2021 HYUNDAI SONATA Unknown Or Other Problems

I own a 2021 Hyundai Sonata 1.6T, which has an open NHTSA safety recall (25V796000) related to fuel tank pressurization and fire risk. I brought the vehicle to an authorized Hyundai dealership due to a check engine light, reduced performance, and DTC P14EE, which aligns with the recall condition. The dealership refused to treat the concern as recall-related unless I paid a diagnostic fee and later attempted to reclassify the issue as a customer-pay fuel pump repair. During this visit, the dealership replaced a fuel system sensor without my authorization, which I did not approve or consent to. The dealership has not provided documented test results explaining how the recall condition was ruled out and has not documented recall inspection on the repair order. I expressed that I do not feel safe driving the vehicle due to the fuel system recall and drivability issues. The dealership also refused to provide alternate transportation. I am concerned the recall is not being handled in compliance with NHTSA requirements and that unauthorized repairs were performed while attempting to shift a recall-related condition to the customer. I am requesting review of recall handling and dealer compliance.

NHTSA: #25V796000 Recall: #286 2020-23MY SONATA (DN8/DN8A) FUEL TANK Issued on 11/18/2025 and there is no remedy yet for this issue. Hyundai of Ocala has not issued me a loaner car. What am I supposed to do? It’s been over a month since the recall was posted and still no remedy. I’m concerned for mine and my families safety. This car is our only means of transportation. I need a solution

P0471 error comes up off and on, this is recall related but the dealership refuses to address it. The seatbelt has to be clicked 2x in order to stick. Happens with driver side.

The vehicle's HVAC (heating) system failed. It stopped producing heat on one side of the vehicle. My mechanic/dealer diagnosed the issue as a broken component within the HVAC case under the dashboard, requiring full dashboard removal and a repair estimated at over $3,000. This failure prevents the defroster from working properly, which is a major safety hazard as it cannot clear fog or frost from the windshield. A search of online forums and owner communities shows this is a widespread complaint from many other Hyundai owners, often identified as a failed blend door or blend door actuator, which requires the same expensive dashboard removal to repair.

The parking assistant camera on the front of the car is loose, which means that the bracket is broke. I took my car into Hyundai and they could not explain to me how it got broke or came loose and this is a safety issue because this helps you park and see what’s in front of you when parking.

I am writing to formally file a complaint regarding Hyundai’s Recall Campaign 216, which involves a safety defect related to the windshield assemblies of certain Hyundai vehicles. Despite the recall being issued to address the risk of inadequate windshield adhesion due to non-conforming clear coat paint, I have been unable to get my vehicle repaired. I contacted my local Hyundai dealership promptly after learning about the recall; however, they informed me that they were unable to perform the repair at the time due to not having a glass technician on staff/on site. I made multiple phone calls after anticipating the service manager’s follow up, as she promised, with dates a glass technician could be on site. I never heard back after leaving various voicemails or being put through to the wrong departments. This delay is concerning because the recall notice specifically outlines the increased risk of injury in a crash if the windshield is not adequately retained. As a concerned vehicle owner, I am left driving a potentially unsafe vehicle without any clarity on when a proper remedy will be available. I urge the NHTSA to investigate this matter and ensure that Hyundai and its dealerships are prepared and properly equipped to carry out the necessary recall repairs in a timely manner, in alignment with their safety responsibilities. I have attached the email received 7/31 from Hyundai following my customer service complaint I submitted 7/9. Please let me know if any additional documentation or vehicle information is required.

The moon roof made a very loud noise as I was driving down the interstate. It sounded like a loud bang. The safety risk was that I could have jerked the wheel from the scare of the loud sound. My moon roof then shattered and began to fly off.

I bought this car in June 2013 for its safety and its Amazing warranty and all the features that it has Hyundai manufacture had an obligation as a consumer service and failed to send notification of any recalled to us in regards to a recall High pressure, fuel pump, and fuel rail Fuel system engine, gas tank This is a product of liability and negligence on time but they failed to take responsibility and comply with federal laws. I was driving with my family in the car when this car was a ticking Time bomb not even being aware of the Death trap on wheels. We ended having towed our home and then to then had to make a call next day and have it towed to Hyundai service center While we were driving this happen, where we heard two loud pops the gas gauge went down from 200 something to 80 engine lights came right up the backseats were heating up under my son seat in the back stated he felt waves as the backseat was getting hotter, we pulled over to a gas station and that’s when we had to call called O’Reillys and then we called a mechanic friend which stated that he ended up looking up the car and stated please pull over and get out car and called the Hyundai manufacture that there was a recall that’s the only way we found out other than that no prior incidents, then called the service technician of Hyundai i called amd complaint with the Honda manufacture corporate. They have failed to take the responsibility for this and they should be ashamed and take their accountability for this we could’ve died and anyone else around us on road as we drive this car daily The car was a higher risk of a ticking time bomb stated by the Hyundai service center technicians. this is an nere to miss accident narrowly avoid catastrophe

Rearview camera fails to display an image. It does work sometimes but then most of the times the rearview camera does not display any image as seen in the images attached. This issue started occurring recently, that is when I reverse the car, the rearview camera image is not displayed at all. Earlier the rearview camera was working with out any issue when I reverse the car. Issue seems to be same as campaign number: 24V879000

P0741 code tcc solenoid

My car is giving a p0741 code and I was told has something to do with transmission and my car has been jerking.

A semi truck passed me from the opposite direction and caused a gust of wind to be generated diagonally across the car. Both of us were traveling at highway speeds. The gust of wind caused the undercarriage retainers\clips to completely fail. The undercarriage folded back on itself and was pinned on both sides against each tire beneath the car. On the left side, the tire tore part of the undercarriage off as if it had came between the tire and the pavement. I believe this has the potential to cause a loss of control given ideal circumstances. Luckily, neither tire failed and I was able to safely pull to the side of the road to zip tie the undercarriage in place. However, part of the wheel well was shredded.

I live northern suburbs of Illinois. I was backing out of a parking spot when I couldn’t switch gears from Reverse to Drive. My car showed flashing lights and said system malfunction and service immediately. I had to put the safety brake and turn of my car. It took a couple minutes to reset and turn on my car for me to move it.

UNKNOWN Wednesday 7-3-24 I was driving on an interstate at night, going approximately 74mph and my car totally powered down and powered back on with no warnings. Everything on the dashboard and display screen went black. This was totally random and has never happened before. I’m a second owner, previously owned by a rental car corporation. I have no idea if there has been previous recalls that have not been repaired or not.

WAS PARKED IN BANK PARKING LOT. STARTED ENGINE, PLACED CAR IN REVERSE AND CAR ACCELERATED AT A VERY HIGH RATE OF SPEED. (LIKE I WAS IN A DRAG RACE!!) APPLIED BRAKES, WHICH DID NOT SLOW THE VEHICLE DOWN. DID NOT STOP UNTIL I RAN INTO A PARKED CAR. WHOLE INCIDENT TOOK JUST SECONDS. CAR HAD BEEN IN FOR REGULAR SERVICE AT THE DEALERS ON [XXX]. NOW HAS 16,597 MILES ON VEHICLE. CAR TO BE SERVICED AT RACHELS COLLISION, 720 S NOVA ROAD, DAYTONA BEACH, FL ON MONDAY [XXX]. IF I HAD NOT RAN INTO A PARKED CAR, I WOULD HAVE ENTERED [XXX] IN DAYTONA BEACH SHORES, FL WHICH WAS CROWDED WITH MOTORCYCLES.... FRIDAY NOON DURING BIKE WEEK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

1. Vehicle Speed Control 2. I was in a friend's driveway with the car in drive with auto hold activated. Car lunged forward and not able to stop it. Ran into a garage door did substantial damage to home owners property. I guess we were lucky the door took the impact. 3. I took to dealer today to report and have appointment to have looked at on January 8th. They have no previous report of this happening. 4. I have contacted my insurance company, but they are just filing a claim. 5. I was talking to my guest and was not looking at the dashboard, but I saw no warning message after the fact.

The car slowly goes forward after releasing the break

The ITMS is failing causing engine over heating and loss of acceleration at higher speeds.

We received a letter back in Dec 2021 about a recall for our windshield that Hyundai was aware of but there was no fix available. It states that if in a crash it could be real bad because the adhesive on the windshield. However i don't think it should take almost 5 months for a serious recall like this.

I have had my 2021 Hyundai Sonata LES for less than a year and am already having problems with the front windshield. There is “air nose” coming through the windshield when I drive above 55 MPH. There has been recalls for this problem on some 2020-2021 Hyundai vehicles. The 2021 Sonata is one of them. However, when I look up to see if there is any recalls with my VIN number, it shows no recalls. I know my windshield is defective or wasn’t properly installed.

Hello The car shut off on the freeway while driving. The display lit up light a Xmas tree including the forward collision warning. I though this was an isolated incident. It has happened now numerous times. The car even braked on its own then shut off while turning in the middle of a busy intersection. There are several reports of very similar symptoms on Edmonds under reviews. This car is dangerous. I have contacted Hyundai twice now.

On August 23rd, 2021, I was on a business trip between High Point, NC and Greenville, SC. I was operating my own vehicle as the mode of transport. Upon arrival in Greenville, the car began behaving strangely. The transmission was not shifting at typical intervals, at times racing the engine at low speeds. After restarting the vehicle, there was a brief return to normal. Then the vehicle reported a "Check Engine" light and the transmission stopped functioning entirely. Due to capacity issues, I was unable to utilize a local dealership. I used AAA to tow the vehicle to Fort Mill Hyundai in Fort Mill, SC, where it remains to this day. The vehicle threw a P0868 code, which is supposedly a generic error relating to an electrical problem in the transmission.

The contact owns a 2021 Hyundai Sonata. The contact stated that after driving out of the garage and parking in the driveway with the engine idling and remote smart parking assist feature activated, 6 minutes later the vehicle suddenly began to slowly roll forward into the garage area making contact with a second vehicle that was parked in the garage before crashing into the back of the garage wall and stopping. During the incident, no injuries were reported, and no police report was filed. The vehicle was taken to the local dealer who was unable the duplicate the failure. The manufacturer was also notified of the failure. The approximate failure mileage was 1,400.

Mileage: 1,400

Excessive wind noise is coming from the driver side window when speeds are over 55mph+. A lot of other owners on the forums are experiencing the same problem.

SEEMS TO BE AN ISSUE WITH THE WIRELESS APPLE CAR PLAY. REGARDLESS IF THE VEHICLE IS IN MOTION OR NOT IT LOSES CONNECTIVITY. WHILE DRIVING THIS CAUSE YOU TO TAKE YOUR EYES OFF THE ROAD AS MESSAGES APPEAR ON THEIR INFOTAINMENT SYSTEM. CALLS ARE DROPPED, NAVIGATION STOPS SO WHILE YOU ARE LOOKING AT THE MESSAGES YOU'RE NOT PAYING ATTENTION TO THE ROAD. APPLE IS AWARE BUT HAS NOT RESOLVED IT. HYUNDAI IS AWARE BUT HAVE NOT RESOLVED IT. THE INTERNET IS LOADED WITH ISSUES FOR THIS SITUATION. NOT SURE IF THIS IS SOMETHING YOU CAN ASSIST WITH BUT I'M ASSUMING AT SOME POINT THEIR WILL BE ACCIDENTS BECAUSE WHEN THIS HAPPENS YOU CAN'T USE THE HANDS FREE OPTION AS IT ALSO STOPS WORKING.