2010 FORD TAURUS Service Brakes, Hydraulic Problems

The contact owns a 2010 Ford Taurus. The contact stated that the brake pedal would depress the floorboard without warning. The vehicle was taken to a dealer where a diagnostic test was performed. The diagnostic test determined that the brake module was defective and needed to be replaced. The manufacturer was not notified of the failure. The contact was informed that parts to repair the vehicle were on backorder. The vehicle was not repaired. The failure mileage was approximately 22,000.

Mileage: 22,000

TL* THE CONTACT OWNS A 2010 FORD TAURUS. WHILE DRIVING 10 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE PEDAL TRAVELED TO THE FLOORBOARD. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT THE BRAKE PEDAL HAD A FRACTURED SPRING AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT GROGAN'S TOWNE CHRYSLER JEEP DODGE RAM (16100 TELEGRAPH RD, TOLEDO, OH 43612, (419) 476-076) WAS CONTACTED, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 69,712. *TT *TR

Mileage: 69,712

TL* THE CONTACT OWNS A 2010 FORD TAURUS. ON SEVERAL OCCASIONS, WHILE THE BRAKE PEDAL WAS DEPRESSED, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD. AS A RESULT, THE CONTACT'S FOOT CAME IN CONTACT WITH THE ACCELERATOR PEDAL. THE ACCELERATOR PEDAL BECAME DEPRESSED WHILE THE BRAKES WERE ALSO BEING APPLIED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS CAUSED BY A MANUFACTURING DESIGN FAULT AND NOT A DEFECT. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS ALSO TAKEN TO MILLINAX FORD NEW SMYRNA BEACH (2317 FL-44, NEW SMYRNA BEACH, FL 32168, (386) 428-9094), BUT WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 55,000. *BF UPDATED 8/23/18*JB

Mileage: 55,000

TL* THE CONTACT OWNS A 2010 FORD TAURUS. WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKE PEDAL HAD TO BE DEPRESSED TO THE FLOORBOARD TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND A DEALER WHERE IT WAS DIAGNOSED THAT THE MASTER CYLINDER WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 51,000.

Mileage: 51,000

WHILE DRIVING ON THE EXPRESSWAY NEAR DEARBORN, MI, MY 2010 FORD TAURUS BEGAN TO INCREASE IN SPEED ON ITS ON. THE LAST TIME I LOOKED AT IT BEFORE I CRASHED, THE ODOMETER WAS AT ABOUT 80 MILES PER HOUR. I COULD NOT STOP THE CAR BY PRESSING ON THE BRAKES. I WAS GETTING CLOSE TO OTHER CARES, SO I TURNED TO THE RIGHT TO AVOID A COLLISION WITH ANOTHER CAR, SO I HIT THE GUARD RAIL AND THE CAR ROLLED OVER. THANKFULLY, I WAS NOT HURT AND NO ONE ELSE WAS EITHER. MY CAR, OF COURSE, WAS TOTALLED AND BASED ON MICHIGAN LAW, I ALSO RECEIVED A TICKET.

TL* THE CONTACT OWNS A 2010 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN ENGAGED, HOWEVER THE VEHICLE DID STOP. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN REPLACED THE MASTER CYLINDER. IN ADDITION, THE CONTACT WAS ADVISED THAT THE HYDRAULIC CONTROL MODULE WAS FAULTY AND WOULD BE REPLACED ONCE THE PART BECAME AVAILABLE. THE VEHICLE REMAINED AT THE DEALER UNTIL FURTHER REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 32,000. THE VIN WAS UNAVAILABLE. UPDATED 03/12/14*LJ THE ABS MODULE NEEDED TO BE REPLACED. 03/21/14

Mileage: 32,000

THIS IS THE SECOND OCCASION IN TWO WEEKS. ONE SURGE OCCURRED FROM A FULL STOP AND THE ABS BRAKES DIDN'T STOP THE VEHICLE BEFORE BUMPER IMPACT. SECOND ACCIDENT WAS WHEN I WAS TRAVELING 20-30 MPH AND WENT TO STOP AND THE CAR SURGE WITH THE ABS FOOT PEDAL PRESSED AS HARD AS POSSIBLE. THE ABS BRAKES MADE A NOISE 3 TIMES BEFORE IMPACT TO REAR BUMPER / SPARE TIRE. IN ADDITION I HAVE COMPLAINED TO MY DEALERSHIP THE LAST 3 SERVICE VISITS THAT THE RIGHT SIDE OF THE FRONT BRAKES MAKE A GRINDING NOISE SPORADICALLY WHEN BRAKING. I HAVE ALSO EXPERIENCED LOSS OF POWER WHILE ON A HIGHWAY (VERY SCARY). *TR

Mileage: 38,000

THERE IS GRUNTING GRINDING AND SQUEALING FROM THE FRONT AND REAR BRAKES THE CAR HAS 10000 MILES ON IT AND NOW IT PULLS SUDDENLY FROM ONE SIDE TO THE OTHER ON HARD BRAKING. MY DEALER HAS REFUSED TO DOCUMENT MY PROBLEMS AND WANTS TO KEEP THE CAR FOR 2 TO 8 WEEKS TO EVALUATE AND FIX THE PROBLEMS, TO DATE THEY CAN NOT DUPLICATE THE PROBLEM AND WILL NOT FIX IT. *TR

Mileage: 159

BOTH FRONT BRAKE PADS DID NOT WEAR IN AS THEY SHOULD HAVE. ONLY THE INNER 1/2 INCH OF THE OUTER PAD APPEARS TO HAVE SEATED AGAINST THE ROTOR, NOT THE FULL WIDTH OF THE PAD. THE PADS AND ROTORS WERE REPLACED BUT THE PROBLEM HAS REAPPEARED ON THE NEW PARTS EXACTLY LIKE THE FIRST SET. THE LEFT AND RIGHT FRONT BRAKES HAVE THE SAME PROBLEM, IT'S NOT JUST ONE SIDE. AN UNUSUAL NOISE SOMETIMES OCCURS WHEN COMING TO A STOP. BRAKING DISTANCE IS COMPROMISED. *TR

Mileage: 8,098

WHILE DRIVING AT ANY SPEED THE FRONT BRAKES WOULD MAKE A GRINDING NOISE. I HAD THE FORD DEALER DIAGNOSE AND ACCORDING TO THEM A TSB WAS PUT OUT BY FORD TO REPLACE THE REAR BRAKES. THE REAR BRAKES WERE REPLACED AND THE NOISE IS TILL THERE. *TR

Mileage: 7,500

VEHICLE WAS FINE UNTIL 20K MILES. NO NOISE, NO PULLING OR STOPPING ISSUES. WITHOUT WARNING THE GRINDING CAME ON AND THE ROTORS WERE ALREADY COMPLETELY SHOT. *TR

Mileage: 20,000

TL* THE CONTACT OWNS A 2010 FORD TAURUS. THE CONTACT STATED THAT WHEN BRAKING FROM ANY SPEED, A GRINDING NOISE COULD BE HEARD COMING FROM THE BRAKES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE ALL OF THE ROTORS AND DRUMS WERE REPLACED. APPROXIMATELY THREE MONTHS AFTER REPAIRS, THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND IT WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE THROTTLE BODY WAS REPLACED. THE FAILURE MILEAGE WAS 2,000 AND THE CURRENT MILEAGE WAS 8,300. THE VIN WAS UNAVAILABLE.

Mileage: 2,000

BRAKES GRINDING IN THE FRONT DRIVERS SIDE. AT FIRST, DEALER ATTEMPTED TO STATE THAT THEY WERE UNABLE TO DUPLICATE. HOWEVER, NOW DEALER ACKNOWLEDGES THAT THEY HAVE HAD SEVERAL COMPLAINTS WITH THE BRAKES ON THIS MODEL/YEAR, AND THAT THERE IS A TSB ON IT. THE WERE ABLE TO RESOLVE THE ISSUE BY REPLACING BOTH SETS OF FRONT ROTORS AND PADS, ALONG WITH A BRACKET AND SUPPORT. *TR

Mileage: 11,700

2010 FORD TAURUS SHO- WHEN BRAKES ARE APPLIED GRINDING NOISE IS HEARD. HAPPENED AFTER ABOUT 1000 MI., DEALER REPLACED PADS..MOST PREVALENT WHEN WEATHER IS COLDER. WAS GOOD FOR AWHILE BUT STARTED AGAIN AFTER 9000 MI.! BROUGHT BACK TO DEALER, SAYS HE WILL CHANGE ROTORS AND PADS THIS TIME. HOPE THIS DOES IT, I'M GETTING TIRED OF TRIPS TO THE DEALER! *TR

Mileage: 1,000

DURING ROUTINE CITY DRIVING, MODERATE BRAKING PRODUCES SIGNIFICANT GRINDING NOISE AND ASSOCIATED VIBRATION IN BRAKE PEDAL. BRAKING ACTION IS STILL GOOD, BUT NOISE PRODUCES A SIGNIFICANT DISTRACTION WHICH CREATES TENDENCY FOR THE DRIVER TO RELEASE BRAKE PRESSURE TO ELIMINATE THE NOISE. FAILURE SEEMS TO OCCUR DURING ALL TYPES OF WEATHER AND DRIVING CONDITIONS, BUT IS MOST OFTEN OBSERVED WHEN MOISTURE IS PRESENT EITHER IN HUMID WEATHER OR PRECIPITATION. DEALER CHECKED ROTORS AND PADS WITHIN TOLERANCES AND ALL CALIPERS APPEAR IN ORDER. DEALER CANNOT DIAGNOSE THE PROBLEM, BUT ADMITS OTHER DRIVERS HAVE REPORTED THE EXACT SAME ISSUE IN THE SAME MODEL YEAR AND TRIM. *TR

Mileage: 2,500

GRINDING FRONT BRAKES NOT RELATED TO WORN PADS. *TR

Mileage: 10,000

BOUGHT THE 2010 FORD TAURUS SEL STARTED HEARING A GRINDING SOUND WHEN BRAKING ON A CONSTANT BASIS. CAR WAS BOUGHT FEB 2010. MILEAGE WHEN IT FIRST OCCURRED WAS ABOUT 9-10,000 KM. CURRENT MILEAGE IS APPROX. 12,000 KM. BROUGHT TO DEALER. THEY REPLACE PIN, BOLTS, AND PADS *TR

Mileage: 10,000

TL*THE CONTACT OWNS A 2010 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE THERE WAS A STEADY GRINDING NOISE. THE FAILURE SEEMED TO OCCUR MORE OFTEN WHEN HE MADE A LEFT TURN. OVER TIME, THE FAILURE BECAME PROGRESSIVELY WORSE. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE GRINDING NOISE WAS STILL PRESENT. THE FAILURE WAS DIAGNOSED BY THE DEALER TWICE. THE CONTACT REFUSED TO PICK UP THE VEHICLE UNTIL IT WAS REPAIRED. THE DEALER LATER STATED THAT THE FAILURE MAY HAVE BEEN CAUSED BY A PIN IN THE CALIPER. THERE IS A RELATED TECHNICAL SERVICE BULLETIN, NHTSA ITEM NUMBER 10032611, SERVICE BRAKES, ANTI-LOCK, CONTROL UNIT/MODULE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 4700. UPDATED 12/01/10. *LJ THE CONSUMER STATED HE CONTINUED TO HEAR NOISES UPDATED 12/14/10*JB

Mileage: 4,700

TL*THE CONTACT OWNS A 2010 FORD TAURUS. THERE WAS A LOUD GRINDING NOISE WHEN THE VEHICLE CAME TO A STOP AND THE BRAKES WERE ENGAGED. THE VEHICLE WAS TAKEN TO THE DEALER FOUR TIMES AND THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE BRAKES, ROTORS AND PADS HAVE BEEN REPLACED AND THE NOISE HAS BECOME LOUDER. THE MANUFACTURER WAS CALLED AND THEY ARE TRYING TO REACH THE DEALER BUT TO NO AVAIL. EACH TIME THE MANUFACTURER CALLED THE DEALER THERE WAS NO ANSWER. A REPORT WAS FILED WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS 800.

Mileage: 800