2003 GMC SIERRA 1500 Service Brakes, Hydraulic Problems

WHILE HAVING MY VEHICLE CHECK OVER FOR THE WINTER, THE MECHANIC INFORM ME THAT THE FRONT BRAKE LINES ARE VERY RUSTY AS WELL AS THE FUEL LINES AND THE COOLING LINES GOING TO THE TRANSMISSION. THIS SITUATION IS VERY DISTURBING SINCE I HAVE VERY LOW MILEAGE. THE TUBING USED FOR THE BRAKE AS WELL AS THE FUEL LINES SHOULD BE ABLE TO WITHSTAND RUSTING FOR THE LIFE OF THE VEHICLE. IF THE MATERIAL USED BY GM WAS NOT UP TO SPECIFICATION AS FAR AS CORROSION PROTECTION EITHER COMPENSATION TO REPAIR IT IS IN ORDER A RECALL SHOULD BE MADE.

Mileage: 44,300

TL* THE CONTACT OWNS A 2003 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE FAILED TO RESPOND TO DECELERATION ATTEMPTS AND THAT THE BRAKE WARNING LIGHT ILLUMINATED. THE CONTACT INSPECTED THE BRAKES AND NOTICED THAT THE FAILURE WAS DUE TO CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. UPDATED 8/19/14*CN

Mileage: 150,000

TL* THE CONTACT OWNS A 2003 GMC SIERRA 1500. THE CONTACT STATED WHILE DRIVING IN REVERSE THE BRAKE PEDAL WAS STUCK TO THE FLOOR. THE EMERGENCY BRAKE HAD TO BE APPLIED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER AND THE FAILURE WAS LOCATED WITHIN THE BRAKE LINES DUE TO CORROSION. THE MANUFACTURER DENIED ASSISTANCE WITH THE REPAIR BECAUSE THE WARRANTY EXPIRED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 65000. THE BRAKE LINES BURST DUE TO RUST AND POOR DESIGN. THE CONSUMER STATED WATER AND SALT WERE TRAPPED INSIDE. THE BRAKE LINES WERE REPLACED AND POSITIONED ANOTHER WAY, SO THEY WOULD NOT HOLD SALT AND WATER FROM THE ROADS. UPDATED 06/27/12

Mileage: 65,000

THIS TRUCK AND I RESIDE IN WISCONSIN BUT WERE IN FLORIDA AT THE TIME OF THE INCIDENT. MY TRAVEL ON 2/21 WAS TO PICK UP MY YOUNG GRANDDAUGHTER AT HER SCHOOL. I WAS TRAVELING AT AROUND 40 MPH IN FAIRLY HEAVY AFTERNOON TRAFFIC, I HAD CROSSED A CONTROLLED INTERSECTION ABOUT A MILE FROM THE SCHOOL AND APPLIED THE BRAKES TO SLOW DOWN, THE PEDAL WENT TO THE FLOOR. I PUMPED THE BRAKES AND WAS ABLE TO SLOW THE TRUCK DOWN. I PROCEEDED TO THE SCHOOL AT A VERY REDUCED SPEED USING THE PARKING BRAKE AND PUMPING THE BRAKES. I WAS ABLE TO SAFELY GET TO THE SCHOOL. I EXITED THE SCHOOL YARD AND PARKED THE TRUCK. CALLED A TOW TRUCK FOR THE REST OF THE TRIP. THE MECHANIC THAT REPAIRED THE BRAKE LINES SAID THERE HAS BEEN A PARTIAL RECALL ON GMC AND CHEVROLET TRUCKS FOR FAULTY BRAKE LINES BUT MY TRUCK WAS NOT INCLUDED. HE SAID THE WORST RUST WAS AT THE ABS CONTROL BUT THERE WERE OTHER AREA'S INVOLVED ALSO. THIS VEHICLE IS ONLY 9 YEARS OLD. I HAVE OWNED VEHICLES MUCH OLDER THAN THIS ONE AND HAVE NEVER HAD A BRAKE LINE RUST THROUGH. I URGE YOU TO DO A DEEPER STUDY AND RECALL IF NECESSARY, INTO WHAT APPEARS TO BE THE USE OF INFERIOR BRAKE LINES AND/ OR POOR PLACEMENT OF THE ABS CONTROL ON A WIDER RANGE OF THIS VEHICLE. IT WAS FORTUNATE THAT THIS INCIDENT DID NOT CAUSE AN ACCIDENT OR INJURY OR TAKE PLACE AS WE WERE RETURNING HOME THROUGH THE MOUNTAINS IN TENNESSEE A FEW WEEKS LATER. I AGAIN URGE YOU TO EXTEND THE RECALL FURTHER INTO THIS TRUCKS PRODUCTION. THANK YOU FOR YOUR ATTENTION TO THIS DANGEROUS AND EXTREMELY UNSAFE CONDITION. *TR

Mileage: 72,380

TL* THE CONTACT OWNS A 2003 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE STOPPED, THE BRAKE PEDAL WAS ABNORMALLY DEPRESSED TO THE FLOORBOARD. THE CONTACT WAS ABLE TO SAFELY DRIVE THE VEHICLE HOME AND PARK. UPON EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT THE BRAKES LINES WERE FRACTURED AND CORRODED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

Mileage: 80,000

LOW SPEED CRASH IN DRIVEWAY DUE TO SUDDEN RUPTURE OF RT. FRONT BRAKE LINE METAL SECTION AT BANJO BOLT. AFTER INSPECTION OF THE TRUCK BY A MECHANIC I WAS INFORMED THAT 4 OTHER STEEL LINES ARE LEAKING DUE TO SEVERE CORROSION AND THAT EVERY STEEL LINE ON THE TRUCK IS IN DANGER OF FAILURE DUE TO SEVERE CORROSION. ESTIMATE TO REPAIR IS NEAR $1000.00 BODY DAMAGE FROM CRASH IS AROUND $900.00. *TR

Mileage: 78,719

MY 2003 GMC SIERRA 1500 SLE HAS CORRODED BRAKE, TRANSMISSION AND FUEL LINES. A CERTIFIED MECHANIC STATED THAT THEY ALL NEED REPLACED OR BREAKAGE AND LEAKAGE WILL OCCUR WITHOUT WARNING CAUSING BREAK, TRANSMISSION OR FUEL DELIVERY OR FIRE DAMAGES. PLEASE HELP WITH THIS PROBLEM ASAP. 00. *TR

I TOOK MY 2003 GMC SIERRA IN FOR AN INSPECTION, INSPECTION FAILED DUE TO CORRODED BRAKE LINES. WAS INFORMED THAT ALL BRAKE LINES NEED TO BE REPLACED. IS THIS NORMAL? I LIVE IN THE NORTH..THERE SEEMS TO BE A LOT OF RUST/CORROSION ON THE UNDERSIDE OF MY TRUCK AS WELL AS STARTING AROUND THE BODY..AM FACING SPENDING $400-$600 TO REPLACE THE LINES..LOOKING FOR INFO REGARDING THIS TYPE OF PROBLEM.. *TR

BRAKES BLEW OUT COMING DOWN A VERY STEEP HILL. I WAS LUCKY BECAUSE I HAD A TOYOTA IN FONT OF ME SLOWING DOWN BECAUSE OF A SQUIRREL CROSSING THE STREET. I HAD ALSO SLOWED DOWN BUT THEN THE TOYOTA STOPPED AND I WENT TO STOP MY BRAKE LINES BOTH FRONT AND BACK BLEW OUT AND MY PEDAL WENT TO THE FLOOR AND I HAD NO BRAKES AT ALL. THANKS TO THE TOYOTA BEING THERE TO STOP ME OTHER WISE I WOULD HAD A VERY BAD CRASH INTO CROSSING TRAFFIC OR HEAD ON INTO A GUARD RAIL OR TREES. I HAD TO PAY FOR ALL NEW BRAKELINES INSTALLED ON MY TRUCK AND THE DAMAGE TO THE TOYOTA AND MY TRUCK COSTING AROUND 2000.00 DOLLARS PLUS THE INSURANCE OVER 2300.00 FOR THE TOYOTA AND MY FRONT END. NOW IM AFRAID TO DRIVE MY TRUCK. *TR

Mileage: 57,540

TL* THE CONTACT OWNS A 2003 GMC SIERRA 1500. WHILE DRIVING 25 MPH, THE CONTACT APPLIED PRESSURE TO THE BRAKES WHEN THE PEDAL WAS DEPRESSED INTO THE FLOORBOARD AND THE VEHICLE DID NOT STOP. HE ACTIVATED THE EMERGENCY BRAKE AND WAS ABLE TO IDLE THE VEHICLE. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INFORMED THE CONTACT THAT THE BRAKE LINES WERE RUSTED AND NEEDED TO BE REPLACED. THE CONTACT WAS AWAITING REPAIRS. THE CURRENT AND THE FAILURE MILEAGES WERE 40,000.

Mileage: 40,000

TL* THE CONTACT OWNS A 2003 GMC SIERRA 1500. WHILE PARKED, DRIVER OF THE VEHICLE DEPRESSED THE BRAKE PEDAL AND PLACED THE GEAR IN DRIVE; HOWEVER, THE BRAKE PEDAL DROPPED TO THE FLOOR BOARD. THE VEHICLE CRASHED INTO THE DRIVER'S HOME. THE CONTACT DID NOT MENTION OF THERE WERE ANY INJURIES. THE VEHICLE WAS TOWED TO A COLLISION REPAIR SHOP. THE MECHANIC STATED THE BRAKE LINES WERE SEVERALLY CORRODED AND WOULD HAVE TO BE REPLACED. THERE WAS AN INVESTIGATION UNDER NHTSA ACTION NUMBER:PE10010 (SERVICE BRAKES, HYDRAULIC SERVICE BRAKES, HYDRAULIC:POWER ASSIST:HYDRAULIC:HOSES, LINES/PIPING, AND FITTINGS) THAT MAY BE RELATED TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 89,093 UPDATED 1/20/12 *CN THE CONSUMER STATED THE VEHICLE WAS PARKED IN THE DRIVEWAY. IT WAS PARKED TOWARDS THE TOP OF THE DRIVEWAY. THE DRIVEWAY HAS A STEEP SLOPE AND SLOPES DOWN TOWARD HIS PARENTS HOUSE. THE CONSUMER'S FATHER ENTERED THE VEHICLE, STARTED THE ENGINE, RELEASED THE EMERGENCY BRAKE, PUT HIS FOOT ON THE NORMAL BRAKE, AND PUT THE VEHICLE IN DRIVE. IT WAS AT THAT POINT, THE BRAKE PEDAL WENT TO THE FLOOR AND THE VEHICLE BEGAN ROLLING DOWN THE DRIVEWAY. THERE WAS APPROX 35 FEET BETWEEN THE STARTING POSITION OF THE VEHICLE AND WHERE THE VEHICLE STUCK THE FOUNDATION OF THE HOME. AT THE MOMENT OF THE BRAKE FAILURE, THE DRIVER TRIED PUMPING THE BRAKES ONE MORE TIME, AND THEN ATTEMPTED TO REACH FOR THE EMERGENCY BRAKE. AT THE TIME OF IMPACT, THE VEHICLE WAS TRAVELING BETWEEN 5-10 MPH. UPDATED 02/22/12

Mileage: 89,093

THE BRAKING SYSTEM FAILED WHEN THE PEDAL WENT TO THE FLOOR. INVESTIGATION REVEALED THAT THE STEEL BRAKE LINE HAD RUSTED AND RUPTURED. THE ONLY PRECURSOR TO THIS WAS NOISE FROM THE ABS UNIT AT LOW SPEED. IT APPEARS THAT ALL OF THE BRAKE LINES ARE BADLY CORRODED AND WILL NEED TO BE REPLACED. *TR

Mileage: 64,975

MAIN BRAKE LINE BLEW WHILE MY WIFE WAS BACKING UP IN A PARKING LOT, THE ONLY WAY TO STOP WAS TO PUT THE CAR IN PARK WHILE MOVING. WE HAD IT TOWED TO OUR LOCAL MECHANIC WHO HAD TO REPLACE EVERY BRAKE LINE. THE TRUCK ONLY HAS 68K MILES ON IT. THE MECHANIC SAID THEY WERE VERY BAD AND WE WERE LUCKY TO BE SAFE. I CANNOT BELIEVE THIS ISSUE HAS NOT BEEN ADDRESSED AND RECALLED BY GMC. OUR BILL WAS AN UNEXPECTED $1,300. I'M EXPECTING A CALL BACK FROM A DISTRICT GMC CONTACT MONDAY ABOUT THE ISSUE. I'M FIGHTING TO BE REIMBURSED AS THIS IS A KNOWN DEADLY ISSUE AND NEEDS TO BE RECALLED. HOW HAVE THEY NOT BEEN SUED FROM THIS PROBLEM YET? *TR

Mileage: 68,000

TL* THE CONTACT OWNS A 2003 GMC SIERRA 1500. WHILE DRIVING 40 MPH, THE BRAKE WARNING LIGHT ILLUMINATED WHEN HE APPLIED PRESSURE TO THE BRAKES. THE BRAKE PEDAL WENT TO THE FLOOR AND DID NOT IDLE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THE VEHICLE WITH RUSTED BRAKE LINES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 63,000.

Mileage: 63,000

A BRAKE LINE BURST UNDERNEATH THE TRUCK WHEN I APPLIED THE BRAKES WITH SUBSTANTIAL PRESSURE (NOT ENOUGH TO ENGAGE ABS ON THE DRY PAVEMENT). WAS ABLE TO SWERVE TO AVOID VEHICLE THAT CUT US OFF AND USE EMERGENCY BRAKE TO SLOW/STOP VEHICLE IN A SAFE PLACE. ALL BRAKE LINES WERE SEVERELY RUSTED/CORRODED AND NEEDED TO BE REPLACED. FUEL LINES WERE REPLACED AS WELL AT THE SAME TIME, DUE TO SEVERE CORROSION.

Mileage: 77,636

WHEN ATTEMPTING TO STOP TRUCK, BRAKE PEDAL FADED TO FLOOR. UPON INSPECTION, THE BRAKE LINES EXHIBITED SEVERE CORROSION AND RUSTED THRU ALLOWING FLUID TO LEAK OUT. THE TRUCK HAS LESS THAN 90,000 MILES. *TR

Mileage: 88,000

I ENTERED MY VEHICLE TO DRIVE HOME AND REALIZED THAT I HAD NO BRAKES. AFTER LOOKING UNDERNEATH I REALIZED THAT MY BRAKE LINES WERE ROTTED AND LEAKING. ONE LINE IS CURRENTLY LEAKING BUT THEY ARE ALL IN VERY BAD CONDITION. I WAS LEFT WITH NO OPTION BUT TO HAVE THE VEHICLE TOWED HOME. I AM GOING TO HAVE TO REPLACE ALL THE BRAKE LINES AS EVEN THE ONES THAT AREN'T CURRENTLY LEAKING ARE IN VERY POOR CONDITION. IT WOULD BE UNSAFE TO DRIVE THE VEHICLE WITHOUT REPLACING THEM. I AM VERY FORTUNATE THAT THE FAILURE DIDN'T OCCUR WHILE I WAS DRIVING AT A HIGH SPEED. WHEN I PARKED THE VEHICLE THE BRAKES WERE FINE AND WHEN I CAME OUT 20 MINUTES LATER I HAD ABSOLUTELY NO BRAKES.

Mileage: 140,127

LUCKILY THERE WAS NO ACCIDENT AS I HAVE BEEN TEACHING MY 16 YEAR OLD DAUGHTER TO DRIVE. THE BRAKES FELT SPONGY AND NOT AS RESPONSIVE AS NORMAL ON MY WAY HOME FROM WORK. WHEN I STOPPED IN MY DRIVEWAY, I LOOKED UNDER THE VEHICLE AND BRAKE FLUID WAS POURING OUT OF AN APPARENTLY RUPTURED LINE TO THE BACK BRAKES. THERE WAS NO WARNING LIGHT ON. REGARDLESS OF THE MILES, THIS TRUCK IS BARELY 8 YEARS OLD. A QUICK INTERNET SEARCH SHOWS THAT THIS MODEL YEAR AND NEARBY YEARS OF THE SAME TYPE OF TRUCK HAVE EXPERIENCED THIS PROBLEM. HAD THIS BEEN ON A HIGHWAY TRIP WITH ALL FLUID DRAINING OUT, THERE CERTAINLY WOULD HAVE BEEN AN ACCIDENT.

Mileage: 97,025

PURCHASED 2003 GMC SIERRA 1500 USED FROM PRIVATE PARTY ON SEPT 10, 2010 AND UPON NYS SAFETY INSPECTION ALL STEEL BRAKE LINES WERE DISCOVERED TO BE COMPLETELY ROTTED OUT. COST TO REPAIR EXCEEDED $700.00. *TR

Mileage: 85,770

TL* THE CONTACT OWNS A 2003 GMC SIERRA 1500. THE VEHICLE WAS TAKEN TO A STATE INSPECTION STATION WHERE THE CONTACT WAS INFORMED BY THE TECHNICIAN THAT THE BRAKE LINES EXHIBITED SEVERE RUST. THE DEALER WAS NOTIFIED OF THE FAILURE BUT BECAUSE THE VEHICLE WAS OUTSIDE OF WARRANTY, THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE CONTACT STATED THAT THE MAIN FRAME ALSO EXHIBITED RUST AND CORROSION. THE CONTACT WAS IN THE PROCESS OF TAKING THE VEHICLE TO AN INDEPENDENT MECHANIC FOR REPAIR. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 72,000.

Mileage: 72,000

TRAVELING TO WORK AND VEHICLE CUT OUT INFRONT OF MY TRUCK. APPLIED BRAKES TO AVOID COLLISION AND HEARD POP AND BRAKE PEDAL WENT TO FLOOR. UPON ARRIVING AT WORK A FEW MOMENTS LATER FOUND REAR BRAKE LINE CORRODED AND PERFORATION WENT THROUGH CAUSING LEAK. REPLACED THE REAR BRAKE LINE TO CORRECT BUT BRAKES STILL INOP. OLD PIECE OF CORRODED LINE IS AVAILABLE. *TR

Mileage: 70,003

ON SEPTEMBER 29, 2010, I WAS DRIVING MY TRUCK ON RT. 66 WEST APPROACHING LINDEN VA. AT APPROXIMATELY 65 MPH WHEN TRAFFIC BEGAN TO STOP ABRUPTLY BECAUSE OF ROADWORK. I WAS IN THE LEFT LANE AND APPLIED MY BRAKES. AT THIS TIME MY BRAKE PEDAL WENT TO THE FLOOR. I HAD BEGUN MY STOP FAR ENOUGH AWAY FROM TRAFFIC AHEAD OF ME THAT I WAS ABLE TO SLOW DOWN WITHOUT HITTING ANYONE IN FRONT OF ME. I MOVED MY TRUCK OVER TO THE RIGHT SHOULDER, THEN ONTO THE RAMP FOR THE LINDEN VA. EXIT AND THEN PARKED ON THE SHOULDER THERE. WHEN I GOT OUT OF THE TRUCK I FOUND A PUDDLE OF BRAKE FLUID QUICKLY FORMING UNDER MY TRUCK, BELOW THE LEFT FRAME RAIL BEHIND THE LEFT FRONT WHEEL. WHEN I LOOKED UP TO SEE WHERE THE FLUID WAS COMING FROM, I FOUND THE LEAK COMING FROM A BUNDLE OR FOUR BRAKE LINES, THAT WERE HEAVILY CORRODED, THAT RAN BESIDE THE FRAME RAIL. AT THIS TIME I MADE ARRANGEMENTS TO HAVE THE TRUCK TOWED TO MY RESIDENCE. AT THE TIME I WAS TOWING A SINGLE AXLE UTILITY TRAILER. THE TRUCK HAS NOT YET BEEN REPAIRED. THIS TRUCK IS A 2003 GMC SIERRA 1500 HD CREW CAB SHORT BED, 8600 GVW. IT IS NEARLY IDENTICAL IN EQUIPMENT TO A 2500 HD CREW CAB SHORT BED. I PURCHASED THIS VEHICLE NEW. *TR

Mileage: 112,985

WHILE DRIVING HOME FROM WORK, I TRIED TO STOP AT A STOP LIGHT. PUSHED THE BRAKE PEDAL AND IT WENT TO THE FLOOR. GOT IT STOPPED BY USING THE PARKING BRAKE. SERVICE BRAKE LIGHT ON. AFTER PARKING THE TRUCK, NOTICED LIQUID ON DRIVEWAY. TRACED THE LIQUID BACK TO A RUSTED BRAKE LINE. *TR

Mileage: 42,200

I OWN A 2003 GMC SIERRA 1500 HD. THIS PAST WINTER I ALMOST HIT A SNOW PLOW DUE TO A BRAKE LINE RUPTURE. UPON INSPECTION IT WAS FOUND THAT ALL THE BRAKE LINES WERE SEVERELY RUSTED AND VERY BRITTLE. I HAD THE ONE LINE REPLACE WHICH COST ME NEARLY $300. NO THIS PAST WEEK ANOTHER RUPTURE ALMOST CAUSED ME TO REAR END ANOTHER VEHICLE. THIS TIME I'M GOING TO HAVE TO REPLACE EVERY LINE IN THE BRAKING SYSTEM. ALSO THE ABS SYSTEM KICKS IN WHEN TRAVELING AT SLOWER SPEEDS (5-10 MPH). THE CAUSE OF THIS IS UNKNOWN TO ME AT THIS TIME. UPON DOING A LITTLE RESEARCH ONLINE I FIND THAT THERE ARE THOUSANDS OF PEOPLE WITH THE SAME MODEL AND NEARLY THE SAME YEAR VEHICLES, HAVING EXACTLY THE SAME PROBLEMS. THEN I FIND ON YOUR SITE WHERE YOU HAVE STARTED AN INVESTIGATION INTO THE PROBLEM. NHTSA ACTION NUMBER: PE10010 THIS TRUCK HAS BEEN VERY WELL TAKEN CARE OF AND THERE IS NO EXCUSE FOR THESE LINES TO BE FAULTY IN ONLY 6-7 YEARS TIME. IT'S LIKELY TO COST ME NEARLY A $1,000 TO HAVE ALL OF THESE LINES CHANGED. MY QUESTION IS IF THE NHTSA FINDS GM RESPONSIBLE FOR THESE FAULTY LINES AND THEY ISSUE A RECALL, WILL I BE REIMBURSED FOR HAVING ALREADY PAID FOR THE REPAIR? *TR

Mileage: 106,000

2003 GMC TRUCK FAILED SAFETY INSPECTION DEW TO EXTREMELY RUSTED BRAKE LINES. *TR

Mileage: 13,312

HAD DEALERSHIP REPLACE DRIVER SIDE FRONT WHEEL BEARING BECAUSE IT WAS MAKING A GRINDING NOISE. A COUPLE MONTHS LATER THE FRONT BRAKE PADS AND ROTORS WERE REPLACED. AFTER THE BRAKES WERE SERVICED, I STARTED NOTICING THAT THE BRAKES WERE PULSATING, WHICH WAS FELT IN THE PEDAL, AT LOW SPEEDS. TOOK VEHICLE TO THE DEALERSHIP AND THEY SAID DURING THE TEST DRIVE THAT THE ABS SYSTEM WAS ACTIVATING UNNECESSARILY. THEY THEN PUT IT ON THE DIAGNOSTIC MACHINE FOR SOME REASONS. I WAS TOLD I NEEDED TO REPLACE BOTH WHEEL ABS SENSORS. THE DEALERSHIP SAID THAT THE ABS HAS NOTHING TO DO WITH THE BRAKE PADS AND ROTORS. WHEN THE PADS AND ROTORS WERE REPLACED, AGAIN THE VEHICLE WAS PUT ON THE DIAGNOSTIC MACHINE, BUT DIDN'T PICK UP THAT THE SENSORS WERE FIRING. I'M DOUBTING IT IS COINCIDENCE THAT THESE THINGS ARE HAPPENING AT RANDOM. THERE HAS TO BE SOME KIND OF CORRELATION BETWEEN THE WHEEL BEARING BEING REPLACED, THE PADS AND ROTORS BEING REPLACED, AND NOW THE SENSORS NEEDING TO BE REPLACED. MY VEHICLE IS A 2003 GMC SIERRA AND HAS 47000 MILES ON IT. ALL THIS HAPPENED WITHIN THE LAST 6 MONTHS AND 1500 MILES. *TR

Mileage: 47,500

LOST APPROXIMATELY 80% OF BRAKING POWER IN A 2003 GMC SIERRA 1500 WITH 60,000 MILES. SMALL LEAK DEVELOPED IN THE METAL BRAKE LINES. THERE WAS NO SENSOR INDICATION THAT FLUID WAS LOW DESPITE BRAKE FLUID BEING ONE QUART LOW. *TR

Mileage: 58,700

TOTAL BRAKE FAILURE ON A 2003 GMC SIERRA PICKUP TRUCK 62,000 MILES. *TR

Mileage: 62,300

TL*THE CONTACT OWNS A 2003 GMC SIERRA 1500. WHILE DRIVING IN REVERSE AND ATTEMPTING TO DEPRESS THE BRAKE PEDAL, THE PEDAL EXTENDED TO THE FLOOR. HE STATED THAT THE BRAKE LIGHT ALSO ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT WAS FORCED TO APPLY CONTINUOUS PRESSURE TO THE BRAKES IN ORDER TO STOP THE VEHICLE. WHEN THE CONTACT STEPPED OUT OF THE VEHICLE, HE NOTICED FLUID LEAKING FROM THE BRAKE LINE WHICH WAS COVERED WITH RUST. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT ALL FOUR BRAKE LINES WERE COVERED WITH RUST. ONE OF THE BRAKE LINES WERE REPAIRED. THE FAILURE MILEAGE WAS 77,448. THE CURRENT MILEAGE WAS 77,548.

Mileage: 77,448

REGARDING NHTSA INVESTIGATION PE10010. I HAVE A 2003 GMC SIERRA AND THE STEEL BRAKE LINES ARE CORRODED BEYOND RECOGNITION. A RECALL TO REPLACE THESE LINES NEEDS TO BE INSTITUTED. *TR

STARTING AT <5K MILES THE VEHICLE POWER TRAIN CLUNKED WHEN SHIFTING FROM 2ND TO 3RD GEAR. NOW AT 70K MILES IT CLUNKS WHEN SHIFTING BETWEEN ALL GEARS EXCEPT FINAL DRIVE. THE DEALERSHIP REPLACED THE OUTPUT SHAFT ON THE TRANNY, THEN THE U-JOINTS, AND MODIFIED THE ELECTRICAL SHIFT PATERN. IT STILL CLUNKS. POWER STEERING INTERMITTENTLY LOCKS UP AT SLOW SPEED TURNS, ESPECIALLY WHEN BRAKING. LIGHT BULBS BURN OUT ALMOST EVERY THREE MONTHS. HAD TO PAY ($486.00) FOR REPLACING THE INTAKE MANIFOLD GASKET WHEN VEHICLE HAD LITTLE OVER 40K MILES. BRAKES FADE AND THE PEDAL ALMOST GOES TO THE FLOOR, AGAIN INTERMITTENT. I HAVE ALMOST CAUSED SEVERAL ACCIDENTS DUE TO THE STEERING AND BRAKE ISSUES. GMC ISSUED A LETTER STATING "THIS IS A NORMAL OCCURANCE AND WILL NOT CAUSE DAMAGE." WELL, IT'S GETTING WORSE IN SOUND AND CLUNKING HARDER DURING SHIFTING. *TR

Mileage: 4,500

BRAKES FAILED BECAUSE OF CORRODED BRAKE LINES THAT FAILED ON THE WAY TO WORK . IT WAS FIXED,AND ANOTHER BROKE WHEN BEING TESTED! BECAUSE OF THIS WERE AFRAID TO DRIVE VEHICLE UNTIL RECALL IS IN EFFECT ! *TR

Mileage: 68,676

2003 GMC HALF TON SIERRA TRUCK. 3 TIME SINCE 2003 THAT I'VE HAD TO TAKE IT IN FOR CLUNKING NOISE FELT THRU STEERING WHEEL. LUBED A COUPLE TIMES THEN REPLACED THE INTERMEDIATE STEERING SHAFT. STILL NO GUARANTEES THAT IT WON'T HAPPEN AGAIN. ALSO VERY HARD TO STEER WHEN BRAKING AND BRAKES DON'T RESPOND WELL WHEN APPLIED QUICKLY. THE FIRST TIME THE INTERMEDIATE STEERING SHAFT NEEDED ATTENTION THE TRUCK ONLY HAD 15,000 MILES ON IT. THE SECOND TIME WAS 30,000 MILES AND THE LAST TIME WAS 45,000 MILES AND OCCURRED IN MARCH 2010. *TR

Mileage: 15,000

PREMATURE FAILURE OF BRAKE LINES DUE TO ACCELERATED CORROSION. ALL METALLIC PORTIONS OF BRAKE LINES EXHIBITING SEVERE CORROSION ALONG TOTAL LENGTH AND LOSS OF THICKNESS TO THE POINT OF FAILURE. HAVE INSPECTED 6 OTHER TRUCKS OF SAME YEAR AND MODEL AND ALL EXHIBITED SIMILAR DEGREE OF CORROSION. IT IS OBVIOUS THAT BRAKE LINE MATERIAL OF CONSTRUCTION IS DEFICIENT.

Mileage: 123,000

CORRODED BRAKE LINES ON 2003 GM SIERRA 1500 LONG BOX PICKUP TRUCK. FIRST FAILURE WAS IN JANUARY 2009. SECOND FAILURE IN FEBRUARY 2010. WHEN TRUCK WAS INSPECTED IN NOV. 2009, INSPECTOR INDICATED THAT GM TRUCK BRAKE LINES ARE A KNOWN SAFETY HAZARD. HE LOOKED OVER MINE, BUT DID SEE EVIDENCE OF NEED FOR IMMEDIATE REPAIR. TRUCK WAS BOUGHT NEW IN OCT. 2003 BY ME, AND NOW HAS ONLY 24,500 ORIGINAL MILES ON IT. GM SHOULD MOST DEFINITELY BE REQUIRED TO RECALL THESE VEHICLES AND REPLACE ALL CORROSION-PRONE BRAKE LINES WITH CORROSION-PROOF ONES. THERE IS NO GREATER SAFETY CONCERN THAN BRAKING. I AM TAKING TRUCK TO HAVE ALL LINES REPLACED AT MY EXPENSE, IN THE INTEREST OF MY AND OTHERS' SAFETY. BUT, GM SHOULD NOT BE ALLOWED TO FOIST JUNK WITH MASSIVE SAFETY CONSEQUENCES UPON CONSUMERS AND GET TO WALK AWAY FROM IT. THE POTENTIAL HERE MAKES THE TOYOTA GAS PEDAL PROBLEM SEEM LIKE A TRIVIAL JOKE! *TR

Mileage: 24,500

2003 GMC SIERRA 1500 PU TRUCK - CORRODED AND FAILING HYDRAULIC BRAKE LINES. THIS TRUCK WAS PURCHASED NEW BY ME IN OCTOBER 2003, AND NOW HAS ONLY 23,700 MILES ON IT. A LINE NEAR THE FUEL TANK, WHICH FEEDS THE REAR WHEEL CALIPERS, RUSTED THROUGH IN JANUARY 2009. OTHER LINES IN NUMEROUS LOCATIONS ALSO SHOW SIGNS OF CORROSION WHICH WILL LEAD TO FUTURE FAILURES. MECHANICS IN THIS AREA TELL ME THIS IS VERY COMMON, EVEN ON SOME NEWER GMC (AND SIMILAR CHEVROLET) VEHICLES. SOME OF THESE MECHANICS REPLACE THE FAULTY LINES WITH TUBING WHICH IS MORE CORROSION-RESISTANT THAN PROVIDED BY THE MANUFACTURER. A COUPLE OF WEEKS AGO, ONE OF THE REAR, REAR WHEEL EMERGENCY BRAKE CABLES ON THIS VEHICLE ALSO FAILED DUE TO CORROSION, AND THE OTHER ONE SHOWED SIGNS OF THE SAME FAILURE IMPENDING. BOTH WERE REPLACED. A SERIOUS, FUNDAMENTAL AND COMPOUND HAZARD EXISTS UNDER THIS SCENARIO. THE MANUFACTURER SHOULD BE REQUIRED TO RECALL THEE VEHICLES AND REPLACE ALL CRITICAL BRAKE COMPONENTS SUBJECT TO CORROSIVE FAILURES WITH CORROSION-PROOF (OR AT LEAST HIGHLY CORROSION-RESISTANT) PARTS. *TR

Mileage: 22,000

2003 GMC 1500 SERIES PICKUP TRUCK...WON'T STOP SLOW SPEED ANTI-LOCK BRAKE FAILURE. *TR

Mileage: 90,000

TL*THE CONTACT OWNS A 2003 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 5 MPH AND ATTEMPTING TO MAKE A COMPLETE STOP, THE ABS WOULD SHUT OFF. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT REPAIRED THE VEHICLE HIMSELF AND STATED THAT IT WAS IDENTICAL TO THE FAILURES MENTIONED IN THE 2005 SIERRA K1500 RECALL. THE FAILURE MILEAGE WAS 31,000 AND CURRENT MILEAGE WAS 32,580.

Mileage: 31,000

TL*THE CONTACT OWNS A 2001 GMC SIERRA 1500. WHILE DECELERATING, THE BRAKES MAKE A STRANGE NOISE AND THE VEHICLE TAKES A LONG TIME TO REACH A COMPLETE STOP. THE DEALER WANTS TO CHARGE $85 TO PERFORM A DIAGNOSTIC; THEREFORE, THE CONTACT WILL NOT HAVE THE VEHICLE REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT HE WOULD RECEIVE A CALL BACK. THE CURRENT MILEAGE WAS 46,000 AND FAILURE MILEAGE WAS 44,000. UPDATED 04/23/08. *LJ THE CONSUMER STATED THE ABS ACTIVATED WHEN BRAKING AT LOW SPEEDS.

Mileage: 44,000

2003 GMC SIERRA WITH SEVERAL PROBLEMS. CONSUMER STATES THAT THE TRANSMISSION FAILED. PASSENGER SIDE WINDOW MOTOR BROKE, SPEEDOMETER FAILED DUE TO STEPPER MOTOR FAILURE, TRUCK IS ON THE THIRD SET OF FRONT BRAKE ROTORS, AND UPPER SUPPORT COLUMN BEARINGS, AND MORE PROBLEMS. *KB THE CONSUMER STATED THE DEALER REFUSED TO REPLACE THE UPPER SUPPORT BEARING, BUT REPLACED THE INTERMEDIATE SHAFT INSTEAD. THE REAR PLANATERY FORWARD CLUTCH WAS BURNT, WHICH CAUSED THE TRANSMISSION TO FAIL. *JB

MY ABS ACTIVATES TOO ON DRY PAVEMENT. HAVE NOT TAKEN TO THE DEALER YET. WAY TOO MANY PROBLEMS WITH THIS VEHICLE. ONLY 60,000 MILES ON IT. *TR

Mileage: 60,000

TL*THE CONTACT OWNS A 2003 GMC SIERRA 1500. WHILE APPROACHING A STOP AT APPROXIMATELY 5 MPH OR LESS, THE BRAKE PEDAL PULSATES. THE VEHICLE WAS TAKEN TO A DEALER AND THEY DISCOVERED THAT THERE WERE TWO FAULTY ABS SENSORS. BOTH SENSORS WERE REPLACED. THE CURRENT MILEAGE WAS 58,195 AND FAILURE MILEAGE WAS 48,000.

Mileage: 48,000

2003 GMC SIERRA 1500 WITH 70K MILES. HAVE HAD PROBLEMS ON DIFFERENT OCCASIONS WITH THE ANTI-LOCK BRAKES AT LOW SPEEDS. HAD TO REPLACE SENSORS ON ALL 3 OCCASIONS. ALSO, BRAKE LINE BUSTED WHICH RESULTED IN A NEAR CRASH INTO A HOME. AFTER FURTHER INVESTIGATION, ALL BRAKE LINES LEADING IN THE ANTILOCK BRAKE COMPONENT WERE SEVERALLY RUSTED. ALL BRAKE LINES NEEDED TO BE REPLACED AT A VERY HEFTY PRICE. *TR

Mileage: 75,000

BRAKE PROBLEMS, AT SLOW SPEEDS, ON MY 2003 GMC SIERRA RESULT IN NEAR CRASHES EVEN THOUGH ALL BRAKE COMPONENTS WERE VERY RECENTLY REPLACED. VEHICLE ONLY HAS 20,000 MILES ON IT. *TR

TL*THE CONTACT OWNS A 2002 GMC SIERRA 1500. WHILE APPLYING PRESSURE TO THE BRAKE PEDAL TO STOP THE VEHICLE, THE ABS ENGAGED AUTOMATICALLY. THIS CAUSED THE VEHICLE TO JERK DRAMATICALLY INSTEAD OF STOPPING. THE DEALER STATED THAT HIS VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V379000 (SERVICE BRAKES, HYDRAULIC:ANTI LOCK). THE VEHICLE HAS NOT BEEN REPAIRED. HE FILED A FORMAL COMPLAINT WITH THE MANUFACTURER. THE CURRENT MILEAGE WAS 53,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 01-11-08. *KB UPDATED 12/31/07. *JB

Mileage: 50,000

ANTI- LOCK BRAKES ON MY 2003 GMC SIERRA ARE CHATTERING AND NOT STOPPING PROPERLY AT LOW SPEEDS. THIS IS THE SAME DEFECT THAT IS SUBJECT TO RECALL BUT ONLY UP TO THE 2002 MODEL. I WOULD LIKE TO HAVE MY VEHICLE INCLUDED IN THIS OR SUBSEQUENT RECALLS. *JB

Mileage: 30,200

TL*THE CONTACT OWNS A 2003 GMC SIERRA 1500. WHILE DRIVING 5 MPH, THE ANTILOCK BRAKES ACTIVATED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE DEALER HAS NOT INSPECTED THE VEHICLE. RECALL # 05V379000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK) DOES NOT INCLUDE THE 2003 MODEL. THE CONTACT FELT THAT HIS VEHICLE SHOULD BE INCLUDED IN THE RECALL. THE CURRENT MILEAGE IS 26,000 AND FAILURE MILEAGE WAS 25,500.

Mileage: 25,500

TL*THE CONTACT OWNS A 2003 GMC SIERRA 1500. THE CONTACT HEARD A GRINDING NOISE COMING FROM THE FRONT DRIVER SIDE OF THE VEHICLE. THE NOISE WAS HEARD WHEN THE VEHICLE WAS SHUT OFF. HE ALSO FELT A VIBRATION COMING FROM THE ABS UNIT. THE DEALER HAS NOT INSPECTED THE VEHICLE TO DETERMINE THE CAUSE OF FAILURE. THE CONTACT STATED THAT HE WAS UNABLE TO DEACTIVATE THE WINDSHIELD WIPERS. THE DEALER STATED THAT THE WIPER PULSE MODULE SHOULD BE REPLACED. THE DEALER MADE THE REPLACEMENT AND NO OTHER FAILURES HAVE OCCURRED. THE CURRENT MILEAGE IS 34,025 AND FAILURE MILEAGE WAS 33,000.

Mileage: 33,000

VEHICLE BRAKE ANTI-LOCK ENGAGES AT LOW SPEED. 1 OCCURRENCE OF LOSS OF BRAKES WHILE SLOWING ON STEEP HILL. THIS IS A CONSTANT PROBLEM EVERY TIME I STOP AT A TRAFFIC LIGHT, STOP SIGN OR PARKING. MY MODEL YEAR IS NOT INCLUDED IN A RECALL FOR THE EXACT SAME PROBLEM IN EARLIER MODEL YEARS. *JB

DT*: THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING UNWARRANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THE VEHICLE IS REGISTERED IN MICHIGAN. THE VEHICLE WAS TAKEN TO THE DEALER ON 12/15/06 WHO DETERMINED THAT THE VEHICLE COULD BE REPAIRED AT COST. THERE IS A NHTSA RECALL #05V379000, REGARDING THE SERVICE BRAKES, HYDRAULIC: ANTILOCK. THE VIN WAS NOT INCLUDED IN THE RECALL.

Mileage: 37,000