2019 FORD FUSION Electrical System Problems

Backup camera keeps going blank with a blue screen also back up camera stays on for a few seconds while driving then the screen turns blue having to do a soft factory reset to the system. Transmission shifts prematurely or kicks down weird. Shifting from park to drive makes a klunk and clicking sound not smooth or quiet at all.

Drove home from work 10/7/25 no issues. Parked the car no issues. Son went to leave and the car just stopped functioning. OEM issues I believe is what my son stated with the computer system. Brake is down and won’t release. Won’t start, sounds like it is even when we aren’t touching anything. Asking for goodwill / Good faith extension on the recall for this vehicle

The contact owns a 2019 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were not yet available, and the recall was put on hold. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and referred the contact to the dealer for further assistance. The contact had not experienced a failure.

I have a 2019 ford fusion turbo engine and everytime I accelerate the turbo is wicking into the pcm the control module which is causing hazards sucking as at random times whenever I turn left the steering wheel with get stuck and the brakes will lock for a couple seconds and then go back to normal. I had Meineke do a diagnostic on the car and they showed oil in the pcm aswell as the loss of connection between the pcm and its sensors. They drove the car and while driving the car going 20mph the car is reading as going 100

Going approximately 55 Miles an hour on the freeway and my car starts profusely shaking. I pulled to the side of the highway tow truck comes up behind me. Ann, my cylinder 4 was noted to be misfiring. I had it towed to Midas and that is where it was determined that engine coolant leaked into my cylinders and now being told that my car requires a new engine!! Mind you i have already paid 5K to replace the timing chain because apparently my car skipped timing due to oil pan leak. Both of these issues are posted on TSB BULLETINS ON THE FORD WEBSITE. I am NOT GOING TO PAY 11K for a new engine not to mention the 5K I already paid and all my other maintenance that I have paid for. Ford was deceptive knowing selling these vehicles with a QA ISSUE! AND THEY REFUSE TO ASSIST THE CONSUMER. THEY NEED TO BE HELD ACCOUNTABLE FOR THEIR NEGLIGENCE!!

First, we will start with every time I turn my car to the left the steering wheel box and the brakes skid then the ABS sensor comes on Then we will start with the car every time I put it into a gear. It automatically goes back to park, and I cannot move the car in any direction. When the issue first started, I could reverse then when I put the car and drive in the middle of the street it would automatically go back to park which could cause a crash I only have video proof of this.

See attached document for complaint. Text from attached document: Despite completing the interim repair, the vehicle still cannot charge, and my repeated inquiries, including under case number CXH-05041947-L 1V3X6, have been met with vague promises of replacement batteries being available "next quarter" with no resolution in sight. Furthermore, I learned on July 23, 2025, that Ford offered a buy-back program for affected vehicles that ended on July 1, 2025, which I was never informed about.

The electrical system constantly discharges the battery. If the car is not started at least every three days, the battery discharges and must be taken to Ford to have the battery replaced. Ford customer service and the dealer know about this and have taken the position that as a customer I must go start the car because Ford cannot fix the problem, Unknown why they cannot fix it. To start the car every three days is very difficult for me because I am disabled and must climb stairs and walk to the street to manually start the car. Ford suggested using the remote start feature of furnished with the car by Ford. The remote start works but it is limited to remote starting the car two times and then you must go to the car and manually start the car. If I am unable to get to the car in time to start it, the battery goes dead and I cannot use my car in case of an emergency. Ford has been made aware of this, Ford says they agree it is a problem but that Ford Engineers won't remove the two start limit. Ford will not say why there is a two start limit. This could be fixed (limit removed) by just updating the software. Ford does not respond anymore when I ask them about it.

My front camera is often unavailable. I took it in multiple times and they couldn’t find an issue. Recently my back up camera has been acting up. It is unavailable most of the time, other times the screen is black, sometimes it’ll work and then cut out. There is a recall on other ford vehicles for this issue. I looked up if it needs a software update and it doesn’t. We’ve checked the camera and wiring harness and they’re both intact and in good condition.

1.5 liter Engine built in 2019 has Antifreeze Leaking inside cylinder 1 needs Complete Engine. Also a recall on Electrical System propulsion System and Traction Battery Management System ENERGY Control Module Part Number: 23533.

During the month of dec 2024 my car didnt start. I called Triple A to jump start my car to get home. During Christmas break of 2024 i purchased a brand new battery and now a month and two weeks later the battery is completely dead again. Sometimes is hard to get the car up to speed and feels like it struggles to maintain it as well. The electrical system also kicks my radio connection off and on while driving. The first incident happened dec. 21,2023 and the second incident happened Jan. 27,2025.

The contact owns a 2019 Ford Fusion. The contact stated while driving at various speeds, the vehicle stalled. The contact stated that on several occasions the vehicle failed to start. The vehicle was taken to the local dealer who replaced the battery, but the failure persisted. The vehicle was taken back to the dealer who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 33,084.

Mileage: 33,084

The contact owns 2019 Ford Fusion. The contact stated that while the vehicle was parked, the vehicle failed to start. No warning light was illuminated. The vehicle was not drivable. The contact stated that a Mobile Ford representative was contacted and arrived at the residence to inspect the vehicle. The dealer suggested that the battery needed to be replaced. The battery was replaced. The vehicle was repaired; however, the failure recurred. The contact stated that the red triangle Master Warning Light was illuminated on the instrument panel while attempting to start the vehicle. The contact was notified that the VIN was included in the NHTSA Campaign Numbers: 23V440000 (Electrical System). The manufacturer was not notified of the failure. The failure mileage was approximately 7,800. The VIN was not available.

Mileage: 7,800

2019 Ford Fusion . Just stopped running while driving . Everything just quit working . Took to shop they replaced alternator and battery . After driving a month car did exact same thing again. I think this is more than an alternator problem.

This has happened multiple times now. Always happens at high speeds (greater than 45 mph). I will be driving on a highway when I unexpectedly lose the ability to accelerate. First noticed in correlation with the collision detection feature showing on the display as NOT FUNCTIONING. That does not happen anymore, but I still lose the ability to accelerate periodically. Once I can safely remove myself from the flow of traffic and stop/restart my car the issue is resolved. Makes me believe this is electrical/computer origin. The vehicle was taken to the dealership twice where they claim “cannot duplicate” but are willing to replace any item that I will pay for out of pocket. The dealership does not want to honor my extended warranty. The vehicle was purchased new in 2019. Within one year they had to replace half my engine (which they decided to do without warning when I dropped off for an oil change). The vehicle was stolen in 2023 (recovered by me in under 24 hours). Multiple cosmetic issues were repaired by a Ford authorized service team. This issue presented about 1.5 months ago 4+ months after the vehicle was repaired.

I put car into park to use the atm and then could not get it back into gear it gave a lot of different issues system fault error oil pressure errors battery error collision error and I ended up replacing the gear shift bushing which had deteriorated and broke off and that fixed most of issues now car makes loud blaring alarm sound that is not the normal car dinging it's loud and high pitched and acts like my battery is dead but won't start or shows any signs it is being jumped. Like the battery is completely dead won't take or hold charge.

check engine code for anti knock sensor. Dealer unable to fix after 4 attempts and car spending > 30 days in service in less than 6 months. Car sold to dealer and I hope they don't sell to an unsuspecting buyer.

My car in February of 202: got stuck in park they said it was electrical issue, then months later I ended up with a coolant leak that then combusted my engine. New engine in August of 2023 fast forward to November 2023 my car is doing the same thing it stalled in the road with myself and newborn in the car, lost all speed and now it will not go in drive or reverse just like it did in February of 2023. It’s been in the shop twice and now ongoing it’s third time and I find this to be a severe issue because if my car is going to keep stalling while driving there is no reason to keep fixing this car. I’m aware past fusion’s have been recalled for something of similar problems so it makes me wonder if this should be recalled as well.

The contact owns a 2019 Ford Fusion. The contact stated while driving at an undisclosed speed, the rear-view camera activated while in drive, and later failed to turn off after reversing. The contact also stated that the instrument panel and infotainment system acted erratically, turning off, not reacting to function buttons, and freezing. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the APIM. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 19,000.

Mileage: 19,000

The contact owns a 2019 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. The VIN was not available.

The contact owns a 2019 Ford Fusion. The contact stated while driving approximately 30-35 MPH, the check engine warning light illuminated. The contact stated that the failure recurred while driving. Additionally, the vehicle lunged forward but failed to respond upon depressing the accelerator pedal. The contact was able to pull to the side of the road. The vehicle was towed to the local Pep Boys, where the ignition coils #3 and #4 were replaced; however, the failure persisted. The vehicle was taken to an independent mechanic, where ignition coil #4 was replaced; however, the failure persisted. The independent mechanic replaced spark plugs #1, #2 and #3. The number four spark plug was stuck and was not removed. The vehicle was taken to the dealer, where it was diagnosed and determined that the cylinder head needed to be replaced. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 67,000

Mileage: 67,000

Pedestrian detection system malfunction. Sync 3 system APIM unit is going out and needs replacing (only at 58k miles, 10k out of warranty). Passenger front seat heater and climate control failed due to seat heater melting wiring harness.

Not sure what system is causing it but my trunk keeps opening and it’s done it many while I was driving. I understand a lot of other Ford Fusion owners are having the same problem and I urge you to look into the problem as it can cause accidents and deaths.

The contact owns a 2019 Ford Fusion. The contact stated that on several occasions while driving or stationary, the trunk would independently open without warning. The contact reached out to a dealer and made an appointment to have the vehicle inspected. The manufacturer had yet to be notified of the failure. The vehicle was not yet repaired. The failure mileage was approximately 36,000.

Mileage: 36,000

MY CAR HAS HAD ONGOING ELECTRICAL PROBLEMS SINCE DAY ONE. THEY HAVE TRIED VARIOUS REMEDIES TO NO AVAIL. NOW THAT IT IS OUT OF WARRANTY THEY REFUSE TO COVER THIS ONGOING ISSUE

T O WHOM IT MAY CONCERN, THANK YOU FOR ASSISTING ME DURING THIS PROCESS. MY CAR I PURCHASED NEW AND I WOULD LIKE TO SAY A FEW MONTH INTO OWNING MY CAR IVE HAD SERVAL INCIDENCE WHERE MY CAR WOULD COMPLETELY SHUT OFF WHILE I'M A RED LIGHT FOR AWHILE DUE TO TRAFFICS. MY CAR HAS AN ECO BUTTON WHERE I CAN TURN IT OFF AND ON SO IT DOESN'T 'SHUT DOWN' WHEN I COME TO A STOP. THE REASON I'M SO UPSET WITH THIS IS BECAUSE 2-3 TIMES IT'S HAPPENED TO I'VE HAD MY TODDLER WITH ME AND IN ORDER FOR ME TO GO (WHEN THE CAR SHOULD AUTOMATICALLY TURN ON ONCE I REMOVE MY FOOT FROM THE BREAK), I HAVE TO TURN OFF MY CAR AND TURN IT BACK ON AND IT'S HAPPENED DURING TRAFFIC AND BUG INTERACTIONS. I DON'T FEEL SAFE IN MY CAR AND MOST IMPORTANTLY I'M SCARED A CAR WILL HIT ME FROM BEHIND DO TO THIS ISSUE WITH MY SON IN THE CAR. I'VE ADDRESSED THIS ISSUE TO FORD AND WHEN I TAKE IT IN THEY SAID THEY CAN'T DETECT THE PROBLEM. THEY'VE CHANGED THE BATTERY THINKING IT WOULD HELP HIT IT DIDN'T. I'VE GIVEN THEM THE OPPORTUNITY TO ASSIST ME AS MUCH AS THEY CAN BUT YET I FEEL LIKE NOTHINGS BEEN DONE.

Mileage: 1,020

THE SYSTEM BEGAN FAILING WHEN THE FIRST THE ALARM DOESN'T SET, THEN THE HORN DOESN'T WORK BUT THE VEHICLE DOES RUN

STARTED THE CAR WHETHER MANUAL OR BY REMOTE START A POWERTRAIN MALFUNCTION WILL COME ON MY FORD PASS APP. ALSO ON THE DASHBOARD IT WILL SAY SHIFT SYSTEM FAULT. ONCE I PUT THE CAR IN DRIVE THE SERVICE LIGHT DISAPPEARS. THE VEHICLE WAS IN MY DRIVEWAY STATIONARY. ON 2 OTHER OCCASIONS SEPTEMBER 18 2019 AND SEPTEMBER 25 2019 THE CAR WAS IN MY DRIVEWAY STATIONARY. I STARTED THE CAR MANUALLY CAR WOULD NOT START (NO ENGINE TURN OVER) BUT CAR START STOP BUTTON WOULD BE GREEN AS IF CAR WAS RUNNING. THE DASHBOARD WOULD SAY FULL ACCESSORY MODE ACTIVE, TRANSMISSION NOT IN PARK, SHIFT SYSTEM MALFUNCTION. THE CAR DASHBOARD WOULD SAY THE CAR WAS IN DRIVE BUT THE TURN DIAL GEAR WOULD SHOW PARK. THE CAR GEAR DIAL WAS ALSO LOCKED AND WOULD NOT TURN. IF I TOOK OFF THE EMERGENCY BRAKE THE CAR WOULD ROLL BACKWARDS. ALSO I COULD NOT TURN THE CAR OFF AFTER THAT. AFTER 40- 60 MIN THE CAR SHOWED IT WAS GOING TO TURN OFF IN 15 MIN TO SAVE POWER. ONCE IT TURNED OFF. THE CAR WOULD START AND ENGINE WOULD TURN OVER AS IF NOTHING HAPPEND. I ALSO HAVE VIDEO OF BOTH TIMES CAR WOULD NOT START. WEBSITE WILL NOT LET ME UPLOAD VIDEOS

Mileage: 5,964