2009 HEARTLAND CYCLONE Problems & Recalls

Upon removing the most rear tire on the driver side of my RV fifth wheel trailer, I discovered the 12-inch I-beam was cracked near the hanger bracket. The crack is 5.5 inches long. If the crack continues to lengthen without repair, there is the potential for catastrophic I-beam failure on the highwa...

THE ALUMINUM WHEEL HAS A 1' CRACK IN IT AND KEEPS LOOSING AIR

TL* THE CONTACT OWNS A 2009 HEARTLAND CYCLONE 3950 EQUIPPED WITH 16X6 SANHUA TTW INC RIMS, MODEL NUMBERS: 66084-6H AND 66082-8H (NA). THE CONTACT STATED THAT THE DRIVER'S SIDE MIDDLE RIM AND REAR PASSENGER SIDE RIM WERE BOTH CRACKED AND CAUSED THE TIRES TO DEFLATE. THE CONTACT STATED THAT THE RIMS W...

TL* THE CONTACT OWNS A 2009 HEARTLAND CYCLONE 3950 RV. THE CONTACT STATED THAT THE TWO REAR ALUMINUM WHEELS CRACKED CAUSING THE TIRE PRESSURE TO DECREASE AND AS A RESULT, THE TIRES BLEW OUT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FA...

Mileage: 12,000

THIS IS THE THIRD FAILURE OF THE SAME MODEL RV TRAILER WHEEL IN 30 MONTHS. TWO FAILED IN THE LAST FIVE MONTHS. ALL THE WHEELS HAVE CRACKED IN THE SAME AREA OF THE WHEELS. THE WHEELS HAVE BEEN UNDER NORMAL USE FOR THE PAST 52 MONTHS DURING MORE THAN 20,000 MILES OF TRAVEL. THESE WHEELS WERE SOLD WITH...

Mileage: 15,000

TL* THE CONTACT OWNS A 2009 HEARTLAND CYCLONE TRAILER. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE VEHICLE SWAYED ABNORMALLY AND DROPPED. UPON FURTHER INVESTIGATION, HE FOUND THAT THE FRONT PASSENGER'S SIDE LEAF SPRING WAS FRACTURED. THE CONTACT REPAIRED THE VEHICLE AND LATER RECEIVED NOTIFICA...

Mileage: 23,000

DURING A ROUTINE STOP AT A TRUCK STOP, THE ONSITE COMPLEMENTARY TIRE INSPECTOR BROUGHT TO MY ATTENTION A TIRE THAT WAS BALLOONED LIKE A DOUGHNUT. THIS IS FAILURE 1 OF 2. THIS WHEEL AND TIRE WAS REMOVED AND REPLACED WITH THE VEHICLE'S SPARE. PICTURES OF THE FAILED TIRE ARE AVAILABLE. *TR

Mileage: 20,817

DURING TIRE REPLACEMENT MAINTENANCE OF A (REPORTED) TIRE FAILURE THE SAME DAY (ODI 10465213), I REQUESTED THE TIRE MECHANIC TO REMOVE AND INSPECT THE OTHER MISSION BRAND TIRES. UPON REMOVAL, THIS TIRE HAD SIGNIFICANT BUBBLING INSIDE. THIS IS FAILURE 2 OF 2. THIS TIRE WAS REMOVED AND REPLACED WITH A ...

Mileage: 20,817

I HAVE A YEAR AND A HALF OLD 5TH WHEEL WITH MISSION ST235/80R16 TIRES THAT HAS SIX TIRES ON IT. I HAD TWO SEPARATE BLOWOUTS IN ONE TRIP YESTERDAY. *TR

Mileage: 2,500