2007 HYUNDAI ELANTRA Suspension Problems

Unknown

The contact owns a 2007 Hyundai Elantra. The contact stated while driving 15 MPH, the driver's side front control arm fractured. Additionally, the contact noticed that the undercarriage was rusted. The contact was able to pull into a parking spot. The vehicle was taken to an independent mechanic, who informed the contact that the arm to the steering wheel was rusted and had cracked. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 80,000.

Mileage: 80,000

What component or system failed or malfunctioned, and is it available for inspection upon request? Rear Upper Rearward Control Arms How was your safety or the safety of others put at risk? Part rusted out and broke causing severe vehicle control issues while driving specifically at higher speeds. Has the problem been reproduced or confirmed by a dealer or independent service center? NA Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO50

Rear subframe rotted away and not the driver rear tire is leaning and car is not drivable

The contact owns a 2007 Hyundai Elantra. The contact stated that while driving at an undisclosed speed, the wheel support fractured. The vehicle was towed to the dealer where it was diagnosed that the subframe was corroded. The dealer informed the contact that the control arms, cross members, and under-bolt assembly needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000.

Mileage: 160,000

2007 HYUNDAI ELANTRA. CONSUMER WRITES IN REGARD TO RUST ON REAR SUSPENSION. THE CONSUMER STATED THE VEHICLE HAD AN UNDER COATING SPRAY APPLIED TO THE VEHICLE DUE TO RUSTING. THE CONSUMER STATED THE SPRAY WAS NOT APPLIED PROPERLY. THE UPPER DRIVER SIDE TRAIL ARM BROKE OFF.

I felt as if I couldn’t control the car on the road, making a noise especially when hit the slightest bump. I had someone follow me to repair station to drop off the car. The mechanic said there was a lot of rust on frame crossbars, one place totally broke off. He said to check with Hyundai about the rust of the frame and not to drive the car. It is frightening to know that the frame parts rusted and broke like that. I have never had that happen to a car before. It is not safe to drive and when I called Hyundai they said there were no recalls with rust and frame breakage in my car. Other Hyundai’s were recalled for this very thing, I’m confused why mine has not been recalled for this safety issue.

I SEVICE MY 2007 HYNDAI ELANTE GLS SE LIMITED AT BILL HYNDIA WILLMINGTON MA.LAST 12 YEARS THIS YEAR THEY TOLD ME REAR END IS ROTTED OUT NOT SAFE TO DRIVE.1RST NOTICE FROM THEM .THE SERVICE MANGER SAID YOUR NOT ALONE 1000 OF THEM TRYING TO GET USED PARTS AND EVERY REAREND THEY LOOK AT THAAT WILL FIT MY CAR UP TO 2012 IS COMPLETLY ROTTED OUT THESE VECHILES ARE UN SAFE TO DRIVE THEY COVERED FRAME IN RUBBER WATER GETS BEHIND IT ROTS IT OUT.ON MY CAR SPRINGS WERE GOING THREW FRAME

Mileage: 125,000

TL* THE CONTACT OWNS A 2007 HYUNDAI ELANTRA. THE CONTACT STATED WHILE DRIVING AT A SLOW SPEED, THE REAR TRAILING ARM FRACTURED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS THEN TOWED TO GARVEY HYUNDAI PLATTSBURGH (271 TOM MILLER RD, PLATTSBURGH, NY 12901) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE CROSS MEMBER HAD ROTTED, THE REAR CARRIER AND SPRINGS WERE FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 112,000.

Mileage: 112,000

WASN'T ON A MAIN ROAD WAS COMING DOWN A DRIVEWAY AND HEARD A NOISE THOUGHT MAYBE IT WAS BUILT UP SNOW BUT THE CAR JUST FELL APART THE TRAILING ARM/ CROSS MEMBER CAME RIGHT OFF THE CAR HAD TO GET IT TOWED TO MY HOME

Mileage: 111,000

REAR PASSENGER SIDE CONTROL ARM RUSTED AND DISCONNECTED FROM THE SUPPORT WHILE DRIVING.

Mileage: 260,000

TL* THE CONTACT OWNS A 2007 HYUNDAI ELANTRA. WHILE DRIVING 40 MPH, THE REAR AXLE DETACHED FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE THE FAILURE. THE CONTACT STATED THAT THE REAR AXLE WAS ROTTED AND THERE WAS FRAME CORROSION ON THE REAR SIDE OF THE FRAME. THE CONTACT HAD THE VEHICLE TOWED TO RIVERHEAD HYUNDAI (1800 OLD COUNTRY RD, RIVERHEAD, NY 11901, (631) 369-0600) AND WAS ADVISED THAT NOTHING COULD BE DONE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 120,000.

Mileage: 120,000

WHILE DRIVING MY RIGHT FRONT AXLE COMPLETELY CAME OFF THE FRAME. AFTER TAKING IT TO A HYUNDAI MECHANIC I WAS TOLD THAT MY FRAME WAS CORRODED AND THAT CAUSED MY AXLE TO DISLOCATE. I ASKED IF THE REPAIR WAS COVERED UNDER THE TT1 CAMPAIGN AND WAS TOLD THAT IT WAS ONLY FOR PREVENTATIVE MEASURES AND DID NOT COVER REPAIRS.

Mileage: 117,000

REAR SUB FRAME ROTTED AND BROKE WHILE I WAS DRIVING. THERE IS A RECALL FOR FRONT END CORROSION. CALLED HYUNDAI AND WAS TOLD TOUGH LUCK. *TR

Mileage: 201,000

IN FEBRUARY OF 2015 MY SON WAS DRIVING MY CAR THE ELANTRA WHEN THE STEERING LOCKED UP..MY HUSBAND HAD TO RESET THE COMPUTER THEN IT WORKED OTHER THAN THE KEY SOMETIMES GETTING STUCK IN THE IGNITION WHEN YOU WHERE IN PARK AND THE CAR WAS OFF.THEN IN APRIL OF 2015 HYUNDAI SENT US A RECALL NOTICE FOR A DEFECT IN THE STEERING SO I HAD IT REPAIRED .WHEN I GOT MY CAR BACK THE STEERING DID NOT LOCK UP ANYMORE AND IT SEEMED TO STEER VERY EASY THE KEY WOULD STILL GET STUCK SOMETIMES.WELL ONJULY 27 2015 I WAS DRIVING AROUND A ROUNDABOUT IN THE INSIDE LANE WHEN I LOST CONTROL OF THE STEERING AND IT SKIDDED TO A STOP IN THE OUTSIDE LANE WHEN I GOT OUT TO LOOK AT MY TIRE I NOTICED THAT MY RACK AND PINION HAD SNAPPED CLEAN IN HALF.MY CAR HAS LESS THAN 98000 MILES ON IT AND I DID NOT HIT ANYTHING .WHEN I CAME HOME I DID SOME RESEARCH AND FOUND THAT THE 2008 ELANTRAS WERE RECALLED FOR THIS EXACT PROBLEM.UPON SPEAKING WITH HYUNDAI THEY SAID THERE IS NO CONNECTION BETWEEN THE TO BUT AN INDEPENDENT MECHANIC HAS SAID OTHERWISE.SO IF YOU COULD LOOK INTO THIS IT WOULD BE GREATLY APPRECIATED SO NO ONE GETS HURT.

Mileage: 93,000

2007 HYUNDAI ELANTRA. CONSUMER WRITES IN REGARDS TO STEERING WHEEL VIBRATION ISSUES. *SMD THE CONSUMER STATED AS HE WAS DRIVING, HE HEARD A NOISE AND THEN THE STEERING WHEEL STARTED VIBRATING. THE CONSUMER STATED HE PULLED OVER, TURNED THE VEHICLE OFF AND REMOVED THE OWNERS MANUAL FROM THE GLOVE COMPARTMENT. THE CONSUMER STATED NO WHERE IN THE OWNERS MANUAL WAS THERE A SECTION RELATING TO STRUTS, SPRINGS OR SHOCK ABSORBERS, WHICH HE THOUGHT WAS THE CAUSE OF THE VIBRATING STEERING WHEEL. *JB

THE REAR SUSPENSION CROSS MEMBER ROTTED WHERE THE CONTROL ARM ATTACHES TO IT AND BROKE FREE. THE CONTROL ARM THEN FELL DOWN AND THE ENTIRE REAR TIRE AND SUSPENSION WAS DRAGGED UNDERNEATH THE REAR END OF THE CAR. THE METAL THAT THE CONTROL ARM ATTACHES TO IS VERY THIN AND THE ONLY THING UNDER THE CAR THAT IS NOT UNDERCOATED IS THAT SUSPENSION CROSS MEMBER. IF THIS PART BROKE FREE AT 55MPH I MAY NOT HAVE SURVIVED THE CRASH. IT BROKE FREE AS I TURNED INTO MY DRIVEWAY, MORE THAN LIKELY FROM THE TWIST OF THE TURN. *TR

Mileage: 111,983

TL* THE CONTACT OWNS A 2007 HYUNDAI ELANTRA. WHILE TRAVELING 55 MPH, THE CONTACT TRAVELED OVER A SMALL ROAD BUMP AND NOTICED THAT THE REAR OF THE VEHICLE SUDDENLY LOST CONTROL CAUSING THE VEHICLE TO CRASH INTO A DITCH. NO ONE WAS INJURED DURING THE INCIDENT. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE DRIVER SIDE INNER BOLT FLANGE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 60,000.

Mileage: 60,000

TL* THE CONTACT OWNS A 2007 HYUNDAI ELANTRA. THE CONTACT STATED THAT THERE WAS AN INTERMITTENT STALLING WHEN DRIVING 10-15 MPH. THE VEHICLE WAS TAKEN TO THE DEALER AT LEAST TEN TO FIFTEEN TIMES BUT THEY WERE UNABLE TO LOCATE OR DIAGNOSE THE CAUSE OF THE FAILURE. THE SWAY BAR WAS ALSO REPLACED AT LEAST THREE TIMES DUE TO BREAKAGE IN THE FRONT OF THE VEHICLE. THE MANUFACTURER WAS CONTACTED WHO SENT A REPRESENTATIVE TO INSPECT THE FAILURE BUT THERE WERE NO FAILURES FOUND WITHIN THE VEHICLE. THEY OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 17,000 AND THE CURRENT MILEAGE WAS 59,000. KMJ

Mileage: 17,000

TL*THE CONTACT OWNS A 2007 HYUNDAI ELANTRA. WHILE STARTING THE VEHICLE THE AIR BAG LIGHT CAME ON AND STAYED ON. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE DEFECTIVE AIR BAG SENSOR. THE FIRST AIR BAG FAILURE OCCURRED IN SEPTEMBER 2008, SINCE THAT TIME THE FAILURE HAD OCCURRED THREE ADDITIONAL TIMES. THE AIR BAG SENSOR WAS REPLACED THREE TIMES AND THE LAST FAILURE THAT OCCURRED THE DEALER REPLACED THE AIR BAG CONTROL MODULE. THE FRONT TIRES WERE REPLACED FOUR TIMES DUE TO THE SUSPENSION WHICH INCLUDED A FRONT END ALIGNMENT. SHE WAS ALSO INFORMED BY THE DEALER ON NOVEMBER 19, 2010 THAT THE REAR CAMPER WAS OUT OF SPECIFICATION AND THAT THE FRONT SWAY BAR LINKS WERE REPLACED TWICE. THE VEHICLE HAD NOT BEEN REPAIRED FOR THE REAR CAMPER SPECIFICATION. THE FAILURE MILEAGE WAS 13,000 AND THE CURRENT MILEAGE WAS 68,000.

Mileage: 13,000

I HAVE A 2007 HYUNDAI ELANTRA THAT WEARS THE FRONT TIRES UNEVENLY. THE ORIGINAL TIRES HAD ABOUT 28,000 MILES ON THEM. THE TIRES LOOKED FINE ON THE OUTSIDE BUT WERE WORN DOWN TO THE STEEL BELTS ON THE INSIDE. THEY ALSO HAD A DIAGONAL WEAR WHICH MADE THE FRONT END HOP. AFTER REPLACING THE TIRES WITH SNOWS I TOOK IT TO A SERVICE AUTO CENTER FOR AN ALIGNMENT AND WAS TOLD THERE WAS NO ADJUSTMENT FOR THE TIRE WEAR. I THEN TOOK BACK TO DEALER AND WAS TOLD THE VEHICLE WAS IN SPECS BUT THEY COULD NOT CORRECT THE PROBLEM. THE SERVICE PERSON SAID I SHOULD ROTATE THE TIRES EVERY 5,000 MILES. I HAVE DONE THIS TO NO PREVAIL.THE SNOWS HAD LESS THAN 8000 MILES WHEN THE NOTICEABLE HOP RETURNED. SPRING CAME AND PUT NEW ALL SEASON TIRES ON. I JUST HOPE THE TIRES DON'T BLOW OUT WHILE DRIVING. *TR

1. WEARING TIRES, 2. NON ADJUSTABLE REAR SUSPENSION OUT OF SPEC. 3. DEALER STATES LOOSENED BOLTS AND ADJUSTED. REPLACED TIRES AT 34,200 MILES. *TR

ONE OF MY ELANTRA'S STARTED SHAKING REALLY BAD TO THE POINT THAT I COULDN'T DRIVE. I BROUGHT IT INTO THE CLOSEST SHOP. THEY TOLD ME THAT THE ALIGNMENT WAS WAY OFF SPEC. THEY ORDERED THE PROPER PARTS AND WERE ABLE TO PUT THE FRONT ALIGNMENT IN SPEC. THEN THEY TOLD ME THAT THE BAD COULD NOT BE FIXED, THEY ARE NON-ADJUSTABLE STRUTS. I THEN TOOK IT TO THE DEALER WHICH HAS NOW TOLD ME THE SAME THING. THE CAR IS 1 YEARS OLD AND CANNOT BE FIXED. I CONTACTED HYUNDAI CORPORATE AND THEY ARE SENDING A REP TO CHECK OUT THE SITUATION. UPON RESEARCHING THIS PROBLEM I FOUND THAT THERE WERE OTHER ELANTRA OWNERS OUT THERE WITH THIS SAME PROBLEM. MY MECHANIC BELIEVES THAT THIS HAS TO DO WITH THE CAR NOT BEING BUILT TO HOLD EVEN THE MAXIMUM WEIGHT CAPACITY. I AM ALSO CONCERNED BECAUSE I HAVE ANOTHER OF THE SAME CAR. *TR

Mileage: 60,000

TL*THE CONTACT OWNS A 2007 HYUNDAI ELANTRA. WHILE DRIVING 60 MPH OR GREATER, THE REAR OF THE VEHICLE SWAYED FROM LEFT TO RIGHT. THE FAILURE WAS PREVALENT WHEN THERE WAS EXTRA WEIGHT IN THE VEHICLE. THE DEALER STATED THAT THE EXTRA WEIGHT CHANGED THE REAR ALIGNMENT AND CAUSED THE VEHICLE TO SWAY. THE DEALER ATTEMPTED TO ALIGN THE REAR OF THE VEHICLE ON FOUR DIFFERENT OCCASIONS, BUT WAS UNABLE TO CORRECT THE FAILURE. THE CURRENT MILEAGE IS 8,252 AND FAILURE MILEAGE WAS 2,783. THE CONSUMER STATED THE DEFECT IS DUE TO UNEQUAL CAMBER AND TOE SETTINGS IS WHAT THE CONSUMER WAS INFORMED BY THE HYUNDAI DEALERSHIP. SPECIALTY PARTS COMPANY ENGINEERS SUGGESTED REPLACING UPPER CONTROL ARMS THAT THE DEFECT WAS DUE TO POOR SUSPENSION. THE CONSUMER PROVIDED NUMEROUS REPAIR INVOICES AND PICTURES FOR THE VEHICLE. UPDATED 08/13/07 *TR

Mileage: 2,783

REAR CAMBER GOES OUT OF FACTORY SPECIFICATION WITH LOADS 75 POUNDS AND OVER CAUSING UNSTABILITY IN THE REAR END CAUSING THE REAR OF THE CAR TO OVER REACT WHEN STEERING THE CAR.

Mileage: 7,384

REAR CAMBER GOES OUT OF FACTORY SPECIFICATION WITH LOADS 75 POUNDS AND OVER CAUSING UNSTABILITY IN THE REAR END CAUSING THE REAR OF THE CAR TO OVER REACT WHEN STEERING THE CAR.

Mileage: 7,384

ALIGNMENT ON MY VEHICLE (2007 HYUNDAI ELANTRA SE) IS NOT ADJUSTED PROPERLY, AND CANNOT BE ADJUSTED PROPERLY. VEHICLE IS UNSAFE TO DRIVE ON THE HIGHWAY. REAR END GOES SIDEWAYS BECAUSE CAMBER SETTINGS ARE CREATING OVERSTEER SITUATION.

Mileage: 7,384

ALIGNMENT ON MY VEHICLE (2007 HYUNDAI ELANTRA SE) IS NOT ADJUSTED PROPERLY, AND CANNOT BE ADJUSTED PROPERLY. VEHICLE IS UNSAFE TO DRIVE ON THE HIGHWAY. REAR END GOES SIDEWAYS BECAUSE CAMBER SETTINGS ARE CREATING OVERSTEER SITUATION.

Mileage: 7,384