2005 GMC SIERRA 2500 Service Brakes Problems

TL* THE CONTACT OWNS A 2005 GMC SIERRA 2500. THE CONTACT STATED HE REPLACED ALL THE BRAKE LINES ON THE VEHICLE AND ALSO STATED THAT THE BODY FRAME OF THE VEHICLE WAS CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENCE MECHANIC WHERE ALL THE CORRODED BRAKE LINES WERE REPLACE. THE VEHICLE WAS NOT DIAGNOSED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 61,000.

Mileage: 61,000

BRAKES FAILED WHILE DRIVING DUE TO METAL BRAKE LINE CORROSION CAUSING AN ACCIDENT. POLICE REPORT: MOORESVILLE, INDIANA PD #A17315

Mileage: 95,000

BREAK LINE RUSTED AND BROKE ALMOST RESULTING IN AN ACCIDENT WHEN TRYING TO STOP BRAKE PETAL WENT TO FLOOR

Mileage: 130,000

BLEW OUT ONE BRAKE LINE LOST ALL BRAKES NO BACKUP,PEDAL WENT ALL THE WAY TO THE FLOOR. 54,000 MILES ALL LINES RUSTED ALL NEEDED TO BE REPLACED THANK GOD I JUST PULLED INTO A PARKING LOT.

Mileage: 54,000

TAKING VEHICLE OUT OF PARK BRAKE PEDAL WENT ALL WAY TO FLOOR BECAUSE STEEL LINE RUPTURED CAUSING MASSIVE LEAKAGE OF BRAKE FLUID, ROLLED OUT OF DRIVE WAY INTO STREET CUTTING WHEEL TO AVOID WRECK BEFORE COULD GET IN NEUTRAL AND ROLL TO STOP !

Mileage: 100,000

2005 GMC 2500HD THAT THE BRAKE LINES FAILED. AFTER CHECKING THEY ARE RUSTED EVERYWHERE. I LOOKED ON THE INTERNET AND I SEE THAT THIS IS A ONGOING ISSUE WITH THIS MODEL YEAR.

Mileage: 216,000

THE BRAKES WENT TO THE FLOOR AND VEHICLE DID NOT STOP, BARELY AVOIDED A CRASH. FOUND POOL OF BRAKE FLUID UNDER TRUCK. FIRESTONE AUTO CHARGED $675 TO REPLACE A RUSTED OUT BRAKE LINE. ALL OTHER LINES ARE HEAVILY CORRODED AND READY TO FAIL AS WELL. *TR

Mileage: 101,000

WHILE DRIVING TO WORK APPROACHING AN INTERSECTION THE CAR IN FRONT OF ME SIGNALED TO TURN RIGHT LAST MINUTE AND APPLIED THE BRAKES, I ALSO APPLIED THE BRAKES AND THE PEDAL WENT ALL THE WAY TO THE FLOOR. IF I DIDN'T HAVE ENOUGH FOLLOWING DISTANCE I WOULD HAVE CRASHED RIGHT IN TO THE CAR. I ONLY HAD ABOUT 1/2 INCH OF BRAKE PEDAL AND DROVE IN LOW GEAR VERY CAREFULLY THE REST OF THE SHORT DISTANCE TO WORK. WHEN I GOT OUT OF THE TRUCK I SAW BRAKE FLUID POURING OUT OF THE BRAKE LINES BELOW THE DRIVERS SIDE DOOR AND THEY WERE COMPLETELY RUSTED OUT. UPON FURTHER INSPECTION I REALIZED ALL MY BRAKE LINES WERE RUSTY ON A NINE YEAR OLD VEHICLE, I NEVER SAW ANYTHING LIKE THIS BEFORE. I HAD TO GET THE VEHICLE TOWED AND REPAIRED AT A LOCAL GARAGE THAT CHARGED ME $1,547.61 TO REPLACE ALL THE LINES AND DID A HORRIBLE JOB. I HAD CALLED THE GMC DEALER I DEALT WITH IN THE PAST AND THEY WERE INUNDATED WITH RECALL WORK AND HAD AT LEAST A 2 WEEK WAIT AND ANOTHER GM DEALER THAT GMC CUSTOMER SERVICE PROVIDED ME AND THEY WERE ALSO ALL BOOKED UP WITH RECALL WORK AND SO I WAS FORCED TO TRUST A LOCAL SHOP. THIS A SAFETY ISSUE THAT COULD GET PEOPLE KILLED, I ALWAYS HAVE MY WIFE AND KIDS IN THE TRUCK AND IT WAS A DEATH TRAP. IN TALKING TO GMC REPS IS SEEMS THEY HAVE NO INTENTION TO REIMBURSE ME FOR THIS PREMATURE AND ACCELERATED RUSTING CONDITION THAT COULD HAVE CAUSED ME OR SOMEONE ELSE THEIR LIFE. *TR

Mileage: 58,771

I BOUGHT MY GMC SIERRA 2500 IN JUNE OF 2005. SHORTLY AFTER I BOUGHT THE TRUCK I STARTED TO NOTICE RUST ON THE TRAILER HITCH AND FRAME RAILS. AS THE YEARS HAVE GONE BY, THE ENTIRE UNDERCARRIAGE IS RUSTED OVER. OVER THE LAST SEVERAL YEARS A BRAKE LINE RUSTED THROUGH AND THE BRAKE PADS & ROTORS HAVE BEEN REPLACED SEVERAL TIMES. I WAS LUCKY TO BE PICKING MY TRUCK UP FROM THE SHOP AFTER AN OIL CHANGE & NOT DRIVING IT, WHEN I NOTICED BRAKE FLUID ON THE GROUND UNDER MY TRUCK.MY SPEEDOMETER DOES NOT WORK PROPERLY & THE DASHBOARD LIGHTING WORKS OCCASIONALLY. MY TRAILER HITCH RUSTED SO BAD THAT THE LAST TIME I PUT THE RECEIVER INTO THE HITCH IT WAS STUCK & I HAD TO GET A FRIEND TO CONNECT A CHAIN TO HIS TRUCK & WHILE I DROVE FORWARD & HE REVERSED, THE RECEIVER FINALLY BROKE FREE AFTER APPROX. 10 MINUTES. *TR

Mileage: 50,000

BRAKE LINE UNDER DRIVERS SIDE BROKE LEAVING VEHICLE WITHOUT ANY REGULAR STOPPING CAPABILITY AND REQUIRING TOW. ESTIMATED REPLACEMENT OF ALL LINES RECOMMENDED BY GMC DEALER DUE TO FAILURES BEING COMMON, $1,480 PLUS TAX. *TR

Mileage: 70,000

I WAS ON MY WAY TO WORK AND I LOST ALL BRAKES,TOOK IT TO A MECHANIC ,HE INFORMED ME IT WAS RUSTED BRAKE LINES. *TR

Mileage: 41,000

AFTER PUTTING THE VEHICLE IN PARK AND PROCEEDING DOWN MY DRIVEWAY, THE ABS LIGHTS BEGAN FLASHING AND CHIMING ON THE DASH. I PUSHED THE BRAKE PEDAL AND IT WENT TO THE FLOOR. I STOPPED THE VEHICLE WITH THE EMERGENCY BRAKE. I GOT OUT OF THE VEHICLE AND NOTICED BRAKE FLUID DRIPPING UNDERNEATH THE TRUCK. I CRAWLED UNDER THE TRUCK AND FOUND THE LEFT REAR BRAKE LINE HAD CORRODED THROUGH JUST ABOVE THE FUEL TANK. I CALLED THE DEALER AND HE STATED THIS IS A KNOWN DEFECT FROM GM. HE SAID I NEEDED ALL BRAKE LINES REPLACED AND GM'S NEW PARTS HAD AN EXTRA COATING TO PREVENT CORROSION. IT COST ME $1100. THIS TYPE OF FAILURE SEEMS WAY TOO SOON FOR A TRUCK WITH 38,000 MILES. *TR

Mileage: 38,391

BRAKES FAILED TO STOP VEHICLE AT INTERSECTION/STOPLIGHT. BRAKE PEDAL WENT TO FLOOR AND STAYED THERE. DETERMINED THAT RUST THROUGH IN BRAKE LINE AT DRIVER SIDE OF FRAME, UNDER DRIVER SEAT, HAD ALLOWED FLUID LOSS. *TR

Mileage: 51,500

STARTED THE TRUCK AND APPLIED THE BRAKES TO SHIFT INTO GEAR AND THE BRAKE PEDAL WENT TO THE FLOOR. AFTER SEVERAL TIMES PRESSING THE PEDAL THERE WAS NO BRAKES AT ALL. THE TRUCK WAS TOWED TO THE DEALER WHERE I WAS INFORMED ALL THE BRAKE LINE WERE RUSTED AND NEEDED TO BE REPLACED AT A COST OF $1,300.00. THE TRUCK ONLY HAD 35,000 MILES ON IT. IF I HAD BEEN DRIVING, I AM SURE THIS WOULD HAVE LIKELY CAUSED A SERIOUS ACCIDENT. *TR

Mileage: 35,000

DRIVING THROUGH AN INTERSECTION AT 40 WHEN A ANOTHER VEHICLE MADE A LEFT TURN IN FRONT OF ME . I APPLIED MY BRAKES AND PEDAL WENT TO THE FLOOR . I SWERVED AND AVOIDED THE ON COMING VEHICLE . THE REAR HARD STEEL BRAKE LINE ABOVE THE FUEL TANK BURST DUE TO CORROSION . NO WARNING NO FLUID OR BRAKE LIGHT JUST A CATASTROPHE FAILURE OF LINE. UPON INSPECTION LINE IS NOT CORRODED ON THE FRAME RAIL BEFORE THE FUEL TANK JUST BEHIND THE TANK. *TR

Mileage: 139,003

DEPRESSED BRAKE PEDAL TO STOP TRUCK AND PEDAL WENT STRAIGHT TO THE FLOOR. FRONT BRAKE LINES HAD RUPTURED DUE TO CORROSION. THIS TRUCK IS MY MAIN TOW VEHICLE AND I HAD A SMALL TRAILER ON WHEN THIS OCCURRED. MY TRUCK HAS NOT SEEN MUCH WINTER USE SINCE NEW AND I AM THE OWNER SINCE NEW. *TR

Mileage: 58,196

WHILE DRIVING DOWN A COUNTRY ROAD IN MY PICKUP TRUCK MY BRAKE LINES FAILED IN 2 SPOTS DUE TO RUST AND CORROSION. I WAS PULLING A TRAILER ALSO. VERY VERY DANGEROUS. LUCKY TO HAVE ACTED SO FAST IN USING THE EMERGENCY BRAKE. *TR

Mileage: 52,250

THE 2005 GMC 2500HD FWD (WELL MAINTAINED AND OILED TO PREVENT CORROSION) EXPERIENCED A FAILURE WHILE TOWING MY 24' PURSUIT FISHING BOAT (7200 LBS.) HOME FROM STURGEON POINT MARINA TO HAMBURG, NY 14075 (APPROXIMATELY 10 MILES) WITH "MINIMAL" STOPPING CAPABILITY AS THE DOT 3 BRAKE FLUID WAS BEING EXPELLED. I HAD TO FEATURE THE THROTTLE TO NEGOTIATE STOPPING SENARIOS WITHOUT ISSUE. AS OF 8/20/12, THIS VEHICLE IS WITH FUCCILLO CHEVROLET, INC. (GRAND ISLAND, NY) FOR OVERHAUL OF ENTIRE BRAKING SYSTEM; INCLUDING FUEL LINES. THE CERTIFIED TECHNICIAN SUGGESTED THE ENTIRE BRAKE LINES SYSTEM BE REPLACED ALONG WITH THE FUEL LINES DUE TO EXTREME CORROSION. ALL THIS WORK IS BEING PERFORMED SINCE THE EXCELLENT CONDITION OF THE VEHICLE.THE ESTIMATE FOR THIS WORK IS APPROXIMATELY $2250 TO REPLACE ALL LINES (BRAKE / GAS) AFFECTED BY SEVERE CORROSION. THIS CONDITION IS A RESULT OF POOR MATERIAL SELECTION NOT CAPABLE OF WITHSTANDING NORMAL WINTER CONDITIONS FOUND IN THE NORTHEAST. THE SAME STANDARDS SHOULD BE USED AS SELECTING EXHAUST SYSTEM MATERIAL. BRAKES CAN KILL YOU....EXHAUST SYSTEMS CAN NOT! FINAL NOTE: TRUCK DRIVEN 50 MILES PER WEEK TO WORK (10 MILES EACH DAY). DURING WINTER MONTHS, THE RESIDUAL SALT IS RINSED AS REQUIRED ON A WEEKLY BASIS (OR SOONER) TO PREVENT CORROSION. THIS TRUCK PRIOR TO WINTER DRIVING HAS HAD OIL APPLIED TO THE UNDERFRAME, APPARENTLY, THE BRAKE / FUEL LINE WHERE NOT ADEQUATELY TREATED. *TR

Mileage: 40,650

BRAKE PEDAL WENT TO THE FLOOR. INSPECTION DISCOVERED THAT ALL THE VEHICLE BRAKE LINES WERE RUSTED, SOME TO THE POINT OF LEAKING BRAKE FLUID. *TR

Mileage: 22,000