High Severity Issue
This component has been associated with crashes, fires, or deaths.
This Problem Across All Years
TL* THE CONTACT OWNS A 2004 FORD F-550 SD. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED; HOWEVER, THE FAILURE RECURRED APPROXIMATELY ONE MILE LATER. THE VEHICLE DID NOT RESTART AND WAS TOWED TO THE CONTACT'S JOB. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS WAS FAULTY, MELTED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 155,862.
TL* THE CONTACT OWNS A 2004 FORD F-550 SD. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED; HOWEVER, THE FAILURE RECURRED APPROXIMATELY ONE MILE LATER. THE VEHICLE DID NOT RESTART AND WAS TOWED TO THE CONTACT'S JOB. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS WAS FAULTY, MELTED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 155,862.
TL* THE CONTACT OWNS A 2004 FORD F-550. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE DEALER DIAGNOSED THAT THE FUEL INJECTOR WIRE WAS MELTING ON THE ENGINE. THE VEHICLE WAS REPAIRED AND RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS. THE FAILURE MILEAGE WAS 116,000 AND THE CURRENT MILEAGE WAS 121,164.
TL* THE CONTACT OWNS A 2004 FORD F-550. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE DEALER DIAGNOSED THAT THE FUEL INJECTOR WIRE WAS MELTING ON THE ENGINE. THE VEHICLE WAS REPAIRED AND RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS. THE FAILURE MILEAGE WAS 116,000 AND THE CURRENT MILEAGE WAS 121,164.
WE PURCHASED A FORD F550 6.0L DIESEL TRUCK NEW IN 2004 AND HAVE BEEN THE ONLY ONES TO DRIVE IT AND HAVE DONE PROPER CARE AND MAINTENANCE OF THIS VEHICLE. IT HAS LESS THAN 40,000 MILES ON IT. THE VEHICLE WOULD NOT START FOR NO REASON ON APRIL 29, 2010 NECESSITATING IT BEING TOWED TO THE LOCAL FORD DEALERSHIP. THEY DIAGNOSED A BAD FICM (FUEL INJECTION CONTROL MODULE) AND REPLACED IT. I HAVE FOUND THERE WAS A RECALL ON THIS VEHICLE FOR THIS PROBLEM, CAMPAIGN NUMBER 05V270000 ON 6/10/05. DUE TO THE LOW MILES AND PROPER CARE OF THIS VEHICLE I AM WONDERING IF THIS PROBLEM IS RELATED TO THAT RECALL. WE USE THIS IN OUR WORK AND HAD THE FICM GONE OUT WHILE WE WERE DRIVING IT WITH A LOAD OF CHIPS IT COULD HAVE POTENTIALLY BEEN EXTREMELY HAZARDOUS. *TR
WE PURCHASED A FORD F550 6.0L DIESEL TRUCK NEW IN 2004 AND HAVE BEEN THE ONLY ONES TO DRIVE IT AND HAVE DONE PROPER CARE AND MAINTENANCE OF THIS VEHICLE. IT HAS LESS THAN 40,000 MILES ON IT. THE VEHICLE WOULD NOT START FOR NO REASON ON APRIL 29, 2010 NECESSITATING IT BEING TOWED TO THE LOCAL FORD DEALERSHIP. THEY DIAGNOSED A BAD FICM (FUEL INJECTION CONTROL MODULE) AND REPLACED IT. I HAVE FOUND THERE WAS A RECALL ON THIS VEHICLE FOR THIS PROBLEM, CAMPAIGN NUMBER 05V270000 ON 6/10/05. DUE TO THE LOW MILES AND PROPER CARE OF THIS VEHICLE I AM WONDERING IF THIS PROBLEM IS RELATED TO THAT RECALL. WE USE THIS IN OUR WORK AND HAD THE FICM GONE OUT WHILE WE WERE DRIVING IT WITH A LOAD OF CHIPS IT COULD HAVE POTENTIALLY BEEN EXTREMELY HAZARDOUS. *TR
TL*THE CONTACT OWNS A 2004 FORD F550. TWO HOURS AFTER THE VEHICLE WAS PARKED, IT CAUGHT FIRE. THE CONTACT STATED THAT IT WAS AN ELECTRICAL FIRE INSIDE THE CAB THAT DID NOT SEEM TO AFFECT THE ENGINE. THE FIRE WAS NOT REPORTED TO THE FIRE DEPARTMENT OR POLICE. THE CONTACT USED WATER AND A FIRE EXTINGUISHER TO EXTINGUISH THE FLAMES. THE VEHICLE HAS NOT BEEN TAKEN TO A DEALER OR MECHANIC AND HAS NOT LEFT THE SCENE OF THE FIRE. THE CURRENT AND FAILURE MILEAGES WERE 50,000.
TL*THE CONTACT OWNS A 2004 FORD F550. TWO HOURS AFTER THE VEHICLE WAS PARKED, IT CAUGHT FIRE. THE CONTACT STATED THAT IT WAS AN ELECTRICAL FIRE INSIDE THE CAB THAT DID NOT SEEM TO AFFECT THE ENGINE. THE FIRE WAS NOT REPORTED TO THE FIRE DEPARTMENT OR POLICE. THE CONTACT USED WATER AND A FIRE EXTINGUISHER TO EXTINGUISH THE FLAMES. THE VEHICLE HAS NOT BEEN TAKEN TO A DEALER OR MECHANIC AND HAS NOT LEFT THE SCENE OF THE FIRE. THE CURRENT AND FAILURE MILEAGES WERE 50,000.
TL* - THE CONTACT OWNS A 2004 FORD F550. THE CONTACT STATED THAT APPROXIMATELY 1 YEAR THE VEHICLE HAD AN ELECTRICAL SHORT., TOOK THE VEHICLE TO BE REPAIRED AND THAT VERY SAME DAY HAD PROBLEMS WITH THE TRANSMISSION SLIPPING. THE CONTACT STATED THAT APPROXIMATELY ONE YEAR LATER IN JANUARY 2007 THE TRANSMISSION WOULD NOT ENGAGE, AND ONE COULD DRIVE DOWN THE ROAD AND THE TRANSMISSION WOULD JUST STOP WORKING. THE TRUCK WAS CURRENTLY IN THE REPAIR SHOP, AND IT HAS TAKEN FORD OVER A WEEK TO DIAGNOSE THE PROBLEM. THE CURRENT DIAGNOSIS SHOWED THAT ALL 4 SOLENOIDS IN THE TRANSMISSION NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE TRANSMISSION NEEDS TO BE TOTALLY REPLACED. THE CONTACT STATED THAT NEITHER SPEED NOR THE WEATHER WERE FACTORS. *AK THE DEALER STATED PERFORMED THE RECALL PERTAINING TO FUEL INJECTOR CONTROL MODULE WIRING AND CHARGED AIR COOLER DUCT. *TR
TL* - THE CONTACT OWNS A 2004 FORD F550. THE CONTACT STATED THAT APPROXIMATELY 1 YEAR THE VEHICLE HAD AN ELECTRICAL SHORT., TOOK THE VEHICLE TO BE REPAIRED AND THAT VERY SAME DAY HAD PROBLEMS WITH THE TRANSMISSION SLIPPING. THE CONTACT STATED THAT APPROXIMATELY ONE YEAR LATER IN JANUARY 2007 THE TRANSMISSION WOULD NOT ENGAGE, AND ONE COULD DRIVE DOWN THE ROAD AND THE TRANSMISSION WOULD JUST STOP WORKING. THE TRUCK WAS CURRENTLY IN THE REPAIR SHOP, AND IT HAS TAKEN FORD OVER A WEEK TO DIAGNOSE THE PROBLEM. THE CURRENT DIAGNOSIS SHOWED THAT ALL 4 SOLENOIDS IN THE TRANSMISSION NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE TRANSMISSION NEEDS TO BE TOTALLY REPLACED. THE CONTACT STATED THAT NEITHER SPEED NOR THE WEATHER WERE FACTORS. *AK THE DEALER STATED PERFORMED THE RECALL PERTAINING TO FUEL INJECTOR CONTROL MODULE WIRING AND CHARGED AIR COOLER DUCT. *TR
WHILE DRIVING A FORD F-550 THAT I BOUGHT USED ON 01-25-06 FROM HUB CITY FORD IN LAFAYETTE, LA...THE ENGINE LOST POWER AND STALLED ON A 65 MPH. HWY (HWY 90). APPARENTLY...THERE IS GOOD CAUSE TO BELIEVE THAT AN IGNORED RECALL ON THIS SPECIFIC TRUCK IS THE EXACT REASON FOR THIS DANGEROUS FAILURE. NOT TO MENTION THE NOW LOST INCOME FROM IT BEING IN THE WAITING LINE AT HUB CITY FORD...WHERE I HAD IT TOWED. I WAS PROMISED THAT ALL WAS INSPECTED AND IN GOOD WORKING ORDER PRIOR TO DRIVING THE TRUCK OFF THE LOT. WELL...IT WASN'T. I CHOSE TO SEE IF THERE WERE ANY RECALL ISSUES WITH THIS TRUCK'S VIN NUMBER AT THE FORD RECALLS WEBSITE... YES...THIS WAS WHAT I SAW: RECALLS RESULTS : BE ADVISED THAT THIS SYSTEM TRACKS SAFETY AND EMISSION RECALLS FOR WHICH VEHICLES ARE SUBJECT TO REPAIR IN THE UNITED STATES. FOR MORE INFORMATION ON FORD MOTOR COMPANY RECALLS OR CONCERNS YOU MAY BE HAVING WITH YOUR VEHICLE, PLEASE CONTACT YOUR DEALERSHIP DIRECTLY. BELOW YOU WILL FIND INFORMATION REGARDING YOUR AFFECTED VEHICLE. RECALLS LISTED 2004 FORD F-550 [XXX] 05E15 EXHAUST PRESSURE SENSOR REPLACEMENT, ON-BOARD DIAGNOSTIC SYSTEM AND ENGINE CONTROL MODULES RECALIBRATION FROM YOUR WEBSITE HERE: MAKE : FORD MODEL : F550 SUPER DUTY YEAR : 2004 MANUFACTURER : FORD MOTOR COMPANY NHTSA CAMPAIGN ID NUMBER : 05V270000 MFG'S REPORT DATE : JUN 07, 2005 COMPONENT: ELECTRICAL SYSTEM:WIRING POTENTIAL NUMBER OF UNITS AFFECTED : 180104 SUMMARY: CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART. CONSEQUENCE: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR. REMEDY: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. FORD RECALL NO. 05S34. *NM UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORM
WHILE DRIVING A FORD F-550 THAT I BOUGHT USED ON 01-25-06 FROM HUB CITY FORD IN LAFAYETTE, LA...THE ENGINE LOST POWER AND STALLED ON A 65 MPH. HWY (HWY 90). APPARENTLY...THERE IS GOOD CAUSE TO BELIEVE THAT AN IGNORED RECALL ON THIS SPECIFIC TRUCK IS THE EXACT REASON FOR THIS DANGEROUS FAILURE. NOT TO MENTION THE NOW LOST INCOME FROM IT BEING IN THE WAITING LINE AT HUB CITY FORD...WHERE I HAD IT TOWED. I WAS PROMISED THAT ALL WAS INSPECTED AND IN GOOD WORKING ORDER PRIOR TO DRIVING THE TRUCK OFF THE LOT. WELL...IT WASN'T. I CHOSE TO SEE IF THERE WERE ANY RECALL ISSUES WITH THIS TRUCK'S VIN NUMBER AT THE FORD RECALLS WEBSITE... YES...THIS WAS WHAT I SAW: RECALLS RESULTS : BE ADVISED THAT THIS SYSTEM TRACKS SAFETY AND EMISSION RECALLS FOR WHICH VEHICLES ARE SUBJECT TO REPAIR IN THE UNITED STATES. FOR MORE INFORMATION ON FORD MOTOR COMPANY RECALLS OR CONCERNS YOU MAY BE HAVING WITH YOUR VEHICLE, PLEASE CONTACT YOUR DEALERSHIP DIRECTLY. BELOW YOU WILL FIND INFORMATION REGARDING YOUR AFFECTED VEHICLE. RECALLS LISTED 2004 FORD F-550 [XXX] 05E15 EXHAUST PRESSURE SENSOR REPLACEMENT, ON-BOARD DIAGNOSTIC SYSTEM AND ENGINE CONTROL MODULES RECALIBRATION FROM YOUR WEBSITE HERE: MAKE : FORD MODEL : F550 SUPER DUTY YEAR : 2004 MANUFACTURER : FORD MOTOR COMPANY NHTSA CAMPAIGN ID NUMBER : 05V270000 MFG'S REPORT DATE : JUN 07, 2005 COMPONENT: ELECTRICAL SYSTEM:WIRING POTENTIAL NUMBER OF UNITS AFFECTED : 180104 SUMMARY: CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART. CONSEQUENCE: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR. REMEDY: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. FORD RECALL NO. 05S34. *NM UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORM
DT: THE VEHICLE SURGED AND ACCELERATED ON ITS OWN. THIS HAPPENED THIS HAS HAPPENED A T LEAST 50 TIMES OR MORE. WHILE DRIVING 43 MPH VEHICLE SHUT DOWN. HAD TO SLAM ON THE EMERGENCY BRAKE AND PULL IT TO THE CURB. ALSO, WHILE DRIVING AT 38 MPH OR 1100 RPMS THERE WAS VIBRATION COMING FROM THE ENGINE. IT FELT LIKE IT WAS COMING RIGHT FROM CONSUMER'S FEET. IT FELT LIKE TRANSMISSION DISENGAGED. THEN, AFTER 10-15 SECONDS IT FELT LIKE IT KICKED BACK IN. THERE WAS A LOUD POP WHEN THIS HAPPENED. THE VEHICLE WAS BURNING MORE FUEL THAN IT DID WHEN FIRST PURCHASED IT. SOMETIMES THE WATER AND FUEL LIGHTS CAME ON. THE DEALER TOLD HIM THAT WHEN THIS HAPPENED HE SHOULD PULL OVER. BUT WHEN HE DOES THERE IS NO WATER IN THE FUEL. THE FUEL GAUGE WILL COMPLETELY GO TO LOW THEN COME BACK UP AFTER ABOUT 10-15 MILES. ALSO, THE AIR BAG LIGHT WILL COME ON. WHEN HE TAKES VEHICLE TO THE DEALER THEY USUALLY GO THROUGH THE WHOLE VEHICLE, SPECIFICALLY THE ELECTRICAL SYSTEMS. THE DEALERSHIP TRIED BUT FAILED TO FIX THESE PROBLEMS. HAD TAKEN THE VEHICLE TO A VARIETY OF DEALERSHIPS MULTIPLE TIMES. THE TURBO, TRANSMISSION AND WIRING WAS REPLACED. THE DEALER TOLD THE CONSUMER THAT THE VEHICLE HAD NOT BEEN CODED WHEN HE PURCHASED IT. *AK
DT: THE VEHICLE SURGED AND ACCELERATED ON ITS OWN. THIS HAPPENED THIS HAS HAPPENED A T LEAST 50 TIMES OR MORE. WHILE DRIVING 43 MPH VEHICLE SHUT DOWN. HAD TO SLAM ON THE EMERGENCY BRAKE AND PULL IT TO THE CURB. ALSO, WHILE DRIVING AT 38 MPH OR 1100 RPMS THERE WAS VIBRATION COMING FROM THE ENGINE. IT FELT LIKE IT WAS COMING RIGHT FROM CONSUMER'S FEET. IT FELT LIKE TRANSMISSION DISENGAGED. THEN, AFTER 10-15 SECONDS IT FELT LIKE IT KICKED BACK IN. THERE WAS A LOUD POP WHEN THIS HAPPENED. THE VEHICLE WAS BURNING MORE FUEL THAN IT DID WHEN FIRST PURCHASED IT. SOMETIMES THE WATER AND FUEL LIGHTS CAME ON. THE DEALER TOLD HIM THAT WHEN THIS HAPPENED HE SHOULD PULL OVER. BUT WHEN HE DOES THERE IS NO WATER IN THE FUEL. THE FUEL GAUGE WILL COMPLETELY GO TO LOW THEN COME BACK UP AFTER ABOUT 10-15 MILES. ALSO, THE AIR BAG LIGHT WILL COME ON. WHEN HE TAKES VEHICLE TO THE DEALER THEY USUALLY GO THROUGH THE WHOLE VEHICLE, SPECIFICALLY THE ELECTRICAL SYSTEMS. THE DEALERSHIP TRIED BUT FAILED TO FIX THESE PROBLEMS. HAD TAKEN THE VEHICLE TO A VARIETY OF DEALERSHIPS MULTIPLE TIMES. THE TURBO, TRANSMISSION AND WIRING WAS REPLACED. THE DEALER TOLD THE CONSUMER THAT THE VEHICLE HAD NOT BEEN CODED WHEN HE PURCHASED IT. *AK
THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING. WHEN THIS OCCURRED THE VEHICLE WOULD LOSE BRAKING POWER. GVW IS 17500 MAKING IT VERY DIFFICULT TO CONTROL THE VEHICLE WHEN IT STALLS. THE VEHICLE HAS BEEN SERVICED SEVERAL TIMES IN WHICH THE HARNESS HAS BEEN REPLACED, BUT THE FAILURE STILL EXISTS. *JB
THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING. WHEN THIS OCCURRED THE VEHICLE WOULD LOSE BRAKING POWER. GVW IS 17500 MAKING IT VERY DIFFICULT TO CONTROL THE VEHICLE WHEN IT STALLS. THE VEHICLE HAS BEEN SERVICED SEVERAL TIMES IN WHICH THE HARNESS HAS BEEN REPLACED, BUT THE FAILURE STILL EXISTS. *JB
THE CONSUMER'S 2004 FORD F550 HAS HAD THREE SETS OF BATTERIES SINCE PURCHASED. THE CONSUMER BELIEVES THE VEHICLE HAS AN ELECTRICAL PROBLEM. *NM
THE CONSUMER'S 2004 FORD F550 HAS HAD THREE SETS OF BATTERIES SINCE PURCHASED. THE CONSUMER BELIEVES THE VEHICLE HAS AN ELECTRICAL PROBLEM. *NM