2005 FORD FREESTAR Electrical System Problems

The rear wheel well has rusted on both sides and completely rusted out a large hole (approx. 1 ft diameter area visibly effected) in the the body of the van. The rusted out section is where the back seat is anchored to the frame, so the rust has cause the seat to no longer be securely anchored to the car. The hole has also caused electrical wires to get wet when water gets into the van and intermittently and unpredictably causing failure of electrical features, including headlights and blinkers, while driving.

CRUISE CONTROL DOESN'T WORK, TRANSAXLE ISSUE-LIGHT FLASHING. *TR

Mileage: 135,000

THIS IS A BIG, BIG, DEAL RELATED TO DANGEROUS SAFETY ISSUE. REFERENCE BULLETIN:FORD TSB 6-14-10, ISSUED JULY 24, 2006 (SUPERSEDES FORD TSB 5-23-7 ISSUED NOVEMBER 28, 2005) MY CAR SUDDENLY LOST CONTROL SURGING AND UNABLE TO SHIFT AND NO REVERSE GEAR. HAVE HAD OFF AND ON PROBLEMS FOR THE PAST YEAR RESULTING IN ABOUT $2000 OF SERVICE TO FIGURE OUT WHY CAR ACTING UP, SURGING, INABILITY TO SHIFT, AT TIMES NO FORWARD OR REVERSE GEAR. ONE TIME DROVE 25 MPH TO GET HOME 20 MILES AND POLICE STOPPED ME BECAUSE SUSPICIOUS DRIVING. I TOLD HIM I WAS HAVE TRANSMISSION PROBLEMS. TRANSMISSION AS IT TURNS OUT IS PERFECT. PCM IS MALFUNCTIONING INTERMITTENTLY BECAUSE OF ENGINEERING PROBLEM OF PCM SHORTING OUT.TOWED TO FORD DEALER AND SAID NEEDED $2-5000 TRANSMISSION. TOWED HOME AND SUDDENLY STARTED WORKING. INVESTIGATED THIS BULLETIN THAT THE FORD DEALER WAS NOT FAMILIAR WITH AND THEY ACCEPTED MY INFORMATION DESCRIBING THE BULLETIN TO THEM. WHY HAS THIS PROBLEM NOT RISEN TO THE RECALL STATUS GIVEN THE EXTREME DANGER ON THE HIGHWAY DRIVING AND LOOSING ALL CONTROL OF THE CAR CAUSING A VERY DANGEROUS PERILOUS SITUATION TO ME MY FAMILY AND OTHERS ON THE ROAD?

Mileage: 82,000

WATER DRIPPED FROM THE WIPER BLADE COWL INTO THE PCM, CAUSING THE VEHICLE TO START, DRIVE BRIEFLY, AND THEN SHUT OFF WHILE MOVING, CAUSING LOSS OF CONTROL OF ELECTRICAL COMPONENTS OF THE VEHICLE WHILE DRIVING ON THE HIGHWAY. STEERING BECAME DIFFICULT. IF THIS HAD HAPPENED AT HIGH SPEEDS OR WITH A LOT OF TRAFFIC AROUND, IT COULD HAVE BEEN EXTREMELY DANGEROUS OR DEADLY. THE MECHANIC SAYS THIS IS A PROBLEM HE SEES WITH FORD WINDSTAR VEHICLES. THE MECHANIC STATED THE PCM WAS LITERALLY UNDER WATER WHEN HE RECEIVED THE VEHICLE, DESPITE THE CAUSE BEING A FAIRLY TYPICAL RAIN STORM, AND DRYING OUT THE PCM DID NOT HELP, AS THE DAMAGE HAD ALREADY BEEN DONE. THIS IS A SAFETY ISSUE THAT, AFTER SEARCHING ONLINE AND SPEAKING WITH MECHANICS, APPEARS TO BE COMMON. FORD NEEDS TO FIX THIS ISSUE BEFORE A VEHICLE LOSES CONTROL AT HIGH SPEEDS.

Mileage: 175,000

WE OWN A 2005 FORD FREESTAR. THE SLIDING DOOR LOCK FAILED ON PASSENGER SIDE AND COULD NOT BE UNLOCKED ELECTRONICALLY OR MANUALLY. THE LOCAL FORD MECHANIC STATED THAT THE COST TO REPAIR WAS $600+ FOR PARTS & $300 FOR LABOR TO FIX. APPROXIMATE FAILURE MILEAGE WAS 126,000.

Mileage: 126,000

2005 FORD FREESTAR. CONSUMER WRITES IN REGARDS TO UNSATISFACTORY CUSTOMER SERVICE AT DEALERSHIP AND UNRESOLVED VEHICLE PROBLEMS. *SMD CONSUMER SENT ADDITIONAL CORRESPONDENCE. *SMD THE CONSUMER STATED THE CHECK ENGINE LIGHT REMAINED ON AFTER MULTIPLE REPAIRS WERE MADE. THE VEHICLE WOULD ALSO STALL. THE TORQUE CONVERTER WENT OUT AND THE VEHICLE HAD TO BE TOWED. THE VEHICLE WAS TRADED IN. *JS *JS

AN INCIDENT FROM ABOUT A MONTH AGO: AFTER TRAVELING ON THE FREEWAY AND COMING TO A STOP AT A RED LIGHT AT THE OFF RAMP AT 2AM, MY CAR BEGAN TO SPUTTER AND REV. I PROCEEDED TO THE NEXT RED LIGHT WHERE MY CAR SHUT OFF. EVERY TIME I STARTED IT, IT WOULD SHUT OFF RIGHT AWAY. I DRIVE FOR A TAXI SERVICE AND LUCKILY I DID NOT HAVE PASSENGERS IN THE CAR WITH ME AT THE TIME. I CALLED A FAMILY MEMBER TO COME LOOK AND HELP. HE ENDED UP PUSHING MY CAR WITH HIS INTO A NEARBY PARKING LOT. AFTER SOME INVESTIGATION, I CONCLUDED IT WAS THE PCM. IT WAS TAKEN OUT TO DRY COMPLETELY AND THE WINDSHIELD AREA WHERE WATER MAY HAVE LEAKED INTO IT WAS SEALED WITH SILICONE. IT STARTED WORKING AGAIN FINE AND HAS BEEN SINCE THEN. NOW IT HAS RAINED AGAIN AND THE PROBLEM HAS REOCCURRED. TODAY, AFTER DRIVING ON THE FREEWAY AND ENTERING A NEIGHBORHOOD, MY TRANS-AXLE LIGHT STARTED BLINKING. THEN MY OIL AND BATTERY LIGHT APPEARED AND SECONDS AFTER MY STEERING WHEEL STOPPED TURNING AND THE CAR SHUT OFF. I WAS ABLE TO PARK IN THE STREET AND RESTART THE CAR, BUT ONCE I PUT IT IN DRIVE AND MOVED ABOUT 1 FOOT, THE CAR SHUT OFF AGAIN. IT WILL TURN ON AND STAY IDLE, BUT ONCE I START MOVING, IT SHUTS OFF AGAIN. IT HAS BEEN RAINING THE PAST 2 DAYS. I SUSPECT IT IS FROM THE SAME ISSUE AS BEFORE. I ALSO HAD MY CHILDREN IN THE CAR WITH ME AS I WAS TAKING THEM TO SCHOOL. I'M VERY LUCKY THIS DID NOT HAPPEN ON THE FREEWAY OR MAJOR STREET.

Mileage: 180,000

DROVE THE VEHICLE 1 MILE TO KIDS SCHOOL ON THE WAY BACK IT LOST POWER , WOULDN'T ACCELERATE .. THE #40 FUSE WAS BLOWN AND EVERY TIME I REPLACE IT AS SOON AS I TURN THE KEY ON IT BLOWS AGAIN. CAN'T DRIVE IT AND JUST SEEMS LIKE ELECTRICAL PROBLEMS KEEP OCCURRING WITH IT LAST TIME WAS WATER IN THE PCM CAUSING OTHER ISSUES, MAY BE THE PCM AGAIN I DON'T KNOW BUT THESE FREE STARS ARE BAD FOR THIS EVIDENTLY. . BAD DESIGN AND DEFINITELY BAD FOR BUSINESS..

Mileage: 154,195

FOR A FEW YEARS NOW VARIOUS ELECTRICAL THING HAVE BEEN GOING ON MY MINI VAN. THE SCREEN THAT SHOWS MILEAGE, ETC. HAS A SHORT AND CAN ONLY BE SEEN WHEN IT'S REALLY DARK OUT AT NIGHT. AWHILE LATER, AS I WAS DRIVING, MY CRUISE CONTROL GAVE OUT AND NO LONGER WORKS. NOW THE LIGHT FOR MY CLOCK AND THE SCREEN THAT TELLS CARDINAL DIRECTIONS AND THE TEMP OUTSIDE IS DEAD. I AM CONCERNED THAT THIS ELECTRICAL ISSUE COULD BE DANGEROUS. I DIDN'T KNOW ABOUT THIS WEBSITE TO REPORT IT TILL NOW.

Mileage: 180,000

VAN GOT UP TO 50 MPH AND STALLED OUT AND THEN COMPLETELY LOST POWER. I TOOK IT TO A MECHANIC AND HE SAID THE COMPUTER COMPONENT WAS FULL OF WATER. COMPUTER HAD TO BE REPLACED.

Mileage: 108,000

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. WHILE DRIVING AT VARIOUS SPEEDS DURING RAINY WEATHER CONDITIONS, ALL OF THE LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED AND THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE DID NOT RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

Mileage: 125,000

ALL GAUGES LOST POWER ON & OFF EACH DAY,UNTIL TODAY SHUT OFF FOR GOOD (4-10-15). ALSO, AT FIRST (DEC. 2014) LOST LIGHTS ON INSIDE OF VEHICLE & DID NOT EFFECT OUTSIDE LIGHTS UNTIL RECENTLY WHEN OUTSIDE ALSO OUT. HAS HAPPENED MULTIPLE TIMES SINCE FIRST NOTICED. AT FIRST SIGNAL LIGHTS WORKED, BUT NOT NOW. ALSO A/C & RADIO DO NOT WORK, PLUS THE DOORS, WINDOWS DO NOT OPEN OR CLOSE AS WELL. THE ONLY DOOR WHICH OPENS IS THE DRIVERS DOOR WITH THE KEY. SOMETIMES EVERYTHING COMES ON & OFF BY ITSELF, (EVEN CD PLAYER & RADIO, BUT NOW DOES NOT WORK), WHEN I GET IN THE CAR TO START IT. I CHECKED MY BATTERY WHICH WAS STILL GOOD, AND PUT IN A NEW ALTERNATOR THIS MONTH (APRIL), BUT THE PROBLEM HAS BEEN GOING ON SINCE LAST DECEMBER. AT FIRST IN DEC. THE MECHANIC SAID HE HAD TO RESET SOMETHING, AND THEN IT WAS OK FOR A COUPLE OF MONTHS UNTIL FEBRUARY, 2015. THEN IT BEGAN TO START UP AGAIN, AND I REPLACED THE ALTERNATOR LAST MONTH (MARCH). THE NOISE & PROBLEMS WERE HAPPENING AT RANDOM, CRACKLING NOISE UNDER THE DASHBOARD AND UNDER THE DRIVERS SIDE UNDER THE STEERING WHEEL, BUT THEN IT HAS OCCURRED MORE OFTEN. AS OF TODAY 4-10-15 THEY ARE ALL HAPPENING, SO I CAN NOT DRIVE THE VAN NOW DUE TO THE LOSE OF THE SIGNALS, LIGHTS, AND NOT BEING ABLE TO OPEN THE DOORS OR WINDOWS. I CHECKED UNDER THE STEERING WHEEL AND SAW A TINY LIGHT GOING ON & OFF AND THEN IT WENT OFF AND SO DID EVERYTHING ELSE WHICH WAS WORKING BEFORE. THE NOISE WAS AROUND THAT LIGHT AREA NEAR A BLACK BOX. WHAT IS CAUSING THIS? I FEEL IT IS DANGEROUS TO DRIVE THE VAN. *TR

WHILE DRIVING DOWN THE ROAD, THE VAN WILL SUDDENLY DIE. ALL ALARMS, ENGINE LIGHT, ABS, TRACTION CONTROL. WILL GO OFF. SUDENLY THERE IS NO POWER. VAN WILL START RIGHT BACK UP AND DRIVE AGAIN. THIS HAS BEEN GOING ON FOR OVER A YEAR. I HAVE HAD IT AT 7 DIFFERENT MECHANICS, INCLUDING THE FORD DEALERSHIP WHERE I PURCHASED THE VEHICLE. IT HAS HAPPENED AT ALL DIFFERENT SPEEDS, 20-65, ALSO HAPPENS IF STALLED AT A STOP LIGHT OR DRIVE-THRU. ADDITIONALLY, I CAN BE DRIVING AT 25-35MPH AND THE RPM'S WILL SHOOT UP TO 7000 OR FALL ALL THE WAY DOWN LIKE YOU ARE IDLEING. VEHICLE MAKES NOISES LIKE IT IS GOING TO BLOW UP AND THEN WILL BE FINE. *TR

Mileage: 100,000

IN 06/2014 MY VAN TRANSMISSION LIGHT CAME ON THEN WENT OUT. I THOUGHT IT WAS NOTHING AS TIME PROGRESS I NOTICE THAT MY VAN WAS SLOW AND HARD SHIFTING. I TOOK IT TO THE NEAREST TRANSMISSION AUTO SHOP AND THEY TOLD ME IT WAS MY INTERNAL TRANSMISSION FAILING. I PUT IT IN THE SHOP AND THE REPAIR COST 1200.00 TO FIX. IT GOT IT OUT WORKED FINE FOR A FEW DAYS THEN STARTED BACK SLOW AND HARD SHIFTING AGAIN. TOOK IT BACK TO MECHANIC THEY SAID THEY DON'T SEE ANYTHING WRONG WITH IT. I DID THIS SEVERAL AND HAD NO LUCK WITH IT. 08/2014 I STARTED HAVING MORE NOTICEABLE ELECTRICAL PROBLEMS LIKE DASH BOARD LIGHTS COME ON NOW AND THEN RADIO RESETS IT SELF SOMETIMES IT WONT WORK AT NOT EVEN THE DVD PLAYER. THE DOORS WONT LOCK ALARM GOES OFF WHEN IT WANTS TO AND POWER SLIDING WONT CLOSE. SO I ONLY DROVE THE VAN AROUND TIME LIMITING MY TRIPS CONTACTED FORD NO HELP THERE. THEN WINTER COMES IN ALL OF SUDDEN MY VAN WORKS GREAT DASH BOARD LIGHTS WORKING DVD AND RADIO WORKING FINE MOST IMPORTANTLY MY VAN TRANSMISSION WAS SHIFTING PROPERLY BUT THEN ON WARMER DAYS IT STARTS TO ACT UP AGAIN.ON 02/16/20015 MY CHILDREN AND I WAS ON OUR WAY TO GET GROCERIES FOR THE WINTER STORM THAT WAS COMING,THE LOST POWER AND DIED LUCKILY WAS CLOSE TO HOME THAT I COULD PULL OVER START IT AGAIN AND MAKE IT HOME SAFELY. THEN TODAY IT WILL NOT START UP AT ALL. IM A SINGLE MOTHER OF FIVE YOUNG DAUGHTERS AND MY OLDEST DAUGHTER AND I ARE BOTH DISABLED. WE DEPEND ON THIS VEHICLE TO GET BACK AND FORTH TO OUR DOCTORS APPT. IM PLANNING HAVE A MECHANIC CHECK MY PCM AND TO SEE IF ITS WATER DAMAGE. BUT I'VE NOTICE SEVERAL FELLOW FORD OWNERS ARE GOING THROUGH SIMILAR PROBLEMS. I DON'T KNOW WHY FORD NOT WILLING TO OWN UP TO THEIR LIFE THREATENING MISTAKES. *TR

Mileage: 101,000

WHILE DRIVING AT 70 MPH THE VAN STOPPED RUNNING. I WAS UNABLE TO RESTART IT. I ALSO LOST ALL ABILITY TO STEER. THIS HAPPENED DURING A VERY BUSY TIME ON THE HIGHWAY. I WAS STRANDED IN THE MIDDLE OF A LANE WITH TRAFFIC AROUND ME CONTINUING TO GO 70 MILES PER HOUR. AFTER RESEARCHING, MY MECHANIC FOUND THAT THE PROBLEM IS THE PCM IS GETTING WET DUE TO A DESIGN FLAW BY FORD MOTOR COMPANY. THIS WAS A VERY DANGEROUS SITUATION FOR ME TO BE IN. THE VAN CONTINUES TO HAVE PROBLEMS WITH MOISTURE EVEN THOUGH THE PCM HAS BEEN CHANGED AND ALL KNOWN AREAS HAVE BEEN SEALED. THIS VEHICLE IS DANGEROUS. *TR

Mileage: 149,856

ON CHRISTMAS EVE 2014 I GOT INTO MY RECENTLY PURCHASED 2005 FORD FREESTAR MINIVAN TO RUN A SHORT ERRAND. AFTER STARTING MY FREESTAR I PUT IT IN REVERSE BUT THE VEHICLE WOULD NOT MOVE. I TRIED ALL THE FORWARD GEARS WITH THE SAME RESULT, THE VEHICLE WOULD NOT MOVE. THE ENGINE RPM'S WOULD GO UP BUT NO MOVEMENT. I TURNED THE VEHICLE ENGINE OFF AND ON SEVERAL TIME WITH THE SAME RESULTS EACH TIME. I HAD TO WAIT TILL THE DAY AFTER CHRISTMAS TO CONTACT MY LOCAL FORD DEALERSHIP SERVICE DEPARTMENT AND DESCRIBE MY PROBLEM. THEY LOOKED UP MY VIN NUMBER AND SAID THAT ALL RECALLS ON MY VEHICLE HAD BEEN DONE INCLUDING THE TORQUE CONVERTER RECALL. I THEN HAD MY FREESTAR TOWED TO THE DEALERSHIP TO INVESTIGATE THE PROBLEM. UPON INVESTIGATION IT WAS DETERMINED THAT WATER HAD GOTTEN INTO MY POWERTRAIN CONTROL MODULE, AND THAT IS WHAT WAS CAUSING THE PROBLEM. THEY REMOVED THE MODULE AND DRIED IT AND THE CONNECTOR OUT THEN REINSTALLED IT AND SEALED IT. AFTER REINSTALLING THE MODULE THEY THEN STARTED THE VEHICLE AND WERE ABLE TO SHIFT THE VEHICLE INTO ALL THE GEARS AND GET THE TRANSMISSION TO FULLY FUNCTION, BUT NOW THERE WAS A SERVICE ENGINE LIGHT ON. THE VEHICLE NOW WOULD NOT IDLE PROPERLY AND HAD A HESITATION WHEN TRYING TO ACCELERATE. IT WAS DETERMINED AFTER FURTHER CHECKS THAT THERE WERE FUEL CODES COMING UP AND THAT THEY WERE RELATED TO THE PCM GETTING WET. IT WAS DETERMINED THAT THE POWERTRAIN CONTROL MODULE (WHICH FORD NO LONGER MANUFACTURES) WOULD NEED TO BE REPLACED. TO FIX THE PROBLEM IT WOULD BE A COST OF $1000.00 FOR A RE-MANUFACTURED MODULE AND REPROGRAMMING IN ADDITION TO THE $650.00 THAT HAD ALREADY BEEN INCURRED FOR THE WORK THAT HAD BEEN DONE SO FAR. NOTE THERE HAD BEEN NO PROBLEMS OR ISSUES OR ENGINE CODES ON THIS VEHICLE TILL THIS PROBLEM OCCURRED OTHER THAN A PROBLEM ONE NIGHT WITH THE POWER DOOR LOCKS NOT WORKING, WHICH CORRECTED ITSELF AFTER RESTARTING THE VEHICLE. *TR

Mileage: 16,953

MY 2005 FREESTAR FAILED TO MAINTAIN FORWARD SPEED AT 65 MILES PER HOUR WHEN IT BUCKED AND BUCKED THEN STALLED LOOKED ON LINE FOR ANSWER? YES PCM IS WATER DAMAGED TRYING TO DRY IT OUT NOW HOPE IT WORKS SOUNDS LIKE FORD IS WAITING FOR SOMEONE TO GET HURT.RELOCATED THE PCM AND SAVE ALOT FOR YOUR COMPANY ITS JUST RIGHT TO DO TSB ISN'T DOING IT PLEASE AND THANK YOU *TR

Mileage: 141,000

WHILE DRIVE THE CAR WILL STALL OUT AND SHUT OFF WITH NO WARNING. IN A NORMAL CITY BLOCK IT HAPPENED AT LEAST TWO TIMES B. *TR

Mileage: 134,500

WE HAVE OWNED OUR 2005 FORD FREESTAR SINCE MAY 2012. IN AUGUST 2012 AND GOING FORWARD WE HAVE EXPERIENCED MANY PROBLEMS WITH THE LOCKING SYSTEMS. THE AUTOMATIC LOCKS WILL NOT UNLOCK VIA THE KEY FOB OR THE DOOR BUTTON. AND BECAUSE FORD DESIGNED THE REAR HATCH / DOORS WITHOUT A MANUAL KEY INPUT. IT BECOMES IMPOSSIBLE TO UNLOCK THE DOORS. THIS IS ESPECIALLY CONCERNING BECAUSE THERE IS NO WAY TO MANUALLY OPEN THE REAR HATCH. THIS IS A SERIOUS FLAW THAT COULD HAVE VERY SERIOUS CONSEQUENCES. THERE SHOULD ALWAYS BE A WAY TO UNLOCK ALL OF THE DOORS FROM THE OUTSIDE OF THE VEHICLE. AS A MOTHER OF TWO KIDS, I KNOW THAT MY KIDS WOULD NOT BE ABLE TO GET OUT OF THE VEHICLE IF THEY NEEDED TO WHEN ONE OF THESE EPISODES HAPPEN. IT IS ALSO A CONCERN IF A LARGE ITEM IS LOADED INTO THE BACK OF THE VAN, THEN THE MALFUNCTION HAPPENS AND YOUR CUSTOMER CAN'T GET IT OUT. THIS JUST HAPPENED TO MY HUSBAND. WE LOST OUT ON MY HUSBAND BEING PAID BECAUSE HE WAS LATE TO HIS SHOW BECAUSE OF THIS RIDICULOUS MALFUNCTION THAT EVERY FORD FREESTAR OWNER IS EXPERIENCING. I GOOGLED THE PROBLEM AND IT IS DISGUSTING THAT SO MANY CUSTOMERS HAVE TO DEAL WITH THIS ISSUE. FIX IT NOW FORD! *TR

Mileage: 85,000

VEHICLE CONTROL CENTER STATES ABS IS NOT FUNCTIONING. TRACTION CONTROL NOT FUNCTIONING. CRUISE CONTROL WORKS INTERMITTENTLY. ALARM SYSTEM TRIGGERS INTERMITTENTLY. ABS AND TRACTION CONTROL FAILURE CAUSES VEHICLE TO BE DIFFICULT TO DRIVE. DEALERSHIP STATES IS COMMON ISSUE AND THERE IS A TSB ON THE ISSUE. REQUIRES ABS MODULE AND HCU MODULE. *TR

Mileage: 72,000

THE LIGHT FOR THE POWERTRAIN MALFUNCTION STARTED FLASHING AFTER WE HAD THE ALTERNATOR CHANGED. DO NOT KNOW IF IT WAS JUST A COINCIDENCE BUT THE SPEEDOMETER ALSO STOPPED WORKING. *TR

Mileage: 250,000

DRIVING HOME VAN STARTING SHUTTERING VIOLENTLY THEN SHUT OFF WHILE STILL ROLLING LOST ALL POWER, WAS SAFELY ABLE TO GET TO SIDE OF ROAD . TOLD ISSUE COST 1500 TO FIX SEEN FORD SERVICE BULLETIN ON DEFECT OF WATER GETTING TO PCM ON INTERNET. *TR

Mileage: 162,000

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT THE SLIDING DOOR LOCK FAILED AND COULD NOT BE UNLOCKED ELECTRONICALLY OR MANUALLY. THE LOCAL MECHANIC STATED THAT THE POWER CONTROL MODULE WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 126,000.

Mileage: 126,000

HEAVY RAIN ALL DAY AND THE WATER WAS LEAKING ON THE MAIN COMPUTER BOARD. CAUSING THE VAN TO STALL OUT AND RESULTING IN A 100.00 TOW BILL. THE SHOP TOLD ME IT IS LEAKING AND NEEDS TO BE REPLACED AND SEALED. *TR

Mileage: 99,000

COMING INTO MY PARKING LOT, I LOST POWER STEERING. IT APPEARS THAT I HAVE A LEAK. BUT BEFORE THIS HAPPENED, I HAD SOME ODD SOUNDS HAPPENING AND SOME OTHER MINOR ISSUES WITH THE VEHICLE THAT AT THE TIME SEEMED UNRELATED. THEN I LOST MY STEERING. I BOUGHT THIS VEHICLE USED IN '09, SO I EXPECTED A FEW ISSUES ALONG THE WAY. THIS IS NOT THE FIRST MAJOR ISSUE I HAVE HAD, AS I HAD TO HAVE THE TRANNY RECALL ISSUE REPAIRED ABOUT A YEAR OR TWO AGO. (WHAT IS IT WITH FORD THINKING IT IS MORE COST EFFICIENT TO ALLOW PEOPLE TO GET HARMED THAN TO FIX A PROBLEM?!!! UNFORTUNATELY I HAVE NOT HAD THE INCOME TO BUY A NON-FORD VEHICLE, BUT MARK MY WORDS, WHEN I DO HAVE THE INCOME, I WILL NO LONGER BE A FORD DRIVER.) NOT THE FIRST TIME THAT I HAVE HAD TO GET RECALL WORK DONE EITHER, I NOW HAVE TO GET THE REAR SEAT FIXED YET, BUT CANNOT DRIVE IT TO THE DEALER TO GET IT FIXED BECAUSE I DON'T HAVE POWER STEERING! IRONIC? HHMMMM...I WONDER. MY CAR HAS BEEN SITTING SINCE JAN 6 2014. NO MONEY TO FIX IT UNTIL NOW. THANKS FORD -PLEASE NOTE: SAID WITH SARCASM. *TR

Mileage: 155,523

I WOULD LIKE TO REPORT THE FAILURE OF A COMPANY AND A VAN. I RECENTLY PURCHASED A 2005 FORD FREESTAR FOR MY FAMILY OF FIVE THAT HAS BEEN THE WORST DECISION OF MY LIFE. A MONTH AFTER I EXPERIENCED WHAT TOO MANY OTHER OWNER HAVE ALSO EXPERIENCED. WATER IN THE PCM, THIS ALMOST RESULTED IN A CRASH AND INJURY TO ME AND MY FAMILY. STALLING OUT WITHOUT WARNING AT ANY SPEED. THIS KNOWN ISSUE HAS GONE ON TOO LONG WITHOUT ANY RESPONSE FROM FORD COMPANY. I AM NOT A BELIEVER IN SOMEONE HAS TO DIE FOR THERE TO BE CHANGE. ALSO DON'T APPRECIATE THE COST OF THIS JOB OVER $1000. I WAS FORTUNATE TO NOT BE ON THE HIGHWAY AND CRASH. ALTHOUGH THEN WE MIGHT GET OUR MONEY BACK. THIS HAS ALSO LED TO OTHER ISSUES THAT HAS BECOME A CHAIN REACTION OF FAILURE. I WILL KEEP MY RECEIPT FOR AS LONG AS I HAVE TO. *TR

Mileage: 134,343

I BOUGHT MY 2005 FORD FREESTAR IN 2005. ALMOST IMMEDIATELY AFTER BUYING IT WE HAD INSTANCES OF THE POWER LOCKS NOT WORKING. THE DRIVER DOOR WILL UNLOCK BUT THE REST WILL NOT. WE HAVE EVEN HAD TO CLIMB IN THROUGH THE DRIVER DOOR TO UNLOCK THE BACK DOORS BY HAND THEN TRY TO GET GROCERIES OUT OF THE WAY BACK THROUGH THE MIDDLE DOORS. THIS IS ALSO A HUGE SAFETY CONCERN FOR ME. IF I WERE TO GET INTO AN ACCIDENT AND BE INCAPACITATED AND MY KIDS WERE IN THE CAR, THEY WOULDN'T BE ABLE TO OPEN THOSE DOORS BECAUSE IT KEEPS THEM LOCKED EVEN IF YOU PUSH THE BUTTONS TO OPEN THEM AUTOMATICALLY. I AM SICK OF DEALING WITH THIS ISSUE. THERE ARE SO MANY FORUMS ON LINE WHERE OTHER PEOPLE HAVE THE SAME PROBLEM. THIS NEEDS TO BE FIXED! *TR

Mileage: 85,000

I HAVE HAD AN ISSUE WITH IT DYING AND STALLING OUT AND NOT WANTING TO MOVE.... AFTER 3 TRIPS IN A MONTH TO THE DEALERSHIP THEY FINALLY FOUND THE PROBLEM, IT WAS THE PCM MODULE..... I CALLED FORD MOTOR COMPANY AND INFORMED THEM THAT AFTER DOING RESEARCH ONLINE THAT I HAVE NOTICED THAT THIS IS A MAJOR ISSUE WITH MANY OWNERS..... THEY SAID THAT IF ENOUGH PEOPLE CALL IN AND INFORM IT WILL GET ADDRESSED BY NHTSA...SO IF YOU ARE HAVING THIS PROBLEM OR HAVE HAD IT PLEASE CALL IN. KEEP YOUR RECEIPTS FOR ANY REPAIRS DONE DUE TO THIS AND IF THERE IS A RECALL AND HOPEFULLY IT WILL BE BEFORE SOMEONE DIES DUE TO IT. WE WILL BE REIMBURSED FOR OUR REPAIR COSTS. *TR

DRIVING AT APPROXIMATELY 35MPH THE VEHICLE STARTED STALLING OUT AND WOULD NOT SHIFT PROPERLY. FORTUNATELY WAS ABLE TO SAFELY COAST TO SIDE OF ROAD. HAD VEHICLE TOWED TO CONWAY FORD IN CONWAY, SC. NEEDED NEW POWER CONTROL MODULAR (PCM) DUE TO WATER LEAKING THROUGH WINDSHIELD COWLING AND SHORTING OUT CONNECTIONS TO PCM. CREATED A POTENTIALLY DANGEROUS SITUATION WITH VEHICLE STALLING OUT WHILE IN MOTION. RESEARCH HAS REVEALED THIS TO BE A VERY COMMON PROBLEM WITH THIS VEHICLE THAT IS A SAFETY HAZARD THAT NEEDS TO BE ADDRESSED BY FORD MOTOR COMPANY WITH A RECALL. *TR

Mileage: 55,439

WHEN IS THE NHTSA GOING TO GET SERIOUS WITH FORD ON FORCING THEM TO ISSUE A RECALL ON THE PCM THAT SHUTS DOWN THE ENGINE AND PUTS THE DRIVER AND PASSENGERS IN A DEATH VEHICLE. THIS IS A KNOWN ISSUE ALL OVER THE INTERNET AS WELL AS ANY MASTER CERTIFIED FORD TECHNICIAN.THE PCM IS UNDER THE COWLING WHERE THE WATER SETTLERS AND GET ELECTRICALLY WICKED INTO THE PCM SHUTTING IT DOWN AT ANY TIME UNDER LOAD IN TRAFFIC FREEWAY SPEEDS.JUST WANT TO KNOW IF PEOPLE HAVE TO DIE BEFORE SOMETHING HAPPENS WITH A WILDLY KNOWN DEFECT WE BOUGHT THIS VEHICLE BRAND NEW BECAUSE OF THE SAFETY RATING AT THE TIME FOR TRANSPORTATIONS OUR SPECIAL NEEDS SON, I SURE HOPE THIS ISSUE DOESN'T END UP WITH A DEATH OF MY WIFE AND CHILDREN DUE TO ,THE LACK OF CONCERN FROM THE NHTSA. WAITING FOR A TIMELY RESPONSE AND RESOLVE. *TR

Mileage: 120,000

MY WIFE HAD JUST LEFT WORK. ON A VERY BUSY STREET THE VAN UP AND DIED. RESTARTED IT AND HAD NO POWER TO GET UP TO SPEED. KEPT SHUTTING DOWN. MANAGED TO GET IN TO A PARKING LOT. HAD IT TOWED TO THE DEALERSHIP. AT FIRST WAS TOLD IT WAS THE TRANSMISSION. NOW, THEY SAY IT IS THE PCM. PCM HAS BEEN ON BACK ORDER FOR SOME TIME. FORD SAID IT WAS SHIPPED ON NOV. 13 2013. CALLED THE DEALERSHIP ON THE FOLLOWING FRIDAY AND NO PART. NO WAS TOLD THAT THERE IS AN EVEN LONGER WAIT TIME FOR THE PCM. HAVING A AFTERMARKET PCM INSTALLED. TWO WEEKS WITHOUT OUR VAN IS LONG ENOUGH. HOPE TO HAVE IT BACK ON FRIDAY THE 22ND OF 2013. HAVE TALKED TO FORD CUSTOMER CARE, THEY KNOW THERE IS A PROBLEM. HAVE READ THAT THE SEAL UNDER THE COWLING LETS GO AND WATER WILL DRIP DOWN ONTO THE PCM CONNECTION AND MESS UP THE PCM. *TR

Mileage: 95,000

THE SITUATION IS VERY DANGER, THE PROBLEM WITH THE PCM ISSUES, THAT SHARE BAD INFORMATION WITH ANY OTHER COMPONENT IN USE, ENGINE, TRANSMISSION, LIGHTS, AC SYSTEM, LOW BATTERY OR NOT TURN ON EVEN WITH NEW BATTERY, AND THE WIRES AND CONNECTORS CLEAN. THE MOST DANGEROUS IS JUST STOP RUNNING IN MIDDLE OF TRAFFIC, OR SOME MECHANIC DID NOT HAVE IDEA ABOUT THE PROBLEM, EVEN THE SARASOTA FORD MECHANICS. A FEW WEEKS A GO I LEFT THE CAR FOR 2 DAYS, PRESENT IN MY OPINION TRANSMISSION MAL-FUNCTION, AFTER THEY CHARGE ME $140, NO PROBLEMS SOLVED, AND THEY SAY THE TECHNICIAN REPORT : NEEDS ENGINE WORK BEFORE TRANSMISSION DIAGNOSTICS. NEEDS CAM SYNCRO ASSY.(FIX WHINNING NOISE) I AGREE OK. NEED A SENSOR ASY ??????? CONNECT A LITTLE METAL WIRE ON TOP ENGINE (THEY CALL BUSH.....???) AFTER THAT ALL THE PROBLEMS STILL HAPPENING ALL THE TIME. IF YOU HAVE ANY ANSWER ABOUT ALL THIS, OR PLACE TO GO AND GET A REAL INSPECTION AND REPORT. FROM NOW AND FOREVER, THANK YOU VERY MUCH. *TR

Mileage: 112,000

IN THE MORNING THE VEHICLE BATTERY HAD BEEN DRAINED AND WE HAD IT TOWED TO THE DEALER. THEY REPLACED THE ALTERNATOR. WE PICKED IT UP AND THE CHECK ENGINE LIGHT CAME ON. THEY SAID IT WAS THE MASS AIR FLOW SENSOR AND REPLACED IT. TWO WEEKS WENT BY AND ONE DAY THE VEHICLE WOULDN'T START. WE HAD IT TOWED TO THE DEALER AND THEY SAID IT WAS THE MASS AIR FLOW CONNECTOR AND REPLACED IT. THE NEXT DAY THE VEHICLE WOULDN'T START. WE HAD IT TOWED TO THE DEALER AND THEY SAID NOTHING WAS WRONG. THE ENGINE ALWAYS IDLES VERY ROUGH AND NO ONE CAN CORRECT IT. IT HAS STALLED IN TRAFFIC. I HAVE DONE RESEARCH AND HAVE BEEN MADE AWARE OF A PROBLEM WITH THE PCM MODULE ON THESE VEHICLES. APPARENTLY RAIN GETS IT AND SOAKS THE MODULE CAUSING ALL SORTS OF ELECTRICAL AND TRANSMISSION PROBLEMS. FORD IS AWARE OF THE ISSUE AND HAS ISSUED A SERVICE BULLETIN AND REPAIR KIT FOR THIS PROBLEM, BUT NO RECALL. *TR

Mileage: 68,000

I WAS DRIVING ON A CITY STREET WHEN MY ENGINE LIGHT BEGAN FLASHING/BLINKING. I WAS HAVING TROUBLE WITH VAN MAKING WEIRD SOUNDS AND VIBRATIONS. I IMMEDIATELY PULLED OVER. JUST HAD TRANNY RECALL WORK DONE, SAME LIGHT ON. I CALLED FORD-THEY SAID IT WAS A MISS AND I SHOULD BRING IT IN. I WAS TOO AFRAID TO DRIVE THAT FAR, AND I HAVE NO $ FOR A TOW OR FIX. WAS TOLD BY MECH FRIEND THAT IT COULD BE ANY OF MANY SENSORS AND I'D HAVE TO TRIAL AND ERROR TO FIND IT. THIS IS NOT THE FIRST TIME THIS HAS HAPPENED TO ME, AND IT SEEMS TO BE WORSE WHEN IT HAS RAINED OR IS VERY DAMP OUT. IT VIBRATES, SHAKES, AND SOUNDS LIKE THE ENGINE IS NOT RIGHT. ALSO I HAVE NO GET UP AND GO, IT WANTS TO STALL OUT EVERY TIME I TRY TO ACCELERATE, AND I HAD A NEAR ACCIDENT ONCE. SEEMS TO BE WORSE ON HILLS OR ANY INCLINES. NOT A HAPPY FORD CUSTOMER-AGAIN. THESE PROBLEMS HAVE BEEN ON-GOING FOR THE LAST SIX MONTHS OR SO. ANYTHING OVER 25MPH AND THE VAN "SHIMMIES" REALLY BAD. *TR

Mileage: 151,666

AFTER RAIN ALL NIGHT ON WED.6/4/2013 WENT TO TAKE VAN TO PITTSBURGH STARTED HESITATING AND VIBRATING WHILE ON HIGHWAY COULD NOT SPEED UP AND TRIED TO GET IN SLOW LANE LOT OF TRAFFIC ALMOST COLLISION . TRIED TO GO UP SMALL HILL NO POWER VIBRATING TRYING TO STALL, TURNED OFF WOULDN'T STARTFOR 15 MINUTES VERY SCARY. LOOKED ONLINE BULLETIN FOR PCM GETS WET AND CAUSES THIS,SOMEONE COULD HAVE BEEN KILLED. *TR

Mileage: 113,000

THE CAR WOULD START THEN STALL. I WOULD BE DRIVING AND IT WOULD JUST SLOW DOWN LIKE NO GAS GETTING INTO ENGINE AND STALL OUT . I TOOK IT TO FORD DEALER (CREST FORD CENTERLINE MICHIGAN) THEY RAN IT ON A SCOPE. TOLD ME I NEEDED TURBINE SHAFT SPEED SENSOR. THEY REPLACED IT AND CALLED TO SAY MY VEHICLE WAS FINE AND READY TO GO. I PICKED UP CAR ON MONDAY EVENING AND ON WEDNESDAY CAR HAD TO BE TOWED BACK TO THE DEALER. CAR WOULD START BUT WOULD NOT DRIVE. FORD COULD NOT FIND PROBLEM AND FINALLY I CALLED A FRIEND TO ASK FOR A SOLUTION. BECAUSE OF ALL THE ISSUES WITH THE PCM AND HIS EXPERTISE I CALLED MY FORD ADVISOR [XXX] AND TOLD HIM TO CHECK THE PCM FOR WATER DAMAGE. HE CALLED ME BACK SHORTLY AND SAID THEY FOUND THE WATER DAMAGE. THIS IS A VAN MADE VERY WRONG WITH A DESIGN SO THAT YOUR WINDSHIELD LETS WATER FLOW ONTO THE COWL AND THEN DAMAGES THE BRAIN FOR THE CAR. I NOW HAVE TO PAY 1000.00 TO FIX A MISTAKE FORD MOTOR CREATED. THIS IS A PROBLEM FOR EVERYONE WHO OWNS THIS VEHICLE. I HOPE FORD FIXES IT ON A RECALL BEFORE SOMEONE DIES. I FEEL AS A CONSUMER I SHOULD NOT HAVE HAD TO GO FIGURE OUT WHATS WRONG WITH MY CAR ON MY OWN. FORD MECHANICS SHOULD KNOW AND BE EXPERIENCED. THIS WILL BE MY LAST FORD WITH THE WAY THEY HANDLE THEIR CARS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 74,420

DON'T HAVE MY VIN ON ME TO SHARE AT THIS TIME. ALSO, THE SPECIFIC ELECTRICAL PROBLEM IS THE PCM. ON 4/4/2013, I WAS DRIVING DOWN THE HIGHWAY AT ABOUT 45-50 MPH WHEN MY CAR 'DIED'. I LOST ALL POWER - NO BRAKES, STEERING, ETC. FORTUNATELY, NONE OF MY KIDS WERE IN THE CAR. THE CAR WAS TOWED TO THE DEALERSHIP THAT NIGHT. THEY SAID IT WAS MY CAM SENSOR. LESS THAN 5 DAYS AFTER PICKING UP THE CAR ON 4/9 TH CAR ACTED UP AGAIN. (THEY KEPT THE CAR FOR A RECALL UNRELATED TO THIS). ON 4/14 I WAS DRIVING DOWN THE HIGHWAY AT ABOUT 70 MPH WHEN THE CAR STARTED TO JERK. LUCKILY I WAS CLOSE TO HOME THIS TIME AND AFTER STOPPING SEVERAL TIMES WAS ABLE TO GET THE CAR IN THE DRIVEWAY. MY YOUNGEST DAUGHTER WAS IN THE CAR WITH ME WHO IS NOW AFRAID TO GET BACK IN THE CAR. THE NEXT MORNING I HAD IT TOWED BACK TO THE DEALERSHIP. A FEW DAYS LATER THEY SAID IT WAS MY ALTERNATOR. I WAS TOLD THEY WOULD CREDIT ME BACK THE MONEY I PUT OUT FOR THE CAM SENSOR. THEY PUT IN THE NEW ALTERNATOR AND TEST DROVE THE CAR. GUESS WHAT - THE CAR STILL JERKED. THE SHOP MANAGER TOOK IT HOME WITH A COMPUTER HOOKED UP TO IT. THEY COULD NOT FIND ANYTHING. THEY THEN PUT A CALL INTO THE FORD HOTLINE. A WEEK LATER THEY TELL ME IT IS THE PCM. IT GOT WET. OVER $400 TO FIX AND THAT IS WITH A USED PART. OVER $1200 IF IT IS NEW. A QUICK INTERNET SEARCH FINDS THE PCM IS A COMMON ISSUE WITH THE FREESTAR. NOT SURE WHEN IT WILL BE RECALLED. I HOPE NO ONE GETS SERIOUSLY INJURED BEFORE THESE COMPLAINTS ARE TAKEN SERIOUSLY. I WILL SAY THIS IS THE LAST FORD I WILL BUY. I AM NOT SURE HOW TO EXPLAIN TO MY KIDS THAT THE CAR IS SAFE TO DRIVE WHEN I DON'T BELIEVE IT MYSELF. I GUESS I WILL KEEP MY RECEIPT FOR WHEN THIS IS RECALLED SO I CAN BE REIMBURSED. *TR

Mileage: 80,000

FIRST WE HAD THE TRANSMISSION FAILURE THAT WAS UNSAFE AND HAD TO PAY FOR THE REPAIR OURSELVES THEN FINALLY FORD ISSUED A TSB TO REPAIR AND RECOVERED OUR MONEY. ALONG WITH THAT IS THE MORE DANGEROUS SITUATION OF THE VAN STOPPING JERKING SPEEDING UP THE DRIVING ON THE ROAD ESPECIALLY WHEN IT RAINS OR EVEN A SLIGHT MIST. THIS NEED TO ADDRESSED BY THE NHTSA AND PRESSURE FORD TO REPAIR THIS BEFORE THEY ARE SUED FOR A DEATH CAUSED BY THE LACK OF ATTENTION TO THIS HIGHLY SAFETY RELATED FAILURE. *TR

TOOK VAN IN TO TRANSMISSION REPAIR SHOP BECAUSE EVEN THOUGH FORD REPLACED THE TORQUE CONVERTER ON THE RECALL THE TRANSMISSION STILL SLIPPED. WHEN REPAIR WAS COMPLETED WE WENT AND PICKED UP OUR VAN ON THE WAY HOME IT DIED AND ALL THE LIGHTS WERE GOING CRAZY. SHOP TOWED BACK TO THEIR SHOP. THEY WENT THROUGH VAN AND FOUND THE COMPUTER WAS SATURATED WITH WATER. WE WERE TOLD NEED A NEW COMPUTER AND NEW WIRING HARNESS AND THIS HAS BEEN A KNOWN ISSUE WITH FORD WITH THEIR COMPUTERS GETTING WET. NOW WE ARE OUT 2600 AND STILL DON'T HAVE A CAR. IF THIS IS A KNOWN ISSUE WHY ISN'T FORD DOING ANYTHING TO FIX THE ISSUE? *TR

Mileage: 112,000

THE VEHICLE STALLED IN THE MIDDLE OF THE ROAD WITH MY WIFE DRIVING AND TWO CHILDREN IN THE CAR. LUCKILY NO ONE WAS INJURED, MY WIFE WAS ABLE TO COAST THE VEHICLE OUT OF HARMS WAY. THIS COULD HAVE BEEN SO MUCH WORSE HAD SHE BEEN PULLING OUT INTO TRAFFIC OR MERGING ON TO THE INTERSTATE. THE PROBLEM IS THE PCM MODULE HAS BEEN GETTING WET, FORD KNOWS OF THIS PROBLEM AND EVEN CREATED A SERVICE BULLETIN ABOUT IT. AT THE VERY, VERY LEAST I WOULD HAVE THOUGHT FORD WOULD HAVE CONTACTED THE VEHICLE OWNERS TO MAKE THEM AWARE THAT A SERIOUS ISSUE LIKE THIS EXISTED. THIS HAS THE POTENTIAL TO HAVE GRAVE CONSEQUENCES FOR INNOCENT FAMILIES OWNING THESE VEHICLES. IT IS MY OPINION THAT VANS IN PARTICULAR SHOULD BE SCRUTINIZED A LITTLE MORE CLOSELY DUE TO THEIR INTENDED AUDIENCE, SOCCER MOMS HAULING AROUND THE MOST VALUABLE POSSESSION OF THAT FAMILY, THEIR CHILDREN. IT IS BEYOND ME HOW AUTOMAKERS CAN PUT UNSAFE VEHICLES LIKE THIS ON THE ROAD AND THEY ARE NOT FORCED TO REPAIR ISSUES LIKE THESE WHEN THE OWNERS AND THEIR FAMILIES ARE AT RISK. THIS IS MY SECOND BUT SEPARATE COMPLAINT I LODGED AGAINST FORD ABOUT THIS VEHICLE. THE FIRST ONE WAS IN 2008 OR 2009 WHEN THE TORQUE CONVERTER FAILED WITHOUT WARNING, LEAVING THE VEHICLE LIFELESS IN THE MIDDLE OF THE ROAD. THIS VEHICLE SHOULD BE DEEMED UNSAFE FOR THE ROADS AND FORD SHOULD BE FORCED TO HAVE A FAIR BUY BACK PROGRAM FOR THESE VEHICLES. *TR

Mileage: 140,000

TRYING TO BACK OUT OF MY DRIVEWAY, VAN WILL NOT GO INTO REVERSE. RESTART VAN, PUT IT INTO REVERSE & IT FALTERS & STALLS. RESTART &GOT VAN INTO DRIVE,BUT IT WILL NOT ACCELERATE UNTIL 3000 RPMS, THEN JERKS INTO DRIVE & STALLS AGAIN. HAD IT TOWED TO A LOCAL MECHANIC I HAVE USED FOR OVER 20 YRS. VAN SHOWS NO CODES.REPLACE BATTERY, HAVE THROTTLE BODY CLEANED, CAM SENSOR IS TESTED, SHOWS NOT PROBLEMS. VAN STARTS & RUNS FOR ONE DAY. SAME EXACT ISSUE HAPPENS AGAIN. HAVE IT TOWED A SECOND TIME. AGAIN, NO CODES COME UP.MECHANIC FLUSHES OUT THE TRANNY,& VAN RUNS AGAIN FOR 50 MILES W/O INCIDENT. BUT AGAIN, TRYING TO LEAVE FOR WORK NEXT DAY, VAN DISPLAYS THE EXACT SAME ISSUES. NO TORQUE TO MOVE THE VAN, CONSTANT STALLING AS SOON AS IT IS TAKEN OUT OF DRIVE. WILL NOT MOVE AT ALL OR STARTS & MOVES VERY HESITANTLY INTO REVERSE, CATCHES GEAR & JERKS, STALLS ONCE AGAIN. TOW AGAIN TO A FORD DEALER. TOLD THE PROB IS THE RECALLED TORQUE CONVERTER. HAVE IT REPLACED, AND VAN DOESN'T MAKE IT THE 12 MILES HOME. THE VAN LOST COMPLETE POWER ON A HIGHWAY & I WAS ALMOST HIT BY ONCOMING TRAFFIC. TOW BACK, NOW BEING TOLD THE TRANSMISSION NEEDS REPLACEMENT, OVER $3,000 BECAUSE METAL FROM THE RECALLED PART HAS DISLOGGED INTO TRANNY. I AM NOW FINDING THRU MY OWN RESEARCH THAT THIS IS A COMMON PROBLEM RELATING TO THE PCM, WHICH REPLACING TRANNY DOESN'T SOLVE THE ISSUES. FORD IS OFFERING NO HELP OR COMPENSATION AM A SINGLE MOM OF 2 KIDS, 1 IS DISABLED,& NOW BEEN FIRED FROM MY JOB BECAUSE I CAN'T GET THERE 28 MILES AWAY. THE VAN IS STRANDED AT THE DEALER, BECAUSE I HAVE NO MONEY TO FIX OR TOW AGAIN. I AM AT MY WITS END. FORD NEEDS TO STEP UP TO THE PLATE &REPLACE THIS VAN!!!! REPAIRING THE TORQUE CONVERTER, CAM SENSOR, OR TRANSMISSION WILL NOT SOLVE THE PCM PROBLEM, WHICH IS NOT SEALED PROPERLY, & AFTER NUMEROUS REPAIRS, WILL MALFUNCTION AGAIN> MY Q TO FORD IS:DOES SOMEONE HAVE TO DIE FOR U TO DO SOMETHING? *TR

Mileage: 85,954

ENGINE STAYS IN THIRD GEAR ON HIGHWAY ,WINDSHIELD WIPER FLUID WON'T SPRAY AND POWER LOCKS DON'T WORK WITH BUTTON ON DOORS OR KEY FOB. GETTING 11 MILES A GALLON BECAUSE WON'T SHIFT INTO FOURTH GEAR AND THAT'S A HIGHWAY TRIP! *TR

Mileage: 131,200

THIS INFORMATION IS A COLLECTION OF INCIDENTS THAT ULTIMATELY FIT TOGETHER. I HAVE NOTICE THAT THE FLOOR BOARD OF MY VAN WAS WET. SINCE I HAVE 3 KIDS I JUST SHRUGGED IT OFF. THIS PAST WEEK I NOTICE THE FLOOR MATS WEREN'T WET ONLY THE CARPET BENEATH IT WAS SOAKED. MY KIDS DON'T SPILL JUST UNDER THE MATS. THE WATER MUST BE ENTERING FROM THE OUTSIDE IN. THE VAN WAS ACTING WEIRD ON AND OFF -NO CHECK ENGINE LIGHT UNTIL IT STARTED HAPPEN MORE FREQUENTLY. JUNE 2012, I GOT THE P1340 CODE THAT THE CAMSHAFT POSITION SENSOR HAD GONE BAD, I REPLACED IT, WENT OUT AGAIN, I WAS TOLD IT COULD HAVE BEEN A FAULTY PART, CHANGED IT AGAIN, WENT OUT AGAIN, DECIDED THIS IS BEYOND ME. I TOOK IT TO THE DEALERSHIP AND THEY "FIXED" THE CAMSHAFT POSITION SENSOR AND ANOTHER PART THAT WAS CAUSING THE CAMSHAFT POSITION SENSOR NOT TO WORK. ($900) IT BROKE AGAIN BECAUSE THE PART THEY PUT IN WAS DEFECTIVE. THEY REPLACED THE DEFECTIVE PART AND THE CHECK ENGINE LIGHT CAME BACK ON AGAIN. AFTER THEY HAD THE CAR FOR 2 WEEKS THEY FOUND ANOTHER SMALL PROBLEM. ($130) I INSISTED AT THE TIME THAT THEY DIDN'T MAKE THE PROPER REPAIRS. THEY ASSURED ME THAT IT ALL STILL NEEDED TO BE DONE. (CAUGHT SOME DOUBLE TALK) I EXPERIENCED A FEW MORE ISSUES WITH THE VAN LOSING POWER. (JULY,SEPTEMBER, OCTOBER -CHECK ENGINE LIGHT DID NOT TURN ON.) I:N DECEMBER THE CAR TURNED OFF AND I WAS ONLY ABLE TO GET ABOUT 25FT PER RESTART AND THE LIGHT CAME ON. I'VE NOTICED OTHER FEATURES NOT WORKING PROPERLY OR WORKING INTERMITTENTLY. (POWER LOCKS, POWER WINDOWS, RADIO, POWER DOORS, KEY REMOTE ...) I HAVE LEARNED THAT OTHER 2005 FREESTAR OWNERS HAVE EXPERIENCED SIMILAR INCIDENTS CAUSED BY WATER LEAKING INTO THE CAR THROUGH THE WINDSHIELD WIPER BLADES AND RUNNING DOWN THE WIRE HARNESS CAUSING MULTIPLE PARTS TO SHORT OUT FROM TIME TO TIME. PLEASE LOOK INTO THIS. I HAVE 3 CHILDREN AND NO MORE MONEY FOR "LET'S TRY THIS REPAIRS". *TR

Mileage: 68,000

THIS VEHICLE HAS A CONTINUING PROBLEM WITH THE PCM SHORTING OUT DUE TO WATER ENTERING THE WIRING HARNESS THROUGH THE WINDSHIELD WIPERS. ONCE THE PCM SHORT CIRCUITS THE TRANSMISSION DOES NOT FUNCTION CAUSING THE CAR TO LOOSE ITS' MOTION. THIS OCCURS WITHOUT WARNING AND PLACES THE OCCUPANTS OF THE VEHICLE AT GREATER RISK OF BEING INVOLVED IN AN ACCIDENT AS THE CAR SIMPLE CEASES TO WORK. THE COMPANY HAS CURRENTLY RECALLED THIS MAKE AND MODEL TO REPLACE A DEFECTIVE TORQUE CONVERTER. ALTHOUGH THIS SEEMS TO SOLVE THE PROBLEM INITIALLY, THE LONG TERM PROBLEM OF WATER SEEPING INTO THE PCM WILL CAUSE THE TRANSMISSION TO FAIL TIME AND TIME AGAIN. *TR

Mileage: 87,000

RECEIVED RECALL FOR TORQUE CONVERTER- HAD IT REPLACED ON AUG 20, 2012. ON NOV. 19TH THE VAN WOULDN'T GO PASS 20 MPH. DROVE SLOW APPROX. 3 MILES TO DESTINATION. HAD IT TOWED TO DEALERSHIP TO CHECK OUT PROBLEM AT INITIAL CONTACT WAS TOLD THEY KNEW OF NO PROBLEMS RELATING TO TORQUE CONVERTER REPLACEMENT. AFTER CHECKING VAN OUT WAS TOLD THAT WE NEEDED A NEW TRANSMISSION, AT SECOND CONTACT WAS TOLD THEY WERE AWARE OF TORQUE RECALL ISSUES BUT NOTHING WOULD BE DONE FOR US. WE HAD NOT HAD ANY PROBLEMS WITH TRANSMISSION PRIOR TO NOV 19TH. WHEN ASKED, WAS ALSO TOLD THAT THEY DID NOT FLUSH AND REPLACE FLUIDS WITH THE TORQUE CONVERTER RECALL SERVICE AS THIS EXTRA COST WAS NOT PART OF THE RECALL. WE WERE TOLD BY AN INDEPENDENT MECHANIC THAT IF FLUIDS WERE NOT CHANGED THAT IT COULD CAUSE THE TRANSMISSION TO FAIL WHICH IT DID. WAS QUOTED A HIGH COST TO REPLACE TRANSMISSION, ENDED UP USING DISABLED VEHICLE AS A TRADE 'AS IS' TO PURCHASE A WORKING VEHICLE. OTHER ISSUES WITH VEHICLE PRIOR TO LAST INCIDENT WERE ELECTRICAL FUNCTIONS NOT WORKING, SLIDING DOORS WOULD REOPEN UPON CLOSING, HAD TO TURN OFF AUTO DOORS, BACKUP WARNING QUIT WORKING, TRACTION CONTROL BUTTON DIDN'T WORK, DVD PLAYER WOULD START RUNNING ON ITS OWN. *TR

Mileage: 168,181

WAS DRIVING THE VEHICLE GOING DOWN THE HIGHWAY AT 60MPH AND THE VEHICLE STARTED TO ACT UP PULLED OVER AND IT SHUT DOWN COMPLETELY SECURITY LIGHT STARTED TO FLASH REAL RAPIDLY TURNED THE KEY TO START IT AGAIN AND NOTHING HAD TO HAVE IT TOWED 300.00 WORTH AND HAS BEEN BROKE DOWN FOR FOUR MONTHS BEEN TRYING TO START IT EVER SINCE AND NOTHING THERE IS DEFIANTLY SOMETHING WRONG WITH THE ELECTRICAL SYSTEM. *TR

Mileage: 130,000

HAVING A SIMILAR PROBLEM TO OTHERS WITH MY 2005 FORD FREESTAR. WATER GETTING INTO PCM AND CAUSING PROBLEMS. TOOK VEHICLE TO DEALERSHIP FOR TORQUE CONVERTER RECALL AND THEY NOTICED WATER IN THE PCM. THEY DRIED IT OUT AND VEHICLE RAN FINE FOR TWO WEEKS. HAD SIGNIFICANT RAIN LAST NIGHT AND PROBLEM HAPPENED AGAIN. THIS IS AN OBVIOUS FLAW IN THIS VEHICLE AND NEEDS TO BE FIXED. *TR

Mileage: 114,351

I WAS DRIVING MY MINIVAN BACK TO WORK FROM LUNCH. IT CUT OFF AS I TOOK A TURN. I STOPPED THE VEHICLE AND RESTARTED IT. AS I BEGAN TO GO AGAIN, IT CUT OFF AGAIN. I PULLED OVER AND RESTARTED THE VEHICLE. I WAS RIGHT OUTSIDE MY WORK PARKING LOT SO I PULLED IN AND PARKED. I CALLED EGAN AUTOMOTIVES BECAUSE THEY ARE LOCATED RIGHT BESIDE MY WORK. DURING MY BREAK I DROVE IT TO THEIR PLACE OF BUSINESS. MY MINIVAN CHECK ENGINE LIGHT WAS ON AND IT WAS ACTING SLUGGISH. I LEFT THE VEHICLE WITH THEM OVERNIGHT. EGAN AUTOMOTIVE CALLED ME AND TOLD ME THAT THERE WAS MOISTURE GETTING INTO THE COMPUTER BOX. THEY SAID THAT FORD KNEW ABOUT THIS PROBLEM AND WERE SELLING A KIT THAT WILL INSULATE THE COMPUTER BOX. I CALLED FORD AND THEY WON'T HELP EVEN THOUGH THE PLACEMENT OF THE COMPUTER BOX UNDER THE WIPER BLADE VENTS WAS THERE BRILLIANT IDEA. LOOKING ONLINE THIS SEEMS LIKE A PRETTY COMMON PROBLEM, YET FORD WON'T RECOGNIZE IT AND FIX IT. THIS IS GOING TO COST ME $300, WHICH I FEEL I'M NOT RESPONSIBLE FOR. A VEHICLE CUTTING OUT WHILE DRIVING IS A SAFETY HAZARD. CAN YOU HELP GET THIS RESOLVED? *TR

Mileage: 85,000

I HAVE HAD THE CAR STOP AFTER AND DURING RAINY DAYS. MOST RECENTLY THE CAR WOULD NOT START OR MOVE DURING A HEAVY RAIN. I HAVE HAD TO WAIT DAYS UNTIL THE CAR DRIES OUT FOR THE CAR TO MOVE. HAVE TAKEN IT TO THE SHOP AFTER SEVERAL INSTANCES OF THIS SAME OCCURRENCE. THEY CAN NOT FIND OUT WHAT IS WRONG AS THE CAR RUNS OK? AFTER RESEARCHING ON THE INTERNET I HAVE COME TO THE CONCLUSION THAT IT IS WATER LEAKING ON AND INTO THE PCM CAUSING THE CAR TO NOT START OR MOVE. FORD DEALERSHIP HAS NOT BEEN ABLE TO SOLVE THE PROBLEM OR HAVE A SOLUTION? *TR

Mileage: 56,000

2005 FORD FREESTAR PCM PROBLEMS. SYMPTOMS INCLUDE INTERMITTENT INCIDENCES INCLUDING VEHICLE'S FAILURE TO START, RUNNING ROUGH, IMPROPERLY ACCELERATING, REFUSING TO MOVE FORWARD/BACKWARD, AND OTHER RANDOM PROBLEMS. THE FUEL SYSTEM COMPONENTS/CAMSHAFT SENSOR/ETC, AS WELL AS THE TRANSMISSION HAVE BEEN REPLACED ON THE VEHICLE, BUT ALL OF THESE ISSUES STILL EXIST. CODES DO NOT SHOW UP ON MECHANIC'S DIAGNOSTIC COMPUTERS UNLESS THE CAR IS ACTIVELY HAVING THE PROBLEM, WHICH SEEMS TO RARELY HAPPEN. MECHANICS, INCLUDING THE LOCAL FORD DEALERSHIP, HAS NOT BEEN ABLE TO CONFIRM THE PROBLEM WITH THE PCM; HOWEVER, OUR MECHANIC DID FIND WATER IN THE COMPUTER MODULE. HE DRIED IT OUT AND RESEALED IT, IN HOPES OF RESOLVING THE ISSUES WE WERE HAVING. THE PROBLEMS HAVE CONTINUED THOUGH AND DESPITE LACK OF CODES, ALL INDICATIONS ARE THAT THE COMPUTER IS NO LONGER GOOD. ANOTHER PROBLEM IS THE FACT THAT GETTING A REPLACEMENT PCM IS NEARLY IMPOSSIBLE. THE DEMAND FOR FREESTAR RECONDITIONED COMPUTERS IS SO HIGH THAT WE'VE NOT BEEN ABLE TO FIND ONE TO REPLACE THE BAD UNIT IN THE VAN. (APPARENTLY, NEW PCM'S ARE NOT AVAILABLE AT ALL.) AFTER SEEING THE MASSIVE NUMBER OF ON-LINE COMPLAINTS WHICH ARE SO SIMILAR TO OURS, I CANNOT BELIEVE THAT FORD SHUT THE CASE REGARDING THE COMPUTER PROBLEM. IF THE DIAGNOSIS OF FAILED PCM'S IS ALMOST IMPOSSIBLE TO ACHIEVE, FORD SIMPLY CHOOSES TO IGNORE THE OBVIOUS. (READ ALL OF THE COMPLAINTS ON NHTSA.DOT.GOV.) POOR PLACEMENT OF THE PCM ON THE BACK OF THE VEHICLE WALL HAS ALLOWED WATER TO RUN OFF OF THE WINDSHIELD INTO THE UNIT, BUT FORD WILL NOT TAKE OWNERSHIP IN THIS PROBLEM. HOW MANY PEOPLE HAVE TO RISK HAVING A WRECK AND POSSIBLY DYING DUE TO WATER-DAMAGED COMPONENTS? IT IS UNFORTUNATE AND UNNECESSARY. ONE LAST QUESTION... IS IT POSSIBLE THAT THE TRANSMISSION PROBLEMS (CURRENTLY ON RECALL) BE RELATED TO THE WATER-DAMAGED PCM'S? *TR

ADD-ON INFO FOR COMPLAINT #10472027. THE DATE STATED FOR THE PROBLEM WITH THE PCM WAS MERELY AN ARBITRARY START DATE FOR OUR PROBLEMS, WHICH WAS REQUIRED TO PROCEED WITH THE COMPLAINT. WE HAVE HAD CONTINUAL PROBLEMS FOR AT LEAST NEAR 2 YEARS WITH THE VEHICLE, BUT NO MECHANIC (INCLUDING FORD'S) HAS BEEN ABLE TO ACCURATELY CONFIRM THE BASIS OF SUCH ISSUES. OUR ASSESSMENT OF A DAMAGED PCM IS BASED ON RESEARCH OF ON-LINE COMPLAINTS FROM OTHER FREESTAR OWNERS WHICH SEEM TO ALMOST PERFECTLY MATCH OUR SITUATION, AS WELL AS THE FACT THAT OUR MECHANIC HAD TO REMOVE WATER FROM THE COMPUTER COMPARTMENT. CURRENTLY, WE ARE IN SEARCH OF A REPLACEMENT COMPUTER, BUT THEY ARE ALMOST IMPOSSIBLE TO FIND. *TR

WAS STALLED OUT SEVERAL TIMES DURING THE MONTH OF JANUARY AND FEBRUARY OF THIS YEAR. IT WOULD JUST STOP RESPONDING. IT ACTED MUCH LIKE A TRANSMISSION GOING OUT, BUT THAT WAS NOT THE PROBLEM. AFTER MULTIPLE TOWES AND TRIPS TO THE MECHANIC TO ATTEMPT GETTING THIS VEHICLE REPAIRED, IT WAS DETERMINED THAT THE PCM HAD GOTTEN WATER INSIDE AND HAD TO BE REPLACED. I SPENT SEVERAL THOUSAND DOLLARS TRYING TO GET THIS VEHICLE TO RUN AS WELL AS IT HAD BEFORE. ONCE THE PCM ISSUE WAS DISCOVERED, IT DID RUN MUCH BETTER, BUT BY THIS TIME I HAD LOST MY FAITH IN THE VEHICLE. I CANNOT BELIEVE THAT FORD POSITIONED A COMPUTER COMPONENT WHERE WATER WOULD RUN DOWN ONTO IT, AND THEY HAVE NOT BEEN FORCED TO FIX THIS ISSUE. AS A RESULT OF ALL OF MY PROBLEMS WITH THIS VEHICLE, AFTER MANY YEARS OF BEING A FORD OWNER, I SOLD THIS VAN AND PURCHASED A CHRYSLER TOWN & COUNTRY. *TR

Mileage: 102,000

I WAS DRIVING 45 MPH IN A HEAVY RAIN WHEN MY VEHICLE BEGAN TO SPUTTER AND CHECK ENGINE LIGHT BEGAN FLASHING. I STARTED TO PULL OVER, BUT LIGHT WENT OFF AND ENGINE RAN FINE. AFTER SEVERAL DAYS OF RAIN ENGINE WOULD HESITATE IN ACCELERATION AND WOULD FEEL LIKE IT WAS MISSING. IT BEGAN ONLY OCCASIONALLY AND USUALLY WHEN TRAVELING UP HILL. IT PROGRESSIVELY GOT WORSE, ESPECIALLY AFTER RAIN OR BEING WASHED. INVESTIGATED AND FOUND THIS TO BE A COMMON PROBLEM WITH THIS MODEL WITH THE POWER CONTROL MODULE GETTING WET. TODAY WHILE DRIVING ON THE INTERSTATE CHECK ENGINE LIGHT BEGAN FLASHING AND ENGINE HESITATED, THEN CHECK ENGINE LIGHT STAYED ON. VERY DANGEROUS SITUATION TO FEEL LIKE MY VAN WAS GOING TO STALL AT 70 MPH WITH MY FAMILY IN THE CAR. *TR

Mileage: 113,000

AFTER DRIVING IN OR AFTER A HARD RAIN, THE ENGINE LIGHT COMES ON AND THE ENGINE RUNS VERY ROUGH AND OFTEN STOPS. HAS HAPPENED WHILE DRIVING ON HIGHWAY AT 55MPH. COWL WAS REMOVED AT DEALERSHIP TO PREVENT WATER INTRUSION IN OCT2010, BUT SAME PROBLEM STARTED HAPPENING AGAIN IN 2012... *TR

Mileage: 47,395

I WAS DRIVING MY FREESTAR HOME, PULLING INTO MY COMPLEX WHEN THE BATTERY LIGHT CAME ON, THEN A SECOND LATER THE BRAKE LIGHT, THEN ALL THE POWER TO THE VAN WAS LOST. I HAD NO CONTROL, THE ENTIRE ELECTRICAL SYSTEM WENT OUT, THE ENGINE SHUT OFF, I HAD TO RUB THE VAN UP AGAINST THE CURB TO STOP IT. WHEN I GOT IT GOING AGAIN AND PARKED IN MY PARKING SPOT THE BATTERY LIGHT CAME ON AGAIN AND I LOST ALL POWER AGAIN. THE NEXT DAY I REPLACED THE BATTERY AS I WAS TOLD IT COULD BE A BATTERY ISSUE, BUT EVEN WITH THE NEW BATTERY THE LIGHT WAS STILL ON. I HAD THE ALTERNATOR AND THE BATTERY CABLES CHECKED AND IT WAS FINE. THEN I WAS TOLD IT MAYBE THE PCM WHICH IS A KNOWN ISSUE WITH THIS MODEL AND WHAT I EXPERIENCED IS THE IDENTIFIED ISSUE...THIS IS VERY SERIOUS AS I WAS BRING HOME MY FAMILY HOME AND WE JUST GOT OFF THE HIGHWAY LIKE 5-10 MINUTES BEFORE THIS THING SHUT DOWN ON ME, IF THIS WAS THE HIGHWAY WE COULD HAVE BEEN SERIOUSLY HURT. PLUS NOW I CAN'T EVEN DRIVE BECAUSE THE PART IS NOT AVAILABLE, IT'S ON BACK ORDER, SO THIS MUST MEAN A LOT OF PEOPLE ARE HAVING THIS ISSUE. WE NEED TO HAVE A RECALL ON THIS BEFORE PEOPLE GET HURT OR KILLED, ESPECIALLY WHEN IT'S A KNOWN ISSUE HTTP://NHTHQNWWS111.ODI.NHTSA.DOT.GOV/ACMS/DOCSERVLET/ARTEMIS/PUBLIC/PURSUITS/2009/DP/INSL-DP09004-35644P.PDF !!!!! *TT

Mileage: 128,000

WAS ON A VERY BUSY HIGHWAY. THE FREESTARS DASH LIGHTS LITE UP AND WENT BACK OFF. AC CUT OFF THEN EVERYTHING STARTED WORKING AGAIN. ABOUT 30 SECONDS LATER THE FREESTAR DIED AT 65. I WAS ABLE TO COAST TO A STOP ON THE SHOULDER. AGAIN ON MAY 5 2012 THE LIGHTS STARTED FLICKERING AND THE AC STARTED TO BLOW HARD AND IT WOULD SLOW BACK DOWN THEN THE DASH LIGHTS ABS,BRAKE,BATTERY LIGHTS WOULD BLINK ON AND OFF THEN THE FREESTAR DIED AGAIN AT 70 MPH. BRAKES DIDN'T WORK I WAS GOING THROUGH A INTERSECTION AND HAD TO USE THE E BRAKE. FREESTAR HAS DONE THIS SEVERAL TIMES OVER THE LAST MONTH I JUST HIT THE HIGH SPOTS. IT HAS HAD TEST AFTER TEST AND I'M ALWAYS TOLD A DIFFERENT STORY! I JUST WANT MY VAN FIXED BEFORE SOMEONE GETS HURT OR KILLED. *TR

Mileage: 98,000

WHEN DRIVING DOWN THE ROAD THE VAN WILL SUDDENLY LOSE ALL FORWARD MOMENTUM AND DRIFT MOMENTARILY UNTIL IT WILL JUST AS SUDDENLY RESUME FORWARD MOMENTUM AND CONTINUE LIKE NORMAL. WHEN THIS HAPPENS, THE RPMS DROP OFF LIKE THE VEHICLE IS STALLING OR FUEL STARVED (HOWEVER IT HAS NO HESITATION LIKE ITS RUNNING OUT OF GAS) NO WARNING LIGHTS COME ON AND THERE IS NO PATTERN TO WHEN OR HOW IT HAPPENS. HOWEVER, THE PROBLEM HAS BEEN GETTING PROGRESSIVELY WORSE AND NOW IT IS NOTICED THAT IT HAS A HIGHER TENDENCY TO DO IT WHEN IT IS RAINING OR THERE IS HIGH HUMIDITY. IT DOES IT AT ALL SPEEDS FROM 25MPH TO 70MPH. FORD DEALERSHIP HAS LOOKED AT THE VAN AND COULD NOT GET IT TO REPRODUCE THE PROBLEM WHEN THEY HAD IT. HOWEVER, THEY STATED THIS DOES NOT SOUND LIKE A TORQUE CONVERTER PROBLEM ADDRESSED UNDER SAFETY RECALL NOTICE 11S25/ NHTSA RECALL 12V-006. THIS IS A VERY DANGEROUS PROBLEM AND HAS ALMOST CAUSED SEVERAL ACCIDENTS AS I HAVE NO WARNING THE PROBLEM IS GETTING READY TO HAPPEN AND HAVE NO WAY TO NOTIFY OTHER MOTORIST OF MY SUDDEN AND QUICK DECELERATION. *TR

Mileage: 102,340

ON SEPTEMBER 21, 2011 I NOTICED THAT MY 2005 FORD FREESTAR WAS HESITATING WHEN I PULLED OUT OF A PARKING SPOT IN FRONT OF MY HOME. I WAS ABLE TO GET TO MY FINAL DESTINATION, A LOCAL SUPERMARKET, WITHOUT INCIDENT BUT COULD TELL THAT THE CAR WAS NOT SHIFTING GEARS AS SMOOTHLY AS I WAS ACCUSTOMED TO. ON THE RETURN TRIP HOME, UPON MERGING ONTO THE EXPRESSWAY I TYPICALLY TAKE, MY FREESTAR'S ENGINE BEGAN TO SPUTTER THEN IMMEDIATELY SHUT DOWN. ALL POWER TO THE ENGINE WAS LOST. POWER STEERING WAS LOST AS WELL MAKING THE CAR IMPOSSIBLE TO MANEUVER. THE ELECTRICAL SYSTEM COMPLETELY SHUT DOWN AND I WAS FORCED TO COME TO A COMPLETE STOP, SHIFT INTO PARK AND REENGAGE THE IGNITION. FROM THAT POINT ON, UNTIL I ARRIVED HOME, THE FREESTAR WOULD NOT SHIFT BEYOND SECOND GEAR. IF I MADE AN ATTEMPT TO ACCELERATE, AGAIN THE ENGINE WOULD SPUTTER AND ALL POWER TO THE ENGINE, POWER STEERING AND ELECTRICAL SYSTEMS WOULD SHUT DOWN COMPLETELY. I MANAGED TO GET HOME THAT DAY BY STOPPING AND RESTARTING MY FREESTAR WHAT I CAN ONLY ESTIMATE TO BE 50 TO 75 TIMES. THE MOST HARROWING PART OF THIS EXPERIENCE WAS THE LOST OF POWER AND CONTROL WITHOUT WARNING. PRIOR TO THIS DAY, I HAD NEVER EXPERIENCED ANYTHING REMOTELY LIKE THIS WITH THE FREESTAR, AND THEN FROM ONE DAY TO THE NEXT, I WAS HELPLESS ON THE EXPRESSWAY EXPECTING A FATAL COLLISION WITH AN UNSUSPECTING DRIVER. *TR

Mileage: 51,379

WAS DRIVING AROUND 30MPH THEN THE RPM'S WENT UP TO 5000 LET OFF GAS RPM SLOWLEY WENT DOWN..2ND TIME IT HAPPENED TOOK IT IN THEY SAID IT WAS A SENSOR "FIXED" IT...THE 3RD TIME WAS GOING THREW AN INTERSECTION DIED ON ME IN MIDDLE OF INTERSECTION ALMOST GOT SMASHED BY ONCOMING TRAFFIC WITH MY KIDS IN THE VAN...HAD IT TOWED THEY COULD NOT FIND ANYTHING WRONG....4TH OR 5TH TIME WAS GOING TO WORK GOT OF HIGHWAY RPMS WENT UP TO 5000 AND THE VAN WONT GO NO WHERES NOW...NO REVERSE NO DRIVE JUST SITS THERE SOUNDING LIKE [XXX]THEY WAY FORD MADE IT...NOW WAITING ON THEM TO TELL ME WHATS WRONG WITH IT.... INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 71,900

THIS VEHICLE HAS DIED ON ME NUMEROUS TIMES WHILE DRIVING DOWN THE FREEWAY OR AROUND TOWN DRIVING. IT HAS BEEN VERY SCARY AND A MIRACLE WE WEREN'T KILLED. THE FIRST TIME IT HAPPENED IN 2006. THE FORD DEALER HAD NO IDEA WHAT IT WAS, FINALLY DISCOVERED IT WAS HAPPENING IN COLD WEATHER, MOIST AIR OR RAIN. THE PCM WAS GETTING WET. THEY PUT FOAM AND SEALED WITH AN ADHESIVE. IT STARTED AGAIN IN 2008 HAD TO BE RESEALED. IT HAS STARTED AGAIN IN 2011 AND 2012 IT IS VERY SCARY AND YOU NEVER KNOW WHEN YOU WILL LOSE POWER. IT IS VERY EXPENSIVE TO HAVE FIXED. FORD KNOWS THIS WAS A BAD DESIGN. THEY ARE WAITING FOR SOMEONE TO GET KILLED AND BE SUED BEFORE THEY WILL TAKE RESPONSIBILITY FOR THIS PROBLEM. MY VAN IS NOW PARKED, WHILE I TRY TO GET THE MONEY TOGETHER TO HAVE IT SEALED AGAIN. HEMBORG FORD DOESN'T EVEN OFFER A DISCOUNT FOR THE REPAIR. THEY ARE NOT CONCERNED AT ALL THAT THE VEHICLE DIES WHILE YOU ARE TRAVELING DOWN THE FREEWAY. THIS VAN HAS HAD NUMEROUS RECALLS, IT SHOULD HAVE HAD ONE FOR THE PCM BUT SO FAR IT HAS NOT. I GUESS THEY ARE WAITING FOR SOMEONE TO DIE. ONLINE THERE IS A LOT OF COMPLAINTS ON THIS SAME ISSUE FROM PEOPLE FROM ALL OVER THE UNITED STATES. *TR

Mileage: 21,223

PCM FAILURE MOISTURE GETS INTO PCM BECAUSE OF DESIGN FLAW AND CAUSES ELECTRICAL SHORTS AND VEHICLE JERKS AND CUTS OUT. LOSES POWER. *TR

Mileage: 141,000

VAN STARTED ACTING LIKE THE KEY WAS BEING TURNED OFF AND ON. MISFIRE WAS SO BAD THAT VAN WAS LIKE RIDING A BUCKING BRONCO. PULLED TO THE SIDE SEVERAL TIMES AS I THOUGHT WE WOULD NOT MAKE IT HOME. GOT HOME FROM SUNDAY DINER AND TOOK TO LOCAL DEALER THE NEXT DAY ON 6/20/11. INSTALLED 1F1Z 6B288 BA SENSOR. BACK TO DEALER ON 6/28/11. INSTALLED 164R4901 FOAM STRIP ALONG WITH SEALANT. BACK TO DEALER ON 7/5/11. INSTALLED. INSTALLED XL3Z 9F472 AA SENSOR. TO INDEPENDANT REPAIR SHOP ON 12/2/11. INSTALLED YFIZ-7H103AA SENSOR. BACK TO SAME REPAIR SHOP. INSTALLED 5F2Z12A650 BC PCM MODULE. THAT SEEMED TO RESOLVE THE PROBLEM AS VAN IS RUNNING BETTER THAN FOR THE LAST 2 YEARS. *TR

Mileage: 48,424

AFTER A RAIN STORM MY VAN EXPERIENCES PROBLEMS WITH THE POWER CONTROL MODULE. THE TRANSMISSION WILL NOT OPERATE CORRECTLY. THIS IS THE THIRD TIME THIS HAS TAKEN PLACE AND ALWAYS ASSOCIATED WITH A RAIN STORM. THIS TIME THE ENGINE WILL NOT START. *TR

Mileage: 76,000

PCM (POWER TRAIN CONTROL MODULE) HAS GOTTEN WET AND CAUSES CAR TO NOT DRIVE. LOSE POWER. NOT START. LUNGE, LURCH FORWARD. WON'T ENGAGE IN DRIVE OR REVERSE. I HAVE REPLACED PCM 6 TIMES. BROKE DOWN 5 TIMES. HAD VAN TOWED 5 TIMES. LEFT VAN AT REPAIR SHOP FOR MONTHS AT A TIME TO DIAGNOSE PROBLEM. FINALLY MOVED THE PCM TO THE INSIDE OF VAN SO THAT IT WON'T BE EFFECTED BY WATER. FORD HAS REFUSED TO ACKNOWLEDGE PROBLEM DESPITE A TSB BEING ISSUED. FURTHERMORE, I REPLACED THE TRANSMISSION AND A RECALL HAS BEEN ISSUED BUT FORD WILL NOT REVIEW MY RECEIPTS FOR THE TRANSMISSION UNTIL LETTERS GO OUT. TOTAL STONEWALLING BY FORD. *TR

Mileage: 97,950

9/2007 MY HUSBAND, MYSELF, AND OUR 5 CHILDREN WERE DRIVING TO MY MOTHERS HOUSE AND OUT OF THE BLUE THE VAN JUST STOPPED ACCELERATING. WE HAD THE VAN TOWED TO THE DEALERSHIP THAT WE BOUGHT IT. THEY TOLD US THAT WE NEEDED A NEW TRANSMISSION AT 41,000 MILES (JUST OUT OF WARRANTY) $2000 OOP!! WE HAD THE TRANS REPLACED AND ARE NOW 12/2011 HAVING THE SAME ISSUE AGAIN. (JUST OVER 90,00 MILES) WE OWE 2000$ ON THE VAN AND THE COST OF REPAIRS ARE OVER THAT. THIS HAS TO BE A SAFETY ISSUE..CHILDREN IN CAR + CAR RANDOMLY STOPPING!! I JUST DON'T UNDERSTAND HOW A VAN BOUGHT NEW OFF THE LOT CAN BE ON ITS 3RD TRANSMISSION ON LESS THEN 100,000 MILES. WE WILL NEVER BUY A FORD AGAIN AND AFTER DOING A LOT OF RESEARCH I HAVE FOUND 1000"S OF OWNERS WITH THE SAME ISSUES...ITS A SHAME FORD WILL CONTINUE TO ALLOW CUSTOMERS TO PAY FOR THEIR FAULTY PRODUCTS! *TR

Mileage: 41,000

DROVE TO THE STORE THAT DAY. WE HAVE BEEN HAVING A LOT OF RAIN. WHEN DONE AT THE STORE GOT IN THE VAN AND IT STARTED FINE BUT WHEN YOU PRESSED ON THE GAS PEDAL THE RPM WOULD RACE UP BUT THE VAN WOULD GO NO WHERE. THE FORD DEALERSHIP REPLACED THE PCM SENSOR BECAUSE IT HAD WATER IN IT. IT WAS RUNNING BUT NOT LIKE BEFORE. TOOK BACK THE VAN ON 4/21/11. ENGINE RUNS FINE. DRIVING DOWN THE ROAD AND VAN STARTED SPUTTERING LIKE IT WAS CHOKING. STOPPED THE VAN AND SHUT OFF THE ENGINE, TURNED IT BACK ON AND IT RAN FINE. TWO DAYS LATER HAD THE SAME PROBLEM BUT I WAS AT A STOP SIGN AND THE VAN DID NOT WANT TO MOVE FORWARD. MY HUSBAND BARELY GOT IT TO THE DEALERSHIP, IT JUST COMPLETELY DIED ON HIM ONCE. ONCE THE DEALERSHIP HAD IT THEY SAID THEY COULDN'T FIND ANYTHING. JUST HAD A SPEED SENSOR CHANGED ON IT ON 11/15/11 THEY HAD THE VAN FOR 8 DAYS TRYING TO FIGURE OUT WHAT IS WRONG. NOW JUST TONIGHT, WHEN YOU PUT THE VAN IN ANY GEAR THE RPMS DROP AND THE SHIFTING IS DELAYED. I AM GUESSING SOMETHING IS WRONG WITH TRANSMISSION. HOW CAN I EVER TRUST THE FORD COMPANY AGAIN? I HAVE BEEN READING TOO MANY OF THE SAME PROBLEMS. WE ARE GOING TO TAKE THE VAN TOMORROW TO SEE WHAT IS WRONG WITH IT AGAIN?! HELP!!! I ALSO READ I NEED TO CALL FORD FOR THEM TO HAVE SOME MANY COMPLAINTS FOR A RECALL IS THIS TRUE? *TR

Mileage: 87,943

THIS VAN HAS A BAD COMPUTER BOARD (PCM) DUE TO RAINWATER THAT IS ALLOWED TO FUNNEL UNDER THE HOOD DUE TO POOR DESIGN OF THE HOOD. IT IS ALSO POSSIBLE THAT THE TRANSMISSION IS BEING AFFECTED BY THIS AS WELL. THE VEHICLE JUST STOPPED SHIFTING INTO GEAR, FOLLOWED BY ALL SORTS OF ELECTRICAL PROBLEMS. THE MECHANIC SAID THE PCM WAS FULL OF WATER AND WOULD NEED TO BE REPLACED. THERE ARE NUMEROUS MESSAGE BOARDS ON THE INTERNET DISCUSSING THIS EXACT SAME PROBLEM WITH FORD FREESTARS RANGING FROM 2004-2007 MODEL YEARS. FORD NEEDS TO ISSUE A RECALL ON THESE VANS AS THIS CAUSES THE ENGINE TO STALL AND THIS COULD HAPPEN AT ANY TIME - IN THE MIDDLE OF A BUSY INTERSECTION, ON THE HIGHWAY, ETC. THIS COULD HAVE DEVASTATING RESULTS IF IT HAPPENS AT THE WRONG TIME. ALSO, FROM WHAT I'VE READ ON THESE MESSAGE BOARDS - THIS IS A REPEAT PROBLEM!!!! ONCE YOU FIX THIS YOU WILL HAVE THE SAME PROBLEM IN A YEAR OR TWO. NHTSA SHOULD DO SOME RESEARCH OUTSIDE OF FORMAL COMPLAINTS FILED AS I'M SURE MOST PEOPLE DO NOT KNOW THE PROPER ROUTE TO GO. A SIMPLE INTERNET SEARCH (THAT WOULD ALLOW YOU TO CONTACT OR RESPOND TO INDIVIDUAL REPORTS) WOULD DIRECT YOU TO HUNDREDS OF PEOPLE WITH THE EXACT SAME ISSUE! *TR

Mileage: 64,800

NUMEROUS PROBLEMS WITH THIS VEHICLE. TRANSMISSION WENT OUT, REPLACED IT AND STILL HAVING ORIGINAL PROBLEM. AFTER EXITING HIGHWAY AND COMING TO COMPLETE STOP, TRANSMISSION WILL WHINE OUT IN 1ST GEAR, WILL NOT SHIFT UNLESS YOU STOP ACCELERATING. ALARM SYSTEM WENT OFF AND WOULD NOT STOP, LIGHTS WOULD NOT SHUT OFF UNLESS YOU DISCONNECT THE BATTERY. CONSISTENT PROBLEMS WITH DRIVERS SIDE VENTILATION SYSTEM (HEAT BLOWING COLD, AIR BLOWING HOT). AIRBAG WARNING LIGHT ON. PASS WARRANTY, TO TIRED TO KEEP PUTTING MONEY INTO THIS VEHICLE. *TR

Mileage: 75,000

MOISTURE DAMAGE TO POWERTRAIN CONTROL MODULE (COMPUTER SYSTEM). VEHICLE WOULD NOT IDLE, TRANSMISSION WOULD NOT SHIFT, AND ERRATIC ELECTRONICS RESULTING IN MULTIPLE WARNING LIGHTS TO GO ON AND OFF. FORTUNATELY, I WAS IN A PARKING LOT, HOWEVER, THIS COULD HAVE RESULTED IN CATASTROPHIC FAILURE IF I WAS DRIVING ON AN INTERSTATE. REPAIR SHOP STATED THAT THEY HAVE SEEN THIS SAME PROBLEM. I HAVE TO HAVE A NEW COMPUTER INSTALLED AND THE VEHICLE IS ONLY 6 YEARS OLD. *KB

MY 2005 FORD FREESTAR HAS STOP DRIVING.IT STARTS BUT WHEN I SHIFT INTO GEARS THE CAR DOES NOTHING. IT WON'T DRIVE OR GO IN REVERSE. I HAD A MECHANIC LOOK AT IT AND THEY SAID WATER GOT INTO THE PCM. AND WOULD COST ABOUT $1200 TO FIX.I HAVE NOTICE MANY OTHER 2005 FORD FREESTARS WITH THE SAME PROBLEM. MANY HAVE REPAIRED THE PROBLEM OUT OF POCKET BECAUSE FORD WON'T PAY FOR THE PROBLEM.WE DIDN'T DESIGN THE VECHILE SO WHY IS IT WE HAVE TO PAY FOR THE PROBLEM.I WAS LUCKY THAT I WAS PULLING INTO MY HOUSE WHEN MY CAR CUT OFF.BUT MANY OTHER STORIES WITH THE SAME WATER ON THE PCM PROBLEM HAVE BEEN ON HIGHWAYS OR BUSY STREETS WHEN THEIR CAR DIES SO IS FORD WAITING FOR SOMEONE OR A GROUP OF PEOPLE TO DIE IN ORDER TO RECALL THIS PROBLEM AND TAKE RESPOSIBILITY AND REPAIR IT SO THE CONSUMER DON'T HAVE TO PAY WITH THIER MONEY OR THIER LIVES.I SWEAR HAD I KNOWN THAT FORD HAS IGNORED SERIOUS LIFETHREATING PROBLEM LIKE THE WATER ON THE PCM OR TRANSMISSION PROBLEM I WOULD HAVE NEVER GOTTEN A VAN FROM FORD OR ANY VEHICLE FROM THEM. FORD CLEARLY STANDS FOR FOUND ON ROAD DEAD AND SOON ITS NOT GOING TO BE JUST THE VEHICLE BUT SOMEONE LIFE AS WELL IF THEY DRIVE A FORD.AND FORD DOESN'T GIVE A CRAP. *TR

Mileage: 85,500

WATER LEAKAGE THROUGH THE LEFT WINDSHIELD WIPER COWLING CAUSED OUR POWER TRAIN CONTROL MODULE TO GO BAD. THIS REPAIR IS COSTING US ALMOST $1,000.00 DOLLARS TO FIX. UPON RESEARCHING THIS ISSUE ON THE INTERNET WE HAVE COME TO REALIZATION THAT THIS IS A VERY PROLIFIC PROBLEM WITH THIS MAKE AND MODEL OF VAN. JUST FOR THEM TO GET THE PART IS GOING TO TAKE A MONTH. THAT SHOWS YOU JUST HOW PROLIFIC IT IS. FORD IS NOT TAKING RESPONSIBILITY FOR THIS FAULTY COWLING THAT LEAKS DIRECTLY ON TO THE PCM EVEN THOUGH TENS OF THOUSANDS OR MORE PEOPLE ARE HAVING TO HAVE THIS PART REPLACED MULTIPLE TIMES COSTING THEM THOUSANDS OF DOLLARS OUT OF THEIR OWN POCKETS. THERE NEEDS TO BE A GOVERNMENT FORCED RECALL ON THESE VEHICLES CAUSE IT'S APPARENT THAT FORD IS NOT GOING TO TAKE RESPONSIBILITY FOR THEIR FAULTY EQUIPMENT DESIGN ON THEIR OWN.

FAILED COMPONENT #1: 8/9/10 - TRANSMISSION FAILED - REPLACED TRANSMISSION - $1,732.32, FAILED COMPONENT #2: 10/9/10 - REMOVE AND REPLACE ALTERNATOR - $442.00. FAILED ON ROUTE 95 SOUTH CT HEADED TO NJ, BATTERY FAILED, ALTERNATOR FAILED, POWER SURGE, POWER LOST, COASTED TO A SAFE PLACE OFF OF EXIT WHERE I WAS STRANDED WITH 2 CHILDREN LATE AT NIGHT. HAD TO GET TOWED AND FIXED, STAYED OVER NIGHT IN SEEDY PART OF CITY. FAILED COMPONENT #3: 11/1/10 - REMOVE AND REPLACE ALTERNATOR - $297.68, FAILED ON ROUTE 113 AGAIN, POWER SURGE AND POWER FAILED, ALTERNATOR DIED, LOST POWER AND MANAGED TO GET HOME A FEW MILES DOWN THE ROAD, HAD TO GET TOWED TO SHOP, NEW BATTERY FAILED AS WELL. HAD IT IN THE SHOP FOR ALMOST 2 WEEKS TOTAL.

I HAVE A 2005 FORD FREESTAR SEL, WHILE DRIVING DOWN THE ROAD THE VAN WILL STALL WITH NO WARNING. I HAVE PULLED THE VAN OVER TO THE SIDE OF THE ROAD AND PLACED THE VAN IN NEUTRAL AND RESTARTED THE VAN. WHILE THE VAN IS IN NEUTRAL THE RPM'S WILL GO UP TO AROUND 2000. WHILE PLACING THE VAN BACK IN DRIVE IT SEEMS FINE AFTER ATTEMPTING TO DRIVE THE VAN IT JERKS AND AFTER GETTING UP TO ABOUT 20 MPH THE VAN WILL STALL AGAIN. I TOOK TO THE VAN THE FORD DEALER SHIP AND THEY FOUND THAT THERE WAS WATER IN THE CONNECTION PLUG FOR THE PCM, THE DEALER SHIP CLEANED THE PLUG AND CONNECTION. THE DEALER SHIP RESEALED THE CONNECTION WITH SILCONE, THEY ALSO SEALED THE PLASTIC GUARD THAT COVERS THE PCM WITH SILCONE. SO FAR WE HAVE NOT HAD ANY PROBLEMS YET. *TR

Mileage: 71,000

I WAS DRIVING ON HWY 36, APPROXIMATELY 50MPH, WHEN MY FORD FREESTAR'S ENGINE FAILED, RESULTING IN LOSS OF ALL CONTROL. I WAS ABLE TO RESTART THE VEHICLE, BUT THE TRANSMISSION WOULD NOT ENGAGE. *TR

Mileage: 47,947

2005 FORD FREESTARS APPARENTLY ARE SUBJECT TO A LEAK THAT ALLOWS WATER TO ENTER THE ELECTIRCAL SYSTEM DURING RAINS AND CAUSE SHORTS AND TRANSMISSION FAILURE. WE HAVE EXPERIENCED THIS PROBLEM THREE TIMES - THE THIRD TIME, AFTER COMBING THROUGH SERVICE BULLETINS, OUR DEALER DISCOVERED A BULLETIN THAT PRECISELY DESCRIBED OUR PROBLEM. WHEN THE TRANSMISSION IS AFFECTED, THE CAR STALLS WHILE DRIVING, FAILS TO SHIFT GEARS (INCLUDING SHIFTS INTO REVERSE) AND OTHER TIMES, WHEN STOPPED, ALTERNATELY RACES AND SLOWS. THE SUDDEN STALLS OBVIOUSLY CAN OCCUR IN TRAFFIC WHEN A FAILURE COULD PUT DRIVERS INTO DANGER. OUR DEALER HAS REPAIRED THE PROBLEM BY SEALING THE LEAK. HOWEVER, WHILE FORD IS WELL AWARE OF THIS PROBLEM, AS INDICATED BY THE SERVICE BULLETIN, THE COMPANY WILL NOT REIMBURSE DRIVERS FOR REPAIR UNDER EXTENDED WARRANTIES, CLAIMING THAT IT IS A "BODY" AND NOT A MECHANICAL OR ELECTRICAL PROBLEM. *TR

Mileage: 66,000

VAN STALLS AT LIGHTS. JUST CUTS OFF. MECHANIC SAID IT HAS SOME THING TO DO WITH THE PCM. TRANS HAS BEEN REPLACED. BUT STILL HAVING PROBLEMS WITH THAT. REAR BRAKE CALIPERS CEASED UP . THIS VAN IS A ROAD HAZARD. NEVER KNOW WHAT IT IS GOING TO DO OR WHEN IT IS GOING TO FAIL . *TR

Mileage: 50,000

2005 FORD FREESTAR LIMITED -- VEHICLE STALLS WHILE DRIVING AND LOSES POWER STEERING AND BRAKES. VEHICLE HAS HAD ACCELERATION AND REVVING OF ENGINE WHEN IDLING IN NEUTRAL, AND ALSO SOMETIMES NO REVERSE GEAR. SOMETIMES IT JUST FAILS TO START. ALL OF THESE PROBLEMS HAVE BEEN ATTEMPTED TO BE REPAIRED BY TWO DIFFERENT FORD DEALERSHIP MAINTENANCE DEPARTMENTS AND ANOTHER LOCAL MECHANIC. ALL PROBLEMS APPEAR TO BE RELATED TO THE COMPUTER (PCM) AND/OR TRANSMISSION. THE COMPUTER (PCM) HAS BEEN REPLACED TWICE BY FORD IN THE LAST EIGHT MONTHS BUT THE PROBLEM PERSISTS. WATER KEEPS GETTING INTO THE PCM COMPARTMENT AND CAUSING HAVOC. THEY DON'T SEEM TO KNOW HOW TO STOP IT, AND THE PROBLEM KEEPS REPEATING ITSELF. LAST TIME, TWO WEEKS AGO, WE HAD TO CALL 911 WHEN WE STOPPED FOR A RED LIGHT ON A BUSY HIGHWAY. WHEN THE LIGHT TURNED GREEN, I STEPPED ON THE GAS, BUT THE VAN DID NOT GO FORWARD. CARS WERE NOW RACING PAST OUR STOPPED VAN, ON BOTH SIDES, AT HIGH SPEED. WE WERE SITTING DUCKS. WE CALLED 911 TO GET POLICE OUT TO STOP TRAFFIC FOR FEAR OF BEING REARENDED AT HIGH SPEED. MYSELF, WIFE AND THREE KIDS (10,7,2) WERE STUCK THERE. GOOD SAMARATIN RISKED HIS LIFE AND STOPPED ALL TRAFFIC BEHIND US WHILE I CARRIED KIDS OUT OF VAN TO SAFETY. OTHERS HELPED PUSH THE VAN OFF THE ROAD. VAN HAS BEEN AT DEALERSHIP SINCE THEN FOR THE LAST TWO WEEKS, BUT THEY SAY "CAN'T DUPLICATE THE PROBLEM" (WHEN THEY KNOW EXACTLY WHAT IT IS). I ASKED THEM TO OPEN COMPUTER AGAIN TO CHECK FOR WATER BUT THEY REFUSE -- SAYING IT'S TOO DIFFICULT AND IT CAN'T BE IN THERE (EVEN THOUGH IT HAS PROVEN TO BE THE PROBLEM ON NUMEROUS PREVIOUS INSTANCES). I REPORTED ISSUE TO FORD NATIONAL "CUSTOMER CARE" HOTLINE SEVERAL TIMES. I HAVE ASKED THEM TO RECALL THE VAN FOR SAFETY ISSUES AND TO HELP ME. THEY REFUSE (CITING "OUT OF WARRANTY"). THE VEHICLE HAS ABOUT 42K MILES ON IT NOW. PROBLEMS BEGAN SPRING 2009 (AT ABOUT 35K MILES) WHEN HEAVY RAINS HAPPENED ALL YEAR. MANY OTHER OWNERS WITH SAME DANGEROUS PROBLEM. *TR

Mileage: 35,000

MY FAMILY AND I PULLED INTO THE BANK TO GET SOME MONEY THEN WHEN WE WERE PULLING OUT ACROSS A FOUR LANE HIGHWAY OUR VAN ACTED LIKE IT WAS PULLED INTO NUTRUAL. I COASTED IT BACK INTO PARKING LOT. WE CALLED FORD AND THEY SAID IT WAS NOT COVERED UNDER WARRANTY BECAUSE IT HAD 50,800 MILES ON IT AND THE WARRANTY RAN OUT AT 50,000 MILES. I HAD AN INDEPENDENT MECHANIC FIX IT. ALSO IT HAS BEEN UP AT OUR LOCAL DEALER 5 TIMES SINCE 10/1/2009 BECAUSE IT WAS SHUTING OFF IN THE MIDDLE OF THE RAOD WHNE IT RAINED.THEY CHANGED THE COMPUTER AND SAID THAT WAS WHAT THE PROBLEM WAS BUT IT DID IT AGAIN. I WAS INFORMED THE NEXT TIME IT WAS THE TRANS. AGAIN. IT TURNED OUT THAT THE FIRE WALL WAS LEEKING WATER ON THE WIRING HARNES.

Mileage: 50,800

PURCHASED A 2005 FORD FREESTAR MARCH 2009. HAS SUFFERED FROM REPEATED LOSS OF MOTIVE POWER WITH THE COMPUTER OFTEN RECORDING "NO CODES" PER THE DEALER. HAS BEEN TO THE DEALER ATMULTIPLE TIMES FOR VARIOUS SUPPOSED REPAIRS INCLUDING NEW COMPUTER, ALTERNATOR, ETC., BUT THE PROBLEM CONTINUES. THE VEHICLE SHUTS OFF UNEXPECTEDLY WHILE DRIVING CAUSING A LOSS OF POWER STEERING AND BRAKE CONTROL. THIS HAS OCCURRED AT LEAST 8 TIMES IN THE LAST 12 MONTHS AND WE LEFT THE VEHICLE AT THE DEALER FROM 9/10/09 THROUGH 11/12/09 AND AGAIN FROM 11/15/09(?) THROUGH 2/5/2010 DUE TO OUR CONCERNS ABOUT THE VEHICLE'S SAFETY. ON 2/10/2010 AN ACCIDENT OCCURRED WHERE THE VEHICLE LOST POWER, THE ROAD TURNED AND THE DRIVER WAS UNABLE TO MAKE THE TURN OR BRAKE ADEQUATELY AND HENCE RAN OFF THE ROAD SUSTAINING NECK INJURIES. *TR

Mileage: 39,500

I WAS DRIVING ABOUT 60MPH AND SLOWED DOWN TO MAKE A LEFT HAND TURN. UPON COMPLETING MY LEFT HAND TURN I STARTED TO TRY TO ACCELERATE BUT THE VAN DIDN'T GO ANY WERE. I IMMEDIATELY PULLED OFF THE SIDE OF THE ROAD AND REALIZED THAT I HAD NO TRANSMISSION. I TRIED ALL THE GEARS AND COULD NOT GO ANY WERE. I HAD THE VAN TOWED TO MY HOUSE ONLY TO CALL A DEALER AND FIND OUT THAT MY TRANSMISSION WAS GOING TO HAVE TO BE REPLACED. I ASKED HOW MUCH AND FOUND OUT THAT THE TRANNY WAS MORE THEN MY VAN WAS WORTH. THE VAN SAT IN MY YARD FOR 9 MONTHS BEFORE I COULD SAVE ENOUGH TO REPLACE THE TRANNY. I HAD NO SIGNS OR SYMPTOMS THAT THE TRANSMISSION WAS GOING OUT AT ALL. I AM GLAD MY FAMILY WAS NOT IN THE VAN WITH ME. THIS SEEMS TO BE A ROUTINE PROBLEM FOR FORD. I HAVE SEEN MORE FORD TECH. BULLETINS FOR THIS MODEL VAN THEN ANY OTHER CAR OF THEIRS. HOW IS THIS VAN CONSIDERED A FAMILY VEHICLE IF IT CAN LEAVE YOU STRANDED ON THE SIDE OF THE ROAD? LOOKS AND SOUNDS LIKE DECEPTIVE ADVERTISING ON FORDS PART. *TR

Mileage: 160,000

I OWN A 2005 FORD FREESTAR MINIVAN. THIS AUGUST MY INSTRUMENT PANEL QUIT WORKING. I TOOK IT TO THE DEALERSHIP AND WAS ADVISED THAT MY ABS MODULE FAILED AND AS A RESULT IT MELTED MY WIRE HARNESS. I JUST DISCOVERED THAT FORD PREVIOUSLY HAD THIS PROBLEM WITH THEIR WINDSTARS. I'D LIKE THIS TO BE LOOKED INTO AS THIS IS A HEFTY REPAIR ($3,000.00 +) THAT I CANNOT AFFORD. AS A RESULT, I AM DRIVING IN A VEHICLE WITH NO ABS AND NO WORKING INSTRUMENT PANEL - INCLUDING SPEEDOMETER. THANK YOU. *TR

Mileage: 150,000

TL*THE CONTACT OWNS A 2005 FORD FREESTAR PURCHASED IN 2008. HE STATED THAT THE VEHICLE WOULD CONTINUE TO STALL WITHOUT WARNING. AN INDEPENDENT MECHANIC CONFIRMED THAT THE COMPUTER WAS DAMAGED. AN AUTHORIZED DEALER STATED THAT THE COMPUTER AND ENTIRE WIRING HARNESS NEEDED TO BE REPLACED SINCE THE COMPONENTS WERE WET AND THE SEAL WAS DAMAGED. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WOULD NOT TAKE ANY LIABILITY FOR THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE UNDER 51,100. UPDATED 12/9/09 *CN THE DEALER REPLAED THE WIRING HARNESS AND COMPUTER AS THE TERMNAL ENDS OF THE HARNESS WERE CORRODED. THE COMPUTER WAS DAMAGED FROM WATER. THE DEAERL STATED THE UPPER SEAL FAILED ON BOTH SIDES WHICH ALLOWED WATER TO SEEP IN FROMT HE TOP COVER. UPDATED 12/10/09

Mileage: 51,100

TWICE OUR 2005 FORD FREESTAR EXPERIENCED WATER LEAKAGE THROUGH THE COWL GRILL ON THE HOOD. AFTER HEAVY RAIN IN MARCH 2008, THE FIRST OF SEVERAL BREAKDOWNS AND FIX ATTEMPTS OCCURRED, RESULTING IN 3 MONTHS OUT OF SERVICE, AND REPLACEMENTS OF THE WIRING HARNESS, THE PCM COMPUTER, SEVERAL OTHER COMPUTERS AND SENSORS, AND THE ENTIRE TRANSMISSION, EQUALING NEARLY $5,000 IN TOW, RENTAL CAR, AND REPAIR BILLS--SOME OF WHICH THE DEALERSHIP TALKED MY INSURANCE TO PAY FOR AS A "WATER DAMAGE CLAIM." IN BETWEEN, WE'VE HAD MULTIPLE ELECTRICAL SYSTEM PROBLEMS AND BREAKDOWNS, AND THEN THIS PAST MARCH 2009, ALSO DURING HEAVY RAIN, THE CAR EXPERIENCED THE WATER DAMAGE BREAKDOWN. THIS TIME THE WATER ONLY RUINED THE PCM COMPUTER, BUT THE DEALERSHIP REFUSED TO HONOR THE REPAIRS THAT WERE LESS THAN 12 MONTHS OLD AND WE TOOK IT TO A PRIVATE LICENSED REPAIR TECHNICIAN. HE FOUND THE TECHNICAL SERVICE BULLETIN ONLINE THAT DESCRIBED THE KNOWN WATER LEAKAGE PROBLEM IN SOME 2005 FREESTAR MODELS AND DID THE RECOMMENDED FIX TWICE. IN HIS OPINION AND IN THE GEICO INSURANCE ADJUSTERS OPINION, THIS IS A SERIOUS PROBLEM THAT FORD NEEDS TO ADDRESS. THIS TIME WE HAD NO COVERAGE FOR THE DAMAGE AND WERE OUT OF A VEHICLE FOR TWO MONTHS AND OUT OF POCKET OVER $3,000. I'VE BEGGED FORD'S CORPORATE OFFICES TO TAKE THE VEHICLE BACK AND JUST LET ME OUT OF THE FINANCING BUT THEY REFUSE DUE TO THE NUMBER OF MILES. ALSO, THE ATTORNEY GENERAL'S LEMON LAW OFFICE SAID THERE WERE TOO MANY MILES. IN ADDITION TO THESE PROBLEMS, IN 90,000 MILES, I'VE HAD TO REPLACE THE ROTORS NOW FOUR TIMES BECAUSE THEY ARE WARPING DANGEROUSLY. THE PADS ARE OK, BUT THE ROTORS ARE CONTINUALLY WARPING AND IT COSTS $800 EACH TIME TO HAVE THE BRAKES FIXED. *TR

Mileage: 66,000

TL*THE CONTACT OWNS A 2005 FORD FREESTAR. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE DOES NOT GO INTO GEAR AND THE RPM'S GO UP AND DOWN. WHEN DRIVING MORE THAN 15 MPH, THE VEHICLE BEGINS TO JERK. WHEN DRIVING MORE THAN 20 MPH, THE INTERIOR LIGHTING ILLUMINATES AND THE VEHICLE STALLS. THE VEHICLE WAS TOWED TO AN AUTO BODY SHOP, BUT THEY COULD NOT LOCATE THE CAUSE OF THE FAILURE AFTER APPROXIMATELY FOUR DIAGNOSTIC TESTS. CURRENTLY, THE VEHICLE IS STILL AT THE REPAIR SHOP. THE FIRST THREE REPAIRS WERE AT THE CONTACT'S EXPENSE, BUT THE FAILURE STILL PERSISTS. THE FAILURE MILEAGE WAS 20,710 AND CURRENT MILEAGE WAS 20,986. UPDATED 05/05/09 *BF UPDATED 05/06/09*JB

Mileage: 20,710

WHEN ACCELERATING AT ABOUT 1800-2000 RPM, THE TACHOMETER MAKES A NOISE SINCE DAY ONE. *NM