BEEN A DRAMATIC HIT ON THE FRONT END OF THE VEHICLE. *AK

THE CONSUMER COMPLAINED ABOUT SUDDEN ACCELERATION. WHILE DRIVING 35 MPH THE VEHICLE LUNGED FORWARD WITH AN INCREASE IN SPEED. THE VEHICLE HAS BEEN BACK TO THE DEALERS ON 4 SEPARATE OCCASIONS. HOWEVER, THE PROBLEM RECURRED. *AK THE VEHICLE ACCELERATES AND LUNGES FORWARD SEVERAL TIMES THEN DIE...

Mileage: 6,000

THERE ARE TOXIC FUMES COMING THROUGH THE DEFROSTER WHEN IT IS TURNED ON. WHICH IS DISTRACTING THE DRIVER ON THE ROAD. MANUFACTURER HAD BEEN CONTACTED BY CONSUMER. *AK THE CONSUMER PURCHASED A CARBON MONOXIDE DETECTOR IN WHICH THE VEHICLE REGISTERED 40 PPM. AS THE WEATHER TURNED COLD, THE CONSU...

Mileage: 1,100

THERE ARE TOXIC FUMES COMING THROUGH THE DEFROSTER WHEN IT IS TURNED ON. WHICH IS DISTRACTING THE DRIVER ON THE ROAD. MANUFACTURER HAD BEEN CONTACTED BY CONSUMER. *AK THE CONSUMER PURCHASED A CARBON MONOXIDE DETECTOR IN WHICH THE VEHICLE REGISTERED 40 PPM. AS THE WEATHER TURNED COLD, THE CONSU...

Mileage: 1,100

THERE ARE TOXIC FUMES COMING THROUGH THE DEFROSTER WHEN IT IS TURNED ON. WHICH IS DISTRACTING THE DRIVER ON THE ROAD. MANUFACTURER HAD BEEN CONTACTED BY CONSUMER. *AK THE CONSUMER PURCHASED A CARBON MONOXIDE DETECTOR IN WHICH THE VEHICLE REGISTERED 40 PPM. AS THE WEATHER TURNED COLD, THE CONSU...

Mileage: 1,100

THERE ARE TOXIC FUMES COMING THROUGH THE DEFROSTER WHEN IT IS TURNED ON. WHICH IS DISTRACTING THE DRIVER ON THE ROAD. MANUFACTURER HAD BEEN CONTACTED BY CONSUMER. *AK THE CONSUMER PURCHASED A CARBON MONOXIDE DETECTOR IN WHICH THE VEHICLE REGISTERED 40 PPM. AS THE WEATHER TURNED COLD, THE CONSU...

Mileage: 1,100

THERE ARE TOXIC FUMES COMING THROUGH THE DEFROSTER WHEN IT IS TURNED ON. WHICH IS DISTRACTING THE DRIVER ON THE ROAD. MANUFACTURER HAD BEEN CONTACTED BY CONSUMER. *AK THE CONSUMER PURCHASED A CARBON MONOXIDE DETECTOR IN WHICH THE VEHICLE REGISTERED 40 PPM. AS THE WEATHER TURNED COLD, THE CONSU...

Mileage: 1,100

THE ENGINE STALLED AND WOULD NOT RESTART. VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP AND IT WAS DISCOVERED THA T ENGINE NEEDED TO BE REPLACED. *AK

Mileage: 109,000

WHILE DRIVING TRANSMISSION HESITATED WHEN IT SWITCHED GEARS ,AND WHEN YOU WOULD REVERSE IT HESITATED SO YOU COULD BACK UP. METAL FLAKES WERE FOUND IN THE TRANSMISSION FLUID FROM IN THE PAN. FORD DEALER WAS AWARE OF THE PROBLEM, AND TRANSMISSION HAS TO BE REBUILT. OTHER TRANSMISSIONS WITH SIMILAR SER...

Mileage: 55,000

WHILE DRIVING THE SEAT BELT WILL TIGHTEN. OWNER TOOK THE VEHICLE TO THE DEALER, WHO EASILY IDENTIFIED THE DEFECT, BUT TOLD THE OWNER THAT IT WAS A MANUFACTURER DESIGN, AND THERE WAS NOTHING ELSE THEY COULD DO. *AK

Mileage: 18,000

ON 16 APRIL 2005 , I TOOK MY F-350 TURBO DIESEL DUALLY IN FOR 10,000 MILE SERVICE ( VEHICLE HAD 9400 MILES) ALSO ASKED TO HAVE LEFT SPEAKER CHECKED AND SCHEDULED AN APPOINTMENT FOR THE RECALL ON THE TRANSMISSION PINS REPLACEMENT. UPON COMPLETION OF 10,000 MILE SERVICE I NOTICED THAT THE VEHICLE WAS...

Mileage: 9,400

WHEN ENGAGING CRUISE CONTROL VEHICLE STARTS TO SHAKE UNCONTROLLABLY. *AK

Mileage: 20,000

FORD F350 TRUCK PROBLEM OCCUR SUDDENLY AND UNEXPECTEDLY LOSE POWER AND STALL OUT. *BF THE DEALER HAS BEEN UNABLE TO CORRECT OR ALLEVIATE THE PROBLEM. (LAWYER WROTE LETTER ON BEHALF OF CONSUMER)*JB

THE CONSUMER EXPERIENCED SUDDEN ACCELERATION WHILE THE VEHICLE WAS IN REVERSE CAUSING THE VEHICLE TO CRASH INTO ANOTHER VEHICLE. *JB *TC

Mileage: 3,500

2004 FORD F350 CREW CAB 4 WHEEL DRIVE W/ 6.0 DIESEL ENGINE AND AUTOMATIC TRANSMISSION. [XXX] 1.) I WAS ON A 180 MILE TRIP, DESCENDING HILL (FROM 3800 FEET TO 1000 FEET ELEVATION) AT LESS THAN 30 MPH WITH COLD OUTDOOR TEMPERATURE. 2.) WHILE COASTING DOWN STEEP GRADE AN ENGINE STALL NEARLY CAUSED A...

Mileage: 6,486

2004 F350 FX4 EXT CAB 6.0 DIESEL TORQUE SHIFT SPEEDS UP WHILE DRIVING AND AT STOP LIGHTS ON ITS OWN. (ONCE WHILE BACKING) MY DAD WILL NOT RIDE IN IT ANY MORE AND CLAIMS I AM CRAZY FOR DRIVING IT.*AK HARSH TRANS LOCK UP AT 45 AFTER AUTO TRANS WAS DROPPED AND UPDATED WITH PLANETARY BULLETIN AT DEALE...

Mileage: 10,500

VEHICLE IS EXPERIENCING A PROBLEM WITH THE EXHAUST FUMES WHICH SEEM TO BE GETTING INTO THE CAB OF THE PICKUP. VEHICLE HAS BEEN TO THE DEALERS ON SEVERAL OCCASIONS. ALSO, CONTACTED THE MANUFACTURER. HOWEVER, THEY DID NOT HELP THE OWNER WITH THIS PROBLEM. THE EXHAUST FUMES WERE COMING THROUGH TH...

Mileage: 31,000

VEHICLE IS EXPERIENCING A PROBLEM WITH THE EXHAUST FUMES WHICH SEEM TO BE GETTING INTO THE CAB OF THE PICKUP. VEHICLE HAS BEEN TO THE DEALERS ON SEVERAL OCCASIONS. ALSO, CONTACTED THE MANUFACTURER. HOWEVER, THEY DID NOT HELP THE OWNER WITH THIS PROBLEM. THE EXHAUST FUMES WERE COMING THROUGH TH...

Mileage: 31,000

VEHICLE STALLS WITHOUT WARNING AND UNDER NO PARTICULAR LOAD OR TEMPERATURE CONDITIONS. *NM

Mileage: 9,200

WHILE DRIVING AT 35 MPH, THE VEHICLE STOPPED AND WOULD NOT SHIFT INTO DRIVE. VEHICLE WAS TOWED. THE PLANET GEAR WAS DEFECTIVE.*AK

Mileage: 38,000

WHEN TRUCK WAS PUT IN GEAR, THE TRANSMISSION WOULD NOT GO IN GEAR. ALSO, WHEN DRIVING, I LET OFF OF THE GAS PEDAL, TRUCK WOULD STALL, AND THEN ENGAGE AND THEN LURCH FORWARD, IN TRAFFIC. ALSO, SAME PROBLEM IN REVERSE.*AK

Mileage: 13,300

WHILE DRIVING 70 MPH RIGHT REAR INNER TIRES EXPERIENCED A BLOW OUT ON A 2004, FORD F350 PICKUP TRUCK WITH ONLY THE DRIVER IN THE VEHICLE. ORIGINAL EQUIPMENT, TIRE SIZE LT235/85R16, DOT #AD0R1P61103. THE TIRE MANUFACTURER WAS NOT NOTIFIED.*AK

Mileage: 31,429

THE ENGINE STALLED TWICE ON THE HIGHWAY AT ABOUT 70 MILES PER HOUR. THE VEHICLE WAS TAKEN TO DEALER FOR A DIAGNOSIS, BUT THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE STALLING. *JB THE CONSUMER STATED THE SHE WAS DRIVING DOWN A MOUNTAIN WHEN THE VEHICLE LOST ALL POWER. *TC

Mileage: 5,456

ENGINE STALLED UNEXPECTEDLY WHILE VEHICLE WAS TRAVELING AT DIFFERENT SPEEDS. CONSUMER TOOK VEHICLE TO DEALER FOR CHECK UP, BUT THE CAUSE WAS UNDETERMINED.*AK

ON TWO SEPARATE OCCASIONS VEHICLE STALLED. THE FIRST TIME IT WAS AT 5 MPH, AND THE SECOND TIME IT WAS AT 35 MPH. VEHICLE WAS TAKEN TO THE DEALER ON BOTH OCCASIONS, AND THEY WERE NOT ABLE TO RESOLVE/ DUPLICATE THIS PROBLEM.*AK....VEHICLE SPEEDS UP ON ITS OWN AND MISSES OUT RUNNING DOWN THE ROAD A...

Mileage: 7,572

WHILE DRIVING AT 55 MPH,MY NEW 2004 F350 6.0 SUPER DUTY DIESEL TRANSMISSION LOCKED UO,. CAUSING THE VEHICLE TO SKID OUT OF CONTROL AT A INTERSECTION.HAD VEHICLE TOWED TO DEALERSHIP WHERE A NEW TRANSMISSION WAS INSTALLED .TWO MOUTHS LATER, VEHICLE STARTED STALLING WHILE AT IDLE AND WHILE DRIVING, CA...

Mileage: 350

WHILE DRIVING AT 55 MPH,MY NEW 2004 F350 6.0 SUPER DUTY DIESEL TRANSMISSION LOCKED UO,. CAUSING THE VEHICLE TO SKID OUT OF CONTROL AT A INTERSECTION.HAD VEHICLE TOWED TO DEALERSHIP WHERE A NEW TRANSMISSION WAS INSTALLED .TWO MOUTHS LATER, VEHICLE STARTED STALLING WHILE AT IDLE AND WHILE DRIVING, CA...

Mileage: 350

INTERMITTENTLY WHILE DRIVING ENGINE SHUT OFF FOLLOWED BY THE METERS ON THE DASHBOARD READING ZERO. THEN, VEHICLE STALLED. THE CONSUMER PUT VEHICLE INTO NEUTRAL AND RESTARTED. WHEN THIS HAPPENED BEFORE LOST CONTROL OF VEHICLE. THE DEALERSHIP PERFORMED SEVERAL DIAGNOSTIC TESTS, AND REPLACED THE P...

Mileage: 2,716

WHEN PULLING OFF FROM AN INTERSECTION, THE VEHICLE STALLED. MOMENTS LATER, THE CONSUMER RESTARTED THE VEHICLE ALL POWER RESUMED AS NORMAL. OWNER HAS TAKEN THE VEHICLE BACK TO THE DEALER WHO WANTED TO KEEP THE VEHICLE FOR A COUPLE OF DAYS SO THEY MAY FIND OUT WHAT WAS CAUSING THE DEFECT. PROVIDE FURT...

Mileage: 31,000

ALL OF THE FOLLOWING IS DOCUMENTED ON FORDS COMPUTER SYSTEM THROUGH MAGNUSSENS IN NEWARK, CA. JUNE04, STARTED WITH A ROUGH IDLE PROBLEM TOOK MY 2004 F350 BACK TO DEALER. DID A REFLASH SEEM TO FIX FOR A WHILE. PROGRESSED TO ROUGH AND SEARCHING IDLE. APPROXIMATELY 9 TIMES BACK TO DEALER, EACH TIME EI...

Mileage: 15,000

WHILE DRIVING,THE VEHICLE STALL. THE DRIVER TRIED TO RESTART,BUT WAS ABLE TO DO SO. THE CONSUMER NOTICED THAT THE VEHICLE STARTED ACCELERATED SUDDENLY WITHOUT WARNING. THE DRIVER APPLIED THE BRAKES AND THE VEHICLE CONTINUE TO ACCELERATING WITH SPEED. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE...

WHILE DRIVING,THE VEHICLE STALL. THE DRIVER TRIED TO RESTART,BUT WAS ABLE TO DO SO. THE CONSUMER NOTICED THAT THE VEHICLE STARTED ACCELERATED SUDDENLY WITHOUT WARNING. THE DRIVER APPLIED THE BRAKES AND THE VEHICLE CONTINUE TO ACCELERATING WITH SPEED. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE...

WHILE DRIVING VEHICLE STALLED. CONSUMER WAS UNABLE TO RESTART VEHICLE, AND HAD IT TOWED TO THE DEALER FOR INSPECTION. DEALER INFORMED CONSUMER THAT THE PROBLEM COULD NOT BE DUPLICATED. *AK

WHILE DRIVING 30 MPH CONSUMER'S VEHICLE CRASHED INTO A POLE. UPON IMPACT, DUAL AIR BAGS DID NOT DEPLOY. DRIVER SUSTAINED NECK AND LOWER KNEE INJURIES. *AK

Mileage: 9,500

THERE IS A LOUD "CLUNK" FROM UNDERNEATH THE VEHICLE WHEN TAKING OFF AFTER PUTTING THE TRANSMISSION IN DRIVE. THE "CLUNK" HAPPENS ABOUT 5 TO 10 FEET AFTER YOU BEGIN MOVING FORWARD AND SOMETIMES ALSO WHEN THE VEHICLE SHIFTS FROM 1ST TO 2ND GEAR AND 2ND TO 3RD GEAR. *AKTHE "CLUNK" CAN NOT ONLY BE HEA...

Mileage: 300

THE BOLTS THAT HOLD THE BRACKETS FOR THE TOP SUPPORT OF THE AIR SUSPENSION SYSTEM CONTINUOUSLY BREAK. THIS OCCURRED IN FIVE VEHICLE (AMBULANCES) SO FAR, VIN NUMBERS: [XXX], [XXX], [XXX], [XXX], AND [XXX]. TOOK THE VEHICLES TO BE REPAIRED AT FORD DEALERSHIP. *AK THERE WERE 2 UNITS WITH BRACKET F...

Mileage: 7,000

THE BOLTS THAT HOLD THE BRACKETS FOR THE TOP SUPPORT OF THE AIR SUSPENSION SYSTEM CONTINUOUSLY BREAK. THIS OCCURRED IN FIVE VEHICLE (AMBULANCES) SO FAR, VIN NUMBERS: [XXX], [XXX], [XXX], [XXX], AND [XXX]. TOOK THE VEHICLES TO BE REPAIRED AT FORD DEALERSHIP. *AK THERE WERE 2 UNITS WITH BRACKET F...

Mileage: 7,000

THE BOLTS THAT HOLD THE BRACKETS FOR THE TOP SUPPORT OF THE AIR SUSPENSION SYSTEM CONTINUOUSLY BREAK. THIS OCCURRED IN FIVE VEHICLE (AMBULANCES) SO FAR, VIN NUMBERS: [XXX], [XXX], [XXX], [XXX], AND [XXX]. TOOK THE VEHICLES TO BE REPAIRED AT FORD DEALERSHIP. *AK THERE WERE 2 UNITS WITH BRACKET F...

Mileage: 7,000

WHILE DRIVING VEHICLE STALLED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

Mileage: 10,000

WHILE DRIVING AT ANY SPEED VEHICLE STALLED. CONSUMER WAS UNABLE TO RESTART VEHICLE, AND IT WAS TOWED TO THE DEALER FOR INSPECTION NUMEROUS TIMES. MECHANIC DETERMINED THAT COMPUTER NEEDED TO BE REPLACED, AND REPLACED IT. HOWEVER, PROBLEM RECURRED. *AK

Mileage: 8,000

ENGINE STALLS/STOPS RUNNING, LEADING TO A LOSS OF STEERING AND BRAKING. THIS HAS OCURRED THREE TIMES, TWICE AT LOW SPEED WHEN COMING TO A STOP, ONCE AT HIGH SPEED.*AK

Mileage: 11,803

INTERMITTENTLY VEHICLE WOULD NOT ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

Mileage: 8,000

TWO INCIDENTS HAPPENED THE SAME DAY WHILE DRIVING AT 65 MPH, VEHICLE STALLED. THIS CAUSED LOSS OF STEERING AND BRAKES. WHILE WAITING FOR STOP LIGHT. VEHICLE LUNGED OR ACCELERATED UP TO 3000 RPMS. *AK

WHILE DRIVING UP A HILL THERE WAS ERRATIC BEHAVIOR IN THE TRANSMISSION THAT CAUSED INCONSISTENCY IN THE SHIFTING. AS A RESULT, VEHICLE STALLED IN THE MIDDLE OF AN INTERSECTION , AND STEERING FAILED. *AK

Mileage: 2,500

WHILE DRIVING UP A HILL THERE WAS ERRATIC BEHAVIOR IN THE TRANSMISSION THAT CAUSED INCONSISTENCY IN THE SHIFTING. AS A RESULT, VEHICLE STALLED IN THE MIDDLE OF AN INTERSECTION , AND STEERING FAILED. *AK

Mileage: 2,500

BREAKING SYSTEM WILL NOT STOP THE TRUCK UNDER NORMAL LOAD AND DRIVING CONDITIONS. F350 - SD- V10 GAS. THE STOPING DISTANCE IS TWO TIMES THAT OF THE F350 - SD - DIESELS IN OUR FLEET. THE TRUCK IS UNSAFE TO DRIVE. FORD FIELD SERVICE ENGINEE UNWILLING TO TO SOLVE PROBLEM.*AK

Mileage: 10

WHILE DRIVING 55 MPH WITH SPEED CONTROL SET AND WITHOUT ANY INDICATION VEHICLE ENGINE STALLED. DEALERSHIP SERVICED VEHICLE, AND TECHNICIAN COULD NOT DUPLICATE THE PROBLEM. *AK

WHILE DRIVING AT ANY SPEED CONSUMER NOTICED FRONT END OF VEHICLE MADE NOISE. CONSUMER INSPECTED UNDER VEHICLE, AND SAW THAT FRONT SPRING PERCH WAS NOT BOLTED TO FRAME. *AK

WHEN APPLYING BRAKES FROM ANY SPEED VEHICLE SURGED FORWARD. WHEN CONSUMER ATTEMPTED TO STOP VEHICLE COASTED INTO THE MIDDLE OF THE INTERSECTION. NO IMPACT REPORTED. *AK

Mileage: 16,000

WHEN DECELERATING VEHICLE STALLED. DEALERSHIP SERVICED VEHICLE, AND TECHNICIAN COULD NOT DUPLICATE THE PROBLEM. *AK

WHILE DEPRESSING THE BRAKE PEDAL IT WAS HARD FOR THE CONSUMER TO TURN THE STEERING WHEEL. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

Mileage: 8,251

WHILE DEPRESSING THE BRAKE PEDAL IT WAS HARD FOR THE CONSUMER TO TURN THE STEERING WHEEL. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

Mileage: 8,251

WHILE DRIVING, T HE VEHICLE STALLED SEVERAL TIMES. THE CONSUMER WOULD RESTART THE VEHICLE WHILE IN MOTION. THE BRAKES WOULD GO OUT WHEN THIS WOULD OCCUR. *AK THE PROBLEM SEEMED TO BE RESOLVED. THE DEALER REPLACED THE EGR VALVE (EXHAUST GAS-RECIRCULATION). THE VEHICLE IDLED ERRATICALLY. THE IN...

CONSUMER NOTICED THAT ENGINE STALLED AT ANY SPEED. DEALERSHIP SERVICED THE VEHICLE SEVERAL TIMES, BUT COULD NOT DUPLICATE THE PROBLEM. *AK

WHILE DRIVING 65 MPH THE VEHICLE'S REAR END FELT LOOSE. THE CONSUMER WAS ABLE DRIVE THE VEHICLE TO THE DEALER FOR INSPECTION. THE MECHANIC WAS ABLE TO DUPLICATE THE PROBLEM BUT WAS UNABLE TO REPAIR IT. *AK *NM

Mileage: 1,166

1.) I OWN AN 04, F350 SUPERDUTY, DIESEL TRUCK. THERE ARE 2 FUEL FILTERS \ WATER SEPERATORS ON IT. ONE ON THE DRIVERS SIDE, UNDER THE FRAME AND THE OTHER ON TOP OF THE ENGINE. OWNERS MANUAL RECCOMENDS THAT YOU MUST DRAIN THE ONE UNDER THE FRAME AT LEAST WITH EVERY FILL UP TO PREVENT WATER FROM GET...

WHILE DRIVING AT ANY SPEED VEHICLE LOST POWER. *AL

Mileage: 3,200

VEHICLE WAS PURCHASED FOR PULLING A HORSE TRAILER. TRANSMISSION AND ENGINE LOCKED AT 600 MILES. DRIVER STATED THERE WAS A REAL BAD JERK. CURRENTLY, WHEN DRIVING VEHICLE WAS CONSTANTLY BUCKING. *AK VEHICLE WAS JERKING WHILE CRUISE CONTROL IS EITHER ON OR OFF, AND WHEN PULLING TRAILER ON ANY SPEE...

Mileage: 600

VEHICLE WAS PURCHASED FOR PULLING A HORSE TRAILER. TRANSMISSION AND ENGINE LOCKED AT 600 MILES. DRIVER STATED THERE WAS A REAL BAD JERK. CURRENTLY, WHEN DRIVING VEHICLE WAS CONSTANTLY BUCKING. *AK VEHICLE WAS JERKING WHILE CRUISE CONTROL IS EITHER ON OR OFF, AND WHEN PULLING TRAILER ON ANY SPEE...

Mileage: 600

WHILE DRIVING 30 MPH THE VEHICLE STALLED WITHOUT WARNING. THIS CAUSED LOST OF STEERING AND BRAKES. THE DEALER TOLD THE CONSUMER THAT HE WAS USING THE WRONG GAS BUT THE CONSUMER IS USING HIGH DIESEL OCTANE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM THE CONSUMER STATED THERE WAS A TECHNICAL...

Mileage: 400

WHILE DRIVING 30 MPH THE VEHICLE STALLED WITHOUT WARNING. THIS CAUSED LOST OF STEERING AND BRAKES. THE DEALER TOLD THE CONSUMER THAT HE WAS USING THE WRONG GAS BUT THE CONSUMER IS USING HIGH DIESEL OCTANE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM THE CONSUMER STATED THERE WAS A TECHNICAL...

Mileage: 400

TRUCK RUNS OUT OF FUEL SHOWING 1/4 TANK ON GAUGE. *AK

Mileage: 1,188

WHILE DRIVING 62 MPH, THE VEHICLE STALLED. THE DRIVER WAS ABLE TO RESTART THE VEHICLE AND DROVE TO THE DEALER FOR ANALYSIS. THE MECHANIC COULD NOT RESOLVE THE PROBLEM. *AK THE CRUISE CONTROL WAS ENGAGED WHEN THE VEHICLE STALLED. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. *SC *JB

Mileage: 23,000

WHILE STOPPED AT A TRAFFIC LIGHT MY DIESEL TRUCK SUDDENLY LURCHED FORWARD. I WAS ABLE TO STEP ON THE BRAKE PEDAL FIRMLY ENOUGH TO PREVENT HITTING THE VEHICLE IN FRONT OF ME. *LA

Mileage: 2,500