2004 FORD RANGER Structure Problems

Rear frame rusted and rotted..spare tire fell off entire evap can also..both sides rear frame shock and spring shackles rotted and broke off. Entire frame rotted and broke while driving ..on rear driver side frame rusted rotted and broke ..value of truck is not worth what estimates are ..gas tank hangers rusted and rotted many other pieces of frame rusted rotted through..truck is now unsafe to drive an probably unsellable due to broken rusted rotted frame..

The contact owns a 2004 Ford Ranger. The contact stated while doing routine maintenance at a local mechanic, the mechanic found that the rear sub-frame assembly was rusted through and needed to be replaced. The vehicle was not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 04V331000 (Structure) however, the VIN was not included. The manufacturer was informed of the failure and informed the contact that the vehicle was not included in the recall. The failure mileage was approximately 129,000.

Mileage: 129,000

RUSTED AND ROTTEN OUT FRAME. THE REST OF THE VEHICLE IS IN REAL GOOD CONDITION. FRAME IS CRACKED THRU IN A FEW PLACES AND CLOSE TO WERE THE SPRING IS MOUNTED TO THE FRAME.

2004 FORD RANGER EDGE HAS RUSTED ROTTEN REAR FAME, SHACKELS RUSTED, SHOCKS RUSTED, BED RUSTED UNDER BEDLINER BUMPER FELL OFF. BEAUTIFUL TRUCK WITH NO BODY RUST. THE REAR SECTION OF FRAME IS ROTTEN. FRAME WILL CERTAINLY BREAK DOWN TO MAKE THE TRUCK NOT DRIVEABLE SHORTLY. IT IS IMPOSSIBLE TO FIND A USED FRAME IN THE SALVAGE YARD, BECAUSE THEY ARE ALREADY RUSTED THROUGH. HELP!!!!

Mileage: 212,000

THE FRAME BROKE IN TWO ON SAID VEHICLE.

Mileage: 119,000

INCREDIBLE AMOUNTS OF PREMATURE RUST ON FRAME AND SUSPENSION PARTS, SHACKLE BRACKETS RUSTED AWAY COMPLETELY AND HAD TO BE REPLACED. FRAME IS RUSTING AT AN UNPRECEDENTED PACE!?

Mileage: 83,000

TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS AT SOLOMON FORD, LLC (502 NATIONAL PIKE W, BROWNSVILLE, PA 15417 (724) 785-5500), THE TECHNICIAN INFORMED THE CONTACT THAT THE SUBFRAME WAS RUSTED AND MAY DETACHED FROM THE VEHICLE SOON. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.

Mileage: 21,000

TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS AT SOLOMON FORD, LLC (502 NATIONAL PIKE W, BROWNSVILLE, PA 15417 (724) 785-5500), THE TECHNICIAN INFORMED THE CONTACT THAT THE SUBFRAME WAS RUSTED AND MAY DETACHED FROM THE VEHICLE SOON. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.

Mileage: 21,000

EXCESSIVE FRAME RUST. RAILS AND CROSS BED SUPPORTS. 2 OF THE BED MOUNTING BOLTS RUSTED OFF AND ALSO THE RUST ATE THROUGH WHATEVER WAS HOLDING THE SPARE TIRE ON. NOT SURE WHERE OR WHEN THAT FELL OFF. I WAS READING MANY ARTICLES ABOUT THE 04 FORD RANGER WITH THE SAME FRAME ROT ISSUES.

THE ENTIRETY OF THE FRAME AND UNDERCARRIAGE IS COVERED IN RUST AND CORROSION. THE SIDES OF THE BED OF THE TRUCK ARE RUSTING OUT. THE FRONT SUSPENSION IS RUSTED THROUGH. THIS TRUCK HAS NEVER BEEN FLOODED OR EXPOSED TO EXCESS WATER OR MOISTURE ASIDE FROM RAIN.

Mileage: 226,000

HEAVY RUST ON THE FRAME. TODAY THE SPARE TIRE FELL OFF WHILE GOING DOWN THE HIGHWAY DUE TO HEAVY RUST. NO INJURY TO PROPERTY OR PEOPLE FROM THE INCIDENT.

Mileage: 60,000

FRAME RUSTED OUT ON PASSENGER SIDE BEHIND FRONT LEAF SPRINF MOUNT. ALSO THE CROSS MEMBER HOLDING FUEL TANK WHERE IT CONNECTS TO THE FRAME IS RUSTED OUT. ITS ONLY THE BACK HALF OF THE TRUCK RUSTING OUT THIS BAD. WHERE THE SPARE TIRE GOES IS ALSO COMPLETLY RUSTED OUT AND FELL OFF. THIS HAPPENED WHILE DRIVING ON SMOOTHLY PAVED ROADS TO AND FROM WORK

Mileage: 246,000

REAR LEAF SPRING BRACKET RUSTED OFF FROM FRAME, WHILE LOADED AND ON ROUTE HOME FROM TREE NURSERY. REAR FRAME SECTIONS ROTTED AND CRACKED ON VEHICLE WITH ONLY 72000 MILES, FOUND WHEN TRYING TO REPLACE BLOWN BRAKE LINE IN REAR DRIVERS SIDE (RUSTED).

WHILE DRIVING, THE SPARE TIRE STARTED TO FALL OFF DUE TO RUSTING AWAY OF THE MOUNTING APPARATUS. LUCKILY I NOTICED IT WHEN I STOPPED FOR GAS (IT WAS HANGING BY ONLY A BIT OF STILL ATTACHED RUSTED METAL BELOW THE TRUCK) SO I CUT THE CABLE WITH SOME BOLT CUTTERS TO REMOVE THE SPARE AND PREVENT AN ACCIDENT WHILE DRIVING. DRIVER'S SIDE CAB MOUNT SEPARATED DUE TO EXCESSIVE RUST. DRIVER'S SIDE FLOOR BOARD FELL OUT DUE TO EXCESSIVE RUST - MY FOOT WENT THROUGH THE FLOOR. FRAME CRACKED NEAR REAR SHACKLE DUE TO EXCESSIVE RUST. FRAME CRACKED NEAR DRIVER'S SIDE REAR SHOCK MOUNT DUE TO EXCESSIVE RUST - EXCESSIVE PLAY AND NOISES CAUSED BE TO DISCOVER THIS. BED RUSTED COMPLETELY OUT - ABOVE WHEEL WELLS ON BOTH SIDES, CENTER OF BED, FRONT CORNERS. IT CAME OFF THE TRUCK IN SEVERAL PIECES AFTER I PUT MY FOOT RIGHT THROUGH THE CENTER. THE FRAME RUST ISSUES AND SPARE TIRE FALLING OFF COULD BE SERIOUS SAFETY PROBLEMS. I HAVE DRIVEN A NUMBER OF VEHICLES FOR MANY YEARS AND NEVER EXPERIENCED RUST ISSUES LIKE ON THIS TRUCK. WAY BEYOND WHAT IS REASONABLE AND EXPECTED.

Mileage: 180,000

REAR END OF FRAME COMPLETELY RUSTED OUT. LEAF SPRINGS BROKEN. SPRING SHACKLE BROKE OFF. BROUGHT THE TRUCK IN FOR SERVICE UNAWARE THERE WAS SO MUCH IRREPARABLE DAMAGE. DAMAGES OCCURRED WHILE DRIVING ON A CITY STREET. PIECES OF THE BODY WERE MISSING. EXACT DATE DAMAGES OCCURRED IS UNKNOWN.

I PURCHASED THIS 2004 FORD RANGER THIS PAST WINTER IN HOPES TO PULL MY BOAT TO THE LAKE WITH IT. YESTERDAY. I PULLED MY SMALL BASS BOAT TO LAKE CHICKAMAUGA AND BACK WHICH IS ABOUT A 40 MINUTE DRIVE. IT WAS A STRAIGHT DRIVE ON A HIGHWAY ONLY GOING 50 MPH. WHEN I GOT BACK MY HITCH, BUMPER AND ALL WAS HANGING. THE FRAME IS SO RUSTED IT BROKE IN HALF. HAD I NOT INSTALLED AN AFTER MARKET HITCH ON THIS TRUCK MY WHOLE BUMPER WOULD HAVE COME OFF ALONG WITH THE BOAT THAT WAS ATTACHED AND PROBABLY WOULD HAVE KILLED WHOEVER WAS BEHIND ME OT NOT MYSELF. I CANT IMAGINE WHAT WOUOD HAVE HAPPENED OF I WAS ON THE INTERSTATE AT HIGHER SPEEDS.THE ONLY THING HOLDING IT ALL TOGETHER WAS THE FRONT BOLT ON THE HITCH WHEN I GOT HOME. THIS IS ABSOLUTELY UNSAFE AND I KNOW THERE ARE MANY OTHERS THAT HAVE PROBLEMS WITH THIS SAME VEHICHLES FRAME THAT HAVE NOT TAKEN THE TIME OIT OF THEIR BUSY SCHEDULE TO COMPLAIN ABOUT.

Mileage: 85,000

TOOK TRUCK FOR STATE INSPECTION AND GARAGE CALLED 2 DAYS LATER,SAID THEY CAN'T INSPECT IT DUE TO FRAME BEING CRACKED IN 2 PLACES AND FRAME IS ROTTED AWAY. TRUCK ONLY HAS 66930 MILES ON IT AND LOOKS IN VERY GOOD SHAPE. I WAS SHOCKED WHEN THEY POINTED OUT THE PROBLEMS. I CALLED FORD MOTOR CO AND THEY WON'T DO ANYTHING ABOUT IT. TRUCK HAS BEEN DRIVEN UP TO THAT POINT.

Mileage: 66,930

I WAS DRIVING DOWN THE ROAD WHILE WORKING ONE DAY LAST SUMMER AND THE REAR CROSSMEMBER COMPLETELY ROTTED AWAY AND FELL OFF MY TRUCK TAKING THE EVAP EMISSIONS CANISTER WITH IT WHEN IT WENT I WAS GOING 45 AND LUCKILY I SAW IT AND HEARD IT AND NO ONE WAS BEHIND ME BUT THE FRAME IN THIS VEHICLE HAS COMPLETELY ROTTED AWAY THE CROSSMEMBERS ARE ALL CRACKED OR GONE THE FRAME RAILS ARE SPLIT AND IT WILL NOT PASS INSPECTION THIS YEAR AND I ALSO LOST THE STAIR TIRE MOUNT WHILE DRIVING THE REAR EXHAUST AND THE CATALYTIC CONVERTER HEAT SHIELD ALL WHILE DRIVING SOME ON THE HIGHWAY I AM DISABLED RECENTLY AND CAN'T AFFORD A NEW VEHICLE OR REPAIRS AND THERE'S NO REASON THIS SHOULD HAVE HAPPENED AT ALL I NEED THE VEHICLE TO MAKE MY PHYSICAL THERAPY AND DOCTORS APPOINTMENT WEEKLY PLEASE HELP IF YOU CAN THANK YOU

Mileage: 240,000

WHILE DRIVING ALONG A SECONDARY ROAD NEAR MY HOME THE LEFT REAR FRAME RAIL IN FRONT OF THE REAR SPRING BROKE IN HALF CAUSING THE TRUCK TO SWERVE INTO THE OTHER LANE, NO ONE WAS HURT JUST SHAKEN UP, THE FRAME RAIL IS REALLY RUSTED. ALSO THE RIGHT SIDE FRAME RAIL IS CRACKED AND RUSTED..

Mileage: 140,000

AS I WAS DRIVING, THE BUMPER AND SPARE TIRE CAME OFF ALMOST CAUSING AN ACCIDENT.

Mileage: 72,000

THE REAR BUMPER FRAME HAS RUSTED OUT AND DETACHED FROM VEHICLE. LOADING BRUSH INTO TRUCK BED, STEPPED ON BUMPER, AND IT COLLAPSED. CHECKING THE REAR FRAME, SPRINGS, AND SUSPENSION SHOWS EXTENDED RUST, MAKING THE VEHICLE UNSAFE TO DRIVE.

Mileage: 91,500

THE FRAME AND UNDERBODY INCLUDING BED AND BED CROSSMEMBERS ARE RUSTED SO BADLY THAT THE SPARE TIRE FELL OUT! THERE ARE LARGE HOLES IN THE FRAME AND BED. THIS IS A KNOWN ISSUE AND THERE ARE MANY DISCUSSIONS AND PHOTOS ABOUT IT ONLINE. LUCKILY THE VEHICLE WASN'T MOVING QUICKLY WHEN THE TIRE FELL OUT.

Mileage: 125,000

EXTREME RUST INCLUDING FRAME, BED SIDE PANELS, BED FLOOR, TAILGATE. NOTICED SPARE TIRE FELL FROM UNDERSIDE DUE TO RUST OF FRAME. LUCKILY FOUND WHILE VEHICLE WAS PARKED. FRAME CROSS MEMBERS ALMOST RUSTED THROUGH. INSPECTION MAY NOT PASS SOON.

Mileage: 162,000

PAINT IS CHIPPING AND FADING ON VEHICLE.KEEPS GETTING WORSE EVERY DAY.I ALSO HAD A 1995 RANGER AND IT DID THE SAME THING AND IT WAS COVERED SO WHY WOULDNT THIS RANGER?

Mileage: 80,000

THE REAR SPRING SHACKLE, BRACKET RUSTING AND FALLING OFF. THE GAS TANK BRACKETS RUSTED AND CAUSIING TANK TOO FALL OFF THE REAR FRAME ROTTED MAKING TRUCK UNSAFE FOR DRIVING ON THE ROAD THE FRONT FRAME OF TRUCK IS OK NO PROBLEM.IT IS JUST THE REAR FRAME RUSTED THRU.THE TRUCK WAS MAKEING A THUMPING NOISE AND WHEN I STOPED I HAD NOTICED THAT THE SPRINGS HAD BROKE THRU BED OF TRUCK PROMPTING ME TOO INSPECT FURTHER WHY THIS HAPPENED AND THAT IS WHEN I FOUND ALL THE OTHER ISSUES WITH THE FRAME.AND THE TANK.

Mileage: 78,511

EXTENSIVE UNDERCARRIAGE RUST. FRAME BROKE BED ROTTED FRAME SPLIT OPEN ON ONE SIDE NEXT TO GAS TANK GAS TANK SUPPORT ROTTED AND BROKE

Mileage: 135,000

THE FRAME, UNDERBODY, SHOCKS, AXELS HAVE RUSTED. THE FRAME HAS ALMOST COMPLETELY RUSTED THROUGH. THE UPPER BODY HAS BEEN WELL MAINTAINED AND IS IN GREAT CONDITION.THIS VEHICLE ONLY HAS 84,000 MILES ON IT.

THE REAR PART OF THE FRAME ROTTED BAD..THE SPARE TIRE HOLD FELL OFF FIRST..THEN NOT LONG AFTER THE REAR BUMPER FELL OFF ON HIWAY ..AFTER CLOSE INSPECTION..THE FRAME IS BRITTLE LIKE A SALTINE CRACKER...PLUS THE REAR SPRING SHACLE RUSTED BEFORE AN HED REPLACED...ACTUALLY MY SON WAS DRIVING MY TRUCK WHEN THE BUMPER FELL OFF...TAKING REAR TAIL PIPE WITH IT...WHEN THE SPARE TIRE HOLDER FELL OFF THE DAY BEFORE..IT TOOK ALL THE EMISSION STUFF ALONG WITH IT..THIS TRUCK HAS ONLY 150,000 MILES ON IT ..THE FRAME IS RUSTED BAD..NEVER BEEN IN SALT WATER..I HAVE TRUCKS OLDER THAN THIS WITH SOLID FRAMES WHEN 25 YEARS OLD....I HAVE READ ON FORUMS HERE AFTER THIS HAPPENED AND SEEMS ITS A COMMON THING WITH SOME YEAR RANGERS,,,T4RUCK IS IN A1 SHAPE BUT NOW USELESS DUE TO POOR QUAILTY STEEL

Mileage: 150,000

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 FORD RANGER. UPON TAKING THE VEHICLE TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE, THE MECHANIC DIAGNOSED THAT THE BAR THAT HELD THE FUEL TANK IN LINE HAD EXTENSIVE RUST AND CORROSION. THE FAILURE COULD CAUSE THE BAR TO FRACTURE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE DEALER AND MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

Mileage: 30,000

TL* THE CONTACT OWNS A 2004 FORD RANGER. WHILE ATTEMPTING TO HAVE THE VEHICLE INSPECTED, RUST WAS OBSERVED ON THE FRAME OF THE VEHICLE. THE VEHICLE FAILED INSPECTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CROSS MEMBER AND BRACKETS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V331000 (STRUCTURE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000. UPDATED 05/06/16*LJ UPDATED 06/16/16.

Mileage: 85,000

JULY 19, 2015 RE: NHTSA RECALL 04V331000 JULY 15, 2004. ON JUNE 18, 2015, BERGLUND FORD OF BEDFORD, VIRGINIA REFUSED TO INSPECT MY VEHICLE TO DETERMINE IF AN IMPROPERLY MANUFACTURED FRAME PART EXISTS THAT COULD RUPTURE THE GASOLINE TANK DURING A SIDE IMPACT TYPE OF COLLISION. 1. A VISUAL INSPECTION IS THE ONLY METHOD TO DETERMINE IF THE RECALL HAZARD EXISTS. 2. FORD'S COMPUTER RECORDS CAN ONLY INDICATE IF AN INSPECTION HAS OCCURRED. 3. IT IS IMPOSSIBLE TO DETERMINE LOGICALLY IF THE RECALL HAZARD EXISTS BY USING VEHICLE IDENTIFICATION NUMBERS. AT THE TIME OF MY REQUEST FOR AN INSPECTION, I WAS PREPARED TO PAY FOR THE SERVICE BECAUSE OF THE AMOUNT OF TIME THAT HAS ELAPSED. ALSO, WHEN I REQUESTED THE INSPECTION OF THE FRAME AND FUEL TANK, I BECAME AWARE OF AN AIR BAG RECALL THAT HAD BEEN RECENTLY PUBLISHED FOR MY MODEL OF LIGHT TRUCK. BERGLUND FORD REFUSED TO ADDRESS EITHER RECALL SITUATION FOR ME BECAUSE, "THE COMPUTER DID NOT CALL FOR IT." I MAY OWN AN EXTREMELY DANGEROUS VEHICLE THAT COULD KILL THE OCCUPANTS DURING A COLLISION BECAUSE OF 2 FEDERAL SAFETY RECALL ISSUES THAT HAVE EXISTED SINCE THE VEHICLE WAS MANUFACTURED. (THE FUEL TANK/FRAME AND THE PASSENGER AIR BAG). BERGLUND FORD HAS VIOLATED FEDERAL LAW AND I REQUEST YOUR ASSISTANCE TO REMEDY THIS. THANK YOU.

Mileage: 41,000

THE FRAME ON THE PASSENGER SIDE OF MY TRUCK HAS RUSTED OUT AND BROKE APART FROM THE CAB. THE OTHER FRAME ON THE DRIVER'S SIDE IS STILL HOLDING UP THE BED, BUT IT WILL SOON GIVE WAY. THERE WAS NO ACCIDENT, NOR WAS THE VEHICLE ABUSED. I REALIZED THE PROBLEM AFTER I BECAME CONCERNED OVER THE TRUCK BEGINNING TO SWAY WHEN I WAS DRIVING. NOBODY HAS EVER HEARD OF THIS HAPPENING LIKE IT DID. MY TRUCK IS BASICALLY JUNK NOW. IT IS 10 YEARS OLD AND NEVER HAD ENGINES PROBLEMS NOR ELECTRICAL ISSUES. I DO NOT KNOW IF THIS WILL RESULT INTO ANYTHING, BUT THIS NEEDED TO BE FILED IN CASE I'M NOT THE ONLY ONE. *TR

Mileage: 66,803

NOTICED THAT THE BED WAS MOVING EXCESSIVELY. IT APPEARS THAT THE FRONT MOUNTS FOR FORD RANGERS ARE PRONE TO RUSTING OUT, LEAVING THE BED SECURED AT THE REAR. AN INTERNET SEARCH HAS CONFIRMED MANY CASES WHERE THE FRONT MOUNTS FAIL. WHILE MY VEHICLE IS 10 YEARS OLD, THERE ARE REPORTS OF FAILURES IN VEHICLES SIGNIFICANTLY NEWER. *TR

Mileage: 100,100

I OWN A 2004 FORD RANGER. THE FRAME IS TWO PARTS FRONT AND BACK HELD TOGETHER BY RIVETS. THE FRONT HALF OF THE FRAME LOOKS IN GOOD SHAPE, NORMAL WEAR AND TARE FOR A 2004 TRUCK BUT THE BACK SECTION OF THE FRAME INCLUDING SHOCK MOUNTS AND GAS TANK MOUNTS ARE A RUSTY ROTTING MESS. ITS LIKE PERFECT LINE. IF THE HOLE FRAME WAS LIKE THIS I WOULD SAY OK ITS A 2004 TRUCK BUT ITS NOT. SEEMS TO ME THIS IS A MANUFACTURER FLAW. *TR

DRIVING DOWN THE ROAD MY SPARE TIRE AND TIRE FRAME FELL OFF. AFTER PICKING EVERY THING OUT OF THE ROAD I NOTICED MY FRAME WAS GONE, MY RIGHT REAR SPRING AND SHACKLE ARE NOT CONNECTED TO THE REST OF THE FRAME. THE WHOLE UNDERCARRIAGE IS GONE. I BOUGHT THIS TRUCK NEW AND TOOK CARE OF IT. THE LAST TWO YEARS RUST IS OVERWHELMING THE TRUCK..BASICALLY THE TRUCK IS SCRAP WITH A LITTLE OVER ONE HUNDRED THOUSAND MILES. TRIED CALLING FORD BUT ...I NEVER COMPLAIN BUT I GOT ROBBED..... *TR

Mileage: 113,640

FRAME RUSTING OUT FROM UNDER TRUCK, NOISE WHEN I TURN TO STEER, AND SPARE TIRE FELL OFF. *TR

Mileage: 62,450

I AM SECOND OWNER ALWAYS GARAGED AT NIGHT. THE FRAME AND ALL PART ARE RUSTING FROM THE UNDER SIDE OUT. THE FRONT AND REAR BUMPERS ARE A SAFETY ISSUE. THEY ARE RUSTING BECAUSE THE FRAME AND THE MOUNTS ARE ROTTING AWAY. I HAVE A FEAR REAR BUMPER (OR SPARE TIRE) FALL OFF WHILE DRIVING....OR THE REAR SPRING SHACKLE, BRACKET RUSTING, FALLING OFF. THE FORD RANGER FRAMES ARE JUST AS BAD (OR WORSE) THAN THE TOYOTA ONES THAT WERE RECALLED (TOYOTA WAS MADE TO REPLACE THE FRAMES, OR BUY BACK THE TRUCKS). THESE TRUCKS ARE FROM 1995 TO 2000 AND PAST. I AM STEAMING MAD OVER THE REAR OF MY FRAME COMPLETELY RUSTING AWAY, WHILE THE REST OF THE TRUCK IS IN BEAUTIFUL CONDITION, *JS

Mileage: 60,000

TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR A ROUTINE OIL CHANGE WHEN IT WAS ADVISED THAT THERE WAS RUST AROUND THE CONTROL ARM WHERE IT WAS MOUNTED TO THE FRAME. THERE WAS A MANUFACTURER'S RECALL INITIATED TO ADDRESS THE CORROSION ISSUE HOWEVER, THE CONTACT'S VEHICLE HAD EXCEEDED THE FIVE-YEAR RUST WARRANTY. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

Mileage: 80,000

TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT STATED THAT BOTH SIDES OF THE BED EXHIBITED RUST CORROSION. IN ADDITION, THE REAR SUB FRAME AND BUMPER WERE COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

Mileage: 130,000

TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE SPARE TIRE FELL AND DETACHED FROM THE VEHICLE DUE TO THE BRACKET BEING CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY STATED THAT THE SUB FRAME WAS ALSO CORRODED AND BOTH THE BRACKET AND SUB FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED, WHO IN TURN INFORMED HIM, THERE WAS NO RECALL. THE FAILURE MILEAGE WAS 59,000. UPDATED 09/05/13*LJ

Mileage: 59,000

TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT WAS EXAMINING THE VEHICLE AND DISCOVERED TWO HOLES UNDER THE OUTSIDE OF THE DOOR LATCH. THE CONTACT STATED THAT WITH THE FAILURE, A SCREW DRIVER COULD BE USED TO UNLOCK THE VEHICLE FROM THE OUTSIDE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 25,000.

Mileage: 25,000

ROT HAS APPEARED IN BED OF TRUCK. ROT HAS COME FROM UNDERSIDE OF BED, SEEMINGLY DUE TO A FABRIC THAT HOLDS MOISTURE AND WATER, THAT IS IN DIRECT CONTACT WITH UNDERSIDE OF BED, CAUSING RUST TO FORM AND EVENTUALLY ROT THROUGH THE BED. IN THE PAST 4 MONTHS, ONE HOLE APPROXIMATELY 5 INCHES IN DIAMETER, ANOTHER 2 INCHES IN DIAMETER AND THIRD HOLE IS FORMING. I AM CONCERNED THAT THERE IS ROT FORMING ON THE FRAME MEMBERS, AND IF THIS WILL LEAD TO AN UNSAFE CONDITION DURING DRIVING OR IN THE EVENT OF AN ACCIDENT. *TR

Mileage: 85,000

MY WIFE SAT ON THE TAILGATE OF THE VEHICLE, AND BOTH TAILGATE SUPPORT CABLES SNAPPED AT THE SAME TIME CAUSING HER TO BE DROPPED ONTO THE GROUND, AND INJURING HER KNEE. NEITHER OF THE CABLES HAD SHOWN ANY PHYSICAL DAMAGE, AND THE RUBBER EXTERIOR COATING OF THE CABLES WAS STILL FULLY INTACT. UPON MY INSPECTING THE CABLES AFTER THEY HAD BROKEN, BOTH STEEL CORES WERE IN FACT CORRODED. *TR

Mileage: 76,000

FRAME HAS ISSUES WITH SEVERE SURFACE RUST PROBLEMS AND POSSIBLE MORE DEEPER RUSTING UNDERNEATH. WORRIED BRACKETS, HANGERS AND OTHER PARTS IN TIME WILL CORRODE TO THE POINT OF FAILURE. *TR

Mileage: 30,000

DT: THE CONSUMER WAS UNABLE TO SEE ODOMETER. THE CONSUMER STATED THE ODOMETER COULD NOT BE SEEN IN DAYLIGHT OR AT NIGHT. THEY CAN'T DO ANYTHING ABOUT IT UNTIL THE MANUFACTURER HAS A RECALL. MANUFACTURER SAID THEY WOULD REPORT IT TO ENGINEERING. *AK

Mileage: 200

PAST SAFETY RECALLS OTIFICATION DATE COMPONENT DESCRIPTION NHTSA CAMPAIGN NUMBER /3/2004 STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS 04V331000 . *AK I BROUGHT MY 2004 FORD RANGER TO THE DEALER THIS DAY 12-13-2004 AND WHEN I MENTIONED THIS RECALL TO INSPECT FOR THIS POSSIBLE FRAME PROBLEM THE SERVICE WRITER AT THE "WORLD FORD" DEALER IN MIAMI, FL. TOLD ME THERE IS NO RECALL. WHAT DO I DO NOW?

1)THERE HAD BEEN A LIGHT RAIN A SHORT TIME EARLIER. 2)ON A 2004 FORD RANGER 4X4 PICK UP; THERE IS A TUBE STEP WITH A RUBBER STEP AREA. AS I WENT TO GET INTO THE VEHICLE, I MADE SURE THAT I WAS ON THAT RUBBER AREA (SINCE IT HAD JUST RAINED). AS I WENT TO STEP IN, MY FOOT SLID OFF THE RUBBER AREA; MY TOE WENT BETWEEN THE DOOR AND THE DOOR JAM, MY HEEL LOCKED TO THE TUBE. I THEN FELL BACK AND HIT THE GROUND, WHILE MY FOOT STAYED LOCKED IN THE DOOR JAM AREA. I HAVE HAD TO HAVE KNEE SURGERY AND NOW HAVE A BLOWN DISK IN MY LOWER BACK THAT WE ARE TRYING TO CORRECT AT THIS TIME.I HAVE BEEN OFF WORK SINCE THIS HAPPENED! 3)IF FORD WOULD HAVE HAD " A BETTER IDEA"; THEY WOULD HAVE JUST PUT THE SANDPAPER NON-SKID IN THE AREA AND THIS HAZZARD WOULD NOT BE THERE. I WANT TO KNOW WHAT IS GOING TO BE DONE! OR IS AN ATTOURNY NEEDED?*AK

1)THERE HAD BEEN A LIGHT RAIN A SHORT TIME EARLIER. 2)ON A 2004 FORD RANGER 4X4 PICK UP; THERE IS A TUBE STEP WITH A RUBBER STEP AREA. AS I WENT TO GET INTO THE VEHICLE, I MADE SURE THAT I WAS ON THAT RUBBER AREA (SINCE IT HAD JUST RAINED). AS I WENT TO STEP IN, MY FOOT SLID OFF THE RUBBER AREA; MY TOE WENT BETWEEN THE DOOR AND THE DOOR JAM, MY HEEL LOCKED TO THE TUBE. I THEN FELL BACK AND HIT THE GROUND, WHILE MY FOOT STAYED LOCKED IN THE DOOR JAM AREA. I HAVE HAD TO HAVE KNEE SURGERY AND NOW HAVE A BLOWN DISK IN MY LOWER BACK THAT WE ARE TRYING TO CORRECT AT THIS TIME.I HAVE BEEN OFF WORK SINCE THIS HAPPENED! 3)IF FORD WOULD HAVE HAD " A BETTER IDEA"; THEY WOULD HAVE JUST PUT THE SANDPAPER NON-SKID IN THE AREA AND THIS HAZZARD WOULD NOT BE THERE. I WANT TO KNOW WHAT IS GOING TO BE DONE! OR IS AN ATTOURNY NEEDED?*AK