2001 GMC SIERRA 2500 Engine And Engine Cooling Problems

TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500. THE CONTACT STATED WHILE DRIVING 50 MPH THE VEHICLE STALLED WITHOUT ANY WARNINGS. THE CONTACT MENTIONED THAT HE WAS ABLE TO TURN THE VEHICLE BACK ON BUT THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MECHANIC ALSO ADVISED THAT THE FUEL LINES NEEDED TO BE CLEANED. THE REMEDY FAILED TO REPAIR THE PROBLEM. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA RECALL CAMPAIGN ID NUMBER: 07V521000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 79,500 AND THE CURRENT MILEAGE WAS 80,000.

Mileage: 79,500

EXHAUST BOLTS BROKE OFF AND NOW GASKET HAS FAILED. *TR

Mileage: 113,000

TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE STALLED WITHOUT WARNING. UPON RESTARTING, THE VEHICLE OPERATED NORMALLY AND WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT THE CRANKSHAFT POSITION SENSOR WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE CONTINUED TO RECUR WHENEVER THE VEHICLE WAS IN MOTION. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 94,000. UPDATED 09/15/11 *BF THE CONSUMER LEARNED A RECALL HAD BEEN ISSUED FOR THE CRANKSHAFT POSITION SENSOR. HOWEVER, HIS VIN WAS NOT INCLUDED. UPDATED 11/04/11

Mileage: 94,000

TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE CRANK SHAFT POSITION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 07V521000 (ENGINE AND ENGINE COOLING) THAT MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 54,500. UPDATED 08/31/11*LJ UPDATED 09/07/11

Mileage: 54,500

TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS UNABLE TO RESTART AND WAS TOWED TO THE CONTACTS HOME. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALL. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 101,000.

Mileage: 101,000

2001 GMC SIERRA - 8.1 ENGINE. ENGINE SHUTTING OFF WHILE DRIVING AND/OR FAILURE TO RESTART AFTER SHUT DOWN. THERE WAS AN NHTSA CASE FOR RECALLS, 07V521000, BUT MY VEHICLE WAS NOT PART OF THE RECALL CAMPAIGN 06083 BY GM FOR A DEFECTIVE CRANKSHAFT POSITION SENSOR. GM WOULD NOT INCLUDE MY VEHICLE IN THE RECALL IN SPITE OF IT BEING AN IDENTICAL FAILURE. I BELIEVE THERE ARE MORE VEHICLES WITH DEFECTIVE SENSORS THAT WERE NOT INCLUDED IN THE ORIGINAL RECALL. IT COST OVER $700 TO REPAIR WHAT I BELIEVE IS A BIG SAFETY PROBLEM. I WAS LUCKY TO NOT GET IN AN ACCIDENT AFTER MY ENGINE SHUT OFF WHILE DRIVING ON THE HIGHWAY. THE SHUT DOWN RESULTED IN A LOSS OF POWER STEERING AND POWER BRAKES SO IT WAS DIFFICULT TO COAST TO A SAFE LOCATION ON THE HIGHWAY. *TR

Mileage: 60,380

ENGINE DIED WHILE DRIVING ON THE FREEWAY. *TR

Mileage: 63,471

TL*THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. THE CONTACT STATED THAT FOR THE PAST YEAR THE VEHICLE HAD STALLED INTERMITTENTLY. THERE WERE NO PRIOR WARNINGS PRIOR TO THE STALLING, BUT THE MESSAGE CENTER AND BATTERY LIGHT WOULD ILLUMINATE AFTER THE FAILURE OCCURRED. THE DEALER PERFORMED A DIAGNOSTIC TEST, BUT WAS UNABLE TO DETECT ANY FAILURE CODES. THE CONTACT TRIED REPLACING THE FUEL PUMP AND RELAYS, BUT THAT DID NOT CORRECT THE FAILURE. THE CONTACT THEN BECAME AWARE OF A RECALL FOR THE CRANKSHAFT POSITION SENSOR UNDER RECALL CAMPAIGN NUMBER 07V521000, ENGINE AND ENGINE COOLING. THE MANUFACTURER CONFIRMED THAT ALTHOUGH THE VEHICLE WAS EXPERIENCING THE SAME FAILURE, IT WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 52000 AND THE CURRENT MILEAGE WAS 58300. UPDATED 02/07/11 *BF UPDATED 04/20/11

Mileage: 52,000

I HAVE OWNED MY 2001 GMC SIERRA 2500HD TRUCK SINCE IT WAS NEW. THE VEHICLE CURRENTLY HAS APPROXIMATELY 92,000 MILES ON IT. DURING THE TIME I HAVE OWNED IT, IT HAS HAD A PROBLEM WITH THE EXHAUST MANIFOLDS COMING LOOSE, DUE TO LOOSING STUDS, BROKEN STUDS OR THE STUDS JUST FALLING OUT. THE TWO DEALERSHIPS HAVE REPAIRED THIS PROBLEM FOUR OR FIVE TIMES WHILE UNDER WARRANTY AND THE PROBLEM HAS OCCURRED AGAIN. I HAVE NEVER SEEN THIS KIND OF PROBLEM ON ANY OTHER VEHICLE THAT I HAVE OWNED AND I HAVE OWNED MANY VEHICLES. THE DANGER THAT THIS PROBLEM CREATES IS THE POSSIBILITY OF FIRE AND CARBON MONOXIDE IN THE CAB OF THE TRUCK. GM/THE DEALERSHIPS REFUSE TO ADDRESS THIS ISSUE, SO I AM FORCED TO TURN IT OVER TO YOU. *TR

I HAVE OWNED MY 2001 GMC SIERRA 2500HD TRUCK SINCE IT WAS NEW. THE VEHICLE CURRENTLY HAS APPROXIMATELY 92000 MILES ON IT. WITH THE BRAKE LINE PROBLEM I RECENTLY HAD I FIGURED I SHOULD REPORT THE OTHER ISSUES THAT I DON?T THINK I SHOULD BE HAVING WITH A VEHICLE THAT IS LESS THAN 10 YEARS OLD. THE OIL COOLER LINES AND THE TRANSMISSION COOLER LINES HAVE ALL RUSTED THROUGH AND HAVE HAD TO BE REPLACED. ALONG WITH THE LINES, THE CONNECTORS FOR THE LINES HAVE ALL HAD TO BE REPLACED DUE TO CATASTROPHIC FAILURE (THEY RUSTED SO BAD THAT WERE FALLING APART). IF THE VEHICLE WAS 20 YEARS OLD I MIGHT EXPECT THIS PROBLEM, BUT NOT ON ONE LESS THAN 10 YEARS OLD AND THE MILEAGE THAT IT HAS. *TR

Mileage: 90,300

CRANK SENSOR FAILURE, WITH VEHICLE STALLING AND NOT RE-STARTING UNTIL ENGINE COOLS DOWN. ALSO CRANK SENSOR WAS REPLACED AT APPROX. 60,000 MILES. SAME PROBLEM RE-OCCURRING WITH VEHICLE NOW AT 84,000 MILES. *TR

Mileage: 84,000

I HAVE A TRUCK THAT HAS THE SAME ISSUE AS THE RECALL IN THIS RECALL NUMBER 07V521000 YET GMC DOES NOT CLAIM IT IN THE RECALL. THE ISSUE IS THAT THE RECALL IS FOR A STALLED ENGINE THAT I HAVE EXPERIENCED MANY TIMES. WHY WOULDN'T GMC COVER ALL THE VEHICLES INVOLVED. THE ENGINE HAS STALLED A NUMBER OF TIMES AT HIGH SPEEDS. I AM ABLE TO CONTROL THE VEHICLE , BUT WHEN IT HAPPENS TO MY WIFE THE BEST SHE CAN DO IS COAST TO A STOP. THIS IS CITY DRIVING SO THE FAILURE IS AN ACCIDENT WAITING TO HAPPEN. *TR

Mileage: 81,000

I HAVE A 2001 GMC SIERRA 2500HD WITH AN 8.1 LITER V8 GASOLINE ENGINE. WHILE I WAS DOING SOME RESEARCH ON THE INTERNET TRYING TO DIAGNOSE WHAT COULD BE WRONG WITH IT, I STUMBLED ACROSS YOUR WEBSITE STATING THAT THERE HAD BEEN A RECALL ON THAT TRUCK WITH THAT ENGINE. NHTSA CAMPAIGN ID NUMBER : 07V521000. THIS RECALL INFORMATION DESCRIBES EXACTLY WHAT HAS BEEN HAPPENING WITH MY VEHICLE AND THAT PART IS ONE I WAS DOING RESEARCH ON BASED UPON A MECHANIC FRIENDS ADVICE. I WAS EXCITED TO HEAR THAT THERE WAS A RECALL AS I CANNOT AFFORD TO HAVE THE PART PUT ON PROFESSIONALLY AND AM NOT KNOWLEDGEABLE TO DO IT MYSELF. THIS DEFECT REALLY IS A SAFETY ISSUE. OVER THE PAST COUPLE OF WEEKS THE TRUCK HAS GONE DEAD AND I HAVE BEEN STUCK IN AN INTERSECTION AND ALSO HAD TO PULL OVER SEVERAL TIMES WHILE THE VEHICLE WAS NOT RUNNING AND NOT STEERING EASILY OR STOPPING EASILY. SO I CALLED A TOLL FREE NUMBER THAT I GOT FOR GMC AND THEY TELL ME THAT MY TRUCK IS NOT COVERED EVEN THOUGH IT IS CLEARLY DOING THE SAME THING THAT THE RECALL DEFINES. MY VIN# IS . I HOPE THAT THERE IS SOMETHING THAT YOUR ORGANIZATION CAN DO TO EXTEND THE RECALL TO AFFECT MY VEHICLE OR LET GMC KNOW THAT IT ALREADY DOES. THANK YOU VERY MUCH AND DO NOT HESITATE TO CALL ME IF YOU NEED ANY FURTHER INFORMATION. *TR

Mileage: 130,000

TL*THE CONTACT OWNS A 2001 GMC SIERRA 2500. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE SHUT OFF ON THREE SEPARATE OCCASIONS WITHOUT WARNING AND HAD TO BE RESTARTED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING). THE CURRENT MILEAGE WAS 60,520 AND FAILURE MILEAGE WAS 60,515. UPDATED 06/09/08 *BF THE CONSUMER STATED THE PROBLEM WAS DIAGNOSED AND THE CRANKSHAFT SENSOR WAS REPLACED. UPDATED 06/09/08

Mileage: 60,515

WHILE REPLACING THE FUEL INJECTORS UNDER A SPECIAL INJECTOR WARRANTY, THE DEALERSHIP BROKE A GLOWPLUG OFF AND CALLED TO SAY I NEED TO REPLACE THE CYLINDER HEAD AT MY COST. CALL GMC CUSTOMER SUPPORT WHO SAY DUE TO THE AGE AND MILEAGE 2001, 124500. THAT THE CORROSION OF THE GLOWPLUG AND THE FACT IT SEIZED IN THE CYLINDER HEAD IS NOT THERE PROBLEM, EVEN THOUGH THEY ARE THE ONE WHO DESIGNED THE ENGINE. THEY SAID THAT IT'S AT MY COST FOR A NEW CYLINDER HEAD WHICH WAS QUOTED TO ME OVER THE PHONE AT A PRICE OF $1,800.00. *TR

Mileage: 124,500

WHILE REPLACING THE FUEL INJECTORS UNDER A SPECIAL INJECTOR WARRANTY, THE DEALERSHIP BROKE A GLOWPLUG OFF AND CALLED TO SAY I NEED TO REPLACE THE CYLINDER HEAD AT MY COST. CALL GMC CUSTOMER SUPPORT WHO SAY DUE TO THE AGE AND MILEAGE 2001, 124500. THAT THE CORROSION OF THE GLOWPLUG AND THE FACT IT SEIZED IN THE CYLINDER HEAD IS NOT THERE PROBLEM, EVEN THOUGH THEY ARE THE ONE WHO DESIGNED THE ENGINE. THEY SAID THAT IT'S AT MY COST FOR A NEW CYLINDER HEAD WHICH WAS QUOTED TO ME OVER THE PHONE AT A PRICE OF $1,800.00. *TR

Mileage: 124,500

TL*THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING AND THEN IMMEDIATELY RESTARTED. THE CONTACT IS A PROFESSIONAL MECHANIC AND HE REPAIRED THE FUEL PUMP, FUEL FILTER, AND FUEL PRESSURE REGULATORS; HOWEVER, THE FAILURE CONTINUED. HE NOTIFIED THE DEALER AND THEY STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING), EVEN THOUGH THE FAILURE WAS IDENTICAL. HE WAS INFORMED THAT HE WOULD HAVE TO REPAIR THE VEHICLE AT HIS OWN EXPENSE. THE FAILURE MILEAGE WAS 62,000 AND CURRENT MILEAGE WAS 72,000.

Mileage: 62,000

TL*THE CONTACT OWNS A 2001 GMC SIERRA 2500. WHILE DRIVING AT ANY SPEED, THE VEHICLE SHUTS OFF AND RESTARTS AFTER A FEW MINUTES. THE DIAGNOSTIC INDICATED THAT THE CRANKSHAFT SENSOR NEEDED TO BE REPLACED. THE CURRENT MILEAGE WAS 64,200 AND FAILURE MILEAGE WAS 63,000. UPDATED 01-10-08. *KB

Mileage: 63,000

COMPLETE ENGINE STOPPAGE AT VARIOUS SPEEDS INCLUDING STOPLIGHTS AND SIGNS, SOMETIMES REFUSING TO START AFTER BEING PARKED FOR SOME TIME. SHOP REPLACED FUEL PUMP. COST $734.27, 4 MONTHS LATER SHOP REPLACED CRANK SHAFT SENSOR COST $296.89. I HAVEN'T HAD PICKUP RETURNED LONG ENOUGH TO KNOW IF PROBLEM IS FIXED. MOST TIMES MOTOR WOULD START AFTER 15 TO 60 SEC. PROBLEM STARTED 12+ MONTHS AGO WITH MOTOR FAILURE INCREASING FROM MONTHS TO DAYS TO HOURS. COMPANION REFUSED TO RIDE WITH ME FOR FEAR OF AN ACCIDENT CAUSING INJURY OR DEATH. THE FIRESTONE TIRES FURNISHED AT TIME OF PURCHASE, ALL 5 DEVELOPED TREAD SEPARATION WITHIN 33000 MILES. THEY SHOULD HAVE LASTED AT LEAST 55,000 TO 60,000 MILES. *TR

Mileage: 63,797

ENGINE STALL WHILE DRIVING, LOSS OF POWER ASSISTED STEERING AND BRAKES. *NM

Mileage: 55,987

ENGINE PINGS/KNOCKS ON EVEN SLIGHT ACCELERATION. *JB

WHEN STARTING UP VEHICLE CONSUMER CAN HERE KNOCKING NOISES COMING FROM MOTOR. ALSO RATTLING NOISE COMING FROM UNDER VEHICLE. DEALER NOTIFIED. *AK THE ENGINE KNOCKS WHEN STARTING COLD. REAR PASSENGER SIDE DOOR MAKES NOISE. THE STEERING COLUMN SHOWS RUBBING SOUND. THE DRIVER SIDE SPEAKER FELL OFF. RIGHT FRONT WINDOW MAKES GRINDING NOISE WHEN GOES UP OR DOWN. PASSENGER SIDE POWER WINDOW REGULATOR FAILED. FUEL DOOR BUMPER FAILED. LEFT FRONT DOOR LOCK SWITCH CAME OFF. *YH