2020 HYUNDAI TUCSON Engine Problems

Vehicle excessively burns oil, engine drives rough, exhaust developed smoke, burnt smell in engine, engine and oil gauge light comes on.

The contact owns a 2020 Hyundai Tucson. The contact stated that the vehicle unintendedly shut off while driving. The vehicle was restarted. There were no warning lights illuminated. The local dealer was contacted and scheduled an appointment. The vehicle was not yet diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.

Mileage: 70,000

the engine failed without warning. While going up a hill the car lost power. Yes, the dealership said it was a known problem. Yes, the dealership fixed the problem by putting in a new engine which I was responsible for 5% of the cost which was 739.66. The only warning that was given was after the car failed, the engine light and the oil light went on.

My adult son was driving and under the hood started to smoke. He pulled over and opened the hood to take a look and then a fire started under the hood! The fire department was called and they put out the fire, cut the gasoline and duct taped it up so the fuel line would not further ignite the hot engine. My insurance is looking into what would have caused a random under the hood fire. Luckily no one was injured. However the engine section of the car is melted beyond belief. My insurance has not told me if the car is repairable or not.

My engine is burning excessive amounts of oil, which is a "known issue" of Hyundai Tucsons. After an oil change with full synthetic oil, I cannot drive my vehicle more than 4,000 miles without reaching dangerously low oil levels. Most importantly, there is no clear indicator of this low oil level—no light that comes on and STAYS on to tell me as the driver to check the oil and see if there is a problem. Instead, if I brake too hard or take a turn to sharply a red oil light will turn on for 1-2 seconds and then turn off again. It is easy to miss. The first few times this happened in May I thought perhaps there was a loose wire on the sensor. After it appeared 3 or 4 times I took it to a mechanic who told me the oil level was so low that they had to add 2 quarts of oil just to have it register on the dip stick. The excessive oil burning is a known issue that Hyundai fights tooth and nail to avoid correcting. But to not have a warning indicator that the oil is at a dangerously low level is reckless on Hyundai's part. The engine could have seized up, thrown a rod, or any number of consequences. I had my oil replaced by Hyundai in May as part 1 of their oil consumption test. My car passed their 1000-mile test and 4,000 miles later I was in dangerously low oil territory again. Thankfully, I knew what to look for this time. Cars should not consume oil at this rapid of a rate but even if they do drivers should be notified about low oil levels via car sensors to keep them and their passengers safe.

Car was fine and I get regular oil changes. Last week all the sudden the car started making noise and just shut off. When my husband checked there was no oil on the dipstick but I park on concrete and the car is not leaking oil. Apparently the motor is blown and completely locked up.

High oil consumption leading to costly repairs outside of warranty.

Vehicle is burning an extreme amount of oil between regular oil changes. We are having no help from our local dealership in Tuscaloosa, AL where we purchased the car to resolve this issue without first spending a lot of money to diagnose an issue we certainly already have. Long before it was due for routine oil change, we checked it and it was COMPLETELY EMPTY of oil. NOTHING IN IT. We have to put oil in it three times before its next routine service. We have always had the vehicle serviced, on schedule, by our local Hyundai dealership and are the only owners of the car.

The contact owns a 2020 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the low oil warning light briefly illuminated. Upon inspecting the vehicle, the contact noticed that the engine oil level was low. The vehicle was taken to the dealer, where the contact was informed that the engine was not consuming oil and that an oil change was needed. The dealer advised the contact to return after 1,000 miles to inspect the oil level. The vehicle was taken back to the dealer; however, it was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 72,000.

Mileage: 72,000

Engine oil excessive consumption/burning oil

In between my last 3 oil changes I have “lost” all of my oil in my car. Checked my oil randomly and there was NO OIL at all on the stick. After this last change I have checked it every week. I did not check for 2 weeks less than 1,000miles and it was below the low on the mark. Obviously running out of oil while driving is not safe and can cause the engine to blow. This can cause a crash or fire. There have been numerous issues with this and the cars need recalled. This is ridiculous.

the car started using a little oil around 80,000 mile, and its just gotten worst , to the point that's it using 1 quart per 150 miles the car runs ok but its ridiculous the amount it is using. and from what I've found researching there is a lot of complaints

Engine run hot smoke from engine car cut off wouldn't restart had totaled to Hyundai company in Lithia Springs Ga was told by service guy that engine locked motor needed replaced. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Heavy oil consumption problem - burns through oil completely every 300 miles. Replaced catalytic converter once already.

MOTOR IS CONSUMING A LOT OF OIL. I need to CHANGE EVERY month, which IS VERY EXPENSIVE

Excessive oil consumption. Confirmed by Strickland service centers on last 2 oil changes. Engine is at risk of failure if oil level drops.

Car is burning through oil at a rate of 5L per week.

Car broke down first time about 2.5 months ago. It was towed to Fred Beans Hyundai of Doylestown PA and they did oil testing on it and I was told that the car was burning oil too fast. They told me under warranty they needed to do a carbon combustion cleaning. So that was down, and less than 24 hours of having the car back, the check engine light came back on, the car wouldn’t drive above 50 miles per hour, and was jumping forward (the same thing that happened the first time) I had the car towed back to the dealership and they told me there was still leftover carbon and it needed to cleaned out again. The car was fine for about 2 months, however just today it broke down again. Same problem, check engine light came on and started flashing, the car will not go above 50 MPH and it jumps forward. I have now been given back a car that is unsafe to drive and put my family and 2 times. Clearly the dealership is not fixing the actual problem at hand and continues to put my family and i’s safety at risk. Each time the car has broken down I have been on the pa turnpike and been put in an extremely dangerous situation.

The contact owns a 2020 Hyundai Tucson. While the contact’s daughter was driving at an undisclosed speed, there was an abnormally loud knocking sound coming from the vehicle before the engine seized. The vehicle was towed to the dealer; however, the vehicle was not yet diagnosed or repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 83,500.

Mileage: 83,500

High oil consumption. Car shaking , sputtering, Shutting off in traffic. Replaced spark plugs 3 times in a year. Having to top oil off every other week because there will not be any oil in engine. Stopped in traffic.

Engine is consuming 3+ quarts per 1000 miles. There is no low oil warning light or notification, just a low oil pressure light which could be caused by many things that would not cause a vehicle fire like low oil would. Hyundai was contacted and we were told that all we need to do was get our oil changed with them, come back in 1000 miles to check the level, if it was consuming greater than 1 quart per thousand miles we would be scheduled for a combustion chamber cleaning (service tech said this would do nothing to solve the issue), drive 1000 more miles and check level again, and if it was greater than 1 quart per thousand we would be scheduled for a new engine. They were informed that we were the second owner and we were told that shouldn’t be an issue. After completing the oil change and going in after 1000 miles we were told that the engine consumed approximately 3 quarts of oil. That information was apparently submitted to Hyundai and they said we were not approved for the combustion cleaning because we were the second owner. The safety of the vehicle was not taken into account at all and Hyundai did not show any concern of vechile fires even though low oil is a contributing factor to many scenarios that can cause injury or death.

The contact owns a 2020 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that several unknown warning lights were illuminated. The contact was able to pull to the side of the road. The contact called a towing service to jumpstart the vehicle. The vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed that the crankshaft bearing failed due to foreign material in the engine and oil consumption. The contact was informed that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately 122,000.

Mileage: 122,000

Excessive oil consumption in the engine. 1 Qt every 900 to 1000 miles. This has been going on a while.

Car had check engine light come on and found out that it had been using oil. Engine started using more than 1 quart of oil every 1000 miles. Catalytic converter had to be replaced because it was plugged. Car had less than 80,000 miles on it when this started happening.

This call actively has a recall on engine rods any Hyundai and some Kia models ranging from 2011 all the way until 2022. They are known for having a faulty motor with active oil consumption and are currently facing several lawsuits and my car is one of these cars facing this issue however, the manufacturer doesn’t want to Fully create a recall on the motor claims that are causing this rapid oil consumption issue I would like this to be investigated as well as it be investigative why you don’t already have their current active recall listed on your website . but if your website was correct and listed the engine, Roddery call, and if my engine rod were to blow, then they would actually address this issue however, some people are getting this issue addressed under their manufacturer warranty however it is becoming extremely difficult because they want us to pay out-of-pocket for a pointless test as newer vehicles should not be burning oil with no active problems. Clearly, the states there is a problem which there is as of all the active lawsuits.

Excess Oil consumption cause the engine to die and the car to stall out in the middle of the road. Engine needs completely replaced.

This engine been consuming tons of oil in it and I keep having to add more oil to it and it doing same thing with the coolant causing the engine to heat up a lot and smoked too

The oil pump failed, causing the car to die while on the interstate. There was no prior signs nor warnings to this issue, and it caused the engine to lock up, meaning that the engine now needs to be replaced. This is not unheard of with Hyundai’s.

2020 Hyundai Tuscon engine continually consumes an excess amount of oil on a weekly basis causing cylinder knocks. This vehicle has been routinely maintainanced and continues to experience this issue which is an issue known by the manufacturer and has yet to be addressed seriously by the manufacturer. The vehicle is just out of warranty; however, the issue stems from known engine faults that are the responsibility of the manufacturer.

The check engine light became flashing and the vehicle went into limp mode while occupied by two adults and one minor child as they were merging to access the freeway

I went to Thompson Automotive to finance a vehicle and within a month and half my engine blew. There were no engine lights, no lost of oil, no warning, no signs of any error, before this series of malfunctions took affect. I was on my way to the dealership and my car being slowing down to a complete stop as I was getting off the highway ramp. I was traveling at the speed of 25mph, when the car started to make loud noises that I never heard before that day, and completely shut down in front of a huge tractor trailer in traffic. The dealership has had my car since 6/7/24. Now the car has about 85,000 miles on it. I have to pay another $3,000 for my portion to get a new engine. Which is outrageous considering I just agreed to pay $19,990. I am highly disappointed that I lost my job and everything behind this horrific situation that actually feels like a set from the beginning. Now that I’m reading all the comments and unfortunate but very similar situation everyone is suffering from with the particular car. I can’t fathom why it’s still on the market to be purchase for consumers with these major and potentially deadly problems.

I was driving 45mph on a major road when, the vehicle with out warning lost power, I heard rattling, lost power. I turned it back on by the power button, drove into gas station where the check engine light flashed, oil light flickered and didn't turn back on. Car was rattling, turned it off. Got out, checked engine under hood and components. Dip stick had oil. Car had no signs of anything else. Vehicle would not start, called tow. Waited 5 hours for tow. Did not hear back from Hyundai dealership in a month. Submitted all articles of maintenance. Going on two months and was told to resubmit. Three months prior, engine over heated due to original hose component coupler piece melting.

Check engine light came on and went off again prior to waiting the 2 weeks for service. Infamous code P0420 catalytic converter bank 1 code where manifold, catalytic converter, and O2 sensor were replaced at a measly 37k miles.

This is the second Hyundai Tucson that I have owned and the same thing has happened wih both of them. My daughter also bought her Hyundai Tucson the same day as I got mine in June, 2020, and the same thing is happening to her. It starts with the engine warning light coming on, and then finding that the engine oil is low in between oil changes. There is no visible sign of the oil leak (no drops on the driveway, no oil in the engine compartment, etc.) but now the oil is disappearing at an alarming rate. My daughter has had her car looked at, and it appears that she may have to get a new engine, which is what happened with my previous Tucson (2015). Luckily, Hyundai "good-willed" me the replacement of my previous engine, but now I am at, or close to the limit on my extended warranty (for which the dealership did not give me paperwork), and have an engine that is just disappearing engine oil. Hyundai has to know of the issue, but refuses to make corrections to the problem which sticks people with huge bills to correct a problem they know exists. I have seen MANY complaints about this exact thing, so it's not a secret.

On 8/7/2024 the engine light came on and stayed on. I took the car to my service pro and he did a pcm scan. Error code displayed a catylitic problem on bank 1. This is the secind time this has happened to this vehicle. First time was 2/13/2023, Mileage was 52000 miles. Salem Hyundai replaced the Cat with a new one. On 8/8/2024 I called Salem NH Hyundai to report the issue and have an appt for 8/14/2024. Milage on vehicle is 77181.

Had for a year. 6 months ago, started sputtering, surging, slowing and dying on a regular basis. Have had it shop at Chapman used in Tucson, AZ and Lawley Hyundai in Sierra Vista Arizona 3 times. Chaan couldn't repair, so we went to Lawley. The mechanism there keep saying they cannot reproduce! The engine malfunctions 3-4 time during any drive we do. Has been going on for 6 months.

The vehicle is a 2020 Hyundai Tucson with AWD. Current mileage of the vehicle is 58,309. In the last 10K miles, there have had 4 separate instances of a sustained flashing check engine light that has put the car into limp mode. Since the first instance, a knock sensor, catalytic converter, and spark plug coil, among other things, have been replaced. However, the issues persist and have yet to be resolved. The engine continues to misfire, resulting in dangerous driving situations. Most recently (XXX) the car went into limp mode on an interstate highway where the vehicle was unable to accelerate and could not exceed 2000 RPMs. The code scanner read P1326 - Glow Relay Short Circuit. This was just a week after the vehicle was towed to McGovern Hyundai in Brockton, due to the car being in limp mode (XXX) and the vehicle was given a clean bill of health. I was told that there was no cause for concern and the code was cleared. I’m extremely concerned about this issue with the vehicle and don’t feel that it is safe to drive, especially when it loses power on the highway. The vehicle is insured, but has not been inspected by an insurer. Nor has the vehicle been inspected by police. The car has been inspected by the dealership, but that have not produced any findings. The car is certainly available for inspection upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the vehicle independently decelerated. In addition, the check engine warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed with a knock sensor failure. The contact was informed that the knock sensor needed to be replaced. The vehicle was repaired. The failure reoccurred. The vehicle was towed to the dealer where it was diagnosed with a failed engine and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 101,196.

Mileage: 101,196

I was driving home last week when I came across a large crash on the highway. Traffic was backed up for a mile. I decided to turn around through one of those crossovers and head a different way home. I accelerated to catch up to the oncoming traffic when my car suddenly sounded more loud like it was struggling to accelerate. I got onto the off ramp and my car slowed from 70mph to 40mph and would not go any faster. It began lurching and I decided to try to get off the highway and get as close to home as I could as it was 9pm. My car slowed to a stop and the oil light and engine light and battery light came on. A few moments later the whole dashboard lit up and the car died. I popped the hood and to my horror there was literally no oil in my car. My oil light never came on and my oil change service notice never came on at any point. I took it to a dealership where they told me my engine has blown and needs replacing. This engine experienced the same issues as listed in the lawsuit earlier this year, only my 2.4L was not included as an affected model. This car only has 88,000 miles on it and has had at least 9-12 oil changes. My car was working normally until it shut down, no warning, no lights, and no other issues this entire time I’ve had it. I was broken down on a country road in the middle of the night with no phone service. Hyundai claims my car was not one of the engines affected by the recall or lawsuit, yet my car did exactly what others stated happened to theirs.

The "check engine" light has come on at least three (3) times. The first time, the car went into slow down mode. We stopped at a mechanic, who reset the computer so that we could drive it. We then had it towed to our mechanic, who told us about the problems these Hyundai engines are having. He told us that engine replacement was inevitable. It happened two (2) more times. This time, we had it towed to a Hyundai dealer. The first time, they kept the car for two weeks, only to tell us that they could not "replicate the problem". We opened a file with Hyundai USA [Hyundai Case Management #: [XXX]. It happened again. Same message: "Could not replicate the problem." The blogs are full of horror stories about the engines failing during high speed travel. [XXX] The Virginia Lemon Law does not apply until at least three (3) attempts have been made to repair it at a Hyundai authorized service provider. Our only options appear to be suing Hyundai, or continuing to drive it, running the risk of an engine failure/shutdown at high speed, or trying to sell it to CarMax with a known safety issue. The attached documents show when the incidents occurred. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I turned on a road that the speed limit is posted 55mph and I accelerated up to about 50 and suddenly my speed dropped back to about 10mph and the car began shaking and the engine light was flashing. There was absolutely no warning at all. I had left my house about 15 minutes prior and everything was fine while I was driving up until then. My engine failed. If I had entered an busy highway I would have most likely caused a Major Accident and been killed and/or killed others. It happened around 5:00 A.M. in the dark which was bad enough as I was alone on my way to work. I had it towed to the Dealership and they replaced the knock sensor and assured me that the car was perfectly safe now. But on Dec. 1,2022 I was driving on a 35 mph road and the car did exactly the same thing and I had to be towed again.This time after much arguing the engine was condemned and replaced.

Jan '22 - Reported check engine light had begun to turn off and back on when gas tank was low. Feb '22 At 19k miles catalytic convertor reported failed for code (P0420), 3 way catalyst, upper and lower gaskets, and manifold all needed to be replaced - took 4 days Aug'23 called to request service for check engine light because it was coming off and on over periods of time. Scheduled for Sep'23 Sep '23 service reports new cat quoted for code P0420, I was not verbally informed by service advisor. 16 Nov '23 driving home and car starts to shake and is slow to accelerate, check engine light started to flash, car enters limp mode, could not drive safely on highway and waited hours for a tow. Codes P0420(cat convertor), P1326 (Knock sensor) 25 Nov '23 picked up car, had catalytic convertor, manifold gasket, knock sensor replaced. Drove 27 miles and car check engine light begins flashing again (P1326) on freeway while merging. Car hesitates, starts to slow, had to merge over to shoulder from far left lane as car had no acceleration. I felt unsafe to exit vehicle being 9 months pregnant. Waited 2 hours for tow back to service dept the same day I picked up vehicle. 8 Feb '24- picked up car from service department. They performed engine combustion chamber cleaning and reported excessive cylinder wall scoring. Service advisor feels confident this fixed the problem. I feel unsafe driving a car that has left me stranded multiple times on busy highways and freeways, especially with children. The manufacturer keeps replacing parts and cannot seem to diagnose issue, they keep repairing problems caused by a major issue that has not been diagnosed.

The oil is burning up so fast. Every oil change that is within the mileage limits they tell me my car is bone dry. If the oil in my car runs out my car engine can blow up or it can stop working. The only way it has been reproduced is that every oil change for 2 years now they have told me it’s bone dry. It has not been inspected by manufacturer. They told me it would cost about $400 for them to even just check it out. There are no warning lights at all.

While driving down the interstate to go back to my college, I noticed a cloud of white smoke coming out of my exhaust. Seconds later, I no longer could accelerate and white smoke was also coming out of the engine. There were no lights on my dash at this point or at any point before this day. I quickly tried to get off of the road when I noticed my car was no longer going. I managed to get to the side of the road where finally my engine and oil light came on. I waited 2.5 hours for a tow truck on the side of the interstate, where I was barely off of the road. It was taken to the dealership where I bought it (since the car only has 32k miles on it) for a "hole in the engine" which is what I was originally told by the service department. Two days later, I received a phone call that there actually was no hole in my motor, and that the drain oil plug disappeared from my engine while driving, causing all of the oil to spill out of my engine that day on the interstate. Despite getting an oil change only 1500 miles ago from this exact dealer, they stated that the plug would have fallen out immediately after their service if it was placed back incorrectly. Hyundai stated this is now an "owner's problem" and that I was to call my insurance company to get an estimate from them because the dealership would not cover it since it was no longer a warranty issue. I called my insurance company who then got pictures from the dealer of the engine and a video. They then called me stating this type of damage is not covered under my policy, and that they would not pay for it. So here I am, stuck with Hyundai refusing to pay for a damaged engine even though the oil drain plug fell out, which inherently caused the damage, and despite having a 10 year/100k mile warranty on the motor. I found out there is an open investigation through the NHTSA about this exact issue and was hoping to receive clarity on what I can do.

Traveling on the highway and the engine decelerated, oil pressure light came on briefly and then went off. The engine light went on. Was not able to accelerate past 50 mph. The car was hesitating and shaking. Had to change lanes and drive a distance to get to safe place. Engine starting knocking and got worse the longer it was driven. Was a safety risk as unable to go any faster than 50 miles per hour and hard to steer with car shaking. Car has 79,384 miles on it. Dealership states engine failure and that engine needs to be replaced. Car had burned up almost all the oil that had been replaced two months prior. Hyundai currently has a recall for this exact problem with their 2017 Tucson’s

Check engine light came on for 2020 Hyundai Tucson; the vehicle has the 2.0 engine. I called Hyundai for service waited 3 weeks for service appt. Service ECM software update completed on 2/13/2023. On 2/15/2023 service light came on again. Advised Hyundai Service dept that the light was on again. There was a recall for 2019 2.0 engines for Exhaust Manafold Catalyst sensor. Advisor stated that bring it in 3 weeks and we will take it for a test drive.

Engine light was flashing on and off in September 2022 I took it in to a Hyundai dealer in September and was told it was the Catalytic convertor. The catalytic convertor was replaced in October 2022, 2 weeks later the engine light was flashing and the car would not accelerate. I took the care that day to Freehold Hyundai where after keeping it for 3 days they said it was an issue with the oil filter. I have taking the car on a regular basis for all oil changes since in my possession. On December 25th as I was driving to my families house for Christmas the engine light again started flashing and the car would not accelerate. I was able to get the car back to my house. No one was available to call that day due to the holiday. I contacted Freehold Hyundai 12/26/2022 and had the car towed to their facility. On 12/27/2022 I was told the cars engine is failing and that they need to obtain authorization from Hyundai in order to get approval. This is a leased vehicle and does have warranty coverage but they are not able to confirm it can be fixed and cannot offer me a lender car.

The car engine completely shuts down without warning. This has happened over a dozen times since last summer. The only thing we can think of was the ABS module recall work, but the dealership says everything is fine with the car and they cannot replicate. This happens when the car is at a stop, or sometimes driving slowly or turning. The engine gets quiet, the lights flicker, and then gas no longer works to accelerate. To fix this, we have to shift the car back to P, then turn the car off, then turn it on again, and then put it back into D. Sometimes this happens in the middle of live traffic which is unsafe. We have an active case with Hyundai America open about this issue since the dealers cannot identify and fix the issue. This is a high safety issue for my family and other drivers. The car is available for inspection. The frequency of this occurs about once a week (it used to happen 1-2 times per month but recently has been increasing.)

These vehicles I been noticing looks like they having issues with their staters or something I been seeing on Youtube everyone having same issue like I'm where on cold days you try to start the engine it just makes a clicking sound with a burning smell

SERVICE RECALL 195 FOR ABS SYSTEM AND POTENTIAL FIRE HAZARD. HYUNDAI SAYS NOT TO DRIVE BECAUSE OF SAFETY RISK AND THAT PARTS ARE NOT AVAILABLE NATIONWIDE. APPARENTLY THIS IS ONLY FOR EXISTING CARS IF YOU BUY NEW THEY WILL FIX THE PROBLEM AND HAVE PARTS AVAILABLE IMMEDIATELY. HOW IS THAT POSSIBLE?

Mileage: 11,332