1994 HOLIDAY RAMBLER ALUMA LITE Problems & Recalls

TL* - THE CONTACT RECEIVED NHTSA RECALL # 06E076000 CONCERNING RV, DOMETIC. NDR1062 DOMETIC REFRIGERATOR. THE CONTACT HAS NOT HAD ANY PROBLEMS WITH HOLIDAY RAMBLER TO DATE AND UNDERSTOOD THE SAFETY RISK INVOLVED. THE PRODUCTION NUMBER WAS921 14 60 83, AND THE MANUFACTURING DATE WAS 03 /31...

REAR OF TRAILER WANDERING ON RETURN TRIP FROM FL. REAR STORAGE COMPARTMENT DROPPING FROM BODY FLOOR. UNDERBODY BELLY PAN WRINKLED AND DISTORTED. RETURNED TO RHONE'S 6/94. NO COMMENT ON SWAY. COMPARTMENT DROP & UNDERBELLY WRINKLE "POOR WORKMANSHIP AT FACTORY". NO CORRECTIONS.

TIRE FAILURE: DURING TIRE ROTATION, WE FOUND A DEEP GOUGE ON THE INSIDE TIRE WALL, CURBSIDE REAR. GOUGING WAS CAUSED BY THE SHOCK BOLT HAVING NOT BEEN REMOVED AFTER INSTALLATION. CUT OFF ALL SHOCK BOLTS, MOUNTED SPARE TIRE AND RETURNED GOUGED TIRE TO RHONE'S FOR REPLACEMENT UNDER WARRANTY.( DOT NUMB...

RIGHT CURBSIDE WHEEL BEARING GREASE SEAL OUT OF HUB ALLOWING GEASE LEAKAGE INTO BRAKES. REPLACE ALL BRAKE PARTS AND BEARING SEALS. NO WARRNTY COVERAGE.

THE BATTERY KILL SWITCH, LOCATED ON THE TOP OFTHE BATTERY BOX, FRONT CURB SIDE UNDER BODY FLOOR, WOULD NOT STAY WOOD SCREWED IN PLACE. RHONE'S RELOCATED TO THE BACK SHEETMETAL WALL OF THE BATTERY BOX. NO WARRANTY COVERAGE.

REAR CURB SIDE TIRE BLOW-OUT ON US RT15, WILLIAMSPORT, PA DAMAGING FENDER. CALLED RHONE'S FOR ROAD SEVICE. THEY CHANGED TIRE AND WE RETURNED TO THEIR SHOP WHERE WE PURCHASED A NEW SPARE TIRE.( DOT NUMBER: TIRE SIZE: 15 )

UPON ARRIVING IN SAN ANTONIO, TX FROM MD, WE HAD A 3" GAP BETWEEN THE TRAILER BODY AND FLOOR. WE CONTACTED HRC. THEY REFERED US TO HOLIDAY WORLD IN HOUSTON, TX FOR INVESTIGATION AND REPAIRS AS MAY NEEDED. AT THAT TIME THE CAUSE WAS NOT KNOWN SO ANY WARRATY COVERAGE WAS IN GUESTION. AFTER OUR 10 ...

BEFORE LEAVING SAN ANTONIO, TX FOR OUR APPOINTMENT WITH HOLIDAY WORLD OF HOUSTON, WE DISCOVERED A BULDGE IN THE CURB SIDE REAR TIRE. WE MOUNTED THE NEW SPARE (PURCHASED FROM RHONE'S IN SEPT.). AFTER ARRINING AT HOLIDAY WORLD IN HOUSTON, WE PURCHASED AND MOUNTED 3 NEW GOODYEAR MARATHON 15" LOAD RANG...

PREPAIRING TO TRAVEL NORTH AFTER OUR WINTER STAY IN SOUTH FL, WE DISCOVERED THAT THE BODY WAS SEPERATING FROM THE FRAME AGAIN. WE COULD LOOK INTO THE GAP AND SEE THAT THE ELEVATOR BOLT HEADS THAT WERE TO HOLD THE UNIT TOGTHER HAD PULLED THROUGH THE BASE CHANNEL OF THE BODY FRAME STRUCTURE. HRC AGA...

DOORS FAIL TO FUNCTION PROPERLY, DUE TO MISALIGNMENT.

RIGHT REAR HUB FROZE.

FISH TAILED VERY BADLY ALMOST LOSING CONTROL. MAIN FRAME OF TRAILER BROKE CAUSING REAR TO DROP. PLEASE DESCRIBE. TT

FISH TAILED VERY BADLY ALMOST LOSING CONTROL. MAIN FRAME OF TRAILER BROKE CAUSING REAR TO DROP. PLEASE DESCRIBE. TT

DUAL AXLE DESIGN CAUSES TRAILER TO SWAY BACK AND FORTH. *DSH