Compare to Other Years

Active Recalls (12)

25V076000 Feb 11, 2025 EQUIPMENT:APPLIANCE:TV/RADIO/SPEAKERS

Gillig, LLC (Gillig) is recalling certain 2019-2024 Low Floor transit buses. The rivet-nut fasteners that secure the TFT flat panel display monitor to the bus ceiling may fail, causing the monitor to...

23V740000 Nov 3, 2023 POWER TRAIN:DRIVELINE:DRIVESHAFT

Gillig, LLC (Gillig) is recalling certain 2019-2023 Low Floor transit buses. The transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power.

22V548000 Jul 28, 2022 ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Gillig, LLC (Gillig) is recalling certain 2019-2022 Low Floor vehicles equipped with Cummins BP74E battery packs. The battery packs may develop a coolant leak internally, causing the battery pack to ...

22V436000 Jun 17, 2022 ELECTRICAL SYSTEM:PROPULSION SYSTEM: CABLES:FASTENER/CONNECTOR

Gillig, LLC (Gillig) is recalling certain 2019-2022 Low Floor electric transit buses. The EV resolver cable connector may experience a loss of electrical connectivity, unexpectedly switching from Dri...

22V276000 Apr 25, 2022 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Gillig, LLC (Gillig) is recalling certain 2014-2021 Low Floor transit buses. The rear-mounted ultracapacitors may allow the engine to be started when the master battery disconnect switch is in the "O...

21V352000 May 14, 2021 FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:FUEL RAIL

Gillig, LLC. (Gillig) is recalling certain 2017-2020 Low Floor vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

20V392000 Jul 2, 2020 STEERING:HYDRAULIC POWER ASSIST:PUMP

Gillig, LLC. (Gillig) is recalling certain 2013-2020 hybrid and all-electric Low Floor buses equipped with a steering system that uses a high-voltage electric motor and hydraulic pump assembly to prov...

20V342000 Jun 10, 2020 SUSPENSION:REAR

Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor buses. The rear suspension lower control rods may experience fatigue failure due to stiffened end bushings.

20V239000 Apr 29, 2020 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor transit buses powered by compressed natural gas (CNG). The thermally activated pressure relief device (PRD) installed on the CNG fuel syst...

20V179000 Mar 25, 2020 ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

Gillig LLC (Gillig) is recalling certain 2012-2020 Low Floor buses. The circuit breaker ratings on the DEF Line Heater circuit and the Aftertreatment-Ignition circuit may be higher than the rating fo...

19V451000 Jun 14, 2019 STRUCTURE:EMERGENCY:ESCAPE/EGRESS/EXIT

Gillig LLC (Gillig) is recalling certain 2018-2019 Low Floor vehicles equipped with a certain batch of glass roof hatches. Temperature and vibration stresses may cause the tempered glass roof hatch t...

19V193000 Mar 8, 2019 EXTERIOR LIGHTING:HEADLIGHTS

Gillig LLC (Gillig) is recalling certain 2014-2019 Low Floor buses. Uncovered electrical terminals in the headlight power circuit may short circuit to ground, causing a loss of headlights.

Complaints

Showing 2 of 2
Sep 9, 2019 Seat Belts 3,100 mi

I DRIVE BUSES FOR DISNEY WORLD AND THEY HAVE JUST GOT SOME NEW BUSES WITH NEW SEATS AND TWO PART SEAT BELTS. THE WAY THE LAP BELT AND SHOULDER BELT HOOK TOGETHER CAUSE THEM TO TWIST WHICH ALLOWS THE SHOULDER BELT TO JAM IN THE RETURN GUIDE NOT ALLOWING THE BELT TO FULLY RETRACT AND HOLD PROPERLY.I H...

Sep 9, 2019 Seat Belts 3,100 mi

I DRIVE BUSES FOR DISNEY WORLD AND THEY HAVE JUST GOT SOME NEW BUSES WITH NEW SEATS AND TWO PART SEAT BELTS. THE WAY THE LAP BELT AND SHOULDER BELT HOOK TOGETHER CAUSE THEM TO TWIST WHICH ALLOWS THE SHOULDER BELT TO JAM IN THE RETURN GUIDE NOT ALLOWING THE BELT TO FULLY RETRACT AND HOLD PROPERLY.I H...