2021 HYUNDAI SONATA Engine Problems

I was driving my 2021 Hyundai Sonata at approximately 3:00 AM when the vehicle suddenly began shaking and vibrating. While stopped at a traffic light, the check engine light illuminated, and the engine was shaking severely. I immediately pulled over and shut off the engine. After waiting approximately one hour, I restarted the vehicle, but it was only able to drive very slowly. The following day, the vehicle was towed to a local repair shop. Diagnostic testing showed a cylinder 3 misfire, along with EVAP system errors and faulty fuel injector issues. This failure occurred without warning and created a potential safety risk while driving. I am concerned this may be related to a defective fuel system.

Engine makes rattling and knocking noises. Transmission hesitates and jerks Suspension front struts and rear shocks are bad. Possible the isolators. Having horrible back pain when riding in car. Starter intermittently doesn't work Lane keep assistance goes over small bump in road will make car drive in opposite lane into on coming traffic. Took car to Tameron hyundai in Birmingham on the 29th of December 2025. Told them everything thats going on with the car. They did nothing about any of the issues. Car has 55,000 miles on it as that is when all problems have incurred. 60000 mile Warranty expires in February of this year.

The vehicle's HVAC (heating) system failed. It stopped producing heat on one side of the vehicle. My mechanic/dealer diagnosed the issue as a broken component within the HVAC case under the dashboard, requiring full dashboard removal and a repair estimated at over $3,000. This failure prevents the defroster from working properly, which is a major safety hazard as it cannot clear fog or frost from the windshield. A search of online forums and owner communities shows this is a widespread complaint from many other Hyundai owners, often identified as a failed blend door or blend door actuator, which requires the same expensive dashboard removal to repair.

After initial startup and drive for a short time, I come to a stop. Then after vehicle doesn’t want to accelerate as it normally would. Vehicle struggles to gain speed but, the engine revs excessively. I pull off the road and come to a stop and try to accelerate again and the same thing happens. I shut the vehicle off and wait a few minutes,then restart and the vehicle accelerates normally again. There were no check engine lights the when this has happened.

The contact owns a 2021 Hyundai Sonata. The contact stated while pulling out of a parking lot, the vehicle failed to accelerate as intended and started shaking abnormally. The check engine warning light was illuminated. The vehicle was taken to the residence. The vehicle was towed to an independent mechanic where it was diagnosed that the fuel injector needed to be replaced. The vehicle was towed to a dealer where it was diagnosed that all four fuel injectors needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 47,000.

Mileage: 47,000

On 5 separate occasions the car has shut itself off while driving. After the first 2 times the car was taken to the dealership where they found nothing wrong and told us to replace the battery. The battery was replaced by the dealer and within the next two weeks the car shut itself off while driving 3 more times. The car will always start back up again right away. This is a very dangerous situation.

This car has two problems. 2 weeks I was driving on the highway. All the sudden the shutoff and lost all power on the car. Thank god I pulled to the side of the road safely. Turned the car off and turned it back on. The car started to run normal. I took it to mechanic. They scanned the car with their computer. Said the car has no problems. Tested the battery and all other components. No problems found. This happened again yesterday on the highway driving. Car engine shuts off again. The car has engine problems as well. But Hyundai denies to address it.

2021 Hyundai Sonata 59,850 miles RPM jumps to around 1,300 at zero miles on occasion. If I am stopped, at a red light or behind other stopped autos, the vehicle jumps forward when I take my foot off the brake. Because this happens quite often, I am aware of this and keep my foot on the brake until other vehicles are out of the way to avoid bumping into them. When this happens, I can cruise at 30 miles per hour without having my foot on the accelerator, I can slow down or stop by applying the brakes but the engine RPM stays at 1,300. If I stop and shut off the vehicle and restart, the operation goes back to normal but occurs again later. The Hyundai dealer has had the vehicle back 9 times but the issue continues. The first few times, they could not find an issue, I returned to the shop when this was happening and the service manager and a technician observed this condition, the EGR valve was replaced. Was OK for a bit but condition returned, the computer was then replaced. Condition continued. Brought the vehicle back and a scan was done and system “re-learned. After a short time the condition returned. Went back to the service center and they did another scan and another re-learn. Condition returned 4-5 days later. Problem still not resolved. Have 59,850 miles on the vehicle, warranty expires at 60,00 miles. This started around July 1, Now October 5. Waiting for a loaner so the service center can drive it around until the situation occurs and they can bring it in immediately for diagnosis. This is the same issue as reported for the same year vehicle in July 2022.

The contact owns a 2021 Hyundai Sonata. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. Additionally, the Forward Collision Avoidance failed to function as intended. The contact stated that the sensor was braking prematurely. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated while driving out of the driveway, the vehicle lost motive power. The vehicle failed to restart. The dealer was contacted and made aware of the failure. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was unknown.

I purchased this vehicle brand new. It is still under factory warranty. It has approximately 14k miles on it. I have followed all recommended maintenance procedures. During a routine maintenance appointment at the dealership (Vancouver Hyundai 6802 NE 40th Street, Vancouver WA 98661) they identified a catastrophic engine failure due to internal component deterioration and the engine needs to be replaced. They have had my vehicle in their possession since [XXX] of this year for a total of 134 days. I have a case number at Hyundai # [XXX]. They have not been helpful in providing any information and as of now, I do not know when they even expect to receive a new engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have been to the dealership on three separate occasions due to the engine misfiring. Two ignition coils have been replaced so far and I recently returned to the dealership for the same issue. This time however, not only did the engine light come on but I went from a full tank to less than a quarter of a tank and the engine is making backfiring sounds. At that time the dealership said that they could not recreate the issue, I got my oil changed and went home. That was a week ago, I am back at the dealership today for the same thing; fuel dumping and backfiring sounds. While at the dealership today it turns out those backfiring noises were the fuel tank expanding so much so that it kept popping the seat up. They deemed the car unsafe to drive and it is currently at the dealership.

faulty engine thermostat

I was on the highway going 60 mph then all of a sudden my vehicles rpm's jumped way up to 8 and completely lost power was on I-45 in Conroe thankfully I was in the slow lane. I have attached pictures of my dash so I could get proof this time. I had to wait 7 minutes for the car to do anything. It also burned all of my engine oil. So had to buy oil for my vehicle. I just had my oil change 3 weeks ago. This has happened before on on the frontage road a few months ago. I have claims open with Hyundai Customer Care. I have been stating that my engine makes a clicking noise, it hesitates, and seizes all the time. I have had this problem since March of 2021 and I bought the car in January 2021. I know I am not a part of the engine recall but I should be. I am scared to drive it. Hyundai doesn't care one bit. Well enough is enough I will be getting rid of this death trap. If you are looking at Hyundai's don't waste your time or money.

I have a 2021 Hyundai Sonata SEL with a Smartstream 2.5L engine w/ GDI & MPI. I have have always heard a loud knocking noise coming from my engine since I got the vehicle when in park. When you are accelerating it hesitates and you can hear a knocking noise. I have taken it to the dealership multiple times and they were able to feel and hear what I was talking about but ensured me it was fine. Recently it has been a lot worse. On 10/18/2023 I was getting on to the highway from the feeder. I tried to accelerate to about 50 mph and I heard the same knocking noise and my rpms jumped all the way to the top. Then my car suddenly stopped getting on to the highway. It took it about a minute before I could start driving again. Luckily there was no one behind me because it could've been really bad. I got home and looked under the hood and it looked like oil had sprayed out of the engine. You could to see oil splatter on the fender. No one was hurt thankfully. I have been complaining about the knocking and hesitation while accelerating for almost 2yrs.

The contact owns a 2021 Hyundai Sonata. The contact stated while driving 45 MPH, the vehicle inadvertently lost motive power in the middle of the roadway and failed to restart. The vehicle was pushed to the shoulder of the roadway, where the failure persisted. No warning lights were illuminated. The vehicle was towed to the dealer, who determined that there was no oil in the engine, causing the engine to seize. The vehicle was then towed to another dealer, who confirmed the diagnostic results. The contact stated that an oil change was performed three days prior to the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 44,000.

Mileage: 44,000

The issue is well known across the DN8 platform, hundreds if not thousands of people have this problem.Car and driver even did an article on a car with this same 2.5L turbo DCT engine having the same problem! The problem is the ITMS or thermostat housing unit. I first experienced this getting on to a highway, I lost all acceleration, the turbo dropped to 0 pSI and I received an engine overheating warning on the dash. After pulling over the car resumed normal driving, but with oil temps running 30-40 degrees higher than normal. Since then, I have had loss of boost and acceleration when passing around cars which has almost caused accidents, oil temps constantly running very high and fans constantly running on full blast even after car is off. I have been to the service center 4 times, and they have failed to "replicate" the issue and stated the fan and oil problem is "normal" which it is not. This problem needs to be addressed before somebody gets seriously hurt due to loss of power unexpectedly while driving. PLEASE help! Thank you for your time.

When attempting to pass other vehicles or under quick acceleration such as an on ramp to the highway, the vehicle will experience a sudden loss of power and oil pressure resulting in a fail safe mode which limits your acceleration and causes a sudden decrease in speed and velocity. The issue results in the oil pressure light illuminating and requires the vehicle to be stopped and completely turned off to reset then once turned back on, the problem is “gone” until a sudden acceleration occurs again, which results in the same issue happening. There is a current recall out for similar models but my vin is not listed. I have approximately 50k miles on the car, and am the first owner.

My 2021 Sonata has 32,000 miles & it broke down in the middle of the road. My safety & my daughters safety were at risk. We could have been hit or killed. There were no warning lights. It had to be towed. Repair shop reports the transmission is no good. This vehicle should not have transmission issues. Hyundai will not even cover a rental car. The dealership can’t even work on it for 1-2 weeks. I work & have kids. I need a vehicle. The car breaking down in the middle of the road with no warning is dangerous.

Oct 12: Engine stalled exiting I95 in Kittery Maine. Engine light flashed but did not stay on. Was able to get to safe place but car would not go more than 15mph. Hampton Huyndai reported mis-fire but stated it cleared on its own. Oct 17th: Engine stalled on highway ramp to I495, nearly causing me to be rear ended by other vehicles. Car would not go more than 15 mph. Engine light stayed on. Towed car to Key Salem Hyundai, defective injectors, warrantee repair. Oct 23rd: Car stalls on I93, was able to take immediate exit and turn engine off. Engine light flashed but did not stay on. Took car in to Salem dealership on Oct 24th, no code found. Oct 25th: Car stalls again on city street. Light stays on, Salem dealership replaces cat. convrtr between Oct 26th through Nov 4th. Nov 9th: Car stalls again on city street. Light stays on, currently in Salem dealership. This is a safety issue, in two cases already this car has nearly gotten me in an accident on the highway. I am seeking arbitration for replacement. I am scared to drive this vehicle. I will have a third invoice pending this next repair.

The contact owns a 2021 Hyundai Sonata. The contact stated while driving 65 MPH and attempting to accelerate, the vehicle failed to respond with the check engine warning light illuminated. The contact also heard a knocking sound coming from the vehicle. The contact pulled over on the side of the road and turn off and restarted the vehicle and the vehicle started operating as designed. The vehicle was taken to the dealer and the contact was informed that the transmission and engine needed to be replaced. The manufacturer was contacted but offered no assistance. A case was filed. The failure mileage was 2,700.

Mileage: 2,700

UNKNOWN

Since we purchased this brand new vehicle, we have had in the dealership service department at a minimum of 5 times for same issue. The vehicle accelerates while stopped at a light so we have to put it in neutral to keep it from accelerating. Once we take out of Neutral and release the break, the vehicle accelerates rapidly without stepping on the gas pedal. The computer system always comes on warning that we need to take to dealership because there are engine problems. Then it goes off and comes on again. We have contacted Hyundai to file a complaint and it has gone no where. We have taken it to Hyundai dealership in Tucson and they keep replacing parts per Hyundai manufacturer service tech reps. per same Egr codes. We are taking the vehicle to the dealership again today 9/22/22 because it started again around 9/1/22 and we have been waiting for a loaner car again from Dealership for same problems. Meawhile, being forced to drive it due to only owning 1vehicle. Hyundai Manufacturer has continued to have dealership change out parts and this keeps happening. The vehicle has just over 25K miles on it to date. The first time we had it in the dealership for this problem was on 4/6/22. We have almost rearended several vehicles and are scared to death to drive this vehicle. It is a safety hazard. We purchased the 2021 Sonata vehicle brand new on 11/24/21 along with the lifetime parts and labor warranty. It had 15 miles on it. We also traded our 2018 Hyundai ELantra. We paid off the 2021 Sonata completely in 2021. The total cost of this transaction was $34,294.74.We have also followed all the Maintenance requirements. It is urgent that this complaint is investigated as soon as possible and Hyundai Manufacturer take responsibility now before someone gets killed. The vehicle is obviously a dangerous manufactured vehicle.

The contact owns a 2021 Hyundai Sonata. The contact stated that while the vehicle was at an independent mechanic for an oil change, the mechanic diagnosed the vehicle with transmission fluid leaking from the engine. The mechanic informed the contact that the transmission fluid leakage was flammable. The dealer was made aware of the failure but informed the contact that they were backed up with other vehicles and could not diagnose the vehicle for approximately three weeks. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was 5,600.

Mileage: 5,600