2016 GMC YUKON XL Engine Problems

The engine is the component that failed and is available for inspection. The issue has been confirmed by an independent service center, and the repair quote is attached. There were no prior warning signs before the failure; the vehicle suddenly began making a knocking noise and experienced a loss of power.

While driving vehicle the vehicle appears to shut off as if someone is turning off the ignition. The steering control becomes stiff, power is lost and electronics flash and turn off and on. This has happened on multiple occasions and is intermittent during acceleration. The accessible grounds have been checked, battery checked and replaced, and alternator checked and verified to be charging appropriately. Several codes are present and have been cleared to return indicating low voltage issues with multiple systems.

We own a 2016 GMC Yukon XLT Denali with the GM 6.2 engine. On Saturday, July 26, 2025 our vehicle suddenly lost power and became undrivable in traffic. We had it towed to our GM dealership who still has the vehicle (Reiselman GMC- Springfield, TN) They called today and said the engine could not be repaired. They stated it had no compression in Cylinder 8. The said our only option was a new engine. THIS IS THE SECOND CATASTROPHIC FAILURE we have had. In November 2021 we experienced another CATASTROPHIC FAILURE when the vehicle suddenly lost power. The engine required a valve and valve spring and seal on cylinder #1. This is 2 major failures we have had which could have been dangerous had we not been able to get out of traffic. The vehicle currently has 116k miles. These types of major failures in a vehicle that has been serviced according to schedules and receives only typical local and commuter use is out of the norm. It is the first generation of GM's 6.2L engine and the sister engine to the one currently under major recall and no-sell orders. We believe that GM knows of these issues as we have spoken with other people who have had similar problems. The problems involve the valve train and the crank and pistons much like the recall on the later models. Please advise what we need to do to move our complaint through the system to see if we can get some relief on this matter. The dealer still has the vehicle so we don't have any paperwork yet on the latest incident. I will send the November 2021 information

In June 2024 I took my vehicle to the dealership for a ticking/clacking noise. The dealership determined lifter failure and that the engine needed to be replaced because the lifters/cam were not readily available from the manufacturer due to a known issue with L87 GM motors. Long block was replaced 7/17/24. I believe this should be part of the recall issued against L87 motors and should be extended beyond the 2021-2024 years initially noted.

6.2L collapsed lifter on cylnder 5. This os my second engine with the exact same problem as the first engine reason for replacement

After leaving a car wash on 12/19/22, the engine began sputtering and did not seem to be able to get any gas. After pressing gas pedal, the vehicle slowly moved forward, but was shifting hard. Pulled over in gas station parking lot and turned vehicle off. Checked Engine. Vehicle would not restart. Vehicle was towed to dealership. They uncovered a broken valve spring, which also caused the catalytic converters to fail. Total bill was over $7500

Having to replace an engine at one hundred and three thousand miles…not something I would expect

Merging onto highway and my car would not get up any speed . Was almost crushed by a tractor trailer. If I hadn’t had a long merge lane I could have been killed . Apparently my transmission failed. This is certainly a safety issue . Your car should not just quit! .called dealer and they said the problem is known but gmc is not doing anything about it! Please help 75,000 $ car should last !

Like many other complaints..when your driving and accelerating it jerks and try’s to change gears ect. Most recent issue is the temperature sensor went out and my fan was running on full speed. Well I got it fixed and within 2 months it has gone out again! Lastly, the paint on the hood and roof. When I bought the dealership fixed the hood and yet again it’s failing again..

The contact owns a 2016 GMC Yukon XL. The contact stated that while driving at approximately 55 MPH, there was a knocking sound coming from the engine compartment before the vehicle stalled. The vehicle was towed to the local mechanic who determined that the engine was faulty and needed to be replaced. The vehicle was not yet repaired. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 140,000.

Mileage: 140,000

At 90500 miles my Yukon xl started shuddering and the transmission started failing and I have never used it to pull anything so this was very dissatisfying for a 75k vehicle

The fuel injectors have gone out on our vehicle. While driving the vehicle, the check engine began blinking and our vehicle went into limp mode- could feel the engine misfiring and the vehicle was shaking. We had a family of five and two dogs in the vehicle and were lucky to be in cell service. A message popped up on our dash stating “engine power reduced.” The local dealership confirmed it is a fuel injector issue. GMC has a current recall In place, however it only includes certain states.

Experienced tapping noise front right passenger side, took vehicle to Firestone diagnosed the problem - the vehicle was confirmed to have 2 broken exhaust manifold studs in the cylinder head. Mileage 85.407- This vehicle has never been used to tow anything.

VEHICLE HAS 125K MILES AND HAD A BROKEN VALVE SPRING WHICH DROPPED THE VALVE INTO THE CYLINDER WHICH IS REQUIRING A NEW ENGINE. I WAS STOPPED AT A STOP LIGHT WHEN THIS OCCURED ON A CITY STREET.

Mileage: 125,000

LED BRAKE LIGHTS DON'T WORK CAR SHAKES AND TRANSMISSION SHUDDERS WHILE DRIVING 35-45MPH

Mileage: 85,000

TL* THE CONTACT OWNS A 2016 GMC YUKON XL. WHILE DRIVING AT LOW OR HIGH SPEEDS, THE VEHICLE SHOOK VIOLENTLY AS IF IT WOULD FALL APART. ALSO, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO CAPPELLINO BUICK GMC (5411 TRANSIT RD, BUFFALO, NY 14221) WHERE IT WAS DIAGNOSED WITH A TORQUE CONVERTER SHUDDER FAILURE AND A TRANSMISSION FLUSH WAS COMPLETED. THE DEALER ADVISED THE CONTACT TO DRIVE FOR 200 MILES TO CORRECT THE FAILURE; HOWEVER, THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE ANOTHER TRANSMISSION FLUSH WAS COMPLETED. THE CONTACT WAS ALSO INFORMED THAT THE SHEET METAL ON THE CROSS-MEMBER WAS CAUSING THE VIBRATION. THE CROSS MEMBER WAS REPAIRED. AFTER THE REPAIRS, THE CABIN OF THE VEHICLE WAS UNCOMFORTABLE WITH UNEVEN PRESSURE AND A HIGH VELOCITY VIBRATION. THE SAME DEALER AND WEST HERR CHEVROLET OF WILLIAMSVILLE (8040 TRANSIT RD, WILLIAMSVILLE, NY 14221) PERFORMED SEVERAL TRANSMISSION FLUSHES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CLAIM WAS FILED. THE CONTACT WAS COMPENSATED FOR THE FAILURE; HOWEVER, THE FAILURE CONTINUED. THE CONTACT STATED THAT THE VEHICLE WAS CURRENTLY AT THE WEST HERR DEALER AS THE VEHICLE WAS STALLING, THE RPMS INCREASED, AND THE TRACTION AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 42,241.

Mileage: 42,241

THE TRANSMISSION WENT OUT, THE ENGINE IS MAKING A NOISE AND A SERVICE CENTER SAID LOTS OF GM'S VEHICLES ARE HAVING THE SAME PROBLEM THE POWER STEERING SYSTEM ALSO STOP WORKING AND I HAVE TO REPLACE IT

Mileage: 189,000

TL* THE CONTACT OWNS A 2016 GMC YUKON XL. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE VEHICLE SHUDDERED WHEN SHIFTING GEARS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TRANSMISSION, TRANSMISSION FLUID, AND WIRING HARNESS NEEDED TO BE REPLACED; HOWEVER, PARTS NUMBER: 700, 711, 2429, 7371, AND 87571 WERE ON BACKORDER. THE CONTACT CALLED TED BRITT CHEVROLET (46990 HARRY BYRD HWY, STERLING, VA 20164, (703) 955-3610), BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY WOULD ATTEMPT TO LOCATE THE PARTS; HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE CONTACT STATED THAT THE VEHICLE WAS A LEMON. THE FAILURE MILEAGE WAS 65,350.

Mileage: 65,350

BOUGHT SUV 6/25/2016 THE SAME WEEKEND THE ENGINE TURNS OFF AFTER A LEFT OR RIGHT TURN :IT HAS HAPPENED 3 TIMES SO FAR. 4 WEEK OLD 2016 YUKON DENALI XL, HAS STALLED 3 TIMES IN LAST 4 WEEKS, ENGINE CUTS OFF AFTER A LEFT OR A RIGHT TURN ONLY AFTER A SHORT DRIVE OUT OF HOME. THE SUV HAS TO BE RESTARTED! COULD HAVE EASILY HAD AN ACCIDENT OR WORSE. I TOOK IT TO THE WESTPOINT GMC DEALER, 3 TIMES. 1ST TWO TIMES, ALL OF SERVICE DEPTARTMENT COULD NOT DIAGNOSE THE PROBLEM. TODAY, AFTER A STALL, I CALLED ONSTAR, WHO RAN A DIAGNOSTICS TEST,BUT ONSTAR FOUND NOTHING OF VALUE , I LEFT IT AT DEALERSHIP AND CONTACTED DISTRICT MGR. MATT TILLSON . I WAS TOLD THAT THEY WOULD ESCALATE THE ISSUE. I DID TELL DEALER THAT GMC AND DEALERSHIP WOULD BE AT FAULT IF VEHICLE IS INVOLVED IN AN ACCIDENT AND STALLS NOR STOPS WHILE I AM DRIVING. I DID NOT WANT THE VEHICLE BACK WITHOUT THE PROBLEM HAVING BEEN FIXED. ITS DAY 6 TODAY. I NEED TO MAKE IT ABSOLUTELY CLEAR, I WILL NOT TAKE THE VEHICLE BACK UNTILL THE PROBLEM HAS BEEN DIAGNOSED, AND FIXED. I DO NOT WANT ME OR MY FAMILY OR GM SERVICE EMPLOYEE INJURED, OR WORSE, OR TO BE INVOLVED WITH A POSSIBLE ACCIDENT IN MY GMC YUKON DENALI XL. A FIELD SERVICE ENGINEER SHOULD HAVE BEEN ON THIS CASE ALREADY ! WILL IT TAKE AN ACCIDENT, OR INJURY BEFORE SOMEONE GETS ASSIGNED?

Mileage: 4,500

IN MY YUKON WHILE IDLEL THE CAR START SHAKING SO BAD, IT HAS A VIBRATION YOU CAN SEE THE NEEDLE GOING UP AND DOWN, TOOK IT SEVERAL TIME TO THE DEALER AND THEY SAID THEY KNOW IS A PROBLEM WITH THE CAR BUT GENERAL MOTOR COMPANY HAS NOT ISSUE ANY REPAIR FOR THAT AT THIS MOMENT, I CONTACT GENERAL MOTOR COMPANY THEY SAID THE CAR IS OPERATING NORMAL BASE ON THE REPORT PROVIDED BY THE DEALERS, FOR ME IS NOT NORMAL HAVING A BRAND NEW CAR SHAKING AND VIBRATING LIKE IF WILL TURN OF, LOOKS LIKE IF MISFIRED ON THE ENGINE,

Mileage: 30