2006 FORD FOCUS Electrical System Problems

THE WIRING HARNESS FLEXES WHERE IT PASSES FROM THE BODY TO THE TAILGATE CAUSING THE IINSULATION AND WIRING TO BREAK AND SHORT TO THE BODY RESULTING IN A BLOWN FUSE AND NO REAR LIGHTS. THIS HAS OCCURRED WHILST DRIVING AND WHEN STATIONARY OPENING THE HATCHBACK.

Mileage: 76,000

DRIVING DOWN THE ROAD AND GAS PEDDLE GET STUCK AND SOMETIMES WONT PUSH DOWN TO GO SOMETIMES WHILE ON THE HIGHWAY THE HEADLIGHTS AND ALL LIGHTS FLICKER ALL THE TIME WHEN I HAVE THEM ON AT NIGHT GOTTIN PULLED OVER A COUPLE OF TIMES TOOKIN IT TOO THE SHOP AND THEY SAID EVERYTHINGS OK ON HIGHWAY 36 BETWEEN BROOKFIELD AND CHILLICOTHE MO

Mileage: 160,000

REAR HATCH WIRING HARNESS HAS FRAYED WIRES AND CAN CAUSE A FIRE THERE IS RUBBING AGAINST WIRING HARNESS FROM THE RUBBER BOOT COVERING IT. THESE WIRES ARE LIVE AND CAUSE A FIRE AND ARE ALWAYS ON DUE TO CONNECTION TO ALL REAR ELECTRICAL COMPONENTS. I FOUND THIS OUT WHEN TRYING TO FIGURE OUT WHY MY REAR HATCH WOULD NOT OPEN UNLESS UNLOCKED WITH THE KEY.

Mileage: 100,000

HELLO NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION, I WOULD LIKE TO CREATE A VEHICLE COMPLAINT REGARDING THE FORD FOCUS 2006 SEDAN ZX4 THAT I PURCHASED THE VEHICLE SEPTEMBER 20, 2017. WHILE DRIVING WITHIN A SERVICE ROAD, THE VEHICLE'S STALLED AND STOPPED RUNNING WHILE DRIVING UPON MULTIPLE INSTANCES OVER THE SAME DAY OF PURCHASING AND THROUGH OUT THE WEEKEND OF SEPTEMBER 22 - SEPTEMBER 30TH. AS A RESULT, I RETURNED THE VEHICLE TO THE DEALER OF LANSING POWER MOTORS INC. FOR AN INSPECTION SEPTEMBER 23, 2017. UPON COMPLETION OF THE INSPECTION, THE MECHANICS CONFIRMED THAT "NOTHING WAS WRONG WITH THE VEHICLE" AND SUGGESTED TO PURCHASE A NEW COMPUTER FOR THE VEHICLE. ON OCTOBER 30, 2017 I WAS INVOLVED IN A CAR ACCIDENT WHICH I THINK WAS DUE TO BAD ELECTRICAL BRAKES WHICH RESULTED IN THE VEHICLE BEING T-BONED BY ANOTHER DRIVER WITHIN A RESIDENTIAL INTERSECTION. THE VEHICLE CONTINUES TO STALL OR STOP COMPLETELY WHILE DRIVING AS OF MAY 14, 2018. IN ADDITION, NOTICED THAT ALL LIGHTS ON THE DASHBOARD DISPLAYED WHILE THE CAR STALLED AND DURING START-UP OF THE VEHICLE. UNCERTAIN ABOUT THE CAR NOT BEING RECALLED, DUE TO RECEIVING A MAILED NOTIFICATION REGARDING THE RECALL OF THE VEHICLE FROM THE ORIGINAL MANUFACTURER. CAN PROVIDE THE NAME UPON CONTACT REGARDING THE VEHICLE COMPLIANT SUBMISSION OF THE FORM. THANKS FOR YOUR TIME, CONSIDERATION, AND I HOPE THAT THIS INFORMATION MAY ASSIST YOU REGARDING THE CREATION OF A VEHICLE COMPLAINT.

Mileage: 1,302

CABIN FILTER - FILTER IS EXCLUDED IN THIS MODEL OF VEHICLE. ELECTRIC WINDOWS NEVER WORKED CORRECTLY . AIRBAG- WAS NEVER INSPECTED BY DEALER

TL* THE CONTACT OWNS A 2006 FORD FOCUS. THE CONTACT STATED THAT WHEN THE IGNITION KEY WAS TURNED, IT WOULD REMAIN STUCK IN THE ON OR OFF POSITION. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS INFORMED THAT THE KEY MIGHT NEED TO BE REPLACED. THE CONTACT MENTIONED THAT THE VEHICLE WAS LEFT AT THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000.

Mileage: 123,000

THE REAR PASSENGER SIDE DOOR LOCK DOES NOT LOCK. THIS IS THE SIDE THE BABY CARSEAT IS LOCATED. ALL THE OTHER DOORS DO LOCK/UNLOCK. IT HAPPENED SUDDENLY WITHOUT ANY REASON. I HAVE NOTICED MULTIPLE OCCURRENCES OF THIS ISSUE ON INTERNET FORUMS FOR FORD AND FORD DOES NOT HAVE A RECALL OR A MANDATORY FIX BUT THEY NEED TO AS THIS IS A REAL SAFETY AND SECURITY ISSUE! *TR

Mileage: 114,300

I HAVE HAD ONLY TWO PROBLEMS WITH MY 2006 FORD FOCUS. FIRST WE HAVE HAD TO CHANGE THE IGNITION SWITCH TWICE DUE TO THE KEY BEING STICK IN LOCK WOULD RESTART BUT WOULD NOT COME OUT. SECOND THE INNER DOOR ON THE DEFROST STICKS WHEN ON FULL DEFROST OR FULL AIR CONDITIONING AND THE CABLES BRAKE KEEPING THE DRIVER FROM USING THE AIR CONDITIONER OR DEFROST AT THIS POINT IT IS STUCK ON AIR. *TR

Mileage: 50,000

REAR DRIVERS SIDE DOOR WILL NOT LOCK. NOT WITH THE KEY REMOTE OR MANUALLY. CHILDREN IN THE BACK SEAT CAN OPEN DOOR ANY TIME. *TR

DRIVING DOWN THE STREET AND VEHICLE JUST STOPPED RUNNING/DIED. IT HAS BEEN AT THE DEALER FOR ALMOST TWO WEEKS AND THEY HAVEN'T FIGURED IT OUT YET. NO CALL, SAME RUN AROUND WHEN I CALL ABOUT UPDATE.... *TR

Mileage: 52,000

THE TRUCK LATCH ON MY 2006 FORD FOCUS ZXW WOULD NOT ACTUATE ELECTRICALLY WHEN THE BUTTON ON THE FOB OR ON THE DASH WAS PRESSED DUE TO BROKEN WIRE IN A WIRING HARNESS RUNNING FROM THE INTERIOR TO THE REAR HATCH DOOR. IT WOULD ALSO BLOW FUSE #63 ON THE BACK OF THE INTERIOR FUSE PANEL WHICH MADE REPLACEMENT DIFFICULT (THE FUSE IS REALLY ON THE BACK OF THE FUSE BOX, THE MANUAL RECOMMENDS THAT ONLY THE DEALER SERVICE OR REPLACE THIS FUSE MAKING THIS ISSUE DIFFICULT OR IMPOSSIBLE TO PARTIALLY RESOLVE IMMEDIATELY). UNTIL THIS FUSE COULD BE REPLACED, MY INTERIOR DOOR LOCKS COULD NOT BE ACTUATED ELECTRICALLY (POWER LOCKS OR FOB) WHICH WAS A SAFETY CONCERN AS ANY CHILDREN IN THE BACK SEAT COULD NOT BE EASILY REACHED IN THE EVENT OF AN EMERGENCY. ONE WOULD NEED TO MANUALLY UNLOCK ANY AND ALL DOORS FROM THE INSIDE OF THE VEHICLE. THE CULPRIT WAS WIRING HARNESS THAT HAD WIRES WITH DAMAGE TO THE INSULATION AND TWO BROKEN WIRES. I WOULD BE HAPPY TO SEND ANY AND ALL PICTURES OF THE DEFECTS. THE DAMAGE OCCURS WHEN THE HARNESS BENDS AS THE REAR HATCH IS SHUT DUE TO POOR DESIGN THAT DID NOT INCORPORATE A STAIN RELIEF TO EITHER END OF THE HARNESS WHERE MAXIMUM BENDING STRESSES WOULD OCCUR. THE WIRES MAY HAVE ALSO SHORTED AFFECTING THE BRAKE LIGHT OPERATION, MARKER LAMP OPERATION, AND NUMEROUS OTHER FUNCTIONS AS THERE ARE AN ESTIMATED TEN WIRES THAT RUN IN PARALLEL IN THIS HARNESS AND ALL WIRE EXCEPT TWO HAD MULTIPLE INSULATION DEFECTS THAT POTENTIALLY RESULTING IN SHORTS. THIS IS A DEFINITE SAFETY ISSUE AND ALL HARNESSES THAT HAVE THE POTENTIAL FOR THIS TYPE OF FAILURE SHOULD BE REPLACED OR REPAIRED IMMEDIATELY. *TR

Mileage: 92,000

HAVE HAD COMPLETE ELECTRICAL FAILURE 3 TIMES WITH MY CAR FIRST TIME WAS AT 12,500 MILES, 2ND. 61 MILES LATER AND LAST WEEK WITH 20,500 MILES. EACH TIME DEALERSHIP TOLD ME THAT MY ALTERNATOR HAD GONE BAD. WAYNE AKERS FORD, LAKE WORTH, FL PUT IN THE FIRST TWO REPLACEMENT ALTERNATORS AND CAR IS NOW AT AN INDEPENDENT MECHANIC FOR A SECOND OPINION. *TR

Mileage: 12,500

REAR PASSENGER DOOR WON'T LOCK. MY WIFE "APPARENTLY" LOCKED THE CAR AT WORK IN AN OPEN PARKING LOT AND LATER WENT TO RETRIEVE SOMETHING FROM BACK SEAT TO FIND THAT THE DOOR WAS NOT LOCKED. NO INDICATION WAS GIVEN WHEN LOCKING THE CAR USING THE REMOTE LOCKING MECHANISM THAT THERE IS AN ISSUE BECAUSE IT SOUNDS LIKE IT IS FULLY LOCKED. IT ISN'T. I CHECKED THE ISSUE BY HAVING HER DRIVE UP AND DOWN THE ROAD MAKING SURE SHE THOUGHT ALL DOORS WERE LOCKED AND WHILE SHE HAD STOPPED, I OPENED THE REAR PASSENGER DOOR AND JUMPED IN THE BACK SEAT MUCH AS AN ATTACKER OR CARJACKER MIGHT DO. THIS IS A SAFETY ISSUE BECAUSE ANYONE CAN JUMP IN THE BACK OF THE CAR WHILE STOPPED AT TRAFFIC LIGHTS EVEN THOUGH THE OWNER MAY THINK THAT THE CAR IS SECURELY LOCKED, IT JUST MIGHT NOT BE. BEWARE AND CHECK ALL YOUR DOOR LOCKS ON A REGULAR BASIS AS THIS SEEMS TO BE REPORTED ON MULTIPLE OCCASIONS ON FORD FOCUS INTERNET FORUMS. TO THIS DATE, WE HAVE NO IDEA WHEN THE ACTUAL LOCKING MECHANISM FAILED AS IT IS NOT SOMETHING WE, OR ANY OTHER DRIVER WOULD CHECK ON A REGULAR BASIS. *TR

Mileage: 130,000

VEHICLES SHIFTER BUTTON FAILED TO ENGAGE. INITIALLY DISCOVERED IT WAS DUE TO A BLOWN FUSE (#32.) AFTER REPLACING, VEHICLE OPERATED FINE FOR A FEW DAYS, BUT AGAIN SHIFTER BUTTON FAILED TO ENGAGE. INVESTIGATED ON THE INTERNET AND FOUND OUT THE BLOWN FUSE WAS DUE TO CRACKED WIRING INSULATION CAUSING EXPOSED WIRES IN THE REAR HATCH. ALSO LEARNED THIS ISSUE CAUSED THE REAR TAIL AND BRAKE LIGHTS NOT TO OPERATE. FOUND MULTIPLE COMPLAINTS ON THE INTERNET REGARDING THIS SAME ISSUE OF WHICH IT WAS ULTIMATELY DUE TO A DESIGN FLAW BECAUSE THE WIRES ON THE REAR WIRING HARNESS ARE TOO SHORT. *TR

Mileage: 98,000

THE FIRST INCIDENT OF KEYS GETTING STUCK IN THE IGNITION WAS ON NOVEMBER 27, 2009 IN IOWA. WE LIVE IN MINNESOTA AND HAD TO GO TO THE FORD DEALERSHIP TO HAVE THE IGNITION REPLACED FOR $485.91. LESS THAN FIVE YEARS LATER ON JUNE 4, 2013 THE KEYS GOT STUCK IN THE IGNITION AGAIN. THIS TIME LUCKILY WE WERE AT HOME. I RESEARCHED ONLINE AND FOUND THAT THIS HAS BEEN A PROBLEM WELL KNOWN TO FORD SINCE 2000, YET THEY REFUSE TO FIX THE ISSUE. AFTER SOME MORE RESEARCH I FOUND A SOLUTION. THERE IS A THREE RING PIECE BETWEEN THE SHIFTER HANDLE AND THE SHAFT. SIMPLY PUSH IT BACK UP TOWARD THE HANDLE AND PRESTO THE KEYS COME OUT. THIS IS A FREE SOLUTION. I AM CURIOUS IF I CALLED FORD IF THEY WOULD TELL ME THIS SOLUTION OR FOR THAT MATTER EVEN FIX THE PART SINCE IT IS LESS THAN FIVE YEARS. IS IT UNDER WARRANTY? ANOTHER PROBLEM IS OUR CD PLAYER HAS A CD STUCK THAT WE CANNOT GET OUT. WE WERE TOLD THAT IT WOULD BE CHEAPER TO GO TO BEST BUY AND BUY AN UPGRADED ONE THAN TO HAVE A DEALERSHIP FIX IT. AT 85000 MILES ANOTHER PROBLEM IS WE HAD TO GET OUR HEAT SHIELD REPLACED BECAUSE IT WAS RUSTING AND ABOUT TO FALL OFF. *TR

Mileage: 47,073

THE REAR PASSENGER DOOR DOES NOT LOCK ON OUR 2006 FORD FOCUS ZX4. IT OPENS AND CLOSES CORRECTLY. IT JUST WON'T LOCK, EVEN WITH CHILD LOCK ON. ALL OTHER DOORS OPERATE CORRECTLY. THIS DOOR OPERATED CORRECTLY BEFORE. WE HEARD FORD HAD A PROBLEM WITH THIS ON PREVIOUS FOCUS MODELS. CUT OFF WAS THE YEAR 2005 FOR THIS PROBLEM. WE FEEL UNSAFE FROM THIS PROBLEM BECAUSE WE TRANSPORT OUR SENIOR MOMS TO SHOPPING TRIPS. *TR

Mileage: 103,352

MY 2006 FOCUS ZX5 STARTED INTERMITTANTLY UNLOCKING THE HATCHBACK WHEN I STEPPED ON THE BRAKE PEDAL. I WAS DRIVING ON THE FREEWAY WHEN I PULLED OVER TO TAKE A PHONE CALL. I LEFT THE CAR IN DRIVE WITH MY FOOT ON THE BRAKE PEDAL. AFTER ABOUT 5 MINUTES I COMPLETED MY CALL AND MERGED BACK INTO TRAFFIC. WHEN I REACHED MY DESTINATION I PARKED MY CAR AND GOT OUT. I RETURNED TO MY CAR, STARTED THE ENGINE AND COULD NOT GET THE GEAR SHIFT OUT OF PARK. I HAD SOMEONE WATCH MY BRAKE LIGHTS WHILE I STEPPED ON THE BRAKE PEDAL. THE LIGHTS DID NOT WORK AND I FOUND THE FUSE FOR THE BRAKE LIGHTS WAS BAD. I TOOK A FUSE FROM ANOTHER CIRCUIT AND GOT HOME. I HAD BEEN DRIVING FOR 20 MILES WITH NO BRAKE LIGHTS. I TOOK THE CAR TO A FORD DEALER AND THEY FOUND A BROKEN WIRE AND 6 OTHER WIRES WITH CRACKING INSULATION. THEY SAID THEY FIXED THE PROBLEM AND THE CAR WORKED OK. IN JANUARY OF 2013 I NOTICED AFTER CLOSING MY HATCHBACK AND GETTING IN THE CAR MY THE "DOOR OPEN" INDICATOR STAYED ON. I CHECKED ALL DOORS AND THE HATCHBACK AND ALL WERE CLOSED. AFTER FINDING OUT ON-LINE THAT THERE HAVE BEEN COMPLAINTS ABOUT THE FOCUS WIRING SINCE THE 2000 MODELS, I TOOK OFF THE CARBODY END OF THE RUBBER CONDUIT TO THE HATCHBACK. I FOUND A BROKEN WIRE (FIXED MY DOOR OPEN INDICATOR PROBLEM WHEN I REPAIRED IT) AND 6 WIRES WITH BLACK ELECTICAL TAPE ON THEM. I FOUND THAT THE ELECTRICAL TAPE IS WEARING THROUGH JUST LIKE THE WIRE INSULATION DID. I CONTACTED THE DEALER AND COMPLAINED ABOUT THE HALF ASS REPAIR THEY DID. THE SERVICE MANAGER STATED THAT WAS THE REPAIR AUTHORIZED BY THE EXTENDED WARRANTY. I ASKED WHAT REPAIR WAS AUTHORIZED BY THE ORIGINAL WARRENTY AND HE SAID THE SAME REPAIR. FORD HAS KNOWN THAT THIS HARNESS IS A PROBLEM SINCE 2000 AND I WAS TOLD THEY ARE STILL USING THE WIRING IN THEIR 2013'S. WHY HAVEN'T THESE CARS BEEN RECALLED! *TR

Mileage: 77,402

DRIVERS SIDE REAR DOOR ELECTRIC DOOR LOCK WILL NOT LOCK. THE SAME THING HAPPENED ON THE PASSENGERS SIDE ABOUT TWO YEARS AGO. *TR

Mileage: 84,574

THE TRUNK LIGHT WOULD NOT COME ON WHEN TRUNK WAS OPENED (REPLACING THE BULB DIDN'T HELP). LATER, THE 'DOOR OPEN' DASH LIGHT CAME ON AND STAYED ON. THE ELECTRIC TRUNK OPEN BUTTON SOMETIMES WOULD NOT OPEN TRUNK. A BIT OF TROUBLESHOOTING WITH A VOM AT THE TRUNK LIGHT POINTED TO AN ELECTRICAL PROBLEM (A VOLTAGE DROP WHEN A NEW BULB WAS PLACED IN THE TRUNK LIGHT SOCKET). TURNS OUT THAT THE WIRING BUNDLE (CONTAINING SIX INDIVIDUAL MULTISTRAND WIRE LINES) HAD FIVE OF THE WIRES LINES FATIGUED APART , BREAKING THE FIVE CIRCUITS. THE WIRE LINES WERE SOMETIMES MAKING INTERMITTENT CONTACT WHEN THE TRUNK WAS OPENED AND CLOSED, NOT NECESSARILY WITH THE MATCHING WIRE LINE. I COULD HEAR NOISE AS THE WIRES WERE MOVED PAST EACH OTHER (NOT SURE IF THIS WAS JUST PHYSICAL SCRATCHING OR, WORSE, ELECTRICAL SPARKING). SINCE I SOMETIMES CARRY A GASOLINE CONTAINER IN THE TRUNK (LAWNMOWER GAS CONTAINER RETURNING FROM GAS STATION), I FEEL THAT THE DESIGN OF THIS WIRING TO THE TRUNK IS FAULTY AND COULD LEAD TO A FIRE UNDER THE RIGHT (AND NOT UNCOMMON) CIRCUMSTANCES. AFTER SEVERAL CONVERSATIONS WITH THE FORD MOTOR CO., A REPAIR WAS MADE (I PARTIALLY PAID FOR THE REPAIR) WHERE THE WIRING WAS REPLACED. I AM NOT SURE IF THE REPAIR WILL BE ANY SAFER THAN THE ORIGINAL DESIGN; HENCE THIS COMPLAINT WITH THE HOPE THAT A SAFER DESIGN (E.G., ONE WITHOUT SUCH A TIGHT RADIUS OF BEND) COULD DEVELOPED AND RETROFITTED INTO THIS CAR. *TR

Mileage: 49,254

KEY STICKS IN IGNITION. *TR

Mileage: 24,900

KEY STUCK IN IGNITION. *TR

Mileage: 58,000

THE KEY CANNOT BE REMOVED FROM THE IGNITION. THE CAR DOES STILL START AND DRIVE FINE, BUT NO MATTER WHAT I DO, THE KEY WILL NOT COME OUT. IT MIGHT JUST BE FOR A FEW HOURS BUT MORE SO IT HAPPENS FOR AT LEAST 24 HOURS. IT SEEMS TO ALSO HAPPEN AFTER THE CAR HAS BEEN USED ON A WARM DAY, SO IT WILL FIRST GET STUCK THAT EVENING WHEN THE CAR IS PUT INTO USE AGAIN. IT IS COSTING $285 TO GET IT FIXED BECAUSE IT NEEDS A NEW IGNITION. *TR

Mileage: 38,000

KEYS ARE STUCK IN THE IGNITION. *TR

Mileage: 62,000

IGNITION LOCK CYLINDER FAILURE ON A 2006 FORD FOCUS. THE KEY AT ONE TIME COULDN'T TURN THE IGNITION...NOW CAN'T REMOVE KEY FROM LOCK CYLINDER WITHOUT HAVING LOCKSMITH OR DEALERSHIP DO IT AT SUBSTANTIAL COST TO MYSELF. APPARENTLY THIS IS A VERY COMMON OCCURRENCE AND IS WAY MORE WIDESPREAD THEN ANY LITTLE RECALL THAT TOYOTA HAS HAD...WE NEED A RECALL OR A CLASS ACTION LAWSUIT. I*TR

Mileage: 45,869

KEY STUCK IN IGNITION. WAS TOLD BY DEALER MOST COMMON PROBLEM WITH FORD FOCUS. LOCK ASSEMBLY REPLACED ON 04/0210 AND KEY STUCK IN IGNITION (NEW PART) 04/23/10. *TR

Mileage: 59,215

TL* THE CONTACT OWNS A 2006 FORD FOCUS. THE CONTACT STATED THAT AFTER TURNING THE VEHICLE OFF, SHE COULD NOT REMOVE THE KEY FROM THE IGNITION. THE VEHICLE WAS TAKEN TO THE DEALERSHIP BUT NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 64,000. THE VIN WAS UNAVAILABLE.

Mileage: 64,000

2006 FORD FOCUS ZX4 YELLOW AIRBAG LIGHT ON DASH WENT ON AND REMAINED ON. DIAGNOSED AS HIGH RESISTANCE IN WIRING SYSTEM,MAKES SAFETY-AIRBAG- SYSTEM INOPERATIVE. DANGEROUS. REPAIRED BY FORD DEALER UNDER 5 YEAR WARRANTY BY REPLACEMENT OF CLOCKSPRING{WIRING PLASTICTAPE} IN STEERING WHEEL HUB. TO DETERMINE SEVERITY OF PROBLEM CHECK FORD REPLACEMENT PARTS RECORDS. *TR

Mileage: 10,000

2006 FORD FOCUS KEY GETS STUCK IN IGNITION....THIS HAS HAPPENED NUMEROUS TIMES......HAVE HAD TO SIT AND JIGGLE KEY BACK AND FORTH IN ORDER TO GET IT OUT OF IGNITION. *TR

Mileage: 60,000

2006 FORD FOCUS CONTINUOUSLY GETS THE KEY STUCK IN THE IGNITION IT SEEMS IT IS DUE TO THE GEAR SHIFT NOT LOCKING IN PLACE. I HAVE HAD TO LEAVE THE KEY IN THE IGNITION ON A FEW OF THOSE OCCASIONS AND PLACE THE EMERGENCY BRAKE ON. *TR

Mileage: 106,000

I HAVE A 2006 FORD FOCUS. THE KEY HAS BEEN CONSTANTLY GETTING LOCKED INTO THE IGNITION. YOU CANNOT TAKE IT OUT AND EVENTUALLY MY KEY BROKE. THIS HAPPENED MORE THAN ONCE. I RESEARCHED AND FOUND OUT THAT A LOT OF OTHER FORD FOCUS CUSTOMERS WERE EXPERIENCING THE SAME THING! *TR

TL* THE CONTACT OWNS A 2006 FORD FOCUS. THE CONTACT STATED THAT HE CAN NOT REMOVE THE KEY FROM THE IGNITION. THE DEALER WAS CONTACTED. UPON CONTACT A TECHNICIAN STATED THAT HE WOULD HAVE TO PAY $300.00 TO REPLACE THE IGNITION SWITCH. NO REPAIRS WERE MADE. THE MANUFACTURER WAS CONTACTED, BUT NO ASSISTANCE WAS PROVIDED BECAUSE THE WARRANTY EXPIRED. THE FAILURE AND CURRENT MILEAGES WERE 32000.

Mileage: 32,000

ABOUT HALF TO 3/4 OF THE TIME MY IGNITION WILL NOT START ON MY FORD FOCUS. THIS PRESENTS A MAJOR PROBLEM WHEN I AM AWAY FROM THE HOME AND MY CAR WILL NOT START DUE TO IGNITION SWITCH PROBLEMS. AT TIMES I HAVE TO TURN THE KEY 20-50 TIMES FOR THE CAR TO COME ON. I AM 76 YEARS OLD AND THIS IS A MAJOR ISSUE FOR ME. I DON'T WANT TO EVEN DRIVE MY CAR FOR FEAR THAT I WILL NOT BE ABLE TO RE-START IT. *TR

ABOUT HALF TO 3/4 OF THE TIME MY IGNITION WILL NOT START ON MY FORD FOCUS. THIS PRESENTS A MAJOR PROBLEM WHEN I AM AWAY FROM THE HOME AND MY CAR WILL NOT START DUE TO IGNITION SWITCH PROBLEMS. AT TIMES I HAVE TO TURN THE KEY 20-50 TIMES FOR THE CAR TO COME ON. I AM 76 YEARS OLD AND THIS IS A MAJOR ISSUE FOR ME. I DON'T WANT TO EVEN DRIVE MY CAR FOR FEAR THAT I WILL NOT BE ABLE TO RE-START IT. *TR

THE FUSE FOR THE RUNNING LAMPS KEPT BLOWING. A FEW DAYS LATER I SMELT A BURNING SMELL, PULLED OVER, TURNED OFF THE CAR, REMOVED KEY, BUT CAR WAS STILL RUNNING. A FEW DAYS LATER, BATTERY LIGHT KEPT FLASHING, TURNS OUT, THE ALTERNATOR WAS FRIED. TOOK IT TO FORD, WAS TOLD THERE WAS NOTHING THEY COULD DO BECAUSE MY POWERTRAIN WARRANTY DOES NOT COVER ELECTRICAL WORK. TOOK IT TO AN ELECTRICIAN, WAS TOLD A FEW WIRES TOUCHED METAL AND FUSED TOGETHER AND BURNT ALL THE WAY BACK TO THE FIREWALL. WHEN YOU LOOK AT THE WIRES, THERE IS METAL SITTING UNDER THEM....THERE ARE NO CLIPS TO HELP HOLD THE WIRES AWAY FROM THE METAL. THERE IS SOME FORM OF PROTECTION ON THE WIRES, I DESCRIBE IT AS A FOAM...BUT ITS WORN THROUGH. WHEN I ASKED HIM HOW THIS COULD HAVE HAPPENED, HE REPLIED WITH "GOING OVER BUMPS, RAILROAD TRACKS, OR HITTING A POTHOLE. HE ALSO TOLD ME IT WAS A FIRE HAZARD. AS A CONSEQUENCE TO THIS, MY CAR IS NOW JUST SITTING, AND I WILL NOT DRIVE IT WITH IT BEING LABELED A FIRE HAZARD. NOTHING WAS DONE TO CORRECT THE FAILURE. *TR

Mileage: 78,000

MY KEY BECAME LOCKED IN THE IGNITION AND COULD NOT BE REMOVED WHILE ON VACATION. I COULD TURN THE CAR ON AND DRIVE IT BUT COULD NOT REMOVE IT, THEREFORE HAD TO END VACATION EARLY TO TAKE CARE TO LOCAL DEALERSHIP. THE CAR WAS 75 DAYS OUT OF WARRANTY AND I HAD NO CHOICE BUT TO FIX THIS- COSTING ME OVER $300.00. THEY (FORD) SAID IT WAS THE SAFETY SWITCH IN THE SHIFTER. VEHICLE HAD A LITTLE OVER 18,000 MILES. THE CAR WAS PURCHASED USED FROM AN ESTATE OF A LADY WHO HAD ONLY DRIVEN 8,000 MILES. *TR

Mileage: 18,000

THE KEY HAS BECOME STUCK IN THE IGNITION AND WILL NOT COME OUT BECAUSE THE CAR DOES NOT THINK IT IS PARK EVEN THOUGH IT IS PARKED. THE DEALER INSIST THAT THERE WAS A SODA SPILLED ON THE IGNITION AND THIS RESULTED IN THE CHIP IN THE IGNITION SHORTING OUT. THIS KEY HAS BEEN STUCK SINCE MAY AND HAS ONLY COME OUT OF THE IGNITION ONCE SINCE THEN! THE DEALERSHIP SAYS THAT THEY HAVE TO ORDER THIS PART AND CHANGE OUT THE IGNITION TO FIX IT. SO FAR, THIS PROBLEM HAS NOT BEEN RESOLVED AND WE CANNOT LOCK ALL OF THE DOORS BECAUSE OF THIS. *TR

Mileage: 65,724

MY 2006 FORD FOCUS HATCHBACK DEVELOPED FRAYED WIRES IN THE HATCHBACK HARNESS THAT CAUSED A SHORT SO THAT THE DASHBOARD LIGHTS DO NOT COME ON AS THEY SHOULD WHEN THE EXTERIOR LIGHTS ARE TURNED ON UNLESS THE REAR WINDOW DEFROSTER IS ALSO TURNED ON. DESPITE BEING COVERED BY FORD'S 'EXTRA CARE' EXTENDED SERVICE PLAN THAT IS SUPPOSED TO COVER WIRING HARNESSES, FORD IS REFUSING TO PAY FOR THE REPAIR. *TR

Mileage: 62,000

I HAVE A 2006 FORD FOCUS AND MY KEY IS STUCK IN THE IGNITION. I HAVE CONTACTED THE DEALERSHIP AND FORD CUSTOMER SERVICE AND THEY WERE NO HELP. THE IS A COMMON PROBLEM WITH THE FORD FOCUS BUT THEY WON'T ISSUE A RECALL ON IT. THIS IS A SAFETY ISSUE- MY CAR IS AT RISK OF BEING STOLEN AND I DON'T HAVE THE 400.00 THEY ASK TO REPAIR THIS. *TR

Mileage: 75,000

THE KEY GETS STUCK IN THE IGNITION AND WON'T COME OUT. I HAVE TO REMOVE ONE OF THE BATTERY CABLE FROM THE BATTERY, REMOVE THE KEY FROM THE IGNITION, THEN REPLACE THE BATTERY CABLE BACK. THIS HAS HAPPEN MORE THAN ONCE. *TR

Mileage: 45,000

ABOUT 2 MONTHS AGO, MY KEY GOT STUCK IN THE IGNITION. I COULD START AND DRIVE THE CAR, BUT NOT GET THE KEY. I DROVE TO A FORD DEALER AND THE PERSON HAD NO TROUBLE GETTING MY KEY OUT. THIS WAS AT 34,000 MILES. NOW, AT 36,500 MILES, THE SAME THING HAPPENED. I AM TAKING TO A FORD DEALER AND THEY BETTER REPAIR UNDER THE 3/36,000 WARRANTY. *TR

Mileage: 36,500

2006 FORD FOCUS ZX4 MODEL SES. IGNITION KEY STUCK IN IGNITION. CAR WILL START BUT KEY WILL NOT COME OUT. CAR CAN BE PUT INTO GEAR WITH SWITCH IN OFF POSITION. SAFETY PROBLEM CAR HAS 35,000 MILES. DEALER DID WARRANTY REPAIR TODAY - WE ARE PICKING THE CAR UP TONIGHT SO I DON'T KNOW THE QUALITY OF THE REPAIR YET. *TR

Mileage: 34,400

MY KEY GOT STUCK IN THE IGNITION OF MY 2006 FORD FOCUS STATION WAGON AND WOULD NOT COME OUT. WHEN I TOOK IT TO THE REPAIR SHOP I FOUND OUT THAT THE IGNITION SWITCH AND BRAKE/SHIFT INTERLOCK HAD BOTH FAILED. THE SERVICE MANAGER SAID HE HAS SEEN THIS PROBLEM OFTEN IN FORD FOCUS CARS. I HAD BOTH PARTS REPLACED, BUT I FEEL THAT THIS IS NOT PART OF NORMAL WEAR AND TEAR OF MY VEHICLE, WHICH IS NOT QUITE THREE YEARS OLD YET. THE PARTS ARE WORKING FINE NOW THAT THEY HAVE BEEN REPLACED THOUGH. *TR

Mileage: 48,665

2006 FORD FOCUS ZX3 SE REAR HATCH DOOR WIRING ---BROKEN WIRES AND WIRE INSULATION. FIRST STARTED WITH PLATE LIGHTS BLOWING OUT. NOW ALL PARKING LIGHTS,TAILLIGHTS AND DASH LIGHTS ARE OUT---BLOWING FUSES!!! OUT OF CURIOSITY I PULLED DOWN THE RUBBER BOOT OF THE WIRE HARNESS OF THE REAR HATCH DOOR AND FOUND BROKEN WIRES AND INSULATION. WENT TO FORD WEBSITE TO SEE IF THERE WAS A RECALL ON THIS, FOUND NO RECALLS AT ALL FOR MY CAR!!!!! UPON FURTHER RESEARCH FOUND THAT THERE IS A RECALL FOR THIS VERY PROBLEM FROM 8 YEARS AGO NOV - DEC OF 2000!!!!!!!!! *TR

Mileage: 73,000

I HAVE A 2006 FORD FOCUS AND THE KEY KEEPS GETTING STUCK INSIDE OF THE IGNITION WITHOUT ANY WARNING. IT WILL STAY STUCK FOR A FEW WEEKS AND THEN ONE DAY IT WILL JUST COME OUT. *TR

TL*THE CONTACT OWNS A 2006 FORD FOCUS. THE CONTACT STATED THAT HE WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. IN ADDITION, THE GEAR SHIFT INDICATOR WOULD ENGAGE WITHOUT DEPRESSING THE BRAKE. AS OF FEBRUARY 14, 2008, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 430,000.

Mileage: 43,000

ON FRIDAY THE IGNITION ON MY CAR DID NOT IMMEDIATELY TURN. I DIDN'T THINK ANYTHING OF IT AT THE TIME. SATURDAY AFTERNOON IT REFUSED TO TURN AT ALL. THE KEY WOULD NOT TURN IN THE IGNITION LOCK CYLINDER. IT FIT AND WAS REMOVABLE BUT JUST WOULDN'T TURN. THE CAR WOULD NOT THEREFORE, START. I WAS LEFT STRANDED IN A PUBLIC PLACE PREGNANT WITH MY 3 YEAR OLD CHILD FOR SO LONG DRUG DEALERS STARTED SHOWING UP. I HAD TO PAY FOR A TOW TRUCK WHEN IT FINALLY ARRIVED. THIS IS IN A 2003 FORD FOCUS ZTW WAGON. IT IS 3 YEARS OLD WITH 50,000 MILES ON IT. I SPENT ALL DAY TUESDAY ON THE PHONE SPEAKING WITH VARIOUS LEVELS OF MECHANICS AND MANAGEMENT. THEY ALL AGREED THAT FORD IS NOT TAKING ANY RESPONSIBILITY FOR THIS DEFECT. ONE OPERATOR DID NOT EVEN RECORD MY PHONE CALL. FORD IS RECALLING DIFFERENT MODEL VEHICLES FOR IGNITION CYLINDER PROBLEMS. THEY HAVE NOT SET UP ANY PUBLIC REIMBURSEMENT OR REPAIR FOR THIS SPECIFIC YEAR AND MODEL VEHICLE. I HAD TO PAY A PRIVATE LOCKSMITH TO COME TO MY HOUSE AND BUILD A NEW CYLINDER AROUND MY KEY BECAUSE I COULD NOT AFFORD TO HAVE THE CAR TOWED AGAIN AND PAY THE EXORBANT DEALER PRICE. I WAS WITHOUT MY VEHICLE FOR SATURDAY, SUNDAY, MONDAY AND THE TUESDAY SURROUNDING LABOR DAY WEEKEND. THE PRIVATE LOCKSMITH REPAIRED IT WEDNESDAY IN A TIMELY MANNER. I HAVE NOT BEEN OFFERED TOWING REIMBURSEMENT, A RENTAL VEHICLE, A REPAIR REIMBURSEMENT OR AN APOLOGY. THE OLD PART (WHAT WAS LEFT AFTER DRILLING IT OUT PER FORD INSTRUCTIONS) WAS NOT SAVED. *NM

Mileage: 50,133

ON FOUR SEPARATE OCCASIONS MY CAR, WITHOUT FOREWARNING, CUT OFF WHILE IN MOTION AND AT VARIOUS RATES OF SPEED. THE CAR IS NOW BEING SERVICED FOR THIS PROBLEM FOR THE THIRD TIME IN THE TWO MONTHS THAT I HAVE HAD IT. THE CAR ALSO HAS A PROBLEM WITH NOT STARTING, FOR NO APPARENT REASON. *JB

Mileage: 1,860

I PURCHASED A 2006 FORD FOCUS ON 12/3/05, IT HAD 4 MILES ON IT WHEN I DROVE OUT OF THE DEALERSHIP. ON THURSDAY MAY 3, 2006, IT CAUGHT FIRE IN MY CARPORT. THE MILEAGE IS BETWEEN 2,000-3,000 MILES, I BELIEVE. I ARRIVED HOME FROM A MEETING AT A LOCAL BANK, HAVING DRIVEN APPROXIMATELY 2 MILES. I PARKED THE CAR IN THE CARPORT, TURNED OFF THE ENGINE AND ENTERED THE HOUSE. I DID NOT NOTICE ANY STRANGE NOISES OR ODORS. MY HUSBAND ARRIVED HOME ABOUT 15-20 MINUTES LATER. HE BEGAN TOOTING THE HORN ON HIS VEHICLE TO GET MY ATTENTION. WHEN I OPENED THE DOOR, HE YELLED "GET YOUR KEYS." I COULD SEE FLAMES UNDER MY CAR AND SMOKE SEEPING OUT THE SIDES OF THE HOOD. I THREW HIM THE KEYS AND RAN FOR THE FIRE EXTINGUISHER. HE ENTERED MY FOCUS GOT THE ENGINE STARTED AND BACKED THE VEHICLE OUT OF THE CARPORT AND AWAY FROM THE HOUSE. AS HE BACKED UP THE VEHICLE, FLAMING PARTS BEGAN FALLING OUT FROM UNDER THE CAR ONTO THE CONCRETE FLOOR. HE GOT THE CAR BACKED UP ABOUT 10 FEET AND THE ENGINE QUIT AND WOULD NOT RESTART. HE EXITED THE CAR AND TRIED TO OPEN THE HOOD. THE HOOD WAS VERY HOT TO THE TOUCH BUT HE GOT IT OPENED. THE FLAMES WERE ABOUT A FOOT HIGH AT THE BACK OF THE ENGINE AREA ON THE LEFT SIDE. WE WERE ABLE TO PUT OUT THE FLAMES WITH THE EXTINGUISHER. WE THEN EXTINGUISHED THE FLAMES ON THE PIECES THAT WERE LYING ON THE CARPORT FLOOR. BOTH CONTINUED TO SMOKE FOR SOME TIME BUT THE FIRE DID NOT RE-IGNITE. WHEN THE SMOKE CLEARED AND WE FELT IT SAFE TO APPROACH THE VEHICLE, WE COULD SEE THE CHARRED REMAINS AND MELTED PARTS. IN RETROSPECT I REMEMBER ON TWO OCCASIONS SEEING THE BATTERY ICON LIGHTED ON THE DASH WHILE A SAT OUTSIDE MY OFFICE WAITING FOR THE BANK TO OPEN WITH THE CAR IDLING AND THE RADIO ON. BOTH TIMES I REVVED THE ENGINE AND THE LIGHT WENT OUT. *NM

Mileage: 3,000