2002 GMC SIERRA 2500 Service Brakes, Hydraulic Problems

I WAS DRIVING MY 2002 GMC SIERRA 2500 HD ON I95 WHEN TRAFFIC CAME TO A SUDDEN STOP. I SLAMMED ON THE BRAKES AT WHICH POINT THE ABS SYSTEM STARTED PULSING THE BRAKES, BUT THE BRAKE PEDAL SUDDENLY WENT TO THE FLOOR WITH NO FURTHER BRAKE RESPONSE. THANKFULLY, THE BRAKES SLOWED THE TRUCK ENOUGH PRIOR TO FAILURE TO PREVENT A COLLISION AT 65 MPH. I HIT THE CAR IN FRONT OF ME AT ~5-10 MPH, CAUSING BUMPER DAMAGE TO MY TRUCK AND THE CAR IN FRONT OF ME. I WAS ABLE TO GET THE CAR TO THE SIDE OF THE ROAD AND TO MY HORROR I HAD NO BRAKES. THE VEHICLE WAS TOWED TO A LOCAL AUTHORIZED GMC DEALER WHO HAS MAINTAINED THE TRUCK FOR ME. THEY CONFIRMED THAT THE BRAKE LINES CATASTROPHICALLY FAILED WHEN I SLAMMED ON THE BRAKES. THE RUSTED BRAKE LINES BURST WHEN I SLAMMED ON THE BRAKES. THEY INDICATED THAT ALL OF THE BRAKE LINES HAD TO BE REPLACED DO TO RUST THROUGHOUT. I CAN'T BELIEVE I HAVE BEEN DRIVING THIS TRUCK AROUND WITH A PENDING CATASTROPHIC BRAKE FAILURE WITHOUT WARNING FROM GM OR THE SERVICING DEALER. IF THE WORD IS NOT PUT OUT TO OWNERS OF AFFECTED GMC TRUCK, LIVES WILL BE LOST. I SHUDDER TO THINK WHAT COULD HAVE HAPPENED IF I HAD BEEN PULLING UP TO A PEDESTRIAN FILLED CROSSWALK WHEN THE FAILURE OCCURRED. UPDATED 10/03/12*LJ *TR

Mileage: 143,000

BRAKE LINE FAILURE DUE TO RUST. ALL BRAKE LINES HAD TO BE REPLACED. *TR

Mileage: 68,000

GMC SIERRA 2500 HD 2002 ROTTED BRAKE LINES FAILURE CAUSED $4500 IN DAMAGE TO THE TRUCK . WRIST INJURY TO MY WIFE. OIL AND TRANNY FLUID ALL OVER DRIVEWAY STAINED. $5000 IN DAMAGE TO MY VW BEETLE RESULTING IN A TOTAL LOSS TO THIS VEHICLE!!!! *TR

BRAKE LINES ARE SEVERELY CORRODED AND LOOK READY TO FAIL, AND I FIND OUT THAT THIS IS A COMMON COMPLAINT AND ALL THE BRAKE LINES SHOULD AND MUST BE REPLACED BY GENERAL MOTORS. THE GMC AND CHEVROLET 2500HD MODELS ARE NOTORIOUS FOR THIS MALADY, AND THE NTSB SHOULD DO THEIR JOB AND FORCE GM TO REPLACE AT NO CHARGE, THE VEHICLES BRAKE LINES. *TR

Mileage: 155,000

TL* THE CONTACT OWNS A 2002 GMC SIERRA 2500. WHILE DRIVING IN REVERSE AT APPROXIMATELY 5 MPH THE CONTACT DEPRESSED THE BRAKE PEDAL AND IT DROPPED TO THE FLOOR. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO A REPAIR SHOP. THE MECHANIC STATED THE BRAKE LINES WERE CORRODED AND HAD TO BE REPLACED. THERE WAS AN INVESTIGATION UNDER NHTSA ACTION NUMBER: PE10010 (SERVICE BRAKES, HYDRAULIC SERVICE BRAKES, HYDRAULIC:POWER ASSIST:HYDRAULIC:HOSES, LINES/PIPING, AND FITTINGS) THAT MAY BE RELATED TO THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.

Mileage: 175,000

A BREAK LINE RUPTURED RESULTING IN LOSS OF FLUID AND DIMINISHED BREAKING. FORTUNATELY IT DID NOT RESULT IN A CATASTROPHIC LOSS IN BREAKING AT A CRITICAL TIME. THE RUPTURED LINE IS NEAR THE GAS TANK AND AT FIRST APPEARED TO BE A GAS LEAK. UPON INSPECTION ALL BREAK LINES ARE SUBSTANTIALLY RUSTED AND MUST BE REPLACED TO MAINTAIN SAFETY. ONE RUSTY LINE COULD INDICATE DAMAGE OR A SINGLE DEFECTIVE PART. 100% OF THE LINES BEING CORRODED TO AN UNSAFE LEVEL INDICATES SUBSTANDARD PARTS. THE REAR DISC BREAKS HAVE BEEN A CONSTANT PROBLEM WITH CORROSION OF SLIDING PARTS RESULTING IN CALIPERS NOT MOVING FREELY. THE SPONGY FEEL TO THE BREAKS WAS ATTRIBUTED TO STICKING OF THE REAR CALIPERS RATHER THAN A FLUID LEAK. ANNUAL LUBRICATION AND A TOTAL REPLACEMENT OF REAR BREAKS HAS BECOME NORMAL PRACTICE. THE POOR REAR BREAKS CAN LEAD ONE TO NOT NOTICE A SLOW LEAK OF BREAK FLUID UNTIL A TOTAL LOSS OF BREAKING ACTION. THE SLIGHT EXTRA COST FOR CORROSION RESISTANT BREAK PARTS COULD SAVE LIVES.

Mileage: 66,750

TL* THE CONTACT OWNS A 2002 GMC SIERRA 2500 HD. THE CONTACT STATED THAT THE BRAKE LINES BROKE AS A RESULT OF CORROSION. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 101,000. UPDATED 9/13/11 *CN UPDATED 11/23/11

Mileage: 101,000

DURING ROUTINE MAINTENANCE IN THE SHOP THE TRUCK WAS STARTED TO MOVE IT AND THE BRAKE LINE BURST NEAR THE POINT THE BRAKE LINE EXITS THE FRAME RAIL NEAR THE REAR AXLE. ALL REAR BRAKING WAS LOST. IF THIS HAD OCCURRED ON THE HIGHWAY IT COULD HAVE BEEN A CATASTROPHIC EVENT. *KB

Mileage: 114,513

TL*THE CONTACT OWNS A 2002 GMC SIERRA 2500. WHILE DRIVING APPROXIMATELY 50 MPH THE CONTACT DEPRESSED THE BRAKE PEDAL AND FELT THE BRAKE PEDAL FALL DOWN TO THE FLOOR BOARD. THE CONTACT WAS ABLE TO DRIVE ONTO THE SIDE OF THE ROAD. THE CONTACT NOTICED FLUID SQUIRTING OUT OF THE BRAKE LINE. THE CONTACT REFILLED THE MASTER CYLINDER WITH BRAKE FLUID AND DROVE THE VEHICLE HOME. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIANS STATED THE FRONT AND REAR BRAKE LINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED BY THE DEALER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FRONT AND REAR BRAKE LINES WERE REPLACED. THE APPROXIMATE FAILURE MILEAGE WAS 37,108.

Mileage: 37,108

TL* THE CONTACT OWNS A 2002 GMC SIERRA 2500 HD. THE CONTACT STATED THAT THE ABS ACTIVATED INDEPENDENTLY AT REDUCED SPEEDS WHEN COMING TO A COMPLETE STOP. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP BUT THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC: ANTILOCK). THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 89,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 88,000. UPDATED 06/01/11*LJ UPDATED 06/02/11

Mileage: 88,000

I APPLIED MY BRAKES ON MY GMC TRUCK AND THEY FAILED . THE BRAKE TUBING RUSTED THRU AT THE ABS UNIT. UPON FURTHER INSPECTION IT WAS DETERMINED THAT ALL THE BRAKE LINES WERE RUSTED SEVERELY. I TRIED TO FIND PRE BENT LINES AND THEY ARE NOT AVAIL. FROM GM AND NOT AVAIL FROM AFTERMARKET FOR A 2002 GMC 2500HD 2WD OR ANY GMC FROM DEALER.FRME AND UNDERCARRIAGE IS RUSTED WORSE THE MY 1983 AND BRAKE ROTORS RUSTED AND FLAKED AWAY. *TR

Mileage: 74,000

BRAKE FAILURE DUE TO RUSTED BRAKE LINE, TRUCK LOST ALL BRAKE FLUID! *TR

Mileage: 130,828

THREE BRAKE LINES RUPTURED SIMULTANEOUSLY CAUSING AN INABILITY TO STOP THE VEHICLE. THE CAUSE OF FAILURE WAS RELATED TO AN EXTENSIVE AMOUNT OF CORROSION ON ALL OF THE BRAKE LINES ON THE VEHICLE. COMPLETE REPLACE IS NECESSARY. THERE IS A REGIONAL RECALL ON THIS EXACT ISSUE BUT DOES NOT INCLUDE MY STATE. THERE ARE CONSIDERABLE REPORTS OF THIS FAILURE ACROSS THE COUNTRY BUT GM AND EVEN WORSE NHTSA FAILS TO FORCE A NATIONWIDE RECALL OF THIS POTENTIALITY DEADLY FAILURE. A SIMPLE SEARCH OF THE INTERNET WILL PROVE THIS DEFECT IS NOT CONSTRAINED TO ONLY THE RUST BELT STATES. MY '66 CHEVY STILL HAS THE ORIGINAL BRAKE LINES WITH NO SIGNS OF DEGRADATION HOWEVER MY '02 GMC REQUIRES THE REPLACEMENT OF ALL METAL LINES ON THE VEHICLE. THE EXISTENCE OF A CURRENT REGIONAL RECALL PROVES THAT GM ADMITS TO THE PROBLEM! THIS FAILURE NEEDS TO BE CORRECTED NATIONWIDE. *LN

Mileage: 166,730

TL*THE CONTACT OWNS A 2002 GMC SIERRA. WHILE TRYING TO PARK THE VEHICLE THE BRAKE PEDAL EXTENDED TO THE FLOOR. THIS WAS THE FIRST TIME THE CONTACT HAD A PROBLEM WITH THE BRAKES ON THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT ALL OF THE BRAKE LINES NEEDED TO BE REPLACED. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 55,445. UPDATED 3/1/11 *CN THE CONSUMER HAS SINCE SOLD THE VEHICLE. UPDATE 03/03/11

Mileage: 55,445

THE ANTI-LOCK BRAKES SYSTEM FAILED. WHILE BRAKING AT APPROXIMATELY 2-10 MPH, THE BRAKES LOCK UP. THIS LOCK-UP OCCURS AT ALL STOP SITUATIONS. THE LOCK-UP CAUSES SKIDDING, AND LONGER STOPPING DISTANCE. *TR

Mileage: 37,800

BACKING UP TO MY TRAILER WHEN MY BRAKE LINES BLEW OUT ON MY 2002 GMC SIERRA 2500 HD. ALSO UNDERNEATH OF TRUCK IS SOO RUSTED AND BOTTOM OF DOORS ARE ALSO RUSTING THROUGH. *TR

Mileage: 89,501

I WAS PARKED IN A FRIENDS DRIVEWAY AND WAS ABOUT TO LEAVE WHEN I RELEASED THE PARKING BRAKE STEPPED ON THE BRAKE PEDAL AND PUT MY 2002 GMC 2500HD TRUCK INTO GEAR. I STARTED DRIVING DOWN THE STREET AND APPROACHED A STOP SIGN, WHEN I APPLIED THE BRAKES THE PEDAL WENT STRAIGHT TO THE FLOOR. I PULLED OFF TO THE SIDE OF THE ROAD AND OPENED THE HOOD WHEN I NOTICED BRAKE FLUID ALL OVER THE FRAME IN THE ENGINE COMPARTMENT. UPON FURTHER INVESTIGATION I FOUND ALL THE BRAKE LINES TO BE SEVERELY RUSTED AND AT LEAST ONE OF THEM RUPTURED. I WAS DRIVING WITH MY 9 MONTH OLD SON AT THE TIME OF THE INCIDENT AND THANK GOD NOBODY WAS COMING THE OTHER WAY DOWN THE ROAD. I HAD THE TRUCK TOWED TO MY HOME WHERE IT SITS AWAITING A TOTAL BRAKE LINE REPLACEMENT. THE UNDERNEATH OF THE TRUCK IS SO SEVERELY RUSTED I THINK GMC IS LIABLE AND SHOULD ISSUE A RECALL TO CORRECT THE PROBLEM. *TR

Mileage: 113,234

TL* THE CONTACT OWNS A 2002 GMC SIERRA 2500. THE CONTACT WAS TOWING A TRAILER AND BRAKING FROM 20 MPH WHEN THE BRAKES DID NOT ENGAGE. THE BRAKE WARNING LIGHT ILLUMINATED. THE CONTACT WAS ABLE TO STOP THE VEHICLE BY USING THE TRAILER BRAKES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE BRAKE LINES WERE CORRODED AND FAILED. THE BRAKE LINES WERE REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 96,000.

Mileage: 96,000

BRAKE LINES BURST UNDER HEAVY BRAKING DUE TO ACCIDENT AVOIDANCE SITUATIONS. FIRST TIME THE REAR LINE BURST, SECOND TIME THE FRONT LEFT LINE BURST BY THE ABS UNIT. *TR

Mileage: 105,023

ABS TRIGGERS FOR NO APPARENT REASON WHEN APPLYING BRAKES TO MY 2002 GMC SIERRA 2500 HD. I'M TOLD THERE WAS SOME TYPE OF A RECALL DUE T CORROSION OF AN ABS WHEEL SPEED SENSOR, BUT NO DEALER WILL SPEAK TO ME. *TR

Mileage: 40,000

BRAKE LINES ON 2002 GMC 2500 RUSTED NEEDED REPLACEMENT. *TR

Mileage: 22,000

I WAS PLOWING SNOW ON THE COMMON DRIVEWAY THAT I SHARE WITH 3 OTHER NEIGHBORS AND CAME AROUND A BEND TO MEET MY NEIGHBOR'S SON ON HIS ATV. I SLAMMED ON THE BRAKES AND THE PEDAL WENT TO THE FLOOR. FORTUNATELY THE PILE OF SNOW IN FRONT OF THE PLOW HELPED STOP MY TRUCK. THE ATV OPERATOR DODGED IN TO THE SNOW BANK. THERE WAS NO CONTACT. I FOUND THAT I HAD MULTIPLE BRAKELINE FAILURES ON MY TRUCK. I HAVE HAD A PREVIOUS BRAKE LINE FAILURE IN 2008 BUT COULD NOT FIND THE WORK ORDER FOR REPAIRS TO VERIFY DATE AND MILEAGE. *TR

Mileage: 88,500

EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH. *TR

Mileage: 55,000

TL*THE CONTACT OWNS A 2002 GMC 2500HD. THE CONTACT STATED THE BRAKING SYSTEM AND SPEED SENSOR HAS FAILED. THE SENSOR WAS REPLACED BY THE DEALER UNDER WARRANTY PREVIOUSLY AND NOW THE SENSOR HAS FAILED AGAIN. THE VEHICLE WAS TAKEN BACK TO THE DEALER. DUE TO THE SENSOR FAILURE THE VEHICLE IS NOT DRIVEABLE. THE MANUFACTURER WAS CALLED.THE CONTACT WAS TOLD THE REPAIR WOULD BE AT THE OWNER'S EXPENSE SINCE THE WARRANTY HAS EXPIRED ON THE VEHICLE. THE VIN NUMBER IS UNKNOWN. THE FAILURE MILEAGE WAS 39,000.

Mileage: 39,000

I HAVE A 2002 GMC SIERRA 2500 DIESEL. I HAVE A HAD SEVERAL PROBLEMS WITH THE BRAKE LINES ROTTING OUT. THIS TRUCK ONLY HAS 84000 MILES ON IT. LAST WEEK MY FAMILY AND I WHERE OUT DRIVING AND THE BRAKES WENT ALL THE WAY TO THE FLOOR AT AND THROUGH A RED LIGHT. I PULLED OVER SAFELY AND INSPECTED THE TRUCK AND FOUND YET ANOTHER BRAKE LINE RUPTURED.. *TR

Mileage: 86,000

ABS SENSOR IN FRONT WHEEL HUB DEVELOPS RUST, ACTIVATING THE ABS SYSTEM EVERY TIME BRAKE IS APPLIED. OCCURS EVERYTIME BRAKE IS APPLIED AND VEHICLE IS IN MOTION. TRYING TO FIND REPLACEMENT SENSOR, AS GM PART IS NOT AVAILABLE. *TR

I HAVE A 2002 GMC SIERRA 2500HD PICKUP TRUCK THAT IS EXHIBITING ABS BRAKING PROBLEMS AT LOW SPEEDS. THE ABS SYSTEM WILL ENGAGE AND DISENGAGE AT LOW SPEEDS ON PERFECTLY DRY DRIVING SURFACES. I WAS INFORMED BY A FRIEND THAT HE THOUGHT GMC HAD A RECALL ON THIS ISSUE. I RESEARCHED ON THE WEB AND FOUND A RECALL THAT DESCRIBED THIS SITUATION EXACTLY. I CONTACTED THE LOCAL DEALER AND THEY SAID THERE WAS NO OUTSTANDING RECALLS FOR MY VEHICLE. I THEN CONTACTED GMC DIRECTLY (FROM A PHONE NUMBER LISTED ON ONE OF THE WEB OBTAINED RECALL NOTICES) AND THEY RAN MY VIN AND SAID THAT MY TRUCK WAS NOT COVERED BY THE RECALL. I WANT TO KNOW HOW TO GET MY TRUCK AND SIMILAR TRUCKS INCLUDED IN THE RECALL THAT APPARENTLY DID NOT INCLUDE MY SPECIFIC VEHICLE. *TR

Mileage: 85,000

FRONT ABS ACTIVATES WHILE TRYING TO STOP. THIS IS COVERED BY MANY RECALLS. MY VEHICLE IS NOT INCLUDED ALTHOUGH IT HAS THE EXACT SYMPTOMS. *TR

Mileage: 111,000

STARTED MY VEHICLE SO COULD MOVE IT IN FRONT OF MY GARAGE. WHEN I TRIED TO TURN THE STEERING WHEEL WOULDN'T MOVE AND I HAD VERY LIMITED BRAKING POWER. IT TOOK AN EXCEPTIONAL AMOUNT OF PRESSURE ON THE BRAKE PEDAL JUST TO STOP THE VEHICLE AT A VERY LOW SPEED. THANKFULLY NO ONE WAS HURT AND NO PROPERTY DAMAGE OCCURRED. *TR

Mileage: 57,000

TL*THE CONTACT OWNS A 2002 GMC SIERRA 2500 HD. WHEN THE CONTACT DEPRESSED THE BRAKE PEDAL, THE VEHICLE DID NOT STOP IMMEDIATELY. THE ABS EVENTUALLY ENGAGED. THE DEALER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V379000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK). THE FAILURE AND CURRENT MILEAGES WERE 101,296.

Mileage: 101,296

TL*THE CONTACT OWNS A 2002 GMC SIERRA 2500 HD. WHENEVER THE CONTACT DEPRESSES THE BRAKE PEDAL WHILE DRIVING AT ANY SPEED, THE PEDAL PULSATES AND ACTS AS IF IT DOES NOT WANT TO GO DOWN PROPERLY. THE BRAKES MAKE A NOISE AND THE VEHICLE DOES NOT STOP PROPERLY. THE CURRENT MILEAGE WAS 7,000 AND FAILURE MILEAGE WAS 300.

Mileage: 300

ABS BRAKE SENSOR FAILURE. AT LOW SPEEDS THE ABS WORK EVEN WHEN WHEELS ARE NOT LOCKED UP. THE FIRST TIME I EXPERIENCED THIS WAS PULLING A 7000LB TRAILER. I HAD TO DIVERT THE TRUCK AND TRAILER ONTO THE SHOULDER TO AVOID PLOWING INTO TRAFFIC IN FRONT OF ME. THIS APPEARS TO BE A VERY EXPENSIVE REPAIR TO MAKE, REPLACING THE FRONT WHEEL HUB ASSEMBLIES. CURRENTLY WE HAVE HAD TO DISCONNECT ONE OF THE ABS SENSORS TO KEEP THE ABS FROM ACTIVATING. *JB

Mileage: 67,000

TL*THE CONTACT OWNS A 2002 GMC SIERRA 2500 HD. THE CONTACT FELT THE VEHICLE'S BRAKES PULSATE. HE TOOK THE VEHICLE TO THE DEALER WHO DISCOVERED THAT THE ROTORS WERE CORRODED, THE FRONT WHEEL HUBS WERE FILLED WITH WATER, THE ABS SENSORS WERE CORRODED, AND THE ENTIRE BRAKING SYSTEM NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 34,000.

Mileage: 34,000

TL* - THE CONTACT CALLED ABOUT 2002 GMC SIERRA 2500 HD. HE STATED THAT WHILE APPLYING BRAKES, 7 OUT OF 10 TIMES THE ABS SYSTEM ACTIVATE\D AND PUMPED THE BRAKES. THIS HAPPENED AT ANY TIME OF THE DAY, AND IN ALL WEATHER CONDITIONS. THE CONTACT STATED THAT THIS HAPPENED WHEN APPLYING BRAKES AT ANY SPEED. THE BRAKES PUSHED BACK AND THERE WAS A THUMPING NOISE COMING FROM THE MASTER CYLINDER. THE CONTACT LOOKED UP INFORMATION FROM THE NHTSA WEBSITE AND FOUND THAT A RECALL 05V379000 HAD BEEN ISSUED FOR THIS VEHICLE. THE CONTACT SAID THAT HE TOOK VEHICLE TO THE DEALERSHIP, AND WAS TOLD THAT THIS VEHICLE DID NOT FALL UNDER THE RECALL DUE TO VIN. *AK THE INNER TIE ROD HAD EXCESSIVE PLAY, THE FRONT DIFFERENTIAL SEAL WAS LEAKING FROM THE VENT CAP, THE DAYTIME RUNNING LIGHT BULB WAS INOPERATIVE. THE CONSUMER DENIED TO HAVE REPAIRS MADE. UPDATED 01/29/07. *JB

Mileage: 37,300

UPON BRAKING UP TO A STOP SIGN FOR INSTANCE. THE VEHICLES ABS WILL KICK IN AT THE LAST MINUTE RELEASING THE LEFT FRONT WHEEL CAUSING THE VEHICLE TO DIVE TO THE RIGHT. THIS HAPPENS IN WET OR DRY CONDITION BUT IS PARTICULARLY BAD IN ICY CONDITIONS. *NM

Mileage: 70,000

DT*: THE CONTACT STATED WHILE TRAVELING 45 MPH UNDER NORMAL ROAD CONDITIONS, THE HYDRAULIC REAR BRAKE ROTORS RUSTED, AND STOPPING DISTANCE WAS INCREASED. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE NATURE OF THE FAILURE WAS PERMANENT GRADUAL WORSENING. THE CONSUMER STATED THE REAR ROTORS HAD RUSTED SO BADLY THAT THEY FLAKED OFF IN PIECES. UPDATED 11/30/06. *JB

Mileage: 32,143

WHEN I PULLED INTO A LEFT TURN LANE AND TRIED TO APPLY THE BRAKES THE PEDAL WENT NEARLY TO THE FLOOR AND I HAD NO BRAKES LUCKILY THERE WERE NO OTHER CARS ON THE ROAD OR IN THE INTERSECTION AT THE TIME SO I WENT ON THROUGH AND THERE WAS NO ACCIDENT, I WAS CAMPING AT THE TIME AND I GOT THE TRUCK BACK TO THE CAMPGROUND WHEN I BACKED THE TRUCK INTO THE CAMPSITE AND APPLIED THE BRAKES THEY STARTED WORKING NORMALLY, I TOOK THE TRUCK TO THE DEALER AND THEY SAID THAT THEY COULD FIND NOTHING WRONG THEY EVEN SAID THAT THEY HAVE HAD SEVERAL OTHER VEHICLES DO THE SAME THING AND COULD NOT FIND ANYTHING WRONG WITH THEM AND THAT THIS PROBLEM WAS NORMAL FOR THE VEHICLE. *NM

Mileage: 46,500

DT*: THE CONTACT STATED THE VEHICLE STALLED ON THREE OCCASIONS. ALL INCIDENTS OCCURRED DURING ACCELERATION WHILE TRAVELING 25 TO 35 MPH. THERE WERE NO WARNINGS PRIOR TO THE INCIDENTS AND THE VEHICLE HAD NO PROBLEMS RESTARTING. THE DEALER COULD NOT DUPLICATE OR RESOLVE THE PROBLEM. *AK UPDATED 11/16/2006 - THERE WERE SUBSEQUENT PROBLEM RESTARTING THE VEHICLE, AND AS MANY AS 3 TO 5 STALLING EPISODES PER WEEK. NOT ALL INCIDENTS OCCURRED WHILE TRAVELING. SOME INCIDENTS OCCURRED WHILE AT IDLE, AND AT A STOP. COMPLETE LOSS OF POWER STEERING AND BRAKES OCCURRED WHEN THE VEHICLE STALLED. THE DEALER DIAGNOSED THE PROBLEM AS A FAULTY CRANKSHAFT SENSOR AND REPLACED IT. RECENTLY THE CHECK ENGINE LIGHT HAS ILLUMINATED. THE DEALER DIAGNOSED THE PROBLEM AS A FAULTY TRANSMISSION SELECTOR POSITION SENSOR AND REPLACED IT. THE ABS ACTIVATED WHILE DRIVING ON DRY PAVEMENT. THE DEALER FOUND IT NECESSARY TO REPLACE BOTH FRONT ABS WHEEL SPEED SENSORS. *NM

Mileage: 57,778

ANTILOCK SYSTEM ACTIVATES ON MY 2002 GMC SERRIA AS STATED IN THE RECALL NHTSA CAMPAIGN NUMBER 05V379000. GMC SAYS MY VEHICLE BY VIN NUMBER IS NOT COVERED UNDER THIS RECALL. MY VIN # IS [XXX]. I'VE HAD A COUPLE OF NEAR ACCIDENTS BECAUSE OF THIS. I ALSO TOW A 36' FIFTH WHEEL CAMPER IN THE SUMMER TIME. *NM UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Mileage: 50,000

UNWANTED ANTILOCK BRAKE ACTIVATION. SAME AS INDICATED ON NHTSA CAMPAIGN # 05V379000. WAS TOLD BY GMC MY VEHICLE WAS NOT PART OF ABOVE RECALL WITH NO REASONABLE EXPLANATION GIVE AS TO WHY. *NM

Mileage: 15,000

GM RECALL #05068 ANTI- LOCK CAUSING INCREASED STOPPING DISTANCES, GM IS ONLY REPAIRING THIS PROBLEM ON 1/2 TON PRODUCTS DUE TO THE FACT IT IS A SIMPLE INEXPENSIVE REPAIR. I OWN A 3/4 TON TRUCK WITH THE EXACT SAME PROBLEM BUT DUE TO THE FACT A REPAIR CONSISTS OF REPLACEMENT OF THE FRONT WHEEL BEARINGS THEY (GM) HAVE CHOSEN NOT TO INCLUDE 3/4 TON IN THIS RECALL. I HAVE ON SEVERAL OCCASIONS HAD INCREASED STOPPING DISTANCES DUE TO THE SENSOR FAILURE, MY DEALERSHIP SAID THEY CAN REPAIR GM'S DEFECT AT A PRICE OF $800.00 TO ME. *JB

Mileage: 40,000

DT: THE CONTACT COMPLAINED ABOUT A BRAKE PROBLEM. REAR ROTORS RUSTED. DEALERSHIP SAID THAT THIS WAS NORMAL WEAR FOR THE REAR ROTORS. THE GM CUSTOMER SERVICE TOLD HIM TO TAKE IT BACK TO THE DEALER, AND ALL THEY WOULD TELL HIM WAS THAT HE NEEDED TO REPLACE ROTORS AND REAR BRAKE PADS BECAUSE THEY COULD NOT TURN THEM OVER. *AK LEFT REAR AXLE SEAL LEAKED. THE SLIP YOKE AND REAR U-JOINT ON THE REAR DRIVESHAFT WERE REPLACED BECAUSE THEY WERE CAUSING A CHATTERING FEELING WHEN THE WHEEL WAS TURNED. *NM

RIGHT REAR BRAKE OF 2002 GMC SIVERADO 2500HD DOES NOT RELEASE COMPLETELY. RIM GETS HOT AND BRAKES SMOKE. GM DEALER ON SECOND SERVICE PROBLEM INSTALLED COVERS OVER THE BRAKES TO KEEP ROAD GRIM OUT. THIS DOES NOT SEEM TO FIX THE PROBLEM. JUST DROPPED OFF TRUCK FOR THE THIRD TIME WITH THE SAME ISSUES AND THEY CAN NOT FIND ANY PROBLEMS. RIM IS DESTROYED DUE TO HEAT AND BRAKE DUST. TRUCK HAS 11,000 MILES ON IT

THE BRAKE LINE FAILED, WHICH CAUSED THE VEHICLE TO EXPERIENCE EXTENDED STOPPING DISTANCE. *JB THE BRAKE LINE CONTAINED A BEND, WHICH WAS SUSCEPTIBLE TO BEING SNAGGED. THE CONSUMER REPAIRED THE BRAKE LINE HIMSELF. *JB

Mileage: 11,800