2010 HARLEY-DAVIDSON FLHTCU Problems & Recalls

I PURCHASED A 2010 HARLEY DAVIDSON ULTRA CLASSIC LAST JUNE. I WAS RIDING HOME LAST WEEK AND WENT TO USE THE REAR BREAK PEDAL AND THE BRAKE WAS ROCK HARD. I SCHEDULED A SERVICE TO DIAGNOIS THE ISSUE AND FOUND THAT THE ABS MODULE CAN CAUSE THE ISSUE. I WAS NOTIFIED TODAY THAT THE ABS MODULE NEEDS TO B...

on Saturday 8/20/22 i was driving to work when i got in the parking lot i lost throttle control it went to limp mode. shut bike off started it back up worked fine. after work i was riding home got bout 2 mile my engine light came on and i lost power to my throttle. it would not rev up. shut bike of...

TL* THE CONTACT OWNS A 2010 HARLEY-DAVIDSON FLHTCU. WHILE DRIVING 20 MPH, THE REAR BRAKE PEDAL FAILED TO OPERATE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V076000 (SERVICE BRAKES, HYDRAULIC). THE MOTORCYCLE WAS TAKEN TO BLUE RIDGE HARLEY-DAVIDSON (2002 13TH AVE DR. SE, HICKORY, ...

Mileage: 21,250

REAR BRAKES WOULD NOT OPERATE. I WAS RIDING AND WHEN I WENT TO APPLY THE REAR BRAKES, IT WAS AS IF I WAS AS IF THE PEDAL WAS FROZE AND NO STOP AT ALL. THE FRONT DID WORK BUT THE REAR WAS COMPLETELY INOPERABLE. FLUSHING THE BRAKE SYSTEM DID NOT WORK AND I ENDED UP REPLACE THE ABS BRAKE MODULE TO C...

Mileage: 70,000

ABS MODULE FAILURE AT SPEED. HD STATES THAT WITH ABS FAILURE, BRAKES ARE OPERABLE WITHOUT ABS FEATURE. REAR PEDAL HAS NO RESISTANCE AND FRONT LEVER IS LOCKED. BRAKE OPERATION IS NORMAL WITH SWITCH OFF, BUT WITH BIKE RUNNING OR SWITCH IN ON POSITION, SYMPTOMS RETURN.

Mileage: 90,000

FRONT BRAKE LEVER LOCKED UP, NO FRONT BRAKES. INVESTIGATED HYDRAULIC SYSTEM. FOUND THAT HYDRAULIC CONTROL UNIT WAS NOT ALLOWING FLUID TO FLOW, THEREBY CAUSING FRONT BRAKES NOT TO APPLY. INVESTIGATED CONCERN ON HARLEY FORUM THAT I AM A MEMBER OF, MULTIPLE COMPLAINTS OF THIS CONCERN. I AM REQUESTING ...

Mileage: 38,505

TL* THE CONTACT OWNS A 2010 HARLEY-DAVIDSON FLHTCU. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THE BRAKE PEDAL AND THE FRONT BRAKE LEVER WERE DEPRESSED BUT THE VEHICLE FAILED TO STOP. AS A RESULT, THE CONTACT CRASHED INTO A PAVEMENT. THE CONTACT SUSTAINED BACK, RIBS, LEFT FOOT, NECK AND LEFT L...

Mileage: 9,000

TL* THE CONTACT OWNS A 2010 HARLEY-DAVIDSON FLHTCU. WHILE DRIVING 20 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE ACCELERATION FAILED. THE CONTACT STATED THAT THE FAILURE OCCURRED FOUR OTHER TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE ACTUATOR F...

Mileage: 26,000

TL* THE CONTACT OWNS A 2010 HARLEY-DAVIDSON FLHTCU. WHILE DRIVING 20 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE ACCELERATION FAILED. THE CONTACT STATED THAT THE FAILURE OCCURRED FOUR OTHER TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE ACTUATOR F...

Mileage: 26,000

I WAS RIDING MY MOTORCYCLE AND EXITING THE FREEWAY RAMP DISCOVERED I HAD NO REAR BRAKES. COULD NOT DEPRESS THE BRAKE PEDAL, LIKE IT WAS FROZEN. TOOK IT TO DEALER AND THEY SAID IT WAS THE ABS MODULE. IF ABS FAILS IT SHOULD GO TO NON ABS BRAKES (FAIL SAFE) INSTEAD OF NO BRAKES. ITS ONLY A MATTER OF T...

Mileage: 24,000

WHILE RIDING BIKE AND TRIED TO STOP ON A CITY STREET. REAR BRAKE PEDAL WENT ROCK HARD AND WOULD NOT ACTIVATE THE REAR BRAKE CALIPER. CHECKED REAR CALIPER TO SEE IF IT WAS LOCKED UP AND CALIPER WAS FINE. CALIPER PISTONS MOVED FREELY. TOOK BIKE TO DEALER AND THEY FOUND THE ABS DISTRIBUTION BLOCK WAS B...

Mileage: 21,230

AFTER RIDING THE MOTORCYCLE NORMALLY FOR APPROXIMATELY 30 MINUTES, I STOPPED AT MY DESTINATION AND SHUT DOWN THE BIKE NORMALLY. APPROXIMATELY 20 MINUTES LATER, I GOT BACK ON THE BIKE TO GO BACK HOME. AT THIS POINT, I FOUND MY RIGHT FRONT BRAKE LEVER WAS FROZE UP AND WOULD NOT MOVE AT ALL. I HAD T...

Mileage: 18,670

TL* THE CONTACT OWNS A 2010 HARLEY-DAVIDSON FLHTCU. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WAS DIFFICULT TO SHIFT INTO DIFFERENT GEARS. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE GASKET, BEARING ROLLER, RETAINING RING, AND INNER PRIMARY...

Mileage: 40,438

MULTIPLE TIMES WHILE RIDDING MY FLHTCU THE BIKE GOES TO "LIMP MODE" NO THROTTLE,AT MULTIPLE SPEEDS, WITH LITTLE TO NO WARNING. AFTER TONES OF RESEARCHING, HOUR OF LABOR, AND A TONE OF MONEY, THE ISSUE STILL EXIST AND I AM AT BUT A LOSE. DURING RESEARCH I FOND THIS ISSUE TO BE A VERY COMMON ONE WIT...

Mileage: 3,700

MULTIPLE TIMES WHILE RIDDING MY FLHTCU THE BIKE GOES TO "LIMP MODE" NO THROTTLE,AT MULTIPLE SPEEDS, WITH LITTLE TO NO WARNING. AFTER TONES OF RESEARCHING, HOUR OF LABOR, AND A TONE OF MONEY, THE ISSUE STILL EXIST AND I AM AT BUT A LOSE. DURING RESEARCH I FOND THIS ISSUE TO BE A VERY COMMON ONE WIT...

Mileage: 3,700

MULTIPLE TIMES WHILE RIDDING MY FLHTCU THE BIKE GOES TO "LIMP MODE" NO THROTTLE,AT MULTIPLE SPEEDS, WITH LITTLE TO NO WARNING. AFTER TONES OF RESEARCHING, HOUR OF LABOR, AND A TONE OF MONEY, THE ISSUE STILL EXIST AND I AM AT BUT A LOSE. DURING RESEARCH I FOND THIS ISSUE TO BE A VERY COMMON ONE WIT...

Mileage: 3,700

ON 06/24/2014 AT 16,948 MILES WHILE ACCELERATING FROM A RED LIGHT STOP ON MY 2010 FLHTCU, I GOT TO 30 MPH AND THE THROTTLE CUT OUT, THE CHECK ENGINE LIGHT CAME ON, AND THE ENGINE WENT INTO LIMP MODE. I LIMPED THE BIKE 4 MILES HOME AND SHUT IT DOWN. THE ENGINE LIGHT RESET ON THE SECOND RESTART AND TH...

Mileage: 16,948

ON 06/24/2014 AT 16,948 MILES WHILE ACCELERATING FROM A RED LIGHT STOP ON MY 2010 FLHTCU, I GOT TO 30 MPH AND THE THROTTLE CUT OUT, THE CHECK ENGINE LIGHT CAME ON, AND THE ENGINE WENT INTO LIMP MODE. I LIMPED THE BIKE 4 MILES HOME AND SHUT IT DOWN. THE ENGINE LIGHT RESET ON THE SECOND RESTART AND TH...

Mileage: 16,948

BIKE WENT INTO THE "LIMP-MODE" WHILE RIDING ON INTERSTATE 80 NEAR JOLIET, ILLINOIS. WHEN IN THE "LIMP-MODE" THE ENGINE CONTINUES TO RUN BUT THERE IS NO THROTTLE RESPONSE WHICH IS EXTREMELY DANGEROUS, ESPECIALLY IF THERE IS NO SHOULDER TO PULL OFF ONTO. THIS HAS HAPPENED AT LEAST 20 TIMES IN THE PAS...

Mileage: 18,500

BIKE WENT INTO THE "LIMP-MODE" WHILE RIDING ON INTERSTATE 80 NEAR JOLIET, ILLINOIS. WHEN IN THE "LIMP-MODE" THE ENGINE CONTINUES TO RUN BUT THERE IS NO THROTTLE RESPONSE WHICH IS EXTREMELY DANGEROUS, ESPECIALLY IF THERE IS NO SHOULDER TO PULL OFF ONTO. THIS HAS HAPPENED AT LEAST 20 TIMES IN THE PAS...

Mileage: 18,500

I WAS ON A 4 LANE HIGHWAY IN THE PASSING LANE TRAVELING AT 55MPH WHEN I LOST MY THROTTLE RESPONSE AND THE BIKE WENT TO AN IDLE MODE. I ALMOST WAS HIT WHILE COASTING OFF OF THE HIGHWAY. THIS BIKE ALSO WENT TO THE IDLE MODE AFTER STARTING IT ONE TIME LAST YEAR AND I HAD TO RESTART IT 3 TIMES TO GET IT...

Mileage: 30,000

I WAS ON A 4 LANE HIGHWAY IN THE PASSING LANE TRAVELING AT 55MPH WHEN I LOST MY THROTTLE RESPONSE AND THE BIKE WENT TO AN IDLE MODE. I ALMOST WAS HIT WHILE COASTING OFF OF THE HIGHWAY. THIS BIKE ALSO WENT TO THE IDLE MODE AFTER STARTING IT ONE TIME LAST YEAR AND I HAD TO RESTART IT 3 TIMES TO GET IT...

Mileage: 30,000

I WAS ON A 4 LANE HIGHWAY IN THE PASSING LANE TRAVELING AT 55MPH WHEN I LOST MY THROTTLE RESPONSE AND THE BIKE WENT TO AN IDLE MODE. I ALMOST WAS HIT WHILE COASTING OFF OF THE HIGHWAY. THIS BIKE ALSO WENT TO THE IDLE MODE AFTER STARTING IT ONE TIME LAST YEAR AND I HAD TO RESTART IT 3 TIMES TO GET IT...

Mileage: 30,000

TL * THE CONTACT OWNS A 2010 HARLEY DAVIDSON FLHTCU MOTORCYCLE. WHILE DRIVING APPROXIMATELY 65 MPH ON A MAJOR HIGHWAY, THE VEHICLE AUTOMATICALLY DECELERATED TO 15 MPH AND STALLED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MI...

Mileage: 23,400

AS PER SERVICE BULLETIN ; TT418-A ,ELECTRICAL CONNECTOR CORROSION AND FRETTING CAUSING THE ENGINE TO SHUT DOWN DUE TO VIBRATION . THIS SITUATION IS HAZARDOUS AS THE BIKE CAN FAIL IN HEAVY TRAFFIC AND INTERSECTIONS . HARLEY DAVIDSON IS AWARE OF THIS SITUATION SENSE 2008 . AS TO DATE THERE...

Mileage: 23,000

AS PER SERVICE BULLETIN ; TT418-A ,ELECTRICAL CONNECTOR CORROSION AND FRETTING CAUSING THE ENGINE TO SHUT DOWN DUE TO VIBRATION . THIS SITUATION IS HAZARDOUS AS THE BIKE CAN FAIL IN HEAVY TRAFFIC AND INTERSECTIONS . HARLEY DAVIDSON IS AWARE OF THIS SITUATION SENSE 2008 . AS TO DATE THERE...

Mileage: 23,000

AS PER SERVICE BULLETIN ; TT418-A ,ELECTRICAL CONNECTOR CORROSION AND FRETTING CAUSING THE ENGINE TO SHUT DOWN DUE TO VIBRATION . THIS SITUATION IS HAZARDOUS AS THE BIKE CAN FAIL IN HEAVY TRAFFIC AND INTERSECTIONS . HARLEY DAVIDSON IS AWARE OF THIS SITUATION SENSE 2008 . AS TO DATE THERE...

Mileage: 23,000

RIDING IN NEBRASKA ON I-80 WESTBOUND, VEHICLE WENT INTO AN ALMOST UNCORRECTABLE FRONT WHEEL WOBBLE, AFTER GAINING CONTROL OF THE MOTORCYCLE I WAS ABLE TO GET ONTO ROAD SHOULDER AND FOUND THE RIGHT FRONT WHEEL BEARING HAD "DISINTEGRATED", NO BALL BEARINGS WERE VISIBLE AND THE SEAL WAS MISSING. THIS ...

Mileage: 15,000

RIDING IN NEBRASKA ON I-80 WESTBOUND, VEHICLE WENT INTO AN ALMOST UNCORRECTABLE FRONT WHEEL WOBBLE, AFTER GAINING CONTROL OF THE MOTORCYCLE I WAS ABLE TO GET ONTO ROAD SHOULDER AND FOUND THE RIGHT FRONT WHEEL BEARING HAD "DISINTEGRATED", NO BALL BEARINGS WERE VISIBLE AND THE SEAL WAS MISSING. THIS ...

Mileage: 15,000

AS I PROCEEDED TO LEAVE ,STARTED MOTORCYCLE.ENGAGE CLUTCH TO SHIFT. TURN THE THROTTLE TO MOVE...NO RESPONSE.HARLEY DAVIDSON THROTTLE BY WIRE..DIDN'T RESPOND..DID RESEARCH ON COMPUTER FOUND THAT MANY INCIDENT'S WHERE IT WOULD COMPLETELY SHUT DOWN ON FREEWAY SPEEDS. THERE IS NO RECALL TO FIX THE PROBL...

Mileage: 16,000

WHILE RIDING I BEGAN TO FEEL A VIBRATION IN THE HANDLEBARS I HADN'T FELT BEFORE TODAY. IT DIDN'T SEEM TO AFFECT ANYTHING ELSE. AFTER PARKING THE BIKE AND CONDUCTING A VISUAL INSPECTION I FOUND A SEAL ON THE LEFT FRONT WHEEL BEARING HAD SEPARATED EXPOSING THE BALL BEARINGS. IT APPEARED TO HAVE LOST 1...

Mileage: 17,000

ABS BRAKE SYSTEM MALFUNCTION, WILL NOT ACTIVATE. *TR

Mileage: 8,805

THE FRONT WHEEL BEARINGS FAILED @ 23K MILES. HD'S MAINTENANCE SCHEDUULE DOES NOT LIST BEARINGS UNTIL 40K MILES. A HD MECHANIC TOLD ME THAT THE NEW SEALED BEARINGS HAVE BEEN ARRIVING WITH VERY LITTLE GREASE. HE RECOMMENDED GENTLY PRYING THE SEAL OFF, ADDING GREASE, RE-SEATING THE SEAL, THEN INSTAL...

Mileage: 23,000

RIDING ALONG AT 60 MPH WHEN THE BIKE WENT INTO "LIMP MODE". I IMMEDIATELY LOST ALL THROTTLE RESPONSE AND MY SPEED INSTANTLY DROPPED TO 10 MPH. ONCE THE BIKE GOES INTO THIS "LIMP MODE", THE SPEED IS AUTOMATICALLY LIMITED TO 10 MPH. THE ENGINE LIGHT CAME ON AND I HAD TO RIDE AT 10 MPH DOWN A BUSY S...

Mileage: 17,900

RIDING ALONG AT 60 MPH WHEN THE BIKE WENT INTO "LIMP MODE". I IMMEDIATELY LOST ALL THROTTLE RESPONSE AND MY SPEED INSTANTLY DROPPED TO 10 MPH. ONCE THE BIKE GOES INTO THIS "LIMP MODE", THE SPEED IS AUTOMATICALLY LIMITED TO 10 MPH. THE ENGINE LIGHT CAME ON AND I HAD TO RIDE AT 10 MPH DOWN A BUSY S...

Mileage: 17,900

COMPENSATOR FAILURE. THE COMPENSATOR ON MY H-D HAS DEVELOPED A BANGING NOISE ON STARTUP AND CONTINUES TO MAKE NOISE UP TO THE 3500 RPM RANGE. HARLEY DAVIDSON IN MIAMI, FLORIDA SERVICED MY MOTORCYCLE AND FOUND THE MOUNTING BOLT TO BE LOOSE. AFTER SERVICE THE COMPENSATOR THE NOISE RECURRED AFTER 100 M...

Mileage: 2,500

THE COMPENSATOR ON MY BIKE IS NOT ENGINE FOR THIS LARGE OF MOTOR. MY COMPENSATOR HAS LOOSENED AND IS A EXTREME SAFETY HAZARD FOR THE DRIVE AND PASSENGER IF THE MOTORCYCLE IS IN MOTION AND THE BOLT FALLS OUT OR THE INADEQUATE COMPENSATOR FALLS APART WHILE DRIVING. MY MOTORCYCLE WAS TAKEN IN BECAUSE O...

Mileage: 4,580

WITH ONLY 1800 MILES ON A 2010 HARLEY DAVIDSON FLHTCU BOUGHT NEW EXCESSIVELY LOUD CLANKING WAS PRESENT AT 2000-2500 RPM. THE PRIMARY CASE NEEDED TO BE REMOVED AND THE COMPENSATOR SHOWED SIGNS OF WEAR ALREADY AND IT WAS FOUND THAT THE MAIN COMPENSATOR BOLT WAS LOOSE. IT WAS RE-TORQUED TO SPEC AND T...

Mileage: 1,800

2010 HARLEY DAVIDSON ULTRA CLASSIC REAR BRAKE QUIT WORKING. REAR BRAKE HAD COMPLETE PEDAL PRESSURE BUT WOULD NOT STOP THE MOTORCYCLE. APPLYING PRESSURE WHILE RIDING WOULD EVENTUALLY CAUSE REAR BRAKE TO START WORKING AS NORMAL. FOUND PUDDLE OF OIL ON GARAGE FLOOR AND UPON INSPECTION FOUND THAT THE...

Mileage: 7,000

TL* THE CONTACT OWNS A 2010 HARLEY DAVIDSON FLHTCU MOTORCYCLE. THE CONTACT EXPERIENCED ISSUES WITH THE STEERING WHEEL TIGHTENING WHILE DRIVING 25 MPH. THE CONTACT TOOK THE VEHICLE INTO A DEALER FOR SERVICE. THE FAILURE WAS DIAGNOSED AS A FRONT WHEEL BARRING FAILURE. THE VEHICLE WAS NOT REPAIRED. T...

Mileage: 13,000

2010 (AND EARLIER) HARLEY-DAVIDSON TOURING MODELS HAVE A PROBLEM WITH THE TRANSMISSION COMPENSATOR THAT IF NOT ADDRESSED, COULD CAUSE AN ACCIDENT WITH INJURY OR DEATH. THE COMPENSATOR BOLT COMES LOOSE IN THE TRANSMISSION HOUSING AND CAUSES SIGNIFICANT INTERNAL DAMAGE WITH COULD CAUSE THE MOTORCYCLE...

Mileage: 5,565

THE 6TH GEAR INDICATOR GOES OUT ON MY 2010 HARLEY FLHTCU AT DIFFERENT TIMES AND FOR NO APPARENT REASON. THIS IS DANGEROUS BECAUSE IF YOU HAVE THE CRUISE CONTROL ENGAGED IT GOES OFF AND WILL NOT WORK UNTIL YOU TURN THE BIKE ON AND OFF AGAIN. *TR

Mileage: 6,525

THE 6TH GEAR INDICATOR GOES OUT ON MY 2010 HARLEY FLHTCU AT DIFFERENT TIMES AND FOR NO APPARENT REASON. THIS IS DANGEROUS BECAUSE IF YOU HAVE THE CRUISE CONTROL ENGAGED IT GOES OFF AND WILL NOT WORK UNTIL YOU TURN THE BIKE ON AND OFF AGAIN. *TR

Mileage: 6,525