2003 GMC ENVOY Electrical System Problems

The car's gas gauge and fuel range indicator are problematic. The fuel gauge quickly drops from a higher reading, like 3/4 full, to empty. After this, the gauge and the fuel range both fluctuate while driving, making it impossible to determine the fuel level.

The contact owns a 2003 GMC Envoy. The contact stated that the headlights ceased to operate as needed. Upon taking the vehicle to a local Pep Boys, it was diagnosed that the electrical wiring harness was burned and needed to be replaced. Additionally, the bulbs needed to be replaced. The contact stated that the vehicle was repaired; however, the failure recurred. The vehicle was taken back the local Pep Boys, who replaced the electrical wiring harness and the bulbs a second time; however, the failure persisted. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.

VEHICLE CAUGHT FIRE UNDER DASH SOMEWHERE WITHOUT VEHICLE BEING TURNED ON.

Mileage: 173,000

THE ELECTRIC WIRING FOR THE WINDOWS AND SIDE MIRRORS WILL START MAKING A CLICKING NOISE AND WHEN I PUT THE KEY INTO THE IGNITION AND TURN THE KEY JUST ONE TURN THE FRONT PASSENGER WINDOW GOES COMPLETELY DOWN AND WILL NOT GO BACK UP UNTIL IT IS DONE CLICKING AND TURNING THE HEATED SEATS ON AND OFF. THE REGULATOR IS NOT BROKE. ALSO THE SIDE MIRRORS EVEN THOUGH THEY ARE PROGRAMMED WILL SOMETIMES JUST START MOVING AND ACT LIKE IT CANT MOVE ANYMORE AND MAKE A NOISE. THE MUSIC AND OR RADIO WILL GO OUT WHILE ITS TURNED ON, IT WILL CUT IN AND OUT AND THEN AFTER DRIVING A WHILE IT WONT CUT IN AND OUT. FOR THE WINDOW TO JUST ROLL DOWN IT USUALLY HAPPENS AFTER IT SAT ALL NIGHT. WONT GO BACK UP FOR AT LEAST 2 MINUTES AND YOU CAN SEE THE DOOR LIGHTS FLICKER AND CLICK.

Mileage: 220,985

THE DASH CLUSTER DOES NOT WORK CORRECTLY, ALL THE LIGHTS TURN ON AND DOORS LOCK WHILE I AM DRIVING ON IN TOWN OR ON THE HIGHWAY , ALL THE GAUGES COME ON AT ONCE WHILE DRIVING ON THE STREETS AT RANDOM TIMES.. THE REAR HAS AIRBAGS IN THE SUSPENSION AND AND AREN'T WORKING PROPERLY, I TOOK IT TO THE SHOP AND THEY SAID IT HAD 30 CODES ON THE DIAGNOSTIC MACHINE BUT THEY COULDN'T FIND THE PROBLEM

Mileage: 217,000

THE LIGHTS COME ON BY THEMSELVES AND DRAINS THE BATTERY. TWO BATTERIES HAVE BEEN INSTALLED. THE CAR HAS HAD ROAD SERVICE JUMP STARTS 3 TIMES IN 2 WKS. THE LIGHTS COME ON THEMSELVES WHEN THEY'R'E OFF. THE ALTERNATOR WAS CHECKED AND IS GOOD. THE VEHICLE WAS PARKED IN A GARAGE WHEN THIS OCCURRED AND 1 TIME IN A PARKING LOT.

Mileage: 154,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. IN ADDITION, THE HEADLIGHTS FAILED TO ILLUMINATE WHILE DRIVING AT NIGHT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

CAR DIES WHEN DRIVING, CAR WONT START SOMETIMES AND HOUR OR 2 LATER STARTS MECHANIC SAID ALTERNATOR AND BATTERY ARE GOOD, IN PARKING LOT AND DRIVING IN THE CITY

Mileage: 114,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT THE POWER WINDOW AND DOOR CONTROLS MALFUNCTIONED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY DIAGNOSED THAT THE VEHICLE NEEDED A NEW POWER SWITCH. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 155,000.

Mileage: 155,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. WHILE THE VEHICLE WAS PARKED AND TURNED OFF, THE LOW BEAM HEAD LAMPS CONTINUED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 144,000. ..UPDATED 10/18/16 *BF UPDATED 03/09/17.*JB

Mileage: 144,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. WHILE AT A COMPLETE STOP, THE VEHICLE STALLED WITHOUT WARNING. AFTER REPEATED ATTEMPTS, THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CYLINDER IGNITION SWITCH WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 36,429. UPDATED 06/14/16*LJ UPDATED 06/30/16.*JB

Mileage: 36,429

TL* THE CONTACT OWNS A 2003 GMC ENVOY. WHILE DRIVING AT 65 MPH, THE INSTRUMENT CLUSTER BECAME INOPERABLE. THE CONTACT STATED THAT THE WINDOW SWITCHES ALSO BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC WAS UNABLE TO RETRIEVE A FAULT CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

I NOTICED A ELECTRICAL BURNING SMELL WHILE DRIVING ON A SIDE STREET. THE ENGINE MADE AN UNUSUAL NOISE SO I PULLED OVER, TURNED THE CAR OFF AND PUT ON THE HAZARD LIGHTS. WHILE WAITING FOR THE TOW TRUCK, THE CAR STARTED WITH NO KEY IN THE IGNITION. THE CAR RAN FOR A SHORT TIME THEN STOPPED AND ATTEMPTED TO RESTART ITSELF ABOUT 5 TIMES. OUR MECHANIC TOOK A LOOK AT IT AND SAID THERE HAD BEEN A FIRE IN THE FUSE BOX. I TOOK PICTURES OF THE CHARRED REMAINS OF THE FUSE BOX, COVER AND CONNECTORS. MOST OF THE PLASTIC CONNECTORS UNDER THE FUSE BOX COULD NOT BE REMOVED BECAUSE THEY HAD MELTED AND WERE FUSED ONTO THE BOX. HE NOTED THE FIRE SEEMED TO ORIGINATE FROM FUSE 46, THE HEADLAMP DRIVER MODULE. FOR THE PAST FEW YEARS, I HAD BEEN EXPERIENCING HEADLIGHT AND TAIL LIGHT ISSUES INVOLVING BULBS THAT WERE BURNING OUT FREQUENTLY OR WERE GOING OUT THEN COMING BACK ON.

Mileage: 169,000

MY CAR STARTED GOING NUTS THE WIPERS WOULDNT TURN OFF THE SEATS WONT MOVE THE DOORS WONT LOCK THE HEATERS OFF AND HOT AIR COMES OUT TRU VENTILATOS. *TR

Mileage: 198,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT THE KEY FAILED TO RELEASE FROM THE IGNITION SWITCH. THE CONTACT WAS ABLE TO RELEASE THE KEY AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000. UPDATED 3/24/15*CN UPDATED 10/20/2015*JS

Mileage: 55,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT THE FUEL GAUGE MALFUNCTIONED AND FAILED TO PROVIDE THE CORRECT FUEL LEVEL READING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL SENSOR AND THE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000.

Mileage: 115,000

I PURCHASED MY ENVOY NEW WITH 243 MILES & HAVE BEEN THE SOLE OWNER. MY SECURITY LIGHT GOES ON & OFF INTERMITTENTLY & THE VEHICLE WON'T START FOR 10-20 MINUTE TIME PERIODS. THERE IS NO APPARENT PATTERN W/WHEN THIS WILL OCCUR. I HAVE BEEN STRANDED IN AREAS THAT I DO NOT FEEL SAFE, OFTENTIMES WITH MY YOUNG CHILDREN IN THE VEHICLE. I INITIALLY TOOK THE VEHICLE TO ALBERT GMC, WHERE I PURCHASED IT (NO LONGER IN SERVICE, SO EXACT DATE/MILEAGE UNKNOWN). DIAGNOSTICS RETURNED MULTIPLE CODES, ALL RELATED TO THE SECURITY SYSTEM. THEY RECOMMENDED THAT I HAVE THE REMOTE STARTER REMOVED THAT WAS PROFESSIONALLY INSTALLED 11/2008. R&R CAR AUDIO REMOVED THE REMOTE STARTER & RAN ALL OF THE WIRING TO ASSURE IT WAS SOUND. I NEXT WENT TO AUTOMOTIVE SPECIALISTS. SERVICE HISTORY: 11/9/10: RAN MULTIPLE DIAGNOSTICS, UNABLE TO DETERMINE PROBLEM OR REPLICATE. 1/19/11: REPLACED IGNITION LOCK CYLINDER & CASE, AT MY INSISTENCE, BASED ON ONLINE FORUMS. 3/11/11: RAN MULTIPLE DIAGNOSTICS, UNABLE TO DETERMINE PROBLEM OR REPLICATE. 5/6/11: REPLACED IGNITION STARTER SWITCH, AT MY INSISTENCE, BASED ON ONLINE FORUMS. 9/23/11: MULTIPLE DIAGNOSTICS, UNABLE TO DETERMINE PROBLEM OR REPLICATE. 9/19/13: REPLACED IGNITION STARTER SWITCH (AGAIN), AT MY INSISTENCE. 11/18/13: SHOP HAD VEHICLE FOR A WEEK, ATTEMPTING TO GET THE PROBLEM TO REPLICATE, WITHOUT LUCK. I HAVE SPENT A GOOD AMOUNT OF $ AND TIME/INCONVENIENCE IN ATTEMPTS TO REMEDY THE STARTING ISSUE. AT GM'S DIRECTION 6 WEEKS AGO, I TOOK THE ENVOY BACK TO A DEALERSHIP,[XXX], & HAD TO PAY ANOTHER DIAGNOSTIC FEE, WHICH ONLY SHOWED THAT THE PASSLOCK SENSOR WAS BAD. I HAD THE PASSLOCK SENSOR REPLACED 1/19/11 & EXPERIENCED THE STARTING ISSUE AGAIN WITHIN 2 MONTHS. GM WOULD NOT GUARANTEE THEIR PART SINCE IT WAS NOT INSTALLED BY AN AUTHORIZED DEALER, EVEN THOUGH IT WAS A GM CERTIFIED PART. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 33,500

WIFE MENTIONED THE INSTRUMENT CLUSTER ( R.P.M . ) & ( VOLTAGE ) /W/ THE ( CHECK ENGINE LIGHT ) ARE ON. MILEAGE=APPROX :106,000 THIS IS A G.M.C FACTORY FLAW IN MANY ENVOYS BUILT . ELECTRICIAN ASLEEP AT THERE POSTS ON THIS ISSUE , AND SAID OTHERS TOO!! OTHER ISSUES ARE MINOR IN REPAIR AND USAGE DICTATED BY AGE , NOT A RECALL ITEM BUT LISTED ANYWAY FOR VIEWING. SEAT--ELECTRICAL-DRIVER SIDE- FRONT LEFT FACING LIFT BRACKET ARM-- BROKE AT WELD .CAN BE REPAIRED. CENTER FLOOR FRONT CONSOLE --LOOSE ? NOT YET INVESTIGATED AS TO WHY. REAR BACK HATCH FLOOR CARPET RUINED BY FORMER OWNERS --UNKNOWN SPILL ATE CARPETING LIKE BATTERY ACID SPILL.? OTHER THEN A FEW MINOR GLITCHES IN A ( NOTE ) ( USED ) VEHICLE ...WE CAN HANDLE IT. NOTE: ALL OTHER SYSTEMS OPERATE AS THEY ARE DESIGNED TO DO. *JS

Mileage: 106,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT AFTER TURNING OFF HER IGNITION, THE DOORS LOCKED LEAVING HER TRAPPED IN THE CAR. THERE WAS NO WARNING PRIOR TO THE FAILURE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 73,134.

Mileage: 73,134

THE CAR DIES FOR NO REASON IT HAS BEEN DOING THIS SINCE THE FIRST DAY I GOT THE CAR. THE CAR ALSO FUNCTIONS LIKE IT HAS HYDROLICS FOR A WHILE IT WILL BE LOW TO THE GROUND WHILE I'M DRIVING IT THEN OUT OF NO WHERE IT WOULD RAISE UP I HAD TO GET THE SUSPENSION DONE WHEN I GOT IT BECAUSE IT WAS OLD AND ALSO THE KEY GETS STUCK IN THE IGNITION ALSO IF I PRESS THE UNLOCK BUTTON IT WILL TURN ON THE HEAT THIS CAR HAS BEEN A HEADACHE. *JS

Mileage: 137,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT THE SPEEDOMETER WOULD PROVIDE ERRONEOUS READINGS OF 120 MPH AND THE TACHOMETER PROVIDED AN ERRONEOUS READING OF ZERO. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 121,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 128,000. *TR

Mileage: 121,000

DROVE TO WORK SATURDAY NIGHT 12/07/2013 PARKED CAR AT 7:30 PM WENT IN TO WORK .CAME OUT TO MY CAR AT 10:00PM FOR BREAK TO SEE MY CAR SMOKING THE PASSENGERS HEATED SEAT TURNED IT'S SELF ON AT SOME POINT AND WAS ON FIRE BURNING THE SEAT AND MY COOLER THAT WAS SITTING ON THE SEAT WAS ON FIRE AND SMOKE FILLED THE CAR WAS MAKING IT HARD TO BREATH THE SMOKE WAS THICK AND SMELLED TOXIC. ME AND MY FELLOW EMPLOYEES DUMPED SNOW ON AND UNDER THE SEAT FROM AS FAR,AWAY AS WE COULD TILL THE SMOKE CALMED DOWN.TO GET THE FIRE OUT.I AM SO GRATEFUL I WAS NOT DRIVING OR THERE WAS NO PERSON SITTING ON THE SEAT AT THE TIME COULD OF CAUSED ME TO WRECK MYSELF OR OTHERS.ON MY DRIVE HOME COULD NOT USE THE HEAT DUE TO THE FUMES BEING TO STRONG WITH THE WINDOWS UP AND HEAT ON HAD TO DRIVE WITH NO HEAT AND WINDOWS DOWN 40 MINUTES WITH THE TEMPS IN THE TEENS. *TR

Mileage: 146,474

AFTER SIX MONTHS HAVING PURCHASED THIS USED VEHICLE FROM A LOCAL DEALER, I NOTICED THAT THE DRIVER'S DOOR WAS NOT WORKING PROPERLY, NOR WERE THE POWER WINDOW DEVICES, CONTROLS, POWER LOCKS AND ALSO THE VISIBILITY OF DRIVER'S REAR WINDOW. I NOTICED THAT THE DOOR WOULD OVERHEAT AND SOMETIMES I CAN SMELL AN ODOR SIMILAR TO WHEN SOMETHING IS BURNING. I HAVE TAKEN THE VEHICLE TO A MECHANIC AND FINDING THE SOLUTION TO THE PROBLEM HAS BEEN DIFFICULT. ON JUNE 2013, I READ ON THE MSN WEBSITE THAT THE GMC ENVOYS FOR 2006 AND 2007 WERE BEING RECALLED (RECALL #13V248000) IN REGARDS TO DRIVER'S MASTER POWER WINDOW SWITCH. SINCE I AM HAVING THIS SAME PROBLEM, WITH MY 2003 ENVOY, I CALLED GMC AND EXPLAINED TO HER THAT I AM HAVING THAT SAME ISSUE WITH MY 2003 ENVOY. SHE INDICATED THAT GMC WOULD PAY FOR THE DIAGNOSTIC FEE LABOR EVEN THOUGH MY CAR'S MILEAGE WAS NOT UNDER WARRANTY AND THAT THE RECALL WAS ONLY FOR 2006 & 2007 ENVOYS. SHE CONNECTED ME TO [XXX] FOR AN APPT. WITH BALISE THE FOLLOWING DAY. SHE ASSIGNED A CASE NUMBER 71-1219059371. THE FOLLOWING DAY, AUGUST 28, 2013, I WENT TO MY APPOINTMENT AT 11 AM. AND LEFT MY CAR. ABOUT AN HOUR LATER, I GET A CALL FROM GMC INDICATING TO ME THAT SHE WAS SORRY, BUT THAT GMC COULD NOT COVER THE COST OF DIAGNOSTIC FEE LABOR. I SAID, "THAT IS NOT WHAT YOU TOLD ME YESTERDAY" AND SHE REPLIED, "I AM SORRY, I WAS NOT AUTHORIZED TO TELL YOU THAT". I SAID TO HER, "I WOULDN'T HAVE TAKEN TIME OFF FROM WORK, ASK FOR A RIDE, BE WITHOUT TRANSPORTATION IF YOU HAD TOLD ME THAT BEFORE". I ALSO SAID TO HER, "HOW CAN YOU TELL ME YOU ARE COVERING THE COST YESTERDAY AND TODAY CHANGE YOUR MIND". ALL SHE RESPONDED WAS, "I AM SORRY". I ASKED TO SPEAK TO HER SUPERVISOR BY THE NAME OF [XXX] AND THE SUPERVISOR JUST SAID THAT HER EMPLOYEE WAS NOT AUTHORIZED TO SAY TO ME THAT GMC WOULD COVER THE COST. I STILL HAVE THE SAME SAFETY ISSUE. *TR

Mileage: 143,084

DRIVING IN A SCHOOL ZONE OF 25 MILES PER HOUR AND BEGAN TO SMELL A ROTTEN EGG SMELL. THE GAUGES ON THE DASH REMAINED NORMAL. PULLED OVER AT THE NEXT PARKING LOT OF A TRACTOR SUPPLY AND TURNED THE CAR OFF. SMOKE WAS COMING FROM UNDER THE HOOD. OPENED THE HOOD AND SAW IMMEDIATELY WHERE THE SMOKE WAS COMING FROM. WE DISCONNECTED THE BATTERY FIRST THE POSITIVE, THEN THE CAR STARTED ON ITS OWN, WITHOUT A KEY IN THE IGNITION. FINALLY GOT THE BATTERY DISCONNECTED AND THE SMOKE CONTINUED. THE RESULT WAS A MELTED FUSE BOX RELAY BLOCK A HOLE ALL THE WAY THROUGH AND A DAMAGED ELECTRICAL HARNESS. THE CAR IS NOT DRIVABLE. IT WAS TOWED. A CLAIM WAS TURNED INTO GEICO AND WAS DENIED BY THE INSURANCE COMPANY. THE REPAIR ESTIMATE IS SOMEWHERE BETWEEN $1000-2500 TO REPAIR. I HAVE NOTICED THROUGH RESEARCH THAT THIS IS NOT AN UNCOMMON PROBLEM WITH THIS VEHICLE. WE HAVE OWNED THIS VEHICLE FROM THE SHOWROOM FLOOR TILL NOW. NO PROBLEMS, WARNINGS, ETC. WHAT TO DO NOW? *TR

Mileage: 129,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED, THERE WAS A BUZZING NOISE COMING FROM THE DRIVERS SIDE DOOR CONTROL MODULE. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC TEST. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 94,000. THE CURRENT MILEAGE WAS 97,000. *TR

Mileage: 94,000

STARTED CAR AND NONE OF MY GAUGES WERE WORKING. THIS HAPPENED ANOTHER TIME ABOUT THREE MONTHS AGO AND THE NEXT DAY WHEN I STARTED MY CAR IT WAS FINE. SO I WAS HOPING IT WOULD HAPPEN AGAIN AND IT WOULD FIX ITSELF. IT DIDN'T! I'VE READ THIS WAS A RECALL ON 2004 TO 2008 WHY NOT 03 I'VE READ SEVERAL SITES THAT ITS A COMMON PROBLEM IN THAT YEAR ALSO. TOOK TO GMC DEALER AFTER BEING TOLD NO FEE FOR DIAGNOSE TO PULL PANEL AFTER SITTING AN HOUR WAITING NOW COST 150.00 AND TURNS OUT ITS A CLUSTER PROBLEM. PART IS 375 PLUS ANOTHER 200 FOR LABOR. *TR

Mileage: 80,000

WHILE DRIVING, SEVERAL INDICATOR LIGHTS CAME ON IN THE INSTRUMENT PANEL. (ABS, SEATBELT, BATTERY PRIMARILY) THESE LIGHTS STAY ON FOR A WHILE AND THEN GO OFF, ONE BY ONE. AFTER PUTTING THE CAR IN PARK, THE BATTERY LIFE METER DROPPED TO ZERO. I TURNED THE CAR OFF AND THE CAR WOULD NOT RE-START. AFTER HAVING IT TOWED TO A REPAIR SHOP, THE BATTERY ITSELF TESTED THAT IT WAS GOOD. I REPLACED THE BATTERY, ANYWAY, HOPING IT SOLVED THE ISSUES, BUT THE LIGHTS ON THE INSTRUMENT PANEL CONTINUE TO TURN ON WHILE DRIVING. AFTER A DAY OR SO, THEY TURN OFF AND THEN DAYS LATER WILL COME ON AGAIN. I HAVE HAD THIS CAR CHECKED MULTIPLE TIMES BY TWO DIFFERENT REPAIR SHOPS AND NEITHER COULD FIND A SOLUTION OUTSIDE OF REPLACING THE INSTRUMENT PANEL. AFTER SEARCHING THE INTERNET, THIS SEEMS TO BE A KNOWN PROBLEM WITH THIS CAR AND OTHER GMC MODELS HAVE BEEN RECALLED FOR THE SAME PROBLEM. WHY HASN'T THE ENVOY BEEN INCLUDED? IT'S OBVIOUSLY A PROBLEM WITH THIS MODEL AS WELL. (ALTHOUGH, OTHER THAN THE AIRBAG RECALL, I HAVE NEVER RECEIVED NOTICES ABOUT ANY OTHER RECALLS REGARDING MY VEHICLE EVEN THOUGH IT APPEARS THERE HAVE BEEN OTHER ISSUES). *TR

Mileage: 53,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT ALL THE GAUGES ON THE INSTRUMENT PANEL FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE ENTIRE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 108,000. THE VIN WAS UNAVAILABLE.

Mileage: 100,000

I WAS DRIVING DOWN THE ROAD AND FIST OFF, MY SPEEDOMETER WENT CRAZY. THEN MY FUEL GAUGE WENT ALL THE WAY TO FULL, THEN TO EMPTY. THEN IT WOULDN'T WORK AT ALL. THERE WAS PLENTY OF GAS IN THE TANK TOO, I TOOK TO A MECHANIC AND HE REPLACED THERMOSTAT, BUT IT DIDN'T FIX THE PROBLEM. I'M STILL HAVING THE PROBLEM AND HEARD THERE IS A RECALL ON THE 2005-2007, AND IT APPEARS I'M HAVING THE SAME PROBLEM ON THIS 2003 THAT THEY ARE HAVING NOW WITH THE NEWER ONES AND THE 2003 SHOULD BE INCLUDED IN A RECALL. PLEASE EVALUATE. I ONLY HAVE 107K MILES ON THE TRUCK. I WAS TOLD, A RECALL COULD COVER UP TO 120K MILES, SO I STILL HAVE SOME WAY TO GO BEFORE I SHOULD NOT BE INCLUDED IN THE RECALL. MY SERVICE ENGINE LIGHT IS STAYING ON TOO, ALTHOUGH IT'S BEEN CHECKED NUMEROUS TIMES AND IT'S ALWAYS SOMETHING TO DO WITH THE FUEL SYSTEM AND TOO EXPENSIVE TO GET FIXED. NOW I AM HAVING MAJOR PROBLEMS BECAUSE OF IT. *TR

I OWN A 2003 GMC ENVOY. TWO YEARS AGO THE SPEEDOMETER STARTED STICKING. IT NOW DOES NOT KEEP THE SPEED AT ALL. MY RPM (WHEN IN PARK) WILL REV UP TO 2 OR 3RPM, MY GAS GAUGE HAS NOW STARTED TO SOMETIMES NOT SHOW I HAVE ANY GAS, THE CHECK ENGINE LIGHT IS ON ALMOST ALL THE TIME, MY AIR CONDITIONER WILL BLOW OUT THE BACK VENT AND BARELY COME OUT OF THE FRONT VENT WHEN I HAVE IT UP FULL BLAST. AND TO TOP IT OFF MY BACK BRAKE LIGHTS CONSTANTLY BURN OUT.. I HAVE READ NUMEROUS FORUMS WHERE MANY PEOPLE ARE HAVING SOME OF THESE SAME ISSUES BUT NO RECALL. I DON'T UNDERSTAND THAT AT ALL. I DEFINITELY THINK THESE BAD INSTRUMENT PANELS CALL FOR A RECALL!! THIS IS A SAFETY ISSUE. I EVENTUALLY HAD TO CUT A HOLE IN THE PLASTIC OVER THE SPEEDOMETER AND BEFORE IT QUIT COMPLETELY WORKING WHEN WE WOULD GO ON VACATION, WE WOULD HAVE TO PULL OVER ON BUSY HIGHWAYS EVERY 20 MINUTES OR SO TO SET THE SPEEDOMETER BACK TO ZERO SO IT WOULDN'T SHOW ME GOING 120MPH. OF COURSE I CAN'T EVEN DO THAT NOW. I'M JUST AMAZED I HAVEN'T ENDED UP WITH A TICKET FOR MY SPEED OR MY RUNNING OR BRAKE LIGHTS. WE HAVE TAKEN THE ENVOY IN TO THE SHOP AND THEY TOLD US WE WOULD HAVE TO TAKE THE CAR IN TO A GM DEALER. I HAVE TO TAKE IT BACK IN THIS WEEK TO HAVE AIR WORKED ON AND WHO KNOWS HOW MUCH THAT WILL COST. I DON'T BELIEVE I SHOULD BE RESPONSIBLE TO PAY OVER $500 FOR PARTS AND LABOR IN A CAR THAT IS CLEARLY DEFECTIVE AND SHOULD BE RECALLED. PLEASE HELP!! *TR

Mileage: 60,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT NOTICED THAT THE SPEEDOMETER WAS INOPERABLE AND SHE WAS UNABLE TO DETERMINE HOW FAST OR SLOW SHE WAS TRAVELING. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR SERVICE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO WAS UNABLE TO DUPLICATE THE FAILURE AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 92,000.

Mileage: 92,000

TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT THE INSTRUMENT PANEL GAUGES WOULD FAIL SPORADICALLY OR PROVIDE INACCURATE READINGS INCLUDING THE SPEEDOMETER AND THE FUEL LEVEL GAUGE. THE VEHICLE WAS NEITHER INSPECTED NOR REPAIRED FOR THE FAILURE. THE FAILURE MILEAGE WAS 105,000 AND THE CURRENT MILEAGE WAS 110,000. UPDATED 5/2/11 *CN UPDATED 05/11/11

Mileage: 105,000

INSTRUMENT PANEL CLUSTER IS FAILING. MY SPEEDOMETER HAS TOTALLY QUIT WORKING.MY GAS GAUGE IS STARTING TO FAIL ALSO. I CHECKED ON THE INTERNET AND FOUND THAT GMC HAS ADMITTED THE STEPPING MOTORS ARE DEFECTIVE, ON THE INSTRUMENT PANEL CLUSTER GAUGES FOR MY 2003 GMC ENVOY. A CLASS LAWSUIT HAS BEEN FILED, ACCORDING TO THE INTERNET .ACCORDING TO THE INTERNET,THIS IS A COMMON PROBLEM FOR 2003-2007 GMC'S. THE COST OF THE REPAIR IS APPX. $800.00. I CANNOT AFFORD THIS REPAIR. I AM FORCED TO DRIVE WITHOUT KNOWING MY CORRECT SPEED, DUE TO THE SPEEDOMETER NOT WORKING. SOON I WILL NOT KNOW ....HOW MUCH GAS I HAVE IN MY GMC. ACCORDING TO THE INTERNET MY OTHER GAUGES WILL SOON FAIL. I PURCHASED MY GMC BRAND NEW FOR $38,000. I FEEL MY GMC ENVOY IS UNSAFE, DUE TO THE REASONS I HAVE JUST LISTED. I FEEL GMC SHOULD PAY FOR THIS REPAIR AS, IT IS UNSAFE FOR ME TO OPERATE THE GMC LIKE THIS. I WOULD LIKE TO BE INCLUDED IN THE CLASS ACTION LAWSUIT. THE FAILURE IS CONSTANT...NO SPEEDOMETER. THIS COULD CAUSE MY TO DRIVE OVER THE LEGAL SPEED LIMIT WITH OUT MY KNOWLEDGE, WHICH IS UNSAFE. I HAVE DONE NOTHING TO CORRECT THE FAILURE AS YET. AT THIS TIME I CANNOT AFFORD THE COST OF THE REPAIR. *TR

Mileage: 46,000

FAILURE OF 2003 GMC ENVOY SPEEDOMETER. *TR

TL*THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT THE SPEEDOMETER HAD NOT WORKED SINCE THE VEHICLE WAS PURCHASED, AND RECENTLY ALL OF THE GAUGES ON THE INSTRUMENTAL PANEL FAILED TO FUNCTION. THE MANUFACTURER STATED THAT WARRANTY HAD EXPIRED AND THE VEHICLE WAS OVER 70,000 MILES; HOWEVER, THE MANUFACTURER HAD OFFERED TO ASSIST WITH THE REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 66,000 AND THE CURRENT MILEAGE WAS 120,000.

Mileage: 66,000

MY VEHICLE WAS MAKING A JET LIKE SOUND ON START UP AND WHILE DRIVING AND EVENTUALLY THE CHECK ENGINE LIGHT CAME ON. IT ALSO WAS MAKING A CLICKING SOUND FROM THE ELECTRONIC HEATING UNIT. I TOOK IT IN TO A CERTIFIED GMC DEALER AND THEY SAID THE CLUTCH FAN NEEDED TO BE REPLACED (EXPENSIVE REPAIR). COULD NOT TELL WHERE THE CLICKING WAS COMING FROM AT THE TIME (1/6/11 CLICKING WILL NOT STOP - ENDED UP BEING A DOOR ACTUATOR). I DID SOME RESEARCH ON THESE PROBLEM AND THEY ARE VERY COMMON IN THESE VEHICLE. I CALLED GMC CUSTOMER SERVICE TO MAKE A COMPLAINT BECAUSE AT A LITTLE OVER 59000 MILES THESE PARTS SHOULD NOT HAVE GONE BAD. I WISH GMC WOULD CONSIDER A RECALL ON THIS PROBLEM AS WELL AS OTHER MAJOR THINGS.

Mileage: 59,410

THE ODOMETER HAS BEEN MALFUNCTIONING FOR 2 YEARS IT WILL WORK AND SOMETIMES IT WILL NOT. I WOULD BE GOING IN SPEEDS OF OVER 50MPH AND THE ODOMETER WOULD READ 20MPH. OR I WOULD GO ABOUT 30MPH IT WOULD READ100MPH OR OVER. IT WILL ERRATICALLY DO THIS. SOMETIMES IT WORKS FINE. I HAVE NOT FIXED THE PROBLEM YET. IT IS WORKING RIGHT NOW. *TR

Mileage: 80,000

I HAVE A 2003 GMC ENVOY. AT FIRST MY RPM NEEDLE STARED TO MOVE UP FASTER THEN WHAT I WAS GOING FOR ABOUT A MONTH. WHEN I SHUT THE ENGINE OFF IT SOUNDED LIKE IT WAS LETTING OUT A VACUUM NOISE. NOW IT'S BEEN A MONTH AND A HALF AND MY MPH IS NOT WORKING. IT SEEMS TO BE STUCK ON 80 MPS WHILE I'M SETTING AND GOES PAST 120 WHILE I'M DRIVING. ALSO THE GAS GAGE IS NOT WORKING RIGHT. IT DOESN'T REGISTER THE RIGHT AMOUNT OF GAS THAT'S IN THE TANK. I HOPE SOON THERE WILL BE A RECALL ON THE ELECTRICAL CLUSTER, BECAUSE EACH GAGE IS GOING OUT ONE BY ONE. I HOPE THIS WOULD BE A VEHICLE SAFETY HAZARD SINCE YOU NEED TO KNOW WHAT SPEED YOU ARE GOING. THANK YOU

2003 GMC ENVOY. THE SPEEDOMETER ONLY WORKS INTERMITTENTLY. IT MAY STICK IN ONE SPOT. OTHER TIMES IT IS CONSISTENTLY OFF BY A GIVEN SPEED. THE NEXT DAY IT MAY BE WORKING FINE. THIS HAS BEEN GOING ON FOR OVER A YEAR AND SEEMS TO BE OCCURRING MORE FREQUENTLY AS THE VEHICLE AGES. THE INTERNET IS LITTERED WITH OTHERS ALL HAVING THE SAME ISSUE. IT LOOKS LIKE A US DISTRICT COURT AWARDED OWNERS OF MANY OTHER GM MODELS WITH THE SAME ISSUE A SETTLEMENT (SEE HTTP://WWW.GMSPEEDOMETERRECALL.COM/). THE ENVOY WAS NOT INCLUDED, ALTHOUGH THE ISSUE IS THE SAME. COST FOR REPAIRING IS APPARENTLY IN THE $700 RANGE. AS FOR CONSEQUENCES, I SEE 2 POSSIBILITIES. I COULD RECEIVE AN UNWARRANTED SPEEDING TICKET. THE OTHER CONSEQUENCE IS THE MAJOR DISTRACTION IT CAUSES. THE ONLY WAY TO TELL IF IT IS WORKING AT TIMES IS TO WATCH IT CLOSELY. IF THE NEEDLE ISN'T MOVING WHEN I ACCELERATE I KNOW NOT TO TRUST IT. DRIVERS SHOULDN'T BE STARING AT THEIR SPEEDOMETER WHEN DRIVING. *TR

Mileage: 65,000

HI, I AM DRIVING A 2003 GMC ENVOY. I BOUGHT NEW BACK IN 2003 WITHIN THE LAST 2 MONTHS THE TACHOMETER AND SPEEDOMETER HAS NOT BEEN WORKING PROPERLY. I CALLED A LOCAL DEALER THEY TOLD ME NO RECALLS FOR THE 2003 GMC ENVOY. I CHECKED ON- LINE IT SEEMS ITS A PROBLEM WITH GM SUV'S AND PICK-UPS .THE RECALL IS FOR OTHER GM MODELS AND MAKES BUT NOT THE GMC ENVOY THAT IS NOT FAIR TO ME AND OTHERS WHO OWN THE SAME VEHICLE MODEL AS I DO. COULD YOU PLEASE LOOK INTO THIS I HAVE NOWAY KNOWING HOW FAST I AM GOING IT COULD BE A SAFETY HAZARD. THANK YOU. I HOPE YOU CAN HELP ME AND OTHER GM GMC ENVOY OWNERS. *TR

Mileage: 75,000

SPEEDOMETER ON MY 2003 GMC ENVOY WITH 57,000 MILES HAS NOT WORKING WITH NO WARNING SIGNALS AT ALL. *TR

Mileage: 57,000

SPEEDOMETER AND DASHBOARD FAILURE ON 2003 GMC ENVOY OCCURRING SPONTANEOUSLY AT APPROXIMATELY 50,000 MILES. GM DEALER WOULD REPLACE FOR $350 PLUS LABOR LAST JANUARY WHEN VEHICLE HAD LESS THAN 70,000.00. UNABLE TO AFFORD THIS COST AFTER A GENERAL SERVICE, HOWEVER THE COMPLAINT IS FILED WITH GM DEALERSHIP IN JAN 2009. CAR IS NOW OVER 70,000.MILES. I AM REALIZING THAT THIS IS NOT AN ISOLATED SITUATION AND THERE HAVE BEEN MANY COMPLAINTS. IS THERE A COMMITMENT FROM GM THAT THEY WILL REPAIR THIS ISSUE FOR CARS WITH MILEAGE UNDER 70,000.00? I BELIEVE THIS ISSUE SHOULD BE INVESTIGATED FOR A RE-CALL REGARDLESS OF MILEAGE. PLEASE DIRECT ME WITH THE APPROPRIATE ACTION MEASURES SO THAT I MAY REMEDY THIS SITUATION PROMPTLY. *TR

Mileage: 5,600

GMC ENVOY 2003 SPEEDOMETER IS ERRATIC AND DOES NOT FUNCTION AT ALL ON OCCASION. *TR

Mileage: 87,000

2003 GMC ENVOY WITH 65,000 MILES I HAVE A SPEEDOMETER THAT IS ERRATIC IN READING SPEED. GETS STUCK AT 35 MPH AS "0" OR REGISTERS -10 MPH FROM ACTUAL SPEED. THIS PROBLEM VARIES FROM ONE TO THE OTHER EVERY TIME I RESTART THE ENGINE. I ALSO HAVE A WEIRD CLICKING SOUND THAT COMES FROM THE DASH AREA ON OCCASION. *TR

I OWN A 2003 GMC ENVOY AND THE SPEEDOMETER ACTS ERRATICALLY, AND IS NEVER CORRECT. I'VE RESEARCHED IT AND THERE IS NOT A RECALL ON IT, AND FROM OTHER INTERNET USERS MESSAGES ON SITES, THERE ARE A LOT OF GM VEHICLES THAT ARE HAVING THIS PROBLEM!! I DON'T PERSONALLY HAVE THE MONEY TO GET IT FIXED, THAT AND I DON'T THINK IT SHOULD BE MY PROBLEM TO HAVE TO PAY FOR IT EITHER, GM PUT A BAD PART IN THE VEHICLES SO I THINK THEY SHOULD HAVE TO RECALL WHATEVER IS WRONG WITH THE SPEEDOMETER. THANK YOU FOR YOUR TIME. *TR

SPEEDOMETER IS WORKING ERRATICALLY ON MY 2003 GMC ENVOY. HAS BEEN FOR ALMOST A YR. THIS NEEDS TO BE CLASSIFIED AS A RECALL. I KNOW SEVERAL PEOPLE WITH THE SAME VEHICLE THAT ARE EXPERIENCING THIS VERY SAME PROBLEM. *TR

WITHIN THE LAST 4 OR 5 MONTHS, THE SPEEDOMETER ON OUR 2003 ENVOY WILL DISPLAY ERRATIC AND INCORRECT SPEEDS. WHEN THE VEHICLE IS FIRST STARTED UP THE SPEEDOMETER SEEMS TO REGISTER CORRECTLY. AFTER 20 MINUTES OR MORE THE NEEDLE WILL BEGIN TO STICK OR STUTTER. WITHIN 30 MINUTES THE SPEEDOMETER WILL REGISTER 90 MPH WITH AN ACTUAL ROAD SPEED OF 60 TO 65 MPH. TODAY IT EVENTUALLY PEGGED THE NEEDLE AT 120 MPH+. AT A COMPLETE STOP, WITH THE ENGINE OFF AND KEY OUT OF THE SWITCH, THE SPEEDOMETER REGISTERED 60 MPH. WE ARE MAKING CONTACT WITH OUR LOCAL GMC DEALER TO SEE WHAT REPAIRS WILL BE INVOLVED. BASED ON SEVERAL INTERNET FORUM SITES AND CHAT BOARDS, THIS IS NOT AN UNCOMMON PROBLEM. IT ALSO APPEARS THAT GM HAS NOT ISSUED A RECALL FOR THIS PROBLEM. THEY EVIDENTLY DO NOT SEE THIS AS A SAFETY PROBLEM OR POTENTIAL SAFETY PROBLEM. OUR ENVOY HAS LESS THAN 67,000 MILES ON THE ODOMETER. *TR

Mileage: 67,000

MOTORS THAT RUN THE GUAGES IN MY 2003 GMC ENVOY HAVE FAILED. THESE CONTROL THE FUEL, AMP, TEMP GUAGES. THIS IS A KNOWN ISSUE FOR THE MOTORS AND OTHER GUAGE CLUSTERS THAT USE THEM IN OTHER GM VEHICLES ARE CURRENTLY RECALLED FOR THE SAME ISSUE. I HAVE NOT CORRECTED THE ISSUE AND STILL HAVE THE DEFECTIVE PARTS. *TR

Mileage: 40,600

NOTICED PERIODIC INSTRUMENT CLUSTER FAILURE/ACCURACY PROBLEMS. SPEEDOMETER WILL SOMETIMES WORK OR WORK ERRATICALLY SO I HAVE NO IDEA HOW FAST I AM GOING. I RESEARCHED ON THE WEB AND FOUND THIS IS VERY TYPICAL FOR THIS MODEL. I CALLED MY DEALERSHIP AND WAS TOLD THAT THEY WILL ONLY REPAIR (NO COST) THE GMC PICKUPS AND NOT MY SUV MODEL EVEN THOUGH THEY HAVE SAME PROBLEM WITH THE SAME PART. THIS PRESENTS A VERY DANGEROUS CONDITION REGARDLESS OF WHAT VEHICLE THIS IS IN. WINTER DRIVING CONDITIONS IN MN REQUIRE DILIGENCE IN SPEED AND BRAKING, THIS IS A HUGE AND DANGEROUS PROBLEM FOR GMC AND THEY ARE JUST IGNORING CERTAIN MODELS FOR WARRANTY REPAIR AND FORCING THE CONSUMER TO SPEND $500.00 (EST.) TO FIX THERE PROBLEM! *TR

Mileage: 60,000

TL*THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT NOTICED THAT THE SPEEDOMETER IN HIS VEHICLE WOULD REGISTER HIGHER SPEEDS THAN WHAT WAS ACTUALLY BEING DRIVEN. WHILE DRIVING APPROXIMATELY 70 MPH WITH THE CRUISE CONTROL ACTIVATED, THE SPEEDOMETER WENT ALL THE WAY PAST THE HIGHEST SPEED INDICATOR AFTER DRIVING FOR 30 MINUTES. WHEN THE CONTACT PARKED THE VEHICLE, THE SPEEDOMETER DISPLAYED 70 MPH. THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS APPROXIMATELY 81,000 AND FAILURE MILEAGE WAS APPROXIMATELY 79,000.

Mileage: 79,000

TL*THE CONTACT OWNS A 2003 GMC ENVOY. WHILE DRIVING APPROXIMATELY 65 MPH, THE SPEEDOMETER DISPLAYED INACCURATE READINGS. THERE WERE NO WARNINGS PRIOR TO THIS FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING, WHICH INDICATED THAT THE FAILURE WAS RELATED TO THE ODOMETER STICKING. THE DEALER RECOMMENDED THAT THE INSTRUMENT PANEL BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT WAS CONCERNED OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 53,028 AND CURRENT MILEAGE WAS 60,200. UPDATED 12/08/08. *LJ UPDATED 12/09/08.*JB

Mileage: 53,028

MALFUNCTIONING OF INSTRUMENT CLUSTER AS DESCRIBED BY THE DEALERSHIP. SPEEDOMETER DISPLAYS INACCURATE SPEED, OTHER READINGS ON PANEL FLIP-FLOP ALSO. ADVISED BY THE SERVICE ADVISOR THAT THIS WAS A NOTED DEFECT WITH GMC AND THEY HAD ALREADY STARTED REPAIRING LARGER GMC'S AND SHOULD GET AROUND TO MINE LATER IN 2008. YESTERDAY, GMC INFORMED ME OF A SPECIAL POLICY ISSUED FOR THE PROBLEM, BUT ONLY FOR SIERRAS AND YUKONS (7YRS 70,00 MILES). GMC TOLD ME THEY WERE NEVER NOTIFIED OF THE PROBLEM WITH THE ENVOY'S. I ONLY HAVE 56,000 MILES ON THIS CAR (FIRST OWNER). NOW THE A/C HAS GONE OF BY ITSELF TWICE THIS MONTH AND THE PRESET STATIONS HAVE VANISHED. *TR

Mileage: 47,962

TL*THE CONTACT OWNS A 2003 GMC ENVOY. WHILE DRIVING 30 MPH, THE SPEEDOMETER DISPLAYED INACCURATE READINGS. THE CONTACT COULD NOT DETERMINE HOW FAST HE WAS TRAVELING. ALL THE GAUGES ON THE INSTRUMENT PANEL WERE ALSO MALFUNCTIONING. THE FAILURES HAVE BEEN REPAIRED. THE CURRENT MILEAGE WAS 100,000 AND FAILURE MILEAGE WAS 64,000.

Mileage: 64,000

TL*THE CONTACT OWNS A 2003 GMC ENVOY. WHILE DRIVING AT ANY SPEED, THE SPEEDOMETER WOULD CONSTANTLY MOVE UP AND DOWN AND DISPLAY INACCURATE SPEEDS. WHEN THE VEHICLE IS TURNED OFF, THE SPEEDOMETER WOULD STAY ANYWHERE BETWEEN 30-40 MPH. THE VEHICLE WAS PREVIOUSLY SERVICED BY THE DEALER, BUT IT HAS NOT RECENTLY BEEN DIAGNOSED. THE CURRENT MILEAGE WAS 173,607 AND FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

SPEEDOMETER DOES NOT WORK ANYMORE. I CAN BE SITTING AT A STOP LIGHT AND THE SPEEDO WILL BE PEGGED AT 120MPH. OR WHEN DRIVING IT WONT MOVE AT ALL. SOMETIMES...I'LL START THE CAR, AND THE SPEED WILL BE SITTING AT 40 MPH. HAS BEEN HAPPENING OFF AND ON SINCE NOVEMBER 2007. THE DEALERSHIP & CUSTOMER ASSISTANCE (800-462-8782) WILL NOT HELP ME. THEY TELL ME I HAVE TO BUY A WHOLE NEW INSTRUMENT CLUSTER ($475+) TO RESOLVE MY PROBLEM. THIS IS A VERY COMMON ISSUE WITH THE FULL SIZE VEHICLES (2003 AND UP). GM HAS ISSUED SPECIAL COVERAGE ADJUSTMENT #07187 ( 9/28/2007) TO REPLACE , FREE OF CHARGE, THIS BAD CLUSTER BUT WON"T FIX THE SAME PROBLEM IN THEIR SMALLER SUV"S. *TR

Mileage: 65,551

TL*THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT SMELLED GASOLINE, BUT DID NOT PAY IT ANY ATTENTION INITIALLY. HIS SON ENTERED THE VEHICLE LATER AND ALSO SMELLED THE STRONG ODOR. THE FOLLOWING DAY THE CONTACT FILLED UP THE TANK WITH GASOLINE AND THE SMELL INTENSIFIED. WHEN HE ARRIVED HOME, HE NOTICED A FUEL LEAK BY THE REAR DRIVER SIDE WHEEL. A MECHANIC STATED THAT THE LEAK ORIGINATED FROM THE TOP OF THE FUEL TANK WHERE THE FUEL PUMP CONNECTS. THE CONTACT DROPPED THE VEHICLE OFF AT THE DEALER THE NEXT DAY AND THEY STATED THAT THE LEAK ORIGINATED FROM THE GAS TANK, AND IT NEEDED TO BE COMPLETELY REPLACED. THE VEHICLE IS STILL AT THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 59,000. UPDATED 04/16/08. *LJ THE TRANSMISSION WAS SLIPPING AND WOULD NOT ENGAGE IN 1ST GEAR. THE AIR CONDTION WAS BLOWING HOT AIR. THE IGNITION SWITHC SHORTED OUT.

Mileage: 59,000

SPEEDOMETER DOES NOT WORK ANYMORE. I CAN BE SITTING AT A STOP LIGHT AND THE SPEEDO WILL BE PEGGED AT 120MPH. OR WHEN IM DRIVING IT WONT MOVE AT ALL. SOMETIMES...I'LL START THE CAR, AND THE SPEED WILL BE SITTING AT 40 MPH. HAS BEEN HAPPENING FOR 3-4 MONTHS NOW. AND THE DEALERSHIP WILL NOT HELP ME. THEY TELL ME I HAVE TO BUY A WHOLE NEW INSTRUMENT CLUSTER ($475+) TO RESOLVE MY PROBLEM. THIS IS A VERY COMMON ISSUE WITH THESE VEHICLES. *TR

TACH GAUGE FOR SPEEDOMETER STARTED BE FAULTY. READ INACCURATE TO MY SPEED. *TR

TL*THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT THE REAR PASSENGER SIDE DOOR WOULD NOT LATCH. THE LATCHES FOR BOTH DRIVER SIDE DOORS WERE PREVIOUSLY REPLACED. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V494000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH) FOR THE ENVOY XL. THE FAILURE MILEAGE WAS 75,000 AND CURRENT MILEAGE WAS 102,000. UPDATED 01/11/08. *LJ THE FRONT DOOR LATCH ARE NOT STARTING TO FAIL. THE WINDSHIELD WIPER MOTOR FAILED. THE PINION SEAL WAS LEAKING AND THE TAILLIGHT CIRCUIT BOARD SHORTED OUT

Mileage: 75,000

THE ENVOY SPEEDOMETER REGISTERS 18 MPH IN THE PARKED POSITION. IT WILL NOT RETURN TO 0. I HAVE 45,000 MILES ON THE CLE AND IT HAS BEEN REGULARLY SERVICED BY THE SAME DEALERSHIP. *AK

Mileage: 45,000

2003 GMC ENVOY WITH A LIST OF PROBLEMS **NAR**CC THE CONSUMER BEGAN TO HEAR A KNOCKING AND PINGING IN THE ENGINE ON COLD STARTS AND FELT A HESITATION WHEN THE AUTOMATIC TRANSMISSION SHIFTED INTO GEAR. AFTER MANY COMPLAINTS, IT WAS FINALLY DISCOVERED THE ENGINE KNOCK WAS DUE TO SHORTER PISTONS IN THE RE-DESIGNED ENGINE AND THE HESITATION IN THE TRANSMISSION SHIFTING REQUIRED REPROGRAMMING. THE CONSUMER WAS TOLD HE WOULD HAVE TO LIVE WITH THE ENGINE KNOCK, BECAUSE IT COULD BE MORE TROUBLE TAKING THE ENGINE APART. ON A SEPARATE OCCASION, THE ENGINE STALLED DUE TO THE BATTERY DYING. FROM APRIL 2004 TO OCTOBER 2004 THE BATTERY FAILED SEVERAL TIMES AND HAD TO BE RE-CHARGED. DURING THAT SAME TIME THE ENGINE LIGHT ILLUMINATED AND EACH TIME IT HAPPENED, THE DEALER WOULD HAVE TO REPROGRAM THE ENGINE COMPUTER. THE RADIO WAS NOT FUNCTIONING PROPERLY WHICH PRIMARILY CONSISTED OF STATIC. THE DRIVER INFORMATION CENTER CONTROL KNOBS AS WELL AS THE RADIO KNOBS WORE OUT. THE FRONT CENTER CONSOLE WAS LOOSE. IT WAS DISCOVERED THAT THE ENGINE LIGHT WAS COMING ON BECAUSE THE THIRD STOP LIGHT THAT'S ON THE TOP OF THE LIFTGATE MALFUNCTIONED. THERE WAS A SHORT CIRCUIT IN THE STOP LIGHT. THE COOLING FAN BROKE, THE BRAKES AND THE LEFT FRONT HEAD LAMP HAD TO BE REPLACED. THE REAR TAIL LIGHTS, DIRECTIONAL AND SIGNAL LIGHTS HAVE BEEN REPLACED SEVERAL TIMES. THE LUG NUT BROKE WHILE A REPLACEMENT TIRE WAS BEING MOUNTED ON THE VEHICLE. THE FRONT STABILIZER LINKAGE WAS REPLACED. THE GAS TANK HAD TO BE REPLACED ALONG WITH THE FUEL LINES AND A SEAL ON THE TANK DUE TO A LEAK. THE SEAT BELT WAS DESIGNED POORLY AND THE BELT CUTS INTO THE CONSUMERS NECK. THE DRIVERS SIDE DOOR DIDN'T CLOSE PROPERLY, THE WINDSHIELD WIPERS WERE REPLACED WITHIN THE FIRST 2 YEARS. *JB

GMC ENVOY 55,000 MILES, SPEEDOMETER NO LONGER WORKS. ERRATIC BEHAVIOR, VARYING FROM REPORTING SPEED OF 30 MPH AT IDLE, TO 0 MPH ON THE HIGHWAY. *JB

Mileage: 55,000

OCTOBER-03 TO MARCH-04, BETWEEN 800 AND 3000 MILEAGE: SEVERAL DUAL AUTOMATIC CLIMATE CONTROL SYSTEM PROBLEMS. TEMPERATURE WOULD RUN BERSERK (VERY HOT IN COLD WEATHER WHEN SET AT 55F, NO AC IN HOT WEATHER). THE RADIO WOULD LOOSE ITS PRESET STATIONS. DEALER COULD NOT IDENTIFY PROBLEM (NO CODE WAS SET) AND TOLD ME TO RETURN WHEN CONDITION REPEATS WITHOUT TURNING OFF THE ENGINE. HE FINALLY FOUND A CODE INDICATION COMMUNICATION INTERRUPTION AND LOW BATTERY VOLTAGE. NO ACTION WAS TAKEN. THE PROBLEM RESURFACED TEMPORARILY AGAIN IN SUMMER OF 2005. *NM

Mileage: 800

1) SEQUENCE OF EVENTS - NOTHING HAPPENS WHEN WE TRY TO START. -BATTERY VOLTAGE OK, AUTO-HEADLIGHTS ON, BRIGHT - INSTRUMENT PANEL COMPLETELY DEAD -2 HOURS LATER, INSTRUMENT ON THE MILES PER HOUR INSTRUMENT IS GOING WILD, BACK AND FORTH FINALLY SETS AT ZERO, NOW ENGINE WILL START. CHECK ENGINE LIGHT IS ON FOR THE FIRST TIME - RADIO LOOSES PRESET STATION MEMORY 2) IT STARTED ABOUT A WEEK; WE HAD PROBLEMS STARTING THE WARM ENGINE. 3) AUTOMATIC CLIMATE CONTROL IS WORKING SORT OF, SOMETIME NOT 4) THE CHECK OIL CAME ON, AT THAT TIME THERE WAS PLENTY 5) THE BACKUP MIRROR OPTION IS ALWAYS LOOSING THE INPUT 6) TRANSMISSION PROBLEM LIGHT WAS ON FOR A DAY SOME TIME AGO WHILE DRIVING IN SB AND IN 2 WD, CALLED YOUR SERVICE AND WAS TOLD TO IGNORE THE DEALER REPLACED THE IGNITION SWITCH, A SUPERFICIAL FIX AS IT TURNED OUT LATER WHEN THE IGNITION SWITCH WAS REPLACED AGAIN. THE CAUSE OF THE PROBLEM WAS NOT IDENTIFIED. *NM

Mileage: 8,202

THE VEHICLE WAS IN SERVICE 3 TIMES WITHIN 14 DAYS, GM SAYS THE PROBLEM WAS THE IGNITION SWITCH, I SAY THE SOURCE OF THE PROBLEM HAS NOT BEEN FIXED. ENGINE STALLED 6 TIMES IN MOVING TRAFFIC, THE "ABS" WARNING LIGHT IS ON, SOME TIME THE "CHECK ENGINE SOON" LIGHT COMES ON. DEALER REPLACES THROTTLE BODY INJECTION ASSEMBLY. NEXT DAY THE VEHICLE STALLS AGAIN WITH SAME SYMPTOMS. DEALER REPLACED IGNITION SWITCH AGAIN. !4 HOURS LATER ENGINE STALLS IN MOVING TRAFFIC. DEALER INSTALLS EVENT RECORDING DEVICE, ENGINE STALLS AND IDENTIFIED LOW IGNITION VOLTAGE (6.7 VS 13.6 VDC). SOURCE OF PROBLEM COULD NOT BE IDENTIFIED, DEALER SAYS VEHICLE IS SAFE TO DRIVE. WE FILED A LEMON LAW CLAIM. *NM

Mileage: 18,707

DT: THE CONTACT STATED WHILE DRIVING, THE REDUCE POWER ENGINE AND OIL PRESSURE LOW, CHECK ENGINE IGHTS ILLUMINATED. THE VEHICLE STOPPED, ALTHOUGH, THE ENGINEWAS STILL RUNNING. THE DEALERSHIP WAS UNABLE TO DIAGNOSE A PROBLEM, BUT REPLACED THE TANK GASKET, GAS PEDAL, AND COMPUTER CHIP. THIS CAUSED THE CONTACT TO REAR END ANOTHER VEHICLE. *AK

Mileage: 27,200

SAFETY PROBLEM REGARDING CONTROL OF DRIVER'S REAR VIEW MIRROR ON 2003 GMC ENVOY. *BF THERE HAD BEEN A STRANGE COMBINATION OF ELECTRICAL EVENTS CENTERED AROUND THE ACCESSORIES IN THE LEFT FRONT OF THE VEHICLE AND THE LEFT DOOR MIRROR. OTHER PROBLEMS: THE SEAT WOULD MOVE ERRATICALLY WHEN STARTING AND SHUTTING DOWN, THE DRIVER'S SIDE DOOR DID NOT LOCK IN SYNC WITH THE OTHERS, THE LOCKS WOULD CLICK 4 TIMES AFTER DRIVING ONE MILE, AND THE CONTROL BUTTON LIGHTS ON THE DRIVERS ARM REST WAS COMING OFF. *SC *JB

THE CONSUMER TOOK THE VEHICLE IN FOR THE INSTRUMENT PANEL NOT WORKING. THE ODOMETER DID NOT SHOW A READING. THE SIDE MIRRORS MOVED ON THEIR OWN. *JB THE RADIO WAS INOPERATIVE, THERE WERE PROBLEM WITH ON STAR, THE A/C FREON WAS GOING INTO THE VEHICLES INTERIOR, FUEL LEAKED FROM THE TANK AND HAD RUN DOWN THE LEFT SIDE OF THE VEHICLE/DOOR, THE BELL LIGHT AND MESSAGE WARNED LOW FUEL WHEN THE TANK WAS AT IT'S CAPACITY, THE LIFTGATE WOULD NOT LATCH. *SC

Mileage: 2,000

UPON STARTING THE VEHICLE AND TAKING OFF THE GEAR SHIFTED, AND THEN DROPPED DOWN TO THE CORRECT GEAR IT SHOULD HAVE BE IN. TRANSMISSION WAS REPLACED WITHIN THE FIRST SIX MONTHS. ALSO, STARTER MADE A CLICKING NOISE SEVERAL TIMES BEFORE STARTING. THEN THE VEHICLE SHUT DOWN. *AK

UPON STARTING THE VEHICLE AND TAKING OFF THE GEAR SHIFTED, AND THEN DROPPED DOWN TO THE CORRECT GEAR IT SHOULD HAVE BE IN. TRANSMISSION WAS REPLACED WITHIN THE FIRST SIX MONTHS. ALSO, STARTER MADE A CLICKING NOISE SEVERAL TIMES BEFORE STARTING. THEN THE VEHICLE SHUT DOWN. *AK

CONSUMER COMPLAINED ABOUT A HORN PROBLEM. THE HORN WORKED INTERMITTENTLY. DEALER WAS UNABLE TO DUPLICATE THE PROBLEM 3 TIMES, BUT WAS ABLE TO CORRECT THE PROBLEM ON THE FOURTH TIME. *AK

Mileage: 27,000

WHILE DRIVING AT ANY SPEED ENGINE CHECK LIGHT CAME ON AND STAYED ON. DEALER CHECKED THIS PROBLEM ON THREE OCCASIONS. ON EACH OCCASION THE SPARK PLUGS WERE CHANGED, AND THE BATTERY CABLE BOLT WAS REPLACED.*AK *NM

Mileage: 3,000

FAULTY WIRING IN BRAKE LIGHT CAUSED VEHICLE TO CATCH ON FIRE. GM HAS OFFERED TO REPAIR BUT I STILL DON'T FEEL IT IS SAFE. *JB

Mileage: 36,000

PROBLEMS WITH THE SOFTWARE. DRIVER 1 AND 2 REMOTES DONT ALWAYS WORK. MIRRORS CHANGE BY JUST UNLOCKING. SOMETIMES THE ELECTRIC SEAT RELEASE PUTS THE SEAT INTO DRIVER 2 POSITION. TRANSFER CASE ON OCCASION, ALL LIGHTS START TO BLINK AND YOU CAN HEAR THE TRANSFER CASE SWITCHING.*AK

Mileage: 1,000

ENGINE STALLING WITH VEHICLE IN MOTION OR WHEN STOPPED. 5 STALLS OCCURRED WITHIN PAST 1000 MILES. SOMETIMES VEHICLE, CHUGS/SKIPS JUST BEFORE STALLING. VEHICLE HAS BEEN SERVICED 3 TIMES FOR THIS PROBLEM SINCE OCTOBER 27TH AND STILL NOT CORRECTED AS OF THIS WRITING. USUAL STALL SPEED IS AROUND 20 MPH. ONE TIME WAS DRIVING AT 65 MPH ON INTERSTATE, ALL DASHBOARD WARNING LIGHTS CAME ON VEHICLE HESITATED BUT DID NOT STALL. CRUISE CONTROL ALWAYS STOPS WORKING IMMEDIATELY FOLLOWING STALLING INCIDENTS. HAS STALLED UPON STOPPING AT STOP LIGHT/SIGN. VEHICLE HAS HAD MANY ELECTRICAL PROBLEMS SINCE APPROXIMATELY 800 MILES INCLUDING WINDSHIELD WASHER SYSTEM FAILURE (TWICE), ABS LIGHT ILLUMINATING, AIRBAG LIGHT. *LA

Mileage: 13,412

THE INSTRUMENT PANEL SPEEDOMETER LIGHT CAME ON AND OFF WITHOUT PRIOR WARNING. *AK

PURCHASED A 2003 ENVOY XL ON 27 DEC 02 - SINCE THAT TIME IT HAS BEEN TO THE GARAGE TWO TIMES - NO CLAMP ON ONE END OF THE POWER STEERING LINE (LUCKILY IT BLEW OFF WHILE STILL IN OUR DRIVE WAY - GOD HELP US IF IT HAD LET LOOSE AT HIGH SPEED ON A CROWDED HIGHWAY) SECOND TIME WAS FOR A BAD CAM SENSOR. AND WE HAVEN'T MADE THE FIRST PAYMENT YET. FIRST CASS NUMBER FROM GMC IS S1-68773551 - SECOND CASE NUMBER I DON'T HAVE YET AS I JUST REPORTED IT THIS MORNING. NEEDLESS TO SAY THAT MY WIFE AND I HAVE NO TRUST IN THIS CAR NOW - WHAT ELSE WILL GO WRONG NEXT.

Mileage: 574