2022 FORD MAVERICK HYBRID Unknown Or Other Problems

The 2022 Ford Maverick repeatedly experiences complete electrical system failures, including engine shutdown, loss of power steering, brakes, and the electronic parking brake, while driving at highway speeds, resulting in total loss of vehicle control and creating a life-threatening situation for the driver, passengers, and others on the road; prior warning signs included the 12-volt battery not staying charged and intermittent total electrical power loss, and while no warning lamps indicated imminent failure, the issue was reproduced and documented by a dealership that replaced the battery, performed a BCM relearn, and applied a software update, yet the problem persisted, leaving the vehicle undriveable and unsafe, requiring repeated jump-starts, and demonstrating a fundamental defect in the electrical and control systems; the vehicle is currently scheduled for further warranty diagnostics at a second dealership, and because prior warranty repairs failed to correct this repeat, safety-critical, and life-threatening defect, I request immediate manufacturer investigation, full warranty coverage, and evaluation for vehicle replacement under applicable Lemon Law or consumer protection remedies, as the repeated failure places lives at risk and the vehicle cannot be safely operated until fully corrected.

While driving around 50MPH my vehicle started to lose engine power going down to 40, then 30, then 20MPH. I had to pull into a break down lane and at the next exit I managed to make it to a Ford Dealership called Flood Ford in Narragansett, R. I. This may be related to NHTSA safety recall number: 24S24 from May 2024. This happened yesterday [XXX] around [XXX]. This is the 2nd time it has happened as it happened another time on [XXX] in North Carolina and it ended up at Huntersville Ford. The dealership in Rhode Island won’t be able to put a diagnostic tool on my truck until Monday August 25th so I’ll be without a car for 6 days. A real inconvenience INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Windshield cracks. First happened in 2024, nothing hitting the windshield, it cracked. The crack spread and required an entire new windshield that was not covered by any warranty. July 2025 same issue, same area where the crack started last time, on the new windshield. I am concerned about the quality of the windshields installed on Ford Mavericks. One dealership said “the Maverick windshields are known to be incredibly thin and crack”

Water leak/intrusion into cabin Hybrid back from the dealer for a water leak. As a recap, only a few weeks old bought it used and discovered a pool of water under the floor liners I put in Water leaking in through HVAC Box, down past the BCM and onto the passenger floorboard. Lower Cowl seal for the cabin air intake defective. Removed engine bay cowls to access defective part. Damaged seal caused water leak and is apart of the lower cabin air intake cover.

My truck shakes like a bad washing machine with an uneven load at 50mph+ only while accelerating. While turning it squeals. I have a hybrid and have not done any off-roading. All my miles are from highway or city driving.

Front axle has had to be repaired twice once under warranty and the second time with an out of pocket cost of $1172. The same issue has been reported numerous times by Maverick owners. This cost should not be out out pocket, Ford needs to issue a recall and I should be reimbursed.

Transmission sensors/Software. My wife stopped at a intersection, light turned green and she went to proceed, the truck went in reverse instead of forward! She stopped it before it hit another car. This is the second time this truck has gone behaved in a dangerous way. Last time it lurched forward almost hitting a car, and then the car went into a safety mode (they 'fixed' that in a previous recall). It seems like another sensor/software malfunction

Vehicle shudders or shakes on acceleration. Seems to only happen during acceleration and doesn't feel like it throws the steering wheel around but more like the front end is just loose or something like a transmission slipping feeling.

While driving the emergency brakes locked up and stopped me in the traffic. I tried to get the vehicle started but it did not start.The dashboard message said" automatic emergency breaking " The AAA mechanic said that the regular battery was not charging and this was confirmed by the mechanic at Gunns Automotive.

Ford has had a recall on my car for far too long causing me to lose money as I cannot rent it out until the recall is fixed

Vehicle enters "Deep Sleep" mode NEARY EVERY DAY and all 12 volt systems such as lighting are not useable. Vehicle will NOT START sometimes when Deep Sleep mode occurs. No matter how much we charge the 12v battery, this deep sleep issue will return within 1 day. Dealer has not fixed this issue after "supposedly" checking it out on a few visits to Livermore Ford Dealership. It has now been over 2 1/2 years of this problem with no fix.

I reported an odor coming from my vehicle and took it to the Ford dealership to get checked. Nothing was found by the dealer. I continued to notice a strong odor. Recently, when cleaning my car, I removed the floor mat and found a puddle of water underneath. I removed a small panel in the dash and could see water leaking when I ran climate control. It was leaking all over multiple electrical components so I have been hesitant to drive. The water will not dry or drain and has begun to mold.

I have a 22 hybrid maverick with ~ 27,000. I was driving back home from out of town and I had already driven for a good two and a half hours. I was passing an 18 wheeler when suddenly my whole truck turned off. The dash, infotainment screen all black. I tried to turn on the hazards but nothing came on. The steering wheel was stiff and I was pressing the brakes as hard as I could but we were barely slowing down. I coasted across the right lane and into the shoulder/grass and finally came to a stop. I turned the truck off and on and a whole bunch of warnings and lights popped up. I turned it off again and when I turned it back on it was like everything was back to normal. I drove the rest of the way home ~ 50 mph. The truck felt awkward when switching from gas to electric and shook a bit when coming to stops. I will be calling the service dept tomorrow.

My 2022 Ford Maverick has a persistent issue with moisture accumulating on the front passenger floorboard, leading to a mildew smell that requires constant deodorizing. This problem has been ongoing since I discovered it around 18,000 miles. Despite taking the vehicle in three times, the issue remains unresolved. The technicians suspected a valve issue on the condenser, allowing moisture in, but couldn't provide a remedy. They mentioned a similar problem with the 2018 F-150, which was eventually resolved through a warranty/recall. I have found multiple online posts describing the same issue. I believe this is a pre-existing issue with all 2022 models. The floorboard gets wet after running the AC for a few hours in warm to hot weather. P.S. Ford conducted a pressure test and said it passed. No resolution for over a year.

My Maverick had water filled in the floor from heavy rain during transport. I waited 2 additional weeks to take delivery. Once I took delivery I was driving around with mold in the carpets on my vehicle for nearly 4 months. Then we had heavy rains again and the same problem resurfaced. I took my car for repair and they kept it for three weeks and returned it repaired. Over the past week-end the carpets are soaked once again with a bad mildew smell and possibly mold. At this point Ford must take some responsibility with this

When I shifted to reverse to leave a parking space, a message popped up on the cluster saying “Camera Not Available. Contact Dealer.” An image then did come up and stayed frozen on the screen for the entire key cycle. The next time I drove the vehicle, the camera operated as intended. Picture attached showing frozen image while vehicle was in Drive gear.

I found mold under my front passenger floor mat. There has been a water leak since u had purchased the vehicle. As of now the dealership has not successfully discovered the source. Vehicle has been in and out of the dealership since Feb 22, 2024.

Drove my car home and parked in my driveway with no issues. 9 hours later when I was about leaving for work, started the car but car won't start. I jumpstarted the car then all of a sudden the (Drive) Shift knob light was flashing, warnings started flashing, hill start assist not available, service vehicle soon, pre collision assist not available, service advance Trac, and parking brake applied automatically and total loss of power. When I pressed on the gas, it wouldn’t go and no throttle response. When I let off the brake and was NOT pressing the gas, it would start to accelerate all on its own up to about 28/29 mph all on its own, acting like it was in cruise control

While driving the vehical at 70 mph it suddenly lost power and all of the warning lights on the dash started to light up, was able to pull over to the side of the road safely. Turned the car off and opened up the door, closed the door and started it back up and the instrument cluster continued to throw signals. Had it towed to the dealership and am awaiting a response.

The Dealer did not reveal the unresolved recall on this used vehicle during sales lot inspection. After I pointed out the recall listed on the CarFax report, the dealer did not address the concern nor mention if the recall had been resolved in order to make the used truck ready for resale. The Dealer did not explain how the recall may apply to this specific truck. This vehicle still has this recall active and unresolved at the Fritts Ford Dealership in Riverside, CA Auto Mall. Instead, pushed the Ford PremiumCare Extended Warranty which in the fine print does not include the engine, the battery, or recalls on any components. I have not purchased this vehicle and unlikely to do so at this time due to this serious and dangerous known risk to operating this 2022 Ford Maverick Hybrid Truck.

On 4/27/24 Vehicle went into limp mode after driving for less than 90 seconds. Multiple various errors messages (powertrain, hill assist, collision, check engine) lit up, vehicle was accelerating on its own when in drive. No error messages prior to this incident. Similar incident happened around 3/10/23 while at Ford service for recall software updates but issue was not confirmed at that time. Vehicle is at Ford service now for second incident. Ford service states when the vehicle got a recall completed for the SOBDCM update, it triggered the vehicle to not update fully and causes the warning messages and can force the vehicle to go into limp mode and lose power.

While on [XXX} in Memphis, I lost power and many indicators came up on the dash. I was able to coast at 20mph to dealership. But this could've been way worse. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I think it's a software issue. As of today, I've had the problem three times since having my BCM and PCM reprogrammed. The truck will suddenly loose power and go into some kind of limp mode. The dash screen starts throwing notices in quick succession: low gear only, check advancetrac, hill assist not available, powertrain malfunction/reduced power, pre-collision assist not available, the light indicating what drive mode (reverse, park, drive, etc.) starts flashing and then switches itself from drive to park, and then the parking brake turns itself on.

Just had a recall completed related to software programming in the past 3 weeks. Since then this has occured twice. While driving at highway speeds the vehicle quickly lost/reduced power and slowed down to 20 mph and produced a message that stated " Powertrain malfunction/Reduced power, engine service soon, and precollision assistance not available". This caused me to almost be rear ended and get into an accident with other vehicles on the road. It likely would have resulted in an accident/injury if not for light traffic that day. Ford has stated they cannot reproduce the issue.

Driving on the freeway and lost gas engine power. Had to coast across several lanes of traffic without propulsion to get the the shoulder. Shut off the vehicle and restarted and it has worked fine for the past couple of months.

My Ford Maverick is one of MANY that has a problem with mold. Mold is growing under the dash in the front passenger footwell. This issue is caused by a water intrusion. There is likely a manufacturing issue with the right front of the truck, which allows water in. The truck has had a problem with fogging up quickly since I purchased it new from Ford. My family's safety is at risk because the mold has led each of us to feel sick after riding in the truck. The truck is going in tomorrow for warranty work. Ford MUST recall every single vehicle that is effected. This is a serious health risk. Plus, the defective seam could fail in an accident, leading to injuries or deaths.

Water leaks from an unknown location causing the front passenger floorboard to be saturated.

Drivers side front brake makes grinding noise, Ford dealer mechanic states I do not drive it enough. The brake noise is most apparent at low speed. Second problem. Using remote entry at night does not turn on interior lights, nor opening the door. But after using the truck and turning off the ignition the interior light is on.

Truck was lost power completely, unable to neither starting, gear shifting, steering nor breaking

Low speed grabby brakes. When I go to park my maverick hybrid at the last moment it stops you very suddenly under 5mph. And my back up camera has frozen up a few times now mening when I back up the camera does not keep movies but stays frozen in 1 spot.

Grabby brakes at low speed. Even after getting the suggested fix from Ford my vehicle still has the grabby breaks. There is also an issue where coming from a fast speed down to a lower speed the vehicle starts to vibrate violently until I either press the gas or press the break. Seems like the breaks are pulsing on and off very fast causing it to shake.

The truck battery connection is faulty causing it to loose complete power to the vehicle after driving and turning off it won’t restart. No power means no hazards, complete blackout on the vehicle. This is reported on YouTube by so many other’s experiencing the same issue. They replaced my battery which was not the issue, the next day I experienced the same dead vehicle issue. Ford also did not tow it, they wanted to charge 626.

Twice, within a one week period, my hybrid vehicle failed to start. In fact, the key fob failed to unlock vehicle. I changed the battery in one key fob and still wouldn't unlock the vehicle. I had to unlock vehicle manually with the key and vehicle still wouldn't start. Vehicle dash board and all interior lights not working. Both times service was called and vehicle started right up with a jump from a battery pack. No check engine light was displayed either time. I have checked the Ford Maverick owners website and a bad wiring harness appears to be a problem that many hybrid owners have reported that Ford replaced to resolve this problem. I am concerned that this defective wiring harness could be a fire hazard. Also now the vehicle is unreliable and could leave me stranded on the highway or die in heavy traffic or when trying to merge or exit the interstate near my home.

When I use my remote start option and just put my key in the ignition and start the truck it has a constant burning wire smell. If I come to the truck and turn it off after remote start and just restart it with the key I don't smell the burning wire. If I don't use the remote start option and just start my truck with the key I don't smell the burning wire smell.

I got back to my Ford Maverick Hybrid after work yesterday and it was completely dead. Nothing at all worked. I was able to jump start it with a friend and drove it straight to my local Ford dealership. They checked the batteries and they were good. I have been reading online Ford Maverick Hybrid forums about these 'dead Mavericks'. Most of the murmor is that there is something wrong with the harness connector or cable of it. But for what it is worth I do want to report my dead Maverick after only six months and 7k miles and zero issues up til now. I love this truck to death I hope they solve this issue.

Random shaking when I step on gas. Makes the whole truck shake but stops when I take my foot off gas and reapply. I took it to the dealership and they said they couldn’t find anything wrong and there’s no check engine light. It happens 2-3 times a month and only under light acceleration.

Purchased new 7-22-2022. On 8-10-2022 drove 14 mi, parked for 2 hours, tried to start truck, message on dash said “stop safely now “, with red triangle, check engine, battery warning lights. Tried repeatedly to start truck waiting 15 minutes each time, wouldn’t start. Used ford pass on phone to call for tow. When tow arrived 30 minutes later the truck started like normal. Drove around parking lot while tow truck waited seemed normal so I drove home. Had dealer check 12v battery on 8-12 and it was fine. Made appointment for diagnostic testing for 8-22. Other owners have received “stop safely now” message while driving on highway, engine lost power and coasted to stop on side of road - obviously a serious safety concern.

I was driving on the highway at about 70 MPH when the truck gave me a "Powertrain Malfunction/Reduced Power" notification & the red battery light came on. The truck then had a "Pull Over Immediately" (Not 100% sure on the wording) notification on the dashboard and stopped accelerating. Once the notification popped up and the truck stopped accelerating, the air conditioning & power steering also stopped working. I was able to coast long enough to get over to the shoulder where I was able to call a tow truck. While waiting for the tow truck, the truck would not start, the hood latch would not open, and it was unable to shift gears so it could not be put in neutral to be towed.

When I shift into drive gear it hesitates to go until it kicks into the battery drive mode. When I am at a stop sign you can feel it switching over and when I go to push on the gas to go from the stop sign it doesn't go immediately until it shifts to the electric mode. When I am in a drive thru and it switching from electric to gas mode it jerks like the transmission is going to fall out

Hybrid Maverick completely loss of power overnight, multiple error warning received on Ford Pass APP. Jumped and at dealer awaiting resolution. Many others with same problem on Ford Maverick Forum. Vehicle can lose all power while driving or parked. Can be very risky/dangerous for vehicle operators.

Vehicle had a check engine light go on for voltage. At 4K miles. Later that day loss complete power nothing electrical worked and it had to be towed to dealership. Stayed at dealership service for over a week trying to diagnose it.

The vehicle switched to Neutral from Drive as the driver made a right turn at low speed, the weather was a little wet and rainy and about 68 degree outside.

Some 2022 Ford Maverick Hybrids have a faulty seal and leak oil onto transmission and clutch. I was accelerating on the HWY when engine light came on (solid). Noticed it needed more time and effort to accelerate. When parked and ran idle vehicle would suddenly jump- the rpm would shoot up sporadically for several minutes. There were no prior symbols or symptoms to this issue, and the vehicle is new. It happened exactly at 128 miles. Issue was apparent less than 12hrs of ownership. Took it to the Ford dealership which I purchased the vehicle from on Monday, I took possession Friday. The service advisor diagnosed it with transmission clutch slippage (P0811) and that the dampener (clutch?) would need to be replaced. Still waiting on them to email me the exact part number. Allegedly, a seal was loose which allowed oil to contaminate the transmission, causing slippage. This could prevent bodily harm, vehicle accident, and death. Pulling out into a busy road or merging with traffic requires a maintained speed or anticipated acceleration - this issue could prevent a driver from reaching this and result in a miscalculation or collision. I, myself, almost experienced an accident when merging off the HWY and the 2022 Ford Maverick would not accelerate. The engine light turned off after 2 hours of gentle driving in which a slippage did not occur after it was allowed to run hot long enough for the oil to burn. This gentle driving carried me through the weekend until I could drop it off Monday. It was easily recreated twice in the shop. Oil could be smelled and observed burning when the hood was propped open. These issues have been verified by the dealerships mechanics and general manager. Ford customer service acknowledged other Hybrid owners are experiencing the same issue when I contacted about parts, and this is a common defect amongst other Hybrid owners. Some required a new transmission when dampener/clutch did not solve the issue.