2006 FORD FREESTAR Electrical System Problems

The alternator caught on fire and burned alternator wring harness.

The contact owns a 2006 Ford Freestar. The contact stated while driving at an undisclosed speed, the speedometer failed to function as intended. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

Mileage: 100,000

LIFTGAIT WON'T OPEN REPLACED IT AND STILL WON'T OPEN

Mileage: 11,200

BEFORE IT BROKE DOWN COMPLETELY THE VAN WAS DRIVING FUNNY, LIKE IF IT DIDN'T HAVE ENOUGH STRENGTH ESPECIALLY WHEN I WAS DRIVING HILL BUT ONE NIGHT I WAS DRIVING THE VAN AND SUDDENLY JUST SHUT OFF IN THE MIDDLE OFF THE HIGHWAY. THANKS GOD I DIDN'T HAVE MANY CARS BEHIND ME AND I MANAGE TO AVOID GETTING HIT BY HOLDING MY PHONE OUT THE WINDOW SO TO BE SEEN UNTIL I WAS ABLE TO "DRIVE" TO A SECTION OF ROAD WITH STREET LIGHTS. THE NEXT DAY I HAD IT TOWED TO MY MECHANIC BECAUSE IT WOULD NOT START ANYMORE. THE MECHANIC TOLD ME THERE WAS A LOT OF COMPLAINTS FOR THIS PROBLEM.SO I DON'T KNOW WHAT ARE THEY WAITING FOR TO MAKE THIS AN OFFICIAL RECALL. I FEEL VERY LUCKY MY CHILDREN AND WIFE WERE NOT IN THE VEHICLE DURING THESE PAST INCIDENCES. I WOULD LIKE A RESPONSE FROM YOU ON THIS RECALL MATTER A.S.A.P. THANK YOU.

Mileage: 96,000

WHERE TO START.... EVERY TIME ITS RAINING MY VAN STARTS TO PUTT AND STALL OUT I HAVE ALMOST HAD 3 ACCIDENTS DUE TO MY VAN STALLING ON A MAIN ROAD TRYING TO GET HOME...ISSUE #2. I USE MY KEY PAD TO UNLOCK MY VEHICLE ON NIGHTS THAT IM WORKING AND LATELY IT WILL UNLOCK THEN RE LOCK N UNLOCK OVER AND OVER WITH OUT BEING TOUCHED. I WAS DRIVING DOWN A ROAD AND IT WOULD UNLOCK AND LOCK.. ITS NOT SAFE IF ITS UNLOCKING ITS SELF AND MY 2 YEAR OLD REACHS HE COULD OPEN THE DOOR WHILE DRIVING... ISSUE #3.. MY VAN SAYS I HAVE 1/2 A TANK OF GAS YET MY DIGITAL GAS READER CONTINUES TO SAY 0 MILES..

Mileage: 111,000

I HAVE PROBLEMS WITH TRANSMISSION WHEN SHIFT, SOME TIMES IS REALLY HARD SHIFTING AND ALSO I HAVE PROBLEM WITH BATTERY LIGHT IN THE CLUSTER IS ALWAYS ON BUT THE CHARGING SYSTEM WORKS NORMALLY, THIS HAPPEN ALL THE TIMES

TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO RESPOND. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. UPDATED 05/03/17*LJ *CN

MY RADIO GOES OFF BY ITSELF, AND ALL LIGHT FLICKER EVEN WHEN DRIVING OF A NIGHT. IT IS NOW MAKING A SOUND LIKE TIGHT BELTS...BUT DOES NOT APPEAR TO HAVE ANY READY TO BREAK. FORD YOU REALLY MESSED UP ON THIS ONE! I NO LONGER LIKE HAVING A FORD CAR! I HAVE HAD 3 DIFFERENT ALTERNATORS ON THE CAR AND IT HAS NOT HELPED! *TR

Mileage: 220,000

I WAS DRIVING DOWN THE ROAD AT 45 MILES AN HOUR AND VEHICLE CUTS OFF. I ALMOST HAD A HEAD ON COLLISION WITH NO CONTROL OF STEERING. IF I HAD BEEN ON INTERSTATE IT WOULD HAVE BEEN A WRECK.

Mileage: 175,000

I HAVE A BATTERY LIGHT THAT KEEPS COMING ON EVEN AFTER REPLACING THE ALTERNATOR TWICE AND BATTERY TWICE. THE LIGHT STILL KEEPS COMING ON AND WILL NOT GO OFF.THERE I AM DRIVING DOWN THE ROAD AND EVERYTHING IS FLASHING AND THEN IT STALLS. I HAVE HAD BOTH BATTERY AND ALTERNATOR CHECKED AND THEY ARE FINE. WIRING HAS BEEN CHECKED AND NOTHING SEEMS TO WORK. ALSO I HAVE REPLACED THE BREAKS ON THE CAR TWICE AND I STILL GET A LOUD GRINDING NOISE WHEN I GO TO STOP. FORD NEEDS TO FIX THESE VEHICLES. I HAVE READ IN MANY FORUMS THAT PEOPLE ARE HAVING THE SAME PROBLEMS WITH THEIRS AND AFTER SPENDING A BUNCH OF MONEY TRYING TO FIX THE PROBLEM IT STILL IS NOT FIXED. I NEED MY VEHICLE TO RUN RIGHT WITHOUT HAVING TO DUMP MONEY INTO IT ALL THE TIME AND I KEEP UP WITH REGULAR MAINTENANCE BUT THIS IS ABOVE AND BEYOND THAT AND THIS IS RIDICULOUS! *TR

I HAVE MY 2 GRANDCHILDREN WHO HAVE MUSCULAR DYSTROPHY. I BOUGHT THIS VAN TO GET THEM TO DOCTORS APPOINTMENTS, ETC WITH WHEEL CHAIR. I WAS DRIVING THE VEHICLE HOME AND STOPPED AT THE LIGHT. AS SOON AS THE LIGHT TURNED GREEN I PROCEEDED THOUGH THE INTERSECTION AND THE VEHICLE JUST STOPPED. THE VEHICLE JUST WOULD NOT MOVE. I HAD CHILDREN IN THIS VAN AND WAS ALMOST HIT BECAUSE OF THE TRANSMISSION IN THIS VEHICLE. WHY WOULD FORD NOT STEP UP AND DO A RECALL ON THESE VEHICLES. WHEN WILL SOMEONE TAKE NOTICE THAT THIS COULD HAVE EASILY CAUSED A ACCIDENT, HURTING INNOCENT CHILDREN. THESE VANS ARE MOSTLY USED AS A FAMILY VAN. DOES SOMEONE HAVE TO GET HURT FOR SOMEONE TO DO SOMETHING? THE VAN IS NOT FIXED YET AND I AM STILL MAKING PAYMENTS. I CAN NOT AFFORD TO FIX IT. *TR

Mileage: 80,000

GOING DOWN A SMALL HILL AND WAS PICKING UP SPEED, LET OFF THE GAS PEDAL TO SLOW DOWN. STARTING UP THE NEXT HILL AND WHEN THE GAS PEDAL WAS PUSHED I ENDED UP GOING BACKWARD AND THERE WERE 4 VEHICLES RIGHT BEHIND ME. THEY ALL WERE STOPPING AND EACH TURNED IN A DIFFERENT DIRECTION NOT TO HIT THE OTHER PERSON IN FRONT OF THEM. IT COULD HAVE BEEN WORSE IF I HAD TAKEN THE INTERSTATE. THIS HAPPENED AT ABOUT 6 A.M. SO THERE WAS NOT A LOT OF TRAFFIC LIKE THERE IS AT 7 A.M. IN THE MORNING. BUT IF I HAD NOT FORGOTTEN MY BILLFOLD, THIS WOULD HAPPENED AT A VERY HIGH TRAFFIC TIME OF DAY WHEN I WOULD HAVE BEEN GOING HOME. *TR

Mileage: 169,046

WATER INTRUSION FROM THE COWL SHORTED OUT THE PCM AND LED TO PREMATURE FAILURE OF TORQUE CONVERTER. FORD HAD A TSB ON THE WATER ISSUE BUT NEVER RECALLED AND NOW THAT HAS LED ME TO HAVING BIG MONEY SPENT ON REPAIRS THAT I FEEL FORD SHOULD CORRECT AND PAY FOR! *TR

Mileage: 70,000

ENGINE IDLE RPM SURGE . *TR

Mileage: 97,758

I WAS DRIVING DOWN THE ROAD IN THE RAIN AND THE ENGINE LIGHT CAME ON. THEN THE VEHICLE STARTED TO SPUTTER AND ACTED LIKE IT WAS GOING TO STALL OUT. IT FELT LIKE I WAS GOING TO LOSE POWER BUT I WAS ABLE TO MAKE IT HOME. THEN THE NEXT DAY THE SUN WAS OUT AND THE CAR SEEMED TO RUN FINE. THIS HAPPENED TO ME SEVERAL MORE TIMES OVER THE NEXT FEW MONTHS. I STARTED TO NOTICE A PATTERN OF IT ONLY HAPPENING WHEN IT WAS RAINING OUTSIDE. OTHERWISE, THE VEHICLE RAN FINE IN GOOD WEATHER. I REALIZED WATER WAS GETTING INTO THE ENGINE SOMEHOW. OUR MECHANIC THOUGHT IT WAS A PROBLEM WITH THE SPARK PLUGS AT FIRST. THEN IT KEPT HAPPENING SO WE HAD IT IN THE SHOP AGAIN. WATER WAS FOUND TO BE LEAKING INTO THE POWERTRAIN CONTROL MODULE. I STARTED TO RESEARCH THE PROBLEM ON THE INTERNET AND FOUND SEVERAL CUSTOMERS COMPLAINING ABOUT THE SAME PROBLEM WITH THEIR VEHICLES. APPARENTLY IT IS A WELL KNOWN DEFECT IN THE MANUFACTURING OF THIS VEHICLE. I FEEL FORD SHOULD TAKE ACTION AND RECALL THESE CARS BEFORE SOMEONE GETS TRAGICALLY INJURED FROM THEIR MINIVAN LOSING POWER ON A BUSY HIGHWAY. *TR

Mileage: 100,000

12/10/13 AND 12/11/13 MINI VAN STALLED ON THE ROAD WHILE DRIVING 25 MILES PER HOUR. NO WARNING LIGHT BEFORE HAND. LOSS OF POWER STEERING AND ENGINE. WAS TOLD THAT IT WAS AN AIR FLOW CONTROL. DROVE CAR HOME FROM DEALERSHIP AND STALLED ON THE ROAD HOME. PCM WAS REPLACED. 1/20/14 NEXT TWO TIMES CAR FAILED TO START WHILE IN A PARKING LOT OR DRIVEWAY. (WAS REPAIRED) PCM WAS REPLACED AGAIN. 2/6/14 FOURTH STALL WAS ON AN EXIT RAMP OF A MAJOR HIGHWAY. CAR WAS GOING 45 MILES PER HOUR AND STALLED. LOSS OF POWER STEERING AND ENGINE. *TR

Mileage: 72,843

WHEN I WAS DRIVING A HILL DOWN, SUDDENLY THE ENGINE AND ALL ELECTRONIC EQUIPMENT STOPPED, WARNING LAMP ENGINE AND BATTERY FLASHES, STEERING WHEEL AND BRAKES DID NOT WORK CORRECTLY. I NEED ABOUT 1 MILE TO STOP THE CAR. AFTER THAT THE CAR COULD NOT BE REACTIVATED/STARTED AGAIN. - CAUSE FOR INCIDENT (FORD SERVICE): THE MOTOR CONTROL UNIT WAS FILLED WITH WATER AFTER A RAIN. *TR

Mileage: 81,417

AFTER HEAVY RAIN THE VAN BEGAN TO MISFIRE AND SHAKE. CHECK ENGINE LIGHT CAME ON. 2 DAYS LATER IT WENT OUT AFTER DRYING OFF. *TR

Mileage: 32,000

TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT STATED THAT UPON ENTERING THE VEHICLE, IT APPEARED THAT THE AUDIO SYSTEM HAD BEEN RESET. THE CONTACT ALSO STATED THAT THE REVERSE INDICATORS FAILED AND THE PASSENGER SIDE AIR BAG LIGHT ILLUMINATED. THE CONTACT ALSO MENTIONED THAT AFTER OPENING THE LIFT GATE, THE VEHICLE WOULD NOT START IMMEDIATELY AND THE BRAKE LIGHT ILLUMINATED ERRONEOUSLY. THE CONTACT TOOK THE VEHICLE TO A DEALER AND WAS INFORMED THAT IT WAS PROBABLY AN ELECTRICAL PROBLEM. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 91,000.

Mileage: 91,000

I WAS DRIVING MY VAN HOME FROM THE GROCERY STORE. ALL OF A SUDDEN THE SPEEDOMETER SAID I WAS TRAVELING AT OVER 100 MILES AN HOUR AND BEGAN TO VIBRATE. I PULLED OVER, TURNED THE CAR OFF AND RESTARTED IT. IT SEEMED TO BE OKAY AT FIRST. THEN WHEN I TRIED TO GET IT UP TO SPEED IT WOULD ONLY MOVE DOWN THE ROAD AT A CRAWL. SAME PROBLEM AS THE 2004-2005 MODELS. *TR

Mileage: 70,000

WHILE DRIVING IN HEAVY TRAFFIC DURING A SNOW STORM WITH MY 9 YEAR OLD DAUGHTER ON THE FREEWAY MY 2006 FORD FREESTAR STARTED JERKING AND TRYING TO STALL OUT WHEN TRYING TO GET OFF THE FREEWAY TO SAFETY SPEEDOMETER WAS SHOWING I WAS DRIVING 120 AT A STOP LIGHT. THE RPM'S WERE AT A 3 WHILE SITTING STILL. IF THE VAN HAD STALLED ON THE FREEWAY THE INCIDENT WOULD HAVE BEEN HORRIFIC. THEN A SECOND INCIDENT HAPPEN ON MARCH 28, 2013 WHEN I WAS PREPARING PULL ONTO A SIDE STREET MY VAN STARTED JERKING AND STALLING OUT ON ME AND THE SPEEDOMETER SHOWED I GOING A 120 WHILE SITTING STILL AT A STOP SIGN. *TR

Mileage: 94,000

TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE INSTRUMENT PANEL FAILED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE LIGHT BEHIND THE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 115,000.

Mileage: 115,000

AIR CONDITIONER, RIGHT SIDE PASSENGER DOOR WINDOW, MOTER MOUNTS. *TR

VAN SHUT OFF WHILE DRIVING AND WOULD NOT RESTART IT HAD NO ELECTRICAL POWER, TURNED OUT COMPUTER SHORTED OUT $1200.00 REPAIR. *TR

Mileage: 98,000

THE VAN HAS BEEN HARD TO START JUST RECENTLY PAST MONTH IT TAKES 4 TURNS OF KEY TO START , VAN DIES WHILE DRIVING, BATTERY HAS DIED . TOOK TO FORD DEALERSHIP AND THEY CANT FIND ANYTHING WRONG AT ALL . THEY HAD ME REPLACE , FUEL PUMP / SPARK PLUGS AND WIRES / FUEL FILTER/ IGNITION COIL / TPS SENSOR / AIR INTAKE IDLE SENSOR / CLEANED AND REPROGRAMMED THE PCM / MADE NEW IGNITION KEY / CLEANED ALL GROUND CONNECTIONS / CHECKED ALTERNATOR / REPLACED BATTERY / DRAINED GAS TANK AND ADDED FUEL CLEANER / AFTER ALL OF THIS EXPENSE I STILL AM HAVING THE EXACT SAME ISSUES ?????? ANY ADVICE FROM ANYONE ??/ THANKS IN ADVANCE . *TR

Mileage: 87,000

DRIVING DOWN ROAD CITY STREET (25 MPH SPEED LIMIT) ON WAY HOME. NOT RAINING OUTSIDE. TEMPERATURE WAS ABOUT 85 DEGREES. VERY HIGH HUMIDITY. AS APPROACHED INTERSECTION THE VEHICLE SUDDENLY SHUT ITSELF OFF. COMPLETE LOSS OF POWER, POWER STEERING, AND POWER BREAKING. WIFE HAD TROUBLE PULLING OVER, BUT BECAUSE WERE ONLY GOING 20 MPH AT THAT POINT, WE MANAGED TO PULL OVER AND STOP CAR. WE WERE ONLY 2 BLOCKS FROM HOME, SO WE RESTARTED ENGINE (WHICH TURNED ON WITHOUT TROUBLE) AND DROVE HOME SLOWLY (NOW WITH THE CHECK-ENGINE LIGHT ON). DANGEROUS SITUATION, AS IT IS INCREDIBLY DIFFICULT TO CONTROL THE VEHICLE WITHOUT POWER STEERING OR BRAKING. IF WE HAD TAKEN THE INTERSTATE HOME INSTEAD OF THE WAY WE WENT, WE COULD HAVE BEEN DRIVING AT 70 MPH ONTO AN OFF RAMP WHEN IT SHUT OFF. VERY DANGEROUS INDEED. *TR

Mileage: 61,000

THE FIRST FAILURE WAS WHEN I WAS DRIVING DOWN THE ROAD DOING JUST OVER 55 MPH, ALL OF A SUDDEN THE VAN DIED AN I COASTED TO THE SIDE OF THE ROAD. AFTER SEVERAL FAILED ATTEMPTS TO RESTART THE VAN IT FINALLY STARTED AND STAYED RUNNING. I EVENTUALLY MADE IT HOME WITHOUT INCIDENT. HAD IT CHECKED AND WAS TOLD IT POSSIBLY HAD AN ELECTRICAL FAILURE BUT CHANGE THE FUEL FILTER IN CASE IT WAS AN ISSUE WITH FUEL GETTING TO THE ENGINE. SO WE DID. IT RAN FINE AFTER THAT UNTIL ABOUT 3 MONTHS LATER. WE TOOK IT TO RUN ERRANDS WITH NO PROBLEM AND RETURNED HOME. WENT TO RUN TO THE GROCERY STORE AND THE VAN WOULD NOT GO INTO GEAR. IT WOULD START OK BUT NOT MOVE, WOULDN'T GO INTO DRIVE OR REVERSE. THANKFULLY IT WAS AT HOME WHEN IT HAPPENED AND NOT GOING DOWN THE ROAD LIKE THE FIRST TIME WHEN I HAD ALL 3 KIDS WITH ME. HAD IT TOWED TO A GARAGE WHERE THEY FOUND METAL SHAVINGS IN THE TORQUE CONVERTER. HAD A NEW ONE PUT IN AND IT RAN FINE FOR ABOUT 2 WEEKS. THEN WE FOUND CRACKS IN THE COIL PACKS AND HD THOSE REPLACED ALONG WITH ALL SPARK PLUGS. NOT SURE IF THAT IS RELEVANT TO THE TORQUE PROBLEM. SPENT $940.00 TO FIX THE TORQUE CONVERTER AND ANOTHER $240.00 TO FIX COIL PACKS AND SPARK PLUGS. THE TORQUE CONVERTER IS A RECALL ON THE '04 AND '05 AND THE SAME NEEDS TO BE DONE WITH THE '06'S. *TR

Mileage: 128,000

TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT STATED THAT ALL OF THE WARNING LAMPS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT MENTIONED THAT THE EXTERIOR AND INTERIOR LAMPS WERE FLICKERING. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT ECM WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE REMEDY FAILED TO REPAIR THE FAILURE. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO DIAGNOSED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND CURRENT MILEAGE WAS 140,000. UPDATED 5/7/12 *CN UPDATED 05/30/12

Mileage: 120,000

TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT STATED THAT ALL OF THE WARNING LAMPS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT MENTIONED THAT THE EXTERIOR AND INTERIOR LAMPS WERE FLICKERING. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT ECM WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE REMEDY FAILED TO REPAIR THE FAILURE. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO DIAGNOSED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND CURRENT MILEAGE WAS 140,000. UPDATED 5/7/12 *CN UPDATED 05/30/12

Mileage: 120,000

EVERY TIME IT RAINED, MY ENGINE WOULD SHUDDER, SHAKE, SOMETIMES KNOCK, THE TRANSMISSION WOULD SHIFT FOR NO GOOD REASON, AND I STALLED OUT IN TRAFFIC ONCE. THE VEHICLE BECAME NON-DRIVABLE WHEN IT RAINED (AND ONLY WHEN IT RAINED). I TOOK THE VEHICLE TO MY FORD DEALER (SCHULTS FORD OF HARMARVILLE, PA), WHERE TECHNICIAN PAT SAND INDICATED THAT THIS IS A KNOWN PROBLEM WITH FORD FREESTARS, AND SAID A FORD SERVICE BULLETIN INDICATES THAT BECAUSE OF A MANUFACTURING PROBLEM (INCORRECT SEALER APPLICATION TO THE PCM AND POOR POSITION OF PCM IN RELATION TO WINDSHIELD RUN-OFF) WATER LEAKAGE INTO THE PROGRAM CONTROL MODULE CAUSES IT TO ISSUE RANDOM COMMANDS AND ERRORS. THEY FOLLOWED THE FORD BULLETIN AND BY SIMPLY BETTER SEALING AGAINST MOISTURE / BLOCKING THE WATER FLOW, RESOLVED THE PROBLEM. THIS IS A SAFETY ISSUE AND A KNOWN MANUFACTURING DEFECT. *TR

Mileage: 67,600

VEHICLE ODOMETER FAILURE. *TR

Mileage: 94,000

VECHICLE JUST STOPPED. GOT IT GOING AGAIN AFTER TURNING OFF AND RESTARTING. CODE SHOWED IT NEEDED TO BE "REFLASHED." COST 110 AT DEALERSHIP AND NO IMPROVEMENT. CODE SHOWED IGNITION COIL. REPLACED AND NO IMPROVEMENT. FINALLY REPLACED PCM APRIL 2011. ALSO EXPERIENCE INTERMITENT ELECTRICAL PROBLEMS (RADIO, CLOCK RESET) WITH NO BATTERY FAILURE. *TT

Mileage: 90,000

I AM EXPERIENCING PROBLEMS WITH MY 2006 FORD FREESTAR WHEN IT BECOMES WET. IF I GO THROUGH A CAR WASH OR DRIVE IN INCLEMENT WEATHER THE ENGINE LIGHT STARTS FLASHING AND THE ENGINE POWER STARTS BECOMING ERRATIC, BUCKING AND HESITATING. WHEN THIS FIRST STARTED HAPPENING I WOULD HAVE TO LET THE VAN SIT FOR A FEW HOURS AND THEN IT WOULD RUN FINE. THE LAST FEW TIMES IT HAS HAPPENED IT IS TAKING DAYS FOR THE MOTOR TO GET BACK TO NORMAL. I HAVE HAD IT AT A SHOP, THEY GAVE IT A TUNE UP. THE PROBLEM RECURRED AND TOOK IT TO A FORD CERTIFIED DEALERSHIP AND THEY RAN DIAGNOSTICS, CHARGED ME $100 AND TOLD ME I NEEDED A TUNE UP WHICH I JUST HAD DONE. TOOK IT BACK TO THE SHOP THAT DID THE TUNE UP AND THEY REPLACED THE EGR VALVES TO THE TUNE OF $700. RAN THE CAR THROUGH THE CAR WASH AND PROBLEM RECURS, THEY HAVE NOW REMOVED THE PCM MODULE LOOKING FOR MOISTURE WHICH THEY DID NOT FIND, ANOTHER $100. $900 LATER I AM STILL STRUGGLING WITH THE SAME PROBLEM AND NOBODY HAS ANY ANSWERS. UPON READING MANY COMPLAINTS ABOUT THIS SAME ISSUE ON THE WEB I AM NOW REPORTING IT TO YOU. FORD NEEDS TO RECALL THIS AND MAKE IT RIGHT. IT'S EXTREMELY DANGEROUS TO BE DRIVING IN INCLEMENT WEATHER AND START LOSING POWER TO YOUR CAR! WE ARE NOW HEADING IN TO THE WET WINTER MONTHS AND I'M SCARED TO DEATH TO DRIVE MY VAN. *TR

Mileage: 155,000

TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT STATED THAT WATER PENETRATED THE HOOD, CAUSING THE TRANSMISSION AND THE ELECTRICAL SYSTEM TO FAIL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT WATER DAMAGED THE TRANSMISSION, INSTRUMENTAL CLUSTER, AND SMART MODULE. THE DEALER REPLACED THE TRANSMISSION. THE INSTRUMENTAL CLUSTER AND SMART MODULE WERE NOT REPLACED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS REPLACED 105,000. THE VIN WAS UNAVAILABLE.

Mileage: 100,000

TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT STATED THAT WHILE ACCELERATING FROM A TRAFFIC STOP, THE VEHICLE STALLED WITHOUT WARNING. AFTER SEVERAL MOMENTS, THE CONTACT WAS ABLE TO RESTART THE VEHICLE YET THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED AS MOISTURE BEING IN THE COMPUTER SYSTEM. THE MANUFACTURER WAS NOT CONTACTED IN REGARDS TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 171,000.

Mileage: 171,000

REAR TURN LAMPS HAVE BURNED OUT 4 TIMES IN THREE YEARS. AT IDLE "ALL" INTERIOR AND HEAD LAMPS FLICKER. I HAVE REPLACED THE BATTERY AND HAD THE ELECTRICAL CHARGING SYSTEM CHECKED AND THEY ARE OK. APPEARS TO BE A WIRING PROBLEM. HEAT AC BLOWER ONLY BLOWS AIR FROM LOWER HEATER VENTS . PCM REPLACED, AND IT HAS MALFUNCTIONED AGAIN. VEHICLE APPEARS TO HAVE A SERIOUS WIRING PROBLEM. *TR

Mileage: 18,000

HAVE OWNED THIS 2006 FREESTAR SINCE NEW. SEVERAL ELECTRICAL ISSUES. STEREO SYSTEM - INTERMITTENT PROBLEMS WITH THE PRESETS RESETTING AND THE CLOCK SETTING BACK TO 12:00. ALSO THE VOLUME FLUCTUATING UP AND DOWN ON ITS OWN WHEN USING THE REAR CONTROLS. THE STEREO HAS BEEN REPLACED TWICE. STILL HAVING THE PROBLEM. REAR DRIVER SIDE TURN SIGNAL LAMP - HAS BURNED OUT AND BEEN REPLACED 7 TIMES. OUTSIDE TEMPERATURE PROBE - IS NOT READING PROPERLY. STARTER - HAVE INTERMITTENT PROBLEMS STARTING THE VEHICLE. HAVE NOT RECEIVED ANY RESOLUTION FROM SEVERAL DEALERS. THE PCM WAS NOT FOUND TO BE WET OR DAMAGED. ARE CONCERNED THAT THE VEHICLE HAS MAJOR WIRING ISSUES AND IS A POSSIBLE FIRE HAZARD. ALSO, THE REAR AC BLOWER SQUEALS INTERMITTENTLY AND HAS BEEN REPLACED TWICE AS WELL. STILL DOING IT. THERE IS A MUFFLED THUMP SOUND COMING FROM THE AIR CLEANER BOX AREA. THE LAST DEALER WHO LOOKED AT THE VEHICLE STATED THAT THIS IS NORMAL. WE DON'T AGREE. SEVERAL, UNRESOLVED, REPETITIVE ISSUES WITH THIS VEHICLE. VERY DISAPPOINTED WITH FORD AND WILL NOT PURCHASE ANOTHER. *TR

Mileage: 26,000

I HAVE A 2006 FORD FREESTAR THAT HAS BEEN NOTHING BUT PROBLEMS. TWICE I LOST POWER COMPLETELY WHILE DRIVING. THE FIRST TIME IT WOULDN'T START SO I HAD IT TOWED TO THE FORD DEALERSHIP. THEY SAID IT STARTED RIGHT BACK UP AND IT WAS FINE NOW. THIS WAS IN NOVEMBER OF 2008. IN JANUARY 2009 IT DIED ON ME AGAIN. I WAITED A FEW MINUTES AND IT STARTED BACK UP. I TOOK IT TO A DIFFERENT DEALER THE SECOND TIME. THEY SAID THERE WAS WATER IN MY POWER CONTROL MODULE (PCM) AND REPLACED IT. I HAVE NOT LOST POWER SINCE THEN. I AM NOW HAVING SOME PROBLEMS STARTING THE VAN. THE VAN HAS BEEN IN THE REPAIR SHOP A MINIMUM OF 30 TIMES IN 2 1/2 YEARS BUT IT IS NEVER THE SAME PROBLEM SO THE LEMON LAW DOES NOT APPLY IN MY STATE. *TR

Mileage: 21,497

ODOMETER FRAUD. *AK

I WAS DRIVING MY FORD FREESTAR IN A RAIN STORM AND THE VAN COMPLETELY SHUT DOWN. TURNS OUT THE MAIN COMPUTER CHIP GOT WET. I HAVE HAD THIS VAN FOR 2 WEEKS. *JB

Mileage: 538

DT*: THE CONTACT STATED WHILE DRIVING 55 MPH THE TRACTION CONTROL LIGHT ILLUMINATED. THE VEHICLE RPM REVVED FROM 0 TO 2 AND THE VEHICLE BUCKED. THE VEHICLE WAS DRIVEN TO A SERVICE DEALER; UPON INSPECTION BOTH REAR AND FRONT BRAKE SYSTEMS HAD FAILED CAUSING THE TRACTION CONTROL TO AUTOMATICALLY USE THE BRAKES. THE DEALER REPLACED THE COMPUTER SYSTEM HOWEVER 48 HOURS LATER THE VEHICLE IS HAVING THE SAME PROBLEM AGAIN. UPDATED 5/10/2006 - *NM

Mileage: 1,032