1995 FORD THUNDERBIRD Electrical System Problems

TL* THE CONTACT OWNS A 1995 FORD THUNDERBIRD. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE STALLED. THE CONTACT MENTIONED THAT THE BATTERY AND THE CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

DRIVER'S SIDE ELECTRIC SEAT BURST INTO FLAME. DRIVER(OWNER) SUSTAINED SEVERE BURNS THAT CHARACTERIZE AS LIFE THREATENING, AND REQUIRED ADMISSION TO THE BURN CENTER AT UNC HOSPITAL. PT WAS NOT SMOKING AND CAN NOT IDENTIFY ANY REASON WHY THERE WOULD HAVE BEEN A FIRE IN HIS CAR. *TR

FORD 1995 THUNDERBIRD CAUGHT ON FIRE. IT WAS PARKED EARLY IN THE MORNING. NO KEYS IN THE IGNITION. *AK THE RIGHT FRONT TIRE EXPLODED FROM THE FLAMES SHOOTING OUT FROM THE RIGHT FRONT WHEEL WELL. THE FIRE SPREAD TO THE INSIDE PASSENGER COMPARTMENT. THE POWER ANTENNA MOTOR HAD NOT WORKED PROPERLY FOR YEARS. TEN DAYS LATER BEFORE THE FIRE, THE POWER DOOR LOCKS FAILED AND THE FUSE WAS REPLACED. THE DOOR LOCK POWER FUNCTION WAS RESTORED AND THE FUSE WAS REPLACED. THE FUSE WAS BEING CHECKED FOR BEING TOO HOT TO TOUCH. *SC *JB

Mileage: 107,000

ON TWO OCCASIONS IN HEAVY TRAFFIC VEHICLE SUDDENLY LURCHED FORWARD. DEALER WAS NOTIFIED. *AK ENGINE ROARS, CONSUMER WOULD TAP THE ACCELERATOR AND WOULD GO TO THE FLOOR, FEELS AS IF VEHICLE IS PUT IN NEUTRAL. DEALER REPLACED TRANSMISSION GEAR SHIFT SWITCH ASSEMBLY. CHECK ENGINE LIGHT CAME ON INTERMITTENTLY. DEALER REPLACE 2 O2 SENSORS AND MAF SENSOR. VEHICLE PULLS TO RIGHT. WHEEL ALIGNMENT PERFORMED. STEERING WHEEL SHIMMY WHEN APPLYING BRAKES. PRFORMED FRONT DISC/ REAR DRUM BRAKE SERVICE. REPLACED FRONT ROTORS AFTER BRAKE JOB DUE TO PULSATION. STEERING COLUMN HAD TO BE REPLACED. AT TIMES, VEHICLE WILL NOT SHUTT OFF. RIGHT DOOR LOCK INOPERATIVE. DEALER CAN NOT DUPLICATE. CUSTOMER STATES FLUID LEAK AT REAR END. RIGHT AXLE SEAL REPLACED. PASSENGER HEAD REST RATTLES OVER BUMPS. DEALER COULD NOT DUPLICATE. CONSUMER STATES NOISE FROM SEAT WHEN NO ONE IS SITTING THERE, DEALER STATES THIS IS NORMAL. SEAT TRACK COVERS MISING ONE LAYING IN THE REAR FLOOR. SEAT TRACK COVER REINSTALLED. CONSUMER STATS THERE IS A PINGING NOISE UPON ACCELERATION. DEALER SUGGESTED HIGHER FUEL OCTANE. CUSTOMER STATES BRAKE PEDAL SEEMS LOW. BRAKES OK. FRONT END SHIMMIES AT 50 TO 60 MPH. 4 TIRES BALANCED. DOME LIGHT WILL NOT COME ON WHEN DRIVER OUTSIDE DOOR HANDLE PULLED UP. TEMPERATURE AND SPEEDOMOTER LIGHT BURNED WAS INOPERATIVE. DEALER REPLACED INSTRUMENT CLUSTER BULBS. COOLANT LEAK UNDER CAR AND WARNING LIGHT IS ON. DEALER FOUND NO LEAKS AND COOLANT LEVEL LOW. CONSUMER STATES MOTOR WILL ROAR AND SHIFT INTO GEAR. DRIVER SIDE HEADLAMP BURNT OUT. HEADLAMP REPLACED. TRANSMISSION SLIPS WHEN NOT IN OVERDRIVE. DEALER REPLACED TRANSMISSION OIL PAN AND GASKET. *TT

AFTER STARTING MY CAR AT 5:30 AM TO PROCEED TO WORK THE KEY FELT A BIT STRANGE AFTER I STARTED THE CAR. UPON DRIVING THE CAR ON THE FREEWAY I DREW MY ATTENTION BACK TO THE KEY AND FELT THAT IT WAS SPINNING FREELY, AND COULD BE REMOVED, AS THE ENGINE CONTINUED TO RUN, ( THE START POSITION APPEARED TO WORK OK). I HAD NO WAY I COULD TURN THE CAR OFF. A TECHNITIAN ON THE 800 PHONE LINE TO FORD SUGGESTED I HIT THE FUEL SHUT OFF IN THE TRUNK ONCE I REACHED MY LOCATION. THIS WOULD SIMULATE A CRASH AND SHUT OFF THE FUEL. I ELECTED TO PULL A LARGE FUSE AND DETACH THE BATTERY. THE CAR WAS SUBSEQUENTLY REPAIRED AT MY EXPENSE ($283) TO REPLACE AN $11 ACTUATOR PIN IN THE STEERING COLUMN THAT INTERFACED WITH THE IGNITION SWITCH. I T WAS PROBABLY WRONG ON MY PART AS I LOOK BACK AT CONTINUING TO DRIVE THE CAR BECAUSE THE BROKEN PIN COULD HAVE POSSIBLY LODGED ITSELF AND PREVENTED ME FROM STEERING THE CAR. MY CONCERN NOW IS ONE OF SAFETY AND WHAT A PERSON NOT TOO FAMILAR WITH AUTOMOBLIES MIGHT DO IN THIS SITUATION. FORD SHOULD CONSIDER THE DESIGN AND MAKE CORRECTIONS TO PREVENT THIS SORT OF OCCURRENCE.*AK

ON SECOND IGNITION FAILIURE ACTUATOR ALSO HAD TO BE REPLACED BECAUSE IT WAS ALSO FAULTY. *AK

VEHICLE WILL STALL WITHOUT PRIOR WARNING. WHEN AT STOP LIGHT CONSUMER WOULD PUT VEHICLE IN NEUTRAL. DEALERSHIP WAS AWARE OF THE PROBLEM.*AK DEALER STATED IGNITION SYSTEM HAD SHORTED OUT RESULTING IN SPARK PLUGS BEING BURNED, DEALER REPLACED THE IGNITION SWITCH AND SPARK PLUGS, CONSUMER STATES THERE ARE STILL PROBLEMS AND NOW THE ENGINE IS MISFIRING, CONSUMER STATED THERE WAS A RECALL REGARDING THE IGNITION SWITCH PROBLEMS, HOWEVER DEALER INFORMED THAT THIS VIN IS NOT INCLUDED. FAN BELT REPLACED. FRONT AND REAR BRAKE PADS REPLACED. *SLC

VEHICLE WAS PLACED IN PARK FOR TEN MINUTES, TURNED OFF WHEN VEHICLE CAUGHT FIRE UNDER THE DASH, TOTALLING VEHICLE. FIRE DEPARTMENT DETERMINED THAT FIRE DUE TO AN ELECTRICAL SHORT. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

VEHICLE WA S PARKED IN PARKING LOT. SUBSEQUENTLY, VEHICLE CAUGHT ON FIRE UNDER THE HOOD. CAN NHTSA PROVIDE ADDITIONAL INFORMATION. *AK

VEHICLE WOULD NOT START AFTER THE CONNECTION TO THE STARTER CAME APART. FLUID LEAKED FROM THE TRANSMISSION AFTER THE TORQUE CONVERTER WAS REPLACED.

IGNITION LOCK FAILED.

WHEN DRIVING CAR SOMETIMES STALLS, DEALER CAN'T FIND PROBLEM. PLEASE DESCRIBE. *AK

THE CAR CONTINUES TO CUT OFF WHENEVER IN USE. *AK

VEHICLE PARKED, RUBBER SMELL AND SMOKE ENTERED INTERIOR. VEHICLE SUDDENLY CAUGHT ON FIRE IN THE IGNITION. *AK

ALTERNATOR FAILED, CAUSING OVERHEATING. *TT