2006 HYUNDAI SONATA Visibility Problems

TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. WHILE DRIVING 55 MPH, THE DRIVER SIDE SUN VISOR DETACHED FROM THE CEILING OF THE VEHICLE AND OBSTRUCTED THE DRIVER'S VIEW OF THE ROADWAY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DRIVER SIDE SUN VISOR NEEDED TO BE REPLACED, BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000. MA 08/11/15 THE CONSUMER STATED THE DEALER ADVISED THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO LOCATION. UPDATED 8/14/2015 *JS

Mileage: 115,000

TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE HINGE ATTACHED TO THE DRIVER SIDE SUN VISOR WAS CRACKED AND CAUSED THE VISOR TO REMAIN IN THE DOWN POSITION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 127,000.

Mileage: 127,000

SUN VISORS DO NOT REMAIN IN PLACE. THEY WILL FALL OBSTRUCTING MY VIEW. *TR

Mileage: 89,000

TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE DRIVER'S SIDE SUN VISOR REMAINED IN THE DOWNWARD POSITION AND OBSTRUCTED THE VIEW OF THE ROAD. THE SUN VISOR WAS UNABLE TO BE SECURED IN THE UPWARD POSITION. THE VISOR WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 65,000.

Mileage: 65,000

TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT ALSO MENTIONED THAT THE REAR DOOR LOCKS AND FRONT PASSENGER WINDOW FAILED TO FUNCTION. THE CONTACT THEN STATED THAT THE REAR DRIVER'S SIDE DOOR FAILED TO LATCH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE PASSENGER'S SIDE OCCUPANCY SENSOR MAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 2,000. UPDATED 06/10/14 MA

Mileage: 2,000

WHILE DRIVING, THE DRIVER'S SIDE SUN VISOR SUDDENLY FLOPPED OPEN. IT STARTLED ME AND ALMOST CAUSED AN ACCIDENT. THE SUN VISOR HAS NOT STAYED UP EVER SINCE. THIS CREATES A SAFETY ISSUE SINCE IT BLOCKS MY LINE OF VISION. *TR

Mileage: 55,000

WHILE DRIVING AT 65MPH, PASSENGER SIDE SUN VISOR FELL, STARTLING DRIVER AND NEARLY CAUSING AN ACCIDENT. SUN VISOR REMAINS DOWN (WILL NOT STAY UP), CAUSING A CONSTANT DISTRACTION AT ALL HOURS AND RESTRICTING VISIBILITY. *TR

Mileage: 136,527

THE DRIVER SIDE SUN VISOR STOPPED WORKING. IT DOES NOT STAY IN THE UP POSITION. APPARENTLY OTHER DRIVERS HAVE EXPERIENCED THE SAME PROBLEM, BUT THE DEALER AND MANUFACTURER HAVE REFUSED TO ACCEPT ANY RESPONSIBILITY FOR THIS DEFECT. *TR

Mileage: 20,500

BOTH SUN VISORS ON MY 2006 HYUNDAI SONATA WILL NOT STAY UP NEAR THE CEILING OF THE CAR. BOTH SLIP DOWN WHICH IS A HUGE DISTRACTION. I HAD TO REMOVE THE PASSENGER SIDE VISOR AND ONLY KEEP THE DRIVER SIDE ONE ATTACHED IN CASE THE SUN IS IN MY EYES. PUTTING IT TO THE LEFT CREATES A BIG BLIND SPOT. IT IS UP TO $100 TO REPLACE THE VISOR AND HYUNDAI HAS REFUSED TO DO ANYTHING DESPITE THE HUGE NUMBER OF PEOPLE COMPLAINING ABOUT SIMILAR ISSUES. *TR

TWO WEEKS AGO I HAD TO REPLACE THE POWER WINDOW OPERATOR ON REAR PASSENGER SIDE DOOR. TODAY THE POWER WINDOW ON THE REAR PASSENGER SIDE WINDOW IS NOT WORKING AND NEEDS REPLACEMENT. THE BAD SOLENOIDS ON THREE DOOR LOCKS WERE REPLACED. BOTH SUN VISORS ON THE CAR WERE REPLACED DUE TO MALFUNCTION. THE COVER ON AUTOMATIC CAR SEAT OPERATORS KEEPS ON FALLING DOWN. THE CASSETTE PLAYER IN THE CAR WAS REPLACED DUE TO BAD DESIGN OF THE ORIGINAL PLAYER. *TR

Mileage: 102,000

2006 HYUNDAI SONATA DROOPING SUN VISOR, COMES DOWN WHILE DRIVING. HYUNDAI WILL NOT RECALL THE SUN VISOR ALTHOUGH THIS IS KNOW PROBLEM AND CAN CAUSE AN ACCIDENT. HYUNDAI IS SHIFTING THE RESPONSIBILITY OF REPAIR ONTO THE OWNER OF VEHICLE WHICH COSTS $80 PER SUN VISOR AND AN INSTALLATION OF $20 PER VISOR. BASICALLY, $200 FOR A PROBLEM THAT IS NOT THE DRIVERS FAULT, BUT A FAULTY DESIGN. *TR

Mileage: 66,000

WHILE DRIVING AT 70 MPH, I NOTICED THE WHITE LINE ON RIGHT SIDE OF ROAD CURVE SHARPLY INWARD TOWARD VEHICLE. THIS STARTLED ME. AT FIRST I THOUGHT THE ROAD CURVED, THEN IT MADE ME DIZZY. THOSE TWO FEELINGS LASTED ABOUT 5 SECONDS TOTAL, MORE THAN ENOUGH TIME TO CAUSE A SERIOUS ACCIDENT. IT TURNS OUT THE WINDSHIELD HAS VISUAL DISTORTIONS ALONG THE LOWER AND SIDE EDGES. I HAVE NOTICED THIS EFFECT IN ANOTHER SONATA AS WELL. *JS

Mileage: 100,450

MY DRIVER'S SIDE SUN VISOR BROKE AND CANNOT STAY UP. I HAVE TO PUT IT TO THE SIDE, BUT IT BLOCKS SIDE VIEW DANGEROUSLY. THIS IS A COMMON DEFECT FOR SONATA 2006-2008. THE TECHNICIAN AT THE DEALERSHIP NOTICED THE PROBLEM, BUT NEVER MENTIONED TO ME DURING WARRANTY. MANY COMPLAINTS HAVE BEEN REPORTED TO HYUNDAI HTTP://WWW.HOWTOMENDIT.COM/ANSWERS.PHP?ID=157121, BUT HYUNDAI SIMPLY IGNORES IT. *TT

Mileage: 32,000

TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT BOTH THE DRIVER AND PASSENGER SIDE SUN VISORS FRACTURED, CAUSING THEM TO FALL INTO THE DRIVER'S VIEW OF THE ROADWAY. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE VISOR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED ONE YEAR LATER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 58,000.

Mileage: 30,000

SUN VISOR WILL NOT STAY UP AND OUT OF THE WAY WHEN NOT NEEDED. VISOR FALLS DOWN INTO THE DRIVERS LINE OF VISION ALSO CREATING A CONSTANT DISTRACTION AS THE VISOR DROPS DOWN AND THE DRIVER TRIES TO MOVE IT UP OUT OF THE WAY WHILE DRIVING AND TRYING TO FOCUS ON TRAFFIC, SIGNALS, ETC. *TR

Mileage: 135,000

SUN VISOR IS NOT FOLDING UP OBSTRUCTING DRIVER VIEW AND POTENTIALLY CAUSING AN ACCIDENT. *TR

Mileage: 36,000

THE DRIVER'S SIDE SUN VISOR KEEPS FALLING DOWN AND WILL NOT STAY UP. IT IMPAIRS THE ABILITY TO DRIVE THE CAR SAFELY BY PARTIALLY BLOCKING THE WINDSHIELD AND/OR REQUIRING THE DRIVER TO DRIVE WITH ONE HAND SO THE OTHER HAND CAN HOLD UP THE VISOR. *TR

Mileage: 32,500

I OWN A 2006 HYUNDAI SONATA AND THE SUN VISOR HAS BROKEN TWICE, WHICH AFFECTS MY VIEW OF THE ROAD. THE VISOR IS UNABLE TO STAY UP AND OUT OF VIEW WHEN NOT IN USE. I'VE READ HYUNDAI ONLINE FORUMS AND IT SEEMS TO BE A RECURRING PROBLEMS WITH A LOT OF THIS MODEL AS WELL AS THE 2007 MODEL. I'VE HAD TO SLIDE OUT THE VISOR EXTENSION AND WEDGE IT BETWEEN BY REARVIEW MIRROR AND ROOF OF MY CAR, WHICH IS NOT A SAFE OPTION EITHER AS IT CAN BECOME UNWEDGED DURING DRIVING AND FALL DOWN AND BLOCK MY VIEW OF THE ROAD. IT HASN'T CAUSED AN ACCIDENT YET, BUT IT'S ONLY A MATTER OF TIME WHICH TERRIFIES ME. PLEASE HELP. *TR

Mileage: 42,000

I OWN A 2006 HYUNDAI SONATA (82K MILEAGE). THE DRIVER SIDE SEAT BELT WARNING LIGHT CAME ON AND NOW STAYS ON CONSTANTLY. BASED ON A WEB SEARCH THIS ISSUE APPEARS TO BE A COMMON PROBLEM WITH THIS MODEL AND ONE THAT IS A MAJOR SAFETY HAZARD. [THE REASON FOR THE VISIBILITY COMPLAINT, THIS VEHICLE ALSO HAD BOTH DRIVER SIDE AND PASSENGER SIDE SUNVISOR FAIL (ANOTHER SAFETY ISSUE FOR ANOTHER TIME)] I TOOK THE CAR TO A HYUNDAI DEALER WHO DID NOT CONSIDER THE PROBLEM WITHIN WARRANTY. THE DEALER DID NOTE THAT THE COST TO REPAIR COULD BE AS MUCH AS $1500.00 SINCE THE ENTIRE SEAT AND SAFETY BELT SYSTEM MAY REQUIRE REPLACEMENT. FOLLOW UP CALLS TO HYUNDAI FOUND THAT, THOUGH THERE ARE HUNDREDS AND POSSIBLY THOUSANDS OF SIMILAR COMPLAINTS, THEY HAVE ELECTED NOT TO ISSUE A RECALL RELATED TO THE PROBLEM AS THEY DID FOR THE PASSENGER SIDE. THIS IS A VERY POPULAR CAR MODEL WITH A MAJOR SAFETY ISSUE THAT NEEDS INVESTIGATION. I STRONGLY SUSPECT YOUR INVESTIGATION WILL ARRIVE AT THE SAME CONCLUSION AND WITH YOUR HELP MAYBE HYUNDAI WILL ISSUE A RECALL BEFORE SOMEONE IS FATALLY INJURED. HERE IS A WEB LINK WITH NUMEROUS SIMILAR COMPLAINTS: HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2006/HYUNDAI/SONATA/FRONTAL+AIRBAG THANK YOU IN ADVANCE FOR YOUR HELP! *TT

Mileage: 81,210

2006 HYUNDAI SONATA VISORS BOTH FAILED ONE AT A TIME REPLACED ONE FOR FREE CHARGE ME FOR OTHER RECALL ON PASSENGER SEAT AIR BAG SENSOR I HAVE RECALL PAPER THEY MAILED ME THEY REFUSE TO REPAIR IT. *TT

Mileage: 44,000

DRIVER SIDE SUN VISOR BROKE AND WILL NOT STAY UP NOW, GREATLY AFFECTING DRIVING VISION AND SAFETY. I HAD TO REMOVE THE VISOR JUST TO DRIVE THE VEHICLE AND NOW HAVE NO SUN BLOCK WHEN DRIVING THE CAR UNTIL I GET IT REPAIRED. *TR

Mileage: 106,580

MY SUN VISOR IS BROKEN AND HAS FALLEN DOWN INTO MY DRIVING LINE OF SIGHT. IT HAS ALSO FALLEN DOWN ON THE PASSENGER'S SIDE. *TR

Mileage: 65,000

HINGE ON DRIVER SIDE VISOR OF 2006 HYUNDAI SONATA GLS HAS BROKE AND VISOR NO LONGER STAYS UP. WENT TO PULL VISOR DOWN TO BLOCK SUN AND IT SNAPPED AND NOW THE VISOR JUST HANGS THERE. I HAVE TO FLIP THE VISOR BACKWARDS INTO THE BRACKET TO KEEP IT OUT OF VIEW. HAVE CONTACT DEALERSHIP AND WAS TOLD THAT I AM 4 MONTHS OUT OF MY WARRANTY AND THAT THEY WILL NOT BE ABLE TO FIX IT WITHOUT ME PAYING FOR THE REPAIRS. AFTER VIEWING MULTIPLE FORUMS, THIS SEEMS TO BE A COMMON OCCURRENCE IN THIS MAKE OF VEHICLE. I AM REALLY SURPRISED THAT THERE HASN'T BEEN A RECALL PLACED FOR THESE. THEY POSE SUCH A HAZARD IN BLOCKING ONES VIEW FROM ONCOMING TRAFFIC, STOP LIGHTS, PEDESTRIANS, ETC. CONSIDERING ALL THE ISSUES THAT HYUNDAI USED TO HAVE WITH THEIR VEHICLES, YOU WOULD THINK THAT THIS WOULD HAVE ALREADY BEEN SOMETHING THAT THEY WOULD HAVE CORRECTED AND PLACED A RECALL FOR. *TR

Mileage: 64,000

TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE SUN VISOR BROKE AND WOULD NOT STAY UP. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 90,000.

Mileage: 90,000

2006 HYUNDAI SONATA SUN VISOR ON PASSENGER SIDE BROKE AFTER 60,000 MILES AND APPROXIMATELY 5 YEARS MAKING IT JUST OUT OF WARRANTY. PASSENGER SIDE SUN VISOR NOW HANGS LOOSELY AND DOES NOT RETAIN ITS POSITION OUT OF THE WAY OF DRIVER'S VISION. VERY DIFFICULT TO SEE PROPERLY WITH THE BROKEN SUN VISOR. THIS IS DEFINITELY A SAFETY HAZARD. IN A QUICK INTERNET SEARCH, THIS IS A _VERY_ COMMON COMPLAINT FOR THE HYUNDAI 2006 - 2008 SONATAS. THIS CONDITION CAUSES REDUCED VISION TO ON COMING TRAFFIC AND PEDESTRIANS. IF HYUNDAI READS THE FORUMS, THEY ALREADY KNOW THIS IS A PRODUCT DESIGN DEFECT. IF THEY TRACK THE SERVICE INCIDENT RATE OF REPLACED SUN VISORS ON THIS MODEL, THEY WOULD ALSO KNOW THIS IS A DEFECTIVE DESIGN. THIS IS A KNOWN SAFETY HAZARD AND SHOULD BE RECALLED. *TR

Mileage: 67,000

PIECE OF PLASTIC ON SUNVISOR SUPPORT CRACKED, AND NOW IT WON'T STAY UP, IMPAIRING VISION. I ALMOST RAN THROUGH A RED LIGHT THE OTHER DAY BECAUSE IT BLOCKS THE VIEW OF TRAFFIC LIGHTS. I HAVE READ ALL THE OTHER COMPLAINTS ON THIS WEBSITE AND OTHERS, BUT YOU ARE DOING NOTHING ABOUT IT. IS THERE ANY OTHER AGENCY THAT WILL LOOK INTO THIS AND DO SOMETHING ABOUT IT? *TR

Mileage: 38,000

THE DRIVER SIDE SUN VISOR WILL NOT STAY UP AND FALLS STRAIGHT DOWN BLOCKING MY VIEW WHILE I DRIVE. *TR

Mileage: 70,000

DRIVER SIDE SUN VISOR WILL NOT STAY IN THE UP POSITION ON 2006 HYUNDAI SONATA, WHEN THE CAR WAS TAKEN TO THE DEALERSHIP THEY SAID THEY WOULD NOT COVER IT UNDER NHTSA CAMPAIGN NUMBER 06V-234 AND WE WOULD HAVE TO PAY $200 TO HAVE IT FIXED. *TR

Mileage: 25,000

DRIVER'S SIDE SUN VISOR SUDDENLY FELL DOWN DURING OPERATION OF THE 2006 HYUNDAI SONATA GLS, CAUSING DRIVER'S VISION TO BE IMPAIRED. *TR

Mileage: 81,000

TL*THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THE FRONT PASSENGER SIDE SUN VISOR INTERMITTENTLY FLIPPED DOWNWARD WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE WAS A KNOWN ISSUE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 73,000.

Mileage: 43,000

RIGHT FRONT SUN VISOR WILL NOT STAY UP. FALLS DOWN AND PASSENGER CAN NOT SEE. *TR

Mileage: 20,000

TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE DRIVER AND PASSENGER SIDE SUN VISORS WOULD CONTINUOUSLY FALL FROM THE UPRIGHT POSITION, BLOCKING THE DRIVER AND PASSENGERS VISIBILITY OF THE ROADWAY. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THERE WAS NOTHING THEY COULD DO TO ASSIST. THE MANUFACTURER WAS ALSO CONTACTED WHO PROVIDED NO ASSISTANCE. THERE WERE NO REPAIRS TO THE VEHICLE. THE FAILURE MILEAGE WAS 88,900.

Mileage: 88,900

BOTH SUNVISORS WILL NOT STAY UP AND WILL FALL. THIS CAUSES LINE OF SIGHT BLOCKAGE AND A SAFETY HAZARD. *TR

Mileage: 50,000

THE DRIVER'S SIDE VISOR ON MY 2006 HYUNDAI SONATA GLS WON'T STAY UP ANYMORE. IT FLOPS DOWN AND IMPAIRS MY ABILITY TO SEE WHILE I'M DRIVING. I'VE DONE SOME RESEARCH ON THE FORUMS AND FOUND THAT HYUNDAI SONATAS SEEM TO BE HAVING THIS PROBLEM. *TR

Mileage: 53,000

TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. WHILE DRIVING APPROXIMATELY 65 MPH, THE DRIVER SIDE SUN VISOR FELL OPEN AND WOULD NOT REMAIN SHUT. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE FAILURE WHERE THE DEALER ADVISED THAT THE SUN VISOR WOULD NEED TO BE REPLACED. THE PART NEEDED FOR REPAIRS WAS NOT READILY AVAILABLE AND THE DEALER ADVISED THAT THE REPAIR COSTS WOULD BE APPROXIMATELY $100, INCLUDING LABOR. THE CONTACT DECLINED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 72,000 AND THE CURRENT MILEAGE WAS 72,466. UPDATED 05/05/11*LJ UPDATED 05/16/11

Mileage: 72,000

2006, 2007, 2008, HYUNDAI SONATAS. SUNVISOR FAILS TO REMAIN IN POSITION OR PLASTIC ARM COVER BREAKS CAUSING THE SUNVISOR TO NOT STAY IN THE UPWARD POSITION. THIS IS A SAFETY ISSUE. WHILE ON A TRIP THE SUNVISOR FAILED TO REMAIN UPRIGHT IMPAIRING ROAD VISION. THERE HAVE BEEN THREE TSB BULLETINS REGARDING THE SONATA SUNVISORS. THE PROBLEM PERSISTS AND THE INTERNET IS LOADED WITH CUSTOMER COMPLAINTSREGARDING RECENT FAILURES OF THE SUNVISOR TO REMAIN IN POSITION. *TR

TL*THE CONTACT OWNS A 2006 HYUNDAI SONATA WITH A WEBASTO HOLLANDIA SUNROOF, MODEL NUMBER 6230137. THE CONTACT SPOKE WITH THE MANUFACTURER IN DECEMBER AND WAS INFORMED THAT THEY WOULD BE CONTACTED WITHIN THIRTY DAYS TO HAVE THE SUNROOF ON THE VEHICLE REPAIRED ACCORDING TO RECALL 10E038000 (VISIBILITY: SUNROOF ASSEMBLY. THE CONTACT NEVER RECEIVED A CALL BACK. THE VIN WAS UNAVAILABLE.

Mileage: 80,000

BROKEN VISOR. WILL NO LONGER STAY IN UP RIGHT POSITION CAUSING RESTRICTED VISION FOR THE DRIVER. SAFETY HAZARD. *TR

1. EVENTS LEADING UP TO THE FAILURE: COMMON USE OF ROTATING THE SUN VISOR UP AND DOWN TO BLOCK THE SUN. 2. THE FAILURE: THE VISOR FAILS TO STAY IN PLACE AND HANGS DOWN "FREE-SWINGING" OBSTRUCTING BETWEEN 25% AND 45% OF THE DRIVERS VIEW DEPENDING ON HEIGHT OF THE DRIVER. IN MY CASE- THE VISOR HANGING DOWN DISTRACTS 40% OF MY VIEW THROUGH MY WINDSHIELD AND I AM 5'10". IF LEFT IN ITS CURRENT CONDITION, IT IS GOING TO PLAY A MAJOR PART IN VEHICLE ACCIDENTS. THIS IS A COMMON PROBLEM AMONG SONATA'S FOR 2006. MY DEALERSHIP EVEN ADMITTED TO IT WHEN I WENT IN TO SEE ABOUT GETTING IT REPAIRED 3 YEARS AGO. 3. CORRECTION OF FAILURE- UNHINGE THE VISOR AND SHOVE IT INTO THE BRACKET BACKWARDS HOPING THAT IT DOESN'T FALL, BUT USUALLY DOES ON ANY SORT OF AGGRESSIVE BRAKING OR ACCELERATING. THE DEALERSHIP TOLD ME IT WOULD COST OVER $300 TO REPAIR. THIS HAPPENED OVER 3 YEARS AGO. THIS IS A MAJOR SAFETY HAZARD THAT IS GOING TO PLAY A MAJOR FACTOR IN WRECKS. YOU CAN FIND OTHER COMPLAINTS ALL OVER THE INTERNET AND NOTHING DONE ABOUT IT. I CAN PROVIDE PICTURES TO ESTABLISH EVIDENCE OF THE PROBLEM. *TR

Mileage: 48,000

TL*THE CONTACT OWNS 2006 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH OR MORE THE DRIVERS SIDE SUN VISOR WOULD NOT STAY IN PLACE AND IT CONTINUED TO FALL DOWN. THE VEHICLE WAS TAKEN TO THE DEALER PREVIOUSLY WHO REPLACED THE SUN VISOR AND THE REPLACEMENT VISOR ALSO FAILED. THE PREVIOUS SUN VISOR WAS REPAIRED UNDER WARRANTY AND THE RECENT REPAIR WILL COST OVER $100. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER FOR THE REPAIRS AND THEY MIGHT REIMBURSE HER AFTER THE REPAIRS WERE MADE. THE CONTACT STATED THAT SHE WILL NOT PAY THE REPAIR COST. THE FAILURE MILEAGE WAS 61,000. UPDATED 04/15/11*LJ UPDATED 09/19/11

Mileage: 61,000

THE DRIVER SIDE SUN VISOR BROKE WHILE DRIVING ON RT3 TO BOSTON BLOCKING VISION IN HEAVY TRAFFIC. *TR

Mileage: 80,100

2006 HYUNDAI SONATA THE DRIVER AND PASSENGER SUN VISOR FALLS STRAIGHT DOWN BLOCKING YOUR VIEW OF THE ROAD. GOING 65 MPH YOU TEND TO PANICK WHEN THIS HAPPENS. IF THIS IS NOT A SAFETY ISSUE I DON'T KNOW WHAT IS. I KNOW OF TWO OTHER OWNERS WITH THE SAME PROBLEM. I REMOVED MY VISOR WHICH CAUSES ANOTHER SAFETY PROBLEM (THE SUN). *TR

Mileage: 77,000

THE DRIVERSIDE SUNVISOR CRACKED DURING NORMAL USAGE. THIS IS AFTER VERY LOW USAGE. THE BROKEN SUNVISOR WOULD NO LONGER FOLD UP FLUSH WITH THE ROOF AND WILL LOWER ITSELF WHEN GOING OVER BUMPS AND POTHOLES. THIS IS A DISTRACTION TO THE DRIVER AT UNEXPECTED TIMES AND COULD DROP TO THE POINT OF BLOCKING THE VISION OF THE DRIVER FOR A SHORT PERIOD UNTIL THE DRIVER LOWERS THEIR EYES TO SEE BELOW THE VISOR . THE SUNVISOR WAS IMMEDIATELY REPLACED AS IT INTERFERED WITH SAFE DRIVING AND IT COULD NOT BE REPAIRED. *LN

Mileage: 60,276

THE PASSENGER SIDE SUNVISOR CRACKED DURING NORMAL USAGE, THIS IS A FEW YEARS AFTER THE SAME THING HAPPENED WITH THE DRIVER SIDE SUNVISOR. BOTH VISORS HAD VERY LITTLE USAGE AND WERE NEVER USED OTHER THEN TO BLOCK THE SUN WHEN IT WAS IN THE PASSENGERS OR DRIVERS EYES WHICH WAS AT MOST 2 OR 3 TIMES A MONTH. THE BROKEN SUNVISOR NO LONGER WILL FOLD UP FLUSH WITH THE ROOF AND STAYS DROOPING AND WHEN GOING OVER ANY BUMPING MOTION WILL LOWER ITSELF. THIS IS A DISTRACTION TO THE DRIVER AT UNEXPECTED TIMES AND CAUSES THE DRIVER TO REACH OVER AND PLACE IT UP AS FAR AS POSSIBLE SO THAT VISIBILITY ISN'T REDUCED. THE SUNVISOR HAD TO BE REPLACED AS IT COULD NOT BE REPAIRED NOR WAS IT SAFE TO DRIVE KNOWING THAT IT MIGHT DROP DOWN. *LN

Mileage: 78,138

2006 HYUNDAI SONATA DRIVER'S SIDE SUN VISOR FALLS AND WON'T STAY UP. IT OBSTRUCTS DRIVER'S VIEW CREATING A REAL SAFETY PROBLEM. THIS IS A RECURRING PROBLEM WITH A GREAT NUMBER OF SONATAS AND JUST REPLACING THE VISOR WITH A NEW ONE DOESN'T FIX IT PERMANENTLY. THERE IS A LARGE DISCUSSION AT: HTTP://WWW.HOWTOMENDIT.COM/ANSWERS.PHP?ID=157121. *TR

Mileage: 80,000

BOTH SUN VISORS HAVE CRACKED IN THE AREA THAT HOLDS THEM STABLE THEY WILL NOT STAY UP ON THEIR OWN. 2006 HYUNDAI SONATA. *TR

Mileage: 78,000

DEC 22 2010 BOTH MY AIRBAG LIGHTS CAME ON DRIVE SIDE STAYS ON THE PASSENGER SIDE FLASHES OFF AND ON AND THE PASSENGER SIDE VISOR DOESN'T NOT STAY UP ALREADY HAD THE DRIVE SIDE VISOR REPLACED BECAUSE OF THE SAME REASON IT WOULDN'T STAY UP. *TR

Mileage: 91,337

DRIVER SIDE VISOR CRACKED & DOES NOT STAY UP, BLOCKING VISION. *TR

TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE DRIVER AND PASSENGER SUN-VISORS WERE DEFECTIVE AND WOULD CONTINUOUSLY FALL DOWNWARD WHILE DRIVING, BLOCKING THE CONTACTS VIEW OF THE ROADWAY. THE CONTACT STATED THAT WHEN THE SUN-VISOR WOULD FALL, HE WOULD HAVE TO REMOVE ONE HAND FROM THE STEERING WHEEL AND HOLD IT ON THE SUN-VISOR TO KEEP IT FROM BLOCKING HIS VISION. THE DEALER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS CONCERNED WITH THE POSSIBILITY OF THE FAILURE POTENTIALLY CAUSING A CRASH. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 195,000.

Mileage: 110,000

WHEN THE SUN VISOR WAS PULLED DOWN THE PLASTIC ATTACHMENT CRACKED. THE SUN VISOR DOES NOT STAY UP ANYMORE. *TR

Mileage: 62,000

TL*THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE SUN VISOR FLIPPED DOWN IMPAIRING HER VISION WHILE DRIVING. THE DEALER WAS CONTACTED AND WAS AWARE OF THE ISSUE. THE MANUFACTURER WAS NOTIFIED AND DIRECTED THE CONTACT TO NHTSA. THE VEHICLE WAS REPAIRED BY A LOCAL MECHANIC. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 26,000. UPDATED 02/01/11*LJ THE CONSUMER ALSO STATED THE WINDSHIELD NEEDED TO BE REPLACED DUE TO IT HAVING SPIDER CRACKS AND CHIPS. UPDATED 03/21/11

Mileage: 26,000

I HAVE A 2006 HYUNDAI SONATA THAT HAS SUN VISORS THAT DO NOT STAY IN PLACE. IT JUST RECENTLY STARTED. AT FIRST THE VISORS WOULD SLIP AND I WOULD MOVE THEM BACK INTO PLACE. THEN A WEEK OR SO AGO BOTH VISORS HAVE STARTED THIS. THIS IS A HUGE DRIVING/SAFETY HAZARD. THE ROADSIDE ISSUES ARE TOO NUMEROUS TO NAME. I CANNOT BELIEVE HYUNDAI WILL NOT RECALL THE CARS WITH THIS PROBLEM. THERE ARE TOO MANY CARS WITH THE IDENTICAL PROBLEM. I HAVE SINCE APPLIED LIBERALLY SUPER GLUE TO THE ROLLERS ON THE VISOR ITSELF. FOR NOW, THE VISORS STAYS IN PLACE. I WILL HAVE TO LIFT EACH VISOR OUT TO MOVE IT INTO ANOTHER POSITION,EVEN THE SLIGHTEST MOVE WOULD SEEM TO BREAK THE SEAL THE GLUE HAS MADE. I WILL CARRY SOME SUPER GLUE WITH ME FOR NOW. BUT FOR NOW, THE VISORS ARE UP AND OUT OF THE WAY. I AM VERY DISAPPOINTED IN HYUNDAI CORP FOR NOT ADDRESSING THIS PROBLEM. *TR

Mileage: 65,000

I HAVE A 2006 HYUNDAI SONATA. BOTH DRIVER AND PASSENGER VISORS HAVE BROKE WHEN BEING PROPERLY USED. ON THE DRIVER ONE, THERE WAS A CRACKING SOUND AND A PIECE OF PLASTIC BROKE OFF THE CORNER OF THE VISOR. BOTH VISORS DO NOT STAY IN THEIR NON-USED OR USED POSITIONS. THE VISORS FALL IN THE SIGHT OF DRIVING AND CAN ONLY BE HELD UP BY OTHER MEANS, SUCH AS VELCRO, WHICH IS NOT EFFECTIVE. I AM UNABLE TO USE MY VISORS AT ALL BECAUSE I AM FORCED TO HAVE THEM PERMANENTLY MODIFIED IN THE UNUSED POSITION. WHEN IN USE, THE EDGE OF THE VISOR RESTS AT FOREHEAD LEVEL MAKING IT EVEN MORE OF A HAZARD, NOT JUST BECAUSE OF LACK OF SIGHT, BUT BECAUSE OF THE FEAR OF GETTING IN A CAR ACCIDENT AND HAVING THE VISOR IMPALE THE DRIVER'S OR THE FRONT SEAT PASSENGER'S HEAD. I HAVE CONTACTED THE DEALERSHIP REGARDING THIS ISSUE AND WAS TOLD THAT MY WARRANTY DOES NOT COVER THEM AND THAT THERE IS NOT A RECALL ON THEM. AFTER READING REPORT AFTER REPORT OF OTHER 2006/2007 HYUNDAI SONATA OWNERS, IT BAFFLES ME THAT NOTHING HAS BEEN DONE. *TR

Mileage: 55,000

SUN VISORS BROKEN. WILL NOT STAY UP. THIS IS A WELL KNOWN HYUNDAI SAFETY ISSUE. *TR

Mileage: 60,000

2006 HYUNDAI SONATA LX. BROKEN DRIVER SIDE SUN VISOR. PLASTIC CRACKED WHERE THE METAL ROD ON THE VISOR MOUNTS INTO THE SWIVEL ARM. CRACKED WHEN RAISING THE VISOR. NOW VISOR SLOWLY FALLS AND OBSTRUCTS VIEW WHENEVER DRIVING. FAULTY PLASTIC COMPONENT ON THE VISOR. *TR

Mileage: 75,650

SUN VISOR ON 2006 HYUNDAI / SONATA DOES NOT STAY UP. IT IS KEEP ON FALLING. I HAD IT REPLACED WHILE IT WAS UNDER WARRANTY AND IT'S BROKE AGAIN AND IT'S NOT UNDER WARRANTY ANY LONGER. I SEE MANY OTHER SIMILAR ISSUE WITH SAME MODEL. THIS WOULD BE SAFETY ISSUE WHEN THE VISOR FALLS WHILE DRIVING. HYUNDAI SHOULD DO A RECALL ON THIS RIGHT AWAY. *TR

Mileage: 67,000

1. RECENTLY MY VISORS STOPPED STAYING IN THE UP POSITION. 2. THE FAILURE TO STAY UP IS CONSTANT. MY VISION IS SEVERELY OBSCURED WHILE DRIVING. MY SAFETY HAS BEEN SEVERELY COMPROMISED. 3. NO REPAIRS MADE. HYUNDAI WANTS ME TO PAY OUT OF POCKET FOR THIS VERY OBVIOUS FACTORY DEFECT. *TR

2006 HYUNDAI SONATA AND BOTH SUN VISORS HAVE BROKEN AND WILL NOT STAY INT THE UPRIGHT POSITION. ACCORDING TO WHAT I HAVE READ ONLINE, THIS IS A MAJOR PROBLEM WITH ALL HYUNDAI MODELS. *TR

Mileage: 63,000

1. HYUNDAI SONATA 2006 SUN VISOR DID NOT STAY IN FULLY FOLDED OR EXTENDED POSITION. 2. TRIED TO MOVE SUN VISOR TO FULLY FOLDED POSITION AND HEARD CRACKING SOUNDS AND SUN VISOR JUST HANGS LOOSE (STRAIGHT DOWN) BLOCKING ROAD FIELD OF VISION 3. I USED SHOE STRING TO TIE SUN VISOR TO SAFETY HANDLE ABOVE DOOR TO KEEP IT FROM OBSTRUCTING VIEW OF ROAD. UNFORTUNATELY IF VISOR IS TIED IT IS NOT FREE TO MOVE INTO FULLY EXTENDED POSITION TO SHIELD SUN WHILE DRIVING WHICH IS ALSO A VISIBILITY HAZARD. I REMOVED THE VISOR AND TOOK APART BROKEN HINGE TO FIND CRACK PLASTIC BUSHING AROUND ROD WHICH ALLOWS ROTATION OF SUN VISOR. SINCE THE THIN PLASTIC BUSHING WAS CRACKED/BROKE INTO PIECES THE VISOR DOES NOT HOLD SPECIFIED POSITIONS. AN ONLINE FORUM SHOWS NUMEROUS CONSUMERS WITH THE SAME PROBLEM AND THEY REPLACE THE SUN VISOR FOR IT TO JUST BREAK AGAIN. THIS PART IS NO LONGER COVERED UNDER MY WARRANTY, BUT I DO NOT WANT TO BUY A NEW PART(~$100) THAT IS MANUFACTURED THE SAME AS THE ONES THAT BREAK EASILY, JUST SO I'LL HAVE TO BUY ANOTHER REPLACEMENT SUN VISOR AGAIN. A THIN PLASTIC BUSHING AROUND A METAL ROD THAT IS LOADED FREQUENTLY IS PRONE TO STRESS FRACTURES AND FAILURE. NUMEROUS INCIDENCES OF THIS DEFECT SHOULD PROMPT A NEW DESIGN AND FREE REPLACEMENT PARTS FOR CONSUMERS SINCE THIS IS A DRIVING VISIBILITY HAZARD. *TR

Mileage: 633,000

TL*THE CONTACT OWNS A 2006 HYUNDAI SONATA. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH, THE DRIVER SIDE SUN VISOR WOULD NOT REMAIN IN A SECURED POSITION. THE SUN VISOR EXHIBITED A CRACK AND WAS SECURED WITH TAPE TO AVOID OBSTRUCTION IN THE VISIBILITY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. THE VIN WAS UNAVAILABLE.

Mileage: 70,000

I WAS DRIVING MY 2006 HYUNDAI SONATA IN EARLY MORNING. SUN WAS BRIGHT SO PULLED DOWN SUNVISOR. HEARD A CRACKING SOUND, A PIECE OF PLASTIC FELL ON MY LAP, AND NOW THE SUNVISOR WILL NOT STAY IN POSITION. IT JUST HANGS STRAIGHT DOWN, BLOCKING VIEW. *TR

Mileage: 55,000

THE SUN VISORS ON BOTH DRIVER AND PASSENGER SEATS DON'T STAY. THEY ARE FLOPPY AND IT BLOCKS THE DRIVER'S SIGHT. IT'S NOT UNDER WARRANTY ANY LONGER, SO I USED TAPES TO HOLD THEM. PLEASE NOTE THAT THE SUN VISOR ON THE DRIVER'S SIDE WAS FIXED ONCE WHILE I HAD A WARRANTY AND NOW IT HAPPENED AGAIN ON BOTH SIDES SEAT. *TR

Mileage: 65,000

2006 HYUNDAI SONATA SUNVISOR - I JUST REPLACED MY FOURTH SUNVISOR AT $81 A PIECE AND $20 TO INSTALL IT HAS BECOME VERY COSTLY. THERE SHOULD BE A RECALL ON THIS ITEM IT IS DANGEROUS BECAUSE IT DOES BLOCK THE VIEW OF THE DRIVER. *TR

BOTH OF MY CAR VISORS HAVE BROKEN OFF. THE FIRST WAS REPLACED BY THE DEALER BECAUSE THE CAR WAS UNDER WARRANTY, BUT THIS TIME I WOULD HAVE TO PAY FOR IT BECAUSE THE WARRANTY EXPIRED. THIS HAS HAPPENED TO OTHER PEOPLE I KNOW THAT HAS THE SAME CAR. IT IS A MANUFACTURING DEFECT THAT POSES A RISK ON THE DRIVERS. THE VISOR STAYS HALF WAY, WHICH AFFECTS THE VISIBILITY OF THE DRIVER. TO BE ABLE TO SEE, YOU HAVE TO MANUALLY MOVE THE VISOR BACK AND FORTH WHILE DRIVING, WHICH CAUSES THE RISK TO GET INTO AN ACCIDENT. *TR

Mileage: 63,000

I HAVE A 2006 HYUNDAI SONATA. THIS CAR HAS A KNOWN HISTORY OF THE SUNVISORS BREAKING OR NOT STAYING UP WHILE NOT BEING USED. AT FIRST THE PASSENGER SIDE FAILED ON ME AFTER TRYING SEVERAL ATTEMPTS AT KEEPING IT IN THE CORRECT POSITION. NOW THE DRIVERS SIDE IS DOING THE SAME THING. I CAN MOVE THE VISOR TO THE SIDE BUT THIS CAUSES LOSS OF SIGHT TO MY SIDE WHEN DRIVING WHICH COULD PROVE TO BE DANGEROUS. AFTER RESEARCHING THE WEB IT SEEMS MANY OWNERS WITH THE SAME CAR HAVE HAD PROBLEMS AND THEY ARE VERY EXPENSIVE TO COVER OUT OF WARRANTY. MY COMPLAINT IS THAT THE SAME THING WILL CONTINUE AND COST A LOT OF MONEY TO KEEP REPAIRING. *TR

Mileage: 98,000

DRIVER'S SIDE SUN VISOR BROKE/CRACKED AND WILL NOT STAY UP ANYMORE, BLOCKS MY VISION. *TR

Mileage: 63,950

BOTH SUN VISORS IN MY 2006 HYUNDAI SONATA BROKE WITHOUT WARNING. THEY BOTH FLOP DOWN AND WON'T STAY UP. I TOOK THEM APART AND FOUND THAT THE PLASTIC FRICTION-SLEEVE AROUND THE METAL HANGER HAS BROKEN ON EACH ONE. THE FLOPPED-DOWN VISORS RESTRICT THE DRIVER'S VISION AND THEIR MID-WAY POSITION BETWEEN THE WINDSHIELD AND THE INTERIOR OF THE VEHICLE MAKES RE-FOCUSING ONE'S EYES BETWEEN THE OUTSIDE AND THE INSIDE OF THE CAR PROBLEMATIC. MY CAR IS OUT OF WARRANTY SO I HAVE NOT HAD THE VISORS REPLACED. INSTEAD, I PUT STRIPS OF VELCRO ON THE ROOF AND ON THE VISORS TO KEEP THEM UP. *TR

Mileage: 50,000

DRIVER SIDE VISOR CAME DOWN UNEXPECTEDLY WHILE DRIVING ON HIGHWAY AND AFTER HITTING A BUMP ON THE ROAD. FORWARD VISIBILITY IMMEDIATELY BLOCKED. VISOR WOULD NOT GO BACK TO POSITION; FUMBLED WITH IT AND HELD IT UNTIL GETTING OFF HIGHWAY AND ONTO A SURFACE ROAD. *TR

Mileage: 60,000

LIGHTS ACROSS INSTRUMENT CLUSTER WILL NOT GO OFF INCLUDING: ESC OFF, CHECK ENGINE, AIRBAGS AND ABS. THERE IS ALSO A VISIBILITY ISSUE REGARDING THE SUN VISOR ON THE DRIVER SIDE. THESE ARE ALL ISSUES THAT I HAVE SEEN MANY OTHER PEOPLE ARE HAVING AS WELL AND ARE POTENTIALLY DANGEROUS. *TR

I HAVE A 2006 HYUNDAI SONATA AND I HAVE REPLACED THE DRIVERS SIDE SUN VISOR 2 TIMES THUS FAR. THE FIRST ONE WAS COVERED UNDER WARRANTY BUT THE 2ND ONE WASN'T. NOW IT HAS BROKE FOR THE 3RD TIME AND IT SEEMS LIKE THIS IS A SAFETY CONCERN SINCE IT WILL NOT STAY UP. *TR

Mileage: 97,000

THE SUN VISOR ON MY 2006 HYUNDAI SONATA WILL NOT STAY IN THE 'UP' POSITION. IT HAS STARTED TO HANG IN A POSITION WHERE IF I MOVE MY HEAD FORWARD I CAN HIT IT WITH MY FOREHEAD. IT ALSO BLOCKS VISION IN FRONT. I HAVE ALREADY HAD ONE REPLACED ABOUT 2 YEARS AGO AND NOW IT IS BROKEN AGAIN. I THINK THERE IS A MANUFACTURING DEFECT IN THIS. I DID AN INTERNET SEARCH ON THIS ISSUE APPARENTLY LOTS OF PEOPLE HAVE HAD THIS ISSUE. *TR

Mileage: 73,000

DRIVER VISOR WILL NOT STAY UP. OUT OF WARRANTY, AND IS NOW NOT COVERED. WILL HAVE TO PAY FOR A NEW ONE. BLOCKS VISION, EITHER SIDE OR FRONT. VERY FRUSTRATING AND A DANGER TO OTHERS AS WELL AS THE PASSENGERS IN THE VEHICLE. COULD POTENTIALLY CAUSE AN ACCIDENT. NOT FIXABLE, ONLY CAN REPLACE AT $100. *TR

Mileage: 99,560

THE DRIVER'S SIDE VISOR WILL NOT STAY IN THE 'UP' POSITION OR IN THE FULLY EXTENDED POSITION (CLOSEST TO THE WINDSHIELD). IT FALLS OVER TIME, ENDING UP EITHER POKING YOU IN THE HEAD (IF IT WAS RESTING AGAINST THE CEILING) OR HANGING STRAIGHT DOWN (IF IT HAD BEEN FULLY EXTENDED). THIS REALLY IS A SAFETY HAZARD! *TR

Mileage: 60,000

THE DRIVER'S SIDE SUN VISOR ALL OF A SUDDEN JUST DROPPED DOWN AND IMPAIRED MY VISION. THIS IS EXTREMELY DANGEROUS AND EASILY COULD HAVE LED TO AN ACCIDENT. HYUNDAI NEEDS TO RECALL THESE DEFECTIVE VISORS IMMEDIATELY TO AVOID INJURY OR DEATH TO THOSE WHO WILL CERTAINLY BE INVOLVED IN ACCIDENTS CAUSED BY THIS DEFECTIVE PART. *TR

Mileage: 13,420

2006 SONATA DRIVER & PASSENGER VISORS FAILURE. WE ARE NOW NEEDING THE 4TH VISOR THAT WON'T STAY UP. DEALER WON'T COVER IT AS VEHICLE IS OVER THE INITIAL WARRANTY PERIOD. WAS TOLD BY THE DEALER WHEN THE 2ND ONES BROKE, THAT HYUNDAI HAD CORRECTED THE MANUFACTURING DEFECT - DON'T THINK SO. THIS IS A SAFETY ISSUE AS THE VISOR IS ANGLED IN AN UNSAFE POSITION WHEN BROKEN TO THE OCCUPANT. *TR

Mileage: 66,000

THE PASSENGER SIDE SUN VISOR WILL NOT STAY IN THE 'UP' POSITION OR IN THE FULLY EXTENDED POSITION (CLOSEST TO THE WINDSHIELD). THE VISOR BLOCKS MY VISION AND THE PASSENGER'S VISION WHILE DRIVING. *TR

Mileage: 72,000

DRIVER'S SIDE AND PASSENGER SIDE SUN VISOR WILL NOT STAY IN THE UP POSITION. KEEPS FALLING DOWN WHILE DRIVING. *TR

Mileage: 90,000

2006 HYUNDAI SONATA SUN VISOR. I HAVE HAD THIS REPLACED NUMEROUS TIMES ON MY CAR. IT WILL CATASTROPHICALLY FAIL WHILE DRIVING DOWN THE ROAD. LAST TIME WAS IN TRAFFIC ON THE FREE WAY. HAD TO PUT CAR INTO DITCH TO AVOID HITTING ANOTHER VEHICLE. 4,000 MILES OUT OF WARRANTY AND HYUNDAI WONT REPLACE. *TR

Mileage: 64,000

THE SUN VISORS ON BOTH SIDES WILL NOT STAY UP. THIS IS ALSO THE CASE FOR MY NEIGHBOR-WHICH HAS A 2006 SONATA AS WELL. IT IMPAIRS VISION WHILE I'M DRIVING AND HITS PASSENGERS IN THE HEAD. I HAVE REPLACED THEM ONCE- AT $125 EACH- ONLY TO HAVE THE SAME THING HAPPEN A YEAR LATER. *TR

THE SUN VISORS BREAK AND DON'T STAY UP CLOSE TO THE CEILING. THEY FALL DOWN AND OBSTRUCT VISION. *TR

Mileage: 69,500

I HAVE A 2006 HYUNDAI SONATA. THE DRIVER SIDE SUN VISOR IS BROKEN AND FALLS DOWN INTO MY LINE OF VISION ALL THE TIME. I HAVE ALMOST HAD MORE THAN ONE ACCIDENT WHEN IT HAPPENS UNEXPECTEDLY. *TR

Mileage: 40,000

HYUNDAI SONATA GLS DRIVER SIDE SUN VISOR DROPS DOWN AND CANNOT BE RETURNED TO POSITION BLOCKING DRIVERS LINE OF SIGHT. *TR

Mileage: 66,000

I AM THE ORIGINAL OWNER OF A 2006 HYUNDAI SONATA. THE DRIVER SIDE SUN VISOR RECENTLY BROKE. MY UNDERSTANDING FROM INFORMATION I RECEIVED FROM THE DEALER AND REPORTS THAT I HAVE SEEN ON THE INTERNET THIS IS A WIDE SPREAD PROBLEM. I BELIEVE THE 2008 SONATA HAD A RECALL FOR THE SAME ISSUE. HYUNDAI SHOULD BE FORCED TO RECALL AND CORRECT THE APPARENT DEFECT WITH THE SUN VISORS. I HAVE EVEN HEARD OF REPORTS FROM PEOPLE WHO HAVE ALREADY HAD THEIR VISORS REPLACED THAT THE REPLACEMENTS HAVE ALSO BROKEN. IT MAKES FOR VERY UNSAFE DRIVING CONDITIONS BECAUSE WHEN THE VISOR HANGS DOWN, YOUR VISION IS IMPAIRED. EVEN WHEN YOU PUSH IT TO THE SIDE, YOUR VISION IS PARTIALLY BLOCKED. WHAT OTHER RECOURSE DO CONSUMERS HAVE TO ENSURE THE MANUFACTURERS ARE SELLING MERCHANTABILITY GOODS. WE AS CONSUMERS HAVE NO WAY OF INSPECTING THE SUN VISOR MECHANISMS TO KNOW IF THEY ARE WORKING OR WILL WORK PROPERLY WHEN A CAR IS PURCHASED. *TR

Mileage: 73,000

TL*THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE SUN VISORS ON THE DRIVER AND PASSENGER SIDE FELL DOWN. THE CONTACT AND PASSENGERS HAVE HIT THEIR HEADS ON THEM AND THE DRIVERS SIDE VISOR ALSO FELL DOWN IN FRONT OF THE DRIVERS FACE, OBSCURING HER VISION WHILE OPERATING THE VEHICLE. HYUNDAI WAS NOT NOTIFIED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 66,000. UPDATED 11/05/10. LJ UPDATED 12/29/10*JB

Mileage: 66,000

THE DRIVERS SIDE SUN VISOR WILL NOT STAY IN PLACE. KEEPS FALLING DOWN OR WILL ALWAYS BE DOWN IN FIELD OF VISION. *TR

Mileage: 56,000

THE DRIVER'S SIDE SUN VISOR ON MY VEHICLE BROKE AND WILL NOT STAY UP. IT HANGS IN FRONT OF THE DRIVER'S VISION NOW. I CALLED THE DEALER AND THEY SAID THE PART COSTS $101. HOWEVER, IT IS AVAILABLE. *TR

Mileage: 101,303

THE DRIVER SIDE SUN VISOR DOES NOT STAY IN THE FIXED POSITION. INSTEAD IT HANGS AT A 45 DEGREE ANGLE OBSCURING THE DRIVER'S VIEW. *TR

Mileage: 77,000

HYUNDAI SONATA, 2006 MODEL - DRIVER'S SIDE SUNVISOR DROPPED DOWN AND WILL NOT STAY IN PLACE, BLOCKING THE VIEW OF THE ROAD. *TR

I OWN A 2006 HYUNDAI SONATA 6 CYL, MADE IN THE USA, AND I AM HAVING A PROBLEM WITH MY DRIVER SIDE SUN VISOR, IT STARTED TOWARD THE END OF MY WARRANTY, OF 60,000 MI., AND I INTENDED TO TAKE IT TO A DEALER, BUT HAD TO MAKE SEVERAL TRIPS TO COLUMBUS OHIO AND PUT MILEAGE ON IN EXCESS OF THE 60000 MIL. I NOW HAVE ABOUT 65000 MI. ON THE CAR. I TOOK IT BACK TO A DEALER AND THEY SAID IT WAS OUT OF WARRANTY AND THEY WOULD NOT FIX IT. I BELIEVE THIS IS A SERIOUS SAFETY ISSUE, BECAUSE I ALMOST CAUSED A SERIOUS ACCIDENT GOING TO COLUMBUS ON MY LAST TRIP WHEN A CAR CUT ME OFF AT AN EXIT ON I-75 AND IN THE MIDST OF TRYING TO MAINTAIN CONTROL OF MY CAR, THE SUN VISOR DROPPED ALL THE WAY DOWN AND I LOST CONTROL AND RAN ONTO THE SOFT SHOULDER OF THE EXIT RAMP; HAD IT NOT BEEN FOR AN ALERT DRIVER BEHIND ME, I COULD HAVE BEEN KILLED. THE PROBLEM WITH THE SUN VISOR IS A DESIGN FLAW IN THE SPRING DESIGN WHICH HOLDS THE VISOR IN POSITION IT FAILS AND EXPRESSES IT'S FAILURE IN THAT GOING OVER A BUMP OR STOPPING SUDDENLY CAUSES IT TO DROP TO ITS FULL DOWN POSITION INTERFERING WITH DRIVER VISIBILITY; AND I DON'T THINK SAFETY EQUIPMENT SHOULD BE WARRANTEED ONLY TO THE FIRST PERIOD OF WARRANTY BUT FOR A REASONABLE LIFE OF THE VEHICLE. I HAVE FOUND OVER 75 PEOPLE ON LINE WHO HAVE THE SAME PROBLEM WITH THE SAME MAKE AND MODEL OF HYUNDAI. PLEASE CHECK OUT THE INTERNET COMPLAINTS AND YOU WILL SEE FOR YOURSELF. *TR

Mileage: 63,000

2006 V6 HYUNDAI SONATA DRIVER SIDE SUN VISOR BROKEN. WILL NOT HOLD POSITION. *TR

Mileage: 80,000

I HAVE A 2006 SONATA AND WENT TO MOVE THE DRIVER'S SIDE VISOR TO BLOCK THE SUN TODAY, HEARD A LOUD CRACK, AND THE PLASTIC HOUSING (THAT APPARENTLY HOLDS THE VISOR IN PLACE) AROUND THE METAL BAR CRACKED AND BROKE. I WAS DRIVING WHILE THIS HAPPENED AND NOW IT JUST HANGS THERE IN THE WAY- HOW DANGEROUS! I TRIED GLUING THE BROKEN PIECE BACK ON, BUT IT DIDN'T HELP. NOW I'VE GOT IT VELCROED UP AND CAN'T USE IT! C'MON HYUNDAI - TAKE SOME RESPONSIBILITY HERE AND FIX WHAT IS OBVIOUSLY A VERY COMMON, AND DANGEROUS, PROBLEM!! *TR

Mileage: 64,200

2006 HYUNDAI SONATA GLS DRIVERS SIDE SUN VISOR BROKE AND WON'T STAY UP. *TR

Mileage: 70,000

BOTH SUN VISORS ARE BROKEN. THEY DO NOT REMAIN IN THE UPWARD POSITION, BUT FALL AND BLOCK VISION. *TR

Mileage: 62,000

2006 HYUNDAI SONATA DRIVERS SIDE SUN VISOR BROKE AND IMPAIRS DRIVERS VISION AND HEAD MOVEMENT. *TR

Mileage: 58,500

BOTH DRIVER & PASSENGER SUN VISORS DO NOT STAY IN PLACE. THEY FALL DOWN. *TR

2006 HYUNDAI SONATA SUNVISORS FAIL TO STAY UP AFTER BEING ADJUSTED, CAUSING A LOSS OF FORWARD VISION. THIS IS A COMMON COMPLIANT WITH SONATAS, AND CAN OCCUR ON DRIVERS AND PASSENGERS SUNVISOR. *TR

Mileage: 50,000

UNDER NORMAL USE, AND NOTHING OUT OF THE ORDINARY, THE SUN VISOR ON THE 2006 HYUNDAI SONATA GLS V6 BREAKS AND FALLS INTO THE VIEW OF THE DRIVER, THIS HAS HAPPENED THREE TIMES. A PIECE OF PLASTIC IN THE SUN VISOR SNAPS AND THEN THE VISOR CAN NO LONGER BE USED NORMALLY. BLOCKED VISION, SUN VISOR SWAYING ON ITS OWN. THIS PART OUT OF WARRANTY COSTS OVER 100 DOLLARS AT A DEALERSHIP, HOWEVER THE SUN VISORS IN THE 2006-2009 SONATAS BREAK FREQUENTLY AND WITHOUT CAUSE. *TR

Mileage: 40,000

2006 HYUNDAI SONATA, 4 CYLINDER ENGINE, 52,000 MILES. DRIVER'S SIDE SUN VISOR NO LONGER MAINTAINS ITS TENSION, CAUSING TO FALL DOWN FREQUENTLY AND RANDOMLY BLOCKING DRIVERS VIEW OF ROAD, AS WELL AS HITTING DRIVER IT THE HEAD. DANGEROUS SITUATION. HAPPENS WHILE VEHICLE IS TRAVELING ON BOTH SMOOTH AND ROUGH PAVEMENT. AS A RESULT, VISOR CAN NOT BE RELIED UPON TO PROVIDE INTEND SAFETY BENEFITS OF BLOCK EXCESSIVE SUNLIGHT TO ENABLE SAVE OPERATION OF THE VEHICLE. *TR

Mileage: 52,000

THE SUN VISOR ON THE PASSENGER SIDE WILL NOT STAY IN ITS UPRIGHT POSITION. IT HANGS CAUSING INTERFERENCE WITH VISION. I'M FEARFUL OF THIS SAME PROBLEM OCCURRING ON THE DRIVERS SIDE. *TR

Mileage: 61,000

MY DRIVER SIDE VISOR BROKE TWICE BEFORE THE WARRANTY WAS UP. NOW THE VISOR IS BROKEN AGAIN, BUT I'M OUT OF WARRANTY. THE CLIP THAT HOLDS IT UP CRACKED AND I CANNOT GET IT TO STAY UP OR DOWN. IT JUST HANGS IN THE MIDDLE. THIS IS DANGEROUS AND ANNOYING. *TR

Mileage: 80,588

I OWN A 2006 SONATA I HAVE APPROX 59,000 MILES AND THE VISOR CRACKED AND NO LONGER STAYS UPRIGHT. BECAUSE IT KEPT FALLING AND OBSTRUCTING MY VIEW I HAD TO REMOVE IT. *TR

Mileage: 59,000

I HAVE A 2006 HYUNDAI SONATA WITH APPROXIMATELY 39,000 MILES. ABOUT A MONTH AGO, THE DRIVER SIDE VISOR FALLS DOWN AND WILL NOT STAY UP. THIS IS A SAFETY HAZARD AS IT FALLS WHILE I AM DRIVING. THIS APPEARS TO BE A COMMON COMPLAINT WITH THIS MODEL. *TR

Mileage: 384,000

BOTH THE DRIVER AND PASSENGER SUN VISORS HAVE FALLEN DOWN AND WON'T RETURN TO THE CORRECT POSITION RESULTING IN DECREASED VISIBILITY. *TR

Mileage: 85,000

TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. WHILE DRIVING AT ANY SPEED, THE PASSENGER'S AND DRIVER'S SUN VISOR WOULD NOT STAY IN THE CLOSED POSITION. THE VISORS WERE REPLACED BUT THEY CONTINUED TO FALL INTO THE VIEW OF THE DRIVER OR FRONT PASSENGER. THE DEALER ADVISED THERE WERE NO RECALLS AND ANY REPAIRS WOULD BE AT THE CONTACT'S EXPENSE. THE MANUFACTURER WAS NOT CONTACTED. THE CURRENT MILEAGE IS 73,000 AND THE FAILURE MILEAGE WAS 40,000. UPDATED 10/22/10 *BF THE CONSUMER STATED HE WAS UNABLE TO MAKE CHANGES TO HIS COMPLAINT. UPDATED 10/26/10

Mileage: 40,000

FAULTY SUNVISOR ON 2006 HYUNDAI SONATA GLS. IT WORKED FINE UNTIL MARCH WHEN IT STARTED TO CREEP DOWN WHEN ON BUMPY ROADS. NOW, JUNE 2010, IT FAILS TO STAY UP AT ALL. IT IS RIGHT IN THE LINE OF VISION OF 5' 10" MALE. I HAVE REMOVED 2 SCREWS TO REMOVE IT FROM THE CAR UNTIL I CAN FIND OUT WHAT TO DO. WARRANTY RAN OUT AT 60,000 MILES. IT HAD 68,000 MILES ON IT WHEN PROBLEM BEGAN. THIS IS ON DRIVERS SIDE. IT HAS NOT BEEN MISTREATED IN ANY WAY. I HAVE KEPT THE VISOR IN TRUNK. *TR

Mileage: 68,000

THE PASSENGER AND DRIVER SUN VISORS WILL NOT STAY IN THE UPPER RITE POSITION. BOTH OF THE SUN VISORS FALL DIRECTLY IN THE FACE SO THAT MY PASSENGER OR MYSELF IS HIT IN THE HEAD. THIS IS A SAFETY HAZARD BECAUSE IN THE CASE OF AN ACCIDENT. THE SUN VISORS WILL DAMAGE OUR HEADS. *TR

DRIVERS SIDE SUN VISOR WILL NOT STAY IN PLACE. THE SUN VISOR STAYS IN THE DOWN POSITION BLOCKING MY LINE OF SIGHT WHILE DRIVING. I HAD TO VELCRO THE SUN VISOR TO THE HEADLINER TO PREVENT THE SUN VISOR FROM FALLING DOWN. I DISASSEMBLED THE SUN VISOR AND FOUND THAT THE PLASTIC ARM INSIDE THE SUNVISOR WAS BROKEN IN HALF AND THAT THIS IS THE REASON FOR THE SUN VISOR TO FAIL. I HAVE 63,000 MILES AND THE PART IS 3000 MILES OUT OF WARRANTY. RESEARCHING ON THE INTERNET I HAVE FOUND THAT THIS IS A MAJOR COMPLAINT AND SO I'M REPORTING MY BROKEN SUN VISOR TO YOU. *TR

Mileage: 63,000

I HAVE A 2006 HYUNDAI SONATA GLS IN WHICH I BOUGHT IN OCTOBER 2007 WITH 24K MILES. THE CAR WAS STILL UNDER WARRANTY WHEN THE DRIVER'S SIDE SUN VISOR WOULD NOT RETURN TO THE UPRIGHT POSITION. IT WOULDN'T GO UP OR DOWN, BUT JUST HANG DOWN IN MY FACE. HAD TO TRY AND CLIP IT TO THE ROOF UNTIL I COULD GET IT FIXED. THE DEALERSHIP SAID IT WAS A COMMON PROBLEM. TWO WEEKS LATER, THE SAME THING HAPPENED TO THE PASSENGER SIDE. TWO YEARS AFTER HAVING BOTH SUN VISORS REPLACED, I AM FACING THE SAME PROBLEM ON THE DRIVER'S SIDE AGAIN. IT IS A TREMENDOUS SAFETY HAZARD AS MY VISION IS BLOCKED AND I AM CONSTANTLY DISTRACTED BY TRYING TO KEEP IT OUT OF THE WAY. IT IS ALSO HAZARDOUS IN THE MORNING AND EVENING WHEN FACING THE SUN, AS MY EYES HAVE NO SHIELD AND AM BLINDED. I KNOW THIS HAS BEEN A COMMON PROBLEM WITH THE SONATA SO I URGE YOU TO INVESTIGATE AND FIND A SOLUTION WITH HYUNDAI. *TR

THE DRIVER SIDE SUN VISOR HAS CRACKED AND WILL NOT STAY IN PLACE. IT WILL FALL DOWN BLOCKING MY VIEW. *TR

Mileage: 48,000

I HAVE A 2006 HYUNDAI SONATA. THREE YEARS AGO, THE DRIVER'S SIDE SUNVISOR STOPPED STAYING IN PLACE, DROPPING IN FRONT OF ME AND CAUSING A POTENTIAL OBSTRUCTION. THE DEALER REPLACED THIS UNDER WARRANTY. LESS THAN A YEAR LATER, THE REPLACED VISOR DEVELOPED THE SAME PROBLEM. THE DEALER WILL NOT RESPOND TO MY REQUEST THAT IT BE FIXED AGAIN UNDER WARRANTY. I BELIEVE THAT THIS IS A MATERIAL DEFECT, AND IT COULD BE HAZARDOUS. *TR

Mileage: 30,000

1.) I ENTERED MY CAR AND NOTICED MY DRIVER SIDE SUN VISOR WAS DOWN. I PUSHED IT BACK TO THE UPRIGHT POSITION, BUT IT JUST FELL BACK DOWN. 2.) IT IS LIKE THE SPRING OR MECHANISM THAT HOLDS IT IN PLACE JUST STOPPED WORKING. 3.) I HAVE NOT YET HEARD BACK FROM THE DEALER ABOUT REPLACING THE VISOR. WHEN THE VISOR IS DOWN I CAN NOT SEE THE STOP LIGHTS AND HAVE TO KEEP HOLDING THE VISOR UP, SO MY SIGHT IS NOT IMPAIRED. *TR

Mileage: 51,103

MY DRIVER SIDE SUN VISOR 2006 HYUNDAI SONATA IS ALWAYS FLOPPING DOWN, OBVIOUSLY A DESIGN FLAW AND SHOULD BE RECALLED AND I CONTINUE TO SEE MORE & MORE ISSUES WITH THIS PROBLEM ONLINE. *TR

Mileage: 60,133

THE SUN VISORS ON THE 2006 HYUNDAI SONATA BREAK AND CAUSE A SAFETY ISSUE BY BLOCKING THE VIEW. THERE ARE MULTIPLE COMPLAINTS ABOUT THESE CARS. SOMETHING NEEDS TO BE DONE. MINE HAS BROKEN TWICE. *TR

2006 HYUNDAI SONATA. SUN VISORS SUDDENLY FALL DOWN OBSTRUCTING VISION. DEALER WON'T ADDRESS THIS DEFECT!!! THIS IS GOING TO CAUSE A CRASH. *TR

Mileage: 45,000

THE DRIVERS SIDE SUN VISOR DROPPED DOWN WHILE I WAS DRIVING & IT WILL NOT STAY UP AND THIS HAPPENED AT NIGHT. ALSO THE PASSENGER SIDE SUN VISOR WILL SOMETIMES DROP DOWN IF I HIT A BUMP IN THE ROAD. OTHER OWNERS OF THE 2006 HYUNDAI SONATA HAVE SIMILAR COMPLAINTS. I FEEL THERE SHOULD BE A SAFETY RECALL. *TR

Mileage: 29,900

2006 HYUNDAI SONATA: THE DRIVER'S SUN VISOR STOPPED WORKING - IT BASICALLY LOST ITS TENSION AND, ALTHOUGH STILL HINGED, IT FLIPPED DOWN ON ITS OWN WHILE I WAS DRIVING DOWN THE HIGHWAY AT 70 MPH. IT NOT ONLY STARTLED ME AND CAUSED ME TO JERK THE WHEEL BUT IT DISTRACTED ME MOMENTARILY AND I WAS JUST THANKFUL IT WAS NOT A TWO-WAY ROAD WHERE I COULD HAVE HIT AN ONCOMING VEHICLE. IN ADDITION, IT HANGS STRAIGHT DOWN DIRECTLY IN MY VISION, OBSTRUCTING IT SO MUCH THAT I CANNOT SEE ADEQUATELY. I IMPROVISED AND USED VELCRO TO AFFIX IT IN ITS ORIGINAL, CLOSED POSITION. HOWEVER, THE VELCRO STICKY BACKING GAVE OUT TODAY AND, AGAIN, THE VISOR SUDDENLY DROPPED STARTLING ME AND OBSTRUCTING MY VISION. MY CAR HAS OVER 72,000 MILES AND IS OUT OF WARRANTY TO REPAIR THIS. I LOOKED ON-LINE TO SEE IF THERE WAS A WAY TO FIX THIS DEFECT AND DISCOVERED COUNTLESS COMPLAINTS AND CONCERNS FOR THE EXACT SAME THING. I CERTAINLY DON'T THINK I'VE MISUSED THE VISOR - I DON'T EVEN USE IT THAT MUCH - SO IT'S NOT AN ISSUE OF MISHANDLING. WITH AS MANY COMPLAINTS AS I SAW ON-LINE, I THINK THIS IS A MANUFACTURING DEFECT THAT WARRANTS ATTENTION. THANK YOU. *TR

Mileage: 72,300

2006 HYUNDAI SONATA BOUGHT IN 07. FLOPPY DRIVERS SIDE VISOR WAS REPLACED AS IT WOULD NOT STAY UP. NOW BOTH DRIVERS AND PASSENGERS SIDE ARE FLOPPY. OBVIOUSLY A DESIGN FLAW AND SHOULD BE RECALLED. THIS IS DEFINITELY A SAFETY ISSUE AS THE VISORS WHEN FLOPPED DOWN BLOCK THE DRIVERS VISION! THERE ARE MANY OTHER SIMILAR COMPLAINTS EASILY LOCATED ON THE INTERNET BY SEARCHING FOR 'SONATA VISOR.' APPARENTLY HYUNDAI HAS NOT YET OFFERED TO FIX THIS PROBLEM, NOR RECOGNIZE IT AS A SIGNIFICANT DEFECT. WHAT WILL IT TAKE SOMEONE GETTING KILLED BEFORE THIS BECOMES "IMPORTANT" ENOUGH?? THIS HAS NOW OCCURRED TWICE - FIRST REPAIR WAS 2007. NOW BOTH VISORS ARE DEFECTIVE TO THE POINT WHERE MY TEENAGE DAUGHTER (WHO DRIVES THE CAR) HAS ASKED FOR THE VISORS TO BE REMOVED (I WILL PROBABLY ATTEMPT A TEMPORARY FIX WITH VELCRO).

Mileage: 28,000

THE DRIVER SIDE VISOR HANGS DOWN AND WON'T STAY UP. THE FAILURE OCCURS ALL OF THE TIME. IT WILL EITHER HANG STRAIGHT DOWN BLOCKING MY VIEW OR I TURN IT TOWARDS THE WINDOW BUT THAT MAKES IT MORE DIFFICULT TO GET IN AND OUT WITHOUT HITTING MY HEAD. THIS IS A SAFETY HAZARD. I HAVE NOT REPLACED IT YET AS I THINK THE VISOR ASSEMBLY SHOULD LAST LONGER THAN 60K MILES (NO LONGER UNDER WARRANTY) AND DON'T THINK IT IS RIGHT I SHOULD HAVE TO PAY FOR THAT. *TR

Mileage: 60,001

THE PUMP FOR THE WINDSHIELD WIPER FLUID WENT OUT RIGHT AFTER THE WARRANTY RAN OUT AT 60K MILES. IT WAS EITHER DEFECTIVE OR THIS IS A PLANNED OBSOLESCENCE. ALTHOUGH THIS IS NOT A MAJOR ISSUE LIKE BRAKES, WHEN YOU ARE ON THE FREEWAY AND GET SPLASHED WITH MUD FROM A PASSING TRUCK, AND YOU CAN NO LONGER SEE THROUGH YOUR WINDSHIELD SINCE THE WIPERS JUST SMEAR THE MUD OVER THE GLASS, THE ABSENCE OF A WORKING FLUID PUMP COULD BE LIFE THREATENING. MY HUSBAND HAD TO PULL OFF THE ROAD AND USE WATER FROM A BOTTLE OF DRINKING WATER HE HAD IN THE CAR TO CLEAR THE WINDSHIELD SO HE CONTINUE DRIVING SAFELY. IN THIS ECONOMY MANY PEOPLE WILL NOT BE ABLE TO PAY THE $120 + TO REPLACE THE PUMP AND WILL CONTINUE TO DRIVE WITH DECREASED VISIBILITY. *TR

Mileage: 61,000

HYUNDAI SUN VISORS SWINGS DOWN WHILE DRIVING. MY PASSENGER VISOR BROKE WHILE DRIVING, ABOUT SIX MONTH LATER THE DRIVERS SUN VISOR BROKE. I CONTACTED OTHER HYUNDAI OWNERS AND THEY ALL HAVE THE SAME PROBLEM. I BELIEVE THIS COULD CAUSE A CRASH. WITH THE VISOR N THE DOWN POSSESSION YOU CANT SEE THE TRAFFIC LIGHT. *TR

Mileage: 60,000

1. THE DRIVER'S SIDE SUN VISOR DOES NOT STAY IN THE UP POSITION. 2. PERMANENT FAILURE 3. NOTHING HAS BEEN DONE. *TR

Mileage: 65,000

SUN VISOR ON DRIVERS SIDE WONT STAY UP. *TR

Mileage: 64,000

SUN VISOR FAILS TO STAY IN UP POSITION ON 2006 HYUNDIA SONATA GLS. *TR

Mileage: 61,000

I HAVE AN '06 SONATA, AND THE DRIVER SIDE VISOR ON IT HAVE BROKEN. THE PLASTIC APPEARS TO BE CRACKING AROUND THE EDGE WHERE THE METAL BAR ENTERS THE VISOR, LEAVING SHARP EDGES EXPOSED. *TR

THE DRIVERS SIDE SUN VISOR ON MY 2006 HYUNDAI SONATA HAS FAILED FOR THE SECOND TIME. . IT HANGS DOWN OBSTRUCTING MY VIEW. THIS LATEST INCIDENT OCCURRED ON THE NJ TURNPIKE CAUSING ME TO SWERVE TO THE SHOULDER OF THE ROAD. A STATE TROOPER SAW WHAT HAPPENED AND PULLED IN BEHIND ME. WHEN I EXPLAINED THE SITUATION HE SAID THAT HE KNEW OF SEVERAL OTHER SONATA'S WITH THIS PROBLEM. TWO DIFFERENT DEALERS SAID THAT THIS IS A COMMON OCCURRENCE. *TR

Mileage: 68,500

2006 HYUNDAI SONATA, LEFT SUN VISOR IS DEFECTIVE AND KEEPS FALLING DOWN WHILE DRIVING. *TR

MY DRIVER-SIDE SUN VISOR IN MY 2006 HYUNDAI SONATA BEGAN HANGING LOWER AND LOWER UNTIL EVENTUALLY IT WOULD NEITHER STAY UP AGAINST THE ROOF OF THE CAR OR OUT TOWARD THE WINDSHIELD. THE VISOR NOW ONLY HANGS DOWN, WHICH OBSTRUCTS MY VIEW WHEN DRIVING. *TR

Mileage: 65,000

WHILE DRIVING A 2006 HYUNDAI SONATA WITH 30,000 MILES, THE DRIVER SIDE SUNVISOR JUST FLOPPED DOWN WHILE DRIVING ON THE INTERSTATE HIGHWAY SYSTEM ON I-95 AT 70 MPH. THERE WAS NO WARNING AND THE VISOR BLOCKED THE DRIVERS VISION BECAUSE IT WOULD NOT RETURN TO THE "UP" POSITION. SINCE THE CAR WAS BEING DRIVEN ON A VACATION TRIP THAT HAD BEEN PREVIOUSLY PLANNED AND IN A DIFFERENT LOCATION, IT WAS NOT PRACTICAL TO GO TO A STRANGE DEALERSHIP. TO SOLVE THE PROBLEM ON THE REMAINDER OF THE TRIP, I USED A "WOODEN CLOTHSPIN" CLIPPED TO THE VISOR AND PUT THE SUNVISOR TO THE LEFT SIDE OF THE VEHICLE AND PUT THE CLOTHSPIN BEHIND THE DRIVER SIDE HAND HOLD LOCATED ON THE INSIDE OF THE ROOF OF THE CAR. SINCE THE TRIP WAS GOING TO BE FOR ABOUT A WEEK, I LATER USED A RUBBER BAND TO KEEP THE VISOR HIGH ENOUGH TO ENTER AN EXIT THE DRIVER DOOR. THE VISOR WAS REPLACED AT THE DEALER BACK HOME AND I BECAME AWARE THAT THIS SEEMED TO BE A FREQUENT PROBLEM ON THIS CAR. THIS IS A VERY DANGEROUS CONDITION AND THIS AGENCY SHOULD LOOK INTO THIS SERIOUS OBSTRUCTION OF DRIVER VISIBILITY WHEN THIS CONDITION OCCURS. OF ALL THE VEHICLES I HAVE OWNED IN THE LAST 40 YEARS, THIS IS THE ONLY ONE TO HAVE THIS PROBLEM. *TR

Mileage: 30,000

2006 HYUNDAI SONATA SUN VISORS WILL NOT STAY UP. FALLS DOWN IN LINE OF VISION. STARTED WITH PASSENGER SIDE AND NOW THE DRIVER SIDE. DEALER WOULD NOT REPAIR AS I WAS <5000 MILES OVER WARRANTY. BASED ON INTERNET THIS IS A COMMON ISSUE WITH HYUNDAI'S. SEEMS SOME HAVE BEEN REPLACED 3 TO 4 TIMES. *TR

Mileage: 64,500

INTERIOR SUN VISORS FAIL AND DO NOT STAY IN THE UP POSITION. ON GOING PROBLEM. AN ORDER FOR REPLACEMENTS HAS BEEN BACK ORDERED ACCORDING TO THE DEALER BECAUSE OF THE VOLUME OF FAILURES. BECAUSE THE VISORS DROP DOWN UNEXPECTEDLY AND DO NOT STAY IN PLACE WHEN RAISED, THERE IS A SERIOUS HAZARD FROM VISION IMPAIRMENT. DRIVING WITH THE VISORS DOWN IMPAIRS VISION OUT OF THE FRONT OF THE VEHICLE, ESPECIALLY FOR TALLER DRIVERS--BECAUSE THE VISORS BLOCK MORE OF THE NORMAL RANGE OF VISION. BECAUSE OF THIS PROBLEM, THE VISORS ALSO CANNOT BE EFFECTIVELY USED AS INTENDED IN ADVERSE LIGHTING CONDITIONS. *TR

Mileage: 62,000

2006 HYUNDAI SONATA - DRIVER'S SIDE SUNVISOR DEFECTIVE. *TR

Mileage: 77,000

BROKEN SUN VISOR BRACKET- HYUNDAI ISSUED A TSB BUT WILL NOT REPLACE VISOR IF VEHICLE IS OUT OF WARRANTY. WHEN DRIVING DOWN THE ROAD I HAD TO SLAM ON THE BRAKES TO AVOID A CHILD CHASING A BALL WHICH BOUNCED ACROSS THE STREET I HIT MY HEAD ON THE EDGE OF THE SUN VISOR WHICH DANGLES DOWN. MY HEAD WOULD NOT HAVE HIT THE VISOR IF IT WAS WORKING PROPERLY. ALSO THE VISOR DANGLES BLOCKING YOUR VISION WHEN THE VISOR IS NOT NEEDED BUT IT WILL NOT STAY IN THE UP POSITION. *TR

Mileage: 80,010

2006 HYUNDAI SONATA - DRIVER SIDE SUN VISOR HAS BROKEN FOR A 2ND TIME. REPLACED THE 1ST ONE IN OCTOBER 08 AT MY EXPENSE, THE PART WAS $127.00. WHEN I CALLED TO SEE IF IT WAS UNDER WARRANTY I WAS ADVISED IT WAS A COSMETIC ISSUE AND NOT A SAFETY ISSUE. NOW I AM IN NEED OF ANOTHER ONE, BUT I THINK I WILL DO WITHOUT BECAUSE I DON'T WANT TO PAY FOR ANOTHER ONE. THE VISOR BECAME DIFFICULT TO MOVE AND AS I LOWERED IT I COULD HEAR IT CRACKING INSIDE. THIS IS DEFINITELY A SAFETY ISSUE BECAUSE THE VISOR WON'T STAY UP OR DOWN, IT FALLS INTO YOUR LINE OF SIGHT. *TR

Mileage: 80,000

I HAVE A 2006 HYUNDAI SONATA AND THE ARM ON THE SUN VISOR CRACKED AND THE VISOR FELL WHILE I WAS DRIVING, OBSTRUCTING MY VIEW AND NEARLY CAUSING ME TO HAVE AN ACCIDENT. I HAVE SINCE DONE SOME RESEARCH, AND HYUNDAI SENT OUT A "TECHNICAL SERVICE BULLETIN" TO DEALERS/SERVICE & PARTS MANAGERS ABOUT THIS VERY PROBLEM IN DECEMBER OF 2008. CUSTOMERS WEREN'T NOTIFIED OF THE PROBLEM, AND I HAVE FOUND THAT IT HAS BEEN AN ISSUE FOR A NUMBER OF CUSTOMERS (THERE ARE MESSAGE BOARDS ON HYUNDAI-FORUMS.COM ABOUT THE ISSUE). SOME ARE GETTING IT FIXED UNDER WARRANTY (AFTER IT BREAKS & OBSTRUCTS VISIBILITY), HOWEVER, I JUST MISSED THE WARRANTY PERIOD AND AM EXPECTED TO PAY $83 JUST FOR THE PART TO REPLACE A SAFETY ISSUE THAT HYUNDAI HAS BEEN AWARE OF. APPARENTLY IT'S NOT A BIG ENOUGH PROBLEM TO THEM TO WARRANT A RECALL. *TR

Mileage: 63,000

2006 - 08 HYUNDAI SONATA SUN VISORS BREAK VERY EARLY IN CAR'S LIFE. MINE WAS AROUND 41000 MI. DRIVER SIDE VISOR BROKE WHEN PUTTING IT DOWN ONE MORNING IN MAY 2009, NOW THE PASSENGER SIDE VISOR IS BROKEN TOO. THE PLASTIC THAT SURROUNDS THE BAR IN THE ELBOW JUST SNAPS AND FLIES OFF, RESULTING IN THE VISOR FLAPPING DOWN LIMPLY IN YOUR FACE, BLOCKING VISION COMPLETELY. THIS IS A MAJOR SAFETY ISSUE AND IT IS VERY COMMON. HYUNDAI DEALER ACKNOWLEDGED IT IS COMMON AND HAD PLENTY IN STOCK. THEY AGREED TO REPLACE 1ST ONE FOR FREE, THOUGH NOT UNDER WARRANTY. I HOPE THE SAME THIS TIME. PLEASE LOOK UP "HYUNDAI SONATA VISOR" ON YOUR SEARCH ENGINE. YOU WILL FIND PERHAPS HUNDREDS OF ENTRIES. I STOPPED AT ABOUT 40 INDIV. ENTRIES WITH EXACTLY THIS PROBLEM. YOU KNOW THOSE ARE ONLY THE ONES WHO ENTERED IT, AND THEY PROBABLY REPRESENT 1000 EACH. *TR

Mileage: 41,000

THE DRIVER SIDE SUN VISOR ON OUR 2006 HYUNDAI SONATA HAS SUDDENLY STOPPED BEING ABLE TO BE IN THE UP POSITION. IT ALSO CANNOT BE PLACED TOTALLY DOWN. AS A RESULT IT IS HANGING DOWN AND IMPEDING VISION AND HITS ME IN THE HEAD IF I LEAN FORWARD TO SEE TRAFFIC OR MOVE MY HEAD TO LOOK OVER BEFORE MOVING INTO ANOTHER LANE. THERE IS DEFINITELY A SAFETY RISK WITH THE FAILURE OF THIS PART. *TR

Mileage: 93,300

TL*THE CONTACT OWNS A 2006 HYUNDAI SONATA. WHEN EVER THE CONTACT DROVE THE VEHICLE BOTH THE DRIVER AND PASSENGER SIDE SUN VISORS FELL DOWN WITHOUT WARNING AND BLOCKED THE DRIVERS VIEW IN FRONT OF HIM. THE DEALER STATED THAT THE SUN VISORS WOULD NEED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 45000.

Mileage: 45,000

I WAS DRIVING IN MY 2006 HYUNDAI SONATA AND I TURNED INTO THE SUN PULLED DOWN MY VISOR AND IT BROKE AND WOULDN'T STAY UP TWO WEEKS LATER THE PASSENGER SIDE DID THE SAME THING U WOULDN'T THINK A VISOR WAS A SAFETY ISSUE BUT IT SURE IS WHEN IT WONT STAY UP OR OUT OF YOUR FACE I TOOK IT TO A LOCAL DEALER THEY SAID THEY HAVE A RECALL BUT THAT MINE WASN'T ON IT APPARENTLY THE PROBLEM IS MORE WIDE SPREAD THEN THEY SAY THE LOCAL DEALER SAYS HE REPLACES ATLEAST ONE A DAY THAT ISN'T UNDER THE RECALL. *TR

Mileage: 50,000

BOTH SUN VISORS ON MY 2006 HYUNDAI SONATA BROKE AND FALL DOWN WHILE DRIVING. THIS HAS BEEN A SAFETY ISSUE. *TR

Mileage: 73,000

MY 2006 HYUNDAI SONATA HAS HAD 2 FAILURES OF THE DRIVER'S SUN VISOR. THE 1ST WAS REPLACED UNDER WARRANTY; THE VEHICLE IS NO LONGER UNDER WARRANTY. IN EACH CASE IT HAS DROPPED INTO THE FULLY DEPLOYED POSITION WHILE DRIVING, CAUSING A SUDDEN AND UNEXPECTED LOSS OF VISION. *TR

Mileage: 94,000

THE VISOR ON MY 2006 HYUNDAI SONATA DOES NOT STAY IN THE UP POSITION. IT WILL FALL DOWN INTO MY FIELD OF VISION WHILE DRIVING UNLESS I HOLD IT UP. *TR

Mileage: 38,000

I OWN A 2006 HYUNDAI SONATA AND THE SUN VISORS ON BOTH SIDES OF THE VEHICLE DO NOT STAY IN THE UP AND STOWED POSITION WHICH IS A KNOWN PROBLEM WITH THESE VEHICLES AND IT IS AN EXTREME SAFETY HAZARD WHEN THEY FALL DOWN WHILE THE VEHICLE IS IN MOTION AND BLOCK THE DRIVERS FIELD OF VISION WHICH IS WHAT HAPPENED TO ME AND IT NEARLY CAUSED A MAJOR FREEWAY ACCIDENT. THE VISOR FELL DOWN BLOCKING MY VISION WHILE I WAS ON THE I-15 FREEWAY AND IT HAPPENED RIGHT AS I WAS SWITCHING LANES DURING A VERY CONGESTED TIME OF THE DAY. AS I TRIED TO MOVE THE VISOR AND TOOK MY EYES OFF THE ROAD AND THE TRAFFIC AROUND AND NEARLY CAUSED A MAJOR FREEWAY ACCIDENT. I FINALLY GRABBED THE VISOR AND TORE IT OUT OF THE OVERHEAD MOUNT AND TOSSED IT IN THE BACK SEAT! THAT IS HOW EXTREME AND HAZARDOUS THESE DARN VISORS ARE TO SAFE VEHICLE OPERATION. *TR

Mileage: 25,000

BOTH OF THE SUN VISORS ON MY 2006 HYUNDAI SONATA BROKE UNDER NORMAL ACTIVITY. THEY WERE NOT PULLED ON OR USED INAPPROPRIATELY. BOTH WILL NOT STAY IN THE UP POSITION. THIS IS A DRIVING HAZARD BECAUSE IT LIMITS VISIBILITY AND IS A DISTRACTION FOR THE DRIVER OF THE CAR. OFTEN TIMES, I HIT MY HEAD ON THE VISOR. NIGHT TIME IS THE MOST DIFFICULT TIME BECAUSE THERE IS NO REASON TO HAVE THE VISOR DOWN (NO SUNLIGHT) BUT THE VISOR HINDERS PROPER VISION OF THE ROAD. *TR

Mileage: 88,000

I HAVE A 2006 HYUNDAI SONATA AND HAVE HAD THE DRIVER'S SIDE VISOR BREAK ON ME 3 TIMES, EACH THROUGH NORMAL USAGE. WHEN IT INITIALLY BREAKS WHILE DRIVING THE VISOR WILL DROP INTO THE DRIVERS VIEW WITH THE INABILITY TO MOVE IT OUT OF THE WAY. AFTER A WHILE OF DRIVING WITH ONE HAND, I HAD FORCED IT OUT OF THE WAY, WHICH FURTHER CAUSED BREAKAGE OF THE TENSION AND ALLOWING ME TO MOVE IT TO THE SIDE. HOWEVER, IT WILL ONLY STAY DOWN AT THIS POINT. INTERNET SEARCHES WITH "HYUNDAI SONATA VISOR" WILL SHOW CASES OF MULTIPLE BREAKAGES FOR MANY OWNERS. FOR EXAMPLE HERE: HTTP://WWW.FIXYA.COM/CARS/T867360-SUN_VISOR_DRIVERS_SIDE I'M SURE FURTHER INVESTIGATION OF WARRANTY CLAIMS FOR THIS PART WILL REVEAL CASES AS WELL. THE DATE LISTED IS THE 3RD TIME THIS HAS HAPPENED TO ME. IN ADDITION, FURTHER SAFETY CONCERNS WITH THEIR LACK OF STOCK. I HAVE BEEN WAITING FOR ALMOST 3 WEEKS, DRIVING WITHOUT A VISOR, WHICH HAS BECOME VERY DIFFICULT AT TIMES WITH THE SUN IN THE EYES. DO WE NEED A TERRIBLE ACCIDENT TO OCCUR IN ORDER TO CAUSE THEM TO REDESIGN A SIMPLE YET IMPORTANT PIECE? *TR

Mileage: 59,400

DURING NORMAL USE OF MY SUNVISORS THEY BOTH BROKE. WHEN IT FIRST BEGAN BOTH VISORS WOULD FALL ANYTIME I HIT A BUMP, BLOCKING MY VIEW OF THE ROAD, VERY DANGEROUS. I WOULD PUSH THEM BACK UP. THIS HAPPENED OVER A PERIOD OF SEVERAL MONTHS. AT THIS POINT BOTH VISORS HANG DOWN AND WILL NOT STAY IN THE UP POSITION. SINCE THEY REMAIN IN THE DOWN POSITION THEY OBSTRUCT MY VIEW OF THE ROAD AND ARE A DANGER. AT THIS POINT ALL I HAVE BOTH VISORS TIED WITH ROPE TO THE HANDLE BAR NEAR THE TOP OF EACH DOOR. *TR

Mileage: 30,000

2006 HYUNDAI SONATA. VISOR WILL NOT STAY UP ON PASSENGER SIDE. DEALER REFUSES TO REPAIR SAYING I CAUSED THE DAMAGE. *TR

Mileage: 13,000

THE SUN VISOR ON THE DRIVER'S SIDE OF MY 2006 HYUNDAI SONATA WILL NOT STAY "UP". IT DROOPS. *TR

Mileage: 59,900

BOTH SUN VISOR SPRING MOUNTS BREAK. WHEN THE DRIVER'S SIDE BROKE IT CAUSES THE VISOR TO HANG DOWN BLOCKING THE VIEW OF THE DRIVER. DRIVER'S SIDE HAS BROKEN 3 TIMES AND THE PASSENGER SIDE 2 TIMES OVER THE LAST 18 MONTHS. THE LAST 2 TIMES WE HAD IT IN UNDER WARRANTY TO GET REPAIRED WE WERE TOLD THAT HYUNDAI HAS FIXED THE KNOWN FLAW, ONLY TO HAVE THEM BREAK AGAIN. *TR

Mileage: 35,000

SUN VISORS WILL NOT REMAIN IN UP POSITION, FALLING INTO THE DRIVERS FIELD OF VISION. DRIVER MUST THEN DRIVE WITH ONE HAND WHILE HOLDING VISOR IN THE UP POSITION. VISOR WAS REPLACED UNDER WARRENTY, BUT THE REPLACEMENT HAS BROKEN IN THE SAME WAY. IT DISTRACTS THE DRIVER AND COULD CONTRIBUTE TO A WRECK. *TR

Mileage: 80,000

THE SUN VISORS IN MY VEHICLE HAVE BROKEN SEVERAL TIMES SINCE PURCHASING. THE DEALER HAS ADMITTED THAT THIS IS A FACTORY DEFECT BUT THEY CONTINUE TO INSTALL THESE DEFECTIVE VISORS. WHEN THE VISOR BREAKS, IT HANGS DIRECTLY IN THE DRIVERS LINE OF SIGHT.

Mileage: 63,000

DRIVER SIDE SUN VISOR MAKES RACHETING NOISE WHEN DRIVER ADJUSTS... THEN BREAKS AND NO LONGER MOVES UP OR DOWN OR STAYS IN UPWARD POSITION. RATHER,VISOR FLOPS DOWN AND HANGS IN DRIVER'S LINE OF VISION AND DRIVER HITS HEAD ON IT UPON ENTERING/EXITING VEHICLE . *TR

Mileage: 23,500

TL*THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATES WHETHER OR NOT SOMEONE WAS SEATED IN THE FRONT PASSENGER SEAT. THE DASHBOARD THAT CONTAINED THE AIR BAG WAS CRACKED ALL AROUND. THE ENTIRE DASHBOARD WAS REPLACED, BUT THE PASSENGER SIDE AIR BAG LIGHT STILL ILLUMINATES. IN ADDITION, THE DRIVER'S SIDE SEAT WOULD NOT MOVE UP WHEN ADJUSTED AND THE DRIVER'S SIDE WINDOW WOULD NOT GO DOWN. THEY WERE BOTH REPLACED UNDER WARRANTY. THE CONTACT IS EXTREMELY DISSATISFIED THAT SHE PURCHASED A BRAND NEW VEHICLE AND HAS EXPERIENCED MAJOR FAILURES. THE CURRENT MILEAGE WAS 13,000 AND THE FAILURE MILEAGE WAS UNAVAILABLE.

THE POWER WINDOWS HAVE STOPPED WORKING. UNABLE TO MOVE WINDOWS FOR DRIVER AND PASSENGER SIDE. *TR

Mileage: 41,000

SINCE LAST SIX MONTHS THE DRIVER SIDE POWER LOCK IS NOT WORKING AND ALSO THE WINDSHIELD WATER PUMP IS NOT OPERATING. I HAVE BOUGHT THIS VEHICLE BRAND NEW FROM THE DEALERSHIP. AND APPROXIMATED 19,750 MILE. THE CAR IS 2006 HYUNDAI SONATA V6. *TR

Mileage: 15,710

SINCE LAST SIX MONTHS THE DRIVER SIDE POWER LOCK IS NOT WORKING AND ALSO THE WINDSHIELD WATER PUMP IS NOT OPERATING. I HAVE BOUGHT THIS VEHICLE BRAND NEW FROM THE DEALERSHIP. AND APPROXIMATED 19,750 MILE. THE CAR IS 2006 HYUNDAI SONATA V6. *TR

Mileage: 15,710

GLASS EXPLODED IN THE SUN ROOF. *TR

Mileage: 25,560

THE CARS ELECTRIC WINDOWS DO NOT ROLL DOWN DURING DAMP WEATHER BELOW FREEZING. WITH HEATER ON HIGH AND 25 MIN. LATER WORKED AFTER DOOR WAS CLOSED. THIS HAPPEN TWICE, NO ICE OR FROST ON ANY WINDOW. SEEMED TO BE INTERNAL. IF THIS WAS THE LAST ESCAPE ROUTE REMANDING, I WOULD BE TRAPPED IN THE CAR.*JB

Mileage: 20