2021 HYUNDAI SONATA Electrical System Problems

My 2021 Hyundai Sonata Limited Hybrid 12v battery has started to die randomly. My car is currently with the Hyundai dealer to confirm if this will be a warranty claim. Searching online, I have found other posts of people complaining about a similar issue with their 2021 Hyundai Sonata Hybrid.

Car sits several days at a time. Door locked. 12 volt auxiliary battery goes dead within 60 minutes after driving 60 miles. Happened 6 times in last 6 weeks. Battery is lithium. Dealer looked at car Sept 8. They did cursory check and said my rodent deterrent caused issue. After driving 60 miles. Turned rodent deterrent off. Still have issue. Car resets the 12 volt battery nearly daily. Lithium battery if bad can blow up and cause vehicle fire. Car is parked in car port next to house. If fire, it burns up my house also. This is fire hazard. If the battery is bad, it must be fixed. Car under 10 year 100,000 mile bumper to bumper warranty. I need car fixed. NOT just looked at. This is fire hazard till it is fixed,

2021 Hyundai Sonata with approximately 39,000 miles. On [XXX], the dashboard displayed the following message "Shifter system malfunction! Service immediately" When the warning appeared, the vehicle shifter button would not function, creating a traffic safety risk. History: Dealer service history shows the transmission was replaced on the vehicle under warranty on 08/30/2021 with 2,212 miles with no campaign/recall issued. Dealer states there is no recall campaign on this vehicles specific VIN # and NHTSA currently shows no open recalls for this vehicle. However, Hyundai advertises an 8-Speed DCT Safety Recall for the same year, make and model, and describes this identical issue, but has left this vehicle's VIN# out of scope for this recall, which is continuing to demonstrate the same issues. Current dealer/manufacturer response: On 9/4/2025, the dealer declined warranty or recall repair unless the fault was active on their diagnostic scan at the moment the scan was performed. A photo was provided to the mechanics of the dashboard showing the transmission service warning, with current mileage. The dealer advised there were no diagnostic log history showing the transmission error code even with photographic proof and attempted to return the vehicle to me. I have rejected the return of the vehicle and advised that this needs to be escalated, because if logs are not appearing, this is even a bigger cause for concern and that the vehicle is a safety hazard. Concern: Because this vehicle required an early transmission replacement and is now exhibiting new transmission/shifter warnings, I am concerned the failure relates to the known transmission/shifter recall on this model and that the recall scope and/or remedy is incomplete for the affected vehicles including my vin #. It is also possible the dealership is attempting to run out the warranty which expires in 3 months. Vehicle, photo of the warning, and service records are available for inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (

The buttons to the door locking and unlocking don't work unless I open and close my door a few times. The same thing with the back windows. But after you do the trick and use the intended button once, it stops working and have to repeat the entire process over again. Which is not safe especially when the car is in motion, I am not able to use those buttons at all.

On 5 separate occasions the car has shut itself off while driving. After the first 2 times the car was taken to the dealership where they found nothing wrong and told us to replace the battery. The battery was replaced by the dealer and within the next two weeks the car shut itself off while driving 3 more times. The car will always start back up again right away. This is a very dangerous situation.

In June 2024, I was driving my vehicle when I started to smell burning from under the dashboard. As I continued to drive, the smell got worse, and on my way to the dealer, my air conditioner stopped working. I took my car back to the dealer for service, and several days later, I was told that my car needed a hardness connected to several components in the engine compartment. I remember while I was dropping off my car at the dealer, one of the service advisors told me that it was good. I drove to the dealer because the car could have gone on fire. It's now six months later, and they have not fixed my car. I was told they're awaiting parts from Korea to complete the fix. My concern is that this part can cause a fire. Why did Hyundai not recall these vehicles? Hyundai knows about the problem. I was told that I'm not the only one waiting; supposedly, there are 100's more customers waiting for this part.

This car has two problems. 2 weeks I was driving on the highway. All the sudden the shutoff and lost all power on the car. Thank god I pulled to the side of the road safely. Turned the car off and turned it back on. The car started to run normal. I took it to mechanic. They scanned the car with their computer. Said the car has no problems. Tested the battery and all other components. No problems found. This happened again yesterday on the highway driving. Car engine shuts off again. The car has engine problems as well. But Hyundai denies to address it.

2021 Hyundai Sonata 59,850 miles RPM jumps to around 1,300 at zero miles on occasion. If I am stopped, at a red light or behind other stopped autos, the vehicle jumps forward when I take my foot off the brake. Because this happens quite often, I am aware of this and keep my foot on the brake until other vehicles are out of the way to avoid bumping into them. When this happens, I can cruise at 30 miles per hour without having my foot on the accelerator, I can slow down or stop by applying the brakes but the engine RPM stays at 1,300. If I stop and shut off the vehicle and restart, the operation goes back to normal but occurs again later. The Hyundai dealer has had the vehicle back 9 times but the issue continues. The first few times, they could not find an issue, I returned to the shop when this was happening and the service manager and a technician observed this condition, the EGR valve was replaced. Was OK for a bit but condition returned, the computer was then replaced. Condition continued. Brought the vehicle back and a scan was done and system “re-learned. After a short time the condition returned. Went back to the service center and they did another scan and another re-learn. Condition returned 4-5 days later. Problem still not resolved. Have 59,850 miles on the vehicle, warranty expires at 60,00 miles. This started around July 1, Now October 5. Waiting for a loaner so the service center can drive it around until the situation occurs and they can bring it in immediately for diagnosis. This is the same issue as reported for the same year vehicle in July 2022.

Blower motor on 2021 Hyundai Sonata SEL stopped working. Same issue happened on my 2020 Hyundai SEL and currently waiting on my 2020 Sonata to be fixed. Hyundai technician said the wiring harness had a crack and it’s why my 2020 Sonata’s Blower motor stopped working. It’s now three months since they diagnosed and ordered the wiring harness but supposedly it’s still on back order and I’m left with a hot car this entire summer and possibly a cold car come this winter. Now it looks like I will have the same issue with my 2021 Hyundai Sonta.

Fuse box has a defect causing the AC blower motor to intermittently not work. Appears to be the result of loose connections between the fuse box and the fuse itself. The receptacle for the fuse is clearly burnt/melting, and appears to pose as a fire hazard as a result. The car is currently in the shop for repair on this part, but won't likely be fixed for a month+. I do have photos of the damaged parts, should it be requested. The car was taken into a Hyundai dealership for repair work in November 2023, and I was told the fuse had blown but that they fixed it. I was never told about the box appearing damaged/melting at that time, or this being a common problem. It worked again till July 2024. Car was just dropped off 9/3, due to backlog of cars at dealership. The only symptom of issue was the AC blower motor would stop working at random. It would turn back on/off while driving. This seems to be due to the loose connections between fuse box and fuse.

Infotainment center won't switch to Radio. No signal for AM/FM or Satellite. Then HVAC system stopped blowing. No defrost, won't blow heat or AC. Blower motors been tested and works, blower motor resister replaced. Everyone I talk to is saying it's an electrical, connection issue.

So for the past year and half my cars left turn signal has been working intermittently. It just stops working and then it starts again. I have taken it to the dealer many times they changed out signal assembly i have taken many videos show proof. I am told at the dealer if you dont bring it in when it is not working then they cannot do anything even if i have video proof documenting this issue for the past year this is a serious safety issue that must be addressed. My next step is to contact Hyundai directly hopefully you can investigate this issue. This is very dangerous.

After 9 months of ownership, on at least five (5) instances, the car has the following things happen at the same time: 1) all warning lights on the dashboard activate, 2) the battery discharge warning light activates, a loss of power steering, no speedometer, no cameras (rear or front), no AC, and all the safety functions are disabled including but not limited to: Forward Collision Warning, Parking Collision Warning, Automatic Emergency Braking, Lane Departure Warning, Rear Cross Traffic Warning. Yes, the car is available for inspection upon request. Safety is at risk by the loss of power steering and the deactivation of all safety functions. After each instance, the car has gone back to the manufacturer's dealer for inspection, they believed it might be an electrical issue after scanning for fault codes, but after 5 times, the dealer has not yet diagnosed the issue.

My vehicle is trending in theft, car was leased to me from Napelton in Lansing IL sept 2022. The first attempt of theft/break in UIC area Dec 10, second attempt in west Chicago area Jan 29. Both times I just cried and shut down. With having to contact the police awaiting the report process in middle of Chicago Winter left me cold and in terrible distress! This is a new vehicle for me which ultimately has caused me so much stress, anxiety, and frustration. I tried to trade it in but because of this nationwide issue that I was not aware of until the first incident! Still the theft numbers continue to rise! I am being told my cars value has depreciated from 25k to 15k which is not fair, and if I abandon this vehicle it will fall hard in my credit and ruin my chances moving forward with another vehicle!! With no where to turn and In dyer need of a reliable vehicle as I work and university student, having to constantly repair the windows after random theft attempts is a major safety hazard and for concerns of what can happen in a worst case scenario. I really need this issue to be addressed so that I can freely live my everyday life and not worry if I am leaving class or work that my car will not be there, or if my windows will be busted. I hope reaching out can help me get this vehicle traded in at a fair value!

UNKNOWN