2006 FORD FUSION Power Train Problems

TL* THE CONTACT OWNS A 2006 FORD FUSION. WHILE DRIVING 65 MPH, THE TRANSMISSION ENGAGED INTO FOURTH GEAR, OVERDRIVE, AND THEN DOWNSHIFTED WITHOUT WARNING. THE DRIVER LOST CONTROL OF THE VEHICLE, BUT MANAGED TO MOVE THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS DRIVEN TO A TRANSMISSION REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION GEAR FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 133,547.

Mileage: 133,547

WHEN DRIVING ON CITY STREET AT 45MPH THE CAR JOLTED EXCESSIVELY ONCE AND THEN WENT OUT OF GEAR UNTILL IT SLOWED TO 30MPH AND SLAMMED AGAIN VIOLENTLY AND RPMS WENT UP TO 5000 WHICH MAINTANED MY SPEED AT 45MPH AT THAT TIME THE WRENCH LIGHT CAME ON AND AS I WAS COMING TO A RED LIGHT IT JERKED FORWARD WHILE I WAS BRAKING ALMOST HIT A PEDESTRIAN IN CROSSWALK. AT GREEN LIGHT I ATTEMPTED TO ACCELERATE BUT THE CAR MOVED SLOWLY UNTILL IT REACHED 25 MPH AND THEN WENT OUT OF GEAR WHILE I WAS ON THE GAS I TRIED TO PUT IT INTO LOW GEAR TO GET GOING SO I COULD PULL OVER BUT IT DIDNT RESPOND AS THIS WAS HAPPENING A DESIEL TRUCK HAD REAR ENDED ME TOTALING THE CAR I JUST BOUGHT A WEEK PRIOR. . ITS VERY UNSAFE CAR FOR THIS TRANSMISSION IS APPARENTLY PLAGUED WITH THIS PROBLEM FOR SO MANY OTHERS I JUST HOPE IT DOSENT TAKE EVEN ONE DEATH OF ANOTHER LIFE BEFORE THIS PROBLEM IS ADMITTED AND RECALLED TO FIX. SO MANY DEPEND ON THEIR CAR AS I HAD DEPENDED ON FORDS SLOGANS BUILT FORD TOUGH ...YEAH BUILT TO GET US NEARLY KILLED I SAY. THOUSANDS OF DOLLARS LOST IN THE CAR PURCHASE AND LOST WORK AND MEDICAL BILLS I MAY NOT RECOVER FROM. AT LEAST I DIDNT DIE AND AM THANKFULL FOR THAT. BUT I WILL NEVER LOOK AT FORD THE SAME WAY AS MY NIGHTMARES CONSUME ME WITH THE REOCCURRING DETAILS OF MY NEAR DEATH EXPERIENCE I HAD OPERATING THIS FUSION SE.

Mileage: 180,000

TANSMISION CUANDO DETENGO LA MARCHA Y VUEVO A PONERLA EN MARCHA GOLPEA FUERTE COMO SI SALTARA DE PRIMERA A TERCERA

Mileage: 20

TRANSMISSION SLIPPING, SHIFT EXTREMELY HARD FROM 2ND TO 3RD. FEELS AS IF THE MOTOR AND TRANNY IS GONNA FALL OUT OF THE VEHICLE.

Mileage: 209,000

MY 2006 FORD FUSION JERKS VIOLENTLY WHILE ATTEMPTING TO ACCELERATE OR BRAKE. IT DOES NOT ACCELERATE AT TIMES, IT INSTEAD JUST REVS MY RPM GAUGE. IT HAS HAPPENED ON THE HIGHWAY GOING HWY SPEEDS OF 60-70, AS WELL AS GOING 35 MPH ON A MILITARY BASE. IT BUMPED WHILE BRAKING AT SPEEDS LESS THAN 20 MPH AS WELL. FORD NEEDS TO ISSUE RECALLS ON THIS VEHICLE BECAUSE IT IS ABSOLUTELY UNSAFE, ESPECIALLY FOR CUSTOMERS WITH CHILDREN. THE AMOUNT OF COMPLAINTS SIMILAR TO MINE IS APPALLING, AS FORD STILL SEES NO RESPONSIBILITY OVER IT.

2006 FORD FUSION: TRANSMISSION SLIPPING WHILE DRIVING. SLOWS DOWN WHILE ON FREEWAY AND GOES IN OUT OF GEAR. TOOK IT TO AMMCO AND THEY RECOMMEND A REBUILT TRANSMISSION. I SEE MANY OF THE SAME COMPLAINTS THEY RECALLED FOCUS AND FIESTA WHY NOT FUSION? IT IS THE SAME ISSUE THAT IS IN BEING SETTLED NOW WITH THE FOCUS AND FORD FIESTA. THIS IS NOT ONLY DANGEROUS BUT COSTLY. I HAVE FINALLY FOUND OUT WHAT THE ISSUE IS WITH THE AISIN TRANSMISSIONS SLIPPING WHICH WERE USED IN THE 2006 FUSION HTTP://WWW.FORDTRANSMISSIONPROBLEMS.COM/FUSION-TRANSMISSION-PROBLEMS/

Mileage: 102,000

2006 FORD FUSION: WHEN DRIVING AFTER THE CAR GETS WARM UP IT IS STARTS SLIPPING AND SHIFTING SOMEONE HARSHLY LIKE IT JUST GOT KICKED. I WAS ON THE FREEWAY AND COULDN'T SPEED UP ALMOST GOT REAR ENDED. I SEE OTHERS HAVE THE SAME ISSUE AFTER DOING A SEARCH I FOUND DIFFERENT ANSWER AS WHAT COULD BE WRONG. FOUND OUT WHAT THE ISSUE IS WITH THE AISIN TRANSMISSIONS SLIPPING WHICH WERE USED IN THE 2006 FUSION. IT IS DUE TO VALVE BORE WEAR IN THE MAIN CONTROL. IF THE TRANS FLUID ISNT BURNT (MEANING THERE IS INTERNAL TRANS CLUTCH DAMAGE) THEN YOU ARE LOOKING AT $800-$1000 TO REPLACE THE MAIN CONTROL. IF THE CLUTCHES ARE BURNT THE WHOLE TRANS WILL HAVE TO BE REPLACED COST??? SOMETHING LIKE $4000-$5000. THE PROBLEM IS THAT WHEN FORD BOUGHT THE AISIN TRANS, FORD DID NOT BUY THE SERVICE RIGHTS. SO THERE ARE NO SERVICE PARTS AVAILABLE OR TRAINING AVAIL ON HOW TO SERVICE THIS TRANS. THE ISSUE WITH THE MAIN CONTROL HAS BEEN SO COMMON THAT AISIN HAS AGREED TO SUPPLY FORD WITH SERVICE MAIN CONTROLS.THERE HAS BEEN A TECHNICAL SERVICE BULLETIN OUT THERE. SEE BELOW TSB BULLETIN DATE: FEB 2007 VARIOUS DRIVEABILITY/TRANSMISSION SYMPTOMS - PCM/TCM CALIBRATION UPDATES 3.0L - AISIN F21 AUTO TRANS. ( NHTSA ITEM NUMBER - 10021277 ) AS ONE PERSON POSTED. FORD NEEDS TO MAKE THIS RIGHT!!! VERY UNSAFE*** OUR CAR IS PARKED IN THE GARAGE WE CAN NOT AFFORD TO FIX IT OR SELL IT WITH A BAD TRANSMISSION .AMMCO SAID NEEDS NEW TRANSMISSION.

Mileage: 102,000

OUR 2006 FUSION SEL'S TRANSMISSION HAS BEEN SLIPPING OUT OF GEAR SINCE AROUND 44K MILES. WHILE IN FORWARD MOTION, REGARDLESS OF THE CURRENT SPEED OR RPMS THE TRANSMISSION SLIPS OUT OF GEAR AND THE FOLLOWING MAY HAPPEN, SOMETIMES ALL IN THE SAME OCCURRENCE: (1) A SUDDEN TRANSMISSION SURGE THEN A JERK RESULTING IN HIGH REVVING RPMS WITH NO FORWARD POWER. THE GAS PEDAL ONLY REVS THE ENGINE WITH NO FORWARD ACCELERATION (2) A SUDDEN GRAB/SLAM OUT OF AND BACK INTO GEAR JOLTING ANYONE IN THE CAR SIGNIFICANTLY (3) GEAR SLIPPAGE RESULTING IN HIGH REVVING RPM INTO THE RED ZONE, NO FORWARD ACCELERATION, AND NO RETURN TO PREVIOUS OR ANY OTHER GEAR (4) BUCKING SURGES OF ACCELERATION AND DECELERATION MAKING THE CAR IMPOSSIBLE TO CONTROL AND DRIVE SAFELY. WHILE ADVANCING FROM A COMPLETE STOP SUCH AS A STOP SIGN OR TRAFFIC SIGNAL (1) TRANSMISSION MAY NOT COME OUT OF HIGH GEAR AND CAR WILL MOVE ONLY SLOWLY UNTIL STOPPED AND RESTARTED (2) TRANSMISSION STAYS IN HIGH GEAR AND THE CAR MOVES SLOWLY ONLY TO UNCONTROLLABLY JOLT FORWARD WHILE SLAMMING INTO A LOWER GEAR. ALL OF THE ABOVE MAY OR MAY NOT BE SOLVED BY STOPPING AND RESTARTING THE CAR. THE ABOVE ISSUES HAPPEN REGARDLESS OF THE TYPE OF ROADWAY, SPEED TRAVELING, AND WHETHER THE CAR IS TRAVELING IN A STRAIGHT PATH OR TURNING. WE WERE TOLD BY A FORD DEALERSHIP THAT IT WAS A KNOWN ISSUE THAT PRESENTS ITSELF AROUND 40K MILES AND USUALLY AFTER THE WARRANTY HAD EXPIRED. ESTIMATES TO REPAIR RANGED FROM $2,500 TO $4,500. IN ADDITION TO THE REPAIR COSTS, THERE IS THE MUCH HIGHER POTENTIAL COSTS OF LOST LIVES DUE TO THE LACK OF CONTROL THIS ISSUE PUTS THE DRIVER IN. WHEN A DRIVER IMMEDIATELY HAS NO CONTROL OF FORWARD MOMENTUM AND SUDDENLY HAS NO WAY TO DIRECT THE VEHICLE TO A SAFE LOCATION AT CURRENT TRAFFIC SPEEDS, THERE IS A SUDDEN POTENTIAL FOR LOSS OF LIVES FOR THE OCCUPANTS OF THE CAR AND POTENTIALLY THE VEHICLES FOLLOWING BEHIND.

TL* THE CONTACT OWNS A 2006 FORD FUSION. WHILE DRIVING BETWEEN 20-38 MPH, THE VEHICLE FAILED TO SHIFT GEARS, JERKED SEVERELY, AND THE CHECK ENGINE AND TRANSMISSION WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO ANDERSON FORD LINCOLN (3601 STOCKTON HILL RD, KINGMAN, AZ 86409, (928) 757-3131) WHERE IT WAS DIAGNOSED THAT THE 4TH AND 5TH GEARS WERE INCORRECT. WHILE THE VEHICLE WAS AT THE DEALER FOR THE GEAR REPAIRS, IT WAS ALSO DIAGNOSED THAT THE VALVE BODY AND SOLENOIDS NEEDED REPLACEMENT, AND THE PCM AND TCM NEEDED REPROGRAMMING. ALL THE REPAIRS WERE COMPLETED, BUT THE FAILURE RECURRED. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT TRANSMISSION FACILITY WHERE IT WAS DIAGNOSED WITH THE SAME FAILURE AND PARTS AS THE DEALER. THE CONTACT STATED THAT THE VEHICLE WAS ONCE AGAIN REPAIRED, BUT THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT TRANSMISSION FACILITY WHERE IT WAS DIAGNOSED THAT THE ENTIRE TRANSMISSION NEEDED REPLACEMENT AND THE FAILURE WAS A KNOWN ISSUE WITH FORD. THE CONTACT STATED THAT THE TRANSMISSION WAS NOT REPLACED BECAUSE HE ALREADY SPENT MONEY TO HAVE THE TRANSMISSION REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. THE VIN WAS UNKNOWN.

Mileage: 100,000

ENGINE JERKS WHEN ACCELERATING OR DRIVING AND SOMETIMES WHEN VEHICLE IS IDLE

Mileage: 132,465

SEAT BELT ON PASSENGER SIDE LIGHT WANT GO OUT....ENGINE LIGHT STAYS ON...HUM SENT A MESSAGE FEB 1ST STATINGPOWER TRAIN 1 ALERT.

WRENCH LIGHT APPEARED ON DASH AND WHILE DRIVING THE CAR ON THE CITY STREETS THE CAR HAS A SLUGGISH START AND THEN A BIT OF A BURST AND THEN LIGHT POWER AS I ACCELERATE. ALSO I HAVE HAD TO CHANGE DOOR HANDLES AND LOCKS 3 TIMES SINCE I HAVE PURCHASE. THE HANDLES JUST SNAP OFF. THE CAR WILL UNLOCK BUT I HAVE TO MANUALLY LOCK MOST LOCKS AND OPEN THE CAR BY PUTTING DOWN THE WINDOW.

Mileage: 100,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. WHILE ACCELERATING FROM A STOP, THE VEHICLE'S SPEED INCREASED VERY SLOWLY AND SHIFTED ABNORMALLY. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE ON THE REBUILT ENGINE WAS APPROXIMATELY 90,000 AND THE VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 152,000.

Mileage: 152,000

VEHICLE AFTER WARMING UP AND PUT IN GEAR WILL ONLY MOVE FORWARD VERY SLOWLY TAKES SEVERAL MINUTES BEFORE I CAN GET A ACCEPTABLE FORWARD MOTION. CAN NOT GO IN TRAFFIC AS CAR ONLY MOVES AT A VERY SMALL RATE OF SPEED. EVENTUALLY IT WILL GO INTO THE NORMAL MODE FOR DRIVING CAR FORWARD..

Mileage: 165,000

IN 2013 I EXPERIENCED A LOSS OF SPEED/POWER ON MY 2006 FORD FUSION. I PULLED INTO A PARKING SPACE AT A SHOPPING CENTER AND TURNED THE CAR OFF. WHEN THE INCIDENT HAPPENED THE WRENCH LIGHT AND THE TRACTION LIGHT WHERE LIT ON THE DASHBOARD DISPLAY. WHEN I STARTED THE CAR BACK UP THE LIGHTS WERE OFF ON THE DASHBOARD AND THE CAR SEEMED TO RUN FINE. I DID NOT HAVE ANOTHER INCIDENT UNTIL 2014. THIS TIME THE CHECK ENGINE LIGHT CAME ON AS WELL AS THE WRENCH AND TRACTION LIGHTS. I TOOK IT AND HAD A DIAGNOSTIC DONE AND WAS TOLD IT WAS THE P CODE INDICATING THE THROTTLE. I DROVE THE CAR BACK HOME AND LOOKED UP THE P CODE AND FOUND HUNDREDS OF COMPLAINTS REGARDING THIS PART. IT WAS ALSO BEING SAID THAT THIS PART WAS DEFECTIVE AND THAT FORD HAD ISSUED A 10 YEAR EXTENDED WARRANTY (FROM TIME OF PURCHASE) ON THE PART. AGAIN, AFTER STARTING THE CAR THE NEXT DAY IT WAS RUNNING FINE, NO CHECK ENGINE LIGHT OR ANY OTHER LIGHTS ON. IT RAN FINE UNTIL JUNE 2015. AT THIS POINT I HAD HAD ENOUGH AND CALLED THE FORD DEALERSHIP WHERE I PURCHASED THE CAR. MIND YOU, MY CAR ONLY HAS 51K ORIGINAL MILES. I MADE AN APPOINTMENT AND DROPPED IT OFF ON JUNE 24TH, 2015. I WAS CALLED THAT DAY AND TOLD THAT FORD WOULD NOT BE COVERING THE THROTTLE BODY BECAUSE MY VIN# WAS NOT ONE LISTED. I QUESTIONED THIS BECAUSE THE INFORMATION I FOUND REGARDING THE WARRANTY FOR THE PART DIDN'T MENTION SPECIFIC VINS ONLY. THE SERVICE PERSON STATED THAT THEY WOULD FIX IT BUT ONLY IF I PAID FOR THE THROTTLE BODY PART AND LABOR. I PICKED THE CAR UP TODAY, JUNE 25TH, 2015 AND PAID A SHOCKING 788.94 FOR THIS PART AND LABOR AND THE 39.99 OIL CHANGE AND TIRE ROTATION SPECIAL. THIS IS INSANE. I WAS NOT IN A CRASH OR WRECK HOWEVER IT DID SURGE AND DROP SPEED TO 20 MILES AN HOUR WITH CARS BEHIND ME SLAMMING ON BREAKS. WHEN WILL FORD DECIDE TO DO THE RIGHT THING AND COVER THE COST OF THIS PART/REPAIR, WHEN SOMEONE IS KILLED?

Mileage: 49,000

WHEN DRIVING THE WRENCH LIGHT COMES ON AND THE CAR LOOSES POWER. I CAN'T ACCELERATE. IF I PULL OFF THE ROAD AND TURN OFF THE CAR AND TURN IT BACK ON IT FIXES IT. SOMETIMES THE CHECK ENGINE LIGHT COMES ON AFTER THAT.

Mileage: 96,500

WHEN PRESSING THE GAS PEDAL TO ACCELERATE TO MERGE ON TO THE HIGHWAY THE CAR JERKED AND THEN WILL NOT GO ANYWHERE THE MOTOR JUST REAVES UP. UNTIL YOU PULL OVER AND TURN IT OFF AND RESTART IT IS THE ONLY WAY TO GET IT TO MOVE AGAIN.

Mileage: 70,000

THE VEHICLE JERKS WHEN CHANGING GEARS OR ENTERING OVERDRIVE AT HIGHER SPEEDS, SOMETIMES VERY VIOLENTLY, OCCASIONALLY RESULTING IN COMPLETE LOSS OF POWER UNTIL CAR IS SHIFTED INTO NEUTRAL AND BACK INTO GEAR. AT LOW SPEEDS VEHICLE HAS VERY ROUGH GEAR TRANSITION WHEN BRAKING.

Mileage: 45,000

IN 2013 I EXPERIENCED A LOSS OF SPEED/POWER ON MY 2006 FORD FUSION. I PULLED INTO A PARKING SPACE AT A SHOPPING CENTER AND TURNED THE CAR OFF. WHEN THE INCIDENT HAPPENED THE WRENCH LIGHT AND THE TRACTION LIGHT WHERE LIT ON THE DASHBOARD DISPLAY. WHEN I STARTED THE CAR BACK UP THE LIGHTS WERE OFF ON THE DASHBOARD AND THE CAR SEEMED TO RUN FINE. I DID NOT HAVE ANOTHER INCIDENT UNTIL 2014. THIS TIME THE CHECK ENGINE LIGHT CAME ON AS WELL AS THE WRENCH AND TRACTION LIGHTS. I TOOK IT AND HAD A DIAGNOSTIC DONE AND WAS TOLD IT WAS THE P CODE INDICATING THE THROTTLE. I DROVE THE CAR BACK HOME AND LOOKED UP THE P CODE AND FOUND HUNDREDS OF COMPLAINTS REGARDING THIS PART. IT WAS ALSO BEING SAID THAT THIS PART WAS DEFECTIVE AND THAT FORD HAD ISSUED A 10 YEAR EXTENDED WARRANTY (FROM TIME OF PURCHASE) ON THE PART. AGAIN, AFTER STARTING THE CAR THE NEXT DAY IT WAS RUNNING FINE, NO CHECK ENGINE LIGHT OR ANY OTHER LIGHTS ON. IT RAN FINE UNTIL JUNE 2015. AT THIS POINT I HAD HAD ENOUGH AND CALLED THE FORD DEALERSHIP WHERE I PURCHASED THE CAR. MIND YOU, MY CAR ONLY HAS 51K ORIGINAL MILES. I MADE AN APPOINTMENT AND DROPPED IT OFF ON JUNE 24TH, 2015. I WAS CALLED THAT DAY AND TOLD THAT FORD WOULD NOT BE COVERING THE THROTTLE BODY BECAUSE MY VIN# WAS NOT ONE LISTED. I QUESTIONED THIS BECAUSE THE INFORMATION I FOUND REGARDING THE WARRANTY FOR THE PART DIDN'T MENTION SPECIFIC VINS ONLY. THE SERVICE PERSON STATED THAT THEY WOULD FIX IT BUT ONLY IF I PAID FOR THE PART AND LABOR. I PICKED THE CAR UP TODAY, JUNE 25TH, 2015 AND PAID A SHOCKING 788.94 FOR THIS PART AND LABOR AND THE 39.99 OIL CHANGE AND TIRE ROTATION SPECIAL. THIS IS INSANE. I WAS NOT IN A CRASH OR WRECK HOWEVER IT DID SURGE AND DROP SPEED TO 20 MILES AN HOUR WITH CARS BEHIND ME SLAMMING ON BREAKS. WHEN WILL FORD DECIDE TO DO THE RIGHT THING AND COVER THE COST OF THIS PART/REPAIR, WHEN IT'S TO LATE AND SOMEONE IS KILLED??

Mileage: 32,000

WAS ON THE FREEWAY IN TRAFFIC. CAR STARTING SURGING AND WAS HARD TO KEEP IT IN A STOPPED POSITION. ONCE TRAFFIC STARTED FLOWING, I STEPPED ON GAS AND WOULD HAD NO POWER COULD NOT ACCELERATE PAST 20 MILES AN HOUR. CAR WAS TOWED TO SHOP. DEALER SAID IT WAS THE THROTTLE BODY. I RESEARCHED AND FORD HAS HAD THIS PROBLEM ON THEIR CARS, BUT SAID MINE IS NOT INCLUDED EVEN THOUGH I FELL INTO THE 10 YEAR UNDER 150,000 MILES. THEY SAID MY VIN IS NOT COVERED.

Mileage: 65,000

MY 06 FUSION HAS BEEN SHIFTING FUNNY, BUT I DIDN'T KNOW WHAT IT WAS. WHILE HAVING MY OIL CHANGED, I HAD A 6 POINT INSPECTION DONE, AND NOTHING CAME BACK EXCEPT MY TIE-RODS NEEDING REPLACED. ONE NIGHT, WHILE DRIVING HOME, SUDDENLY MY CAR HAD A HESITATION WHEN SHIFTING INTO SECOND GEAR. IT WOULD REV UP TO 3 RPM, THEN SHIFT HARD INTO 2ND GEAR AND RUN FINE. TWO STOP LIGHTS LATER, THE SHIFT BEGAN TO GET HARDER. I FINALLY MADE IT HOME, BUT LATER HAD TO RUN AN ERRAND. THE SHIFTING GOT WORSE. NOW, IT WAS AS IF I WAS ABOUT TO GET A NECK INJURY FROM THE SHIFTING FROM 1ST TO 2ND GEAR. I REALIZED THAT I NEEDED TO GET HOME, BECAUSE IT WAS TOO LATE TO GO TO THE DEALERSHIP. WHEN HEADING TO WORK THE NEXT MORNING, THE WRENCH LIGHT POPPED UP ON THE DASHBOARD. LIVING ONLY 7 MINUTES FROM WORK, I THOUGHT I WAS FINE. BUT NOW, I NO LONGER MADE IT TO 2ND GEAR. IT STAYED ON FIRST, AND REMAINED REVVED UP TO THE POINT IT WAS LOSING POWER. I WAS SCARED THAT I WAS GOING TO GET STUCK IN THE MIDDLE OF THE ROAD. NOW, WITH MY VEHICLE IN THE SHOP, I'M BEING TOLD THAT THE TRANSMISSION NEEDS AN OVERHAUL. THE COST IS $2800. WHEN IS THE RECALL GOING TO COME INTO PLAY?

Mileage: 135,000

CAR DIES WHILST DRIVING. THIS IS A SAFETY ISSUE. AUTHORIZED FORD DEALER SERVICE DETERMINED ISSUE WAS CAUSED BY A DEFECTIVE THROTTLE BODY. *TR

Mileage: 78,333

TL*THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 75 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE SPEED WOULD DECREASE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE VARIABLE VALVE SOLENOIDS, THE IGNITION COILS, THE PCM REFLASH AND THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

Mileage: 98,000

TRANSMISSION STARTED SLIPPING AND THEN FAILED COMPLETELY.HAD TO HAVE CAR TOWED TO DEALER.THEY SAY IT NEEDS TRANSMISSION REPLACED.THEY SAY RUST CAUSED A HOLE IN TUBING AND FLUID RAN OUT.CAR HAS JUST MORE THAN 73,000 MILES ON IT.CAR SERVICED ROUTINELY,NOT DRIVEN IN BAD WEATHER MUCH.

Mileage: 73,400

MY 2006 FORD FUSION WITH A 3.0 V6 AND AUTOMATIC TRANSMISSION HAS HAD THE FOLLOWING SAME ISSUES OVER THE PAST 18 MONTHS: - LOSES POWER AT CITY, HIGHWAY AND PARKING LOT SPEEDS WITHOUT WARNING .... AT LEAST A HALF-OF-DOZEN TIMES - ENGINE STILL IDLES/RUNS ROUGH, BUT WILL NOT ACCELERATE BEYOND 15-20 MPH - WRENCH LIGHT INDICATOR COMES ON, (SOMETIMES ENGINE LIGHT TOO). WHEN I TURN THE ENGINE OFF AND RESTART THE VEHICLE, IT WILL OPERATE FINE MOST THE TIMES. IT HAS DONE IT REPEATEDLY A COUPLE OF TIMES. THE WRENCH LIGHT INDICATOR WILL GO OFF AFTER RESTART, BUT THE CHECK ENGINE LIGHT WILL REMAIN ON FOR A COUPLE OF DAYS THEN GO OUT. - FORD CLAIMS THAT THE 2006 FUSION IS NOT COVERED UNDER CUSTOMER SATISFACTION PROGRAM #13N03 WHICH COVERS NEWER FUSIONS AND OTHER FORD MODELS. FORD ADVISE TO HAVE THE REPAIR MADE AND THEY WILL REIMBURSE CUSTOMERS OF THE REPAIR EXPENSE AT A FUTURE DATE, IF FORD SHOULD EVER ISSUE A CSP PROGRAM FOR THE 2006 FUSION. - I HAVE HAD THIS HAPPEN AT HIGHWAY SPEEDS ON INTERSTATE HIGHWAYS AND RURAL HIGHWAYS WITHOUT SHOULDERS TO PULL OVER. THIS IS OBVIOUSLY A DANGEROUS SITUATION AND NEEDS TO BE RECTIFIED ASAP. - I HAVE HAD SEVERAL INCIDENTS WHERE I WAS ALMOST HIT FROM BEHIND DUE TO THIS ISSUE AND IT'S JUST A MATTER OF TIME BEFORE SOMEONE IS SERIOUSLY INJURED DUE TO THIS ISSUE. MY RESEARCH SHOWS THAT THIS IS AN ONGOING PROBLEM FOR PEOPLE WITH CERTAIN FORD PRODUCTS. - FORD.....DUE THE RIGHT THING AND MAKE IT RIGHT FOR ALL! *TR

Mileage: 112,000

THIS VEHICLE LOSE POWER AND SLOWS DOWN, IT HAPPENED ON THE EXPRESS WAY MORE THAN 5 TIMES. I WAS ALMOST REAR ENDED BY A SEMI TRUCK. I ONLY DRIVE IT ON SIDE STREETS NOW. IT POPS INTO GEAR VERY HARD, THE WRENCH LIGHT AND THE CHECK ENGINE LIGHT IS ON. IT GETS STUCK IN SECOND GEAR AND BURNS A LOT OF GAS. IT STARTED SOON AFTER THE WARRANTY RAN OUT. I HAD A LOT OF REPAIRS DONE AND THE POWER TRAIN AND ENGINE IS NOT WORKING RIGHT AS OF YET, SOMETHING IS WRONG WITH THIS FORD FUSION 06 AND A LOT OF PEOPLE ARE HAVING THE SAME PROBLEMS WITH IT. WHY DOES IT TAKE THE DEATHS OF MANY INNOCENT PEOPLE FIRST BEFORE THERE'S A RECALL? *TR

Mileage: 55,000

WHILE DRIVING ON THE SUNCOAST PKWY AT 60 MPH MY VEHICLE SUDDENLY SLOWED TO ONLY 20 MPH CAUSING ME TO BE A ROAD HAZARD. I WAS NEARLY KILLED BY THE OTHER CARS IN THE FLOW . IT WAS A FRIGHTENING EXPERIENCE. *TR

Mileage: 97,780

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SUDDENLY DECELERATED AND FAILED TO ACCELERATE OVER 20 MPH. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN NOTICED THAT THE WRENCH WARNING LIGHT ILLUMINATED AND DIAGNOSED THAT THE DRIVE TRAIN AND THE THROTTLE BODY FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.

Mileage: 97,000

WHILE SHIFTING FROM HIGHER GEAR TO LOWER GEAR WHILE CLIMBING A HILL, TRANSMISSION JUMPED BETWEEN GEARS, SLAMMING THE GEARS AS IF POPPING A CLUTCH (IT'S AN AUTOMATIC TRANSMISSION). ON ANOTHER HILL, THE VEHICLE DID NOT ENGAGE IN THE LOWER GEAR, REVVING UP TO ABOUT 4000 RPM AS IF IN NEUTRAL, LEAVING THE CAR DECELERATING ON THE UPHILL STRETCH AMONG SPEEDING TRAFFIC. I HAD TO MOVE THE GEAR SHIFT TO NEUTRAL AND BACK TO DRIVE, EASE ON THE ACCELERATOR, AND THE LOWER GEAR ENGAGED, AFTER SLOWING TO ABOUT 35 ON 65 MPH SPEED LIMIT FREEWAY. FORD LISTS THE REPAIR IN TSB 08-24-1 AS "TRANSMISSION HARSH SHIFTING" AND RECOMMENDS REPLACEMENT OF THE MAIN CONTROL. THIS PART HAS BEEN IDENTIFIED AS FAULTY AND COMMON WITH THE TRANSMISSIONS INSTALLED ON MY VEHICLE AND MANY OTHER MAKES AND MODELS. IT PRESENTS A CLEAR DANGER TO DRIVERS AND PASSENGERS WHO RISK BEING REAR-ENDED DUE TO SUDDEN DECELERATION OR STRANDED DUE TO "HARSH SHIFTING" DAMAGE TO THE TRANSMISSION AND DRIVE TRAIN. I HAVE NO CONFIDENCE DRIVING THE CAR OUT OF TOWN OR NEAR ANY HILL, AND THE VEHICLES SHOULD BE RECALLED. *TR

Mileage: 51,320

I WAS TRYING TO ACCELERATE TO MERGE ON TO THE FREEWAY. MY 2006 FORD FUSION REFUSED TO RESPOND. THE REVS WENT UP TO 4000 RPM AND THE CAR JUST STAYED THERE GOING VERY SLOWLY. AFTER A FEW SECONDS, IT JERKED FORWARD, SO I PULLED BACK ON THE SIDE OF THE ROAD AND LET THE "TANTRUM" PAST. I'VE HAD SEVERAL CLOSE CALLS SINCE-- THE MOST SCARY ONE OCCURRING IN STOP-AND-GO TRAFFIC. WHEN ACCELERATING AFTER SLOWING DOWN, THE FUSION WILL REV UP AND CREEP SLOWLY FORWARD UNTIL ONE REMOVES ONE'S FOOT FROM THE GAS PEDAL AND ALLOW IT TO SETTLE BACK IN GEAR. LUCKILY, I'VE AVOIDED BEING REAR-ENDED BY FAST APPROACHING CARS. RECENTLY, FORD CLEANED THE THROTTLE BODY AND CHARGED $232.00, I STILL HAVE THE SAME PROBLEM AND AM STILL WAITING FOR A RECALL ON THIS VEHICLE. INCIDENTALLY, THE STALLING ALSO HAPPENS AFTER MAKING A RIGHT OR LEFT HAND TURN. *TR

Mileage: 35,700

VEHICLE IS HESITANT TO START AND GET UP PAST 5 MPH AND ENGINE LIGHT CAME ON. TOOK CAR TO LOCAL PEP BOYS WHERE THEY PLACED IT ON ENGINE MACHINE. PER PEP BOY CAR THROUGH THROTTLE BODY STUCK OPEN CODE. LOCAL DEALER CLOSED DROPPED CAR OFF FOR LOOK OVER. DEALER CONFIRMED MONDAY THAT THROTTLE BODY IS STUCK BUT STATE THAT THIS VEHICLE IS NOT A PART OF CURRENT THROTTLE BODY RECALL...IM WRITING THIS HERE SO IF FORD SHOULD DECIDE TO COVER THIS AT A FUTURE TIME I'LL BE ABLE TO FILE FOR A REFUND. *TR

Mileage: 103,000

AS REPORTED MULTIPLE TIMES THESE TRANSMISSIONS BEGIN TO SLIP VERY BADLY. WHILE TRYING TO MERGE INTO TRAFFIC ALMOST 90% OF THE TIME HOT OR COLD AT ABOUT 40MPH WHEN YOU PRESS THE GAS THE TRANSMISSION WILL SLIP LEAVING YOU HANGING OUT TO DRY(THIS IS EXTREMELY DANGEROUS)...WHEN DOWNSHIFTING SOMETIMES AROUND 20MPH THERE WILL BE A LOUD BANGING UNDER THE DRIVERS SIDE AREA...THE TSB WAS ISSUED WAY BACK IN 2007 REGARDING ALL THESE ISSUES BUT NO RECALL...THE FLOOR MATS WERE RECALLED? BUT NOT THIS ISSUE. ALL OVER THE INTERNET YOU SEE THE INSANE AMOUNT OF PEOPLE HAVING THIS SAME ISSUE DUE TO THE AISIN TRANSMISSION THEY USED....SAME PROBLEM OCCURRED IN MULTIPLE MAKES AND MODELS OF VEHICLES WITH SAME TRANSMISSION COMPONENTS. THEY SAY REPLACE THE TRANSMISSION "VALVE BODY" OR AKA CONTROL ASSEMBLY...ITS ONLY $2,000 IF YOU HAVEN'T ALREADY BURNT UP THE WHOLE TRANSMISSION THEN ITS $4-5K. *TR

Mileage: 57,000

DRIVING ON INTERSTATE 5 EVENING COMMUTE, GOING UP A HILL WHEN THE ENGINE LOST POWER, REACHING A MAXIMUM SPEED OF 20MPH WITH THE ACCELERATOR PEDAL PRESSED DOWN FULLY. THE ESC LIGHT AND A "WRENCH" LIGHT BOTH ILLUMINATED. WAS ABLE TO SAFELY EXIT THE INTERSTATE AND TURNED THE CAR OFF. AFTER A FEW MINUTES I RESTARTED WITH THE AFOREMENTIONED LIGHTS REMAINING OFF. VEHICLE RAN FINE. TOOK IT TO THE FORD DEALER THE NEXT DAY AND WAS TOLD THE THROTTLE BODY WOULD HAVE TO BE REPLACED, WHICH I REJECTED AT THE TIME. THE VEHICLE RAN FINE UNTIL 1 DAY PAST A YEAR FROM THE FIRST INCIDENT (JUNE 26, 2014). THE SAME THING HAPPENED TWICE, ONCE AT 60MPH AND AGAIN AT 40MPH. IT OCCURRED AGAIN ON JUNE 27, 2014, HOWEVER THIS TIME FROM A STOP. I BEGAN TO ACCELERATE FROM THE STOP SIGN AND BARELY MADE IT ACROSS THE INTERSECTION. EACH OCCURRENCE I TURNED THE ENGINE OFF AND RESTARTED, THE VEHICLE RAN FINE. I DID A WEB SEARCH ON THE ISSUE AND FOUND NUMEROUS OTHER FORD OWNERS ARE EXPERIENCING THE SAME THING WITH MODEL YEARS 2005, 2006 AND 2007. *TR

Mileage: 135,138

WAS DRIVING DOWN A BUSY HIGHWAY WHEN THE CAR JUST CHUGGED AND DIED. THE TOOL LIGHT CAME ON AFTER IT FAILED TO GO BY GIVING IT GAS.THIS IS THE SECOND TIME THIS HAS HAPPENED TO MY CAR. I TOOK IT TO MY FORD DEALERSHIP AND IT TURNED OUT TO BE THE THROTTLE BODY. I AM VERY UPSET AND BEING A WOMEN I HAD NO IDEA HOW TO HANDLE THIS SITUATION WHEN IT HAPPENED. IT HAS COST ALOT OF MONEY TO REPLACE AND IT IS VERY DANGEROUS. IS THERE A RECALL ON THIS PART ? IF SO I WOULD LIKE TO KNOW ABOUT IT. *TR

Mileage: 97,000

WHEN I WAS DRIVING 55 MPH, THE CAR DID A LITTLE JERK LIKE IT HAD MISSED. NO LIGHTS CAME ON AND I DROVE TO THE NEAREST SIDE ROAD OFF THE HIGHWAY AND STOPPED. I TRIED TO GO FURTHER BUT ONLY MADE IT ABOUT 100 YARDS BECAUSE I LOST ALL POWER INCLUDING STEERING. MY CAR WAS HALF IN THE ROAD SO I WAS THANKFUL THIS WAS NOT A HIGH TRAFFIC ROAD. THE ENGINE LIGHT CAME ON AND THERE WAS A SMELL. IT WASN'T THE SMELL OF OIL BUT WAS A FLUID SMELL. THE CAR WOULD NOT TURN OVER AND HAD TO BE TOWED TO THE DEALERSHIP. IT CAME UP AS A MISFIRE 3 AND THEY TOLD ME THAT THEY HAD TO REPLACE THE COIL. THIS DID NOT FIX THE PROBLEM AND THEY SAID THE 3 COIL WHEN IT BLEW IT TOOK OUT THE OTHER COILS AS WELL AS THE 6 SPARK PLUGS AND THE PCM. THIS WAS A $2250 REPAIR. I ONLY HAVE 68,000 ON THE CAR. AFTER READING OTHER TSB, SOME STATED THAT IF UNDER 80,000 MILES/8 YEARS THAT IT WAS COVERED UNDER THE MANUFACTURE WARRANTY. I CALLED FORD AND WAS TOLD I MISSED THE 8 YEAR MARK BY EXACTLY 30 DAYS. THERE WAS NOTHING THAT I COULD DO BUT HOLD ON TO MY RECEIPTS IN CASE THERE WOULD EVER BE A RECALL. THIS IS THE ONLY MAJOR ISSUE I HAVE HAD. I HAVE NEVER HAD ANY OTHER ENGINE ISSUES WITH THE CAR. I'VE ONLY HAD 2 MINOR ISSUES BEFORE THIS AND THEY WERE THE LUMBAR GOING OUT IN THE DRIVER'S SEAT ($300 REPAIR THAT I DID NOT REPLACE) AND 2 DOOR HANDLES BREAKING FROM THE INSIDE THAT WERE $160 TO REPLACE EACH. I DID REPLACE BC OF THE SAFETY ISSUE OF NOT BEING ABLE TO GET OUT OF THE CAR. AFTER READING THE TSB, I SEE THAT THE PCM AND COILS ARE A RECURRING ISSUE AND I AM THANKFUL I WAS ON A SIDE ROAD WHEN IT OCCURRED... I AM VERY WORRIED THAT IT MAY OCCUR AGAIN AND HOPE THIS ISSUES WILL BE OR HAS BEEN LOOKED INTO FOR THE SAFETY OF OTHERS. *TR

Mileage: 68,000

TRYING TO ACCELERATE ONTO HIGHWAY, VEHICLE WOULD REV UP TO LIMIT 6K AND SLAM INTO GEAR CAUSING TIRES TO SPIN AND ALMOST LOSE CONTROL. HAVE TO PARK AND TURN OFF VEHICLE TO RESUME DRIVING. OTHERS TIME CAR WOULD JUST LOSE MOMENTUM AND RPMS GO VERY HIGH BUT NO MOVEMENT. AGAIN, PARK CAR TURN OFF AND RESUME DRIVING. WAS TOLD BY MANY MECHANICS THAT THIS IS A TRANNY PROBLEM IN THIS MODEL FORD. COST OF $2,000 TO REPAIR. SEEMS TO BE VERY COMMON AND AM JUST LOGGING MY RECORDS INCASE FORD FINALLY ACKNOWLEDGES IT. *TR

Mileage: 124,135

I HAVE HAD PROBLEMS WITH IT SINCE I BOUGHT IT, IT HAS PROBLEMS STARTING ESPECIALLY WHEN ITS COLD OUTSIDE. DRIVER HEATED SEAT CAUGHT FIRE AND MELTED MY SEAT, NOW MY HEATED SEAT DOESN'T WORK AND SEAT IS RUINED. TRANSMISSION IS POORLY MADE AND UNSAFE. WHILE DRIVING IT HAS PROBLEMS SHIFTING, SHOOTS THE RPMS ALL THE WAY UP. THE CAR SOUNDS LIKE ITS GOING TO BLOW UP. DOES IT MOSTLY WHEN SHOWING DOWN AND SPEEDING UP. NOT THE ONLY PERSON HAVING ISSUES, FORD NEEDS TO STOP BEING SO CHEAP AND RECALL THE 2006 HTTP://REPAIRPAL.COM/TRANSMISSION-PROBLEM-242. *TR

Mileage: 116,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IDLE, IT RESPONDED AS IF IT WAS SHUTTING DOWN. WHEN GASOLINE WAS ADDED TO THE VEHICLE, IT ONLY ACCELERATED UP TO 5 MPH. THE VEHICLE HAD TO BE SHUT DOWN AND RESTARTED IN ORDER TO REGAIN PROPER ACCELERATION. THE FAILURE RECURRED THREE TIMES OVER A PERIOD OF FOUR MONTHS. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE VEHICLE HAD AN INTERNAL SHORT. THE THROTTLE BODY ASSEMBLY NEEDED TO BE REPLACED AND THE PCM RESET IN ORDER TO REPAIR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.

Mileage: 124,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IDLE, IT RESPONDED AS IF IT WAS SHUTTING DOWN. WHEN GASOLINE WAS ADDED TO THE VEHICLE, IT ONLY ACCELERATED UP TO 5 MPH. THE VEHICLE HAD TO BE SHUT DOWN AND RESTARTED IN ORDER TO REGAIN PROPER ACCELERATION. THE FAILURE RECURRED THREE TIMES OVER A PERIOD OF FOUR MONTHS. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE VEHICLE HAD AN INTERNAL SHORT. THE THROTTLE BODY ASSEMBLY NEEDED TO BE REPLACED AND THE PCM RESET IN ORDER TO REPAIR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.

Mileage: 124,000

I WAS DRIVING AT ABOUT 30MPH SUDDENLY I COULD NOT ACCELERATE AND THE CAR DIED IN THE MIDDLE IF THE ROAD LUCKILY I WAS ABLE TO PULL OFF SAFELY WITHOUT KILLING ANYONE! TOOK THE CAR TO A LOCAL MECHANIC AS WELL AS A FORD DEALER BOTH AGREED NEEDS NEW PCM AND 6 IGNITION COILS = $2000! IS IT GOING TO TAKE AN ACTUAL DEATH FOR THIS TO BE RECALLED? *TR

Mileage: 73,000

I WAS GOING HOME ON HIGHWAY (65 MPH) AND THE TRAFFIC STARTED TO SLOW DOWN AND SO I PUT ON MY BRAKE AND LOST MY POWER. IT WAS IN LIMP MODE. FORTUNATELY, I WAS IN LOW SPEED LANE AND COULD GET OVER TO THE SIDE OF HIGHWAY AND MANAGED TO PULL OFF. AFTER 5 MINUTES I WAS ABLE TO RESTART CAR AND GET HOME. THE THROTTLE BODY HAD TO BE REPLACED. THIS IS A SAFETY CONCERN. I FEEL I WAS VERY LUCKY I DID NOT GET SLAMMED INTO AND SOMEONE DID NOT GET HURT. *TR

Mileage: 65,000

COMING OFF AN EXIT RAMP AT APPROX. 35 MPH I FELT A JERKING/STALLING FEELING AS I MERGED INTO FREEWAY TRAFFIC WHERE THE SPEED LIMIT IS 65 MPH. I VIEWED MY INSTRUMENT PANEL AND FOUND THE WRENCH SYMBOL ILLUMINATED. ACCELERATION WAS SLUGGISH BRIEFLY, BUT AFTER AWHILE ACCELERATION SEEMED TO RETURN TO NORM. ALL THE WHILE THE WRENCH LIGHT REMAINED ILLUMINATED FOR AN APPROX. 25 MILES. ONCE IN A SAFE LOCATION I TURNED THE CAR OFF AND WAITED APPROXIMATELY TWO MINUTES BEFORE ATTEMPTING TO RESTART IT. UPON RESTARTING THE WRENCH LIGHT WAS NO LONGER ILLUMINATED. I DROVE THE CAR ANOTHER APPROX. 10 MILES TO MAKE IT HOME AND THE WRENCH LIGHT IS NO LONGER ILLUMINATED WHEN CAR IS RESTARTED. THIS ALL TOOK PLACE IN THE MIDST OF A SNOW/SLEET STORM. A DRIVE THAT TYPICALLY TAKES APPROX. 45 MINUTES TOOK APPROX. 4 HOURS. I CALLED THE SERVICE DEPARTMENT OF MY LOCAL FORD DEALERSHIP AND UNDERSTANDABLY I FOUND THAT THEY HAD CLOSED AND REOPENING THE NEXT DAY WAS/IS IN QUESTION DUE TO THE WEATHER. *TR

Mileage: 106,300

TL* CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE FRONT PASSENGER AND BOTH REAR INTERIOR DOOR HANDLES BECAME FRACTURED WHEN ENGAGED. IN ADDITION, THE CONTACT WAS DRIVING 55 MPH WHEN THE VEHICLE FAILED TO RESPOND TO ACCELERATION ATTEMPTS OVER 55 MPH. THE SEAT BELT MECHANISM ALSO FAILED AND THE CONTACT WAS UNABLE TO SECURE THE SEAT BELT. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE TRANSMISSION WAS REPLACED. THE INTERIOR DOOR HANDLES AND THE SEAT BELT WERE NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000.

Mileage: 55,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE WOULD SHAKE AND JERK WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A DIAGNOSTIC WAS PERFORMED, WHICH LOCATED THE FAILURE AT THE TRANSMISSION CONTROL UNIT. THE TRANSMISSION CONTROL UNIT WAS REPLACED HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS TOWED TO THE DEALER WHERE A SECOND DIAGNOSTIC WAS PERFORMED, WHICH LOCATED THE FAILURE AT THE TRANSMISSION CONTROL MODULE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 92,294 AND THE CURRENT MILEAGE WAS 104,983.

Mileage: 92,294

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE BEGAN TO VIBRATE IN A JERKING MOTION. IN ADDITION, AN ABNORMAL NOISE EMITTED OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE PCM AND POWER TRAIN MODULE WAS REPLACED UNDER THE SERVICE WARRANTY. THE FAILURE RECURRED ONE YEAR LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

Mileage: 76,000

I AM HAVING THROTTLE BODY ISSUES WITH MY FORD FUSION (2006) THE PROBLEM WAS FIRST DIAGNOSED IN 2011 AND AGAIN LAST YEAR , BOTH BY TWO DIFFERENT MECHANICS/BODY SHOPS (ONE WAS A FORD DEALER). I SAW ABOUT A MONTH AGO ON MY LOCAL NEWS OF CONSUMERS WHO ARE HAVING THE SAME ISSUES (THROTTLE BODY,CAR LOSES POWER WITHOUT NOTICE,ETC.) I EMAILED FORD TO ASK ABOUT REPAIR OR EVEN GOING HALF ON THE REPAIR FOR MY VEHICLE AS MY HOUSEHOLD IS UNABLE TO AFFORD IT DUE TO LOSS OF INCOME/JOB. I WAS TOLD THERE IS NOTHING THEY CAN DO OR WILL OFFER HOWEVER, "CERTAIN" PEOPLE ARE GETTING THEIR REPAIRS TAKEN CARE OF. FOR IT TO MAKE THE NEWS THIS ISSUE IS A BIG DEAL. I BROUGHT IT TO FORDS ATTENTION TO LET THEM KNOW THAT ITS SIMPLY NOT THE NEWER MODEL CARS THAT ARE EXPERIENCING THIS MINE, AS WELL AS A FRIENDS FORD (2008) HAVE THE SAME PROBLEM. *JS

Mileage: 145,000

I HAVE A 2006 FUSION THIS PROBLEM STARTED A YEAR AGO. FIRST MY CAR SHAKES, WHEN DRIVEN 20MPH AND TRY TO ACCELERATE IT HAS A HARD TIME PICKING UP SPEED IT MISSES. SO I HAD MY SPARK PLUGS CHANGED TWICE IN THE LAST YEAR BECAUSE I THOUGHT THAT'S WHAT WAS WRONG. I TOOK IT TO MY LOCAL GOOD YEAR AND THEY NOTICED THAT I'VE HAD MY SPARK PLUGS CHANGED WITH THEM TWICE SO, THE MECHANIC TOOK MY CAR APART AND FOUND THAT MY 5TH CYLINDER WAS BAD AND THAT IT WAS BURNING THROUGH MY COILS. 2 YEARS AGO I HAD ISSUES WITH MY BALLS JOINTS ON MY CAR FRONT TIRES FIXED IT NOW, I AM HAVING THE SAME PROBLEM MY BALL JOINTS HAVE CLAY IN THEM HOW THAT HAPPEN I DON'T KNOW. THERE IS ALSO A 3RD PROBLEM THAT I AM HAVING WITH MY TRANSMISSION. I CAME ACROSS THIS WEBSITE TO SEE IF THERE WERE ANY RECALLS FOR MY VEHICLE, OF COURSE IT WOULD BE MY LUCK NOTHING!!! I WORK FOR TOYOTA AND THEY RECALL THEIR VEHICLES ALL THE TIME FOR ANY ISSUE THEY HAVE WITH THEIR VEHICLES. I WILL NEVER BUY A FORD AGAIN!!! *JS

Mileage: 89,000

I WAS TRAVELING ON A LOCAL HIGHWAY BEHIND A SLOW MOVING TRAFFIC AT 30MPH. A CAR LET ME OVER IN TO THE LEFT TRAVELING LANE, AS I PUSHED DOWN THE GAS PADDLE TO ACCELERATE MY CAR JUMPED SEVERAL TIMES AND MADE A POPPING SOUND. IT WENT FROM 30MPH TO 0MPH AND THE CAR BEHIND ME SLAMMED ON IT'S BRAKES AND CAME WITHIN INCHES OF HITTING ME! AFTER DOING RESEARCH ONLINE LAST NIGHT (HTTP://REPAIRPAL.COM/TRANSMISSION-PROBLEM-242#), I REALIZED THAT MANY FUSION OWNERS HAVE HAD SIMILAR ISSUES, AND THAT FORD IS AWARE OF THE ISSUE WITH THE GERMAN TRANSMISSION INSTALLED IN THIS MODEL. IT WAS A VERY SCARY, LIFE THREATENING EXPERIENCE AND I CANNOT BELIEVE THAT FORD HAS NOT RECALLED 2006 FUSION KNOWING THAT THE TRANSMISSION HAS A HISTORY OF BEING FAULTY! I WAS FEARFUL FOR MY LIFE, THE LIFE OF MY PUPPY IN THE BACKSEAT, AND THE LIFE OF THE DRIVER AND OTHER DRIVERS BEHIND ME! I HAVE THIS QUESTION FOR FORD, "IS MAKING MONEY MORE IMPORTANT THAN A HUMAN LIFE?" LET'S GET THIS RIGHT AND RECALL ALL MODELS THAT HAVE THIS SPECIFIC GERMAN TRANSMISSION INSTALLED! *TR

Mileage: 86,500

TODAY WHILE TRAVELING DOWN I-40 WITH MY CHILDREN IN THE CAR MY FORD FUSION REVVED UP TO ALMOST 5 RPMS AND STARTED JERKING I STEPPED ON THE GAS AND NOTHING WAS HAPPENING JUST REVVED UP AND THEN FINALLY JUMPED INTO GEAR. AT THAT TIME WE JUST ABOUT GOT REAR ENDED BY TWO VEHICLES THAT WAS BEHIND US ON THE INTERSTATE RUNNING BETWEEN 55-60MPH. IM VERY CONCERNED ABOUT THE 2006 FORD FUSIONS TRANSMISSIONS AND BELIEVE THIS PROBLEM NEEDS TO QUIT BEING OVER LOOKED. AS OF TODAY I HAVE BEEN DOING SOME INVESTIGATING MYSELF AND APPARENTLY EVERYONE THAT OWNS A 2006 FORD FUSION HAS HAD A SIMILAR INCIDENT, L HAVE READ FORUMS AND JUST GOOGLED AND A LOT OF PEOPLE ARE HAVING THE SAME EXPERIENCES. I JUST WANT SOMETHING DONE LIKE A RECALL I BELIEVE THAT WOULD BE THE RIGHT THING TO HAVE DONE. ONE MORE THING I HAD NO IDEA MY FUSIONS TRANSMISSION WAS EVEN BAD NEVER HAD MY CAR DO ANYTHING LIKE IT DONE TODAY. THANKS *TR

Mileage: 70,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THERE WAS A SUDDEN LOSS OF POWER AS THE CHECK CHARGING SYSTEM WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PCM MODULE, COILS, SPARK PLUGS, AND THE INTAKE MANIFOLD GASKET NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 84,000. *TR

Mileage: 84,000

TRAVELING DOWN BUSY LOCAL HIGHWAY ABOUT 45MPH IN LATE RUSH HOUR TRAFFIC. THE CAR SUDDENLY BEGAN TO RUN VERY ROUGH AND THEN ENGINE STALLED. CHECK ENGINE LIGHT CAME ON. THE CAR HAD TO BE MANEUVERED TO THE SIDE OF THE ROAD WITH NO POWER ON VERY BUSY HIGHWAY. THERE WERE A COUPLE CLOSE CALLS BUT NO ACCIDENT THANKFULLY. THE CAR WAS TOWED TO A LOCAL DEALER. THE DEALER INDICATES THE POWER TRAIN CONTROLLER MODULE (PCM) UNIT FAILED. THIS SEEMS TO BE VERY COMMON FAILURE ON THESE CARS AND IT CAN BE DANGEROUS. *TR

Mileage: 180,000

WHEN I WAS PASSING A CAR ON THE HIGH WAY THE TRANSMISSION SLIPPED OUT OF GEAR. I WAS IN THE MIDDLE LANE AND LOST ALL ACCELERATION. DEAD IN THE WATER. I HAD TO PUT MY HAZARD LIGHTS ON AND PULL OVER TO THE SIDE OF THE ROAD. TURNING THE CARD ON AND OFF FIXED THE ISSUE. SINCE THAT IT HAS DONE THIS MULTIPLE TIMES. *TR

Mileage: 90,100

AT FIRST I FELT ON PREVIOUS DAY SLIPPAGE AT SLOW UPHILL DRIVING AND SOME STARTS. HUGE BANG LIKE THE BOTTOM WAS FALLING OUT OF THE CAR. LIKE I WAS REAR ENDED. THEN ON JULY 6TH WHILE ON FLAT, DRY 4 LANE AT 50 MPH IT FELT LIKE IT SLIPPED INTO NEUTRAL AND THE ENGINE REVVED UP. I TOOK FOOT OFF OF ACCELERATOR AND IT WENT BACK INTO GEAR. I HAD SOMEONE ELSE'S CHILD IN MY CAR. THIS IS DANGEROUS. I AM IN THE NC AREA TO HAVE SURGERY AND STAYING AT A FRIENDS HOUSE. I AM DISABLED TOO. I CANNOT IN ANYWAY AFFORD TO FIX THIS. I WAS A FORD EMPLOYEE WHEN I GOT THIS CAR. I LOVE FORD. ONLY HEATED SEAT AND LUMBAR PROBLEMS THAT I CAN'T FIX EITHER. I WOULD LIKE A RECALL AND HELP TO FIX THIS. PLEASE. I HAVE NO PLACE TO LIVE AND MY CAR IS ALL I OWN. PLEASE HELP.THANKS *TR

DRIVING ON THE HIGHWAY AT 65MPH WHEN THE TRANSMISSION SLIP OUT OF GEAR AND THE ENGINE STARTED TO REV UP. GOT OF TO THE SIDE OF THE RODE WHEN THERE WAS A SAFE SPOT TO LET THE TRAFFIC BEHIND US GO AROUND. I HAD MY WIFE AND TWO GRAND CHILDREN IN THE CAR NOT A SAFE POSITION TO BE IN. FORD KNOWS ABOUT THE VALVE IN ASIN TRANSMISSION. CAN NOT BELIEVE THEY WILL NOT HONOR THIS PROBLEM, WHEN THEY KNOW ABOUT IT. THE PROBLEM IS GETTING WORSE. PLEASE HELP! *TR

Mileage: 125,000

WHEN ATTEMPTING TO ACCELERATE AT A HIGHWAY SPEED, WHICH CAUSED THE CAR TO DOWNSHIFT, THE TRANSMISSION WOULD "SLIP" OUT OF GEAR, CAUSING THE RPM'S TO REV UP TO AN UNSAFE LEVEL. TO GET THE CAR BACK INTO GEAR, I HAD TO REMOVE MY FOOT FROM THE ACCELERATOR AND LET IT COAST FOR A BIT. ONCE THE RPM'S RETURNED TO BETWEEN 1000-2000, IT SLAMMED HARD INTO GEAR AND BEGAN DRIVING AGAIN. THIS OCCURS REGULARLY EVEN AT REGULAR STREET SPEEDS, WHEN YOU NEED TO ACCELERATE WHERE A DOWNSHIFT IS NECESSARY. THIS COULD EASILY LEAD TO A CRASH. FORD MOTOR COMPANY KNOWS ABOUT THE PROBLEM WITH THE TRANSMISSIONS IN THESE CARS, BASICALLY IT IS DUE TO VALVE BORE WEAR IN THE MAIN CONTROL. THEY HAVE A DEFECTIVE CONTROL BODY WHICH HAS EXTREME SPOOL BORE WEAR. A TSB WAS ISSUED: TSB BULLETIN DATE: FEB 2007 VARIOUS DRIVEABILITY/TRANSMISSION SYMPTOMS - PCM/TCM CALIBRATION UPDATES 3.0L - AISIN F21 AUTO TRANS. ( NHTSA ITEM NUMBER - 10021277 ). NO RECALL BY FORD TO DATE. IF YOU CATCH IT BEFORE THE CLUTCH IS BURNT UP, YOU CAN GET BY WITH REPLACING THE MAIN CONTROL VALVE BODY FOR AROUND $800-$1000, HOWEVER IF YOU'RE BEYOND THAT POINT IT'S A $4500+ NEW TRANSMISSION. *TR

Mileage: 93,000

MY FORD FUSION V6 SEL HAS BEEN SLIPPING SINCE 50,000 MILES. I HAVE HAD 2 MINOR TRANSMISSION CHANGES WITHIN THE PAST 3 YEARS. TODAY ME AND MY KIDS WERE DRIVING ABOUT 20-35 MPH AROUND TOWN WHEN THE TRANSMISSION SLIPPED. THE CAR WOULD NOT RESPOND TO ACCELERATING ON THE GAS PEDAL. I TRIED PLACING THE CAR INTO LOW GEAR, REVERSE WITH NOTHING HAPPENING. THIS WAS ON A BUSY INTERSECTION, THE CAR FINAL AFTER FORCING ME AND MY KIDS TO JERK FORWARD STARTED TO WORK AGAIN. EACH TIME I STOPPED AT A STOP LIGHT THE CAR TOOK 1-2 MINUTES TO RISE ABOVE 20 MPH. I FINALLY MADE IT TO MY HOUSE WHICH HAS A SMALL SLANT ON THE DRIVE WAY AND THE CAR STRUGGLED JUST TO MAKE IT IN THE GARAGE. THIS WAS THE MOST EMBARRASSING DAY OF MY LIFE!!!! THE CAR CLEARLY IS OUT OF WARRANTY AND EACH TIME I LOOK UP TSB'S I SEE MORE AND MORE 2006-11 FORD FUSION POSTINGS. BEING A FORD FAN MY WHOLE LIFE I MUST SAY IF NOTHING IS DONE WITH THIS COMPLAINT I WILL NO LONGER SUPPORT FORD AND WILL ENCOURAGE OTHER NOT TO AS WELL. THE NEXT STEPS ARE TO GO TO THE FORD DEALERSHIP AND DO A DIAGNOSTIC. I MAY ALSO TRY A MAJOR TRANSMISSION CHANGE, MY FEAR WOULD BE TO DO A TRANSMISSION CHANGE WITH ZERO CONFIDENCE THAT THIS WILL FIX THE PROBLEM!!! FORD MUST KEEP QUALITY AND SAFETY IN MIND WITH EVERY CAR THEY SELL ESPECIALLY A 1ST GENERATION MODEL. *TR

Mileage: 105,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE RPMS INCREASED AND THE VEHICLE SQUEAKED WITH THE ILLUMINATION OF THE TRANSMISSION WARNING LIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE PCM MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 37,000. *TR

Mileage: 37,000

WE STARTED HAVING PROBLEMS WITH THE TRANSMISSION IN OUR 2006 FORD FUSION IN EARLY 2012. WE REPLACED THE TRANSMISSION IN APRIL WHEN IT HAD ROUGHLY 65,000, WITH A USED TRANSMISSION. IT WAS FINE FOR A FEW MONTHS, AND NOW WE ARE HAVING HARD SHIFTING AND TRANSMISSION SLIPPAGE. THE CAR HAS AROUND 70,000 MILES NOW. I HAVE HEARD OF THIS ISSUE BY MANY FUSION OWNERS, AND FORD REFUSES TO DO ANYTHING ABOUT IT. IT IS IN MY OPINION THAT THE TRANSMISSIONS IN THIS CAR NEED TO BE RECALLED. *TR

Mileage: 65,000

THE TRANSMISSION IS BAD IN THE CAR. THE 2006 FORD FUSION WAS PURCHASED BRAND NEW AND THE EXTENDED WARENTY EXPIRED, THE TRANSMISSION WENT BAD. WHAT MAKES IT SO BAD IS THAT THE CAR ONLY HAS A LITTLE OVER 46000 MILES. SO MANY PEOPLE HAVE SUBMITTED COMPLAINTS AND I WANT TO KNOW WHAT IS FORD GOING TO DO TO CORRECT THE PROBLEM AND REIMBURSE US AT LEAST SOME OF THE MONEY THAT WE HAD TO PAY FOR THE TRANSMISSION. *TR

Mileage: 45,000

I WAS ACCELERATING AS I WAS ENTERING/MERGING ONTO THE HIGHWAY. THE VEHICLE JERKED VIOLENTLY AND STOPPED WITH A LOUD THUD. AFTER THE SUDDEN STOP, DRIVING ON THE HIGHWAY WAS ERRATIC, MEANING THE RPM AND SHIFTING WAS ALL OVER THE PLACE. I EXITED AS SOON AS THE NEXT EXIT WAS AVAILABLE. THEN, EVEN THOUGH THE VEHICLE WAS IN DRIVE, IT WENT "OUT OF GEAR" AND I WAS UNABLE TO PROPEL THE VEHICLE FORWARD. I HAD THE VEHICLE TOWED TO THE DEALERSHIP. THE DEALERSHIP STATED THAT THE VALVE BODY OF THE TRANSMISSION WOULD NEED TO BE REPLACED. THIS IS DUE TO FORD TSB DUE TO PART OF THE TRANSMISSION THAT IS DEFECTIVE. REFER TO NHTSA #10021277. IF I HAD BEEN MERGING INTO TRAFFIC OR IF I HAD BEEN ATTEMPTING TO CROSS THE STREET AND THE VEHICLE WILL NOT PROPEL ITSELF FORWARD IN THE MANNER I EXPECT, IT COULD LEAD TO SERIOUS ACCIDENT. PLEASE HAVE FORD RECALL THIS PART FOR ALL SUCH VEHICLES SO NO ONE GETS INJURED OR KILLED. *TR

Mileage: 75,000

AFTER 3 MONTHS OF PURCHASING MY 2006 FORD FUSION I WAS EXPERIENCING TRANSMISSION PROBLEMS THAT CAUSES MY CAR TO JERK AND LOCK IN GEAR. THUS, PREVENTS ME FROM DRIVING ON THE FREEWAY AND MAIN STREETS. A CAUTIOUS DRIVER IS NOT A GOOD DRIVER. *TR

DRIVING ON FREEWAY 70 MPH WHEN ALL OF A SUDDEN THERE WAS NOTHING WHEN I PRESSED ON THE GAS...FELT LIKE IT WAS IN NEUTRAL. THIS CAR WAS PURCHASED ON MAY 29,2012 FOR OUR 16 YEAR OLD DAUGHTER. THANK GOODNESS I WAS DRIVING THE VEHICLE AND NOT HER. VERY DANGEROUS!! WE DIDN'T KNOW FORD FUSION'S HAD TRANSMISSION PROBLEMS; WE NEVER WOULD HAVE PURCHASED THE CAR IN THE FIRST PLACE. *TR

Mileage: 109,500

CAR EQUIPPED WITH AISIN F21 6 SPEED AUTOMATIC TRANSMISSION. WHEN THE AUTOMATIC TRANSMISSION DOWN SHIFTED THERE WAS A LOUD CLUNK AND THE CAR SLOWLY CAME TO A HALT. THE ENGINE RPM INCREASED AS I TRIED TO GET THE VEHICLE TO MOVE OFF TO THE SIDE OF THE ROAD. AFTER SHUTTING THE CAR OFF AND RESTARTING IT WAS ABLE TO GET ME HOME. THE NEXT TIME I DROVE IT, IT WAS FINE FOR A WHILE AND DID IT AGAIN. TOOK IT TO THE FORD DEALER AND WAS TOLD IT NEEDED AN NEW TRANSMISSION CONTROL VALVE BODY. I ASKED IF THERE HAD BEEN PROBLEMS WITH THIS TRANSMISSION IN OTHER FUSIONS AND THEY SAID NONE THAT THEY KNEW OF. IN LOOKING ON THE INTERNET I FIND THAT THIS TRANSMISSION HAS BEEN A PROBLEM FOR MANY PEOPLE FROM THE YEARS 2005-2010. CHECK SERVICE BULLETIN PUT OUT BY FORD # 08-24-1 PUBLICATION DATE NOV. 13 2008. I AM SURE THERE ARE OTHER SERVICE BULLETINS ALSO. MANY PEOPLE HAVE HAD THEIR VEHICLE STOP ON A VERY BUSY HIGHWAY AND HAVE BEEN PUT IN DANGER BECAUSE OF THE ABOVE PROBLEM. SINCE FORD HAD BEEN AWARE OF THIS PROBLEM THEY SHOULD HAVE HAD A RECALL TO CORRECT IT IN THE INTEREST OF PUBLIC SAFETY. THANK YOU *TR

Mileage: 62,000

MY TRANSMISSION IS SLIPPING A LOT. I WILL BE ACCELERATING MY SPEED AND ALL OF THE SUDDEN MY CAR ACTS LIKE IT IS IN NEUTRAL. I HAVE READ A LOT OF COMPLAINTS FROM OTHER FORD FUSION OWNERS STATING THE SAME PROBLEM. THIS NEEDS TO BE RECALLED. THIS IS VERY UNSAFE. DRIVING ON THE HIGHWAY AND THEN ALL OF THE SUDDEN YOUR TRANSMISSION SLIPS AND THERE ARE CARS AT FAST SPEEDS TRAVELING NEXT TO YOU AND BEHIND YOU IS NOT SAFE AT ALL. *TR

Mileage: 94,000

TRANSMISSION SLIPPING AT DOWNSHIFT AT AROUND 35 MPH. DEALER CHANGED FLUID. HELPED FOR AROUND 3 WEEKS AND STARTED AGAIN. TODAY 7/24/2012 TRANSMISSION SLIPPED OUT OF GEAR ENTERING HIGHWAY RT 78 AT RT 100 AND ALMOST INVOLVED IN A CRASH, HAD TO PULL ON TO SHOULDER TO AVOID IT. FORD CLEARLY KNOWS OF THE PROBLEMS WITH THE AISIN TRANSMISSION AND SHOULD BE HELD RESPONSIBLE FOR ANY REPAIRS. THE PROBLEM IS WITH VALVE BORE WEAR IN THE MAIN CONTROL OR MEGATRONIC. WHY SHOULD CITIZENS BE MADE TO PAY FOR FAULTY PARTS USED IN CONSTRUCTION ? *TR

Mileage: 54,000

I WAS DRIVING UP A STEEP HILL WHEN THE TRANSMISSION BEGAN TO SLIP IN AND OUT OF GEAR. SEVERAL VERY LOUD CLUNKING NOISES WERE HEARD UNDER THE VEHICLE LIKE THE TRANSMISSION WAS NOT WORKING PROPERLY. I BEGAN TO SLOW DOWN ON A BUSY ROAD WITH SEVERAL CAR BEHIND ME DUE TO THE FACT THAT THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE DIRECTLY BEHIND ME ALMOST RAN RIGHT INTO THE REAR END OF THE CAR WITH MY 7 WEEK OLD SON IN THE BACK. WHEN I TOOK IT TO THE DEALERSHIP THEY FOLLOWED THE TSB 08-24-1 RECOMMENDATIONS AND SAID THAT I NEEDED A NEW TRANSMISSION. THIS VEHICLE IS VERY DANGEROUS TO DRIVE NOW. I WILL NOT TAKE IT ON THE ROAD DUE TO THE FACT THAT IT WILL NOT ACCELERATE AT TIMES. THIS PROBLEM ONLY OCCURS AFTER ABOUT 1 HOUR OF DRIVING THE VEHICLE. A RECALL IS NEEDED! *TR

Mileage: 107,124

PURCHASED 2006 FORD FUSION SEL 6 CYL, NEW. AND ABOUT YEAR AGO STARTING HAVING TRANSMISSION PROBLEMS. UPON ACCELERATING BETWEEN 25-40, THE TRANSMISSION JUMPS IN AND OUT OF GEAR, OFTEN MAKING A LOUD BANGING NOISE AND TAKING AWAY ALL ACCELERATION. IN ORDER FOR IT TO GET BACK INTO GEAR, YOU HAVE TO COMPLETELY LET OF THE GAS AND IT WILL EVENTUALLY GO BACK INTO GEAR. THIS ALLOWS FOR MINIMAL ACCELERATOR AT BEST WHEN TRYING TO SPEED UP. THIS FAILURE OCCURS RANDOMLY EVERYTIME I DRIVE THE VEHICLE. IF NOT FIXED, THE TRANSMISSION IN MY CAR WILL EVENTUALLY GO BAD. DUE TO NO CODES SHOWING UP ON THE COMPUTER, THAT ON THE FORD BULLETIN IT WAS GOING TO NEED A NEW VALVE BODY, TRANSMISSION FLUSH, AND REPROGRAMMING. THIS IS GOING TO COST ROUGHLY $2200. THE VALVE BODY, FROM FORD, WAS $1400. I GOT INTO AN ACCIDENT IN MARCH OF THIS YEAR DUE TO NOT BEING ABLE TO ACCELERATE FROM ANOTHER VEHICLE MERGING INTO MY LANE,TRANSMISSION JUMPED OUT GEAR. *TR

Mileage: 55,000

THE TRANSMISSION SLIPS AND JERKS HARD, REALLY HARD WHEN CHANGING GEAR. THE CAR LOSE POWER WHILE DRIVING. THEN IT WILL KICK BACK IN HARD. I WILL NOT BUY ANOTHER FORD!!! NOW I SEE WHY PEOPLE BUY FOREIGN. *JS

Mileage: 69,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE GEAR SHIFTER NEEDED TO BE REPLACED. THE DEALER ADVISED THE CONTACT THAT THE PROBLEM WAS WITH THE SOFTWARE NOT READING WHEN THE VEHICLE WAS IN PARK. THE CONTACT STATED THAT THE DOOR LOCKS ALSO FAILED AS THE FAILURE OCCURRED. THE FAILURE AND THE CURRENT MILEAGE WAS 44,000.

Mileage: 44,000

BOUGHT THE CAR USED WITH APPROX. 45,000 MILES ON IT FROM FORD DEALERSHIP. WITHIN A WEEK I WAS BACK AT THE FORD DEALERSHIP I BOUGHT IT AT. THE CAR WOULD NOT ACCELERATE, STUCK IN GEAR, JERK VIOLENTLY. THEY GAVE ME A LOANER CAR TO DRIVE, ANOTHER 06 FORD FUSION. THEY TOLD ME THERE WAS NOTHING WRONG WITH THE CAR AND IT WAS THE WAY I DRIVE. I TOLD THEM I DIDN'T HAVE ANY PROBLEMS WITH THE LOANER CAR OR ANY OTHER CAR I'VE EVER DRIVEN OR OWNED. THEY INSISTED I WAS WRONG. OVER THE NEXT MONTH I BROUGHT THE CAR BACK TO THE DEALERSHIP AND ENCOUNTERED THE SAME RESISTANCE. THE PROBLEM GOT PROGRESSIVELY WORSE AND DANGEROUS TO DRIVE TO THE POINT WHERE I WOULD BE GOING 60+ MPH ON A HIGHWAY AND THE CAR WENT INTO NEUTRAL. THE TRANSMISSION COMPLETELY FAILED IN 2010, AT THAT TIME I HAD IT REPLACED, COSTING $3,000. MAY 31, 2012 - APPROX 65,000 MILES. SIMILAR PROBLEMS AGAIN. CAR WOULD NOT ACCELERATE, VERY HESITANT, ENTIRE CAR SHAKES VIOLENTLY WHILE DRIVING. CHECK ENGINE LIKE CAME ON. I TOOK THE CAR TO MY MECHANIC, HE TESTED AND DETERMINED THREE COILS WENT BAD. LOOKED IN THE CAR AND DISCOVERED THE COILS HAD ACTUALLY MELTED. WITH RESEARCH, DETERMINED THE COMPUTER SYSTEM HAD FAILED. COILS AND COMPUTER SYSTEM NEED TO BE REPLACED. APPROX COST (SO FAR) - $1500.00. *TR

Mileage: 40,000

CAR HAS MULTIPLE ISSUES WITH HARD REVS OF THE TRANSMISSION. IT HAS CAUSED ME TO HAVE TO SLOW BECAUSE IT FEELS LIKE THE ENTIRE CAR SHIFTS SO HARD THAT IT IS GONNA BREAK APART. CAR NOW DOES NOT EVEN REV. REVIEWED HUNDREDS OF COMPLAINTS ONLINE ABOUT SAME PROBLEM WITH THE 2006 FORD FUSION AND NOTHING IS BEING DONE. IT IS HORRIBLE! SOMETHING NEEDS TO BE DONE. THERE IS NO RECALL AND EVEN AFTER REPLACING PARTS ON THE TRANSMISSION OR THE ENTIRE TRANSMISSION AS HUNDREDS HAVE SAID THEY DID, THE PROBLEM STILL OCCURS SHORTLY THERE AFTER! *TR

Mileage: 125,000

HARD SHIFTING FROM 1ST TO 2ND. JUST WANT IT FIXED. *TR

Mileage: 106,688

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE DRIVER'S SIDE DOOR HANDLE DETACHED FROM THE VEHICLE. PRIOR TO THE FAILURE, THE VEHICLE ALSO FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER WHO CONFIRMED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED REGARDING BOTH FAILURES. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 78,000.

Mileage: 78,000

2006 FUSION SEL. 1) IGNITION KEY GETS STUCK IN IGNITION. APPROXIMATELY 9 INCIDENTS BEGINNING MAY 2009 OF PARKING THE CAR, TURNING OFF THE MOTOR, KEY CANNOT BE REMOVED FROM IGNITION: 3-4 TIMES THE KEY COULD NOT BE REMOVED FOR OVER 48 HOURS; 4 - 5 TIMES WITHIN 12 HOURS.. CAR CAN BE LOCKED IF USING THE SECOND REMOTE-CONTROL KEY, BUT WILL UNLOCK ALL DOORS WITH IN 5 SECONDS WHEN LOCK ON THE INSIDE DOOR IS PUSHED AND DOOR IS CLOSED. HAVE HAD THE ALARM GO OFF 3 TIMES WHEN CAR DOOR IS OPENED AFTER CAR LEFT UNATTENDED FOR 15+ MINUTES, UNLOCKED, WITH KEY STUCK IN IGNITION, BUT ALARM HAS NOT SOUNDED AT ALL TIMES FOR THE SAME SCENARIO. 2) CHROME VENEER ON INTERIOR FRONT DOOR HANDLES WRINKLING AND PEELING. PROBLEM WAS BEGINNING TO SHOW IT SELF WHEN CAR WAS PURCHASED. *TR

I BOUGHT THE CAR IN APRIL OF 2011 AND THE TRANSMISSION WAS SLIPPING A LITTLE. I HAD A MECHANIC, WHICH WAS A PREVIOUS FORD MECHANIC, TOLD ME FORD HAD A RECALL ON THE TRANSMISSION FOR THAT TYPE OF CAR. I THEN CALLED THE DEALERSHIP TO HAVE THEM CHECK THE VIN# TO SEE IF MY CAR HAS THE RECALL. THE DEALERSHIP SAID THERE WAS NO RECALL. BUT AS I RESEARCHED IT, I FOUND OUT THAT THERE WERE OTHER VEHICLES OF THE SAME MAKE AND MODEL AS MINE AND EXPERIENCING THE SAME PROBLEM. I DO NOT UNDERSTAND WHY MY VEHICLE DOESN'T HAVE ANY DEFECT EVEN THOUGH THERE ARE MANY OTHERS LIKE THIS. *TR

Mileage: 101,000

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE VIOLENTLY JERKED FORWARD FOR A FEW MOMENTS. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

Mileage: 80,000

I SUFFERED THE BASIC SAME COMPLAINTS WITH THE TRANS SLIPPING OUT OF GEAR AFTER FREEWAY DRIVING AND HAVING IT SLAM BACK INTO GEAR. IT USUALLY HAPPENS WHEN I LET OFF THE THROTTLE AND NEED TO RE-ACCELERATE. I HAVE BEEN LUCKY SO FAR I USUALLY CAN GET IT TO RE-ENGAGE IN GEAR WITHOUT CAUSING ANY PROBLEMS BEHIND ME. ONE TIME IT LOCKED INTO A HIGH GEAR AND I ALMOST BURNED UP THE CLUTCH BECAUSE IT WOULD NOT DOWNSHIFT WHEN I GOT OFF THE FREEWAY. I PULLED OVER TO THE SHOULDER TO FIGURE OUT WHAT TO DO AND WHILE I WAS STOPPED I TURNED OFF THE MOTOR. WHEN I TURNED IT BACK ON APPROX 5 MINS LATER IT HAD RESET ITSELF AND I WAS ABLE TO DRIVE HOME FINE. THIS IS HOW MY COMMUTE IS BASICALLY EVERY DAY NOW, IT SEEMS TO HAPPEN MORE OFTEN IN THE AFTERNOON COMMUTE WHEN THE WEATHER IS WARMER. (ON A SIDE NOTE IF YOU GET STRUCK SOMEWHERE, ALLOW THE CAR SIT FOR 5 MINS WITH KEY OFF ALLOWING IT TO RESET AND IT MIGHT ALLOW YOU TO ARRIVE SOMEWHERE SAFE). *TR

Mileage: 75,000

TRANSMISSION JUMPS AT LOW SPEED SOMETIMES, AS IF IT WAS TRYING TO GO INTO THE NEXT GEAR BUT MISSES. IT WILL GRAB ALL AT ONCE AND IT FEELS LIKE THE ENGINE IS GOING TO JUMP OUT OF THE CAR. WE NOW HAVE A RUMBLING LIKE A BEARING IS GOING OUT. *TR

Mileage: 78,000

TRANSMISSION PROBLEMS. DAUGHTER WAS DRIVING CAR AND BACKING UP FROM DRIVE IT POPPED AND WOULD NOT MOVE IN DRIVE. IT WOULD REVERSE AND DRIVE SLOW AT LOWER GEAR, BUT NOT DRIVE IN D. MECHANIC SAID GEARS ARE FINE AND NOT TRANSMISSION , BUT CONFIRMED MAY BE SENSOR IN TRANSMISSION. FROM READING SIMILAR COMLAINTS, IT IS WIDESPREAD PROBLEM AND A POTENTIAL ROAD HAZARD. RECALLS HAVE BEEN DONE ON SAME MAKE AND MODEL, BUT FROM 2007 - CURRENT. WHY ISNT THE 2006 COVERED? THE AUTO MECHANIC HAS BROUGHT VEHICLE TO 3 DIFF AUTO SHOPS AND PROBLEM IS THAT IT IS A MAZDA ENGINE WITH GERMAN PARTS IN A FORD CAR AND NOT FAMILIAR WITH PARTS. FORD DEALER WAS CONTACTED AND ALSO FORD PRODUCT COMPLAINT LINE. ALL THEY WOULD SAY WAS THERE ARE NO RECALLS FOR 2006 FORD FUSIONS. WHY??? THE AUTO SHOPS INSIST ON REPLACING ENTIRE TRANSMISSION TO WARRANTY THEIR WORK AND CHARGE $2500+ WHEN ALL IS NEEDED IS A PART FOR LESS $. *TR

Mileage: 56,000

I HAVE BEEN HAVING TRANSMISSION PROBLEMS WITH MY CAR BUT THE SERVICE LIGHT HAS NEVER COME ON! I HAVE ALSO HAD THE KEY STUCK IN THE IGNITION! THESE PROBLEMS ARE GETTING RIDICULOUS AND TO HAVE FORD NOT COVER THEM IS JUST NOT ACCEPTABLE! THE TRANSMISSION IS SLIPPING, NOT SHIFTING WHEN IT IS SUPPOSED TO, DOWNSHIFTING HARD. ANYTIME I TRY TO ACCELERATE TO PASS, OR SPEED UP IT BANGS AND JERKS REALLY HARD I'VE ALMOST DRIVEN OFF THE ROAD A FEW TIMES BECAUSE OF HOW HARD IT BANGS. IT JUST KEEPS GETTING WORSE, TO THE POINT MY KIDS ASK ME "MOM, WHAT WAS THAT?" THIS IS A COMPLETE HAZARD TO DRIVE ON THE ROAD CAUSE YOU NEVER KNOW IF OR WHEN IT IS GOING TO HAPPEN. LET ALONE HAVING MY KIDS IN THE CAR! I HAVE BEEN ALMOST REAR-ENDED A COUPLE OF TIMES BECAUSE THE TRANSMISSION SLIPS AND WON'T GO INTO GEAR, ALL IT DOES IS REV THE ENGINE AND IF YOU TAKE YOUR FOOT OFF THE GAS TO TRY AND GET THE RPM'S TO GO DOWN, YOU REALLY SLOW DOWN AND COULD CAUSE AN ACCIDENT! IS THIS WHAT FORD NEEDS?! IS FOR SOMEONE TO GET INTO A BAD ACCIDENT AND GET SERIOUSLY INJURED OR DIE IN ORDER TO GET THIS RECALLED?! THIS IS HAPPENING TO SOOO MANY FORD FUSIONS AND IT IS ALL OVER THE INTERNET WITH THE EXACT SAME PROBLEMS!! SOMETHING NEEDS TO BE DONE ABOUT THIS! THERE IS NO REASON WHY THEY CAN RECALL THE TRANSMISSIONS ON THE NEWER FORD FUSIONS BUT NOT THE VERY FIRST YEAR IT WAS OUT!! THEY KNOW SOMETHING IS GOING ON WITH THESE TRANSMISSION, THEY JUST DON'T WANT TO SPEND THE MONEY TO FIX THEM ALL AND I FIND THAT ABSOLUTELY RIDICULOUS!! MY KIDS SHOULD NOT HAVE TO RIDE IN A CAR THAT COULD BE THE CAUSE OF AN ACCIDENT ALL BECAUSE FORD DOESN'T WANT TO ACKNOWLEDGE THERE IS A SERIOUS PROBLEM! IT'S NOT FAIR THAT I PAID 20K FOR THIS CAR AND WHEN IT HAS ABOUT 60K MILES ON IT FOR THE TRANSMISSION TO START TO MESS UP AND THEY WANT ME TO PAY FOR IT!! THIS IS GIVING FORD A BAD NAME!!! I WILL NEVER RECOMMEND A FORD TO ANYONE EVER!!! *TR

Mileage: 60,000

THE CAR STARTED ABOUT 2 YEARS AGO, SLIPPING OUT OF GEAR WHEN HAVING TO ACCELERATE. IT ALSO SLAMS INTO GEAR WHEN DOWN SHIFTING. THIS IS VERY DANGEROUS, MY WIFE WAS GETTING ON THE INTERSTATE AND IT SLIPPED OUT OF GEAR AND SHE HAD TO COAST OFF OF THE HIGHWAY BECAUSE THERE WAS A TRACTOR AND TRAILER QUICKLY APPROACHING. WE ALSO CANNOT GO UP ANY BIG HILLS OR MOUNTAINS. WE HAVE HAD IT AT THE DEALERSHIP WHEN IT FIRST HAPPENED AND THEY CHANGED THE TRANSMISSION FLUID AND UPDATED THE COMPUTER. THIS COST $500. THEY FINALLY CAME TO THE CONCLUSION THAT IT NEEDED A NEW TRANSMISSION WHICH WOULD COST $4000. WE STILL OWE OVER $12,000 AND DO NOT HAVE THE $4000 TO REPLACE THE TRANSMISSION. *TR

THE TRANSMISSION SLIPS AND JERKS WHILE DRIVING. I BOUGHT THE CAR BRAND NEW AND HAVE BEEN KEEPING UP WITH MAINTENANCE RELIGIOUSLY. *KB

Mileage: 70,000

THE TRANSMISSION SLIPS AND JERKS WHILE DRIVING. I BOUGHT THE CAR BRAND NEW AND HAVE BEEN KEEPING UP WITH MAINTENANCE RELIGIOUSLY. *KB

Mileage: 70,000

2006 FORD FUSION SEL V6 AUTOMATIC TRANSMISSION WHEN TRYING TO ACCELERATE TO ENTER THE HIGHWAY MY CAR JERKED VIOLENTLY WHEN IT SLAMMED ITSELF INTO GEAR IT MADE A VERY LOUD NOISE WHEN IT SHIFTED. I ALMOST LOST CONTROL OF MY VEHICLE. I TOOK THE CAR TO A DEALERSHIP TO REPAIR THEY SAID IT WAS THE THROTTLE BODY AND I HAVE IT REPLACED. LESS THAN 30 MINUTES OF LEAVING THE DEALERSHIP IT DID IT AGAIN . I HAD THE DEALERSHIP PICK UP THE CAR BECAUSE OF THE DEFECTIVE TRANSMISSION AND NOW THEY AGREE IT NEEDS TO BE REPLACED. HOWEVER, I DID FURTHER RESEARCH AND I HAVE FOUND THAT MANY CONSUMERS HAVE THE SAME COMPLAINT AS MINE AND THEIR ARE MANY SIGHTS AVAILABLE. WHY HASN'T FORD RECALLED THIS TRANSMISSION. TO AD MORE SALT IN MY WOUND MY INSURANCE COMPANY IS CHOOSING TO USE A USED 2006 TRANSMISSION FROM 2006 FORD FUSION SEL WITH 48,000 MILES ON IT AND TO TOP IT OFF THE CAR TAT THIS TRANSMISSION IS COMING FROM WAS T-BONED AND TOTALED THANKS GEICO SO NOW IM NOT A THE MERCY OR FORD BUT GEICO SO NOW I HAVE TO GET RID OF MY CAR BECAUSE I AM SCARED THAT HIS WILL OCCUR AGAIN. IF SOMEONE WOULD JUST GOOGLE FORD FUSION 2006 SEL VIOLENTLY JERKING.. YOU WILL SEE THOUSANDS OF PEOPLE HAVING THE SAME ISSUE. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE WOULD JERK SPORADICALLY WHILE IN MOTION. IN ADDITION, THE VEHICLE WOULD LOSS POWER AND STALL WITHOUT WARNING. THE DEALER DIAGNOSED THAT THE POWER TRAN CONTROL MODULE WAS DEFECTIVE AND NEEDED REPAIR. THE MANUFACTURER WAS NOTIFIED, BUT TOLD THE CONTACT THAT THE VIN WAS NOT ASSOCIATED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 52,000 AND THE CURRENT MILEAGE WAS 52,082.

Mileage: 52,000

WHILE DRIVING ON THE ON RAMP TO GET ON THE INTERSTATE. WHEN I WENT TO ACCELERATE THE CAR JERKED VIOLENTLY ALMOST CAUSING ME TO LOOSE CONTROL OF MY VEHICLE. THIS CONTINUED UNTIL I COULD GET OF THE HIGHWAY. WHEN COMING TO A STOP AND TRYING TO ACCELERATE TO PROCEED FORWARD THE CAR CONTINUED JERKING VIOLENTLY AND NOW I AM SCARED TO DRIVE MY CAR. I CONTACTED FORD NO RECALL ON THIS PROBLEM, THEN I DID FURTHER RESEARCH AND I NOTICED THAT THERE WAS SEVERAL COMPLAINTS REGARDING THIS ISSUE WITH THIS MODEL. I COULD HAVE BEEN KILLED TODAY AS THIS IS A DANGEROUS DEFECT. IF YOU GOOGLE FORD FUSION 2006 SEL V6 JERKING DURING ACCELERATION YOU WILL SEE THOUSANDS OF REPORTS. *TR

EARLY MAY 2011 I WAS DRIVING HOME AT 65MPH AND I LOST 5TH GEAR. THEN 4TH GEAR. ON WAY TO DEALERSHIP I LOST 3RD GEAR. WARRANTY COVERED A BRAND NEW TRANSMISSION. THEY CLAIM AFTER A WEEK THEY FINALLY GOT THE TRANSMISSION IN AND INSTALLED BUT THEY WERE WAITING ON A PART FOR IT BECAUSE THE TRANSMISSION CAME WITH A PART FOR A MAZDA 6 AND WOULDN'T WORK. AFTER TWO WEEKS THEY WERE FINALLY DONE. TOOK VEHICLE BACK TO DEALERSHIP ON 09/26/2011 STATING GREAT DIFFICULTY GETTING VEHICLE TO SHIFT OUT OF PARK. ALSO STATED THERE IS AN EXCESSIVE AMOUNT OF HEAT COMING FROM THE CONSOLE IN TO THE CABIN ABOVE THE TRANSMISSION. ALSO STATED THE TRANSMISSION IS SHIFTING VERY HARD AT TIMES. FORD CALLED TODAY AND STATED THE TRANSMISSION HAS NO PROBLEMS AT ALL AND THAT I CAN'T GET OUT OF PARK BECAUSE THE SHIFT INTERLOCK SYLIONID NEEDED TO BE REPLACED REQUIRING THAT EVERYTHING FROM THE SHIFTER AND EVERYTHING BELOW ALL THE WAY TO THE FLOORBOARD WOULD HAVE TO BE REPLACED COSTING OVER $400. I HAVE FOUND HUNDREDS OF COMPLAINTS ONLINE *TT

Mileage: 79,000

TL* THE CONTACT OWNS A 2000 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE HESITATED TO SHIFT INTO GEAR WHEN SHE ATTEMPTED TO ACCELERATE FROM A STOP. THE VEHICLE EVENTUALLY JERKED INTO GEAR AND BEGAN TO ACCELERATE. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE VEHICLE NEEDED A NEW TRANSMISSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 47,000.

Mileage: 47,000

TRANSMISSION PROBLEMS ON V6 SIX SPEED TRANSMISSION. HARD SHIFTING FROM 3RD TO 4TH GEAR (SOMETIMES A VERY LOUD BANG). DOWN SHIFTS LIKE A MANUAL TRANSMISSION WHEN SLOWING DOWN. *TR

Mileage: 74,000

WHEN DRIVING CAR 25 MILES PER HOUR THE CAR STOPS JERKS DECELERATES THE EVENTUALLY KICKS BACK UP SOME TIMES IT DOES IT WITH NORMAL SPEED . WHICH HAS ALMOST CAUSED SEVERAL ACCIDENTS WHEN CAR SUDDENLY DECELERATES STOPS IN THE FLOW OF TRAFFIC THEN HAVING TO WAIT TILL IT KICKS BACK UP OR JUST TRY TO PULL OFF ROAD TO KEEP FROM GETTING HIT VERY SCARY WHEN DRIVING ON HIGHWAY OF IN RUSH HOUR TRAFFIC! OR PUTTING ON FLASHERS AT THE LAST MINUTE HOPING NOT TO GET HIT! *KB

TRANSMISSION WENT COMPLETELY OUT OF GEAR WHEN EXITING THE TURNPIKE AND ENTERING THE HIGHWAY. THE TRANSMISSION HAD BEEN SLIPPING INTERMITTENTLY FOR MONTHS.

Mileage: 79,000

BOUGHT THE CAR IN 2008 W/ 65,000 MILES. WITHIN A FEW MONTHS OF PURCHASE NOTICED VERY VIOLENT UPSHIFTS WHILE ON THE FREEWAY AND OCCASIONALLY THE CAR WOULD SLIP INTO NEUTRAL WHILE TRAVELING @ 65-70MPH (VERY SCARY). TOOK CAR TO DEALERSHIP WHILE UNDER USED CAR WARRANTY AND WAS TOLD NOTHING WAS WRONG AND IT WAS THE WAY I WAS DRIVING. WE STARTED FILING COMPLAINTS WITH FORD BUT THEY WERE OF NO HELP AND THEY HAVE TOLD US THAT THE TRANS NEEDS TO BE REPLACED. TWO YEARS LATER (@75K MILES) THE TRANSMISSION COMPLETELY FAILED WHILE DRIVING (VERY DANGEROUS). TRANS AND TCM MODULE NEEDS TO BE REPLACED (APPROX: $5000) AND NOT EVEN SURE IF THAT WILL FIX THE PROBLEM. *TR

Mileage: 65,000

THE TRANSMISSION IN MY VEHICLE STARTED SLIPPING AT 60,000 MILES. IT WILL SLIP OUT OF GEAR AND SLAM VIOLENTLY BACK INTO GEAR MAKING THE VEHICLE HARD TO CONTROL. IT DOES NOT HAPPEN ALL THE TIME BUT IT HAS BEEN HAPPENING MORE OFTEN.THERE HAS BEEN MANY COMPLAINTS OF THIS MODELS TRANSMISSION DOING THIS IN OTHER VEHICLES. *TR

Mileage: 60,000

06 FORD FUSION DOESN'T SHIFT - I WAS TRAVELING WITH MY DAUGHTER FROM NV TO AZ. AFTER HAVING DRIVEN 2 HOURS I EXITED THE HIGHWAY, STOPPED AT A STOP SIGN AND WAS ABLE TO TRAVEL APPROXIMATELY A 100 FEET WHEN OUT OF NO WHERE THE ENGINE REVVED UP TO 5000 RPMS AND STOPPED MOVING. THE VEHICLES BEHIND ME WERE CAUGHT OFF GUARD BECAUSE OF MY SUDDEN STOP IN THE MIDDLE OF THE ROAD. I TRIED PUSHING THE GAS PEDAL TO GET US TO THE ROADSIDE BEFORE BEING REAR-ENDED. THE ENGINE KEPT REVVING UP AND CREEPING TOWARD THE SIDE. I PULLED TO THE SIDE OF THE ROAD TO LET THE CARS BEHIND ME PASS AND WAITED 5 MINUTES BEFORE DECIDING I WAS NOT GOING TO HAVE MY DAUGHTER AND I IN THE MIDDLE OF THE NIGHT STRANDED ON THE SIDE OF THE ROAD. I PUSHED THE GAS PEDAL AND GOT THE CAR TO VERY SLOWLY ACCELERATE AND MOVE WITHOUT SHIFTING BUT CATCHING SPEED. ONCE THE CAR WAS MOVING AT 60 MPH THERE WEREN'T ANY PROBLEMS, BUT IF I HAD TO SLOW DOWN OR COME TO A STOP THE CAR WOULD TAKE FOREVER TO BEGIN CATCHING SPEED. I WAS ABLE TO GET US TO A SAFE PLACE 25 MINS AWAY AND PARKED THE CAR UNTIL THE NEXT DAY. BECAUSE IT WAS A SMALL TOWN AND A SATURDAY THERE WERE NO MECHANICS AVAILABLE UNTIL MONDAY. I HAD TO STAY THE WEEKEND WAITING FOR A MECHANIC. WHILE WAITING I DID A GOOGLE SEARCH AND DISCOVERED THE HORRIFYING FACT THAT FORD IS FULLY AWARE OF THIS ISSUE CAUSED BY THEM PURCHASING TRANSMISSIONS WITH FAULTY VALVE'S. I AM A SINGLE MOTHER AND IT IS UNBELIEVABLE TO ME THAT FORD CAN GET AWAY WITH SELLING A FAULTY PRODUCT. I AM TAKING MY CAR TO A TRANSMISSION MECHANIC THAT WAS REFERRED BY A FRIEND WHERE I AM GOING TO DETERMINE IF THIS ISSUE CAN EVEN BE FIXED. I ONLY HAVE 10 PAYMENTS LEFT ON THE CAR AND AM DUMBFOUNDED THAT I MIGHT HAVE TO SPEND 1/2 OF WHAT I OWE ON THE CAR TO FIX A PROBLEM THAT FORD CAUSED. WHAT DOES IT TAKE TO GET A RECALL LIKE THEY DID WITH THE 2010 FUSIONS? *TR

Mileage: 123,000

CAR SLIPS OUT OF GEAR AND FAILS TO SHIFT OUT OF NEUTRAL FOR ACCELERATION. *TR

I WAS DRIVING ON A HIGHWAY AT 65 MILES PER HOUR WHEN ALL OF SUDDEN MY CAR JUST STARTED SLIPPING OUT OF GEAR. I HAVE 70,000 MILES ON MY CAR AND IT STARTED WITH ABOUT 63,000 MILES. I WAS JUST RECENTLY AT A 2 WAY STOP WITH THE NON STOP BEING A HIGHWAY OF 64 MILES PER HOUSE IN SOUTH DAKOTA. I STOPPED AND SEEN NO CARS COMING AND STARTING GOING ACROSS THE INTERSECTION AND MY CAR WOULDN'T GO INTO GEAR. I SAT IN THE MIDDLE OF THE INTERSECTION TRYING TO GET IT TO GO AND FINALLY AFTER ABOUT 15 SECONDS I GOT IT TO RUN AND LUCKILY THERE WAS NO TRAFFIC COMING OR I WOULD HAD TO GET OUT OF MY CAR AND RUN TO THE SIDE BECAUSE IT WOULDN'T START GOING. I DON'T HAVE THE KIND OF MONEY TO GO INTO A REPAIR SHOP AND SPEND 5000 DOLLARS ON A NEW TRANSMISSION WHEN I KNOW THAT IS WHAT IT IS. IT OCCURS PROBABLY ONCE A DAY. *TR

Mileage: 63,000

TRANSMISSION MISHAP, JUMPED OUT OF GEAR WHILE DOING HIGHWAY SPEEDS RESULTING IN NEAR COLLISION. TRANSMISSION DOWNSHIFTS EXTREMELY HARD CAUSING CAR TO JUMP AND HAVE ERRATIC SHIFTING. FORD AWARE OF PROBLEM, THEIR RECOMMENDATION IS A NEW TRANSMISSION RESULTING IN A $4256.00 REPAIR BILL.

Mileage: 77,250

2006 FORD FUSION TRANSMISSION SLIPS OUT OF GEAR AND SLAMS BACK INTO GEAR AT HIGHWAY SPEEDS. ALSO CLUNKS INTO EACH GEAR AS IT IS DOWNSHIFTING. *TR

Mileage: 37,000

TRANSMISSION WILL NOT SHIFT,THIS IS THE SECOND TIME THIS HAS HAPPENED. THE FIRST TIME WE TOOK IT TO A REPAIR SHOP AND A REBUILT TRANSMISSION WAS PUT IN. THEN 9000 MILES LATER IT HAPPENED AGAIN. *TR

Mileage: 125,240

AUTOMATIC TRANSMISSION STICKS WHEN IN SLOW MOVING, STOP AND GO TRAFFIC ON THE HIGHWAY. IN SEVERAL CASES, I HAVE NEARLY BEEN HIT FROM BEHIND BECAUSE THE CAR DOES NOT ACCELERATE IMMEDIATELY AFTER PUTTING MY FOOT ON THE GAS PEDAL AND WHEN THE CAR FINALLY DOES ACCELERATE, THERE IS A STRONG THUMP AND IT FEELS AS IF THE TRANSMISSION IS GOING TO FALL OUT OR AS IF I HAD BEEN HIT FROM BEHIND. *TR

I HAVE A 2006 FORD FUSION SEL WITH 40,500 MILES ON IT. HAVE TO HAVE TRANSMISSION VALVE BODY REPLACED, $1800 REPAIR. I'VE SEARCHED ON LINE AND FOUND THIS TO ME A PROBLEM WITH MANY, MANY OTHER FORD FUSIONS. CONTACTED FORD OFFICE AND SAID THERE ARE NO SAFETY ISSUES WITH THE CAR. THE TRANNY "KICKED" SO HARD IT BROUGHT MY 14 YEAR OLD DAUGHTER OUT OF HER SEAT, I DO SEE THIS AS A SAFETY ISSUE. IT COULD CAUSE A ME TO WRECK, BECAUSE YOU NEVER KNOW WHEN ITS GOING TO HAPPEN. STILL OWE 9000 ON THIS CAR, IT'S A SAME US CONSUMERS ARE HAVING TO PUT SUCH MONEY INTO A VEHICLE. FORD NEEDS TO STEP UP AND MAKE THIS RIGHT, THIS IS AN ONGOING PROBLEM WITH THIS MAKE OF CAR. *TR

Mileage: 40,500

2006 FORD FUSION V6.... MY WIFE WAS DRIVING ON THE EXPRESSWAY WITH MY TWO YEAR DAUGHTER IN THE BACK SEAT WHEN THE TRANSMISSION SLIPPED OUT OF GEAR AS IF IT WENT INTO NEUTRAL GOING 60MPH. SHE LET OFF THE GAS PEDDLE AND THE TRANSMISSION ENGAGED . TRYING TO GET BACK UP TO SPEED SHE STEPPED ON THE GAS PEDDLE AND THE CAR JERKED VIOLENTLY AND CAUSED IT TO SLOW DOWN EVEN MORE. SHE WAS ABLE TO GET IT BACK UP TO SPEED BY SLIGHTLY PUSHING DOWN ON THE GAS PEDDLE.. AFTER READING ALL THE COMPLAINTS, HOW IS THERE NOT A FORCED RECALL!!!! THIS IS EXTREMELY DANGEROUS! THE 2010 FUSION HAS A RECALL FOR UNSAFE TRANSMISSION ISSUES, WHY NOT THE 2006? *TR

Mileage: 76,000

WHEN DRIVEN IN TOWN CAR WILL STALL FOR ABOUT 10 TO 15 SECOND THEN JERK FORWARD AROUND SPEED BETWEEN 25- 40MPH WITH A SUDDEN INCREASE IN SPEED UP TO 10MPH. WHEN ENTERING HIGHWAY AND MERGED INTO TRAFFIC. I BEGAN SPEEDING UP TO 60 MPH THE TRANSMISSION HESITATEDTHE STALL FOR 10 SECONDS THEN JERKED,LIKE IT FINALLY SHIFTED BUT THEN TURN AROUND AND STALL GAIN. THE CAR WOULD NOT RESPOND TO THE GAS PEDAL AND WAS STUCK IN 2ND OR 3RD GEAR ONE OF THEM. I TOOK THE CAR TO THE DEALER SEVERAL TIMES AND THE DON'T KNOW WHAT THE PROBLEM, THIS SUDDEN INCREASED IN SPEED IS VERY DANGEROUS DURING RUSH HOUR WITH TRAFFIC I NEARLY HIT THE CAR INFRONT OF ME, THE CAR STALLING IS VERY FLIGHTING WHEN ENTERING HIGHWAY. THIS CAN CAUSE A MAJOR HIGHWAY ACCIDENT. *TR

Mileage: 76,000

ENTERED HIGHWAY AND MERGED INTO TRAFFIC. BEGAN SPEEDING UP TO AROUND 55 MPH AND TRANSMISSION HESITATED AND JERKED, CAUSING ME TO SLOW DOWN TO AROUND 45 MPH. THE CAR WOULD NOT RESPOND TO THE GAS PEDAL BEING PUSHED AND WAS STUCK IN 2ND OR 3RD GEAR. I COASTED TO THE NEXT EXIT WHERE I EXITED THE HIGHWAY AND DROVE TO A SAFE PLACE TO STOP. THE TRASMISSION LIGHT CAME ON AND I HAD THE CAR CHECKED AT A NEARBY AUTOZONE TO SEE IF SAFE TO DRIVE. THEY COULD NOT DUPLICATE PROBLEM BUT AFTER STOPPED AND RESTARTING CAR, IT DID NOT HAPPEN AGAIN AND TRANSMISSION LIGHT WENT OUT. 63,000 MILES ON THE VEHICLE...I HAD MY 3 CHILDREN, ALL UNDER 5 YRS OLD WITH ME...DEFINITELY A SERIOUS SAFETY ISSUE. *LN

Mileage: 63,000

2006 FORD FUSION. CONSUMER STATES THAT THE TRANSMISSION IS NOT SHIFTING CORRECTLY. MECHANIC INFORMED THE CONSUMER THAT THERE WERE TSB'S OUT FOR THIS ISSUE. *KB THE CONSUMER STATED AFTER PAYING $3,408.45 FOR THE REPLACEMENT TRANSMISSION, A FEW WEEKS LATER SHE STARTED HAVING THE SAME PROBLEM AGAIN. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHERE THEY CONCLUDED A DEFECTIVE VALVE BODY WAS INSTALLED IN THE VEHICLE DURING A PREVIOUS VISIT. *JB

Mileage: 73,000

2006 FORD FUSION S 2.3 L WITH 5SP AUTOMATIC TRANSMISSION... WITH LESS THAN 20,000 MILES I BROUGHT MY CAR TO A FORD DEALER AND WAS TOLD NOTHING WAS WRONG WITH THE TRANSMISSION... NOW I KNOW IT SOUNDS HUGE, BUT 3 YEARS LATER HARD SHIFTING AND SOMETIMES REFUSING TO SHIFT FOR A CAR WITH AN MSRP OF 19800 AND 100000 MORE MILES OF EXTREMELY IRRITATING SHIFTING (CLUNKING) I AM UP A CREEK WITHOUT A PADDLE FOR A KNOWN FAULTY TRANSMISSION. SO EITHER I PAY ON THIS CAR FOR NEARLY 2 MORE YEARS FOR A YARD ORNAMENT OR PAY OUT 4000 TO FIX IT. THIS IS A KNOWN AND QUITE COMMON PROBLEM. I WAS TOLD IT WAS NORMAL AND NOTHING WAS WRONG... REALLY? I HAVE HAD 10 YR OLD CARS WITH 200,000 MILES THAT SHIFTED BETTER THAN THIS CAR DID AFTER 15000 MILES. RIDICULOUS....... FORD KNOWS OF THIS PROBLEM AND HAS REFUSED SERVICE AND REPLACEMENT DUE TO COST. THEY KNEW OF THIS PROBLEM 4 YEARS AGO AND STILL THOUSANDS ARE PAYING THOUSANDS OF DOLLARS TO REPAIR A FAULTY TRANSMISSION. *TR

Mileage: 15,000

WHILE DRIVING MY 2006 FORD FUSION SE V6 WITH 6 SPEED TRANSMISSION, THE TRANSMISSION STARTED SLIPPING AT 40MPH IN A SNOW STORM AND I ALMOST LOST CONTROL OF MY VEHICLE FROM THE LOSS IN POWER. IT NOW RANDOMLY SLIPS OUT OF GEAR AT ALL SPEEDS AND DOWNSHIFTS HARD LURCHING THE CAR OUT OF THE LANE. *TR

Mileage: 58,000

WHEN ACCELERATING, MERGING INTO TRAFFIC, THE TRANSMISSION POPS OUT OF GEAR AND THE ENGINE WILL CONTINUE TO ACCELERATE WHILE THE CAR COASTS, AND SLOWS. THE TRANSMISSION WILL EVENTUALLY ENGAGE A LOWER GEAR WHEN IT HAS SLOWED DOWN, BUT ONLY IF YOU ARE PATIENT AND IGNORE THE URGE TO ACCELERATE AS TRAFFIC BEARS DOWN ON YOU FROM BEHIND. THIS IS TERRIBLY FRIGHTENING AND DANGEROUS AS THE VEHICLES WHICH REQUIRE THE MOST ROOM TO STOP, USUALLY TRAVEL IN THE SAME LANE ONE IS MERGING ON TO. THIS OCCURS NOT ONLY ON FREEWAY ENTRANCES, BUT ON LONG UPHILLS AND ANYTIME ONE LETS OFF THE THROTTLE AND THEN TRIES TO ACCELERATE AGAIN QUICKLY. A DIAGNOSTIC FROM AN AUTO REPAIR SHOP REVEALS NOTHING. I HAVE CONTACTED ABOUT 30 OTHER SAME MODEL CAR OWNERS WHO DESCRIBE THE SAME PROBLEM. THE FORTUNATE FEW WHO HAVE BEEN ABLE TO GET TO THE ROOT OF THE PROBLEM HAVE SAID THAT THE DEFECT IS IN THE "VALVE BODY". MOST HAVE THIS PROBLEM AFTER THE 50,000 MILE MARK. MANY, LIKE MYSELF, HAVE HAD THIS PROBLEM FOR A LONG TIME. IT IS A MATTER OF TIME BEFORE ONE OF US GETS REAR ENDED AND CRASH, OR WORSE! *TR

Mileage: 50,000

MY 2006 FORD FUSION TRANSMISSION STARTED SLIPPING AT 34,000 MILES. DEALER SAID THERE WAS NOTHING THEY COULD DO SINCE MY CAR WAS MADE IN THE FIRST PART OF 2006, NO ADDITIONAL WARRANTIES WERE AVAILABLE. I BOUGHT THE CAR UNDER THE ASSUMPTION THAT THERE WAS A WARRANTY STILL AVAILABLE. NOW MY TRANSMISSION IS GOING OUT, I STILL OWE 11,000 ON MY CAR. AFTER TALKING TO ALOT OF FUSION PEOPLE, THIS APPEARS TO BE A VERY VERY COMMON PROBLEM. IT'S ALSO VERY DANGEROUS, THE CAR SLIPS OUT OF GEAR REVS UP AND THEN POPS BACK INTO GEAR JUST AS YOU ARE TRYING TO GET INTO A LANE. VERY DANGEROUS, I HAVE ALMOST WRECKED SEVERAL TIMES AND HAD TO PULL OVER. *TR

Mileage: 45,000

2006 FORD FUSION FAILING TO SHIFT DURING ACCELERATION, SHIFTING SUDDENLY AND VIOLENTLY, FAILING TO DOWNSHIFT AND RUNNING EXTREMELY HIGH RPM CREATING VERY DANGEROUS CONDITIONS WHEN PASSING, MERGING AND SLOWING. DEALER FAILED TO RESOLVE THE ISSUE DURING 3 SEPARATE REPAIR VISITS 2008 TO 2009. SEVERAL ATTEMPTS TO REPROGRAM TCM & PCM WERE UNSUCCESSFUL. PCM REPLACED IN 2009 BUT HAS NOT RESOLVED THE ISSUE. RESEARCH INDICATES THAT FORD IS AWARE OF DEFECTIVE TRANSMISSION VALVE BODY CAUSING THE ISSUE BUT HAS NOT DONE A RECALL. *TR

Mileage: 43,000

TRANSMISSION WOULD SHIFT OUT OF A GEAR, CAR WOULD REV UP TO HIGH, THEN TRANSMISSION WOULD SHIFT VIOLENTLY BACK IN JERKING THE CAR AROUND FEELING LIKE YOU HAVE BEEN REAR ENDED. THE TRANSMISSION WILL SLAM SO HARD INTO GEAR WHEN TRYING TO ACCELERATE( I HAVE HAD THIS EXPERIENCE ACCELERATING AT 45MPH AND AT 65MPH) ENGINE LIGHT COMES ON STAYS ON FOR A FEW DAYS GOES OFF PROBLEM COMES BACK A FEW DAYS LATER. ONLY SOLUTION WHEN THIS HAPPENS IS TO PULL OVER AND SHUT THE CAR OFF. ONCE CAR IS TURNED BACK ON THE GEAR SHIFTER (AUTOMATIC) IS VERY TIGHT TO PUT IN REVERSE OR DRIVE. *TR

Mileage: 76,000

I OWN A 2006 FORD FUSION SE WITH THE 3.0 V6 ENGINE. AT JUST OVER 55,000 MILES, VEHICLE WOULD COME OUT OF GEAR WHILE SHIFTING BETWEEN 30-60MPH, ROUGHLY 2ND-3RD, OR 3RD-4TH GEAR. VEHICLE WOULD GO INTO A HIGH REV AND NOT MOVE. AFTER LETTING OFF GAS, YOU HAVE TO WAIT 5 SECONDS FOR IT TO "RE-ENGAGE", THEN SOMETIMES IN A HIGH GEAR AT LOW SPEEDS CAUSING VEHICLE TO SHAKE VIOLENTLY. THIS IS A VERY SERIOUS AND DANGEROUS MECHANICAL FLAW WITH THIS TRANSMISSION! IT IS THE AISIN TRANSMISSION USED IN A VARIETY OF FORD, LINCOLN, AND MERCURY VEHICLES. (2005-2006 FORD FIVE HUNDRED, 2006 FORD FUSION, 2006 MERCURY ZEPHYR, 2006 MERCURY MILAN, 2005-2006 MERCURY MONTEGO) THERE ARE 100'S TO 1000'S OF COMPLAINTS ON THESE AND MULTIPLE TSB (TECHNICAL SERVICE BULLETINS) THROUGH FORD MOTOR COMPANY, ETC. (TSB 07-26-9, TSB 08-24-1) CALLING IT AISIN TRANSMISSION HARSH SHIFTING. HARSH BEING AN EASY TERM TO DESCRIBE THIS PROBLEM. AND STILL NO RECALL ON THIS OR COMPENSATION FROM DEALER OR MANUFACTURER. IF YOUR VEHICLE IS OUT OF WARRANTY, YOU ARE ON YOUR OWN WITH THIS $1,500 PLUS REPAIR ON A DEFECTIVE VALVE BODY ACCORDING TO FORD MOTOR CO. THIS IS A TREMENDOUS SAFETY ISSUE ESPECIALLY WHEN NEEDING TO MERGE OR ACCELERATE RAPIDLY TO GET ONTO A FREEWAY SYSTEM OR OVERTAKE AND PASS ON THE HIGHWAY! I GUESS IT WILL TAKE A SERIOUS INJURY OR FATALITY TO CAUSE A LAW SUIT FOR ANYTHING TO BE DONE EXCEPT A TSB! WITH ALL THE DOCUMENTATION AND COMPLAINTS I HAVE SEEN ON THESE, I HOPE THE MANUFACTURERS HAVE A STRONG LEGAL TEAM! I WILL NEVER BUY A FORD, LINCOLN, OR MERCURY AGAIN. AND WE WONDER WHY AMERICANS BUY FOREIGN! IT IS A SAD DAY PEOPLE, BUT THE TRUTH HURTS! OUR US CAR MAKERS NEED TO STAND BEHIND THEIR PRODUCTS BETTER AND IMPROVE THEIR BUSINESS ETHICS OR THEY WILL CONTINUE TO FAIL AND GO BANKRUPT. *TR

Mileage: 55,000

TL*THE CONTACT OWNS A 2006 FORD FUSION. WHILE DRIVING APPROXIMATELY BETWEEN 15-30 MPH, THE CONTACT STATED THAT THE TRANSMISSION SLIPPED IN AND OUT OF GEAR CONTINUOUSLY. IN ADDITION, THE VEHICLE WOULD JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000. UPDATED 01/11/2011*LJ

Mileage: 80,000

TRANSMISSION SLIPS IN AND OUT OF GEAR WHILE DRIVING AT ANY SPEED. THESE ARE VERY HARD GEAR SHIFTS AND THE ENTIRE CAR SHAKES. SOMETIMES IT WON'T GO INTO ANY GEAR AT ALL, INCLUDING REVERSE. THE CAR HAS UNUSUALLY HIGH RPM DURING SOME GEAR SHIFTS...PARTICULARLY WHEN SHIFTING GETS "STUCK" BETWEEN 4TH & 5TH GEARS. MY CAR WAS STUCK IN THE MIDDLE OF AN INTERSECTION BECAUSE THE TRANSMISSION FROZE AND WOULDN'T SHIFT GEARS. THE CAR CANNOT ACCELERATE AT A NORMAL SPEED ANYMORE WHICH DOESN'T ALLOW FOR NORMAL HIGHWAY DRIVING, AND IS DANGEROUS DUE TO THE FACT THAT THE TRANSMISSION IS SLIPPING GEARS OR STICKING IN A GEAR. *TR

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH AND ATTEMPTING A RIGHT TURN WHEN THE TRANSMISSION EXHIBITED A HESITATION AND BEGAN JERKING ABNORMALLY. THE RPM GAUGE DISPLAYED AN EXTREMELY LOW READING. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD. AFTER WAITING A FEW MOMENTS, THE VEHICLE RESUMED AT A LOW SPEED WITHOUT EXPERIENCING THE PREVIOUS FAILURES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE COMPLETE BRAKE SYSTEM WAS REPLACED. THE FAILURE CONTINUED TO OCCUR. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR INSPECTION. THE FAILURE WAS RELATED TO THE TRANSMISSION AND THE TECHNICIAN DETECTED THE THAT THE GEARS WERE STICKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT TRANSMISSION SHOP FOR A SECOND OPINION WHERE THEY STATED THE SAME DIAGNOSIS AS MENTIONED BY THE DEALER. THE CONTACT WAS WAITING UPON A RESPONSE FROM THE MANUFACTURER REGARDING THE TRANSMISSION FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 61,000.

Mileage: 61,000

I OWN A 2006 FORD FUSION, WHEN DRIVING ON THE HIGHWAY WHILE TRYING TO PASS ANOTHER VEHICLE, THE CAR WILL DROP OUT OF GEAR. THE CAR WILL NOT REENGAGE UNTIL THE TACHOMETER RETURNS TO AN IDLE. EVEN THEN THE CAR MAY NOT ENGAGE THE GEAR AGAIN. WITH ONCOMING TRAFFIC OR OTHER CARS BEHIND THIS CAUSES AN UNSAFE CONDITION. *TR

Mileage: 78,000

ON THE INTERSTATE AND GAVE CAR THE GAS TO GO AROUND A TRUCK AND THE CAR REVVED THE ENGINE AND THE TACHOMETER WENT ALL THE WAY DOWN. LET OFF THE GAS AND THE CAR WAS STUCK IN HIGH GEAR AND WOULD NOT SHIFT TO A LOWER GEAR. HAD TO DRIVE THE CAR THAT WAY IN STOP AND GO TRAFFIC IN ABLE TO PULL OFF THE ROAD. ONCE THE CAR WAS TURNED OFF AND RESTARTED IT RESET ITSELF AND HAD LOWER AND UPPER GEARS IN TRANSMISSION. THE CAR STILL JERKS AND DOESN'T WANT TO GO INTO DIFFERENT GEARS WHEN DRIVING. TOOK CAR TO DEALER SHOP AND WAS TOLD THAT IT HAD A TSB BULLETIN ABOUT THE TRANSMISSION VALVE BODY. THERE IS A PROBLEM WITH THIS AND THEY WOULD NOT ADMIT TO A PROBLEM WITH THE TRANSMISSION. SEARCHING THE INTERNET I AM NOT THE ONLY ONE WITH THIS PROBLEM (100'S OF PEOPLE). *TR

Mileage: 52,879

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHEN TRAVELING AT ANY SPEED AND DOWNSHIFTING, THE VEHICLE WOULD BEGIN TO SHAKE AND VIBRATE VIOLENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE FAILURE. THE CURRENT MILEAGE WAS 41,000 AND THE FAILURE MILEAGE WAS 38,000.

Mileage: 38,000

2006 FORD FUSION, WITH 65000 MILES, TRANSMISSION GETTING STUCK BETWEEN SECOND AND THIRD GEAR. WHEN THE TRANSMISSION IS STUCK, THE CAR WILL REV TO 5-6K RPMS AND DROP SEVERELY IN SPEED. WHEN MOVING FROM A STOP POSITION THE CARE THEN TAKES ABOUT 40-60 SECONDS TO GET UP TO 25MPH (BECAUSE IT IS STILL IN SECOND OR THIRD GEAR). THIS OCCURRED WITH ME ENTERING AN ON RAMP TO A FREEWAY AND DRIVING FROM A STOP LIGHT IN A BUSY BUSINESS DISTRICT. I TOOK THE CAR INTO THE DEALERSHIP WHERE THE CAR WAS PURCHASED AND SERVICED SINCE PURCHASE 12/31/2005. AFTER THE FIRST DAY IN THE SHOP THE DEALER TOLD ME THE TRANSMISSION IS BEYOND REPAIR AND I NEED A NEW (REBUILT) FORD TRANSMISSION. THEY WANTED $80 FREIGHT FOR DELIVERY OF TRANSMISSION AND APPROX. $4500 FRO THE TRANSMISSION AND INSTALLATION. WHEN I BOUGHT OUT MY LEASE LAST YEAR I PURCHASED AN EXTENDED WARRANTY ON MY CAR (THE ORIGINAL ENDED AT 36000 MILES). IT HAS NOW BEEN FIVE DAYS WITH MANY PHONE CALLS, A RENTAL CAR (ONLY COVERED FIVE DAYS UNDER MY WARRANTY), AND A VISIT FROM A PRIVATE INSPECTOR/ADJUSTER. THE WARRANTY COMPANY IS STILL "REVIEW THE CLAIM" AND HAS NOT YET AUTHORIZED THE REPAIR. WITHOUT AUTHORIZATION FROM THE WARRANTY CO I CAN NOT BEGIN REPAIRS. IT WILL TAKE 2-3 DAYS TO GET THE TRANSMISSION SHIPPED AND 2-3 DAYS FOR THE REPAIR. I BELIEVE FORD SHOULD BE RESPONSIBLE AND RECALL THE TRANSMISSIONS. NOT ALL OWNERS HAVE THE EXTENDED WARRANTY LIKE I DO. THE FAILING TRANSMISSIONS ARE A HUGE SAFETY DEFECT AND COULD LEAD TO EXPENSIVE REPAIRS, ACCIDENTS AND DEATH. SIMILAR COMPLAINT CAN BE FOUND ON REPAIR PAL AT: HTTP://REPAIRPAL.COM/TRANSMISSION-PROBLEM-242. *TR

Mileage: 65,000

MY 2006 FORD FUSION SEL V6 STARTED VIOLENT JERKING WHILE DRIVING. I AM AFRAID TO DRIVE IT BECAUSE I HAVE ALMOST REAR ENDED ANOTHER CAR WHEN ACCELERATING AND THE JERKING HAPPENED. MY HUSBAND THINKS IT IS THE TRANSMISSION BUT IT IS OUT OF WARRANTY AND WE DON'T HAVE THE MONEY TO REPAIR IT. IT SEEMS LIKE THERE ARE MANY OTHER OWNERS OUT THERE (DUE TO THE MASS FORUMS AND THE TSB'S) THAT ARE EXPERIENCING THE SAME PROBLEM. FORD IS DOING NOTHING ABOUT IT EVEN THOUGH THERE ARE PLENTY OF DOCUMENTATIONS THAT IT IS AN ONGOING SITUATION. IT OCCURS EVERYTIME THE VEHICLE IS DRIVEN. I DON'T FEEL SELLING IT TO SOMEONE ELSE IS THE ETHICAL SOLUTION. FOR SHOULD BACK/STAND BEHIND THERE PRODUCT. NOT RUN FROM THE PROBLEM. PEOPLE COULD BE SERIOUSLY HURT, IN FACT, I WOULDN'T BE SURPRISED IF THERE AREN'T REPORTED INJURIES. *TR

Mileage: 66,150

06 FORD FUSION TRANSMISSION SLIPS OUT OF GEAR AROUND 25-35 MPH. THIS HAPPENED ON THE HIGHWAY RESULTING IN 4 CARS ALMOST HITTING US & ALMOST CAUSING 2 OTHER ACCIDENTS. IT HAS BEEN GETTING PROGRESSIVELY WORSE FOR A MONTH NOW. IT'S @ THE DEALERSHIP NOW ,THEY SAID THERE IS NOTHING WRONG WITH IT @ 1ST,NOW THEY SAY THEY HAVE DUPLICATED THE PROBLEM & I NEED A NEW TRANSMISSION $4700. THE CAR HAS 54K MILES ON IT. I HAVE READ NUMEROUS OTHER COMPLAINTS ONLINE @REPAIRPAL.COM. SOMETHING NEEDS TO BE DONE,THIS IS A VERY HAZARDOUS PROBLEM. *TR

Mileage: 54,000

TL*THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT A PLASTIC PIECE OVER THE BUTTON ON THE GEAR SHIFT BROKE INSIDE THE SHIFTER. THE BROKEN PIECE CAUSED THE VEHICLE NOT TO ACKNOWLEDGE THAT THE VEHICLE WAS IS IN PARK AND CAUSED THE KEY TO BECOME STUCK IN THE IGNITION. THE DEALER STATED THAT THE ENTIRE GEAR SHIFT NEEDED TO BE REPLACED. THE CONTACT WAS CONCERNED ABOUT NUMEROUS COMPLAINTS REGARDING THE GEAR SHIFT AND THE KEY FOR HIS YEAR, MAKE AND MODEL VEHICLE. THE CONTACT STATED THAT THIS WAS A SAFETY CONCERN SINCE IT MAY BE DIFFICULT TO DETECT THAT THE BROKEN PIECES WERE DAMAGING THE GEAR SHIFT. THE FAILURE MILEAGE WAS 40,000. UPDATED 11/05/10. *LJ

Mileage: 40,000

AUTOMATIC TRANSMISSION SLIPS OUT OF GEAR DURING ACCELERATION. WHEN DOWNSHIFTING IT SLIPS AND SOMETIMES SLAMS ITSELF INTO GEAR. STARTING FROM A STOP SOMETIMES THE TRANSMISSION DOESN'T SEEM TO KNOW WHICH GEAR TO START IN AND SLAMS INTO 1ST. THE MOST FREQUENT PROBLEM IS THAT OF THE TRANSMISSION DROPPING OUT OF GEAR UPON ACCELERATION OR TRYING TO TOP A GRADE. IF YOU ARE NOT CAREFUL THE RPMS WILL REACH 5000+ RPMS. THIS ISSUE BEGAN AROUND 50K MILES. FORD DEALERSHIP IN STERLING HEIGHTS MICHIGAN CHECKED THE TRANSMISSION IN APPROX MAY OF 2008 AND THEY ONLY OFFERED A COMPLETE TRANSMISSION REPLACEMENT AT A COST OF 4K+, THEY COULD NOT DETERMINE WHAT THE PROBLEM WAS. *TR

Mileage: 60,000

AUTOMATIC TRANSMISSION SLIPS OUT OF GEAR WHEN GOING UP A HILL OR WHEN PASSING ANOTHER VEHICLE. THE CAR MAKE A ROUGH NOISE AND YOU HAVE TO BRAKE IN ORDER TO GET THE CAR TO CHANGE GEARS. WHEN THE CRUISE CONTROL WAS SET AT 65 MPH THE CAR APPROACHED A SMALL HILL AND THE GEAR WOULD NOT CHANGE AND MADE A AWFUL NOISE. I TOOK THE CAR TO A FORD DEALERSHIP FOR DIAGNOSTIC CHECK AND IT REVEALED THAT I NEED A TRANSMISSION. THE COST WAS QUOTED AT 4900.00. THIS STARTED APPROX 2 MONTHS AGO AND IS STILL HAPPENING. *TR

Mileage: 91,000

TRANSMISSION FAILS TO RESPOND MOSTLY DURING SHIFTS IN THE RANGE FROM 2ND TO 5TH GEAR. THE CAR FAILS TO ACCELERATE, TRANSMISSION/ENGINE WINDS AND BECOME USELESS UNTIL YOU LET THE CAR RETURN TO FIRST GEAR. THIS DOESN'T ALLOW FOR PROPER PASSING MANEUVERS. THE TRANSMISSION ALSO CLANKS WHEN DOWNSHIFTING. *TR

Mileage: 107,000

PURCHASED 2006 FORD FUSION SEL 6 CYL., WITH ROUGHLY 48K ON IT AND CURRENTLY HAVE 62K ON IT NOW, IN/AROUND OCTOBER OF 2009, AND ABOUT 3 MONTHS AGO STARTING HAVING TRANSMISSION PROBLEMS. UPON ACCELERATING BETWEEN 25-40, THE TRANSMISSION JUMPS IN AND OUT OF GEAR, OFTEN MAKING A LOUD BANGING NOISE AND TAKING AWAY ALL ACCELERATION. IN ORDER FOR IT TO GET BACK INTO GEAR, YOU HAVE TO COMPLETELY LET OF THE GAS AND IT WILL EVENTUALLY GO BACK INTO GEAR. THIS ALLOWS FOR MINIMAL ACCELERATOR AT BEST WHEN TRYING TO SPEED UP. THIS FAILURE OCCURS RANDOMLY EVERYTIME I DRIVE THE VEHICLE. IF NOT FIXED, THE TRANSMISSION IN MY CAR WILL EVENTUALLY GO BAD. I TOOK IT IN TO ADVANCED AUTOMOTIVE IN ANN ARBOR TO HAVE IT FIXED. THEY TOLD ME, AFTER DOING EXTENSIVE RESEARCH DUE TO NO CODES SHOWING UP ON THE COMPUTER, THAT ON THE FORD BULLETIN IT WAS GOING TO NEED A NEW VALVE BODY, TRANSMISSION FLUSH, AND REPROGRAMMING. THIS IS GOING TO COST ROUGHLY $2200. THE VALVE BODY, FROM FORD, WAS $1400. *TR

Mileage: 58,000

TL*THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THEY WERE UNABLE TO REMOVE THE KEY OUT OF THE IGNITION. THE RING AROUND DRIVE SHIFT WAS BROKEN AND GAVE THE APPEARANCE THAT THE VEHICLE WAS IN PARK WHEN IT WASN'T WHICH ALSO MADE IT IMPOSSIBLE TO REMOVE THE KEY FROM THE IGNITION. WHEN THE BROKEN RING WAS REMOVED, THE CONTACT WAS ABLE TO REMOVE THE KEY FROM THE IGNITION; HOWEVER, THE TRANSMISSION CONTINUED TO MALFUNCTION. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLAINT. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 50000.

Mileage: 50,000

2006 FORD FUSION - NORMAL DRIVING UNTIL I HIT 59,500 MILES. TRANSMISSION WOULD SLIP AFTER REACHING APPROXIMATELY 40 MPH AND THE EMISSIONS LIGHT WOULD TURN ON. IT WAS TAKEN TO THE DEALER ON 5/14/10, AND I WAS TOLD IT WAS THE TRANSMISSION WHICH WAS COVERED UNDER THE EXTENDED WARRANTY. AFTER TRANSMISSION WAS REPAIRED, THE CAR WAS PUT ON DIAGNOSTICS AND NOW THE POWER MODULE NEEDED TO BE REPLACED. THE CAR WAS BROUGHT IN ON 5/14/2010 AND IT IS 7/28/10 AND I STILL HAVE NOT RECEIVED THE CAR. THEY ARE WAITING FOR THE PART WHICH THEY SAY WAS RECEIVED TODAY. AND BECAUSE I BROUGHT MY CAR IN FIRST, I GET THE PART FIRST. THERE IS ANOTHER 06 FUSION WITH THE SAME ISSUE, WAITING FOR THE SAME PART. WAS THE PART ON BACK ORDER FOR SO LONG BECAUSE FORD NEEDED TO REPLACE SO MANY OF THEM? MY GUESS IS YES. I WAS TOLD THE PART WOULD BE IN JULY 15 AND IT WAS JUST RECEIVED TODAY (7/28/10). *TR

Mileage: 59,500

I AM UNABLE TO REMOVE MY KEY FROM MY IGNITION UNLESS I REMOVE A PIECE OF THE SHIFTER ON MY TRANSMISSION. *TR

Mileage: 55,550

EVENTS LEADING: NORMAL DRIVING OPERATION. FAILURE:TRANSMISSION SLIPS AFTER REACHING 35 MPH+, OCCURS ANYTIME I AM ON THE HIGHWAY GOING UPHILL OR TRYING TO PASS. HAVE SEEN MANY FORUMS WITH OTHERS THAT ARE HAVING SIMILAR ISSUES. CAUSES MY CAR TO SLIP OUT OF GEAR UNTIL I LET OFF THE ACCELERATOR OR CAUSES A VERY HARD SHIFT CAUSING THE TRANSMISSION TO BANG REALLY LOUD. WHAT HAS BEEN DONE TO FIX: NOTHING CURRENTLY, HAVE ONLY DONE RESEARCH INTO THE ISSUE AND FOUND MANY FORUMS WITH INDIVIDUALS THAT HAVE SIMILAR ISSUES AND HAVE HAD THEIR VEHICLES IN TO THE DEALER ONLY TO HAVE THEIR CAR WORKED ON AND STILL HAVE PROBLEMS. *TR

Mileage: 88,353

MY 2006 FORD FUSION 3.0L V-6 IS EXPERIENCING SEVERE PROBLEMS WITH THE TRANSMISSION. THIS ALL STARTED AT 55,000MI. IT WILL SLIP OUT OF GEAR AT ACCELERATION AND CLUNKS AND THUDS WHEN IT IS DOWNSHIFTING. THIS IS AN EXTREME SAFETY HAZARD, ESPECIALLY IF YOU DECIDE TO TURN QUICKLY IF FRONT OF ON COMING TRAFFIC. THE TRANS JUST MAY NOT CATCH. FORD ENGINEERS KNOW WHAT THE PROBLEM IS. IT IS THE TRANSMISSION WHICH FORD PURCHASED FROM "AISEN" IN GERMANY. THEY HAVE A DEFECTIVE CONTROL BODY WHICH HAS EXTREME SPOOL BORE WEAR. SOMEONE BETTER REQUIRE FORD TO FIX THIS ISSUE BEFORE SOMEONE GETS HURT.... I HAVE MANY CLOSE CALLS SINCE I OWNED THIS CAR. THE DEALER WANTS TO CHARGE ME 5000.00 TO FIX THEIR ISSUE. WHY IS FORD SO HUSH HUSH? *TR

Mileage: 55,000

THE PUSH BUTTON ON THE GEAR SHIFT WILL NOT FULLY COME OUT, THUS ALLOWING SHIFTING WITHOUT THE NEED TO DEPRESS THE BUTTON. THIS ISSUE HAS ALSO RESULTING IN NOT BEING ABLE TO REMOVE THE KEY. SINCE THE LOCKING/UNLOCKING REMOTE IS INTEGRATED INTO THE KEY ITSELF, I CANNOT LOCK THE CAR WITHOUT THE SECOND KEY. NOT ONLY IS LEAVING THE KEY IN THE IGNITION AKIN TO GIFT WRAPPING THE CAR FOR THIEVES, THE SHIFTING ISSUE IS ABSOLUTELY A SAFETY CONCERN! I SEARCHED THE PROBLEM AND IT APPEARS VERY COMMON, SO MUCH SO THAT A TSB HAS BEEN ISSUED. FORD NEEDS TO OWN UP TO THIS ISSUE. *TR

Mileage: 96,280

2006 FORD FUSION. CONSUMER STATES TRANSMISSION HAS SLIPPED *TGW THE CONSUMER SENT IN A TSB THAT WAS ISSUED REGARDING TRANSMISSION PROBLEMS ON CERTAIN VEHICLES.. *JB

HIGHWAY OR REGULAR ROAD DRIVING TRANSMISSION GIVES OUT. THE TRANSMISSION RED LINES AND THE CAR FAILS TO RESPOND MOSTLY ON SLIGHT TO MODERATE INCLINES. YOU MUST LET UP OFF THE GAS AND ALLOW THE RPMS TO DROP TO NORMAL AND ALLOW FOR THE CAR TO CHANGE GEARS. DEALERSHIP CLAIMS NO ISSUES BUT THEY DO HAVE A TSB ON THE PROBLEM BUT CLAIM THAT CUSTOMER NEEDS TO PAY $2500 TO FIX THE PROBLEM. *TR

Mileage: 106,000

I HAVE HAD MY 2006 FUSION FOR TWO YEARS. MY TRANSMISSION STARTED SLIPPING AROUND 60,000 MILES. AT FIRST IT ONLY SLIPPED WHEN I TRIED TO ACCELERATE QUICKLY, BUT OVER THE LAST FEW MONTHS IT HAS GOTTEN WORSE. I AM AFRAID TO DRIVE IT ON THE HIGHWAY BECAUSE WHEN IT SLIPS IT JUMPS OUT OF GEAR AND I CAN'T ACCELERATE AT ALL. I JUST PRAY THAT THE PERSON BEHIND ME CAN SLOW DOWN IN TIME NOT TO HIT ME AND MY CHILDREN. IT TAKES A FEW MILES FOR IT TO JUMP BACK INTO GEAR. I HAVE HAD TO PULL OVER ON THE SIDE OF THE ROAD TO WAIT FOR IT TO GET BACK INTO GEAR. I CANNOT AFFORD A NEW TRANSMISSION! THIS CAR REPLACED MY FORD ECONOLINE WHICH I DROVE FOR OVER 200,000 MILES BEFORE ITS TRANSMISSION WENT OUT. IF I WANTED TO BUY A TRANSMISSION I WOULD HAVE BOUGHT ONE FOR THE VEHICLE I WAS REPLACING. THIS IS THE ONLY CAR I HAVE TO GET MY KIDS AND MYSELF TO WORK AND TO SCHOOL. I CANNOT AFFORD EXPENSIVE REPAIRS ON A RELATIVELY NEW CAR; AND I SHOULDN'T HAVE TO. THESE CARS ARE DANGEROUS. *TR

Mileage: 60,000

TRANSMISSION FAILED WITHOUT WARNING AT 67,000 MILES UPON ENTERING HIGHWAY WHERE ACCELERATION IS REQUIRED. UNABLE TO GET TO SPEED CONSISTENT WITH HIGHWAY TRAFFIC. AUTOMOBILE IS FORD FUSION, 2006. *TR

Mileage: 67,000

TRANSMISSION ON VEHICLE IS NOT GOOD AT ALL... THERE ARE MANY CONSUMERS THAT ARE HAVING THIS SAME ISSUE AS 50,000 MILES SNA ABOVE. THERE ARE MANY COMPLAINTS ON THE WEB AND IN FORUMS ON THE 2006 FORD FUSIONS. THE CAR WILL SHAKE WHILE DRIVING AND ALSO IT WILL SWITCH GEARS ON ITS OWN AS WELL AS THE GEAR WILL GET STUCK. THIS IS UNSAFE AND VERY UNSAFE WHEN ON THE HIGHWAY. HAS HAD THE PROBLEM FIXED AND THE VEHICLE HAD BEGAN HAVING THE SAME PROBLEMS AND MUCH WORSE. *TR

Mileage: 52,456

HAVING TRANSMISSION ISSUES AT 50,000 AND ABOVE ON THE 2006 FORD FUSION... I HAVE RESEARCHED THIS ISSUE AND FORD HAS TRIED TO BRUSH IT OFF AS I NEED A BRAND NEW TRANSMISSION, BUT I MADE THEM CHECK THEIR SERVICE ALERTS... THERE IS AN ALERT OUT ON ALL 2006 FORD FUSION'S WITH A CERTAIN ISSUE WITH THE TRANSMISSION AND SINCE THERE IS AN ALERT OUT ON IT. I WAS WONDERING WHY THERE ISN'T A RECALL ON THIS VEHICLE? MY CAR IS VERY UNSAFE TO DRIVE, IT SLIPS IN AND OUT OF GEAR AND IT IS VERY UNSAFE TO DRIVE ON THE HIGHWAY BECAUSE IT WILL GET STUCK IN CAR AND VERY UNSAFE TO DRIVE ON REGULAR ROADS AT REGULAR SPEEDS. AS IT WILL GET STUCK IN LOWER GEARS AS WELL. I DO PLAN ON GETTING THE PROBLEM FIXED BECAUSE I NEED MY CAR, BUT I ALSO FEEL THAT I SHOULD NOT HAVE TO PAY SINCE FORD HAS A KNOWN ISSUE OF THIS PROBLEM ON THIS MODEL CAR. WHAT WILL IT TAKE? FOR SOMEONE TO BE DRIVING ON THE HIGHWAY AND THEIR CAR GETS STUCK IN GEAR AND CAUSE AN ACCIDENT THAT WILL KILL THEM AND ANOTHER PERSON. I HOPE THIS IS INVESTIGATED AND WILL HELP THE NEXT MAN. *TR

Mileage: 64,000

TRANSMISSION STICKS IN GEAR, THEN ABRUPTLY CHANGES. LATEST INCIDENT OCCURRED WHILE ATTEMPTING TO ACCELERATE FROM STOP AND GO TRAFFIC ON THE FREEWAY, CAR STRUGGLED TO REACH 40 MPH WHILE OTHER VEHICLES REACHED SPEEDS OF APPROXIMATELY 55-65 MPH. *TR

TRANSMISSION IN 2006 FORD FUSION KEEPS SLIPPING WHEN ATTEMPTING TO SPEED UP OR GOING UP A STEEP HILL. *TR

Mileage: 59,000

I HAVE A 2006 FORD FUSION THAT HAS DEVELOPED A TRANSMISSION PROBLEM. IT HAS BEEN DIAGNOSED AS A VALVE BODY DEFECT WITH A SERVICE BULLETIN DATING BACK TO 2001. I FIRST CONTACTED THE DEALERSHIP TO INVESTIGATE THE PROBLEM IN DECEMBER 2008, BUT THE TRANSMISSION DEPARTMENT WAS CLOSED (ON A SATURDAY). MY MILEAGE AT THAT TIME WAS 35129 (WELL WITHIN WARRANTY PERIOD). I WASN'T ABLE TO MAKE IT BACK UNTIL SEPT. OF '09 FOR EVALUATION, AND THEY JUST DID A SOFTWARE UPGRADE. BACK AGAIN WITH SAME PROBLEM IN NOV. '09 WHEN THEY INDICATED THE VALVE BODY FROM TSB DATED 08/24/01. IT HAS NEARLY CAUSED ME TO HAVE SEVERAL ACCIDENTS BECAUSE AT RANDOM TIMES, THE TRANSMISSION POPS INTO NEUTRAL WHETHER ON THE HIGHWAY, TURNING A CORNER, OR ACCELERATING - THEN POPS BACK INTO GEAR, CAUSING THE CAR TO BUCK VIOLENTLY. CARS BEHIND ME HAVE NEARLY RAMMED INTO MY CAR BECAUSE OF THIS SUDDEN FAILURE OF MY TRANSMISSION. I FEEL THIS SHOULD BE A RECALL AND CORRECTED BY FORD CORPORATE. THIS PROBLEM HAS OCCURRED ON SEVERAL OCCASIONS. I HAVE DOCUMENTED SOME OF THE MORE SEVER INCIDENCES. THE LATEST INCIDENCES WERE YESTERDAY, 3/30/10. I CALLED THE LOCAL DEALERSHIP AS WELL AS FORD CORPORATE, BUT THEY SAY THE PROBLEM IS NOT UNDER WARRANTY.

Mileage: 35,129

PUSH BUTTON RETAINING CLIP FOR SHIFTER HANDLE IS BROKEN, CAR WILL SHIFT INTO ANY GEAR WITHOUT PRESSING BUTTON. DEALER WANTS $500 TO REPLACE A FAULTY PLASTIC CLIP

Mileage: 61,234

I DRIVE 2006 FORD FUSION THAT HAS ABOUT 74K AND HAVE NOT HAD ANY PROBLEMS WITH UNTIL YESTERDAY. MY GEAR SHIFT WAS STUCK AND WOULD NOT GO INTO PARK AND AFTER I HAD TO FORCE IT TO GO IT TO PARK I COULD NOT LEAVE MY KEYS FROM THE IGNITION. NOW MY CAR CAN NOT BE LOCKED AND IT CAN BE KNOCKED OUT OF GEAR BY JUST A PUSH OF A HAND. I AM AFRAID TO PARK MY CALL, AFRAID THAT IT MIGHT ROLL AND HURT SOMEONE. I CONTACTED FORD AND THEY SAID THAT I WOULD HAVE TO BRING IT IN AND THAT IT COULD COST UP TO $400.00. I HAVE GOOGLE THIS ISSUE AND FOUND THAT OVER 50 FUSION OWNERS HAVE HAD THE SAME PROBLEM. I DO NOT HAVE THE MONEY TO GET THIS FIXED BUT I CAN'T EVEN GO INTO A STORE WITHOUT WORRYING THAT MY CAR IS GOING TO ROLL AWAY OR SOMEONE MIGHT STEAL IT. *TR

Mileage: 74,000

2006 FORD FUSION KEY WILL NOT COME OUT OF IGNITION; GEAR SHIFT DOES NOT GO INTO PARK EVEN THOUGH IT LOOKS AS THOUGH IT HAS. *TR

Mileage: 93,000

I OWN A 2006 FORD FUSION AND THE KEY WILL NOT COME OUT OF THE IGNITION. I HAVE RESEARCHED THE PROBLEMS ON FORD'S FORUMS AND MANY, MANY PEOPLE HAVE HAD THIS SAME PROBLEM AND EXPLAIN THAT REMOVING THE SILVER RING ON THE SHIFTER KNOB WILL FIX THE PROBLEM. HOWEVER, I DON'T WANT TO DO THIS AND HAVE MY CAR ROLL DOWN MY DRIVEWAY AND KILL SOMEONE. *TR

I OWN A 2006 FORD FUSION 4 DOOR SEDAN. UPON ARRIVING HOME FROM A SHORT TRIP, I ATTEMPTED TO SHUT MY CAR OFF. I SHIFTED INTO WHAT I THOUGHT WAS PARK AND SHUT THE CAR OFF. MY KEY WOULD NOT RELEASE FROM THE IGNITION. I ATTEMPTED TO SHIFT THE CAR INTO PARK AGAIN AND IT SHOWED IT WAS IN PARK. THE KEYS STILL WOULD NOT RELEASE FROM THE IGNITION. I FINALLY WENT INTO MY HOME AND LOOKED ONLINE. I FOUND ONLINE A DESCRIPTION OF THE PROBLEM AND A TEMPORARY SOLUTION. IT SEEMS THE DECORATIVE RING AROUND THE BUTTON ON THE SHIFTER KEEPS THE BUTTON FROM FULLY DISENGAGING. I WENT BACK OUT TO MY CAR AND TRIED TO SHIFT OUT OF PARK WITHOUT HITTING THE BUTTON AND WAS SUCCESSFUL AT WHICH TIME THE CAR WAS EASY TO ROLL. IF THE CAR WAS PARKED ON A SLOPE AND THE SHIFTER DID NOT FULLY ENGAGE IN PARK IT IS POSSIBLE THAT IT COULD POP INTO NEUTRAL AND ROLL AWAY. I ATTEMPTED TO CALL MY LOCAL DEALER AND WAS TOLD THAT THE SERVICE DEPARTMENT WAS CLOSED AND NOBODY WOULD BE ABLE TO HELP ME. THIS HAS HAPPENED 3 OR 4 OTHER TIMES AND EVENTUALLY THE KEYS CAME OUT BUT ON THIS PARTICULAR INCIDENT I STRUGGLED WITH IT FOR MOST OF AN HOUR BEFORE I FINALLY LOOKED ON THE INTERNET FOR THE SOLUTION. *TR

Mileage: 77,000

TL*THE CONTACT OWNS A 2006 FORD FUSION. SHE STATED THAT HER KEYS WOULD NOT DISLODGE FROM THE IGNITION. THE DEALER STATED THAT THE COLUMN SHIFT FAILED AND NEEDED TO BE REPLACED. THE DEALER ESTIMATED REPAIRS AT OVER $400 AT THE OWNER'S EXPENSE. THERE WERE NO RECALLS FOR THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE UNDER 70,000.

Mileage: 70,000

SEVERAL PROBLEMS WITH 2006 FORD FUSION SE IGNITION ON/OFF, KEY REMOVAL AND GEAR SELECTION. WHEN STARTING CAR, COMES OUT OF GEAR. ON STARTUP, GEAR SHIFT WILL NOT ENGAGE/DISENGAGE FULLY. ON STARTUP, CANNOT START MOTOR BECAUSE GEAR SHIFT WILL NOT FULLY ENGAGE "PARK". KEY CANNOT BE REMOVED FROM IGNITION WHEN TURNING CAR OFF. WHEN AT STOPLIGHTS, TRANSMISSION WILL SLIP OUT OF GEAR. *TR

Mileage: 50,000

CAR JUMPING, AND HESITATING. IT HAPPENED ALOT. ENGINE LIGHT WOULD COME ON. TOLD THAT THERE WAS NOTHING WRONG, AND THAT IF THE GAS CAP OR ENGINE TOP WASN'T ON THAT IT WAS CAUSE THE LIGHT TO GO ON, AND WAS TOLD ABOUT THE JUMPING OF THE CAR THAT THE SENSOR NEEDED TO CATCH UP TO THE ENGINE, THAT IS WHAT IS WAS SUPPOSE TO DO. ALSO CAR SWITCHING ITS GEAR BY ITSELF THEN SLOWING DOWN AND LOSING POWER ON THE HIGHWAY. WOULD HAVE TO PULL OVER PUT THE CAR IN PARK, THEN PROCEED TO PUT IT IN DRIVE THEN IT WOULDN'T HAPPEN FOR A COUPLE OF WEEKS. *TR

Mileage: 60,000

VEHICLE FAILED IN HIGH TRAFFIC, CAR JERKED AND WHEN I PUSHED THE GAS I HAD NOTHING, NO CONTROL. I WAS ABLE TO GET THE CAR SAFELY OFF THE ROAD AS CARS SWERVED BY. THE CAR DOES NOT ALWAYS DO THIS. TOOK THE CAR TO THE DEALER WHERE I BOUGHT IT TWO TIMES, THEY NOW SAY I NEED TO REPLACE THE TRANSMISSION. THIS FORD FUSION 2006 HAS ONLY 49,000 MILES ON IT. IT IS A SAFETY HAZARD, BUT FORD OR THE DEALER SO FAR TO DATE WILL NOT FIX IT. HELP! THIS CAR IS A DANGER TO MY FAMILY AND OTHER DRIVERS AROUND ME. *TR THE CONSUMER WANTED TO KNOW THE STATUS OF HIS COMPLAINT. UPDATED 01/13/10.*JB

Mileage: 48,500

TL*THE CONTACT OWNS A 2006 FORD FUSION. ON THREE SEPARATE OCCASIONS, WHILE DRIVING VARIOUS SPEEDS, THE ENGINE REVVED HIGH AND JERKED HARD INTO GEAR WHEN THE BRAKE PEDAL WAS DEPRESSED. THE DEALER STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 51,000 AND FAILURE MILEAGE WAS 49,000.

Mileage: 49,000

2006 FORD FUSION I-4 MANUAL TRANSMISSION CLUTCH FAILED ON FREEWAY EXIT RAMP. VEHICLE WAS UNDRIVABLE AND OBSTRUCTED RUSH HOUR TRAFFIC. THERE WAS ONLY 18,804 MILES ON THE VEHICLE. *TR

Mileage: 18,804