2005 FORD FIVE HUNDRED Power Train Problems

The contact owns a 2005 Ford Five Hundred. The contact stated that while driving at various speeds, the vehicle made an abnormal knocking sound. The vehicle was taken to two independent mechanics, where the flywheel was replaced twice with used parts because the part had been discontinued. The contact stated that while her son was driving approximately 20 MPH, the vehicle stalled. The check transmission warning light, the check engine warning light, and other unknown warning lights were illuminated. The driver was able to pull over to the side of the road. The vehicle was able to restart but was undrivable. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 80,000.

Mileage: 80,000

While waiting at the light in traffic, my car all of a sudden Accelerated, and decelerates, I have to push hard on the breaks in order for it to not slam into the cars infront of me.. this is really dangerous, from what I have been reading this is a wide spread issue that ford has ignored for years..

I PURCHASED THE CAR USED WITH THE UNDERSTANDING THAT IT HAD SOME ISSUES WITH A MISFIRE. UPON INITIAL INSPECTION I FOUNT THE CAR WAS THROWING THE CODE P0351 I CLEARED ALL FAULTS AND PROBLEM WENT AWAY WEKS WENT BY AND PROBLEM STARTED AGAIN BUT MORE SEVER DURING NORMAL OPERATION THE CAR STARTED SHAKING AND SHIFTING ERRATIC I THEN CAME UPON SOME K FORMATION AS TO A RECALL FORD PUT IN PLACE STATING IMPROPER CALIBRATION OF PCM AND TCM CAUSE UNNECESSARY INTERACTION I THE ELECTRICAL SYSTEM AND MALFUNCTION OF THE VEHICLE

Mileage: 237,232

TRANSMISSION HAS VERY HARD AND DELAYED UPSHIFT AND DOWNSHIFT MAKING IT DIFFICULT TO CONTROL SPEED WHEN ACCELERATING AND DECELERATING. RPM GETS STUCK AROUND 3000 AT LOWER SPEEDS AND UPON ENGAGING INTO GEAR HAS MADE MY TIRES SQUAWK WITH A SUDDEN LUNGE IN SPEED AND SAME PROBLEM WHEN TRYING TO STOP, THE CAR LUNGES FORWARD. IT ACTS AS THOUGH IT IS IN NEUTRAL BUT THEN WHEN IT ENGAGES INTO GEAR SUDDEN CHANGES IN SPEED OCCUR CAUSING RAPID ACCELERATION OR DECELERATION. THE PROBLEM GETS WORSE AFTER THE CAR IS UP TO NORMAL OPERATING TEMPERATURE. IT DOESN'T OCCUR AS OFTEN AT COLDER OPERATING TEMPERATURE. THIS PROBLEM MAKES IT DIFFICULT TO GET BACK UP TO SAFE HIGHWAY SPEEDS AFTER HAVING TO STOP FOR TRAFFIC OR RED LIGHTS AS WELL AS HARD TO GET UP TO SPEED TO SAFELY MERGE INTO TRAFFIC FROM AN ON RAMP. AS FAR AS "WHEN" THIS HAPPENED IT IS EVERY DAY AS I DRIVE DAILY.

Mileage: 226,768

RECEIVED A CODE STATING THAT I HAVE A FAULTY PCM. WHEN I DRIVE ALL THE LIGHTS COME ON AND THE SPEED GAUGE SHUTS DOWN.

Mileage: 266,000

(ETB) ELECTRONIC THROTTLE BODY ON MY CAR CAUSES AN ACCELERATION THAT MAKES THE CAR JERK FORWARD. I'VE ALMOST HIT A WALL, AND GOD FORBID THIS HAPPENS ON THE HIGHWAY I COULD CAUSE AN ACCIDENT. ITS UNSAFE AND SHOULD BE RECALLED. POOR DESIGN I GUESS BUT IT'S NOT WORTH MY LIFE. THIS HAPPENED WHILE IDLING IN DRIVE THRU WHEN I TRIED TO GO FORWARD IT IDLED REALLY HIGH THEN DROPPED DOWN. WOULD BOT ACCELERATE AFTERWARDS.

Mileage: 270,453

I STOPPED ON A CITY STREET AT STOP SIGN. AS I TRIED TO ACCELERATE, BUT THE CAR WOULD BARELY MOVE. THE THROTTLE CONTROL/TRANSMISSION WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. I TURNED THE CAR OFF AND LET IT SIT FOR ABOUT 2 TO 3 MINUTES. I STARTED THE CAR UP AND WAS ABLE TO MAKE IT HOME. I AM THANKFUL THAT THIS HAPPEN ON CITY STREET AND NOT ON THE HIGHWAY. I PLAN ON CONTACTING MY FORD DEALER TOMORROW.

Mileage: 86,921

BOUGHT THE VEHICLE USED IN MAY 2010. REALIZED EARLY-ON THAT THE TRANSMISSION WAS NOT SMOOTH, BUT WILLING TO SETTLE FOR LESS THAN PERFECTION SINCE IT WAS A 2005 VEHICLE. IN LATE 2012 OR EARLY 2013, I RECEIVED 'RECALL' NOTICE THAT PCM (I.E. - POWERTRAIN CONTROL MODULE) COULD NEED TO BE REPROGRAMMED DUE TO STALLING, HERKY-JERKY TRANSMISSION, ETC. TOOK CAR TO DEALERSHIP, THEY RAN DIAGNOSTICS, CHARGED ME $100, AND TOLD ME THAT MY CAR WASN'T EFFECTED BECAUSE NO ERROR CODES WERE NOTED AND CHECK ENGINE LIGHT WASN'T ON. I WAS NOT HAPPY, AND REFUSED TO TAKE MY CAR TO THE DEALERSHIP FOR REPAIR. PROBLEM PERSISTED, UNTIL CHECK ENGINE LIGHT CAME ON IN OCTOBER 2017 AT ROUGHLY 125,000 MILES. TOOK TO LOCAL MECHANIC, WAS CHARGED $150 FOR SENSOR REPLACEMENT. LIGHT CAME BACK ON A DAY LATER. TOOK BACK, REPLACED SENSOR FOR FREE (NICE!), BUT LIGHT BACK ON A DAY LATER. TOOK TO A DIFFERENT MECHANIC, WAS CHARGED $250, REPLACED MULTIPLE SENSORS, LIGHT BACK ON THE NEXT DAY. TOOK BACK TO 2ND MECHANIC, WHEN THEY SHARED WITH ME THAT IT WAS LIKELY THE PCM AND THE DEALERSHIP WOULD NEED TO FIX. CALLED DEALERSHIP 3 DAYS IN A ROW, ON HOLD FOR NEARLY AN HOUR THE 3RD TIME, WAS NEVER CONNECTED TO A SERVICE WRITER OR TECH, LEFT 3 VOICE MAILS FOR SERVICE MANAGER AND WAS NEVER CALLED BACK. RESEARCHED ISSUE AND FOUND NHTSA ACTION NUMBER PE11018, WHERE FORD INITIATED A CUSTOMER SATISFACTION PROGRAM 12N03 TO EXTEND COVERAGE TERMS OF REPAIR OF ENGINE IDLE RPM SURGE CAUSED BY PCM NEEDING REPROGRAMMING WITH SOFTWARE CONTAINING UPDATED IDLE SPEED CONTROL. PER NHTSA, SYMPTOMS ASSOCIATED WITH THE CONDITION MAY INCLUDE CHECK ENGINE LIGHT, DIAGNOSTIC CODES (DTCS) P0505, P0506, OR P061B. FORD ISSUED BULLETIN TSB 11-10-21 THAT INCLUDED UPDATED POWERTRAIN CONTROL CALIBRATION.

Mileage: 100,000

HARSH AND DELAYED SHIFTING. LUNGES FORWARD WHEN IN DRIVE AT STOP EVEN WITH FOOT ON BRAKE, SAME IN REVERSE. CAR SHIFTS FINE FOR FIRST 20-30 MINUTES THEN STARTS TO SHIFT HARD UP AND DOWN... SEEMS TO GET WORSE AS CAR GETS WARMER

Mileage: 80,000

AT LOW SPEEDS, WHEN TURNING AND WHEN ACCELERATING FROM A STOP, THE CAR WILL SHAKE, LUNGE AND THEN SHUT OFF. SOMETIMES IT JUST SHAKES AND HESITATES AND THEN KEEPS GOING. SOMETIMES IT TAKES A WHILE TO GET IT RUNNING AGAIN. IT ALWAYS HAPPENS WHEN THE CAR IS IN MOTION. A COUPLE OF TIMES THIS HAPPENED, THE TRANSMISSION ERROR CODES WERE DISPLAYED. I HAVE HAD THE TRANSMISSION CHECKED OUT AND IT WAS FINE.

Mileage: 130,000

FRONT DRIVER SIDE LOWER CONTROL ARM BALL JOINT SHEARED OFF AT 25 MPH WHILE MAKING A LEFT HAND TURN AND THEN SNAPPED THE CV JOINT AXLE SHAFT CAUSING THE DRIVER SIDE WHEEL TO JAM INSIDE THE WHEEL WELL AND DAMAGE LOWER PART OF BODY AND FENDER. THE VEHICL WAS TOTALLY DISABLE AT THIS POINT SITTING IN THE MIDDLE OF AN INTERSECTION. SIMILAR INCIDENT HAPPENED TWO YEARS AGO WITH THE PASSENGER SIDE FRONT WHEEL AND THE LOWER CONTROL ARM BALL JOINT SHEARED AND SNAPPED THE CV JOINT AXLE SHAFT AT 45 MPH AND CAUSED VEHICLE TO TURN 180 DEGREES BLOCKING TWO LANES OF HWY. THAT TIME FRONT WHEEL DAMAGED WHEEL WELL AND SENSOR WIRES ON THAT SIDE FO THE ENGINE BAY

Mileage: 295,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING VARIOUS SPEEDS, IT WAS DIFFICULT TO SHIFT GEARS. THE CONTACT DID NOT NOTICE IF ANY WARNING INDICATORS WERE ILLUMINATED. A MECHANIC DETERMINED THAT THE TRANSMISSION FAILED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 145,753.

Mileage: 145,753

THE TRANSMISSION DISENGAGES AT VARIOUS SPEEDS EVEN ON THE INTERSTATE AT 55+ MPH CAUSING IT TO LOSE POWER. YOU MUST BE ABLE TO GET IT STOPPED ON THE SIDE OF THE ROAD AND SHUT THE CAR OFF AND THEN RESTART IT TO CORRECT THE PROBLEM FOR A SHORT PERIOD OF TIME.

Mileage: 188,000

I OWN A 2005 FORD FIVE HUNDRED CVT. 2 MONTHS AGO THE TRANSMISSION BEGAN ACTING UP. DRIVING ALONG AND THE "WRENCH" LITE COMES ON THEN THE "SKID" LITE COMES ON. THE CAR GOES INTO A LOSS OF POWER, LIKE LOW GEAR. IT MOVED BUT REVS UP AND WON'T SHIFTS UP. I KNOW ITS A CONSTANT VELOCITY TRANS SO IT IS AT IT'S LOWER RATIO. AFTER HOURS OF DIAGNOSTIC IT COMES DOWN TO THE TRANS CONTROL MODULE, AND STILL NOT SURE. THE OBD CODES SAY LOSS OF COMMUNICATION, A U CODE. EVERY INCH OF HARNESS HAS BEEN CHECKED THE WHOLE INTERIOR HAS BEEN REMOVED, DASH DISASSEMBLED. I'M INTO IT OVER $2,000. I LOVE THE CAR, IT RIDES GREAT. ITS HAS BEEN WELL MAINTAINED. FORD I NEED HELP. NEED TO RECALL THIS ISSUE OR HOW ABOUT A P01 OR Z01 POLICY ADJUSTMENT.

Mileage: 141,000

LEAVING A GROCER AT 13:15 ON 9/7/2015 STARTED TO BACK OUT OF PARKING SPOT WHEN AUTO SUDDENLY ACCELERATED BACKWARD, ACROSS THE AISLE AND SLAMMED INTO PARKED VEHICLE WITH IMPACT SENDING THAT AUTO INTO A 3RD. DAMAGES TO BOTH VEHICLES. WHEN I WENT TO PULL INTO MY ORIGINAL SLOT TO DEAL WITH SITUATION, AS SOON AS I REMOVED FOOT FROM BRAKE, AUTO LUNGED FORWARD AT HIGH RATE OF SPEED, JUMPED A 6" LANDSCAPE CURB AND PLOWED INTO THE FRONT END OF A CADILLAC SRX CAUSING MAJOR DAMAGE TO THAT VEHICLE, STILL UNK TOTAL DAMAGE TO MINE. IT WAS A VERY HOT DAY AND THE AC WAS RUNNING. NO OTHER VEHICLES WERE OCCUPIED OTHER THAN MINE, AND I WAS SOLE OCCUPANT. MY AIRBAG DID NOT DEPLOY AND PASSENGER'S WAS NOT TURNED ON. I DID RECEIVE A SIGNIFICANT BRUISE ON MY STERNUM FROM THE SHOULDER COMPONENT OF MY SEAT BELT. MY FOOT WAS NOT ON THE ACCELERATOR FOR EITHER "LUNGE". CRASHES WERE WITNESSED AND PEORIA AZ POLICE DID RESPOND WITH 2 UNITS. OFFICERS DID TAKE INFORMATION, BUT WHEN I INQUIRED ABOUT INCIDENT # FOR MY RECORDS OFFICER RESPONDED THAT THERE WOULD BE NO REPORT AND NO CITATIONS AS IT OCCURRED ON PRIVATE PROPERTY. MY INSURANCE CARRIER WAS CONTACTED FROM SITE, BUT BEING A HOLIDAY, I WAS NOT ABLE TO SPEAK WITH ADJUSTER AT THAT TIME. KNOWING THAT IT WAS NOT MY ACTIONS THAT CAUSED THIS INCIDENT, I CHECKED THE NEXT DAY AND DISCOVERED THAT THIS IDENTICAL SITUATION HAD BEEN UNDER INVESTIGATION WITH NHTSA AT THE TIME I PURCHASED THE CAR ON OR ABOUT 11/16/12 AT WHICH A SERVICE PROGRAM TO RETIFY WAS IN EFFECT. WITH MY INCIDENT THOUGH, MAJOR DAMAGE OCCURRED. NEITHER AT THE TIME OF PURCHASE, NOR THROUGHOUT THE INVESTIGATION & TENURE OF MY OWNERSHIP (CURRENT) WAS I NOTIFIED OF THE KNOWN SAFETY PROBLEM NOR IT'S PROGRAM TO MITIGATE. ATTACHED AERIAL PHOTO SHOWS BACK TO BACK DIMENSION TO FIRST IMPACT AND BACK TO FRONT DIMENSION OF 2ND. I WAS PARKED IN POSITION OF WHITE VEHICLE.

Mileage: 82,700

THIS PROBLEM IS GOING FOR A WHILE, EVEN IN A STOP LIGHT, FOOT ON BRAKE PEDAL THE ENGINE ACCELERATE HIMSELF AND WHILE SHIFTING FROM PARK TO REVERSE OR DRIVE THE SOUND ON THE TRANSMISSION IS HARD. IT GO FROM 700 RPMS TO 1300 RPMS ON SECONDS, AND NOW IS WORSE. TOOK THE VEHICLE TO TWO FORD REPAIR DEALERS, AFTER PUTTING ON THE COMPUTER,BOTH WANTED TO CHARGE ME $6,000.00 ON A TRANSMISSION, EVEN KNOWING THE RECALLS ON THIS UNITS.THIS CAR LOOKS LIKE NEW I CAN SEND YOU PHOTOS, AND I LOVE MY CAR.

Mileage: 94,000

I WAS DRIVING DOWN THE ROAD 35MPH AT THE TIME AND ALL OF A SUDDEN MY CAR STOPS IN THE MIDDLE OF THE ROAD AND THE WRENCH LIGHT CAME ON. I HAD TO CUT THE CAR OFF THEN SIT FOR A FEW MINUTES THEN CRANK BACK UP. THE NEXT TIME I DROVE IT I WAS DRIVING 55 MPH AND THEN ALL OF A SUDDEN IT STOPPED WHILE I WAS DRIVING THE WRENCH LIGHT CAME ON AGAIN I WAS STUCK IN THE ROAD THEN AFTER A FEW MINUTES I WAS ABLE TO CRANK BACK UP. I DROVE THE CAR FOR A FEW WEEKS SO I DECIDED TO DRIVE HOME ONE DAY ON I-95 AS I WAS DRIVING IT STOPPED AGAIN WITH CRAZY TRAFFIC. AFTER THIS EPISODE WHEN I FINALLY MADE IT HOME I DECIDED TO PARK MY CAR FOR SEVERAL WEEKS UNTIL I CALLED FORD TO SEE IF THERE WAS A WARRANTY AND THEY TOLD ME TO BRING MY CAR TO BE REPAIRED ONLY TO BE TOLD IT WAS NOT UNDER WARRANTY AND IT WOULD COST ME $2000 TO GET MY CAR REPAIRED BECAUSE THERE WAS A ALSO A LEAK WHICH IS SUPPOSED TO BE UNDER RECALL. I'VE READ A LOT OF THINGS GOING ON WITH THIS CAR IN PARTICULAR THE 2005 FORD FIVE HUNDRED. I CALLED THE FORD 800 NUMBER THAT THE MECHANIC GAVE ME TO SEE IF THEY WOULD REPAIR THE THROTTLE FOR MY CAR THEY TOLD ME THAT ITS OVER THE MILEAGE WARRANTY AND THERE IS NOTHING THEY CAN DO AND THEY DIDN'T EVEN APOLOGIZE FOR MY INCONVENIENCES WHEN I WAS STOPPED ON THE ROAD, I AM CURRENTLY USING A BORROWED CAR BECAUSE I DON'T WANT TO PUT MY LIFE IN JEOPARDY DRIVING THIS CAR UNTIL I AM ABLE TO GET IT REPAIRED. *TR

Mileage: 156,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE FAILED TO SHIFT INTO GEAR AND BECAME INOPERABLE. THE FAILURE OCCURRED FIVE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 139,000.

Mileage: 139,000

TRAVELING DOWN THE INTERSTATE AT 75 MPH WE RECEIVED A MESSAGE ON THE MESSAGE CENTER ABOUT A FAILURE OF SOME SORT (I DON'T REMEMBER WHAT IT SAID EXACTLY NOW). WE LOST ALL ACCELERATION OF THE CAR. WE PULLED OVER AND LET IT SIT WHILE I LOOKED UP THE ERROR ON MY PHONE. I TRIED THE CAR A BIT LATER AND IT WAS FINE. THEN WE KEPT GETTING THE ERROR. I TOOK IT TO OUR FORD DEALER AND HE CLEANED THE THROTTLE BODY...THEN REPLACE IT A WEEK LATER WHEN THAT DIDN'T FIX IT. A ABOUT 2 WEEKS LATER WE WERE GETTING ANOTHER ERROR ABOUT THE TRANSMISSION FAILING. IT STARTED MAKING A TERRIBLE NOISE. I STILL OWE 3200 ON THIS CAR,,.AND A NEW TRANSMISSION IS OVER 7K. SERIOUSLY?? I HAVE READ SO MANY POSTS ABOUT THE CVT TRANSMISSION ON THE FIVE HUNDRED AND OTHER CARS FAILING. FORD SHOULD BE ASHAMED OF THEMSELVES FOR PASSING OFF SOMETHING LIKE THIS. NOW I HAVE A 3200.00 PAPER WEIGHT IN MY DRIVEWAY....AND I CANNOT AFFORD TO BUY ANOTHER CAR. THANKS FORD!! *TR

Mileage: 150,000

THROTTLE ASSEMBLY PROBLEM. VERY SIMILAR CONCERNS AS EARLIER RECALL WHICH SUPPOSEDLY APPLIED FIX TO THE CAR A COUPLE YEARS AGO. EXCEPT .ALONG WITH UNEXPECTED ACCELERATION WHILE STOPPED A NEW PROBLEM ARISES. MOTOR ACTS AS IF IT IS NOT GETTING FUEL AND SLOWS TO A CRAWL SPUTTERING TO A STOP.. WRENCH MALFUNCTION LIGHT COMES ON. AFTER CARS SITS FOR A PERIOD OF TIME WRENCH DISPLAY GOES OFF AND CAR OPERATES NORMALLY. OWNERS MANUAL INDICATES THAT THIS MAY BE A THROTTLE ASSEMBLY PROBLEM. PRIOR RECALL NOTICE THAT HAS EXPIRED. ON MULTIPLE WEB BOARDS PROBLEM IS MENTION WITH GREAT FREQUENCY FOR THE FORD 500. THIS HAPPENED TO MY WIFE ON A SIDE STREET AT 15-20 MPH. IF IT OCCURRED ON NEXT BUST STREET IT COULD HAVE PRESENTED A DANGEROUS SCENARIO. FORD DEALER ACKNOWLEDGED THIS AS A KNOWN PROBLEM, BUT FORD MFG ONLY PROVIDED 1 TIME FIX IN RECALL & SINCE THE THROTTLE CLEANING FIXED THE PROBLEM AT THE TIME OF RECALL NO FURTHER ATTENTION WAS NEEDED. I MENTIONED THEY DID EXTEND FOR RECURRING PROBLEM BUT THAT EXTENSION 2013. I DON'T FEEL A MFG SHOULD BE ABLE TO TIME LIMIT A PROBLEM RESOLUTION THAT THEY NEVER PERMANENTLY FIX. BY WHAT I READ ON THE WEB THIS IS AN ISSUE THAT NEEDS AREAL RESOLUTION.....COST ME 900+ DOLLARS TO FIX AND FORD NOTHING! *TR

Mileage: 163,000

2005 FORD FIVE HUNDRED THIS PRODUCT WITH A CVT TRANSMISSION SHOULD BE INVESTIGATED AND RECALLED IMMEDIATELY. THERE ARE THOUSANDS FAILING AND IT IS VERY DANGEROUS! THE TRANSMISSION DISENGAGES CAUSING THE AUTOMOBILE TO LOSE POWER WITHOUT WARNING. I'VE SEEN POSTS OF THOUSANDS OF THIS SAME FAILURE BEGINNING AT 3500 MILES! I CONTACTED FORD BECAUSE MINE IS DOING THIS AND THEY BASICALLY SENT A FORM LETTER SAYING OH WELL, SORRY ABOUT YOUR LUCK. MANY OF FORD'S PRODUCTS HAVE THIS SAME ISSUE WITH THE CVT TRANSMISSION INCLUDING THE FORD FLEX WHICH IS INVOLVED IN A CLASS ACTION LAWSUIT. THE FIVE HUNDRED SHOULD BE INVOLVED IN THIS LAWSUIT AS WELL. *JS

Mileage: 120,500

PART OF AN ONGOING SERIES OF ISSUES WITH THIS VEHICLE (SEE EARLIER REPORTS), INITIAL SYMPTOM WAS THE DASH LIGHTS & NEEDLES SHUTTING OFF INTERMITTENTLY (BUT NOW FOR EXTENDED PERIODS). VEHICLE THEN BEGAN SHOWING RANDOM WARNING LIGHTS INCLUDING "CHECK ENGINE", WHICH WAS DIAGNOSED FIRST TIME AS LOW FUEL LEVEL SENSORS A & B. SINCE THAT TIME I'D DISCONNECTED THE BATTERY ON A SUGGESTION OF A MECHANIC FRIEND AND ALL THE ISSUES DISAPPEARED FOR A FEW WEEKS. YESTERDAY THE CHECK ENGINE LIGHT CAME BACK, AND THE CAR WAS RUNNING POORLY (CREEPING WHEN FIRST OFF BRAKES, NOT UP SHIFTING), WHEN THE DASH WAS OPERABLE IT SHOWED ALTERNATING CHECK ENGINE/CHECK TRANSMISSION WARNINGS, AND VEHICLE WAS SURGING/LAGGING NOTICEABLY AT HIGHWAY SPEEDS. I AGAIN DID THE BATTERY DISCONNECT LAST NIGHT, AND THE CAR IS OPERATING NORMAL TODAY, BUT I'M SURE IT WILL RECUR SHORTLY. I AM HESITANT TO TAKE IT TO A DEALER AS THIS SOUNDS LIKE A SIGNIFICANT ELECTRONICS ISSUE, AND I HAVE ALREADY READ UP ON THE FORD TSB 06-17-9 THAT IS DOCUMENTED ONLINE, NOT ALL OF WHICH ALIGNS WITH MY ISSUES. HAD THE BATTERY RESET HAD NO IMPACT ON THE PROBLEMS I WOULD SAY IT'S A MECHANICAL MATTER, BUT IT SEEMS CLEAR ITS A COMPUTER OR ELECTRICAL ISSUE. *TR

Mileage: 36,000

ON THE INTERSTATE HEADED TOWARDS DENVER, AFTER ABOUT AN HOUR, WHEN TO ACCELERATE FROM ABOUT 70MPH TO ASCEND UP THE HILLS, THE ENGINE RPMS ACCELERATE, HOWEVER, IT FEELS THAT THE TRANSMISSION IS DISENGAGED (SLIPPING) WITH NO POWER TO THE DRIVETRAIN RESULTING IN A DRASTIC LOSS OF SPEED. THIS HAPPENED NUMEROUS TIMES IN EFFORTS TO REGAIN CONTROL AND MAINTAIN SPEED. THIS WAS EXTREMELY HAZARDOUS AS TRAFFIC WAS SOMEWHAT CONGESTED, AND OTHER DRIVERS ARE EXPECTING ME TO ACCELERATE, HOWEVER, VEHICLE WAS IN A DECELERATING MODE. THIS WAS ONLY WITH LIGHT PRESSURE TO THE ACCELERATOR. IT SOUNDED AS IF THE GEARS HAD STRIPPED IN THE TRANSMISSION. WE TURNED AROUND AND HEADED HOME, AUTO WOULD NOT ALLOW SPEEDS OVER 60MPH. LATER THE SAME HAPPENED AT SPEEDS OF 35-40 ON LOCAL ROADS. THESE TRANSMISSIONS ARE EXTREMELY DANGEROUS. FORD KNOWS OF THIS PROBLEM AND REFUSES TO DO ANYTHING ABOUT THEM. *JS

Mileage: 89,600

WHEN STOPPED AT RED LIGHT, CAR SHOOK A COUPLE TIMES THEN CHECK ENGINE LIGHT IMMEDIATELY CAME ON. WHEN RED LIGHT TURNED GREEN, TOOK FOOT OFF OF BRAKE AND PRESSED GAS PEDAL AND WAS UNABLE TO DRIVE, BUT CAR WAS STILL ON. THROTTLE BODY CONTROL SYSTEM FAILED AND NEEDS REPLACEMENT. *TR

Mileage: 96,651

APPROXIMATELY TWO MONTHS AFTER SERVICE PERFORMED UNDER NHTSA CAMPAIGN PE11018 THE VEHICLE BEGAN TO ACCELERATE IRREGULARLY AND THEN IT PLACED ITSELF INTO "FAIL SAFE" MODE AND ILLUMINATED THE CHECK ENGINE LIGHT. VEHICLE WAS RETURNED TO THE FORD DEALER THAT PERFORMED THE SERVICE AND THEY DETERMINED THAT THE ELECTRIC THROTTLE CONTROL WAS AT FAULT BUT WAS NOT ASSOCIATED WITH THE SERVICE THEY PERFORMED ON THE SAME COMPONENT JUST WEEKS EARLIER. DEALER CONTACTED FORD MOTOR CO AND THEY ALSO CLAIMED THE TWO WERE NOT RELATED REGARDLESS OF THE SIMILAR CLAIMS FOUND ONLINE. *TR

Mileage: 129,928

I HAVE TAKEN MY 2005 FORD 500 TO MY LOCAL FORD DEALER SO MANY TIMES I CAN NOT COUNT FOR THE SAME RECURRING ISSUES. THIS VEHICLE ALWAYS LUNGES WHEN I PUT IN GEAR IN REVERSE OR FORWARD. THE CAR LUNGED BACKWARD STRIKING A PARKED CAR THE FIRST WEEK I GOT IT. I PAID FOR ALL DAMAGE CAUSE I DIDN'T WANT TO CLAIM NEW CAR ON MY INSURANCE. WHILE DRIVING ON HIGHWAY ENGINE STARTS TO DECELERATE WHILE TRYING TO PASS CAR OR CHANGE LANES..BIG PROBLEM IN TRAFFIC..HAVE TO FLOOR IT TILL IT KICKS INTO GEAR. DANGEROUS. THEN, EVERYTIME IT RAINS, ALL 4 DOORS FILL WITH WATER..I HAVE TO LIFT UP RUBBER AT THE BOTTOM..CLEAR THE HOLES..WAIT FOR 5 MINUTES EACH DOOR. EVERY WINTER THE DRIVER SIDE DOOR LATCH FREEZES UP AND I CAN'T CLOSE THE DOOR..I THOUGHT THEY DEALER FIXED THE DOOR LATCH DUE TO A SAFETY RECALL..THAT IS NOT THE CASE..SEVERAL TIMES, I HAVE HAD TO DRIVE TO WORK 15 MINUTES HOLDING THE DOOR SHUT WHILE DRIVING DOWN THE HIGHWAY.DANGEROUS. I HAVE HAD IT LUBED WITH SEVERAL PRODUCTS, DOESN'T WORK..THE SERVICE MANAGER AT MY LOCAL FORD DEALER SHOWED ME HOW TO HOLD THE DOOR HANDLE OPEN WHILE USING A SCREWDRIVER TO FREE THE LATCH..HANDY LITTLE TRICK. I KEEP SILICONE LUBE SPRAY, SCREWDRIVER, PLIERS, AND A JUMPER BOX IN THE CAR AT ALL TIMES.I HAVE CALLED FORD MOTOR CO. MANY TIMES..ALWAYS GOT RUN AROUND AND NO STRAIGHT ANSWERS. FINALLY LAST WEEK AFTER CALLING 5 TIMES, I WAS TRANSFERRED TO A SUPERVISOR THAT EXPLAINED TO ME THAT THE OTHER 10 TIMES I CALLED.NO COMPLAINT WAS FILED AND INFORMED ME ON THE COMPLAINT PROCESS..I JUST PURCHASED A NEW TAURUS AND AM HOPING TO LET MY SON USE THE 500 TO DRIVE TO COLLEGE DAILY..I AM CONCERNED ABOUT HIS SAFETY IN THIS CAR..SO UNLESS THESE ISSUES ARE ADDRESSED AND CORRECTED, I DON'T KNOW WHAT TO DO..I HAVE PUT A LOT MONEY INTO THIS CAR.WHAT HAPPEN TO THE LEMON LAW. THIS CAR IS A LEMON. *TR

Mileage: 30,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE HESITATED WHILE DRIVING UPHILL AT 40 MPH . THE VEHICLE WAS TAKEN TO DEALER FOR INSPECTION BUT A CLEAR DIAGNOSIS WAS NOT GIVEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

Mileage: 55,000

WHEN I STARTED IT UP AND TRIED TO TAKE OFF IT STALLED OUT AND THE WRENCH LIGHT CAME ON. *TR

Mileage: 157,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT RECEIVED A SERVICE NOTICE FROM THE MANUFACTURER ABOUT A THROTTLE BODY REMEDY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND ROUTINE SERVICE. THE THROTTLE BODY WAS CLEANED BUT THE CONTACT STATED THAT THE VEHICLE BEGAN TO IDLE AT VARIOUS SPEEDS. THE CHECK ENGINE LAMP ILLUMINATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 51,000. UPDATED 01/07/2014*LJ THE CONSUMER STATED THE DURING THE TEST DRIVING THE VEHICLE IT WENT INTO FAIL SAFE MODE. THE TECH RESET THE LIGHT AND RETURNED THE VEHICLE. N THE WAY HOME THE VEHICLE WENT INTO FAIL SAFE MODE AGAIN ALMOST CAUSING AN ACCIDENT. UPDATED 01/22/2014 *JS

Mileage: 51,000

MY 2005 FORD 500 WHILE DRIVING 25 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS COASTED OFF ROAD AND RESTARTED, BUT NO POWER. THE VEHICLE WAS CHECKED WHERE IT WAS DIAGNOSED AS A THROTTLE BODY FAILURE. *JS

Mileage: 133,500

I BOUGHT THIS CAR A YEAR AGO THROUGH RONDUPRATT USED CARS IN JANUARY 2012 CAR SEEMED TO DRAG A LITTLE BUT DIDN'T PAY MUCH ATTENTION TO IS AS SUMMER CAME AROUND TRIED TO USE THE AC IT ONLY BLEW COLD ON THE FREEWAY I JUST THINKING IT NEEDED TO BE SERVICED BUY THE TIME I GOT THE AC CHARGED IT WAS WINTER AGAIN. BUY MARCH OF NEXT YEAR THE CAR STARTED DOING THIS WEIRD SHAKING AT EVERY STOP LIGHT AND EVERY STOP SIGN THE CAR WOULD START TO SHAKE IN APRIL A LETTER COMES IN THE MAIL EXPLAINING THE CAR WAS BEING RECALLED DUE TO THE CARS RPM IDLE SURGING TOOK THE CAR TO FAIRFIELD FORD AN WHEN I GOT THE CAR BACK IT WAS WORSE THEN IT. HAD EVER BEEN SO I DECIDED TO GO PAY RONDUPRATT TO DIAGNOSTIC THE CAR THE SAID WHERE I TOOK THE CAR TO DIDN'T PERFORM THE RECALL AND THE CAR NEEDED AN AC COMPRESSOR AND AN EGR VALVE I HAVE GOTTEN THE EGR VALVE REPLACED AN THE SAME DAY THE CAR WOULDN'T GO IN TO GEAR SO CONFUSED ON WHY THEY ARE ALLOWED TO SELL CARS THAT THEY KNOW ARE EXPERIENCING THESES PROBLEMS AND RANT WILLING TO DO ANYTHING TO FIX THE PROBLEM. *TR

WHILE ATTEMPTING TO SLOW TO A STOP OR MAKE A TURN, AT APPROXIMATELY 25 MPH, THE TRANSMISSION DOWNSHIFTED HARD. IT DOES NOT DO THIS WHILE SPEEDING UP. I HAVE HAD TWO MECHANICS TELL ME THERE IS NO KNOWN FIX, SHORT OF REPLACING THE TRANSMISSION, AND THERE IS NO INFORMATION AVAILABLE, PARTS BRAKE DOWN, ETC, FOR THEM TO DIAGNOSIS THE PROBLEM. I HAD THE VEHICLE AT A FORD DEALER TO HAVE THE THROTTLE BODY ISSUE FIXED. AT THAT TIME, THE POWER CONTROL MODULE AND THE TRANSMISSION CONTROL MODULE WERE BOTH RE-PROGRAMMED. NO LONG TERM FIX WAS ACHIEVED. *TR

Mileage: 74,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE FAILED TO ACCELERATE AND BOTH THE FAIL SAFE ENGINE MODE AND THE WRENCH WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS STOPPED AND RESTARTED, AS IT OPERATED NORMALLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE THROTTLE BODY WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 168,400. UPDATED 08/15/13*LJ

Mileage: 168,400

I HAD PREVIOUSLY HAD PROBLEMS WITH UNINTENDED ACCELERATION WHEN PARKED AND THEN PUTTING THE CAR INTO REVERSE (AUTOMATIC TRANSMISSION). AFTER READING MANY COMPLAINTS ON YOUR SITE IN WHICH CONSUMERS SAID THE THROTTLE BODY HAD BEEN DIAGNOSED AS CAUSING THE PROBLEM, I HAD THE DEALERSHIP REPLACE THE THROTTLE BODY. ( A FEW MONTHS LATER, FORD SENT A LETTER OFFERING TO REPLACE THE THROTTLE BODY). DESPITE HAVING HAD THE DEALERSHIP REPLACE THE THROTTLE BODY, THE CAR CONTINUES TO ACCELERATE FASTER THAN IT SHOULD SOMETIMES WHEN PUT IN REVERSE AND I MUST ALWAYS BE PREPARED TO BRAKE RAPIDLY. IF A DRIVER WAS UNAWARE OF THE PROBLEM OR HAD SLOW REACTION TIME, A CAR OR PERSON IN A PARKING LOT COULD BE HIT. *TR

Mileage: 53,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE ALL WHEEL DRIVE MALFUNCTIONED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD, POWERED OFF, THEN RESTARTED THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE OXYGEN SENSOR AND DIM MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 150,000.

Mileage: 150,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE TRANSMISSION FAILED AND THE SPEED DROPPED TO 30 MPH. THE CONTACT MOVED THE VEHICLE OFF THE ROADWAY AND ALLOWED THE VEHICLE TO COOL DOWN. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE HOME. THE VEHICLE WAS LATER TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE TRANSMISSION CONTROL MODULE NEEDED TO BE REPROGRAMMED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 200,000. THE VIN WAS UNAVAILABLE.

Mileage: 200,000

IN AUGUST 2010, I HAD THE CONTINUOUSLY VARIABLE TRANSMISSION REPLACED AT ~98,000 MILES. LUCKILY, IT WAS UNDER WARRANTY. NOW IN OCTOBER 2012, THE SECOND TRANSMISSION AS THE SERVICE MEMBER SAID AT THE FORD DEALERSHIP "THE TRANSMISSION EXPLODED, WE'RE NOT EVEN SURE HOW YOU WERE ABLE TO DRIVE THIS VEHICLE. THIS WAS AT ~146,000 MILES, BUT THERE IS ONLY ~48,000 MILES ON THE TRANSMISSION ITSELF. TWO TRANSMISSIONS HAVE FAILED IN THIS VEHICLE. SEARCHING THE INTERNET I HAVE COME ACROSS SEVERAL INSTANCES OF THE FORD FIVE HUNDREDS CONTINUOUSLY VARIABLE TRANSMISSION FAILING. I CALLED THE FORD CARE LINE TO REPORT IT, BUT THEY CLAIM THEY ARE UNAWARE OF ANY ISSUES. MY CONCERN IS THIS THIRD TRANSMISSION WILL ALSO FAIL AT SOME POINT. *TR

Mileage: 146,500

2005 FORD FIVE HUNDRED. CONSUMER WRITES IN REGARDS TO HARD SHIFTING AND TWO INSTRUMENT PANEL LIGHTS ILLUMINATING. *TGW THE CONSUMER ALSO STATED THE RPM'S WOULD RACE AT TIMES. THE CONSUMER WENT TO HER LOCAL DEALER AND A DIAGNOSTIC'S TEST REVEALED A PROBLEM WITH THE PCV VALVE. THE PCV WAS REPLACED AT A COST OF $ 112.95. HOWEVER, IT DID NOT RESOLVE THE PROBLEM. THE CONSUMER WENT BACK TO THE DEALER FOR A TRANSMISSION DIAGNOSTIC TEST, BUT THE DEALER WAS UNABLE TO GIVE A DEFINITIVE ANSWER AS TOW HAT THE PROBLEM WAS. FORD CUSTOMER SERVICE WAS THEN CONTACTED AND THEY INFORMED THE DEALER TO REPLACE THE TRANSMISSION AT A COST OF $5000. THERE WAS ALSO ANOTHER INTERMITTENT PROBLEM WHERE THE VEHICLE WOULD REV WHILE STOPPED AT A STOP SIGN, OR RED LIGHT ETC. AFTER GETTING OTHER OPINIONS, THE CONSUMER WAS INFORMED, THE PROBLEM WAS NOT WITH THE TRANSMISSION. AFTER DOING SOME RESEARCH ONLINE, THE CONSUMER DISCOVERED IT WAS A VERY COMMON OCCURRENCE WITH HER PARTICULAR MAKE, WHICH SEEMED TO BE A MANUFACTURING DEFECT.

ON HOT DAYS, WHEN BACKING OUT OF PARKING SPACES, THE CAR HAS SOMETIMES "SURGED" MEANING THAT THERE HAS BEEN UNINTENDED ACCELERATION WITHOUT THE ACCELERATOR BEING PRESSED AT ALL. I HAVE HAD TO SUDDENLY AND FIRMLY PUT MY FOOT ON THE BRAKE TO PREVENT THE CAR FROM HITTING OTHER VEHICLES. THIS HAS HAPPENED ON SEVERAL OCCASIONS IN AUGUST OF 2012. I OWN A 2006 FORD FIVE HUNDRED ALSO AND IT HAS HAD THE SAME PROBLEM IN THE SAME CONDITIONS (FILING SEPARATE COMPLAINT). *TR

Mileage: 52,155

MY FORD FIVE HUNDRED HAS BEEN UNEXPECTEDLY SURGING WHEN RELEASING THE BRAKE PEDAL WHEN GOING FORWARD AND REVERSE. IT HAS ALMOST CAUSED ME TO HIT OTHER VEHICLES IN A PARKING LOT ON SEVERAL OCCASIONS AND MAKES IT EXTREMELY DIFFICULT TO CONTROL THE SPEED OF THE VEHICLE WHEN STARTING TO ACCELERATE. SOMETHING NEEDS TO BE DONE ABOUT THIS ISSUE. I AM NOT THE ONLY PERSON WHO IS EXPERIENCING THIS. THERE ARE MANY MORE PEOPLE WHO HAVE POSTED THE SAME ISSUE ON BLOGS AND WEBSITES I HAVE READ. PLEASE LOOK INTO THIS ISSUE. *TR

Mileage: 99,000

OUT SIDE AIR TEMP WAS APPROX 96 DEGREES SO AC WAS ON . WHILE SHIFTING INTO REVERSE THE VEHICLE LUNGED SO HARD IT WAS UNCONTROLLABLE,AND UNSTOPPABLE, IF SOME ONE HAD STEPPED OUT BEHIND ME THEY WOULD HAVE DIED AS I COULD ONLY STOP REWARD MOVEMENT BY SHIFTING INTO DRIVE. THIS OCCURRED THREE TIMES TRYING TO GET OUT OF A PARKING SPACE AT A CROWDED MALL.THE VEHICLE THEN STALLED. THE LUNGING WAS SO FAST THE BRAKES COULD HARDLY HOLD THE CAR FROM MOVING IN REVERSE. IN CHECKING THERE IS A SERVICE BULLETIN TSB-05-25-13 FROM FORD MOTOR COMPANY ON THIS VERY ISSUE BUT NO RECALL, ALSO MANY INCIDENTS/ACCIDENTS RECORDED IN THIS REGARD. IF I WAS NOT PREPARED ENOUGH DURING THIS INCIDENT IN A CROWDED PARKING LOT SOME ONE WOULD HAVE DIED, THIS MUST BE ADDRESSED B-4 SOMEONE IS RUN OVER. CURRENTLY FORD HAS NO COMMENT. PLEASE CONTACT ME FOR FURTHER DETAILS. *TR

Mileage: 157,139

THE CAR SUDDEN SURGES FORWARD OR BACK WHEN MOVING OUT OF PARK. IF YOUR FOOT IS NOT FIRMLY ON THE BRAKE IT WILL GO MOVE SIGNIFICANTLY. UPON RESEARCH ONLINE AND TALKING TO FORD DIRECTLY THIS IS KNOWN PROBLEM THAT IS NOT UNDER RE-CALL YET BUT SHOULD BE. OUR LOCAL FORD DEALER CARRIES THE THROTTLE BOTTLE IN STOCK BECAUSE THEY SELL SO MANY OF THEM. THEY AVERAGE 10 A YEAR. A SIMPLE RESEARCH OF THE PROBLEM SHOWS UP. IT IS EXTREMELY DANGEROUS. ALSO IF THERE IS QUICK STOP IT WILL GO TO A FAIL SAFE MODE AND BASICALLY SHUT OFF THE CAR COMPLETELY. THE CAR HAS TO BE SHUT OFF AND RESTARTED IN ORDER TO MOVE THE VEHICLE AGAIN. THE THROTTLE BOTTLE MUST BE REPLACED IN ORDER FOR IT TO BE SAFE AS A PARTS COST OF ALMOST $600.00. *TR

Mileage: 79,000

WE WERE DRIVING DOWN A HIGHWAY AND WENT TO GET BACK TO SPEED AFTER PASSING THROUGH A SPEED ZONE. I NOTICED A DECREASE IN POWER AND LOOKED AT THE INFORMATION SCREEN. THE FAIL SAFE MODE AND THE "WRENCH" ICON WAS ON. I PULLED THE CAR OVER AND TURNED IT OFF. I THEN TURNED IT ON AND THE CAR ACTED NORMAL. IT HAS HAPPENED TWICE SINCE THE FIRST INCIDENT. MY WIFE TOOK IT TO THE DEALERSHIP AND FORD CANNOT DUPLICATE THE PROBLEM AND THE ISSUE DOES NOT THROW A CHECK ENGINE CODE OR LEAVES ANY TYPE OF ELECTRONIC HISTORY OF THE ISSUE. I CANNOT ALLOW MY WIFE TO DRIVE THIS CAR BECAUSE SHE IS SEVEN MONTH PREGNANT AND CANNOT HAVE HER DRIVE IT IF THE CAR BREAKS DOWN DUE TO THIS ISSUE. *TR

Mileage: 93,000

ON HOT SUMMER DAYS AND ONLY ON HOT SUMMER DAYS WHEN STOPPED AT LIGHT OR STOPPED PERIOD CAR BEGINS TO SURGE FORWARD WHILE HOLDING BRAKE. WENT ASKED FORD WHY IS THIS HAPPENING THEY SAID THEY DON'T KNOW. THAT I SHOULD GET THE THROTTLE BODY AND MASS AIR FLOW SENSOR SERVICED IF NOT DONE ALREADY. I GUESS IT HAD TO BE DONE AT 90K BUT I DID NOT KNOW. WELL I DID WHAT THEY SAID, WENT HOME AND CAR IS NOW IDLING ROUGH WENT BACK AND THEY WANT TO CHARGE ME ANOTHER $90 DOLLARS ONTOP OF THE $105 THEY HAVE ALREADY CHARGED ME FOR THE THROTTLE AND MAFS. I HAVE ALMOST GOTTEN IN NUMEROUS ACCIDENTS BECAUSE OF THIS BUT FORD DOESN'T WANT TO ACKNOWLEDGE THAT THIS IS A PROBLEM WITH THIS CAR. *TR

Mileage: 99,940

SO HERE I AM ANOTHER VICTIM OF A FAULTY THROTTLE BODY. THANKS FORD I LOVE WHEN MY CAR TAKES OFF ON ME WITHOUT NOTICE, ESPECIALLY WHEN YOU HAVE KIDS IN THE CAR. HOW MANY OF THESE DO I HAVE TO READ BEFORE ACTION IS TAKEN. DOES IT TAKE A DEATH OR SERIOUS ACCIDENT. COST ME 718 DOLLARS I EXPECT A RECALL SOON AND MY MONEY BACK I WILL NOT QUIT UNTIL THIS IS TAKEN CARE OF. IT'S SAD WHEN YOU GO TO A MECHANIC AND THEY SAY "WOW THERE IS STILL NOT A RECALL ON THIS". OH BY THE WAY IT IS SUCH A COMMON PROBLEM I DIAGNOSED MY OWN CAR ISSUE IN 5 MINUTES BY USING GOOGLE AND TYPING FAILSAFE ENGINE MODE. *TR

Mileage: 78,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE DOWN SHIFTED AND LOST ENGINE POWER. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE DEALER REPROGRAMMED THE COMPUTER, BUT THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR A DIAGNOSTIC TEST, WHICH LOCATED THE FAILURE AT THE TRANSMISSION VALVE BODY. THE TRANSMISSION VALVE BODY WAS REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 67,407.

Mileage: 67,407

VEHICLE SHIFTS HARD WHEN HITTING PASSING GEAR ON HIGHWAY LIKE TRANSMISSION IS SLIPPING OR GOING OUT. LOSE ALL POWER AND CAR WILL BUCK BACK AND FORTH. ALSO DOES IT WHEN TRANSMISSION DOWN SHIFTS AND THEN TRIES TO UPSHIFT WHEN ACCELERATING AND ENGINE WARM. *TR

Mileage: 47,000

VEHICLE SLIPPED OUT OF DRIVE INTO NEUTRAL WHILE ASCENDING HILL. I HAD TO PULL OVER COMPLETELY AND STOP, SHIFT INTO LOW AND SLOWLY BACK INTO DRIVE. THE CAR BEHIND ME ALMOST REAR ENDED ME AS I HAD LOST POWER WITH NO WARNING. CAR ONCE WARMED STARTS TO BUCK VIOLENTLY WHILE DRIVING AT AN EVEN SPEED, BUCKS VIOLENTLY WHEN COMING TO A STOP AND RANDOMLY SLIPS OUT OF GEAR WITH NO WARNING. I HAVE HAD THIS CAR SINCE 2009 AND HAVE POT LESS THEN 20000 MILES ON IT. THE DEALER TELLS ME THE COMPUTER DOES NOT READ ANY PROBLEMS. *TR

Mileage: 48,000

I HAD THE NEED TO AVOID AN ACCIDENT BY SUDDENLY CHANGING LANES BUT WHEN I STEP ON THE GAS PEDAL MY TRANSMISSION FAILED TO SHIFT TO HIGHER SPEED. INSTEAD TWO CLUNKING SOUNDS TOOK PLACE BEFORE FINALLY SWITCHING INTO HIGHER GEAR .I WAS ABLE TO AVOID THE CAR IN FRONT OF ME , BUT NOW THE CAR BEHIND ME ALMOST REAR ENDED US. THIS WOULD HAVE CREATED A FATAL CHAIN REACTION WE COULD HAVE BEEN CRUSHED IN. I FOUND OUT THIS CARS HAVE A GREAT AMOUNT OF FAILURES ON RECORD FORD 500 2005 PLEASE HELP *JS

Mileage: 128,000

I HAVE AN ONGOING ISSUE WITH THE TRANSMISSION DE-ENGAGING WHEN THE TEMPERATURE OF THE TRANSMISSION WARMS UP. WHEN I ACCELERATE WHEN PASSING OR USING THE CRUISE CONTROL THE TRANSMISSION WILL DIS-ENGAGE LEAVING ME WITH NO FORWARD POWER, I MUST PUT THE CAR IN NEUTRAL AND HOPE IT ENGAGES ALL THE WHILE ALMOST BEING RUN OVER BY TWO SEMI-TRUCKS. THIS HAPPENED ALMOST A DOZEN TIMES DOWN AND BACK ON MY TRIP FROM BUFFALO TO PEAPACK NJ ON MONDAY 4/16/2012. THIS IS A KNOW PROBLEM THAT FORD IS AWARE ON THE FIVE HUNDRED MODEL, MONTEGO AND SOME FUSION MODELS. MANY START TO FAIL AT LESS THAN 30,000 MILES AND HAPPENED AT 65,000 MILES ON MY VEHICLE. I CONSIDER THIS AN EXTREMELY DANGEROUS SITUATION AND AMAZED NO ONE HAS BEEN KILLED DUE TO THESE DEFECTIVE TRANSMISSIONS. THE FORD FORUM HAS OVER 10 PAGES OF COMPLAINTS REGARDING THIS PROBLEM. FORD TOLD ME THEY WOULD NOT DO ANYTHING UNLESS THERE WAS A RECALL.

Mileage: 65,000

I HAVE AN ONGOING ISSUE WITH THE TRANSMISSION DE-ENGAGING WHEN THE TEMPERATURE OF THE TRANSMISSION WARMS UP. WHEN I ACCELERATE WHEN PASSING OR USING THE CRUISE CONTROL THE TRANSMISSION WILL DIS-ENGAGE LEAVING ME WITH NO FORWARD POWER, I MUST PUT THE CAR IN NEUTRAL AND HOPE IT ENGAGES ALL THE WHILE ALMOST BEING RUN OVER BY TWO SEMI-TRUCKS. THIS HAPPENED ALMOST A DOZEN TIMES DOWN AND BACK ON MY TRIP FROM BUFFALO TO PEAPACK NJ ON MONDAY 4/16/2012. THIS IS A KNOW PROBLEM THAT FORD IS AWARE ON THE FIVE HUNDRED MODEL, MONTEGO AND SOME FUSION MODELS. MANY START TO FAIL AT LESS THAN 30,000 MILES AND HAPPENED AT 65,000 MILES ON MY VEHICLE. I CONSIDER THIS AN EXTREMELY DANGEROUS SITUATION AND AMAZED NO ONE HAS BEEN KILLED DUE TO THESE DEFECTIVE TRANSMISSIONS. THE FORD FORUM HAS OVER 10 PAGES OF COMPLAINTS REGARDING THIS PROBLEM. FORD TOLD ME THEY WOULD NOT DO ANYTHING UNLESS THERE WAS A RECALL.

Mileage: 65,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED WHILE DEPRESSING THE ACCELERATOR PEDAL. ALL OF THE LIGHTS ON THE INSTRUMENT PANEL FAILED AND THE REVERSE LIGHTS ILLUMINATED ERRONEOUSLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY ADVISED THE CONTACT THAT THE PCM MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 125,000.

Mileage: 80,000

WHILE STOPPED AT A RED LIGHT, THE CAR STARTED TO JERK AND THE MOTOR RACED/IDLED UP HIGH. *TR

WE BOUGHT MY CAR IN JULY 2011, ITS WAS GARAGED BY THE 1ST OWNER SO IT WAS LIKE BRAND NEW!! LOW MILES JUST 12,850 , START WHAT NOW SEEMS TO BE THE ENDLESS DRIVES IN A RENTAL CAR AND WITH EMPTY WALLETS TOTALING NOW APPROX; CLOSE TO AN ADDITIONAL $3,500 NOW IN REPAIRS FROM THE BATTERY IN AUG 2011 TO NOW TO HAVING THE THROTTLE BEING REPLACE ALONG WITH A SET IF TIRES AND THE 2ND SET OF BOTH REAR AND FRONT BRAKES IN LESS THEN A YEAR , ALL DUE TO THE CONSENT STOPPING AND GOING OF THE CAR BY HITTING THE BRAKES TOO MUCH AND HAVING TO ACCELERATE, BECAUSE THE CAR WOULD WHILE TEMPTING TO PULL OUT OF MY GARAGE AT WHAT SHOULD OF BEEN A MERE 3MILES PER HOUR; RESULTED IN FLYING BACKWARDS SUDDENLY WHILE FOOT WAS APPLYING PRESSURE ON THE BRAKES TO KEEP FROM MOWING DOWN MY TEENAGE SON AT 15 MILES A HOUR ON ITS OWN WITH THE MP RISING RAPIDLY , WAS THE SCARE OF MY LIFE!!!! PLEASE SOMEONE RECALL THIS CAR , BEFORE SOMEONE REALLY DOES GET KILLED OR HURT!!! AS OF TODAY THE TOTAL THIS TIME TO REPAIR MY CAR IS AT A TOTAL IF$ 1,585.00; TO REPLACE THE THROTTLE AND TIRES & BRAKES AGAIN, AND FORD WOULDN'T EVEN COMP, US A RENTAL CAR THIS TIME ON OUR 5 TRIP DOWN TO THE SERVICE DEPT OF FORD!!!! *TR

Mileage: 12,500

DRIVING FROM SJ TO LA, CALIF. 200 MILES INTO MY JOURNEY WITH WIFE AND 3 KIDS, PULLED OFF HIGHWAY FOR GAS. SLOWED DOWN AND NOTICED THE WRENCH AND CHECK ENGINE LIGHTS ON AND CAR WOULD ONLY GO 10 TO 15 MILES PER HOUR AND REVVED AT MORE THAN 3000 RPMS. THE CAR CLUNKED HARD WHEN PUT INTO DRIVE OR REVERSE. TURNED OFF THE ENGINE, SEVERAL TIMES AND RESTARTED. SOMETIMES FIXED PROBLEM, OTHER TIMES DID NOT. I HAD CAR TOWED TO HANFORD, CALIFORNIA, AND THEN AGAIN TO LOS ANGELES-ANOTHER 198 MILES TO FORD DEALERSHIP. I HAD TO RENT A CAR AND DRIVE THE REST OF THE WAY TO LA AND DRIVE BACK - 198 MILES-TO HANFORD-TO RETURN THE RENTAL CAR. I TESTED THE CAR A FEW TIMES IN HANFORD AND WHEN IT WAS AT THE FORD DEALER. FROM A COLD START, THE CAR WORKED FINE. DROVE AND SHIFTED WELL WITH NO PROBLEMS. BUT ONCE THE CAR WARMED UP, IT WENT BACK INTO LIMP-MODE, CLUNKED HARD WHEN YOU SHIFTED INTO DRIVE OR REVERSE, AND WOULD GO ONLY 10-15 MPH AT 3000 OR MORE RPMS. THE DEALER TEST DROVE IT AND HAD THE SAME RESULT. THE DEALER GOT CODES P0701, P0871, AND P0961 AND SAID THAT MEANT THE TRANSMISSION HAD INTERNAL PROBLEMS. THEY SAID THEY CALLED FORD ENGINEERS WHO TOLD THEM THE LIKELY PROBLEM WAS WHEN THE TRANSMISSION FLUID WARMS UP, IT IS NOT PROPERLY CIRCULATING DUE TO LEAKS IN WHAT THEY CALLED TWO VARIATORS INSIDE THE TRANSMISSION. THEY QUOTED THE COST TO REPLACE THE VARIATORS AS $3600 FOR PARTS AND LABOR OF $1200 FOR A TOTAL OF $4800 AND THAT IS MORE THAN THE COST TO REPLACE THE TRANSMISSION FOR WHICH THEY QUOTED $4500. SO THEY REPLACED THE TRANSMISSION. AFTER STARTING, THEY FOUND A BROKEN TRANSMISSION MOUNT SO THEY REPLACED THAT FOR ANOTHER $250 (PART ONLY - NO LABOR CHARGE). I TEST DROVE THE NEW TRANSMISSION YESTERDAY. THE CAR NO LONGER GOES INTO LIMP MODE AND DRIVES NICELY EXCEPT AFTER IT WARMS UP IT CLUNKS HARD INTO DRIVE AND REVERSE AND WINES IN REVERSE GEAR. NOT TAKING CAR TILL FIXED PROPERLY. *TR

Mileage: 79,500

I PURCHASED THIS 2005 FORD FIVE HUNDRED AS A GIFT FOR MY WIFE,11/26/11 WITHIN A WEEK AFTER OWNING IT THE AWD MALFUNCTION LIGHT CAME ON. IN LOOKING OVER THE INTERNET I'M FINDING OTHER FORD OWNERS ARE EXPERIENCING THE SAME PROBLEM AND THAT FORD DOES NOT WANT TO DO ANYTHING ABOUT IT OR TAKE RESPONSIBILITY FOR A DEFECTIVE PRODUCT THAT POTENTIALLY COULD BE VERY COSTLY OVER AND ABOVE THE HIGH COST OF THE VEHICLE ITSELF. IT SEEMS THE CONSUMER SHOULD HAVE ''SOME'' RECOURSE OR HELP WITH THIS RECURRING PROBLEM AND MAKE FORD OWN UP AND REPAIR THE DEFECT AND PROBLEMS MANY OF US ARE DEALING WITH... OUT OF POCKET!!! *TR

Mileage: 99,460

NOT LONG AFTER PURCHASING MY VEHICLE MY HUSBAND AND I WERE DRIVING ON THE INTERSTATE WITH THE CRUISE CONTROL ON AND THE TRANSMISSION STOPPED WORKING. WE WERE ABLE TO PULL OFF SAFELY ONTO THE SHOULDER AND SHUT THE CAR OFF AND ONCE RESTARTED WAS FINE. WE HAVE SINCE STOPPED USING CRUISE CONTROL IN FEAR OF AN ACCIDENT. THE PROBLEM IS STILL THERE AND SEEMS TO BE GETTING WORSE. THE DASH WILL LIGHT CHECK TRANSMISSION, TRACTION CONTROL AND SOMETIMES CHECK ENGINE. ONCE THE CAR IS TURNED OFF AND BACK ON IT IS FINE FOR A WHILE, THE CHECK ENGINE LIGHT TAKES SOME TIME TO GO OFF. IT IS GETTING SO WE ARE AFRAID TO DRIVE IT, SOMETIMES IT DRIVES FINE AND OTHERS THE TRANSMISSION QUITS. THE OTHER DAY I WENT TO PASS A CAR AND THE LIGHTS CAME ON AS I HAD MOVED INTO THE LANE TO PASS ON THE INTERSTATE. ONCE I WAS IN MY LANE AGAIN A FEW MINUTES LATER IT DOES IT AGAIN AND THIS TIME A BIG MAC TRUCK IS COMING UP ON ME. I HAVE READ OF SEVERAL PROBLEMS OF THIS WITH THIS SAME CAR AND IT HAS BEEN SAID THERE IS A PROBLEM WITH THE THROTTLE BODY AND/OR ELECTRICAL SYSTEM. THIS IS VERY DANGEROUS AND FORD SHOULD BE ISSUING A RECALL TO FIX THE PROBLEM BEFORE SOMEONE IS INJURED OR KILLED. *TR

Mileage: 155,000

2005 FORD FIVE HUNDRED SEL 3.0L V6 AUTOMATIC 6 SPEED TRANSMISSION ACCELERATING ON INTERSTATE CAR SEVERELY HARD SHIFTED AND THEN RPMS FLARED LET OFF GAS AND CAR SLAMMED INTO A LOWER GEAR NOW CAR HARD SHIFTS IN DOWN GEARS AND RPMS GO UP CAR DOESN'T MOVE SOMETIMES WHILE ACCELERATING VERY SPORADIC AND DANGEROUS. *TR

Mileage: 81,000

NOT SURE THE EXACT TIME BUT WITHIN THE PAST YEAR OR SO MY 2005 FORD FIVE HUNDRED ( PURCHASED NEW) IS GOING INTO FAILSAFE MODE LIMITED THROTTLE POWER, VERY SPORADIC AT FIRST BUT NOW HAPPENING QUITE OFTEN. IF YOU PULL OVER AND SHUT THE CAR OFF AND RESTART IT CLEARS AND DRIVES NORMAL. MY DAUGHTER WAS DRIVING IT YESTERDAY AND IT HAPPENED 7 TIMES FROM MALL TO THE HOUSE (ABOUT 20 MILES). ONCE WHILE SHE WAS IN HEAVY TRAFFIC DRIVING ABOUT 55 MPH. CAR JERKED THEN STARTED SLOWING DOWN. THIS IS A SAFETY ISSUE THAT NEEDS TO BE LOOKED AT. VERY DANGEROUS. MY MECHANIC IS TROUBLE SHOOTING PROBLEM, LOOKING LIKE THROTTLE BODY OR GAS PEDAL. I BELIEVE FORD CAME OUT WITH A NEW THROTTLE BODY IN 2010 TO CORRECT THE PROBLEM (TSB 05-25-13)BUT WILL ONLY REPLACE IT AT THEIR COST IF STILL UNDER WARRANTY, OTHERWISE THE COST IS ON US THE CONSUMER. (ABOUT A THOUSAND DOLLARS). *TR

Mileage: 90,000

THE VEHICLE LUNGES WHILE HOLDING THE BRAKE WHEN PUTTING INTO REVERSE OR DRIVE AND CONTINUES TO DO SO WHILE WAITING TO PULL INTO TRAFFIC MAKING IT VERY DANGEROUS! IT ALSO DOES THIS WHILE TRYING TO PARK MAKING IT DANGEROUS TO PARK NEAR ANYTHING! I HAVE SEEN SEVERAL COMPLAINTS REGARDING THIS VERY SAME PROBLEM STATING IT IS A THROTTLE BODY DEFECT THAT COSTS AT LOWEST $700.00 TO REPAIR. FRONT SUSPENSION IS SHOT ALREADY WITH LOUD CLUNKING NOISES, VERY ROUGH RIDE! REAR DOORS FILL WITH WATER WHICH WILL RESULT IN RUST HOLES! ALL OF THESE PROBLEMS HAVE BEEN REPORTED SEVERAL TIMES BY OTHER OWNERS OF THIS SAME YEAR AND MAKE OF VEHICLE. FORD SHOULD BE RESPONSIBLE FOR THE REPAIRS NEEDED TO FIX THESE PROBLEMS. *TR

THE CAR ACCELERATES BY ITSELF AND TRANSMISSION IS NOT PERFORMING CORRECTLY AS IT DOES NOT ACCELERATE AFTER BRAKING AFTER THE TRANSMISSION WARMS UP , THEY SAID IT WAS THROTTLEBODY BUT REPLACED THAT AND TRANS FLUID BUT STILL HAVE SAME TROUBLE AFTER ABOUT 30 MILES OF DRIVING . THIS COULD GET PEOPLE KILLED AND IT SHOULD BE RECALLED NO IFS ANDS OR BUTS ABOUT IT !!!!!! FORD TAKE CARE OF YOUR CUSTOMERS. *TR

Mileage: 49,000

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHEN THE HEAT INDEX WAS ABOVE 80 DEGREES, THE CHECK TRANSMISSION AND WRENCH SYMBOLS WOULD ILLUMINATE ON THE INSTRUMENT PANEL. AS A RESULT, THE ENGINE WOULD LOSE SOME OF ITS POWER WHENEVER THE CONTACT DECELERATED. THE CONTACT WOULD SHUT THE VEHICLE OFF AND UPON RESTART IT WOULD OPERATE AS NORMAL, BUT THE WARNING LIGHTS WOULD CONTINUE TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE THE VALVE BODY WAS REPLACED, BUT THE FAILURE CONTINUED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 101,000 AND THE CURRENT MILEAGE WAS 131,000.

Mileage: 101,000

THE VEHICLE HAS RPM SURGES AT LOW SPEEDS EITHER IN REVERSE OR FORWARD. I NEARLY HAD 3-4 ACCIDENTS IN 2 DAYS BECAUSE OF THE ISSUE. THE VEHICLE WILL ACTUALLY INCREASE UP TO 1000 RPMS BY ITSELF WHILE I HAVE MY FOOT ON THE BRAKE. AS SOON AS I BEGIN TO RELEASE PRESSURE OFF THE BRAKE WHILE TRYING TO PARK OR NEGOTIATE THE VEHICLE AT VERY LOW SPEEDS THE ENGINE WILL JUST TAKE OFF. THE FIRST TIME I NOTICED IT I WAS BACKING OUT OF A PARKING SPACE AND THE VEHICLE TOOK OFF BACKWARD CAUSING ME TO HAVE TO SLAM THE BRAKES ON. I ALMOST HIT A WOMAN WHO WAS PASSING ON THE OTHER SIDE OF THE LANE. *KB

Mileage: 73,000

I HAVE THE WRENCH LIGHT UP ON THE DASH BOARD AND IT SAID ENGINE FAILSAFE MODE IN THE MESSAGE CENTRE? THIS STARTED HAPPENING TO ME A FEW WEEKS AGO FROM TIME TO TIME. NO WARNING, I JUST ACCELERATE FROM A RED LIGHT AND I NOTICE I HAVE NO POWER, I LOOK DOWN AND SURE ENOUGH - WRENCH IS LIT AND ENGINE FAILSAFE MODE. I PULL OVER, TURN THE CAR OFF FOR A FEW MINUTES AND THEN THE PROBLEM IS GONE WHEN I START AGAIN. I COULDN'T FIND ANY SPECIFIC INFO ON WHAT IS CAUSING THIS AROUND THE 'NET - AND EVEN THE MANUAL SAYS, IF IT IS PERSISTS, TAKE IT TO THE DEALER. IT HAPPENED A FEW MORE TIMES, BUT THIS TIME IT SEEMED THE RPM'S WERE REVVING WITHOUT MY FOOT ON THE ACCELERATOR. I HAD MY FOOT ON THE BRAKE SO NOTHING HAPPENED, BUT DID IT A FEW TIMES, SO I BROUGHT IT TO THE DEALER LAST WEEK. THEY RAN SOME DIAGNOSTICS AND ULTIMATELY SAID THEY REPAIRED A VACUUM HOSE AT MY AIRBOX. OK, SURE, WHATEVER. NEXT TWO DAYS, NO PROBLEM. THE THIRD DAY, HAPPENED AGAIN. THIS TIME, I WAS GOING INTO AN UNDERGROUND PARKING SPOT AND IT STARTED REVVING AND I ENDED UP (VERY LIGHTLY) HITTING THE WALL AS IT LURCHED FORWARD. WHEN I WENT TO LEAVE THE SPOT - IN REVERSE - HAPPENED AGAIN - ALMOST HIT THE PARKED CAR BEHIND, AS IT LURCHED. SO TOOK IT TO THE DEALER THIS MORNING - AND THE SERVICE ADVISOR MENTIONED HE SUSPECTS THE THROTTLEBODY AS HE HAS HAD SOME OTHER 500'S IN FOR THE SAME THING. NO IDEA WHY, BUT THE COMPUTER DIDN'T HAVE A CODE FOR THE THROTTLEBODY PROBLEM LAST TIME - BUT IT DID THIS TIME, SO AS I WRITE THIS, THEY ARE PUTTING THE NEW ONE ON AND I'LL BE THERE IN AN HOUR TO PICK IT UP. *TR

Mileage: 233,000

THROTTLE BODY BAD ALL MOST HAD WRECK CAR WOULD NOT GO JUST IDLED. *KB

Mileage: 160,500

BACKING OUT OF THE DRIVEWAY IN A 2005 FORD 500 AWD, CAR STUMBLES THEN LAUNCHED BACKWARD VIOLENTLY. LUCKILY I HAD MY FOOT ON THE BRAKE OR THE CAR WOULD HAVE KEPT GOING. "FAILSAFE ENGINE MODE" APPEARS ON THE DASHBOARD. THIS HAS HAPPENED SEVERAL TIMES BEFORE. SHOULD BE A RECALL ON THIS CAR. *KB

Mileage: 77,778

THE VEHICLE IN QUESTION WAS IDLING IN PARK. VEHICLE WAS SHIFTED INTO REVERSE WITH THE FOOT ON THE BRAKE. ONCE FOOT WAS RELEASED FROM THE BRAKE THE CAR LUNGED BACKWARD, THE TACHOMETER READ ABOUT 3000 RPM, WITH NO PRESSURE ON THE GAS PEDAL. JUST AS QUICKLY PRESSURE WAS APPLIED TO THE BRAKE AND THE CAR ENTERED "ENGINE FAILSAFE MODE" AND SHUT DOWN. TURNING THE VEHICLE OFF AND RESTARTING WOULD CLEAR THE PROBLEM. THIS HAS HAPPENED 4 MORE TIMES SINCE THE REPORTED INCIDENT DATE, ALL WITH THE SAME CIRCUMSTANCES. THE VEHICLE HAD THE A/C ON AND WAS IDLING IN APPROXIMATELY 90 DEGREE FAHRENHEIT TEMPERATURES WITH +50% RELATIVE HUMIDITY. *KB

Mileage: 70,258

THE VEHICLE IN QUESTION WAS IDLING IN PARK. VEHICLE WAS SHIFTED INTO REVERSE WITH THE FOOT ON THE BRAKE. ONCE FOOT WAS RELEASED FROM THE BRAKE THE CAR LUNGED BACKWARD, THE TACHOMETER READ ABOUT 3000 RPM, WITH NO PRESSURE ON THE GAS PEDAL. JUST AS QUICKLY PRESSURE WAS APPLIED TO THE BRAKE AND THE CAR ENTERED "ENGINE FAILSAFE MODE" AND SHUT DOWN. TURNING THE VEHICLE OFF AND RESTARTING WOULD CLEAR THE PROBLEM. THIS HAS HAPPENED 4 MORE TIMES SINCE THE REPORTED INCIDENT DATE, ALL WITH THE SAME CIRCUMSTANCES. THE VEHICLE HAD THE A/C ON AND WAS IDLING IN APPROXIMATELY 90 DEGREE FAHRENHEIT TEMPERATURES WITH +50% RELATIVE HUMIDITY. *KB

Mileage: 70,258

I HAD MY VEHICLE AT THE SERVICE DEPARTMENT THREE TIMED FOR TRANSMISSION PROBLEMS. THE CAR WOULD JUMP AND SPUTTER BUT EVERY TIME THE DEALERSHIP CAME TO THE SAME CONCLUSION, NOTHING WRONG WITH THE VEHICLE. WENT TO GET A THIRD OPINION AT ANOTHER DEALERSHIP WAS TOLD I NEED NEW VALVE BODY. EVERYTIME I TOOK THE CAR TO THE DEALERSHIP THE CAR WAS UNDER EXTENDED WARRANTY. NOW IT IS NO LONGER UNDER WARRANTY AND THE COST WILL RISE ABOVE $2100.00 THIS SHOULD HAVE BEEN A RECALL ISSUE. TRANSMISSION PROBLEMS SHOULD BE TAKEN MORE SERIOUSLY. *TR

Mileage: 50,000

THE CAR ENTERED ENGINE "FAILSAFE MODE" AND SHUT DOWN WHILE TRYING TO MERGE INTO TRAFFIC ON A BUSY RUSH-HOUR HIGHWAY. AFTER PULLING OVER AND RESTARTING THE ENGINE, OPERATION WAS NORMAL. THIS WAS THE 3RD TIME IN A 2.5 WEEK PERIOD THIS OCCURRED. THE CAR EXPERIENCED THE SAME ISSUES IN JULY 2010 FREQUENTLY (IT HAD EXISTED FOR 2-3 YEAR ON AND OFF BEFORE THEN). FORD APPLIED THE SERVICE ALERT FIX BY REPLACING THE THROTTLE BODY AND REFRESHING THE PCM. THIS FIX HAS NOT WORKED. THE CAR WILL SPORADICALLY ENTER FAILSAFE MODE ON WARM DAYS WHEN TRYING TO ACCELERATE/SHIFT GEARS. THE ORIGINAL FIX IN JULY 2010 WAS COVERED UNDER WARRANTY. IN OCTOBER 2010 THERE WAS A TRANSMISSION CONTROL FAILURE AND THE COMPUTER HAD TO BE REPLACED. THE WARRANTY HAD EXPIRED AND THE FIX COST $2000. OPERATION WAS NORMAL DURING THE WINTER MONTHS, HOWEVER, WHEN THE WARM WEATHER RETURNED SO DID THE PROBLEM. AN INDEPENDENT MECHANIC BELIEVES THE FAILSAFE MODE ISSUE WAS THE BEGINNING OF THE TRANSMISSION FAILURE AND FORD SHOULD NOT HAVE CHARGED $2000 FOR A NEW COMPUTER. THE PROBLEM HAS NOT BEEN RESOLVED AND CONTINUES TO OCCUR. THE DEALERSHIP'S SUGGESTION IS TO PULL OVER AND RESTART THE CAR TO CLEAR THE COMPUTER. THE CAR IS UNSAFE TO DRIVE, ESPECIALLY ON MULTIPLE LANE HIGHWAYS. ONCE THE FAILSAFE MODE ENGAGES, THERE IS LITTLE POWER TO GET THE CAR OFF THE ROAD. IF YOU ARE ON AN INCLINE IT WILL STOP ALTOGETHER. THIS IS A DANGEROUS SITUATION AND THE POSSIBILITY OF A REAR END COLLISION IS GREAT. FORD HAS NOT ISSUED A RECALL, ONLY A SERVICE ALERT FOR A FIX THAT DOES NOT WORK. *TR

Mileage: 80,500

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED SEL. WHILE DRIVING APPROXIMATELY 40-60 MPH, THE TRANSMISSION BEGAN TO JERK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO ADVISED THAT THE TRANSMISSION VALVE BODY INTERNAL BORE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT AND WAS UNABLE TO PROVIDE ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.

Mileage: 47,000

2005 FORD FIVE HUNDRED. VEHICLE ACCELERATES WITHOUT THE GAS PEDAL BEING DEPRESSED. VEHICLE ENTERS INTO FAILSAFE MODE. OCCURRENCES ARE INTERMITTENT. DIAGNOSTIC CHECKS SHOW SOMETHING OTHER THAN THE REAL CULPRIT WHICH IS A FAULTY THROTTLE BODY. HAS NOT BEEN REPAIRED YET. DEALER IS ASKING FOR 800.00. *TR

Mileage: 50,000

THE CAR STARTED TO ACCELERATE BY ITSELF. AND NEARLY PLOWED INTO THE CAR IN FRONT OF ME. THEN ON THE HWY HAS LOSE OF POWER NEARLY REAR-ENDED @60MPH CHECK ENGINE LIGHT NOW W/WRENCH. DIAGNOSED CODE P2106 AND P2135 THROTTLE BODY . OCCURS MORE WHEN A/C IS ON. HAD AIR FLOW SENSOR REPLACED, BUT PROBLEM STILL EXIST. *TR

Mileage: 120,000

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED SEL. THE CONTACT STATED THAT THE TRANSMISSION WAS REPLACED AND WITHIN A COUPLE OF DAYS SHE DROVE THE VEHICLE AGAIN AND IT STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY DIAGNOSED THAT THE THROTTLE BOTTLE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 102, 000.

Mileage: 102,000

I PURCHASED A USED 2005 FORD 500 LTD AWD IN MAY 2008. I WAS TOLD IT WAS A LEASE TURN IN. THE MILEAGE WAS VERY LOW, UNDER 30,000 MILES. THE FACTORY WARRANTY EXPIRED IN JULY 2008. IN OCTOBER 2008, MY DASH BEGAN MALFUNCTIONING. THE GAUGES WOULD GO COMPLETELY DEAD. I COULD NOT TELL HOW FAST I WAS GOING, HOW MUCH GAS I HAD LEFT OR THE TEMPERATURE OF THE ENGINE. NOTHING ON MY DASH WOULD WORK. IT VARIED FROM LASTING SECONDS TO APPX A HALF AN HOUR. I DROVE HOME ONE NIGHT (IT TOOK ME APPX 25 MINUTES) NOT KNOWING HOW FAST I WAS GOING OR HOW MUCH GAS I HAD LEFT. ALSO, THE REVERSE LIGHTS WERE ON WHEN MY CAR WAS IN BOTH DRIVE AND PARK. I STOPPED AT A RED LIGHT (MY CAR WAS IN DRIVE) AND THE REVERSE SENSOR ALARM WENT OFF WHEN A CAR PULLED UP BEHIND ME. WE TOOK IT TO THE DEALERSHIP WE BOUGHT IT FROM & WERE TOLD IT WAS A CLUSTER IN THE DASH THAT WAS A "KNOWN PROBLEM WITH THIS VEHICLE" BUT BECAUSE IT WAS NOT A "SAFETY ISSUE" FORD DID NOT HAVE TO RECALL THIS. I FEEL THAT NOT BEING ABLE TO KNOW WHAT SPEED YOU ARE DRIVING DOWN THE HIGHWAY TO BE A HUGE SAFETY ISSUE. ALSO HAVING YOUR REVERSE LIGHTS ON WHILE THE CAR IS IN PARK OR DRIVE SEEMS A BIT DANGEROUS AS WELL. WE HAD IT REPAIRED AND IT COST US OVER 400.00. ABOUT 2 WEEKS AGO, WE HAD TO HAVE ANOTHER "CLUSTER" REPAIRED THAT WAS MAKING MY TRANSMISSION SHAKE & THE CHECK ENGINE LIGHT AS WELL ANOTHER WARNING LIGHT APPEAR. IT WAS A SENSOR THAT WENT BAD AND WAS MAKING MY CAR THINK IT WAS OUT OF GAS. THIS COST US ALMOST 350.00 TO REPAIR. NOT SURE WHAT'S GOING ON WITH THE SENSORS/CLUSTERS ON THESE CARS BUT IT SEEMS TO BE A SAFETY ISSUE TO ME. *TR

MY WIFE WAS RETURNING HOME FROM CHURCH IN BUSY TRAFFIC. THE 2005 500 FORD MOVED INTO ETC - ENGINE FAILSAFE MODE. THIS WAS A VERY DANGEROUS SITUATION. THIS EVENT OCCURRED ON SATURDAY, 22 JANUARY. WE WILL BE IN TOUCH WITH THE DEALER AS SOON AS MONDAY ARRIVES. *LN

Mileage: 60,000

TRAVELING ON MOUNTAIN HIGHWAY AND ATTEMPTING TO PASS TRACTOR TRAILER DEPRESSED THROTTLE AND TRANSMISSION DOWNSHIFTED TO NEXT LOWER GEAR THAN SLAMMED INTO THE NEXT LOWER GEAR. LOSS OF ALL ACCELERATION TRANSMISSION ILLUMINATED. THAN TRANSMISSION APPEARS TO HAVE ELECTRONICALLY DISENGAGED FROM ENGINE (NO FORWARD MOVEMENT AT ALL, MIND YOU I WAS TRYING TO PASS) ENGINE REVOLUTIONS INCREASED TO OVER 7,000 RPM. BOTH TRANSMISSION LIGHT AND CHECK ENGINE LIGHT ILLUMINATED. AFTER A BRIEF REST AT SIDE OF RODE VEHICLE RESTARTED AND COULD BE MOVED BOTH LIGHTS REMAINED ILLUMINATED. AFTER 5 OR 10 RESTARTS BOTH ERROR LIGHTS EXTINGUISHED. *TR

Mileage: 58,000

OUR CAR STALLS WHILE DRIVING. IT OFTEN HAPPENS ON THE HIGHWAY, BUT ALSO ON RESIDENTIAL STREETS AND AT ALL SPEEDS. THE CAR WILL LURCH FORWARD, THE LIGHTS ON THE DASHBOARD WILL ALL LIGHT UP, AND THEN THE ENGINE WILL SHUT DOWN CAUSING US TO HAVE TO SHIFT INTO NEUTRAL AND TRY TO PULL OVER TO SAFETY. WHEN WE TRY TO RESTART THE CAR IT WILL SPUTTER AND DIE AGAIN. OCCASIONALLY WE WILL BE ABLE TO GET IT TO A PARKING LOT, WE HAVE HAD TO BE TOWED HOME. WE HAVE REPLACED THE FUEL PUMP AND SPARK PLUGS. THE FORD DEALERSHIP DROVE IT AND RAN DIAGNOSTICS ON IT FOR WEEKS AT A TIME AND FOUND NOTHING TO TELL THEM ANYTHING. THIS HAS BEEN HAPPENING EVERY WEEK OR SO FOR NEARLY A YEAR, AND NO ONE CAN TELL US WHAT'S WRONG. THERE ARE TIMES WHEN IT HAPPENS EVERY DAY, AND THERE ARE TIMES WHEN IT DOESN'T HAPPEN FOR A MONTH. MANY PEOPLE'S DESCRIPTION OF A DEFECTIVE TRANSMISSION BODY MATCHES OUR DESCRIPTION, BUT THAT PART IS, APPARENTLY, ON BACKORDER. THE CAR IS ESSENTIALLY UN-DRIVABLE, BECAUSE WE CANNOT COUNT ON IT TO GET TO US WORK ON TIME OR SAFELY. *TR

Mileage: 70,000

2005 FORD 500 AWD MALFUNCTION, FORDS REFUSAL TO OFFER ANY COMPENSATION FOR A FAULTY TRANSMISSION. *TR

Mileage: 77,000

WE OWN A 2005 FORD 500 AND MY WIFE HAS TAKEN IT TO 3 DIFFERENT FORD DEALERS TO HAVE AN ISSUE LOOKED AT. THE VEHICLE HAS STALLED ON HER OVER A DOZEN TIMES WHILE DRIVING DOWN THE HIGHWAY AND IT HAS GONE INTO FAIL SAFE MODE. THE VEHICLE SEEMS TO LURCH WHEN IN GEAR EITHER DRIVE OR REVERSE. I'VE LOOKED UP THE ISSUE ON LINE AND IT APPEARS TO BE VERY COMMON WITH THIS MODEL OF VEHICLE. THROTTLE BODY AND REPROGRAMMING OF THE PCM. I BELIEVE THIS TO BE A VERY BIG SAFETY ISSUE AND THERE NEEDS TO BE A RECALL ON THESE BEFORE SOMEONE GETS SEVERELY HURT. *TR

Mileage: 96,000

SHIFTING CONCERNS ARE GENERALLY NOTICED DURING PASSING MANEUVERS WITH TRANSMISSION AT TEMPERATURES GREATER THAN 212 F (100 C) OPERATING TEMPERATURES. SYMPTOMS MAY BE PRESENT DURING DOWNSHIFT 5-3 AT 35 MPH (56 KM/H) AND/OR 4-3 AT 20 MPH (32 KM/H) WITH THROTTLE OPENING AT APPROXIMATELY 50% OR GREATER AND INCLUDE: HARSH SHIFT AND/OR CLUNK NOISE DELAYED SHIFT AND/OR PERCEIVED SLIP/ENGINE FLARE. *TR

Mileage: 74,000

FORD 500 SE 2005 . PUT THE CAR DRIVE OR REVERSE AND THE CAR LUNGES. PUSH DOWN ON ACCELERATOR AND CAR LAGS . THROTTLE BODY DEFECTIVE. HAPPENS EVERY TIME I DRIVE THE CAR. PART NEEDS TO BE REPLACED BACK ORDERED UNTIL DECEMBER. *TR

Mileage: 69,679

I WAS DRIVING MY FORD 500 ON THE HIGHWAY, WHEN I LOST POWER TO THE TRANSMISSION. I COULD REV THE ENGINE, BUT NO POWER WOULD GO TO THE TRANSMISSION. I WAS LUCKY ABLE TO PULL OVER TO THE SIDE OF THE ROAD. THE CAR NOW HAS A LITTLE LURCH WHEN FIRST STARTING OUT. *TR

Mileage: 82,300

MY 2005 FORD 500 BEGAN TO SURGE WHEN CHANGING FROM PARK TO REVERSE AND ALSO WHEN CHANGING FROM PARK TO DRIVE . AT TIME IT WOULD CHANGE FROM 800 RPM TO 1500 TO 2500 RPM . VERY SCARY IN TIGHT QUARTERS AND IN A PARKING LOT . OTHER TIMES IT THOUGHT IT WAS A TOYOTA AND JUST TAKE OFF.FAULT CODES DID APPEAR AND THE DEALERS FIRST TRY DID NOTHING TO FIX THE PROBLEM . THE LAST TIME WAS ON THE INTERSTATE. IT TERRIFIED MY WIFE. WE DROPPED IT OFF AGAIN AT THE DEALER AND WAS TOLD THAT THE REPAIR PART WOULD TAKE 14 DAYS . DOES FORD HAVE THAT MANY PROBLEMS ? I CHECKED THE INTERNET AND MANY FORD PRODUCTS ARE HAVING THROTTLE BODY PROBLEMS . THE REPLACEMENT PART WAS COMPLETELY DIFFERENT FROM THE ORIGINAL. *TR

Mileage: 55,400

ELECTRONIC THROTTLE CONTROL IS BAD. THE CAR LUNGES FORWARD AND BACK. IT ALSO GOES INTO ENGINE FAIL SAFE MODE. IT ALSO CAUSED ME A LITTLE ACCIDENT, I WENT IN REVERSE AND THE CAR LUNGED INTO THE GARAGE WALL, BROKE THE FRAME OF GARAGE AND CAR HAS SCRATCHES AND MARKS AT THE REAR. VERY SCARED TO DRIVE, WIFE WONT DRIVE. PART IS ON BACK-ORDER, AND ITS MY ONLY CAR. HAVE WIFE AND TWO KIDS AND I DO NOT WANT THEM TO DRIVE IN THE CAR. THIS IS A SERIOUS SAFETY ISSUE AND I CAN NOT BELIEVE HOW LIGHTLY IT IS GETTING TAKEN CARE OF. FORD NEEDS TO FORCE A RECALL FAST. *TR

Mileage: 25,400

2005 FORD 500. CAR BEGAN BUCKING/SURGING/ACCELERATING ON OWN WHEN STARTING TO PULL OUT INTO HEAVY TRAFFIC FROM SHOPPING CENTER TO MAIN ROAD. STRONG BRAKING REQUIRED TO CONTROL CAR. CONTINUED TO HAPPEN, PULLED BACK INTO SHOPPING CENTER LOT. WOULD HAPPEN IN DRIVE OR REVERSE WITH CAR TAKING OFF ON OWN IF NO BRAKE APPLIED. CAR STALLED TIMES TWO. WAS ABLE TO GET CAR TO FORD DEALERSHIP IN VERY NEAR VICINITY. CONTINUED TO HAPPEN FOR SERVICE REP WHILE AT DEALERSHIP. DEALERSHIP FOUND ELECTRONIC THROTTLE BODY TO BE AT FAULT. A KNOWN PROBLEM TO EXIST, SO STATED. TSB EXISTS FOR THIS. MUST REPLACE THROTTLE BODY WITH UPDATED MODEL. UNIT ON BACKORDER. CAR UNDRIVABLE TILL PART ARRIVES. GREATER THAN 1 MONTH BACKORDER ON PART! VERY DANGEROUS SITUATION OCCURRED. COULD HAVE BEEN SERIOUS ACCIDENT. *TR

Mileage: 80,000

2005 FORD FIVE HUNDRED WITH 51000 MILES HAD CHECK ENGINE LIGHT COME ON. CAR ACCELERATES UNEXPECTEDLY WHEN SHIFTING INTO REVERSE OR FROM REVERSE TO DRIVE THEN LUNGES FORWARD OR BACKWARD LIKE IT WILL TAKE OFF ON ITS OWN. THE ENGINE SURGE CAN BE FELT EVEN STANDING STILL AT TIMES. TOLD IT IS THE THROTTLE BODY AND HAVE BEEN WAITING FOR PART AS IT IS ON BACKORDER. THIS IS AN 800.00 REPAIR AND I HAVE BEEN WAITING ALMOST A MONTH. SOMEONE COULD BE INJURED WHEN THESE VEHICLES LUNGE FORWARD OR BACKWARD UNEXPECTEDLY. I SEE MANY MANY SIMILAR COMPLAINTS WITH THIS MODEL CAR AND THIS PARTICULAR PART. I BELIEVE IT SHOULD BE RECALLED BEFORE SOMEONE IS INJURED OR WORSE. *TR

Mileage: 51,000

I AM BUYING A 2005 FORD 500 LIMITED WITH AN 6 SPD TRANSMISSION IT NOW HAS 136K MILES ON IT. IT HAS BEEN A PROBLEM EVER SINCE I PURCHASED THE VEHICLE USED FROM CROSSROADS FORD IN MEMPHIS. I HAD TO HAVE THE ENGINE REPLACED AT 54K MILES. NOW THE TRANSMISSION/TRANSAXLE IS STARTING TO SLIP AND STALL IN TRAFFIC. YOU START TO MOVE FROM A TRAFFIC LIGHT AND IT WILL GO SLOWLY THEN JUMP TO ABOUT 4K TO 6K ON THE TACHOMETER AND AT THAT POINT THE CAR STALLS AND YOU ARE ABOUT TO BE REAR ENDED BY OTHER DRIVERS DUE TO THE CAR STALLING. ACCORDING TO FORD THEY HAVE KNOWN OF THIS PROBLEM BUT ONLY OFFER SELLING YOU A NEW TRANSMISSION WHICH THEY SHOULD BE RESPONSIBLE FOR SINCE THEY BUILT THE PRODUCT EVEN IF THE FACTORY WARRANTY IS GONE. CANT AFFORD TO BUY ANOTHER CAR OR TRADE THIS ONE IN OR GET THE TRANSMISSION FIXED ACCORDING TO FORD THE REPLACEMENT IS AROUND $4600. DON'T HAVE THAT KIND OF MONEY LYING AROUND. *TR

Mileage: 135,000

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH ON APRIL 15, 2009, THE VEHICLE SUDDENLY DECELERATED AND LOST POWER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS THEN TAKEN TO A REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE MOTOR MOUNT WAS BROKEN AND IT WAS REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000. THE CURRENT MILEAGE WAS APPROXIMATELY 41,000.

Mileage: 30,000

FOR APPROXIMATELY THE PAST YEAR OUR 2005 FORD 500 HAS BEEN LURCHING WHEN SHIFTING INTO REVERSE WITH THE "WRENCH" SYMBOL ON THE DASH LIGHTING UP. I HAVE HAD THE CODES RUN AND NOTHING COMES UP. I HAVE BEEN DOING INTERNET RESEARCH ON THIS PROBLEM AND IT SEEMS THAT MANY PEOPLE HAVE REPORTED THIS ISSUE IN ONLINE FORUMS WITH MANY HAVING TO HAVE THE THROTTLE BODY REPLACED, COMPUTER REPROGRAMMED AND ACCELERATOR REPLACED. THIS ISSUE HAS NOT SHOWN UP ON FOR A RECALL BUT I DO BELIEVE IT SHOULD AS MY WIFE DRIVES THE VEHICLE AND ALMOST GOT INTO AN ACCIDENT WITH OUR THREE YOUNG CHILDREN. *TR

Mileage: 88,000

IN 2009 I TOOK MY FORD 500 TO SUTTON FORD IN THE AUTO MALL IN MATTESON, IL BECAUSE I WAS HAVING AN ACCELERATION ISSUE. THE AC LIGHT AND BOARD LIGHT WAS ON. THEY CALL ME AND I PAID THE BILL FOR ALMOST $800.00, THEY TOLD ME THAT THEY HAD REPAIRED THE PROBLEM AND GAVE ME THE CAR BACK. I RETURNED THE CAR TO THEM THE NEXT DAY BECAUSE THE AC LIGHT CAME BACK ON AND THE ACCELERATION PROBLEM STILL EXISTED. THEY REPLACED A FEW PARTS AND RETURNED THE CAR TO ME AFTER A FEW DAY. WELL THE PROBLEM WAS NOT CORRECTED AND THEY INSISTED THAT THERE WAS NOT AN ACCELERATION ISSUE WITH MY CAR AND WOULD NOT WORK ON IT ANY MORE. WELL WE HAVE DEAL WITH THIS ISSUE FOR ALMOST A YEAR LATER WHEN ON LAST NIGHT, MAY 25, 2010, MY HUSBAND AND I ALONG WITH MY GRANDSON WAS SITTING IN THE DRIVE THROUGH AT MCDONALDS WHEN WE PROCEEDED TO HAVE AN EXTREME SUDDEN ACCELERATION. IT REALLY SCARED ME AND MY HUSBAND. TO OUR SURPRISE THE PROBLEM EXIST. IT WANTED TO JET OFF AT THE STOP SIGN AND WHILE SHIFTING FROM PARK TO DRIVE AND WHILE BACKING UP. I'M RETURNING THE CAR ON TOMORROW TO SUTTON FORD WHO WAS TO DO THE FIRST REPAIR. THERE IS A SERIOUS PROBLEM WITH MY CAR AND I NEED TO GET TO THE BOTTOM OF IT BEFORE A SERIOUS INCIDENT OCCUR. *TR

2005 FORD FIVE HUNDRED ERRATIC TRANSMISSION BEHAVIOR. UNSAFE SHIFTING CAUSES CAR TO LUNGE SIDEWAYS AND VIBRATE AT HIGHER SPEEDS. THE DOWNSHIFT DELAY LUNGES THE CAR FORWARD MAKING QUICK STOPS UNSAFE AND NEARLY CREATES A WRECK EVERYDAY. *TR

Mileage: 51,000

IN PARKING SPOT. JUST STARTED CAR. FOOT ON BRAKE. SHIFTED CAR TO REVERSE GEAR. AFTER A COUPLE OR MORE SECONDS, THE CAR LURCHED, WITH MY FOOT ON THE BREAK, AND NEARLY HIT A PEDESTRIAN WALKING BEHIND MY CAR. UPON RESEARCHING THIS SYMPTOM, I DISCOVERED OTHER OWNERS OF THE FIVE HUNDRED, FREESTYLE AND TAURUS REPORTING THE SAME SYMPTOMS. THE CULPRIT APPEARS TO BE A MALFUNCTIONING THROTTLE BODY, WHICH IS OR WAS IN SHORT SUPPLY FOR REPLACEMENT. THIS PARTICULAR INCIDENT IS NOT THE FIRST TIME I EXPERIENCED THIS EVENT. THIS IS JUST THE FIRST TIME A PEDESTRIAN WAS AT RISK. THE PEDESTRIAN CAN BE CONTACTED FOR VERIFICATION. *TR

Mileage: 175,000

TRANSMISSION BUCKED WHEN TRYING TO PASS AT HIGHWAY SPEEDS. VEHICLE HAS 73,000 MILES AND NOW TRANSMISSION HAS TO BE REPLACED. ENTIRE TRANSMISSION REPLACED DUE TO SEAL FAILURE INSIDE TRANSMISSION. *TR

Mileage: 73,000

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE SUDDENLY DOWNSHIFTED GEARS AND THE RPMS BEGAN TO INCREASE. THE VEHICLE DID NOT INCREASE IN SPEED AND IT STAYED IN ONE GEAR. THE PROBLEM OCCURRED FIVE TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP BUT THE DEALER COULD NOT DUPLICATE THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 41,000. THE FAILURE MILEAGE WAS APPROXIMATELY 31,000.

Mileage: 31,000

CAR FAILS TO DOWN SHIFT WHEN ACCELERATING HARD. TRANSMISSION SLIPS AND BECOMES DISENGAGED. THIS PREVENTS ME FROM SAFELY ACCELERATING TO PASS OR AVOID OTHER VEHICLES. TRANSMISSION PROBLEM ARE CHRONIC ON THIS 2005 FORD FIVE HUNDRED 6 SPEED TRANSMISSION. *TR

Mileage: 64,555

CAR HESITATES THEN LUNGES FORWARD, AND EVEN FEELS LIKE THROTTLE GETS STUCK.. *TR

JUST PURCHASED A 2005 FIVE HUNDRED WITH 32000 MILES AND HAD TO BRING BACK TO DEALER FOR TRANSMISSION UP-DOWN HARD SHIFTING. THEY SAID THEY HAD TO FLASH W/NEW SOFTWARE. PICKED UP AND DID NOT NOTICE ANY DIFFERENCE, STILL HARD SHIFTING. HAVE 10 DAYS LEFT ON MY 60 DAY WARRANTY. WILL BRING BACK TO DEALER FOR DIAGNOSTICS. SOUNDS TO ME THAT A HUGE AMOUNT OF LOYAL FORD CUSTOMERS ARE HAVING A HUGE PROBLEM WITH THE THIS TRANSMISSION. I SUPPOSE I WILL HAVE AN TRANSMISSION FAILURE SOON TO COME. WHY IN GODS NAME IS NOBODY DOING SOMETHING ABOUT THIS PROBLEM. I ALSO HAD TO HAVE MY DRIVER HEATED SEAT PADS REPLACED BECAUSE OF FAILURE. *TR

Mileage: 31,589

I OWN A 2005 FORD 500 (PURCHASED 9/08 WITH 32K) CURRENTLY HAS 58K; TOOK TO DEALERSHIP LAST WEEK DUE TO TRANSMISSION SLIPPING AT VARIOUS SPEEDS ON CITY STREETS AS WELL AS INTERSTATE SPEEDS (CAR JERKS ERRATICALLY); WAS ADVISED IT WAS A "COMPUTER GLITCH" & DEALER CHARGED $80 FOR DIAGNOSTICS. TONIGHT I WAS DRIVING DOWN A CITY STREET WHEN SUDDENLY THE CAR BEGAN TO JERK ERRATICALLY AGAIN ONLY THIS TIME THE DISPLAY PANEL READ "FAILSAFE ENGINE MODE" AND THE CHECK ENGINE LIGHT (YELLOW WRENCH LIGHT) CAME ON; ONCE I GOT HOME I SHUT THE CAR OFF; RESTARTED IT AND THE DISPLAY PANEL CLEARED BUT FROM WHAT I'M READING ON DIFFERENT FORUMS IS THAT THIS COULD BE A MULTITUDE OF ISSUES; CAR IS UNDER EXTENDED WARRANTY; WILL BE TAKING TO DEALERSHIP TOMORROW. *TR

Mileage: 58,175

MY WIFE HAS A 2005 FORD 500 AND WE WITNESS A SUDDEN LURCH WHEN SHIFTING THE VEHICLE OUT OF PARK, ANDEVEN AT TIMES WHERE WE ARE AT A STANDSTILL. THIS HAS BEEN HAPPENING OFF AND ON FOR AT LEAST 2 YEARS. WE HAVE CONTACTED OUR LOCAL FORD DEALERSHIP AND WE KEEP GETTING TOLD ITS THE AIR FILTER BEING DIRTY. I CLEANED THE FILTER(K&N) AND REINSERTED IT IN THE VEHICLE. WE HAVE NOT HAD ANY INJURIES OR ACCIDENTS AS OF YET, BUT WE ARE AFRAID OF THE TIME WHERE IT DOES DO IT AND CAUSE AN ACCIDENT. HAVE THERE BEEN OTHER COMPLAINTS ABOUT THIS PROBLEM? *CN

Mileage: 58,000

I WAS DRIVING MY VEHICLE ON A CITY ROAD DOING 30MPH WHEN THE CAR MADE A HORRIBLE EXPLODING SOUND. AFTER THAT POINT THE CAR WAS MAKING NUMEROUS GRINDING NOISES AND WOULD NOT ACCELERATE. I STOPPED AND HAD THE CAR TOWED. THE DEALER TOLD ME IT WAS ELECTRONIC AND WANTED $1800 TO FIX IT, BUT WOULD NOT GUARANTEE THAT IT WOULD FIX THE CAR. I GOT A SECOND OPINION AND THEY SHOWED ME THE INSIDE OF THE TRANSMISSION WHICH WAS IN SHRAPNEL SIZED PIECES. THE DAMAGE WAS OBVIOUSLY NOT ELECTRONIC. THE VEHICLE IS OUT OF WARRANTY BY TIME BUT ONLY HAS 33K MILES ON IT. I AM 70+ YEARS OLD AND HAVE NEVER DRIVEN THE VEHICLE IN ANY WAY THAT COULD CAUSE THIS TYPE OF DAMAGE. I HAVE SPOKEN TO SEVERAL DEALERS AND TO FORD CUSTOMER SERVICE AND NO ONE WILL HELP ME. THE REPAIR IS OVER $6000 AND I HAVE NO GUARANTEES THAT IT WILL NOT HAPPEN AGAIN. THERE IS AN OBVIOUS MASSIVE MECHANICAL DEFECT IN THE VEHICLE THAT NEEDS TO BE INVESTIGATED. I HAVE SEEN NUMEROUS COMPLAINTS ON THIS TRANSMISSION YET FORD DOES NOT SEEM TO ACKNOWLEDGE THE PROBLEM EVEN AFTER SATURN HAD THE SAME PROBLEMS ON A SIMILAR TRANSMISSION. *TR

Mileage: 33,000

2005 FORD FREESTYLE...THROTTLE BODY ISSUES, WHEN THE CAR IS PUT INTO DRIVE IT JUMPS FORWARD. RPM'S RUN HIGH ON THE CAR AT ALL TIMES. THE CAR WILL ALSO JUMP IN REVERSE IT ALSO SOUNDS LIKE IT IS GOING TO DROP THE TRANSMISSION AT TIMES. THIS VEHICLE DOES THIS ALL OF THE TIME. IT ALSO WANTS TO SHUT DOWN WHEN YOU ATTEMPT TO ACCELERATE, LIKE TO GET ONTO FREEWAY FOR EXAMPLE. I HAVE SEARCHED THE INTERNET AND KNOW THIS IS NOT AN ISOLATED INCIDENT! THIS IS CLEARLY A HUGE ACCIDENT WAITING TO HAPPEN, NOT TO MENTION 800.00 DOLLARS IN REPAIRS. I WAS ALMOST KILLED IN MY 1995 FORD F-250 POWER STROKE DUE TO CAM SENSOR ISSUES, WHICH WAS RECALLED RIGHT AFTER I PAID FOR A TOW TRUCK AND REPAIRS. THIS ISSUE NEEDS SERIOUS ATTENTION BEFORE SOMEONE GETS KILLED, IF THEY HAVEN'T ALREADY! FORD NEEDS TO BE HELD ACCOUNTABLE. PLEASE PAY ATTENTION TO THIS! I WILL BE REPLACING THIS PART AS SOON AS I CAN FIND ONE. I HAVE TAKEN THIS VEHICLE TO A MECHANIC BUT NOT TO FORD DEALERSHIP YET. I NO LONGER TRUST FORD! NOT TO MENTION, I CANNOT AFFORD THEM... *TR

Mileage: 38,000

I OWN A FORD 500, I AM NOW ON MY THIRD REPLACEMENT OF A THROTTLE BODY. I HAVE FOUND OUT THAT THIS IS A COMMON PROBLEM ON THAT VEHICLE. THIS HAPPENS OUT OF NO WHERE AND IS DANGEROUS BECAUSE WHEN DRIVING THE VEHICLE IT JUMPS FORWARD AND COULD CAUSE AN ACCIDENT. NOT ONLY AM I IN DANGER BUT THOSE IN THE VEHICLE ARE AS WELL AS THOSE AROUND ME. THE PART IS ON BACK ORDER FOR MONTHS BUT I HAVE BEEN ABLE TO GET USED THROTTLE BODIES BUT THEY KEEP GOING OUT AND NONE HAVE BEEN SUCCESSFUL. I JUST PICKED MY VEHICLE UP FROM FORD 3 DAYS AGO AND ITS NOW BACK AT THE DEALERSHIP YET AGAIN. THE FIRST TIME THIS HAPPENED I GOT STRANDED OUT OF TOWN FOR 4 DAYS AND HAD TO DRIVE HALF WAY BACK TO MY HOME TOWN IN A RENTAL TO GET A USED PART AND DRIVE ALL THE WAY BACK. THIS A HUGE INCONVENIENCE THAT HAS COST TIME AND MONEY. THERE IS NO TELLING HOW LONG THIS REPAIR IS GOING TO TAKE ONCE AGAIN AND HOW MUCH MONEY I WILL HAVE TO GIVE AWAY AGAIN. *TR

Mileage: 84,000

I OWN A 2005 FORD 500 (SE MODEL) CAR. IT JUST PASSED 52K MILES AND THE TRANSMISSION JUST BROKEN WHEN I DROVE AT NORMAL SPEED ON HIGHWAY. I WAS LUCK THAT I CAN STILL SURVIVE. THE DEALER INSPECTED IT AND TOLD ME TO REPLACE WHOLE TRANSMISSION. FROM THE SIMILAR REPORTS FROM A LOT OF CUSTOMERS, THIS IS OBVIOUSLY A MANUFACTURING ISSUE. PLEASE INVESTIGATE FORD COMPANY ON THEIR COMMON TRANSMISSION PROBLEM. *TR

Mileage: 52,000

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING 30 MPH THE VEHICLE BEGAN SHAKING AND THEN IDLING AS IF IT WANTED TO SHUT OFF. THE VEHICLE WAS TAKEN TO THE DEALER AND INSPECTED WHERE IT WAS DETERMINED THAT THE VALVE BODY BOX WAS FAILING AND THE COST FOR REPAIR WOULD BE $1800.00. THE VEHICLE HAS NOT BEEN REPAIRED AND THE CONTACT IS TRYING TO GET THE MANUFACTURER TO COVER THE COST OF THE REPAIR. THE CONTACT CALLED THE MANUFACTURER AND A COMPLAINT WAS FILED AND THE CONTACT WAS ADVISED THAT HER CLAIM WOULD BE REVIEWED. THE FAILURE MILEAGE WAS 25,281 AND THE CURRENT MILEAGE WAS 74,000. UPDATED 11/10/09 *CN THE CONSUMER STATED THE VEHICLE SHUT OFF SEVERAL TIMES, THE GAUGE ACT ERRATICALLY. UPDATED 11/18/09

Mileage: 25,281

WHILE DRIVING FOR OVER 45 MINUTES OR A REALLY HOT DAY CAR WILL BUCK AND SHAKE WHEN SLOWING DOWN. AFTER THAT IT HAS HAPPENED TWICE CAR SLIPS OUT OF GEAR THEN KICK BACK IN 30 SECONDS LATER WHILE GOING 65MPH ON HIGHWAY TRYING TO PASS SOMEONE.BROUGHT INTO DEALER SAID NEVER HEARD OF THIS AND COULD NOT REPEAT OCCURRENCE. SO UPGRADED COMPUTER FOR $ 250.00 DID NOT FIX ANYTHING ,THEN HAD TO WAIT 3 WEEKS FOR ANOTHER APPOINTMENT GOING ON THURSDAY WISH ME LUCK. *TR

Mileage: 65,000

I PURCHASED A USED 2005 FORD FIVE HUNDRED IN JULY 2008. AT THE TIME THE CAR HAD 68K MILES, AND NO WARRANTY. IN JANUARY, MY CAR STARTED DOWN-SHIFTING VERY ROUGH AROUND 1000 RPM. THIS HAPPENS AT EVERY DOWN-SHIFT AFTER THE ENGINE REACHES A CERTAIN TEMPERATURE. IT ALSO SHIFTS HARD WHEN I ACCELERATE AS IF TO PASS SOMEONE ON THE INTERSTATE. FORD HAS FLASHED THE COMPUTER AND FOUND NO PROBLEMS. THEY SUGGESTED THAT I REPLACE THE VALVE BODY AND FLUID. I HAVE BEEN CHECKING MESSAGE BOARDS AND HAVE NOTICED MANY OTHER CONSUMERS ARE HAVING THE SAME EXACT ISSUE WITH THEIR FIVE HUNDREDS, TAURUSES, AND MONTEGOS WITH THE CVT TRANSMISSION. HOWEVER, NO ONE SEEMS TO HAVE FOUND A SOLUTION AT THIS TIME, AND FORD HAS NOT MADE ANY RECALLS. I REFUSE TO SHELL OUT RIDICULOUS AMOUNTS OF MONEY TO "MAYBE" FIX THIS SERIOUS TRANSMISSION ISSUE. ALSO, I AM UNABLE TO TRADE MY CAR FOR SOMETHING ELSE BECAUSE IT IS NOW COMPLETELY DEVALUED. PLEASE HELP THE HUNDREDS OF FORD CONSUMERS WHO SHARE IN THIS ISSUE. *TR

Mileage: 75,000

I'M DRIVING A 2005 FORD 500 THAT I HAVE FOUND TO BE A CRASH WAITING TO HAPPEN. CAR ONLY HAS 55K MILES ON IT AND I'M GETTING NOTHING BUT TROUBLE FROM THE TRANSMISSION. THIS IS A COMMON PROBLEM WITH FORDS CVT TRANSMISSION. HTTP://WWW.FORDFORUMS.COM/F632/MERGED-TRANSMISSION-PROBLEMS-PLEASE-POST-THEM-HERE-160576/ THE TRANSMISSION BUCKS, SKIPS AND SHAKES WHEN DECELERATING/ACCELERATING AROUND 25MPH. IT DOES THE SAME THING WHEN TRYING TO ACCELERATE FAST TO PASS SOMEONE. OR DRIVING ON A INCLINE/DECLINE. FORD HAS A SERIOUS PROBLEM HERE AND THEY ARE NOT OWNING UP TO IT! *TR

Mileage: 45,000

05 FORD FIVE HUNDRED FWD. TRANSMISSION SHUDDER DOWN SHIFTING AROUND 1500 RPM FEELS ALMOST LIKE A BRAKE PROBLEM. HAPPENS MORE AND MORE OFTEN ESPECIALLY ON HOT DAYS. DEALER SERVICED TRANSMISSION 55,000 MILES CHANGING FLUID AND COMMUNICATING NO APPARENT PROBLEMS. TOTAL FAILURE 58,000 MILES NO REVERSE AT ALL ,COULD DRIVE IT ON THE TRAILER IN LOW. WILL REQUIRE A NEW TRANSMISSION FOR SURE, THIS IS THE LAST FORD. *TR

Mileage: 58,000

I BOUGHT MY 2005 FORD 500 IN MISSOURI NOW LIVE IN NEW JERSEY THE TRANSMISSION STARTED ACTING UP AT 42, 000 MILES IT HAS HARD SHIRTS WITH A CLUNKING NOISE WHICH WAS DIAGNOSED AS A VALVE BODY IN THE TRANSMISSION I WAS READING IN THE FORD FORUMS THEIR IS QUITE OF FEW CARS WITH THE SAME PROBLEM WITH FORD 500.. I HAD TO PULL OFF THE ROAD ONCE THE TRANSMISSION ALMOST GOT ME IN A ACCIDENT. I KNOW FORD KNOWS OF THE PROBLEMS BUT DOESN'T CARE . *TR

Mileage: 42,000

I HAVE AN 05 FORD 500, 2 WHEEL DRIVE, W/6 SPEED AT/TRANS. AT 30K MILES IT DEVELOPED A TRANSMISSION "SLIPPAGE/JERK" WHEN SLOWING TO A STOP FROM 35MPH OR LESS. I HAVE ALSO NOTICED THE SAME WHEN ACCELERATING AT HIGHWAY SPEEDS OR CLIMBING A HILL WHEN I HIT PASSING GEAR. I CANNOT USE THE CRUISE CONTROL IN HILLY TERRAIN BECAUSE OF THIS PROBLEM. IT FEELS AS IF THE WHOLE FRONT END OF THE CAR WILL JERK LOOSE. *TR

Mileage: 25,000

2005 FORD 500 SIX-SPEED AUTOMATIC TRANSMISSION SHIFTS TO NEUTRAL WHEN DRIVER IS ATTEMPTING TO PASS AT HIGHWAY SPEEDS. SO FAR OTHER DRIVERS HAVE ALSO COMPLAINED TO FORD. SO FAR FORD IS NOT ACKNOWLEDGING THIS AS A SERIOUS PROBLEM AND HAS NOT ISSUED A RECALL. *TR

Mileage: 40,000

TRANSMISSION IN FORD FIVE HUNDRED IS GOING BAD AT 65,000. *TR

Mileage: 65,000

I HAVE A FORD FIVE HUNDRED 2005 SEL.WITH ONLY 50,000 MILES ON IT. WHEN THE CAR GETS WARM THE TRANSMISSION WILL SHIFT IN TO A LOWER GEAR WHILE DRIVING ON THE ROAD. I WAS ALMOST HIT FROM BEHIND BECAUSE OF THIS. I NOTICED ON THE INTERNET THAT THIS IS A COMMON PROBLEM WITH FORDS. *TR

Mileage: 50,000

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING 55 MPH, THE VEHICLE SLIPPED OUT OF GEAR AND THE RPM'S INCREASED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY COULD NOT PROVIDE A REMEDY. THE CONTACT FEELS THAT A CRASH COULD OCCUR DUE TO THE OVER ACCELERATION. THE CURRENT MILEAGE WAS 120,000 AND FAILURE MILEAGE WAS 60,000.

Mileage: 60,000

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE PLACING THE VEHICLE INTO PARK, THE CONTACT NOTICED A LOUD WHINING NOISE COMING FROM THE ENGINE. WHEN PLACING THE VEHICLE INTO REVERSE, SHE HEARD A LOUD NOISE COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY DETERMINED THAT THE TRANSMISSION WAS FAILING. THE REPAIR COULD COST UP TO $5,100. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT NO COMPENSATION WOULD BE PROVIDED BECAUSE HER VEHICLE WAS NOT UNDER WARRANTY. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 44,000 AND CURRENT MILEAGE WAS 48,000.

Mileage: 44,000

THE AWF21 TRANSMISSION ON MY 2005 FORD FIVE HUNDRED IS "BUCKING" ON DOWNSHIFTING AND UP SHIFTING AFTER IT IS WARMED UP AND DRIVEN FOR ABOUT 35-45 MINUTES. THIS IS DANGEROUS AND CAUSES CONFUSION TO THE OTHER DRIVERS IN MY FAMILY. THIS HAS BEEN OCCURRING ON AND OFF FOR ABOUT 30 DAYS. *TR

Mileage: 62,500

WHEN THE CAR IS VERY WARM (START AFTER A SHORT TIME OF BEING PARKED OR 100+ DEGREE DAY), WHEN THE TRANSMISSION IS SHIFTED INTO DRIVE OR REVERSE, THE ENGINE REVS TO 1,500 RPM AND THE TRANSMISSION ENGAGES MAKING THE CAR LURCH FORWARD, THEN STALLS OCCASIONALLY. THE SERVICE INDICATOR (WRENCH) LIGHT COMES ON AND THE ENGINE OPERATES IN FAIL-SAFE MODE. IF THIS HAPPENS, THEN THE CAR LURCHES WHEN YOU LET OF THE THROTTLE (TRANSMISSION "CLUNKS"). TURN THE CAR OFF AND LET IT SIT UNTIL IT COOLS AND THE SERVICE LIGHT TURNS OFF AND THE CAR DRIVES NORMAL AGAIN. IT'S A CVT TRANSMISSION. *TR

Mileage: 76,000

2005 FORD 500 - LIMITED RECEIVED A AWD MALFUNCTION WITH IN THE DASHBOARD WARNING SYSTEM. THE MALFUNCTION HAS BEEN OFF AND ON FOR THE LAST TWO WEEKS. NO APPARENT DRIVABILTY WHEN THE MALFUNCTION COMES ON. WOULD RESET IT SELF AFTER THE IGNITION IS TURNED OFF AND THE WARNING WOULD COME ON BACK ON AFTER APPROXIMATELY 25 MINS OF DRIVING. BROUGHT THE CAR TO AUTO MECHANIC AND HAD THE COMPUTER CONNECTED AND GOT A P1889 CODE, WHICH IS TO REPLACE THE OIL PUMP PRESSURE SENSOR. AFTER REPLACING THE SENSOR WITH A KIT SUPPLIED BY FORD THE WARNING STILL CAME UP THE NEXT DAY AFTER 25 MINS OF DRIVING. THAT IS WERE I AM TODAY. *TR

Mileage: 72,000

HI I'M FROM MEXICO AND I GOT A PROBLEM WITH MY FORD FIVE HUNDRED 2005 TRANSMISSION WHICH I HAVE READ A LOT OF CONSUMERS ALSO GOT, IN FACT I WAS ON MY WAY TO THE JOB (IN THE CHAOTIC CITY OF MEXICO) WHEN SUDDENLY IT BEGAN TO JERK AND THEN THE CAR GOT NO TRACTION, I CANT ACCELERATE NEITHER SUSTAIN VELOCITY, FORTUNATELY THE CAR THAT WAS BEHIND ME REALIZE OF MY PROBLEM AND AWARE THE TRAFFIC TO DE-ACCELERATE, AFTER THAT I STOP THE CAR AND SEE THAT IT WAS SPILLING OIL FROM THE TRANSMISSION. I TURN IT OFF AND RESTART THE ENGINE BUT THE CAR STILL DOES NOT MOVE BY ITSELF SO I WAIT FOR THE WRECKING CRANE TO TAKE THE CAR WITH THE DEALER. WHAT IMPRESSED ME IS THAT THE CAR ONLY GOT 25,000 MILES AND IT WAS SPILLING OIL. THE TOLD ME THAT THE TRANSMISSION MUST BE CHANGED, BUT MY WARRANTY RUN OUT ON JANUARY AND THE CHANGE OF WILL HAVE A COST OF 10,000 US DOLLARS. I'M WRITING TO YOU TO CHECK WITH FORD THIS PROBLEMS CAUSE THE LOSE THE LOSE CONTROL OF THE ENGINE AND THE JERK SPILLING OIL WILL PROBABLY HAVE CAUSED AN ACCIDENT. *TR

Mileage: 25,000

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHEN DRIVING ABOVE 50 MPH, THE VEHICLE SHAKES AND EXPERIENCES DIFFICULTY SWITCHING GEARS. THE VEHICLE HAS NOT BEEN DIAGNOSED TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 56,000. UPDATED 10/16/08 *BF THE CONSUMER WAS INFORMED THERE WAS A POSSIBILITY THERE WAS SOME INTERNAL DAMAGE TO THE TRANSMISSION. UPDATED 10/20/08.*JB

Mileage: 56,000

FOR THE PAST MONTH OR SO MY FORD FIVE HUNDRED (2005 @ 64,000 TEXAS HWY MILES) HAS BEEN SHIFTING HARD AND CHANGING GEARS ERRATICALLY, WHILE MAKING CLUNKING NOISES. WE TOOK IT TO OUR REPAIR SHOP AND THEY WERE MYSTIFIED SO THEY SENT IT TO THEIR TRANSMISSION SPECIALTY SHOP. IT TURNS OUT THAT THEY HAVE ANOTHER FIVE HUNDRED IN THE SHOP GETTING ITS TRANSMISSION REPLACED BECAUSE OF THE SAME PROBLEMS. WE JUST HAD THE TRANSMISSION FLUSHED AND OIL CHANGED BUT THAT DID NOT HELP. THE TRANSMISSION SHOP CONTACTED THE FORD DEALER SERVICE CENTER AND THEY GAVE THEM THE CODES TO 'FLASH' THE NEWEST CODES INTO THE TRANSMISSION & THROTTLE COMPUTERS. NO CHANGE. THEY TESTED NEW TRANSMISSION MODULES WITH NO CHANGE. SO NOW THEY SAY THEY HAVE TO CHANGE OUT THE TRANSMISSION @ $4,300. THIS IS NOT GOOD! THE TRANSMISSION SPECIALIST SAYS THIS IS THE 4TH FIVE HUNDRED HE HAS HAD THIS PROBLEM WITH AND THAT THEY CANNOT GET PARTS TO REPAIR THE TRANSMISSION SO THEY HAVE NO OTHER OPTION BUT TO REPLACE IT. I CONTACTED MY FORD DEALER AND THEY ALSO SAY THEY CANNOT GET PARTS FOR THE TRANSMISSION. TOMORROW I AM GOING TO THE BIG GUYS AT FORD AND GET AN ANSWER FROM THEM ABOUT WHAT IS GOING ON. *TR

Mileage: 640,000

I HAVE A FORD FIVE HUNDRED LIMITED. THE CAR HAS STOP RUNNING WHILE THE CAR IS IN GEAR AND MOVING. IT ALSO STOPPED WHEN I STARTED TO DRIVE FROM A STOP LIGHT. WHILE IT WAS BEING FIXED AT THE CAR DEALERSHIP IT STOP (DIED) ON THEM SEVERAL TIMES. THE FORD DEALER COMPANY THOUGHT IT WAS THE POWER STEERING PUMP BECAUSE THE POWER STEERING PUMP WAS MAKING A KNOCKING SOUND. THEY ALSO NOTICED THAT IF THEY WAS TO TURN THE WHEEL IT WOULD USUALLY DIE ON THEM. THE DEALERSHIP HAS REPLACED THE BATTERY, POWERSTEERING PUMP, BELT AND THE THROTTLE AND THE CAR STILL DIES. MY UNDERSTANDING FROM THEM IS THAT THEY HAVE NEVER COME ACROSS THIS PROBLEM BEFORE. WHAT MADE ME TAKE THE CAR IN TO BEGIN WITH WAS THAT I WENT TO START THE CAR AFTER PLAYING TENNIS FOR ABOUT 45 MINUTES AND IT WOULDN'T START. THE BATTERY WAS SOMEWHAT DEAD AND THE SECURITY LIGHT WAS FLASHING RAPIDLY. *TR

Mileage: 50,076

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT ACCELERATED TO SWITCH LANES; HOWEVER, THE GEARS WOULD NOT SHIFT. HE HEARD A LOUD, BANGING NOISE UNDER THE HOOD OF THE VEHICLE AND IT BEGAN TO JERK. THE CONTACT WAS FORCED TO REMAIN AT THE SPEED HE WAS TRAVELING BEFORE ATTEMPTING TO ACCELERATE. THE SAME FAILURE RECURRED THREE DAYS LATER. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THERE WAS DOWNSHIFTING FAILURE, AND RECOMMENDED THAT THE TRANSMISSION BE REPLACED. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE VEHICLE HAS NOT YET BEEN REPAIRED. THE FAILURE MILEAGE WAS 40,100 AND CURRENT MILEAGE WAS 42,000.

Mileage: 40,100

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE APPROACHING A STOP SIGN, THE VEHICLE WOULD NO LONGER GO FORWARD. THE VEHICLE WOULD ONLY MOVE IN REVERSE. THE CONTACT WAS CLOSE TO HER RESIDENCE AND DROVE THERE IN REVERSE. THE VEHICLE WAS TOWED TO THE DEALER AND THEY CHECKED THE FLUID LEVELS AND THE TRANSMISSION LIGHT. A DIAGNOSTIC WAS PERFORMED AND THE PCM AND TCM WERE REPROGRAMMED. IN APRIL OF 2008, THE VEHICLE HESITATED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO A SERVICE CENTER FOR ANOTHER DIAGNOSTIC AND WAS CHARGED OVER $500. THE CURRENT MILEAGE WAS APPROXIMATELY 17,000 AND FAILURE MILEAGE WAS APPROXIMATELY 4,000. UPDATED 07/15/08. *LJ UPDATED 07/15/08

Mileage: 4,000

PURCHASED MY 500 9/05 IT ONLY HAD 5 MILES ON IT. 6 MONTHS LATER LOUD EXPLOSION IN ENGINE WHICH BEGAN TO LEAK SOME SORT OF FLUID GOT THE CAR TOWED TO DEALER PURCHASED WAS TOLD A/C LEAKING OIL AND THEY HAD TO REPLACE THE MANIFOLD I WASN'T EVEN USING THE A/C WAS MARCH!!! MY DASH CONSOLE HAD TO BE REPLACED SINCE IT WAS DEFECTIVE AND THE COMPUTER ALSO HAD TO BE REPROGRAMMED SINCE THE CAR WOULDN'T START IN 30 DEGREE WEATHER THIS HAPPENED IN JAN06......MY FUEL STRAPS WERE REPLACED DUE TO RECALL AND MY DOOR LOCKS WERE REPLACED DUE TO RECALL AND I HAD 22K MILES WHEN THE BACK BRAKES BEGAN MAKING A TERRIBLE GRINDING NOISE WHEN BACKING UP TOOK TO DEALER SAID THAT ALTHOUGH CAR IS UNDER WARRANTY BRAKES ARE UNDER WEAR AND TEAR AND WOULD NOT BE COVERED NOW WHICH DIDN'T MAKE ANY SENSE SINCE THE FRONT BRAKES WERE GOOD HOW COULD BACK BRAKES GO BAD BEFORE FRONT BRAKES UNLESS YOU ONLY DRIVE YOUR CAR IN REVERSE????? I PAID THE $400 TO FIX SINCE WAS INFORMED 500 ROTORS CANT BE TURNED EVER WILL ALWAYS HAVE TO PURCHASE NEW ONES......THEN 6 MONTHS LATER BRAKES WERE RECALLED AND I DID REQUEST REFUND WHICH I DID RECEIVE. HOWEVER I NOW HAVE 44K NO LONGER HAVE WARRANTY SINCE EXPIRED AND I DIDN'T BUY EXTENDED WARRANTY BROUGHT CAR IN TO FORD SINCE TRANSMISSION LIGHT WAS TURNING ON AND OFF ALONG WITH THE TRACTION CONTROL LIGHT THEN HAD TRANS CENSOR REPLACED WAS TOLD THAT WAS PROBLEM THEN 2 DAYS LATER LIGHT STILL TURNING ON AND CAR WILL NOT REVERSE TOOK INTO DEALER AGAIN WAS TOLD TRANS AXLE BROKE IN HALF AND NEED NEW TRANS WHICH COSTS $5300 CAR IS ONLY WORK 9K!!!! FORD COMPANY SAID THEY WILL OFFER ASSISTANCE ONLY OF 3K SINCE OUT OF WARRANTY THEY ALSO INFORMED ME THAT HAD I PURCHASED THE EXTENDED WARRANTY I WOULD ONLY BE PAYING $100 NOTHING LIKE THROWING THAT IN YOUR FACE. I HAVE NO CHOICE BUT TO PAY IT NEED A CAR AND AM A SINGLE PARENT OF 2. ALSO BACK DOORS TRIM IS COMING APART PASSENGER SINCE IS COMPLETELY ROTTED OUT. *TR

Mileage: 44,444

DRIVING AT APPROXIMATELY 40-45 MILES PER HOUR A LOUD NOISE EMANATED FROM THE BOTTOM OF THE CAR, ENGINE RPMS RACED FROM 1500 TO 4500, A CLATTERING NOISE FOLLOWED SOUNDING LIKE A METAL SPOON DROPPED INTO A RUNNING GARBAGE DISPOSAL, CAR DRAMATICALLY SLOWED COMPLETE LOSS OF ACCELERATION CONTROL, STEERING CONTROL UNCERTAIN AS CAR WANDERED. NO UNUSUAL EVENTS OCCURRED PRIOR TO THIS INCIDENT, ITS OCCURRENCE CAME WITHOUT WARNING AND WAS TOTALLY UNEXPECTED. EVENT OCCURRED ON TWO LANE RURAL ROAD,VEHICLES FOLLOWING AND ONCOMING HAD TO TAKE EVASIVE ACTION BUT NO COLLISION OCCURRED. PASSENGERS STRANDED. VEHICLE TOWED TO DEALERSHIP. RIGHT AXLE SHAFT BROKEN IN HALF. RIGHT AXLE CARRIER BEARING BROKEN TRANSMISSION AND SPLINES DAMAGED. OLD PARTS ARE AVAILABLE. AXLE SHAFT AND CARRIER BEARING WERE REPLACED AND TRANSMISSION SPLINES FILED DOWN. *TR

Mileage: 49,016

DRIVING AT APPROXIMATELY 40-45 MILES PER HOUR A LOUD NOISE EMANATED FROM THE BOTTOM OF THE CAR, ENGINE RPMS RACED FROM 1500 TO 4500, A CLATTERING NOISE FOLLOWED SOUNDING LIKE A METAL SPOON DROPPED INTO A RUNNING GARBAGE DISPOSAL, CAR DRAMATICALLY SLOWED COMPLETE LOSS OF ACCELERATION CONTROL, STEERING CONTROL UNCERTAIN AS CAR WANDERED. NO UNUSUAL EVENTS OCCURRED PRIOR TO THIS INCIDENT, ITS OCCURRENCE CAME WITHOUT WARNING AND WAS TOTALLY UNEXPECTED. EVENT OCCURRED ON TWO LANE RURAL ROAD,VEHICLES FOLLOWING AND ONCOMING HAD TO TAKE EVASIVE ACTION BUT NO COLLISION OCCURRED. PASSENGERS STRANDED. VEHICLE TOWED TO DEALERSHIP. RIGHT AXLE SHAFT BROKEN IN HALF. RIGHT AXLE CARRIER BEARING BROKEN TRANSMISSION AND SPLINES DAMAGED. OLD PARTS ARE AVAILABLE. AXLE SHAFT AND CARRIER BEARING WERE REPLACED AND TRANSMISSION SPLINES FILED DOWN. *TR

Mileage: 49,016

CAR RANDOMLY STALLS. ON OCCASIONS WHEN THE ACCELERATOR IS DEPRESSED THE CAR DOES NOT MOVE IT STUTTERS, I EVEN TRIED TO DEPRESS THE GAS PEDAL TO THE FLOOR AND STILL NOTHING. I HAVE TAKEN MY CAR TO THE LOCAL FORD DEALER FOR SERVICE. THE ONLY THING THAT I WAS TOLD "THE COMPUTER CHIP IN THE TRANSMISSION NEEDED UPDATED." OK THIS HASN'T CORRECTED MY PROBLEM. I AM AFRAID THAT THIS COULD CAUSE ME TO GET INTO AN ACCIDENT. I HAVE TWO SMALL CHILDREN, I HOPE THAT THEY ARE NOT IN THE CAR WHEN IT HAPPENS. I AM ASSUMELY THAT THE REASON THIS HASN'T BEEN RECALLED YET, IS BECAUSE FORD DOESN'T HAVE A REPAIR FOR THIS. BESIDES THE OBVIOUS, REPLACING THE TRANSMISSION. PLEASE LOOK INTO THIS. YOU MAY NEED TO DRIVE ONE, I WILL LET YOU USE MINE. JUST SO THIS GETS TAKEN CARE OF. *TR

PURCHASED FORD FIVE HUNDRED IN FEBRUARY 2006, AN SEL AUTOMATIC. AROUND 15,000 MILES BEGAN NOTICING TRANSMISSION ISSUES, MOSTLY HESITATION WHEN SHIFTING INTO GEAR. FIRST MAJOR INCIDENT OCCURRED OCT. 22, 2006 WHILE TRAVELING AT 65 MILES PER HOUR ON THE FREEWAY, ENGINE REVVED WHILE PRESSING THE GAS PEDAL BUT VEHICLE SLOWED AS IF IT WAS IN NEUTRAL. THEN IT PUNCHED VIOLENTLY AND RESUMED DRIVING NORMALLY. WE PULLED OVER THINKING SOMETHING MAJOR WAS WRONG WITH THE VEHICLE. WE BEGAN OUR JOURNEY AGAIN AND HAD SEVERAL INCIDENTS OF MINOR PUNCHING OF THE TRANSMISSION, LIKE IT WAS SLIPPING OUT OF GEAR AND GOING BACK IN AGAIN. AFTER WE RETURNED HOME, THESE PROBLEMS WERE VERY INTERMITTENT. ABOUT 2 WEEKS LATER WHILE DRIVING ON THE FREEWAY, THE VEHICLE SLIPPED OUT OF GEAR AND ALMOST CAME TO A COMPLETE STOP BEFORE RE-ENGAGING. WE BROUGHT IT TO THE FORD DEALER THE SECOND WEEK IN NOVEMBER. THEY SAID THEY COULD NOT DUPLICATE THE ISSUE, HOWEVER THEY SAID THERE WAS A COMPUTER TECHNICIAN LOG THAT SUGGESTED A RESET. THEY RESET THE COMPUTER, CHANGED THE OIL, CHECKED THE TRANSMISSION FLUID, ETC. A FEW DAYS LATER THE TRANSMISSION WAS BACK TO SLIPPING INTERMITTENTLY. ON NOVEMBER 20, 2006, THE SEVERE PUNCHING BEGAN AGAIN, SO BAD THIS TIME THE VEHICLE ALMOST CAME TO A COMPLETE STOP. WE HAD TO SHIFT THE GEAR INTO 2ND BEFORE IT ENGAGED AND WE WERE ABLE TO ACCELERATE. SINCE WE WERE ON VACATION, WE HAD TO CONTINUE ON OUR TRIP WITH THE TRANSMISSION SLIPPING IN AND OUT OF GEAR. WHEN WE RETURNED FROM OUR TRIP, BACK TO THE FORD DEALER WE WENT. WE TOOK THE TRANSMISSION TECHNICIAN GUY FOR A TEST DRIVE AND LUCKILY WE WERE ABLE TO DUPLICATE THE PROBLEM. HE WAS AMAZED, HADN'T SEEN ANYTHING LIKE IT BEFORE. HE TALKED TO OTHER TRANSMISSION TECH'S WHO WERE STUMPED BY THE PROBLEM, TOO. HE ENDED UP CALLING FORD HEADQUARTERS AND SPOKE WITH THE ENGINEERS. THEY DECIDED A COMPLETE REPLACEMENT OF THE TRANSMISSION WAS IN ORDER BECAUSE THEY WEREN'T SURE WHAT WAS CAUSING THE PROBLEM. *JB

Mileage: 15,000

2005 FORE FIVE HUNDRED- THE FOLLOWING PROBLEMS HAVE OCCURRED; 1)FOUR TIMES THE CHECK TRANSMISSION LIGHT HAS COME ON , AND CAR THEN WAS UNABLE TO DRIVE FASTER THAN 40 MPH. EACH TIME CAR WAS BROUGHT TO THE DEALERSHIP FOR REPAIRS, INCLUDING REPLACING MODULES AND THE TRANS AXLE PAN. CURRENTLY THE CAR AT THE DEALERSHIP FOR THIS PROBLEM. 2) ON TWO SEPARATE OCCASIONS DRIVER'S SIDE FRONT WINDOW WOULD GO TO THE DOWN POSITION WHEN THE BUTTON WAS PRESSED FOR THE UP POSITION. THE WINDOW MOTOR AND HARNESS WERE REPLACED AFTER THE FIRST INCIDENT. CURRENTLY AT DEALERSHIP FOR THIS PROBLEM ALSO. *NM

Mileage: 14,000

BRAND NEW 2005 FORD 500 PURCHASED ON SEPTEMBER 24 2005 BEGAN AT 15000 MILES WITH BRAKE PROBLEMS. SAME PROBLEM OCCURRED AT 30,000 MILES. MY JOB IS 100% SALES AND MY CAR IS MY ONLY REVENUE PROVIDER. AT 35,000 CAR SHOWING PROBLEMS WHEN HITTING THE GAS, IT WOULD NOT RUN. AT 39,000 MILES AN ELECTRIC SHORT CIRCUIT. AT 39,000 I ASKED THE DEALER TO RECHECK THE WHOLE CAR THAT IT WAS SHOWING TRANSMISSION AND BRAKE PROBLEMS. AT 43,000 MILES NOW IS SITTING IN THE FORD DEALER WHERE I PURCHASED AT SINCE LAST FRIDAY SEPT 22,2006. THE FORD DEALER MECHANICAL DIRECTOR WAS INSIDE THE CAR AND ME TEST DRIVING IT, AND COULD NOT BELIEVE THE PROBLEMS WITH THE TRANSMISSION. HIS WORDS WERE' IF THIS WAS MY CAR I WOULD NOT BE SITTING IN IT, IT'S A RISK TO ANYONE'S LIFE" TODAY, FORD INFORMED ME THAT THEY HAVE TO BRING THE TRANSMISSION DOWN AND OPEN IT. THEY ASK ME EVERY TIME TO SIGN IN ACCEPTANCE THEY WILL PAY FOR EVERYTHING. IT IS BEING REPORTED TO CONSUMER AFFAIRS DEPARTMENT TOMORROW, I HAVE NOTIFIED THE BANK WHO GAVE ME THE LOAN. THIS DOES NOT INCLUDE ALL THE CAR RENTAL EXPENDITURES I'VE HAD TO INCUR IN ADDITION TO CONSTANT REPAIRS PRIOR TO CAR REACHING 1 YEAR. *JB

Mileage: 35,000

ON THE TWO OCCASIONS THAT WE HAD SNOW THIS PAST WINTER, MY FORD 500 BEGAN TO SURGE UNCONTROLLABLY AND THE ENGINE FAILURE LIGHT CAME ON WHEN ACCELERATING. IT BECAME NECESSARY TO PULL TO THE SIDE OF THE ROAD AND TURN THE VEHICLE IGNITION OFF. WHEN I RESTARTED, THE TROUBLE LIGHT WAS OFF AND I CONTINUED MY JOURNEY HOME. WITHIN A FEW MINUTES THE SAME PROBLEM OCCURRED, ENGINE FAILURE LIGHT AND THE SURGING. NEEDLESS TO SAY, IT TOOK QUITE AWHILE TO GET HOME. I BROUGHT THE VEHICLE TO AN AUTHORIZED FORD DEALER THE FIST TIME AND THEY COULD NOT FIND ANYTHING WRONG. AFTER THE SECOND SNOW STORM, AND THE SAME SYMPTOMS, THE DEALER SAID THE PROBLEM OCCURRED BECAUSE THE FILTER WAS INSTALLED BACKWARDS. SOMEWHAT SKEPTICAL, I ACCEPTED THEIR EXPLANATION BECAUSE OF MY GOOD RELATIONSHIP WITH THE DEALER OWNER AND SERVICE MANAGER. WHILE AT WORK THE OTHER DAY, I NOTICED A CO-WORKER WITH A SIMILAR TYPE VEHICLE AND INQUIRED AS TO HOW SHE LIKED THE FORD 500. HER RESPONSE SHOCKED ME WHEN SHE STATED THAT SHE LIKED THE VEHICLE, BUT HAD TROUBLE THIS PAST WINTER IN THE SNOW. SHE DESCRIBED THE SAME PROBLEM THAT I HAD EXPERIENCED AND NOW I WONDER HOW MANY OTHER 2005 FORD 500 OWNERS HAVE EXPERIENCED THE SAME PROBLEMS. I AM HOPING THAT YOU WILL BE ABLE TO ASSIST ME IN DETERMINE THE CAUSE OF THIS PROBLEM. *JB

Mileage: 21,060

DT*: THE CONTACT STATED WHILE APPLYING PRESSURE TO THE ACCELERATOR PEDAL AND THE VEHICLE HESITATED. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS CONTACTED. UPDATED 05/30/06.*AK

Mileage: 9,450

DT: THE CONTACT OWNS A 2005 FORD 500 SEL. THE VEHICLE WAS MADE WITH A SIX SPEED AUTOMATIC TRANSMISSION. WHEN GOING DOWN HILL IT HAS A OVERDRIVE IN THE TRANSMISSION. WHEN THE CONSUMER REMOVED HIS FOOT FROM THE ACCELERATOR THE VEHICLE BEGAN TO SPEED UP GOING DOWN HILL AND IF PRESSING THE BRAKES FOR A LONG DISTANCE, THE BRAKES WILL GET HOT. MANUFACTURER TOLD HIM THAT THIS WAS THE WAY THE VEHICLE WAS DESIGNED. THE CONTACT FELT THAT THERE SHOULD BE SOME WAY TO TURN THE OVERDRIVE OFF. HE OWNED OTHER FORD VEHICLES THAT HAD THE OPTION TO TURN THE OVERDRIVE OFF. *AK *JB

DT: LAST SUNDAY THE CONSUMER DISCOVERED SHE HAD A FLAT TIRE. WHEN SHE ATTEMPTED TO START THE VEHICLE, THE MOTOR STARTING RACING AND MAKING A LOUD NOISE LIKE IT WAS REVVING UP. THE TRANSMISSION LIGHT CAME ON. THE CONSUMER PLACED THE VEHICLE IN PARK THEN PUT IT INTO DRIVE AND IT WOULD NOT MOVE AT ALL. THE TRANSMISSION WOULD NOT ENGAGE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER WHO COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE. THEY THINK IT WAS JUST A GLITCH. *JB

Mileage: 6,908

DT: 2005 FORD 500 SEDAN DID NOT HAVE AN INTERMEDIATE OR SECOND GEAR FOR GEARING DOWN TO GOING DOWN MOUNTAINS. THIS WAS A SAFETY ISSUE, AND NEEDED TO BE BROUGHT TO FORD'S ATTENTION. *AK *NM

VEHICHLE CONSTANTLY SHIFTING. "SEARCHES" FOR FOR CORRECT GEAR. HAD COMPUTER REPLACED AND A WEEK LATER REOCCURRED. REPROGRAMMED COMPUTER AGAIN AND REOCCURRED. FORD UNABLE TO REPAIR. LOSING 6-8 MPG.*AK

Mileage: 560

UPON PUTTING THE VEHICLE IN PARK IT WILL PUT ITSELF INTO REVERSE. THIS HAPPENED TWICE. GOING DOWN HILL THE AT 50 MPH THE SPEEDOMETER WILL DROP TO 20 MPH. LOSING TWO TO TWO AND ONE HALF MILES TO A GALLON. CONTACTED THE DEALER. TOOK THE VEHICLE IN. FORD HAD THE VEHICLE FOR FOUR WEEKS. FORD STATED THERE WAS NOTHING WRONG WITH THE VEHICLE. HOWEVER, THE PROBLEM RECURRED. *AK