1996 FORD F SERIES Problems & Recalls

TRUCK WAS DRIVEN THEN PARKED, 15 MINUTES LATER WHILE MOWING THE GRASS, I LOOKED OVER AT THE PARKED TRUCKAND IT WAS ON FIRE. THE FIRE STARTED AT THE BRAKE MASTER CYLINDER AND IT WAS A TOTAL LOSS.

Mileage: 219,000

OPENED REAR TANK CAP AND FUEL SPURTED OUT AND WOULD NOT STOP HAD TO PUT CAP BACK ON, I NEVER USE THIS TANK ONLY REFUEL IN THE FRONT TANK. *TR

Mileage: 90,000

I HAVE TRIED NUMEROUS TIMES TO REPLACE MY DOOR HANDLES FROM THE INSIDE OF MY TRUCK. THEY KEEP BREAKING, AND NOW I AM DRIVING A TRUCK THAT I CAN ONLY OPEN FROM THE OUTSIDE AFTER ROLLING MY WINDOWS DOWN. I HAVE TALKED TO FORD ABOUT THIS DEFECT, WHICH I CONSIDER A HIGH SAFETY ISSUE IN AN EMERGENCY. THE...

Mileage: 197,832

GASOLINE IS LEAKING OUT OF THE FRONT FUEL CAP OF MY 1996 FORD F-150 TRUCK. MY TRUCK HAS DUAL TANKS. I CONSIDER THIS TO BE A VERY DANGEROUS PROBLEM THAT COULD CAUSE A FIRE OR EXPLOSION. MY RESEARCH ONLINE FOUND NHTSA CAMPAIGN ID NUMBER 91V146000. THIS IS THE PROBLEM MY TRUCK IS HAVING BUT IT IS NOT C...

GASOLINE IS LEAKING OUT OF THE FRONT FUEL CAP OF MY 1996 FORD F-150 TRUCK. MY TRUCK HAS DUAL TANKS. I CONSIDER THIS TO BE A VERY DANGEROUS PROBLEM THAT COULD CAUSE A FIRE OR EXPLOSION. MY RESEARCH ONLINE FOUND NHTSA CAMPAIGN ID NUMBER 91V146000. THIS IS THE PROBLEM MY TRUCK IS HAVING BUT IT IS NOT C...

A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE. *KB

Mileage: 120,000

CRUISE CONTROL REFUSES TO DISENGAGE WHEN BRAKES APPLIED. ISSUE REPORTED TO FORD DLR. IN 2002 AND DLR. REFUSED TO REPAIR AS NOT UNDER WARRANTY RECALL AND UNIT OUT OF WARRANTY. I DO NOT TRY TO USE CRUISE CONTROL AS VEHICLE ACCELERATES WITH CONTROL ON AND WILL NOT DISENGAGE. THIS IS A SAFETY ISSUE THA...

Mileage: 105,000

THE REAR FUEL TANK DRAINS FUEL FROM THE FRONT FUEL TANK AND CAUSES FUEL TO OUT PAST THE FILL CAP. *TR

Mileage: 102,000

1996 FORD F 150 AUTO TRANS W/ OVERDRIVE CRUISE & TILT, THE PROBLEM IS STEERING COLUMN FAILURE FIRST TIME WAS ABOUT THREE YEARS AGO AND AGAIN NOW 11/30/2007. THE 1ST TIME AT ABOUT 78,000 MI. AND THE MILEAGE NOW IS 179,000 MI THE DESCRIPTION OF THE FAILURE STARTS AS POPPING SOUNDS ALONG WITH TH...

Mileage: 179,000

ON 1/10/05, I ARRIVED HOME FROM WORK AND PARKED MY VEHICLE AT APPROXIMATELY 6:00 PM. THE VEHICLE WAS PARKED UNDER THE CARPORT 15 FEET AWAY FROM MY BEDROOM WINDOW. AT 12:30 AM, MY WIFE AND I HEARD A NOISE, LOOKED OUT THE BLINDS TO FIND FIRE COMING FROM DRIVERS SIDE EDGES OF HOOD. ME AND MY SON ...

Mileage: 91,000

MY SONS TRUCK 1996 FORD F150 CAUGHT FIRE SITTING IN THE DRIVEWAY IT HAD BEEN SITTING THERE A LITTLE OVER TWO HOURS. IT STARTED ON THE RIGHT SIDE OF THE VEHICLE UNDER THE HOOD. THE TRUCK IS TOTALED, MY SOFIC AND GUTTER WAS DESTROYED MY GARAGE. MY 2005 CAR-MATE TRAILER HAS HEAT DAMAGE ON THE FRONT...

Mileage: 155,000

13-21 AUG TRUCK WAS PARKED IN DRIVEWAY WHILE WE VISITED FAMILY IN SOUTH CAROLINA. TRUCK NOT DRIVEN. DROVE TRUCK 22 AUG TO WORK APPROX. 12.5 MILES. TRUCK WAS PARKED IN PARKING LOT UNTIL 4PM WHEN I DROVE IT HOME. TRUCK WAS PARKED IN DRIVEWAY FROM 4:30 PM UNTIL THE FIRE WAS DISCOVERED BETWEEN 8:30 A...

Mileage: 103,000

DT: CONTACT STATES: A FIRE STARTED WHICH WAS RELATED TO THE CRUISE CONTROL MODULE SITTING ON THE BRAKE MASTER CYLINDER. THE FIRE STARTED WHILE THE VEHICLE WAS SHUT OFF IN A PARKING LOT BY ITSELF. SOME OF THE ENGINE EQUIPMENT BURNED. CONSUMER CONTACTED FORD ,AND FORD SAID THE VEHICLE WAS NOT UNDER...

Mileage: 73,000

NYS VEHICLE INSPECTION REQUIRES EMISSION TESTING ON 96 & NEWER MODELS. I HAD MY OXYGEN SENSORS REPLACED SEVERAL TIMES & TWICE IN ONE YEARS TIME. THE OXYGEN SENSORS THAT FORD MAKES ARE DEFECTIVE. IT COSTS ME OVER $500 EACH TIME TO REPLACE THESE SENSORS. *AK

Mileage: 20,000

1996 FORD F150 FUSE BLOWN # 13 (IN DASH) BRAKE LIGHT FAILURE; SPEED CONTROL ASSOCIATED SENSORS. LOCAL FORD DEALER SERVICED 9-27-04 @ $510.30 TO DIAGNOSE SITUATION AND REMEDIED BY REPLACING THE WHOLE MASTER CYLINDER WHERE IT WAS OBVIOUS THAT THE SWITCH FROM THE SPEED CONTROL ON THIS BRAKE UNI...

Mileage: 152,002

SEPT. 5TH I ENCOUNTERED A PROBLEM I THOUGHT I WOULD NEVER HAVE TO DEAL WITH. I HAVE BEEN A LONG TIME SUPPORTER OF FORD, BUT THIS HAS TURNED ME SOUR. I HAVE A PUPPY THAT I PUT INTO THE CAB OF MY TRUCK. AS HE WAS MOVING TOWARDS THE PASSENGERS SEAT (ON THE FLOOR) HE MUST HAVE RUBBED HIS PAW UP NEXT ...

Mileage: 57,000

MY F150 ONLY HAS 65000 MILES AND IS 7 YRS. OLD AND DTHE OIL PAN IS RUSTED OUT. FROM THE SOUNDS OF IT, THIS HAS BEEN AN ONGOING PROBLEM WITH FROD TRUCKS BASED ON INFO. POSTED ON A WEBSDSITE BULLETIN BOARD. I THINK FORD SHOULD TAKE CARE OF THIS.*AK