2023 HYUNDAI ELANTRA HYBRID Electrical System Problems

The horn has failed four times on my vehicle, and I have owned and maintained it since November 2022. While Hyundai has replaced it under warranty at no charge, I foresee this being a continuing issue.

This vehicle I am driving has going on 24,000 miles only and over the course of the 23,000 miles it started making me do a 12V reset which very scary when you in traffic, have to pull to the side of the road, the car blinks "Check Hybrid System" with the little what looks like a tire pressure monitor system but it is a exclamation point and says "HEV" inside. My vehicle will die while pulling off to the side of the road, I have to park it, and 12V reset it, and start the car up again, in order to get to where I was going. I can not sit in one place. In fact this battery reset happened two times last night on June 18th at a drive thru while waiting for dinner and once while waiting on a pharmacy drive thru line about two weeks ago. All this is idling. I never had a lockout issue with my car where I had to get in with my key and 12V reset it. It's only when the car is on and idling. I'm well aware of Hyundai hybrids having 2 batteries, so it is definitely not the battery controlling my acc, it's controlling my main controls. I have done so much research on my vehicle and just know this will be such a hassle to get replaced although I paid very good money for my vehicle, and the batteries are under warranty. I will have to roll the dead battery into Hyundai's lot so they do something, but even then they think 12V resetting will be a normal thing, not when I'm travelling down the freeway during rush hour. A 12V reset should be there for utmost emergencies, not to be used on a daily basis multiple times a day. Hyundai needs to take ownership and do something about it. Is it an alternator to the battery or is it their lithium ion batteries they use, is it a wire that sucks, they need to do something and get all the hybrids fix because it's not just Elantras, many Tucsons, sonatas, etc. Have the same issue all across the years I have seen to 2020. Very faulty.

The issue involves the hybrid electric powertrain or electrical control system in my 2023 Hyundai Elantra Limited Hybrid. The vehicle has shut off multiple times while driving, with complete loss of power and propulsion. This poses a serious safety risk, as it happens without warning in the middle of the road. Restarting the car requires shifting into Park and trying multiple times to turn it off, but the vacuole turns back on the first try. I have experienced this issue several times, including twice during a 300-mile highway trip. After each shutdown, the dashboard displays multiple warning lights, including the Check Engine Light, Battery Light, Oil Pressure Light, and Hybrid System Warning (orange car icon). I took a photo immediately after the most recent failure to document these warnings. The vehicle has been inspected three times by two different Hyundai dealerships. Both confirmed the vehicle is under warranty but have not repaired or diagnosed the issue, citing that they cannot replicate it. They have driven it ~200 miles without success. However, they have not pulled ECU data or freeze-frame codes, even though warning lights were active at the time of failure. There are no symptoms or warning messages before the failure — the vehicle shuts off suddenly. The car is available for inspection, and I am in the process of opening a formal case with Hyundai. This is a significant and recurring safety hazard that must be addressed. This issue has an occurred a various speeds including during acceleration and braking. The picture attached is the dashboard after the I indent has occurred and have shifted to park after stopping to try and restart the car to get out of the middle of the road.

While driving in a parking lot. The car wouldn't accelerate. Kept pressing on the gas pedal but the car wouldn't move. After about 5 seconds the car shut down. I had to place the car on P then press the start button, pressed the brake pedal and then the start button again and the car turned back on

For the second time in two years, my horn suddenly stopped working. About 6 months after purchasing the car, the horn began to sound high pitched. Then about three weeks later the horn stopped working, requiring the replacement of the horn. A month later, the horn sounded high pitched again. Hyundai advised me the horn is a "two-horn system" in which a high pitch and low pitch horn produce the horn noise. The low pitch keeps failing. About 4 months after the horn was only sounding a high pitched sound, the horn stopped when I hit the horn to avoid an oncoming driver.

The car has been making clicking noise when braking or acceleration for about a year. I had all recalls software updated. I have brought it in multiple times. First saying a wheel bearing needed replacement, then a lose bolt. It helped for a while and then the clicking started again. Then the system failure occured recently and all the lights came on. The dealer currently cannot figure out what the issue is. The ABS light is on and the brakes don't seem to be working properly. I can't safely drive the vehicle and have no car to drive now. I have had the car a little over two years so lemon law most likely does not apply to this situation.

See attached document for complaint.

I experienced an issue where I was driving the vehicle, and then a "hybrid system fault" message appeared on the driver information display followed by the complete loss of power. This made me have to pull over to the side of the road with no ability to accelerate out of the way of traffic to come to a stop. Once I was stopped I tuned off the vehicle and tried to turn it back on, but the vehicle would not respond so I attempted pressing the 12 volt battery reset button to the left of the steering wheel to see if this would allow me to turn the vehicle on and the car came back to life with no warning lights or messages and drove normally. This happened three more times over the course of ~1.5 hrs on my way home on the highway. I understand that things happen, I just wish there was more warning before all power was cut and the vehicle went into limp mode as this left me in a dangerous situation. The vehicle has been dropped off at the dealer and is awaiting a new hybrid battery replacement under warranty.

Vehicles electronic key fobs and Bluelink become deactivated every 12 hours after vehicle is parked. Had vehicle since June 2023 and this has happened 163 times. Dealerships cannot recreate the issue and vehicle battery tests reflect no issues. To start the vehicle, car has to be manually unlocked and 12V battery reset. The vehicles security features become deactivated during the lapse in battery/electronic functions.

Auto would not go into reverse or drive gears at startup in regular parking space. Received a Bluetooth message that Drive Train would not function. Towed to dealership where problem confirmed. Electric engine ordered along with high voltage wires. Upon installation of these parts it was discovered that the Assay Harness was severely crimped during construction of vehicle at the factory and had crimped (cut) wires. Parts ordered and repaired. Hyundai refused to install new electric motor, only replaced Harness and wires. Please note this appears to be a defective auto as built at the factory.

The contact owns a 2023 Hyundai Elantra. The contact had received notification of NHTSA Campaign Number: 23V589000 (Electrical System, Vehicle Speed Control) and the recall repair was completed by a dealer. The contact stated while driving at approximately 60 MPH with the cruise control activated, she momentarily disengaged the cruise control to slow for traffic. The contact stated that when the cruise control was re-engaged, the vehicle independently accelerated to almost 100 MPH. The contact was able to slow the vehicle by tapping the brake pedal. The contact stated the failure became a recurring failure. The contact stated no warning light was illuminated. The local dealer who completed the recall repair was contacted and informed the contact that there was no available appointment until December 16, 2023, for the vehicle to be serviced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 18,000.

Mileage: 18,000

Animal chewed the wiring harness causing an airbag malfunction warning and transmission failure. My safety was put at risk because the airbag wouldn't work and the transmission failed while I was driving. The vehicle is being repaired right now with a new harness. Talking with the insurance adjuster. I was informed this was a common issue with this vehicle due to the materials the manufacturer uses. The harness is not properly designed with the proper materials for the environment it is used in.

I turned on Cruise Control at 60 mph and it immediately set itself to 20 mph, braking fast to slow down quickly. This caused the car behind me to slam on his brakes so he would not rear end me. I tried increasing cruise control speed to no avail. I had to turn it off. Once I did not have any cars behind me, I tried once again so I could take a video and of course, it worked as it should. Not five minutes later, my radio turned the volume down to zero, all by itself. 20 minutes later, when I slowed to turn into a parking lot, my car lagged and acted as if it didn't have gas enough to go up a small incline. Pressing on the gas pedal didn't do very much but I made it up the incline and was able to park. I will be calling Hyundai Dealership tomorrow where I purchased the vehicle last year. I do not have any type of pictures or recordings as it just happened and it was a pretty scary event considering I was almost rear ended.

when on a test drive before the purchase of my vehicle, I and my family smelt a burning smell in the cabin. On return from the test drive, we informed our sales person who told us this was characteristic of a hybrid vehicle, and the smell will go away. It has been almost two months and 1,400 miles; the smell is still there. I don't know how and why it comes, but it definitely is smelt from time to time. I cannot duplicate it at will. I did take it to the dealership's service department, they kept it overnight and could not find any issues. When the technician took me for a test drive, it was there when I started the vehicle, but he said he did not smell burning smell, instead he said it was leather smell. I have had several people in my vehicle smell the burning smell, the problem is I cannot duplicate it on demand.

I was rear ended and the air bags didn't deploy. The police and body shop said they should have. The car is unmodified and dealer serviced