2006 HARLEY-DAVIDSON FLHTCUI Problems & Recalls

2006 HARLEY DAVIDSON. CONSUMER WRITES IN REGARDS TO INCORRECT MILEAGE ON MOTORCYCLE. *LD *TR

MY 2006 HARLEY DAVIDSON ULTRA CLASSIC FRONT BRAKE LINE FAILED. THE MOTORCYCLE HAS 8,2XX MILES. I SQUEEZED THE FRONT BRAKE LEVER AS I WAS STARTING THE BIKE AND FELT THE LEVER FULLY DEPRESS. I SAW BRAKE FLUID SQUIRT ON THE BIKE AND ONTO MY LEG. MY MECHANIC SAYS HE HAS HEARD OF THIS PROBLEM FROM OT...

Mileage: 8,257

FAILURE HAS NOT OCCURED ON MY BIKE HOWEVER NUMEROUS REPORTS FROM OTHERS AND DEALER RECOMMENDATION TO HAVE CAM CHAIN TENSIONERS CHECKED BECAUSE AS I WAS TOLD, IT IS NOT A QUESTION OF WHETHER BUT WHEN THEY WILL FAIL. FAILURE RESULTS IN IMMEDIATE LOSS OF POWER WHICH UNDER HIGHWAY CONDITIONS, FOR EXAM...

Mileage: 42,000

2006 HARLEY DAVIDSON FLHTCUI. BROKEN UPPER FAIRING MOUNTS. FAILURE OF THESE MOUNTS (BREAKING AT ONE OR BOTH ENDS ON BOTH LEFT AND RIGHT SIDE OF INNER FAIRING) RESULTS IN CATASTROPHIC VIBRATION CAUSING LOSS OF CONTROL. I HAVE JUST EXPERIENCED THIS PERSONALLY AND I CAN ATTEST THAT HUNDREDS OF OTHERS I...

Mileage: 10,461

BRAKE LINE WAS FOUND TO BE CHAFFED FROM RUBBING ON THE CLUTCH LINE WHICH IS BUNDLE TOGETHER. THIS RESULTED IN A APPROXIMATELY 1/8" HOLE IN THE BRAKE LINE. FOUND WHEN CHANGING THE BRAKES. *TR

Mileage: 31,000

INNER CAM BEARING FAILED ON MY 2006 HARLEY DAVIDSON ULTRA CLASSIC. THE MOTOR HAD TO BE COMPLETELY REBUILT INCLUDING NEW BEARINGS, OIL PUMP, CAMSHAFTS. CAM COVER AND ALL GASKETS. *TR

Mileage: 29,000

TL*THE CONTACT OWNS A 2006 HARLEY DAVIDSON FLHTCUI. THE CONTACT STATED THAT THE LINING OF THE BRAKE PAD FELL OFF AFTER IT RUSTED. WHILE DRIVING 4 MPH, THE FRONT BRAKE LEVER EXTENDED COMPLETELY DOWN AND THE CONTACT HAD TO USE THE REAR BRAKES TO STOP. THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP A...

Mileage: 28,140

I AM WRITING ABOUT A BRAND NEW DUNLOP D402 MU85B16 SW TIRE I BOUGHT FOR MY 2006 (HARLEY DAVIDSON) FLHTCUI IN PREPARATION FOR A NEARLY 3700 MILE ROAD TRIP. THE TRIP WENT JUST FINE, FOR ABOUT THE FIRST 450 MILES. AT THAT POINT THE TIRE, WHICH HAD LESS THAN 500 MILES TOTAL USE, SELF- DESTRUCTIVE. TH...

Mileage: 8,017

I WAS PREPARING TO STOP AT A TRAFFIC LIGHT ON MY 2006 HARLEY DAVIDSON FLHTCUI WHEN MY FRONT BRAKE LEVER LOST ALL FEELING AND MOVED TO THE HANDLE BAR. FURTHER INVESTIGATION REVEALED THE BRAKE MATERIAL HAD SEPARATED FROM THE BACKING PLATE. NOW, I HAVE HAD A SECOND BRAKE PAD, ON THE REAR BRAKE DO THE S...

Mileage: 12,000

MOTOR STUMBLES, COUGHS, DIES FOR NO REASON. MOTORCYCLE DIES WHEN TURNING AND FALL OVER ON MY LEG CAUSING INJURY. HARLEY DAVIDSON DEALER SAYS CANT FIND PROBLEM. *NM

Mileage: 35

THE CONSUMER LOST CONTROL OF HIS 2006 HARLEY DAVIDSON ULTRA CLASSIC WHEN THE REAR TIRE WENT FLAT. THE VEHICLE BEGAN TO FISHTAIL AND CRASHED INTO A CONCRETE WALL. *TS THE VEHICLE'S LEFT HEADLIGHT, LEFT FRONT PEGS, SEAT, LEFT DRY BOX, LEFT SIDE AND HANDLE BAR WERE DAMAGED. *NM

REAR BRAKE FAILURE AT APPROXIMATELY 14, 630 MILES, DUE TO CORROSION OF BRAKE SHAFT PIVOT ARM. UNIT NO LONGER HAS GREASE FITTING. I CAN FIND NO SERVICE INTERVAL SPECIFICATION FOR THIS PART. REPAIRED UNDER WARRANTY BY HARLEY-DAVIDSON TECHNICIAN IN BLUE SPRINGS, MO. *JB

Mileage: 14,630

MOTORCYCLE ELECTRONIC SPEEDOMETER AND TACHOMETER LOST POWER (NEEDLES TO ZERO). FOUND THAT BRAKE LIGHTS, TURN SIGNALS, AND EMERGENCY FLASHER LIGHTS WERE ALSO A NONFUNCTIONAL, LEAVING ME UNABLE TO RENDER ANY OF THE STANDARD WARNINGS OF STOPS, TURNS OR TROUBLE.*AK HD MECHANICS BELIEVE THAT THE FAIL...

Mileage: 1,200

MOTORCYCLE ELECTRONIC SPEEDOMETER AND TACHOMETER LOST POWER (NEEDLES TO ZERO). FOUND THAT BRAKE LIGHTS, TURN SIGNALS, AND EMERGENCY FLASHER LIGHTS WERE ALSO A NONFUNCTIONAL, LEAVING ME UNABLE TO RENDER ANY OF THE STANDARD WARNINGS OF STOPS, TURNS OR TROUBLE.*AK HD MECHANICS BELIEVE THAT THE FAIL...

Mileage: 1,200

MOTORCYCLE ELECTRONIC SPEEDOMETER AND TACHOMETER LOST POWER (NEEDLES TO ZERO). FOUND THAT BRAKE LIGHTS, TURN SIGNALS, AND EMERGENCY FLASHER LIGHTS WERE ALSO A NONFUNCTIONAL, LEAVING ME UNABLE TO RENDER ANY OF THE STANDARD WARNINGS OF STOPS, TURNS OR TROUBLE.*AK HD MECHANICS BELIEVE THAT THE FAIL...

Mileage: 1,200

MOTORCYCLE ELECTRONIC SPEEDOMETER AND TACHOMETER LOST POWER (NEEDLES TO ZERO). FOUND THAT BRAKE LIGHTS, TURN SIGNALS, AND EMERGENCY FLASHER LIGHTS WERE ALSO A NONFUNCTIONAL, LEAVING ME UNABLE TO RENDER ANY OF THE STANDARD WARNINGS OF STOPS, TURNS OR TROUBLE.*AK HD MECHANICS BELIEVE THAT THE FAIL...

Mileage: 1,200

2006 ULTRA CLASSIC HAS SMOKED SINCE DAY I BOUGHT IT! HAD ONLY 2 MILES ON IT WHEN I WAS GIVEN THE PDI BY SALESMAN. BIKE IS STILL SMOKING ON STARTUP WHEN COLD. SO FAR HARLEY'S ONLY ANSWER IS TO WRENCH MY ENGINE, WHICH IN ESSENCE MEANS I HAVE PURCHASED A USED BIKE FOR A NEW PRICE! *JB