2007 HYUNDAI SANTA FE Electrical System Problems

UNKNOWN Went to the grocery store and vehicle was working fine. Upon leaving the store, started the car, ESC OFF light was on and when I went to press the brake to put the vehicle in reverse, the gearshift was locked and I couldn't move the gear. Long story short, I had to get my vehicle towed to the house as the vehicle is non-drivable at this time. Kelly's Blue Book indicated there were a few Hyundai recalls related to the ESC but my make and model was not affected but clearly I believe it is based on my experience and find this very unsafe.

My vehicle had an oil leak from the front cylinder bank valve cover onto the alternator. the oil damaged the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. On 11/09/2021, the engine light came on and my car turned off. I had it towed to my mechanic and on 11/10/2021 he replaced the valve cover gaskets, alternator and belt. On 12/2023, I found out there was a manufacture recall related to the valve cover. I placed a claim in 12/2023. They have asked for several versions of documents and then stop communicating and eventually deny/close the account. I have filed approximately 4 claims and they stop communicating. The last claim was filed on 1/2/2025 and I have only received an email stating "Thank you for contacting Hyundai Motor America." I have tried to ask for an update and no response. I have called and it refers me to the recall portal. What do I have to do to get reimbursed for the towing and repair work I that I have paid for.

The E .C. M. PART# 39110-3C561 started faulting out, causing stalling abruptly while stop at an intersection an merging into traffic.This events were randomly happening causing higher risks of accidents. I took the vehicle for service an was informed that the "ECM" was causing this faults. The vehicle had the check engine light on during this time. The service shop advised me to bring the vehicle in to the Hyundai dealer, because the problem is likely to increase. The Hyundai dealer verify that the "ECM " is faulty an extremely difficult if not impossible to find. This faulting "ECM " part has literally but my vehicle totally useless.

The contact owns a 2007 Hyundai Santa Fe. The contact stated while attempting to start the vehicle, the battery exploded leaving a hole in the hood of the vehicle. No warning light illuminated. The contact referenced Hyundai Campaign Number: 976. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 47,000.

Mileage: 47,000

Brake/stop light switch located behind the brake pedal sticks causing the gear shift to not be removed from or into Park. Hyundai issued Recall #110 for this issue but the recall does not cover all versions of 2007 Santa Fe even though the issue occasionally occurs on non recalled versions.

In 2015 Hyundai issued service campaign 936 for 2007-2009 Santa Fe valve cover & alternator due to the valve cover leaking & dripping oil onto the alternator, potentially damaging the alternator resulting in the charging system becoming inoperative. My 2007 Santa Fe was repaired under this campaign. Now with less than 30K miles since the repair the same problem exists, the valve cover is leaking oil onto the alternator again. I've contacted my local Hyundai dealer but they refuse to repair the issue under the campaign a 2nd time. The issue was detected by the local dealership during a routine oil change & they advised me that the cost to replace the valve cover gasket & the alternator would be in excess of $1,000.

ENGINE LIGHT STAYS ON AND THE FUEL NEEDLE STAYS ON EMPTY AFTER THE TANK IS FULL.

Mileage: 109,000

THE VALVE COVER GASKET FAILED AFTER BEING REPLACED UNDER A PREVIOUS RECALL IN THE SAME MANNER AND OIL LEAKS DIRECTLY INTO THE ALTERNATOR CAUSING IT TO ULTIMATELY FAIL.

IT STARTED OFF AS WHAT SEEMED LIKE JUST THE BULBS BURNING OUT IN ANY WHICH LIGHT. THEN MY PASSENGER WINDOW STOPPED WORKING THEN STARTED WORKING. THE LIGHTS STILL WERE HAVING ISSUES. IT TOOK A BIT FOR ME TO REALIZE THAT THERE IS A SHORT OR SOMETHING IN THE CAR. THE LIGHTS GO OUT THEN COME BACK ON THEN SWITCH WHICH ONE IS OUT. THE WORST TIME WAS WHEN IT WENT IN FOR AN OIL CHANGE AND CAME BACK OUT WITH NO LIGHTS WORKING. I CONTACTED THE COMPANY TO MAKE SURE THERE WAS NO FOUL PLAY AND THEY CHECKED THEIR CAMERA. I'VE HAD THE LIGHTS LOOKED AT MULTIPLE TIMES BY MULTIPLE DIFFERENT COMPANIES. IT NEVER FIXES THE PROBLEM PERMANENTLY. A FEW WEEKS AGO THE BACK RIGHT PASSENGER LOCK STOPPED WORKING THEN THE NEXT WEEK THE FRONT PASSENGER WINDOW AGAIN. THEN YESTERDAY THE LOCK STARTED TO WORK AND TODAY IT DOESN'T AGAIN. AND SPEEDOMETER IS OFF. HARD TO SAY BY HOW MUCH. DEPENDS ON WHICH SPEED READER I GO BY.

POTENTIAL FIRE HAZARD AND ENGINE FAILURE. OIL LEAKING FROM TOP, ANTERIOR, PASSENGER SIDE OF ENGINE AGAIN CAUSING ELECTRICAL ISSUES AND ALTERNATOR FAILURE. MULTIPLE ELECTRICAL ISSUES, CAR NOT STARTING, CLOCK RESETTING, DRAINING OF BATTERY. SOLUTION: REPLACED VALVE COVER GASKET AT OWNERS EXPENSE FIRST TIME AT 114900 MILES, BEFORE SERVICE CAMPAIGN 936 WAS KNOWN. MULTIPLE ELECTRICAL ISSUES AGAIN, CLOCK RESETTING, CAR NOT STARTING, TRIPOMETER RESETTING. SOLUTION: DEALERSHIP REPLACED VALVE COVER GASKET SECOND TIME AT 136,434 MILES, UNDER RECALL. DEALERSHIP ALSO REPLACED FAULTY, OIL COVERED ALTERNATOR. DEALERSHIP NOTED THAT THE TIMING CHAIN COVER WAS LEAKING OIL. THE TIMING CHAIN COVER IS NOT COVERED UNDER THE SERVICE CAMPAIGN 936, BUT SHOULD BE AS THE LEAK IS THE SIMILAR ISSUE TO THE VALVE GASKET COVER. *TR

Mileage: 136,434

CAR HAS RECALL. DEALER TOLD ME TO BRING IT IN THEY WOULD FIX IT. DEALER THEN TELLS ME CORPORATE HYUNDAI WILL NOT ALLOW THEM TO DO THE WORK EVEN THOUGH DEALER HAS THE PART. AN ELECTRICAL SHORT WITHIN THE ABS MODULE MAY CAUSE AN ENGINE COMPARTMENT FIRE, EVEN WHEN THE CAR IS TURNED OFF, INCREASING THE RISK OF AN INJURY. *TR

Mileage: 79,000

MY VEHICLE STALLS AND EXPERIENCES A LOSS OF POWER AT APPROXIMATELY 20 MILES PER HOUR FREQUENTLY, WHICH SHUTS OFF THE VEHICLE IN A MIDDLE OF TRAFFIC, POSING A SAFETY RISK.THIS HAPPENS EVERYDAY AND I'M WORRIED ABOUT THE SAFETY OF MY CHILDREN

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE TURN SIGNAL INDICATORS AND THE CRUISE CONTROL FEATURE WOULD NOT OPERATE WHEN NEEDED. IN ADDITION, THE ECM WARNING INDICATOR ILLUMINATED WHEN THE FAILURES OCCURRED. ALSO, WHEN THE CONTACT REPLACED THE REAR PASSENGER SIDE TURN SIGNAL BULB, THE REAR DRIVER SIDE BULB ALSO FAILED TO OPERATE. FURTHERMORE, THE CONTACT STATED THAT BOTH BRAKE LIGHTS BEGAN TO FAIL AFTER THE BULBS WERE REPLACED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ECM FAILED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURES. THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 13V113000 (SERVICE BRAKES, HYDRAULIC, EXTERIOR LIGHTING), WHICH LISTED THE SAME FAILURES SHE WAS EXPERIENCING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 185,000.

Mileage: 185,000

ISSUE 1) FUEL SENSOR HAD TO BE REPLACED, ONE WAS DONE BY ME THE OTHER BY MECHANIC. IT STOPPED SHOWING HOW MUCH GAS I HAD IN TANK SO I HAD TO GUESS. SEEMS TO BE A KNOW. AND RECURRING ISSUE ISSUE 2) HEADLIGHTS HAVE ALL OF A SUDDEN STOPPED WORKING, THE HIGH BEAMSS WORK ISSUE 3) THE DRIVER LOCK NO LONGER WORKS BUT OTHERS DO AND THE GAS DOOR NO LONGER UNLOCKS FROM DRIVER DOOR SO I HAVE TO USE THE EMERGENCY RELEASE TO GET AT THE TANK. ISSUE 4) THE LATCH FOR THE HOOD IS STUCK OPEN, THIS HAS BEEN A KNOWN ISSUE ON ANOTHER MODEL FROM THE SAME YEAR. I CAN GET MECHANIC RECORDS FOR FUEL ISSUE, THAT WAS ABOUT 1.4 YEARS AGO. HEADLIGHTS WERE YESTERDAY AND HOOD AS OF TODAY. THE DOOR ISSUE WITHIN LAST FEW MONTHS AND GAS DOOR WITHIN 2 YEARS.

2007 SANTE FE ALTERNATOR ISSUE. POST RECALL FIX, OIL LEAK STILL HAPPENING AND THIS TIME THE ALTERNATOR ALMOST CAUGHT ON FIRE. SMOKE STARTED POURING OUT FROM UNDER THE HOOD. HAD TO PULL OVER AND POUR WATER ON THE ALTERNATOR TO KEEP IT FROM CATCHING ON FIRE. CAR BECAME DISABLED AND HAD TO BE TOWED. FAMILY WAS IN CAR WHILE THIS WAS HAPPENING.

Mileage: 120,000

FRONT CORNER OF VALVE COVER IS LEAKING OIL ONTO MY ALTERNATOR CAUSING IT TO BECOME SATURATED WITH OIL AND ELECTRICAL SHUTDOWN. THE SAME OIL IS SPREADING ALL AROUND MY DRIVE BELT FROM THE ALTERNATOR AND SATURATING ALL PULLIES AND THE ENTIRE DRIVE BELT AS WELL. I AM HAVING PROBLEMS CHARGING MY BATTERY ELECTRICAL SHUTDOWNS ON THE HIGHWAY AND WITH OTHER COMPONENTS SUCH AS STEERING, A/C AND BELT NOT WANTING TO GRIP THE PULLIES THAT IT RIDES ON. VERY DANGEROUS. NUMEROUS COMPLAINTS SIMULAR TO THE SAME EXACT ENGINE ON THE HYUNDAI CROSSOVER THAT HAS THE SAME ENGINE TYPE BUT WAS RECALLED TO FIX. WHY ARE SANTA FE OWNERS LEFT OUT OF THIS RECALL IF IT IS THE SAME EXACT ENGING AS THE CROSSOVER THAT WAS RECALLED AND FIXED.

Mileage: 187,000

HYUNDAI RECALLS SANTA FE FOR ALTERNATOR OIL LEAK.SANTA FE CROSSOVER TO FIX AN OIL LEAK, CAUSED BY A FAULTY VALVE COVER GASKET, THAT COULD AFFECT ALTERNATOR PERFORMANCE..DEALER SAID THEY WONT HONOR THE RECALL CAUSE ITS OUT OF WARRANTY.ALSO THE COIL WAS NOT REPLACED AND A RECALL WAS SENT OUT ALSO ON COIL SPRING. THE WONT HONOR THAT.

Mileage: 189,000

CHECK ENGINE LIGHT STAYS ON AFTER A PROFESSIONAL RESET BRAKES LIGHT WONT GO OFF UNLESS I UNHOOK THE BATTERY

WE HAVE A 2007 HYUNDAI SANTA FE LIMITED V6 3.3L WITH ~80K MILES THAT SUFFERED AN ALTERNATOR FAILURE WHILE DRIVING YESTERDAY 8/14: CAR LOST ALL POWER IN THE MIDDLE OF THE ROAD AND STALLED... HOPEFULLY WITHOUT MUCH TRAFFIC AROUND. WE THOUGHT IT WAS A BATTERY PROBLEM, SO WE GOT A NEW BATTERY BUT PROBLEM HAPPENED AGAIN. WE CHECKED TO SEE IF OTHERS HAD SIMILAR PROBLEMS AND FOUND THERE WAS A SANTA FE 2007'S RECALL ON A VALVE GASKET IN 2016. NOW, IT SEEMS OUR OLD HYUNDAI DEALER CHANGED IT DURING THE 60K MAINTENANCE (WE DIDN'T RECEIVE A NOTICE OR WERE TOLD ABOUT IT AT THAT TIME, ALTHOUGH TODAY WE FOUND THEY DID IT IN 2016 B/C WE WERE INFORMED ABOUT THAT IN THE DEALER THIS MORNING). IN ANY CASE, WE TOWED THE CAR TO A CLOSER HYUNDAI DEALER (CAR WOULD NOT MOVE EVEN AFTER BATTERY JUMP) AND THEY BASICALLY TOLD US THE REPLACED GASKET DIDN'T WORK AND IMPACTED THE ALTERNATOR. PROBLEM IS, THE CAR IS 11 YEARS OLD AND IS 'OUT OF WARRANTY'. THEY ARE 'CHECKING WITH CORPORATE' WHETHER THEY SHOULD CHARGE US FULL PRICE FOR THE REPAIR ($1700) EVEN IF THE PROBLEM IS -MORE THAN LIKELY- RELATED TO THAT RECALL... SO, MY QUESTION: SINCE THE PROBLEM THAT THE WORK DONE IN 2016 SHOULD FIX STILL HAPPENED, AM I STILL COVERED BY THAT RECALL? DO FREE-COST RECALLS END WITH THE WARRANTY (10-YR) FOR THE CAR? I REALLY THOUGHT RECALLS DO NOT END.THANKS IN ADVANCE. P.S. I ALSO WROTE A SIMILAR NOTE THROUGH YOUR FACEBOOK PAGE.

Mileage: 80,000

THERE WAS A RECALL ON THE VALVE COVER GASKET AS ITS POOR DESIGN CAUSED IT TO FAIL AND LEAK INTO THE ALTERNATOR CAUSING THE ALTERNATOR TO EVENTUALLY FAIL. I'VE HAD IT REPLACED TWICE AND THE THIRD GASKET HAS FAILED AND IS LEAKING INTO THE ALTERNATOR ONCE AGAIN. HYUNDAI HAS FAILED TO CREATE A PERMANENT SOLUTION TO THIS ISSUE AND SHOULD CONTINUE TO REPLACE THE GASKET AND ALTERNATOR IF NECESSARY UNTIL THEY DO.

Mileage: 165,000

VEHICLE INTERMITTENTLY DOES NOT TURN ON WITHOUGHT CYCLING OF THE SHIFTER FROM PARK TO DRIVE REPEATEDLY. I HAVE TAKEN THE CAR TO A REPUTABLE ASE CERTIFIED MECHANIC AND WAS INFORMED THAT IT WAS A BAD SHIFTER CABLE. HE ALSO STATED THIS WAS A KNOW PROBLEM WITH THIS YEAR AND MODEL VEHICLE.

Mileage: 150,000

CRANKSHAFT HARMONIC BALANCER BROKE APART WHICH CAUSED LOSS OF CONTROL: ( OF THE STEERING, BRAKES, LIGHTING, ETC. ) THE VEHICLE WAS IN MOTION AT A VERY LOW SPEED WHILE TURNING INTO A DRIVEWAY! FORTUNATELY I WAS ABLE TO IMMEDIATELY STOP AND SHUT OFF THE ENGINE WHICH PREVENTED EXCESSIVE DAMAGE FROM SHRAPNEL. IF THIS OCCURRED AT THE INTERSTATE SPEEDS, IT COULD HAVE PROVED CATASTROPHIC FOR MYSELF, PASSENGERS AND OTHER HIGHWAY TRAVELERS. MY CHECKING ONLINE DISCLOSED THERE ARE MANY OCCURRENCES OF THIS NATURE! UNFORTUNATELY I DID NOT TAKE PHOTOS.

Mileage: 111,149

BOTH FUEL GAUGE SENDING UNITS NEEDED TO BE REPLACED AT 91,000 MILES. CHECK ENGINE LIGHT AND IMPROPER/INACCURATE FUEL GAUGE READINGS PROMPTED THE REPAIR WHICH COST OVER $400 AT MY LOCAL MECHANIC. PER THE MECHANIC AND INTERNET RESEARCH, THIS ISSUE SEEMS TO BE PREVALENT WITH PRE-2010 SANTA FE MODELS AS HE RECENTLY REPLACED ANOTHER SET OF FUEL GAUGE SENDING UNITS IN A SANTA FE. CLEARLY NOT NORMAL WEAR AND TEAR.

FOR THE LAST 3-6 MONTHS MY ENGINE LIGHT AND FUEL GAUGE HAVE BEEN ACTING UP. MY ENGINE LIGHT COMES ON TO CHECK ENGINE AT SAME TIME MY FUEL AMOUNT READS EMPTY OF 1/4 TANK AMOUNT AFTER I JUST FILLED UP. I'M TOLD THAT I NEED TO REPLACE DEFECTIVE SENSORS FOR 600.00 PLUS DOLLARS AS SOON AS POSSIBLE. I DONT WANT TO RUN OUT OF FUEL BY A BAD READ OUT OR STALL IN TRAFFIC.

Mileage: 86,000

TURN SIGNAL COLUMN, TURN SIGNAL RAPID CLICKING, TURN SIGNAL DOESN'T TURN OFF, SMOKE FROM STEERING COLUMN.

WHILE DRIVING APPROXIMATELY 50 MPH ON A TWO LANE HWY MAKING MY WAY TO THE MAIN HWY THE CAR LOST ALL POWER, WAS UNABLE TO ACCELERATE. I PUT CAR IN NEUTRAL WHILE TRYING TO STEER THE CAR OFF THE ROAD. THE POWER STEERING WAS ALSO OUT, VERY HARD TO STEER. AFTER PULLING OVER I PUT THE CAR IN PARK AND TRIED STARTING THE ENGINE. IT STARTED UP, I DROVE HOME IN THE SLOW LANE SO IF IT HAPPENED AGAIN I WOULD BE CLOSE TO THE SHOULDER. THIS WAS VERY SCARY, NOW I'M AFRAID TO GO ANYWHERE. AFTER SEARCHING GOOGLE TO SEE IF I COULD FIND SOMETHING THAT MAY HAVE CAUSE THIS, I READ ABOUT A RECALL THAT MAYBE THE PROBLEM. I BELIEVE MY CAR HAS ALREADY HAD THE RECALL REPAIRED BUT FEEL IT MAYBE DEFECTIVE AGAIN.

Mileage: 80,000

THERE IS A GASKET LEAK THAT DRIPS OIL ON TO MY CAR'S ALTERNATOR, AFFECTING ITS ABILITY TO WORK. LAST YEAR, THIS PROBLEM CAUSED MY CAR NOT TO START, AND COMPLETELY DRAINED MY NEW CAR BATTERY (WHEN I THOUGHT THIS WAS SIMPLY A CAR BATTERY ISSUE). LAST YEAR, IT WOULD NOT START FOR ME AT ALL - I DISCOVERED THIS PROBLEM TOO LATE. THIS PROBLEM WITH THE GASKET LEAK IS OCCURRING AGAIN AND CAUSES MY BATTERY LIGHT TO COME ON WHILE DRIVING. WHILE I WAS ABLE TO DRIVE IT TO THE DEALERSHIP FOR EVALUATION AND REPAIR, I WAS BY HYUNDAI'S CAR DEALERSHIP TO NOT DRIVE AT NIGHT AND TO NOT DRIVE WHILE IT'S RAINING.

Mileage: 146,000

GASKET LEAKS OIL ONTO ALTERNATOR CAUSING IT TO FAIL. HYUNDAI HAS A RECALL ON THE SISTER CAR HYUNDAI VERACRUZ FOR THIS ISSUE, BUT NOT THE SANTA FE. I HAVE SPENT ALOT OF MONEY ON THIS REPAIR AND THINK THAT I HAVE THE SAME ISSUE AGAIN.

FRIDAY, AUG 12, I PARKED THE CAR AROUND 6:30 PM. AROUND 8:40 AM, SATURDAY AUG 13, NEIGHBORS RANG MY DOOR BELL AND BANGED ON THE MY DOOR. THE SANTA FE WAS ON FIRE. MY INSURANCE COMPANY FOUND NO EVIDENCE OF ARSON. THE CAR PARKED FOR AROUND 14 HOURS CAUGHT FIRE. RESEARCHING ONLINE, I FOUND NUMEROUS COMMENTS FROM OTHER HYUNDAI OWNERS WHO FACED A SIMILAR EXPERIENCE.

Mileage: 157,000

GAS GAGE GOES FROM FULL TO EMPTY IN A MATTER OF MINUTES. CAN'T TELL HOW MUCH GAS I HAVE AS TRIP TICKET FUNCTION GOES "BERSERK" AS WELL AND MAY REGISTER FOR INSTANCE 20 MILES WHEN THE ODOMETER SAYS I HAVE ONLY TRAVELLED 10 MILES.

Mileage: 64,000

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE ELECTRONIC FUNCTION PANEL ON THE DRIVER SIDE FAILED TO WORK AND ALL OF THE DOORS RANDOMLY FAILED TO LOCK ON THE INSIDE AND OUTSIDE. THE VEHICLE WAS TO BE TAKEN TO THE DEALER FOR FURTHER INSPECTION AND DIAGNOSIS. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V122000 (SERVICE BRAKES, HYDRAULIC). THE BRAKE PEDAL WAS APPLIED SEVERAL TIMES AND TRAVELED TO THE FLOORBOARD. THE CONTACT HAD TO PUMP THE BRAKE PEDAL EACH TIME THE FAILURE OCCURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

I HAVE RECENTLY EXPERIENCED A FAULTY FUEL GAUGE, THEREFORE ACTIVATING THE CHECK ENGINE LIGHT COMING ON. VEHICLE HAS 107236 MILES ON IT. I GOT ON LINE AND SOUGHT OUT POSSIBLE INFO FOR THIS PROBLEM, AND WAS MADE AWARE THAT MANY, MANY OTHER OWNERS OF THIS VEHICLE WERE HAVING THE SAME PROBLEM. SO I WENT TO THE HYUNDAI WEB SITE LOOKING TO SEE IF A RECALL HAD BEEN ISSUED. THERE WAS NONE THIS PROBLEM APPEARS TO BE ABLE TO POSSIBLY ENDANGER HUMAN LIFE, AND/OR INJURY. IT IS MINE, AND SEVERAL OTHER'S OPINION THAT A RECALL SHOULD BE ADMINISTERED BY THE NHTSA TO FORCE HYUNDAI MOTOR CORP. TO ENGAGE A RECALL FOR THIS PROBLEM, AS THIS IS BECOMING SYMPTOMATIC FROM THE FACTS THAT HAVE BEEN POSTED ON THE WEB. I, AND MANY OTHERS WOULD APPRECIATE ANY ASSISTANCE THAT YOU CAN GIVE US IN THIS MATTER, AS AFTER CHECKING INTO COST OF REPAIRS, ARE QUITE COSTLY, AND THE POSSIBILITY OF A DETRIMENTAL INJURY, AND/OR LOSS OF LIFE COULD OCCUR!! THE APPARENT CAUSE OF SAID PROBLEM, IS A FAULTY FUEL LEVEL SENSOR SENDING UNIT, AND/OR FUEL PUMP. THANK YOU, SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 107,236

I BOUGHT THIS CAR A YEAR AGO AND THEY TOLD ME EVERYTHING WAS UP TO DATE. THERE WAS A RECALL BACK IN 2008 ON THE TRAILER HITCH THAT WASN'T FIXED AND SOMETHING ABOUT THE AIR BAGS. ALSO THE DID PLAYER FOR THE TV ISN'T PLAYING ANYTHING.

THIS IS ACTUALLY MY THIRD COMPLAINT. I HAVE SPOKEN TO HYUNDAI NO ONE WILL ACKNOWLEDGE THAT THERE IS A PROBLEM. FIRST MY CHECK ENGINE LIGHT CAME ON. I WAS TOLD IT WAS A FUEL GAUGE SENSOR. I RECENTLY HAD THEM REPLACED NOW MY CAR'S CHECK ENGINE LIGHT IS FLASHING AND THE CAR HAS STALLED ON ME SEVERAL TIMES WHILE IN TRAFFIC OR ON THE INTERSTATE. HYUNDAI IS IGNORING THIS. I THINK IT'S MY FUEL/ PROPOSITION SYSTEM. I HAD A TUNE-UP THE CAR SHAKES LIKE IT'S GOING TO STALL CONSTANTLY. I CAN SMELL THE FUEL FROM INSIDE OF THE CAR. I CANNOT BELIEVE AFTER ALL THE COMPLAINTS THEY STILL SAY THAT THE CARS AFFECTED WERE EITHER ONLY 2006 MODELS OR WERE NEVER SOLD. THAT'S A LIE. THEY'VE HAD OVER FOUR HUNDRED COMPLAINTS AND THREE YEARS TO DO SOMETHING ABOUT THIS.

CHECK ENGINE LIGHT COMES ON AND OFF; GAS GAUGE CLAIMS THE TANK IS EMPTY, FULL, EMPTY, HALF TANK...ALL WITHIN MINUTES; HEADLIGHTS WON'T LIGHT BUT FOG LIGHTS AND PARKING LIGHTS CURRENTLY WORK. HAPPENS WHETHER VEHICLE IS STATIONARY OR DRIVING.

Mileage: 93,000

FUEL SENSOR/GAUGE SHOWS EMPTY AND CHECK ENGINE LIGHT STAYS ON. THIS IS INTERMITTENT SO GAUGE GOES UP AND DOWN. CAN NEVER TELL HOW MUCH FUEL IS IN TANK SO YOU WILL RUN OUT OF GAS. A LOT OF OTHERS HAVE HAD THE SAME PROBLEM WITH SAME VEHICLE AND YEAR. THIS IS A SAFETY ISSUE IF YOU RUN OUT OF GAS ON THE INTERSTATE. THANK YOU FOR ANY HELP. *TR

Mileage: 98,000

ABOUT 2 MONTHS AGO THE GAS GAUGE DROPPED TO "E" AND THE CHECK ENGINE LIGHT CAME ON. I TOOK TO AUTOZONE AND WAS TOLD IT WAS THE FUEL SENDING UNIT. WITH A COST OF $300.AT THAT TIME I DIDN'T KNOW THERE WERE 2 SENDING UNITS. WOW $600. I PUT SOME CLEANER IN THE GAS WHICH HAS HELPED A LITTLE, JUST PROLONGING GETTING IT FIXED. SOMETIMES IT WORKS SOMETIMES IT DOESN'T. I WATCHED THE RANGE IN MILES BOUNCE AROUND THE OTHER DAY WHILE DRIVING. I CAN'T PAY $600 TO REPAIR SOME THING IF IT ISN'T COMPLETELY BROKE.

Mileage: 85,000

CAR MADE RAPID CLICK FAILED TURN SIGNAL SOUND WHILE DRIVING WITHOUT SIGNAL ACTIVATED AND HAPHAZARDLY ACTIVATED LEFT SIGNAL INDEPENDENT OF DRIVER. SIDEOUND STOPPED IF SIGNAL ACTIVATED. AS APPROACHED BUSY TRAFFIC AREA (AIRPORT), STEERING COLUMN STARTED SMOKING AND BURNING SMELL FILLED PASSENGER CABIN. HYUNDAI DEALER ACKNOWLEDGED IS MANUFACTUER SWITCH DEFECT, WITHOUT SAFETY FUSE TO PREVENT FIRE ON OVERHEATING, BUT IS CHARGING $250 TO REPAIR AND KEEPING MY ONLY CAR FOR AT LEAST A WEEK WHILE ORDERING ANOTHER PART (WHICH AS IT IS THE SAME DEFECTIVE PART IS JUST AS LIKELY TO EVENTUALLY FAIL AND RISK A CAR FIRE WHILE DRIVING MY KIDS). DEALER SAYS HYUNDAI ACCEPTS NO RESPONSIBILITY FOR THE DEFECTIVE PART. A COMPLAINT 10629458 WAS FILED FOR WHAT SOUNDS LIKE THE SAME DEFECT IN A 2010 SANTA FE WITH SIMILAR ABDICATION OF RESPONSIBILITY BY HYUNDAI. THINGS THAT CAUSE CABIN FIRES SHOULD PROMP A RECALL.

Mileage: 90,300

I RECEIVED A SERVICE CAMPAIGN NOTIFICATION RE MY 2007 HYUNDAI SANTE FE AUTO TO INSPECT (& POSSIBLY REPLACE) THE ALTERNATOR & REPLACE THE FRONT VALVE COVER GASKET. I MADE AN APPOINTMENT WITH THE VAN NUYS CA SERVICE DEPARTMENT. AFTER PERSISTING TO GET AN ANSWER AS TO HOW LONG THE SERVICE WOULD TAKE, I WAS TOLD I COULD EXPECT 2 DAYS. I NEED TRANSPORTATION TO & FROM HYUNDAI. I WAS TOLD THEIR SHUTTLE WOULD ONLY TAKE ME 6 MILES. MY HOME IS 8.2 MILES AWAY. I WAS TOLD I COULD RENT A VEHICLE FOR $30+ PER DAY. IT IT APPROPRIATE THAT SUCH A NOTIFICATION SHOULD COST ME UPWARDS OF $60????? WHAT AGENCY OVERSEES AUTOMOBILE SAFETY OR TO WHOM SHOULD I COMPLAIN ABOUT THIS?

Mileage: 38,000

I PURCHASED THIS VEHICLE USED IN AUGUST OF 2015 AND WHEN I FILLED THE CAR UP I NOTICED THE FUEL GAUGE DIDN'T READ FULL. WITHIN A FEW MINUTES THE FUEL HAND DROPPED BELOW HALF FULL. I HIT THE TRIP BUTTON TO SEE WHAT THE RANGE DISPLAY WAS REPORTING AND IT WAS DROPPING LIKE A ROCK (STARTED AT 200+ MILES AND DROPPED DOWN TO LESS THAN 100 MILES). THEN A FEW MINUTES AFTER THAT THE EMPTY LIGHT CAME ON AND THE CHECK ENGINE LIGHT CAME ON. I TOOK IT TO AUTOZONE AND THEY DIAGNOSED IT WITH A P0460. THIS APPEARS TO BE A FREQUENT PROBLEM ON THIS MODEL CAR. I CAN'T UNDERSTAND WHY THIS IS NOT A RECALL SITUATION. IT IS POSSIBLE TO RUN OUT OF GAS WHILE MOVING (ON EXPRESSWAY) WHICH COULD CAUSE A MAJOR ACCIDENT.

Mileage: 150,000

WHILE DRIVING THE FUEL GAUGE DROPPED TO EMPTY. THEN THE CHECK ENGINE LIGHT CAME ON. I HAD TO CODE READ AT A LOCAL AUTOMOTIVE STORE. THE PRICE OF THERE PART WAS 350. I CAN ONLY IMAGINE WHAT A DEALER WILL CHARGE. HE TOLD ME IT WAS A FUEL LEVEL SENDING UNIT. AFTER RESEARCHING THIS I FOUND LOTS OF COMPLAINTS ON THIS SAME ISSUE. THIS SHOULD NOT BE FAILING THIS SOON.

Mileage: 95,423

HYUNDAI DEALER INFORMED ME THAT VALVE COVER GASKET IS LEAKING ONTO ALTERNATOR WHICH WILL CAUSE IT TO FAIL. ESTIMATED OUT OF POCKET COST TO REPAIR IS OVER $700. THIS IS THE SAME PROBLEM THAT CAUSED THE RECALL ON THE HYUNDAI VERA CRUZ. I'M AFRAID THAT THE ALTERNATOR WILL FAIL AT SPEED CAUSING LOSS OF POWER AND DIMINISH BRAKING AND STEERING CAPABILITY. *TR

Mileage: 85,000

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT, BATTERY LIGHT, ECS LIGHT, AND ABS LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND IT WAS DETERMINED THAT THE CRANK SHAFT POSITION SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 83,100.

Mileage: 83,100

THE FUEL LEVEL GAUGE CHANGES RANDOMLY. CHECK ENGINES CODES P0463, P0464, P2068 INDICATES A FUEL LEVEL SENSOR FAILURE. THIS IS ISSUE HAS OCCURRED ON OTHER CAR MANUFACTURERS POTENTIALLY USING THE SAME SENSOR SYSTEM. THERE HAVE BEEN NO RECALLS ISSUED FOR THIS PROBLEM. THE OWNER WILL NOT BE ABLE TO KNOW THE ACCURATE FUEL LEVEL OF THE VEHICLE. THIS MAY CAUSE TANK OVERFILLING AND POTENTIALLY SAFETY AND ENVIRONMENTAL ISSUES. THIS IS VERY EXPENSIVE TO REPAIR ($1000) AND IS NOT COVERED BY HYUNDAI AFTER THE 5 YEAR WARRANTY. *TR

Mileage: 82,000

GAS GAUGE READS EMPTY TO 1/4 FULL AFTER FILLING. DRIVING HOME FROM WORK, LOST ALL POWER TO VEHICLE AND ALL THE WARNING LIGHTS ON THE INSTRUMENT PANEL WENT ON. HAD VEHICLE TOWED THEN READ OTHER COMPLAINTS.WHEN I RESTARTED VEHICLE NEXT DAY THE VEHICLE SEEMED TO RUN FINE.THE FUEL LIGHT AND CHECK ENGINE LIGHT ARE STILL ON BUT THAT IS A DIFFERENT ISSUE. *TR

Mileage: 110,000

HYUNDAI SANTA FE ESC LIGHT POPS ON INTERMITTENTLY AND AFTER PUSHING THE ON/OFF SWITCH DOES NOT PUT IT OUT. THE CHECK ENGINE LIGHT ALSO POPS ON ALONG WITH THE ESC LIGHT. RESEARCH SHOWS THIS IS A COMMON PROBLEM IN MANY HYUNDAI MODELS AND RECALLS HAVE BEEN ISSUED. I AM THE ORIGINAL OWNER OF THE VEHICLE. *TR

Mileage: 98,500

FUEL GAUGE LEVEL ERRATIC. CHECK ENGINE CODE INDICATES FUEL LEVEL SENSORS. NO RECALLS HAVE BEEN ISSUED FOR THIS PROBLEM. *TR

Mileage: 112,000

WARNING LIGHT CAME ON WHILE DRIVING VEHICLE INDICATING AN ELECTRICAL PROBLEM. WAS ABLE TO DRIVE HOME, BUT NEXT DAY CAR WOULD NOT START DUE TO DRAINED BATTERY. BATTERY WAS THEN RECHARGED AND CAR DRIVEN TO LOCAL FIRESTONE STORE FOR DIAGNOSIS. WAS DETERMINED THAT THE ALTERNATOR WAS NOT WORKING PROPERLY DUE TO OIL THAT HAD LEAKED FROM THE FRONT VALVE COVER GASKET. THE ALTERNATOR WAS HEAVILY CAKED WITH THIS OIL/GRIME. AFTER INSTALLING NEW VALVE COVER GASKET AND ALTERNATOR TODAY, CAR NOW RUNS FINE. THIS PROBLEM SEEMS TO ME TO BE IDENTICAL TO THAT DESCRIBED IN HYUNDAI'S RECALL NUMBER 121 WHICH COVERED CERTAIN VERACRUZ MODELS (NHTSA CAMPAIGN NUMBER 14V415000) AND THEREFORE I BELIEVE THAT THE RECALL SHOULD BE EXTENDED TO COVER AT LEAST MY CAR AND PROBABLY OTHERS. *TR

Mileage: 142,700

THE FUEL GAUGE BEGAN TO FLUCTUATE INACCURATELY, FINALLY INDICATING THE TANK IS EMPTY AND EMPTY LIGHT IN ON. THE ENGINE LIGHT CAME ON AND STAYS ON AS WELL. A COUPLE OF DIFFERENT MECHANICS ESTIMATED IT WILL COST BETWEEN $700 AND $1,100 DOLLARS TO TRACK DOWN AND REPAIR THE PROBLEM. MY INSPECTION WILL BE OUT OF DATE SOON AND HAVE NOTICED THROUGH RESEARCH THAT THERE ARE SEVERAL HUNDRED CASES AND COMPLAINTS CONCERNING THIS ISSUE WITH 2007, HYUNDAI, SANTE FE AND OTHER HYUNDAI VEHICLES. WHY IS THERE NOT A FORCED RECALL FOR THE MANUFACTURER TO REPAIR THIS DESIGN FLAW FOR THESE CARS? DOES SOMEONE HAVE TO LOSE THEIR LIFE FOR THIS ISSUE TO GET REPAIRED? *TR

Mileage: 81,000

FUEL LEVEL GAGE READOUT IS FAULTY, PROVIDING ERRONEOUS AND IRREGULARLY FLUCTUATING READINGS ON REMAINING GAS LEVELS. TOOK IT TO DENNIS HYUNDAI OF DUBLIN OH AND WAS INFORMED BY SERVICE MANAGER THAT THIS IS A REGULAR PROBLEM ON 2007 SANTA FE'S. HE SAID THE YELLOW CHECK ENGINE LIGHT THAT SPORADICALLY LIGHTS IS TRIGGERED BY FAULTY GAS LEVEL SENSOR. THE DEALER CLEARED THE TROUBLE CODE FOR ME AND SUGGESTED I NOT WASTE MY MONEY ON THE COSTLY REPAIR OF THE SENSOR AND USE MY ODOMETER TO TRACK WHEN I SHOULD FILL THE TANK. UNFORTUNATELY THE ODOMETER IS NOT DESIGNED OR INTENDED FOR THIS PURPOSE. MOST OF THE TIME THE FUEL LEVEL GAGE ON THE DASHBOARD READS COMPLETELY EMPTY SO I HAVE NO IDEA HOW MUCH FUEL REMAINS IN MY TANK. ALSO WITH THE YELLOW CHECK ENGINE CONTINUALLY LIT I'LL HAVE NO PRACTICAL WAY OF KNOWING IF SOME OTHER EMISSION CONTROL FAULT HAPPENS WITHOUT REPEATEDLY HAVING TO TAKE THE CAR TO THE DEALER TO VERIFY THE TROUBLE CODE CAUSE. GAS GAUGES SERVE A VITAL ROLE IN KEEPING THE DRIVER INFORMED OF WHEN THE TANK NEEDS MORE FUEL. WITHOUT A RELIABLE FUNCTIONING GAUGE THERE IS CONTINUAL RISK OF DEPLETING THE FUEL, RESULTING IN A STALLED ENGINE AND LOSS OF POWER BRAKES AND POWER STEERING, GREATLY INCREASING RISK OF AN ACCIDENT. IT IS EVIDENT FROM THE NUMBER OF COMPLAINTS FILED ON THIS PROBLEM THAT THERE IS A DESIGN FLAW OR DEFECT IN THE PARTS OR SYSTEM INVOLVING THIS FUEL LEVEL SENSOR AND GAUGE. ISN'T TIME HYUNDAI BE MADE RESPONSIBLE FOR PROVIDING/FUNDING A REMEDY FOR THIS DEFECT? *TR

Mileage: 68,000

I HAD A NEW BATTERY INSTALLED TWO DAYS EARLIER AND CAR WAS RUNNING FINE. DRIVING ON THE FREEWAY, MY BATTERY LIGHT CAME ON AND THE ESC AND BRAKE WARNING LIGHTS. THIS WAS ABOUT A MILE FROM MY INTENDED EXIT. AFTER THE EXIT MORE LIGHTS CAME ON AND THE ENGINE STARTED RUNNING ROUGH. IF I STEPPED ON THE BRAKE, THE TACH AND TEMPERATURE GAUGES DROPPED TO ZERO. AS I PULLED INTO MY DRIVEWAY, THE ENGINE DIED. I LOOKED TO SEE IF I HAD BROKEN A BELT BUT SAW IT WAS INTACT. I DID NOTICE THAT THE ALTERNATOR SEEMED TO BE SHINY FROM OIL. I WENT ONLINE AND SEARCHED FOR THE SYMPTOMS AND FOUND THAT THERE WAS A RECALL FOR THE VERACRUZ WITH THE VERY SAME SYMPTOMS CAUSED BY A LEAKING VALVE COVER GASKET. THE RECALL IS NHTSA CAMPAIGN 14V415000. AS OTHERS HAVE STATED, IF IT'S THE SAME ENGINE WITH THE SAME ISSUE, IT SHOULD BE COVERED BY THE RECALL AND THE REPAIRS COVERED. *TR

Mileage: 67,000

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. WHILE DRIVING 70 MPH, THE ENGINE SEIZED. THE VEHICLE WAS TOWED TO A DEALER WHO DIAGNOSED AN OIL LEAK THAT DAMAGED THE ALTERNATOR, BATTERY, AND COMPUTER CHIP. THE VEHICLE WAS REPAIRED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 78,000.

Mileage: 78,000

AIRBAG LIGHT IS ALWAYS ON, AS WELL AS MY CHECK ENGINE LIGHT. ALL DOORS DO NOT ALWAYS LOCK ON THEIR OWN, PUSHING LOCK BUTTON ON KEYCHAIN TWICE DOES NOT SOUND THE BEEP TO ENSURE DOORS LOCKED, CAR ALARM GOES OFF RANDOMLY, FUEL GAUGE DOES NOT WORK. ALL OF THESE HAVE BEEN RECALLED BY HYUNDAI BUT FOR SOME REASON, MY 2007 WITH LESS THAN 90,000 MILES IS NOT COVERED. *TR

Mileage: 80,000

MY WIFE TRIED TO PUT CAR IN REVERSE TO AVOID ACCIDENT BUT COULD NOT BECAUSE OF FAILURE OF PART STOP LAMP SWITCH. SHE COLLIDED DUE TO THIS FAILURE. HYUNDAI HAS A RECALL ON MANY VEHICLES INCLUDING THIS MODEL BUT NOT THIS MANUFACTURING DATE. THEY ARE NOT INCLUDING ALL THE VEHICLES THAT HAVE THIS DEFECTIVE PART. THIS COULD CAUSE ACCIDENTS OR DEATHS DUE TO THIS. *TR

Mileage: 91,924

EXACTLY AS PER HYUNDAI RECALL #121, THE VALVE COVER GASKET LEAKED OIL ONTO THE ALTERNATOR AND DESTROYED THE ALTERNATOR: BUT HYUNDAI DEALER IS TELLING ME MY AUTO IS NOT COVERED IN THE RECALL. THIS DOES NOT SEEM FAIR OR RIGHT TO ME. PLEASE HELP! *TR

Mileage: 65,000

2007 SANTA FE LIMITED 6 CYL 3.3L. OIL IS LEAKING FROM VALVE COVER GASKET KILLING THE ALTERNATOR AND BATTERY AND THE MOTOR. LIGHTS FLASH ON DASH SEAT BELT LIGHT, BATTERY LIGHT, ESC , TPMS. REPLACED BATTERY IN THE DARK AT FIRST. I SAW THE SAME ISSUES WITH A NEW BATTERY. THEN RESEARCHED AND SAW SIMILAR ISSUES POINTING TO VALVE COVER GASKET LEAKING OIL ONTO ALTERNATOR. I CHECKED THE VALVE COVER IN THE LIGHT AND SAW THE LEAK IMMEDIATELY AND THE ALTERNATOR COVERED IN OIL. IF THE 2007 VERA CRUZ IS GETTING A RECALL FOR THIS EXACT SAME ISSUE AS OF AUG 1ST 2014, THEN THE 2007 SANTA FE SHOULD AS WELL AS OTHER YEARS OF SANTA FE'S. DEALERSHIP WANTS $900 PLUS TAX TO FIX THIS. ALSO HAD TO REPLACE THE FUEL SENDING UNIT -THAT WAS $700 IN JAN OF 2013 AND THERE ARE TONS OF COMPLAINTS ABOUT THAT ONE TOO. I STILL SMELL GAS WHEN I FILL THE TANK FULL AND THE CHECK ENGINE LIGHT COMES ON DUE TO THIS. I CAN AND HAVE PROVEN IT USING A OBD CODE READER TO RESET THE CODE, FILL THE TANK AND BINGO CODE IS BACK LIKE THE FUEL CAP IS LOOSE BUT IT IS NOT AND THE INTERIOR SMELLS OF GASOLINE TILL THE FUEL LEVEL IS REDUCED. *TR

Mileage: 94,000

ON WEDNESDAY, JULY 30TH, 2014, I WAS DRIVING ON THE FREEWAY IN MY 2007 HYUNDAI SANTA FE WITH MY FAMILY AND CHILDREN ON BOARD AT 60 MPH WHEN ALL OF THE WARNING LIGHTS ON THE DASHBOARD FLASHED ON AT THE SAME TIME. THE VEHICLE STARTED TO SHAKE, THE ENGINE STALLED AND BOTH THE STEERING AND BRAKES SUDDENLY BECAME VERY HEAVY TO OPERATE. LUCKILY I MANAGED TO VEER OFF THE FREEWAY BEFORE IT COMPLETELY SHUT DOWN ON A LIVE HIGH SPEED LANE AND ORDERED A TOW TRUCK FROM MY AUTO CLUB. THE HYUNDAI DEALERSHIP TECHNICIAN ADVISE THAT THE CAUSE OF THIS BREAKDOWN WAS AN OIL LEAK FROM A VALVE COVER GASKET ONTO THE ALTERNATOR, CAUSING IT TO FAIL. THE BATTERY WAS ALSO AFFECTED BY CHAIN OF EVENT. THIS CASCADING CHAIN OF BREAKDOWN IS A SYSTEMIC FAILURE AND THIS DEFECT IS NOT PARTICULAR TO ONLY MY CAR BUT IS RAMPANT WITH THE HYUNDAI SANTA FE OWNERS. ANY INTERNET SEARCH WITH " SANTA FE 2007 LEAKING VALVE COVER GASKET " WILL TURN UP COUNTLESS RESULTS. IT IS ALSO THE SAME TYPE OF FAILURE THAT HAS ALREADY BEEN RECALLED FROM ANOTHER HYUNDAI SUV, THE VERACRUZ AS IT WAS BUILT ON A HYUNDAI SANTA FE PLATFORM. I WAS LUCKY THAT I DIDN'T COME TO A COMPLETE DEAD STOP WITHOUT WARNING ON A LIVE FREEWAY LANE AT A HIGH RATE OF SPEED AS THE RESULT WOULD HAVE BEEN CATASTROPHIC FOR ALL INVOLVED. LINK TO HYUNDAI VERACRUZ RECALL WITH THE SAME PROBLEM. HTTP://WWW-ODI.NHTSA.DOT.GOV/ACMS/CS/JAXRS/DOWNLOAD/DOC/UCM459247/RCDNN-14V415-5243P.PDF KIND REGARDS, *TR

Mileage: 58,075

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. WHILE DRIVING 70 MPH, THE STOP LAMP SWITCH FAILED AND CAUSED THE CRUISE CONTROL AND BRAKES TO DISENGAGE. THE BRAKE LIGHTS FAILED TO ILLUMINATE. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 09V122000 (SERVICE BRAKES, HYDRAULIC), BUT THE FAILURE RECURRED. THE DEALER STATED THAT THE STOP LAMP SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

Mileage: 80,000

THE GAS GAUGE JUMPS ALL AROUND. I CAN FILL THE TANK UP AND THEN IT WILL SAY EMPTY. DON'T EVER KNOW HOW MUCH GAS IS IN THE CAR EVER. I CALLED THE DEALER THAT I BOUGHT THE CAR AT AND THEY GAVE ME THE RUN AROUND ABOUT GETTING IT FIXED. I HAVE TO PUT GAS IN THE CAR EVERY OTHER DAY DUE TO THE GAS GAUGE NOT WORKING PROPERLY. *TR

Mileage: 78,970

WHILE TRAVELING ON EXPRESSWAY AT 65 MPH OUR 2007 SANTA FE SUDDENLY LOST ALL POWER AND WE HAD TO PULL OVER TO THE EMERGENCY LANE. A DEFECTIVE VALVE COVER GASKET LEAKED OIL ON THE ALTERNATOR CAUSING IT TO SHORT OUT AND BE DAMAGED BEYOND REPAIR. HYUNDAI HAVE A RECALL (#121) ON THE 2007-2012 VERACRUZ FOR THE EXACT SAME PROBLEM. CLEARLY THE SANTA FE NEEDS TO BE INCLUDED IN THE 121 RECALL. MY FAMILY AND I WERE PLACED IN DANGER AS WE WERE IN THE LEFT LANE ON A BUSY EXPRESSWAY AND HAD TO QUICKLY MERGE OVER TO THE EMERGENCY LANE ON THE RIGHT SIDE WHILE QUICKLY LOSING SPEED. ADDITIONALLY, THE COST OF REPAIR WAS $750 FOR THE ALTERNATOR AND GASKET COVER REPLACEMENT. *TR

Mileage: 92,263

WHILE DRIVING DOWN THE HIGHWAY, MY DRIVER'S SIDE SUN VISOR FELL FROM THE CEILING AND WAS DANGLING BY THE ELECTRICAL WIRE WHICH CONTROLS THE AUTOMATIC LIGHT WHEN THE VISOR IS OPENED. THIS NOT ONLY OBSTRUCTED MY VIEW, BUT ALSO CAUSED A KNEE-JERK REACTION TO BRAKE AS THE VISOR SWUNG TOWARD MY FACE. UPON INSPECTION, THE PLASTIC JOINT WHICH HOLDS THE VISOR IN PLACE HAD FAILED. THE VISOR HAD FALLEN DESPITE THE FACT THAT I WAS NOT ADJUSTING IT AT THE TIME, AND THERE WERE NO SIGNIFICANT BUMPS OR HAZARDS IN THE ROAD WHICH MAY HAVE JARRED IT LOOSE. *TR

Mileage: 85,000

THE AIRBAG LIGHT HAS COME ON MULTIPLE TIMES IN MY VEHICLE. THE CLOCKSPRING REPLACEMENT RECALL WAS PERFORMED ON MY VEHICLE. THE AIRBAG INDICATOR HAS CONTINUED TO COME ON INTERMITTENTLY SINCE THEN. FINALLY, ABOUT TWO MONTHS AGO, THE LIGHT CAME ON AND STAYED ON. I TOOK THE VEHICLE INTO THE HYUNDAI DEALERSHIP AND THEY STATED LOW VOLTAGE AND RESET THE LIGHT. THE LIGHT CAME BACK ON IMMEDIATELY WHEN I DROVE IT OFF THEIR LOT. I TOOK THE VEHICLE BACK IN AND THEY STATED IT WAS BECAUSE OF THE JUNCTION BOX AND THAT I NEEDED TO SPEND $895 TO REPLACE IT. I BELIEVE HYUNDAI SHOULD REPAIR THE AIRBAG ISSUE BECAUSE OF THE FAILURE OF THEIR AIRBAG SYSTEM THROUGHOUT THE ENTIRE TIME I HAVE OWNED THIS VEHICLE. I WILL NOT BUY A HYUNDAI AGAIN IF THIS IS NOT HONORED AND I HAVE PURCHASED TWO BRAND NEW VEHICLES FROM THEM. *TR

Mileage: 15,300

AIR BAG LIGHT ON DASH WOULD STAY ON,ANDWHEN LOCKING CAR WITH KEY FOB,LIGHTS WOULD FLASH WHEN PRESSING KEY FOB FIRST TIME,BUT ON SECOND PRESS HORN WOULD NOT BEEP,VEHICLE ALARM WOULD GO OFF INTERMITTENTLY REPLACED SENSOR UNDER SEAT AND IT FIXED PROBLEM FOR AWHILE.6-20-2007,SAME EXACT PROBLEM AGAIN.AFTER GOOGLING SYMPTOMS HAVE FOUND NUMEROUS COMPLAINTS OF ALMOST THE SAME PROBLEM OR SOME VARIATION THERE OF!MY QUESTION TO THE SAFETY BOARD IS,WHY HAVEN'T YOU FORCED A RECALL ON HYUNDAI ON THIS ISSUE?LIVES ARE BEING PLACED IN JEOPARDY BY YOUR INACTION.IS SOMEONE ON HYUNDAIS PAYROLL THERE ,OR WHAT?IF SO THEY SHOULD HAVE BECOME A SENATOR OR CONGRESSMAN,THATS WHERE THE BIG PAYOFFS ARE. *TR

Mileage: 41,798

WHILE DRIVING MY HYUNDAI SANTE FE 2007 I NOTICED THE CHECK ENGINE LIGHT CAME ON... I NOTICED THE MILES AT LITTLE OVER 95000 SO I THOUGHT IT JUST NEEDED SERVICE. THEN THE GAS GAUGE LIGHT CAME ON INDICATING I HAVE NO GAS AND WAS EMPTY WHICH I KNEW IS IMPOSSIBLE SINCE I HAD FILLED UP A DAY PRIOR AND HAD NOT DONE MUCH DRIVING. THE CHECK ENGINE LIGHT THEN WENT OFF ABOUT A 2-4 MILES LATER. I WENT TO THE GAS STATION AND FILLED UP AND THE LIGHT WENT AWAY... BUT WILL ALWAYS COME ON OR AFTER HALF TANK OF GAS. I TOOK THE CAR TO THE DEALER FOR SERVICE AND THEY INDICATED ITS THE FUEL SENDERS. THEY INDICATED NO WARRANTY ON MY CAR SINCE IT HAS PASSED THE 5 YEAR 60,000 MILES WARRANTY AND THE COST WOULD BE PAID BY ME TO FIX. I INQUIRED IF THIS WAS A SYSTEMATIC PROBLEM WITH THIS VEHICLE AND THE SERVICE REP INDICATED HE HAS SEEN A FEW ON THIS VEHICLE, HOWEVER NO RECALL MADE. IM COMPLAINING SINCE I HAVE VIEWED THIS TO BE AN ISSUE WITH THIS MODEL CAR ONLINE AND SHOULD BE CORRECTED BY THE COMPANY AT NO COST TO THE CONSUMER. *TR

Mileage: 95,000

AS I WAS DRIVING IS A RAIN STORM, MY BATTERY LIGHT CAME ON. I LOST MY WINDOW DEFROSTING CAPABILITY, MY LIGHTS DIMMED AND I HAD NO POWER STEERING. I AM NOT SURE WHAT ELSE WAS AFFECTED AT THIS TIME AS I WAS JUST CONCENTRATING ON GETTING HOME ALIVE. WHEN HOME, I OPENED THE ENGINE COMPARTMENT AND FOUND THAT THE CRANK SHAFT PULLEY HAD COME APART. LUCKY, IT WAS LAYING ON A SMALL LEDGE IN THE CAR. THIS COULD HAVE FALLEN OFF, DAMAGED THE ENGINE COMPARTMENT, FALLEN TO THE STREET AND BECOME A ROLLING PIECE OF METAL. IF A WOMAN HAD BEEN DRIVING(THIS IS ACTUALLY MY GIRLFRIENDS CAR), THIS WOULD HAVE BEEN A DANGEROUS SITUATION. *TR

Mileage: 92,000

WHEN LOWERING THE DRIVER SIDE SUN VISOR TO BLOCK SUNLIGHT FROM MY EYES, THE VISOR SNAPPED AT THE ARM AND FELL IN FRONT OF MY LINE OF SIGHT AS I WAS DRIVING DOWN THE HIGHWAY AT 65 MPH. I WAS FORTUNATE ENOUGH TO NOT HAVE AN ACCIDENT. MY SAFETY, ALONG WITH THE SAFETY OF OTHERS, WAS COMPROMISED WHEN THE VISOR BROKE AND BLOCKED MY VIEW. UPON SEARCHING FOR OPTIONS ON HOW TO FIX THIS PROBLEM, I CAME ACROSS NUMEROUS FORUMS AND WEBSITES STATING THAT THIS IS A VERY COMMON PROBLEM AMONG THE HYUNDAI CARS AND SUVS. *JS

Mileage: 109,516

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED HE HAD TO MAKE SEVERAL ATTEMPTS TO START THE VEHICLE BEFORE THE ENGINE WOULD OPERATE. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS CURRENTLY BEING DIAGNOSED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

I WAS DRIVING AND MY GAS GAUGE READ EMPTY, I WENT IMMEDIATELY TO A GAS STATION TO FILL IT AND IT ONLY TOOK $8.00. AFTER THAT THE GAS GAUGE WOULD FLUCTUATE FULL TO EMPTY WHENEVER IT FELT LIKE IT. THIS WAS A SERIOUS DEFECT BECAUSE IF I WOULD HAVE RUN OUT OF GAS ON A HIGHWAY GOING 55 MPH, I WOULD HAVE LOST CONTROL OF THE STEERING AND BRAKES. MY FATHER HAS THE EXACT SANTA FE AND HAS THE SAME EXACT PROBLEM; WHAT ARE THE CHANCES 2 CARS IN THE SAME FAMILY HAVING THE SAME DEFECT? HYUNDAI WOULD NOT TAKE RESPONSIBLY FOR THE DEFECT. IF MINE AND MY FATHER'S SANTA FES HAVE THIS PROBLEM, THERE HAVE GOT TO BE OTHERS ON THE ROAD WITH THIS SERIOUS DEFECT. ALSO, MY SUN VISOR HAD LITTLE TO NO WEAR AND TEAR; I PULLED IT DOWN ONE DAY AND IT LANDED IN MY LAP LEAVING THE SUN BLARING INTO MY EYES. OF ALL THE CARS I HAVE EVER OWNED, THIS HAS NEVER BEEN AN ISSUE FOR ME. *TR

Mileage: 107,500

BRAKE SWITCH MALFUNCTIONED CAUSING ESC OFF LIGHT TO ILLUMINATE, CRUISE CONTROL NOT TO ENGAGE, AND BRAKE LIGHTS TO NOT ILLUMINATE. CHECK ENGINE CODE OF P0405 BEING THROWN BY ONBOARD COMPUTER TO INDICATE FAILURE. *TR

Mileage: 89,800

SHORTLY AFTER HAVING A NEW BATTERY INSTALLED ON MY CAR BY OUR LOCAL AUTO SUPPLY STORE A FEW MONTHS AGO, I HAD TO REPLACE FIRST ONE HEADLIGHT BULB... THEN A FEW DAYS LATER, THE OTHER HEADLIGHT BULB... A COUPLE OF WEEKS LATER I NOTICED THE GAS GAUGE GOING BAD. IT WOULD WOBBLE ALL OVER THE PLACE. THEN I NOTICED THAT THE GUY WHO INSTALLED THE BATTERY DID NOT TIGHTEN DOWN THE TERMINAL. I TOOK IT BACK & HE FIXED THAT. WENT TO CHURCH ONE SUNDAY MORNING WITH AN ALMOST FULL TANK OF GAS. WHEN I STARTED THE CAR IN THE CHURCH PARKING LOT THE YELLOW EMPTY WARNING LIGHT WAS ON. THEN I DROVE TO THE NEAREST GAS STATION FOR A COUPLE BUCKS OF GAS. THE LIGHT WENT OUT, BUT THE GAUGE CONTINUED TO WOBBLE. THEN A WEEK LATER THE CHECK ENGINE WARNING LIGHT CAME ON. AFTER ALL THIS, THE CAR PASSED INSPECTION. NOW BOTH THE YELLOW LOW-GAS WARNING LIGHT AND THE CHECK-ENGINE LIGHT ARE ON AGAIN & WON'T GO OFF. THE TECHNICIAN TOLD US THAT THE FUEL SENSOR IS BAD & THAT REPAIRS WOULD COST UP TO $800.00. *TR

Mileage: 68,000

SPEEDOMETER BEGAN BOUNCING AND THEN COMPLETELY QUIT WORKING; OUTSIDE TEMPERATURE GAUGE STUCK ON LOWEST TEMPERATURE READ OUTSIDE, MODE BUTTONS FOR HEATING AND AIR CONDITIONING OPERATE ERRATICALLY. *TR

Mileage: 111,000

THE BRAKES LIGHT WAS FUNCTIONING (NOT ON) WHEN THE BRAKE PEDAL IS DEPRESSED. THE ESC OFF LIGHT START TO STAY ON. *TR

Mileage: 43,492

BRAKE LIGHT MODULE FAILS TO LIGHT UP, WHICH CAUSES HIGHER RISK OF COLLISION. THERE IS RECALL ON THIS, BUT THIS DOES NOT COVER MY VEHICLE. THIS VEHICLE HAS MULTIPLE PROBLEMS, ALL OF WHICH ARE HAZARDS. THE GAS GAUGE NEEDLE DOES NOT FUNCTION PROPERLY, AND SHOWS ERRATIC GAS USAGE, EVEN SHOWING THE LOW FUEL LIGHT RIGHT AFTER FILLING UP. THE ESC LIGHT STAYS ON, WHICH CAUSES THE ENGINE LIGHT TO STAY ON. AND THE VEHICLE WILL HESITATE AT TIMES WHEN THE GAS PEDAL IS DEPRESSED. ALL OF THESE ISSUES HAVE BEEN REPORTED BY OTHER SANTA FE OWNERS. *TR

HELLO, I AM THE ORIGINAL OWNER OF A 2007 SANTA FE. I WAS DRIVING LAST WEEK TO PICK UP MY 6 YEAR OLD DAUGHTER WHEN ALL OF A SUDDEN IN THE MIDDLE OF AN INTERSECTION I HAD NO POWER WHEN I PRESSED ON THE GAS PEDAL. I COASTED INTO THE PARKING LOT, NOTICED THE CHECK ENGINE LIGHT ON, SHUT OFF THE CAR AND IMMEDIATELY GRABBED MY MANUAL TO SEE WHAT HAPPENED. WHEN RETURNING TO THE CAR AFTER GETTING MY DAUGHTER FROM CAMP, THE CAR STARTED AND WE MADE IT HOME. I AM FORTUNATE THAT MY WORK, CAMP, AND OUR HOME ARE VERY CLOSE. THE NEXT MORNING I CALLED MY HYUNDAI DEALER AND DISCUSSED WHAT THEY THOUGHT MAY HAVE HAPPENED. THEY AND I AGREED IT WAS BETTER SAFE THAN SORRY TO BRING IT IN TO BE CHECKED. I JUST RETURNED FROM THE APPOINTMENT AND WAS TOLD IT WAS THE "THROTTLE POSITION SENSOR", WHICH IS A VERY IMPORTANT PART CONSIDERING YOU CAN JUST LOSE POWER IN THE MIDDLE OF AN INTERSECTION OR A HIGHWAY. I ONLY HAVE 49,000 MILES ON MY CAR, WHICH IS GREAT FOR A 2007. I WOULD EXPECT THESE IMPORTANT PARTS TO HOLD UP MUCH LONGER THAN THAT. I WOULD APPRECIATE YOU INVESTIGATING THIS VERY IMPORTANT MATTER. I AND MANY OTHER FAMILIES HAVE VERY PRECIOUS CARGO WE CARRY IN OUR CARS...OUR KIDS. THANK YOU! *TR

Mileage: 49,000

FUEL SENSORS HAVE GONE OUT AND FUEL GAUGE FLUCTUATES BETWEEN EMPTY AND 1/2 TANK. CAUSES ENGINE LIGHT TO COME ON. KNOWN ISSUE, YET NO RECALLS OR ACKNOWLEDGEMENT FROM HYUNDAI. *TR

Mileage: 54,000

MY EXPERIENCE AND OBSERVATION IS SAME WHAT IS EXPLAIN IN THE EARLIER POST. I CAR DOES HAVE BRAKE LIGHT SWITCH FAILURE WHICH WAS NOT COVERED UNDER THE RECALL. UNFORTUNATELY I HAVE SHELL OUT $70 FROM POCKET TO FIX IT. THE HYUNDAI DEALER (HYUNDAI MARK ZIMMERMAN) CHARGED ME $291 FOR FIXING THE TPS AND PROGRAMMING THE ECM. WHEN I WOULD BEGIN ACCELERATION THE VEHICLE WOULD HESITATE THEN TAKE OFF RAPIDLY THEN I WOULD LOOSE POWER TO A SPEED OF @ 25 MILES PER HOUR AND THE ESC OFF SWITCH WOULD APPEAR ON THE DASHBOARD FOLLOWED BY THE CHECK ENGINE LIGHT. I SAFELY PULLED OVER AND TURNED THE VEHICLE OFF FOR ABOUT 30 SECONDS. ONCE I TURNED THE VEHICLE BACK ON, THE DASHBOARD LIGHTS WOULD GO OUT AND I WOULD REPEAT THIS CYCLE 8-9 TIMES BEFORE BEING ABLE TO DRIVE NORMALLY. ON SEVERAL OCCASIONS AFTER DRIVING NORMALLY FOR ABOUT 10 MILES THE ESC OFF LIGHT WOULD REAPPEAR ON THE DASHBOARD IN MY OPINION THIS IS A SERIOUS MALFUNCTION AND CERTAINLY DANGEROUS COMBINATION AND SHOULD BE LABELED AS A RECALL. HYUNDAI SHOULD VALUE THE SAFETY AND EXPECTATIONS OF THEIR CAR BUYERS. THANKS! *TR

Mileage: 106,300

WHILE TRAVELING ON THE INTERSTATE AT APPROXIMATELY 70 MPH, I ATTEMPTED TO DEACTIVATE THE CRUISE CONTROL BY TAPPING ON THE BRAKE PEDAL. THE CRUISE CONTROL DID NOT TURN OFF EVEN WITH HOLDING THE BRAKE DOWN HARDER. I WAS ABLE TO SHUT OFF THE CRUISE CONTROL USING THE OFF SWITCH ON THE STEERING WHEEL. UPON EXITING THE INTERSTATE AND REACHING MY DESTINATION, I COULD NOT GET THE SHIFTER TO GO INTO PARK. AFTER SHUTTING THE CAR OFF AND ON SEVERAL TIMES, I GOT IT TO GO INTO PARK. IT HAS ONLY DONE THIS ONE TIME AND NEVER HAPPENED SINCE THEN. FORTUNATELY, I WAS DRIVING AND NOT MY TEENAGE DAUGHTER WHO NORMALLY DRIVES THIS VEHICLE. HER LACK OF EXPERIENCE MAY HAVE CAUSED HER TO PANIC WHEN THE CRUISE CONTROL FAILED TO DEACTIVATE WITH THE BRAKE PEDAL. *TR

Mileage: 69,000

SUV WILL START BUT ESC LIGHT STAYS ON AND THEN THE SUV FAILS TO ACCELERATE. SUV MUST THEN BE RESTARTED FOR A CYCLE OF 10-15 TIMES UPON WHICH TIME THE ESC LIGHT TURNS OFF AND SUV WILL THEN ACCELERATE WHEN GOING UP A HILL. SYSTEM FAILURE HAS OCCURRED DAILY SINCE MARCH 2013. DEALERSHIP KNOWS HYUNDAI IS RECALLING 2007 SANTA FE BUT REFUSES TO SERVICE VEHICLE AT NO COST UNLESS I RECEIVE A RECALL NOTICE. *TR

Mileage: 90,000

MY CAR HAS DIED 3 TIMES AFTER I TURN. I HAVE TURNED BOTH LEFT AND RIGHT WHEN THIS HAPPENS. I USUALLY HAPPENS WHEN I'M TURNING OUT OF MY DRIVEWAY OR ONTO ANOTHER STREET/ROAD AS SLOWER SPEEDS. I LOSE POWER STEERING, MY CAR DIES AND MY BATTERY LIGHT QUICKLY FLASHES ON WITH THIS HAPPENS. ONCE I TURN THE CAR OFF AND TURN IT BACK ON, EVERYTHING WORKS AGAIN. AND NO WARNING LIGHTS ARE ON. THIS JUST HAPPENS TO ME SPARATICALLY. IT HAS HAPPENED 3 TIMES OVER THE LAST 4 MONTHS. I'VE TAKEN IT IN TWICE TO THE DEALER. ONCE THEY REPLACED A PART (SORRY DO NOT RECALL AT THIS TIME). HOWEVER IT DID IT A FEW WEEKS AFTER THAT WAS REPLACED, SO OBVIOUSLY WASN'T WHAT WAS WRONG WITH IT. THE SECOND TIME THEY JUST TOLD ME THEY DO NOT KNOW WHAT IS WRONG. AND STATE THEY COULD HELP ME, NOR WILL IT BE COVERED UNDER MY WARRANTY IF IT HAPPENS OVER 100,000 MILES. I'VE NOW HEARD OF OTHERS THIS HAS HAPPENED TOO. *TR

Mileage: 75,000

ESC OFF LIGHT IS ILLUMINATED WHEN VEHICLE IS NOT IN PARK, AND CHECK ENGINE LIGHT IS ILLUMINATED. BRAKE LIGHTS DON'T WORK (SEEM TO BE ALWAYS ON). I GOT THE PROBLEM CODE FROM THE VEHICLE, DID SOME RESEARCH, AND FOUND HYUNDAI CAMPAIGN 092 COVERED THESE CONDITIONS CAUSED BY A FAULTY STOP LAMP SWITCH. I CONTACTED HYUNDAI, AND THEY INFORMED ME MY VEHICLE WAS MANUFACTURED (JULY 2006) PRIOR TO THE RECALL DATE RANGE (WHICH STARTED IN OCT 2006), AND WOULD NOT BE REPLACED WITHOUT CHARGE BY A DEALER. THIS IS THE SAME PROBLEM AS WAS COVERED IN THE RECALL, AND HYUNDAI SHOULD BE LIABLE TO FIX IT! *TR

Mileage: 75,000

I RECEIVED A RECALL LETTER FROM HYUNDAI CONCERNING THE AIRBAGS IN THE VEHICLE. I REALIZED THAT MY AIRBAG LIGHT ON MY DASH HAD BEEN ON FOR A LONG TIME, PERHAPS A YEAR OR TWO, BUT I THOUGHT THAT WAS NORMAL AND DIDN'T REALIZE IT MEANT IT DIDN'T WORK. I BROUGHT MY VEHICLE TO THE DEALER AND THEY PERFORMED THE REPAIR RELATED TO THE RECALL. THE DEALER STATED THAT THE REPAIR DID NOT FIX THE PROBLEM AS THE AIRBAG LIGHT WAS STILL ON. I AGREED TO PAY THE DIAGNOSTIC CHARGE SO THE DEALER COULD FIND THE PROBLEM. THE DEALER SAYS THERE IS A SHORT IN THE WIRING HARNESS THAT IS THE CAUSE OF THE PROBLEM WHICH WOULD COST $1500 TO FIX. THEY SAID THE SRS COMPUTER AND AIRBAG SENSOR MAY ALSO NEED TO BE REPLACED FOR A COST OF $600 AND $400 RESPECTIVELY. *TR

Mileage: 82,000

WIFE'S CAR-DRIVING ONE DAY AND NOTICED AIRBAG WARNING LIGHT ON. TOOK TO DEALER. DEALER SAID IT WAS SAFE TO DRIVE WHILE PART WAS ORDERED, WOULD NOT OFFER LOANER. CAME BACK AND HAD PART INSTALLED A WEEK-1/2 LATER, AFTER FINALLY GOT PART NOTICE IN MAIL. PART REPLACED-NO LIGHT ANYMORE. PROBLEM IS BACK AGAIN. CALLED CUSTOMER SERVICE, BUT THEY DON'T SEEM TO BE TOO CONCERNED. *KB

Mileage: 55,800

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHEN STARTING THE VEHICLE, THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY INFORMED THE CONTACT THAT THERE WAS A WIRING MALFUNCTION WITHIN THE STEERING COLUMN. THE TECHNICIAN ALSO ADVISED THAT IN THE EVENT OF A CRASH, THE AIR BAGS COULD POSSIBLY NOT DEPLOY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS ALSO CONTACTED AND OFFERED NO ASSISTANCE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. UPDATED 03/16/11 *BF THE CONSUMER ALSO STATED THE HEADLIGHTS WENT OUT AND HAVE BEEN REPLACED 10 TIMES OR MORE SINCE THE VEHICLE WAS PURCHASED. ALSO, THE PASSENGER FRONT DOOR WAS NOT LOCKING/UNLOCKING PERIODICALLY. THE CONSUMER BELIEVED THE VEHICLE HAD AN ELECTRICAL PROBLEM. UPDATED 06/03/11

Mileage: 70,000

THREE MAJOR COMPLAINTS. AT 18,000 MILES THE TOP SEAL OF THE ENGINE HAD TO BE REPLACED, REPAIRED UNDER WARRANTY. AT 21,000 MILE THE REAR BRAKE CALIPERS HAD TO BE REPAIRED FOR STICKING AND PADS REPLACED AT OWNERS EXPENSE. OWNER TOLD BY DEALERSHIP THE CAUSE WAS "PROBABLY FROM SALT USED TO TREAT ROAD SURFACES DURING SNOW REMOVAL". HYUNDAI REFUSED WARRANTY CLAIM AND WOULD NOT ADMIT IMPROPER MATERIALS USED FOR BRAKING SYSTEM. AT 27,000 MILES, MULTIPLE VISITS TO DEALERSHIP FOR REPAIR OF INOPERATING TURN SIGNALS. PARTS REPLACED IN ATTEMPT TO REPAIR INCLUDE ELECTRICAL BOX IN STEERING COLUMN, ALL BULBS,FLASHER UNIT,GROUNDING POINTS FOR SYSTEM. PROBLEM RECURRING AND DANGEROUS. *TR

WEDNESDAY, JUNE 23, 2010: CAR WAS PARKED IN A STORE PARKING LOT. ON APPROACH TO CAR SMOKE WAS OBSERVED ON THE INTERIOR OF THE CAR. UPON OPENING THE CAR, SMOKE AND FIRE COULD BE SEEN CENTERED AROUND THE RIGHT SIDE SEAT WARMER SWITCH AND ELECTRICAL PORT. NOTHING WAS PLUGGED IN AND KEY WAS NOT IN THE IGNITION. FIRE WAS PUT OUT BY BLOWING ON IT. SEAT WARMER SWITCH WAS MELTED ON THE RIGHT SIDE AND THE ELECTRICAL PORT CAP WAS PARTIALLY MELTED AND BLOWN OFF INTO THE CONSOLE TRAY. SOOT AND DAMAGE TO BUTTONS AND CONSOLE ABOVE THE SEAT WARMER BUTTONS ALONG WITH BUBBLED, MELTED VINYL ON CENTER CONSOLE. RETURNED CAR TO HYUNDAI DEALERSHIP THE NEXT MORNING. SERVICE MGR SAID THAT IT WAS SOMETHING THAT WE HAD PLUGGED IN AND TOOK PICTURES. SERVICE MGR SENT PICTURES TO CORPORATE HEADQUARTERS. CORP HEADQUARTERS ALSO SAID IT WAS SOMETHING THAT WE DID. CONTACTED HYUNDAI CONSUMER AFFAIRS AND ASKED FOR INVESTIGATION BEHIND THE PANEL. JUNE 19, 2010 HYUNDAI INVESTIGATED AND SAID THAT THEY COULD NOT DETERMINE THE CAUSE OF THE FIRE SO IT MUST HAVE BEEN SOMETHING THAT WE DID. *TR

Mileage: 56,000

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING AT45 MPH AND ATTEMPTING TO ACCELERATE, THE INSTRUMENT PANEL FAILED AND THE VEHICLE WOULD INDEPENDENTLY DECELERATE. THE CONTACT MOVED FROM THE ROADWAY AND SHUT OFF THE VEHICLE. WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THE DEALER ADVISED THAT THE INTERNAL THROTTLE WAS DEFECTIVE AND WAS REPLACED AT THE CONTACTS EXPENSE. THE FAILURE RECURRED. THE MANUFACTURER STATED THEY HAD NOT RECEIVED ANY COMPLAINTS SIMILAR TO HIS AND WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 23,900 AND THE CURRENT MILEAGE WAS 35,900.

Mileage: 23,900

LETTER REGARDING THE ELECTRICAL PROBLEMS HE HAS EXPERIENCED WITH HIS 2007 HYUNDAI SANTA FE. *TGW THE CONSUMER STATED WHENEVER HE PARKED NEAR ELECTRICAL TOWERS, THE LOCKS ON THE DOOR WOULD MALFUNCTION, THE CRUISE CONTROL LIGHT WOULD NOT GO OUT, THE WINDOWS WOULD NOT GO UP, THE GEAR BOX WOULD NOT DISPLAY WHICH GEAR THE VEHICLE WAS IN. THE CLIMATE CONTROL NEVER FUNCTIONED ACCORDING TO THE MANUAL. THE CRUISE CONTROL SOMETIME EXCEEDED THE SET SPEED OVER OR DOWN LONG INCLINES. THE DRIVER'S SEAT WHICH WAS ELECTRONIC SAT UP TOO HIGH. THE ROOF RACK CROSS BAR WAS TOO FAR, WHICH ALLOWED AIR TO PULL OFF THE LOADS. THE TIRE JACK WAS NOT SUFFICIENT FOR THE VEHICLE*JB

FOLLOW UP TO COMPLAINTS #'S 10319062-10319460-10319463. VEHICLE POWER STEERING LOSS HAS BEEN CORRECTED BY HYUNDAI DEALER. BE ADVISED THAT THE CAUSE FOR THE LOSS OF THE POWER STEERING WAS (THE PULLEY SEPARATED DAMAGING BELT). (BALANCER FELL APART AND BALANCER AND BELT WERE REPLACED). VEHICLE ONLY HAD 12,869 MILES ON IT. *TR

Mileage: 12,868

WHILE MAKING A RIGHT HAND TURN GOING FROM AN EASTWARD DIRECTION TO A SOUTHERN DIRECTION THE POWER STEERING ON MY VEHICLE WENT DEAD, THE RED DRIVER SEAT BELT LIGHT CAME ON AND IN A FEW SECONDS THE POWER STEERING CAME BACK AND THE EAT BELT LIGHT WENT OFF. TRAVELING AT A VERY SLOW SPEED IN A RURAL AREA OF TOWN.. AFTER INCIDENT I DROVE HOME WITHOUT ANY PROBLEM. *TR

Mileage: 11,680

WHILE DRIVING IN A SOUTHERN DIRECTION I MADE A LEFT HAND TURN IN AN EASTERN DIRECTION, AS I WAS MAKING THE TURN I HEARD A LOUD SOUND SIMILAR TO THE DROPPING OF A HEAVY OBJECT AND IMMEDIATELY AFTERWARD THE POWER STEERING ON MY CAR WENT DEAD AND THE RED BATTERY LIGHT IN THE DASH CAME ON. I WAS ABLE TO PULL THE CAR TO THE SIDE OF THE ROAD AND I STOPPED. THE RED BATTERY LIGHT WAS STILL ON, I THAN TURNED THE KEY TO TURN THE MOTOR OFF AND WHEN I STARTED THE CAR AGAIN THE RED LIGHT WAS STILL ON AND I DID NOT HAVE POWER STEERING. AS I WAS CLOSE TO MY HOME, I PROCEEDED TO DRIVE HOME AND PARK THE CAR IN THE DRIVEWAY, THE POWER STEERING WAS NOT WORKING AND THE RED BATTERY LIGHT WAS STILL ON. SINCE THIS IS THE THIRD TIME THAT I HAVE EXPERIENCED THE LOSS OF THE POWER STEERING I AM GOING TO HAVE THE CAR TRANSPORTED TO THE DEALERS SERVICE SHOP FOR INSPECTION. THE FIRST TIME THAT I EXPERIENCED THE LOSS OF THE POWER STEERING AN INSPECTION WAS MADE BY THE SERVICE MECHANICS OF THE DEALER, AND THEY AFTER KEEPING THE CAR SEVERAL DAYS COULD FIND NOTHING WRONG. IF THESE INCIDENTS WOULD HAVE OCCURRED WHILE I WAS DRIVING ON THE N.J. TURNPIKE I FEEL THAT THE OUTCOME WOULD HAVE BEEN MUCH DIFFERENT. *TR

Mileage: 12,868

WHILE MAKING A RIGHT HAND TURN GOING FROM AN EASTWARD DIRECTION TO A SOUTHERN DIRECTION THE POWER STEERING ON MY VEHICLE WENT DEAD, THE RED DRIVER SEAT BELT LIGHT CAME ON AND IN A FEW SECONDS THE POWER STEERING CAME BACK AND THE EAT BELT LIGHT WENT OFF. TRAVELING AT A VERY SLOW SPEED IN A RURAL AREA OF TOWN.. AFTER INCIDENT I DROVE HOME WITHOUT ANY PROBLEM. *TR

Mileage: 11,680

RE: 2007 HYUD SANTA FE G. 49880 MILES (AT OIL CHANGE 11/02/2009). I DROVE MY CAR APPROX 90 MILES ON A SHOPPING TRIP. I PARKED THE CAR IN FRONT OF THE HOUSE APPROX 3 PM, WENT INSIDE THE HOUSE AND APPROX 5 MINUTES WENT TO THE CAR TO REMOVE THE ITEMS I BOUGHT. I FOUND THE CAR BURNING AT THE DASH BOARD IN FRONT OF THE STEERING WHEEL. I CALL 911 AND THE FIRE DEPT ARRIVE TO EXTINGUISH THE FIRE. THE ENTIRE INSIDE OF THE CAR WAS BURNED. *TR

Mileage: 49,990

AIR BAG LIGHT COMES ON AND PANIC ALARM GOES OFF BY ITSELF. AFTER EACH EVENT, ALARM WILL NOT FULLY RESET. *TR

Mileage: 13,400

TL*THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STARTED THE IGNITION IN THE VEHICLE AND SMOKE ERUPTED FROM THE FRONT WINDSHIELD AND INSTRUMENT PANEL. THERE WAS NO WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT IMMEDIATELY EXITED THE VEHICLE AND INSPECTED UNDERNEATH THE HOOD, BUT THERE WAS NO SMOKE OR FLAMES. THE WINDSHIELD WAS DAMAGED. THERE WERE NO INJURIES. THE FIRE DEPARTMENT WAS NOT CALLED TO THE SCENE. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER, BUT THEY COULD NOT DETECT THE CAUSE OF THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 10,000 AND CURRENT MILEAGE WAS 12,000. UPDATE 09/10/08 *CW UPDATED 09/16/08 *JB

Mileage: 10,000

ON MONDAY DECEMBER 18, 2007 I GOT A 2007 SANTA FE TO DRIVE AS A LOANER FROM A HYUNDAI DEALERSHIP. TUESDAY NIGHT WHEN I FILLED THE GAS TANK, THE VEHICLE WOULD NOT START FOR ABOUT 20 MINUTES. I CALLED ROADSIDE ASSISTANCE WHO TOLD ME TO CALL THE DEALERSHIP, WHO IN TURN TOLD ME TO CALL ROADSIDE ASSISTANCE. BROWN'S MANAGER, ISHMAEL TOLD MY HUSBAND THAT HE COULD NOT HELP US. THE NEXT DAY I CALLED THE DEALERSHIP SERVICE MANAGER WHO SAID THAT THE PROBLEM HAD TO DO WITH THE REMOTE STARTER ON THE KEY CHAIN, WHICH I COULD PRESS TWICE AND THE CAR WOULD RESTART. HE OFFERED ANOTHER CAR TO ME BUT ASSURED ME THAT I SHOULD BE FINE. I OPTED TO KEEP THE SANTA FE. THAT NIGHT AS I RETURNED ON THE FAIRFAX COUNTY PARKWAY FROM HERNDON TO MY HOME, THE SANTA FE DIED AGAIN. NO AMOUNT OF PRESSING ON THE REMOTE RESTARTED THE VEHICLE AND I BECAME PANICKED AS CARS RACED BY ON EITHER SIDE OF ME. THE VEHICLE NEVER RESTARTED ALTHOUGH THE DASHBOARD LIGHTS WOULD OCCASIONALLY FLASH ON THEN OFF. A POLICEMAN CONTACTED A TOW TRUCK WHO TOWED ME BACK TO THE DEALERSHIP. I FELT MY LIFE WAS AT RISK BY THE SANTA FE'S TOTAL FAILURE IN THE MIDDLE OF A MAJOR HIGHWAY AT RUSH HOUR, WHERE I WAS STRANDED FOR 40 MINUTES. *TR

Mileage: 6,800

TL*THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT TOOK THE VEHICLE TO THE DEALER BECAUSE THE AIR BAG LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER ORDERED A FUSE BOX, BUT THAT DID NOT CORRECT THE FAILURE. THEY ORDERED THE SAME PART AGAIN, BUT THE LIGHT REMAINS ILLUMINATED. HE FILED A COMPLAINT WITH HYUNDAI CONSUMER AFFAIRS. THE AIR BAG HAS NOT YET DEPLOYED UNEXPECTEDLY. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 6,000. UPDATED 11/14/07 *TR

Mileage: 6,000