This Problem Across All Years
SPARK PLUG SHOOTOUT/ SPARK PLUG THREAD FAILURE. *TR
SPARK PLUG SHOOTOUT/ SPARK PLUG THREAD FAILURE. *TR
THIS WAS THE RECALL DRIVEABITITY. PERFORMED BY SELLING DEALER FORD OF WALLA WALLA UNDER WARRANTY. FORM WILL NOT ACCEPT PARTS. REPLACED EP SENSOR DID RECALL MAINTENANCE 59B01 AND RECALL DIESEL ENGINE01F0Z14. *TR
THIS WAS THE RECALL DRIVEABITITY. PERFORMED BY SELLING DEALER FORD OF WALLA WALLA UNDER WARRANTY. FORM WILL NOT ACCEPT PARTS. REPLACED EP SENSOR DID RECALL MAINTENANCE 59B01 AND RECALL DIESEL ENGINE01F0Z14. *TR
ON APRIL 5, I WAS IN HE PROCESS OF STOPPING FOR A STOP SIGN, WHEN THE ENGINE STOPPED RUNNING. I WAS ABLE TO RESTART THE TRUCK. I DROVE LESS THAN 2 MILES, TURNED THE TRUCK OFF AND IT WOULD NOT RESTART. I HAD TRUCK TOWED TO AUTONATION FORD IN ST. PETERSBURG FL. MECHANIC NOT ON DUTY, BUT MONDAY (APRIL 7, 2014), SERVICE DEPARTMENT CALLED AND SAID NOTHING SHOWED UP ON THEIR COMPUTER CHECK, AND WAS STARTING FINE AFTER A MINOR ADJUSTMENT. I PICKED UP THE TRUCK, DROVE LESS THAN 2 MILES, WHEN IT STALLED AS I WAS IN THE PROCESS OF COMING TO A STOP, WHILE MY SPEED WAS ABOUT 30 MPH. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. I WAS ABLE TO RESTART TRUCK AND RETURNED TO DEALER. TOLD THEM I DID NOT THINK I SHOULD HAVE TO PAY FOR A SECOND DIAGNOSTIC TEST, SINCE THEY HAD FAILED TO FIND OR FIX THE PROBLEM. ON APRIL 10, DEALER CALLED SAID THEY COULD NOT REPRODUCE THE PROBLEM AND SAID IT COULD BE EGR DIRTY OR TURBO BOOST. SINCE I HAD NOTICED TURBO WAS NOT KICKING IN PROPERLY DURING ACCELERATION FROM A STOP, I TOLD THEM TO DO BOTH BUT TO TAKE OFF THE $155 THEY HAD CHARGED ME FOR DIAGNOSIS. THEY AGREED AND MY TRUCK WAS RETURNED TO ME ON APRIL 12, 2014. ON APRIL 13, THE TRUCK STALLED WHEN COMING TO A STOP FOR A TRAFFIC SIGNAL. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. LESS THAN A MILE LATER WHEN SLOWING TO MAKE A TURN, ENGINE SHUTDOWN AND I LOST POWER STEERING. I WAS BARELY ABLE TO MISS STRIKING A HOUSE AT THE INTERSECTION. TRUCK STALLED TWICE DURING THE NEXT 2 MILE TRIP. I THINK THIS IS A VERY DANGEROUS PROBLEM AND IT IS NOT BEING ADDRESSED BY FORD OR IT'S DEALER. PLEASE INVESTIGATE. *TR UPDATED 10/2/2014 *JS
ON APRIL 5, I WAS IN HE PROCESS OF STOPPING FOR A STOP SIGN, WHEN THE ENGINE STOPPED RUNNING. I WAS ABLE TO RESTART THE TRUCK. I DROVE LESS THAN 2 MILES, TURNED THE TRUCK OFF AND IT WOULD NOT RESTART. I HAD TRUCK TOWED TO AUTONATION FORD IN ST. PETERSBURG FL. MECHANIC NOT ON DUTY, BUT MONDAY (APRIL 7, 2014), SERVICE DEPARTMENT CALLED AND SAID NOTHING SHOWED UP ON THEIR COMPUTER CHECK, AND WAS STARTING FINE AFTER A MINOR ADJUSTMENT. I PICKED UP THE TRUCK, DROVE LESS THAN 2 MILES, WHEN IT STALLED AS I WAS IN THE PROCESS OF COMING TO A STOP, WHILE MY SPEED WAS ABOUT 30 MPH. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. I WAS ABLE TO RESTART TRUCK AND RETURNED TO DEALER. TOLD THEM I DID NOT THINK I SHOULD HAVE TO PAY FOR A SECOND DIAGNOSTIC TEST, SINCE THEY HAD FAILED TO FIND OR FIX THE PROBLEM. ON APRIL 10, DEALER CALLED SAID THEY COULD NOT REPRODUCE THE PROBLEM AND SAID IT COULD BE EGR DIRTY OR TURBO BOOST. SINCE I HAD NOTICED TURBO WAS NOT KICKING IN PROPERLY DURING ACCELERATION FROM A STOP, I TOLD THEM TO DO BOTH BUT TO TAKE OFF THE $155 THEY HAD CHARGED ME FOR DIAGNOSIS. THEY AGREED AND MY TRUCK WAS RETURNED TO ME ON APRIL 12, 2014. ON APRIL 13, THE TRUCK STALLED WHEN COMING TO A STOP FOR A TRAFFIC SIGNAL. LOST POWER STEERING BUT WAS ABLE TO MAINTAIN CONTROL. LESS THAN A MILE LATER WHEN SLOWING TO MAKE A TURN, ENGINE SHUTDOWN AND I LOST POWER STEERING. I WAS BARELY ABLE TO MISS STRIKING A HOUSE AT THE INTERSECTION. TRUCK STALLED TWICE DURING THE NEXT 2 MILE TRIP. I THINK THIS IS A VERY DANGEROUS PROBLEM AND IT IS NOT BEING ADDRESSED BY FORD OR IT'S DEALER. PLEASE INVESTIGATE. *TR UPDATED 10/2/2014 *JS
VEHICLE ENGINE (6.0 DIESEL) UNEXPECTEDLY AND SUDDENLY DIED WHILE CLIMBING A NARROW MOUNTAIN STATE HIGHWAY, JUST IN BETWEEN SWITCHBACKS THAT HAD NO SHOULDERS; HAD ENOUGH SPEED TO JUST CLEAR ROAD ONTO A SHOULDER. NO WARNING LIGHTS, NO CHECK ENGINE LIGHT HAD EVER DISPLAYED PREVIOUSLY TO THIS INCIDENT. VEHICLE WOULD NOT START, TOWED TO LOCAL FORD DEALER. ENGINE TEARDOWN REVEALED LOSS OF HIGH PRESSURE OIL; AND FICM FAILURE AND GLOW PLUG MODULE FAULT BY OBD AND CHECK ENGINE LIGHT THAT NOW'S CONTINUOUSLY ILLUMINATED. STC FITTING REPLACED, DECLINED FICM AND GPM REPAIRS DUE TO COST AND VEHICLE ABLE TO RUN TO GET IT HOME. CHECK ENGINE LIGHT REMAINS ILLUMINATED. RESEARCH ON THE INTERNET REVEALS THESE 3 PARTS, AMONG OTHERS ON THE 6.0 ENGINE, HAVE EXTREMELY HIGH FAILURE RATES, ALL RESULTING IN AN IMMEDIATE LOSS OF POWER AND POTENTIAL STRANDING. THE MANUFACTURER AND DEALER WERE CONTACTED WITHOUT SATISFACTION. THE NHTSA NEEDS TO INVESTIGATE THIS AS A SAFETY AND INHERENT DEFECTIVE DESIGN OR MANUFACTURING ISSUE (AND COST!!!). IT MAY ALSO BE AN EMISSIONS CONTROL ISSUE AS THESE PARTS FAIL AND ARE NOT REPAIRED OR ARE REMOVED. THIS VEHICLE IS FACTORY STOCK AND DEALER MAINTAINED, HAD 6 YEAR, 75,000 MILE FORD EXTENDED WARRANTY. *TR
VEHICLE ENGINE (6.0 DIESEL) UNEXPECTEDLY AND SUDDENLY DIED WHILE CLIMBING A NARROW MOUNTAIN STATE HIGHWAY, JUST IN BETWEEN SWITCHBACKS THAT HAD NO SHOULDERS; HAD ENOUGH SPEED TO JUST CLEAR ROAD ONTO A SHOULDER. NO WARNING LIGHTS, NO CHECK ENGINE LIGHT HAD EVER DISPLAYED PREVIOUSLY TO THIS INCIDENT. VEHICLE WOULD NOT START, TOWED TO LOCAL FORD DEALER. ENGINE TEARDOWN REVEALED LOSS OF HIGH PRESSURE OIL; AND FICM FAILURE AND GLOW PLUG MODULE FAULT BY OBD AND CHECK ENGINE LIGHT THAT NOW'S CONTINUOUSLY ILLUMINATED. STC FITTING REPLACED, DECLINED FICM AND GPM REPAIRS DUE TO COST AND VEHICLE ABLE TO RUN TO GET IT HOME. CHECK ENGINE LIGHT REMAINS ILLUMINATED. RESEARCH ON THE INTERNET REVEALS THESE 3 PARTS, AMONG OTHERS ON THE 6.0 ENGINE, HAVE EXTREMELY HIGH FAILURE RATES, ALL RESULTING IN AN IMMEDIATE LOSS OF POWER AND POTENTIAL STRANDING. THE MANUFACTURER AND DEALER WERE CONTACTED WITHOUT SATISFACTION. THE NHTSA NEEDS TO INVESTIGATE THIS AS A SAFETY AND INHERENT DEFECTIVE DESIGN OR MANUFACTURING ISSUE (AND COST!!!). IT MAY ALSO BE AN EMISSIONS CONTROL ISSUE AS THESE PARTS FAIL AND ARE NOT REPAIRED OR ARE REMOVED. THIS VEHICLE IS FACTORY STOCK AND DEALER MAINTAINED, HAD 6 YEAR, 75,000 MILE FORD EXTENDED WARRANTY. *TR
ALMOST TOTAL LOSS OF ENGINE POWER WHILE ATTEMPTING TO PASS ANOTHER VEHICLE IN THE RAIN, TWICE! ALSO VIOLENT ENGINE SHAKING RIGHT AFTER START UP. SHAKING STOPPED AFTER ENGINE WAS TURNED OFF AND RESTARTED. *TR
ALMOST TOTAL LOSS OF ENGINE POWER WHILE ATTEMPTING TO PASS ANOTHER VEHICLE IN THE RAIN, TWICE! ALSO VIOLENT ENGINE SHAKING RIGHT AFTER START UP. SHAKING STOPPED AFTER ENGINE WAS TURNED OFF AND RESTARTED. *TR
THE VEHICLE STARTED TO GO SLOWER AND SLOWER AND THEN ONCE STOPPED AND PULLED OVER WHITE SMOKE CAME OUT OF TAIL PIPE. THE TRUCK WAS TOWED TO A FORD DEALER AND THEY KNEW RIGHT OFF THAT IT WAS THE EGR COOLER THAT FAILED AND SAID IT IS A KNOW DEFECT IN THIS MOTOR AND TRUCK. THE EGR COOLER IN TURN COKED THE CENTER OF THE TURBO AND THE HEAD GASKETS FAILED. I FOUND OUT FROM THE DEALER THAT THIS IS A KNOW DEFECT IN THIS MOTOR BUT FORD WOULD NOT BACK IT UP SINCE IT IS OUT OF WARRANTY. *TR
THE VEHICLE STARTED TO GO SLOWER AND SLOWER AND THEN ONCE STOPPED AND PULLED OVER WHITE SMOKE CAME OUT OF TAIL PIPE. THE TRUCK WAS TOWED TO A FORD DEALER AND THEY KNEW RIGHT OFF THAT IT WAS THE EGR COOLER THAT FAILED AND SAID IT IS A KNOW DEFECT IN THIS MOTOR AND TRUCK. THE EGR COOLER IN TURN COKED THE CENTER OF THE TURBO AND THE HEAD GASKETS FAILED. I FOUND OUT FROM THE DEALER THAT THIS IS A KNOW DEFECT IN THIS MOTOR BUT FORD WOULD NOT BACK IT UP SINCE IT IS OUT OF WARRANTY. *TR
I JUST RECENTLY PURCHASED MY FIRST 2005 FORD F-250 IN AUGUST OF 2012. THIS IS THE FIRST VEHICLE THAT I PURCHASED THAT WAS A FORD PRODUCT. ON AUGUST 13, 2012 I WAS DRIVING MY TRUCK DOING APPROXIMATELY 35 MPH WHEN I NOTICED THAT I STARTED TO LOSE POWER ON THE ACCELERATOR AND MY VEHICLE JUST SHUTT OFF ALL OF A SUDDEN. THE VEHICLE LEFT ME STRANDED AND WOULD NOT RESTART. I HAD TO WAIT ABOUT THIRTY MINUTES BEFORE THE VEHICLE WOULD START AGAIN. I ALSO SMELLED A STRONG ODOR OF EXHAUST IN THE CABIN OF MY TRUCK. I THEN WENT TO A LOCAL MUFFLER SHOP AND HAD THEM CHECK MY EXHAUST SYSTEM. I WAS TOLD THAT THE TRUCK HAD NO EXHAUST LEAKS. I THEN STARTED TO RESEARCH THE SYMPTOMS OF MY TRUCK ONLINE AND FOUND OUT THAT THERE WERE NUMEROUS COMPLAINTS ABOUT THE SAME ISSUES THAT I WAS HAVING ON MY TRUCK. SINCE THEN IT HAS HAPPENED TO ME ON SEVERAL MORE OCCASIONS MAKING IT VERY UNSAFE TO DRIVE MY VEHICLE. MY LOCAL MECHANIC HAS BEEN UNABLE TO FIND ANYTHING WRONG WITH THE TRUCK. MY RESEARCH HAS INDICATED THAT THIS IS A MANUFACTURE PROBLEM CREATED BY FORD MOTOR COMPANY AND THEY WILL FIX THE PROBLEM UNDER WARRANTY. HOWEVER DUE TO THE UN-SAFENESS OF THIS PROBLEM FORD MOTOR COMPANY SHOULD DO A RECALL ON THIS MODEL AND CORRECT THE DEFECT AT NO COST TO THE CONSUMER. I WILL BE MAKING ARRANGEMENTS TO CONTACT MY LOCAL FORD DEALERSHIP AND HAVE THEM DIAGNOSE WHAT IS WRONG WITH MY VEHICLE. I MADE THIS COMPLAINT BECAUSE OF ALL THE OTHER COMPLAINTS MADE WITH THE SAME PROBLEM THAT NEEDS TO BE ADDRESSED BY FORD MOTOR COMPANY. *TR
I JUST RECENTLY PURCHASED MY FIRST 2005 FORD F-250 IN AUGUST OF 2012. THIS IS THE FIRST VEHICLE THAT I PURCHASED THAT WAS A FORD PRODUCT. ON AUGUST 13, 2012 I WAS DRIVING MY TRUCK DOING APPROXIMATELY 35 MPH WHEN I NOTICED THAT I STARTED TO LOSE POWER ON THE ACCELERATOR AND MY VEHICLE JUST SHUTT OFF ALL OF A SUDDEN. THE VEHICLE LEFT ME STRANDED AND WOULD NOT RESTART. I HAD TO WAIT ABOUT THIRTY MINUTES BEFORE THE VEHICLE WOULD START AGAIN. I ALSO SMELLED A STRONG ODOR OF EXHAUST IN THE CABIN OF MY TRUCK. I THEN WENT TO A LOCAL MUFFLER SHOP AND HAD THEM CHECK MY EXHAUST SYSTEM. I WAS TOLD THAT THE TRUCK HAD NO EXHAUST LEAKS. I THEN STARTED TO RESEARCH THE SYMPTOMS OF MY TRUCK ONLINE AND FOUND OUT THAT THERE WERE NUMEROUS COMPLAINTS ABOUT THE SAME ISSUES THAT I WAS HAVING ON MY TRUCK. SINCE THEN IT HAS HAPPENED TO ME ON SEVERAL MORE OCCASIONS MAKING IT VERY UNSAFE TO DRIVE MY VEHICLE. MY LOCAL MECHANIC HAS BEEN UNABLE TO FIND ANYTHING WRONG WITH THE TRUCK. MY RESEARCH HAS INDICATED THAT THIS IS A MANUFACTURE PROBLEM CREATED BY FORD MOTOR COMPANY AND THEY WILL FIX THE PROBLEM UNDER WARRANTY. HOWEVER DUE TO THE UN-SAFENESS OF THIS PROBLEM FORD MOTOR COMPANY SHOULD DO A RECALL ON THIS MODEL AND CORRECT THE DEFECT AT NO COST TO THE CONSUMER. I WILL BE MAKING ARRANGEMENTS TO CONTACT MY LOCAL FORD DEALERSHIP AND HAVE THEM DIAGNOSE WHAT IS WRONG WITH MY VEHICLE. I MADE THIS COMPLAINT BECAUSE OF ALL THE OTHER COMPLAINTS MADE WITH THE SAME PROBLEM THAT NEEDS TO BE ADDRESSED BY FORD MOTOR COMPANY. *TR
DROVE TRUCK APPROXIMATELY 30 MILES DOWN THE HIGHWAY. PARKED IN STORE PARKING LOT, AND WHEN I WENT TO START IT TO LEAVE, IT WOULD NOT START. HAD IT TOWED TO CLOSEST DEALER. $3000 LATER, HIGH PRESSURE OIL PUMP BEING REPLACED. *TR
DROVE TRUCK APPROXIMATELY 30 MILES DOWN THE HIGHWAY. PARKED IN STORE PARKING LOT, AND WHEN I WENT TO START IT TO LEAVE, IT WOULD NOT START. HAD IT TOWED TO CLOSEST DEALER. $3000 LATER, HIGH PRESSURE OIL PUMP BEING REPLACED. *TR