2001 GMC SIERRA Service Brakes Problems

05068A PRODUCT SAFETY RECALL FRONT WHEEL SPEED SENSOR CORROSION. MY VEHICLE WAS SERVICED FOR THIS RECALL IN 2006 WHICH INVOLVED REMOVING AND CLEANING THE ABS SENSOR AND REINSTALLING IT. NO REDESIGN WAS CREATED TO IMPROVE THIS FLAWED DESIGN. I'M HAVING THE SAME FAILURES DESCRIBED AND COVERED IN THIS RECALL. WHILE MOVING AT SLOW SPEEDS IN DRY CONDITIONS ABS KICKS IN AND INCREASES MY STOPPING DISTANCE. I HIT A PARKED CAR IN A PARKING LOT DUE TO THIS DEFECT. MY VEHICLE WAS IN MOTION AT <5MPH ON DRY PAVEMENT WHEN THE BREAKS WENT INTO 'ABS MODE' AND HIT A STATIONARY PARKED CAR. LUCKILY NO ONE WAS HURT. WHEN I CONTACTED GMC I WAS TOLD THAT THIS WOULD NOT BE COVERED UNDER THE RECALL BECAUSE IT WAS ALREADY SERVICED FOR THIS RECALL IN 2006 AND THAT THE ISSUE WAS THEREFORE CLOSED. IN MY CASE THE ORIGINAL RECALL WAS NOT ADEQUATE AND MY CAR BREAKS STILL FAILED EVEN THOUGH SERVICED IN 2006. I HOPE THIS DOESN'T START TO OCCUR WITH ALL OF THE VEHICLES THAT WERE SERVICED ~10 YEARS AGO WHICH IS WHY I'M FILING THIS COMPLAINT. LINK TO RECALL: HTTP://WWW-ODI.NHTSA.DOT.GOV/ACMS/CS/JAXRS/DOWNLOAD/DOC/ACM5671334/RCRIT-05V379-9258.PDF

Mileage: 250,000

WENT TO STOP AT TRAFFIC LIGHT AND EXPERIENCED BRAKE LINE RUPTURE DUE TO EXCESSIVE RUST. HAD TO USE EMERGENCY BRAKE TO COAST TO A STOP. FORTUNATE NO CARS WERE IN LANE.$1200.00 FOR REPAIR OF LINES.

Mileage: 134,000

BRAKE PEDAL MOVED ALL THE WAY TO FLOOR WITH NO APPARENT HYDRAULIC PRESSURE WHICH FAILED TO ENGAGE BRAKES WHEN SHIFTING INTO DRIVE. INSPECTION OF BRAKE LINES BENEATH DRIVERS SIDE DOOR REVEALED EXCESSIVE RUST AND A HOLE IN STEEL BRAKE LINE LEAKING FLUID.

Mileage: 145,050

TL* THE CONTACT OWNS A 2001 GMC SIERRA. THE CONTACT STATED THAT WHILE ATTEMPTING TO STOP, THE ABS FAILED AND THE VEHICLE STARTED TO PULL TO THE RIGHT. THE CONTACT DETERMINED THAT THE CAUSE OF THE FAILURE WAS A DEFECTIVE WHEEL SPEED SENSOR. THE VIN WAS NOT AFFECTED BY NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 105,000. ...UPDATED 06-11-15 *BF UPDATED 11/23/2015*JS

Mileage: 105,000

BRAKE LINE FAILED AND BROKE, UPON INSPECTION ALL BRAKE LINES WERE CORRODED AND BRITTLE, HAD TO REPLACE ALL BRAKE LINES. *TR

Mileage: 118,000

TL* THE CONTACT OWNS A 2001 GMC SIERRA. WHILE DRIVING 15 MPH, THE BRAKE PEDAL FAILED TO DEPRESS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE SENSORS ON THE FRONT OF THE VEHICLE FAILED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

I PULLED INTO MY DRIVEWAY AND APPROACHED THE GARAGE, APPLIED BRAKES AND ALL THEY DID WAS VIBRATE AND MAKE THAT PULSE NOISE. NO MATER HOW HARD I PUSHED THE PEDAL, THE TRUCK WOULD NOT STOP AND I WENT THROUGH THE GARAGE DOOR AND ALSO KNOCKED OVER MY HARLEY THAT WAS IN THE GARAGE. I CANT BELIEVE THE AMOUNT OF COMMON STORY'S ABOUT THIS BRAKE ISSUE. THERE SHOULD BE A CLASS ACTION LAWSUIT. *TR

Mileage: 223,000

HEADING INTO PARKING SPOT AT WALMART , APPLIED BRAKES WOULD NOT STOP , HEADING HEAD ON INTO PARKED CAR , SLAMMED EMERGENCY BRAKE , PUT INTO NEUTRAL , FINALLY STOPPED . HAD TO HAVE TOWED TO MECHANIC BRAKE LINES ALL BURST DUE TO RUST , MECHANIC SAID COST TO FIX , APPROX. $1000 OR MORE ? WHICH I DON'T HAVE . THANK GOD I WAS GOING SLOW AND DIDN'T CAUSE ANY INJURY , POUR DESIGN AND POUR QUALITY PARTS PER MECHANIC ON GM'S PART , NOTICE A LOT OF COMPLAINTS ON THESE ERA OF TRUCKS. *TR

Mileage: 219,844

I WAS TRAVELING ON I-95 SOUTH IN VIRGINIA ON THE HOV LANES AT ABOUT 1:30 PM APPROACHING THE ROUTE 1 EXIT. TRAFFIC WAS DEAD STOPPED IN FRONT OF A MODERATE FLOW OF TRAFFIC AND EVERYONE QUICKLY SLAMMED THE BRAKES (INCLUDING ME) TO SLOW AND STOP TO PREVENT REAR ENDING THE STOPPED CARS. TRAFFIC WAS FLOWING AT APPROXIMATELY 75 MPH WHEN I SLAMMED MY BRAKES. THE BRAKES GRABBED MOMENTARILY AND THEN I HEARD A LOUD POP AND THE BRAKE PEDAL WENT TO THE FLOOR; THE VEHICLE BRAKES WERE GONE. NO PRESSURE WAS AT THE PEDAL EVEN AS I PUMPED IT. THE ONLY WAY OUT WAS TO HIT THE SHOULD AND BERM AND TAKE THE ROUTE 1 EXIT TO COAST TO A STOP; WHICH I DID. NO FLUID LOSS WAS EVIDENT AT THE MASTER CYLINDER RESERVOIR AND I COULDN'T SEE EVIDENCE OF A BLOWN LINE OR BRAKE CALIPER UNTIL I GOT THE VEHICLE HOME AND NOTICED THE METAL (STEEL) BRAKE LINE BETWEEN THE MASTER CYLINDER AND THE ANTI-LOCK BRAKE CONTROL VALVE/MODULE WAS LEAKING AT A PIT IN THE LINE CAUSED BY RUST. THE POINT WAS UNDER THE DRIVER SIDE FLOOR PAN ON THE OUTSIDE OF THE FRAME AND PARALLEL WITH THE FRAME. IT BLEW A RUSTED PITTED SPOT ON THE LINE UNDER PRESSURE.. *JS

Mileage: 154,976

TL* THE CONTACT OWNS A 2001 GMC SIERRA. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THE BRAKE PEDAL WAS ENTIRELY DEPRESSED AND THE VEHICLE ROLLED INTO AN INTERSECTION. THE CONTACT STATED THAT THE EMERGENCY BRAKE WAS APPLIED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 227,570.

Mileage: 227,570

TL* THE CONTACT OWNS A 2001 GMC SIERRA. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE BRAKES FAILED TO RESPOND. THE CONTACT HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE INDEPENDENT MECHANIC DIAGNOSED THAT THE BRAKE LINES HAD RUST BUILD UP. THE INDEPENDENT MECHANIC REPAIRED ONE BRAKE LINE. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

Mileage: 170,000

I WAS ON MY WAY HOME FROM AN EVENT THIS PAST SATURDAY HEADING TO DROP OFF MY SON. AFTER DROPPING HIM OFF I CONTINUED HOME. I WAS TRAVELING ABOUT 35 MPH WHEN THE LIGHT TURNED RED AND I DEPRESSED THE BRAKE AND WAS TERRIFIED WHEN IT WENT DOWN TO THE FLOOR. ALTHOUGH I HAVE AS ABLE TO COME TO A STOP WITHOUT INCIDENT I HAVE AS STILL TERRIFIED. I AM A DISABLED VETERAN WITH A HEART CONDITION AND COULD HAVE HAD A HEART ATTACK. I HAD MY TRUCK LOOKED AT BY MY CERTIFIED MECHANIC AND HE TOLD ME THAT MY BRAKE LINE RUPTURED DUE TO RUST AND IT WILL COST ME AROUND $1000.00 FOR REPAIRS. I HAVE HAD MANY MANY CARS AND TRUCKS IN MY LIFETIME AND NEVER EVER EXPERIENCED ANY PROBLEMS OF THIS NATURE. IT SEEMS TO ME THE MANUFACTURE WOULD ALLOW FOR THESE NORTHERN CONDITIONS WITH THE PARTS THEY USE IN PRODUCTION. *TR

Mileage: 94,000

TL* THE CONTACT OWNS A 2001 GMC SIERRA. THE CONTACT WAS DRIVING APPROXIMATELY 2 MPH WHEN THE BRAKES FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

Mileage: 120,000

EXPERIENCED COMPLETE FAILURE OF THE BRAKING SYSTEM. FORTUNATELY THE VEHICLE WAS ONLY TRAVELING 15MPH AND IN AN AREA THAT WASN'T CONGESTED WITH TRAFFIC. I WAS ABLE TO STOP BY USING THE ROADSIDE BERM BANKING AND AVOIDED ANY FURTHER DAMAGE. VEHICLE WAS TOWED TO A NEARBY GM DEALERSHIP WHERE IT WAS DETERMINED THAT BOTH BRAKE LINES HAD CORRODED SO BADLY IT CAUSED THE LINES TO RUPTURE RESULTING IN AN IMMEDIATE LOSS OF PRESSURE AND COMPLETE BRAKE FAILURE. JUST DAYS EARLIER I HAD THE BRAKES SERVICED AT A DIFFERENT GM DEALERSHIP NEAR MY HOME AND THERE WAS NO MENTION OF THIS CONDITION NOR THE PREVIOUS REPORTS OF THIS PROBLEM FROM OTHER OWNERS AS NOTED ON THIS WEB SITE. EVEN IF GM OR THE NHTSA DOES NOT DEEM THIS ISSUE FREQUENT ENOUGH TO ISSUE A TSB, AT MINIMUM A SERVICE WARNING/RECOMMENDATION SHOULD BE ISSUED TO GM DEALERSHIPS AND OTHER REGISTERED SERVICE PROVIDERS ALERTING THEM TO INSPECT FOR THIS CONDITION WHILE SERVICING THE BRAKING SYSTEMS FOR THESE MODEL YEARS. DEATH OR SERIOUS INJURY CAN AND MOST LIKELY WILL OCCUR AS THERE ARE MANY VEHICLES FROM THESE MODEL YEARS STILL ON THE ROAD. *TR

Mileage: 72,495

BRAKE PEDAL WENT TO FLOOD, HAD DIFFICULTY STOPPING TRUCK, LEAKING BRAKE FLUID. *TR

Mileage: 149,000

IT WAS SNOWING AND ICY OUTSIDE. I ATTEMPTED TO BRAKE FOR AN UPCOMING RED LIGHT. THE BRAKE PEDAL WENT COMPLETELY TO THE FLOOR. I HAD VERY LITTLE BRAKING POWER. I STEERED TO THE CURB TO AVOID TRAFFIC IN THE INTERSECTION. I JUMPED THE CURB AND CAME TO A STOP AGAINST A POWER POLE. DAMAGE TO THE POWER POLE AND TO THE FRONT OF MY TRUCK. ONE OF THE STEEL BRAKE LINES RUPTURED. UPON CLOSER INSPECTION, ALL THE BRAKE AND FUEL LINES WERE SEVERELY CORRODED. *TR

Mileage: 135,052

TL* THE CONTACT OWNS A 2001 GMC SIERRA. THE CONTACT STATED THAT THE BRAKE PEDAL BECAME STUCK TO THE FLOOR BOARD WHILE ATTEMPTING TO DEPRESS THE BRAKES. THE CONTACT WAS ABLE TO STOP THE VEHICLE WITH AN ABNORMAL INCREASE IN STOPPING DISTANCE. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE REAR BRAKE LINE WAS LEAKING FLUID DUE TO CORROSION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 115,000.

Mileage: 115,000

STEPPED ON BRAKES APPROACHING YELLOW LIGHT ,SAILED RIGHT THOUGH LIGHT. *TR

Mileage: 80,000

METAL BRAKE LINES RUSTED CAUSING BRAKES TO FAIL AND REPLACEMENT OF MASTER CYLINDER AND BRAKE LINES. *TR

Mileage: 130,000

THE FIRST DAY I NOTICED THAT THE BRAKE PEDAL WENT CLOSER TO THE FLOOR BEFORE THE BRAKES ACTIVATED. THE SECOND DAY THE PEDAL NEARLY TOUCHED THE FLOOR AND THEN THE BRAKE WARNING LIGHT CAME ON. I TOOK THE VEHICLE TO MY NEIGHBORHOOD INDY TIRE CENTER WHERE THEY QUICKLY DETERMINED BRAKE LINE FAILURE NEAR THE LEFT REAR WHEEL. THE BRAKE LINE HAD RUSTED COMPLETELY CAUSING A HOLE AND RAPID LOSS OF BRAKE FLUID. A NEW TEFLON COATED MAIN BRAKE LINE AND FITTINGS WAS INSTALLED ALONG WITH NEW BRAKE FLUID. OTHER BRAKE LINES WERE EXAMINE AND FOUND TO BE RUSTED BUT NOT COMPROMISED. THE TOTAL COST OF REPAIR WAS $461.38. *TR

Mileage: 86,740

REAR BRAKE LINE CORRODED, LEAKING. ANTILOCK SPEED SENSOR ENGAGES DURING LOW SPEED STOPPING - EVEN AFTER RECALL WORK WAS DONE. *TR

Mileage: 90,000

WAS DRIVING ON HIGHWAY AND WAS APPROACHING A RED TRAFFIC LIGHT. PUSHED DOWN ON BRAKE PEDAL WHICH WHEN ALL THE WAY DOWN TO THE FLOOR. I IMMEDIATELY DOWN SHIFTED THE TRANSMISSION FROM "D" TO "3" AND AFTER SLOWING DOWN TO AROUND 35 MPH, DOWN SHIFTED TO "1" SLOWED DOWN MORE AND THEN SHIFTED TO "2". AT THAT POINT, I WAS APPROACHING A CAR AHEAD OF ME, WAITING AT THE RED LIGHT, AND I BEGAN SLOWLY APPLYING THE PARKING BRAKE AND FINALLY CAME TO A STOP, NARROWLY MISSING THE CAR IN FRONT OF ME. AFTER PULLING OFF THE SIDE OF THE ROAD, I LOOKED UNDER THE TRUCK AND DETERMINED THAT BRAKE FLUID WAS LEAKING FROM A BRAKE LINE LOCATED IN THE AREA UNDER THE DRIVER'S SEAT LOCATION. *TR

Mileage: 134,950

FRONT BRAKE LINE FAILED. COMPLETELY RUSTED, IT BLEW OUT INSIDE ONE THE CLIPS THAT HOLD IT IN PLACE. HORRIBLE DESIGN. TRUCK IS SITTING IN MY DRIVEWAY BECAUSE I CANNOT AFFORD TO REPAIR BRAKES. ESTIMATE WAS OVER 1500, JUST TO REPLACE THE LINES, WITH COATED STEEL, NOT STAINLESS. FUEL LINES ARE ALL RUSTED AS WELL. ALL NEED REPLACEMENT. *TR

Mileage: 180,000

WHILE DRIVING TO WORK IN THE MORNING, APPLIED BRAKES AND THE PEDAL SEEMED TO GO DOWN FURTHER THAN NORMAL. WAS EXITING FREEWAY AND APPLIED THE BRAKES, THE PEDAL WENT DOWN TO THE FLOOR BUT THE VEHICLE STOPPED. I THEN PUMPED THE BRAKE PEDAL AND IT WENT TO THE FLOOR AND THE VEHICLE STARTED TO ROLL. I WAS ABLE TO PULL OFF TO THE SIDE OF THE EXIT RAMP AND GET VEHICLE TO STOP BY PUTTING IT INTO REVERSE THEN PARK. IT NOW HAD COMPLETE BRAKE FAILURE. AFTER INSPECTING UNDER THE VEHICLE NOTICED THAT A BRAKE LINE HAD RUSTED THROUGH AND FAILED. THIS ONE LINE FAILURE CAUSED BOTH THE FRONT AND REAR BRAKES NOT TO APPLY AT ALL. AFTER INSPECTING FURTHER NOTICED THAT ALL THE BRAKE LINES HAVE SEVERE CORROSION AND LOOK LIKE THEY COULD FAIL AT ANYTIME. *TR

Mileage: 141,000

ON 12/14/2012. I ENTERED A CONTROLLED INTERSECTION, WENT TO APPLY BRAKES AND BRAKE PEDAL WENT TO FLOOR. TRUCK STOPPED, BUT I NEEDED TO APPLY A LOT OF PRESSURE. CHECKED BRAKE FLUID AND FOUND IT WAS A PINT LOW. ADDED BRAKE FLUID, BUT BRAKE PEDAL STILL NEEDED TO BE PUSHED TO FLOOR TO STOP VEHICLE. BROUGHT TRUCK TO MECHANIC ON 12/18/12. THEY PUT TRUCK ON LIFT, FOUND ENTIRE BRAKE SYSTEM WAS CORRODED. THE BACK PLATE WAS ALSO CORRODED. TO REPAIR, ALL BRAKE LINES, BOLTS NEED TO BE REPLACED, AS MANY PARTS HAVE RUSTED AWAY COMPLETELY. ESTIMATE IS OVER $4,000 TO REPAIR. *TR

Mileage: 150,574

I LOST MY BRAKES WHILE PULLING OUT ONTO THE ROAD. PEDAL WENT TO THE FLOOR BEFORE TRUCK BEGAN TO SLOW DOWN, ABS KICKED ON AND GRINDING ROTORS BEFORE A FULL STOP. BRAKE LINE FAILED LEAKING FLUID UNDER DRIVER'S SIDE DOOR - MOST LIKELY DUE TO RUST. *TR

Mileage: 207,000

THE CHASSIS BRAKE LINES ON MY 2001 GMC SIERRA 1500 ARE RUSTED TO THE POINT THAT THEY ARE FALLING APART. I NOTICED LAST WEEK THAT THE BRAKE PEDAL FEEL IS STARTING TO GET MUSHY. AFTER INSPECTING THE ENTIRE BRAKE SYSTEM I DISCOVERED THAT ALL OF THE HARD CHASSIS BRAKE LINES ARE RUSTED AND FLAKING APART. I CAN NO LONGER SAFELY DRIVE THIS TRUCK UNTIL THESE LINES ARE REPLACED. *TR

Mileage: 109,500

BACKED OUT OF DRIVEWAY AND BRAKE PEDAL FELT SOFT. GOT TO END OF STREET AND SUSPECTING A PROBLEM BEGAN SLOWING EARLY. BRAKE PEDAL WENT TO THE FLOOR WITH VERY LITTLE PRESSURE AND VERY LITTLE STOPPING POWER. WENT BACK TO HOUSE AND FOUND A LARGE PUDDLE OF BRAKE FLUID WHERE THE TRUCK HAD BEEN SITTING. OPENED THE HOOD TO LOOK AT BRAKE RESERVOIR AND FOUND IT EMPTY BUT ALSO REALIZED ALL HARD BRAKE LINES IN VIEW WERE HEAVILY CORRODED AND CRUSTED. LEAK WAS FROM BURST HARD LINE BELOW DRIVER. ALL HARD LINES ARE HEAVILY CRUSTED AND CORRODED NEAR THE POINT OF FAILURE IF NOT ALREADY FAILED. SOME FUEL LINES ALSO CORRODED. *TR

TL* THE CONTACT OWNS A 2001 GMC SIERRA. THE CONTACT STATED THAT WHILE REVERSING FROM A RESIDENTIAL DRIVEWAY, SHE THE BRAKES FAILED AND BRAKE FLUID LEAKED FROM THE VEHICLE ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THEY NEEDED TO REPLACE THE BRAKE LINES. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THERE WERE NO RECALLS FOR THE VEHICLE. THE FAILURE MILEAGE WAS 88,000 AND THE CURRENT MILEAGE WAS 100,005. THE VIN WAS NOT AVAILABLE.

Mileage: 88,000

THIS BRAKE LINE RUPTURE HAPPENED WHILE MY WIFE WAS @ 15 MPH STOPPING FOR TRAFFIC .HOW SHE MANAGED TO STOP I DON'T KNOW. SHE DOES NOT LIKE DRIVING THIS GMC 2500 HD PICKUP BECAUSE IT IS SCARY FOR HER, AFTER THIS BRAKE LINE RUPTURE SHE WILL PROBABLY NEVER DRIVE THIS VEHICLE AGAIN. THANKS GENERAL MOTORS A BUNCH FOR THE NONEXISTENT WARNING ABOUT THIS COMMON OCCURRENCE. THE GENERAL MOTORS PROFIT MEANS MORE TO THEM THAN THE SAFETY OF THEIR CUSTOMERS PRECIOUS FAMILIES. *TR

Mileage: 96,000

BRAKE LINE RUPTURED WHEN ATTEMPTING TO STOP AT A RED LIGHT. HAD TO VEER INTO ADJACENT LANE TO AVOID REAR ENDING TRUCK STOPPED IN FRONT OF ME. VERY FORTUNATE! *TR

Mileage: 104,550