2001 HYUNDAI ACCENT Suspension Problems

Repair shop did not perform alignment requested on 2001 Hyundai Accent. One reason was: "Cradle is rusted through" Similar recalls exist for Hyundai Elantra (similar design) and Sonata (engine cradle) for same model year. This represents a dangerous condition. Vehicle is operated in Wisconsin, where roads are salted in winter.

MY MECHANIC TOLD ME IN APRIL 2020 MY 2001 HYUNDAI ACCENT IS NOT SAFE TO DRIVE BECAUSE THE SUB FRAME HAS DECAYED UP TO WERE IT CONNECTS TO THE BODY UNDERNEATH. *TR

Mileage: 141,351

BOTH CONTROL ARMS AND DRIVERS SIDE OF SUB FRAME COMPLETELY ROTTED OUT. THERE IS A RECALL FOR THE 2001-2003 ELANTRA AND TIBERON, YET NOT THE ACCENT? SOMEBODY ISN'T DOING THEIR JOB!! *TR

Mileage: 81,000

FRONT SUB FRAME IS SEVERELY CORRODED BETWEEN DRIVERS LOWER CONTROL ARM AND SUB FRAME MOUNT AT RADIATOR CORE SUPPORT. CORROSION HAS CREATED A HOLE ON EACH SIDE OF THE FRAME RAIL THAT WILL ALLOW FOR PASSAGE OF AN OBJECT SIMILAR IN SIZE TO A DECK OF CARDS. PASSENGER SIDE IS SIMILARLY CORRODED. FRONT SUB FRAME REPLACEMENT WILL BE NECESSARY IN ORDER MAINTAIN SAFE VEHICLE OPERATION. THE DEGREE OF FRONT SUB FRAME CORROSION IS NOT IN LINE WITH THE CONDITION OF THE BALANCE OF THE VEHICLE. BALANCE OF THE VEHICLE EXHIBITS MINIMAL CORROSION. *TR

Mileage: 114,000

TL* THE CONTACT OWNS A 2001 HYUNDAI ACCENT. THE CONTACT STATED THAT THE SUB FRAME AND CONTROL ARMS WERE COMPLETELY CORRODED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 85,000. ...UPDATED 11-12-13 *BF

Mileage: 85,000

FRONT CONTROL ARM CORRODED AND BROKE APART. UNABLE TO STEER. TOWED TO AND CONFIRMED BY MECHANIC. *TR

Mileage: 114,000

TL* THE CONTACT OWNS A 2001 HYUNDAI ACCENT. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURES MENTIONED IN NHTSA CAMPAIGN ID NUMBER: 09V125000 (SUSPENSION:FRONT:CONTROL ARM), INCLUDING A PERFORATED FRONT LOWER CONTROL ARM. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED.THE FAILURE AND CURRENT MILEAGES WERE 77,000.

Mileage: 77,000

TL* - THE CONTACT OWNS 2001 HYUNDAI ACCENT. WHILE DRIVING AT 45 MPH ON A VERY NICE DAY THE VEHICLE BEGAN DRIFTING ON THE ROAD. THE FRONT PASSENGER TIRE WENT OFF THE ROAD AND THE REAR TIRE WENT OFF THE ROAD AS WELL. THE VEHICLE SLOWED DOWN TO APPROXIMATELY 40 MPH WHEN THE DRIVER LOST COMPLETE CONTROL. HE STATED THAT ONLY THE DRIVER'S SIDE TIRE WAS STEERING CORRECTLY, THE OTHER TIRES WERE GOING SIDE TO SIDE. THE CONTACT COULD NOT CONTROL THE VEHICLE AND WAS REAR ENDED. HE SUSTAINED MINOR INJURIES. THE CONTACT HAD TAKEN SOME PICTURES, AND SAID THAT THERE WAS A BOLT THAT SHEARED OFF. THE RUBBER BUSHING WAS WIDE OPEN AND DEFORMED. THE CONTACT HAD A POLICE REPORT. THE CURRENT AND FAILURE MILEAGE WERE BOTH 100,000. *AK

Mileage: 100,000

WHEN THE BRAKES WERE APPLIED, THERE WAS A POPPING NOISE FROM UNDER FRONT END. ALSO A CREAKING NOISE WAS HEARD FROM UNDER THE RIGHT FRONT WHEN CAR WAS AT IDLE AND WHEN THE STEERING WAS TURNED BACK AND FORTH. CUSTOMER FELT NOISE WAS RELATED. DEALERSHIP COULD NOT FIND AT THE TIME. THIS HAPPENED THREE TIMES. *TT *JB

Mileage: 29,099

THERE IS A BOLT THAT HAS A 1/2" GAP ON THE DRIVER'S SIDE UNDER THE FRAME THAT WAS NOTICED WHEN REPLACING THE FRONT BRAKE PADS. THE PASSENGER SIDE SUSPENSION BOLT IS FLUSH WITH THE FRAME OF THE CAR. THIS CAN ONLY BE SEEN IF THE CAR IS ON THE GROUND. THIS IS A POTENTIAL HAZARD. WAS NOTIFIED BY THE MECHANIC THAT IS WAS A DEFECT WITH SUSPENSION AND TOLD TO GET THE CAR IN ASAP. THIS COULD POSE A SERIOUS RISK TO THE DRIVER AS WELL AS OTHERS ON THE ROAD.*AK

DEALER FIXED WHEEL BEARINGS AT NO CHARGE IN 1 DAY. DEALER REPLACING TRANSMISSION BY END OF THE WEEK - NO LOANER OR RENTAL CAR AVAILABLE; I HAVE TO RENT A CAR. SERVICE REP. COMPLAINED ABOUT CAR BEING OUR OF WARRANTY; I REMINDED HER CAR WAS BOUGHT MAY 11. DO I HAVE A LEMON? ARE MY KIDS SAFE IN IT? I'M VERY DISPLEASED WITH DEALER ABOUT THIS.*AK

CONSUMER STATES WHILE STARTING VEHICLE UP USING THE AIR CONDITIONER OR HEATER THERE IS A POWDER SMELL THAT COMES OUT OF THE VENTS CONSUMER STATES HAVING TO NOTIFY DEALERSHIP MECHANIC STATES ITS JUST FUEL THAT NEEDS TO BURN OFF.

THE CAR WAS TRAVELING BELOW THE SPEED LIMIT AND THE DRIVER BEGAN TO NOTICE AN UNCONTROLLABLE SHAKE WITH THE STEERING WHEEL AND THE FRONT OF THE CAR THIS IS WHAT CAUSED THE ACCIDENT.*AK

FRONT END SUSPENSION CONNECTORS HAVE FALLEN OFF OF VEHICLE FOR SECOND TIME, RESULTING IN LOSS OF A TIRE. DEALER HAS BEEN CONTACTED. PLEASE PROVIDE FURTHER DETAILS.*AK

WHEN GOING UP OR DOWN A HILL THE FRONT END OF THE CAR SHAKES. *AK

IGNITION COIL WENT OUT 3 DAYS AFTER VEHICLE PURCHASED. SINCE THEN IT HAS BEEN REPLACED 2 MORE TIMES.ALSO, FRONT END WILL SHAKE, AND ENGINE CHECK LIGHT COMES ON. *AK