High Severity Issue
This component has been associated with crashes, fires, or deaths.
This Problem Across All Years
FORD TRUCK BEGAN LOOSING POWER. BECAME UNABLE TO CLIMB HILL AND CONTINUE UP ROAD. DRIVER WAS IN VERY REMOTE ALASKA IN SUBZERO TEMPERATURES IN WORK TRUCK (AS MOST F550S ARE) MILES FROM HELP. PLOWING A FIREWOOD ROAD FOR THE STATE OF ALASKA. WE MAINTAIN OUR TRUCKS TO THE BEST OF OUR ABILITY TO PREVENT SUCH A LIFE THREATENING CIRCUMSTANCE. DRIVER CALLED ME FOR HELP. I WAS ABLE TO GO ONLINE AND FIND ENOUGH INFORMATION (KNOWING IT WAS NOT A FILTER OR PUMP OR MAINTENANCE ISSUE I DUG DEEPER) TO DEDUCE THE FUEL TANK HAD DELAMINATED AS LATELY HAS BECOME "COMMON" WITH THESE TRUCKS. UNDER MY ADVICE DRIVER (BEING A MECHANIC) WAS ABLE TO BLOW COMPRESSED AIR FROM A COMPRESSOR HE HAD ON BOARD BACK INTO THE TANK AND TEMPORARILY GET THE TRUCK RUNNING CORRECTLY AND GET BACK CIVILIZATION. TRUCK CLOGGED AGAIN AND HAS BEEN RUN STARVING FOR FUEL FOR HOURS BEFORE IT GOT TO THE HILL. WE ARE COMPLETELY UPSET AT THE PRICE FORD WANTS TO REMEDY AN EXTREMELY DANGEROUS DESIGN FLAW. THESE TRUCKS ARE USED ALL OVER THIS NATION AS EMERGENCY SERVICE VEHICLES. I KNOW BECAUSE I HAVE 3 FOR THAT PURPOSE. I BELIEVE MY 2008 WILDLAND FIRE ENGINE MAY HAVE THE SAME ISSUE (2008 F550) AS THE 2000 F550 PLOW TRUCK I WROTE ABOUT ABOVE. THESE TRUCKS ARE RELIED ON WITH LIVES TO NOT BE BURNED OVER DURING FIRE BURNOUTS AND OPERATIONS. OTHERS OF THIS TYPE OF VEHICLE ARE AMBULANCES, WRECKERS, ETC. I TALKED TO A FORD TECH AND ALL DEALERS THAT WORK ON THESE HEAVY DUTY TRUCKS KNOW ABOUT THIS PROBLEM. WHY DIDN'T I. MY DRIVERS ARE IN DANGER AND GOOGLE TOLD ME ENOUGH TO GET FORD TECH'S TO TELL ME, AND IT'S MY FINANCIAL LOSS???? PLEASE LOOK INTO THE DELAMINATING TANK ISSUE FOR F550 TRUCKS. $3,000 AND RISK OF STRANDED IN FRONT OF THE FLAMES IN SUMMER AND REMOTE ALASKA FREEZING TEMPS IN WINTER. SAFETY ISSUE LIKE THAT SHOULD BE STAMPED INTO THE DASH IF ITS KNOWN ON THESE EMERGENCY SERVICE TRUCKS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
FORD TRUCK BEGAN LOOSING POWER. BECAME UNABLE TO CLIMB HILL AND CONTINUE UP ROAD. DRIVER WAS IN VERY REMOTE ALASKA IN SUBZERO TEMPERATURES IN WORK TRUCK (AS MOST F550S ARE) MILES FROM HELP. PLOWING A FIREWOOD ROAD FOR THE STATE OF ALASKA. WE MAINTAIN OUR TRUCKS TO THE BEST OF OUR ABILITY TO PREVENT SUCH A LIFE THREATENING CIRCUMSTANCE. DRIVER CALLED ME FOR HELP. I WAS ABLE TO GO ONLINE AND FIND ENOUGH INFORMATION (KNOWING IT WAS NOT A FILTER OR PUMP OR MAINTENANCE ISSUE I DUG DEEPER) TO DEDUCE THE FUEL TANK HAD DELAMINATED AS LATELY HAS BECOME "COMMON" WITH THESE TRUCKS. UNDER MY ADVICE DRIVER (BEING A MECHANIC) WAS ABLE TO BLOW COMPRESSED AIR FROM A COMPRESSOR HE HAD ON BOARD BACK INTO THE TANK AND TEMPORARILY GET THE TRUCK RUNNING CORRECTLY AND GET BACK CIVILIZATION. TRUCK CLOGGED AGAIN AND HAS BEEN RUN STARVING FOR FUEL FOR HOURS BEFORE IT GOT TO THE HILL. WE ARE COMPLETELY UPSET AT THE PRICE FORD WANTS TO REMEDY AN EXTREMELY DANGEROUS DESIGN FLAW. THESE TRUCKS ARE USED ALL OVER THIS NATION AS EMERGENCY SERVICE VEHICLES. I KNOW BECAUSE I HAVE 3 FOR THAT PURPOSE. I BELIEVE MY 2008 WILDLAND FIRE ENGINE MAY HAVE THE SAME ISSUE (2008 F550) AS THE 2000 F550 PLOW TRUCK I WROTE ABOUT ABOVE. THESE TRUCKS ARE RELIED ON WITH LIVES TO NOT BE BURNED OVER DURING FIRE BURNOUTS AND OPERATIONS. OTHERS OF THIS TYPE OF VEHICLE ARE AMBULANCES, WRECKERS, ETC. I TALKED TO A FORD TECH AND ALL DEALERS THAT WORK ON THESE HEAVY DUTY TRUCKS KNOW ABOUT THIS PROBLEM. WHY DIDN'T I. MY DRIVERS ARE IN DANGER AND GOOGLE TOLD ME ENOUGH TO GET FORD TECH'S TO TELL ME, AND IT'S MY FINANCIAL LOSS???? PLEASE LOOK INTO THE DELAMINATING TANK ISSUE FOR F550 TRUCKS. $3,000 AND RISK OF STRANDED IN FRONT OF THE FLAMES IN SUMMER AND REMOTE ALASKA FREEZING TEMPS IN WINTER. SAFETY ISSUE LIKE THAT SHOULD BE STAMPED INTO THE DASH IF ITS KNOWN ON THESE EMERGENCY SERVICE TRUCKS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
FORD F-550 WAS SITTING IN DRIVEWAY WITH THE ENGINE OFF AND CAUGHT ON FIRE, THE CAB OF THE TRUCK WAS COMPLETELY ENGULFED IN FLAMES SECONDS LATER VEHICLES CRUISE CONTROL SWITCH HAD BEEN REPLACED UNDER FORDS RECALL OF THE PART ACCORDING TO CONCERNS OF VEHICLE FIRES BUT WAS OBVIOUSLY STILL FAULTY. *TR
FORD F-550 WAS SITTING IN DRIVEWAY WITH THE ENGINE OFF AND CAUGHT ON FIRE, THE CAB OF THE TRUCK WAS COMPLETELY ENGULFED IN FLAMES SECONDS LATER VEHICLES CRUISE CONTROL SWITCH HAD BEEN REPLACED UNDER FORDS RECALL OF THE PART ACCORDING TO CONCERNS OF VEHICLE FIRES BUT WAS OBVIOUSLY STILL FAULTY. *TR
WAS DRIVING ALONG IN MY FORD F550 PSD WHEN THE ENGINE QUIT. LOST POWER STEERING AND BRAKES. PULLED OVER THE SIDE OF THE ROAD FOR FIVE MIN. AND RESTARTED TRUCK. NEXT DAY IT DID THE SAME THING THIS TIME AS WE WERE PULLING INTO A PARKING LOT. RESTARTED AND DROVE BACK TO CAMP GROUND AND CHANGED THE CPS (CAM POSITION SENSOR) THE PROBLEM NEVER HAPPENED AGAIN. GLAD I WAS NOT TOWING THE FIFTH-WHEEL AT THE TIME. *JB
WAS DRIVING ALONG IN MY FORD F550 PSD WHEN THE ENGINE QUIT. LOST POWER STEERING AND BRAKES. PULLED OVER THE SIDE OF THE ROAD FOR FIVE MIN. AND RESTARTED TRUCK. NEXT DAY IT DID THE SAME THING THIS TIME AS WE WERE PULLING INTO A PARKING LOT. RESTARTED AND DROVE BACK TO CAMP GROUND AND CHANGED THE CPS (CAM POSITION SENSOR) THE PROBLEM NEVER HAPPENED AGAIN. GLAD I WAS NOT TOWING THE FIFTH-WHEEL AT THE TIME. *JB
200 FORD F-550, MISS IN ENGINE UNRESOLVED THRU DEALERS AND OTHER SHOPS, BEEN THIS WAY SINCE NEW, CONSULTED WITH LAST 2 OWNERS, SAME ISSUE, I REPLACED ALL 8 INJECTORS, INJECTOR HARNESS,ROCKER ARMS, STILL ENGINE MISSES AT 24-2600 RPMS, WHITE/BLUE SMOKE, HARD COLD STARTS, ROUGH IDLING, PROBLEM HAS STILL NOT BEEN ABLE TO BE RESOLVED I PURCHASED TRUCK TO ADD TO FLEET IN DECEMBER 2004 AND NO ONE INCLUDING FORD CAN FIX THIS TRUCK AFTER SEVERAL THOUSAND DOLLARS IN REPAIRS IVE READ REPORTS FORD HAD ISSUES NOT YET RESOLVED ON THESE TRUCKS. IS THIS THE CASE,? HAS IT BEEN RESOLVED , AND IF SO WHAT CURE FIXED THESE TRUCKS? *JB
200 FORD F-550, MISS IN ENGINE UNRESOLVED THRU DEALERS AND OTHER SHOPS, BEEN THIS WAY SINCE NEW, CONSULTED WITH LAST 2 OWNERS, SAME ISSUE, I REPLACED ALL 8 INJECTORS, INJECTOR HARNESS,ROCKER ARMS, STILL ENGINE MISSES AT 24-2600 RPMS, WHITE/BLUE SMOKE, HARD COLD STARTS, ROUGH IDLING, PROBLEM HAS STILL NOT BEEN ABLE TO BE RESOLVED I PURCHASED TRUCK TO ADD TO FLEET IN DECEMBER 2004 AND NO ONE INCLUDING FORD CAN FIX THIS TRUCK AFTER SEVERAL THOUSAND DOLLARS IN REPAIRS IVE READ REPORTS FORD HAD ISSUES NOT YET RESOLVED ON THESE TRUCKS. IS THIS THE CASE,? HAS IT BEEN RESOLVED , AND IF SO WHAT CURE FIXED THESE TRUCKS? *JB
2000 F 550 THE OIL PAN HAS ROTTED FROM THE VEHICLE. DEALER STATES THIS IS A BIG PROBLEM ON THIS MODEL. REPLACEMENT OF THE PART REQUIRES THIS REMOVAL OF THE ENGINE. THIS IS NOT A WARRANTY COVERED ITEM.*JB
2000 F 550 THE OIL PAN HAS ROTTED FROM THE VEHICLE. DEALER STATES THIS IS A BIG PROBLEM ON THIS MODEL. REPLACEMENT OF THE PART REQUIRES THIS REMOVAL OF THE ENGINE. THIS IS NOT A WARRANTY COVERED ITEM.*JB