2020 FOREST RIVER FLAGSTAFF Problems & Recalls

When forced to drive over a canvas tent bag, Due to traffic and road conditions. The tent bag wrapped around the drive shaft, ripped out the brake lines and the emergency brake lines damaged the master cylinder and damage the emergency brake mechanism in the cab of the RV. There should be protectio...

When forced to drive over a canvas tent bag, Due to traffic and road conditions. The tent bag wrapped around the drive shaft, ripped out the brake lines and the emergency brake lines damaged the master cylinder and damage the emergency brake mechanism in the cab of the RV. There should be protectio...

3500# axles added to a trailer with a gross weight of 3920#. Tires are severely worn on the inside from an undersized axel. Possible tire blow out if not corrected.

The structure supporting the fresh water tank is insufficient to carry the weight when full of water. The 36 inch long support bars sag ~2 inches when the tank is full, and the tank itself sags another 1.5 inches between the bars. There have been numerous accounts of these tanks detaching and fallin...

The fabric side wall failed to keep my daughter safe as she slept in the camper. She fell out of the camper onto the hard, cold ground while she was sound asleep. She could have been seriously injured. The Velcro on the fabric was secured to the camper frame.

The fabric side wall failed to keep my daughter safe as she slept in the camper. She fell out of the camper onto the hard, cold ground while she was sound asleep. She could have been seriously injured. The Velcro on the fabric was secured to the camper frame.

The fabric side wall failed to keep my daughter safe as she slept in the camper. She fell out of the camper onto the hard, cold ground while she was sound asleep. She could have been seriously injured. The Velcro on the fabric was secured to the camper frame.

Subject Castle Rock Radial ST 205/75/R14 tire was running 10 degrees F. hotter (around 110 F) than the three sibling tires after about 30 minutes of travel. This had been the case for an earlier trip of approximately 275 interstate miles. All of these tires are original equipment and similarly use...

The RV came with a heated mattress which I would often used to pre-heat the mattress before going to bed. On 11/23/2022, I turned the mattress heater on level 4 & went out of the camper. After about an hour, the smoke alarm went off & I came into the camper to find a very strong toxic odor. I found ...

The contact owns a 2020 Forest River Flagstaff. The contact stated that when he had inspected the RV spare tire prior to a trip, he noticed that the spare had a blister on the tread. The contact stated that the blister extends from the inner side of the tread to the outer and is approximately five i...

What component or system failed or malfunctioned, and is it available for inspection upon request -Tire. -I will keep the tire until 11/1/22. I will also have the undamaged spare available of the same make and model if needed. This will accompany a separate report with nearly identical language for...

What component or system failed or malfunctioned, and is it available for inspection upon request -Tire. -I will keep the tire until 11/1/22. I will also have the undamaged spare available of the same make and model if needed. This will accompany a separate report with nearly identical language for...

ST225/75R15 - had blowout on front driver side of RV that has dual axles. After putting spare tire on, I had gone less than 30 minutes down I-75 and had a second blowout on rear passenger tire as I pulled into a Camping World to get new spare. After 3rd tire was determined to be bad, ended up replac...

TIRES ARE PREMATURELY CRACKING AND POSE A SAFETY ISSUE BECAUSE THEY MAY FAIL AND BLOWOUT AT HIGH SPEED. CONDITIONS EXIST ON ALL FOUR TIRES. ALL TIRES SHOW SIDEWALL CRACKS AND SEPARATION CRACKS WHERE TREAD MEETS THE SIDEWALL.

Mileage: 5,000