2010 FORD FUSION HYBRID Vehicle Speed Control Problems

CAR WARNING LIGHT PLEASE PULL OVER SAFELY AND THEN CAR LOOSES ALL POWER HAS HAPPED A TOTAL OF 19 TIMES IN 4 MONTHS. STOPPED ME IN MIDDLE IF INTERSECTION TODAY. TWICE. HAPPENS WHEN DRIVING OR STARTING TO DRIVE FROM STILL POSITION.

Mileage: 150,000

DRIVING ON CITY STREET, SPEED LIMIT 45, UNABLE TO NORMALLY ACCELERATE - DID SO EXTREMELY SLOWLY - NOTICED WRENCH INDICATOR LIGHT AND STOP SAFELY WARNING LIGHT BOTH ON. CAR WOULD ONLY ACCELERATE TO 40MPH DESPITE PRESSING GAS PEDAL DOWN COMPLETELY. COULD NOT DRIVE TO WORK AS IT REQUIRED HIGHWAY DRIVING UP TO 60 MPH AND COULDN'T RISK DANGER OF SLOW OR STALLING VEHICLE. RESEARCH INDICATES THIS IS WELL KNOWN TO FORD (FAULTY THROTTLE BODY) AND WAS PARTIALLY ACCOMMODATED WITH EXTENDED WARRANTY (13N03) BUT OTHERWISE ELIGIBLE HYBRID VEHICLES NOT COVERED BY THAT PROGRAM. DANGEROUS ISSUE + KNOWN TO MANUFACTURER = EVENTUAL LAWSUIT.

Mileage: 123,000

WELL IT STARTED EARLY THIS YEAR. WHEN DRIVING THE CAR SOME TIME LOSE SPEED. IT SLOW DOW TO IT FEEL LIKE CAR NOT ON. THEN IT HAPPENS SOMETIMES ON HIGHWAY BE DRIVING THEN IT JUST START LOSING ACCELERATION. I HAVE TURN CAR ON AND OFF FOR FEE TIME THEN IT SEEM GO FOR FEE. THEN LOSE POWER. NOW MY CAR WAS SITTING IDLE FOR WHILE NOW IT WON'T ACCELERATE AT ALL FEW PEOPLE SAID IT IN SAFE MODE NO ACCELERATION AT ALL TURN CAR. ON AND NO SPEED WHEN PUSHING PALLAL DOWN

Mileage: 223,700

OUT OF NO WHERE MY POWER STEERING LIGHT CAME ON AND IT IS VERY HARD TO TURN.

Mileage: 56,000

THROTTLE BODY MALFUNCTIONS CAUSING LOSS OF ACCELERATION WHEN DRIVING. FORD ISSUED AN EXTENDED WARRANTY FOR MY MAKE, MODEL, & YEAR AS PART OF A PREVIOUS NHTSA INVESTIGATION, BUT NOTHING SHOWS UP FOR MY VIN.

Mileage: 110,000

TL* THE CONTACT OWNS A 2010 FORD FUSION HYBRID. WHILE DRIVING, THE VEHICLE INADVERTENTLY BEGAN TO SHAKE VIOLENTLY AND LOST POWER. THE WAS ABLE TO PULL THE VEHICLE OVER AND THE POWER TRAIN FAULT AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO PRESTIGE FORD (17701 US-441, MT DORA, FL 32757 (352) 357-5522) WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY POWER TRAIN MALFUNCTIONED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

Mileage: 40,000

STARTING IN LATE JULY, 2017, THE CAR STALLS WHEN BEING DRIVEN RELATIVELY SLOWLY. SOMETIMES A WHEEZING NOISE CAN BE HEARD AT THE TIME OF STALLING. OVER THE LAST APPROX. 2+ WEEKS, THE FREQUENCY OF STALLING HAS INCREASED, BUT IT SEEMS ERRATIC OR RANDOM. THE CAR DOES START RIGHT UP AGAIN AFTER SUCH AS STALL, BUT I AM AFRAID TO DRIVE AT HIGHWAY SPEEDS. UNFORTUNATELY, THE FORD DEALER TO WHOM I TOOK IT COULD NOT REPRODUCE OR DIAGNOSE THE PROBLEM AND DOESN'T WANT TO CONSIDER LOOKING INTO IT.

Mileage: 66,000

WHILE DRIVING AT 65 MPH YELLOW WRENCH LIGHT APPEARED AND VEHICLE LOST ALL POWER. THIS WAS ON A BUSY HIGHWAY. PULLED OVER AND RESTARTED CAR. VEHICLE OPERATED SMOOTHLY. TWO DAYS LATER SAME ISSUE, NOW WITH YELLOW WRENCH AND CHECK ENGINE LIGHT. VEHICLE WILL NOT ACCELERATE ABOVE 30 MPH. I TOOK MY VEHICLE TO LOCAL AUTO PARTS STORE AND PULLED CODES MYSELF (115) DOLLARS CHEAPER THEN THE DEALERSHIP WOULD HAVE DONE IT. THROTTLE BODY CONTROL FAILURE. THIS IS THE SAME ENGINE THAT HAS EXTENDED WARRANTY FOR ALOT OF VIN NUMBERS BUT MY CAR HAS THIS ISSUE AMD ISNT COVERED.

Mileage: 137,060

MY 2010 FORD FUSION HYBRID EXPERIENCED IDENTICAL SYMPTOMS (TWICE) TO THOSE OF CUSTOMER SATISFACTION PROGRAM 13N03 HOWEVER THE HYBRID VERSION OF THE FORD FUSION IS NOT INCLUDED IN THE PROGRAM (FORD CLAIMS IT DOES NOT HAVE THE ISSUE). I FIRST HAD THE ISSUE IN AUGUST 2015. I WAS DRIVING ON I-40 IN RALEIGH, GOING UP A SLIGHT HILL WHEN I NOTICED THE CAR WASN'T GOING, IT WAS JUST DECELERATING NO MATTER HOW MUCH I PRESSED THE GAS. VERY SCARY ON A HIGH SPEED INTERSTATE IN THE MIDDLE LANE. THE TWO WRENCH LIGHTS CAME ON. I WAS ABLE TO 'LIMP HOME'. WHEN WE GOT TO THE FORD DEALER, THE WRENCH LIGHTS WERE NO LONGER ON. THE DEALER CLAIMED FORD FUSION HYBRIDS DID NOT HAVE THE ETB PROBLEM. WE ASKED THEM TO DRIVE THE CAR AROUND, WHICH THEY DID, AND COULDN'T REPRODUCE THE PROBLEM. THEY SAID THERE WAS NOTHING THEY COULD DO UNLESS I CAME IN WITH THE PROBLEM HAPPENING. THE PROBLEM DIDN'T SURFACE AGAIN UNTIL ALMOST 10,000 MILES LATER. THIS TIME I WAS ON A LOWER SPEED ROAD, SO INITIALLY IT WASN'T QUITE AS SCARY; HOWEVER AFTER THE EXPERIENCE AT THE DEALER LAST TIME, I WANTED TO GET TO THE FORD DEALER WHILE THE PROBLEM WAS OCCURRING. THIS REQUIRED ME TO DRIVE IN THE POURING RAIN, ON A 55 MPH ROAD, WHERE GOING UP THE HILL MY SPEED DROPPED TO 15 MPH THE DEALER DID PULL THE CODES, AND WAS ABLE TO CONFIRM THE P2112 CODE, THROTTLE STUCK OPEN. I HAD TO PAY FOR REPAIRS, AND FORD REFUSES TO REIMBURSE ME. *TR

Mileage: 98,606

WHILE DRIVING ON THE HIGHWAY 70 MPH SPEED LIMIT THE CAR STOP ACCELERATING AND SLOWED DOWN TO THE EQUIVALENT OF DRIVING IN "CRUISE CONTROL" AT 30 MPH. A YELLOW WRENCH WARNING LIGHT TURNED ON. TOOK CAR TO FORD DEALER AND THEY FELT PROBLEM WAS CONSISTENT WITH A THROTTLE PART PROBLEM AND THEY RECOMMENDED REPLACING THE PART WHICH I DID AND FIXED THE PROBLEM. OF NOTE, BY THE TIME I HAD THE CAR TOWED TO FORD DEALER (DAY AFTER INCIDENT) THE WARNING LIGHT WAS OFF AND FORD DEALER SAID THAT THE CAR SYSTEM HAD NO RECORD OF EVENT.

Mileage: 160

TL* THE CONTACT OWNS A 2010 FORD FUSION HYBRID. WHILE DRIVING 55 MPH, THE VEHICLE DECELERATED AND THE POWER TRAIN WARNING INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO REPAIR THE THROTTLE BODY; HOWEVER, THE CONTACT WAS INFORMED THAT THE REPAIR WAS NOT PART OF A RECALL AND WAS OUTSIDE OF THE EXTENDED WARRANTY DUE TO THE VEHICLE BEING A HYBRID. THE CONTACT WAS INQUIRING ABOUT REIMBURSEMENT ELIGIBILITY. THE FAILURE MILEAGE WAS 37,500. THE CONSUMER STATED SHE IMMEDIATELY LOST SPEED AND HAD TROUBLE ACCELERATING. UPDATED 10/27/16.*JB..UPDATED 12/20/16 *BF *TR

Mileage: 37,500

DRIVING ON HIGHWAY W/ CRUISE CONTROL ENGAGED AT 65 MPH SPEED. SUDDENLY CAR LOSES COMPLETE ACCELERATION & PROPULSION ABILITY, RESULTING IN CAR TO SLOW DOWN RATHER SUDDENLY. I WAS ABLE TO PULL ONTO OFF RAMP IN MY CASE, BUT IF I WAS IN A DIFFERENT LOCATION, I WOULD HAVE DEFINITELY BEEN IN A VERY DANGEROUS SITUATION/SERIOUS ACCIDENT. I TURNED OFF VEHICLE AND RESTARTED THE VEHICLE A FEW MINUTES LATER. PROCEEDED TO THE HIGHWAY AGAIN, EXPERIENCED THE PROBLEM AGAIN, THIS TIME I WAS ONLY ABLE TO PULL OVER TO THE LEFT SHOULDER, WHICH WAS QUITE NARROW TO BEGIN WITH."WRENCH SYMBOL" APPEARED THE SECOND TIME AND STAYED ON WITH CHECK ENGINE LIGHT ON. CAR WAS UNSAFE TO DRIVE FURTHER. THE CHECK ENGINE TROUBLE SHOOTING CODES I HAD WERE P2111 AND P2112. CAUSE OF THIS ISSUE IS KNOWN TO FORD MOTOR BUT THEY REFUSE TO INCLUDE HYBRID CARS IN THEIR "CONSUMER SATISFACTION PROGRAM 13N03". THROTTLE BODY CONTROL MODULE SENOR, INCLUDING THE ENTIRE ASSEMBLY IS DEFECTIVE AS FORD HAS AGREED TO REPLACE THIS ON MILLIONS OF CARS ACROSS VARIOUS MODEL YEARS, INCLUDING THE FUSION 2010, BUT NOT FUSION HYBRID VERSIONS. FORD STATES THEY WILL NOT REPAIR PROBLEM THAT I EXPERIENCED RECENTLY UNDER THIS ESTABLISHED PROGRAM WHICH NHTSA WAS PROPONENT FOR. THE DEFECTIVE PART IN QUESTION IS THE THROTTLE BODY ASSEMBLY AND SENSOR WHICH IS NO DIFFERENT THAN THE PART IN THE NON-HYBRID VERSION FOR THE SAME MODEL YEAR. REAL HAZARD TO DRIVER AND I WAS LUCKY THAT I WAS NOT REAR ENDED AS A RESULT OR IN A SERIOUS CAR ACCIDENT FROM THIS KNOWN DEFECTIVE PART. FORD MOTOR MUST BE REQUIRED TO NOTIFY ALL AFFECTED OWNERS WHO WILL/HAVE EXPERIENCED THIS PROBLEM TO HAVE IT REPAIRED AT THEIR EXPENSE, AS THIS IS A SERIOUS SAFETY ISSUE THAT MUST BE TAKEN SERIOUSLY GIVEN NUMBER OF VEHICLES THAT ARE INVOLVED THAT WILL EXPERIENCE THIS. I EXPERIENCED THIS AT MILEAGE OF 75K BUT I HAVE READ THAT OTHERS HAVE HAD THIS HAPPEN AT MUCH LOWER MILEAGE.

Mileage: 75,000

MY 2010 FUSION HYBRID BEGAN A NO-START/STALLING CONDITION. IT HAS HAPPENED SIX TIMES NOW. FIRST OCCURRENCE WAS AFTER FUELING AT LOW SPEED AFTER ENTERING STREET. SECOND OCCURRENCE WAS WHILE TRAVELING ON THE HIGHWAY AT 55 MPH. THIRD OCCURRENCE WAS WHILE EXITING THE INTERSTATE. FOURTH OCCURRENCE WAS AT LOW SPEED. FIFTH OCCURRENCE WAS IMMEDIATELY AFTER REFUELING WHILE STILL IN PARKING LOT. AND SIXTH OCCURENCE WAS ALSO IMMEDIATELY AFTER REFUELING JUST AFTER LEAVING GAS STATION AT LOW SPEED. FOUR OF THE SIX OCCURRENCES WAS A FAILURE FOR THE INTERNAL COMBUSTION ENGINE TO START AFTER THE ELECTRIC MOTOR HAD ALREADY BEGAN MOVING THE VEHICLE. THE OTHER TWO OCCURRENCES WAS WHILE COASTING. IN ALL INSTANCES THERE WOULD BE A RED TRIANGLE WARNING MESSAGE TO PULL OVER SAFELY, NO CODES WERE THROWN ACCORDING TO THE ENGINEERING REPORT, NO ISSUES REPORTED VIA THE VEHICLE HEALTH REPORT, THE VEHICLE WAS TRAVELING IN A MOSTLY LEVEL AND STRAIGHT LINE, AND THE VEHICLE WOULD USUALLY RESET AND RUN NORMALLY AFTER THE FIRST OR SECOND ATTEMPT AT RESTARTING ONCE THE VEHICLE WAS PULLED OVER.

Mileage: 53,000

I WAS DRIVING ON THE HIGHWAY AT 65 MPH WHEN TWO WRENCH SYMBOLS APPEARED ON THE DASHBOARD. WITHIN A FEW MINUTES, THE CAR BEGAN TO DECELERATE QUICKLY AND LOST POWER. I HAD TO PULL OVER TO THE SHOULDER TO AVOID AN ACCIDENT. IT IS THE SAME ISSUE THAT FORD HAS EXTENDED THE WARRANTY FOR WITH REGARD TO THE NON-HYBRID FORD FUSION MODEL. ALSO THERE ARE MANY SIMILAR COMPLAINTS THAT HYBRID OWNERS ARE REPORTING ON THE INTERNET. I DO NOT KNOW WHY THE EXTENDED WARRANTY DOES NOT APPLY TO THE HYBRIDS AS IT IS THE SAME ISSUE. THE DEALER TOLD ME THAT THE THROTTLE BODY MUST BE REPLACED IN MY CAR AND THEY ALSO HAVE TO REPROGRAM THE POWERTRAIN CODE.

Mileage: 71,000

I EXPERIENCE RAPID DECELERATION OF MY VEHICLE WHEN GOING OVER 60MPH ON THE HIGHWAY. THE WRENCH SERVICES LIGHT CAME ON, AS WELL AS THE CHECK ENGINE LIGHT, AND THE ACCELERATOR STOPPED RESPONDING AT ALL. I HAVE FOUND MANY INSTANCES OF THIS HAPPENING IN OTHER FORD VEHICLES, INCLUDING THE FUSION, BUT AM TOLD BY FORD THAT THE HYBRID HAS NOT BEEN AFFECTED AND THEREFORE THERE IS NO RECALL OR REPAIR ASSISTANCE. HOWEVER, CLEARLY THIS SAME PART IN MY VEHICLE, THE FUSION HYBRID, IS EXPERIENCING ISSUES.

Mileage: 144,000

TL* THE CONTACT OWNS A 2010 FORD FUSION HYBRID. WHILE DRIVING 65 MPH, THE WRENCH WARNING LIGHT ILLUMINATED AND THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT SWITCHED OFF AND WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 87,000.

Mileage: 87,000

I WAS DRIVING THE CAR ABOUT 60 MPH ON THE HIGHWAY WHEN I SAW A BIG RED TRIANGLE ON THE DISPLAY SAYING "PULL OVER AND STOP SAFELY" AND THE CAR SLOWED DOWN DRAMATICALLY. I DID THAT AND TURNED OFF THE ENGINE. I RESTARTED THE CAR. THIS OCCURRED 8 MORE TIMES BEFORE I GOT HOME (15 MILES LATER). WHEN I GOT HOME, I NOTICED THAT THE CAR'S FAN WAS RUNNING VERY HIGH FOR SEVERAL MINUTES. IT FINALLY STOPPED.

Mileage: 70,000

MY DAUGHTER HAS HER LEARNER'S PERMIT AND WAS DRIVING MY FORD FUSION HYBRID ON A 45 MPH STREET. THE WRENCH LIGHT CAME ON AND THE CAR WOULD NOT ACCELERATE AS SHE WAS DRIVING UP A HILLY PART OF THE STREET. CARS BEGAN HONKING AND PASSING AND MY DAUGHTER BECAME EXTREMELY NERVOUS. THANKFULLY, WE WERE NOT INVOLVED IN A CAR ACCIDENT BUT SHE WAS QUITE SHAKEN BY THE INCIDENT. I TOOK THE VEHICLE TO THE FORD DEALERSHIP TO HAVE IT REPAIRED AND WAS ADVISED THIS WAS NOT A RECALL EVEN THOUGH THERE ARE SEVERAL THOUSAND COMPLAINTS AND ISSUES. I HAD TO HAVE THE THROTTLE BODY REPLACED WHICH IS APPARENTLY A DEFECTIVE PART. I DON'T UNDERSTAND WHY THERE ISN'T A RECALL FOR THIS DEFECT. I UNDERSTAND THE NHTSA CONSIDERS SAFETY A HUGE FACTOR WHEN RECALLING PARTS. HOWEVER, THE PART IS CLEARLY DEFECTIVE AND HAS COST CONSUMERS GREATLY. PLEASE RECONSIDER RECALLING OR AT LEAST SUBSIDIZING THE PAYMENT FOR THOSE AFFECTED BY THIS DEFECTIVE PART.

Mileage: 75,250

WHEN OPERATING THE CAR ON THE FREEWAY, THE CAR SUDDENLY LOST POWER AND ONLY COULD ACHIEVE 45 MPH IN SPITE OF THE ACCELERATOR BEING FLOORED. WHEN EVENTUALLY STOPPED, THE ENGINE WOULD SURGE AND SHUDDER PERIODICALLY. THE CHECK ENGINE LIGHT CAME ON. PULLING THE TROUBLE CODE REVEALED P2112 WHICH IS A THROTTLE BODY ERROR.

Mileage: 65,000

VEHICLE WAS ON THE HIGHWAY WHEN THE THROTTLE CLOSED. I SUDDENLY COULD NOT GET TO A SPEED ABOVE 25 MPH. FORTUNATELY I WAS ABLE TO GET TO AN EXIT WITHOUT BEING HIT, AND LIMPED TO THE FORD DEALER WHERE I BOUGHT IT. IT IS MY UNDERSTANDING THAT OTHER FORD FUSIONS OF THAT YEAR HAD AN EXTENDED WARRANTY CREATED WHEN THEY HAD THE SAME FLAW; IT EVEN TRIGGERED THE SAME CODE (P2112). THIS PROBLEM SEEMS TO EXTEND, THEN, TO HYBRIDS, ALTHOUGH FORD CURRENTLY DOES NOT INCLUDE THEM.

Mileage: 79,333

I WAS CRUISING ALONG A MAJOR URBAN HIGHWAY @ 50MPH WHEN I SUDDENLY LOST THE ABILITY TO ACCELERATE. CAR LOST SPEED AND WENT TO 45 THEN DOWN TO 40 AND I WAS UNABLE TO ACCELERATE. LUCKILY TRAFFIC WAS LIGHT AND I WAS ABLE TO CROSS THE TWO LANES OVER TO THE RIGHT AND EXIT THE MAIN ROAD AND LIMPED ALONG TO A STOP IN A SAFE AREA. DEALERSHIP HAD TO REPLACE THE THROTTLE BODY AND MOTOR. WAS NOT COVERED BY FORD'S CSP 13N03 WHICH HAD BEEN ISSUED FOR A SIMILAR PROBLEM. WAS TOLD THE PROGRAM DID NOT APPLY TO THE HYBRID MODEL, AND YET IT WAS THE SAME PROBLEM DESCRIBED IN THE NHTSA ACTION NUMBER PE 13003!

Mileage: 89,000

WHEN DRIVING ON THE HIGHWAY AT APPROXIMATELY 70 MPH, THE WRENCH INDICATOR LIGHT ("LIMP HOME" MODE) SUDDENLY STARTED FLASHING, AND THE GAS PEDAL ABRUPTLY BECAME UNRESPONSIVETHE VEHICLE WOULD NO LONGER ACCELERATE AND COULD ONLY COAST. THE ABRUPTLY DECELERATING VEHICLE WAS MANEUVERED ACROSS MULTIPLE LANES OF TRAFFIC TO THE SHOULDER AND TURNED OFF. UPON RESTARTING THE VEHICLE AFTER A MINUTE, IT WAS ABLE TO RESUME NORMAL OPERATION FOR ABOUT 15 MINUTES, WHEN THE PROBLEM REOCCURRED, AND THE SAME STEPS WERE TAKEN. IT OCCURRED AGAIN 90 MINUTES LATER. SYMPTOMS CORRESPOND TO OTHER ACCOUNTS OF ELECTRONIC THROTTLE BODY ISSUES, BUT FORD SAYS THAT THE VEHICLE IS NOT COVERED UNDER ANY RECALLS, EXTENDED WARRANTIES, OR CUSTOMER SAFETY PROGRAMS.

Mileage: 34,400

WHILE DRIVING AT SPEED CAR SUDDENLY SLOWS WITH A JERK. A WRENCH LIGHT COMES ON THE DASH. THROTTLE CONTROL/POWERTRAIN MALFUNCTION LIGHT AND ENGINE LIGHT ILLUMINATES. CAR GOES INTO "LIMP MODE". CAN'T GO OVER LOW SPEEDS. CAR IS UNSAFE TO DRIVE.

Mileage: 122,000

TL* THE CONTACT OWNS A 2010 FORD FUSION HYBRID. WHILE DRIVING AT 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MERGED TO THE SIDE OF THE ROAD AND WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE COULD NOT BE DUPLICATED. THE THROTTLE BODY WAS REPAIRED, WHICH REMEDIED THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 104,000.

Mileage: 104,000

FIRST TIME, CHECK ENGINE LIGHT CAME ON WHEN DRIVING ON HIGHWAY BUT NO APPARENT IMPACT TO CAR'S FUNCTIONING. TOOK IT TO THE DEALER. THEY SAID THAT THE SURGE VALVE NEEDED TO BE REPLACED AT A COST OF $500 "TO START WITH", BUT THEY DIDN'T SEEM VERY SURE ABOUT IT SO I CHOSE NOT TO PROCEED. THE CHECK ENGINE LIGHT HAD GONE BACK OFF AND THE CAR WAS DRIVING FINE. ABOUT TWO WEEKS LATER ON A SATURDAY I WAS DRIVING ON THE HIGHWAY AGAIN, AT ABOUT 65 MPH, WHEN THE CAR SEEMED TO LOSE ACCELERATION. STANDING ON GAS PEDAL PRODUCED NO RESULT. EXITED AND WAS ABLE TO DRIVE ON BATTERY POWER TO PULL OVER. AFTER WAITING FOR ABOUT 30 MINUTES, TRIED AGAIN. CHECK ENGINE LIGHT WAS BACK OFF AND CAR DROVE NORMALLY BACK HOME. TOOK TO MY REGULAR MECHANIC FIRST THING THAT MONDAY. THEY FOUND OIL IN THE INTAKE MANIFOLD AND QUESTIONED WHETHER I HAD TAKEN THE CAR ANYWHERE UNUSUAL FOR SERVICING, WHICH I HAD NOT, UNLESS YOU COUNT THE DEALER. DID REPAIRS AT A COST OF $2000. ONE WEEK LATER, EXACT SAME THING. CAR IS BACK IN SHOP, AWAITING RESULTS.

Mileage: 39,000

MY HYBRID EXPERIENCED LOSS OF POWER ON 2 OCCASIONS.1ST WAS AT APPROXIMATELY 33,000 MI ON SEP 6, 2014. DRIVING 35MPH ON A PARKWAY WRENCHES APPEARED ON THE DASHBOARD DISPLAY & THEN SUDDEN & IMMEDIATE LOSS OF POWER FOLLOWED.NO RESPONSE TO FULL ACCELERATOR PUSH. MOTOR POWER SHUT DOWN & ONLY ELECTRIC POWER ALLOWED US TO LIMP OFF THE ROAD, HEADED UPHILL AT MAX SPEED OF 10 MPH. VEHICLE TAKEN TO DEALER WHO COULD NOT REPLICATE THE CONDITIONS OR "GET IT TO ACT UP" IN THE WEEK+ A HALF THE CAR WAS THERE.ODOMETER READING SHOWS 700 MI PUT ON PRESUMABLY IN EFFORT TO MAKE DIAGNOSIS.THEIR SUGGESTION WAS TO PICK UP THE VEHICLE SINCE NO DIAGNOSIS COULD BE MADE,DESPITE OUR PROTEST THAT THE CAR WAS UNSAFE TO DRIVE.CALLED FORD CUST.RELATIONSHIP CTR 800# ON SEP15 TO SEEK ASSISTANCE.CASE WAS OPENED BUT NO ACTION TAKEN.THEY CONCURRED WITH DEALER THAT NO REPAIRS WERE TO BE MADE WITHOUT DIAGNOSIS.AGAIN,WE VOICED CONCERN THAT THE CAR WAS UNSAFE.DEALER SUSPECTED THROTTLE BODY ISSUE BUT WITHOUT DIAGNOSIS INSIST THAT REPAIRS WOULD BE AT OUR COST $400-$500. 2ND OCCURRENCE WAS OCT 2 2014.WHILE DRIVING IN TRAFFIC EXPERIENCED IMMED & SUDDEN LOSS OF POWER,NO RESPONSE TO ACCELERATION ATTEMPTS,ELECTRIC POWERED LIMP OFF UPHILL ROAD AT MAX SPEED OF 10 MPH.WAS ADVISED BY DEALER NOT TO ATTEMPT STARTING THE CAR ONCE IT DIED IN EFFORT TO MAINTAIN ERROR REPORT IN SYSTEM. WE ADHERED TO THIS ADVICE AND HAD VEHICLE TOWED TO DEALER A 2ND TIME WITHOUT STARTING IT. DEALER WAS AT THE READY WITH THE PHRASE "THROTTLE BODY" AND ASKED IF WE HAD RECEIVED ANY LETTERS IN REGARDS TO SUCH.VEHICLE WAS DIAGNOSED AS HAVING CARBON BUILDUP THAT CAUSED THROTTLE BODY TO SHORT OUT. REPAIRS MADE AT OUR EXPENSE $709.NUMEROUS COMPLAINTS ARE DOCUMENTED ON THE NHTSA WEBSITE OF THROTTLE BODY ISSUES! HYBRID OWNERS HAVE REPORTED AS WELL. OWNERS WHO HAVE HAD TO PAY FOR REPAIRS OF DEFECTIVE PARTS OUT OF THEIR OWN POCKET DESERVE COMPENSATION BY FORD. *TR

Mileage: 33,000

FORD HYBRID WOULD NOT ACCELERATE. IT DID NOT GO ABOVE 30 MPH IN HEAVY TRAFFIC. I WAS LUCKY A FORD DEALER WAS NEARBY. IT WAS DANGEROUS CROSSING A MAJOR INTERSECTION. SERVICE DEPARTMENT SAID IT WAS THE ELECTRONIC THROTTLE BODY. NHTSA IS AWARE OF THIS PROBLEM BUT ALLOWED FORD TO LIMIT THEIR RECALL TO A LIMITED CUSTOMER SATISFACTION PROGRAM. THE PROBLEM MAY NOT PRESENT ITSELF FOR MANY MILES. MY CAR IS BEYOND WARRANTY AND I CALLED FORD. THEY SAID I WAS NOT COVERED IN THEIR LIMITED PROGRAM BECAUSE MY CAR WAS MADE AT A PLANT WHERE THEY CLAIM NO PROBLEMS EXIST. I ASKED IF THE PART WAS MADE AT THE PLANT. FORD CS DECLINED TO ASSIST ME. I WAS RESPONSIBLE FOR THE COST OF REPAIR. THE MONEY IS NOT IMPORTANT. MY WIFE WAS DRIVING AND SHE WAS PUT IN A PRECARIOUS POSITION ON THE HIGHWAY. THIS SEEMS TO BE THE RESPONSE OF AUTOMAKERS. I SUFFERED THROUGH THE 2007 TOYOTA CAMRY LIES AND BOUGHT THIS FORD. IN THE MINDS OF AUTOMAKERS, I SUPPOSE THEY WOULD SAY IT IS JUST MY BAD LUCK. TOYOTA LIED, FORD EVADED THEIR RESPONSIBILITY. *TR

Mileage: 595,000

INTERMITTENTLY LOSE RESPONSE FROM THROTTLE. HAPPENS ON START UP AS WELL AS WHILE DRIVING. CAR WILL NOT GO OVER 45 MPH. YOU HAVE TO PULL OVER SHUT OFF THE CAR FOR 5 SECONDS TURN IT BACK ON AND IT WILL WORK UNTIL IT HAPPENS AGAIN. MAY GO DAYS BETWEEN INCIDENT BUT HAS HAPPENED 5 TIMES IN ONE DAY. I WOULD NOT FEEL SAFE WITH THE FAMILY IN THE CAR. THE WRENCH DOES COME ONE RIGHT BEFORE THIS HAPPENS. DEALERSHIP CONFIRMED BAD THROTTLE BODY. WILL NOT COVER THE COST OF REPAIR. CURRENTLY DISPUTING WITH FORD. *TR

Mileage: 65,000

ENGINE CUT OFF AND THE CAR ENTERED IN TO SAFE MODE (BATTERY ONLY DRIVE SYSTEM). TOOK IT TO DEALERSHIP AND THEY SAID THE THROTTLE BODY NEEDS REPLACING. IT SEEMS TO BE A COMMON DEFECT. SO MUCH SO THAT FORD ISSUED A SELECTIVE RECALL, BUT MINE ISN'T INCLUDED FOR SOME REASON. DEALER CLAIMS THEY HAVE REPLACED A LOT OF THEM. *TR

Mileage: 64,819

I WAS DRIVING AT ABOUT 30 MPH WHEN A YELLOW WRENCH LIGHT ICON CAME ON. THE CAR STOPPED ACCELERATING, AND IT SEEMED LIKE ONLY THE ELECTRICAL POWER FROM THE BATTERY WAS KEEPING IT GOING. I HAD JUST EXITED A BUSY FREEWAY WHERE PEOPLE WERE GOING 65 MPH AND HIGHER, AND IF I HAD NOT JUST HAPPENED TO EXIT I FEAR I WOULD HAVE HAD AN ACCIDENT. *TR

Mileage: 75,000

TL* THE CONTACT OWNS A 2010 FORD FUSION HYBRID. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE STALLED AND AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 62,000.

Mileage: 62,000

TL* THE CONTACT OWNS A 2010 FORD FUSION HYBRID. THE CONTACT STATED WHILE DRIVING 55 MPH, THE VEHICLE SUDDENDLY DECELERATTED.THE CONTACT MENTIONED THAT THE THROTTLE AND CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE PROBLEM WAS INTERMITTENT AND THE DEALER COULD NOT DUPLICATE THE PROBLEM THE FIRST TIME THE VEHICLE WAS INSPECTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE THROTTLE WAS DEFECTIVE AND NEEDED TO BE REPLACED.THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 94,300.

Mileage: 94,300

TL* THE CONTACT OWNS A 2010 FORD FUSION HYBRID. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THERE WAS A SUDDEN LOSS ON ENGINE POWER AS THE ELECTRONIC THROTTLE CONTROL WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY MALFUNCTIONED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 62,000.

Mileage: 62,000

WHILE ON THE HIGHWAY DRIVING AT 60 MPH THE CAR WOULD NOT ACCELERATE AND STARTED LOOSING SPEED, TILL IT GOT TO 40 MPH. THE WRENCH LIGHT CAME ON. I HAD TO PULL ONTO THE SIDE OF THE HIGHWAY, TURN OFF THE ENGINE AND RESTART. I WAS ABLE TO DRIVE HOME WELL. THE NEXT DAY IT HAPPENED TWICE AGAIN. I TOOK IT TO THE DEALER AND THEY FIXED THE THROTTLE BODY AND MOTOR ASSY. I AM NOT HAPPY THEY CHARGED ME FOR FIXING THIS ISSUE WHICH IS THEIR FAULT. THEY HAD PERFORMED A FULL INSPECTION 15 DAYS EARLIER AND THE CAR WAS FINE ACCORDING TO THEM. NOW I SEE THERE ARE A LOT OF COMPLAINTS LIKE MINE. THANK GOODNESS THERE WAS NO ACCIDENT INVOLVED. *TR

Mileage: 59,832

MONDAY, JAN. 27 - POWER SUDDENLY GAVE OUT WHEN ACCELERATING ON FREEWAY. SERVICE WRENCH HAD BEEN ON EARLIER THAT DAY BUT HAD GONE OFF. DIXON FORD TOLD US IT WAS OK TO DRIVE. I WAS IN LEFT LANE AND HAD TO CROSS 5 LANES TO GET TO MEDIAN. TOOK IT IN TO WALNUT CREEK FORD AND THEY "RE-FLASHED IT", SAYING NO CONCERN WAS PRESENT AT THE TIME. THEY GAVE THE DANGEROUS CAR BACK TO US FRI, JAN 31ST 130 MILES DRIVEN IN 2ND LANE (ONE FROM CARPOOL LANE) AT 65 MPH ACCEL LIGHTLY SUDDENLY, CAR'S GAS GAVE OUT, LIKE BEFORE THE ROAD CURVED TO RIGHT. TRY TO STEER CAR RIGHT TO FOLLOW LANE AS CAR DECEL NOTICED THAT STEERING NOT RESPONDING, EVEN TO STRONGEST INPUTS (ALMOST LIKE LOCKED, LIKE CAR WAS OFF) TRIED TO HIT BRAKES, BUT PEDAL SANK TO FLOOR NO RESPONSE REGARDLESS OF PRESSURE. KEPT PRESSURE BUT CAR DID NOT SLOW BEGAN TO DRIFT PASSENGER GRABBED WHEEL ALSO AND TRIED TO PULL RIGHT. GRADUALLY STARTED TO GO RIGHT, BUT WITH EXTREME FORCE APPLIED. AFTER FORCE, WHEEL AT MOST 5 DEGREES TURN EMERGENCY BRAKE TO SLOW (NOT STOP) STEERING CORRECTIONS COULD NOT SUFFICIENTLY TURN CAR SO CAR SLAMMED INTO CONCRETE MEDIAN AT 50 MPH TIGHTENED EMERGENCY BRAKE AND CONTINUED TO PULL ON THE WHEEL SLID ALONG MEDIAN AS CAR SCREECHED CAR FINALLY STOPPED ON THE LEFT SIDE OF FREEWAY GEAR SELECTOR LOCKED IN DRIVE TURNED OFF THE ENGINE WHILE THE SELECTOR WAS STILL IN PARK. RESPONDING CHP OFFICER K. ALLEMAN ASKED US TO DRIVE CAR TO THE OTHER SIDE OF THE FREEWAY COULD NOT START CAR. TURNED KEY 3 TIMES BUT CAR REFUSED TO RESPOND. GETTING VERY HOT IN THE CAR, JUST LIKE MON, PROB 95 -100 AMBIENT TEMP AGAIN WHEN EXT. TEMP. 58 FINALLY ABLE TO SELECT NEUTRAL AND RELEASE PARKING BRAKE. CAR DID NOT START PAX&I HAD TO PULL HARD TO GET WHEEL TO TURN AT ALL INCIDENT REPORT #[XXX] OFFICER CONFIRMED BRAKES, STEERING, AND POWER WERE ALL GONE. DETAILS IN REPT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 19,300

CAR WRENCH LIGHT CAM ON UPON STARTING THE CAR. THE ELECTRIC HYBRID SYSTEM TOOK OFF ON ITS OWN AND CRUISED AT 30MPH WITHOUT ANY PRESSURE ON THE ACCELERATOR. VERY DANGEROUS THAT THE CAR WILL ACCELERATE WITHOUT TOUCHING THE GAS PEDAL. I CRUISED DOWN A VACANT STRETCH OF ROAD FOR 5 MINUTES AT 30MPH WITHOUT TOUCHING THE GAS PEDAL. THE HYBRID SYSTEM KICKED IN AND HAS A MIND OF IT'S OWN. VERY CREEPY. I WILL SEE IF IT IS THE THROTTLE BODY BUT MINE IS A HYBRID AND IT MAY BE A LITTLE DIFFERENT THIS SHOULD BE ADDRESSED BY FORD ASAP. *TR

Mileage: 115,675

VEHICLE SUDDENLY LOST POWER AND WAS UNRESPONSIVE. DASHBOARD INDICATED "DOUBLE WRENCH" WARNING. UPON COASTING TO THE SIDE OF THE ROAD, VEHICLE WAS ABLE TO BE REACTIVATED AND DROVE NORMALLY FROM THIS POINT. *TR

Mileage: 107,543

WHEN DRIVING ON THE HIGHWAY AT 65 MILES AN HOUR, A WRENCH LIGHT WENT ON IN THE CAR AND WITHIN SECONDS THE CAR LOST POWER AND I WAS ONLY ABLE TO GO 20-30 MILES PER HOUR. GOT OFF THE HIGHWAY, PULLED OVER AT A GAS STATION AND TURNED THE CAR OFF. AFTER ABOUT 15 MINUTES I TURNED THE CAR BACK ON (THINKING IT MIGHT HAVE BEEN AN ISSUE WITH MY HYBRID BATTERY), THE CAR SEEMED TO WORKING OKAY BUT JUST TO BE SAFE I DROVE THE CAR 10 MILES TO THE LOCAL FORD DEALER. THE SERVICE ADVISOR TOOK A QUICK LOOK AT IT AND AGREED THAT IT WAS THE BATTERY (SAID IT HAD PROBABLY GOTTEN TOO HOT) AND TOLD ME THE CAR WAS OKAY TO DRIVE. WENT TO GRAB LUNCH AND THEN 45 MINUTES LATER GOT BACK ON THE HIGHWAY AND AS SOON AS THE CAR GOT TO ABOUT 60 MILES, THE SAME THING HAPPENED. SO AGAIN I GOT OFF THE HIGHWAY AND GOING ABOUT 10 MILES PER HOUR WENT TO ANOTHER FORD DEALER TO HAVE THEM LOOK AT IT. THEY DETERMINED IT WAS A FAILED THROTTLE BODY AND REPLACED IT THE NEXT DAY. *TR

Mileage: 55,500

WHILE DRIVING ALONG THE HIGHWAY VEHICLE LOST ALL GAS POWER AND BEGAN TO SLOW DOWN UNRESPONSIVE TO OPERATION OF THE GAS PEDAL. HAVE READ DIAGNOSTIC CODE WHICH INDICATES A FAILED THROTTLE BODY. *TR

Mileage: 40,200

CAR PERFORMING NORMALLY THEN WRENCH SYMBOL COMES ON DASH AND CAR ACCELERATOR WOULD NOT RESPOND. LIMPED CAR OVER TO FORD DEALER ON THE HYBRID BATTERY. DEALER WHO DID NOT HAVE STAFF ENOUGH TOO LOOK AT IT FOR 2 DAYS. TOWED OVER TO DEALER NEAR ME . HEARD TODAY IT IS A BAD THROTTLE BODY AND ASSOCIATED ELECTRONICS AND GOING TO COST $600-$700 TO REPLACE. LOOKING A THE INTERNET IT SURE SEEMS A LOT OF OWNERS ARE HAVING THE SAME ISSUE. THERE IS ACTUALLY A VIDEO NOW ON U-TUBE ON HOW TO REPLACE YOURSELF THERE ARE SO MANY OF THESE THROTTLE BODY'S FAILING. *TR

Mileage: 40,100

POWERTRAIN WARNING LIGHT APPEARED AND CAR WOULD NOT ACCELERATE ABOVE 25MPH. ISSUE CLEARED AND THEN LIGHT CAME ON AGAIN A DAY LATER, THIS TIME CAR DROVE FINE. TOOK TO DEALER AND DIAGNOSED STICKING THROTTLE BODY ASSEMBLY. DEALER REPORTED THIS HAPPENS FREQUENTLY AND $500 COST IS NOT COVERED UNDER WARRANTY. QUICK INTERNET SEARCH SHOWED THIS SEEMS TO BE A PERVASIVE SAFETY ISSUE THAT IS NOT BEING ADDRESSED ADEQUATELY BY FORD. *TR

Mileage: 54,865

SUDDEN LOSS OF POWER WHILE DRIVING. VEHICLE STALLED AS I WAS ABOUT TO GET ON THE ON-RAMP TO THE INTERSTATE HIGHWAY. WAS NOT ABLE TO ACCELERATE OR MAINTAIN SPEEDS FASTER THAN 35 MPH. VEHICLE WAS TAKEN TO REPAIR SHOP AND THE PROBLEM WAS DIAGNOSED AS A FAULTY THROTTLE BODY. *TR

Mileage: 51,000

WHILE TURNING AROUND IN A PARKING LOT AND NEITHER BRAKING OR ACCELERATING BUT SIMPLY COASTING WITH THE WHEELS TURNED VERY SHARPLY, THE CAR SUDDENLY ACCELERATED. QUICKLY SLAMMING ON THE BRAKES STOPPED THE ACCELERATION. THIS WAS NOT A FLOOR MAT PROBLEM SINCE THE FLOOR MAT IS ANCHORED AND CANNOT SLIDE UNDER THE ACCELERATOR. *TR

Mileage: 38,852

I WAS ON THE LEFT LANE GOING 55MPH ON A FREEWAY UP A SLIGHT INCLINE WHEN I NOTICED I WAS LOSING SPEED. PRESSED THE GAS PEDAL A LITTLE HARDER THINKING I NEEDED TO COMPENSATE FOR THE INCLINE, BUT THE CAR WOULD NOT ACCELERATE. I NOTICED A YELLOW WRENCH APPEAR ON THE LEFT SIDE OF THE DASH DISPLAY. I HAD THE GAS PEDAL TO THE GROUND AND CAR STILL WOULD NOT ACCELERATE BUT DECELERATED ALL THE WAY DOWN TO 30MPH WHERE IT STOPPED DECELERATING AND MAINTAINED THIS SPEED. I HAD TO MANEUVER AT 30MPH OFF THE FREEWAY TO GET INTO THE RIGHT SHOULDER LANE. TURNED THE CAR OFF, THEN BACK ON. YELLOW WRENCH NO LONGER VISIBLE AND CAR OPERATED NORMALLY. THIS POSES A VERY DANGEROUS SITUATION. LUCKILY IT WAS NOT DURING RUSH HOUR TRAFFIC AND THE CARS BEHIND ME YIELDED TO MY HAZARD LIGHTS AND LET ME GET TO THE RIGHT SHOULDER LANE. *TR

Mileage: 26,147

DRIVER WAS IN SMALL LOCAL SHOPPING CENTER, HE TURNED INTO PARKING SPACE, APPLIED BRAKE, WHEN CAR ACCELERATED OVER CURB ONTO SIDEWALK AND THROUGH FRONT OF BUILDING. *TR

Mileage: 25,000