2005 HYUNDAI TUCSON Power Train Problems

The contact owns a 2005 Hyundai Tucson. The contact stated that on several occasions while driving 65 MPH and attempting to accelerate, the RPM failed to raise, and the vehicle failed to respond. No warning lights were illuminated. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 105,000.

Mileage: 105,000

INITIAL ISSUES ON VEHICLE PRESENTED IN JANUARY 2021 WITH VARIOUS CHECK ENGINE LIGHT CODES INCLUDING P0133. ALTHOUGH VEHICLE PASSED EMISSIONS IN 2020, VARIOUS CHECK ENGINE CODES FOR MASS AIR FLOW SENSOR, OXYGEN SENSORS, MISFIRE FOR VARIOUS CYLINDERS. AFTER REPLACING INDICATED MASS AIR FLOW SENSOR, OXYGEN SENSORS INDICATED VIA OBD II TOOL, BATTERY, ALTERNATOR (MORE THAN ONCE), BOTH FRONT CV BOOTS, HEAD GASKET SEALS FOR BOTH CYLINDER BANKS, MORE CHECK ENGINE LIGHT ISSUES APPEAR ACCORDING TO THE VEHICLE. CURRENTLY ANOTHER CYLINDER MISFIRE CHECK ENGINE CODE HAS APPEARED AFTER ALL SPARK PLUGS HAVE BEEN REPLACED WITH OEM RECOMMENDED BRAND REPLACEMENTS (NKG PRE-GAPPED SPARK PLUGS). THE MISFIRE CODE HAS CLEARED AT THIS TIME. THE CURRENT CHECK ENGINE CODE FROM THE OBD II TOOL IS ERROR CODE FOR DRIVE TRAIN DRIVEABILITY P0420 REGARDING CATALYST SYSTEM OPERATING BELOW THRESHOLD AT BANK 1. I HAVE UTILIZED LOCAL STORE CATALYTIC CLEANER LIQUIDS TO CLEAN THE SYSTEM, WHICH HAS NOT RESOLVED THIS ISSUE. ADDITIONALLY, BEGINNING IN JANUARY 2021, THE VEHICLE WAS TAKEN TO THE CLOSEST LOCAL DEALSHIP FOR A LARGE MAJORITY OF THESE REPAIRS INCLUDING A $150 DEALERSHIP FEE JUST TO HAVE THESE CODES REVIEWED AND ADDITIONAL FEES FOR THE LABOR TO ADDRESS FOR EACH ISSUE FOR EACH REPAIR.

Mileage: 218,900

VEHICLE WILL START MOVING IF ON AN INCLINE WHILE IN PARK. DEALER HAS ADJUSTED SHIFTER CABLE SEVERAL TIMES AND KEEPS RETURNING TO THE BEING ABLE TO PUSH THE CAR WHILE IN PARK CONDITION 9-12 MONTHS LATER. THEIR APPEARS TO BE NO FIX.

Mileage: 80,000

WELL TRANMISSION ITS SHAKING WHEN I GO OVER 65MPH AND THIS IS NOT NORMAL.

Mileage: 100,000

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. AFTER THE CONTACT RELEASED THE BRAKE PEDAL AND DEPRESSED THE ACCELERATOR PEDAL, THE VEHICLE FAILED TO ACCELERATE. THE CONTACT STATED THAT THE FAILURE ALSO OCCURRED WHILE DRIVING UP A HILL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE ALTERNATOR AND SERPENTINE BELT WERE REPLACED, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE PLANT THAT BUILT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 159,000.

Mileage: 159,000

TRANSMISSION KEEPS SLIPPING OUT OF GEAR WHEN YOU PUT INTO GEAR AND CAR WON'T MOVE. YOU STOP AT A LIGHT AND EVEN THOUGH CAR IS IN GEAR IT WON'T MOVE. FLIP IT BACK AND FORTH ON AUTO GEAR SHIFT SOMETIMES IT MOVES. OTHER TIMES IT CHANGES GEARS OR SLIPS OUT. *TR

Mileage: 50,000

WHILE STOPPED AT A LIGHT THE ENGINE REVVED UP TO A HIGH RATE. I TRIED TO PUT THE TRANSMISSION INTO NEUTRAL BUT PUT IT INTO REVERSE INSTEAD, THE HIGH RATE OF REVS CONTINUED, FINALLY GOT IT INTO NEUTRAL AND ENGINE WENT BACK TO NORMAL IDLE SPEED. WHEN LIGHT CHANGED PUT TRANSMISSION INTO DRIVE AND PROCEEDED HOME (A FEW BLOCKS) WITHOUT INCIDENT. THIS HAPPENED ABOUT 13 MONTHS AGO WHEREBY THE MECHANIC REPLACED THE IDLE SPEED CONTROL AND THROTTLE POSITION SENSOR. ALSO THEY DID A THROTTLE BODY AND FUEL INJECTION SERVICE AT THAT TIME. *TR

Mileage: 49,143

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, SHE ATTEMPTED TO ACCELERATE FURTHER, BUT THE VEHICLE WOULD NOT ACCELERATE BEYOND THAT SPEED. THE VEHICLE REMAINED STUCK IN THIRD GEAR WHILE THE CONTACT ATTEMPTED TO ACCELERATE FURTHER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AT LEAST SIX TIMES, BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT BACK TO THE DEALER. THE FAILURE MILEAGE WAS 47,000.

Mileage: 47,000

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED WHILE DRIVING 45 MPH, THE ENGINE COMPLETELY SHUT DOWN WHEN THE ACCELERATOR WAS NO LONGER DEPRESSED. THE VEHICLE WAS TAKEN TO A DEALER, AND THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 57,000 AND THE CURRENT MILEAGE WAS 57,500.

Mileage: 57,000

MY WIFE'S HYUNDAI TUCSON (EITHER 2005 OR 2006) ALMOST CAUSED AN ACCIDENT TODAY WHEN THE ACCELERATION BECAME ERRATIC AND THEN STALLED WHILE AT AN INTERSECTION. SHE IMMEDIATELY BROUGHT IT INTO OUR HYUNDAI SERVICE CENTER. I SPOKE WITH A SERVICE MANAGER TO TELL HIM ABOUT A TPS (THROTTLE POSITION SENSOR) PROBLEM THAT I HAVE FOUND OUT ABOUT SPECIFIC TO THE 05-06 HYUNDAI TUCSON. I ALSO CALLED HYUNDAI BECAUSE THIS PROBLEM WILL NOT SHOW UP AS A 'FAULT CODE'. I HAVE INCLUDED HERE ONE OF MANY NOTES FOUND ON THE INTERNET CONCERNING THIS SAME PROBLEM: AFTER HAVING OUR 2006 TUCSON IN THE DEALER'S SERVICE SHOP FOR OVER THREE DAYS, IT WAS DETERMINED THAT THE CAR NEEDED A NEW TPS(THROTTLE POSITION SENSOR). THIS WAS AFTER THEY CONTACTED HYUNDAI TECHLINE AND AFTER I SUGGESTED THAT THEY TEST THE TPS AS A POSSIBLE CAUSE (CAME TO THIS CONCLUSION AFTER REVIEWING MANY WEBSITES/AUTOFORUMS. SOME FACTS: YOU WILL NOTICE A STUTTERING OR JERKING FEELING ALMOST AS IF YOU HAD A MANUAL TRANSMISSION, WERE DOWNSHIFTING AND RELEASING THE CLUTCH QUICKLY WHEN THE ENGINE RPM WAS NOT MATCHED TO THE LOWER GEAR, OR AS IF YOU TAPPED ON THE BRAKE TWICE WHILE DECELERATING. THIS MOTION CAN BE EITHER VERY SLIGHT OR RATHER VIOLENT (ONCE CAUSED US TO BE ACTUALLY PUSHED AGAINST OUR SHOULDER SEAT BELT. 1. ALMOST ALWAYS OCCURS WHEN EITHER COASTING OR DECELERATING, NEVER WHEN ACCELERATING. 2. USUALLY HAPPENS BETWEEN 40 -45 MPH. 3. NO FAULT CODE EVER COMES UP SO DON'T EVEN HAVE THE TECH WASTE HIS TIME. THE SERVICE DEPARTMENT DROVE THE CAR FOR OVER THREE TOTAL HOURS TO TRY TO GET A FAULT CODE READING WITH NO RESULTS. 4. CAR WILL STALL WHEN COMING TO A STOP 50% OF THE TIME. 5. HAPPENS WHEN THE TRANSMISSION IS WARM. 6. FEELS LIKE TRANSMISSION IS TRYING TO FIGURE OUT WHAT GEAR IT WANTS TO GO INTO WHEN DECELERATING. *TR

Mileage: 60,000

PROBLEMAS CON EL POWER TRAIN. HISTORY = EN EL PRIMER AO SE DAO CD PLAYER LO CAMBIARON PERO EMPECE A TENER DIFICULTADES CON EL HORN POR UN MAL ENTENDIDO CAMBIARON EL CLOCK, HASTA LA FECHA NUNCA ME ARREGLARON EL HORN EL CUAL DEJA Y EMPIEZA A FUNCIONAR EN CUALQUIER MOMENTO. EL VEHICULO EN VECES PRENDIA LA LUZ DEL "CHECK" PERO POR UNAS HORAS O UN DIA EL DEALER NUNCA ENCONTRO NADA EN VECES TAMBIEN SE DABA COMO JALONES COMO QUE SE QUERIA PARAR, SE LLEGO A PARA 3 VECES, LOS DEL DEALER NUNCA ENCONTRARON NADA SIEMPRE LA LLEVE AHI PARA MANTENIMIENTO Y CAMBIO DE ACEITE, ELLOS COBRAN DEMASIADO POR LOS SERVICIOS, YA CAMBIE HEADLIGHTS 2 VECES Y OTRAS LUCESITAS DEL FRENTE, SE CAMBIO SERPENTINE BELT,BATERIA , LLANTAS, PARABRISAS, FRENOS; EN LOS ULTIMOS 9 MESES CAMBIE A OTRO LUGAR PARA CAMBIO Y CHEQUEO DE FLUIDOS. EL 12/17/09 7AM, PRENDIO A LA 3RD VEZ QUE TRATE FUI Y VINE AL TRABAJO Y CASA SIN PROBLEMAS, POR LA TARDE SALI A LOS 15 MINUTOS SE EMPEZO A JALONEAR Y CADA VES QUE BAJABA LA VELOCIDAD SE QUERIA APAGAR EL MOTOR LO CUAL SUCEDIO AL HACER ALGUN STOP, PERO LA PRENDIA DE NUEVO SIN NINGUN PROBLEMA AL REGRESO A CASA VOLVIO A PARARSE VARIAS VECES, ADEMAS SE PRENDIO LA LUZ DE "CHECK" Y A LOS 5 MINUTOS SE PRENDIO OTRA QUE POR EL SEOR QUE LEVANTO EL VEHICULO SE QUE INDICABA PROBLEMAS EN EL "POWER TRAIN" Y MENCIONO TAMBIEN EL 4X4. TOTAL QUE AL PRENDER ESA LUZ YA NO QUISO LEVANTAR LA MARCHA NOMAS COMO A 1 MILLA POR HORA Y ESO JALONENDOSE MUCHO, BUENO POR UNA U OTRA RAZON YO HABLE HASTA EL 12/29/09 PARA QUE LA LEVANTARAN Y HASTA HOY SE ME COMUNICO QUE TENIA UN SENSOR DAADO ALGO ASI COMO "THROTLE POSITION CENSOR" POR LO CUAL ME QUIEREN COBRAR 455.00 + TAXES. YO NO TENIA IDEA DE ESTE SITIO, Y CREO QUE TENIA DERECHO DE QUE SE ME COMUNICARA EN EL DEALER ACERCA DE TODOS LOS RECALLS PARA ESTE TIPO DE VEHICULO, ESTOY INSATISFECHA CON EL VEHICULO Y POR LOS ALTOS COSTOS DE MANTENIMIENTO QUE HE TENIDO QUE PAGAR DE ALGO QUE YA SABIAN QUE EXISTIA. NECESITO AYUDA URGENE, PLEASE. *TR RECEIVED COMPLAINT WRITTEN IN ENGLISH.

Mileage: 66,000

DT*: THE CONTACT STATED WHILE STARTING THE VEHICLE, IT LURCHED FORWARD AND WOULD NOT ENGAGE INTO GEAR. ALSO WHILE DRIVING, THE 4WD LIGHT INTERMITTENTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES WHO COULD NOT DUPLICATE THE PROBLEM.

Mileage: 22,000

THE PROBLEM WAS DISCOVERED AFTER A STOP FOR FUEL DURING A HIGHWAY TRIP. THERE WAS NO INDICATION OF TROUBLE BEFORE WE STOPPED FOR FUEL. WHEN WE ATTEMPTED TO RETURN TO THE ROAD WE FOUND THAT THE TRANSMISSION WOULD NOT ENGAGE IN EITHER A FORWARD OR REVERSE GEAR. AFTER CHECKING ATM FLUID AND FINDING IT CORRECT WE TRIED AGAIN AND FOUND SAME PROBLEM. WE FINALLY FOUND THAT IF WE INCREASED ENGINER RPM TO APPROXIMAGE 3000 RPM THE TRANSMISSION WOULD BEGIN TO ENGAGE IN THIRD GEAR WITH SOME SLIPPAGE. THE SLIPPAGE CONTINUED UNTIL WE REACHED THE APPROXIMATE SPEED FOR NORMAL THIRD GEAR. AT NORMAL HIGHWAY SPEED THE CAR OPERATED NORMALLY BUT WOULD NEVER SHIFT INTO 4TH GEAR. WE WRE ABLE TO GET HOME AND TO THE DEALER. THEY TOLD US THE TRANSMISSION HAD FAILED AND WOULD NEED TO BE REPLACED. ONE WEEK LATER AFTER INSTALLATION OF THE TRANSMISSION WE WERE TOLD THEY DID NOT LIKE THE SOUND OF THE POWER STEERING AND WOULD REPLACE THAT COMPONENT AS WELL. ANOTHER WEEK LATER WE GOT OUR VEHICLE BACK. THE DEALER CLAIMED THEY HAD NOT SEEN THIS PROBLEM NOR HAD THEY BEEN NOTIFIED OF THIS PROBLEM BY OTHER DEALERS. THIS OCCURRED AT 9500 MILES.

DT: CONSUMER STATED: SHIFT LEVER CABLE ASSEMBLY BROKE WHILE IN TRAFFIC AND VEHICLE HAD LESS 400 MILES. WAS SLOWING DOWN, CHANGING GEARS AND BROKE OFF INSIDE. VEHICLE WAS STUCK IN CENTER LANE, AND NO FOR WARNING. *AK

Mileage: 397

NEW HYUNDAI TUCSON 5 SPEED MANUAL 4 WHEEL DRIVE(2005) WITH LESS THAN 400 MILES DRIVEN, THE SHIFT LIVE BROKE OFF INSIDE TRANSMISSION. THIS WAS LIFE THREATINING. I WAS IN THE CENTER LANE EAST BOUND ON THE CROSS BRONX EXP. CAR COULD NOT MOVE. I WAS ABOUT ONE MILE EAST OF THE G.W. BRIDGE. THE PROBLEM WAS THE SHIFT LEVER CABLE ASSEMBLY DEFECTIVE. IT WAS REPLACED.

Mileage: 397

I WAS DRIVING DOWN THE HIGHWAY AT 60MPH WHEN THE VEHICLE MADE A LOUD SOUND A ROUGHLY JERKED FORWARD AND CONTINUED TO DO SO AS THE CAR GRADUALLY DOWNSHIFTED. THE CAR WAS FOUND TO HAVE A DEFECTED TRANSMISSION CONTROL MODULE AND THEY NEEDED TO REPLACE THE TRANSMISSION DUE TO THIS. THIS VEHICLE ONLY HAD APPROX 5900 MILES ON IT AT THIS TIME. RECIEVED THE VEHILE 9 DAYS LATER AND HAD THE CAR FOR 1 DAY WHEN IT CONTINUED TO HAVE MORE PROBLEMS RELATED TO THE TRANSMISSION. IN ADDITION TO THIS PROBLEM, THE FIRST FEW DAYS OF OWNING THIS VEHICLE I HAD TO STOP THE VEHICLE ABRUPTLY AND THE CAR ACCELERATED INSTEAD. I HAVE READ THAT OTHERS HAVE EXPERIENCED SOMETHING SIMILIAR TO THIS IN THE HYUNDAI SANTE FE