2003 FORD F-450 SD Problems & Recalls

THE TRUCK BEGAN TO SHAKE AND LOSE POWER, EVENTUALLY NOT EVEN BEING ABLE TO STAY RUNNING. THE MECHANIC UPON REVIEW FOUND THE TANK LINER HAD DELAMINATED FROM INSIDE FUEL TANK AND HAD PLUGGED UP FUEL SENDER. BOTH NEEDED TO BE REPLACE AT A COST OF $2800, FORD DEALER STATED THERE WAS NOTHING THEY COULD...

Mileage: 119,311

THE EGR, FICM, AND INJECTORS ON THIS VEHICLE HAVE CAUSED TRAFFIC HAZARDS. WE CAN NOT PULL OUT WITHOUT THE ENGINE SPITTING AND SPUTTERING. WE HAVE REPLACE ALL OF THE ABOVE, SOME MORE THAN ONCE. LAST TIME IN TO THE FORD DEALER THEY SUGGESTED THAT WE USE A THINNER OIL TO LUBRICATE THE INJECTORS BE...

Mileage: 5,000

TRUCK HAS NO POWER WHEN FIRST STARTING AND THE FRONT END SHIMMIES SOMETHING TERRIBLE. HARD TO CONTROL. *TR

Mileage: 25,000

TRUCK HAS NO POWER WHEN FIRST STARTING AND THE FRONT END SHIMMIES SOMETHING TERRIBLE. HARD TO CONTROL. *TR

Mileage: 25,000

THE COATING ON THE INTERIOR OF FORD DIESEL FUEL TANKS CORRODES AND COLLECTS AS SEDIMENT IN THE FUEL SYSTEM. THE SEDIMENT, COLLECTS AT THE BOTTON OF THE FUEL TANK AND IS SUCKED INTO THE FUEL SYSTEM. THE FUEL LINES BECOME FOULED, THE FUEL PUMPS BECOME CLOGGED AND REQUIRE REPLACEMENT. AS THE COATING...

Mileage: 64,042

THE LINING OF THE FUEL TANK HAS BEEN FLAKING OFF INTO MY FUEL LINES, WHICH IS RESTRICTING MY FUEL FILTERS. BECAUSE OF THE LACK OF FUEL, 2 FUEL INJECTORS WENT BAD AND HAD TO BE REPLACED. AND THE TURBO WAS OVER COMPENSATING FOR THE LACK OF POWER, DUE TO FUEL SHORTAGE, SO THE TURBO HAD TO BE REPLACED A...

Mileage: 136,000

WHEN DRIVING DOWN A HILL WITH LOTS OF TURNS. THE TRUCK STALLED (SHUT OFF) ALL OF THE SUDDEN RIGHT BEFORE A TURN. LUCKILY WAS ABLE TO KEEP THE TRUCK ON THE ROAD AND RESTART THE TRUCK IN NEUTRAL. TOOK TRUCK STRAIGHT TO HANSEL FORD ASKED THEM TO TELL ME WHAT WAS WRONG WITH THE TRUCK. THEY CHECKED THE C...

Mileage: 90,000

THE LINING OF THE DIESEL FUEL TANK FLAKED OFF WHICH CLOGGED THE FUEL FILTERS, WHICH RESULTED IN POOR ENGINE PERFORMANCE. *TR

Mileage: 54,579

TL*THE CONTACT OWNS A 2003 FORD F450 SUPER DUTY. THE VEHICLE HAS DOUBLE COIN RADIAL TIRES, SIZE 225/70/19.5 (NA). THE TIRES WERE SERVICED BY AN INDEPENDENT TIRE MECHANIC AND TREAD SEPARATION WAS DISCOVERED IN SIX TIRES. THERE WERE FIVE TIRES WITH THE SAME DOT NUMBER. THE TIRES WERE REPLACED ON T...

Mileage: 95,733

TL*THE CONTACT OWNS A 2003 FORD F450 SUPER DUTY. THE VEHICLE HAS DOUBLE COIN RADIAL TIRES, SIZE 225/70/19.5 (NA). THIS COMPLAINT IS RELATED TO ODI NUMBER 10239016 REGARDING THE OTHER FIVE DEFECTIVE TIRES. THE TIRES WERE SERVICED BY AN INDEPENDENT TIRE MECHANIC AND TREAD SEPARATION WAS DISCOVERED ...

Mileage: 95,773

EVENTS LEADING TO FAILURE: TRUCK WAS PURCHASED ON 12-19-03 1.) ON 1-19-04 TRUCK HAD NO POWER, DEALER FOUND 2,3 INJECTOR SHORTED, DEALER REPLACED INJECTORS AND CHECKED BORE IN CYL HEAD PER HOTLINE. 2.)1-21-04 ENGINE WAS MISSING IN FIRE. DEALER REPLACED BOTH INJECTORS PER HOTLINE. O-RINGS BLOWN A...

Mileage: 500

DT: CONTACT STATES WHILE APPLYING THE BRAKES IT IS DIFFICULT TO TURN THE WHEEL LEFT OR RIGHT. THE HARDER THE BRAKE IS PRESSED THE HARDER IT IS TO TURN THE WHEEL UNTIL THE STEERING IS LOCKED UP. EVENTUALLY THE STEERING GEAR STARTED LEAKING, LEADING TO REPLACEMENT OF THE STEERING GEAR. THIS DID NOT...

DT: CONTACT STATES WHILE APPLYING THE BRAKES IT IS DIFFICULT TO TURN THE WHEEL LEFT OR RIGHT. THE HARDER THE BRAKE IS PRESSED THE HARDER IT IS TO TURN THE WHEEL UNTIL THE STEERING IS LOCKED UP. EVENTUALLY THE STEERING GEAR STARTED LEAKING, LEADING TO REPLACEMENT OF THE STEERING GEAR. THIS DID NOT...

WHILE SITTING ON THE SCENE OF A MEDICAL EMERGENCY WITH ENGINE IDLING, THE ENGINE SHUTDOWN AND THEM WOULD NOT TURN OVER TO START(LOCKED UP)

Mileage: 55,221

THE MOTOR WAS LEAKING NUMEROUS AMOUNT OF OIL BETWEEN THE BLOCK WHICH COULD HAVE CAUSE THE VEHICLE TO OVERHEAT. CONSUMER TOOK VEHICLE TO THE DEALER FOR A NEW REPLACEMENT MOTOR, BUT THE PROBLEM RECURRED. *AK

WHILE DRIVING 65 MPH, BOTH REAR WHEEL LUGS NUTS CAME OFF THE TIRES, CAUSING THE TIRES TO DETACH FROM VEHICLE. CONSUMER MANAGED TO PULL OVER, AND HAD THE VEHICLE TOWED. DEALERSHIP WAS NOTIFIED, BUT THE PROBLEM WAS NOT RESOLVED.*AK

Mileage: 4,053

PROBLEMS WITH THE ATTACK SETUP. MR THE VEHICLE DID NOT STOP IN A SAFE WAY. AND THE PROBLEM ONLY OCCURRED WHEN IT WAS TOWING. SCC. *JB

THE VEHICLE WAS NOT PROPERLY ALIGNED WHICH CAUSED THE VEHICLE TO PULL TO THE LEFT. TWO TIRES WERE ALSO RUINED. THE DEALER WAS CONTACTED. *NLM

Mileage: 4,000