2017 GRAND DESIGN REFLECTION Problems & Recalls

Noticed the left side of the 5th wheel seemed lower, the smell of burning rubber was highly present. Upon further investigation noticed the front axle leaf spring had broken. Noticed the new tire was hot and rubbed up on and caused damage to the metal of the chassis and ruined the new tire.

INTERMITTENT BRAKES (LOST BRAKES) ON FIFTH WHEEL DUE TO THE USE OF UNDERSIZE WIRE AND OVERUSE OF SCOTCHLOK GUILLOTINE CONNECTORS. EACH BRAKE HAS A MAXIMUM CURRENT DRAW OF 4AMPS. 4X4 = 16 AMP POSSIBLE DRAW ON 14 AWG WIRE AT APPROXIMATELY 60+ FOOT LOOP ROUND TRIP FROM PIN BOX TO BRAKES BACK TO PIN B...

Mileage: 25,000

TL* THE CONTACT OWNS A 2017 GRAND DESIGN REFLECTION FIFTH WHEEL TRAILER EQUIPPED WITH WESTLAKE SUPER ST TIRES, SIZE: ST225/75/R15, DOT NUMBER: JULT1CM4016. THE CONTACT NOTICED A BULGE ON THE SIDEWALL OF THE FRONT PASSENGER TIRE UPON INSPECTION AT A REST STOP. THE CONTACT STATED THAT WHILE DRIVING UP...

Mileage: 5,000

I WAS DRIVING IN ARKANSAS IN OCTOBER 11TH 2019 WHEN I NOTICED THE RV DID NOT APPEAR TO BE TRACKING STRAIGHT BEHIND THE TRUCK. I PACKED UP AND LEFT THE CAMPGROUND ABOUT 2 HOURS EARLIER. THERE WERE NO ISSUES WITH THE AXLES AT THAT TIME. THERE WERE NO UNUSUAL ROAD HAZARDS OR SHOCKS TO THE FRAME DURI...

Mileage: 21,300

I WAS DRIVING IN ARKANSAS IN OCTOBER 11TH 2019 WHEN I NOTICED THE RV DID NOT APPEAR TO BE TRACKING STRAIGHT BEHIND THE TRUCK. I PACKED UP AND LEFT THE CAMPGROUND ABOUT 2 HOURS EARLIER. THERE WERE NO ISSUES WITH THE AXLES AT THAT TIME. THERE WERE NO UNUSUAL ROAD HAZARDS OR SHOCKS TO THE FRAME DURI...

Mileage: 21,300

THE RIGHT REAR LEAF SPRING HANGER FOR THE REAR AXLE BROKE OFF FROM THE TRAILER FRAME, THIS HAPPENED WHEN VEHICLE WAS IN MOTION ON THE HIGHWAY. NOTICED REAR AXLE OUT OF PLACE WHEN WE WERE PARKED IN OUR DRIVEWAY UPON FURTHER INSPECTION THAT IS WHEN WE NOTICED THE RIGHT REAR HANGER BROKEN COMPLETELY O...

Mileage: 15,000

TWO SEPARATE ISSUES: 1. LIPPERT WHEEL BEARINGS LEAKED GREASE ALL OVER THE DRUM BRAKES WITH LESS THAN 4000 MILES. LIPPERT REFUSED TO PAY FOR REPAIRS BECAUSE IT HAS BEEN MORE THAN ONE YEAR. 2. WITH BRAND NEW BRAKES PROPERLY ADJUSTED, BRAKES ARE STILL VERY WEAK. APPLYING 12 VOLTS FROM BRAKE CONTROLLE...

Mileage: 4,000

DURING MOSTLY HIGHWAY TRAVEL WITH OUR CAMPER THE AXLE GREASE SEALS FAILED WHICH ALLOWED GREASE TO CONTAMINATE THE BRAKE SHOES AND BRAKE DRUMS AFFECTING BRAKING PERFORMANCE. REVIEWING OTHER POSTS ON-LINE A LOT OF OTHER OWNERS OF THESE CAMPERS ARE EXPERIENCING THE SAME PROBLEM, WHICH IS A SIGNIFICANT...

MY COMPLAINT IS FOR WHEEL BEARINGS. I'VE CONTACTED BOTH SELLER BYOUNG RV IN PORTLAND OREGON (XXXX) AND MANUFACTURE GRAND DESIGN RV (XXXX). MY TRAILER HAS BEEN HAVING ISSUES WITH EXCESSIVE RESIDUE BUILD UP ON WHEELS. ANOTHER REFLECTION OWNER TOLD ME HIS TRAILER WAS DOING SAME THING. THE DEALER WHERE ...

Mileage: 5,500

THE BRAKES, SEALS AND BEARINGS ON MY 5TH WHEEL TRAVEL TRAILER WILL HAVE TO BE REPLACED FOR THE THIRD TIME DUE TO THE SEALS LEAKING GREASE ONTO THE BRAKES. ALL FOUR BACKING PLATES, THE FRONT TWO HUBS AND ALL FOUR GREASE SEALS AND BEARINGS WERE REPLACED ON OUR FIRST TRIP AFTER TAKING POSSESSION OF ...

Mileage: 1,000

BRAKES WERE NOT WORKING VERY WELL, WITH THE TRAILER BRAKE CONTROLLER GAIN IN MY TRUCK SET AT 10.0 (FULL ON). PROBLEM WAS CAUSED BY LEAKING AXLE SEALS ON THE PASSENGER SIDE OF THE VEHICLE WHICH RESULTED IN THE BRAKE SHOES AND DRUMS BEING COATED WITH AXLE GREASE. ALL FOUR BRAKE ASSEMBLIES AND AXLE S...

Mileage: 1,500

3 OF 4 WHEELS HAD GREASE LEAKING FROM THE INNER HUB SEAL ONTO THE BRAKE SHOES AND DRUMS, WITH LOSS OF BRAKING POWER. ALL BRAKES HAD TO BE REPLACED.

Mileage: 1,700

THE AXLES/BRAKE ASSEMBLIES HAD DEFECTIVE INTERIOR SEALS. THE SEALS FAILED AND CONTAMINATED THREE OUT OF FOUR BRAKES WITH GREASE. THIS NEARLY CAUSED ME TO HAVE A SERIOUS ACCIDENT DUE TO UNABLE TO STOP THE TRAILER TO AVOID VEHICLE THAT PULLED OUT IN FRONT OF ME. I HAD TO RUN OFF ROAD TO AVOID ACCID...

Mileage: 3,000

WHEEL BEARING GREASE TOO THIN AND LEAKS PAST SEALS CONTAMINATING BRAKE MAGNETS AND BRAKES. MANY CUSTOMERS IMPACTED BASED ON FACEBOOK GROUP POSTS.

Mileage: 1,000

WHEEL BEARING GREASE TOO THIN AND LEAKS PAST SEALS CONTAMINATING BRAKE MAGNETS AND BRAKES. MANY CUSTOMERS IMPACTED BASED ON FACEBOOK GROUP POSTS.

Mileage: 1,000

TRAILER HAS LEAKING GREASE SEALS WHICH CONTAMINATED THE BRAKE SHOES. THIS IS A NEW TRAILER AND ARRIVED FROM DEALER IN THIS CONDITION. THIS IS A 2 AXLE TRAILER.

Mileage: 2,000

TRAILER HAS LEAKING GREASE SEALS WHICH CONTAMINATED THE BRAKE SHOES. THIS IS A NEW TRAILER AND ARRIVED FROM DEALER IN THIS CONDITION. THIS IS A 2 AXLE TRAILER.

Mileage: 2,000

AXLE SEAL LEAKED CAUSING GREASE TO LEAK ONTO BRAKE FRICTION SURFACE, GREATLY REDUCING BRAKING ABILITY. PROBLEM WAS FOUND DURING OWNERS SELF INSPECTION. THIS PROBLEM WAS BROUGHT TO MY ATTENTION FROM THE GRAND DESIGN OWNERS FORUM. "HTTP://WWW.GRANDDESIGNOWNERS.COM/FORUM/SHOWTHREAD.PHP/8531-POLL-HOW-MA...

Mileage: 1,700

WITH LESS THAN 3000 MILES, THE WHEEL GREASE SEALS HAVE LEAKED CONTAMINATING THE TRAILER BRAKES. RESULTED IN REDUCED BRAKING ABILITY. POTENTIAL SAFETY PROBLEM REDUCING TRAILER BRAKES EFFECTIVE STOPPING POWER.

Mileage: 3,000

WITH LESS THAN 3000 MILES, THE WHEEL GREASE SEALS HAVE LEAKED CONTAMINATING THE TRAILER BRAKES. RESULTED IN REDUCED BRAKING ABILITY. POTENTIAL SAFETY PROBLEM REDUCING TRAILER BRAKES EFFECTIVE STOPPING POWER.

Mileage: 3,000

WITH LESS THAN 3000 MILES, THE WHEEL GREASE SEALS HAVE LEAKED CONTAMINATING THE TRAILER BRAKES. RESULTED IN REDUCED BRAKING ABILITY. POTENTIAL SAFETY PROBLEM REDUCING TRAILER BRAKES EFFECTIVE STOPPING POWER.

Mileage: 3,000

WE WERE ON A TRIP FROM CALIFORNIA TO TEXAS AND THE GREASE SEALS ON ALL 4 WHEELS FAILED AND CONTAMINATED THE BRAKES. I HAVE OWNED THE VEHICLE FOR 1 MONTH AND IT HAD LESS THAN 1,200 MILES ON IT.

Mileage: 1,200

WE WERE ON A TRIP FROM CALIFORNIA TO TEXAS AND THE GREASE SEALS ON ALL 4 WHEELS FAILED AND CONTAMINATED THE BRAKES. I HAVE OWNED THE VEHICLE FOR 1 MONTH AND IT HAD LESS THAN 1,200 MILES ON IT.

Mileage: 1,200

WHEEL GREASE SEALS ARE LEAKING ON THE NEW TRAILER (2 OF 4 SEALS). THIS IS A NEW TRAILER AND I HAVE ONLY PUT ON ABOUT 50 MILES. THERE HAS BEEN NUMEROUS COMPLAINTS ON THIS ISSUE WITH GRAND DESIGN TRAILERS.

Mileage: 50

WHEEL GREASE SEALS ARE LEAKING ON THE NEW TRAILER (2 OF 4 SEALS). THIS IS A NEW TRAILER AND I HAVE ONLY PUT ON ABOUT 50 MILES. THERE HAS BEEN NUMEROUS COMPLAINTS ON THIS ISSUE WITH GRAND DESIGN TRAILERS.

Mileage: 50

LEAKING GREASE SEALS ON BOTH PASSENGER SIDE AXLES CONTAMINATING BRAKE SHOES. I HAD DEALER PULL THE BRAKE DRUMS PRIOR TO DELIVERY OF OUR NEW TRAILER AND WE FOUND GREASE CONTAMINATION. THE TRAILER ONLY HAD BEEN TRANSPORTED FROM INDIANA TO FLORIDA DEALER.

Mileage: 1,200

TL* THE CONTACT OWNS A 2017 GRAND DESIGN REFLECTION RV. THE CONTACT STATED THAT THERE WAS AN ABNORMAL PROPANE FUEL ODOR EMITTING FROM THE RV. THE RV WAS INSPECTED BY A SERVICE TECHNICIAN WHO STATED THAT THE FUEL LINE SHOWED EVIDENCE THAT A RODENT CHEWED THROUGH THE PROPANE FUEL LINE, WHICH NEEDED TO...

Mileage: 60

THIS NEW VEHICLE, A 9000 LB UVW, WAS DELIVERED WITH BRAKES CONTAMINATED WITH GREASE RENDERING THEM INEFFECTIVE AND CREATING AN UNSAFE CONDITION. NO ACCIDENT OCCURED. THE BRAKES ARE GOING TO BE REPLACED. WHEEL BEARING GREASE BREACHED THE HUB SEALS, CONTAMINATING THE BRAKE DRUMS AND BRAKE SHOES.

Mileage: 100

JUST PURCHASED AN NEW TRAVEL TRAILER. MANY, MANY REPORTS OF LCI AXLE SEALS LEAKING AND DISPERSING GREASE ON BRAKE ASSEMBLIES. SURE ENOUGH, DEALER HAD TO REPLACE TWO OF FOUR BRAKE ASSEMBLIES, AS WELL AS ALL FOUR SEALS AS THEY ALL HAD LEAKED (TRAILER WAS NEW, JUST DROVE TO DEALER FROM FACTORY). THIS I...

Mileage: 2,500

A JUST PURCHASED NEW REFLECTION 337RLS THAT HAS A 11/30/16 DATE IN THE VEHICLE INFORMATION SHEET AND 11/24/16 DATE ON THE SERIAL NUMBER DATA SHEET. THE ONLY MILES ON THE UNIT WERE THE DELIVERY MILES FROM THE PLANT TO THE DEALER IN COLORADO AND THE ~400 MILES ADDED TO THOSE. ON THE TRIP HOME (THE...

Mileage: 1,800

AT 1,850 MILES, THE BRAKES ON THIS UNIT WERE COMPLETELY SATURATED IN WHEEL BEARING GREASE CAUSING THEM TO BECOME INEFFECTIVE AT EVEN THE HIGHEST BRAKE CONTROLLER SETTING. ALL FOUR BRAKES WERE AFFECTED. A TRAILER OF THIS SIZE IS REQUIRED TO HAVE FUNCTIONING BRAKES. THE BRAKES ARE DESIGNED THAT THE...

Mileage: 1,850

GREASE LEAKING FROM AXLE SEALS WITH EXTENSIVE CONTAMINATION OF BRAKES ON 2 OUT OF 4 WHEELS. A 3RD WHEEL IS JUST STARTING TO SHOW SIGNS OF GREASE LEAKING PAST SEAL WITH ONLY THE START OF CONTAMINATION OF BRAKE PAD. LIPPERT AXLE AND BRAKE ASSEMBLIES. APPROXIMATELY 3,420 MILES SINCE MANUFACTURE OF T...

Mileage: 3,420

GREASE LEAKING FROM AXLE SEALS WITH EXTENSIVE CONTAMINATION OF BRAKES ON 2 OUT OF 4 WHEELS. A 3RD WHEEL IS JUST STARTING TO SHOW SIGNS OF GREASE LEAKING PAST SEAL WITH ONLY THE START OF CONTAMINATION OF BRAKE PAD. LIPPERT AXLE AND BRAKE ASSEMBLIES. APPROXIMATELY 3,420 MILES SINCE MANUFACTURE OF T...

Mileage: 3,420