This Problem Across All Years
FRONT DRIVERS SIDE SPARK PLUG BLEW OUT OF ENGINE AND DESTROYED COIL PACK RIPPING THE THREADS OUT OF THE HEAD. *TR
FRONT DRIVERS SIDE SPARK PLUG BLEW OUT OF ENGINE AND DESTROYED COIL PACK RIPPING THE THREADS OUT OF THE HEAD. *TR
V6 4.2L ENGINE: GASKET FAILURE CAUSING WATER/FLUID FILL UP THE CYLINDER WHICH CAUSES THE ROD TO BLOW.*AK
V6 4.2L ENGINE: GASKET FAILURE CAUSING WATER/FLUID FILL UP THE CYLINDER WHICH CAUSES THE ROD TO BLOW.*AK
UPON STARTING ONE MORNING, THE ENGINE MADE A LOUD BANGING NOISE. HAD THE ENGINE INSPECTED AND FOUND THAT AN INTAKE MANIFOLD GASKET HAD FAILED. THE ENGINE HAD TO BE REPLACED. *NM
UPON STARTING ONE MORNING, THE ENGINE MADE A LOUD BANGING NOISE. HAD THE ENGINE INSPECTED AND FOUND THAT AN INTAKE MANIFOLD GASKET HAD FAILED. THE ENGINE HAD TO BE REPLACED. *NM
I USED TO BE A PROUD OWNER OF A 1997 FORD F150 4.2 LITER V6. THAT WAS UNTIL TODAY WHEN MY ENGINE HYDROLOCKED FOR THE THIRD TIME. THE TRUCK NOW HAS 164000 MILES ON IT, HOWEVER, THE FIRST TIME HAPPENED AT APPROX. 110000 MILES. AFTER DOING SOME RESEARCH IT WAS DISCOVERED THAT THIS IS A COMMON PROBLEM WITH THE V6 ENGINES, AND THAT FORD WILL NOT DO ANYTHING DO TO THE "HIGH" MILES. I REPLACED THE ENGINE WITH A COMPLETE NEW SHORT BOCK,AND THE RECOMMENDED BY FORD 4MM HEAD GASKETS INSTEAD OF THE 3MM THAT THEY ORIGINALLY INSTALLED. THIS ENGINE LASTED ANOTHER APPROX 20000 MILES BEFORE IT HYDROLOCKED AGAIN. THIS TIME IT WAS REPAIRED UNDER THE WARRANTY FROM THE ENGINE SUPPLIER...THANKFULLY. NOW, HOWEVER THERE ISN'T ANYTHING TO DO BUT REPLACE THE ENGINE AGAIN. IT'S NOT WORTH MUCH AS A RUNNING VEHICLE DO TO IT'S AGE, BUT AS A NON-RUNNING ONE IT'S REALLY WORTHLESS. I JUST HOPE THE SOMEDAY FORD WILL BE PRESSURED INTO MAKING SOME KIND OF ACKNOWLEDGEMENT THAT THEY HAVE A PROBLEM WITH THESE ENGINES AND AT THE VERY LEAST OFFER ADVICE THAT TRULY HELPS THE CONSUMER NOT JUST BAND-AIDS THE ISSUE UNTIL IT'S TOO LATE. ON A SIDE NOT I'M NOT A DISGRUNTLED FORD OWNER I CURRENTLY OWN FOUR OTHER FORD VEHICLES DATING FROM 2003 BACK TO 1986. I JUST HOPE MAYBE I CAN HELP GET SOMETHING DONE BY WRITING THIS. THANK YOU FOR YOUR TIME. *NM
I USED TO BE A PROUD OWNER OF A 1997 FORD F150 4.2 LITER V6. THAT WAS UNTIL TODAY WHEN MY ENGINE HYDROLOCKED FOR THE THIRD TIME. THE TRUCK NOW HAS 164000 MILES ON IT, HOWEVER, THE FIRST TIME HAPPENED AT APPROX. 110000 MILES. AFTER DOING SOME RESEARCH IT WAS DISCOVERED THAT THIS IS A COMMON PROBLEM WITH THE V6 ENGINES, AND THAT FORD WILL NOT DO ANYTHING DO TO THE "HIGH" MILES. I REPLACED THE ENGINE WITH A COMPLETE NEW SHORT BOCK,AND THE RECOMMENDED BY FORD 4MM HEAD GASKETS INSTEAD OF THE 3MM THAT THEY ORIGINALLY INSTALLED. THIS ENGINE LASTED ANOTHER APPROX 20000 MILES BEFORE IT HYDROLOCKED AGAIN. THIS TIME IT WAS REPAIRED UNDER THE WARRANTY FROM THE ENGINE SUPPLIER...THANKFULLY. NOW, HOWEVER THERE ISN'T ANYTHING TO DO BUT REPLACE THE ENGINE AGAIN. IT'S NOT WORTH MUCH AS A RUNNING VEHICLE DO TO IT'S AGE, BUT AS A NON-RUNNING ONE IT'S REALLY WORTHLESS. I JUST HOPE THE SOMEDAY FORD WILL BE PRESSURED INTO MAKING SOME KIND OF ACKNOWLEDGEMENT THAT THEY HAVE A PROBLEM WITH THESE ENGINES AND AT THE VERY LEAST OFFER ADVICE THAT TRULY HELPS THE CONSUMER NOT JUST BAND-AIDS THE ISSUE UNTIL IT'S TOO LATE. ON A SIDE NOT I'M NOT A DISGRUNTLED FORD OWNER I CURRENTLY OWN FOUR OTHER FORD VEHICLES DATING FROM 2003 BACK TO 1986. I JUST HOPE MAYBE I CAN HELP GET SOMETHING DONE BY WRITING THIS. THANK YOU FOR YOUR TIME. *NM
I HAD JUST ARRIVED BACK IN LAKELAND FL FROM A TRIP TO THE EAST COAST. I STOPPED AT A STORE TO BUY A FEW THINGS AND WHEN I CAME OUT AND STARTED MY 5.4 LITER F- 250 LIGHT DUTY TRUCK IT BLEW A SPARK PLUG ON THE PASSENGER SIDE. IT WAS THE SECOND PLUG FROM THE REAR. MY TRUCK IS A 1997 FORD WITH 100500 APPROXIMATELY MILES ON IT. I HAD IT TOWED TO THE FORD DEALERSHIP THAT I BOUGHT IT FROM FOR REPAIR. THE SERVICE MANAGER SAID HE HAD NEVER HEARD OF TRITON ENGINES BLOWING SPARK PLUGS. I HAPPENED TO KNOW A PERSON THAT WORKED IN THE SERVICE DEPARTMENT AND ACCORDING TO THAT INDIVIDUAL IT WAS A COMMON PROBLEM NORMALLY REQUIRING A NEW HEAD AT A COST OF AROUND $3000 BUT SOME COULD BE REPAIRED BY LNSTALLING A NEW PLUG IF I WAS LUCKY. HOWEVER FORD WOULD NOT GUARANTEE THE INSTALLATION OF A NEW PLUG REPAIR. UPON GOING ONLINE I FOUND OUT THAT ALOT OF OTHER PEOPLE ARE HAVEING THE SAME PROBLEM AND FORD IS DONING LITTLE OR NOTHING ABOUT IT. I FOUND THAT PRIOR TO THE PLUG BLOWING MOST PEOPLE WERE HEARING A KNOCKING NOISE ON A COLD START. I HAD HEARD THAT THE WEEK PRIOR TO MY PLUG BLOWING. AFTER THE REPAIR THE NOISE WAS GONE FOR ABOUT 4 DAYS. WE HAD A COLD FRONT COME THRU AND WHEN I STARTED MY TRUCK THAT MORNING THE NOISE WAS BACK AND MUCH WORSE. I TRADED MY TRUCK AS A RESULT. NO OLD PARTS WERE AVAILABLE. THEY DISCARDED THEM. THEY ALSO ASSURED ME THAT THEY HAD RETORQUED ALL THE PLUGS. I HAD HAD ALL THE PLUGS REPLACED AT APPROX. 80,000 MILES BY A FORD DEALER. BIGSERT MAKES A KIT FOR INSTALLING AN INSERT IN TRITON ENGINES. IT COMES COMPLETE WITH ALL THE SPECIAL TOOLS REQUIRED TO DO THE JOB. IF THERE IS NOT A DEMAND FOR SUCH A KIT COMPANIES WONT GO TH THE EXPENSE OF DISIGNING SUCH A KIT. *AK
I HAD JUST ARRIVED BACK IN LAKELAND FL FROM A TRIP TO THE EAST COAST. I STOPPED AT A STORE TO BUY A FEW THINGS AND WHEN I CAME OUT AND STARTED MY 5.4 LITER F- 250 LIGHT DUTY TRUCK IT BLEW A SPARK PLUG ON THE PASSENGER SIDE. IT WAS THE SECOND PLUG FROM THE REAR. MY TRUCK IS A 1997 FORD WITH 100500 APPROXIMATELY MILES ON IT. I HAD IT TOWED TO THE FORD DEALERSHIP THAT I BOUGHT IT FROM FOR REPAIR. THE SERVICE MANAGER SAID HE HAD NEVER HEARD OF TRITON ENGINES BLOWING SPARK PLUGS. I HAPPENED TO KNOW A PERSON THAT WORKED IN THE SERVICE DEPARTMENT AND ACCORDING TO THAT INDIVIDUAL IT WAS A COMMON PROBLEM NORMALLY REQUIRING A NEW HEAD AT A COST OF AROUND $3000 BUT SOME COULD BE REPAIRED BY LNSTALLING A NEW PLUG IF I WAS LUCKY. HOWEVER FORD WOULD NOT GUARANTEE THE INSTALLATION OF A NEW PLUG REPAIR. UPON GOING ONLINE I FOUND OUT THAT ALOT OF OTHER PEOPLE ARE HAVEING THE SAME PROBLEM AND FORD IS DONING LITTLE OR NOTHING ABOUT IT. I FOUND THAT PRIOR TO THE PLUG BLOWING MOST PEOPLE WERE HEARING A KNOCKING NOISE ON A COLD START. I HAD HEARD THAT THE WEEK PRIOR TO MY PLUG BLOWING. AFTER THE REPAIR THE NOISE WAS GONE FOR ABOUT 4 DAYS. WE HAD A COLD FRONT COME THRU AND WHEN I STARTED MY TRUCK THAT MORNING THE NOISE WAS BACK AND MUCH WORSE. I TRADED MY TRUCK AS A RESULT. NO OLD PARTS WERE AVAILABLE. THEY DISCARDED THEM. THEY ALSO ASSURED ME THAT THEY HAD RETORQUED ALL THE PLUGS. I HAD HAD ALL THE PLUGS REPLACED AT APPROX. 80,000 MILES BY A FORD DEALER. BIGSERT MAKES A KIT FOR INSTALLING AN INSERT IN TRITON ENGINES. IT COMES COMPLETE WITH ALL THE SPECIAL TOOLS REQUIRED TO DO THE JOB. IF THERE IS NOT A DEMAND FOR SUCH A KIT COMPANIES WONT GO TH THE EXPENSE OF DISIGNING SUCH A KIT. *AK