2005 FORD FIVE HUNDRED Electrical System Problems

I am having problem with the reset button in my 2005 five hundred ford, the oil light stays on after oil changes, no one does not know how to reset, the reset button does not work, several mechanic told me not to worry about it , but the car can't pass the smog, it reads not ready, they told my to take a ride for about 50 miles and drive up to sixty miles per hour. . On going problem and I am running out of money, can you help, please

The engine keep going into limp mode. The car stalls out while at lights an stop signs, power steering goes out on highway an other roads making it impossible to steer or steer out of others ways, limp mode causes car to not be able to keep up with traffic on highway and other roads. Engine jerks forward an shifts irractically an shifts an downshifts hard.

I WAS AT RED LIGHT PERSON CROSSING ROAD I WAS I. DRIVE FOOT ON BRAKE, RPMS SHOT UP ENGINE REEVES CAT LUNGED FORWARD I PRESSED HARDER IN BRAKE ALMOST HIT PERSON. AT THE TIME NO WARNING LIGHTS. THEN AT PHARMACY DRIVE THRU W CAR I. FROM AND I. BACK OF ME CAR DID SAME THING. I HAD TO PRESS BRAKE HARD TO PREVENT MOVING HITTING CAR IN FROM OF ME. I WAS IN DRIVE BUT FOOT ON BRAKE! NO WARNING LIGHTS AT TIME. HAD THROTTLE BODY REPLACED STILL HAD SIMILAR PROBLEMS PROGRESSING LITTLE DID I KNOW WHEN THROTTLE BODY IS REPLACED HAS TO BE REPROGRAMMED BY FORD! SPENT SO MUCH MONEY AND TIME TRYING TO FIGURE OUT PROBLEM. THIS IS A FLAW W FORD 500 2005 THROTTLE BODY MANY COMPLAINTS AND TEST DOES NEVER ISSUES RECALL, UNSAFE. I COULD HAVE KILLED SOMEONE.

Mileage: 170,000

I PURCHASED THE CAR USED WITH THE UNDERSTANDING THAT IT HAD SOME ISSUES WITH A MISFIRE. UPON INITIAL INSPECTION I FOUNT THE CAR WAS THROWING THE CODE P0351 I CLEARED ALL FAULTS AND PROBLEM WENT AWAY WEKS WENT BY AND PROBLEM STARTED AGAIN BUT MORE SEVER DURING NORMAL OPERATION THE CAR STARTED SHAKING AND SHIFTING ERRATIC I THEN CAME UPON SOME K FORMATION AS TO A RECALL FORD PUT IN PLACE STATING IMPROPER CALIBRATION OF PCM AND TCM CAUSE UNNECESSARY INTERACTION I THE ELECTRICAL SYSTEM AND MALFUNCTION OF THE VEHICLE

Mileage: 237,232

I WAS DRIVING MY CAR IT STARTED TO SHAKE VERY HARD WELL I HEARD A SNAP SOUND AND MY CAR STARTED TO DRAG I GOT OUT MY FRAME ABOVE MY RIGHT LOWER CONTROL HAD SNAPPED IVE READ THAT MANY OTHER PEOPLE ARE HAVING THE SAME PROBLEM I CONTACTES FORD ABOUT THE ISSUE AND THEY SAID THERE IS NOTHING THEY CAN DO WELL I'M OUT OF A VEHICLE BUT VEFORE ALL OF THIS I KEPT GOING THROUGH FUEL RELAY ISSUES AND EVENTUALLY STARTED LOSING MY INSTRUMENT CLUSTER SO NOW I'M FIGHTING WITH THEM TO DO THE REPAIRS

TAKATA RECALL MY CAR HAS A FUEL LEAK PROBLEM AND FUEL TANK IS DAMAGE TO WELD DEFECT CIDE: P04442. ALSO PREVIOUS OWN INSTALLED A AFTERMARKET REMOTE CAR STARTER. NOW MY CAR HAS TROUBLE STARTING EVER AFTER I REPLACED THE STARTER. PROBLEM MIGHT BE THE (ECU) ENGINE CONTROL UNIT NOW WORKING PROPERLY.

Mileage: 172,940

GAUGES DROP CHECK ENGINE LIGHT COMES ON THEN WRENCH LIGHT THEN ONE SHAPED LIKE A CAR N STARTS LOOSEN POWER

Mileage: 244,141

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. AFTER PLACING FUEL IN THE VEHICLE, WHITE SMOKE EMERGED FROM THE ENGINE COMPARTMENT. THE CONTACT OPENED THE HOOD AND FLAMES EMERGED FROM THE ENGINE AND THE SMOKE TURNED BLACK. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE; HOWEVER, THE FIRE ERUPTED AGAIN AND WOULD NOT STOP UNTIL THE BATTERY WAS DISCONNECTED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS NOT CONTACTED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 250,000.

Mileage: 250,000

I HAVE RESEARCHED ONLINE AND A LOT OF PEOPLE WITH MY SAME CAR ARE HAVING THE SAME PROBLEM. WHILE DRIVING MY WHOLE DASH BOARD GOES OUT . I CAN NO LONGER SEE HOW FAST I'M GOING. EVERYTHING GOES TO 0 THE GAS GOES TO E AND MY REVERSE LIGHTS STAY ON UNTIL THE DASH BOARD COMES BACK UP. IF AND WHEN IT COMES BACK ON MY CHECK ENGINE LIGHT WILL BE ON. THIS HAS BEEN HAPPENING EVERY SINCE I PURCHASED THE CAR 3YEARS AGO ON AND OFF.

Mileage: 60,000

I WILL NEVER BUY ANOTHER FORD VEHICLE EVER AGAIN!!!!!! I OWN A 2005 FORD FIVE HUNDRED THERE WAS A RECALL IN 2012 ON THE THROTTLE BODY, A FORD DEALER SUPPOSABLY CLEANED THE THROTTLE BODY, WELL NOW ITS NOT DRIVEABLE. WE HAVE SINCE TALKED TO SEVERAL FORD DEALERS INCLUDING FORD MOTOR COMPANY , THEY ALL SAID IT WAS OUR RESPONSIBILITY TO FIX THE PROBLEM. I DO NOT THINK IT SHOULD BE MY RESPONSIBILITY TO PAY FOR THIS SINCE THE PART WAS RECALLED !!! THE CAR COULD STALL AT ANYTIME WHILE DRIVING PUTTING MYSELF AND MY FAMILY AT RISK, I DON'T THINK MUCH OF THIS AUTOMOBILE COMPANY FOR NOT STANDING BEHIND THERE PRODUCT, I WILL NEVER RECOMMEND A FORD VEHICLE TO FRIENDS,FAMILY OR EVEN MY WORST ENEMY NEVER NEVER AGAIN!!!!

Mileage: 177,000

I DONT FEEL SAFE DRIVING MY CAR I PUT 2000 DOLLARS OF WORK AND STILL DO NOT FEEL SAVE.

Mileage: 110,000

INSTRUMENT CLUSTER NOT WORKING. OIL AND BRAKE LIGHT ILLUMINATE CONSTANTLY. REVERSE LIGHTS AND BRAKE LIGHTS CONSTANTLY ON ON THE EXTERIOR OF THE VEHICHLE. CRUISE DOES NOT WORK. BLINKERS DO NOT WORK. STARTS DOING THIS AS SOON AS THE CAR IS STARTED. STARTED WHILE GOING DOWN THE EXPRESSWAY NOW CONSTANT.

Mileage: 140,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING 50 MPH, THE VEHICLE LOST POWER AND JERKED. ALL THE LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE HAD TO BE TURNED OFF AND RESTARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE COMPUTER NEEDED TO BE REPLACED. THE COMPUTER WAS REPLACED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

Mileage: 95,000

THE TRANSMISSION DISENGAGES AT VARIOUS SPEEDS EVEN ON THE INTERSTATE AT 55+ MPH CAUSING IT TO LOSE POWER. YOU MUST BE ABLE TO GET IT STOPPED ON THE SIDE OF THE ROAD AND SHUT THE CAR OFF AND THEN RESTART IT TO CORRECT THE PROBLEM FOR A SHORT PERIOD OF TIME.

Mileage: 188,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE VEHICLE WAS SHIFTED OUT OF PARK AND THE RPM GAUGE FLUCTUATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE RPM SURGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 101,000. THE VIN WAS UNAVAILABLE. MA 10/25/15 *CN

Mileage: 101,000

WHILE DRIVING DASH LIGHTS, SPEEDOMETER, TACHOMETER, GAS LEVEL, AND TEMPERATURE GO OUT FOR SEVERAL MINUTES AT A TIME. REVERSE LIGHTS COME ON AND AIRBAG LIGHT COMES ON. THIS IS DANGEROUS; UNABLE TO TELL SPEED! PER INTERNET RESEARCH THIS IS HAPPENING IN SEVERAL FORD MODELS AND STEMS FROM A BAD SOLDER JOINT.

Mileage: 220,000

WAS DRIVING IN HEAVY TRAFFIC THROUGH METRO CITY IN RUSH HOUR ON INTERSTATE.ON 4 LANE HIGHWAY HAD TO CROSS 2 LANES OF TRAFFIC TO EXIT;CAR LOST POWER AND MESSAGE CENTER SAID ENGINE FAIL SAFE MODE.TRIED TO ACCELERATE TO EXIT;CAR HAD LOST POWER WITH NO ACCELERATION.WHEN I FINALLY GOT TO EXIT WAS DOWN TO 20 MILES PER HOUR. *TR

Mileage: 159,985

I WAS DRIVING IN TOWN GOING ABOUT 40 MPH WHEN THE CAR LOST ALL POWER, THEN ENGINE FAILSAFE MODE DISPLAYED ON THE INFORMATION CENTER AND A LITTLE WRENCH WAS ALSO DISPLAYED. WITH NO POWER STEERING, I HAD TO PULL OVER QUICKLY IN LUNCHTIME TRAFFIC. AFTER STOPPING THE CAR, I WAITED A FEW SECONDS AND RESTARTED IT. NO PROBLEMS WITH IT UNTIL THE NEXT DAY WHEN THE CHECK ENGINE LIGHT CAME ON. I HAVE ALSO NOTICED A MECHANICAL SMELL COMING FROM THE AC. IT APPEARED, AT FIRST, THAT THIS PROBLEM HAD COME OUT OF NOWHERE WHEN I SUDDENLY REMEMBERED TWO OCCASIONS WHEN THE RPMS SUDDENLY STUCK ON 3000 AND WOULD NOT STOP UNTIL I PUT THE CAR IN NEUTRAL. ALSO, WHEN USING CRUISE CONTROL, THE WHOLE CAR SHAKES AND STUTTERS SLIGHTLY WHEN GOING UP OR DOWN VERY SLIGHT INCLINES. *TR

Mileage: 177,320

ONLY HAD THE CAR FOR FIVE MONTHS DRIVING DOWN THE STREET THE CHECK ENGINE LIGHT CAME OUT CAR STOPPED IN THE MIDDLE OF THE STREET WITH MY CHILDREN IN IT AND WOULDN'T START UP..WORST CAR I'VE EVER BOUGHT SECOND MAJOR INCIDENT THAT HAS HAPPENED SINCE I GOT THE CAR.IT SHOULD BE A RECALL MAJOR SAFETY VIOLATION. *TR

Mileage: 131,000

PART OF AN ONGOING SERIES OF ISSUES WITH THIS VEHICLE (SEE EARLIER REPORTS), INITIAL SYMPTOM WAS THE DASH LIGHTS & NEEDLES SHUTTING OFF INTERMITTENTLY (BUT NOW FOR EXTENDED PERIODS). VEHICLE THEN BEGAN SHOWING RANDOM WARNING LIGHTS INCLUDING "CHECK ENGINE", WHICH WAS DIAGNOSED FIRST TIME AS LOW FUEL LEVEL SENSORS A & B. SINCE THAT TIME I'D DISCONNECTED THE BATTERY ON A SUGGESTION OF A MECHANIC FRIEND AND ALL THE ISSUES DISAPPEARED FOR A FEW WEEKS. YESTERDAY THE CHECK ENGINE LIGHT CAME BACK, AND THE CAR WAS RUNNING POORLY (CREEPING WHEN FIRST OFF BRAKES, NOT UP SHIFTING), WHEN THE DASH WAS OPERABLE IT SHOWED ALTERNATING CHECK ENGINE/CHECK TRANSMISSION WARNINGS, AND VEHICLE WAS SURGING/LAGGING NOTICEABLY AT HIGHWAY SPEEDS. I AGAIN DID THE BATTERY DISCONNECT LAST NIGHT, AND THE CAR IS OPERATING NORMAL TODAY, BUT I'M SURE IT WILL RECUR SHORTLY. I AM HESITANT TO TAKE IT TO A DEALER AS THIS SOUNDS LIKE A SIGNIFICANT ELECTRONICS ISSUE, AND I HAVE ALREADY READ UP ON THE FORD TSB 06-17-9 THAT IS DOCUMENTED ONLINE, NOT ALL OF WHICH ALIGNS WITH MY ISSUES. HAD THE BATTERY RESET HAD NO IMPACT ON THE PROBLEMS I WOULD SAY IT'S A MECHANICAL MATTER, BUT IT SEEMS CLEAR ITS A COMPUTER OR ELECTRICAL ISSUE. *TR

Mileage: 36,000

I PURCHASED THE VEHICLE USED ON 2/21/14 W/31,000+/- MILES, INITIAL ISSUE WAS WITH INSTRUMENT CLUSTER INTERMITTENTLY BLIPPING ON & OFF (SOMETIMES FOR EXTENDED PERIODS). THAT ISSUE WAS FOLLOWED BY A CHECK ENGINE LIGHT, WHICH WHEN ANALYZED SHOWED LOW FUEL SENSORS A&B (OCCURRED IN LATE APRIL 2014). UP TO THIS POINT THE VEHICLE WAS DRIVABLE WITH NO IMPACT ON ACTUAL DRIVABILITY. LAST FRIDAY 5/9/14, I WAS AT A LIGHT AND WHEN IT TURNED GREEN I PROCEEDED TO DRIVE OFF, BUT VEHICLE WAS BARLEY MOVING OR RESPONDING TO THROTTLE INPUT, THIS CONTINUED FOR A SHORT DISTANCE & EVENTUALLY BUILT UP TO NORMAL SPEED. IT RECURRED AGAIN AT THE NEXT LIGHT, WITH SAME SYMPTOMS. I CONTACTED A MECHANIC I KNOW AND THE NEXT DAY I DISCONNECTED THE BATTERY CABLE IN AN ATTEMPT TO CLEAR THE SYSTEM, AND AS OF A WEEK LATER ONLY THE DASH LIGHTS ISSUE HAS RECURRED. HOWEVER I FEEL THE LOSS OF POWER IS A SIGNIFICANT CONCERN IF IT WERE TO OCCUR ON A BUSY ROAD OR AT HIGHWAY SPEEDS. *TR

Mileage: 35,500

INSTRUMENT CLUSTER INTERMITTENTLY WENT DARK AND/OR GAUGES WENT TO ZERO/OFF POSITIONS, WE PULLED OVER TO SEE IF EXTERIOR LIGHTS WORKED AND ALL DID, AS WELL AS BLINKERS AND FLASHERS, BUT WE NOTED THAT REVERSE LIGHTS WERE NOW ON. IT HAS RECURRED A FEW TIMES, ITS MOST NOTICEABLE AFTER DARK AS DASH LIGHTS GO BLACK. ONLY LIGHT ON DASH WAS THE AIRBAG LIGHT. I WENT ONLINE & FOUND INFO ON A TECHNICAL SERVICE BULLETIN "TSB 06-17-9 09/04/06 - INTERMITTENT INSTRUMENT CLUSTER", IT DOES NOT APPEAR TO BE A RECALL ITEM SO ASSUMING ANY REPAIRS ARE ENTIRELY OWNER COST ? *TR

Mileage: 33,850

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE INSTRUMENT CLUSTER DIMMED INTERMITTENTLY WHICH MADE IT DIFFICULT TO SEE THE DISPLAY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

Mileage: 75,000

CAR DRIVES ON ITS OWN! IF I DO NOT HAVE FOOT ON GAS ON BREAK IT WILL CONTINUE TO MOVE. SAID FAILSAFE MODE THEN CHECK ENGINE LIGHT ILLUMINATED, DASH BOARD SAID CHECK ENGINE CHECK TRANSMISSION THEN THE LIGHT WENT OUT THE FOLLOWING DAY. NOW DRIVING BACK TO NORMAL. I TOOK TO AUTO ZONE THE DAY IT WENT HAYWIRE & THEY ADVISED ME ITS A POSSIBLE RECALL SEVERAL PPL SAID THE SAME ISSUE WITH THEIR FORD.

Mileage: 87,530

DRIVING DOWN THE INTERSTATE AND THE INSTRUMENT CLUSTER STOPPED WORKING. THE SPEEDOMETER, TACOMETER, FUEL GAUGE, TURN SIGNAL INDICATOR AS WELL AS THE REST OF THE DIGITAL INSTURMENTS QUITE WORKING. I PULLED OVER AND CHECKED AND MY OUTSIDE LIGHTS AND RADIO WORKED. *TR

Mileage: 150,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE TRAVELING AT UNKNOWN SPEEDS, THE INSTRUMENT PANEL FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 79,000.

Mileage: 79,000

ONE DAY IN JUNE I WAS PULLING UP TO A STORE PARKING SPACE ROLLING ROUGHLY 5MPH. I HAD MY FOOT ON THE BRAKE, I WAS ABOUT TO STOP. WITHOUT TOUCHING THE GAS MY 2005 FORD FIVE HUNDRED LUNGED AT THE BUILDING AS IF THE THROTTLE WAS STUCK WIDE OPEN! I HAD TO PUSH THE BREAK AS HARD AS I COULD TO KEEP IT FROM CRASHING INTO THE STORE! FORD SHOULD HAVE A RECALL ON THIS ISSUE! IT IS EXTREMELY DANGEROUS! THIS HAS HAPPENED TO MANY FORD FIVE HUNDRED OWNERS! LAST MONTH IN JANUARY MY FIVE HUNDRED HAD OTHER ISSUES. I WAS DRIVING 35MPH AND ALL OF A SUDDEN MY CAR HAD NO POWER, I GAVE IT GAS AND IT WOULD GROWL BUT NO POWER. I HAD TO PULL OVER AND SHUT THE CAR OFF. ONE RESTARTED IT RETURNED TO NORMAL BUT THE WRENCH ICON LIGHT WAS ON THE DASH. I HAVE ALSO HAD AN IDLING PROBLEM. WHILE AT IDLE MY CAR WOULD SPUTTER. THE RPM'S WERE LOW AND IT WOULD IDLE ROUGH AND SURGE FROM LOW TO HIGH, I TRIED HITTING THE GAS PEDAL AND THE CAR STALLED! AGAIN OTHER FORD FIVE HUNDRED OWNERS ALSO EXPERIENCED THESE ISSUES! FORD ITS TIME TO STEP UP AND DO A RECALL!!!! *TR

Mileage: 160,000

THE HEADLIGHT SOCKET ON BOTH HEADLIGHTS ARE OVER HEATING AND MELTING CAUSING THE BULB NOT TO OPERATE. I'M JUST NERVOUS THAT THIS WILL CAUSE A FIRE AS ALL THE PARTS ARE PLASTIC. I ALSO NOTED ON LINE THAT IT IS A VERY REAL PROBLEM AND I'M NOT THE ONLY ONE EXPERIENCING THIS. *TR

WAS DRIVING MY 2005 FIVE HUNDRED TODAY. I PULLED OFF THE HIGHWAY AND STOPPED AT A RED LIGHT. WHEN THE LIGHT TURNED GREEN I HAD HARDLY ANY POWER. NO POWER STEERING, ALL GAUGES AT HOME AND A MESSAGE SAY "ENGINE FAILSAFE MODE". I TURNED THE CAR OFF AND RESTARTED WITH NO PROBLEMS. I'VE READ ON DIFFERENT SITES WHERE PEOPLE HAVE HAD THIS SAME ISSUE OF THE THROTTLE STICKING OPEN AND THE CAR LUNGING FORWARD OR BACK NEARLY CAUSING A WRECK. *TR

Mileage: 135,000

OUT SIDE AIR TEMP WAS APPROX 96 DEGREES SO AC WAS ON . WHILE SHIFTING INTO REVERSE THE VEHICLE LUNGED SO HARD IT WAS UNCONTROLLABLE,AND UNSTOPPABLE, IF SOME ONE HAD STEPPED OUT BEHIND ME THEY WOULD HAVE DIED AS I COULD ONLY STOP REWARD MOVEMENT BY SHIFTING INTO DRIVE. THIS OCCURRED THREE TIMES TRYING TO GET OUT OF A PARKING SPACE AT A CROWDED MALL.THE VEHICLE THEN STALLED. THE LUNGING WAS SO FAST THE BRAKES COULD HARDLY HOLD THE CAR FROM MOVING IN REVERSE. IN CHECKING THERE IS A SERVICE BULLETIN TSB-05-25-13 FROM FORD MOTOR COMPANY ON THIS VERY ISSUE BUT NO RECALL, ALSO MANY INCIDENTS/ACCIDENTS RECORDED IN THIS REGARD. IF I WAS NOT PREPARED ENOUGH DURING THIS INCIDENT IN A CROWDED PARKING LOT SOME ONE WOULD HAVE DIED, THIS MUST BE ADDRESSED B-4 SOMEONE IS RUN OVER. CURRENTLY FORD HAS NO COMMENT. PLEASE CONTACT ME FOR FURTHER DETAILS. *TR

Mileage: 157,139

THE ELECTRONIC THROTTLE BODY IS BAD IN MAJORITY OF VEHICLES IN MY CLASS YEAR. THIS COSTLY REPAIR CAUSES THE VEHICLE TO LUNGE FORWARD WHILE IN DRIVE AND LUNGE BACKWARDS WHILE IN REVERSE. IT IS WORST WHEN THE AC IS ON,,IT CAUSES THE VEHICLE TO IDLE HIGH AND LOW TO THE POINT OF ALMOST SHUTTING OFF THE VEHICLE IN TRAFFIC. *TR

DURING WARM WEATHER WITH THE A/C OPERATING, THE RPMS SURGE AND THE VEHICLE LUNGES IN THE DIRECTION OF THE TRANSMISSION LEVER SELECTION (FORWARD OR REVERSE) WHEN MOVING THE SHIFT LEVER FROM PARK TO DRIVE OR FROM PARK TO REVERSE WITH DRIVER'S FOOT ON THE BRAKE. ENGINE RPMS SURGE UP TO APPROX. 1,500 FROM IDLE AT A DEAD STOP WITHOUT INPUT FROM ACCELERATOR PEDAL. DIFFERENT INDICATOR LIGHTS COME ON AND OFTEN THE ENGINE DIES AFTER THE SURGE. IF DRIVER DOES NOT KEEP APPROPRIATE PRESSURE ON BREAK PEDAL WHILE SHIFTING FROM PARK, THE VEHICLE WILL ACCELERATE WITHOUT INPUT FROM GAS PEDAL. THIS SURGE ALSO HAPPENS WHEN DECELERATING TO A STOP. VEHICLE SLOWS DOWN AND RPMS DECREASE TO APPROX 600 (IDLE), AND WITH PRESSURE APPLIED TO BRAKE PEDAL, ENGINE RPMS WILL INCREASE, WITHOUT INPUT FROM ACCELERATOR PEDAL, FORCING THE DRIVER TO INCREASE PRESSURE ON BRAKE PEDAL OR RISK UNCONTROLLED FORWARD MOVEMENT. INITIAL REPORTS INDICATE A FAULTY THROTTLE BODY AS REFERENCED IN NHTSA INVESTIGATION # PE110818. *TR

Mileage: 135,453

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE OIL PRESSURE AND BRAKE LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THAT THE TURN SIGNALS FAILED AND THE REVERSE LIGHTS ILLUMINATED ON THEIR OWN. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC TEST PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 175,000 AND THE CURRENT MILEAGE WAS 190,000.

Mileage: 175,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE ENTERING THE VEHICLE, HE NOTICED THAT SMOKE FILLED THE INTERIOR. THE CONTACT THEN NOTICED THAT THE TRUNK LIGHT WAS ON FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE FIRE DEPARTMENT WAS NOT CALLED AND NO ONE WAS INJURED. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 84,000.

Mileage: 84,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT ALL OF THE GAUGES ON THE INSTRUMENT PANEL FAILED TO FUNCTION AND THE REVERSE LIGHT WAS ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOTIFIED WHO STATED THERE WERE NO RECALLS FOR THE FAILURE AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER FOR INSPECTION. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 109,102.

Mileage: 80,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE GAUGES ON THE INSTRUMENT PANEL WOULD BECOME INOPERATIVE AND ALL OF THE WARNING LIGHTS WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THAT THE REAR REVERSE SENSOR WOULD ONLY OPERATE WHILE THE VEHICLE WAS IN DRIVE AND THE REVERSE LIGHTS WOULD CONTINUOUSLY ILLUMINATE WHILE IN DRIVE. THE DEALER PERFORMED A HARD RESET ON THE VEHICLE, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 80,000.

Mileage: 30,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE LIGHTS ON THE INSTRUMENT PANEL WOULD SHUT ON AND OFF INTERMITTENTLY WITHOUT WARNING. IN ADDITION, THE CHECK ENGINE AND AIR BAG WARNING LIGHTS WERE ILLUMINATED SPORADICALLY. SHE BELIEVED THAT THE ENTIRE ELECTRICAL SYSTEM WAS FAULTY SINCE A RECENT FAILURE OF THE ODOMETER READING. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE CURRENT MILEAGE WAS 42,000 AND THE FAILURE MILEAGE WAS 41,500.

Mileage: 41,500

MY NEEDLES AND CONTROLS FAIL ON MY 2005 FORD FIVE HUNDRED AWD. I HAVE HAD THE CLUSTER REPLACED TWICE (OUT OF POCKET) WHEN IT FAILS, MY REVERSE LIGHTS COME ON, TURN SIGNALS FAIL AND SOMETIMES MY RADIO FAILS (NOT REALLY A SAFETY ISSUE BUT IS ANNOYING) MY AIRBAGS ARE DEACTIVE WHEN THE EVENT OCCURS. I KNOW FORD KNOWS ABOUT THE ISSUE AND SHOULD DO A RECALL AS I HAVE NOTICED (MORE THAN I SHOULD FOR THERE NOT TO BE A RECALL) ALOT OF OTHER FIVE HUNDRED/MONTEIGO DRIVERS WITH THE EXACT SAME PROBLEM. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE LIGHTS ON THE INSTRUMENT FAILED AND ALL OF THE GAUGES WERE INOPERABLE. IN ADDITION, THE REAR BACK UP SENSORS WERE BUZZING HAPHAZARDLY. THE CONTACT CHECKED ALL OF THE FUSES AND WAS UNABLE TO LOCATE A CAUSE FOR THE FAILURE. THE VEHICLE WAS NOT INSPECTED BY THE DEALER OR A MECHANIC. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 1/27/12 *CN UPDATED 02/01/12

Mileage: 50,000

SIMILAR ISSUE AS IN PE07058. INSTRUMENT CLUSTER FAILS FOR EXTENDED PERIODS. IN THIS TIME I HAVE NO INSTRUMENTATION AVAILABLE, SPEED, RPM, FUEL, ETC. MULTIPLE WARNING LIGHTS ILLUMINATE, INCLUDING AIRBAG. ALL INTERIOR LIGHTING DIMS SIGNIFICANTLY. REVERSE LIGHTS ILLUMINATE EVEN WHILE IN PARK, OR DRIVING FORWARD. *TR

THE THROTTLE BODY IS DEFECTIVE AND NEEDS TO BE REPLACED. THE SYMPTOMS ARE VERY DANGEROUS: THE CAR GOES INTO FAIL SAFE MODE AND CANNOT ACCELERATE. ON ONE OCCASION THIS HAPPENED IN THE MIDDLE OF THE ROAD; FORTUNATELY IT WAS A QUIET STREET AND I WAS ABLE TO COAST TO THE SIDE OF THE STREET. IF THIS HAD HAPPENED ON A BUSY STREET IT COULD HAVE CAUSED INJURY OR DEATH. SEVERAL MECHANICS DID DIFFERENT KINDS OF REPAIRS, BUT THE PROBLEM KEPT RECURRING. WE ARE NOW GETTING THE THROTTLE BODY REPLACED AND HOPE THIS IS THE FINAL REPAIR THAT REMOVES THE PROBLEM. NUMEROUS OTHER FORD FIVE HUNDRED OWNERS HAVE EXPERIENCED THIS (PER INTERNET RESEARCH). FORD NEEDS TO RECALL THE FIVE HUNDRED AND REPLACE THE THROTTLE BODY TO PREVENT INJURY OR DEATH. *TR

Mileage: 75,685

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHT FAILED. THE CONTACT WAS UNABLE TO SEE THE MILES DRIVEN OR ANY OF THE OTHER COMPONENTS ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE INSTRUMENT PANEL DIGITAL SYSTEM. THE VEHICLE WAS REPAIRED. THE DEALER REPLACED THE ELECTRICAL INSTRUMENT PANEL DIGITAL SYSTEM. THE FAILURE AND THE CURRENT MILEAGE WAS 59,090.

Mileage: 59,090

NOT SURE THE EXACT TIME BUT WITHIN THE PAST YEAR OR SO MY 2005 FORD FIVE HUNDRED ( PURCHASED NEW) IS GOING INTO FAILSAFE MODE LIMITED THROTTLE POWER, VERY SPORADIC AT FIRST BUT NOW HAPPENING QUITE OFTEN. IF YOU PULL OVER AND SHUT THE CAR OFF AND RESTART IT CLEARS AND DRIVES NORMAL. MY DAUGHTER WAS DRIVING IT YESTERDAY AND IT HAPPENED 7 TIMES FROM MALL TO THE HOUSE (ABOUT 20 MILES). ONCE WHILE SHE WAS IN HEAVY TRAFFIC DRIVING ABOUT 55 MPH. CAR JERKED THEN STARTED SLOWING DOWN. THIS IS A SAFETY ISSUE THAT NEEDS TO BE LOOKED AT. VERY DANGEROUS. MY MECHANIC IS TROUBLE SHOOTING PROBLEM, LOOKING LIKE THROTTLE BODY OR GAS PEDAL. I BELIEVE FORD CAME OUT WITH A NEW THROTTLE BODY IN 2010 TO CORRECT THE PROBLEM (TSB 05-25-13)BUT WILL ONLY REPLACE IT AT THEIR COST IF STILL UNDER WARRANTY, OTHERWISE THE COST IS ON US THE CONSUMER. (ABOUT A THOUSAND DOLLARS). *TR

Mileage: 90,000

DASHBOARD HAS BEEN ERRATIC, COMPLETELY BLANK.

Mileage: 27,000

WE HAVE A 2005 FORD FIVE HUNDRED. TWO DAYS AGO, THE CAR FAILED TO RESPOND WHEN THE ACCELERATOR WAS PRESSED, EVEN AS IT WAS PRESSED TO THE FLOOR. THE WRENCH LIGHT CAME ON AND THE CAR STARTED LUNGING AND HESITATING IN ADDITION TO NOT ACCELERATING PROPERLY. THIS OCCURRED WHILE DRIVING THROUGH A VERY BUSY INTERSECTION; THANKFULLY, I WAS ABLE TO MOVE THE CAR WITH MY TWO SMALL CHILDREN OUT OF TRAFFIC. A DIAGNOSTIC COMPUTER PROVIDED TWO CODES - P2106 AND P061B. THIS IS NOT THE FIRST TIME THE CAR HAS LUNGED; IT HAS BEEN DOING THIS FOR APPROXIMATELY 1.5 YEARS. IT HAS REPEATED THIS SEVERAL TIMES IN BOTH DRIVE AND REVERSE. IN MOST INSTANCES, THE AIR CONDITIONER WAS RUNNING AT THE SAME TIME; HOWEVER, THE CAR HAS LUNGED WHEN THE A/C WAS NOT ON. THE LUNGING OCCURS WHEN THE CAR IS BEING DRIVEN OR SITTING IDLE (I.E., STOP LIGHTS, PREPARING TO MERGE INTO TRAFFIC). I HAVE BEEN ABLE TO AVOID ACCIDENTS BY KEEPING MY FOOT FIRMLY ON THE BRAKE AND BY CREATING A LARGE STOPPING DISTANCE CUSHION. WE CONTACTED THE DEALER AND WERE TOLD THE ENTIRE THROTTLE BODY WOULD NEED REPLACED, AT A COST OF OVER $530.00. WE ARE NOW REVIEWING OUR OPTIONS. *TR

Mileage: 136,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT NOTICED THAT THE INSTRUMENT CLUSTER WOULD BECOME DARK INTERMITTENTLY WHICH MADE IT IMPOSSIBLE TO SEE THE INSTRUMENT DISPLAY. WHEN THE VEHICLE ACCELERATED FORWARD THE BACK UP LIGHTS WOULD ILLUMINATE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INFORMED THE CONTACT THAT THE INSTRUMENT CLUSTER WAS FAULTY AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS AWARE OF THE FAILURE. NONE OF THE REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

Mileage: 75,000

THIS IS THE SECOND TIME THE DASH CLUSTER HAS FAILED IN MY FORD FIVE HUNDRED. IT WAS REPLACED THE FIRST TIME. WHILE UNDER THE PART WARRANTY OF 12MO/12K MILES, THE CLUSTER FAILED AGAIN. I TOOK IT TO THE DEALER AND THEY PULLED THE IDENTICAL CODES AS THE FIRST TIME THEY REPLACED THE CLUSTER, BUT WOULD NOT REPLACE IT THIS TIME BECAUSE NONE OF THE INDICATOR LAMPS WHERE ON AT THE TIME THEY LOOKED AT IT. NOW THE WRENCH, TRACTION CONTROL, CHECK ENGINE ARE LIT, AND THE DISPLAY READS CHECK ENGINE, CHECK TRANSMISSION, AND TRANSMISSION DATA ERROR. THESE ARE THE SAME AS THE LAST TIME WHEN IT WAS REPLACED. THE CAR WILL NOT ACCELERATE PROPERLY, AND THIS TIME AFTER PARKING THE CAR IT WOULD NOT RESTART. I CAME BACK IN ABOUT 20MIN. AND THE CAR STARTED. I TOOK IT TO THE DEALER, NOW OUT OF THE PART WARRANTY AND NOW THEY IMMEDIATELY WANT TO REPLACE THE CLUSTER. SEEMS FORD JUST WANTED ME TO PAY FOR THE REPAIR, AGAIN. *TR

Mileage: 108,000

DURING NORMAL OPERATION THE INSTRUMENT CLUSTER GAUGES (SPEEDOMETER, TACHOMETER, ETC..) SWING FROM 0 TO MAX AND THEN DOWN TO 0. THE GAUGES STAY LIKE THAT FOR AWHILE THEN RETURN TO OPERATION. DURING THE GAUGE OUTAGE THE REVERSE LIGHTS ON THE CAR COME ON. THIS COULD LEAD TO AN ACCIDENT IF THE DRIVER BEHIND YOU IS NOT PAYING ATTENTION AS WELL AS POSSIBLE EQUIPMENT VIOLATION TICKETS FROM THE LOCAL POLICE. THERE IS A TECHNICAL SERVICE BULLETIN ABOUT THE PROBLEM BUT FORD DOESN'T SEEM TO THINK THIS IS A SAFETY ISSUE. THE CAR IN QUESTION IS A 2005 FORD 500 WITH LESS THAN 50K MILES ON IT. THE CAR IS PRISTINE IN ALL OTHER AREAS, WE BABY THE CAR. *TR

Mileage: 44,000

DASH CLUSTER DISPLAYS CHECK ENGINE, CHECK TRANSMISSION, AND TRACTION CONTROL LIGHTS. THE TROUBLE INDICATORS ILLUMINATE, AND THE VEHICLE WILL NOT ACCELERATE NORMALLY. AFTER TURNING OFF AND RESTARTING VEHICLE MAY OR MAY NOT DRIVE NORMAL WITH TROUBLE INDICATORS STILL LIT. AFTER SHUTTING OFF AND RESTARTING SOMETIMES THE INDICATORS ARE OFF AND THE VEHICLE DRIVES NORMALLY FOR SOME TIME AND THEN THE PROBLEM RETURNS. THIS HAPPENS WHILE DRIVING AND DOES NOT ALLOW THE DRIVER TO ACCELERATE NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE DASH CLUSTER WAS REPLACED AND I WAS INFORMED THEY KNEW OF THE PROBLEM WITH THE CLUSTER. THE PROBLEM HAS REOCCURRED A FEW MONTHS LATER. *TR

Mileage: 105,406

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY 70 MPH, ALL OF THE GAUGES ON THE INSTRUMENT CLUSTER STOPPED FUNCTIONING AND DISPLAYED READINGS OF ZERO. THE CONTACT CONTINUED TO DRIVE AND THE INSTRUMENT CLUSTER BEGAN WORKING A FEW MOMENTS LATER. THE FAILURE OCCURRED INTERMITTENTLY WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 70,000.

Mileage: 70,000

THE GAUGES PERIODICALLY GO FLAT AND THE REVERSE LIGHTS COME ON. FORD KNOWS ABOUT THIS, THEY'VE ISSUED A TECHNICAL SERVICE BULLETIN (TSB 06-17-9). THE PROBLEM IS A FAULTY SOLDER JOINT AND THE INSTRUMENT CLUSTER NEEDS TO BE REPLACED. THIS IS NOT DUE TO NORMAL WEAR FROM DRIVING BUT FROM POOR DESIGN AND SHOULD BE RECALLED. FORD SHOULD CORRECT THEIR MISTAKES.

Mileage: 90,000

I PURCHASED A USED 2005 FORD 500 LTD AWD IN MAY 2008. I WAS TOLD IT WAS A LEASE TURN IN. THE MILEAGE WAS VERY LOW, UNDER 30,000 MILES. THE FACTORY WARRANTY EXPIRED IN JULY 2008. IN OCTOBER 2008, MY DASH BEGAN MALFUNCTIONING. THE GAUGES WOULD GO COMPLETELY DEAD. I COULD NOT TELL HOW FAST I WAS GOING, HOW MUCH GAS I HAD LEFT OR THE TEMPERATURE OF THE ENGINE. NOTHING ON MY DASH WOULD WORK. IT VARIED FROM LASTING SECONDS TO APPX A HALF AN HOUR. I DROVE HOME ONE NIGHT (IT TOOK ME APPX 25 MINUTES) NOT KNOWING HOW FAST I WAS GOING OR HOW MUCH GAS I HAD LEFT. ALSO, THE REVERSE LIGHTS WERE ON WHEN MY CAR WAS IN BOTH DRIVE AND PARK. I STOPPED AT A RED LIGHT (MY CAR WAS IN DRIVE) AND THE REVERSE SENSOR ALARM WENT OFF WHEN A CAR PULLED UP BEHIND ME. WE TOOK IT TO THE DEALERSHIP WE BOUGHT IT FROM & WERE TOLD IT WAS A CLUSTER IN THE DASH THAT WAS A "KNOWN PROBLEM WITH THIS VEHICLE" BUT BECAUSE IT WAS NOT A "SAFETY ISSUE" FORD DID NOT HAVE TO RECALL THIS. I FEEL THAT NOT BEING ABLE TO KNOW WHAT SPEED YOU ARE DRIVING DOWN THE HIGHWAY TO BE A HUGE SAFETY ISSUE. ALSO HAVING YOUR REVERSE LIGHTS ON WHILE THE CAR IS IN PARK OR DRIVE SEEMS A BIT DANGEROUS AS WELL. WE HAD IT REPAIRED AND IT COST US OVER 400.00. ABOUT 2 WEEKS AGO, WE HAD TO HAVE ANOTHER "CLUSTER" REPAIRED THAT WAS MAKING MY TRANSMISSION SHAKE & THE CHECK ENGINE LIGHT AS WELL ANOTHER WARNING LIGHT APPEAR. IT WAS A SENSOR THAT WENT BAD AND WAS MAKING MY CAR THINK IT WAS OUT OF GAS. THIS COST US ALMOST 350.00 TO REPAIR. NOT SURE WHAT'S GOING ON WITH THE SENSORS/CLUSTERS ON THESE CARS BUT IT SEEMS TO BE A SAFETY ISSUE TO ME. *TR

MY 05 FORD 500 HAS 58,000 MILES ON IT AND NOW THE DASH LIGHTS FLASH/GO OFF AND THE GAUGES READ 0. THE REVERSE LIGHTS COME ON TOO. IT WAS VERY SCARY WHEN IT HAPPENED. IT APPEARS TO BE AT RANDOM: NO PARTICULAR TIME OF DAY, NO CERTAIN WEATHER, AND AT NO PARTICULAR SPEED. I HAVE FAMILY MEMBERS WHO ALSO HAVE FORD 500S AND SAY THIS HAS HAPPENED TO THEM AS WELL. THIS ISSUE NEEDS TO BE ADDRESSED! *TR

Mileage: 58,000

DASH GAUGES, LIGHTS, INOPERABLE. STUCK IN VARIOUS POSITIONS. TURN SIGNALS ARE INOPERABLE AND REVERSE LIGHTS ARE ON IN THE DRIVE POSITION. REVERSE WARNING INDICATORS BEEP WHEN IN TRAFFIC AT STOP LIGHTS OR WHEN OTHER VEHICLES GET CLOSE TO REAR OF VEHICLE. AIR BAG INOPERABLE WARNING LIGHT IS ON ALL THE TIME. EXISTING RESEARCH BY NHTSA INDICATES EXTERIOR LIGHTING WORKING ON PREVIOUS COMPLAINTS. INTERNET RESEARCH INDICATES TURN SIGNALS AND REVERSE LIGHTS DO NOT OPERATE WHEN CLUSTER FAILS. POSSIBLE AIR BAG FAILURE COUPLED WITH INOPERABLE TURN SIGNALS AND INCREASED RISK OF ACCIDENT AS WELL AS REVERSE LIGHTS ON IN DRIVE ARE MAJOR SAFETY CONCERNS. *TR

Mileage: 67,000

APPARENTLY, I AM NOT THE FIRST PERSON TO BRING THIS ISSUE TO THE NHTSA'S ATTENTION. I LIKE SO MANY OTHER, HAVE ALSO HAD A PROBLEM WITH MY INSTRUMENT PANEL ON MY FORD FIVE HUNDRED. I WOULD LIKE FOR A RECALL TO BE ISSUED AS IT HAS NEARLY CAUSED ME AN ACCIDENT TODAY, AND CAN LEAD TO OTHER HAZARDOUS DRIVING CONDITIONS FOR OTHERS. THE INSTRUMENT PANEL ON MY CAR HAS FAILED COMPLETELY, AND MY SPEEDOMETER, ODOMETER, AND ALL OTHER GAUGES SHUT OFF. WHENEVER I DRIVE MY CAR, THE REVERSE (OR WHITE) LIGHT TURNS ON DESPITE THE FACT THAT I MIGHT BE DRIVING FORWARD AT 55MPH ON A HIGHWAY. I THINK CORRECTIVE ACTION SHOULD BE TAKEN TOWARDS A RESOLUTION. THERE ARE COUNTLESS OTHERS WHO HAVE FILED COMPLAINTS AND CONCERNS REGARDING THIS VERY ISSUE.

Mileage: 42,000

WHILE DRIVING THE INSTRUMENT PANEL BLACKED OUT AND WHEN IT CAME BACK ON THE INSTRUMENTS ALL REGISTERED 0. AFTER THE INITIAL INCIDENT IT HAS CONTINUED TO ESCALATE. ON OR ABOUT DECEMBER 26, 2010 THE PANEL BLACKED OUT AND THE CAR BOGGED DOWN AND I HAD TO PULL OFF OF THE ROAD, TURN THE CAR OFF AND RESTART TO GET IT TO RUN NORMALLY. THERE IS A REAL SAFETY ISSUE WITH THE CAR AND I FEEL THAT THERE SHOULD BE A RECALL ON THIS VEHICLE.

Mileage: 35,600

TL*-THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE INSTRUMENT PANEL STOPPED FUNCTIONING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO HAD THE PANEL RESTORED. THE DEALER COULD NOT GUARANTEE THAT THE FAILURE WOULD NOT OCCUR AGAIN AS THE ENTIRE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 120,000.

Mileage: 120,000

AS I WAS SLOWING TO TURN OFF OF A STATE HIGHWAY, MY CAR SHUT OFF AND DISPLAYED A MESSAGE THAT SAID "FAILSAFE ENGINE MODE." I WAS SOMEWHAT ABLE TO STEER, SO I COMPLETED MY TURN ONTO A SIDE STREET, WHERE THE CAR DRIFTED TO A STOP. I WAS ABLE TO RESTART THE CAR AND DRIVE HOME. THE NEXT MORNING, THE CAR WOULD START BUT IMMEDIATELY SHUT OFF, DISPLAYING THE SAME ERROR MESSAGE. I HAD IT TOWED TO A GARAGE, WHICH INDICATED THAT THE DIAGNOSTIC TEST REVEALED A FAILED ELECTRONIC THROTTLE BODY. THEY ORDERED A REPLACEMENT PART, WHICH WAS THEN INSTALLED. INCIDENTALLY, THE PART HAD SINCE BEEN REDESIGNED BY FORD. ONCE THAT PART WAS REINSTALLED, THE COMPUTER WAS REFLASHED TO "LEARN" THAT A NEW THROTTLE BODY ASSEMBLY WAS INSTALLED. THE COMPUTER WOULD NOT LEARN THE NEW PART, THOUGH, SO A NEW COMPUTER HAD TO BE ORDERED AND INSTALLED. OVER THE LAST FIVE YEARS, THIS SAME PROBLEM (SHUTTING OFF WHILE DRIVING) HAD OCCURRED, BUT IN EACH CASE I WAS ABLE TO RESTART THE CAR WITHOUT ANY FURTHER PROBLEM. THIS WAS DANGEROUS IN THAT MY CAR SIMPLY SHUT OFF WHILE I WAS DRIVING,MAKING A LEFT TURN ACROSS ONCOMING TRAFFIC. FORTUNATELY NOBODY WAS COMING THE OTHER DIRECTION, SO I WAS ABLE TO SAFELY DRIFT THROUGH THE ONCOMING LANE TO ANOTHER SIDE STREET. ALSO, IT IS IMPORTANT TO NOTE THAT WHILE MY CAR WAS AT THE DEALERSHIP HAVING THE THROTTLE BODY REPLACED, I WAS TOLD THAT THERE WERE APPROXIMATELY FIVE OTHER FORD FIVE HUNDRED VEHICLES IN THE SHOP AT THE SAME TIME FOR THE SAME PROBLEM WITH THEIR ELECTRONIC THROTTLES AS WELL.

Mileage: 103,000

I PURCHASED A 2005 FORD 500 4-DOOR SEDAN 2-1/2 YEARS AGO FROM A FORD DEALERSHIP. IT WAS DESCRIBED AS A "PROGRAM" CAR. I SOON NOTICED THAT THE DASHBOARD DISPLAY LIGHTS WOULD NOT LIGHT UP DURING DAYLIGHT HOURS, EVEN THOUGH THE RHEOSTAT WAS SET ON MAXIMUM BRILLIANCE. I PROVED THIS BY DRIVING INTO A DARK PARKING GARAGE AND SAW THAT THE SAID LIGHTS TURNED ON AT MAXIMUM. I ASKED THE SERVICE MANAGER ABOUT THIS AND HE SAID FORD HAD WIRED THE LIGHTS THROUGH THE SOLAR SWITCH VIA THE ELECTRONIC CONTROL UNIT AND COULD NOT BE CHANGED. THIS IS A DANGEROUS DISTRACTION WHEN DRIVING IN DAYLIGHT HOURS AND TO SEE THE INFORMATION O THE DASHBOARD THE RUNNING LIGHTS MUST BE TURNED OFF. IN MY OPINION THIS DEFECT NEEDS TO BE REMEDIED WITH A RECALL. THANK YOU. *TR

Mileage: 19,000

AT FIRST OUR 2005 FORD FIVE HUNDRED HAD ISSUES WITH INSTRUMENT CLUSTER FAILURES (BLACKING OUT AND NEEDLES ZEROING ETC. BUT NOW REAR BACK UP LIGHTS COME ON GOING DOWN THE HIGHWAY BECAUSE OF THIS ELECTRICAL PROBLEM. I BELIEVE THIS HAS TO BE CONSIDERED A SAFETY ISSUE AND SHOULD WARRANT A RECALL .THANK YOU

Mileage: 80,000

INSTRUMENT CLUSTER FAILURE. ALL GAUGES DROP TO ZERO. MULTIPLE DASH WARNING LIGHTS COME ON THEM GO BACK OFF LEAVING THE CHECK ENGINE LIGHT ON. TURN SIGNAL LIGHTS WILL NOT OPERATE. PROBLEM IS INTERMITTENT. THE REVERSE LIGHTS COME ON WHEN THE CAR IS NOT IN REVERSE. PROBLEM STARTED THIS MORNING 9/20/2010 I CAN NOT BELIEVE THAT THE NHTSA HAS NOT MADE FORD ISSUE A RECALL! *TR

Mileage: 58,000

WE OWN A 2005 FORD 500 AND MY WIFE HAS TAKEN IT TO 3 DIFFERENT FORD DEALERS TO HAVE AN ISSUE LOOKED AT. THE VEHICLE HAS STALLED ON HER OVER A DOZEN TIMES WHILE DRIVING DOWN THE HIGHWAY AND IT HAS GONE INTO FAIL SAFE MODE. THE VEHICLE SEEMS TO LURCH WHEN IN GEAR EITHER DRIVE OR REVERSE. I'VE LOOKED UP THE ISSUE ON LINE AND IT APPEARS TO BE VERY COMMON WITH THIS MODEL OF VEHICLE. THROTTLE BODY AND REPROGRAMMING OF THE PCM. I BELIEVE THIS TO BE A VERY BIG SAFETY ISSUE AND THERE NEEDS TO BE A RECALL ON THESE BEFORE SOMEONE GETS SEVERELY HURT. *TR

Mileage: 96,000

FORD 500 2005 - 74K MILES....CAR STARTED JERKING FORWARD AS SOON AS I LIFT MY FOOT OFF THE BRAKE,WHICH HAS ALMOST CAUSED ME TO RUN INTO THINGS IN A PARKING LOT FULL OF CARS. THE SENSORS WENT OUT,WHICH I WASN'T AWARE OF UNTIL I BACKED INTO A TREE WITHOUT WARNING. NOW THE AIR CONDITIONING HAS GONE OUT AND IT SEEMS MY CAR IS NOT THE ONLY ONE WITH THESE PROBLEMS. *TR

Mileage: 70,000

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE THE CONTACT WAS PARKING THE VEHICLE, ALL OF THE GAUGES ON THE INSTRUMENT PANEL FAILED TO FUNCTION. THE FAILURE ALSO RECURRED INTERMITTENTLY WHILE DRIVING AT VARIOUS SPEEDS. THE CONTACT ALSO STATED THAT WHEN THE FAILURE OCCURRED SHE WAS NOT ABLE TO USE THE TURN SIGNALS. ALL OF THE WARNING LIGHTS ON THE INSTRUMENT PANEL BEGAN TO SHUT ON AND OFF INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THEY COULD NOT DUPLICATE OR DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 75,200.

Mileage: 75,200

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY AND ABNORMALLY ACCELERATE WITHOUT DRIVER INTENT. THE FAILURE WOULD OCCUR WHETHER THE VEHICLE WAS IN DRIVE OR REVERSE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS SCHEDULED FOR FURTHER DIAGNOSTIC TESTING BY THE DEALER. THE FAILURE MILEAGE WAS 106,000 AND THE CURRENT MILEAGE WAS 108,000. UPDATED 08/24/10*LJ THE CONSUMER STATED THE VEHICLE RANDOMLY ACCELERATES AT A RATE OF 65 MPH WHEN HER FOOT IS NOT ON THE GAS PEDAL. THE VEHICLE ALSO HAS WIRING PROBLEMS THAT LEADS TO THE HEADLIGHTS CAUSING THEM TO FAIL. THE WIRES OVERHEAT AND SOMETIMES FLICKERS. THE CASING MELT AS WELL AND THEN THE LIGHTS BEGIN TO SMOKE. UPDATED 08/25/10 *JB

Mileage: 106,000

I PURCHASED A 2005 FORD 500 LTD. THE FIRST INCIDENT OCCURRED WHILE DRIVING HOME FROM ATLANTIC CITY. THE DASHBOARD LIT UP LIKE I WAS STARTING THE CAR AND WENT INTO FAILSAFE ENGINE MODE. AFTER PULLING OVER, THE CAR RAN NORMAL. THE NEXT OCCURRENCE WAS WHEN THE CAR STARTED SHUTTING OFF WHILE DRIVING. IT HAS DONE THIS ON NUMEROUS OCCASTIONS. THEN THE DASHBOARD LIT UP AGAIN AND THE REVERSE LIGHTS STAYED ON. THIS WINTER SEASON THE DOOR LATCHES WOULD NOT CATCH TO KEEP THE DOORS SHUT. AFTER IT RAINS THE REAR DOORS HAVE WATER SITTING INSIDE OF THEM. UPON DOING SOME RESEARCH, I FOUND THAT THESE PROBLEMS WERE ON FORD'S TECHNICAL SERVICE BULLITEN (TSB). I CALLED FORD AND THEY SAID THERE WERE NO RECALLS ACCORDING TO THE VEHICLE IDENTIFICATION NUMBER. THEY ALSO STATED THAT THERE WAS WORK DONE PRIOR TO ME PURCHASING THE VEHICLE. I ALSO HAD THE CAR WORKED ON FOR THE ELECTRICAL PROBLEM AND WAS TOLD THE CAR WAS FIXED. THE CAR IS STILL EXPERIENCING THESE PROBLEMS. I DON'T HAVE THE FINANCES TO CONTINUE TO HAVE WORK DONE AND THE PROBLEMS NOT BE FIXED. *TR

Mileage: 84,000

IT STARTED WITH MY INSTRUMENT CLUSTER GOING OUT (NO LIGHTS, GAUGES, ANYTHING) AND IT CAN LAST ANYWHERE FROM 15 MINUTES TO HOURS. THE OTHER NIGHT MY BOYFRIEND AND I HIT A DEER AND WE WENT FROM 70 TO 50 ON IMPACT (WHICH WAS HEAD ON) AND OUR AIRBAGS DID NOT DEPLOY. HOWEVER A FEW MINUTES AFTER THE IMPACT, THE LIGHT CAME ON SAYING SOMETHING WAS WRONG WITH THE AIRBAGS. *TR

Mileage: 59,000

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING 30 MPH THE VEHICLE BEGAN SHAKING AND THEN IDLING AS IF IT WANTED TO SHUT OFF. THE VEHICLE WAS TAKEN TO THE DEALER AND INSPECTED WHERE IT WAS DETERMINED THAT THE VALVE BODY BOX WAS FAILING AND THE COST FOR REPAIR WOULD BE $1800.00. THE VEHICLE HAS NOT BEEN REPAIRED AND THE CONTACT IS TRYING TO GET THE MANUFACTURER TO COVER THE COST OF THE REPAIR. THE CONTACT CALLED THE MANUFACTURER AND A COMPLAINT WAS FILED AND THE CONTACT WAS ADVISED THAT HER CLAIM WOULD BE REVIEWED. THE FAILURE MILEAGE WAS 25,281 AND THE CURRENT MILEAGE WAS 74,000. UPDATED 11/10/09 *CN THE CONSUMER STATED THE VEHICLE SHUT OFF SEVERAL TIMES, THE GAUGE ACT ERRATICALLY. UPDATED 11/18/09

Mileage: 25,281

MY WIFE CALLED ME OUTSIDE AND SAID THE PASSENGER SIDE HEADLIGHT WAS OUT, I SAID NO PROBLEM I'LL HAVE IT REPLACED IN THE MORNING, GO AHEAD WITH ONE HEAD-LIGHT, SHE ONLY WENT AROUND THE BLOCK AND CAME BACK SCREAMING THAT THE CAR WAS ON FIRE, AND THE FIRE WAS RIGHT BEHIND THE HEADLIGHT THAT JUST WENT OUT. I EXTINGUISHED THE FLAME AND DISCONNECTED THE BATTERY. THE CAR HAS BEEN TOWED TO THE SHOP FOR AN ESTIMATE. I CONTACTED MY FORD DEALER, THE CAR IS NOT UNDER WARRANTY, 2005 FORD FIVE-HUNDRED WITH 58,150 MILES IN EXCELLENT CONDITION. HE SAID " THEY HAVE NEVER HEARD OF THAT HAPPENING BEFORE, AND TO CONTACT FORD CUSTOMER RELATIONS ON MONDAY. *TR

Mileage: 58,150

WE ARE HAVING A PROBLEM WITH THE INSTRUMENT CLUSTER OF OUR 2005 FORD FIVE HUNDRED. ALL THE LIGHTS ON THE DASHBOARD GO OUT. ALL THE GAUGES DROP DOWN TO ZERO. SOMETIMES THIS LASTS FOR A SECOND. SOMETIMES IT WILL GO OUT FOR HOURS. THIS IS DANGEROUS BECAUSE YOU DO NOT HAVE A SPEEDOMETER READING. *TR

Mileage: 112,000

MY INSTRUMENT PANEL LIGHTS WILL BLINK OFF AND ON. STARTED ABOUT 6/1/2008. DOES IT RANDOMLY IN ALL WEATHER CONDITIONS. MOSTLY ON INITITAL START UP. *TR

Mileage: 85,000

SPORADICALLY, THE INSTRUMENT CLUSTER ON MY CAR FAILS. SOMETIMES THE DASHBOARD LIGHTS GO OFF, SOMETIMES ALL THE NEEDLES GOT TO "0" AND JUST TWITCH FOR A FEW SECONDS. THEN THEY COME BACK UP. THIS HAPPENS DAY AND NIGHT, WARM AND COLD. IT STARTED HAPPENING AROUND 60,000 MILES. *TR

Mileage: 60,000

I AM DRIVING A 2005 FORD FIVE HUNDRED WITH THE CHARACTERISTICS OF TSB 06-17-9 WHERE THE INSTRUMENTATION QUITS WORKING AND THEN COMES BACK. THIS HAS HAPPENED SEVERAL TIMES. HOWEVER, IN ADDITION TO THAT, SOMETIMES THE TURN SIGNALS QUIT WORKING AND WHEN THAT HAPPENS THE AIR BAG LIGHT COMES ON AND THE BACK UP LIGHT COMES ON EVEN THOUGH THE CAR IS NOT IN REVERSE. AFTER THE CAR SITS A WHILE, THIS CLEARS UP, BUT THE CHECK ENGINE LIGHT WILL BE ON. IT IS GOING IN THE SHOP IN TWO DAYS AND HOPEFULLY CAN BE FIXED, HOPEFULLY NO CHARGE. THE TURN SIGNAL ISSUE IS OBVIOUSLY A SAFETY ISSUE. *TR

Mileage: 47,000

I WOULD LIKE TO SEE THE INVESTIGATION REOPENED FOR NHTSA ACTION NUMBER : PE07058 AND A RECALL BY THE FORD MOTOR COMPANY DUE TO THE FAILURE OF THE ELECTRICAL SYSTEM:INSTRUMENT PANEL ON THE 2005 FORD FIVE HUNDRED. WHILE DRIVING MY 2005 FORD FIVE HUNDRED THE OIL PRESSURE LIGHT AND BRAKE LIGHT ILLUMINATED. AT THE SAME TIME THIS OCCURRED THE RADIO VOLUME WOULD DECREASE AS IF I WAS COMING TO A STOP, THE TURN SIGNALS WOULD FAIL (JUST THE INDICATION ON THE INSTRUMENT CLUSTER), AND MOST IMPORTANTLY THE REVERSE LIGHTS WOULD ILLUMINATE. THIS WOULD LAST FROM A FEW SECONDS TO SEVERAL MINUTES AT A TIME. ON THE WAY TO THE DEALERSHIP, I WAS PULLED OVER BY THE POLICE AND GIVEN A VERBAL WARNING IN REGARDS TO MY REVERSE LIGHTS BEING ILLUMINATED WHILE DRIVING. THE POLICE ASSUMED MY BRAKE LIGHTS WERE INOPERATIVE(BLOWN BULB/BROKE LENSES) AS MY REVERSE LIGHTS WERE ILLUMINATED CAUSING AN UNSAFE CONDITION. THE VEHICLE IS AT THE FORD DEALER NOW, THE DEALER DID SUPPLY ME WITH ANOTHER CAR UNTIL MINE WAS REPAIRED AS THEY DEEMED THE CAR UNSAFE TO DRIVE IN THIS CONDITION. THE DEALER HAS ORDERED THE ENTIRE INSTRUMENT CLUSTER FOR REPLACEMENT. THE DEALER ALSO STATED THAT I WILL BE LOOKING AT A $100-200 DOLLAR DEDUCTIBLE AS THIS IS NOT DIRECTLY COVERED ON THE WARRANTY. THIS NEEDS TO BE ADDRESSED BEFORE AN ACCIDENT/DEATH OCCURS AS A RESULT OF THIS KNOWN EXISTING PROBLEM. *TR

Mileage: 52,000

STARTED DRIVING MY 2005 FORD FIVE HUNDRED SEL FRONT WHEEL DRIVE AS I NORMALLY DO, EXCEPT THE INSTRUMENT CLUSTER AND LIGHTS STARTED FLICKERING, MY A/C TURNED OFF AND CHECK ENGINE LIGHT CAME ON. AFTER STOPPING ON THE SIDE OF THE ROAD EVERYTHING RETURNED TO NORMAL. ABOUT 40 MINUTES LATER A SIMILAR SITUATION OCCURRED, ONLY THIS TIME JUST THE INSTRUMENT PANEL FAILED. MY CRUISE CONTROL STILL WORKED BUT MY TACH, SPEED, BATTERY AND POWER GAUGE ALL DROPPED TO ZERO, HOWEVER THE LIGHTS REMAINED ON. I AM WRITING TODAY BECAUSE I SAW ONLINE THAT OTHER OWNERS OF THE SAME MAKE AND MODEL ARE HAVING IDENTICAL PROBLEMS. THIS IS A MAJOR SAFETY ISSUE AND COULD CAUSE AN ACCIDENT, ESPECIALLY IF THE LIGHTS CUT OFF AT RANDOM. I'M SURPRISED THERE HASN'T BEEN A RECALL ISSUED OR AN ACCIDENT YET AS A RESULT OF THIS. *TR

Mileage: 74,500

I HAVE A FORD FIVE HUNDRED LIMITED. THE CAR HAS STOP RUNNING WHILE THE CAR IS IN GEAR AND MOVING. IT ALSO STOPPED WHEN I STARTED TO DRIVE FROM A STOP LIGHT. WHILE IT WAS BEING FIXED AT THE CAR DEALERSHIP IT STOP (DIED) ON THEM SEVERAL TIMES. THE FORD DEALER COMPANY THOUGHT IT WAS THE POWER STEERING PUMP BECAUSE THE POWER STEERING PUMP WAS MAKING A KNOCKING SOUND. THEY ALSO NOTICED THAT IF THEY WAS TO TURN THE WHEEL IT WOULD USUALLY DIE ON THEM. THE DEALERSHIP HAS REPLACED THE BATTERY, POWERSTEERING PUMP, BELT AND THE THROTTLE AND THE CAR STILL DIES. MY UNDERSTANDING FROM THEM IS THAT THEY HAVE NEVER COME ACROSS THIS PROBLEM BEFORE. WHAT MADE ME TAKE THE CAR IN TO BEGIN WITH WAS THAT I WENT TO START THE CAR AFTER PLAYING TENNIS FOR ABOUT 45 MINUTES AND IT WOULDN'T START. THE BATTERY WAS SOMEWHAT DEAD AND THE SECURITY LIGHT WAS FLASHING RAPIDLY. *TR

Mileage: 50,076

I WOULD LIKE A SAFETY RECALL ISSUED FOR THE FORD 500, THE INSTRUMENT PANEL HAS A DEFECT CAUSING ALL OF THE NEEDLES AND CONTROLS TO MALFUNCTION LEAVING THE DRIVER WITH NO SPEEDOMETER, GAS GAUGE OR TEMPERATURE GAUGE, FORD IS AWARE THERE IS A PROBLEM AND HAS ISSUED A TECHNICAL SERVICE BULLETIN TO THE DEALERS, HOWEVER, WITH NO RECALL YOU WILL BE CHARGED FOR THE REPLACEMENT OF THE PANEL AND THIS MAY KEEP SOME PEOPLE FROM HAVING THEM REPLACED, I WAS CHARGED A $100 DEDUCTIBLE FOR THIS REPAIR AND IN ALL FAIRNESS IT SHOULD HAVE BEEN COVERED BY A FORD RECALL SINCE THEY ARE AWARE OF THE PROBLEM AND HAS THE POTENTIAL TO BE A SERIOUS SAFETY ISSUE!! *TR

Mileage: 37,500

I PURCHASED A 2005 FORD FIVE HUNDRED USED LAST 2/07; ON 3/4/08 MY INSTRUMENT PANEL WENT OUT COMPLETELY WHILE DRIVING. NO GAUGES, LIGHTS, NOTHING. I TOOK IT TO MY FORD DEALER 3/5/08 WHO LOOKED AT IT, AFTER 3 HOURS RETURNED IT TO ME SAYING I NEEDED A NEW INSTRUMENT PANEL, BUT THEY HAD TO ORDER ONE AND SAID TO COME BACK WHEN THEY HAD IT. THE PANEL WORKED, SO I WONDERED WHAT WAS UP; HOWEVER AFTER A FEW DAYS, THE GAUGES WOULD QUIT MOMENTARILY BEFORE WORKING AGAIN PERIODICALLY. I HAVE YET TO HEAR FROM FORD ABOUT MY PART, ALSO, THEY SAY I HAVE TO PAY FOR IT. THIS IS NOT NORMAL WEAR AND TEAR AND OBVIOUSLY A DEFECT, I'VE OWNED 5 CARS IN MY LIFE AND NEVER HAD AN INSTRUMENT PANEL REPLACED EVER. I'VE OWNED VEHICLES FOR 10 YEARS. I SHOULDN'T HAVE TO PAY FOR A FACTORY DEFECT WHICH IS A SAFETY HAZARD. I HAVE YET TO GET THE PART REPLACED, AS THEY DON'T SEEM TO HAVE ONE YET. SO I RISK MY SAFETY EVERY TIME I DRIVE. *TR

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING 65 MPH, THE VEHICLE STALLED ON THE HIGHWAY. THE CONTACT WAS ABLE TO PULL OFF THE ROAD. ON JULY 11, 2007, THE DEALER PERFORMED A DIAGNOSTIC TEST. THE VEHICLE WAS RETURNED ONE WEEK LATER. THE FAILURE RECURRED ON JULY 17, AUGUST 31, SEPTEMBER 25, OCTOBER 3, NOVEMBER 2, AND DECEMBER 18. THE DEALER DID NOT RETURN THE VEHICLE UNTIL FEBRUARY 23,2008. THE DEALER WAS ABLE TO DUPLICATE THE FAILURE ONCE THE VEHICLE WAS RETURNED. THE CONTACT EXPERIENCED THE FAILURE AGAIN AND THE DEALER PICKED UP THE VEHICLE ON MARCH 20, 2008. THE DEALER REPLACED THE INSTRUMENT PANEL. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 31,058.

Mileage: 31,058

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT PARKED THE VEHICLE, TURNED OFF AND REMOVED THE KEY FROM THE IGNITION. HE WALKED INTO THE HOUSE WITH HIS KEYS AND THE VEHICLE TURNED ITSELF ON. THE CONTACT ORIGINALLY THOUGHT THAT THE VEHICLE HAD AN AUTOMATIC START SYSTEM, BUT IT DOES NOT. THE VEHICLE WILL BE TAKEN TO THE DEALER FOR A DIAGNOSIS. THE CURRENT AND FAILURE MILEAGES WERE 23,820.

Mileage: 23,820

2005 FORD FIVE HUNDRED, INTERMITTENT INSTRUMENT CLUSTER, VEHICLE ODO 20K MILES, MULTIPLE FAILURES, PANEL GOES DARK, THEN ALL LIGHTS ILLUMINATE. DRIVABILITY NOT AFFECTED. NEW DEFECT ON CAR. *TR

Mileage: 20,180

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE INSTRUMENT PANEL WOULD FLICKER ON AND OFF WHEN THE HEADLIGHTS WERE ACTIVATED. A FEW DAYS LATER, THE INSTRUMENT PANEL FAILED COMPLETELY. THE DEALER STATED THAT THE INSTRUMENT CLUSTER NEEDED TO BE REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 48,000.

Mileage: 48,000

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHEN THE VEHICLE WAS STARTED, ONLY THE WRENCH AND AIR BAG INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE FAILURE OCCURRED WHILE IT WAS DARK OUTSIDE AND THE FUEL GAUGE AND SPEEDOMETER WERE NOT VISIBLE. THE RADIO WAS STILL OPERATING. AFTER 15 MINUTES, THERE WAS A POWER SURGE AND THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS STILL AT THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 45,200. UPDATED 01-30-08. *KB THE CONSUMER STATED TOOK THE VEHICLE TO THE DEALER ON JANUARY 11, 2008 AND STATED THERE IS A SERVICE BULLETIN TO PROBLEM AND RESET THE SYSTEM. UPDATED 01/30/08 *TR

Mileage: 45,200

2005 FORD FIVE HUNDRED INSTRUMENT PANEL TEMPORARILY STOPS WORKING AND ALL GAUGES GO TO ZERO. I WAS TOLD I NEEDED A NEW NODULE, BUT IT WAS NOT IMMEDIATE. THIS HAPPENS ALMOST DAILY FOR A FEW MINUTES. *TR

Mileage: 58,000

INSTRUMENT CLUSTER FAILURE. ALL GAUGES DROP TO ZERO. MULTIPLE DASH WARNING LIGHTS COME ON, DASHBOARD LIGHTS GO BLACK, TURN SIGNAL LIGHTS WILL NOT OPERATE. PROBLEM IS INTERMITTENT. PROBLEM BEGAN 8/3/07. OFF AND ON SINCE. DEALER CAN NOT FIND PROBLEM. *JB

Mileage: 38,891

THE 2005 FORD FIVE HUNDRED HAD JUST UNDER 30000 MILES ON IT AND FOR THE LAST 5000 MILES THE DASHBOARD HAD BEEN ACTING UP TO THE POINT THAT IT DID IT ALMOST EVERY TIME WE USED IT. SYMPTOMS: AIB AG LIGHT WENT ON AND DASH LIGHTS WENT OFF, THE 4 GAUGES IN THE INSTRUMENT CLUSTER WENT TO ZERO, DIGITAL DISPLAY WENT OUT AND SOME TIMES RESET GALS USED & MILES TRAVELED, DIRECTIONALS WENT OUT WHEN DASH LIGHTSWENT OUT.*AK

Mileage: 25,000

UPON STARTING CAR AND A FEW MINUTES AFTER DRIVING THE CAR, THE CAR STARTS TO SPIT AND SPUTTER AND TOTALLY SHUTS DOWN. THIS HAS HAPPENED AT LEAST 8 TIMES IN THE PAST 4 MONTHS AND HAS LEFT ME TO SWERVE ON THE HIGHWAY BEFORE IT SHUTS COMPLETELY DOWN SO I AM NOT IN A DANGEROUS SITUATION (COMPLETELY STOPPED IN THE MIDDLE OF FLOWING TRAFFIC). THE MESSAGE "ENGINE FAIL SAFE MODE" COMES ON. WE HAVE HAD CAR TO THE DEALER NUMEROUS TIMES AND THEY CANNOT FIND ANYTHING WRONG. PROBLEM HAS NOT BEEN FIXED AND CAR CONTINUES TO STOP. *JB

Mileage: 22,000

THE ELECTRICAL SYSTEM THROUGH OUT THE CAR IS BEING HEARD IN THE SPEAKERS. IF THE SEATS, WINDOW, ETC., ETC. ARE TOUCHED YOU CAN HEAR THEM THROUGH THE BACK END WITH A LOUD ROARING NOISE. IT IS SO LOUD THAT YOU CAN NOT KEEP THE RADIO ON. IT ONLY REACTS WHEN IT IS EXTREMELY HOT, EXTREMELY COLD OR AFTER THE CAR HAS BEEN WASHED OR IT RAINS. WE HAVE TAKEN THIS TO THE DEALER WHERE THE AMP, RADIO, CD PLAYER AND SPEAKERS HAVE ALL BEEN REPLACED 3 TIMES. THEY HAVE EVEN ELIMINATED WATER LEAK WHICH ONLY LEAVES WIRING ISSUES IN WHICH THEY REFUSE TO REPLACE. OUR FEAR IS THAT IT COULD CAUSE FIRE. WE HAVE ARBITRATED AND CONTACTED CORPORATE AND THEY REFUSE TO DO ANYTHING ABOUT IT. WE EVEN TOOK THIS TO ANOTHER FORD DEALER IN WHICH THEY TOLD US AFTER SHOWING THEM ALL THE WORK ORDERS THAT THEY WILL NOT GET INVOLVED SINCE IT IS A PRE-EXISTING ISSUE THAT ANOTHER DEALER HAS TRIED TO RESOLVE MANY, MANY TIMES. JUST BE CAUTIOUS AND PLACE YOUR VEHICLE INSIDE AWAY FROM THESE CONDITIONS SO IT DOESN'T ACT UP AND CAUSE MORE ISSUES. *NM

WHILE DRIVING MY 2005 FORD FIVE HUNDRED WITH 18000 MILES ON IT ALL GAUGES DROPPED TO ZERO. THE LIGHTS WENT OUT AND AIR BAG FAILURE LIGHT CAME ON. I TOOK THE VEHICLE TO THE DEALER WHO SAID THEY NEEDED TO ORDER A NEW DASH CLUSTER PANEL ,AFTER 2 WEEKS CALLED DEALER AND WAS TOLD IT WOULD TAKE A MONTH TO GET PART I WAS TOLD BY ANOTHER MECHANIC THAT CAR WAS UNSAFE TO DRIVE BECAUSE OF AIR BAG WAS IN FAILURE MODE. NOT ONCE WAS I TOLD THIS BY DEALER. HAS NOT BEEN REPAIRED. *JB

Mileage: 17,900

ON THE TWO OCCASIONS THAT WE HAD SNOW THIS PAST WINTER, MY FORD 500 BEGAN TO SURGE UNCONTROLLABLY AND THE ENGINE FAILURE LIGHT CAME ON WHEN ACCELERATING. IT BECAME NECESSARY TO PULL TO THE SIDE OF THE ROAD AND TURN THE VEHICLE IGNITION OFF. WHEN I RESTARTED, THE TROUBLE LIGHT WAS OFF AND I CONTINUED MY JOURNEY HOME. WITHIN A FEW MINUTES THE SAME PROBLEM OCCURRED, ENGINE FAILURE LIGHT AND THE SURGING. NEEDLESS TO SAY, IT TOOK QUITE AWHILE TO GET HOME. I BROUGHT THE VEHICLE TO AN AUTHORIZED FORD DEALER THE FIST TIME AND THEY COULD NOT FIND ANYTHING WRONG. AFTER THE SECOND SNOW STORM, AND THE SAME SYMPTOMS, THE DEALER SAID THE PROBLEM OCCURRED BECAUSE THE FILTER WAS INSTALLED BACKWARDS. SOMEWHAT SKEPTICAL, I ACCEPTED THEIR EXPLANATION BECAUSE OF MY GOOD RELATIONSHIP WITH THE DEALER OWNER AND SERVICE MANAGER. WHILE AT WORK THE OTHER DAY, I NOTICED A CO-WORKER WITH A SIMILAR TYPE VEHICLE AND INQUIRED AS TO HOW SHE LIKED THE FORD 500. HER RESPONSE SHOCKED ME WHEN SHE STATED THAT SHE LIKED THE VEHICLE, BUT HAD TROUBLE THIS PAST WINTER IN THE SNOW. SHE DESCRIBED THE SAME PROBLEM THAT I HAD EXPERIENCED AND NOW I WONDER HOW MANY OTHER 2005 FORD 500 OWNERS HAVE EXPERIENCED THE SAME PROBLEMS. I AM HOPING THAT YOU WILL BE ABLE TO ASSIST ME IN DETERMINE THE CAUSE OF THIS PROBLEM. *JB

Mileage: 21,060

DASH GAUGES DROP TO ZERO WHILE CAR IS RUNNING USUALLY FOR A FEW SECONDS, SOMETIMES FOR SEVERAL MINUTES. OCCASIONALLY THE LED DISPLAY ALSO GOES OUT WITH HEADLIGHTS AND TURN SIGNALS FOR 10 SECONDS TO 10 MINUTES WHILE THE ENGINE IS RUNNING PERFECT. *JB

Mileage: 13,285

DT*: THE CONTACT STATED THAT ALL THE INDICATORS ON THE INSTRUMENT PANEL FAILED WHILE DRIVING 65 MPH. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHERE THE DEALER COULD NOT DETERMINED THE CAUSE OF THE PROBLEM.

Mileage: 11,000

BATTERY ACID EATS AWAY PLASTIC TRANSMISSION CABLE LINKAGE. *NM

OIL LIFE DIAGNOSTIC MESSAGE CONTINUES TO REPORT ZERO PERCENTAGE LIFE REMAINING. *JB

Mileage: 750

STARTING IN DECEMBER WE HAVE HAD NUMEROUS STARTING PROBLEMS WITH THIS CAR. WE HAVE HAD IT BACK TO THE DEALERSHIP FIVE TIMES FOR THIS PROBLEM AND THREE OTHER TIMES FOR OTHER WARRANTY PROBLEMS. WHEN YOU GO TO START THE CAR IS TURNS OVER BUT WILL NOT START OR IT WILL START THEN DIE. WHEN IT ACTED UP WE ALSO HAD A LOSS OF POWER ONCE IT WOULD START THE SECOND TIME IT WENT TO DEALER FOR THE PROBLEM WE COULD NOT GET IT STATED AT ALL AND IT HAD TO BE TOWED. AFTER THE LAST REPAIR IT NOW IS GETTING ONLY ABOUT 19 MILES TO THE GALLON IN COMBINED DRIVING. WE HAVE ASKED FORD TO BUY THE VEHICLE BACK AND THREE TIMES WE WERE TOLD A FORD REGIONAL REP WOULD CALL US BACK TO WORK WITH US AND THEY NEVER WOULD CALL US BACK. WE ARE CURRENTLY TRYING TO HAVE FORD BUY THE VEHICLE BACK OR REPLACE IT THROUGH THE BBB DISPUTE REPLACEMENT BUT THEY WILL NOT. WE HAVE ALSO HAD PROBLEMS WITH THE DOORS AND MOLDINGS NOT BEING ALIGNED CORRECTLY AND THIS CAUSED DAMAGE WHEN THE REAR DOOR OPENED AND DAMAGED THE DOORS. ALSO THE POWER WINDOWS HAVE MALFUNCTIONED TWICE AND NEEDED REPAIR OR REPLACEMENT OF THE WINDOW REGULATOR. WE ARE VERY DISAPPOINTED IN THIS VEHICLE AND FORD. *NM

Mileage: 5,200