2015 FORD TAURUS Engine Problems

Airbags failed to deploy in a right front collision with a deer. Banged head off steering wheel. GEICO repaired over 8000 in damage. Took 19 days to repair.

Was driving and the accelerator/has pedal stopped working. A wrench indicator came on. The engine stopped working. I pulled to the side of the road and the engine started shaking. I turned the engine off then restarted it. It functioned fine. This happened twice in 2 days. It's the electronic throttle body. Ford won't fix the issue for free. It has 44k miles on it. An obvious manufacturer defect

Water pump is defective, leaks, and provides no warning in system. Replacing is unbelievably expensive ($5,000 for a water pump, but inside engine so extensive labor) and Ford needs to perform a recall as it can create major motor damage rendering the vehicle inoperable. Had to replace ours this past summer and now our daughter's 2013 Lincoln MKS has the same issue for same unbelievable expense and now we have to monitor our 2013 Ford Explorer for potential same issue. NO WARNING LIGHTS! TOO EXPENSIVE for consumers to repair! Please, do right thing and make FORD responsible. Under 150K miles on each vehicle!

My 2015 Ford Taurus goes into limp mode because of inadequate air flow across the Throttle Body Actuator. Scanner results show the Throttle Body Actuator as the problem issue. I have sprayed cleaner in the butterfly spring but the vehicle is still going into limp mode after driving it only a few miles after spraying the cleaner. It could be the throttle body has issues or it could be one of the sensors. At any rate, having the vehicle go into limp mode while driving 80 MPH down the freeway is a very dangerous situation. It has put me in precarious positions and it is clear that the Throttle Body is the issue.

The contact owns a 2015 Ford Taurus. The contact stated that while driving in the rain at various speeds, the vehicle would stall as the "check manual" and wrench warning light would illuminate on the instrument panel. The contact had taken the vehicle to the dealer on two separate occasions and each time the dealer was unable to duplicate the failure. The manufacturer was notified of the failure and provided a case number. The contact was then referred to the NHTSA for assistance. The vehicle had yet to be repaired and remained in the possession of the dealer. The failure mileage was approximately 42,000.

Mileage: 42,000

03/16/2021 Was the purchase date. The battery was pretty much dead when we took it in for its first oil change (about a month after purchase), they may still have record of it. The check engine light has been on since June. The front head light wiring was faulty, not sure if the person has any record of it. But I can ask that finally got fixed in December. The check engine light was only read at the auto store. Unfortunately due to me losing my job, the cobuyer (my fiancé) has been responsible for all bills and we can’t afford to have it looked at in depth. We purchased a limited warranty when we got the car, but every time we contacted them. They were rude and very put off. They made it seem like we were the issue and not the car. And they NEVER let us bring it in to have it looked at. We are paying almost $475 for a car that has had major problems since purchasing it.

Fuel pump control module failure. No start intermittent. Could have been stuck 5 hours away if it would've been a week earlier. No warning lights or indications previously.

TWICE THE POWER WENT OFF ON MY CAR WHILE DRIVING ON THE HIGHWAY. I WAS LUCKY TO BE ABLE TO PULL OFF THE ROAD. WAITED A FEW MINUTES AND GOT POWER BACK. THE CAR MAKES NOISE WHEN GOING DOWN THE ROAD, AND I HAVE ALWAYS BEEN TOLD THAT THE FORD TAURUS DOES THIS. THEY SAID NOTHING WAS WRONG. THE NOISE IS WHERE YOU WONDER IF YOU ARE SAFE, AND PROBABLY WOULD NEVER FIND A BUYER FOR THE VEHICLE. THE CAR SOUNDS LIKE AN ELECTRICAL PROBLEM SOMETIMES FROM THE RADIO, AND WHEN I USE THE PHONE. WEIRD. THE BLUE LIGHTS ON THE DASH BOARD CAN BE BLINDING. HAD MY EYES CHECKED BY A SPECIALIST AND NOT MY EYES. ONE TIME I HAD LEFT MY CAR RUNNING IN PARK IN THE DRIVEWAY AND WHEN WALKING AROUND TO THE OTHER SIDE OF THE CAR, THE CAR ROLLED OUT OF MY DRIVEWAY AND DAMAGED THE DOOR ON THE GARAGE DOOR. OBVIOUSLY THE CAR LOSING POWER TWICE ON A HIGHWAY IS A SERIOUS ISSUE. THIS HAPPENED TWO YEARS AGO, AND TWO MONTHS AGO WAS THE SECOND TIME.

Mileage: 129,000

MY CAR STALLS WHEN I'M DRIVING AND TURNS OFF. NO CHECK ENGINE LIGHT ON

Mileage: 27,500

IT'S MAKES A WEIRD NOISE AND I TOOK IT TO PEP BOYS AND THEY DIDN'T FIND ANYTHING. *TR

Mileage: 107,100

WHILE DRIVING MY VEHICLE HOME FROM WORK THE ENGINE BEGAN SHUDDERING, SURGING, AND FINALLY DIED LEAVING ME STRANDED ON THE SIDE OF THE ROAD CAUSING POTENTIAL HAZARD FOR MYSELF AS WELL AS OTHER DRIVERS. I TOWED THE VEHICLE TO MY MECHANIC WHO TOLD ME IT COULD BE EITHER THE HIGH PRESSURE FUEL PUMP OR THE FUEL PUMP CONTROL MODULE. THE VEHICLE ONLY HAS 61,000 MILES ON IT MAKING IT JUST OUTSIDE THE MANUFACTURER'S 60,000 MILE WARRANTY. FORD REFUSED TO EXTEND ANY KIND OF WARRANTY WHEN THE MECHANIC CALLED. WHEN I CHECKED THE ISSUE ONLINE I LEARNED OF A 2016 FORD RECALL REGARDING THE FUEL PUMP CONTROL MODULE FOR 2013-2015 FORD VEHICLES WHICH APPARENTLY DOES NOT COVER MY CAR. BOTH THE MECHANIC AND I ARE BAFFLED THAT A FUEL PUMP COULD SUDDENLY FAIL WITH ONLY 61,000 MILES ON THE VEHICLE AND HE WAS VERY SURPRISED THAT FORD WOULD NOT DO ANYTHING TO EVEN ASSIST WITH THE COST OF THE REPAIR. AS FAR AS THE FUEL PUMP CONTROL MODULE, I AM STILL IN THE PROCESS OF TALKING WITH FORD ABOUT IT.

Mileage: 61,000

WHILE DRIVING THE CAR. IT WAS NOTICED THAT THE VEHICLE WAS PUTTING OUT COOL AIR ONLY WHEN THE HEAT WAS ENGAGED. IT WOULD EVENTUALLY WARM A BIT BUT WOULD RETURN TO BLOWING COOL AIR ONLY. WHEN THE VEHICLE WAS TAKEN TO A MECHANIC, IT WAS EXPLAINED THAT THE PROBLEM WAS THE WATER PUMP. WE WERE TOLD THAT THE DESIGN OF THE VEHICLE REQUIRES THE ENGINE TO BE REMOVED TO GET TO THE PUMP AND THE COST OF THE REPAIR WOULD BE IN EXCESS OF $2000. THE VEHICLE CANNOT BE DRIVEN IN ORDER TO PREVENT FURTHER DAMAGE

Mileage: 68,580

TL* THE CONTACT OWNED A 2015 FORD TAURUS. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE BATTERY WAS CRACKED, WHICH CAUSED WIRES TO CORRODE IN THE ENGINE. THE VEHICLE WAS TOWED TO FAIRWAY FORD INC (444 US-117, BURGAW, NC 28425, (800) 291-7714) AND WAS REPAIRED. THE CONTACT MENTIONED THAT THE SAME FAILURE OCCURRED ON ANOTHER VEHICLE OF THE SAME YEAR, MAKE, AND MODE THAT HE PREVIOUSLY OWNED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. THE VIN WAS UNKNOWN.

Mileage: 70,000

2015 FORD TAURUS UNDER 93,000 WATER PUMP FAILURE. NO WARNINGS WHILE DRIVING ON THE HIGHWAY. STARTED TO OVER HEAT AND COOLANT WAS PORING OUT UNDERNEATH. HAD IT TOWED TO A FORD DEALERSHIP AND WAS TOLD THE WATER PUMP NEEDS REPLACED. OVER $2000 DOLLARS FOR THIS FIX. THE WATER PUMP SHOULD LAST UNTIL 150,000. FORD KNEW IT WAS AN ISSUE AND NEEDS TO STEP UP AND FIX IT. CURRENTLY STILL IN GARAGE TRYING TO FIGURE OUT WHAT I'M GOING TO DO.

Mileage: 92,000

TL* THE CONTACT OWNS A 2015 FORD TAURUS. WHILE DRIVING 5 MPH AND MAKING A TURN, THE VEHICLE STALLED AND THE OIL CHANGE MESSAGE WAS DISPLAYED. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT AND THE TOW TRUCK DRIVER STATED THAT THE FUEL PUMP WAS INOPERABLE. THE CONTACT CALLED ACADEMY FORD (13401 BALTIMORE AVE, LAUREL, MD 20707, (800) 658-7794) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND REFERRED THE CONTACT TO THE LOCAL DEALER. THE FAILURE MILEAGE WAS 80,000.

Mileage: 80,000

TL* THE CONTACT OWNS A 2015 FORD TAURUS. WHILE DRIVING BELOW 50 MPH, THE VEHICLE STALLED ON THE HIGHWAY WITHOUT WARNING. THE CONTACT HAD TO COAST AND STEER THE VEHICLE TO THE SIDE OF THE ROAD BEFORE THE APPROACHING TRAFFIC CAUGHT UP. THE CONTACT NOTICED THAT "WARNING TOOL" APPEARED ON THE INSTRUMENT PANEL WITH AN ORANGE WRENCH ICON. THE VEHICLE WAS TAKEN TO MALLOY FORD OF WINCHESTER (1911 VALLEY AVE, WINCHESTER, VA 22601, (540) 667-4434) TO BE DIAGNOSED, BUT NO FAILURE WAS FOUND. A MECHANIC DROVE THE VEHICLE AND WAS ABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS REPAIRED BUT IT WAS UNKNOWN WHICH PARTS WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 43,000.

Mileage: 43,000

TL* THE CONTACT OWNS A 2015 FORD TAURUS. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO KRAPOHL FORD & LINCOLN (1415 E PICKARD RD, MT PLEASANT, MI 48858, 1-800-772-5974) WHERE IT WAS DIAGNOSED THAT THE ENGINE FUEL MODULE FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000.

Mileage: 55,000

TL* THE CONTACT LEASES A 2015 FORD TAURUS. WITHIN LESS THAN A MONTH AFTER THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 16V621000 (FUEL SYSTEM, GASOLINE) BY SHAMALEY FORD (11301 GATEWAY BLVD W, EL PASO, TX 79936, (915) 591-8600), IT STALLED WITHOUT WARNING. THE SAME DEALER AND THE MANUFACTURER WERE NOTIFIED AND PLANNED TO CONDUCT MORE DIAGNOSTIC TESTING. A CASE NUMBER WAS PROVIDED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 16,823.

Mileage: 16,823

VEHICLE STALLED MULTIPLE TIMES AT HIGHWAY SPEEDS ON BUSY INTERSTATE. AFTER A FEW START/STALL CYCLES, MOTOR WOULD NOT START AT ALL. FULL FUEL TANK, WELL MAINTAINED VEHICLE, WITH ONLY ABOUT 42K MILES AND NO DAMAGE HISTORY. NEEDED TO PUSH OFF ROADWAY, VERY HAZARDOUS SITUATION. TOWED TO GARAGE, CURRENTLY AWAITING DIAGNOSIS.

Mileage: 42,860

WHILE DRIVING THE CAR AND LOW OR HIGH SPEEDS IT WILL STALL IN THE MIDDLE OF DRIVING IT. NO ENGINE LIGHTS WILL BE ON OR ANY TYPE OF WARNING. ONCE IT STALLS AND THE VEHICLE IS TURNED OFF AND THEN TURNED BACK ON IT WILL WORK FINE UNTIL IT WILL DO IT AGAIN. WITH THE RECALLS OF SOME OF THESE MODELS I LOOKED UP THE VIN NUMBER AND THERE IS NO RECALL HOWEVER IT SEEMS BASED ON RESEARCH WE ARE HAVING THE SAME PROBLEM AS OTHER FORDS WERE HAVING WITH THE FUEL SYSTEM.

Mileage: 55,000

TL* THE CONTACT OWNS A 2015 FORD TAURUS. UPON ATTEMPTING TO START THE VEHICLE, IT FAILED TO START. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE FAILURE OCCURRED TWICE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 80,100. *TT

Mileage: 80,100

SERVICE ENGINE SOON INDICATOR CAME ON. LATER, THE CAR STALLED ON THE HIGHWAY, ALMOST CAUSING AN ACCIDENT. DEALER COULD NOT PROVIDE AN ANSWER TO WHY THIS HAPPENED. UPON INVESTIGATING THIS ISSUE MYSELF, I FOUND SAFETY RECALL 16S31 WHICH DESCRIBED THE EXACT SYMPTOMS EXPERIENCED WITH MY CAR. MY CAR WAS MANUFACTURED AT THE FORD CHICAGO PLANT DURING THE DESIGNATED TIME PERIOD OF THE RECALL, YET MY VIN # WAS NOT PART OF THE RECALL. FORD DEALER AGREED THAT THE REASON FOR THE RECALL COULD HAVE BEEN THE CAUSE OF MY CAR SHUTTING DOWN ON THE HIGHWAY. THIS SITUATION IS TOO POTENTIALLY DANGEROUS IF IT OCCURS AGAIN. I CONTACTED FORD, THEY WOULD NOT ACCEPT FAULT AND TOLD ME THEY WOULD REPORT THE INCIDENT TO NHTSA, CASE# [XXX]. *TT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 89,000

CAR STALLED WHILE GOING 50 MPH, LIGHTS INSIDE WORKED FINE, NOTICE ALERTED ME ON THE DASH THAT CAR WAS NOT IN PARK. I WAS UNABLE TO ACCELERATE, PULLED TO A STOP ON THE SIDE OF THE ROAD AND PUT THE CAR IN PARK AND TURNED THE VEHICLE OFF. RESTARTED AND IT RESTARTED JUST FINE. I NOTICED THERE WERE RECALLS ON THE 2015 FORD TAURUS THAT WERE MADE IN THE CHICAGO PLANT FOR VERY SIMILAR PROBLEMS BUT MINE IS NOT INCLUDED. 37000 MILES ON THE VEHICLE. PRETTY DANGEROUS FOR IT TO JUST STALL WHEN GOING THAT FAST FOR NO APPARENT REASON.

Mileage: 37,000

2015 FORD TAURUS/APPROX 7850MILES ON CAR/6 MONTHS OLD....VEHICLE WENT INTO LIMP HOME MODE AT HIGHWAY SPEED. ESPECIALLY IN THE HANDS OF A LESS EXPERIENCED DRIVER, THIS COULD CAUSE MAJOR CONFUSION, AND POSSIBLY A MAJOR REAR END COLLISION AND IT IS A SAFETY CONCERN THAT PROVES THIS PROBLEM STILL EXISTS WITH THIS PART, EVEN THOUGH THE NHTSA HAS "CLOSED THE FILE" AND ACCEPTED FORD'S EXPLANATION. THE NHTSA SHOULD RE-OPEN THIS FILE AND INVESTIGATE. THE FOLKS AT FORD SERVICE SEEM TO BE ALL TOO FAMILIAR WITH THIS PROBLEM. FORD MUST BE HELD ACCOUNTABLE FOR THESE POTENTIALLY LIFE THREATENING SITUATIONS CAUSED BY THESE PARTS AND THEY MUST BE FORCED TO PERFORM A FULL SCALE RECALL ON PART AT4Z-9E926-B (THROTTLE BODY)

Mileage: 7,850

2015 FORD TAURUS SEL 3.5L ECOBOOST FLEX FUEL HAS VIBRATIONS AT IDLE AND SPEEDS OF 60-70 MPH. VIBRATION DOES NOT ALWAYS OCCUR AT IDLE OR AT HIGH SPEEDS, USUALLY HAPPENS DURING DECELERATION, AND SOMETIMES HAPPENS AT LOW SPEEDS AS WELL. WAS TOLD BY FORD DEALER THAT OTHER SIMILAR MODELS WERE TEST DRIVEN TO COMPARE, AND THESE VIBRATIONS ARE NORMAL FOR SIMILAR CARS. I DROVE A 2011 FOR TAURUS SEL FOR 4 YEARS AND NEVER HAD ANY VIBRATIONS SO AM CERTAINLY NOT HAPPY WITH THE DEALER'S RESPONSE BUT THEY SAID SINCE NO CODES ARE POPPING UP THERE IS NOTHING THEY CAN DO, AND I TOOK IT TO A DIFFERENT FORD DEALER AND THEY WOULDN'T EVEN HAVE THE TECHNICIANS CHECK ANYTHING SINCE IT WASN'T VIBRATING AT THAT MOMENT

Mileage: 9,000

MY 2015 FORD TAURUS WITH THE 3.5L V6 WILL UNEXPECTEDLY STALL OUT WHILE DRIVING. THE CAR WILL GO INTO "LIMP HOME MODE" UNTIL YOU TURN THE CAR OFF. THIS HAS HAPPENED AT 70MPH AND AT 45MPH. THE DEALERSHIP UPDATED THE COMPUTER IN THE CAR AND COULDN'T FIND ANYTHING ELSE WRONG. A WEEK AND A HALF LATER THE CAR STARTS STALLING OUT AGAIN. THIS TIME I HAVE A OBDII HOOKED UP TO THE CAR AND THE CODE IS P2112 (THROTTLE ACTUATOR CONTROL). THE DEALERSHIP IS TOO BUSY THIS WEEK, SO I HAVE TO SEE WHAT THEY DO. FROM WHAT I'VE READ OTHER FORDS HAVE HAD THE SAME PROBLEM. THE CAR CURRENTLY HAS OVER 23,000 MILES ON IT.

Mileage: 23,470

TL* THE CONTACT OWNS A 2015 FORD TAURUS. WHILE MERGING ONTO THE HIGHWAY, THE VEHICLE'S RPMS SUDDENLY REDUCED AND FORCED THE VEHICLE TO DRIVE AT APPROXIMATELY 5 MPH. THE CONTACT DROVE OFF TO THE SIDE OF THE ROAD. THE DEALER STATED THAT THEY WOULD NEED TO TOW THE VEHICLE TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 11,000.

Mileage: 11,000

TL* THE CONTACT OWNS A 2015 FORD TAURUS. WHILE DRIVING 65 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART, BUT FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY MODULE AND GASKET FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 12,630.

Mileage: 12,630

DRIVING ON THE HIGHWAY AT 70 MPH EXPERIENCED SUDDEN LOSS OF ENGINE POWER- NO LIMP HOME MODE JUST LOSS OF ACCELERATION - COASTED TO THE SIDE OF THE ROAD. AFTER TURNING CAR OFF AND BACK ON WAS ABLE TO CONTINUE DRIVING. ONLY ERROR SHOWN WAS SEE MANUAL. FAILED THREE MORE TIMES BEFORE I COULD GET OFF THE ROAD - KNOWN PROBLEM WITH THROTTLE BODY - EXTREMELY DANGEROUS SITUATION AS YOU CAN CAN HAVE DIFFICULTY GETTING OFF THE ROAD CROSSING SEVERAL LANES. THIS SHOULD BE A MAJOR RECALL. IF YOU ARE NOT ABLE TO GET OFF THE ROAD IN TIME YOU WILL MOST LIKELY EXPERIENCE BEING REAR ENDED ON THE HIGHWAY. AS I RESEARCHED THIS THIS HAS BEEN HAPPENING FOR YEARS AND IS STILL NOT FIXED - WHY IS THE NHSTB NOT TAKING THIS MORE SERIOUSLY.

Mileage: 40

AVIS RENTAL CAR IN LAS VEGAS, NV: PRESSING THE ENGINE START/STOP PUSHBUTTON SWITCH CAUSED THE WHOLE SWITCH ASSEMBLY TO FALL BACKWARDS DOWN BEHIND THE DASH PANEL, RENDERING THE TAURUS INOPERABLE. ALTHOUGH THIS INCIDENT OCCURRED IN A PARKING LOT, PRESSING THE ENGINE START/STOP PUSHBUTTON SWITCH AND HAVING IT FALL DOWN INTO THE DASHBOARD AREA CREATES A POTENTIAL SERIOUS SAFETY ISSUE. (THIS FREQUENTLY USED SWITCH SHOULD NOT BE MOUNTED FROM BEHIND THE PANEL WITH THE SMALL TANGS/GROOVES CURRENTLY USED.) I WAS UNABLE TO OBTAIN THE RENTAL CAR VIN BUT HAVE .JPG PHOTOS OF THE AFFECTED VEHICLE.

Mileage: 1,502

TL* THE CONTACT OWNS A 2015 FORD TAURUS. AFTER DRIVING THE VEHICLE, A STRONG ABNORMAL ODOR EMITTED FROM THE HOOD. WHEN THE CONTACT OPENED THE HOOD, THE STEAM WAS SO HOT THAT HE COULD NOT TOUCH THE RADIATOR HOSE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT THE WATER PUMP WAS PLACED IN A DIFFERENT LOCATION FROM PREVIOUS OLDER MODELS CAUSING THE RADIATOR TO EMIT HIGHER HEAT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 300. UPDATED 5/11/15*CN

Mileage: 300