2006 FORD FUSION Engine Problems

The contact owns a 2006 Ford Fusion. The contact became aware of an oil leak on the ground underneath the vehicle. The vehicle was taken to an independent mechanic who stated that oil was leaking from the engine. The mechanic was unsure where the leak originated. The vehicle was not repaired. The manufacturer was contacted but provided no assistance. The approximate failure mileage was 108,000.

Mileage: 108,000

The contact owns a 2006 Ford Fusion. The contact stated that while driving at various speeds, there was an abnormal creaking sound coming from the front end of the vehicle. There was no warning light illuminated. The contact stated that the vehicle was repaired on several occasions due to the failure. The contact stated that each summer after the vehicle was repaired, the failure returned. The manufacturer was notified of the failure but provided no assistance. The vehicle was not repaired. The failure mileage was unknown.

The serpentine belt keeps coming off or breaking. The idler pulley bolt keeps breaking off into the engine.

THE CAR HAS A PROBLEM WITH THE BRAKES, IT DOES NOT BRAKE VERY WELL AND IS NOT SAFE TO DRIVE ON THE STREET

Mileage: 205

2006 FORD FUSION: WHEN DRIVING AFTER THE CAR GETS WARM UP IT IS STARTS SLIPPING AND SHIFTING SOMEONE HARSHLY LIKE IT JUST GOT KICKED. I WAS ON THE FREEWAY AND COULDN'T SPEED UP ALMOST GOT REAR ENDED. I SEE OTHERS HAVE THE SAME ISSUE AFTER DOING A SEARCH I FOUND DIFFERENT ANSWER AS WHAT COULD BE WRONG. FOUND OUT WHAT THE ISSUE IS WITH THE AISIN TRANSMISSIONS SLIPPING WHICH WERE USED IN THE 2006 FUSION. IT IS DUE TO VALVE BORE WEAR IN THE MAIN CONTROL. IF THE TRANS FLUID ISNT BURNT (MEANING THERE IS INTERNAL TRANS CLUTCH DAMAGE) THEN YOU ARE LOOKING AT $800-$1000 TO REPLACE THE MAIN CONTROL. IF THE CLUTCHES ARE BURNT THE WHOLE TRANS WILL HAVE TO BE REPLACED COST??? SOMETHING LIKE $4000-$5000. THE PROBLEM IS THAT WHEN FORD BOUGHT THE AISIN TRANS, FORD DID NOT BUY THE SERVICE RIGHTS. SO THERE ARE NO SERVICE PARTS AVAILABLE OR TRAINING AVAIL ON HOW TO SERVICE THIS TRANS. THE ISSUE WITH THE MAIN CONTROL HAS BEEN SO COMMON THAT AISIN HAS AGREED TO SUPPLY FORD WITH SERVICE MAIN CONTROLS.THERE HAS BEEN A TECHNICAL SERVICE BULLETIN OUT THERE. SEE BELOW TSB BULLETIN DATE: FEB 2007 VARIOUS DRIVEABILITY/TRANSMISSION SYMPTOMS - PCM/TCM CALIBRATION UPDATES 3.0L - AISIN F21 AUTO TRANS. ( NHTSA ITEM NUMBER - 10021277 ) AS ONE PERSON POSTED. FORD NEEDS TO MAKE THIS RIGHT!!! VERY UNSAFE*** OUR CAR IS PARKED IN THE GARAGE WE CAN NOT AFFORD TO FIX IT OR SELL IT WITH A BAD TRANSMISSION .AMMCO SAID NEEDS NEW TRANSMISSION.

Mileage: 102,000

TAKATA RECALL HAVE YET TO GET PAPERS AND GET PROBLEM FIXED. INTERMITTEN FAILURE OF THE ELECTRONIC THROTTLE BODY.

Mileage: 120,000

THERMOSTAT STICKS OPEN (COLD) WHILE DRIVING. SUDDEN JUMPS TO NORMAL TEMPERATURE RANGE FOLLOWED BY DROP TO COLD AGAIN. VEHICLE HAS HARD TIME STARTING WHEN TEMPERATURE GAUGE IS ON COLD MARK AFTER RUNNING FOR ANY PERIOD OF TIME. THERMOSTAT HAS BEEN REPLACED WITH NO IMPROVEMENT. THROTTLE STICKS ON ACCELERATION CAUSING ENGINE TO BOG DOWN AND ALMOST CHOKE OUT FOLLOWED BY SUDDEN BURST OF ACCELERATION THAT COULD LEAD TO ACCIDENT.

Mileage: 15

TAKATA RECALL, BODY PAINT HORRIBLE, RUSTED EARLY, TRANSMISSION WENT WENT, ELECTRICAL SYSTEM HORRIBLE, TURNS LIKE A TRUCK

Mileage: 100,000

WHILE DRIVING THE CAR ON THE HIGHWAY AT TYPICAL HIGHWAY SPEEDS (60MPH-70MPH) THE WRENCH INDICATOR LIGHT COMES ON IN THE DASHBOARD AND THE CAR LOOSES THE ABILITY TO ACCELERATE ANY FASTER THAN ABOUT 10 MILES AN HOUR. WE PULL OVER, TURN THE CAR OFF AND START IT BACK UP AGAIN AND IT APPEARS TO RUN FINE. THIS CAN HAPPEN RANDOMLY ONE DAY AND THEN NOT HAPPEN AGAIN FOR A FEW WEEKS OR EVEN A MONTH OR TWO THEN IT DOES IT AGAIN. BASED ON MY RESEARCH COMPARING OTHER DRIVERS POSTING ABOUT THE SAME PROBLEM I BELIEVE THIS PROBLEM IS DUE TO A DEFECTIVE THROTTLE BODY OR WHAT IS SOMETIMES CALLED THE ETB = ELECTRONIC THROTTLE BODY. THE PROBLEM IS THE RESULT OF THE COMPUTER AND SENSORS SENDING BAD SIGNALS TO THE THROTTLE BODY MECHANISM WHICH THEN AFFECTS THE AIR/GAS MIXTURE AND ADVERSELY AFFECTS ACCELERATION, THIS IS DANGEROUS AND A SAFETY ISSUE. THERE WAS A RECALL ON DEFECTIVE THROTTLE BODIES FOR FORD FUSIONS BUT IT ONLY INCLUDED 2009 MODELS AND LATER MODELS, BUT IT DID NOT INCLUDE 2006 MODELS. I HAVE READ OF OTHER PEOPLE IN EARLIER MODEL CARS FROM AS EARLY AS 2005 POSTING ON FORUMS THAT THEY HAD THE SAME ISSUE, SO I BELIEVE THIS WASN'T ONLY A PROBLEM ON 2009'S AND LATER. FORD ISSUES AN EXTENDED WARRANTY ON THE FUSION OF TEN YEARS OR 150,000 MILES. I DON'T KNOW THE NAME OF THE SPECIFIC RECALL OTHER THAN A REFERENCE TO CONSUMER SATISFACTION PROGRAM 13N03. THE PROBLEM SOMETIMES IS REFERRED AS THE "LIMP HOME" MODE. IN CONCLUSION, I WOULD LIKE OUR 2006 FORD FUSION TO BE INCLUDED OR QUALIFIED IN THE RECALL SO I CAN FIX THIS PROBLEM OR AT LEAST GET REIMBURSED ONCE I GET IT FIXED SINCE IT IS A DEFECT WITH THE CAR.

Mileage: 131,426

TL* THE CONTACT OWNS A 2004 (NA) FORD FUSION. WHILE DRIVING THE VEHICLE, SMOKE APPEARED AND THE VEHICLE STALLED. THE VEHICLE CAUGHT FIRE WITHOUT WARNING. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE CONTACT PREVIOUSLY CALLED A LOCAL DEALER (CRAIN FORD OF LITTLE ROCK LOCATED AT 4601 COLONEL GLENN PLAZA DRIVE 72116 501-542-6041) STATED THAT THE PARTS FOR THE REPAIR WERE ON BACKORDER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

Mileage: 60,000

WHILE DRIVING MY ENGINE INTERMITTENTLY SHUTS OFF. THE CAR WILL STILL BE "ON". IN THE SENSE THAT THE AC AND RADIO AND OTHER FEATURES ARE STILL WORKING, BUT THE CAR WILL NOT ACCELERATE OR MOVE. I HAVE TO PUT IT IN PARK. AND RESTART IT. "CHECK ENGINE" AND "CHECK CHARGING SYSTEM" INDICATOR LIGHTS POP UP ON THE DASH. I HAVE DONE SEVERAL THINGS, CHANGE BELTS, CHANGED ALTERNATORS, CHANGED CAM SHAFTS, AND FINALLY AFTER THAT THOUSAND DOLLARS WAS SPENT THE CODE I'M GETTING READ FROM MY MECHANIC IS FOR THE THROTTLE BODY SHUT DOWN.

Mileage: 77,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. WHILE ACCELERATING FROM A STOP, THE VEHICLE'S SPEED INCREASED VERY SLOWLY AND SHIFTED ABNORMALLY. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE ON THE REBUILT ENGINE WAS APPROXIMATELY 90,000 AND THE VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 152,000.

Mileage: 152,000

DRIVING ON THE HIGHWAY AT 80 MPH THE CAR LOOSES ACCELERATION POWER AND AN ORANGE WRENCH SYMBOL SHOWS UP ON THE DASHBOARD. I HAVE TO SAFELY COAST MY VEHICLE TO A SAFE SPOT OFF THE ROAD. WHEN CAR COMES TO COMPLETE STOP IT IDLES REALLY ROUGH AND LOUD AND MAKES A LOUD NOISE WHEN PLACED INTO PARK. I HAVE TO SHUT CAR OFF THEN RESTART AND I'M ABLE TO CONTINUE DRIVING AS IF NOTHING EVER HAPPENED. THE PROBLEM KEEPS HAPPENING AND IS STARTING TO OCCUR MORE OFTEN BUT ALWAYS WHILE DRIVING ON THE HIGHWAY...PRAY TO GOD NOTHING SERIOUS EVER HAPPENS.

Mileage: 122,500

I WAS PARKING IN A BETTENDORT, IOWA RESTAURANT PARKING LOT WHEN MY CAR SURGED FORWARD. I APPLIED THE BRAKES, BUT CAR WOULD NOT STOP. IT LEFT THE PARKING LOT, CROSSED A SIDEWALK AND WENT ONTO A STREET NEAR AN INTERSECTION. I KEPT APPLYING THE BRAKES, BUT CAR STILL WOULDN'T STOP. IT COLLIDED WITH AN ONCOMING CAR, CROSSED OVER A MEDIAN AND FINALLY STOPPED ON ANOTHER STREET ACROSS FROM THE INTERSECTION.

Mileage: 143,000

INTERIOR FRONT DOOR LATCHES BROKE AROUND THE 100,000 MILEAGE. ALL FOUR ELECTRIC WINDOW REGULATORS/MOTOR HAVE FAILED FROM THE 80,000-110,000 MILEAGE PERIOD. EACH OF THE REGULATORS PLASTIC ROLLERS WHERE THE CABLE GOES AROUND WERE BROKEN. TWO OF THE AUTOMATIC DOOR LOCKS QUIT WORKING AS WELL. ALL MOTOR MOUNTS HAVE BEEN REPLACED AT LEAST ONCE AND 2 HAVE BEEN REPLACED TWICE EACH. 4-CYLINDER. I HAVE SEEN 100'S OF COMPLAINTS ONLINE ABOUT THE MOTOR MOUNTS AND MANY FOR THE INTERIOR LATCHES AND WINDOW REGULATORS. I HAVE SPENT OVER A THOUSAND DOLLARS ON THE MOTOR MOUNT ISSUES.

Mileage: 80,000

OUR FORD FUSION ENGINE SUDDENLY STARTED DYING IN TRAFFIC. WHEN STOPPING AT A LIGHT OR STOP SIGN IN TRAFFIC, THE IDLE WOULD DROP BELOW 5000 RPMS, THEN SUDDENLY THE ENGINE WOULD DIE. AFTER PLACING THE VEHICLE IN PARK, WE WOULD HAVE TO RESTART THE ENGINE. USUALLY WOULD DIE AFTER SITTING STILL AFTER ABOUT 10 SECONDS. SOMETIMES THE VEHICLE WOULDN'T START BACKUP RIGHT AWAY, SO WE WERE STUCK ON THE ROAD UNTIL IT FINALLY DECIDED TO START. NO CHECK ENGINE LIGHT OR WRENCH WOULD DISPLAY. WE TOOK IT IN TO FORD DEALER AND THEY DETERMINED THE THROTTLE BODY WAS DEFECTIVE. APPARENTLY THIS IS AN ISSUE WITH MOST FORD FUSIONS, AS WELL AS OTHER MODELS THAT USE THE SAME THROTTLE BODY. THE VEHICLE HAS 80,000 MILES ON IT. REPAIR COSTS WERE OVER $1000. WHEN IS FORD GOING TO ADDRESS THIS ISSUE FOR THE FUSIONS THAT WERE MADE BEFORE 2009? THANKS, [XXX] 'INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *BF

Mileage: 80,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE VEHICLE ACCELERATED AND DECELERATED INDEPENDENTLY AS THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ECM FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 121,759.

Mileage: 121,759

WHILE REVERSING OUT OF MY PARKING SPOT AT WORK THE OTHER DAY, THE CAR COMPLETELY STALLED WHILE MY FOOT WAS ON THE GAS PEDAL. I WAS THANKFUL THAT NO ONE WAS BEHIND ME BECAUSE THE CAR COMPLETELY SHUT DOWN. I PUT IT IN PARK AND RESTARTED IT EASILY, BUT I WAS TOO NERVOUS TO DRIVE ON A HIGHWAY AFTER THE INCIDENT, AS THERE WAS NO INDICATION THE FIRST TIME THAT THE CAR WAS GOING TO SHUT DOWN. I DROVE DOWN A COUNTRY ROAD WITH MY FLASHERS ON UNTIL I GOT TO A SAFE PLACE WHERE I COULD CALL MY HUSBAND. WHILE I WAITED FOR HIM TO COME GET ME, I KEPT THE CAR IN IDLE AND RAN THE HEATER. THE CAR SHUT DOWN AGAIN, AND THIS TIME I WAS ABLE TO TAKE A PICTURE OF THE WARNING LIGHTS THAT ACCOMPANIED THE FAILURE. (SEE ATTACHED.) THE DASH SAID "CHECK CHARGING SYSTEM" AND THE OIL, EMISSIONS, AND BATTERY LIGHTS CAME ON. WE CALLED AND HAD IT TOWED TO A LOCAL SHOP BUT MAN THERE HAS NO IDEA WHAT THE PROBLEM IS AND TOLD US TO TOW IT TO THE DEALERSHIP. MY CAR HAS OVER 100,000 MILES, BUT I HAVE HAD TROUBLE WITH IT SINCE I BOUGHT IT. I HAVE HAD MECHANICS TELL ME THAT THE ELECTRICAL SYSTEM DOES NOT WORK WELL. I HAVE ALSO HAD THEM TELL ME THAT IT IS NORMAL FOR THE AIR-CONDITIONER IN THESE CARS TO JUST TURN ON RANDOMLY TO COOL THE ENGINE, WHICH MINE DOES FREQUENTLY. MOREOVER, THE BATTERY IN THE CAR NOW IS THE THIRD ONE I'VE HAD. BRAKE LIGHTS BURN OUT CONSTANTLY, AND THE TRANSMISSION MAKES TERRIBLE NOISES WHEN I START THE CAR AND PARTICULARLY WHEN I REVERSE. THIS NEW PROBLEM OF STOPPING UNEXPECTEDLY IS SIMPLY UNACCEPTABLE. I HATE TO GIVE UP MY FUSION BECAUSE WHEN IT'S RUNNING CORRECTLY, IT'S A GREAT CAR; HOWEVER, THIS LAST INSTANCE IS JUST TOO DANGEROUS. IF I WERE ON THE HIGHWAY, I COULD HAVE BEEN KILLED. THIS SAME THING HAS HAPPENED TO FRIENDS OF MINE WHO OWNED FORDS. I WILL BE CALLING FORD AND ASKING THEM ABOUT THROTTLE BODY AND PCM PROBLEMS THAT OTHERS HAVE NOTED IN THEIR COMPLAINTS.

Mileage: 110,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT AND ELECTRONIC THROTTLE CONTROL WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC THROTTLE BODY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 159,070.

Mileage: 159,070

AFTER SLOWING DOWN JUST BEFORE THE STOP SIGN, MY CAR STARTED TO SPUTTER AND WHEN I TRIES TO ACCELERATE AFTER THE INTERSECTION IT STOPS ACCELERATING. I HAD TO LIMP ALONG TO GET HOME. LUCKILY, I WAS JUST ABOUT 1.5 MILES FROM HOME. I HAVE DONE FOR THIS CAR ALL SCHEDULED MAINTENANCE AND NEVER MISSED THE RECOMMENDED PERIODICAL OIL CHANGES. I DRIVE LESS THAN 5000 MILES A YEAR WITH THIS CAR AN IT HAS LESS 59,000 MILES ON IT. THIS MUST BE DUE TO A DEFECTIVE PART FROM THE FACTORY AND I SHOULD NOT PAY FOR IT. I HAVE LEFT IT PARKED ON MY DRIVEWAY UNTIL I HEAR FROM YOU AND BY WAY OF YOUR GOOD OFFICES HOPEFULLY FROM FORD. THANK YOU FOR KIND ASSISTANCE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 58,800

CAR DIES WHILST DRIVING. THIS IS A SAFETY ISSUE. AUTHORIZED FORD DEALER SERVICE DETERMINED ISSUE WAS CAUSED BY A DEFECTIVE THROTTLE BODY. *TR

Mileage: 78,333

I STARTED HAVING ISSUES WITH MY CAR IN 2008. MY CAR THEN WOULD NOT GO ANY FASTER THAN 50 MPH WOULD NOT ACCELERATE ON THE FREEWAY ON RAMP , AND COULD NOT GO UP HILLS. SO I REPAIRED IT OR SO I THOUGH. NOW BRING ME TO LAST YEAR 2014 I STILL EXPERIENCE ALL THAT PULL WHEN TRAVELING BUT NOW MY SPEEDOMETER WAS GOING CRAZY AND WOULD JUST GO UP TO 100 MPH AS I WAS SITTING AT A STOP LIGHT/SIGN. FAST FORWARD TO AUGUST 2014 WHEN I HAD THE SPEED SENSOR CHANGED...AND NOW I'M IN MARCH 2015 AND AGAIN MY CAR PULLS, ME SPEEDOMETER GOES CRAZY. WELL AS I WAS DRIVING WITH MY TWO CHILDREN IN THE CAR AGES 5 YEARS, AND 7 MONTH OLD. I WAS REAR ENDED WHILE PULLING UP TO A STOP SIGN!!! LUCKILY IT WAS JUST ENOUGH TO SCARE MY DAUGHTER AND I WAS JUST A BIT SORE THE WHOLE DAY BUT THINGS COULD HAVE BEEN WORSE! AFTER READING UP ON THE SURE MY ISSUE I AM HAVING I JUST ABOUT HAD ENOUGH! FORD NEEDS TO TAKE RESPONSIBILITY FOR FAULTY TRANSMISSIONS AND FAULTY VEHICLES!!! *TR

WHEN DRIVING ON THE HIGHWAY AND ROADWAY, SUCH AS BRIDGES THIS SUMMER, MY VEHICLE STALLED SEVERAL TIMES, LOST POWER COMING ALMOST TO A COMPLETE STOP, PUTTING MY FAMILY AND I AT RISK. WHEN I PRESSED ON THE GAS TO ACCELERATE, THE ENGINE BEGIN TO RACE, CAUSING THE "CHECK ENGINE LIGHT" TO COME ON. IT ALSO JERKED AND SKIDDED AS I TRIED TO MANEUVER THE STEERING. TO AVOID ACCIDENTS ON THESE OCCASIONS, THE VEHICLE HAD TO BE PULLED OVER AND SUBSEQUENTLY, PARKED. HIGHWAY DRIVING WAS ALSO AVOIDED MOST OF THE SUMMER FOR SAFETY AND CONCERN. THERE IS ALSO AN ISSUE WITH THE FRONT DRIVER SIDE AIRBAG, AS RECENT AS THIS SUMMER, THE SEAL BECAME DISTORTED, TWISTED AND CRACKED IN THE DASHBOARD. LASTLY, ABOUT 2 WEEKS AGO, THE REAR DOOR LOCK ON THE DRIVER SIDE NO LONGER WORKS, THE DOOR MUST BE OPENED MANUALLY FROM THE INSIDE OF THE CAR. THESE ARE VALID VEHICLE DEFECTS AND SAFETY ISSUES AND FORD MUST STEP UP AND DO THE RIGHT THING FOR ALL PARTIES OF INTEREST. *TR

THIS VEHICLE LOSE POWER AND SLOWS DOWN, IT HAPPENED ON THE EXPRESS WAY MORE THAN 5 TIMES. I WAS ALMOST REAR ENDED BY A SEMI TRUCK. I ONLY DRIVE IT ON SIDE STREETS NOW. IT POPS INTO GEAR VERY HARD, THE WRENCH LIGHT AND THE CHECK ENGINE LIGHT IS ON. IT GETS STUCK IN SECOND GEAR AND BURNS A LOT OF GAS. IT STARTED SOON AFTER THE WARRANTY RAN OUT. I HAD A LOT OF REPAIRS DONE AND THE POWER TRAIN AND ENGINE IS NOT WORKING RIGHT AS OF YET, SOMETHING IS WRONG WITH THIS FORD FUSION 06 AND A LOT OF PEOPLE ARE HAVING THE SAME PROBLEMS WITH IT. WHY DOES IT TAKE THE DEATHS OF MANY INNOCENT PEOPLE FIRST BEFORE THERE'S A RECALL? *TR

Mileage: 55,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SUDDENLY DECELERATED AND FAILED TO ACCELERATE OVER 20 MPH. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN NOTICED THAT THE WRENCH WARNING LIGHT ILLUMINATED AND DIAGNOSED THAT THE DRIVE TRAIN AND THE THROTTLE BODY FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.

Mileage: 97,000

VEHICLE IS HESITANT TO START AND GET UP PAST 5 MPH AND ENGINE LIGHT CAME ON. TOOK CAR TO LOCAL PEP BOYS WHERE THEY PLACED IT ON ENGINE MACHINE. PER PEP BOY CAR THROUGH THROTTLE BODY STUCK OPEN CODE. LOCAL DEALER CLOSED DROPPED CAR OFF FOR LOOK OVER. DEALER CONFIRMED MONDAY THAT THROTTLE BODY IS STUCK BUT STATE THAT THIS VEHICLE IS NOT A PART OF CURRENT THROTTLE BODY RECALL...IM WRITING THIS HERE SO IF FORD SHOULD DECIDE TO COVER THIS AT A FUTURE TIME I'LL BE ABLE TO FILE FOR A REFUND. *TR

Mileage: 103,000

THE FACTORY IGNITION COILS BEGAN TO SHORT AGAINST THE INTERIOR WALLS OF THE ENGINE HEAD ABOVE THE SPARK PLUGS. AS THEY SHORTED IT BURN THE POWER CONTROL MODULE (PCM). WITH NO PCM MY SPARK PLUGS FAILED TO LIGHT, CAUSING MY ENGINE BECOME FLOODED WITH GASOLINE, WHICH WASHED AWAY THE LUBRICANTS ON MY CYLINDER AND HEADS CAUSING ALL OF MY CYLINDERS AND HEADS TO BECOME DAMAGED. AS THIS HAPPENED BEFORE I WAS ABLE TO PULL OVER MY ENGINE SHUT OFF. CAUSING ME TO LOSE POWER STEERING AND ALL OF THE OTHER ELECTRICAL FUNCTIONING COMPONENTS. LUCKILY I WAS ON A FAIRLY QUIET ROAD AND AT SOMEWHAT LOW SPEEDS, BUT FOR THE MANY OTHERS THAT HAVE OR COULD EXPERIENCE THE SAME PROBLEM MIGHT NOT HAVE BEEN OR BE AS LUCKY. 2006 FORD FUSION 3.0L V6. *TR

Mileage: 70,020

CAR STARTED KNOCKING GO SLOW THAN WOULD SPEED UP, BRAKES WOULD WORK THAN NOT! GOT HOME CHECKED THE OIL IT WAS LOW, WHICH WAS FINE A WEEK BEFORE THAT. PUT OIL IN IT, MY SON SAW IT LEAKING AROUND OIL PAN. SO HAD IT TOWED TO A CAR REPAIR CHECKED IT OUT, THEY ARE TELLING ME IT'S THE TIMING CHAIN, NOW THEY SAY THE CODES COMING OFF THE MACHINE THEY ARE HOOKING IT UP WITH SAY IT NEEDS A NEW ENGINE. I DON'T EVEN HAVE A 100 THOUSAND MILES ON IT AND TAKE GOOD CARE OF MY CAR! *TR

Mileage: 98,375

THE MOTOR MOUNT AND BRACKETS BROKE AS I DROVE ON A LOCAL STREET AT SPEED OF 25 MPH. IT WAS THE WRONG DESIGN FOR THIS VEHICLE BUT THEY INSTALLED IT ANYWAY. LATER THEY DESIGNED THE CORRECT PART WHICH WAS THE ONE THE SERVICE TECH PUT IN THE CAR THAT SAME DAY,THE BILL WAS $400. *TR

Mileage: 91,206

DRIVING ON INTERSTATE 5 EVENING COMMUTE, GOING UP A HILL WHEN THE ENGINE LOST POWER, REACHING A MAXIMUM SPEED OF 20MPH WITH THE ACCELERATOR PEDAL PRESSED DOWN FULLY. THE ESC LIGHT AND A "WRENCH" LIGHT BOTH ILLUMINATED. WAS ABLE TO SAFELY EXIT THE INTERSTATE AND TURNED THE CAR OFF. AFTER A FEW MINUTES I RESTARTED WITH THE AFOREMENTIONED LIGHTS REMAINING OFF. VEHICLE RAN FINE. TOOK IT TO THE FORD DEALER THE NEXT DAY AND WAS TOLD THE THROTTLE BODY WOULD HAVE TO BE REPLACED, WHICH I REJECTED AT THE TIME. THE VEHICLE RAN FINE UNTIL 1 DAY PAST A YEAR FROM THE FIRST INCIDENT (JUNE 26, 2014). THE SAME THING HAPPENED TWICE, ONCE AT 60MPH AND AGAIN AT 40MPH. IT OCCURRED AGAIN ON JUNE 27, 2014, HOWEVER THIS TIME FROM A STOP. I BEGAN TO ACCELERATE FROM THE STOP SIGN AND BARELY MADE IT ACROSS THE INTERSECTION. EACH OCCURRENCE I TURNED THE ENGINE OFF AND RESTARTED, THE VEHICLE RAN FINE. I DID A WEB SEARCH ON THE ISSUE AND FOUND NUMEROUS OTHER FORD OWNERS ARE EXPERIENCING THE SAME THING WITH MODEL YEARS 2005, 2006 AND 2007. *TR

Mileage: 135,138

I HAVE HAD PROBLEMS WITH IT SINCE I BOUGHT IT, IT HAS PROBLEMS STARTING ESPECIALLY WHEN ITS COLD OUTSIDE. DRIVER HEATED SEAT CAUGHT FIRE AND MELTED MY SEAT, NOW MY HEATED SEAT DOESN'T WORK AND SEAT IS RUINED. TRANSMISSION IS POORLY MADE AND UNSAFE. WHILE DRIVING IT HAS PROBLEMS SHIFTING, SHOOTS THE RPMS ALL THE WAY UP. THE CAR SOUNDS LIKE ITS GOING TO BLOW UP. DOES IT MOSTLY WHEN SHOWING DOWN AND SPEEDING UP. NOT THE ONLY PERSON HAVING ISSUES, FORD NEEDS TO STOP BEING SO CHEAP AND RECALL THE 2006 HTTP://REPAIRPAL.COM/TRANSMISSION-PROBLEM-242. *TR

Mileage: 116,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STALLED AS THE TRACTION CONTROL WARNING LIGHT ILLUMINATED. THE CONTACT COASTED ONTO THE SHOULDER AND WAS ABLE TO RESTART THE ENGINE AND RESUME NORMALLY. THE DEALER PERFORMED A DIAGNOSTIC WHICH LOCATED THE FAILURE AT THE THROTTLE. THE VEHICLE WAS REPAIRED. THE COMPUTER SYSTEM AND THE THROTTLE BODY WAS REPLACED. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,189 AND THE CURRENT MILEAGE WAS 97,000. *TR

Mileage: 90,189

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 70 MPH, THE VEHICLE HESITATED AS THE ENGINE LIGHT ILLUMINATED. THE VEHICLE THEN STALLED AND FAILED TO RESTART. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE MAIN COMPUTER AND IGNITION COIL FAILED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 102,000...UPDATED 02-04-14 *BF ..

Mileage: 102,000

CAR UNEXPECTEDLY TURNS OFF WHEN IN MOTION USUALLY AFTER VEHICLE HAS BEEN IDLE AT A RED LIGHT. *JS

Mileage: 116,000

CAR STARTED MISFIRING WHILE ACCELERATING ABOUT A MONTH AGO. SOMETIMES THE KICK WAS SO MUCH IT FELT LIKE GETTING REAR ENDED. TWICE (BOTH INCIDENTS WITHIN THE SAME WEEK) THE VEHICLE WENT INTO LIMP MODE. THE FIRST TIME WAS DURING ACCELERATING TO MOVE AROUND A SLOW VEHICLE TO AVOID HITTING IT AND THE SECOND TIME THE CAR WOULD MISFIRE EVERYTIME IT REACHED 65 MPH. I STOPPED AT A RED LIGHT AND WHEN THE LIGHT TURNED GREEN THE CAR WOULDN'T RESPOND TO THE GAS PEDAL. I TURNED OFF THE CAR AND TURNED IT BACK ON AND IT STARTED WORKING AGAIN. THE CHECK ENGINE LIGHT NEVER CAME ON. FORD DIAGNOSED IT AS THE THROTTLE BODY BEING STUCK OPEN OR CLOSED. THIS SAME PROBLEM TENDS TO HAPPEN WITH THIS SAME THROTTLE BODY IN A NUMBER OF VEHICLES. *TT

Mileage: 100,000

DRIVING WITH 20 MONTH OLD CHILD AND 6 WEEK OLD CHILD WHEN CAR BEGAN RUNNING ROUGH AND ONE OF THE CHECK ENGINE LIGHTS CAME ON. THE CAR LOST POWER, IT WOULD ROUGHLY INCREASE SPEED SLOWLY WHEN I STEPPED ON THE GAS THEN SUDDENLY IT WOULD SPEED UP AND SMOOTH OUT A LITTLE, BUT WAS NOT RUNNING NORMALLY. THE AIR CONDITIONING ALSO BEGAN TO LOSE POWER. SINCE THIS CONTINUED, I MADE ARRANGEMENT TO BORROW A CAR THE SAME DAY AS I FELT THIS VEHICLE WAS UNSAFE TO DRIVE. *TR

Mileage: 93,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THERE WAS A SUDDEN LOSS OF POWER AS THE CHECK CHARGING SYSTEM WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PCM MODULE, COILS, SPARK PLUGS, AND THE INTAKE MANIFOLD GASKET NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 84,000. *TR

Mileage: 84,000

TRAVELING DOWN BUSY LOCAL HIGHWAY ABOUT 45MPH IN LATE RUSH HOUR TRAFFIC. THE CAR SUDDENLY BEGAN TO RUN VERY ROUGH AND THEN ENGINE STALLED. CHECK ENGINE LIGHT CAME ON. THE CAR HAD TO BE MANEUVERED TO THE SIDE OF THE ROAD WITH NO POWER ON VERY BUSY HIGHWAY. THERE WERE A COUPLE CLOSE CALLS BUT NO ACCIDENT THANKFULLY. THE CAR WAS TOWED TO A LOCAL DEALER. THE DEALER INDICATES THE POWER TRAIN CONTROLLER MODULE (PCM) UNIT FAILED. THIS SEEMS TO BE VERY COMMON FAILURE ON THESE CARS AND IT CAN BE DANGEROUS. *TR

Mileage: 180,000

THE ENGINE THRU A ROD RITE AFTER WARRANTY WAS EXPIRED . I ALWAYS HAD THE OIL CHANGED REGULAR FROM A CERTIFIED MECHANIC AND ALWAYS HAD REGULAR SERVICE AS DIRECTED . I HAD TO REPLACE MOTOR COSTING ME $ 5000.00 DOLLARS , I REPORTED IT TO DEALERSHIP WHERE I HAD PURCHASED ANOTHER NEW CAR FROM . THEY SAID NO RECALL WAS IN AFFECT SO THEY DID NOTHING . I WORKED FOR FORD AND HAVE ALWAYS BEEN A FORD OWNER , BUT SINCE I COULD NEVER GET MY MONEY BACK OUT OF THIS VEHICLE WITH ALL I HAVE INVESTED IN IT I WILL PROBABLY NEVER BUY A FORD AGAIN !!!! NOT TO MENTION I HAD TO REPLACE A COMPUTER PART UNDER THE DASH THAT COULD ONLY BE DONE BY DEALERSHIP , COSTING ME $500.00 MORE . NOW MY TRANSMISSION IS SHIFTING HARD IN 3RD GEAR . WHAT A PIECE OF [XXX] !!!!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 70,000

MY FORD FUSION V6 SEL HAS BEEN SLIPPING SINCE 50,000 MILES. I HAVE HAD 2 MINOR TRANSMISSION CHANGES WITHIN THE PAST 3 YEARS. TODAY ME AND MY KIDS WERE DRIVING ABOUT 20-35 MPH AROUND TOWN WHEN THE TRANSMISSION SLIPPED. THE CAR WOULD NOT RESPOND TO ACCELERATING ON THE GAS PEDAL. I TRIED PLACING THE CAR INTO LOW GEAR, REVERSE WITH NOTHING HAPPENING. THIS WAS ON A BUSY INTERSECTION, THE CAR FINAL AFTER FORCING ME AND MY KIDS TO JERK FORWARD STARTED TO WORK AGAIN. EACH TIME I STOPPED AT A STOP LIGHT THE CAR TOOK 1-2 MINUTES TO RISE ABOVE 20 MPH. I FINALLY MADE IT TO MY HOUSE WHICH HAS A SMALL SLANT ON THE DRIVE WAY AND THE CAR STRUGGLED JUST TO MAKE IT IN THE GARAGE. THIS WAS THE MOST EMBARRASSING DAY OF MY LIFE!!!! THE CAR CLEARLY IS OUT OF WARRANTY AND EACH TIME I LOOK UP TSB'S I SEE MORE AND MORE 2006-11 FORD FUSION POSTINGS. BEING A FORD FAN MY WHOLE LIFE I MUST SAY IF NOTHING IS DONE WITH THIS COMPLAINT I WILL NO LONGER SUPPORT FORD AND WILL ENCOURAGE OTHER NOT TO AS WELL. THE NEXT STEPS ARE TO GO TO THE FORD DEALERSHIP AND DO A DIAGNOSTIC. I MAY ALSO TRY A MAJOR TRANSMISSION CHANGE, MY FEAR WOULD BE TO DO A TRANSMISSION CHANGE WITH ZERO CONFIDENCE THAT THIS WILL FIX THE PROBLEM!!! FORD MUST KEEP QUALITY AND SAFETY IN MIND WITH EVERY CAR THEY SELL ESPECIALLY A 1ST GENERATION MODEL. *TR

Mileage: 105,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS FOUND THAT THE ENGINE COIL WIRING SYSTEM HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 122,000.

Mileage: 122,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THERE WAS ALSO A VIBRATION IN THE STEERING WHEEL. THE FAILURE OCCURRED FIVE TIMES. THE VEHICLE WAS CURRENTLY BEING DIAGNOSED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.

Mileage: 79,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY LOST POWER AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 85,000. UPDATED 04/30/13*LJ

Mileage: 80,000

ERROR CODE FOR ENGINE TEMPERATURE BEING TOO LOW. THE CAUSE IS BELIEVED TO BE A THERMOSTAT STUCK OPEN. THE FIX IS A REPLACEMENT OF THE THERMOSTAT AND FORD MUST BE AWARE OF THIS PROBLEM AS THEY HAVE REPLACED THE OEM THERMOSTAT WITH A HIGHER TEMPERATURE RATED ONE. BY LOOKING AT NUMEROUS AUTOMOBILE FORUMS ON THE INTERNET THIS IS A VERY COMMON PROBLEM. *TR

Mileage: 85,000

MY TRANSMISSION IS SLIPPING A LOT. I WILL BE ACCELERATING MY SPEED AND ALL OF THE SUDDEN MY CAR ACTS LIKE IT IS IN NEUTRAL. I HAVE READ A LOT OF COMPLAINTS FROM OTHER FORD FUSION OWNERS STATING THE SAME PROBLEM. THIS NEEDS TO BE RECALLED. THIS IS VERY UNSAFE. DRIVING ON THE HIGHWAY AND THEN ALL OF THE SUDDEN YOUR TRANSMISSION SLIPS AND THERE ARE CARS AT FAST SPEEDS TRAVELING NEXT TO YOU AND BEHIND YOU IS NOT SAFE AT ALL. *TR

Mileage: 94,000

CRUISE CONTROL STARTED MALFUNCTIONING. I HAVE FIVE CONTROLS FOR MY CRUISE CONTROL. THE RESUME CRUISE JUST STOPPED WORKING. THE +SET BUTTON WHICH IS SUPPOSE TO SET CRUISE OR SPEED IT UP NOW RESUMES CRUISE. THE - SET NOW SETS THE CRUISE AND SPEEDS THE CAR UP AND NOT THE ON AND OFF ARE ONLY WORKING SOMETIMES. THIS IS A REAL SAFETY ISSUE BECAUSE MYSELF OF SOMEONE ELSE COULD HIS THE - SET BUTTON TRYING TO SLOW OUR VEHICLE DOWN AND INSTEAD OF SLOWING DOWN THE CAR SPEEDS UP. *TR

Mileage: 52,322

CAR HAS MULTIPLE ISSUES WITH HARD REVS OF THE TRANSMISSION. IT HAS CAUSED ME TO HAVE TO SLOW BECAUSE IT FEELS LIKE THE ENTIRE CAR SHIFTS SO HARD THAT IT IS GONNA BREAK APART. CAR NOW DOES NOT EVEN REV. REVIEWED HUNDREDS OF COMPLAINTS ONLINE ABOUT SAME PROBLEM WITH THE 2006 FORD FUSION AND NOTHING IS BEING DONE. IT IS HORRIBLE! SOMETHING NEEDS TO BE DONE. THERE IS NO RECALL AND EVEN AFTER REPLACING PARTS ON THE TRANSMISSION OR THE ENTIRE TRANSMISSION AS HUNDREDS HAVE SAID THEY DID, THE PROBLEM STILL OCCURS SHORTLY THERE AFTER! *TR

Mileage: 125,000