2005 FORD FIVE HUNDRED Engine And Engine Cooling Problems

THE CAR PERIODICALLY LURCHED AND SURGED. FINALLY, IT WOULD NOT START. THE DEALER DETERMINED THAT THE ELECTRONIC THROTTLE BODY WAS DEFECTIVE. BASED ON INFORMATION FROM THE DEALER AND FROM THIS WEBSITE, IT APPEARS THAT THIS IS A COMMON PROBLEM ON CERTAIN FORD MODELS. IF THIS PROBLEM IS AS WIDE-SPREAD AS IT APPEARS, THERE SHOULD BE A RECALL. *TR

Mileage: 95,215

BEING STOPPED AT AN ATM, MY CAR BEGAN TO SMOKE. PULLED OVER INTO THE BANK PARKING LOT TO SEE IF IT WAS OVER HEATING. THE WHITE SMOKE WOULD NOT SUBSIDE AND BEGAN GETTING WORSE. DIALED 911 AND A FIRETRUCK CAME OUT OPENED THE HOOD AND EXTINGUISHED A FIRE UNDER THE HOOD. PRIOR TO THE TRUCK ARRIVING, A LOUD BANG OCCURRED UNDER THE HOOD. *TR

Mileage: 109,550

SINCE 2007 THE CAR INTERMITTENTLY WILL PERIODICALLY LUNG FORWARD AND IT IS ALMOST IMPOSSIBLE TO CONTROL THE CAR. THIS HAS HAPPENED SEVERAL TIMES SINCE JUNE 2007 (88,000 MILES). EVEN HARD BRAKING DOES NOT NECESSARILY STOP THE CAR...I HAVE HAD TO PUT THE CAR IN NEUTRAL THE ENGINE REVS UP AS IF I AM TOUCHING THE ACCELERATOR (AND MY FOOT IS NOT ON THE PEDAL) AND I SHUT THE CAR OFF. TURNING THE CAR BACK ON DOES NOT NECESSARILY REMEDY THE PROBLEM. IN ADDITION, THE CAR ROUTINELY GOES INTO FAIL SAFE ENGINE MODE OR CUTS OFF WHILE I AM DRIVING AT A REASONABLE RATE OF SPEED BOTH ON RURAL ROADS AND HIGHWAYS. THIS CAR IS A HAZARD TO DRIVE, MORE SO IN THE WARMER MONTHS...MY THOUGHT IS SOMETHING MUST GET OVERHEATED BUT WHAT I DO NOT KNOW. *TR

Mileage: 88,000

THIS HAS HAPPENED MULTIPLE TIMES (MEANING MORE THAN 5 TIMES) DURING THE SUMMER OF 2011. DRIVING ON HIGHWAY AT POSTED SPEED LIMITS AND CAR SUDDENLY LURCHES THEN DROPS INTO FAILSAFE MODE (AS INDENTIFIED BY ALERT POSTED ON THE DASH). PULL OVER, READ OWNER'S MANUAL. FOLLOW DIRECTIONS HOW TO CLEAR FAILSAFE AND IMPLEMENT THEM. A FEW TIMES IT WORKED FOR SHORT PERIODS OF TIME. OTHER TIMES, IT WOULD NOT WORK AT ALL. TWICE THE CAR WAS RUNNING AT APPROXIMATELY 65 MPH AND SUDDENLY GO INTO FAILSAFE MODE THEN STALL OUT. ESPECIALLY DURING STREET/CITY DRIVING, CAR SUDDENLY KICKS FORWARD THEN FAILSAFE AND WILL SOMETIMES STALL OUT IN MIDDLE OF STREET. UNABLE TO RESTART. LAST TIME THIS OCCURRED CAR REQUIRED TOWING TO LOCAL FORD DEALER. INITIALLY SAID IT WAS THE THROTTLE SENOR FOR A COST OF $300. WHEN I OK'D THAT REPAIR, THE DEALERSHIP CALLED BACK LATER AND STATED IT WAS THE ENTIRE THROTTLE BODY AND REPAIR WOULD COME AT A COST OF $1000. THE CAR NOW SITS IN MY DRIVEWAY WHERE IT WAS TOWED TO AND SITS FOR SAFETY REASONS. AFTER RESEARCHING THE INTERNET, I HAVE COME TO FIND THAT THIS IS A COMMON OCCURRENCE WITH FORD AND AN ANNOUNCED RECALL SHOULD BE IMPLEMENTED IMMEDIATELY. *KB

WE BOUGHT MY CAR IN JULY 2011, ITS WAS GARAGED BY THE 1ST OWNER SO IT WAS LIKE BRAND NEW!! LOW MILES JUST 12,850 , START WHAT NOW SEEMS TO BE THE ENDLESS DRIVES IN A RENTAL CAR AND WITH EMPTY WALLETS TOTALING NOW APPROX; CLOSE TO AN ADDITIONAL $3,500 NOW IN REPAIRS FROM THE BATTERY IN AUG 2011 TO NOW TO HAVING THE THROTTLE BEING REPLACE ALONG WITH A SET IF TIRES AND THE 2ND SET OF BOTH REAR AND FRONT BRAKES IN LESS THEN A YEAR , ALL DUE TO THE CONSENT STOPPING AND GOING OF THE CAR BY HITTING THE BRAKES TOO MUCH AND HAVING TO ACCELERATE, BECAUSE THE CAR WOULD WHILE TEMPTING TO PULL OUT OF MY GARAGE AT WHAT SHOULD OF BEEN A MERE 3MILES PER HOUR; RESULTED IN FLYING BACKWARDS SUDDENLY WHILE FOOT WAS APPLYING PRESSURE ON THE BRAKES TO KEEP FROM MOWING DOWN MY TEENAGE SON AT 15 MILES A HOUR ON ITS OWN WITH THE MP RISING RAPIDLY , WAS THE SCARE OF MY LIFE!!!! PLEASE SOMEONE RECALL THIS CAR , BEFORE SOMEONE REALLY DOES GET KILLED OR HURT!!! AS OF TODAY THE TOTAL THIS TIME TO REPAIR MY CAR IS AT A TOTAL IF$ 1,585.00; TO REPLACE THE THROTTLE AND TIRES & BRAKES AGAIN, AND FORD WOULDN'T EVEN COMP, US A RENTAL CAR THIS TIME ON OUR 5 TRIP DOWN TO THE SERVICE DEPT OF FORD!!!! *TR

Mileage: 12,500

I WAS DRIVING DOWN A RESIDENTIAL STREET WHEN ALL OF THE SUDDEN THE ENGINE STALLED ON ME AND I RECEIVED A "FAILSAFE ENGINE MODE" MESSAGE IN THE MESSAGE CENTER. I STOPPED THE CAR AND SHUT OFF THE ENGINE, THEN WAITED A COUPLE OF MINUTES AND STARTED IT AGAIN AND HAD NO PROBLEMS. I WAS THEN DRIVING DOWN A RESIDENTIAL STREET AGAIN A COUPLE OF DAYS LATER AND THE SAME THING HAPPENED WHERE THE ENGINE STALLED ON ME. THE ONLY WARNING SIGNS THAT I CAN RECALL WERE THAT AT TIMES, I WOULD EXPERIENCE SLUGGISH ACCELERATION. THIS IS A HUGE ISSUE TO ME AND VERY DANGEROUS SINCE I HAVE A CHILD AND WHAT IF I WAS TRAVELING ON THE HIGHWAY AND THIS HAPPENED TO ME? *TR

Mileage: 89,000

CARS ENTERS INTO FAILSAFE MODE AND ENGINE CUTS OUT. I HAVE BEEN ALMOST REAR- ENDED THREE TIMES SINCE FIRST OCCURRENCE AND ONE TIME ALMOST T-BONED. SLUGGISH ACCELERATION WHEN TAKING OFF MAY OCCUR ALSO. I HAVE NOTICED THIS HAS BEEN A COMMON PROBLEM WITH THIS MODEL AND THE FAULTY THROTTLE BODY HAS SINCE BEEN REDESIGNED BY FORD. THEY SHOULD RECALL THIS AS IT IS A SAFETY HAZARD. I KNOW THAT I WAS LUCKY TO HAVE NOT BEEN INJURED IN AN ACCIDENT DUE TO THIS FAULTY PART, BUT I AM SURE SOME HAVE NOT BEEN SO LUCKY. *TR

Mileage: 71,599

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE HARNESS FOR THE FRONT PASSENGER SIDE HEADLIGHT HAD TO BE REPLACED BECAUSE IT MELTED. AN AUTHORIZED DEALER STATED THAT THE FAILURE MAY HAVE BEEN CAUSED BY EXCESS MOISTURE, BUT THE CONTACT STATED THAT THE HEADLIGHT BECAME BRITTLE AND FRACTURED. THE DEALER ALSO STATED THAT THE TOP MOTOR MOUNT HAD WORN. THE CONTACT FELT THAT THESE WERE MANUFACTURERS DEFECTS. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 89,700.

Mileage: 70,000

I OWN A 2005 FORD 500. THE CAR HAS STARTED LURCHING FORWARD ON ITS OWN. I HAVE BEEN READING FORUMS AND HUNDREDS OF OTHER PEOPLE ARE HAVING THE SAME PROBLEMS. THEY SAY IT IS THE THROTTLE BODY. FORD SHOULD HAVE A RECALL ON THE 500 .THE FORD FREESTYLE IS HAVING THE SAME PROBLEM. DO PEOPLE HAVE TO DIE OR BE RUN OVER BEFORE SOMETHING IS DONE. IT IS EXTREMELY SCARY WHEN MY CAR LURCHES FORWARD ON ITS OWN. HELP, PLEASE HELP! *TR

Mileage: 89,000

THE VEHICLE HAS RPM SURGES AT LOW SPEEDS EITHER IN REVERSE OR FORWARD. I NEARLY HAD 3-4 ACCIDENTS IN 2 DAYS BECAUSE OF THE ISSUE. THE VEHICLE WILL ACTUALLY INCREASE UP TO 1000 RPMS BY ITSELF WHILE I HAVE MY FOOT ON THE BRAKE. AS SOON AS I BEGIN TO RELEASE PRESSURE OFF THE BRAKE WHILE TRYING TO PARK OR NEGOTIATE THE VEHICLE AT VERY LOW SPEEDS THE ENGINE WILL JUST TAKE OFF. THE FIRST TIME I NOTICED IT I WAS BACKING OUT OF A PARKING SPACE AND THE VEHICLE TOOK OFF BACKWARD CAUSING ME TO HAVE TO SLAM THE BRAKES ON. I ALMOST HIT A WOMAN WHO WAS PASSING ON THE OTHER SIDE OF THE LANE. *KB

Mileage: 73,000

BACKING OUT OF THE DRIVEWAY IN A 2005 FORD 500 AWD, CAR STUMBLES THEN LAUNCHED BACKWARD VIOLENTLY. LUCKILY I HAD MY FOOT ON THE BRAKE OR THE CAR WOULD HAVE KEPT GOING. "FAILSAFE ENGINE MODE" APPEARS ON THE DASHBOARD. THIS HAS HAPPENED SEVERAL TIMES BEFORE. SHOULD BE A RECALL ON THIS CAR. *KB

Mileage: 77,778

FAILSAFE ENGINE LIGHT WENT ON, I PULLED OVER AND CAR BEGAN ACCELERATION ON IT'S OWN WHILE IN STOP POSITION... *TR

Mileage: 138,940

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE HAVING THE VEHICLE SERVICED BY AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE, HE WAS INFORMED THAT THE UPPER MOTOR MOUNTS WERE CRACKED. AN AUTHORIZED DEALER WAS NOTIFIED AND THE CONTACT WAS AWAITING A RESPONSE. THE MANUFACTURER WAS THEN NOTIFIED, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 82,000.

Mileage: 82,000

A/C COMPRESSOR PROBLEM. AFTER READING NUMEROUS BLOGS, SEEMS TO BE A VERY COMMON PROBLEM FOR THE FORD FIVE HUNDRED MODELS. FORD NEEDS TO RECALL AND FIX. *TR

Mileage: 76,600

A/C PROBLEM,COOL WHEN GOING DOWN THE ROAD. WORM AT IDLE. 05 FORD 500. *TR

Mileage: 40,000

A/C PROBLEM,COOL WHEN GOING DOWN THE ROAD. WORM AT IDLE. 05 FORD 500. *TR

Mileage: 40,000

CAR GOES INTO "ENGINE FAILURE MODE" WHILE DRIVING. ENGINE DIES AND POWER BRAKES AND STEERING GO OUT. WENT TO DEALER FOR INJECTOR FLUSH AND AND THROTTLE BODY CLEANING PLUS REPROGRAM PCM. STILL GET "ENGINE FAILURE MODE". VERY DANGEROUS. MY ONLY CAR. HAVE BEEN TOLD THIS IS VERY COMMON PROBLEM WITH THESE FORDS AND YET NO RECALL. I AM OUT $340 AND NO LASTING FIX. AT DEALER 5/18/1L. WHAT IS WRONG WITH GETTING THIS REPAIRED CORRECTLY. WENT TO MAROONE FORD, 1333 N. FEDERAL HWY. FORT LAUDERDALE, FL 33304. CAR NOW SITTING IN MY GARAGE. IT WON'T RUN AND I'M AFRAID TO DRIVE IT. IT STARTS BUT IS VERY ROUGH AND WON'T RESPOND TO GAS PEDAL. CAN I TRY AND DRIVE IT BACK TO THE DEALER AT 10 MPH WITHOUT DAMAGING THE ENGINE? I AM RETIRED AND DON'T HAVE THE BIG BUCKS TO REPAIR THIS CAR. WILL FORD PAY FOR THE REPAIR? THE FAILURE MODE HAS HAPPENED 4 TIMES SINCE THE REPAIR BUT HAS "FIXED" ITSELF UNTIL TODAY. *TR

Mileage: 79,843

2005 FORD FIVE HUNDRED. VEHICLE ACCELERATES WITHOUT THE GAS PEDAL BEING DEPRESSED. VEHICLE ENTERS INTO FAILSAFE MODE. OCCURRENCES ARE INTERMITTENT. DIAGNOSTIC CHECKS SHOW SOMETHING OTHER THAN THE REAL CULPRIT WHICH IS A FAULTY THROTTLE BODY. HAS NOT BEEN REPAIRED YET. DEALER IS ASKING FOR 800.00. *TR

Mileage: 50,000

I HAVE A 2005 FORD FIVE HUNDRED WITH 68K MILES. I WAS LEAVING A REST AREA AND ACCELERATING ONTO THE INTERSTATE. MY CAR SHUDDERED AND HAD NO POWER. I NOTICED THE ENGINE FAIL SAFE MODE LIGHT. I WENT TO THE SHOULDER AND STOPPED THE CAR. I WAITED A MINUTE AND RESTARTED THE CAR. MY CHECK ENGINE LIGHT CAME ON. THIS IS REPEAT OF SYMPTOMS I HAD TWO WEEKS AGO. THE FORD DEALER REPLACED THE THROTTLE BODY ASSEMBLY TWO WEEKS AGO. AT THAT TIME, I WAS IN LINE AT MY GRANDSON'S SCHOOL. SAME SYMPTOMS EXCEPT THAT THE CAR SHUDDERED AND THEN ACCELERATED. FORTUNATELY, I HAD MY FOOT ON THE BRAKE. OVER THE LAST SIX MONTHS, I HAVE HAD REPEATED ENGINE FAIL SAFE MODES, BUT HAVE ALWAYS RESET WHEN I TURN OFF THE CAR AND WAIT A FEW MINUTES. FORD HAS A SAFETY ISSUE WITH THIS THROTTLE BODY ASSEMBLY. MINE HAS BEEN REPLACED TWICE. CAR IS IN THE SHOP FOR THE THIRD TIME FOR THE SAME PROBLEM. *TR

Mileage: 68,000

AIR CONDITIONING COMPRESSOR LEAKING REFRIGERATE OIL, NOT POSSIBLE TO REPAIR, REPLACE COMPRESSOR. 2005 FORD FIVE HUNDRED 90,000 MILES. *TR

Mileage: 90,000

EXPERIENCED A SPARK PLUG BLOWOUT REQUIRING REPLACEMENT OF FRONT HEAD. REPAIR COST $2600. I UNDERSTAND THIS IS A PROBLEM ON FORD TRUCKS. I THINK FORD SHOULD INVESTIGATE WHY THIS OCCURS AND FIX IT! I'M LUCKY I DIDN'T EXPERIENCE A FIRE, THAT WOULD HAVE TOTALED THE CAR!

Mileage: 87,107

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT STATED THAT THE VEHICLE STALLED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, TURNED IT OFF AND RESTARTED IT. ONCE THE VEHICLE WAS RESTARTED, IT BEGAN TO JERK WHEN ACCELERATED. THE CONTACT STATED THAT AT TIMES WHEN THE VEHICLE WAS STOPPED AT A TRAFFIC LIGHT, IT WOULD ACCELERATE SLOWLY UPON TAKE-OFF. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO LUBRICATED A COMPONENT (THE CONTACT WAS UNSURE OF WHAT COMPONENT) BUT THE FAILURE CONTINUED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 80,000. UPDATED 03/24/11*LJ UPDATED 05/23/11

Mileage: 60,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHEN DRIVING AT ANY SPEED, THE VEHICLE WOULD INTERMITTENTLY DISPLAY A FAIL SAFE MODE MESSAGE ON THE DASHBOARD. THE VEHICLE WOULD THEN STALL ONCE THE MESSAGE WAS DISPLAYED AND WOULD NOT RESTART. THE VEHICLE WOULD THEN BE TOWED TO AN AUTHORIZED DEALER WHERE THEY WERE ALWAYS UNABLE TO DIAGNOSE THE FAILURE. THE ECU WAS REPLACED APPROXIMATELY THREE TIMES BUT THE FAILURE PERSISTED. THE CONTACT ALSO STATED THAT WHILE IN PARK, THE VEHICLE WOULD ATTEMPT TO ACCELERATE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 82,000.

Mileage: 70,000

I FILLED THIS IN ALREADY. THE CONSUMER STATED HE EXPERIENCED AN ENGINE FAIL SAFE MODE PROBLEM. UPDATED 01/28/11. *TR

I TOOK MY 2005 FORD FIVE HUNDRED SEL IN FOR A SCHEDULED OIL CHANGE A COUPLE OF WEEKS AGO AND WAS INFORMED BY THE MECHANIC THAT THE TORQUE STRUT MOUNT, ALSO KNOWN AS THE TOP MOTOR MOUNT WAS BROKEN. PRICE TO REPAIR IS $619. AFTER DOING MORE EXTENSIVE RESEARCH, I HAVE FOUND OUT THAT THIS IS APPARENTLY A DEALER KNOWN PROBLEM WITH THESE PARTICULAR CARS! SO, WHY DOESN'T FORD MOTOR COMPANY ISSUE A RECALL TO FIX THESE FAULTY PARTS INSTEAD OF MAKING CONSUMERS PAY THESE RIDICULOUS REPAIR BILLS??! *TR

Mileage: 50,000

WHILE REVERSING MY CAR IT WILL ALL OF A SUDDEN ACCELERATE QUICKLY ON ITS OWN, I IMMEDIATELY STEP ON THE BRAKES AND MY CAR STALLS. ON THE DASH BOARD "FAIL SAFE ENGINE MODE" APPEARS ON MY CONSOLE. THIS HAS HAPPENED ABOUT 7 TIMES NOW. *TR

Mileage: 30,000

OUR CAR STALLS WHILE DRIVING. IT OFTEN HAPPENS ON THE HIGHWAY, BUT ALSO ON RESIDENTIAL STREETS AND AT ALL SPEEDS. THE CAR WILL LURCH FORWARD, THE LIGHTS ON THE DASHBOARD WILL ALL LIGHT UP, AND THEN THE ENGINE WILL SHUT DOWN CAUSING US TO HAVE TO SHIFT INTO NEUTRAL AND TRY TO PULL OVER TO SAFETY. WHEN WE TRY TO RESTART THE CAR IT WILL SPUTTER AND DIE AGAIN. OCCASIONALLY WE WILL BE ABLE TO GET IT TO A PARKING LOT, WE HAVE HAD TO BE TOWED HOME. WE HAVE REPLACED THE FUEL PUMP AND SPARK PLUGS. THE FORD DEALERSHIP DROVE IT AND RAN DIAGNOSTICS ON IT FOR WEEKS AT A TIME AND FOUND NOTHING TO TELL THEM ANYTHING. THIS HAS BEEN HAPPENING EVERY WEEK OR SO FOR NEARLY A YEAR, AND NO ONE CAN TELL US WHAT'S WRONG. THERE ARE TIMES WHEN IT HAPPENS EVERY DAY, AND THERE ARE TIMES WHEN IT DOESN'T HAPPEN FOR A MONTH. MANY PEOPLE'S DESCRIPTION OF A DEFECTIVE TRANSMISSION BODY MATCHES OUR DESCRIPTION, BUT THAT PART IS, APPARENTLY, ON BACKORDER. THE CAR IS ESSENTIALLY UN-DRIVABLE, BECAUSE WE CANNOT COUNT ON IT TO GET TO US WORK ON TIME OR SAFELY. *TR

Mileage: 70,000

FORD FIVE HUNDRED (500). FAIL SAFE ENGINE MODE COMES ON AND ENGINE " SHUTS DOWN" HAVE TO PULL OVER AND RESTART CAR. IT SEEMS THAT IT DOESN'T WANT TO ACCELERATE WHEN YOU WANT, BUT DOES WHEN YOU DON'T WANT TO. SERIOUS SAFETY ISSUE. I HAD THROTTLE BODY "CLEANED" HOWEVER, CAR STILL IS NOT PERFORMING AS IT SHOULD. ON TOP OF THAT I HAD IT SERVICED, OIL CHANGE AND TUNE UP, AND I AM STILL HAVE PROBLEMS. PROBLEM STILL IS NOT CORRECTED. *TR

Mileage: 110,500

70 DEGREE AIR BLOWING AT IDLE AND LOW SPEED. LOWERS TO 62 DEGREES AT HIGHWAY SPEED. NO CONDENSATION DRAINING THRU CONDENSATE TUBE. REFRIGERENT EVACUATED AND SYSTEM CHARGED WITH FRESH 134. *TR

Mileage: 40,100

2005 FORD 500 HAS ISSUE WITH LUNGING WHEN PUT INTO GEAR. CAR STARTED TO STALL CHECK ENGINE LIGHT AND THROTTLE LIGHT CAME ON TOOK IT IN NO ONE KNEW WHAT THE CODE WAS. FINALLY FOUND OUT IT WAS THE THROTTLE BODY NEEDED TO BE REPLACED. THIS ISSUE IS HAPPENING ALOT ON THE FIVE HUNDREDS. PART IS ON BACK ORDER AS OF TODAY OVER 700 ARE ON BACKORDER SOME FOR 5 MONTHS FORD SHOULD BE HELD ACCOUNTABLE FOR THIS AND PAY FOR RENTAL CARS FOR PEOPLE WHO ARE PUT OUT. *TR

Mileage: 147,000

MY FORD FIVE HUNDRED SEL HAS REALLY BEEN A PROBLEM FROM DAY ONE,HOWEVER,THE PROBLEM NOW IS GET EITHER THE CHECK ENGINE LIGHT AND THE FAIL SAFE MODE TOGETHER.THIS CAR HAS BEEN IN THE SHOP SO MANY TIMES WITHIN THE LAST THREE YEARS UNTIL NOTHING SHOULD BE WRONG WITH IT. *TR

2005 FORD 500 WITH APPROX. 85,000 MILES LURCHES FORWARD OR IN REVERSE WITHOUT PRESSING THE ACCELERATOR AFTER PERIOD OF IDLE SUCH AS AT A RED LIGHT OR IN LINE AT A DRIVE THROUGH RESTAURANT. THE LURCH IS SIGNIFICANT, VIOLENT ENOUGH TO MAKE PASSENGER THINK THEY WERE HIT FROM BEHIND. I NARROWLY AVOIDED COLLISIONS WITH CARS IN FRONT OR BEHIND ME. DEALER INFORMED ME THAT IT WAS CAUSED BY A DEFECTIVE THROTTLE BODY. PARTS TO REPAIR ARE BACK ORDERED WITH A 2 MONTH WAIT AND A COST OF $500.00. THIS IS NO LONGER COVERED BY WARRANTY OR EXTENDED WARRANTY. THIS DEFECT IS DANGEROUS. *TR

Mileage: 85,000

THE ENGINE SURGES WHEN I PUT MY CAR IN REVERSE. IT REV'S UP SOMETIMES IN FORWARD BUT HE ENGINE WILL QUICKLY DIE. IT GOES INTO FAIL SAFE MODE AND ONLY GOES AT A VERY LOW SPEED. *TR

Mileage: 63,000

IN MY 2005 FORD FIVE HUNDRED SEDAN, THE COMPRESSOR FOR THE AIR CONDITIONING DOES NOT WORK PROPERLY. THE AIR COMPRESSOR WILL NOT COOL THE CAR UNLESS YOU ARE DRIVING AT OR ABOVE HIGHWAY SPEED. WHEN SITTING AT IDLE OR DRIVING AROUND TOWN, AIR CONDITIONING SYSTEM WILL BLOW HOT AIR INSTEAD OF COLD. THE COMPRESSOR MUST BE REPLACED IN ORDER FOR AIR CONDITIONING SYSTEM TO WORK PROPERLY. SEEMS TO BE A VERY COMMON PROBLEM WITH 2005 AND 2006 FORD FIVE HUNDRED SEDANS. *TR

Mileage: 29,000

FORD 500 2005 - 74K MILES....CAR STARTED JERKING FORWARD AS SOON AS I LIFT MY FOOT OFF THE BRAKE,WHICH HAS ALMOST CAUSED ME TO RUN INTO THINGS IN A PARKING LOT FULL OF CARS. THE SENSORS WENT OUT,WHICH I WASN'T AWARE OF UNTIL I BACKED INTO A TREE WITHOUT WARNING. NOW THE AIR CONDITIONING HAS GONE OUT AND IT SEEMS MY CAR IS NOT THE ONLY ONE WITH THESE PROBLEMS. *TR

Mileage: 70,000

MY 2005 FORD FIVE HUNDRED HAS BEEN A VERY DEPENDABLE VEHICLE, EXCEPT WHEN THE COMPRESSOR WENT OUT. AFTER DOING MUCH RESEARCH, IT SEEMS THAT I AM NOT THE ONLY ONE WITH THIS ISSUE. FORD SHOULD DO THE RIGHT THING AND REPAIR THE COMPRESSORS ON THE FORD FIVE HUNDREDS BECAUSE IT IS A VERY HIGH SAFETY CONCERN. I HAVE HAD TO DRIVE AROUND WITH NO AIR BECAUSE I CANNOT AFFORD THE REPAIR ON TOP OF THE MONTHLY PAYMENTS FOR THE CAR. IF I HAD KNOWN THAT THERE WAS AN ISSUE WITH THE COMPRESSOR GOING OUT, AND A $1200 BILL TO ENSUE, I WOULD HAVE RECONSIDERED BUYING THIS VEHICLE. ALL THE FORD FIVE HUNDRED DRIVERS, INCLUDING ME, NEED HELP ON THIS ACROSS THE BOARD REPAIR. IT IS OBVIOUSLY A MANUFACTURING ERROR AND SHOULD BE MADE RIGHT BY FORD. *TR

Mileage: 102,638

THE CAR WOULD GO INTO "FAIL SAFE ENGINE MODE." I COULD NOT ACCELERATE. THIS HAPPENED SEVERAL TIMES ON THE HIGHWAY PUTTING MY LIFE AND THE LIFE OF MY FAMILY IN JEOPARDY. I SUDDENLY HAD NO POWER AT 65 MPH. I BROUGHT IT TO A FORD DEALER AND MECHANIC WHO RAN THE SYSTEM ON THE COMPUTER SPECULATING IT WAS THE THROTTLE BODY BY CLEARED DATA SO THEY COULD GATHER MORE INFORMATION. THESE COMPUTER CHECKS (3 OF THEM) COST ME MORE THAN $420.00. THEN I WAS TOLD THAT THE THROTTLE BODY WAS INDEED FAULTY. THE REPAIR COST ME $947.98 TO FIX. THE MECHANIC TOLD ME THIS SHOULD BE A FORD RECALL. HE ALSO SAID HE WOULDN'T BE SURPRISED IF IT DIDN'T TURN INTO A CLASS ACTION LAWSUIT BECAUSE THE PROBLEM IS SO COMMON. A SIMPLE GOOGLE SEARCH SHOWS HOW PREVALENT THIS PROBLEM IS. *TR

Mileage: 83,228

NO SPECIFIC EVENTS LEANING TO FAILURE, INTERMITTENT. THE FAILURE OCCURRED INTERMITTENTLY OVER THE LAST FEW WEEKS, WHILE DRIVING CAR GOES INTO THE ENGINE FAIL SAFE MODE, TRYING TO DRIVE THE CAR IS RATHER DANGEROUS, CAR STALLS,WON'T GO, THEN SUDDENLY TAKES OFF. TOOK CAR TO DEALERSHIP TOLD, THROTTLE BODY BAD AND THE PART IS BACK ORDERED (THE #3 MOST BACK ORDERED PART OUT OF 500). *TR

Mileage: 28,800

I HAVE A 2005 FORD FIVE HUNDRED LIMITED THAT SHUTS OFF THE ENGINE WITH A SAFE ENGINE MODE. THE OBDII SHOWS A P2111 CODE THAT THE THROTTLE IS STUCK OPEN. IS THERE ANY RECALL TO THIS CONCERN. *TR

Mileage: 60,945

I HAVE A 2005 FORD FIVE HUNDRED AND AS I WAS DRIVING UP THE GRAPE VINE IN CALIFORNIA THE TRANSMISSION STARTED BUCKING, AND KICKED IN TO NEUTRAL, I ALMOST GOT RAN OFF THE HIGHWAY AT A COUPLE THOUSAND FEET ELEVATION BY A SEMI BECAUSE THE VEHICLE WOULD NOT GO. I HAD TO LEAVE THE VEHICLE THERE WHICH IS 8 HOURS FROM WHERE WE RESIDE IN ARIZONA. *TR

Mileage: 97,400

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE APPROACHING A STOP SIGN, THE VEHICLE WOULD NO LONGER GO FORWARD. THE VEHICLE WOULD ONLY MOVE IN REVERSE. THE CONTACT WAS CLOSE TO HER RESIDENCE AND DROVE THERE IN REVERSE. THE VEHICLE WAS TOWED TO THE DEALER AND THEY CHECKED THE FLUID LEVELS AND THE TRANSMISSION LIGHT. A DIAGNOSTIC WAS PERFORMED AND THE PCM AND TCM WERE REPROGRAMMED. IN APRIL OF 2008, THE VEHICLE HESITATED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO A SERVICE CENTER FOR ANOTHER DIAGNOSTIC AND WAS CHARGED OVER $500. THE CURRENT MILEAGE WAS APPROXIMATELY 17,000 AND FAILURE MILEAGE WAS APPROXIMATELY 4,000. UPDATED 07/15/08. *LJ UPDATED 07/15/08

Mileage: 4,000

ENGINE BEGAN TO LOSE POWER WHILE DRIVING IN THE CITY(SURGING). CHECK ENGINE LIGHT CAME ON. JUST BEFORE GETTING HOME THE ENGINE BACKFIRED THROUGH THE TAILPIPE(TWICE) THE CAR STALLED AND HAD TO BE TOWED TO THE DEALER. UPON INVESTIGATION IT WAS FOUND THAT THE ENGINE HAD BLOWN UP. AN EXHAUST VALVE HEAD AND THE REMAINS OF THE PISTON WERE FOUND IN THE OIL PAN. A NEW 3 LITRE DURATECH ENGINE IS GOING TO BE ORDERED UNDER WARRANTY TO REPLACE THE BROKEN ONE. *TR

Mileage: 34,086

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING 65 MPH, THE VEHICLE STALLED ON THE HIGHWAY. THE CONTACT WAS ABLE TO PULL OFF THE ROAD. ON JULY 11, 2007, THE DEALER PERFORMED A DIAGNOSTIC TEST. THE VEHICLE WAS RETURNED ONE WEEK LATER. THE FAILURE RECURRED ON JULY 17, AUGUST 31, SEPTEMBER 25, OCTOBER 3, NOVEMBER 2, AND DECEMBER 18. THE DEALER DID NOT RETURN THE VEHICLE UNTIL FEBRUARY 23,2008. THE DEALER WAS ABLE TO DUPLICATE THE FAILURE ONCE THE VEHICLE WAS RETURNED. THE CONTACT EXPERIENCED THE FAILURE AGAIN AND THE DEALER PICKED UP THE VEHICLE ON MARCH 20, 2008. THE DEALER REPLACED THE INSTRUMENT PANEL. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 31,058.

Mileage: 31,058

WAS DRIVING IN TOWN ON TUESDAY MORNING AND MY FORD 500 (2005) SHUT DOWN AND THE MESSAGE FAILSAFE ENGINE MODE CAME ON ALONG WITH A WRENCH. THIS COULD HAVE BEEN POTENTIALLY DANGEROUS, I WAS FORTUNATE THAT THIS OCCURRENCE HAPPENED WHEN THERE WAS NOT A LOT OF TRAFFIC ON THE ROAD. CAR IS NOW IMMOVABLE AND WAITING TO BE TOWED IN TO DEALERSHIP. *TR

Mileage: 60,300

PURCHASED MY 500 9/05 IT ONLY HAD 5 MILES ON IT. 6 MONTHS LATER LOUD EXPLOSION IN ENGINE WHICH BEGAN TO LEAK SOME SORT OF FLUID GOT THE CAR TOWED TO DEALER PURCHASED WAS TOLD A/C LEAKING OIL AND THEY HAD TO REPLACE THE MANIFOLD I WASN'T EVEN USING THE A/C WAS MARCH!!! MY DASH CONSOLE HAD TO BE REPLACED SINCE IT WAS DEFECTIVE AND THE COMPUTER ALSO HAD TO BE REPROGRAMMED SINCE THE CAR WOULDN'T START IN 30 DEGREE WEATHER THIS HAPPENED IN JAN06......MY FUEL STRAPS WERE REPLACED DUE TO RECALL AND MY DOOR LOCKS WERE REPLACED DUE TO RECALL AND I HAD 22K MILES WHEN THE BACK BRAKES BEGAN MAKING A TERRIBLE GRINDING NOISE WHEN BACKING UP TOOK TO DEALER SAID THAT ALTHOUGH CAR IS UNDER WARRANTY BRAKES ARE UNDER WEAR AND TEAR AND WOULD NOT BE COVERED NOW WHICH DIDN'T MAKE ANY SENSE SINCE THE FRONT BRAKES WERE GOOD HOW COULD BACK BRAKES GO BAD BEFORE FRONT BRAKES UNLESS YOU ONLY DRIVE YOUR CAR IN REVERSE????? I PAID THE $400 TO FIX SINCE WAS INFORMED 500 ROTORS CANT BE TURNED EVER WILL ALWAYS HAVE TO PURCHASE NEW ONES......THEN 6 MONTHS LATER BRAKES WERE RECALLED AND I DID REQUEST REFUND WHICH I DID RECEIVE. HOWEVER I NOW HAVE 44K NO LONGER HAVE WARRANTY SINCE EXPIRED AND I DIDN'T BUY EXTENDED WARRANTY BROUGHT CAR IN TO FORD SINCE TRANSMISSION LIGHT WAS TURNING ON AND OFF ALONG WITH THE TRACTION CONTROL LIGHT THEN HAD TRANS CENSOR REPLACED WAS TOLD THAT WAS PROBLEM THEN 2 DAYS LATER LIGHT STILL TURNING ON AND CAR WILL NOT REVERSE TOOK INTO DEALER AGAIN WAS TOLD TRANS AXLE BROKE IN HALF AND NEED NEW TRANS WHICH COSTS $5300 CAR IS ONLY WORK 9K!!!! FORD COMPANY SAID THEY WILL OFFER ASSISTANCE ONLY OF 3K SINCE OUT OF WARRANTY THEY ALSO INFORMED ME THAT HAD I PURCHASED THE EXTENDED WARRANTY I WOULD ONLY BE PAYING $100 NOTHING LIKE THROWING THAT IN YOUR FACE. I HAVE NO CHOICE BUT TO PAY IT NEED A CAR AND AM A SINGLE PARENT OF 2. ALSO BACK DOORS TRIM IS COMING APART PASSENGER SINCE IS COMPLETELY ROTTED OUT. *TR

Mileage: 44,444

I WAS DRIVING MY 2005 FORD FIVE HUNDRED TO WORK AND THE "FAIL SAFE MODE" MESSAGE CAME ON AND THE WRENCH LIT UP. THE ENGINE STARTS TO DIE AND THE CAR STARTS LURCHING FORWARD. I PULLED OVER, SHUT THE CAR OFF. WHEN I STARTED IT BACK UP, IT RAN FINE. I CALLED THE DEALER WHO SAID THEY WOULD NEED TO HAVE ME BRING THE CAR IN SO THEY CAN LOOK INTO IT. FORD HAS NO BULLETINS ON THIS - THIS SHOULD BE A RECALL. AS I RESEARCH ONLINE, THIS HAS HAPPENED TO MANY FORD VEHICLES, NOT JUST THE FIVE HUNDRED. *TR

OIL LIFE DIAGNOSTIC MESSAGE CONTINUES TO REPORT ZERO PERCENTAGE LIFE REMAINING. *JB

Mileage: 750

CONSUMER 2005 FORD 500 DOOR CAME OPEN WHILE DRIVING. *TS WATER LEAKED INTO THE VEHICLE FROM THE DOORS. THE DEALER REPLACED BOTH FRONT DOOR LATCHES AND NEW WATER CANELS. THE DASH HAD A BUBBLE IN THE LEATHER AND THE DEALER REPLACED IT. THE MOLDING WAS COMING OFF THE VEHICLE. THE VEHICLE WOULD NOT START ON ONE OCCASION. *NM

Mileage: 6,947

DT: CONSUMER SAID THAT THE ENGINE FAILED AND CAUSED A SAFETY PROBLEM. THE VEHICLE LOST POWER WHEN PRESSING THE ACCELERATOR. THIS HAPPENED FOR A MONTH BUT HAS BEEN INTERMITTENT. THE ENGINE FELT LIKE IT WAS SKIPPING. THE SPEED THAT THE VEHICLE WAS TRAVELING WAS NOT A FACTOR NOR WERE THE ROAD CONDITIONS. THE CONSUMER TOOK VEHICLE TO DEALERSHIP TWICE BUT THE PROBLEM RECURRED. THE MANUFACTURER HAS NOT BEEN CONTACTED. THE DEALERSHIP SUGGESTED THAT THE PROBLEM COULD BE A COMPUTER RELATED ISSUE. THE OWNER HAD THE BLACK BOX INSTALLED IN THE VEHICLE AND TURNED IT OVER TO THE DEALERSHIP THIS MORNING. THE PROBLEM HAS STILL NOT BEEN RESOLVED. OWNER IS TAKING THE VEHICLE BACK TO DEALER NEXT WEEK FOR ADDITIONAL TESTING. *AK

Mileage: 5,000

VEHICHLE CONSISTENTLY FAILS TO START ON THE FIRST TRY. HARD STARTS, DIESELING, AND STALLING ARE CONSTANT.*AK

Mileage: 1,500