2022 GRAND DESIGN REFLECTION Problems & Recalls

The contact owns a 2022 Grand Design Recreational Reflection RV. The contact stated that while driving approximately 60 MPH, the propane compartment doors opened unintendedly. The failure had occurred on several occasions. The contact stated that the roof was peeling and cracking and the contact was...

The contact owns a 2022 Grand Design Recreational Reflection RV. The contact stated that while driving approximately 60 MPH, the propane compartment doors opened unintendedly. The failure had occurred on several occasions. The contact stated that the roof was peeling and cracking and the contact was...

After the trailer collapsed, I’m deeply concerned for my children’s safety and the safety of others. Despite raising these issues, the manufacture Grand Design has deflected responsibility and refused to act, even while under warranty. I kindly request immediate attention and a formal response. ...

After the trailer collapsed, I’m deeply concerned for my children’s safety and the safety of others. Despite raising these issues, the manufacture Grand Design has deflected responsibility and refused to act, even while under warranty. I kindly request immediate attention and a formal response. ...

After the trailer collapsed, I’m deeply concerned for my children’s safety and the safety of others. Despite raising these issues, the manufacture Grand Design has deflected responsibility and refused to act, even while under warranty. I kindly request immediate attention and a formal response. ...

1. EXCESSIVE FRAME FLEX / FAILURE: Symptoms include: Bowing of walls; Trim coming loose; Cracks in fiberglass wall by slide (occurred a 2nd time after side wall repaired by factory) ; crack in interior wall; crack in roof; Main door opening during transport; Sawdust repeatedly appearing in cabinets;...

1. EXCESSIVE FRAME FLEX / FAILURE: Symptoms include: Bowing of walls; Trim coming loose; Cracks in fiberglass wall by slide (occurred a 2nd time after side wall repaired by factory) ; crack in interior wall; crack in roof; Main door opening during transport; Sawdust repeatedly appearing in cabinets;...

1. EXCESSIVE FRAME FLEX / FAILURE: Symptoms include: Bowing of walls; Trim coming loose; Cracks in fiberglass wall by slide (occurred a 2nd time after side wall repaired by factory) ; crack in interior wall; crack in roof; Main door opening during transport; Sawdust repeatedly appearing in cabinets;...

We purchased our 2022 Grand Design Reflection in January 2022 and were told it is good for full-time living since that is what we do. We have had issues with the slides, roof and other items list below: 3/11/2022 - Warranty Items: Driver side large slide won’t go in all the way and driver side fr...

We purchased our 2022 Grand Design Reflection in January 2022 and were told it is good for full-time living since that is what we do. We have had issues with the slides, roof and other items list below: 3/11/2022 - Warranty Items: Driver side large slide won’t go in all the way and driver side fr...

We purchased our 2022 Grand Design Reflection in January 2022 and were told it is good for full-time living since that is what we do. We have had issues with the slides, roof and other items list below: 3/11/2022 - Warranty Items: Driver side large slide won’t go in all the way and driver side fr...

Crack in side wall . This Crack was already fixed by the Grand Design once . A year later I looked at wall and Crack is back . This is one of many issues regarding this rig . Most of which I fixed myself . 1st issue the door was improperly installed . It would open going down the road . I fixed it b...

Cargo Bay doors open while driving. The skirting screws along the wheel wells have become loose and started flapping while driving. refrigerator doors opened spilling contents while driving. The table lock failed and the table came loose while driving. water leaks in the undercarriage. front jacks a...

Cargo Bay doors open while driving. The skirting screws along the wheel wells have become loose and started flapping while driving. refrigerator doors opened spilling contents while driving. The table lock failed and the table came loose while driving. water leaks in the undercarriage. front jacks a...

We purchased the coach fall 2022. First major trip was in summer 2023. The main slide out failed (stopped working halfway out and would not extend or retract) the second night of camping. There was not a local repair facility available. A mobile repair person was able to get the slide out retracted....

We purchased the coach fall 2022. First major trip was in summer 2023. The main slide out failed (stopped working halfway out and would not extend or retract) the second night of camping. There was not a local repair facility available. A mobile repair person was able to get the slide out retracted....

We purchased the coach fall 2022. First major trip was in summer 2023. The main slide out failed (stopped working halfway out and would not extend or retract) the second night of camping. There was not a local repair facility available. A mobile repair person was able to get the slide out retracted....

Frame and structure issues Entrance door opens during transit Propane compartment opens during transit Large slide difficult to extent

Frame and structure issues Entrance door opens during transit Propane compartment opens during transit Large slide difficult to extent

Frame and structure issues Entrance door opens during transit Propane compartment opens during transit Large slide difficult to extent

While returning from a recent camping trip my wife while following the trailer home noticed the house structure was swaying and bouncing too much. She had thought the rig would fall apart. We arrived home and notice that the slide was out 2-4 inches, the cabin door had opened, an interior wall had ...

While returning from a recent camping trip my wife while following the trailer home noticed the house structure was swaying and bouncing too much. She had thought the rig would fall apart. We arrived home and notice that the slide was out 2-4 inches, the cabin door had opened, an interior wall had ...

While returning from a recent camping trip my wife while following the trailer home noticed the house structure was swaying and bouncing too much. She had thought the rig would fall apart. We arrived home and notice that the slide was out 2-4 inches, the cabin door had opened, an interior wall had ...

The welds for the rear wall framing have broken loose and the rear wall is shifting side to side. I assume after time it could fully detach from the trailer and fall into the roadway. The trailer has not been inspected yet, but there are other cases documented on the internet. [XXX] [XXX] [XXX] ...

There is an issue with the structural integrity of the front upper deck where the walls are bolted to the frame. The only fasteners that I could find are loose and stripped out with no way of tightening them. There is also a lot of creaking and popping noises from the front upper deck area when hitc...

Both sidewalls on my 5th Wheel have broken frames at the top of the walls and the walls need replaced. The side doors and compartment doors come open going down the road. The large side window exploded going down the road from the frame twisting. The RV has to be sent back to the factory to be repai...

Both sidewalls on my 5th Wheel have broken frames at the top of the walls and the walls need replaced. The side doors and compartment doors come open going down the road. The large side window exploded going down the road from the frame twisting. The RV has to be sent back to the factory to be repai...

Awning has started to detach from roller. There is a recall on the awning but Grand Design says my trailer doesn't fall within the recall date. Obviously the issue started before the dates they listed and the recall should be extended.

-Baggage compartment doors, when latched securely and locked with key, would open during travel down the highway at random. Luckily no cargo was lost (I take turns very slowly and noticed flapping baggage doors in my side view mirrors pretty quickly). This has happened on multiple occasions, and con...

-Baggage compartment doors, when latched securely and locked with key, would open during travel down the highway at random. Luckily no cargo was lost (I take turns very slowly and noticed flapping baggage doors in my side view mirrors pretty quickly). This has happened on multiple occasions, and con...

-Entry door of travel trailer opens during travel even with both deadbolt & handle locks in locked positions. -This could allow items inside travel trailer to be sucked out onto roadway. That could lead to property damage, injuries, & even death to myself, my passengers, & any other vehicle on the ...

-Entry door of travel trailer opens during travel even with both deadbolt & handle locks in locked positions. -This could allow items inside travel trailer to be sucked out onto roadway. That could lead to property damage, injuries, & even death to myself, my passengers, & any other vehicle on the ...

-Stabilizer leveling powered scissor jacks front and rear collapsed during first trip ever; at a level campsite (Lippert LCI brand) on brand new travel trailer. -Rear stabilizer failed the worst, with the metal arms deforming so much that the jack could not be retracted fully via power or manual wi...

-Stabilizer leveling powered scissor jacks front and rear collapsed during first trip ever; at a level campsite (Lippert LCI brand) on brand new travel trailer. -Rear stabilizer failed the worst, with the metal arms deforming so much that the jack could not be retracted fully via power or manual wi...

-Stabilizer leveling powered scissor jacks front and rear collapsed during first trip ever; at a level campsite (Lippert LCI brand) on brand new travel trailer. -Rear stabilizer failed the worst, with the metal arms deforming so much that the jack could not be retracted fully via power or manual wi...

-Fresh water tank 54gal capacity leaking after being filled, began as a small leak and over time has become decently extreme (but only leaks when trailer is in motion/traveling down road). It is now to the point that when I followed behind travel trailer in another vehicle, I had to use my windshiel...

-Black tank 43gal capacity leaking after loud "bang" followed a second later by a thud (turned my head to look and saw the travel trailer underbelly enclosure fall/sag about two inches instantly, then after a few moments sewage water began pouring out from multiple locations (I have a video of it le...

After removing the factory installed refrigerator to install a warranty replacement unit, I discovered that the aluminum housing of the refrigerator was coming in contact with two 120v electrical outlets and the corresponding wiring. Excess movement of the refrigerator while towing caused chafing of...

NHTSA Recall No. 22V-308. Defective quick disconnect fitting on LP gas system. Pursuant to the recall notice, on [XXX], I took my 2022 Grand Design Reflection 226RK into the dealership where purchased, Lazy Days in Woodland, WA. The quick disconnect fitting was inspected and determined to be okay...

NHTSA Recall No. 22V-308. Defective quick disconnect fitting on LP gas system. Pursuant to the recall notice, on [XXX], I took my 2022 Grand Design Reflection 226RK into the dealership where purchased, Lazy Days in Woodland, WA. The quick disconnect fitting was inspected and determined to be okay...

NHTSA Recall No. 22V-308. Defective quick disconnect fitting on LP gas system. Pursuant to the recall notice, on [XXX], I took my 2022 Grand Design Reflection 226RK into the dealership where purchased, Lazy Days in Woodland, WA. The quick disconnect fitting was inspected and determined to be okay...

The large slide that has the fridge and dinette has a inadequate schwintek slide mechanism that fails and leaves the buyer to fix out of their own pocket. About all of the floor plan 28BH has this problem. Grand Design may attempt to fix it but it's a bandaid. I have had to pay out of pocket to get ...

From the uploaded documents - Job#s 5,6,7 are the most serious, with #6 being the most likely to cause injury to the occupants of the tow vehicle and the motoring public. The dates are when we had to take it in to the dealer. Purchased the RV [XXX] and took it to FL for full time residency. Conferre...

The bunk beds in the rear room of this 5th wheel camper are approximately 5' off the ground and are not equipped with safety like a standard bed of this height would require from other regulations. This is a MAJOR safety issue that resulted in facial and upper body injuries to my 12 year old daughte...