2014 HYUNDAI SANTA FE Service Brakes Problems

The start of this journey to Wesley Chapel Hyundai service department were 4 or 5 lights on the dashboard. I can’t remember what day I called to make the appointment-probably a week before the appointment as followed. I made appointment to take my Sante Fe Sport to Wesley Chapel for Monday 02/17/2025. The vehicle was not driven after the multiple lights came on the dashboard. That was their earliest appointment for service. On [XXX] the Santa Fe Sport was towed to Westly Chapel service department because a neighbor came over to tell us that the car lights were blinking. The car was not on. When they lifted the hood on the vehicle there was smoke and the smell of something burnt. They disconnected the battery, and the vehicle was towed by AAA to the Westley Chapel Hyundai. We live in a mobile home and park the car close to the kitchen window. This scared me. What could have been was losing my home to fire. Thankfully it didn’t happen. My question is how does an ABS ASSY go bad under 30,000 miles on a vehicle? And we are being told that some pump went bad first that caused the ABS ASSY to go bad. So also, I question how does a pump go bad under 30,000 miles on a vehicle? Should this ABS ASSY failure been covered under a recall? I have attached the Hyundai of Wesley Chapel invoice. Thank you, [XXX] & [XXX] [XXX] 33541-7345 [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On [XXX}, the abs module failed. I did not know this until it was diagnosed by Pope Automotive, Lubbock, TX on 9/27/24. They discovered there was a recall 205 related to this issue. They started a case with Hyundai in regard to this: #[XXX]. I was in contact with my case worker who told me to have it towed to a Hyundai dealership. I did and it is currently at Gene Messer Hyundai, Lubbock, TX. Messer diagnosed the vehicle and stated the abs module is not related to the recall, because the recall work was done on 2/25/24 in Alabama. I contacted Messer Service Dept and spoke with Victoria. She stated that perhaps only the fuse was replaced, but not the abs. We need a copy of the invoice from Feb 2022, in order to know. I called Carvana, where I purchased the vehicle on [XXX] (only weeks from when the service was done). I was told it has been too long, they don't have the record. Serra Hyundai Trussville, AL said I'd have to get the information from Carvana, they cannot provide it to me. I called Carvana again today. I spoke with a different person and was told it would take 24-48 hours to send me the copy. On this invoice, we will find the abs module was replaced. There is no logical reason for it to go out in just 2.5 years. Perhaps it was a bad part. I feel it is unfair that I am being held responsible for it's replacement. If the abs module was not replaced as part of the 205 recall, I would expect it replaced. There were several model years included in the recall and hundreds of thousands of vehicles affected. There was also a class action lawsuit. There was a period of time where Hyundai parts were not quality or reliable. This has been a very stressful situation requiring many phone calls and research. It should have been a simple solution - replace the defective abs module at no cost to me. I have been without my vehicle now since [XXX]. It is the only transportation for a family of 4. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2014 Santa Fe was scheduled for a Recall 251 ABS Brake Failure-Fire hazard. NHTSA and Hyundai both advised owners of vehicles associated with this recall to park away from structures and recommended the vehicle not to be driven. Hyundai did not have a solution for roughly 6 months. During that time I kept my vehicle parked and away from structures as recommended for that 251 safety concern. I periodically would start the car and let it run to keep it from failing. I went through an entire winter season waiting for a solution a recall. My car just sat. Extreme weather and susceptible to dirt as it sat outside parked. Finally in May 2024 I was informed that Hyundai had a solution and parts were ready for the 251 recall repair. Well the day I was scheduled to bring my vehicle in to be repaired I went out and attempted to start the vehicle but could not. I tried to jump the battery and it still wouldn’t start so I called the dealer and told them that I couldn’t get the vehicle started. They would not provide a tow so I rescheduled the appointment and I called a tow service the next day. Tow came and checked the battery. The battery was fine. They jumped the battery and the vehicle turned on. the vehicle to a local dealer and they repaired the recalls. The vehicle was driven to the dealer that week. My vehicle’s recalls were completed and I picked up the car a week later. All of a sudden when I went to start the car it would not turn over. I stalled in the lane of travel and avoided a collision. I called a private tow again, towed to the same dealer that did the recall. Engine light came on and they were able to determine that the crank position sensor failed as to the reason for stalling and intermittent starting. $600 later they repaired it. I left and the next day my car wouldn’t start again. I associated this with the 251 recall and wear as it sat dormant for too many months. Hyundai refused to provide Goodwill or reimbursement for the crankshaft repair.

1) What component or system failed or malfunctioned, and is it available for inspection upon request? I tried to park in the parking space next to it by making a slight right turn. As soon as I stepped on the brake to park, the car began to rush forward. I noticed again and again that my foot was slamming on the brakes, but the car didn't stop. My car went over the ledge between the parking lot and the store, slammed into the pillar of the building on the left, smashed all the glass in the dance studio, and hit the wall on the right before coming to a stop. It took six seconds from rushing forward to into the store. 2) How was your safety or the safety of others put at risk? I must have been severe injured if the car didn't stop by hitting a right-side wall of the store. And if there were people, I was not able to avoid casualites. 3) Has the problem been reproduced or confirmed by a dealer or independent service center? No, the car was towed and reviewd by car insurance. Car insurance informed that th e car will be total loss. No information about reproducing the issue 4) Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No 5) Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, that was suddenly occured 6) Request: I want NHTSA to investigate my car of sudden unintended acceleration. I would like to get EDR, X-ray of PCB board of electrical central unit(a.k.a ECU) managing brake and accelerator and car manufacturer's reliability sign-off report of the ECU board. I have a security footage taking the accident moment. I failed to upload the video. If you want, please let me know. Will send the video file with NHTSA.

CUSTOMER COMPLAINT OF ERRATIC GAUGE OPERATION AND MULTIPLE WARNING LIGHTS. CODE SCAN REVEALED MULTIPLE CODES STORED IN ABS FOR SPEED SENSOR INPUT. DATA LIST SHOWED VEHICLE SPEED SPIKING ON MUPLTIPLE WHEELS THEN UNIT STOPPED COMMUNICTING WITH SCAN TOOL. UNPLUGGED ABS CONTROL UNIT TO CHECK FOR POWER AND GROUND AND FOUND BRAKE FLUID AND BURNED CONNECTOR. RECALL HAS NOT BEEN EXPANDED TO THIS VIN YET BUT SHOULD BE.

I received a letter 6 months ago advising me to park my car outside and away from buildings because the car could catch fire even when not running. I've had to get permission from my HOA every month to park in the parking lot. I call the dealership every month to see if there has been a solution. Sometimes I have to drive my grandchildren and two of them are in car seats. Sometimes I have to drive my dogs and they are restrained in safety harnesses. I am afraid to drive with them because I'm not sure I'd be able to get them out in time if there was a fire. I called Hyundai customer service and they told me to ask my dealership for a loaner car. when I did, they said they would call me back. They did not. I have an upcoming road trip at the end of this month and I'm afraid I will have to cancel because of this safety issue. I feel that Hyundai is taking much too long to come up with a resolution and they are putting me and my family, my grandchildren, and my dogs at risk, not to mention the inconvenience and the worry.

Hyundai Campaign 251 ABS Module may leak hydraulic fluid, internally, and could cause a fire while driving, or parked. Hyundai has known about this problem since, at least, August 2023. The recall paperwork says this leak may cause a fire in the engine compartment while parked, or driving. What is taking Hyundai so long to correct this safety issue? I can't park my car in the garage because it may start a fire and cause damage to my home. I'm concerned about driving it because it may start burning while I'm on the highway. If the ABS stops working it may result in the brakes not working properly. Is there anything the NHTSA can do to encourage Hyundai to find a resolution.

On June2 2023 I was driving on I75 north to Wesley chapel, Pasco exit ramp 273 I and granddaughter were left on highway no Emergency lights nothing. My SUV just shut down just no warning no lights no noise huge smell of chemical burn when my daughter and the road ranger arrived they notice the bad smell at engine like chemical very bad. There was ni emergency lights, rpms were not working i notice ut dropped down, a tractor trailer wad seconds inches on my suv. I did a sudden sharp turn steering column so I can get the SUV to glide into the triangular Divider with the exit was for me to get off so we were stuck I 75 north in between pasco exit to 73 that's where my SUV broke down. No Warning nothing now which is November 2023 my car still not running I had a recall dates but I became ill now ill Now I have to find out I can get my car fixed. When I purchase the car several months later I noticed the Abs lights were on but ABS breaks the slope and the traction all those lights go on emergency break light goes on while i drive but that did not happen during the time that I was driving on the i75 north highway. I had my granddaughter who was 9 years old at the time. We could have been hit. Suv was locked down And said goodbye it was like someone controlling my suv. SUV was zzz like gliding I have a full tank of gas. I had to tow it after waiting 8 hours no lights on suv but I also tried to have the battery tested or started it'll start but the key fob will not work. Its confused. I'm very very upset I paid off my suv, had one recall after I bought and now again. This time SUV died no warning nothing I feel courtesy Hyundai should tow my suv, recall check, courtesy check and my two key fobs. This I should not have to feel UNSAFE in my suv always wondering will this happen again and will I be a fatal driver hoping I don't have any of my grandchildren nor my adult kids or any human being.

I was driving down the interstate at the speed limit of 60mph, traffic slowed down then totally stopped. I was at a safe distance to stop, i began tapping on the brakes and i had no brakes. the brake pedal was hard no give in the pedal which caused me to rear end a stopped vehicle doing 60 MPH with me and my son in the vehicle. We went by ambulance to go to the emergency room. The car was declared a total loss by AAA. This happened on September 19th 2023. My safety and my son along with everyone driving on the interstate was at risk because of total brake failure. There were no warning lights present or malfunction indicator lights warnings at all. My son and I, are lucky to be alive.

I received a notice of recall on the ABS for my Hyundai Santa Fe 2014 Sport. My ABS light recently illuminated, I went to the Hyundai site to make an appt. I was given one a week out, while waiting for the appt my brake lights wouldn’t turn off unless I disconnected the battery. I took the vehicle to the dealership in Brevard Fl, the guy kept trying to upsell me $180 for diagnostics and that I had to pay it for every light on. Which I explained had all happened since the ABS light. I was there for 4 hours and I asked him to fix the ABS he didn’t said he didn’t have time and I had to reschedule. I had to wait another week, I took it to a friend who is a certified mechanic. He put it on his diagnostic computer and it kept coming back with ABS code. Said he couldn’t do the brakes until that was fixed. Went back this week, didn’t ask me anything when I pulled in, not even an hour later said my vehicle was done come get it. He handed me a quote of $1300 for brakes. I asked if I paid that would it fix the ABS he said no, but ur vehicle is not safe to drive. I explained I know, it wasn’t safe last week and you didn’t help me. I was able to get my vehicle to nearby brake-shop. I explained everything that happen, they also ran diagnostics and said it was ABS that they couldn’t fix it either until the dealership fixed the ABS. Now my vehicle is stuck at brake-shop and I just started a new job and have already had to miss two days work. I am completely dumbfounded as to why I am getting the run around and no one wants to help. I deplore having to complain, however it feels as though there is no more customer service/satisfaction.

2014 Hyundai Santa Fe are not safe vehicles as I have experienced many issues with this vehicle since purchase such as several recalls and recently the motor gave out. Due to recent class action lawsuit on this vehicle the dealer replaced the motor for free. My daughter recently reported to me the brakes appeared to not work properly and she planned to take it to the dealer on Monday, but over the weekend the brakes failed resulting in her crashing into a tree. My daughter could have been killed due to safety issues with this vehicle. The car is a total loss. These vehicles are not safe and should be pulled off the road. The first dangerous issue was the vehicle stalling in traffic as the motor malfunctioned and now the brakes. Please advise.

My air bags don’t work and the brake system fails. Motor went out recalled and dealership not working on it

I HAVE A 2014 HYUNDAI SANTA FE SPORT THAT BURNS AN EXSESSIVE AMOUNTS OF OIL. I DO ALOT OF DRIVING MAYBE AROUND 36 MILES A DAY. EVERY TWO WEEKS ANOTHER OIL CHANGE IS NEEDED. BOUGHT THIS VECHLE IN 2017 WITH ONLY 20,000 MILES ON IT THE EVERYTIME I GOES TO JIFFY LUBE IT SHOWS THAT THE ENGINE WAS SUPPOSED TO BE REPLACED. THERE HAS BEEN MULTIPLE PROBLEMS WITH THIS VECHILE SINCE DAY ONE OF HAVING IT. I NEVER GOTTEN A NOTICE ABOUT THIS INFORMATION. HYUNDAI HAS BEEN CALLED NUMEROUS OF TIMES CONCERNING THIS MATTER. THE ENGINE WAS NEVER REPLACED OIL STILL BURNING REALLY FAST. ITS CAUSING A LOT OF TIME AND MONEY. I DONT THINK ANY OF THE PROBLEMS WERE TAKEN CARE OF.

The contact owned a 2014 Hyundai Santa Fe. The contact stated that while driving approximately at 75-80 mph when another vehicle driving at high speeds crashed into the rear of the vehicle causing the vehicle to sway. The contact attempted to avoid crashing into another vehicle but crashed into a concrete divider. When the contact depressed the brake pedal, it failed to respond. As a result, the vehicle flipped over. During the incident, the seat let's failed to retract and secure the contact therefore he collided with the windshield during the impact. The air bags failed to deploy. The contact sustained injuries to his back, ribs, and shoulder that required medical attention. The vehicle was towed and deemed totaled. A police report was not filed. The manufacturer was made aware of the failure. The approximate failure mileage was 70,100.

Mileage: 70,100

Back in March my landlord lost his keys then Someone started to enter my unit illegally I filed numerous police reports to ensure safety for me and my two small children but wasn’t taken serious was forced and admitted into the hospital for trying to protect me and my children losing custody as well and my car was left parked on a city street, my house possessions were all damaged as well and I believe a rodent or someone left the windows down purposely for a rodent to gain entrance to my vehicle and living area as well, my vehicle tires kept needing repairs the interior had some kind of infestation and something was wrong with the ventilation system in the car and I didn’t feel safe driving the vehicle nor did I feel that the vehicle was worth the 413 monthly payments which I never missed payments on up until this incident. I tried to go through my car insurance company and local Hyundai dealer for a replacement of my vehicle and nothing was done to protect my safety or health also my banking information was compromised and I lost financial control and was unable to make payments for the last two months because of this I reached out to Santander consumer which is my finance company to express my concerns and they was unable to stop the repossession, I feel horribly scammed and is wondering if there is anything that can be done to stop me from further loss if anything is needed further feel free to contact me

Recall campaigns have been issued for the ABS system. The recall notice says repairs must be made, and they should be made asap if the ABS warning lights are active. On July 23, 2021, I brought my vehicle to Sterling Hyundai (5000 Johnston St., Lafayette, LA) where they inspected the part only, with a verbal notice from the Service Manager (Jason) that the part would be in the following Tuesday (July 27) and I would be called to schedule repair. On August 17, 2021, I was the one who called inquiring when the part would be in, and I spoke with the Parts Manager. He said my part wasn't in yet, but another person's part was in so they would use that part on my vehicle. He transferred me to the booking line where I left a message to schedule an appointment. As of today, September 13, 2021, I have not received any phone calls or emails, and I still have not had the recall issue corrected by the dealership. On July 23 and August 17, I informed the people I spoke with that the ABS warning lights were active, and they were active at the time of the alleged inspection. I should not have to beg the dealership to fix manufacturer's recall, and I have done my due diligence calling multiple times and rendering my vehicle for inspection. My next complaint will be with the Louisiana Auto Dealer's Association, should NHTSA not take action.

The vehicle is in excellent condition with all maintenance complete. Starting intermittently at approximately 40,000 miles, and now consistently since 49,000 miles, 3 warning lights illuminate on the dash simultaneously; 1: ABS warning light, 2: TCS warning light, 3: Hill Assist warning light. Reading the codes with a code scan tool indicates the Right Rear Wheel Speed Sensor has a short circuit, an open circuit, or has failed, or the wire connector has failed. If the ABS or TCS systems are not functioning, there is a higher risk of crash. This is a very common problem according to simple google searches, and affected vehicles should be recalled and repaired.

Hyundai had recall campaign 194 in place to address faulty ABS module but never developed a suitable remedy to correct problem, consequently turning people away at dealerships with no fix - now they have recall campaign 205 replacing 194 to correct the module problem but again Hyundai says they have no solution for problem so far and give no perspective date for finding a solution - customers are still faced with threat of fire from leaking break fluid with no remedy in sight except for an unbelievable warning from Hyundai to not park the car in a garage -

TOOK THE CAR IN FOR A RECALL AND SERVICE ENGINE SOON LIGHT ON FEBRUARY 4TH. WHEN I GOT ALMOST HOME THERE WERE 4 MORE LIGHTS ON. REAR WHEEL SENSORS, SKID CONTROL, DOWNHILL AND CAR APPROACHING LIGHT. MADE AN APPOINTMENT TO GET THESE FIXED AND I EXPLAINED I HAD CAR SHIELD AND THEY SAID THEY ACCEPTED CAR SHIELD. TODAY, MAY 5TH WHEN I TOOK THE CAR BACK (FIRST APPT. I COULD GET) AFTER I SAT THERE FOR 1-1/2 HOURS THEY CAME BACK AND TOLD ME MORE THINGS WERE WRONG AND INFORMED ME AT THAT TIME THEY NO LONG USE CAR SHIELD. I'M DONE WITH HYUNDAI. THEY RUN YOU IN CIRCLES AND TREAT YOU LIKE [XXX] AND THE TECH HAD THE NERVE TO GET MAD AT ME. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Mileage: 28,091

TL* THE CONTACT OWNED A 2014 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT A LOW RATE OF SPEED, HER BRAKES FAILED TO OPERATE AS NEEDED AND COLLIDED INTO ANOTHER VEHICLE. THE CONTACT WAS UNCERTAIN IF ANY WARNING LIGHTS HAD APPEARED ON THE INSTRUMENT PANEL PRIOR TO THE FAILURE. THE CONTACT STATED THAT ALL AIRBAGS DEPLOYED UPON IMPACT. THE AUTHORITIES WERE CALLED TO THE SCENE AS A GRAYISH SMOKE BEGAN TO EMIT FROM HER VEHICLE. NO FIRE HAD IGNITED FROM THE SMOKE AND A POLICE REPORT WAS FILED. DUE TO THE FAILURE, THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE HER INSURANCE LATER DEEMED THE VEHICLE A TOTAL LOSS. THE CONTACT DID SEEK MEDICAL TREATMENT BY HER DOCTOR FOR INFLAMMATION TO SEVERAL AREAS OF HER BODY, AS WELL AS BRUISES TO HER RIGHT LEG, CHEST, AND LEFT ARM. NO OTHER INJURIES WERE REPORTED. THE DEALER NOR THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE WAS DEEMED A TOTAL LOSS. THE FAILURE MILEAGE WAS 106,000. *DT*JB*DT*JB

Mileage: 106,000

TL* THE CONTACT OWNED A 2014 HYUNDAI SANTA FE SPORT. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD EXPERIENCED A FAILURE WHILE THE VEHICLE WAS IN THE DRIVEWAY OF HIS RESIDENCE WITHOUT WARNING AFTER EXITING HIS HOME TO WALK TO HIS VEHICLE. THE CONTACT NOTICED THE VEHICLE WAS ON FIRE INSIDE THE CARPORT WHICH WAS ATTACHED TO THE HOUSE. THE CONTACT RAN BACK IN THE HOUSE CONTACTED THE FIRE DEPARTMENT WITHIN MOMENTS THE VEHICLE AND RESIDENCE WENT UP IN FLAMES. THE FIRE DEPARTMENT WAS CONTACTED CAME OUT AND EXTINGUISHED THE FLAMES. A POLICE REPORT WAS MADE. MEDICAL ATTENTION WAS CONTACTED AND CAME OUT TO THE SEEN BUT WAS NOT NEEDED. THE FIRE DEPARTMENT DEEMED THE VEHICLE AND RESIDENCE A TOTALED. DORAL HYUNDAI 10285 N.W. 12TH STREET, DORAL, FL 33172 (305) 477-4005 CONTACTED THE CONTACT FOR A COURTESY CALL AND WAS INFORMED, FROM THE CONTACT THAT THE VEHICLE WENT UP IN FLAMES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000. THE PARTS DISTRIBUTION DISCONNECT.

Mileage: 130,000

IT WAS INDICATED BY A LETTER FROM HYUNDAI MOTOR AMERICA THAT THE BRAKE SYSTEM ON THIS CAR CAN POSSIBLY REACT TO A ELECTRICAL SHORT IN THE ANTI-LOCK BRAKE SYSTEM, CAUSING A FIRE WITHIN THE ENGINE COMPARTMENT. THEREFORE A RECALL WAS INITIATED, BUT A SOLUTION FOR REPAIR, FOR THE PAST 4 MONTHS, IS NOT YET AVAILABLE. IT IS MY OPINION THAT A CAR WITH THIS CONDITION IS NOT SAFE TO DRIVE AND THEREFORE HYUNDAI SHOULD FURNISH A LONER CAR FOR THE PERIOD IT TAKES TO MAKE A SAFETY REPAIR OR REPLACE THE CAR. THE CONSUMER REFERENCED RECALL 21V-303. THE CONSUMER INQUIRED ABOUT THE PURPOSE OF THE RECALL.

IT'S THE ABS BRAKE SYSTEM THAT IS LEAKING FLUID AND COULD POSSIBLY LEAK ON AN ELECTRICAL BOX CAUSING A FIRE.

TL* THE CONTACT OWNS A 2014 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, THE TRACTION CONTROL WARNING LIGHT ILLUMINATED AND THE VEHICLE LOSS MOTIVE POWER AND WOULD NOT PROPERLY ACCELERATE WHILE DEPRESSING THE ACCELERATOR PEDAL. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER RICK CASE HYUNDAI LOCATED AT 3180 SATELLITE BLVD NW, DULUTH, GA 30096, WHO WAS UNABLE TO DIAGNOSE THE CAUSE OF FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 58,000.

Mileage: 58,000

MY 2014 SANTA FE SPORT BEGAN SHAKING VIOLENTLY AT 72 MPH. I TOOK IT TO A SHOP THINKING THE WHEELS HAD BECOME UNBALANCED. IMMEDIATELY THE VEHICLE BEGAN SHAKING AGAIN. I AGAIN TOOK IT FOR RE-BALANCING. SAME SHAKING PROBLEM. I TOOK IT A THIRD TIME TO AN AUTO REPAIR SHOP WHO FOUND THAT THE CALIPERS WERE SO HOT THEY WERE ABOUT TO BURN. YOU COULD FEEL AND SMELL THE HEAT. THE SHOP REPLACED THE CALIPERS THINKING THE SHAKING WAS A BRAKING ISSUE SINCE EVERY TIME I APPLIED THE BRAKES, THE VEHICLE WOULD SHAKE EVEN WORSE. THE CALIPER REPLACEMENT DID NOT FIX THE ISSUE. FINALLY AFTER REPLACING THE BRAKE PADS, CALIPERS, AND ROTORS, THE SHOP DID ANOTHER ROAD TEST. THEN THE CAR NOT ONLY SHOOK BUT THE ENGINE STARTED KNOCKING DUE TO TIE ROD FAILURE. THE VEHICLE CONTINUED TO BE DANGEROUS TO DRIVE, SO THE SHOP HAD IT TOWED TO HYUNDAI FOR AN ENGINE REPLACEMENT UNDER A TSB. HYUNDAI REPLACED THE ENGINE BUT WOULD NOT TAKE RESPONSIBILITY FOR THE CALIPER AND BRAKING ISSUES, WHICH ENDED UP BEING DIRECTLY RELATED TO THE ENGINE ISSUE.

Mileage: 121,500

STEERING LOCKED UP, DIFFICULT TO TURN. WARNING STEERING LIGHT CAME ON AND BRAKE WARNING LIGHT. DOWN HILL WARNING LIGHT CAME ON. IT WAS A BLESSING THAT I WAS DURING ONLY 30MPH.

Mileage: 78,000

TL* THE CONTACT OWNS A 2014 HYUNDAI SANTA FE. WHILE DRIVING AND APPROACHING A STOP LIGHT AND WHILE DEPRESSING THE BRAKE PEDAL TO COME TO A STOP, THE VEHICLE SHOOK VIOLENTLY AND STALLED WITHOUT WARNING. THE FAILURE RECURRED FOUR TIMES WHEN COMING TO A STOP. AFTER EACH FAILURE, THE VEHICLE WAS TAKEN TO UNIVERSAL HYUNDAI (12801 S ORANGE BLOSSOM TRAIL, ORLANDO, FL 32837, (321) 418-6386), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

Mileage: 95,000

ERROR MESSAGE FLASHED ON DASH DISPLAY "BSD CANCELLED". THEN THE DISPLAY RETURNED TO NORMAL FOR ABOUT 2 SECONDS, THEN THE ENTIRE DISPLAY RETURNED TO "BSD CANCELLED". THIS REPEATED UNTIL THE IGNITION WAS SHUT OFF. AT THE SAME TIME THE ABS LIGHT AND STABILITY CONTROL LIGHTS CAME ON. I LEFT THE CAR OVERNIGHT. WHEN THE CAR STARTED THE NEXT DAY ALL OF THE LIGHTS HAD EXTINGUISHED. TRYING TO GET DIAGNOSED AT DEALERSHIP AT THIS TIME. CAR WAS IN MOTION AT THE TIME ABOUT 1 MILE FROM MY HOME, TRAVELING ABOUT 25 MPH SO I CONTINUED HOME AND PARKED THE VEHICLE. NO ACCIDENT.

Mileage: 77,800

TL* THE CONTACT OWNS A 2014 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 50 MPH AND ATTEMPTING TO MAKE A RIGHT TURN, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT HAD TO APPLY EXCESSIVE FORCE TO THE BRAKE PEDAL IN ORDER FOR THE VEHICLE TO COME TO A COMPLETE STOP. THERE WERE NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 89,060.

Mileage: 89,060

DRIVING IN STOP AND GO TRAFFIC (5-20 MPH), WHEN I STEPPED ON THE BRAKES WITH NORMAL PRESSURE FOR THIS TYPE OF CITY DRIVING. AT THIS TIME I HEARD A LOUD GRINDING NOISE AND I HAD TO DRIVE OFF THE ROAD TO AVOID HITTING THE CAR AHEAD BECAUSE THE VEHICLE DID NOT STOP. IT TOOK LONGER AND MUCH MORE PRESSURE THAN JUST A REGULAR TAP ON THE BRAKE NEEDED TO STOP IT AT THIS SPEED. I DRIVE ON THIS ROAD EVERY DAY AND THERE WAS NOTHING WRONG WITH THE ROAD OR WEATHER. I CALLED ROADSIDE ASSISTANCE AND HAD IT TOWED TO THE DEALERSHIP. NO PROBLEM WAS IDENTIFIED. I AM NO W AFRAID TO DRIVE THIS VEHICLE FOR FEAR OF REPEAT INCIDENT.

Mileage: 23,300

JUNE15,2015 EXPERIENCED COMPLETE BRAKE FAILURE WHILE DRIVING NEAR HOME.SOMEHOW MADE IT INTO MY DRIVEWAY W/O INCIDENT. HAD VEHICLE TOWED TO DEALERSHIP THAT AFTERNOON. DEALER CONFIRMED BRAKE FAILURE DUE TO TOTAL LOSS OF ALL BRAKE FLUID, "VERIFIED NO BRAKES & MASTER CYLINDER EMPTY, FOUND BRAKE FLUID LEAKING FROM ABS MODULE BRAKE LINES. TIGHTEN ALL (16) BRAKE LINES." DEALER SVS TOLD ME THE LINES HAD NOT BEEN TIGHTENED AT THE FACTORY.

Mileage: 11,166