1999 FORD RANGER Suspension Problems

I was driving to the store around 1 month ago and I noticed the truck was trying to tail to the side as I was driving. I thought nothing of it until my Uncle Bobby noticed my rear shock was scraping the ground. We looked underneath to investigate and found both shock mounts completely rusted off and the frame in terrible shape. The truck itself barely has any rust other than the tailgate and bed floor. Also thought I should include that the hose that connect the gas tank and where you pump the gas is rusted to where every time I pump gas, a little drips out onto the floor. I was trying to find videos on how to fix it but came across a page that says Rangers have been recalled from the years 1995 to 2000 because of Toyota starting to make frames for them. *EDIT* Also would like to mention that the frame where the bumper attaches to on the driver side has cracked and now the bumper is sagging down .

I was driving to the store around 1 month ago and I noticed the truck was trying to tail to the side as I was driving. I thought nothing of it until my Uncle Bobby noticed my rear shock was scraping the ground. We looked underneath to investigate and found both shock mounts completely rusted off and the frame in terrible shape. The truck itself barely has any rust other than the tailgate and bed floor. Also thought I should include that the hose that connect the gas tank and where you pump the gas is rusted to where every time I pump gas, a little drips out onto the floor. I was trying to find videos on how to fix it but came across a page that says Rangers have been recalled from the years 1995 to 2000 because of Toyota starting to make frames for them. *EDIT* Also would like to mention that the frame where the bumper attaches to on the driver side has cracked and now the bumper is sagging down .

I WAS DRIVING WAS ABOUT 20 MPH AND HIT A SMALL POT HOLE. I HEARD A LOUD POP BANG NOISE AND THE LEFT SIDE OF TRUCK DROPPED ABOUT 2 OR 3 INCHES. I THOUGHT THE FRONT END FELL OFF. THE FRAME IS RUSTED SO BAD YOU CAN PUNCH HOLES IS THE FRAME WITH A SCREW DRIVER, THE DRIVER SIDE TORSION BAR HAS COLLAPSED DUE TO RUST ON THE FRAME THAT HOLDS IT IN PLACE, THE CROSSMEMBER TO TRANSMISSION IS BARLEY HOLDING TRANSMISSION UP, THE SPARE TIRE AREA IS RUSTED IN HALF, ALL MAIN CROSSMEMBERS ARE RUSTED IN HALF AND THE FRAME IS RUSTED IN HALF BEHIND FUEL TANK. TRUCK HAS 127K MILES AND THE BODY BODY HAS LITTLE TO NO RUST, UPPER AND LOWER CONTROL ARMS ARE UNSAFE FROM RUST. I DO NOT UNDERSTAND HOW THE BODY CAN BE SO GOOD BUT FRAME AND SUSPENSION IS COMPLETELY RUSTED TO NO RETURN.

Mileage: 127,642

FRAME IS VERY RUSTED AND BIG HOLES IN THE FRAME. I THINK THERE IS A GAS LEAK AS WELL BUT THE FRAME IS VERY BAD.

THE FRAME IS RUSTING AWAY. BOTH LEAF SPRING SHACKLES RUSTED COMPLETELY THROUGH, MUFFLER HANGERS ALL RUSTED OFF LOST MY MUFFLER ON A ROAD.

Mileage: 150,000

GAS PETAL IS TOO CLOSE TO BRAKES...AND IF NOT CAREFUL RIGHT FOOT HITS BOTH.CAUSING A ROARING OF ACCELERATION , WHILE TRYING TO STOP VEHICLE.VERY DANGEROUS!

Mileage: 178,000

MECHANIC TELLS ME THAT VEHICLE IS UNSAFE DUE TO EXTREME RUST/CORROSION ON CHASSIS FRAME (LEFT SIDE) OVER AND NEAR GAS TANK AND BRAKE LINES. NO ACCIDENT TO REPORT BUT I WON'T DRIVE VEHICLE NOW DUE TO OBVIOUS SAFETY ISSUES.

THE FRAME AT THE RIGHT FRONT SUSPENSION POCKET RUSTED OUT. UPPER CONTROL ARM REAR BRACKET IS COMPLETELY DETACHED. DROVE THE TRUCK TO MY DESTINATION WITH NO ISSUES, ON THE RETURN TRIP IT FELT "FLOATY" AS IF IT WAS OUT OF ALIGNMENT WHILE I WAS DRIVING DOWN A TOWN ROAD. THERE WAS NO BUMP OR AUDIBLE NOISE PRIOR TO OR ACCOMPANYING THE ISSUE. BODY HAS VERY MINIMAL RUST, THE REST OF THE FRAME APPEARS SOLID. TRUCK HAS 104,660 MILES.

Mileage: 104,660

FRAME RAILS ARE ROTTING OUT MORE ON THE LEFT SIDE THAN THE RIGHT, CRACKS AND ROT HOLES NEAR ALL THE CHASSIS /SUSPENSION MOUNTS INCLUDING THE MOUNTS FOR THE FUEL TANK, VERY DANGEROUS AS THESE VEHICLES LOOK GREAT IN APPEARANCE BUT FRAMES ARE ROTTING TO PEOPLE UNKNOWN POSSIBLY TOO LATE AS SOME MAY GET KILLED AS A RESULT, EITHER BY AN ACCIDENT OR GETTING BLOWN UP BY THE FUEL TANK FALLING OUT

LIKE MOST OF THE OTHER COMPLAINTS, REAR FRAME IS JUST DISCENTERGRATING. FIRST NOTICED AT ABOUT 54000 MILES, DID SOME REPAIRS AND NOW AT AROUND 90000 I NOTICED BOTH SIDES ARE GOING BAD, HAVE CRACKS AND HOLES, AND THE CROSSMEMBERS ARE IN BAD SHAPE. I'M NOT A WEALTHY PERSON AND CANNOT JUST AFFORD TO BUY ANOTHER VEHICLE. I DON'T UNDERSTAND WHY THE GOVERNMENT OR FORD DOESN'T REALIZE WHAT A SAFETY CONCERN THIS IS. DOES SOMEONE'S LIFE HAVE TO END BECAUSE A FRAME BRAKES OFF WHILE DRIVING ON THE STREET OR INTERSTATE. DOESN'T' ANYONE READ THE COMPLAINTS ON THIS VEHICLE AND UNDERSTAND HOW DANGEROUS THIS COULD BE. I KNOW FORD IS AWARE OF THE REAR FRAMES ROTTING ON THIS MODEL YEAR AND OTHERS OF THE RANGER. I CONTACTED THEM PERSONALLY. WHAT MAKES FORD BETTER THAN TOYOTA? I ALWAYS SAY BUY AMERICAN, BUT I'M HAVING SECOND THOUGHTS.

Mileage: 90,000

SEVERE FRAME RUSTING, BED HAS SEVERE RUST, REAR LEAF SPRING SHACKLES RUSTED OUT AND HAD TO BE REPLACED AT MY EXPENSE. VEHICLE IS NEARLY UNUSABLE AND UNSAFE AT 112,000 OR SO MILES.

Mileage: 110,000

TL* THE CONTACT OWNS A 1999 FORD RANGER. WHILE DRIVING AT VARIOUS SPEEDS, AN ABNORMAL NOISE WAS HEARD COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS DIAGNOSED THAT THE REAR SPRING SUSPENSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 237,000.

Mileage: 237,000

MY 1999 FORD RANGER FRAME IS RUSTING IN SEVERAL LOCATION WHICH WILL MAKE IT VERY UNSAFE THE BODY LOOKS BRAND NEW BUT THE FRONT FRAME AND REAR FRAME ARE RUSTING AWAY. THE SHOCKS ON THE FRONT RIGHT SIDE ARE ABOUT THE BREAK THROUGH THE SUPPORT AND THE UPPER CONTROL ARM IS ABOUT THE BREAK OFF.

Mileage: 116,503

MY FRAME HAS RUSTED/ ROTTED ALMOST COMPLETELY OFF WHERE IT CONNECTS TO MY REAR BUMPER. THE BUMPER IS NOW ATTACHED BY ONE OF TWO BRACKETS AND IS SOON TO FALL OFF WHERE AS IT MAY CAUSE A FATAL INJURY TO ANOTHER DRIVER OR PEDESTRIANS.

UPON INSPECTION MECHANIC SAID "SHACKLES , FRAME, LEAFSPRINGS, ALL RUSTED AND TRUCK WILL NOT LAST. MOTOR RUNS GREAT, BODY NO RUST.

Mileage: 104,000

MY REPAIR GARAGE CALLED ME IN TO LOOK AT THE FRAME ON MY 1999 FORD RANGER. THE FRAME WAS DETERIORATED SO BADLY FROM RUST NEAR THE FRONT ENGINE AND BY THE REAR SPRING HANGERS AND SHACKLES IT IS UNSAFE TO DRIVE. MECHANICALLY IT RUNS AND DRIVES GREAT AND THE SHEET METAL AND INTERIOR IS EXCELLENT. THE FRAME IS A MAJOR SAFETY ISSUE FOR A VEHICLE WHICH HAS BEEN GARAGED, WELL CARED FOR, AND HAS BEEN DRIVEN ONLY AN AVERAGE OF 6,125 MILES ANNUALLY. FORD SHOULD BE HELD ACCOUNTABLE FOR THIS!

Mileage: 98,000

I HAVE OWNED 4 RANGERS OVER THE PAST 15 YEARS, A 1995, 1998,1999,AND A 2001 AND ALL 4 TRUCKS HAVE HAD THE LEAF SPRING HANGERS ROT OFF . MY LATEST TRUCK THE LEAF SPRING HANGER AND NOW THE FRAME HAS ROTTED AWAY THERE IS NO WAY THIS IS AN ISOLATED INCIDENT. THE INTERNET IS FULL OF COMMENTS ABOUT THIS PROBLEM. IT IS MY UNDERSTANDING THAT TUNDRAS HAD A RECALL ON THIS SAME ISSUE. WHY IS IT DIFFERENT FOR A RANGER? *TR

Mileage: 76,000

FOR THE SECOND TIME AS FAR AS I KNOW THE REAR FRAME (REAR SPRING SHACKLES AND SPEAR TIRE HOLDER SPECIFICALLY) HAVE AND ARE BEING REPLACED BECAUSE THEY HAVE RUSTED AND THEY TORE APART. AS I WAS DRIVING I HIT A REGULAR BUMP IN THE ROAD. I WAS DRIVING ABOUT 35 TO 45 MPH ON THE WAY TO WORK. WELL IT SOUNDED LIKE IT HIT PRETTY HARD, AS I WAS DRIVING I NOTICED THE TRUCKS PERFORMANCE WAS LACKING. SO, WENT TO WORK, GOT OUT OF WORK AND ON THE WAY BACK HOME I NOTICED THE SAMETHING WITH THE PERFORMANCE OF THE TRUCK. IT WAS LACKING IN A BIG WAY. AS I WAS PULLING INTO THE DRIVEWAY I HEARD A LARGE CLUNK SOUND. THE NEXT DAY I HAD A PRIOR APPOINTMENT AT MY TRANSMISSION SHOP. AS THE MECHANICS PUT IT ON THE LIFT "THE REAR AXLE DROPPED TO THE FULL EXTENT OF THE SHOCK ABSORBER AND BUSTING THEIR SEALS. BECAUSE THE SHACKLE BROKE IT WAS CAUSING THE AXLE TO TWIST WHILE I WAS DRIVING GIVEN THE TRUCK THE BAD PERFORMANCE, BAD STEERING, AND GIVING THE TRANSMISSION A PULSATING AFFECT. ALSO THE ENGINE LOST THE POWER GIVING THE TRUCK RESISTANCE AND USING MORE GAS. SO I AM REPLACING BOTH SHACKLES, BOTH SHOCK ABSORBERS, AND THE SPEAR TIRE MECHANISM. AT THE SAME TIME I WILL BE SANDING THE FRAME DOWN, AND COATING ALL PARTS (CLEANING AND COATING PARTS) WITH BEDLINER COATING TO HOPEFULLY STOP THE RUST. THE PARTS THAT I AM REPLACING ARE ALSO REPLACEMENT PARTS BECAUSE THEY ARE BOLTED ON TO THE FRAME INSTEAD OF RIVETED LIKE THE ORIGINALS WERE. ALSO THE STEEL SEAMS TO BE THINNER IN THE REAR THAN THE FRONT AND MIDDLE. *TR

Mileage: 16,500

I TRIED TO GET MY 99 RANGER INSPECTED WHEN THEY PUT IT ON THE LIFT A BIG CHUNK OF THE FRAME FELL TO THE GROUND .UPON FURTHER INSPECTION THERE WERE HOLES IN THE RIGHT SIDE FRAME NEXT TO THE REAR SPRING SHACKLES AND THE GAS TANK STRAPS WERE RUSTED OUT OF THE FRAME .THE GARAGE OWNER TAPED THE FRAME WITH A BALL PEEN HAMMER AND FOUND MORE HOLES ON THE LEFT SIDE AND THE RIGHT FRONT UNDER THE AIR CONDITIONER .I COULD NOT DRIVE THE TRUCK HOME IT WAS SO UNSAFE I CAN'T BELIEVE THE FRAME DID NOT BRAKE WHEN I WAS DRIVING IT .IF I WAS TO GET INTO AN ACCIDENT WITH THE TRUCK IN THAT CONDITION THE FRAME WOULD HAVE CRUMPLED UP LIKE TIN FOIL .READING THE COMPLAINTS HERE I'M NOT ALONE .THE TRUCK WAS TAKEN CARE OF WASHED ALL THE TIME IF FORD IS GOING TO SELL TRUCKS IN NEW YORK THEY BETTER BE SAFER .I WILL NEVER BUY ANOTHER FORD . *TR

Mileage: 118,000

I NOTICED A HOLE IN THE REAR OF MY TRUCK BED. UPON FURTHER INSPECTION I FOUND SPRING SHACKLES AND FRAME MOUNTS WERE RUSTED AWAY AND NOT HOLDING THE SPRINGS ANYMORE. THEY WERE COMING THROUGH MY TRUCK BED! THIS MADE MY TRUCK UNSAFE TO DRIVE. THE REST OF MY TRUCK IS IN VERY GOOD SHAPE. THIS KIND OF RUST IS NOT NORMAL AND IS NOT SAFE! AS I CHECKED ON THE INTERNET I'VE FOUND THAT I'M NOT THE ONLY ONE THAT HAS HAD THIS PROBLEM WITH THE 1999 FORD RANGER! *TR

WHILE DRIVING ON THE HIGHWAY, I WAS HAVING DIFFICULTY STEERING. THE CAR WAS PULLING TO THE LEFT AND I HAD TO PULL OVER BECAUSE IT WAS TOO DIFFICULT TO MANAGE. UPON INSPECTION, THE RIGHT FRONT TIRE WAS TOED-IN AND THE UPPER TIRE STABILIZER ARM BROKE AWAY FROM THE FRAME AT THE BRACKET. THE BRACKET ATTACHING THE ARM TO THE FRAME HAD SNAPPED. THE FRAME ITSELF JUST BELOW THAT BRACKET WAS CRACKED WITH SEVERE ROT ON BOTH SIDES. THE REST OF THE TRUCK IS IN PERFECT CONDITION EXCEPT FOR THE FRAME. I WAS TOLD THAT THIS CANNOT BE FIXED. *TR

Mileage: 186,000

I NOTICED HEAVY RUST SCALE ON GROUND AND INSPECTED TO SEE MY SPARE TIRE WAS MISSING, THERE IS A LARGE HOLE RUSTED ALL THE WAY THRU THE FRAME IN FRONT OF THE LEFT REAR SPRING SHACKLE AND A CRACK IN THE FRAME IN FRONT OF THE FRONT SHACKLE ALMOST ALL THE WAY AROUND THE CHANNEL. FURTHER INVESTIGATION SHOWED ALL CROSS MEMBERS, GAS TANK STRAP AND BED SUPPORTS ARE SEVERELY RUSTED AND THE RIGHT SIDE FRAME RAIL FOLLOWING SUIT WITH THE LEFT FRAME RAIL. THE REMAINDER OF THE TRUCK IS IN VERY GOOD CONDITION THIS SHOULD NOT HAPPEN TO A TRUCK WITH THIS AGE AND MILEAGE. *TR

Mileage: 161,120

TL* THE CONTACT OWNS A 1999 FORD RANGER. THE CONTACT STATED THAT THE BOLTS BEHIND THE REAR WHEELS THAT WERE CONNECTED TO THE BED OF THE VEHICLE WERE COMPLETELY RUSTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR A ROUTINE INSPECTION WHEN THE DEALER ADVISED HIM OF THE FAILURE. THE DEALER STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 102,000. *TR

THE FAR REAR RIGHT SPRING SHACKLE AND MOUNT FELL OUT OF THE TRUCK. I FELT THE BODY FALL AND HEARD A BANG AND IN THE MIRROR SAW SOMETHING FALL ON THE GROUND. AFTER INVESTIGATING I FOUND THAT THOSE PARTS HAD ROTTED OUT AND FELL OUT. THE SPRING WAS RESTING ON THE BOTTOM OF THE TRUCK BED. I'M A MECHANIC, SO I GOT THE PARTS TO FIX IT, BUT FOUND THAT AS I TOOK APART THE FRAME PARTS, THE FRAME HAD RUSTED THROUGH ON BOTH SIDES OF THE SPRING MOUNT. THE LEFT SIDE, THOUGH THE SHACKLE MOUNT HAD NOT ROTTED OFF YET, WAS IN BAD SHAPE. WHEN I GOT THE LEFT SIDE SPRING MOUNT OFF, THE FRAME WAS ROTTED THROUGH BEHIND IT AND HAD RUSTED THROUGH ON BOTH SIDES OF THE SPRING MOUNT. THIS ISN'T GOING TO LAST LONG. INFACT I'M LOOKING INTO MY OPTIONS FOR REPAIR. FORD SHOULD BE MADE RESPONSIBLE FOR THIS. THERE IS NO WAY A TRUCK FRAME SHOULD MELT LIKE THIS. TO REMOVE THE RIVOTS USED FROM THE FACTORY TO MOUNT THE FRAME PARTS, I USED AN AIR CHISEL. THE VIBRATION CAUSED MASSIVE AMOUNTS OF RUST FLAKES TO FALL OFF OF OTHER PARTS OF THE FRAME, SOME AN EIGHTH IN THICK AND THE SIZE OF A LARGE TIRE PATCH. THIS MAKES ME WONDER IF THE REST OF THE FRAME IS SAFE TO USE.! IF YOU GO TO A JUNK YARD YOU CAN FIND TRUCK FRAMES THAT ARE 40 YEARS OLD THAT DON'T HAVE THIS KIND OF ROT!!! PLEASE PRESS FORD TO DO SOMETHING ABOUT THIS...THANK YOU. *TR

Mileage: 126,000

I WAS DRIVING ON THE HIGHWAY AND NOTICED THAT THE STEERING WAS PULLING TO THE LEFT. AFTER A SHORT WHILE I COULD NOT MANAGE THE STEERING. WHEN I PULLED OVER IN THE BRAKEDOWN LANE I NOTICED THAT THE RIGHT FRONT TIRE WAS TOED IN. WHEN THE TOW TRUCK CAME WE NOTICED THAT THE FRAME WAS CRACKED AND ROTTED AT BOTH WHEEL MOUNTS AND THE THE RIGHT FRONT MOUNT WAS THE WORSE. WE ALSO NOTICED THAT THE MOTOR MOUNTS WERE ALL ROTTED AND THE OVERALL FRONT SECTION OF THE FRAME WAS ROTTED WHICH PREVENTED ANY REPAIR. *TR

Mileage: 189,341

STRUCTURE, FRAME RUSTED, FRONT BUMPER RUSTED FROM INSIDE. REAR SPRING SUPORT RUSTED. GAS FILLER DOOR RUSTED. *TR

Mileage: 102,000

SHACKLES, FRAME ,FRAME BRACKETS AND BUMPERS RUSTED . SHACKLE BRACKETS AND REAR FRAME BRACKETS BROKE INTO WHEN RAISING TRUCK ON LIFT. *TR

Mileage: 84,267

1999 FORD RANGER REAR FRAME SECTION ROTTED BEHIND REAR SHACKLE MOUNT. BROKE OFF AND CAUSED REAR AXLE TO BECOME DISCONNECTED FROM THE REAR FRAME SECTION. BUMPER FELL TO THE GROUND. *TR

Mileage: 167,822

FRAME RUSTED THROUGH NEAR SPRING HANGER REPLACED SPRING HANGERS NOW FRAME HAS SO MANY HOLES SPRING HANGERS MAY COME LOOSE. REAR BUMBER IS FALLING OFF. *TR

Mileage: 69,000

WE HAVE HAD NUMEROUS RANGERS AND EVERY ONE OF THEM HAS HAD A RUSTED FRAME!! WE CURRENTLY HAVE 2 A 1999 AND A 1998 AND BOTH FRAMES ARE RUSTED. WHY CAN FORD NOT MAN UP LIKE TOYOTA? TALK ABOUT A [XXX] COMPANY WHO WILL NOT ADMIT THEY SCREWED UP ON THESE FRAMES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

YOU GUYS SHOULD MAKE FORD MOTORS REPLACE EVERY SINGLE FRAME ON FORD RANGER PICK UPS. I HAVE ONE NOW THAT I AM TRYING TO FIX AND IT IS JUST INCREDIBLE THE AMOUNT OF RUST AND HOLES THAT ARE IN A TRUCK THAT IS BARELY TEN YEARS OLD. *TR

Mileage: 80,000

IT WAS REVEALED TO ME THAT MY BUMPER APPEARED TO BE FALLING OFF. A CLOSER INSPECTION SHOWED THAT THE REAR PORTION OF THE FRAME HAS ROTTED. THE BUMPER MOUNT HAS DETERIORATED AND NO LONGER SUPPORTS THE BUMPER. THE SHOCK MOUNTS APPEAR TO BE HAZARDOUS AS WELL. THE VEHICLE HAS BEEN GARAGE KEPT AND HAS NEVER BEEN INVOLVED IN A REAR END COLLISION. AS I HAVE RESEARCHED THIS PROBLEM ONLINE, IT SEEMS TO BE A MAJOR PROBLEM WITH THIS YEARS MODEL OF THE FORD RANGER. *TR *JS

Mileage: 115,651

1999 FORD RANGER WITH 130,000 MILES. LEAF SPRINGS RUSTED OUT (BOTH SIDES) AND MOUNTING BRACKETS ALSO RUSTED. WENT TO 3 AUTOBODY SHOPS AND NOBODY WOULD TOUCH IT. BUMPER JUST RUSTED OUT ON BOTH SIDES AND SPARE TIRE WELL IS COMPLETELY RUSTED. BUMPER AND SPARE CURRENTLY BEING HELD TOGETHER WITH 2, 1900 LB CHAINS. RANGER RUNS FINE JUST BODY FALLING APART. VERY CONCERNED TIRE, BUMPER MAY BECOME DISLODGED AND CAUSE FURTHER DAMAGE TO MYSELF OR OTHERS. GAS TANK ALSO RUSTED BUT NOT LEAKING SO FAR. *TR

Mileage: 127,000

TRUCK LOST BRAKES WHILE GOING DOWNHILL. FRAME CORROSION HAD CAUSED RIGHT SPRING HANGER TO FAIL, AND CORRODED BRAKE LINE BURST. I WAS ABLE TO PUMP THE BRAKE PEDAL AND AVOID AN ACCIDENT. BRAKE WARNING LIGHT CAME ON AFTER THE INCIDENT. MECHANIC PUT THE TRUCK ON A LIFT, AND IDENTIFIED SEVERE CORROSION TO THE BRAKE LINES, DIFFERENTIAL, FRAME, AND SEVERAL OTHER UNDERCARRIAGE COMPONENTS. TRUCK HAD BEEN UNDERCOATED AND WASHED REGULARLY, AND HAS LESS THAN 105,000 MILES. MECHANIC SUGGESTED ALL NEW BRAKE LINES, TOTAL FRAME, AND REAR END REPLACEMENT. *TR

Mileage: 104,000

EXCESSIVE UNDER CARRIAGE/FRAME RUST. SPARE TIRE MOUNT RUSTED COMPLETELY THROUGH AND FELL OFF AT 30,000 MILES. LADDER FRAME CROSS MEMBERS COMPLETELY RUSTED THROUGH AND FELL OFF AFTER 35000, FRONT PART OF LADDER FRAME WHERE ENGINE MOUNTS IS RUSTED 80% THROUGH BY 41,000 MILES. MOST OF FRAME IS HEAVILY DAMAGED BY EXCESSIVE RUST. UPPER BODY LOOKS FINE, NO RUST ON MAIN BODY, ONLY UNDER CARRIAGE AND FRAME. VEHICLE IS ABOUT TO COLLAPSE. *TR

Mileage: 30,000

REAR LEAF SPRING SUPPORTS COMPLETELY RUSTED AWAY. BEFORE REPLACEMENT SUPPORT BRACKETS COULD BE MOUNTED, STEEL PLATES HAD TO BE WELDED TO THE FRAME FOR SUPPORT BECAUSE PART OF THE FRAME HAD RUSTED AWAY ALSO. *TR

Mileage: 98,500

MY GRANDFATHER BOUGHT THIS TRUCK NEW AND REPLACED THE REAR SPRING HANGERS IN10/2009. I HAVE THE TRUCK NOW. AFTER PRESSURE WASHING THE FRAME I NOTICED THE FRAME CROSS MEMBER HAS A HOLE IN IT AT THE MUFFLER. FRONT SPRING HANGERS ARE EXTREMELY RUSTY AS IS THE SHOCK MOUNTS. THE FRAME FROM THE CAB TO REAR IS EXTREMELY RUSTY AND THIN LOOKING. THE SPARE TIRE HOLDING AREA HAS A HOLE IN IT. THIS TRUCK HAS NEVER BEEN OFF ROAD OR IN THE MUD. VERY LITTLE TIME ON THE ROAD IN THE WINTER. THE BODY IS IN EXCELLENT SHAPE AS IS THE FRAME FROM CAB TO FRONT. TRUCK HAS ONLY 98,000 MILES ON IT NOW. COULD THIS BE A FRAME ISSUE AS IT WAS WITH TOYOTA? SAME MANUFACTURE MAYBE? JUST A THOUGHT BECAUSE THEY ARE PLENTY OF THE SAME COMPLAINTS IN THE SAME AREA.

Mileage: 80,000

FIRST FAILURE WAS WHERE LEAF SPRINGS ATTACH TO FRAME (REAR SHACKLES) FAILED DUE TO RUST AND PUT HOLE IN TRUCK BED. REPLACED PARTS. SECOND FAILURE IS WHEN FILLING TANK WITH FUEL; GAS HAS STARTED TO RUN OUT ON THE GROUND AT THE GAS STATION. JUST RECEIVED FILLER NECK TODAY TO REPLACE CURRENT RUSTED ONE. WHILE UNDER VEHICLE NOTICED TANK STRAP IS HANGING LOOSE NOT ATTACHED DUE TO CONNECTION POINT RUSTED OFF (SIMILAR FAILURE TO NHTSA RECALL CAMPAIGN #11V385000 FUEL TANK STRAP FAILURE). ALSO NOTICED SEVERE RUST LIKE LITTLE OR NO RUST INHIBITOR WAS APPLIED TO FRAME AND COMPONENTS. SHIELD ABOVE MUFFLER IS ALMOST NON-EXISTENT, FRAME CROSS MEMBER IS FLAKING AWAY DUE TO RUST. I AM NOT QUALIFIED TO PROVIDE FULL DETAILS OF PROBLEMS OR CAUSE BUT RUST IS BECOMING A SAFETY ISSUE WITH THIS VEHICLE. CONTACTED FORD AND THEY SAY VEHICLE IS NOT PART OF RECALL. *TR

Mileage: 153,000

THE SHACKLE ON THE LEFT REAR SPRING TOTALLY BROKE OFF OF VEHICLE. THE SHACKLE ON THE RIGHT SIDE IS ALMOST TOTALLY DETACHED. THERE IS NO WAY TO ATTACH NEW SHACKLES BECAUSE THE TRUCK FRAME IS TOTALLY ROTTED AWAY. ALSO MUCH TO MY AMAZEMENT THE SPARE TIRE WHICH WAS SUSPENDED UNDERNEATH THE PICKUP BED IS GONE. WHERE IT WAS ATTACHED IS ALL ROTTED AWAY SO AT SOME POINT IT JUST FELL OFF WHEN WE WERE DRIVING, DON'T KNOW WHERE OR WHEN. TODAY I TALKED TO THE SERVICE DEPT OF THE FORD DEALER WHERE THE TRUCK WAS PURCHASED AND FORD IS NOT DOING ANYTHING ABOUT THIS. THEY SAID WE HAVE THIS PROBLEM WITH SHACKLES ALL THE TIME. THEY RUST OUT. MY MECHANIC, WHO DISCOVERED THE PROBLEM SAID HE SEE THIS A LOT ON ALL MODELS OF FORDS PICKUPS. MY BROTHER IN LAW HAS A TOYOTA TACOMA PICKUP WHICH JUST FAILED A SAFETY INSPECTION BECAUSE OF A ROTTED FRAME. TOYOTA IS REPLACING HIS FRAME FREE OF CHARGE. I FEEL THAT IS WHAT FORD SHOULD BE FORCED TO DO. I THANK GOD THE OTHER SHACKLE DIDN'T GIVE WAY WHILE MY WIFE WAS DRIVING IT ON THE HIGHWAY AND HAVE A SERIOUS ACCIDENT.

Mileage: 124,279

REAR SPRING SHACKLES AND REAR SPRING HANGERS RUSTED OUT ALLOWING REAR OF SPRING TO BECOME DISCONNECTED FROM THE VEHICLE. LOSS OF REAR SUSPENSION STABILITY LOSS OF CONTROL. *TR

Mileage: 90,000

WHILE DRIVING ON HIGHWAY NOTICED SOMETHING BOUNCING DOWN THE ROAD IN MIRROR THAT APPEARED TO HAVE COME OFF OF MY VEHICLE. UPON LATER INSPECTION NOTICED THAT LEFT FRONT SWAY BAR LINK HAD FAILED. STEERING ARM WAS STILL ATTACHED TO LINK, BUT PORTION OF LINK ATTACHED TO SWAY BAR WAS COMPLETELY MISSING.

Mileage: 85,750

1999 FORD RANGER EXPERIENCING PROBLEMS WITH WHEEL BEARING FAILURE.***NO ANSWER REQUIRED***. *MR THE CONSUMER EXPERIENCED A FRONT END VIBRATION AFTER THE BEARING FAILED. *JB

Mileage: 56,000

THE UPPER AND LOWER BALL JOINTS WORE OUT PREMATURELY. CONSUMER NOTICED THAT THERE WAS NO GREASE FITTINGS IN THEM. *AK.....*AK

Mileage: 32,234

THE UPPER AND LOWER BALL JOINTS WORE OUT PREMATURELY. CONSUMER NOTICED THAT THERE WAS NO GREASE FITTINGS IN THEM. *AK.....*AK

Mileage: 32,234

CONSUMER COMPLAINED ABOUT FRONT END NOISE. TOOK VEHICLE TO DEALER, AND DEALER REPLACED UPPER CONTROL ARM. ALSO, A BULLETIN WAS ISSUED ON THIS PROBLEM. *AK

Mileage: 49,000

WHILE DRIVING RIGHT FRONT WHEEL CAME COMPLETELY OFF THE VEHICLE AT 40 MPH DUE TO A DEFECTIVE WHEEL BEARING. *AK

ON OR ABOUT NOVEMBER OF 2002 IT WAS FOUND THAT MY FRONT CALIPERS HAD BECOME SEVERELY WARPED, LARGE PORTIONS OF STEEL WERE GOUGED OUT AND ROTOR WAS REPLACED BY THE DEALER UNDER WARRANTY. THIS DEFECT LED TO CONSEQUENTAL DAMAGE BY WEARING OUT THE UPPER BALL JOINTS PREMATURELY. THE VEHICLE ONLY HAS 45,000 MILES AND AT THE TIME OF THE REPAIR HAD JUST OVER 37,500 MILES. *AK

Mileage: 37,500

THE VEHICLE MADE A SQUEAKING NOISE DUE TO THE LOWER BALL JOINT HAD WORE OUT PREMATURELY. *JB

Mileage: 40,000

I OWN A 99 FORD RANGER THAT HAS A PROBLEM OF EXCESSIVE OUTERWEAR ON THE RIGHT FRONT TIRE. I'VE REPLACED THE TIRE TWICE AND TRIED TO HAVE THE VEHICLE ALIGNED BY BIG O TIRE IN VALLEJO, CA. I WAS TOLD THAT EVERY OTHER FORD REQUIRES AN AFTER MARKET CAMBER KIT INSTALLATION IN ORDER TO PERFORM A FRONT-END ALIGNMENT. I VISITED WILSON-CORNELIUS FORD IN VALLEJO, WHO CONFIRMED THAT IT IS A COMMON PROBLEM. I CALLED FORD'S CUSTOMER SERVICE WHO WAS NO HELP, BECAUSE THE THREE YEAR MANUFACTURER WARRANTEE HAS EXPIRED. ADDITIONAL, FORD REFUSES TO LOOK AT THE VEHICLE AT THEIR OWN EXPENSE. I CONTENT THAT THIS IS A MANUFACTURER DEFECT AND SHOULD BE REPAIRED AT FORD'S EXPENSE. ON THE POSITIVE SIDE, I WAS ABLE TO PURCHASE A CAMBER KIT (PART # FMC F5TZ3B236A), WHICH ARE MERELY TWO IDENTICAL SPECIALLY DESIGNED BOLTS THAT COST $41.98/EACH. THIS JUST DOES NOT SEEM RIGHT, NOR SHOULD ONE EXPECT TO INCUR COSTS TO MAKE A VEHICLE ADHERE TO A MANUFACTURER SPECIFICATION. PLEASE HELP. THANK YOU.

Mileage: 8,000

FRONT END KNOCKS AT IDLE SPEED. TOOK TO DEALER 3 TIMES THEY SAY IT IS CHARACTERISTIC FOR THIS MAKE & MODEL. CALLED FORD, TOOK TRUCK BACK TO DEALER AGAIN THAT IS WHEN THEY CALLED IT CHARACTERISTIC. BUT TOLD DEALER & FORD JUST STARTED DOING THIS. BOTH SAID THEY WERE GOING TO DO NOTHING, NOISE STILL THERE. ALL I WANT IS IT FIXED, I FEEL IT IS NOT NORMAL FOR ANY CAR/TRUCK TO HAVE FRONT END KNOCK AT IDLE SPEED. *****DIMS 11 IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS******769320. *AK *JB

Mileage: 34,300

CONTACTED FORD AND THEY WILL NOT LOOK AT TRUCK SINCE IT IS OUT OF WARRANTY 3/36MONTH.NO SAFETY DEFECT LISTED. *AK

WHILE DRIVING, VEHICLE SWERVES OR PULLS TO THE LEFT OVER ROAD. MORE SPEED THE WORSE IT GETS. *AK VEHICLE ORIGINALLY BROUGHT IN DEALER FOR DOG TRACKING, DEALER REPLACED REAR SPRINGS AND BUSHINGS, BUT CONSUMER STATES DOG TRACKING STILL EXISTS, DEALER COULD NOT FIND ANYTHING FURTHER AND STATES THAT VEHICLE IS WELL WITHIN SPECS. *TT

WHILE DRIVING ON HIGHWAY AND WHEN MAKING A CERTAIN STOP OR TURING THERE IS A CLUCKING NOISE COMING FROM UNDERNEATH OF VEHICLE. *AK

WHILE DRIVING 45-50 VEHICLE VIBRATES VERY HARD WHICH MAY CAUSE LOSS OF CONTROL. DEALER REPLACED PART OF TRANSMISSION/TIRES, BUT WON'T REPLACE WHEEL WHICH MAY BE CAUSING THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. *AK

VEHICLE WANDERS ALL OVER THE ROAD, ALSO CAN FEEL A CONSTANT VIBRATION. *JG

WHILE DRIVING HIT A BUMP AND LOST CONTROL, TOOK TO DEALER, AND THEY COULD NOT DUPLICATE THE PROBLEM. ONE MONTH LATER, PROBLEM OCCURRED AGAIN. TOOK TO DEALER AGAIN THEY SAID WHEELS WERE PULLING TO THE LEFT. DEALER TOLD CONSUMER TO TAKE SOME WEIGHT OUT THE TRUCK. CONSUMER SAID IF GOING OVER A SPEED BUMP ENTIRE CAR SHAKES UNCONTROLLABLY. *AK

BRAKES AND BEARINGS WORK COMPLETED. *SLC

FRONT LEFT DRIVER'S SIDE WHEEL COLLAPSED INWARD WHILE PULLING INTO DRIVEWAY. DEALER / MANUFACTURER WERE CONTACTED. *AK

SUSPENSION ALIGNMENT--DEALER HAS MADE TWO ATTEMPTS TO CORRECT CONSTANT WANDERING OF VEHICLE TOWARD LOW SIDE OF ROAD. UNABLE TO CORRECT, VEHICLE DRIFTS UNLESS CONSTANTLY CORRECTED. BRAKE SYSTEM--FIRST REPORTED TO DEALER AS SEVERE GRABBING/PULLING TO RIGHT (VEHICLE WILL ALMOST CHANGE LANES). ROTORS MACHINED, THEN PULLED LEFT. DEALER TRIED SAME REMEDY AGAIN, RETURNED TO PULLING RIGHT. LAST ATTEMPT, TRIED TO CORRECT SUSPENSION/FRONT-END ALIGNMENT PROBLEMS TO ALLEVIATE BRAKING PROBLEMS. HEAD LIGHTS--FAILED WITHOUT WARNING AT INTERSTATE SPEED. RUNNING LIGHTS CONTINUED TO OPERATE. SPONTANEOUSLY TURNED ON AGAIN AFTER ABOUT THREE MINUTES. DEALER UNABLE TO DIAGNOSE/CORRECT FAILURE. *AK

WHEN APPLYING BRAKES VEHICLE WOULD PULL TO LEFT OR TO RIGHT. WHEN DRIVING AT HIGHWAY SPEEDS CONSUMER WOULD HEAR LOUD/WEIRED RUBBING NOISE. CONSUMER TOOK VEHICLE TO DEALER. DEALER FELT NOISE WAS COMING FROM DRIVELINE AND FRONT END ALIGNMENT, BUT COULD NOT CORRECT DEFECT. *AK

PULLS TO LEFT AT TIMES. CAN CAUSE LANE CHANGE AT FREEWAY SPEED. DEALER CAN'T FIX. *AK

VEHICLE VERY UNSTABLE(BOUNCES AROUND ALL OVER THE ROAD WHEN DRIVING ON ROUGH ROAD). VEHICLE ALSO LUNGES AT SLOW IDLE SPEEDS IN 1ST & 2ND GEAR. *AK

SHOCKS WERE WORE OUT AT 12000 MILES CAUSING TIRES TO CHAT AS YOU DROVE DOWN THE ROAD, DEALER REPLACED SHOCKS AND ROTATED TIRES SHOCKS WENT OUT AGAIN AT 15000 MILES NOW WAITING TO HAVE THEM REPLACED AGAIN ONE SHOCK IS LEAKING OIL.

REAR END IS THREE QUATERS OF AN INCH OFF LINE. WHEN THE BRAKES ARE APPLIED VEHICLE PULLS TO THE LEFT. DEALERS HAS REPAIRED THE VEHICLE SEVERAL TIMES. ALSO, TRANSAXLE SEAL IS LEAKING. MANUFACTURER HAS BEEN NOTIFIED. *AK

WHILE DRIVING OVER BUMPS THE VEHICLE JUMPS TO THE LEFT SIDE SEVERLY WHICH MAY RESULT A CRASH. ALSO FRONT TIRES ARE HAVING ABNORMAL WEAR AND TEAR. DEALER IS AWARE OF THE PROBLEM, BUT CANNOT DETERMINE THE CAUSE OR HAVE A SOLUTION FOR THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. *AK

WHILE DRIVING AT 60 MPH VEHICLE VIBRATES VIGOROUSLY WHICH MAY RESULT A LOSS OF VEHICLE CONTROL. DEALER REPLACED REAR END OF VEHICLE, BUT PROBLEM STILL OCCURRING. DEALER CANNOT DETERMINE THE CAUS EOF THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. *AK

WHEN DRIVING OVER 50 MPH VEHICLE STARTS TO SHAKE AND CONSUMER LOSES CONTROL OF VEHICLE. *AK

SUSPENSION OUT OF ALIGNMENT. MJS

CONSUMER SAYS WHEN MAKING LEFT AND RIGHT TURNS THE POWER STEERING STICKS AND MAKES IT HARD TO RETRACT THE WHEEL. CONTINUED PROBLEMS WITH SUSPENSION, UNUSUAL NOISES AND BUMPY RIDE. *AK.ET.