2011 FORD FUSION Electrical System Problems

am filing this complaint regarding a serious safety defect in my 2011 Ford Fusion. The vehicle’s electric power steering (EPAS) intermittently fails while driving, causing the steering to become extremely heavy and sometimes lock up. The dashboard displays a “Power Steering Assist Fault” warning. Restarting the car temporarily restores steering assist, but the problem recurs. This is a direct safety hazard. Driving the vehicle in this condition is dangerous, as the steering can fail at any time, including at highway speeds. They say The vehicle was previously repaired under recall but the issue has recurred. I have contacted Ford Customer Service and a Ford Safety Supervisor multiple times, and they refused to perform any further repair, citing that the recall occurred over 10 years ago and my VIN may not be in the current “recall bin.” I am requesting that the National Highway Traffic Safety Administration investigate this issue and require Ford to repair the electric power steering under a recall reoccurrence / safety escalation program, at no cost to me. This is a critical safety issue, and the current refusal by Ford puts me at risk of serious injury or death while driving.

My driver heating element in my seat stopped working. I went to get it fixed and that’s when they noticed the charred heating pad in the seat had burnet makers on it. I have picture showing that the electrical part in the heating pad indicator has black marks around the wires and burnt through the pad and the electrical coils. The seat under the leather part had damage to it. This would have caused a fire. I’m very lucky. I bought the part on [XXX]. I just want to be reimburse from Ford Dealership the part cost. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The Power Steering failed on a 2011 ford fusion se. The recall supposedly ended after 150k miles and I’m 150 miles over and they refused to do it which is shady. Never had a issue until I passed the certain mileage.

As stated in a previous complaint vehicle has what one professional mechanic diagnosed as an "electrical fathom draw" which drains the battery. The issue with the vehicle started on July 1st which the timing seems ironic since it was the first day of the month. I have taken the vehicle to several qualified mechanics who could not diagnose what was draining the battery. Purchased a new battery and still having the same issue. Each time I had roadside assistance jumpstart the battery they stated it was not the altenator or the starter. No codes to perform a diagnostic like "check engine" light or other warning signs.

The steering wheel becomes stiff and won’t move.. I can not turn it at all if I’m driving.. which can cause me to have an accident because I can’t even turn the wheel. Also I called Ford here in Mississippi and they said my particular VIN was not in the recall for power steering problems but it was in the years that were recalled. My teenager drives this car and that’s how we found out, she called me panicking and that could have ended very badly.

#FMSCA v. #GST . * DEATH by HAZMAT 12/12/12. 07/07/07. 05.05.05. Few other dates. *Voip, *Sirus , IQ EMS speaks only central asia languages. Unknown war zone in conflict by indemnity policy in place via marriage certificate. EMT heisted by satellite controls of vehicle and few other fuel funds fuels DBA . Heisted all of my USA insurance associate with land records retrieval orders.

The contact owns a 2011 Ford Fusion. The contact stated that the vehicle had failed to start. The vehicle was taken to several independent mechanics to be diagnosed. The contact stated that a mechanic replaced the starter; however, the failure persisted. The contact related the failure to an unknown recall. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 145,000. The VIN was not available.

Mileage: 145,000

The "Power Steering Assist Fault" light came on when the car was started and the steering wheel was very heavy and hard to move. Simultaneously, the "Service AdvanceTrac" light also came on. The vehicle was later scanned and an internal component failure code "U-3000:04-68" was identified for the Power Steering Motor. This is an internal system failure. The safety risk was to the driver along with other drivers on the road due to the vehicle being harder to control. The failure happened during a 600 mile drive and the vehicle was driven home carefully as no other arrangements could be made. Driver sustained wrist injury and pain at the carpals from increased effort needed to manually steer vehicle. The "Power Steering Assist Fault" had previously appeared for a couple seconds upon vehicle start up but had not previously disabled the power steering. It had been originally reprogrammed with the recall in 2016 but the recall re-programming proved ineffective.

Within one week, my power steering fault came on twice, luckily driving at 5-10mph. But still scary at 10mph. Scary to imagine any faster. It locks up randomly out of no where in the neighborhood. Nothing touched before hand, no indication it was going to lock up, no warning. It locks up and cannot move the wheel so I have put it in park and turned off engine and restart it to move the steering wheel again. On the dash it will say ‘Power Steering Fault’. This is my vehicle I rely on for work and commute for myself and my child. No other vehicle possible for backup. This is dangerous and will not risk driving the vehicle, and at dead end with work and transportation on a busy schedule. I was lucky it did not happen in an intersection or crowded street or freeway and more lucky that my child was with me on one of the two times it happened driving 5mph and not 10mph. Cannot imagine it happen with other vehicles around.

While driving on a major highway during rush hour, at the posted speed limit (65MPH) , without any warning the vehicle completely lost any and all braking capability without any prior warning or indication of an issue later on after managing to avoid any type of accident or collision with anything around. I turned the car off, when turning the car back on then and only then I received a dashboard full of lights most important being “service advancetrac” and (!) BRAKE, “Check break system”. By reading many other forums with the same car and the exact issues and notifications it says that there is a glitch in the ABS module with communicates with the hydraulic control unit which caused complete and catastrophic brake failure. Which could have resulted in a major accident, risking my life, the occupants of my vehicle, and any other vehicle around. Lucky I was able to maneuver my way off to the side of the highway, and slowly make my vehicle come to a stop, then putting it in park, which would be the only way to stop the vehicle from moving or rolling back or forward. I believe this is a very serious issue that must be addressed. The car is now being diagnosed at a Ford Dealer at a cost of $200 and probably a repair cost of over $2600 according to others. I’am still waiting after spending $1000 on a car rental to make it to work so I would not risk my job. This is all more money then I even make, these companies need to be held accountable for putting the lives of me and my family and all the other people and families on the road that day. Thank god this did not end differently. The website is not allowing me to upload any photos of the light that appeared on the dashboard only after the incident occurred! I would have liked for people to see incase they experience this same issue

I was driving on the highway and my power steering suddenly went out on me in the middle of traffic. My 2011 Ford Fusion SE had a "Power Steering Assist Fault" on my dash and it stopped working, it only had 117k miles on it. I then took it to the dealership to get it diagnosed and they said it was the Rack and Pinion that needed to be replaced. They told me that its a known problem, and for this generation of Fusion there was an extended warranty for this problem, but only 10 year/150k miles, whichever comes first and my car(12 years old) is now too old to get it replaced at no charge. Said that Ford around 2011 was introducing electric power steering for the first time. The Ford Dealership then wanted me to pay out something like $2300 to have them replace the parts needed. This was so incredibly dangerous to have this suddenly happen, I almost wrecked trying to get off the highway during rush hour. I have no clue why Ford would make a car and not make it a mandatory recall to replace parts for the electronic steering. After Googling my issue, I found many others having this same problem and getting screwed over by Ford. Please don't keep letting them get away with this. I just want to feel safe on the road in my car.

on November 28, 2023, I was driving about 30 mph when my power steering completely went out. Two warnings popped up stating “service power steering now” and “service advancetrac”. The two icons with what looks like tires sliding / tcs indicator are also present. I did nothing out of the ordinary and typical driving. I wasn’t on icy roads or speeding. I didn’t hit my brakes in any manner that would trigger a mishap with sliding. But this is scary to have happened and now because it’s winter in Idaho, it will be absolutely unsafe for me to operate this vehicle. This needs to be taken care of.

As I drive the power steering is locking up and my steering assist vault keeps coming on. I have taken my vehicle to Clinton , Indiana Ford dealer & currently taking it back 11/28 for the same issue. Please help. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

June2 2023 my car the power steering quit no longer able to steer the car. No longer able to drive the car 2011 ford fusion. i noticed there were recalls on steering and electrical my is electrical power steering (no pump). i need to know if i qualify to have it fixed i have reported this to everyone in ford i know to ask. i need my car. my husband was driving when it happen he made it home safe thankful.

It started in February 2023 no warning lights nothing just when I came to a stop at a red light the car dies it will start right back most of the time but other times when you start it back it's like the starter stays engaged and makes a struttering sound and whole car shakes and you have to hurry and shut it back off and restart it again the longer you drive the car the more it dies when you come to a stop other times it may not do it for days I've almost been in 7 accidents that I've counted bc of this issue bc it dies and ppl think I should be moving and I can't or I just turn at a light and it will die and I can go until I restart it I also think it cause my battery to go out bc I had to replace it not long after this started. It's not been reported to anyone but you or inspected but is available to be anytime. Components affected ( DOOR HANDLE INSIDE PASSANGER SIDE)My 2nd issue is with my passenger side door handle without warning it just stopped working and now you have to roll window down to open from outside my safety could be at risk bc I wouldn't be able to get out of car if there was a crash. It's not been reported, inspected by anyone but is available anytime to be.

Service power steering in 2011 Ford fusion SE 2.5 L

The power steering has failed intermittently (at least 5 separate occasions) while driving. The failure was inconsistent between times driven and parked. First time noticed, turned vehicle on and could barely move the wheel. Turned vehicle off and back on and didn't have an issue with the steering wheel or on the road and got home okay. The issue started out this way and then once it was consistent it was unable to operate the vehicle safely. This vehicle is our main vehicle so it happened to myself and to my husband while on his way home from work. However, when the power steering failed was extremely difficult to turn the wheel while driving. We took into dealership and the diagnostics was the electrical power steering is faulty and the traction control has failed. After looking into the issue - we believe our 2011 Ford Fusion may have been one of the recalls that should have been included for the power steering failure recall that was sent to other 2011 Ford Fusions. We did not receive a notification, however after viewing online - Ford recalled 445K vehicles with the same exact issue.

CHECK FUEL FILL INLET THE LIGHT STAY ON

Power Steering Assist Fault I've seen where the 2011 Ford Fusion was recalled for this and mine has failed. Please add my VIN to the list. If you have any questions or need more information, please contact me. Thank you.

The contact owns a 2011 Ford Fusion. The contact stated while driving 60 MPH with the air conditioning activated, there was a burning odor inside the vehicle. The contact reached under the glove box and discovered that the heat sink and wiring harness connecting the fan was extremely hot to the touch. The contact indicated that no flames were present but the wires were visibly charred and burnt. The contact stated that the heat sink and wiring harness connection to the fan had been replaced on multiple occasions. The manufacturer was notified of the failure but no assistance was offered. The local dealer was not contacted regarding the failure. The failure mileage was 80,000.

Mileage: 80,000

Advance Trac light abs traction control light came on next thing I know car goes out of control and now my car is totaled total loss smashed right into side of the road brakes failed steering failed and all this popped up moments before and then q truck ran into me my mom went to hospital but is ok I'm fine

Advancetrac light started turning on, then about the 3rd time the light flashed electric brakes went away and was left with extremely hard to press hydraulic brakes. Just to SCAN the car ford wants $200 because they have a proprietary system...

On 12/13/21, my son swerved out of an accident and hit a high curb which damaged the driver's side tire. Luckily the Air Bag did not discharge. Recall 21S12 Driver Air Bag Inflator Replacement was issued in March of 2021, yet I did not receive a letter, and my car still has not been repaired. Are you waiting for a fatality to occur before providing the dealers with the necessary supplies?

AT 138825 MILES, THE ENGINE BEGAN TO HAVE A MISFIRE ON CYLINDER #4, WHICH WAS INITIALLY A VACUUM HOSE LEAK. THEN, THE CAR STARTS HAVING AN “EARTHQUAKE” WHENEVER THE CAR IS STOPPED AT A RED LIGHT. THE CAUSE WOULD THEN BE AN EGR MALFUNCTION. AS TIME WENT BY, THE MISFIRE ON CYLINDER 4 SHOWS UP AGAIN. TOOK MY CAR TO THE SHOP TO HAVE THE ISSUE LOOKED AT, FOUND TO BE A CROSS THREADED SPARK PLUG, AND THEY RECOMMENDED THE CYLINDER HEAD BE REPLACED, THE ENGINE ASSEMBLY REPLACED, THE COOLANT BEING REPLACED, AND THE AC BEING RECHARGED. REPAIR WOULD’VE COST $10,500.

Mileage: 139,063

AFTER HAVING THE TAKATA AIRBAG RECALL TAKEN CARE OF BY FRANKLIN FORD LINCOLN THE ENGINE OIL LIGHT WAS ON AND THE BATTERY KEPT DRAINING AND HAD TO BE REPLACED TODAY. FORD CLAIMS THAT THEY DID NOTHING INCORRECT IN THE RECALL BUT PRIOR TO TAKING MY CAR TO FORD THE BATTERY AND 02 SENSOR WERE IN FINE WORKING ORDER. AFTER THE RECALL THEY WERE NOT. AFTER REPLACING THE BATTERY TODAY THE CAR STILL HESITATES TO START AND THE AC SYSTEM KEEPS MAKING A CLICKING NOISE. THIS WAS NOT HAPPENING BEFORE THE RECALL WAS PERFORMED. I DON'T THINK THAT MY CAR WILL EVER BE THE SAME AND IT IS ALL DUE TO FORD LINCOLN OF FRANKLIN REPLACING THE AIRBAGS.

MY DAUGHTER WAS DRIVING HER FORD FUSION WHEN THE POWER STEERING STOPPED WORKING.

Mileage: 160,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE ABS, EMERGENCY AUTOMATIC BRAKING, TRACTION CONTROL, AND SERVICE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL WHILE DEPRESSING THE BRAKE PEDAL. THE CONTACT ALSO STATED THAT EXCESSIVE FORCE WAS NEEDED TO BRING THE VEHICLE TO A COMPLETE STOP. THE VEHICLE WAS TAKEN TO LUCAS FORD (900 US-130, BURLINGTON, NJ 08016) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 128,262.

Mileage: 128,262

MY CAR HAS BEEN ABSOLUTELY FINE FOR THE MOST PART UNTIL ABOUT 4 WEEKS AGO , WHILE I WAS DRIVING THE LOW TIRE PRESSURE LIGHT CAME ON, SO I WENT AND AIRED UP THE TIRES, THE LOW TIRE PRESSURE LIGHT WENT OFF BUT THEN THE SERVICE POWER STEERING LIGHT AND ADVANCE TIRE TRACTION APPEARED AT THIS TIME IM PULLING BACK INTO MY DRIVE WAY, THEN I CAME OUT MY HOUSE A FEW HOURS TO LEAVE AND THE STIRRING WHEEL WAS LOCKED I TRIED TO DRIVE IT AND NOW THE STRRING WHEELS GOES TO THE RIGHT I NEVER HAD THIS ISSUE BEFORE LET ALONE ANY WARNING SIGNS .. I LOOKED INTO RECALLS WITH FORD AND IT SHOWED MY 2011 FORD FUSION HAD RECALLS FOR WHATS GOING ON, SO I CALLED A LINCOLN FORD DEALERSHIP THAT SAID BRING IT IN THEY KEPT MY CAR FOR A WEEK AND WHEN I PICKED IT UP NOTHING WAS FIXED ON IT AND THEY HAD NO PAPERWORK TO GIVE ME THE SHOW THEY FIXED IT SO I RETURNED MY CAR THE VERY NEXT DAY BECAUSE WHEN I DROVE OFF IT WAS STILL DOING EXACTLY THE SAME THING BUT WORSE SO NOW THEY'VE HAD MY CAR FOR A WEEK AND THEY CALLED ME THIS MORNING TO TELL ME MY CAR HAS BEEN DOING THE SAME EXACT THING AND IT IS THE WIRE HARNESS THAT NEEDS TO BE FIXED AND IT'S NOT UNDER THE RECALL BUT IT IS PART OF THE POWER STEERING SO I DON'T GET IT

MULTIPLE TIMES NOW THIS HAS HAPPENED... I'LL GIVE YOU THE MOST NERVE WRACKING EXPERIENCE, WHERE I HONESTLY WAS SCARED FOR MY LIFE. IT WAS 10:30PM, I WAS DRIVING OUT OF TOWN ON MY WAY BACK HOME FROM A FRIENDS, ON A TINY 2 LANE ROAD GOING 55, ALL OF A SUDDEN ALL OF MY POWER CUT OUT! NO RADIO, HEADLIGHTS, HAZARD LIGHTS WOULDN'T EVEN WORK!!! I HAD TO SLOW DOWN IN THE PITCH BLACK DARKNESS, HOPING TO GOD THERE WASN'T ANY DEER. ON TOP OF THAT... JUST WAITING FOR ANOTHER CAR TO TURN DOWN THE ROAD I WAS ON, BARRELING AT ME AT 55MPH. I WAS TERRIFIED! MY BATTERY AND ALTERNATOR ARE FINE. THE ELECTRIC FINALLY CAME BACK ON AFTER A FEW MINUTES... BUT THIS COULD HAVE HAD A VERY DIFFERENT ENDING.

Mileage: 70,000

FAILURE OF THE THROTTLE BODY AND MOTOR ASSY. T\INTERNAL FAULT CODE P2112 CAUSED THE POWER ON CAR TO GO TO LIMP MODE. THIS CREATED A DANGEROUS SITUATION AT HIGHWAY SPEEDS. THE ITEM HAS BEEN FLAGGED IN FEBRUARY 21, 2013 NHTSA ACTION NUMBER: PE13003ELECTRONIC THROTTLE BODY MALFUNCTION NHTSA ACTION NUMBER: PE13003 FORD HAS FAILED TO CORRECT THE ISSUE ON MY VEHICLE. THIS OCCURRED 17 AUG 2020. THE VEHICLE WAS AT 152,000 MILES AND HAD BEEN SERVICED REGULAR BY FORD SINCE PURCHASE IN 2011. THIS ISSUE SHOULD HAVE NEVER OCCURRED. I HAD STOPPED AT A LIGHT AND MADE A RIGHT TURN ON TO EXPRESSWAY IN RUSH HOUR TRAFFIC. WITH NO ACCELERATION THIS BECAME A DANGEROUS SITUATION VERY QUICKLY. I EXPECTED TO ACCELERATE TO 45MPH BUT COULD BARLEY CREEP TO 20 MPH MAX.

Mileage: 152,845

HEATER/DEFROST BLOWER SPEED CONTROLLER AND ASSOCIATED WIRING FAILURE CAUSING WIRE SMOKE COMING OUT FROM UNDER DASH BOARD. IF I DIDN'T TURN OFF CLIMATE CONTROL, I SUSPECT IT COULD HAVE ESCALATED TO AN ELECTRICAL FIRE. WITHOUT DEFROST WORKING, IT IS HARD TO SEE OUT OF WINDSHIELD.

Mileage: 103,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE LOSS MOTIVE POWER AND STALLED. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. BILL KNIGHT FORD LOCATED AT 9607 S. MEMORIAL DR, TULSA, OK 74133 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

Mileage: 140,000

WHENEVER I TRY TO MAKE A LEFT OR RIGHT TURN MY DASHBOARD LIGHTS UP READING 'POWER STEERING ASSIST FAULT' AND MY STEERING WHEEL LOCKS UP AND I CAN NOT TURN OR DO ANYTHING UNLESS I TURN OFF MY CAR AND TURN IT BACK ON. SOMETIMES I WOULD HAVE TO CONSTANTLY DO THIS TILL I CAN DRIVE. I ALWAYS NOTICE WHENEVER I HAVE MY AC ON IT MAKES MY POWER STEERING ASSIST ACT UP. *TR

Mileage: 80,000

DRIVER DOOR WON'T OPEN FROM THE INSIDE

WHENEVER I MAKE A CERTAIN TURN MY WHEEL LOCKS UP AND I CAN NO LONGER TURN WITHOUT WRESTLING MY WHEEL TO TURN. MY DASHBOARD STARTS TO GO OFF AND I GET A MESSAGE 'POWER ASSIST AT FAULT'. I WOULD HAVE TO TURN MY CAR OFF AND ON A COUPLE TIMES FOR ME TO BE ABLE TO DRIVE AGAIN WITHOUT ANY ISSUES. IT GETS WORSE WHEN I'M ABOUT TO PULL OUT FROM A PARKING SPOT, THAT'S WHEN IT MAINLY STARTS.

Mileage: 86,000

NO POWER STEERING ASSIST. SAYS "POWER STEERING ASSIST FAULT" AND STEERING IS DIFFICULT. VEHICLE WAS IN MOTION

Mileage: 146,000

FOR THE LAST YEAR EXPERIENCING PROGRESSIVELY WORSENING DRIVABILITY ISSUES. THE MOST CONCERNING IS STEADILY INCREASING THROTTLE LAG (TIME BETWEEN APPLYING MORE PRESSURE TO ACCELERATOR AND VEHICLE RESPONDING), WHICH I VIEW AS A SAFETY ISSUE. THE VEHICLE DOES NOT RESPOND APPROPRIATELY WHEN APPLYING THROTTLE, WHICH MAY INCREASE RISK OF ACCIDENT B/C VEHICLE MAY NOT ACCELERATE PROPERLY WHEN NEEDED EITHER PLACING ME AT RISK BECAUSE IT LEAVES ME IN THE PATH OF ANOTHER VEHICLE OR PREVENTS MY VEHICLE FROM EXPEDITIOUSLY RESPONDING TO AVOID ANOTHER VEHICLE.. SECONDARILY VEHICLE NOW OPERATING ALMOST EXCLUSIVELY IN GAS POWER MODE (WORSENING MPG EFFICIENCY) BUT ALSO CAUSING JERKING/HESITATION WHEN TRANSITIONING BETWEEN GAS/EV MODES. THIS POWERTRAIN WAS NOT DESIGNED TO WORK IN GAS ONLY BUT AS A PARTNERSHIP BETWEEN GAS/EV, THEREFORE IN GAS ALONE IS NOT WORKING PROPERLY. INTERNET SEARCH REVEALS MANY OTHER OWNERS EXPERIENCE SAME PROBLEM. TO DEALER SERVICE X 3 - 1ST 2 DEALER SAID NOTHING WRONG. FINALLY GIVEN A FORD SERVICE BULLETIN (ATTACHED) THAT FORD IS AWARE FOR AT LEAST 4 MONTHS AND FORBIDS SERVICE TO THE CAR! THUS I HAVE AN UNSAFE VEHICLE THAT FORD HAS NO SOLUTION FOR REPAIR FOR AT LEAST 4 MONTHS, AND NO INDICATION OF WHEN THIS WILL BE ADDRESSED.

Mileage: 120,000

SERVICE POWER STEERING LIGHT CAME ON WHILE DRIVING ON THE STREET AND IT WAS HARD TO STEER THE CAR.

Mileage: 170,000

I BEGAN GETTING POWER STEERING FAILURE ERROR MESSAGES ABOUT A YEAR AGO ON MY 2011 FORD FUSION. THEY WOULD ONLY OCCUR WHEN I STARTED MY CAR, BUT I WOULD CUT THE ENGINE OFF AND OPEN THE DOOR AND THE ERROR WOULD GO AWAY. A WEEK AGO, THE ERROR CAME ON AND HAS STAYED. I HAVE NO POWER STEERING AND FORD IS TELLING ME MY VEHICLE IS NOT UNDER RECALL BASED ON THE VIN. IT WILL COST APPROXIMATELY $2,000 TO REPAIR. I DON'T UNDERSTAND HOW THERE IS A RECALL FOR THIS PROBLEM ON 2011 FORD FUSIONS, BUT MY CAR DOESN'T QUALIFY. HOW CAN FORD REFUSE TO REPAIR A KNOWN ISSUE WITH THIS VEHICLE WHEN THEY KNOW THIS IS A PROBLEM THEY CREATED WHEN MANUFACTURING THIS VEHICLE. IF I HAVE TO BUY A NEW CAR, IT WON'T BE WITH FORD WHICH IS FRUSTRATING BECAUSE I LOVE MY CAR.

Mileage: 123,000

MY CARS WINSHIELD WIPERS HAVE A SHORT IN THEM WHEN I PUT ON AIR. THE MY CAR KEEPS SHAKING WHEN DRIVING. MY AIRBAGA STILL ARENT WORKING AND CAR FEELS LIKE ITS STILL IDLING ROUGH. ALL OF RHE RECALLS WERE FIXED BUT STILL HAVING SAME PROBLEM. CAR WAS IN MOTION FOR VIBRATING AND PARKED WHEN I NOTICED AIR BAGS

Mileage: 120,090

ONE NIGHT I WAS DRIVING IN THE CITY TO RUN SOME ERRANDS. THE VEHICLE WAS IN MOTION APPROXIMATELY 30 TO 35 MILES PER HOUR IN A MAIN STREET WHEN I SUDDENLY HEAR A SOUND COMING FROM MY VEHICLE ALERTING ME THAT THE WRENCH LIGHT DETECTED A MALFUNCTION. AT THE MOMENT I WAS ALERT AND VIEWING MY DASH REGARDING THE ILLUMINATION IT THREW UNTIL I SUDDENLY FELT MY STEERING GEAR BECOME REALLY STIFF AND PULLING ME TO THE SIDE NEAR THE CURB REALLY FAST. I HAD LOST CONTROL OF MY VEHICLE TO STEER THAT RESULTED IN MY VEHICLE JUMPING UP THE CURB AND COLLIDING WITH A LIGHT POLE DAMAGING THE PASSENGER SIDE OF MY FRONT BUMPER AND PASSENGER FRONT AND REAR DOOR. THE MAJORITY OF THE DAMAGE HAPPEN TO MY VEHICLE WHICH LEFT SCRATCHES, DENTS, AND PAINT AND BODY DAMAGE TO PRETTY MUCH THE RIGHT SIDE OF MY VEHICLE. THE LIGHT POLE CONSIDERING THE IMPACT FROM JUMPING UP THE CURB ASSISTED IN NOT CAUSING ANY STREET DAMAGE TOWARD THE STREET LIGHT. I REPORTED THE INCIDENT IMMEDIATELY TO MY INSURANCE COMPANY TO FILE A CLAIM. EVENTUALLY I WAS INFORMED BY A FEW OF MY COWORKERS THAT THERE WAS A RECALL ISSUED ABOUT THE STEERING GEAR ON THE 2011 FORD FUSIONS. I TOOK IT TO MY FORD DEALER IN WHICH WAS A REALLY HORRIBLE EXPERIENCE SINCE THEY AUTOMATICALLY CLOSED THERE DOOR IN MY FACE WHEN I INFORMED THEM ABOUT THE STEERING GEAR ISSUE AND RECALL. THERE EXCUSE WAS MY VIN DID NOT MATCH THE RECALL ISSUED SO THERE WAS NOTHING THEY CAN DO. FORD THEN QUOTED ME OVER $2000 FOR PARTS AND LABOR AND PROGRAMMING. I WAS SO PISSED AND LEFT EMPTY HANDED SINCE DOWN THE ROAD I HAD NO CHOICE BUT TO PURCHASE THE STEERING GEAR AND YET TO STILL SELL ME A DEFECTIVE ONE THAT I HAD AN OUTSIDE SHOP PERFORM THE WORK TWICE. AFTER MY REPAIRS I SPOKE TO THE SERVICE MANAGER FOR A REIMBURSEMENT IN WHICH TILL THIS DAY, THEY DO NOT WANT TO ISSUE ME ONE.

Mileage: 94,000

I PULLED IN MY DRIVEWAY, PARKED 2011 FORD FUSION AND THEN SHUT VEHICLE OFF. I RETURNED, STARTED VEHICLE, WENT TO START DRIVING MY VEHICLE OUT OF DRIVEWAY AND THE CAR STARTED BEEPING AND LISTED THAT THE POWER STEERING DID NOT WORK. I LOOKED IT UP ONLINE AND THERE WAS A RECALL FOR STEERING: ELECTRIC POWER ASSIST SYSTEM FAILURE (15V340000 OR 15S18). I TOOK TO DEALERSHIP AND WILL ATTACH QUOTE WHICH THEIR RECOMMENDATION IS EXACTLY WHAT FORD'S RECOMMENDATION WAS. HOWEVER MY CAR DOESN'T FALL INTO THE CORRECT DATE FOR THIS RECALL, I AM HAPPY THAT I WAS NOT DRIVING 75MPH DOWN INSTERSTATE 70 IN WHEELING, WV OR DRIVING UP TO WEST LIBERTY, WV WHERE I WORK. EITHER COULD HAVE RESULTED IN A HORRIBLE ACCIDENT FOR ME, MY KIDS AND POTENTIALLY OTHER VEHICLES INVOLVED. THE CAR HAS ONLY 73,000 MILES ON IT ROUGHLY AND IS IN EXCELLENT CONDITION.

Mileage: 73,000

THE STEERING WHEEL STARTED TO JERK. SHORTLY AFTER THIS HAPPENED, THE POWER STEERING STOPPED WORKING ENTIRELY. THE INSTRUMENT PANEL DISPLAYED A NOTICE THAT SAID SERVICE POWER STEERING NOW. THE TCS LIGHT CAME ON WHEN THE POWER STEERING STOPPED WORKING.

Mileage: 100,000

I'M DEALING W/THE SAME THING EVERYONE ELSE IS. FORD KNOWS THE STEERING IS BAD, REPLACES IT & THEN SAYS IT'S ONLY VALID FOR ONE YEAR. NOW, MINE HAS GONE OUT THE SECOND TIME & THEY WILL DO NOTHING. I NEARLY WRECKED MY CAR, W/MY CHILD IN IT!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!! STEERING IS RECALLED FOR MY SAME MODEL & YEAR. FORD SAYS MY VIN IS NOT COVERED, SURPRISE! I'VE ALREADY HAD THE STEERING RACK REPLACED ONCE & NOW IT'S OUT AGAIN! """"" 445K VEHICLES RECALLED FOR "POWER STEERING"

Mileage: 160,000

CAR CAME UP WITH "SERVICE ADVANCETRAC/SERVICE POWER STEERING NOW" ERROR CODES.

Mileage: 126,000

I WAS DRIVING IN A 45 MILE LANE, MY ELECTRIC POWER STEERING HOPPED OFF AND POWER STEERING SERVICE NOW CAME ON. MY CAR HIT THE CURB AND LANDED IN SOMEONE YARD. VERY TERRIFYING. I CONTACTED FORD AND THEY SAID THEY WILL NOT REPLACE IT. BECAUSE I DON’T MEET THE GUIDELINES FOR THE RECALL. MY CAR IS OVER 150,000 MILES. AND I WILL HAVE TO PAY. I FELT LIKE THIS IS NOT OKAY I ONLY HAD THIS CAR FOR 2 MONTHS AND THE OWNER NEVER TOOK IT IN WHEN IT WAS UNDER 150,000 MILES. IF IT’S ON RECALL IT SHOULDN’T HAVE A TIME FRAME TO GET IT FIX. IF THEY MESSED UP ON THEIR END FIX IT. NOW THEY ASKING ME TO PAY OUT OF POCKET TO FIX ON THEIR BEHAVE.

Mileage: 257,000

THE BLOWER MOTOR CONNECTOR AND BLOWER MOTOR RESISTOR WILL MELT WITH USE, WHICH CAUSES SMOKING TO COME FROM THE PASSENGER SIDE FLOOD UNDER THE GLOVE BOX. IS NOT SAFE AND I HAVE REPLACED 3 TIMES SINCE 2014. IT CAN HAPPEN WHILE SITTING AND DRIVING, DOES NOT MATTER. I HAVE REACHED OUT TO FORD THEY MUST NOT CARE BECAUSE I HAVE BEEN TOLD ITS NOT THEIR PROBLEM, OR TO GET OVER IT.

Mileage: 100,000

THE VEHICLE WAS STATIONARY. THE INSIDE DOOR HANDLE AND LOCK BROKE AT THE SAME TIME. TWO WAYS TO GET OUT, ROLLING THE WINDOW DOWN AND OPENING FROM OUTSIDE OR PULLING THE HANDLE AND LOCK AT THE SAME TIME ON THE INSIDE. THE DOOR WILL NOT LOCK.

Mileage: 130,857

FAULTY DRIVER'S SIDE DOOR LATCH WILL NOT OPEN FROM THE INSIDE. THE VEHICLE WAS PARKED. AFTER CLIMBING OUT THE PASSENGER SIDE DOOR AND WALKING AROUND THE CAR THE DRIVER'S DOOR DID OPEN FROM THE OUTSIDE. FORD LISTS A RECALL FOR 2013-2014 FUSION, BUT NOT EARLIER YEARS. AN INTERNET SEARCH SHOWS I AM NOT THE ONLY 2011 OWNER WITH THIS SAFETY ISSUE.

Mileage: 70,100

MY FIANCE WENT TO START THE CARE TO GO TO WORK AND THE POWER STEERING ASSIST FAILURE AND SERVICE ADVANCETRAC WARNINGS WERE ON. SHE COULDN'T EVEN TURN THE STEERING WHEEL. IF SHE HAD BEEN DRIVING WITH OUR 2 YEAR OLD SON IN THE CAT THEY COULD HAVE BEEN KILLED. THERE ARE MANY OTHERS THAT I HAVE FOUND WITH THE SAME PROBLEMS WHY HAD THIS NOT BEEN RECALLED, SERIOUS INJURY OR DEATH COULD OCCUR. THEN THERE WOULD BE MULTIPLE LAWSUITS

Mileage: 204,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. WHILE DRIVING 65 MPH AND CHANGING LANES, THE STEERING WHEEL BECAME DIFFICULT TO TURN. IN ADDITION, THE CHECK ENGINE, LOW TIRE PRESSURE, AND STABILITY CONTROL SYSTEM WARNING INDICATORS WERE ILLUMINATED. THE CONTACT CALLED CAVALIER FORD (1515B S. MILITARY HWY, CHESAPEAKE, VA 23320, 866-385-6930) AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 115,702.

Mileage: 115,702

POWER STEERING KEEPS GOING OUT. MECHANIC FIXES BUT ONLY LAST A FEW MILES THTHETHTHEN GOES OUT AGAIN.

Mileage: 126,000

STEERING KEEPS PULLING TO THE LEFT, DOME LIGHTS STAY ON WHILE DRIVING

Mileage: 49,183

I WAS DRIVING HOME WHEN OUT OF NOWHERE MY CAR STARTS DINGING SAYING 'SERVICE POWER STEERING NOW' & I LOST CONTROL OF THE POWER STEERING.. THE WHEEL IMMEDIATELY LOCKED.

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THE DRIVER'S SIDE DOOR FAILED TO OPEN FROM INSIDE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED BY AN INDEPENDENT MECHANIC OR A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2011 FORD FUSION. WHILE THE DRIVER WAS MAKING A LEFT TURN, THE STEERING WHEEL SEIZED AND BECAME EXTREMELY TIGHT WHEN IT WAS TURNED IN EITHER DIRECTION. CLASSIC FORD OF MADISON (6251 N RIDGE RD, MADISON, OH 44057, 1-(440) 417-1100) DIAGNOSED THAT THE TWO FRONT CONTROL ARMS NEEDED TO BE REPLACED. THE VEHICLE WAS ALSO TAKEN TO AVENUE AUTO CLINIC (1170 MENTOR AVE, PAINESVILLE, OH 44077, 1-(440) 639-9956) WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC COMPUTER AND THE ELECTRONIC STEERING MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING) AND WAS NOT INCLUDED IN NHTSA ACTION NUMBER: PE14030 (STEERING). THE MANUFACTURER WAS NOTIFIED AND PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS NOT AVAILABLE. *TT*JB

Mileage: 58,134

I TOOK MY 2011 FORD FUSION TO THE FORD DEALERSHIP IN HARLINGEN TX. THEY VERIFIED THE VEHICLE WAS UP FOR RECALL SINCE IT HAS NOT BEEN REPAIRED. THE MECHANICS TOOK THE CAR IN AND REPAIRED THE CAR AFTER 7 DAYS OF DROPPING IT OFF. ON DAY 7 THEY CALLED ME THAT IT NEEDED A TIE ROD WHICH I PURCHASED AND DELIVERED FIRST HAND. 2 HOURS LATER THEY CALLED ME THAT I HAD TO PAY $1,300 BECAUSE THE CAR WAS NOT UP FOR RECALL AND THAT IF I DIDN'T PAY THEY WOULD BE PUTTING MY BROKEN PART BACK ON AND RELEASING THE CAR TO ME. I WENT ON TO COMPLAIN TO THE MANAGER AND THEY MANAGED TO TAKE $500 OUT FOR THE REPAIRS THEY HAVE DONE THAT WERE SUPPOSED TO BE UP FOR RECALL. I WAITED 7 DAYS TO FIND OUT I WAS BEING CHARGED FOR A SERVICE THAT WAS SUPPOSED TO BE FREE. RECALL NUMBER 15NO1 AND 15NO2. I HAVE RECITE AND VIDEO OF THE CONFRONTATION. I HAD ALREADY WRECKED THE CAR DUE TO THE STEERING ISSUES. I ALSO REPAIRED THE DAMAGED AFTER THE ACCIDENT TO LATER FIND OUT IT WAS UP FOR RECALL!

Mileage: 148,739

I HAD A RECALL ON MY CAR LAST YEAR 2017. I TOOK IT TO BE FIXED. THEY REPLACED THE THROTTLE BODY AND POWER STEERING MODULE. AFTER HAVING THAT REPLACED I LATER NOTICE MY CAR WASN'T DRIVING RIGHT. THERE WAS A WHINING NOISE AND A NOISE COMING FOR STEERING WHEEL. SO I TOOK MY CAR BACK TO HAVE IT CHECK OUT.THE GUY SAID IT WILL COST $130.00 FOR THEM TO CHECK MY CAR. I ASKED IF COST TO CHECK THE PART THEY REPLACED BECAUSE MY CAR WAS DRIVING THE SAME SINCE THEY FIXED IT. IT TOOK LESS THAN AN HOUR FOR THEM TO TELL ME THAT THERE WASN'T ANYTHING WRONG WITH THE PARTS THAT WAS REPLACED. NOW MY CAR HAS BEEN GOING DOWN SINCE. SO JUNE 30,2018 I TOOK IT TO A MECHANIC FOR OIL CHANGE AND HE TOLD ME THAT I SHOULD TAKE MY CAR TO DEALERSHIP TO GET RACK AND PINION CHECK.HE EXPRESS TO ME THAT I SHOULD GET IT LOOKED AT SOON BECAUSE MY WHEEL SEEM LIKE IT WILL LOCK. AUGUST 5,2018 I WAS DRIVING THE EXPRESS WAY AND ALMOST LOST CONTROL OF MY CAR. IT KEPT SWERVING BACK AND FORWARD IN AND OUT OF LANE. I WAS TRYING TO AVOID HITTING THE CAR ON MY RIGHT SIDE AND HITTING THE BRICK WALL ON MY LEFT. I TO BRAKE ON THE EXPRESSWAY ALMOST COMING TO A COMPLETE STOP TO GET CONTROL OF THE CAR. I THANK GOD THERE WASN'T A CAR BEHIND ME. I HAD TO REPLACE THE TAIL LIGHT SEVERAL TIMES. THERE A STATIC NOISE COMING FROM THE CENTER DASH.

Mileage: 141,452

THE A/C BLOWER RESISTOR AND THE BLOWER RESISTOR CONNECTOR HAS BURNED AND MELTED 2 TIMES SINCE I BOUGHT THIS CAR IN 2012. AS I WAS DRIVING A/C WOULD BLOW HARD FOR A MINUTE OR SO THE GO OUT, AND THE FINAL TIME IT WENT OUT BOTH TIMES MY PASSENGER SAW SMOKE AT HIS FEET FROM UNDER THE GLOVE BOX.

Mileage: 111,500

DRIVING 8 HOURS, 70 MPH, ON 92 OUTSIDE TEMP DAY THE CAR STARTED MAKING A THUMPING SOUND WHEN BREAKING/STEERING SIMULTANEOUSLY. STEERING BECAME SOMEWHAT STIFFER. THE SOUND GOT LOUDER AS TIME WENT ON, POSSIBLY DUE TO EXTREME HEAT. WIFE WAS WITH ME AND WE BOTH BECAME VERY WORRIED BECAUSE WE WERE IN ATLANTA 5 PM TRAFFIC. WE MADE IT HOME AND I BEGAN AN INFORMATION SEARCH. I FOUND THAT OUR 2011 FORD FUSION WAS INCLUDED IN A FIELD SERVICE ACTION 15N01. I SPOKE WITH THE LOCAL FORD SERVICE MANAGER AND WAS TOLD THAT DID NOT APPLY TO THE SYMPTOMS I DESCRIBED BECAUSE THERE IS NO ADVANCE INDICATION THAT THE ELECTRIC CONTROLLED STEERING IS GOING OUT - IT JUST GOES OUT. FORD'S OWN REPORT MENTIONS THIS BEING POSSIBLY DANGEROUS BUT DOWNPLAYS THE CONCERN BY SAYING STEERING IS STILL POSSIBLE, JUST MORE DIFFICULT. I CALLED FORD CUSTOMER SERVICE FOR SOME SUPPORT BUT OTHER THAN RECOMMENDING A DIAGNOSES AND SAYING SHE IS NOT A TECH, OFFERED NO MEANINGFUL INFORMATION. SHE DID ADMIT SHE WOULD NOT WANT TO DRIVE A CAR WITH THIS CONDITION EXISTING. LAST, I TRIED TO GET INFORMATION VIA LIVE CHAT AND WHEN I SENT THE FSA NUMBER, I WAS ACTUALLY BLOCKED OF MY ABILITY TO QUESTION HIM AND HE ENDED THE CHAT. FRANKLY, I WOULD LIKE TO HEAR THE RESPONSE OF A FORD MANAGEMENT PERSON TO THE QUESTION "WOULD YOU ALLOW YOUR DEAREST FAMILY MEMBERS RIDE IN A VEHICLE THAT SHOW FRIGHTENING SYMPTOMS OF A STEERING ISSUE KNOWING THE EXISTENCE OF THE 'FIELD SERVICE ACTION' WHICH IS ABOUT THE STEERING GOING OUT.

Mileage: 96,571

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THE EPS WARNING INDICATOR ILLUMINATED WITHIN LESS THAN A MONTH OF OWNING THE VEHICLE. THE POWER STEERING ABILITY FAILED TO FUNCTION EACH TIME THE WARNING INDICATOR FLASHED. THE CONTACT STATED THAT IT WAS EXTREMELY DIFFICULT TO TURN THE STEERING WHEEL IN EITHER DIRECTION. IN ADDITION, THE VEHICLE STALLED MORE THAN ONCE WITHOUT WARNING. THE VEHICLE HAD NOT BEEN DIAGNOSED BY A DEALER OR AN INDEPENDENT MECHANIC. THE INDEPENDENT FACILITY THAT SOLD THE VEHICLE MADE NO MENTION OF IT BEING INCLUDED IN NHTSA CAMPAIGN NUMBERS: 15V340000 (STEERING) AND 15V793000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

STEERING WHEEL LOCKS UP ON OCCASION , NOT ALL THE TIME , YOU WONT BE ABLE TO STEER

Mileage: 64,250

I WAS BACKING UP IN MY 2011 FORD FUSION AND THAT ELECTRONIC POWER STEERING WENT OUT THANK GOD I WAS NOT ON THE FREEWAY OR IT WOULD HAVE BEEN HORRIBLE

Mileage: 84,000

WHEN I START MY CAR I GET A POWER STEERING ASSIST FAILURE AND A SERVICE ADVANCE TRAC MESSAGE. I CAN NOT TURN MY STEERING WHEEL AND MY CAR ACTS AS IF IT WON'T DO ANYTHING. I CAN TURN MY CAR OFF, WAIT, THEN START AGAIN AND IT IS FINE. MY PASSENGER SEAT BELT ALSO WILL RANDOMLY NOT CLICK INTO THE BUCKLE OR COME UNLOCKED. NOW THIS IS AFTER FORD SUPPOSEDLY FIXED ANOTHER RECALL CAUSING MY CAR TO DROP TO A LOW SPEED OUT OF NOWHERE.

Mileage: 123,316

I CAME HOME FROM SHOPPING AND WAS UNABLE TO OPEN MY DRIVER SIDE DOOR TO EXIT THE CAR. THIS IS A SAFETY ISSUE, I HAVE OWNED PREVIOUS VEHICLES AND NEVER HAD ISSUES THAT A DOOR WOULD NOT OPEN. I HAD TO OPEN MY DRIVER SIDE WINDOW AND ACTUALLY REACH OUT TO OPEN THE CAR DOOR. THIS WAS A ISSUE THAT WAS ONGOING FOR FORD FUSIONS AS I HAVE SEEN SEVERAL COMPLAINTS REGARDING THE FAULTY DOOR LATCHES.

Mileage: 60,000

CROSS TRAFFIC ALERT SYSTEM MALFUNCTION AND REAR PARK AID ALERT MALFUNCTION.

Mileage: 83,000

BATTERY, STARTER AND FLYWHEEL. FLYWHEEL MISSING TEETH POSSIBLY AFTER FAILED BATTERY. ORIGINALLY MY CAR WAS JUMP STARTED BY AAA 01/2014 DUE TO BATTERY FAILURE. WAS ADVISED TO GET BATTERY REPLACED. WHICH WAS RELUCTANTLY REPLACED BY FORD AT 36,805 01/2014. UNFORTUNATELY, THIS MAY HAVE TRIGGERED A NOISE THAT I IGNORED FOR A TIME, WHERE WHEN THE CAR WOULD START SOMETIMES IT WOULD MAKE A LOUD NOISE. IT WAS NOT EVERY START, BUT IT DID BECOME INCREASINGLY PRONOUNCED. IN MAY I FINALLY WENT BACK TO THE DEALER WHO SAID I HAD TEETH MISSING FROM THE STARTER AND FLY WHEEL AND THAT IT WAS MY FAULT FOR TRYING TO START THE CAR WHILE IT WAS RUNNING (THOUGH MY CAR HAS THE START LOCKOUT FEATURE). THE DEALER WANTED OVER $1700 TO REPLACE FLYWHEEL AND STARTER. OPENED A CASE WITH FORD AND THEY COVERED THE MAJORITY OF THE REPAIR, LEAVING ME WITH ABOUT A $450 DEDUCTIBLE. AFTER THE REPAIR WAS APPROVED, DEALER RE-CLASSIFIED THE PROBLEM AS THE STARTER STAYING ENGAGED WHICH DISTORTED THE FLYWHEEL. I RAISE THIS CASE, BECAUSE I THINK PERHAPS THE FAILED BATTERY COULD HAVE BEEN THE CAUSE, BUT FURTHER THE REPLACEMENT BATTERY FAILED AGAIN IN 6/25/2017, WHICH I REPLACED AGAIN. ON MY 3RD BATTERY. MAY BE WORTH NOTING THAT MY VEHICLE IS EQUIPPED WITH INTEGRATED NAVIGATION SYSTEM AND DISPLAY. COULD BATTERY FAILURE ALSO BE THE SOURCE OF REPEATED FAN BLOWER MOTOR ISSUE?

Mileage: 36,805

VEHICLE REPAIRED 4 TIMES FOR INOPERABLE BLOWER MOTOR. FAN/BLOWER WILL EITHER FAIL OUTRIGHT, OR OPERATE INTERMITTENTLY FOR SEVERAL WEEKS AND EVENTUALLY COMPLETE FAILURE. WILL FAIL EITHER IN WINTER OR SUMMER WHEN FAN IS USED THE MOST. THE FIRST TWO TIMES (3/1/2014 & 3/14/2016) THE RESISTOR CONTROL ASSEMBLY WAS REPLACED ALONG WITH THE WIRE HARNESS. THE THIRD TIME (11/29/2016) THE BLOWER MOTOR WAS REPLACED. THE FOURTH TIME THE BLOWER MOTOR CONNECTOR WAS REPLACED. OBVIOUSLY THESE CONNECTORS ARE MELTING DUE TO THE CURRENT DRAWN BY THE BLOWER MOTOR. I BELIEVE THERE MAY BE A TSB ISSUE, BUT FORD REFUSES TO ASSIST AS THE VEHICLE IS OUT OF WARRANTY. THE DEALERSHIP REFUSES TO HELP OR HONOR ANY WARRANTY BECAUSE THEY MANAGE TO REPLACE "DIFFERENT" PARTS EACH TIME, THOUGH I BELIEVE THAT IF THE BLOWER MOTOR, THE RESISTOR, AND ALL CONNECTORS WERE ALL REPLACED AT THE ONSET WHEN THE VEHICLE WAS UNDER WARRANTY ONE OR MORE OF THESE REPAIRS COULD HAVE BEEN AVOIDED. THERE IS A SAFETY ISSUE PRESENTED DURING WHEN THE FAN BLOWER STOPS WORKING SUDDENLY, AND THE WINDSHIELD WILL NOT DEFROST IN THE WINTER. THIS HAS HAPPENED WHILE DRIVING. DURING THE SUMMER DURING HIGH HUMIDITY, THE SUDDEN FAILURE OF THE FAN BLOWER MOTOR ALSO CAUSES THE DRIVER WINDSHIELD TO FOG UP ABRUPTLY, ALSO A SAFETY HAZARD. BOTH HAVE HAPPENED TO ME. THE COST OF THE REPAIRS $368, $455, $165 (~$1000) THUS FAR WITH THE FIRST CLAIM BEING UNDER WARRANTY. I'M CONCERNED THAT AFTER 4 VISITS FOR THE SAME CONCERN, THIS WILL REPEATEDLY HAPPEN. NOT SURE IF IT MAKES A DIFFERENCE BUT MY VEHICLE HAS THE INTEGRATED ONBOARD NAVIGATION SYSTEM.

I WAS DRIVING ON A BUSY CITY STREET DURING RUSH HOUR WHEN I NOTICED THE CAR JERKING WHEN IT CHANGED GEARS. THE RPM WOULD SHOOT UP HIGH THEN BACK DOWN WHILE LOSING POWER TO THE VEHICLE. I MANAGED TO GET TO AN AUTO ADVANCE STORE WHERE I HAD A DIAGNOSTIC DONE SINCE MY CHECK ENGINE LIGHT WAS ON. THE DIAGNOSTIC CAME BACK WITH CODE PO455 TWICE AND PO457 TWICE. IT WAS THEN EXPLAINED THAT TOO MUCH AIR WAS GETTING INTO MY FUEL SYSTEM. I PROCEEDED TO GO TO THE FORD DEALERSHIP, WHICH WAS A HALF MILE AWAY. ON THE WAY, MY CAR CONTINUED TO JERK AND LOOSE POWER AND SOME POINTS. THEN EVERYTHING DIGITAL WHICH ONE DISPLAYS MY MILEAGE AND THE OTHER DISPLAYS HOW MANY MILE TILL EMPTY DISPLAYED INTERMITTENT LINES AND THE WRENCH ILLUMINATED ON MY DASHBOARD. AT THIS TIME MY CAR WAS ON BUT QUICKLY LOST POWER TO GO FORWARD. IT ALMOST GOT REAR ENDED BY THE CAR BEHIND ME. I PUT ON MY TURN SIGNAL AND I COASTED TO THE SIDE OF THE ROAD, TURN OFF MY CAR WAITED A FEW MINUTES THE TURNED BACK ON AND PUT IT IN DRIVE. THE CAR WOULD NOT MOVE FORWARD. THE ENGINE JUST REVVED UP LIKE I HAD IT IN NEUTRAL. I PUT IT BACK IN PARK THEN PUT IT IN REVERSE. THE CAR WOULD OPERATE IN REVERSE. HAD TO HAVE CAR TOWED TO DEALERSHIP. THREE MONTHS PRIOR TO THIS INCIDENT, I HAD TO TAKE MY CAR TO THE DEALERSHIP BECAUSE OF EXCESSIVE BATTERY ACID ON MY POSITIVE TERMINAL THAT HAD EATEN THROUGH THE WIRING HARNESS. HAD TO HAVE HARNESS AND BATTERY REPLACED. I STILL NOTICE ISSUES OF BATTERY ACID ACCUMULATING AROUND THE SCREWS ON THE BATTERY HARNESS AND POSITIVE LEAD AGAIN.

Mileage: 105,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. WHILE DRIVING, THE BATTERY CABLE FRACTURED AND CAUSED AN ELECTRICAL SPARK/CURRENT. THE FAILURE COULD HAVE POTENTIALLY LED TO A FIRE. THE VEHICLE WAS TAKEN TO FORD COUNTRY OF HENDERSON, NEVADA AND THE BATTERY CABLE WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 37,000.

Mileage: 37,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THERE WAS A FAILURE IN WHICH THE VEHICLE EXPERIENCED INTERMITTENT STALLING. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO REPLICATE AND DIAGNOSE THE FAILURE, ALTHOUGH THEY HAD BEEN NOTIFIED SEVERAL TIMES. THE VEHICLE CONTINUED TO STALL AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO REPLACED THE THROTTLE BODY, BUT THE CONTACT WAS UNCERTAIN IF THE OEM PART WOULD FAIL AGAIN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO RECOMMENDATION NOR A SOLUTION. THERE WAS NO CLARIFICATION IF THERE WAS A NEWLY DESIGNED PART OR THE SAME PART THAT HAD PREVIOUSLY FAILED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

ISSUE HAPPENED WHILE VEHICLE WAS IN MOTION. INSTRUMENT CLUSTER LIGHT GOES OFF AND ON EVERY SECOND WITH BEEPS AND CHANGING MESSAGES: TIRE PRESSURE MONITOR FAULT, DOOR AJAR. VEHICLE LEFT/RIGHT TURN SIGNALS STOPPED WORKING COMPLETELY. ISSUE RESOLVED BY ITSELF AFTER 10 MINUTES DRIVING. HOWEVER RADIO SYSTEM STOPPED WORKING COMPLETELY AFTER THIS INCIDENT. THERE IS VIDEO RECORDED BY SOMEONE ELSE SHOWING THIS ISSUE HTTPS://WWW.YOUTUBE.COM/WATCH?V=0AYKJOSUDEW . DEALER DID NOT FIX ANYTHING, TELLING THAT THERE ARE NO MESSAGES IN COMPUTER.

Mileage: 25,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. WHILE THE VEHICLE WAS STATIONARY, THE BLOWER MOTOR RESISTER MALFUNCTIONED. THE CONTACT STATED THAT THE WIRES ASSOCIATED WITH THE COMPONENT MELTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,295.

Mileage: 120,295

6 MONTHS OLD CAR HAD TRANSMITION AND ELECTRICAL PROBLEMS, DRIVER DOOR LOCK NOT OPENING, AC WENT OUT! AIR BAGS SENSOR OUT, AND NOW EXPERIENCING 2ND TRANSMITION ISSUE. DEALERSHIP IS NOT TAKING FULL RESPONSIBILITY FOR IT, AS TRANSMITION WAS REPLACED AT ANOTHER GARAGE! HAVE BEEN DEALING WITH THIS CAR SINCE 2012. HARD JERKING.

Mileage: 63,349

TL* THE CONTACT OWNS A 2011 FORD FUSION. WHILE APPROACHING A RED LIGHT WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE BEGAN TO ACCELERATE INDEPENDENTLY WITHOUT WARNING. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. EARLIER THAT DAY, WHILE DRIVING 10 MPH, THE SENSORS ON THE INSTRUMENT PANEL AND HEATER FAILED. THE CONTACT SHUT OFF AND RESTARTED THE VEHICLE; HOWEVER, THE ELECTRICAL POWER DID NOT RETURN UNTIL MINUTES LATER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.

Mileage: 65,000

DRIVERS SIDE INSIDE DOOR LATCH BROKE. COULD NOT OPEN DOOR FROM INSIDE THE CAR. HAD TO PUT WINDOW DOWN AND REACH OUTSIDE THE CAR TO OPEN DOOR.

Mileage: 94,000

MY DRIVER SIDE DOOR LATCH WOULD NOT OPEN... WENT TO THE DEALERS AND THEY TOLD ME THAT 2012 , 2013 HAVE BEEN RECALLED BUY NOT MY YEAR.

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE STALLED MORE THAN FOUR TIMES AFTER THE WARNING INDICATOR WRENCH ILLUMINATED. THE VEHICLE WAS TAKEN TO A MECHANIC WHO DIAGNOSED THAT THE FUEL THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS ALSO TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 15V793000 (FUEL SYSTEM, GASOLINE) AND 15V340000 (STEERING). THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 93,545. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.

Mileage: 93,545

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THE AIR CONDITIONER BEGAN TO BLOW COLD AIR, BUT CHANGED TO HOT AIR INDEPENDENTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 44,557. UPDATED 03/07/17*LJ *CN

Mileage: 44,557

BEGAN HAVING PROBLEMS WITH THIS VEHICLE THE SECOND MONTH AFTER PURCHASE. THE FIRST INCIDENT WAS STEERING WHEEL LOCKED AND I COULD NOT CONTROL THE DIRECTION OF THE CAR. I ENDED UP ON THE LEFT SIDE OF THE ROAD OFF THE SHOULDER BEFORE I COULD STOP IT. IT HAPPENED ON SEVERAL OCCASIONS. CAR DIES FOR NO REASON. I END UP HAVING IT TOWED OR RESTARTED BY CHARGING BATTERY. THE BATTERY ALWAYS HAS A FULL CHARGE. ALSO I HAVE BEEN SHOPPING AND GET IN THE CAR TO START IT AND IT WILL NOT START. DOOR HANDLES WOULD NOT WORK FROM INSIDE. WINDOWS WOULD NOT OPEN. HAD TO FORCE WINDOW DOWN ENOUGH TO OPEN FROM THE OUTSIDE. HAD FRONT DOOR HANDLE ASSEMBLE REPLACED HAD TRANSFER CASE RESEALED HORRIBLE SMELL, NEW TIRES 3 TIMES SINCE IT WAS PURCHASED HAD REAR DRIVE SHAFT REPLACED, FUEL PUMP REPLACED HAD TAKEN IT TO FORD JUST RECENTLY FOR WHAT I DEEMED WAS COMPUTER PROBLEMS, OF COURSE THEY COULD NOT FIND ANYTHING WRONG. I WAS TOLD BY MY MECHANIC THE LAST TIME I HAD NEW TIRES PUT ON THE CAR THAT I WOULD NEED NEW RIMS SOON. THE RIMS ARE ERODING FROM THE INSIDE OUT. I HAVE SEVERAL INVOICES FOR WORK THAT WAS DONE AND A FEW MORE I CAN'T LOCATE AT THIS TIME. I WOULD LIKE TO SEND THEM ALL TO YOU. PURCHASE CAR 12/1/12.

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THERE WAS AN ODOR OF FUEL COMING FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V793000 (FUEL SYSTEM, GASOLINE). HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 52,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. UPDATED 04/20/16*LJ THE CONSUMER STATED THERE WAS A PROBLEM WITH THE TRANSMISSION AND THE STEERING. ALSO, THE VEHICLE WOULD SUDDENLY STALL, WHILE DRIVING. UPDATED 05/11/16.*JB

Mileage: 52,000

THE VEHICLE IS VERY HARD TO STEER. ELECTRIC POWER STEERING IS OUT

Mileage: 130,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. WHILE DRIVING AT LOW SPEEDS, THE STEERING WHEEL SEIZED AND THE BATTERY WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE CONTACT STATED THAT THE HEATED SEATS FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER NUMEROUS TIMES WHERE THE FAILURE WAS NOT DUPLICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.

Mileage: 78,000

ELECTRIC LOCKS ON DRIVERS DOOR WILL NOT DISENGAGE BY HITTING THE DOOR BUTTON OR THE REMOTE -MUST LOWER WINDOW AND REACH THROUGH TO UNLOCK FROM THE OUTSIDE. BEING TRAPPED INSIDE THE CAR IS A SAFETY ISSUE. MILEAGE WHEN PROBLEM FIRST OCCURRED WAS APPROXIMATELY 91000.

Mileage: 91,000

'3 MAY 2013 (MILEAGE 32,800) MOAB, UTAH. DRIVING IN THE MOUNTAINS AROUND MOAB FOR MY DAUGHTERS WEDDING. ONE PASSENGER IN THE CAR BESIDE MYSELF. WHILE DRIVING AROUND A SHARP CURVE, ALL THE ELECTRONICS IN THE CAR WENT DEAD. THE ENGINE SHUT DOWN, ALL LIGHTS ON THE DASH, THE RADIO, AC ALL STOPPED WORKING. POWER STEERING, POWER BRAKES WERE NON-FUNCTIONING. THIS HAPPENED A TOTAL OF FIVE TIMES. '26 AUGUST 2015 (MILEAGE APPROXIMATELY 55,600) TIME: 6:00PM. DRIVING HOME FROM WORK. I'D STOPPED AT A STREET LIGHT AND WHEN I PULLED SHARPLY OUT ONTO MAIN ROAD, THE CAR WENT DARK AGAIN AND ALL ELECTRICAL SYSTEMS SHUT DOWN. I QUICKLY RESTARTED IT BY SHIFTING INTO NEUTRAL AND STARTING IT WITH THE KEY. THREE BLOCKS LATER, IT HAPPENED AGAIN. THIS WAS THE FIRST TIME IT HAD HAPPENED ON A STRAIGHTAWAY. I WAS DRIVING BY MYSELF. '6 SEPTEMBER 2015 (MILEAGE APPROXIMATELY 55,950 BETWEEN SAN JUAN CAPISTRANO AND LAKE ELSINORE, CA. COMING OUT OF A SHARP CURVE IN THE ROAD WHILE GOING UPHILL ALL ELECTRICAL COMPONENTS OF THE CAR SHUT OFF. I SHIFTED INTO NEUTRAL, TURNED THE KEY, AND THE ENGINE STARTED UP AGAIN. '19 NOVEMBER 2015 (MILEAGE APPROXIMATELY 56,751) WENT OVER A SPEED BUMP WITH ANOTHER PASSENGER IN THE CAR. THE FORD FUSION SHUT DOWN AGAIN, AND AFTER I RESTARTED IT, TWO HUNDRED YARDS LATER DID IT AGAIN. 'FORD HAS TRIED TO LOCATE THE PROBLEM THREE TIMES. FINALLY REPLACED THROTTLE BODY ON 22 SEPT. AND SAID THAT FIXED PROBLEM. IT DIDN'T! FORD CORPORATION CUSTOMER SERVICE NOW REFUSES TO RETURN MY LAST FIVE CALLS

Mileage: 56,751

TL* THE CONTACT OWNS A 2011 FORD FUSION. WHILE DRIVING 25 MPH, THE VEHICLE EXPERIENCED A LOSS OF POWER; HOWEVER, IT STILL HAD SOME ELECTRICAL FUNCTION. PRIOR TO THE FAILURE, THE VEHICLE WAS REMEDIED UNDER FORD'S CUSTOMER SATISFACTION PROGRAM 13N03, BUT THE FAILURE RECURRED. THE THROTTLE BODY WAS REPLACED AND THE VEHICLE WAS REPROGRAMMED THREE TIMES. THE FAILURE OCCURRED SEVEN TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 38,500.

Mileage: 38,500

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THE REAR TAIL LIGHTS FAILED TO FULLY ILLUMINATE. THE SOCKET PREMATURELY RUSTED AND CAUSED AN INTERNAL FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE FAILURE MILEAGE WAS NOT AVAILABLE. UPDATED 1/12/16 *CN UPDATED 02/04/16.*JB

TL* THE CONTACT OWNS A 2011 FORD FUSION. WHILE DRIVING APPROXIMATELY 50 MPH, THERE WAS A BURNING ODOR COMING FROM THE PASSENGER SIDE GLOVE BOX. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. ON ANOTHER OCCASION, WHILE TURNING LEFT OR RIGHT, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN INFORMED THE CONTACT THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 118,000. UPDATED 11/19/15*LJ

Mileage: 118,000

THE ABOVE CAR DISPLAYED A TROUBLE LIGHT. A MECHANIC USED AN ODB II SCANNER AND DIAGNOSED THE ENGINE PROBLEM WITH THE CODE "P2119" I DID SOME RESEARCH ON LINE AND FOUND OUT THAT THIS IS A COMMON PROBLEM INVOLVING THE THROTTLE BODY. IS THIS A RECALL ITEM?

Mileage: 30,000

WE HAD A RECALL ON POWER STEERING.HAD IT CHECKED BY DEALER TOLD IT WAS GOOD THEN FEW DAYS LATER POWER STEERING WENT OUT. THE DEALER WORKED ON IT 3 TIMES THEN SENT IT BACK STILL TORE UP. THE DEALER IS ED SHERLING FORD IN ENTERPRISE AL 36330.

Mileage: 100,000

FIRST AT ABOUT 42000 MILES IN OCTOBER 2012 THE DRIVER SEAT BECAME SO HOT IT CREATED 1ST DEGREE BURNS ON MY HUSBAND. THE SEAT HEATER WENT OUT SOON AFTER. NEEDS TO BE FIXED. THE SEAT COULD CAUSE A FIRE AT 55000 MILES THE DRIVER DOOR HANDLE BECAME UNLATCHED WITHIN THE DOOR AND STOPPED OPENING FROM THE INSIDE. WHAT IF I HAD A WRECK AND COULDN'T GET OUT? NEEDS TO BE RECALLED FOR THIS ISSUE. I'VE HEARD IT'S COMMON ON THE FUSIONS. THE FRONT DOOR SPEAKERS WENT OUT SOON AFTER ALL OF THIS. AT 90000 MILES THE PASSENGER SEAT HEATER WENT OUT. SAME BURNING HOT THING BUT THIS TIME NO ONE WAS BURNED. AT 95000 MILES THE SAFETY SYSTEM HAS NOW GONE OUT. IT FLASHES THAT THERE IS A PROBLEM WITH THE REAR PARK AID AND A FAULT WITH THE CROSS TRAFFIC SYSTEM. I'VE READ THAT THE REAR DRIVER SIDE SPEAKERS CAUSE THIS. THE FRONT DRIVER SIDE SPEAKERS WENT OUT 2 YRS AGO. MAYBE THESE ARE CONNECTED. IT SEEMS THE WHOLE CAR HAS PROBLEMS WITH FUSES AND ELECTRICAL WIRES EITHER BURNING OUT WAY TOO QUICKLY. MY VEHICLE IS A 2011 MANUFACTURED IN OCTOBER OF 2010

Mileage: 42,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER ON AUGUST 20, 2015 TO COMPLETE THE RECALL REPAIR FOR NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE CONTACT WAS NOT EXPERIENCING ANY FAILURES BEFORE THE RECALL WAS COMPLETED. WITHIN A WEEK, THE ADVANCED TRACK WARNING LIGHT ILLUMINATED AND THE VARIOUS GAUGES AND WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. AFTER THE SOFTWARE UPDATE, THE VEHICLE HAD A SUDDEN LOSS OF POWER. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO STATED THAT THERE WAS AN ELECTRICAL SHORT WITHIN THE MODULE CONNECTIONS ASSOCIATED WITH THE POWER STEERING. THE VEHICLE WAS AT THE DEALER FOR WEEKS AS THEY DIAGNOSED THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND PROVIDED NO REMEDY. THE FAILURE MILEAGE WAS NOT AVAILABLE. MA 10/25/15

TL* THE CONTACT OWNS A 2011 FORD FUSION. WHILE DRIVING 65 MPH, THE VEHICLE JERKED, ALL THE INSTRUMENT PANEL LIGHTS ILLUMINATED, AND THE VEHICLE STALLED. THE CONTACT RESTARTED THE VEHICLE, BUT THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 126,000.

Mileage: 126,000

CAR WAS TRAVELING 60MPH ON STRAIGHT ROAD WHEN IT JERKED AND WRENCH LIGHT AND CHECK ENGINE LIGHT AND ABS AND STABILITY LIGHTS CAME ON. PULLED TO SIDE OF ROAD AND SHUT OFF CAR. RESTARTED AND DROVE 100 FEET AND WRENCH LIGHT CAME BACK ON AND ONCE AGAIN PULLED OVER TO SHOULDER TO RESTART CAR. AFTER 2ND RESTART IT DROVE FINE FOR 15 MINUTES AND THEN STALLED COMPLETELY, ONCE AGAIN RESTARTED CAR AND DROVE 5 FEET IT ONCE AGAIN STALLED AND LOST ALL POWER. RESTARTED AND DROVE FOR 10 MINUTES TO HAVE IT START JERKING AT A STOP LIGHT AND THEN STALL OUT ONCE I PULLED INTO WORK.

Mileage: 76,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE LIGHT WOULD ILLUMINATE AND THE VEHICLE STALLED. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE CONTACT INDICATED THAT THE PCM WAS RE-PROGRAMMED, BUT THE VEHICLE CONTINUED TO EXPERIENCE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 30,000. THE VIN WAS NOT AVAILABLE.

Mileage: 30,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. WHEN THE CONTACT STARTED THE VEHICLE, THE POWER STEERING ASSIST WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING MALFUNCTIONED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V340000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 96,275.

Mileage: 96,275

THE BLOWER RESISTOR AND BLOWER RESISTOR PLUG HAS CAUGHT FIRE AND MELTED. I HAVE PICTURES. THIS CAUSES YOU AC TO COME ON AND OFF INTERMITTENTLY.

Mileage: 110,000

THE VEHICLES WIRING IS HEATING UP AND I'M CONCERNED IT MAY START A FIRE, ALSO THE CAR OCCASIONALLY TURNS OFF BY ITSELF, I WOULD LIKE TO TO KNOW IF THERE IS A RECALL ON MY VEHICLE, PLEASE REACH OUT TO ME AS SOON AS POSSIBLE.

Mileage: 57,000

BURNT TAIL LIGHT SOCKETS SOME MELTING AS WELL BECAUSE THE BULB WAS STUCK INSIDE SOCKET

Mileage: 119,000

WENT TO TOWN AND PARKED THE CAR WENT IN TO THE STORE AND WHEN I STARTED TO LEAVE I NOTICED THAT THE POWER STEERING DIDN'T WORK. I DROVE THE CAR HOME WITH NO POWER STEERING. IT'S A GOOD THING THIS DIDN'T HAPPEN WHILE GOING THE SPEED LIMIT. THE DEALER SAID THAT THIS IS A COMMON PROBLEM MY QUESTION IS WHY HAS IT NOT BEEN RECALLED IF IT'S A COMMON PROBLEM.

Mileage: 56,000

A WRENCH LITE UP ON MY CAR AD MY CHECK ENGINE LIGHT CAME ON WHILE DRIVING AND YOUR SLOWS DOWN WHILE DRIVING AND YOU CAN NOT GET YOUR CAR TO GO. I HAD TO STOP AND RESTART MY CAR 4 TIMES WITHIN 40 MILES. THIS NEEDS TO BE A SAFETY RECALL. I HAD KIDS IN MY CAR AND I LIVE 40 MILES OUT OF TOWN. I GOT REALLY SCARED AND DID NOT KNOW WHAT IS GOING ON. I AM NOT PAYING A MECHANIC TO FIX THIS WHEN FORD KNOWS IT IS A PROBLEM. FORD NEEDS TO PAY TO HAVE THIS FIXED. IF THIS DOES NOT GET FIXED FREE OF CHARGE I WILL NEVER BUY A FORD AGAIN. *TR

Mileage: 108,000

POWER STEERING HAS GONE OUT SEVERAL TIMES SINCE I FIRST BOUGHT THIS CAR. EACH TIME I HAVE TAKEN IT INTO THE DEALER IN THE PAST THEY HAVE TOLD ME THEY WEREN'T WILLING TO LOOK AT IT WITHOUT A FAULT CODE ON THE DASH. TODAY (04/17/2015) I FINALLY MANAGED TO GET THEM TO LOOK AT THE CODE AND THEY ARE UNWILLING TO FIX THE PROBLEM UNDER WARRANTY DESPITE IT HAVING BEEN AN ONGOING ISSUE. LOOKING IT SEEMS TO BE A PROBLEM NOT JUST RELATED TO MY CAR, BUT A NUMBER OF THESE 2011 FUSIONS. *TR

Mileage: 1,200

DRIVING TO THE STORE POWER STEERING JUST WENT OUT KNOW WARNING. *TR

Mileage: 84,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THE SERVICE ENGINE AND THE WRENCH WARNING LIGHTS ILLUMINATED INTERMITTENTLY. IN ADDITION, THE VEHICLE STALLED SEVERAL TIMES WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. UPDATED 6/30/15*CN UPDATED 9/18/15*JS

Mileage: 53,000

I HAVE EXPERIENCED MULTIPLE INSTANCES OF LOSING POWER STEERING BOTH WHILE STATIONARY AND DRIVING. THE CAR GENERATES A "POWER STEERING ASSIST FAULT" AND "SERVICE POWER STEERING NOW" ERROR MESSAGE. OFTEN AFTER TURNING OFF THE CAR AND RESTARTING (SOMETIMES TAKING SEVERAL TIMES), THE FAULT WILL CLEAR AND THE CAR OPERATES AGAIN NORMALLY; HOWEVER, THIS HAS RECURRED AT LEAST 3-4 TIMES IN THE FOUR YEARS I HAVE OWNED THE CAR. THIS ALSO OCCURS WHILE DRIVING, WHICH WOULD PRESENT A SIGNIFICANT SAFETY HAZARD FOR SOMEONE UNLIKE MYSELF WHO DOES NOT HAVE PRIOR EXPERIENCE WITH MANUAL STEERING VEHICLES THAT CAN ADJUST ON THE FLY. WHEN TAKEN TO THE DEALER FOR DIAGNOSIS/ASSISTANCE SEVERAL TIMES, I AM TOLD THEY CANNOT DIAGNOSE IT UNLESS IT IS ACTIVELY SHOWING THE ERROR CODE (WHICH IS NOT FEASIBLE AS THE CODES CLEAR AFTER THE CAR IS TURNED OFF, AND TYPICALLY WOULD REQUIRE EITHER A TOW TO A DEALERSHIP OR THE ABILITY TO DRIVE STRAIGHT TO A FORD FACILITY AT THE PRECISE TIME THE INCIDENT OCCURS, WITHOUT TURNING THE CAR OFF AT ANY POINT) AND THUS IT DOES NOT GET ADDRESSED OR FIXED. I HAVE READ SEVERAL OTHER REVIEWS OF OTHERS HAVING THE SAME ISSUE WITH THIS SAME MAKE AND MODEL, AND MANY HAVE RESULTED IN HIGHLY COSTLY RECOMMENDATIONS FOR REPAIR WHICH DO NOT FIX THE PROBLEM. I SEE THAT NHTSA CURRENTLY HAS AN INVESTIGATION ONGOING REGARDING THIS SAME ISSUE, AND AS SUCH WANTED TO ENSURE I DID MY PART BY FORMALLY DOCUMENTING ANOTHER INSTANCE OF THIS PROBLEM, AS I FELT FORD'S REPORT THAT IT IS AN ISOLATED INCIDENT ONLY AFFECTING 3 IN 1000 CARS SEEMS HIGHLY QUESTIONABLE GIVEN THE EXTENT OF OTHERS REPORTING THE SAME FAILURES IN A LIMITED NUMBER OF THESE CARS OF THE SAME MODEL YEAR SOLD, AND THOSE BEING LIMITED ONLY TO THOSE (UNLIKE MYSELF, UP UNTIL THIS JUNCTURE) WHO ELECTED TO TAKE THE TIME TO ENTER AN INTERNET COMPLAINT. *TR

Mileage: 18,000

THE HVAC BLOWER RELAY OR CONTROLLER OVERHEATED AND BEGAN SMOKING MELTING THE HOUSING FOR THE WIRING. *TR

Mileage: 52,000

TWICE NOW MY VEHICLE HAS LOST POWER STEERING WHILE DRIVING. THE LIGHTS SUDDENLY COME ON SAYING "SERVICE POWER STEERING NOW" "SERVICE ADVANCETRAC". THE FIRST TIME THIS HAPPENED THEY WERE ABLE TO RESET THE COMPUTER STATING IT WAS AN ISSUE WITH THE ELECTRONIC COMPUTER. NOW IT HAS HAPPENED AGAIN AND IT IS COMPLETELY UNSAFE. THIS IS NOT THE ONLY ELECTRICAL ISSUE I HAVE HAD WITH THIS CAR. ABOUT A YEAR AGO THE ELECTRONIC THROTTLE BODY SENSOR WENT ON IT. THIS WAS AN INTENSE SAFETY PROBLEM THAT WAS THANKFULLY RECALLED. FORD REALLY NEEDS TO REALIZE THE IMPLICATIONS OF ELECTRONIC ISSUES IN THIS VEHICLE. *TR

Mileage: 105,000

THE POWER STEERING IS NOT WORKING.THE VEHICLE IS HARD TO MAKE TURNS. I ONLY HAD THIS CAR ALMOST 3 YEARS AND I PURCHASED IT USED. THE POWER STEERING IS GONE AND I HAVE SEEN A LOT OF COMPLAINTS ABOUT THIS MODEL WITH POWER STEERING PROBLEMS. I KNOW THERE SHOULD BE SOME KIND OF RECALL ON THIS VEHICLE. I CAN NOT AFFORD TO HAVE THIS FIXED. I AM HOPING THAT YOU ALL WILL CHECK INTO THIS. IT IS UNSAFE. I AM CONSIDERING THE NEWS ABOUT THIS BECAUSE I KEEP GETTING THE RUN AROUND. I LOVE MY CAR AND I JUST CAN'T AFFORD TO HAVE IT FIXED BECAUSE OF THIS MECHANICAL PROBLEM.

WHEN TURNING ON THE VEHICLE, I GET A "POWER STEERING ASSIST FAULT" ERROR MESSAGE. THE CAR LOSES POWER STEERING AND I AM NOT ABLE TO TURN THE WHEEL. *TR

Mileage: 38,000

POWER STEERING FAILED NUMEROUS TIMES, THE LATEST OF WHICH WAS TODAY. USUALLY IT HAPPENS WHEN JUST DEPARTING THE DRIVEWAY, BUT IT ONCE HAPPENED WHILE MOVING ON A STREET - IT'S SCARY. I UNDERSTAND THE POWER STEERING IS ELECTRICAL. I HAD TO REPLACE THE BATTERY A COUPLE MONTHS AGO AND I THOUGHT THAT MIGHT HAVE TAKEN CARE OF THE PROBLEM, BUT IT HAS RECURRED WITHIN THE LAST COUPLE OF WEEKS. I BOUGHT THE CAR USED AND PURCHASED THE EXTENDED WARRANTY WHICH IS STILL IN EFFECT, BUT THE DEALER WAS UNABLE TO REPLICATE THE PROBLEM SO NO CURE WAS ABLE TO BE UNDERTAKEN. THE DEALER SAID IF WE WANTED TO, THEY COULD REPLACE THE STEERING MECHANISM FOR ABOUT $2,000 WHICH WE DECLINED. *TR

Mileage: 40,000

POWER STEERING ASSIST FAULT. OVER THE LAST 3 MONTHS, HAVE HAD MULTIPLE RANDOM POWER STEERING ASSIST FAULTS. BY SHUTTING DOWN VEHICLE AND RESTARTING, THESE HAVE CLEARED IN THE PAST, BUT ON NOV.2, 2014, UPON START OF VEHICLE, POWER STEERING ASSIST FAULT OCCURRED AND WOULD NOT CLEAR. WAS FORCED TO DRIVE CAR HOME WITHOUT POWER STEERING AND ALMOST CRASHED MULTIPLE TIMES. IN ADDITION, THIS FAULT SOMETIMES HAS OCCURRED AT SAME TIME AS ADVANCETRAC WARNING. APPEARS THAT WHATEVER ELECTRICAL DEVICE IS FAILING IS RELATED TO BOTH SYSTEMS. *TR

Mileage: 95,000

MESSAGE REGARDING ENGINE FUNCTION

THE POWER STEERING HAS GONE OUT NOW A FEW TIMES. EACH TIME THE CAR HAS TO BE PLACED IN PARK, SHUT OFF AND TURNED BACK ON FOR IT TO BE RESET. IT JUST HAPPENED AGAIN AT 91, 777 MILES. ENOUGH IS ENOUGH AND THIS SHOULD BE ADDRESSED BEFORE SOMEONE GETS KILLED. MY WIFE WAS DRIVING THIS TIME ON A FAIRLY BUSY ROAD WITH OUR DAUGHTER. *TR

Mileage: 10,383

I GOT IN MY CAR AFTER WORK AND THERE WAS DINGING AND A NOTIFICATION APPEARED ON THE DASH THAT MY POWER STEERING NEEDED SERVICE NOW. I COULD NOT MOVE MY WHEEL OR STEER AT ALL. AFTER TAKING IT IN TO THE SERVICE STATION I WAS TOLD THE MY ELECTRONIC STEERING GEAR HAD MALFUNCTIONED, I BELIEVE THEY REFERRED TO IT AS THE EPAS SYSTEM. IT IS A COMPLETE MALFUNCTION OF THE POWER STEERING SYSTEM AND I AM LUCKY THAT I WAS NOT DRIVING THE VEHICLE WHEN IT WENT OUT. *TR

Mileage: 53,000

WHILE DRIVING TO WORK ALL OF A SUDDEN MY ADVANCE TRAC LIGHT WENT ON AND THERE WAS NO STEERING AT ALL. ALL THE LIGHTS WENT DEAD AND I HAD TO STOP IN THE MIDDLE OF THE STREET. I TRIED TO GET THE CAR TO THE SIDE OF THE ROAD BEFORE STOPPING BUT WASN'T ABLE TO MANEUVER IT, IT WAS TOO HARD TO STEER. AFTER STOPPING SHORT I FINALLY WAS ABLE TO FORCE THE STEERING WHEEL TO TURN AND MOVED TO THE SIDE OF THE ROAD. I READ THE MANUAL AND IT SAID TURN OFF THE CAR AND RESTART, I DID AND NOTHING HAPPENED. I CALLED AAA AND THEY TOWED ME TO FORD IN TOMS RIVER, NJ. IT COST ME $2,152.14 FOR THE STEERING RACK TO BE REPLACED AS WELL AS HAVING MY CAR FOR 6 DAYS AND HAVING TO RENT A CAR FOR ADDITIONAL COSTS. *TR

Mileage: 61,514

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THE LOW TIRE PRESSURE INDICATOR ILLUMINATED AND THE POWER STEERING MALFUNCTIONED. THE CONTACT HAD TO EXERT EXCESSIVE FORCE TO TURN THE STEERING WHEEL. THE DEALER STATED THAT THE COMPUTER HAD TO BE REPROGRAMMED AND RESET. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 37,000.

Mileage: 37,000

THIS HAPPENED TO ME ON MULTIPLE OCCASIONS WHERE I WILL BE DRIVING AND MY CAR JUST LOOSES POWER AND THE THROTTLE WONT WORK. I HAVE BEEN LUCKY ENOUGH NOT TO HAVE BEEN IN AN ACCIDENT BUT HAVE ALMOST BEEN IN TWO BECAUSE OF THE PROBLEM. I HAVE TO PULL OVER AND SHUT THE CAR OFF FOR A COUPLE OF MINUTES BEFORE I CAN START IT BACK UP AND WHEN I TRY TO START IT BACK UP IT HAS A HARD TIME STARTING. *TR

Mileage: 60,000

AFTER HAVING MY CAR FOR 3 MONTHS OR SO I HAD THE FIRST INCIDENT WITH THE POWER STEERING FAILING ON MY CAR WHILE DRIVING WITH A WARNING MESSAGE THAT STATED "POWER STEERING ASSIST FAULT, SERVICE ADVANCETRAC" I WAS ABLE TO PULL OVER TURN THE VEHICLE OFF AND BACK ON AND THE PROBLEM WOULD BE CORRECTED, THE LAST EVENT WITH.WITH THIS SAME PROBLEM DID NOT CLEAR THE MESSAGE, I HAVE READ A NUMBER OF BLOGS WITH PEEP OWNING FORD FUSIONS TO.KNOW THIS IS NOT AN ISOLATED ISSUE AND YET FORD MOTOR COMPANY STILL HAS YET TO TAKE CORRECTIVE ACTION AGAINST THIS PROBLEM AND AT AROUND 1900.00 FOR REPAIR COSTS OF THIS ISSUE THAT IS UNACCEPTABLE. *TR

Mileage: 65,500

DRIVING TO WORK 25 MPH AND SUDDENLY MY POWER STEERING WENT OUT, THEN THE TRACTION CONTROL SYSTEM(TSC) LIGHTS WENT ON. *TR

Mileage: 78,341

PULLED FROM A RED LIGHT AND CAR STARTED SHAKING VIGOROUSLY. PULLED OVER SAFELY INTO A PARKING LIGHT AND A WRENCH LIT UP ON THE DASH BOARD. TOOK IT TO A NEAR BY AUTO PARTS STORE, CLERK SCANNED IT AND SAID IT WAS A THROTTLE BODY MALFUNCTION. *TR

Mileage: 46,000

MY DAUGHTER WAS DRIVING MY CAR AND ALL OF A SUDDEN POWER STEERING AND ADVANCE TRAC SYSTEM LIGHT DISPLAYS ON THE DASH, CUT THE CAR OFF AND RESTARTED NO CHANGE. WITH ALL THESE COMPLAINTS I PRAY THAT FOR DO SOMETHING ABOUT THIS, NOW MY CAR IS OUTSIDE IN THE PARKING LOT, NOT SURE IF IM GOING TO BE ABLE TO PAY TO GET IT FIX BC I WAS JUST LAID OFF MY JOB. *TR

Mileage: 75,000

AFTER STOPPING AT A STOP SIGN, WHEN I PUSHED THE ACCELERATOR, THE VEHICLE JERKED AND WOULD NOT ACCELERATE PAST THE IDLE DRIVE SPEED; A WRENCH LIGHT DISPLAYED ON THE DASH; I SLOWLY MANEUVERED INTO A PARKING LOT. AFTER RESTARTING THE VEHICLE, I MANAGED TO GET HOME AND DRIVE THE CAR FOR SEVERAL DAYS WITHOUT ISSUE. A QUICK INTERNET SEARCH LED ME TO SUSPECT THE THROTTLE BODY. ON ABOUT JULY 29TH, THE SAME THING HAPPENED. I PULLED TO THE SIDE OF THE PARKING LOT THAT I WAS IN AND RESTARTED THE VEHICLE. ON THE MORNING OF JULY 31ST, AS I PUT IT IN PARK AT MY PLACE OF EMPLOYMENT, THE VEHICLE STALLED (THE ENGINE STOPPED AND RPM DISPLAY SHOWED 0) AND THE BATTERY LIGHT AND OIL LAMP LIGHT DISPLAYED. THE VEHICLE STARTED RIGHT BACK UP. UPON LEAVING MY PLACE OF EMPLOYMENT, THE VEHICLE STALLED FOUR ADDITIONAL TIMES WITHIN THE 9 MILES BETWEEN WORK AND THE NEAREST AUTO PARTS STORE. THE EMPLOYEE STATED THAT THE AFFECTED PART WAS THE "THROTTLE BODY" JUST AS I HAD FOUND BEFORE. *TR

MY 16 TEEN YEAR OLD SON WAS DRIVING, HE IS ONLY ON A LEARNERS PERMIT WHEN THE LIGHTS AND CHIMES WENT OFF AND HE LOST POWER STEERING. IT TOOK ME AND HIM TO PULL IT OFF THE ROAD. THANK GOD HE WAS ON A STRAIGHT AWAY! SHUT THE CAR OFF AND IT RESET. NEXT DAY I AM DRIVING 50 MPH WHEN I LOOSE POWER STEERING I MANAGE TO STOP AND PULL OFF TO THE SIDE OF THE ROAD. TRIED THE TURN OFF TRICK AND DID NOT WORK. HUSBAND TOOK BATTERY CABLE OFF FOR 15 MIN, STILL NO LUCK. NOW IT SITS, IT IS NOT SAFE TO DRIVE, YOU NEED TWO PEOPLE TO TURN THE CAR! *TR

Mileage: 76,000

ON JUNE 27, 2014 I TOOK MY CAR TO A DEALERSHIP FOR A RECALL TO REPROGRAM IT. ON JULY 14, 2014, MY CAR JUST STOPPED RUNNING WHILE I WAS DRIVING. AFTER SEVERAL ATTEMPTS, IT DID RESTART AFTER I TURNED OFF THE AIR CONDITIONER AND RADIO. THE NEXT DAY I BROUGHT IT INTO THE DEALERSHIP ONCE AGAIN. THE SERVICE PERSON TOLD ME THE SAME THING HAPPENED TO SEVERAL OTHER CUSTOMERS AFTER THE INITIAL RECALL AND THAT NOW THE THROTTLE BODY NEEDED TO BE REPLACED. WHEN I ASKED WHY THAT WASN'T REPLACED WHEN IT WAS REPROGRAMMED, HE SAID FORD TOLD THEM TO WAIT UNTIL THE SECOND PROBLEM OCCURRED BEFORE REPLACING IT. MY CONCERN IS SAFETY. HAD MY CAR STOPPED RUNNING ON A BUSY HIGHWAY GOING A HIGHER SPEED LIMIT, I MIGHT HAVE BEEN KILLED. I CALLED FORD CUSTOMER SERVICE AND WAS GIVEN A CASE NUMBER AND TOLD THIS WOULD BE "LOOKED INTO." HOW MANY MIGHT DIE BEFORE THIS RECALL WILL BE DONE PROPERLY? *TR

Mileage: 43,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STALLED AS THE WRENCH WARNING ICON ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE JERKED VIOLENTLY WHEN THE FAILURE OCCURRED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD WHERE THE VEHICLE WAS RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT THE THROTTLE BODY, ENGINE VALVE AND FUEL SYSTEM NEEDED TO BE CLEANED AND THE POWER CONTROL MODULE NEEDED TO BE REPROGRAMMED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,552 AND THE APPROXIMATE 160,000.

Mileage: 53,552

DRIVING AT CITY SPEEDS AND THE POWER STEERING COMPLETELY FAILS. TURN THE VEHICLE OFF AND THEN ON AGAIN AND IT FIXES THE PROBLEM. DRIVE SOME MORE AND A FEW DAYS LATER, IT HAPPENS AGAIN. A FEW DAYS LATER, IT COMPLETELY GOES. TAKE THE CAR TO THE LOCAL FORD DEALER AND AM CHARGED $1832.35 FOR A NEW RACK AND PINION. LADIES AND GENTLEMEN, A RACK AND PINION WON'T FIX ITSELF IF YOU TURN THE CAR ON AND OFF. I DID SOME RESEARCH ON THIS PROBLEM ON LINE AT FORDFUSIONFORUM.COM. IT SEEMS TO BE AN ABS MODULE, NOT THE RACK AND PINION. CALLED FORD TODAY AND THEY SAID NO REIMBURSEMENT WAS POSSIBLE. A NEW RACK AND PINION FOR A CAR WITH ONLY 21 THOUSAND MILES ON IT? CRAZY. *JS

Mileage: 21,856

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED WHILE DRIVING AT 40 MPH, THE DEFROSTER FAILED CAUSING THE CONTACT'S VISIBILITY TO BE BLOCKED. THE CONTACT INSPECTED THE VEHICLE AND DIAGNOSED THAT THE BLOWER MOTOR RESISTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE REOCCURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 32,000 AND CURRENT MILEAGE WAS 50,000.

Mileage: 32,000

WHILE DRIVING ALONG THE HIGHWAY MY GAUGES ON THE INSTRUMENT PANEL WENT OUT MOMENTARILY, AND THEN CAME BACK ON WITH THE MESSAGE "SERVICE ADVANCETRAC." I DIDN'T THINK MUCH ABOUT IT BECAUSE IT WENT AWAY WHEN I TURNED MY CAR OFF AND BACK ON. A COUPLE WEEKS LATER (STARTING JUNE 16TH) THE INSTRUMENT PANEL KEPT GOING OUT EVERY TIME I DROVE THE VEHICLE, AND MULTIPLE MESSAGES CAME UP IN THE MESSAGE CENTER ABOUT GETTING MY BRAKE SYSTEM CHECKED AND ALL FOUR TIRE PRESSURES WERE LOW. ALONG WITH THESE OTHER MESSAGE CENTER MALFUNCTIONS, THE ANTI-THEFT SECURITY SYSTEM WAS MALFUNCTIONING AND NOT RECOGNIZING EITHER KEY I HAVE FOR THE CAR. A COUPLE OF TIMES IT TOOK 20 MINUTES OF TRYING AND HOPING TO GET THE VEHICLE TO RECOGNIZE THE KEY. I TOOK IT IN TO THE DEALERSHIP, AND NOW I HAVE TO PAY $2000 TO GET MY POWER STEERING MODULE REPLACED. I AM COMPLETELY DISAPPOINTED THAT MY 2011 FORD NEEDS TO HAVE ITS POWER STEERING REPLACED AT NOT EVEN 60000 MILES. *TR

Mileage: 58,600

SUDDEN LOSS OF POWER STEERING WHILE STOPPED IN TRAFFIC..RESOLVED ON RESTART...3RD SUCH INCIDENT OVER THE LAST SEVERAL MONTHS...OTHER INCIDENTS OF POWER STEERING LOSS HAVE OCCURRED WHILE AT FREEWAY SPEEDS AND ALSO WHILE WAITING AT STOP LIGHTS...RESOLVES ON RESTART...RESTARTS AT LESS THAN 30 SECONDS AFTER THE FAILURES WILL NOT SET TROUBLE CODES, SO THAT DIAGNOSIS IS NOT POSSIBLE... *JS

Mileage: 74,000

POWER STEERING ASSIST FAULTS OUT. HAVE TO TURN THE CAR OFF AND TURN BACK ON. VERY DANGEROUS. HAS HAPPENED 3 TIMES NOW. *TR

Mileage: 65,000

WAS DRIVING AND PULLED UP TO A STOP LIGHT AND NOTICED A FOUL SMELL THAT SMELLED LIKE BRAKES FROM VEHICLE NEXT TO ME. PULLED INTO MY WORK AND THE SMELL GOT REALLY STRONG AND I NOTICED SOME SMOKE STARTING TO ROLL FROM THE TRUNK OF MY CAR. I OPENED THE TRUNK TO FIND THAT THE TRUNK HAD CAUGHT FIRE. I WAS ABLE TO PUT THE FIRE OUT BUT THE WHOLE LIGHT ASSEMBLY HAD BEEN BURNED ALONG WITH SOME WIRING AND THE MOLDING THAT HOUSES THE LIGHT ASSEMBLIES. RECALL ISSUED FOR FORD TAURUS BUT NOT FRO FUSION WITH SAME BAD PARTS. *TR

Mileage: 96,500

SOMETHING TO DO WITH THE ELECTRICAL IN THE POWER STEERING. *TR

Mileage: 50,000

I STARTED THE CAR UP AND A WARNING READ POWER STEERING ASSIST FAULT. RESTARTED THE CAR AND NO PROGRESSIVE . A LITTLE OVER TWO WEEKS LATER, I STARTED THE CAR AND IT THEN READ SERVICE ADVANCETRAC IN ADDITION TO PREVIOUS WARNING. *TR

Mileage: 54,000

PULLED OUT OF A PARKING LOT ONTO A MAIN STREET WHEN VEHICLE LOST ALL POWER. IT WAS DARK AND THE CAR IS BLACK AND I FEARED SOMEONE WOULD HIT ME SINCE THE HAZARD FLASHERS WERE NOW INOPERATIVE. VEHICLE HAD TO BE PUSHED ONTO A SIDE ROAD. A SIMILAR INCIDENT OCCURRED IN JULY 2013 BUT THE VEHICLE WAS IN THE GARAGE AT THE TIME SO IT WASN'T A SAFETY ISSUE. AT THAT TIME THE DEALER INSTALLED A NEW BATTERY SINCE THE ORIGINAL HAD SO MUCH CORROSION THAT IT ATE AWAY AT THE POSITIVE BATTERY POST. I NO LONGER FEEL SAFE DRIVING THIS CAR AND WILL BE CONTACTING THE DEALER TOMORROW. *TR

Mileage: 28,000

WHILE DRIVING OUR CAR, MY WIFE (ALONG WITH MY 9 MONTH OLD BABY GIRL) EXPERIENCED A SUDDEN LOSS OF POWER AND SHAKING ENGINE. THE CAR WAS NOT DRIVABLE SO SHE PULLED ONTO A SIDE STREET AND PARKED THE CAR, LEAVING THEM STRANDED. NO ENGINE WARNING LIGHTS EVER CAME ON. THIS IS EXACTLY AS DESCRIBED (MINUS THE LACK OF CHECK ENGINE LIGHT) IN THE "FORD CUSTOMER SATISFACTION PROGRAM 13N03" LETTER THAT WE RECEIVED A FEW MONTHS AGO. THIS IS AN INTERMITTENT PROBLEM, SO WE WERE ABLE TO TAKE THE CAR IN TO THE FORD DEALER. OUR LOCAL FORD DEALER WAS NOT ABLE TO PULL A CODE AS THE CHECK ENGINE LIGHT NEVER CAME ON. THE DEALER, AND FORD CUSTOMER SERVICE, REFUSE TO REPLACE THE THROTTLE BODY UNTIL THE CODE FOR MALFUNCTIONING THROTTLE BODY IS READ. MY WIFE AND INFANT DAUGHTER MUST NOW DRIVE AROUND (TWICE A DAY, 5 DAYS A WEEK) WAITING FOR IT TO FAIL AGAIN, AND TAKE THE CAR TO THE DEALER AT THE TIME OF MALFUNCTION. THIS IS A MAJOR SAFETY CONCERN AS THE CAR WILL BARELY MOVE AND SHAKES SO BADLY. IT SHOULD NOT BE DRIVEN ACROSS THE CITY TO THE DEALERSHIP IN THIS CONDITION, ESPECIALLY WITH A BABY IN THE CAR. FORD NEEDS TO RECALL THESE PARTS AND REPLACE THEM ALL TO STOP PUTTING CUSTOMERS IN DANGER WITH CARS THAT BARELY MOVE. AS FOR THE "CUSTOMER SATISFACTION PROGRAM"? NOT FEELING VERY SATISFIED AT ALL... *TR

Mileage: 79,000

MY WIFE, [XXX], WAS DRIVING OUR FUSION. SHE HAD TRAVELED APPROX. 1/4 MILE AND WAS APPROACHING A STOP SIGN AT BAYSIDE DR. NEWPORT BEACH,CA AT THE HARBOR IS. DR. INTERSECTION. SUDDENLY, THE CAR ACCELERATED, CATCHING HER BY SURPRISE SHE WENT THROUGH THE INTERSECTION AND WAS NARROWLY MISSED BY TWO ONCOMING CARS. SHE TOLD ME LATER THAT IT HAPPENED A SECOND TIME ON THE FREEWAY (SHE WAS ON HER WAY HOME) BUT WAS NOT IN IMMEDIATE DANGER WHEN IT OCCURRED. WE HAVE TRAVELED THESE STREETS SEVERAL TIMES. HAD JUST LEFT THE RESTAURANT WHERE WE HAD LUNCH....WAS RIDING MY BICYCLE HOME AND WATCHED HER GO THROUGH THE INTERSECTION....VERY SCARY!! NOTE: THE THROTTLE POSITIONER WAS REPLACED ON THIS VEHICLE A COUPLE MONTHS AGO. IT HAD FAILED TO 5MPH. VILLA FORD IN ORANGE CA DID THE REPAIR. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR UPDATED 10/7/2014 *JS

Mileage: 50,220

BATTERY GOES DEAD AFTER SITTING A FEW DAYS. POSSIBLE SIGN OF ELECTRIC THROTTLE BODY FAILURE.!!??? BATTERY REPLACED TWICE IN 4 MONTHS, CHARGES NORMALLY. WHILE LOOKING FOR POSSIBLE ELECTRICAL PROBLEMS ASSOCIATED WITH THE 2011 FUSION (11K MILES) I DISCOVERED THERE IS MANY, MANY PEOPLE COMPLAINING OF THROTTLE BODY FAILURE. I WENT TO THE LOCAL DEALER AND CALLED FORD AND ASKED THEM TO REPLACE THE THROTTLE BODY AND TRACE THE ELECTRICAL PROBLEM. I WAS TOLD THAT THEY WOULD ONLY HONOR THEIR "CUSTOMER SATISFACTION PROGRAM" CONCERNING THE THROTTLE BODY IF IT FAILS!!!!!! I EXPLAINED THAT I WAS AFRAID TO DRIVE THE VEHICLE AND IF THEY HAD AN UPDATED THROTTLE BODY AND "LIMP HOME" UPDATE THEY SHOULD INSTALL IT AND MAKE CORRECTIONS. A CALL TO FORD AND THEY REFUSED TO FIX THE POTENTIALLY DEADLY PROBLEM. SO WHAT RECOURSE IS THERE?? MY FUSION AND F-350 ARE BOTH HEADED FOR TRADE AT A NO NONSENSE DEALER. LACROSSE AND SILVERADO, HERE I COME!!!!!!! I SUGGEST YOU DO SOMETHING SIMILAR. *TR

Mileage: 11,000

2011 FORD FUSION. CONSUMER WRITES IN REGARDS TO THROTTLE BODY CUSTOMER SATISFACTION PROGRAM RECALL NOTICE. *SMD

2011 FORD FUSION LOST POWER AND STALLED AND FOUND OUT THAT THE ELECTRICAL THROTTLE BODY NEEDED TO BE REPLACED FOR A COST OF 500.94 BY A MECHANIC BECAUSE IT IS NOT COVERED BY FORD EVEN THOUGHT THERE ARE MANY COMPLAINTS ABOUT THIS BAD PART IN THE FUSIONS. THERE SHOULD BE A RECALL ON THIS AND/OR REIMBURSEMENT FOR GETTING IT FIXED. ONLY HAD THE CAR 6 MONTHS WITH LESS THAN 28K MILES ON IT. *TR

Mileage: 27,875

I WAS DRIVING DOWNTOWN AND NEXT THING I KNOW MY WRENCH LIGHT COMES ON AND I LOSE ALL POWER TO MY FORD FUSION. I WAS SCARED BECAUSE I DIDN'T KNOW WHAT WAS GOING ON. I COULDN'T DO ANYTHING UNTIL I PULLED OFF THE ROAD AND SHUT MY CAR OFF AND RESTARTED IT. THIS PROBLEM HAS HAPPENED TO ME MULTIPLE TIMES WITHIN THE PAST 3 WEEKS. I WOULD HAVE TO SAY ITS HAPPENED AT LEAST 15 TIMES IN THOSE 3 WEEKS. I AM STARTING TO GET ANNOYED WITH THIS PROBLEM BECAUSE I TOOK THE CAR TO THE DEALERSHIP AND THEY CONSTANTLY TELL ME NOTHING IS WRONG WITH MY CAR, YET I KNOW THERE IS DEFINITELY SOMETHING WRONG. THE PROBLEM HAPPENED AGAIN ON 11/26/2013 AND WHEN IT DID MY CHECK ENGINE LIGHT CAME ON WITH THE WRENCH LIGHT SO I TOOK IT TO AUTOZONE FOR THEM TO CHECK THE ENGINE LIGHT CODE AND THE CODE WAS P2111 AND THE DESCRIPTION IT GAVE WAS THAT THE THROTTLE ACTUATOR CONTROL SYSTEM WAS STUCK OPEN. I NOW HAVE PROOF TO TAKE TO THE FORD DEALERSHIP THAT SOMETHING IS WRONG WITH THE CAR. THEY BETTER FIX THIS PROBLEM! *TR

Mileage: 30,000

THE ERROR OCCURRED AS I WAS DRIVING ON A MAJOR 8-LANE HIGHWAY. I WAS ABOUT A QUARTER-MILE FROM MY EXIT (AFTER BEING ON THE HIGHWAY FOR 60 MILES) WHEN I FELT A "CLUNK" AND AN ORANGE-LIT WRENCH APPEARED ON MY DASH. AS I TURNED ONTO THE EXIT RAMP, I SLOWED TO A STOP AT A STOP-LIGHT, WAITING TO TURN LEFT. WHILE THE BRAKE WAS DEPRESSED, THE CAR WAS ATTEMPTING TO MOVE FORWARD VERY ABRUPTLY, AS PART OF IT'S "LIMP HOME" FEATURE. WHEN THE LIGHT TURNED GREEN, I RELEASED THE BRAKE AND ATTEMPTED TO ACCELERATE THROUGH THE INTERSECTION, BUT PRESSING THE GAS PEDAL PRODUCED NO RESPONSE FROM THE CAR. AFTER LIMPING THROUGH THE INTERSECTION, I SHIFTED THE CAR INTO PARK AND TURNED THE ENGINE OFF. AFTER WAITING 10-15 SECONDS, I RESTARTED THE CAR AND THE THROTTLE ISSUE AND DASH LIGHT WERE BOTH GONE. I HAVE SINCE DRIVEN ~100 MILES WITHOUT SEEING THE ISSUE RE-APPEAR. *TR

Mileage: 46,984

I WAS DRIVING ON THE HIGHWAY AT ABOUT 65MPH, I BEGAN TO EXIT AND CAME DOWN TO 40. ONCE I STARTED TO SLOW DOWN I FELT THE CAR TUG, IT WAS ODD BECAUSE IT HAD NEVER DONE THAT BEFORE BUT I FINISHED EXITING AND TRIED TO PICK UP SPEED AGAIN BUT COULDN'T. THE RPM WENT DOWN, WRENCH SIGNAL CAME OUT ON DASH, I PUSHED ON THE GAS AND NOTHING, IT DID NOT HAVE ANYMORE POWER. LUCKILY THERE WERE MANY BUSINESSES TO MY RIGHT TO WHERE I WAS ABLE TO PARK SAFELY, IF I WAS STILL ON THE HIGHWAY WHILE THIS HAPPENED I COULD HAVE EASILY BEEN REAR ENDED OR WORSE BECAUSE THE CAR SLOWED ON ITS OWN AND I WAS UNABLE TO CONTROL THE GAS. AS I PULLED OVER THE CAR BEGAN TO SHAKE, I TURNED IT OFF QUICKLY AND CALLED FOR HELP. A RELATIVE CAME TO MY AID TO CHECK IT OUT BUT WE COULDN'T FIND ANYTHING VISIBLE, WE CAUTIOUSLY TURNED THE VEHICLE BACK ON AND THE WRENCH SIGNAL TURNED OFF, NO MORE SHAKING, IT WAS ODD THAT IT JUST COMPLETELY LOST POWER A FEW MINUTES PRIOR AND NOW IT WAS BACK TO NORMAL. WE DROVE IT AROUND THE PARKING LOT TO TEST IT, DIDN'T WANT TO LEAVE IT BEHIND DUE TO THE AREA AND POSSIBILITY OF THEFT, ALSO COULD NOT AFFORD A WRECKER TO PICK IT UP. I ENDED UP HEADING BACK HOME WITH MY RELATIVE BEHIND ME. IT WAS VERY UNCOMFORTABLE, I'M SO GLAD IT WAS MYSELF AND NOT MY WIFE AND KIDS AS THIS IS HER VEHICLE. I KNOW THEY ARE NUMEROUS KNOWS ISSUES ON THE THROTTLE BODY WITH THIS VEHICLE. IT IS SAD THAT IT HAS NOT BEEN RECALLED YET, PLEASE TAKE A STAND AND DO NOT WAIT UNTIL SOMEBODY IS SERIOUSLY INJURED OR WORSE. *TR

Mileage: 44,150

LUCKY ME, I HAPPENED TO HAVE TWO OF THESE FAILED DESIGNED VEHICLES. MY WIFE HAS A 2010 THAT DEVELOPED THROTTLE BODY PROBLEMS AT 35000 MILES AND NOW MINE AT 87500 MILES. THE 2010 LEFT HER STRANDED WITH ZERO ENGINE POWER, IN THE MIDDLE OF BUSY ROADS A TOTAL OF TWO TIMES BEFORE THE DEALERSHIP (PALM COAST FORD) ON THE THIRD VISIT DECIDED THAT JUST CLEANING AND SPRAYING DOWN THE FAILING HARDWARE DIDN'T CUT IT AND FINALLY PUT A NEW ONE ON, LUCKILY STILL UNDER WARRANTY. THE MECHANIC DID HOWEVER SAY THAT THIS IS A COMMON OCCURRENCE FOR THESE FORD PRODUCTS AND THAT THE SAME THING WOULD PROBABLY HAPPEN TO THE THROTTLE BODY HE JUST PUT ON. WHY FORD DID NOT FIX THE PROBLEM SOONER AT THAT POINT IN TIME? MY GUESS, NOT ENOUGH PEOPLE HAD A DIRECT LINK TO THEIR DEATH FROM CAR ACCIDENTS AT THAT POINT IN TIME! 20,000 MILES LATER SO FAR NO OTHER PROBLEMS. NOW MY 2011 FUSION IS A MANUAL 6 SPEED. WHEN MY THROTTLE BODY FAILED THIS MORNING WHILE GOING TO WORK I NOTICED THAT WHILE IN CRUISE CONTROL THE SPEED WAS PULSING DOWN AND UP AROUND TWO MPH. THIS WOULD HAPPEN FOR A SHORT TIME AND THEN STOP AND BE FUNCTIONING PROPERLY FOR A WHILE AND THEN DO IT AGAIN. FINALLY AT A LIGHT I NOTICED THE IDLE UP AND DOWN AND AFTER ACCELERATING TO 60 IT SUDDENLY WENT TO IDLE OF 900 RPM. NO POWER FROM THE ENGINE. YOU COULD FLOOR IT AND NOTHING. WELL ONCE AGAIN LIKE MANY OTHERS THAT HAVE HAD THE SAME FORD FAILURE EXPERIENCE I ALMOST WAS HIT BY ANOTHER VEHICLE BECAUSE OF NO WHERE TO PULL OVER. I WILL PURCHASE THE PART AND REPLACE IT MYSELF. I THOUGHT I WOULD GIVE FORD A TRY AGAIN FROM YEARS AGO WHEN I HAD A LYNX THAT CAUGHT ON FIRE, AND A TAURUS SHO WITH A POORLY ENGINEERED CLUTCH DESIGN, BUT THEY FAILED ME AGAIN. *TR

Mileage: 87,500

WAS TRAVELING 45 MPH WRENCH LIGHT CAME ON AND STALLED. *TR

Mileage: 52,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE BATTERY CABLE ASSEMBLY WAS BURNED, CAUSING FIVE FUSES TO MALFUNCTION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 51,960. UPDATED 01/07/14*LJ UPDATED 1/17/2014 *JS

Mileage: 51,960

WHILE DRIVING AT ALL TIMES, THE VEHICLE WOULD START TO SURGE AND BUCK THEN LOOSE POWER. IT NEVER COMPLETELY DIED BUT WHEN I PULLED OVER IT RAN TERRIBLE AND WOULD NOT ACCELERATE. I TURNED IT OFF FOR A FEW SECONDS AND RESTARTED IT. IT WOULD RUN FOR A WHILE, GOOD, THEN THE PROBLEM WOULD REOCCUR. THE ENGINE LIGHT CAME ON, I HAD THE CODE CHECKED. THE RESULT WAS A FAULTY THROTTLE BODY OR SORT IN THE THROTTLE BODY MODULE. *TR

Mileage: 63,000

MY WIFE HAD MY 6 MONTH OLD SIGN IN THE BACKSEAT WHEN SHE WAS PULLING OUT FROM A STOP SIGN INTO A 4WAY WHEN THE CAR LURCHED AND THE ACCELERATOR QUIT RESPONDING IN THE MIDDLE OF THE STREET A TRUCK NEARLY T BONED HER ON THE DRIVER SIDE WHERE OUR SON WAS IN HIS CAR SEAT UPON DIAGNOSTICS THE ELECTRONIC THROTTLE BODY WAS STUCK OPEN. I'VE FOUND SIMILAR ISSUES WITH SIMILAR VEHICLES ALTHOUGH THE DEALERSHIP INFORMED ME MY VEHICLE IS NOT CURRENTLY ON A RECALL LIST. *TR

Mileage: 60,717

THIS HAS HAPPENED MULTIPLE TIMES VARYING FROM ACCELERATING FROM A STOP TO HIGHWAY SPEEDS OF 60+ MPH. 2011 FORD FUSION SEL SUDDENLY LOSES ALL POWER AND WRENCH ICON ILLUMINATES AND NO ACCELERATION HAPPENS AT ALL. THE ENGINE REMAINS AT IDLE WITH FLUCTUATIONS FROM 800-1200 RPMS. HAD TO CROSS MULTIPLE LANES AND WAS ALMOST RAN INTO BY THREE CARS GOING A LOT FASTER THAN ME WHILE I WAS LISTING TO THE EMERGENCY LANE. ONCE CAR IS TURNED OFF AND RESTARTED THE PROBLEM WILL GO AWAY. AFTER MUCH RESEARCH AND THE ONE TIME IT SHOWED A CHECK ENGINE LIGHT I RAN THE CODES AND IT ALL WAS POINTING TO A DEFECTIVE THROTTLE BODY. I NOTICED THAT THERE ARE A LOT OF COMPLAINTS WITH THIS ASPECT ON THIS CAR AND JUST HOPE SOMEONE DOESN'T HAVE TO GET KILLED ON THE ROAD LIKE I ALMOST DID TO GET A RECALL ON THIS CAR AND PART. *TR

Mileage: 45,000

ON SEPTEMBER 15, 2013 I WAS DRIVING ON A MAJOR SURFACE STREET AT APPROXIMATELY 35 MILES PER HOUR WHEN THE CAR JUST STOPPED WORKING. COMPLETELY POWERLESS. I SAW TWO LIGHTS ON THE DASHBOARD: THE BATTERY AND THE OIL. THERE MAY HAVE BEEN MORE BUT I WAS MORE FOCUSED ON SAFETY AND ONCOMING TRAFFIC THAN THE LIGHTS ON THE DASH. I DECIDED NOT TO TAKE A CHANCE OF GETTING REAR ENDED (INJURED OR KILLED) SO AT THE FIRST BIG BREAK IN TRAFFIC I SAFELY EXITED THE VEHICLE AND WALKED OVER TO THE SIDEWALK (ONE LANE OVER). A LOCAL APARTMENT RESIDENT SAW THE INCIDENT AND GRABBED A SAFETY CONE TO PUT BEHIND MY CAR AS A WARNING. THANKFULLY THERE WERE NO ACCIDENTS BUT THERE WERE SOME CLOSE CALLS AND LAST MINUTE LANE CHANGES AS DRIVERS CAME UPON MY CAR. I CALLED FORD ROADSIDE ASSISTANCE AND THEY SENT A TOW TRUCK TO GET THE VEHICLE. IT STARTED UP PERFECTLY FOR THE DRIVER, BUT I HAD IT TOWED ANYWAY. IT HAS BEEN AT THE DEALER FOR TWO DAYS. THEY HAVE BEEN UNABLE TO DUPLICATE THE SITUATION AND HAVE RECEIVED NO "CODES" TO INDICATE A PROBLEM WITH THE VEHICLE. THEY HAVE CALLED FORD TO ASK FOR ASSISTANCE AND FORD HAS ASKED THEM QUESTIONS REGARDING LIGHTS GOING ON, MY SPEED AT THE TIME OF THE INCIDENT, HOW FAR I HAD BEEN DRIVING THE CAR BEFORE THE INCIDENT, ETC. THIS IS THE SECOND TIME I HAVE HAD A PROBLEM WITH MY 2011 FUSION COMPLETELY FAILING. THE FIRST TIME WAS IN SEPTEMBER 2012 WHEN THE THROTTLE FAILED ON THE FREEWAY. IT WAS SUPPOSEDLY FIXED. THIS TIME THE LOST OF POWER DID NOT FEEL LIKE THE THROTTLE. IT JUST STOPPED WORKING. HAD POWER. DIDN'T HAVE POWER. I AM EXTREMELY CONCERNED THAT THE DEALER WILL FIND NOTHING WRONG WITH THE VEHICLE AND IT WILL BE RETURNED TO ME IN AN UNSAFE CONDITION. OTHERS HAVE REPORTED THIS AND SIMILAR ISSUES. PLEASE GET THESE VEHICLES RECALLED BEFORE SOMEONE LOSES A LIFE.

Mileage: 34,000

CAR DIES WHILE DRIVING, SURGES AT TIMES, HAD BEEN HAPPENING ON AND OFF. DIED PART WAY THROUGH A LARGE INTERSECTION ON 7-13-13, LUCKILY I JUST AVOIDED A COLLISION. IT WOULD START AND GO A FEW FEET, THEN SURGE AND DIE. CALLED CRATER LAKE FORD IN MEDFORD, OR, THEY STATED VERY BUSY THAT DAY AND HAD NOT HEARD OF THE SYMPTOMS I DESCRIBED. PLACED A CALL TO DAVE'S IMPORT SERVICE THEY SAID THEY WOULD LOOK AT THE CAR. WITHIN 45 MIN THEY HAD DIAGNOSED FAILED THROTTLE BODY. *TR

Mileage: 37,245

I HAVE BEEN SENSING A SURGE IN ENGINE POWER FOR SEVERAL MONTHS IN MY 2011 FUSION. I SUSPECTED A THROTTLE BODY PROBLEM AND GOOGLED FOR INFORMATION. I FOUND ALL OF THE INFORMATION ON THE NHTSA WEBSITE ABOUT THROTTLE BODY PROBLEMS FOR THIS CAR AS WELL AS INFORMATION IN OTHER FORUMS. IT WAS A GOOD THING AS I WAS PREPARED FOR WHAT HAPPENED TODAY. I HAD JUST LEFT MY HOUSE WHEN THE DREADED (AND EXPECTED) LOSS OF ENGINE POWER WITH THE WRENCH LIGHT BEING ILLUMINATED. I EXPERIENCED THE SAME SYMPTOMS REPORTED BY SO MANY COMPLAINTS LOGGED FOR THIS ISSUE: LOSS OF POWER, ROUGH IDLE, JUST ENOUGH POWER TO BARELY MOVE THE CAR, CERTAINLY NOT ENOUGH TO LIMP ANYWHERE, MUCH LESS HOME, EVEN THOUGH THE ENGINE WAS IN "LIMP HOME" MODE. I HAD MY CODE SCANNER WITH ME AND WAS ABLE TO RETRIEVE THE P2111 (THROTTLE STUCK OPEN) CODE BEFORE I RESTARTED THE CAR TO RESTORE FULL POWER. THIS ONLY WORKED ENOUGH TO GET THE CAR TURNED AROUND WHEN LIMP HOME WAS TRIGGERED AGAIN. I RESTARTED AGAIN AND WAS ABLE TO GET WITHIN A BLOCK OF MY HOUSE WHEN LIMP HOME TRIGGERED ONCE MORE. THE THIRD TIME I WAS ABLE TO GET TO MY HOUSE. I CALLED THE DEALER AND THEN ROADSIDE ASSISTANCE TO GET MY CAR TOWED TO THE LOCAL FORD DEALER AFTER VERIFYING THAT THEY HAD A THROTTLE BODY IN STOCK. THE CAR WAS TOWED THERE AND A DEFECTIVE THROTTLE BODY WAS DIAGNOSED AND REPLACED. THIS IS NOT A CASE OF IF THE FAILURE WILL HAPPEN, BUT RATHER WHEN. I WAS FULLY EXPECTING IT ANY DAY AND SURE ENOUGH, IT HAPPENED. I WAS EXTREMELY FORTUNATE AS I WAS LESS THAN A MILE FROM HOME, KNEW WHAT TO EXPECT AND HOW TO DEAL WITH IT, AND MY CAR WAS STILL IN WARRANTY, BUT ONLY BY 1,806 MILES! ANY OTHER SITUATION WOULD HAVE RESULTED IN ME BEING IN A VERY DANGEROUS PREDICAMENT WITH A CAR THAT WAS BASICALLY DEAD IN THE WATER. I WAS ALMOST TO THE POINT OF PURCHASING A NEW THROTTLE BODY ON MY OWN IN THE INTEREST OF BEING PROACTIVE RATHER THAN BEING STRANDED. *TR

Mileage: 34,194

I LEFT FROM MY HOME IN THE EARLY AFTERNOON. THE CAR HAD NOT BEEN USED SINCE THE PREVIOUS EVENING. ABOUT 2 MILES FROM MY HOUSE I GOT ONTO A STATE ROUTE AND STARTED TO GO UP A SLIGHT HILL. I HAD ACCELERATED UP TO APPROXIMATELY 45 MPH AND THE ENGINE STARTED RUNNING REALLY ROUGH, THEN STALLED. THE CHECK ENGINE LIGHT LIT UP. IT SEEMED TO GO DOWN TO IDLE WITH NO RESPONSE FROM ENGINE WHILE PUSHING THE PEDAL. I GLIDED TO THE SIDE OF THE ROAD AND CRESTED THE HILL, THEN LET THE ENGINE SPUTTER AT AROUND IDLE AS I WAS ABLE TO PUT IT IN NEUTRAL AND LET GRAVITY TAKE ME TO THE BOTTOM OF THE HILL WHERE I COULD GLIDE AROUND THE CORNER INTO A SAFE PARKING LOT. I SHUT THE CAR DOWN, WAITED A MINUTE AND IT STARTED BACK UP AS THOUGH NOTHING HAD HAPPENED. THE CHECK ENGINE LIGHT WAS CLEAR. I HAVE NOT TRIED TO CHECK TO SEE IF IT STORED ANY CODES YET. I HAD EXPERIENCED 2 PREVIOUS EVENTS IN THE PREVIOUS 2 WEEKS WITH THIS CAR. THE CAR HAS BEEN SERVICED REGULARLY. *TR

Mileage: 60,300

DROVE A MILE FROM OUR HOME TO PICK UP PIZZA. WENT INTO THE SHOP FOR ABOUT 5 MINUTES, CAME OUT AND STARTED THE CAR. BACKED OUT OF THE SPACE AND PULLED ACROSS A DIVIDED ROAD TO HEAD HOME AND THE CAR SPUTTERED AND LOST POWER SO THAT I HAD TO PULL OVER TO THE SIDE. THE CHECK ENGINE LIGHT WAS LIT. I SHUT DOWN THE CAR AND IT STARTED RIGHT UP AND THE CHECK ENGINE LIGHT WAS CLEAR. IT REPEATED THIS ISSUE AGAIN ABOUT 1 WEEK LATER ON THE HIGHWAY FOR MY WIFE THOUGH RECOVERED. THEN AGAIN FOR ME WHILE ACCELERATING UP A STATE ROUTE BUT DID NOT RECOVER. *TR

Mileage: 60,100

MY WIFE WAS DRIVING DOWN THE HIGHWAY AND THE ENGINE BUCKED AND SEEMED TO STALL, THEN RECOVERED. THE PREVIOUS WEEK IT HAD STALLED COMPLETELY. SHORTLY AFTER IT STALLED WHILE I WAS DRIVING IT AGAIN AND DID NOT RECOVER. *TR

Mileage: 60,250

CAR EXPERIENCED A SUDDEN LOSS OF POWER DURING ACCELERATION FROM A STOP SIGN. LOST 99% OF POWER AND MISSED HEAVILY. NEARLY REAR-ENDED. PULLED OVER, TURNED CAR OFF, WAITED A FEW MINUTES AND RESTARTED THE CAR. RAN FINE. DROVE APPROXIMATELY 15 MILES AND 25 MINUTES BEFORE PARKING THE CAR; PROBLEM DID NOT RECUR. DROVE APPROXIMATELY 20 MILES AND 30 MINUTES TO DEALERSHIP; PROBLEM DID NOT RECUR. DEALERSHIP DIAGNOSED THE PROBLEM THE SAME AS MANY OF THE COMPLAINTS ON THIS WEBSITE - THE THROTTLE BODY ACTUATOR IS STICKING. $400 REPAIR. INFORMATION ONLINE INDICATES THAT THIS IS A NEW THROTTLE DESIGN BY FORD, SO IN ESSENCE, FORD IS EXPERIMENTING ON MY DIME. NOT ACCEPTABLE. *JB

Mileage: 55,000

THE ENGINE SHOOK VIOLENTLY. THE WRENCH LIGHT AND CHECK ENGINE LIGHT SUDDENLY APPEARED. THE SPEED OF THE CAR WENT FROM 45 MPH TO 0 IN AN INSTANT. THEN THE ENTIRE CAR POWERED OFF. I MANAGED TO PULL OVER TO THE SHOULDER AS THIS HAPPENED AND NOT BEING ABLE TO ACCELERATE AT ALL. I TURNED THE CAR ON AGAIN WITH KEYS IN IGNITION. STARTED TO DRIVE AND THE SAME SERIES OF EVENTS HAPPENED AGAIN AND MY CAR COMPLETELY POWERED OFF. I GOT MY CAR TOWED TO FORD MALCOLM CUNNINGHAM ON 8/26/13. THEY CONFIRMED IT WAS THE THROTTLE BODY THAT CAUSED THE ISSUES. I PURCHASED EXTENDED WARRANTY ON MY CAR WHICH ONLY COVERED THE ACTUAL PART AND NOT THE LABOR TO REPLACE THE THROTTLE BODY. THE DEALERSHIP SERVICE REP, [XXX], SAID THAT THEY RECOMMENDED I ALSO FLUSH THE ENGINE BECAUSE THEY HAVE SEEN THIS IS RELATED TO THE THROTTLE BODY ISSUE. SHE ALSO SAID THE THROTTLE BODY ISSUE IS A COMMON PROBLEM WITH FUSIONS AND ESCAPES, AS SHE HAD ANOTHER PERSON IN THERE FOR THE SAME ISSUE ON AN ESCAPE. FORD NEEDS TO REALIZE THIS IS EXTREMELY UNSAFE AND ISSUE A RECALL ASAP! I CANNOT BELIEVE MY CAR IS PRACTICALLY NEW AND I'M OUT OF POCKET $400, WHILE FORD DOESN'T TAKE ANY RESPONSIBILITY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

Mileage: 36,500

THREE ISSUES HAVE ARISEN IN THE LAST MONTH: 1) WHILE SLOWING DOWN TO TURN A CORNER, TO STOP OR AFTER A STOP AND STARTING TO ACCELERATE, MY CAR STALLS 2) AT A STOP LIGHT, MY CAR JUMPS - WILL INTERMITTENTLY STALL WHEN GOING TO ACCELERATE 3) AFTER PUTTING GAS IN THE TANK IT IS VERY DIFFICULT TO TURN OVER. *TR

Mileage: 78,052

DASH BOARD REPORTS POWER STEERING ASSIST FAULT. DIFFICULTY STEERING. DRIVE TO PARKING PLACE. TURN CAR OFF. TWO HOURS LATER RETURN TO CAR. TURN ON CAR AND THE POWER STEERING IS OK. SECOND FAULT AT 46045 MILES. CAR WAS PARKED. TURN CAR ON. POWER STEERING ASSIST FAULT. TURN CAR OFF. TURN CAR ON. POWER STEERING OK. *TR

Mileage: 45,500

I WAS DRIVING WITH MY DAUGHTERS IN THE CAR IN THE MIDDLE LANE OF A 3 LANE HIGHWAY. I WAS TRAVELING THE SPEED LIMIT, AT OR AROUND 55 MPH, WHEN ALL OF A SUDDEN THE CAR WENT LIMP. THERE WAS NO ACCELERATION AND THE CAR IMMEDIATELY BEGAN TO COAST. A WRENCH LIGHT AND THE ENGINE LIGHT WENT ON. WITH NO ABILITY TO SPEED UP, I HAD TO NAVIGATE THROUGH TWO LANES OF HIGH SPEED TRAFFIC WITH A PARALYZED CAR TO GET ME AND MY CHILDREN TO SAFETY. LUCKILY, I WAS ABLE TO DO SO. THE DEALERSHIP INFORMED ME THAT THIS DOESN'T HAPPEN VERY OFTEN, AND THAT UNFORTUNATELY, THIS REPAIR WOULD NOT BE COVERED UNDER THE POWER TRAIN. THEY ORDERED AND REPLACED THE THROTTLE BODY. UPON INVESTIGATING THIS ISSUE ONLINE, I WAS SHOCKED TO DISCOVER THAT THIS PROBLEM IS SO PREVALENT. THE FACT THAT FORD IS COVERING THIS UP AND PUSHING THE COSTS ON TO ITS CUSTOMERS IS FRUSTRATING (MORE THAN $1300 IN MY CASE), BUT THE FACT THAT THEY ARE WILLING TO RISK THE LIVES OF THESE VERY SAME CUSTOMERS IS DOWNRIGHT DISTURBING. THERE SHOULD BE AN IMMEDIATE RECALL ON ALL THE CARS AFFECTED BY THIS THROTTLE BODY ISSUE, AS WELL AS A FULL REIMBURSEMENT FOR ALL THOSE WHO HAVE HAD TO SUFFER THROUGH THIS ALREADY. *TR

Mileage: 56,752

WENT TO START CAR AND IT WOULD NOT START. FORD ROADSIDE TOWED IT THE NEXT DAY. AFTER TRYING VARIOUS THINGS FOR 3 WEEKS FORD ENGINEERING CALLED TO TELL ME IT WAS DUE TO A LIGHTNING STRIKE. INSURANCE BELIEVES IT IS A WARRANTY CLAIM AS THE CAR IS STILL UNDER WARRANTY; FORD WILL NOT HONOR THIS AS A WARRANTY CLAIM. NO ONE AT FORD HAS BEEN ABLE TO GIVE ME A COST FOR REPAIRS ALREADY ATTEMPTED OR FOR FURTHER REPAIRS TO MAKE THE CAR WORK NORMALLY AGAIN. I FEEL THERE IS A DEEPER ELECTRICAL ISSUE WITH THE CAR, BUT FORD IS CLAIMING THERE IS NOTHING IN THE CAR THAT COULD SUPPLY THIS KIND OF ELECTRICITY TO FRY SEVERAL MODULES, FUSES, AND LIGHT BULBS. WORRIED ABOUT A BIGGER ISSUE WHICH IS NOT BEING DIAGNOSED AND FIXED PROPERLY. COULD BE A SAFETY HAZARD. *TR

Mileage: 24,000

WHILE DRIVING AT 60 MPH ON THE HIGHWAY, VEHICLE APPEARED TO "STALL" CAUSING A SUDDEN LOSS OF ACCELERATION. THIS OCCURRED ON THREE SEPARATE OCCASIONS IN THE PAST WEEK. VEHICLE MALFUNCTION CAUSED VEHICLE TO ENTER "LIMP" MODE. *TR

Mileage: 36,700

DRIVING 45MPH ON STATE ROAD 45 IN SOUTHERN INDIANA, WHICH IS VERY CURVY. LET OFF GAS, THEN WHEN I WENT TO ACCELERATE, PEDAL WENT COMPLETELY TO THE FLOOR. CAR THEN STARTED SPUTTERING. NO ACCELERATION AT ALL. FINALLY GOT CAR OFF OF STATE HIGHWAY. CAR NEVER COMPLETELY DIED, JUST ABSOLUTELY NO ACCELERATION, THROTTLE BODY SENSOR BAD! THIS IS A SAFETY ISSUE! HAD I BEEN GOING FASTER AND VEHICLES BEHIND ME, THERE WOULD HAVE BEEN A MAJOR ACCIDENT. COST $580 TO REPAIR ON A 2011 CAR! ACCORDING TO THE FORD TECHNICIAN THAT REPAIRED MY CAR, THEY HAVE REPLACED SEVERAL IN THE LAST 6 MONTHS! VERY DISAPPOINTING FOR FORD NOT TO RECALL SURE A IMPORTANT REPAIR! *TR

Mileage: 55,131

MY WIFE WAS DRIVING HER CAR WHEN THE CHECK ENGINE LIGHT CAME ON, IT REDUCED ENGINE POWER AND WOULD NOT ACCELERATE. SHE TURNED IT OFF, THEN RESTARTED IT. SHE DROVE HOME WITH NO FURTHER INCIDENT. THIS WAS JUNE 1ST. IT HAPPENED A FEW MORE TIME THROUGH JUNE AND JULY AND WE HAD A COMPETENT MECHANIC CLEAN THE THROTTLE BODY AFTER THE CODE HE SCANNED SAID THROTTLE BODY WAS STUCK CLOSED/STUCK OPEN. THIS DID NOT FIX THE PROBLEM. ON THE WAY HOME FROM DINNER WITH MY FAMILY ON AUGUST 3, WE MADE A TURN ACROSS TWO LANES OF TRAFFIC. IN THE MIDDLE OF THE TURN, THE WRENCH LIGHT CAME ON, CAR LOST POWER, AND WE WERE ESSENTIALLY DEAD IN THE WATER WHILE MAKING A TURN. THE VEHICLE COMING DOWN THE LANE HAPPENED TO SEE US IN THE MIDDLE OF THE ROAD. HAD THEY NOT BRAKED, WE WOULD HAVE BEEN T-BONED. IT HAPPENED THE NEXT DAY ON THE INTERSTATE. NOT VERY CONFIDENCE INSPIRING TO TRAVEL AT 70MPH, THEN HAVE YOUR CAR NOT GO OVER 900 RPM. LOOK FOR A SHOULDER VERY QUICKLY. IN ALL INSTANCES, CAR GOES TO REDUCED ENGINE POWER (WHICH LIMITS IT TO 900 RPM). AT A STOP LIGHT, THE IDLE IS VERY ERRATIC GOING FROM 1000 RPM DOWN TO ABOUT 400. *TR

Mileage: 41,800

WHILE DRIVING IN HEAVY TRAFFIC ON INTERSTATE, ENGINE BEGAN TO LOOSE POWER AND AS MY SPEED DECREASED I PULLED OFF THE HIGHWAY AND THOUGH ENGINE REMAINED RUNNING AND INTERMITTENTLY COUGHED OR VIBRATED, I TURNED THE IGNITION OFF AND CALLED FOR A TOW TRUCK. DURING SLOW DOWN, DASH WARNING LIGHTS DISPLAYED A WRENCH AND ALSO POSSIBLY A WIGGLY LINE SYMBOLS. WHILE DRIVING BEFORE TROUBLE STARTED I ATTEMPTED TO CUT BACK MY SPEED BY PRESSING THE MINUS SET BUTTON ON THE CRUISE CONTROL SEVERAL TIMES, BUT NOT CONSECUTIVELY. INCIDENT OCCURRED SHORTLY AFTER I DECREASED MY SPEED WITH ABOVE ACTION. THIS INCIDENT LEFT US IN A DANGEROUS SPOT IN THE BREAKDOWN LANE WHILE HIGH SPEED HEAVY TRAFFIC PASSED CLOSE BY UNABATED. FOLLOWING COMPUTER ANALYSIS FORD DEALER REPLACED ELECTRONIC THROTTLE BODY. WHEN I GOOGLED ABOVE FORD PART I DISCOVERED A GROWING HISTORY OF ABOVE TROUBLE BUT SO FAR, NO RECALL ISSUED TO DATE. REAL DANGER WHILE OPERATING A VEHICLE IS INDICATED. *TR

Mileage: 38,642

WHILE DRIVING MY CAR TO WORK, I WAS ON THE HIGHWAY AND THE CAR SUDDENLY LOST POWER AND THE ENGINE STALLED. I HAD TO PULL OVER TWICE ON THE WAY TO WORK WHILE NAVIGATING INTERSTATE TRAFFIC. MY CAR ENGINE STALLED AND I HAD TO PULL OVER - I TOOK IT TO THE DEALER ON FRIDAY AND THEY TOOK CARE OF IT REALLY FAST, BUT IT APPEARS THAT THEY HAVE KNOWLEDGE OF IT HAPPENING ALOT. THIS IS A MAJOR SAFETY ISSUE FOR ME, AS I HAVE TO TRAVEL INTERSTATE EVERY DAY.. IT IS UNNERVING THAT WHEN DRIVING 55-65 MPH, THE WRENCH LIGHT COMES ON AND THE ACCELERATOR PEDAL BECOMES UNRESPONSIVE. THE ENGINE WAS TURNED OFF AND UPON RESTARTING, RESUMED NORMALLY. JUST A VERY BASIC GOOGLE SEARCH, IT SEEMS THAT THIS IS A VERY COMMON PROBLEM AND NEED A RECALL NOTICE. *TR

Mileage: 17,625

VEHICLE LOST ENGINE POWER AND WOULD NOT ACCELERATE. VEHICLE WAS MANEUVERED TO THE ROAD SIDE WHERE IT WAS SHUT OFF FOR 1 MINUTE. UPON RESTART, VEHICLE DROVE AND ACCELERATED NORMALLY. AFTER DRIVING FOR 5 MINUTES, VEHICLE AGAIN LOST ENGINE POWER AND WOULD NOT ACCELERATE. VEHICLE WAS AGAIN MANEUVERED TO THE ROAD SIDE AND SHUT OFF FOR 1 MINUTE. UPON RESTART, VEHICLE DROVE AND ACCELERATED NORMALLY. CONDITION WAS EXPERIENCED THREE TIMES THE SAME DAY. ECU STORED CODE FOR THROTTLE CONTROL SYSTEM. *TR

Mileage: 13,750

AUTO SUDDENLY SLOWED DOWN, BECAME JERKY, AND HAD MINIMUM RESPONSE GSA PEDAL PRESSURE. I PULLED OVER, SHUT OFF THE ENGINE, RESTARTED THE ENGINE AND WAS ABLE TO CONTINUES DRIVING. FORD DEALER PERFORMED IDS TEST, NO CODES, RAN PINPOINT TESTS BY SYMPTOM. TEST ETB. FAILED. REPLACED ELECTRONIC THROTTLE BODY,CLEARED KAM AND ROAD TEST. TOTAL COST $433. *TR

Mileage: 69,000

WHILE DRIVING ON A HIGHWAY WITH A FAIR AMOUNT OF TRAFFIC THE GAS PEDAL QUIT WORKING THEN MY CAR STALLED OUT. THIS ALL HAPPENED VERY QUICKLY. I WAS ABLE TO PULL TO SIDE. I RESTARTED THE CAR MERGED BACK ON HIGHWAY AND IN 1/4 TO 1/2 MILE IT DID IT AGAIN. ONCE AGAIN I WAS ABLE TO RESTART IT AND MERGED BACK INTO TRAFFIC HOPING TO MAKE IT TO THE NEXT EXIT, BUT IT DID IT AGAIN IN LESS THEN 1/4 MILE. I RESTARTED IT AND STAYED ON THE SIDE OF HIGHWAY. IT WENT INTO LIMP MODE AND I WAS ABLE TO GET TO A GAS STATION AT NEXT EXIT. THE CAR HAD STALLED OUT A MONTH OR SO PRIOR BUT RESTARTED AND NO OTHER ISSUES UNTIL THIS REPORTED EVENT. ALSO AS WE RESEARCHED ON LINE MY CAR HAD THE SURGES OF POWER OR LACK THEREOF AS MENTIONED ON LINE. NOTE: I AM A PERSON WITHOUT MUCH MECHANICAL KNOWLEDGE AND THIS WAS AN EXTREMELY UNSETTLING EVENT. I DO A LOT OF HIGHWAY DRIVING IN MY WORK INCLUDING RUSH HOUR. I AM WELL AWARE THAT MY LIFE COULD HAVE EASILY ENDED THAT DAY OR BEEN SEVERELY CHANGED. PLEASE ADDRESS THIS BEFORE SOMEONE'S LIFE IS ENDED OR SEVERELY CHANGED!! *TR

Mileage: 59,000

I WANTED TO CONTACT YOU ABOUT A SERIOUS SAFETY ISSUE IN MY 2011 FORD FUSION. I TOOK IT IN FOR SERVICE IN JANUARY 2013 AND WAS TOLD THAT THE THROTTLE BODY NEEDED REPLACED AFTER MY CAR STALLED A FEW TIMES. I WAS TOLD THEN THE THROTTLE BODY WAS BACKORDERED. I TRIED AGAIN IN JUNE AND WAS TOLD THAT THIS IS A COMMON PROBLEM AND THEY ARE STILL BACKORDERED. AFTER THAT, I WAS TOLD THAT I COULD SIMPLY TAKE THE KEY OUT AND PUT IT BACK IN AFTER IT STALLED AND IT WOULD BE FINE. AND THEY WERE BACKORDERED FROM FORD. ON JULY 11TH, THE CAR STALLED AT THE CORNER OF I-70 AND I-270 IN COLUMBUS WHILE TRAVELING AT 65MPH. I PULLED OFF TO THE SIDE OF THE ROAD AND RESET THE CAR. WHILE TRYING TO GET OFF THE ROAD, I WENT OFF THE ROAD TO AVOID ANY OTHER CARS AS THEIR WAS CONSTRUCTION AND NO SHOULDER. AFTER RESTARTING IT, I GOT BACK ONTO THE ROAD AND THE CAR STALLED AND I WASN'T ABLE TO MAKE IT BACK OFF THE ROAD AND NEARLY WAS HIT BY A SEMI FROM BEHIND. THE CAR STALLED A MINIMUM OF TEN TIMES DURING RUSH HOUR. *TR

Mileage: 52,000

***NOTE: THIS STARTED IN MAY 2013 HAPPENED 3 TIMES. DEALERSHIP REPLACE AN INTAKE SENSOR AND THEN IT HAPPENED AGAIN AS LISTED BELOW. THIS IS PUTTING ME AND MY DAUGHTERS IN DANGER EVERYTIME THIS HAPPENS WITHOUT PRIOR WARNING. ---------------------------------------- JULY 19, 2013 @ 3:29 AM: WITHOUT WARNING THIS TIME THE "CHECK ENGINE" INDICATOR CAME ON , THE CAR MADE A WEIRD NOISE LIKE A DYING RUMBLE/PURRING NOISE AS IT BECAME SILENT AND ALL POWER LEFT. -SHE PUT THE CARE IN ?P? PARK -STARTED THE ENGINE AND IT ACTED NORMAL -------------------------------------- JULY 19, 2013 @3:28 AM: WITHOUT WARNING THE ?THROTTLE CONTROL/TRANSMISSION? INDICATOR LIT UP, THE CAR BECAME SILENT AND ALL POWER LEFT. -SHE PUT THE CARE IN ?P? PARK -STARTED THE ENGINE AND IT ACTED NORMAL ------------------------------------------- JULY 19, 2013 @ 1:20 AM : WITHOUT WARNING THE ?THROTTLE CONTROL/TRANSMISSION? INDICATOR LIT UP, THE CAR BECAME SILENT AND ALL POWER LEFT. -SHE PUT THE CARE IN ?P? PARK -STARTED THE ENGINE AND IT ACTED NORMAL ---------------------------------------------------------- JULY 18, 2013 @4:30 PM: WITHOUT WARNING THE ?THROTTLE CONTROL/TRANSMISSION? INDICATOR LIT UP, THE CAR BECAME SILENT AND ALL POWER LEFT. -SHE PUT THE CARE IN ?P? PARK ?.I WAS IN THE BACK SEAT & INSTRUCTED HER WHAT TO DO. -STARTED THE ENGINE AND IT ACTED NORMAL ***** FORD DEALERSHIP SERVICE TECHNICIANS COULD NOT FIND OR DUPLICATE THE PROBLEM. THE ISSUE ESCALATED TO THE FORD ENGINEERS. THEY DETERMINED THAT IT WAS SOMETHING LIKE THE MASSIVE INTAKE AIR FLOW SENSOR AND INSTALLED A NEW ONE ( FORD PART: FP 3L3Z-128579-BA SENSOR ASSY) JUNE 13 JUST PRIOR TO MY BUSINESS TRIP ON JUNE 17,2013. *TR

Mileage: 33,000

ENGINE CUT-OFF GOING AT 5 MPH. ACCORDING TO AAMCO CODE P2112 APPEARED ON THEIR READER. THIS CODE HAS TO DO WITH THE THROTTLE ACTUATOR CONTROL SYSTEM. TOOK CAR TO LOCAL FORD DEALER AND WAS TOLD THAT THE PART, THROTTLE BODY AND MOTOR ASY., ARE ON NATIONAL BACK ORDER. IT TOOK AT TWO DAYS OR TWO WEEKS TO RECEIVE THE PART. THIS IS NOT ACCEPTABLE; FORD AND THEIR DEALERS SHOULD HAVE THIS PART AVAILABLE IMMEDIATELY. DOES SOMEONE NEED TO HAVE A SERIOUS OR DEADLY ACCIDENT BEFORE ACTION IS TAKEN? *TR

Mileage: 21,300

CAR IS HAVING A HARD TIME CRANKING AND IDLING HIGH, POWER STEERING HARD TO MOVE BECAUSE OF A POWER STEERING ASSIST FAULT AND THE CAR IS HARD TO STEER IT HAS DONE IT 3 TIMES. ONCE WHILE DRIVING AND 2 OTHER TIMES WHILE PARKED BUT CAR WAS HARD TO CRANK. *TR

ORIGINAL INCIDENT OCCURRED IN JUNE 2011. VEHICLE LOST ALL ACCELERATION UNEXPECTEDLY AND WAS TOWED TO DEALERSHIP. VEHICLE WAS ONLY 6 MONTHS OLD AND THROTTLE BODY WAS REPLACED UNDER WARRANTY. HAS SUBSEQUENTLY HAPPENED TWO MORE TIMES. THE SECOND TIME THE DEALERSHIP SERVICE COULD NOT RECREATE THE PROBLEM. THE THIRD TIME WAS JULY 2013. AGAIN VEHICLE WAS TOWED TO DEALERSHIP. ADVISED THAT IT WAS AGAIN A FAILURE OF THE THROTTLE BOTTLE. PART ALONE WILL BE $400 TO REPLACE AND WILL NOT BE AVAILABLE FOR 10 DAYS TO 3 WEEKS. THIS WILL BE THE THIRD THROTTLE BOTTLE ON A CAR THAT IS LESS THAN 3 YEARS OLD. THE FAILURE POSES A SEVERE SAFETY RISK IF OCCURS ON HIGH SPEED HIGHWAY WHILE IN MIDDLE OR LEFT LANES. *TR

Mileage: 8,000

I WAS DRIVING MY 2011 FORD FUSION S WITH A V4 ENGINE ON 07/03/2013 AT APPROXIMATELY 19:15 IN THE EVENING. I WAS TRAVELING ON A SLIGHT INCLINE ON A TWO-LANE ROAD AT A SPEED OF APPROXIMATELY 50 M.P.H. WHEN ALL OF THE SUDDEN THE CAR STALLED AND WOULD NOT LONGER ACCELERATE. I PULLED OFF THE ROAD AND THE CAR BEGAN TO SHAKE AND THE TRANSMISSION SLIPPED WHILE SHIFTING DOWN. I TURNED OFF THE CAR AND THEN TURNED IT ON AGAIN. I DROVE TO MY DESTINATION 2 HOURS AWAY WITHOUT FURTHER INCIDENT. I DROVE THE CAR A SECOND TIME AND THE INCIDENT DID NOT RECUR. THE THIRD TIME I DROVE THE CAR AFTER THE FIRST INCIDENT, THE PROBLEM OCCURRED AGAIN, WHICH WAS ON 07/05/2013 AT APPROXIMATELY 17:00. IT OCCURRED IN THE MIDDLE OF AN INTERSTATE AND I HAD TO PULL TO THE SIDE OF THE ROAD BY CUTTING ACROSS TRAFFIC WITHOUT THE ABILITY TO ACCELERATE!!! I TOOK THE CAR TO A FORD DEALER AND THEY DIAGNOSED THE PROBLEM AS A FAULTY THROTTLE CONTROL. I HAD TO PAY FOR THE REPAIR OUT OF POCKET BECAUSE THE WARRANTY EXPIRED AT 36,000 MILES (MY CAR HAS 38000 MILES). THIS IS A SERIOUS PUBLIC SAFETY CONCERN. I HAVE READ THAT 2010 FORD FUSIONS ALSO HAVE A HISTORY OF THE SAME PROBLEM AT ABOUT 2-3 YEARS AFTER PURCHASE. I AM GRATEFUL TO HAVE AVOIDED A CRASH, BUT ONE COULD EASILY FIND THEMSELVES IN A SITUATION WHERE THEY CANNOT ACCELERATE BECAUSE OF THIS PROBLEM AND END UP SERIOUSLY INJURED OR DEAD BECAUSE OF A CRASH THAT IT COULD CAUSE. THE CAR SUDDENLY STOPS ACCELERATING AND THIS HAPPENS APPARENTLY AT RANDOM, USUALLY WITHIN 10-15 MINUTES OF TURNING THE CAR ON. *TR

Mileage: 37,900

2011 FUSION W/ 3.0 LITER 6CYL. WHILE TRAVELING AT APPROXIMATELY 50 MPH THE ENGINE SUDDENLY BOGGED DOWN. I PRESSED THE GAS PEDAL AND NOTHING HAPPENED. I WAS ABLE TO PULL OVER TO THE SIDE AND THE ENGINE WAS STILL RUNNING. A WRENCH LIGHT CAME ON. I PUT THE CAR IN PARK AND TRIED THE GAS PEDAL AGAIN WITH NO RESPONSE. I TURNED THE ENGINE OFF, WAITED A FEW SECONDS, THEN TURNED IT BACK ON. I WAS ABLE TO DRIVE HOME, THEN TO THE FORD DEALERSHIP WITH NO INCIDENT. I WAS TOLD THAT THE PROBLEM WAS THE THROTTLE BODY WHICH IS ON NATIONAL BACK ORDER. FORD WOULD NOT COVER THE REPAIR EVEN THOUGH CAR WAS JUST OVER THE WARRANTY MILEAGE LIMIT. I FOUND OUT THAT THE NHTSA STARTED AN INVESTIGATION ON THIS ISSUE IN FEBRUARY 2013 AND FORD IS AWARE OF THE MULTIPLE COMPLAINTS OF THIS SAME PROBLEM. I WAS LUCKY NO TRUCK WAS BEHIND ME SINCE MY CAR SLOWED QUICKLY AND SUDDENLY WITH NO WARNING. THE INTERNET IS FILLED WITH COMPLAINTS OF THIS SAME ISSUE. PLEASE DO SOMETHING BEFORE SOMEONE IS KILLED! *TR

Mileage: 37,000

I WAS DRIVING ON THE FREEWAY AT 65MPH DURING HEAVY AFTERNOON TRAFFIC WHEN MY CAR ALL OF A SUDDEN DIED AND I HAD TO QUICKLY VEER OFF TO THE SERVICE LANE DODGING HONKING, ANGRY DRIVERS NEARLY ALMOST GETTING HIT BY ONE. LUCKILY AN ACCIDENT WAS DIVERTED BY SMART DRIVING BY ME. AFTER COASTING TO A STOP, I TURNED THE CAR OFF AND TURNED IT BACK ON. THINKING IT WAS A MINOR HICCUP, I DROVE BACK ONTO THE ROAD. AFTER 10 MILES THE INCIDENT HAPPENED AGAIN AND NEARLY ANOTHER BRUSH WITH DEATH/ACCIDENT, I GOT OFF THE FREEWAY AND DROVE SLOWLY ALL THE WAY HOME WHICH IT DIED 2 MORE TIMES. *TR

Mileage: 39,000

ON THE MORNING OF FEBRUARY 7TH 2013, I NOTICED THE VEHICLE'S ACCELERATION AND DECELERATION WAS RIDGED AND JUMPY. PRIOR TO THIS PROBLEM, THE VEHICLE HAS SHUT OFF RANDOMLY APPROXIMATELY THREE TIMES WHILE IN DRIVE AND IN MOTION. THIS PROMPTED ME TO BRING THE VEHICLE IN FOR MAINTENANCE AT A FORD DEALER AUTO CENTER. THEY DETERMINED THE POWER TAKEOFF UNIT AND DRIVE SHAFT WERE FAULTY, REPLACED BOTH PARTS AND RETURNED THE VEHICLE TO ME ON FEBRUARY 15TH 2013. ON MARCH 18TH 2013, THE VEHICLE SHUT OFF AGAIN WHILE DRIVING AT HIGHWAY SPEEDS ON A BUSY ROAD, FORCING ME TO NAVIGATE CAUTIOUSLY TO A SHOULDER. THE ENGINE LIGHT AND WRENCH LIGHT WERE ILLUMINATED THIS TIME. I SHUT THE VEHICLE OFF, WAITED 5 MINUTES, AND RESTARTED. THE ENGINE LIGHT REMAINED ON AND THE VEHICLE WAS DRIVABLE. I QUICKLY RETURNED THE VEHICLE TO THE PREVIOUS FORD AUTO CENTER, IN WHICH THEY DISCOVERED THE THROTTLE BODY WAS FAULTY. THEY REPLACED THE THROTTLE BODY AND RETURNED THE CAR TO ME ON MARCH 21ST 2013. ON MARCH 22ND 2013, THE ENGINE COVER FELL OFF WHILE THE CAR WAS IN MOTION, I IMMEDIATELY RETURNED VEHICLE TO THE PREVIOUS FORD AUTO CENTER, THEY REPLACED WITH NEW ENGINE COVER. AS OF TODAY, THE VEHICLE IS AGAIN SHOWING HESITATION AT ACCELERATION AND DECELERATION, RPM DASH METER NEEDLE BOUNCES PLUS MINUS 500RPMS DURING ACCELERATION AND DECELERATION. BREAKING IS NOT SMOOTH OR INSTANT, THE VEHICLE TENDS TO JUMP DURING BREAKING. AT COASTING SPEEDS, THE VEHICLE ALSO JUMPS. THESE ARE SIMILAR PROBLEMS THAT OCCURRED PRIOR TO THE VEHICLE SPONTANEOUSLY SHUTTING OFF. THIS PROBLEM IS ALARMING AND AN EXTREME SAFETY HAZARD TO YOURSELF AND OTHERS AROUND YOU, NOTABLY AT HIGH HIGHWAY SPEEDS. FORD HAS BEEN PRESENTED WITH THE ISSUE AND HAS CLAIMED THAT THE ISSUES ARE ALL UNRELATED, EVEN THOUGH THE VEHICLE SHUTS OFF EACH TIME. I AM CONCERNED FOR MY SAFETY AND THE SAFETY OF OTHERS DRIVING THIS MODEL, 2011 FORD FUSION SEL AWD.

Mileage: 38,281

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE AIR CONDITIONING SYSTEM FAILED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. *TR

Mileage: 50,000

WAS DRIVING 2011 FORD FUSION THEN SHUT DOWN TO IDLE, NO POWER, ALMOST GOT RE ENDED, PULLED OVER AND PUT IN PARK TURNED OFF AND RESTARTED PROBLEM WAS GONE BUT RECURRED LESS THAN 2 TENTHS OF MILE. REPEATED STEPS WITH CAUTION FLOORED GAS PEDDLE BUT STILL HAPPEN. AUTOZONE CHECKED IT AND CLEARED THE COMPUTER. HAPPEN RIGHT AWAY AFTER LEAVING. CALLED FORD COULD NOT REPAIR BECAUSE NO CODES. PROBLEM CAME BACK 5 DAYS LATER. AT INTERSECTION LIGHT CHANGE GREEN CAR DID SAME THING, STUCK IN MIDDLE ON INTERSECTION. PUT IN PARK AND RESTART WAS HARD TO START. RED LIGHT NOW JUST GOT OUT OF TRAFFIC WAY. CAR IS AT FORD NOW. THIS IS A VERY BAD SAFETY FEATURE AND WILL CAUSE AN ACCIDENT SOONER OR LATER. FORD SAID THEY HAVE HAD A FEW PROBLEMS BUT NO RECALL. *TR

Mileage: 18,200

AS WE WERE DRIVING IN THE FREEWAY AT ABOUT 70 MPH ON APRIL 7TH 2013, THE CAR LOST POWER AND STALLED OUT IN THE MIDDLE LANE OF THE FREEWAY. AT THAT EXACT MOMENT THE CAR FELT LIKE IT JERKED HARD AND THEN STALLED AND THE LIGHT WITH THE WRENCH SYMBOL CAME ON IN THE DASHBOARD. THEN IT IMMEDIATELY DISAPPEARED AFTER BEING ON WHEN THE CAR JERKED AND STALLED. MANAGE TO PUT HAZZARD LIGHTS ON AND MAKE IT SAFELY TO THE FREEWAY SHOULDER WHERE THE CAR AFTER A COUPLE OF MINUTES TRYING AND WAITING STARTED AGAIN AS IF NOTHING HAPPENED. AFTER TURNING THE CAR OFF THE CAR WOULD NOT TURN BACK ON AND SOUNDED LIKE THE ENGINE WAS STRUGGLING TO KEEP UP AFTER THE CAR WAS JUMP STARTED. THE CAR THEN WAS MAKING SOUNDS IN THE ENGINE BAY AND MANAGED TO MAKE IT TO A GAS STATION COUPLE FEET AWAY AND THE CAR DIED AGAIN AFTER TURNING IT OFF TO REFUEL ONCE AGAIN HAD TO GET THE CAR JUMP STARTED. CAR ONCE AGAIN STARTED TO FEEL AND SOUND AS IF IT WAS STRUGGLING TO STAY STABLE. HAD THE CAR TOWED THE NEXT MORNING TO LOCAL FORD DEALERSHIP WHERE THEY REPLACED THE BATTERY AND INSTALL A NEW THROTTLE BOX. COMPUTER CODE AT DEALERSHIP DETERMINED CAUSE OF PROBLEM WAS DUE TO FAULTY THROTTLE BOX. *TR

Mileage: 34,700

CAR BUCKED THEN COMPLETELY DIED (IN THE MIDDLE OF THE STREET)! LIGHTS THAT CAME ON: STOP SAFELY NOW, WRENCH, ENGINE, TRIANGLE WITH EXCLAMATION POINT. TOOK A FEW TIMES TO START BACK UP. TOOK IT TO THE DEALER AND THEY SAID THEY DID NOT HAVE A CODE BUT DID NOT FIND ANYTHING WRONG. A FEW DAYS LATER, IT HAPPENED AGAIN. THIS TIME IN THE MIDDLE OF THE INTERSECTION! ( SAME CODES) BROUGHT IT TO DEALER AGAIN, THIS TIME APPARENTLY THEY FOUND THE CODE. THE DEALER SAID GAS WAS GOING IN THE WRONG PLACE AND REPLACED A VALVE. IT HAS SINCE HAPPENED MORE THAN FIVE TIMES, ALL HAPPENING AT LESS THAN 5 MPH WHEN STARTING AFTER A STOP. CURRENTLY WITH ANOTHER FORD DEALERSHIP (GIVEN THE PREVIOUS ONE CRACKED THE WINDSHIELD BUT CLAIMED IT WAS ALREADY THERE, NOT TO MENTION THE POOR SERVICE TO THE CAR). THIS LATEST INCIDENT WE HAD THE CAR TOWED. THIS WAS AT THE RECOMMENDATION OF THE FORD REGIONAL REPRESENTATIVE WHO HAS BEEN EXTREMELY HELPFUL. (BY THE WAY, THIS FUSION IS A HYBRID.) CURRENTLY WAITING FOR DIAGNOSIS. *TR

Mileage: 21,500

AT SOMETIME, AFTER CAR WAS SHUT OFF, THE DRIVER, PASSENGER WINDOWS AND SUN ROOF OPENED. THIS HAS HAPPENED 6 TIMES. *TR

Mileage: 8,000

THIS HAPPENED SOMETIME BACK, HOWEVER IT COULD BE RELATED TO YOUR CURRENT INVESTIGATIONS. WHEN I HAD APPROX 1900 MILES ON THE CAR AND WHILE I WAS GOING AROUND 70 MPH, THE CAR WENT INTO LIMP MODE AND I LOST ALL THROTTLE CONTROL. AFTER NEARLY GETTING HIT FROM BEHIND FROM A TRUCK (CAUSE I LOST SPEED), I MANAGED TO PULL OVER TO SAFETY AND SAW I HAD NO THROTTLE RESPONSE. I TURNED OFF THE CAR, AND THEN TURNED IT BACK ON TO FIND IT OUT IT WOULDN'T START. SO I TURNED IT OFF ONCE AGAIN, WAITED 20 OR SO SECONDS, AND TURNED THE CAR BACK ON AND PROCEEDED TO WORK. LATER ON THAT NIGHT, I PULLED THE CODES OFF THE SYSTEM AND KEPT THEM AS PICTURES (P2104 AND P2112) JUST IN CASE THE CODES CLEARED (COLD CYCLE). SURE ENOUGH I GO TO THE DEALER THE NEXT DAY, NO CODES FOUND AND THERE IS NOTHING THEY (FORD) CAN DO. I SHOWED THEM THE PICTURES, HOWEVER I WAS STILL TURNED AWAY. LATER ON AT AROUND 7500 MILES, THIS HAPPENED AGAIN AND THIS TIME I WAS CLOSE ENOUGH TO THE DEALER TO RUN THE CODES. THEY PERFORMED TSB 11-4-23 ON THE ENGINE THROTTLE BODY AND ECU, AND INSTALLED A NEW WIRING HARNESS. LITTLE DID I KNOW AT THE TIME, BUT THIS STATES THAT UNDER RARE CONDITIONS THE ENGINE WILL EMIT THOSE CODES WHILE THE WIPERS ARE ON. *TR

Mileage: 7,581

I HAVE NOW TWICE EXPERIENCED THE SAME PROBLEM DESCRIBED IN THE NEWS ARTICLES FROM THIS DATE REGARDING ENGINE STALL. THE FIRST OCCASION, THE VEHICLE WAS DRIVING ON A SURFACE STREET AT APPROXIMATELY 40 MPH WHEN IT SUDDENLY STALLED. THE SECOND OCCASION WAS WHILE I WAS TRYING TO ENTER A FREEWAY AT BETWEEN 50-55 MPH. AFTER THE ENGINE WAS TURNED OFF FOR A MINUTE, THE VEHICLE STARTED WORKING AGAIN PROPERLY. *TR

Mileage: 30,000

2011 FORD FUSION -WHILE DRIVING ON THE INTERSTATE AT 70 MPH, VEHICLE SUDDENLY LOST ACCELERATION, TACHOMETER STARTED GOING UP AND DOWN, TRACTION LIGHT CAME ON,FUEL GAGE GOING UP AND DOWN, A LOCK LIGHT WAS ILLUMINATED, BELLS WERE GOING OFF AND CAR BEGAN TO DE-ACCELERATE. WHEN I PULLED THE CAR TO THE SHOULDER TURNED THE CAR OFF AND BACK ON THE PROBLEM CONTINUED. I IMMEDIATELY DROVE TO THE FORD DEALER WHICH WAS CLOSE BY AT THE TIME AND HAD THE MANAGER VIEW WHAT WAS HAPPENING. HE PULLED THE CAR INTO THE SHOP, SHUT OFF THE ENGINE AND IT NEVER RESTARTED. THIS COULD HAVE CAUSED A SERIOUS ACCIDENT IF I WAS NOT ABLE TO REACT AS QUICKLY AS I DID. THE CAR HAS ONLY 37000 MILES. THIS PROBLEM HAS BEEN INTERMITTENTLY OCCURRING IN THIS VEHICLE FOR A YEAR NOW. THE CAR IS NOT SAFE! WHEN IS FORD GOING TO RECALL THIS CAR!!! *TR

Mileage: 29,000

I BOUGHT THIS 2011 FORD FUSION AT 40,000 MILES AND SINCE IT HAS BEEN AT 45,000 MILES I BEEN HAVING STALLING AND IDLE PROBLEMS . I THOUGHT I WAS GOING CRAZY UNTIL I SEEN AN ARTICLE IN THE NEWS TODAY . MY CAR HAS STALLED ON THE HWY TO WHERE ON NUMEROUS OCCASIONS I HAVE ALMOST BEEN HIT. I HAVE HAD TO PULL OVER AND RESTART IT. I ALSO SEE THE WRENCH WHEN IT HAPPENS. I ALSO HAVE BEEN SITTING STILL AT LIGHTS TO WHERE MY CAR WOULD IDLE UP REAL FAST. MY CAR ALSO POPS AND GETS STUCK WHEN I CHANGE GEARS. I HATE THIS CAR. I JUST PRAY SOMETHING GETS DONE BEFORE SOMEONE REALLY GETS HURT INCLUDING MYSELF .... *TR

Mileage: 45,000

I BOUGHT MY CAR ON DECEMBER, 2011. 1ST PROBLEM WAS THE DASHBOARD TURNING OFF FOR NO REASON. THE 2ND PROBLEM IS LIFE THREATENING. I AM DRIVING DOWN THE ROAD AND OUT OF NO WHERE THE DASH BOARD LIGHTS UP, THE READERS GO CRAZY, AND MY CAR WILL DECELERATE TO 25MPH AND WILL NOT GO OVER THAT SPEED. EVERY TIME I HAVE HAD TO PULL OVER AND WHEN I DO THE CAR SHAKES. I TURNED MY CAR OFF AND WHEN I TURN IT BACK ON ITS LIKE IT NEVER HAPPENED. NO LIGHTS STAY ON AND THE CAR DRIVES LIKE A CHAMP. IT DOES IT AT RANDOM TIMES, AND RANDOM SPEEDS. I TOOK THE CAR TO A FORD DEALERSHIP IN MAY 2012 AND THEY COULD NOT FIND A PROBLEM WITH IT. THIS HAPPENED 3 TIMES AND IN AUGUST I TOOK THE CAR IN TWICE, THE FIRST TIME NOTHING WAS FOUND, THE SECOND TIME THEY CHANGE THE THROTTLE BODY ON IT. PROBLEM FIXED RIGHT?? NOT EVEN CLOSE. IN NOVEMBER IT DID IT AGAIN. I CALLED THE DEALER BUT THEY COULD NOT SEE MY CAR FOR A FEW DAYS AND DIDN'T HAVE ANY LOANER VEHICLES. THE CAR THEN BEGAN TO RANDOMLY JERK AT A STOP LIGHTS OR WHEN I CHANGED GEARS. THIS WEEK THE FLARE UP HAPPENED AGAIN BUT THIS TIME THE CAR JERKED WHEN I PUT IT IN DRIVE AND THE ENGINE LIGHT AND WRENCH LIGHT BOTH TURNED ON. I CONTINUED TO DRIVE AND RIGHT WHEN I STARTED GOING UP A HILL THE DASHBOARD LIT UP, THE READERS WENT CRAZY AND MY CAR STARTED ROLLING BACKWARDS. I WAS ABLE TO BREAK BUT WHEN I PUSHED ON THE GAS THE CAR BARELY CREPT UP THE HILL. THE WRENCH LIGHT THEN TURNED OFF BUT THE ENGINE LIGHT STAYED ON. THE NEXT MORNING I TOOK IT TO THE DEALER. WHEN I TOOK IT IN THE ENGINE LIGHT WAS ON BUT WHEN THEY CHECKED IT THE ENGINE LIGHT WAS OFF AND THERE WERE NO CODES ON THE COMPUTER. I AM SCARED OF THE CAR I AM DRIVING. I KNOW THE CAR HAS A PROBLEM AND SO DOES THE DEALER BUT THEY JUST CAN'T FIGURE OUT WHAT THE PROBLEM IS. I CALLED FORD BUT ALL THEY SAID WAS THAT THEY WERE WORKING WITH THE DEALER. I AM PAYING FOR A CAR I CAN'T DRIVE. *TR

Mileage: 9,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH, THE POWER STEERING AND TRACTION WARNING LIGHTS ILLUMINATED. THE CONTACT MERGED TO THE SIDE OF THE ROAD WHERE THE VEHICLE WAS RESTARTED. UPON RESTARTING, THE VEHICLE BECAME DIFFICULT TO STEER. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S HOME AND WAS LATER TAKEN TO A DEALER WHERE IT WAS DETERMINED THAT THE COMPUTER NEEDED TO BE RESET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE ISSUE. THE FAILURE MILEAGE WAS 56,625 AND THE CURRENT MILEAGE WAS 56,708. THE VIN WAS NOT AVAILABLE.

Mileage: 56,625

STEERING JUST QUIT ALL KINDS OF LIGHTS CAME ON THE DASH THEY REPLACED IT TWICE. AND IT STILL ISN'T RIGHT. *TR

Mileage: 12,512

THE FAN BLOWER TO THE AIR CONDITION FAILED TO WORK AFTER A SHORT PARK. THE DEALERSHIP TOLD ME THE WIRE AND RESISTER HAD BURNED,DID NOT KNOW WHICH HAPPENED FIRST. I WAS TOLD IT COULD CAUSE A FIRE SO THE PARTS WERE DISCONNECTED. UNTIL NEW PARTS WERE INSTALLED. MY CONCERN IS THIS VEHICLE WAS PARKED IN MY GARAGE AND THIS COULD HAVE BEEN A MUCH BIGGER PROBLEM . I ALSO AM CONCERNED THAT I AM NOT THE ONLY ONE. WHY SHOULD THIS HAPPEN TO A CAR LESS THAN 2 YEARS OLD. *TR

Mileage: 40,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THE ICONS AND BUTTONS THAT WERE USED FOR TURNING ON THE AIR CONDITIONING, HEAT, RADIO AND OTHER COMPONENTS WAS TOO HARD TO REACH. IN ADDITION, THE CONTACT STATED THAT IT WOULD BE HARD TO SEE THE BUTTONS FOR SENIOR CITIZENS. THE CONTACT WOULD FOR THE VEHICLE DESIGN TO BE CHANGED WITH SENIOR CITIZENS IN MIND. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 6,000 THE FAILURE MILEAGE WAS UNAVAILABLE. UPDATED 09/05/12*LJ

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT THE ICONS AND BUTTONS THAT WERE USED FOR TURNING ON THE AIR CONDITIONING, HEAT, RADIO AND OTHER COMPONENTS WAS TOO HARD TO REACH. IN ADDITION, THE CONTACT STATED THAT IT WOULD BE HARD TO SEE THE BUTTONS FOR SENIOR CITIZENS. THE CONTACT WOULD FOR THE VEHICLE DESIGN TO BE CHANGED WITH SENIOR CITIZENS IN MIND. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 6,000 THE FAILURE MILEAGE WAS UNAVAILABLE. UPDATED 09/05/12*LJ

VEHICLE LOST POWER. TROUBLE LIGHT WAS A WRENCH. TURNED IGNITION OFF AND RESTARTED OK. THE NEXT DAY THE SAME THING HAPPENED. ODDLY BOTH TIMES THIS OCCURRED AFTER MAKING A RIGHT TURN. *TR

Mileage: 42,175

2011 FORD FUSION. CONSUMER STATES SAFETY ISSUES WITH VEHICLE RELATED TO DRIVER CONTROLS AND DISTRACTIONS, BATTERY FAILURE AND LOSS OF ELECTRIC POWER STEERING CAPABILITY *TGW THE CONSUMER STATED THERE WAS NO WARNING THAT THE STEERING WAS ABOUT TO FREEZE WHILE DRIVING. THE CONSUMER ALSO STATED IT WAS DIFFICULT TO READ THE INSTRUMENT PANEL. THE HEADLIGHT CONTROL WAS LOCATED IN AN INCONVENIENT PLACE, THE OBSTRUCTION OF THE LEFT SIDE PLASTIC MOLDING INSIDE THE STEERING WHEEL PREVENTED A CLEAR VIEW OF OBJECT. *JB

2011 FORD FUSION. CONSUMER STATES SAFETY ISSUES WITH VEHICLE RELATED TO DRIVER CONTROLS AND DISTRACTIONS, BATTERY FAILURE AND LOSS OF ELECTRIC POWER STEERING CAPABILITY *TGW THE CONSUMER STATED THERE WAS NO WARNING THAT THE STEERING WAS ABOUT TO FREEZE WHILE DRIVING. THE CONSUMER ALSO STATED IT WAS DIFFICULT TO READ THE INSTRUMENT PANEL. THE HEADLIGHT CONTROL WAS LOCATED IN AN INCONVENIENT PLACE, THE OBSTRUCTION OF THE LEFT SIDE PLASTIC MOLDING INSIDE THE STEERING WHEEL PREVENTED A CLEAR VIEW OF OBJECT. *JB

LETTER SENT OCT. 2011. CUSTOMER UNHAPPINESS DEPARTMENT FORD MOTOR COMPANY P.O. BOX 6248 DEARBORN MI 48126 GENTLEMEN AND/OR LADIES: I HAVE OWNED A FORD (FUSION SE) FOR SEVERAL MONTHS AND EVERY TIME I TAKE IT OUT OF THE GARAGE TO DRIVE I AM AFRAID. I AM AFRAID BECAUSE AS SOON AS I LEAVE THE GARAGE I HAVE TROUBLE SEEING THE RED NEEDLE THAT SHOULD BE TELLING ME HOW FAST I AM GOING. IN THE GARAGE, I SEE THE SPEEDOMETER NEEDLE EASILY. THE FEW TIMES I HAVE DRIVEN AT NIGHT (AT AGE 90, I TRY TO AVOID NIGHT DRIVING) I COULD SEE IT QUITE WELL. BUT IN ANY DAYLIGHT THE BIG NEEDLE TENDS TO DISAPPEAR, AND ON BRIGHT SUNLIT DAYS I USUALLY CANNOT SEE IT AT ALL IN THE FRACTION OF A SECOND I TAKE MY EYES OFF THE ROAD TO LOOK DOWN AT THE DASHBOARD. CURIOUSLY, THE SMALLER NEEDLE ON THE RIGHT THAT TELLS ME THE TEMPERATURE OF THE RADIATOR FLUID SHOWS UP BETTER THAN THE -- MUCH MORE IMPORTANT -- LARGE NEEDLE THAT SHOULD TELL ME THE SPEED. THE ORDER WRITER AT MY DEALER SAYS THERE IS NOTHING THEY CAN DO EXCEPT TURN UP THE DIAL THAT CONTROLS BRIGHTNESS OF THE NEEDLES WHICH HAVE, HE SAYS, LIGHTS INSIDE THEM. I HAD ALREADY DONE THAT. IN MY JUDGMENT, A WHITE NEEDLE WOULD SHOW UP BETTER THAN THE RED ONE. CAN ANYTHING BE DONE TO MAKE MY DRIVING SAFER? DO I NEED TO TRADE FOR ANOTHER MAKE OF CAR SO I CAN FEEL SAFE WHEN I DRIVE? ******* THEIR REPLY SAID, IN EFFECT, "TOUGH LUCK KID; WE CAN'T AFFORD TO SOLVE ALL PROBLEMS." *TR

Mileage: 1,000

ON SEPTEMBER 15, 2011 I WAS DRIVING MY 5 MONTH OLD 2011 FORD FUSION HYBRID WITH 5700 MILES ON IT WHEN A BRAKE WARNING LIGHT CAME ON AND A WARNING TONE SOUNDED IN MY VEHICLE. I PULLED OVER AND STOPPED THE VEHICLE. I CALLED WALKER FORD IN CLEARWATER AND THEY SAID IT PROBABLY WAS ONLY A DEFECTIVE REAR BRAKE LIGHT AND BRING IT IN WHEN YOU HAVE TIME. I RESTARTED MY VEHICLE AND THE WARNING LIGHT AND TONE WERE GONE. I CONTINUED DRIVING HOME AND WHEN I WAS ALMOST HOME, THE BRAKE WARNING LIGHT CAME ON AGAIN AND SO DID THE WARNING TONE. BUT THIS TIME I NOTICED MY ESTIMATED MILES PER GALLON ON THE ONBOARD COMPUTER SYSTEM WAS GOING UP AND DOWN AND THE VEHICLE NO LONGER WENT INTO THE ELECTRIC HYBRID MODE. I CALLED WALKER FORD AND TOLD THEM I WAS GOING TO BRING THE VEHICLE IN ON THE MORNING OF SEPTEMBER 16TH. I BROUGHT IT IN AND ALL DAY LONG THEY TROUBLESHOOT IT AND WALKER FORD COULD NOT FIGURE OUT WHAT WAS WRONG WITH IT. THEY PUT A CALL INTO THE FORD TECHNICIAN HOTLINE TO FIND OUT WHAT WAS WRONG WITH THE VEHICLE. AT THE END OF THE DAY THEY DID NOT HEAR BACK FROM THE HOTLINE AND I NEEDED A VEHICLE TO GET HOME. WALKER FORD WANTED TO GIVE MY VEHICLE BACK TO ME TO DRIVE HOME AND USE OVER THE WEEKEND. I REFUSED SAYING THAT THE MANUAL SAID TO BRING THE VEHICLE IN FOR SERVICE FOR THE BRAKE WARNING LIGHT AND THE ELECTRIC/HYBRID SYSTEM NOT WORKING. NOTHING IN THE MANUAL SAID TO CONTINUE DRIVING THE VEHICLE. SO WALKER FORD FINALLY GAVE ME A LOANER TO DRIVE. MONDAY SEPTEMBER 19TH THEY GOT AN ANSWER FROM THE HOTLINE AND IT SAID A VACUUM HOSE/ASSEMBLY WAS BAD AND THEY PUT ONE ON ORDER. THE NEXT DAY THE PART WAS NOT DELIVERED BUT A NOTICE THAT THE PART WAS NOT AVAILABLE BUT BACK ORDERED AND IT WOULD BECOME AVAILABLE SOMETIME AROUND OCTOBER 14TH. I CONTACTED FORD CUSTOMER SERVICE AND MADE A COMPLAINT CASE # [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 5,700

THE WINDOWS AND SUN ROOF ON MY FORD FUSION 2011 OPENS ON THEIR OWN WHEN NO ONE IS AROUND THE CAR. MY CAR WAS 200 MILES AWAY FROM ME AND FRIEND FOUND WINDOWS AND SUNROOF OPENED. HAD TO MAKE TRIP TO CAR IN ORDER TO CLOSE WINDOWS. FORD DEALER SAID THAT THIS COULD NOT POSSIBLY HAPPEN EVEN THOUGH THE TAURUS HAD THE SAME PROBLEM. *TR

Mileage: 3,000

TL* THE CONTACT OWNS A 2011 FORD FUSION. THE CONTACT STATED THAT HE WAS UNABLE TO TOW THE VEHICLE WITHOUT THE BATTERY GOING DEAD. THE DEALER ADVISED THE CONTACT TO CONNECT A BATTERY DISCONNECT HOWEVER, WHEN THE BATTERY DISCONNECT WAS ADDED, THE VEHICLE BEING TOWED HAD NO AUXILIARY BRAKES. THE DEALER ALSO ADVISED THE CONTACT TO DISCONNECT SOME FUSES UNDERNEATH THE VEHICLE BUT DUE TO THE CONTACT'S PHYSICAL CONDITION IT WAS IMPOSSIBLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 4,006. UPDATED 07/20/11*LJ UPDATED 01/30/12

Mileage: 4,006